NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 1

MUMBAI.

NITIN CORPORATION

402, 4th

Floor,

Bezzola Commercial Complex,

Sion – Trombay Road, Chembur,

Mumbai – 400071,

India .

WEB : www.corponit.com E – MAIL : nitincorporation@yahoo.com

enquiry@corponit.com

PH (O) : +91 - 22 - 25234478/67973677

FAX : +91 - 22 - 25235386

THE FOLLOWING HFO FIRED GENERATOR SET IS AVAILABLE FOR SALE WITH US

WITH IMMEDIATE DELIVERY:

1 No. – 5.8 MW, WARTSILA (2003) make HFO Fired Generator set having the

following technical specifications:

MAIN ENGINE SPECIFICATION:

Make : Wartsila – Finland

Model : 18V32LN

Capacity : 5800 KW

Rating : 7250 KVA

Year of installation : 2003

TURBOCHARGERS:

02 Nos. Mounted on Engine, Make-ABB, Type-VTR-354-11P & b. Electronic

Governor, UG-40 Woodward makes Engine mounted with Controller 723.

ALTERNATOR:

Make : LEROY SOMER, Made in France Date-12/87

Type : PA160 G105 - 90-8P

KW : 5800

KVA : 7250

RPM : 750

Voltage : 3300

Amps : 1268

Hz : 50

Power Factor : 0.8

Number of Hours used so far : 35,880.00 hours since installation.

Details of Major Overhauling and number of Hours used after Major Overhauling:

Last 32,000 hours scheduled major overhaul was done at actual 34,106 hours. Running

hours after this overhaul is 1774 hours.

Load Trial Report available: Load trial report is available for 5500 KW during

commissioning of DG after 32,000 hours overhaul.

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 2

MUMBAI.

Details of HFO and Lub Oil Consumption per KWH Power Generation: HFO Cons.

Approx. 3.50 to 3.90 Kwh/Ltr. & Lube oil consuption : Approx. 1.20 to 1.50 gram per Unit.

LIST OF AUXILLARY EQUIPMENTS OF WARTSILA DG SET

Equip.

No.

Description Specification

1 HFO Separator unit HFO SEPERATOR 1 & 2

Make- Westfalia seperator AG D-4740 Oelde

West Germany

Type-OSA-20-02-066

2 Fuel Booster module 02 Nos. Feed pumps

02 Nos. Transfer pumps

01 No Master booster pump

3 Lube oil system

3.1 Gear pump Type- self priming, engine drive

3.2 Spare Lube oil tank Cap-7000 ltrs.

3.3 Lube oil filters engine mounted. Wire gauge with paper filter

3.4 Lube oil thermo state 60 degree Temp

4 Lube oil separator unit

LO SEPERATOR 1 No

4.1 Gear pump Make- Westfalia seperator AG D-4740 Oelde

4.2 Lube oil heater West Germany

Type-OSA-20-02-066

5 Lube oil cooling

5.1 Plate heat exchange Alfa Laval make PHE

6 Cooling water system

Engine jacket water system Alfa Laval make PHE

6.1 Jacket water thermo state 87 Degree

6.2 Jacket water heat exchanger Alfa Laval make

6.3 Jacket water expanson tank 50 liters cap.

7

Engine charge air cooling water

system

7.1 Charge air cooling water Two Nos. charge air coolers mounted in Engine

7.2 Thermo state 50 degree

7.3

Charge air cooling water heat

exchanger Alfa Laval make

7.4

Charge air cooling water

expansion Tank 50 liters cap.

7.5 Engine water maintenance tank Cap-500 liters.

7.6 Water piping inside dg room various sizes

7.7 Water piping outside dg room various sizes

7.8

Water circulating pumps for c/a ;

01 nos Engine mounted

7.9

Water circulating pumps for

jacket water : 02 nos Engine mounted

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 3

MUMBAI.

8 Open circuit : Cooling Tower

8.1 Cooling Tower Paharpur supply

8.2 Raw water pumps ; 02 nos Kirloskar make,

8.3 Capacity 312 cubic meter/hour flow, 30 Mtr head

8.4 Model UP 150/38 B

9 Starting air system Air receiver : 01 No

9.1 Air compressors Air compressors : 03 nos, Type :15T2, IR Make

10 Automaze air Filters with duct 02 Nos. oil bath Filters, Automaze make

11 Pressure & Ventilation system

11.1 system for wartsila 02 Nos Blowers capacity ; 85,000 cub m/hr

Water pumps ; 04 Nos Kirlosker make

11.2 New system for MWM 02 Nos Axial Impellers capacity ; 50,000 cub m/hr

Water pumps; 04 Nos. Kirlosker make

GI Ducting

12 M.S.Chimney Height : 35 meter, Dia : 800 mm through out

SPARES

Sr.

No.

Items UOM Stock

Qty.

1 STRIPPABLE PROT.COAT WR2560 500ML WEARRESIST

FOR DG SET

NOS 2

2 AIR COOLER CLEANER ACC119 FOR DG SET KGS 200

3 CHROME GALVENISE Z143 700ML MAKE:STANVAC

FOR DG SET

BTL 1

4 O RING - SIZE:67X4MM VITON NOS 48

5 STAINER - CI 25 MM 'Y' TYPE - NOS 3

6 H.T.HEX HEAD BOLT WITH NUT - SIZE:22X60MM NOS 69

7 V BELT B SERIES - B142 - B142 NOS 2

8 MAXIGARD CORROSION - INHIBITOR F/DG SET KGS 93

9 CENTRI.MONO.PUMP - AE25/2 100MM 7.2M3/H - TYPE

AE25/2(100MM) 7.2M3/HR KOLMERKS MAKE

F/WARTSILA DG SET

NOS 1

10 VALVE SAFETY - PN.X1396T28-60 - PN.X1396T28-60 NOS 2

11 CABLE - PN.506107 - PN.506107 NOS 1

12 CHEMICAL F/WATER TRE - VS CLT60/NALPREP2001 -

CLT60/NALPREP-2001

LTR 50

13 NITRIC ACID - NITRIC ACID - NITRIC ACID LTR 525

14 SPARE PART KIT - PN.121066 F/18V32 - PN.121066

F/ROTOCAP

NOS 1

15 TEMPERATURE SENSOR - PN.506054 - PN.506054 NOS 1

16 SPEED AMPLIFIER IMP - VF50G1 0-10VDC 0-70C - VF50G1

0-10VDC 0-600HZ TU0-70C UE24VDC TA97-136 F/MWM

NOS 1

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 4

MUMBAI.

17 O RING - PN.130570440003 3 - PN.130570440003 3 DN.10530-

11-23

NOS 4

18 O RING - PN130570152001 II-20 - PN.130570152001 II-20

DN.F1080

NOS 4

19 O RING - PN.181166 - PN.181166 NOS 1

20 SPRING - PN.181163 - PN.181163 NOS 1

21 O RING - PN.228043 - PN.228043 NOS 1

22 O RING - PN.228101 - PN.228101 NOS 1

23 O RING - PN.228024 - PN.228024 NOS 2

24 O RING - PN.228019 - PN.228019 NOS 2

25 O RING - PN.228025 - PN.228025 NOS 2

26 SPRING - PN.228032 - PN.228032 NOS 1

27 HEX NUT - PN.224051 HEX HEAD - PN.224051 HEX HEAD NOS 2

28 LOCK WASHER - PN.224052 - PN.224052 NOS 2

29 FELT RING - PN.0004-1950-830 - PN.0004-1950-830

34/47QX5.5

NOS 2

30 SPRING - PN.228103 - PN.228103 NOS 4

31 O RING - PN.483084 - PN.483084 NOS 4

32 O RING - PN.483085 - PN.483085 NOS 4

33 GASKET-JOINT - PN.2-219 - PN.2-219 NOS 3

34 HELICAL SPRING - PN.213007 - PN.213007 NOS 2

35 SPRING - PN.228004 - PN.228004 NOS 1

36 BEARING - PN.130030154001/ - PN.130030154001/903352 NOS 2

37 FELT RING - PN.0004-1953-0830 - PN.0004-1953-0830

40/52QX5.5

NOS 4

38 O RING - PN.352127 - PN.352127 NOS 4

39 HEX NUT - PN.228007 HEX HEAD - PN.228007 HEX HEAD NOS 1

40 SPRING - PN.228034 - PN.228034 NOS 1

41 O RING - PN.191052 - PN.191052 NOS 2

42 SHAFT SEAL - PN.483082 - PN.483082 NOS 1

43 SPRING - PN.214007 - PN.214007 NOS 2

44 SPRING - PN.211008 - PN.211008 NOS 9

45 O RING - PN.834025 F/HYD.TOOL - PN.834025 F/HYD.TOOL

PN.834050

NOS 6

46 O RING - PN.834026 F/HYD.TOOL - PN.834026 F/HYD.TOOL

PN.834050

NOS 6

47 O RING - PN.834024 F/HYD.TOOL - PN.834024 F/HYD.TOOL

PN.834050

NOS 6

48 SPRING - PN.181170 - PN.181170 NOS 1

49 FILTER CARTRIDGE - PN.471251 - PN.471251 NOS 1

50 O RING - PN.228042 - PN.228042 NOS 2

51 PLUG - PN.120002 - PN.120002 NOS 4

52 SPRING - PN.217030 - PN.217030 NOS 2

53 SHAFT SEAL - PN.483081 - PN.483081 NOS 1

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 5

MUMBAI.

54 SLIDING O RING - PN.214006 - PN.214006 NOS 3

55 BEARING - PN.191010 - PN.191010 NOS 1

56 PIPE UNION - PN.352689 - PN.352689 NOS 2

57 O RING - PN.350018 - PN.350018 NOS 10

58 GASKET - 200X265X1MMTK,COPPER -

200X265X1MMTK,COPPER ASBESTOS

NOS 9

59 C.R.ROD CRANKSHAFT - C1136 PN170190154052 -

DN.C1136 PN.170190154052/215442

NOS 1

60 GASKET-JOINT - PN.2-247 - PN.2-247 NOS 8

61 BEARING - PN.181101 - PN.181101 NOS 5

62 CAM SHAFT BEARING - PN.228040 - PN.228040 NOS 2

63 O RING - PN.196163.DN.4V34L75 - PN.196163.DN.4V34L75

HT MOTOR MS125

NOS 12

64 BEARING BUSHING - PN.145014 - PN.145014 NOS 7

65 ELEMENT F/THERM.VALV - DN.4V34L75 NS125 63C -

DN.4V34L75 NS125 63C.Amot5bobc-145/63-0

NOS 2

66 BELLOWS - NS800 NP1.5 - NS800 NP1.5 NOS 1

67 HEX NUT - PN.111006 - PN.111006 F/BIG END BRG.SCREW NOS 10

68 SLIDE - PN.211007 - PN.211007 NOS 9

69 SLIDE - PN.211006 - PN.211006 NOS 9

70 DRIVE GEAR WHEEL - PN.181191(GR1163/03) - PN.181191

ICRR 1163/2003 PO1106/2002

NOS 1

71 OIL SLINGER - PN.32180(GR/1640/20) - PN.32180

ICRR1640/99 PO/2823/99

NOS 2

72 OIL SLINGER - PN.34180(GR/1640/20) - PN.34180

ICRR1640/9900 PO2823/99

NOS 2

73 RING GEAR HUB SET - W/FANSHAFT DISC&ACC. - W/FAN

SHAFT DISC&HARDWARE F/DG COOLING TOWER

SET 2

74 SEALING SET - PN.473040 - PN.473040 SET 2

75 FUEL FILTER ELEMENT - PN.470200 PRES.10BAR -

PN.470200 PRES.10BAR 145C-9NOS=1SET

SET 1

76 FILTER INSERT - PN.471196 1SET=8NOS - PN.471196

1SET=8NOS

SET 1

77 PISTON RING SET - PN.113013 - PN.113013 SET 1

78 BUSH F/POLY.TUBE - F/8BK20 3.3KV PNL - F/8BK20 HT

PANEL 3.3KV 3AF1054-4

NOS 12

79 PVC CLAMP ON NOZZLE F/PRESSU.&VENTI.SYS.

PVC CLA ON NOZZLE

NOS 25

80 POLYPROPLINE TUBE - F/8BK80&8BK20 - F/8BK80&8BK20

HT PANEL 2000A 3.3KV 3AF1164-3&3AF1054-4

NOS 6

81 P3CARD - PN.15074/1104AVR UNT - PN.15074/1104AVR

UNT ICRR44/9900 PO/1839/98

NOS 1

82 DESPEMES SPEED SENSI - C2 - C2(PO1271/94) NOS 1

83 TEMPERATURE GAUGE - 0-200C - 0-200C NOS 2

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 6

MUMBAI.

84 CIRCUIT BOARD - TYPE AS/384 - TYPE AS/384 AE MAKE

F/DG BATTERY CHARGER

NOS 1

85 CIRCUIT BOARD - TYPE BUV/995 - TYPE BUV/995 AE

MAKE F/DG BATTERY CHARGER

NOS 1

86 CIRCUIT BOARD - TYPE 130V/995 - TYPE 130V/995 AE

MAKE F/DG BATTERY CHARGER

NOS 1

87 CIRCUIT BOARD - TYPE FC-1QU-188 - TYPE FC-1QU-188

F/DG BATTERY CHARGER

NOS 1

88 SOLENOID VALVE - PN.357016 CV321 - PN.357016 CV321 NOS 1

89 P6 MAIN CARD - 15066/227 15074/1304 - 15066/227

15074/1304 FOR WARTSILA DG AVR CONTROL CARD

NOS 1

90 P2 DETECT.®U.CARD - 15066/2200A,15074/13 -

15066/2200A,15074/1300 F/WARTSILA DG AVR CONTROL

NOS 1

PHOTOGRAPHS:

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 7

MUMBAI.

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 8

MUMBAI.

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 9

MUMBAI.

NITIN CORPORATION, 1 No. 5.8 MW Wartsila HFO Generator Set Page 10

MUMBAI.