Replacement Parts List No. 700053400 Revision D 03/2020
DaikinNavigator®
Water-Cooled Screw Compressor Chiller
WWVJNNS, MNNS, RNNS
Vintage A
To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.DaikinApplied.com
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 2
Contents
Parts List Revision History.................................................................................................................................. 3Nomenclature Serial Number & Unit Model Number ........................................................................................................... 4 Unit Model Number- Complete ............................................................................................................... 5 - 8Electrical Legend ................................................................................................................................................ 9Unit Layout Diagram ......................................................................................................................................... 10Refrigeration Section Compressor ................................................................................................................................................11 Liquid Line .................................................................................................................................................. 12 Jet Pump Line ............................................................................................................................................ 13 Suction Line ........................................................................................................................................ 14 - 15 Discharge Line .................................................................................................................................... 16 - 17 Oil Line ....................................................................................................................................................... 18 Evaporator and Condenser ........................................................................................................................ 19VFD .................................................................................................................................................................. 20Valves and Flow Switch .................................................................................................................................... 21Insulation Compressor Motor, Evaporator Vessel & Head ......................................................................................... 22 Compressor Sound Enclosure ................................................................................................................... 23Unit Controls Device ID Label .......................................................................................................................................... 24 Control Box Layout Diagram ...................................................................................................................... 25 Common Control Box Components ........................................................................................................... 26 Transformers, Fuses, Sensors, Transducers ............................................................................................. 27 Communication Modules ........................................................................................................................... 28Field Installed Accessories Rapid Restore Field Install Kit .................................................................................................................... 29 Ground Fault Relay Kit ............................................................................................................................... 29
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 3
Parts List Revision History
Revision Date Description NEW 01/2018 New A 02/2018 Page 6: Code 38- removed option 2, added option S. Code 40- Removed options H and J. Page 7: Code 67- Added option L. Page 18: Added part # for Sensor Well. Page 24: Changed Schem. Sym. for Solenoid Connector w/MOV, were Y1B1, Y2B1, Y3B1. B 09/2018 Page 20: Corrected Ref. F31 and F34, were flip-flopped. C 02/2020 Pages 5-8: Updated Unit Model Nomenclature. Page 9: Added F13 High Pressure Switch. Page 11: Updated part #s for 575V Compressors, added 380V Compressors. Page 16: Added "Without Shut-Off Valve" to title. Page 17: New page for Discharge Line With Shut-Off Valve. Page 18: Updated part #s for YMO-1 Solenoid Valve, were 331761609 and 331761608. Page 20: Added VFD102N315T4. Changed 460V description to 380, 460V. Page 22: Added Double Insulation. Page 23: New page for Insulation- Compressor Sound Enclosure. Page 26: Updated part # for DS1 Disconnect Swith 250A 380-460V, added 250A 575V. Added Cable for EEXV1 Electronic Exp Valve. Updated part # for RR Rapid Restore, was 193407601. Page 27: Added Temperature Sensors. Updated part #s for Transducer Cables, were 910217971, -72, -73, -74. Removed Transducer Boot. Page CPL1: Corrected part # for Low Pressure Transducer, was 333992041. D 03/2020 Page 28: Corrected part #s for Communication Modules, were 350147415, -14, -13, -12.
Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 4
NomenclatureSerial Number & Unit Model Number
WWV JNNS A SN
Unit Model Number
Unit Type: WWV= Water- Cooled World VFD Screw Compressor Chiller
Compressor Size
Vintage
ConfigurationSN= Single Refrigerant Circuit w/o Economizer
STN U 17 05 03800
Plant IdentificationSTN = Staunton, VA
Year of Manufacture17= 201718= 201819= 2019 20= 2020
etc.
U= Unit
Serial Number (build sequence)
Month of Manufacture01= January02= February03= March04= April05= May06= June
07= July08= August09= September10= October11= November12= December
Serial Number
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 5
NomenclatureUnit Model Number- Complete
WWV JNNS A SN AC 00460 H6 D A E2010 GB 2 C DZ L 2 V C N M 4 440FCode 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22
00580 C C A A C2010 HB 2 C A2 N N N NN L 1 V A N L 4 1050F 00725 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45
C C N N NN A A 0150 A 0700 S2 MD E N N A 01020 S D P N H H N 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69
N N H 2 B 1 5 A N N A F N N E A N N J 000 U Y N 0 A N S S70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97
U A 02487 NNNNNNNNNN ND W NNNNN 00000 01020 00000 05156 VFD102N132T498 99 100 101 102 103 104 105 106 107 108 109
VFDNNNNNNNNN 123H NNNH N L 110 111 112 113 114
02 Compressor Size JNNS - Single Compressor MNNS - Single Compressor RNNS - Single Compressor
03 Vintage A= Vintage A
04 Chiller Configuration SN= Single Refrigerant Circuit w/o Economizer
05 Compressor Motor Type AC= AC Power
06 Power Supply Voltage 00380= 380V 00400= 400V 00460= 460V 00575= 575V
07 Power Supply Hertz H5= 50 Hertz H6= 60 Hertz 08 Always D
09 Compressor Model Revision A= Revision A
10 Evaporator Shell Diameter and Length E1610= 16" Diameter Shell, 10' Length E2010= 20" Diameter Shell, 10' Length E2410= 24" Diameter Shell, 10' Length
11 Evaporator Tube Count 16" 20" 24" GB= 136 190 235 HB= 120 154 188 JB= 108 -- 170 KB= 80 -- --
12 Evaporator Tube Thickness 2= 0.025
13 Evaporator Tube Type C= CU
14 Evaporator Tube Model
15 Evaporator Inlet Nozzle Location L= Left R= Right
16 Evaporator Water Passes 2= 2 Pass
17 Evaporator Inlet Nozzle Connection Type V= Groove F= Flanged
18 Evaporator Inlet Nozzle Configuration C= Dish, 2 or 3 Pass, Entering End/Bottom, Leaving End/Top H= Wtr Box, 2 or 3 Pass, Entering Rear, Leaving Rear J= Wtr Box, 2 or 3 Pass, Entering Front, Leaving Front L= Wtr Box, 2 or 3 Pass, Entering Rear, Leaving Top M= Wtr Box, 2 or 3 Pass, Entering Front, Leaving Top
19 Evaporator Hinge Type N= None
20 Evaporator Refrigerant Design Pressure M= 232 PSIG
21 Evaporator Water Side Design Pressure 4= 150 PSIG- Non ASME Code
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6
22 Evaporator Leaving Water Temperature Ex. 440F= 44.0 F
23 Evaporator GPM Ex. 00580= 580 GPM
24 Evaporator Tube Sheet Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy
25 Evaporator Head/Water Box Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy 26 Evaporator Tube Cleaning System N= None
27 Evaporator Model Revision A= Revision A
28 Condenser Shell Diameter and Length C1810= 18" Diameter Shell, 10' Length C2010= 20" Diameter Shell, 10' Length C2410= 24" Diameter Shell, 10' Length
29 Condenser Tube Count 18" 20" 24" HB= 150 221 290 JB= 130 185 244 KB= 109 -- --
30 Condenser Tube Thickness 2= 0.025
31 Condenser Tube Type C= CU
32 Condenser Tube Model
33-35 Always N
36 Always NN
37 Condenser Inlet Nozzle Location L= Left R= Right
38 Condenser Water Passes 1= 1 Pass S= 1 Pass with same end connection
39 Condenser Inlet Nozzle Connection Type V= Groove F= Flanged
40 Condenser Inlet Nozzle Configuration A= Dish, 1 Pass, Entering End/Center, Leaving End/Center E= Wtr Box, 1 Pass, Entering Rear, Leaving Rear F= Wtr Box, 1 Pass, Entering Front, Leaving Front
41 Condenser Hinge Type N= None
42 Condenser Refrigerant Design Pressure L= 319 PSIG
43 Condenser Water Side Design Pressure 4= 150 PSIG- Non ASME Code
44 Condenser Leaving Water Temperature Ex. 1050F= 105.0 F
45 Condenser GPM Ex. 00725= 725 GPM
46 Condenser Tube Sheet Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy
47 Condenser Head/Water Box Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy 48-49 Always N
50 Always NN
51 Condenser Model Revision A= Revision A
52 Pressure Vessel Code A= ASME 1= CRN- British Columbia 2= CRN- Alberta 3= CRN- Saskatchewan 4= CRN- Manitoba 5= CRN- Ontario 6= CRN- Quebec 7= CRN- New Brunswick 8= CRN- Nova Scotia 9= CRN- Prince Edward Island 0= CRN- Newfoundland F= Nunavut U= CRN- Yukon W= Northwest Territories
NomenclatureUnit Model Number- Complete
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 7
53 Unit Tons Ex. 0150= 150 Tons
54 Refrigerant A= 134A
55 Refrigerant Quantity Ex. 0700= 700 pounds
56 Expansion Valve Type S2= Electr Exp Valve, single actuator, 250 Tons S4= Electr Exp Valve, single actuator, 400 Tons
57 Controller Type MD= MicroTech III w/Door Mounted Display
58 Language E= English
59 Controller Rapid Restore N= None R= Rapid Restore
60 Controller Communications N= None B= BACnet MS/TP E= BACnet IP L= Lonmark M= Modbus
61 Power Box and Unit Controller Box Type A= NEMA 1
62 Input Rated Load Amps (RLA) - Compressor 1 Ex. 01020= 12.0 Amps
63 Power Box, Box Type S= Single Point, Single Box
64 Power Connection Type D= Disconnect Switch
65 EMI Filter P= EMI Filter
66 Intelligent Equipment N= None
67 Short Circuit Ratings H= High, 65 KA L= Low, 25KA
68 Ground Fault Protection N= None F= With GFP
69 Harmonic Filter N= None
70 Hot Gas Bypass N= None
71 Compressor Sound Reduction N= None C= Discharge Line Wrap and Compressor Sound Reduction D= Discharge Line Wrap S= Compressor Sound Reduction
72 Vessel Insulation H= .75 Insul Evap Shell, Suct Piping, Compr Inlet, Motor Barrel 3= 1.5 Insul Evap Shell, Suct Piping, Compr Inlet, Motor Barrel J= .75 Insul Evap Shell, Suct Piping K= 1.5 Insul Evap Shell, Suct Piping
73 Head Insulation 2= Evap OPP & ENT Heads Insulated
74 Factory Water Flow Indicator B= Both Evap and Cond Flow Control
75 Exterior Painting 1= Standard Painting
76 Shipping
77 Refrigerant Charge 78 Special N= None X= Special
79 Low Lift Conditions N= None
80 Knockdown
81- 83 Testing
84 Agency Listing E= ETL/cETL N= None
85 AHRI Listing A= AHRI N= None
86 ASHRAE Listing A= ASHRAE N= None
87 OSP-IBC Listing N= None
88 Brand Name J= Daikin
89 Future
90 Startup
NomenclatureUnit Model Number- Complete
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 8
NomenclatureUnit Model Number- Complete
91 Standard Chiller Warranty Y= Domestic and Canadian-1 Yr Parts & Labor P= Export- 1 Year Parts Only
92 Extended Chiller Warranty N= None A= 1 Yr Parts Only B= 1 Yr Parts & Labor C= 2 Yr Parts Only D= 2 Yr Parts & Labor E= 3 Yr Parts Only F= 3 Yr Parts & Labor G= 4 Yr Parts Only H= 4 Yr Parts & Labor J= 5 Yr Parts Only K= 5 Yr Parts & Labor L= 6 Yr Parts Only M= 6 Yr Parts & Labor P= 7 Yr Parts Only Q= 7 Yr Parts & Labor R= 8 Yr Parts Only S= 8 Yr Parts & Labor T= 9 Yr Parts Only V= 9 Yr Parts & Labor
93 Refrigerant Warranty 0= None B= 1 Yr D= 2 Yr F= 3 Yr H= 4 Yr K= 5 Yr
94 Delayed Warranty Start A= 0 Additional Months B= 2 Additional Months C= 4 Additional Months D= 6 Additional Months E= 8 Additional Months F= 10 Additional Months G= 12 Additional Months
95 Extended Compressor Warranty N= None A= 1 Yr Parts Only B= 1 Yr Parts & Labor C= 2 Yr Parts Only D= 2 Yr Parts & Labor E= 3 Yr Parts Only F= 3 Yr Parts & Labor G= 4 Yr Parts Only H= 4 Yr Parts & Labor J= 5 Yr Parts Only K= 5 Yr Parts & Labor L= 6 Yr Parts Only M= 6 Yr Parts & Labor P= 7 Yr Parts Only Q= 7 Yr Parts & Labor R= 8 Yr Parts Only S= 8 Yr Parts & Labor T= 9 Yr Parts Only V= 9 Yr Parts & Labor
96 Standard Ship
97 Miscellaneous
98 Manufacturing
99 Model Revision A= Revision Level A B= Revision Level B
100 Unit kW Ex. 02487 = 248.7 kW
101 Stock Modifications
102 Isolation Valves ND= Without Suct or Discharge Shut-off Valve WV= With Suct and Discharge Shut-off Valve
103 Always W
104 Always NNNNN
105 Always 00000
106 Output Amps Ex. 01020 = 102.0 Amps
107 Always 00000
108 IPLV Ex. 05156 = 0.5156 kW/Ton
109 VFD #1 Size VFD102N132T4= 132 kW, 380- 460V VFD102N160T4= 160 kW, 380- 460V VFD102N200T4= 200 kW, 380- 460V VFD102N250T4= 250 kW, 380- 460V VFD102N315T4= 315 kW, 380-460VV VFD102N132T7= 132 kW, 575V VFD102N160T7= 160 kW, 575V VFD102N200T7= 200 kW, 575V VFD102N250T7= 250 kW, 575V VFD102N315T7= 315 kW, 575V VFD102N400T7= 400 kW, 575V
110 VFD #2 Size VFDNNNNNNNNN= None
111-112 Operating Hertz
113 Liquid Injection N= None
114 Altitude L*****= Lower Altitude (less than or equal to 1000M) H*****= Higher Altitude (greater than 1000M)
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 9
Electrical Legend
Schem. Sym. Description C Terminal Blocks CC1 Controller Expansion Module CEWT Condenser Entering Water Temperature CLWT Condenser Leaving Water Temperature CNT1A Multi Cable Harnesses Connector CNT1B Temperature Sensors Connectors CMP-M1 Compressor Motors COND FLOW SW Condenser Flow Switch CP1 Condenser Pressure Transducer CT- GFR1 Current Sensor Ground Fault DS1 Disconnect Switch DT-1 Discharge Temperature Sensor EEWT Evaporator Entering Water Temperature EEXV1 Electronic Expansion Valve Module ELWT Evaporator Leaving Water Temperature EP-1 Evaporator Pressure Transducer EVAP FLOW SW Evaporator Flow Switch EVEXV-1 Evaporator Electronic Expansion Valve F10 Fuse Block Ventilation Fan F11 Fuse Block for 120V Control Circuits F13 High Pressure Switch F120A, 120B T1 Transformer Primary Fuse Block F121A, 121B T2 Transformer Primary Fuse Block GFR1 Ground Fault Relay GLG1 Main Panel Ground GND Single Point Ground Terminal Block GND10 Ventilation Fan Ground GND11 T1 Ground K11 Emergency Stop Relay K13 High Pressure Switch Relay KT2 Thermostat LCD1 Door Mounted Display LT-1 Liquid Line Temperature Sensor M5 Field Wiring Terminal Blocks M10 Exhaust Fan M10-1 Intake Grill MQ 120V Terminal Blocks MS 24V Terminal Blocks OP-1 Oil Pressure Transducer PE1 Ground Bar PS-IE 24VDC Power Supply Q11 E-STOP Push Button Q12 T1 Secondary Fuse Q13 T3 Secondary Fuse RES50 50 Ohm Terminated Resistor RR Rapid Restore SA Surge Absorber SC1, 2 Shielded Wires Terminal Block ST-1 Suction Temperature Sensor T1 Control Transformer- Main Power T2 Control Transformer- 24 Secondary UC Main Unit Controller Unit Switch Switch 50%SV-1 50% VR Solenoid, Ckt #1 75%SV-1 75% VR Solenoid, Ckt #1 100%SV-1 100% VR Solenoid, Ckt #1 YJP1 Jet Pump Solenoid YMO1 Oil Return Solenoid
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 10
Unit Layout Diagram
Liquid Line
Discharge LineSuction Line
CompressorVFD
Evaporator
Condenser
Control Box
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 11
Refrigeration SectionCompressor
380V
460V
575V
380V
460V
575V
380V
460V
575V
Code 02 JNNS MNNS RNNS
Part Part Description Number Compressor 332948658 1 Compressor 332948653 1 Compressor 332948659 1
Compressor 332948668 1 Compressor 332948663 1 Compressor 332948669 1
Compressor 332948678 1 Compressor 332948673 1 Compressor 332948679 1
Screw, Compr Mounting, M12 x 1.75 330821907 4 4 4 4 4 4 4 4 4 Lock Washer, Compr Mounting 048164814 4 4 4 4 4 4 4 4 4 Plain Washer, Compr Mounting 040500310 4 4 4 4 4 4 4 4 4
Immersion Well 131506010 1 1 1 1 1 1 1 1 1 Immersion Well Bushing 132010016 1 1 1 1 1 1 1 1 1 Oil Temp Sensor Well 118510358 1 1 1 1 1 1 1 1 1 Ground Lug 132010035 1 1 1 1 1 1 1 1 1 Oil Filter 332115201 1 1 1 1 1 1 1 1 1
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 12
Refrigeration SectionLiquid Line
Ref. Part Part No. Description Number Qty. L102 Shut Off Valve, 2.125 Code 56= S2 & Code 102= WV 330296046 1 L102 Shut Off Valve, 2.625 Code 56= S4 & Code 102= WV 330296047 1
L106 Electronic Expansion Valve, 250 Ton Code 56= S2 333935801 1 L106 Electronic Expansion Valve, 400 Ton Code 56= S4 333935802 1
L102
L106
Note: Code 56= S2 when Code 02= JNNS; Code 56= S4 when Code 02= MNNS or RNNS
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 13
Refrigeration SectionJet Pump Line
Ref. Part Part No. Description Number Qty. Jet Pump, Complete Assy 332950260 1
JP01
to Compressor
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 14
Refrigeration SectionSuction Line without Shut Off Valve (Code 102= ND)
S06
S06
S07
S07
S06
Code 02= JNNNS or MNNNSand Code 10= E1610and Code 28= C1810 or C2010
Ref. Description Part No. Qty. S06 Gasket, 7.42 OD x 5.66 ID 070199150 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1
Code 02= MNNNSand Code 10= E2010 or E2410and Code 28= C2010 or C2410
Ref. Description Part No. Qty. S06 Gasket, 8.35 OD x 6.73 ID 070199151 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1
Code 02= RNNNSCode 10= E2010 or E2410Code 28= C2010 or C2410
Ref. Description Part No. Qty. S06 Gasket, 8.35 OD x 6.73 ID 070199151 2
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 15
Refrigeration SectionSuction Line with Shut Off Valve (Code 102= WV)
S06
S07
Code 02= JNNNS or MNNNSand Code 10= E1610and Code 28= C1810 or C2010
Ref. Description Part No. Qty. S06 Butterfly Valve, 5 inch 073062130 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1
Code 02= MNNNSand Code 10= E2010 or E2410and Code 28= C2010 or C2410
Ref. Description Part No. Qty. S06 Butterfly Valve, 6 inch 073062131 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1
Code 02= RNNNSCode 10= E2010 or E2410Code 28= C2010 or C2410
Ref. Description Part No. Qty. S06 Butterfly Valve, 6 inch 073062131 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1
S07
S07
S06
S06
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 16
Refrigeration SectionDischarge Line without Shut Off Valve (Code 102= ND)
Ref. Part Part Qty. No. Description Number Code 02= JNNS or MNNS D25 Gasket, 5.13 OD x 4.44 ID x .06 thick 070199144 1
Code 02= RNNS D25 Gasket, 7.42 OD x 5.91 ID x .06 thick 070199152 1
D25
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 17
Refrigeration SectionDischarge Line with Shut Off Valve (Code 102= WV)
Ref. Part Part Qty. No. Description Number Code 02= JNNS or MNNS D05 Shut-Off Valve 332948590 1 D25 Gasket, 5.13 OD x 4.44 ID x .06 thick 070199144 1
Code 02= RNNS D05 Shut-Off Valve 332949151 1 D25 Gasket, 7.42 OD x 5.91 ID x .06 thick 070199152 1 D26 Gasket, 10.75 OD x 5.66 ID x .06 thick 070199035 2
D25
D25
D26
D05
D05
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 18
Refrigeration SectionOil Line
E1610/ E1610/ E1610/ E2010/ C1810 C1810 C2010 C2010
E1610/ E2010/ E2410/ C2010 C2010 C2410 E2410/ C2410
YMO-1 OL07 OL20
OL01OL20
Code 02 JNNS MNNS RNNS Code 10 / Code 28 Ref. Part Part No. Description Number OL01 Shut-Off Valve 735039953 1 1 1 1
YMO-1 Solenoid Valve, 1.125 331451005 1 1 YMO-1 Solenoid Valve, 1.375 331451006 1 1
OL07 Sight Glass, 1.125 330508602 1 1 OL07 Sight Glass, 1.375 015997808 1 1
OL20 Ring Seal 736017605 2 2 2 2
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 19
Refrigeration SectionEvaporator and Condenser
To identify any other components pertaining to the Evaporator or Condenser, please contact Daikin Applied.
Part Part Qty. Description Number Sensor Well 332948751 4
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 20
VFD
Part Part Qty. Description Code 109 Number VFD 380, 400, 460V VFD102N132T4 332948542 1 VFD 380, 400, 460V VFD102N160T4 332948543 1 VFD 380, 400, 460V VFD102N200T4 332948551 1 VFD 380, 400, 460V VFD102N250T4 332948552 1 VFD 380 V VFD102N315T4 332948553 1
VFD 575V VFD102N132T7 332948545 1 VFD 575V VFD102N160T7 332948546 1 VFD 575V VFD102N200T7 332948554 1 VFD 575V VFD102N250T7 332948555 1 VFD 575V VFD102N315T7 332948556 1 VFD 575V VFD102N400T7 332948557 1
VFD
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 21
Valves and Flow Switch
Ref. Part Part Qty. No. Description Number F21 Evaporator Shut-Off Valve 735039964 1 F24 Evaporator Relief Valve 735045829 2
F31 Condenser Shut-Off Valve 735039964 1 F34 Condenser Relief Valve 735045834 2
SK03 Shut-Off Valve 735039929 5 SK04 Valve Core 047135507 4 SK05 Valve Cap 032943500 3
N/S Flow Switch with Adapter 331893901 2 Flow Switch Cable, 15M 349906901 2
SK04
SK04
F21F24
F34
F31
SK03
SK03
SK03SK05
SK05SK04
SK03
SK04
SK05
N/S= Not shown
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 22
InsulationCompressor Motor, Evaporator Vessel & Head
Code 02 Part Part JNNS MNNS RNNS Description Number Single Insulation, Compressor Motor 047662050 25 sq ft 28 sq ft 30 sq ft (Code 72= H, J) Double Insulation, Compressor Motor 047662050 56 sq ft 62 sq ft 68 sq ft (Code 72= 3, K)
Code 10 Part Part E1610 E2010 E2410 Description Number Insulation, Evap Vessel 047662050 66 sq ft 81 sq ft 96 sq ft
Insulation, Evap Head 047662050 6 sq ft 9 sq ft 10 sq ft
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 23
InsulationCompressor Sound Enclosure
N/S= Not shown
Code 02 Ref. Part Description Quantity No. IN01 Insulation Panel, Base 1 332950700 332950701 332950702 IN02 Insulation Panel, Discharge End 1 332950733 332950734 332950735 IN03 Insulation Panel, Suction End RH 1 332950710 332950711 332950712 IN04 Insulation Panel, Suction End LH 1 332950720 332950721 332950722 IN05 Insulation Panel, Corners 4 332950730 332950731 332950732 IN06 Insulation Panel, Door 2 332950750 332950751 332950752 IN07 Insulation Panel,Top, Discharge End 1 332950745 332950746 332950747 IN08 Insulation Panel, Top, Suction End 1 332950740 332950741 332950742 IN09 Insulation Panel, Base Cover 1 -- -- 332950709 N/S Gasket, Black Neoprene .75 x .125 070199209 070199209 070199209 24 ft. 25 ft. 26 ft. N/S Edging Gasket with Metal Core 4 ft. 332945380 332945380 332945380 N/S Panel Latch 8 331995102 331995102 331995102
JNNS MNNS RNNS
IN01
IN04
IN02
IN09
IN06
IN03
IN08
IN07
IN05
RNNS only
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 24
Unit ControlsDevice ID Label
For any control component not detailed on the following pages, refer to the Device ID label found inside the control panel (sample shown below) or contact Daikin Applied with the Control Box GOI number and/or the Unit GO number and Unit serial number.
S a m p l e
S a m p l e
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 25
Unit ControlsControl Box Layout Diagram
GRF1
GLG1
DS1
Q12
F120A
KT2
K11 T1F10
F11
UC
SAUNITSW
RR
CC1
EEXV1
CT-GFR1
M10
F120B
COMM
K13F121A
F121B T2
Q13
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 26
Unit ControlsCommon Control Box Components
Schem. Part Part Qty. Sym. Description Number CC1 Circuit Control Module 193407501 1
CT-GFR1 Sensor, Ground Fault 349937411 1
DS1 Disconnect Switch, 250A (380, 400, 460V) * 300061925 1 DS1 Disconnect Switch, 250A (575V) * 193551602 1 DS1 Disconnect Switch, 400A * 193551701 DS1 Disconnect Switch, 600A * 193551801 1
EEXV1 Evaporator Expansion Valve Module 193407901 1 Cable for Evap Expansion Valve 349945083 1
F13 Switch, High Pressure, 270 psi (not shown on diagram) 074796310 1
GFR1 Relay, Ground Fault 193466201 1 GLG1 Ground Lug 349938012 1
K11 Relay, Emergency Stop,120VAC, 3PDT 349934923 1 Socket for Emergency Stop Relay 349935021 1
K13 Relay, High Pressure Switch 349934721 1 Socket for High Pressure Switch Relay 300044070 1
KT2 Thermostat, Disc 120/240 VAC, N.O. 193418404 1
LCD1 Door Mounted Display (not shown on diagram) 193408002 1 HMI Cable for Door Mounted Display 193423901 1
M10 Control Box Exhaust Fan, 300 CFM, 120VAC 193419102 1 Exhaust Fan Cord, 72 inches 193420402 1 Exhaust Fan Guard, 6.7 inch diameter 193420302 1
Q11 Push Button Switch, Emergency Stop, Door Mount (not shown on diagram) 193441102 1
RES50 Resistor, 50 ohm (not shown on diagram) 349945090 1
RR Rapid Restore Module 193407701 1
SA Surge Absorber 332606801 1
UC Unit Controller, MTIII 193407201 1 Battery for Unit Controller 193409001 1
UNIT SW Unit Switch 802005045 1
50%SV-1 75%SV-1 Solenoid Connector with MOV (not shown on diagram) 331996402 3 100%SV-1 YMO1 Solenoid Connector with MOV (not shown on diagram) 331996402 1
*To determine correct DS1, see the Control Box label or contact Daikin Applied.
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 27
Unit ControlsTransformers, Fuses, Sensors, Transducers
Schem. Part Part Qty. Sym. Description Number T1 Transformer 1KVA, 380V - 120V 349984101 1 T1 Transformer 1KVA, 460V - 120V 099477105 1 T1 Transformer 1KVA, 575V - 120V 099477305 1 T1 Transformer 1KVA, 400V/50 Hz - 120V 193566001 1
T2 Transformer 100VA, 120/240V - 24V 099477123 1
F10 Fuse- Vent Fan Time Delay, 2A 349937116 1
F11 Fuse- 120V Control Circuit Time Delay 10A 349937131 1
F120A,B Fuse- T1 Transformer, Primary Time Delay, 5A 349937124 2 Q12 Fuse- T1 Transformer, Secondary Midget, Time Delay, 12A 349937033 1
F121A,B Fuse- T2 Transformer, Primary Time Delay 4A 349937123 2 Q13 Fuse- T2 transformer, Secondary Midget, Delay, 6A 349937027 1
Schem. Part Part Qty. Sym. Description Number EP-1 Transducer- Low Pressure 333992043 1
OP-1, CP-1 Transducer- High Pressure 333992042 2
N/S Cable for Transducers, 20 ft. (includes Boot) 335793003 4 N/S Cable for Transducers, 25 ft. (includes Boot) 335793004 4N/S = Not Shown
Schem. Part Part Qty. Sym. Description Number CEWT, CLWT, EEWT, ELWT, Temperature Sensor, 25 ft. 332544305 7 DT-1, LT-1, ST-1
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 28
Ref. Description Part Qty. No. Number COMM BACnet MS/TP Installation Kit 335788902 1
BACnet MS/TP
Ref. Description Part Qty. No. Number COMM MODBUS Installation Kit 335788903 1
MODBUS
Ref. Description Part Qty. No. Number COMM LonMark Installation Kit 335788901 1
LonMark
Unit ControlsCommunication Modules
Ref. Description Part Qty. No. Number COMM BACnet IP Installation Kit 335788904 1
BACnet IP
Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 29
Field Installed Accessories
Rapid Restore Field Install Kit
Description Part No. Rapid Restore Field Install Kit 193503108
Ground Fault Relay Kit
Description Part No. Ground Fault Relay Kit 349982802
Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs.To Locate A Distributor, Go To www.DaikinApplied.com or Call 1-800-37PARTS
Critical Daikin Applied OEM PartsAre What Your HVAC Unit Needs!
Daikin Water-Cooled Screw ChillerWWV
Compressors JNNS, MNNS, RNNSVintage A
7000534 Rev. D 03/20 CPL Page 1 of 1
CRITICALCOMPONENTS UNIT SIZE VOLTAGE PART NUMBERCONTROLS
UC MTIII Unit Controller ALL ALL 193407201 Battery for MTIII Unit Controller ALL ALL 193409001
EEXV1 Electronic Expansion Valve Module ALL ALL 19340790
KT2 Thermostat, Disc ALL ALL 193418404
EP-1 Transducer- Low Pressure ALL ALL 333992043 OP-1,CP-1 Transducer- High Pressure ALL ALL 333992042
F13 Switch- High Pressure ALL ALL 074796310
UNIT SW Unit Switch ALL ALL 802005045
COMPRESSORS Compressor JNNS 460V 332948653 Compressor MNNS 460V 332948663 Compressor RNNS 460V 332948673
Top Related