Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV...

30
Replacement Parts List No. 700053400 Revision D 03/2020 Daikin Navigator ® Water-Cooled Screw Compressor Chiller WWV JNNS, MNNS, RNNS Vintage A To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.DaikinApplied.com

Transcript of Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV...

Page 1: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Replacement Parts List No. 700053400 Revision D 03/2020

DaikinNavigator®

Water-Cooled Screw Compressor Chiller

WWVJNNS, MNNS, RNNS

Vintage A

To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.DaikinApplied.com

Page 2: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 2

Contents

Parts List Revision History.................................................................................................................................. 3Nomenclature Serial Number & Unit Model Number ........................................................................................................... 4 Unit Model Number- Complete ............................................................................................................... 5 - 8Electrical Legend ................................................................................................................................................ 9Unit Layout Diagram ......................................................................................................................................... 10Refrigeration Section Compressor ................................................................................................................................................11 Liquid Line .................................................................................................................................................. 12 Jet Pump Line ............................................................................................................................................ 13 Suction Line ........................................................................................................................................ 14 - 15 Discharge Line .................................................................................................................................... 16 - 17 Oil Line ....................................................................................................................................................... 18 Evaporator and Condenser ........................................................................................................................ 19VFD .................................................................................................................................................................. 20Valves and Flow Switch .................................................................................................................................... 21Insulation Compressor Motor, Evaporator Vessel & Head ......................................................................................... 22 Compressor Sound Enclosure ................................................................................................................... 23Unit Controls Device ID Label .......................................................................................................................................... 24 Control Box Layout Diagram ...................................................................................................................... 25 Common Control Box Components ........................................................................................................... 26 Transformers, Fuses, Sensors, Transducers ............................................................................................. 27 Communication Modules ........................................................................................................................... 28Field Installed Accessories Rapid Restore Field Install Kit .................................................................................................................... 29 Ground Fault Relay Kit ............................................................................................................................... 29

Page 3: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 3

Parts List Revision History

Revision Date Description NEW 01/2018 New A 02/2018 Page 6: Code 38- removed option 2, added option S. Code 40- Removed options H and J. Page 7: Code 67- Added option L. Page 18: Added part # for Sensor Well. Page 24: Changed Schem. Sym. for Solenoid Connector w/MOV, were Y1B1, Y2B1, Y3B1. B 09/2018 Page 20: Corrected Ref. F31 and F34, were flip-flopped. C 02/2020 Pages 5-8: Updated Unit Model Nomenclature. Page 9: Added F13 High Pressure Switch. Page 11: Updated part #s for 575V Compressors, added 380V Compressors. Page 16: Added "Without Shut-Off Valve" to title. Page 17: New page for Discharge Line With Shut-Off Valve. Page 18: Updated part #s for YMO-1 Solenoid Valve, were 331761609 and 331761608. Page 20: Added VFD102N315T4. Changed 460V description to 380, 460V. Page 22: Added Double Insulation. Page 23: New page for Insulation- Compressor Sound Enclosure. Page 26: Updated part # for DS1 Disconnect Swith 250A 380-460V, added 250A 575V. Added Cable for EEXV1 Electronic Exp Valve. Updated part # for RR Rapid Restore, was 193407601. Page 27: Added Temperature Sensors. Updated part #s for Transducer Cables, were 910217971, -72, -73, -74. Removed Transducer Boot. Page CPL1: Corrected part # for Low Pressure Transducer, was 333992041. D 03/2020 Page 28: Corrected part #s for Communication Modules, were 350147415, -14, -13, -12.

Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330

Page 4: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 4

NomenclatureSerial Number & Unit Model Number

WWV JNNS A SN

Unit Model Number

Unit Type: WWV= Water- Cooled World VFD Screw Compressor Chiller

Compressor Size

Vintage

ConfigurationSN= Single Refrigerant Circuit w/o Economizer

STN U 17 05 03800

Plant IdentificationSTN = Staunton, VA

Year of Manufacture17= 201718= 201819= 2019 20= 2020

etc.

U= Unit

Serial Number (build sequence)

Month of Manufacture01= January02= February03= March04= April05= May06= June

07= July08= August09= September10= October11= November12= December

Serial Number

Page 5: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 5

NomenclatureUnit Model Number- Complete

WWV JNNS A SN AC 00460 H6 D A E2010 GB 2 C DZ L 2 V C N M 4 440FCode 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22

00580 C C A A C2010 HB 2 C A2 N N N NN L 1 V A N L 4 1050F 00725 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45

C C N N NN A A 0150 A 0700 S2 MD E N N A 01020 S D P N H H N 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69

N N H 2 B 1 5 A N N A F N N E A N N J 000 U Y N 0 A N S S70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97

U A 02487 NNNNNNNNNN ND W NNNNN 00000 01020 00000 05156 VFD102N132T498 99 100 101 102 103 104 105 106 107 108 109

VFDNNNNNNNNN 123H NNNH N L 110 111 112 113 114

02 Compressor Size JNNS - Single Compressor MNNS - Single Compressor RNNS - Single Compressor

03 Vintage A= Vintage A

04 Chiller Configuration SN= Single Refrigerant Circuit w/o Economizer

05 Compressor Motor Type AC= AC Power

06 Power Supply Voltage 00380= 380V 00400= 400V 00460= 460V 00575= 575V

07 Power Supply Hertz H5= 50 Hertz H6= 60 Hertz 08 Always D

09 Compressor Model Revision A= Revision A

10 Evaporator Shell Diameter and Length E1610= 16" Diameter Shell, 10' Length E2010= 20" Diameter Shell, 10' Length E2410= 24" Diameter Shell, 10' Length

11 Evaporator Tube Count 16" 20" 24" GB= 136 190 235 HB= 120 154 188 JB= 108 -- 170 KB= 80 -- --

12 Evaporator Tube Thickness 2= 0.025

13 Evaporator Tube Type C= CU

14 Evaporator Tube Model

15 Evaporator Inlet Nozzle Location L= Left R= Right

16 Evaporator Water Passes 2= 2 Pass

17 Evaporator Inlet Nozzle Connection Type V= Groove F= Flanged

18 Evaporator Inlet Nozzle Configuration C= Dish, 2 or 3 Pass, Entering End/Bottom, Leaving End/Top H= Wtr Box, 2 or 3 Pass, Entering Rear, Leaving Rear J= Wtr Box, 2 or 3 Pass, Entering Front, Leaving Front L= Wtr Box, 2 or 3 Pass, Entering Rear, Leaving Top M= Wtr Box, 2 or 3 Pass, Entering Front, Leaving Top

19 Evaporator Hinge Type N= None

20 Evaporator Refrigerant Design Pressure M= 232 PSIG

21 Evaporator Water Side Design Pressure 4= 150 PSIG- Non ASME Code

Page 6: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6

22 Evaporator Leaving Water Temperature Ex. 440F= 44.0 F

23 Evaporator GPM Ex. 00580= 580 GPM

24 Evaporator Tube Sheet Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy

25 Evaporator Head/Water Box Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy 26 Evaporator Tube Cleaning System N= None

27 Evaporator Model Revision A= Revision A

28 Condenser Shell Diameter and Length C1810= 18" Diameter Shell, 10' Length C2010= 20" Diameter Shell, 10' Length C2410= 24" Diameter Shell, 10' Length

29 Condenser Tube Count 18" 20" 24" HB= 150 221 290 JB= 130 185 244 KB= 109 -- --

30 Condenser Tube Thickness 2= 0.025

31 Condenser Tube Type C= CU

32 Condenser Tube Model

33-35 Always N

36 Always NN

37 Condenser Inlet Nozzle Location L= Left R= Right

38 Condenser Water Passes 1= 1 Pass S= 1 Pass with same end connection

39 Condenser Inlet Nozzle Connection Type V= Groove F= Flanged

40 Condenser Inlet Nozzle Configuration A= Dish, 1 Pass, Entering End/Center, Leaving End/Center E= Wtr Box, 1 Pass, Entering Rear, Leaving Rear F= Wtr Box, 1 Pass, Entering Front, Leaving Front

41 Condenser Hinge Type N= None

42 Condenser Refrigerant Design Pressure L= 319 PSIG

43 Condenser Water Side Design Pressure 4= 150 PSIG- Non ASME Code

44 Condenser Leaving Water Temperature Ex. 1050F= 105.0 F

45 Condenser GPM Ex. 00725= 725 GPM

46 Condenser Tube Sheet Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy

47 Condenser Head/Water Box Coating/Material C= Carbon Steel E= Enecon Coating- Ceramalloy 48-49 Always N

50 Always NN

51 Condenser Model Revision A= Revision A

52 Pressure Vessel Code A= ASME 1= CRN- British Columbia 2= CRN- Alberta 3= CRN- Saskatchewan 4= CRN- Manitoba 5= CRN- Ontario 6= CRN- Quebec 7= CRN- New Brunswick 8= CRN- Nova Scotia 9= CRN- Prince Edward Island 0= CRN- Newfoundland F= Nunavut U= CRN- Yukon W= Northwest Territories

NomenclatureUnit Model Number- Complete

Page 7: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 7

53 Unit Tons Ex. 0150= 150 Tons

54 Refrigerant A= 134A

55 Refrigerant Quantity Ex. 0700= 700 pounds

56 Expansion Valve Type S2= Electr Exp Valve, single actuator, 250 Tons S4= Electr Exp Valve, single actuator, 400 Tons

57 Controller Type MD= MicroTech III w/Door Mounted Display

58 Language E= English

59 Controller Rapid Restore N= None R= Rapid Restore

60 Controller Communications N= None B= BACnet MS/TP E= BACnet IP L= Lonmark M= Modbus

61 Power Box and Unit Controller Box Type A= NEMA 1

62 Input Rated Load Amps (RLA) - Compressor 1 Ex. 01020= 12.0 Amps

63 Power Box, Box Type S= Single Point, Single Box

64 Power Connection Type D= Disconnect Switch

65 EMI Filter P= EMI Filter

66 Intelligent Equipment N= None

67 Short Circuit Ratings H= High, 65 KA L= Low, 25KA

68 Ground Fault Protection N= None F= With GFP

69 Harmonic Filter N= None

70 Hot Gas Bypass N= None

71 Compressor Sound Reduction N= None C= Discharge Line Wrap and Compressor Sound Reduction D= Discharge Line Wrap S= Compressor Sound Reduction

72 Vessel Insulation H= .75 Insul Evap Shell, Suct Piping, Compr Inlet, Motor Barrel 3= 1.5 Insul Evap Shell, Suct Piping, Compr Inlet, Motor Barrel J= .75 Insul Evap Shell, Suct Piping K= 1.5 Insul Evap Shell, Suct Piping

73 Head Insulation 2= Evap OPP & ENT Heads Insulated

74 Factory Water Flow Indicator B= Both Evap and Cond Flow Control

75 Exterior Painting 1= Standard Painting

76 Shipping

77 Refrigerant Charge 78 Special N= None X= Special

79 Low Lift Conditions N= None

80 Knockdown

81- 83 Testing

84 Agency Listing E= ETL/cETL N= None

85 AHRI Listing A= AHRI N= None

86 ASHRAE Listing A= ASHRAE N= None

87 OSP-IBC Listing N= None

88 Brand Name J= Daikin

89 Future

90 Startup

NomenclatureUnit Model Number- Complete

Page 8: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 8

NomenclatureUnit Model Number- Complete

91 Standard Chiller Warranty Y= Domestic and Canadian-1 Yr Parts & Labor P= Export- 1 Year Parts Only

92 Extended Chiller Warranty N= None A= 1 Yr Parts Only B= 1 Yr Parts & Labor C= 2 Yr Parts Only D= 2 Yr Parts & Labor E= 3 Yr Parts Only F= 3 Yr Parts & Labor G= 4 Yr Parts Only H= 4 Yr Parts & Labor J= 5 Yr Parts Only K= 5 Yr Parts & Labor L= 6 Yr Parts Only M= 6 Yr Parts & Labor P= 7 Yr Parts Only Q= 7 Yr Parts & Labor R= 8 Yr Parts Only S= 8 Yr Parts & Labor T= 9 Yr Parts Only V= 9 Yr Parts & Labor

93 Refrigerant Warranty 0= None B= 1 Yr D= 2 Yr F= 3 Yr H= 4 Yr K= 5 Yr

94 Delayed Warranty Start A= 0 Additional Months B= 2 Additional Months C= 4 Additional Months D= 6 Additional Months E= 8 Additional Months F= 10 Additional Months G= 12 Additional Months

95 Extended Compressor Warranty N= None A= 1 Yr Parts Only B= 1 Yr Parts & Labor C= 2 Yr Parts Only D= 2 Yr Parts & Labor E= 3 Yr Parts Only F= 3 Yr Parts & Labor G= 4 Yr Parts Only H= 4 Yr Parts & Labor J= 5 Yr Parts Only K= 5 Yr Parts & Labor L= 6 Yr Parts Only M= 6 Yr Parts & Labor P= 7 Yr Parts Only Q= 7 Yr Parts & Labor R= 8 Yr Parts Only S= 8 Yr Parts & Labor T= 9 Yr Parts Only V= 9 Yr Parts & Labor

96 Standard Ship

97 Miscellaneous

98 Manufacturing

99 Model Revision A= Revision Level A B= Revision Level B

100 Unit kW Ex. 02487 = 248.7 kW

101 Stock Modifications

102 Isolation Valves ND= Without Suct or Discharge Shut-off Valve WV= With Suct and Discharge Shut-off Valve

103 Always W

104 Always NNNNN

105 Always 00000

106 Output Amps Ex. 01020 = 102.0 Amps

107 Always 00000

108 IPLV Ex. 05156 = 0.5156 kW/Ton

109 VFD #1 Size VFD102N132T4= 132 kW, 380- 460V VFD102N160T4= 160 kW, 380- 460V VFD102N200T4= 200 kW, 380- 460V VFD102N250T4= 250 kW, 380- 460V VFD102N315T4= 315 kW, 380-460VV VFD102N132T7= 132 kW, 575V VFD102N160T7= 160 kW, 575V VFD102N200T7= 200 kW, 575V VFD102N250T7= 250 kW, 575V VFD102N315T7= 315 kW, 575V VFD102N400T7= 400 kW, 575V

110 VFD #2 Size VFDNNNNNNNNN= None

111-112 Operating Hertz

113 Liquid Injection N= None

114 Altitude L*****= Lower Altitude (less than or equal to 1000M) H*****= Higher Altitude (greater than 1000M)

Page 9: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 9

Electrical Legend

Schem. Sym. Description C Terminal Blocks CC1 Controller Expansion Module CEWT Condenser Entering Water Temperature CLWT Condenser Leaving Water Temperature CNT1A Multi Cable Harnesses Connector CNT1B Temperature Sensors Connectors CMP-M1 Compressor Motors COND FLOW SW Condenser Flow Switch CP1 Condenser Pressure Transducer CT- GFR1 Current Sensor Ground Fault DS1 Disconnect Switch DT-1 Discharge Temperature Sensor EEWT Evaporator Entering Water Temperature EEXV1 Electronic Expansion Valve Module ELWT Evaporator Leaving Water Temperature EP-1 Evaporator Pressure Transducer EVAP FLOW SW Evaporator Flow Switch EVEXV-1 Evaporator Electronic Expansion Valve F10 Fuse Block Ventilation Fan F11 Fuse Block for 120V Control Circuits F13 High Pressure Switch F120A, 120B T1 Transformer Primary Fuse Block F121A, 121B T2 Transformer Primary Fuse Block GFR1 Ground Fault Relay GLG1 Main Panel Ground GND Single Point Ground Terminal Block GND10 Ventilation Fan Ground GND11 T1 Ground K11 Emergency Stop Relay K13 High Pressure Switch Relay KT2 Thermostat LCD1 Door Mounted Display LT-1 Liquid Line Temperature Sensor M5 Field Wiring Terminal Blocks M10 Exhaust Fan M10-1 Intake Grill MQ 120V Terminal Blocks MS 24V Terminal Blocks OP-1 Oil Pressure Transducer PE1 Ground Bar PS-IE 24VDC Power Supply Q11 E-STOP Push Button Q12 T1 Secondary Fuse Q13 T3 Secondary Fuse RES50 50 Ohm Terminated Resistor RR Rapid Restore SA Surge Absorber SC1, 2 Shielded Wires Terminal Block ST-1 Suction Temperature Sensor T1 Control Transformer- Main Power T2 Control Transformer- 24 Secondary UC Main Unit Controller Unit Switch Switch 50%SV-1 50% VR Solenoid, Ckt #1 75%SV-1 75% VR Solenoid, Ckt #1 100%SV-1 100% VR Solenoid, Ckt #1 YJP1 Jet Pump Solenoid YMO1 Oil Return Solenoid

Page 10: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 10

Unit Layout Diagram

Liquid Line

Discharge LineSuction Line

CompressorVFD

Evaporator

Condenser

Control Box

Page 11: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 11

Refrigeration SectionCompressor

380V

460V

575V

380V

460V

575V

380V

460V

575V

Code 02 JNNS MNNS RNNS

Part Part Description Number Compressor 332948658 1 Compressor 332948653 1 Compressor 332948659 1

Compressor 332948668 1 Compressor 332948663 1 Compressor 332948669 1

Compressor 332948678 1 Compressor 332948673 1 Compressor 332948679 1

Screw, Compr Mounting, M12 x 1.75 330821907 4 4 4 4 4 4 4 4 4 Lock Washer, Compr Mounting 048164814 4 4 4 4 4 4 4 4 4 Plain Washer, Compr Mounting 040500310 4 4 4 4 4 4 4 4 4

Immersion Well 131506010 1 1 1 1 1 1 1 1 1 Immersion Well Bushing 132010016 1 1 1 1 1 1 1 1 1 Oil Temp Sensor Well 118510358 1 1 1 1 1 1 1 1 1 Ground Lug 132010035 1 1 1 1 1 1 1 1 1 Oil Filter 332115201 1 1 1 1 1 1 1 1 1

Page 12: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 12

Refrigeration SectionLiquid Line

Ref. Part Part No. Description Number Qty. L102 Shut Off Valve, 2.125 Code 56= S2 & Code 102= WV 330296046 1 L102 Shut Off Valve, 2.625 Code 56= S4 & Code 102= WV 330296047 1

L106 Electronic Expansion Valve, 250 Ton Code 56= S2 333935801 1 L106 Electronic Expansion Valve, 400 Ton Code 56= S4 333935802 1

L102

L106

Note: Code 56= S2 when Code 02= JNNS; Code 56= S4 when Code 02= MNNS or RNNS

Page 13: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 13

Refrigeration SectionJet Pump Line

Ref. Part Part No. Description Number Qty. Jet Pump, Complete Assy 332950260 1

JP01

to Compressor

Page 14: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 14

Refrigeration SectionSuction Line without Shut Off Valve (Code 102= ND)

S06

S06

S07

S07

S06

Code 02= JNNNS or MNNNSand Code 10= E1610and Code 28= C1810 or C2010

Ref. Description Part No. Qty. S06 Gasket, 7.42 OD x 5.66 ID 070199150 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1

Code 02= MNNNSand Code 10= E2010 or E2410and Code 28= C2010 or C2410

Ref. Description Part No. Qty. S06 Gasket, 8.35 OD x 6.73 ID 070199151 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1

Code 02= RNNNSCode 10= E2010 or E2410Code 28= C2010 or C2410

Ref. Description Part No. Qty. S06 Gasket, 8.35 OD x 6.73 ID 070199151 2

Page 15: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 15

Refrigeration SectionSuction Line with Shut Off Valve (Code 102= WV)

S06

S07

Code 02= JNNNS or MNNNSand Code 10= E1610and Code 28= C1810 or C2010

Ref. Description Part No. Qty. S06 Butterfly Valve, 5 inch 073062130 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1

Code 02= MNNNSand Code 10= E2010 or E2410and Code 28= C2010 or C2410

Ref. Description Part No. Qty. S06 Butterfly Valve, 6 inch 073062131 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1

Code 02= RNNNSCode 10= E2010 or E2410Code 28= C2010 or C2410

Ref. Description Part No. Qty. S06 Butterfly Valve, 6 inch 073062131 1 S07 Gasket, 6.29 OD x 5.51 ID 070199149 1

S07

S07

S06

S06

Page 16: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 16

Refrigeration SectionDischarge Line without Shut Off Valve (Code 102= ND)

Ref. Part Part Qty. No. Description Number Code 02= JNNS or MNNS D25 Gasket, 5.13 OD x 4.44 ID x .06 thick 070199144 1

Code 02= RNNS D25 Gasket, 7.42 OD x 5.91 ID x .06 thick 070199152 1

D25

Page 17: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 17

Refrigeration SectionDischarge Line with Shut Off Valve (Code 102= WV)

Ref. Part Part Qty. No. Description Number Code 02= JNNS or MNNS D05 Shut-Off Valve 332948590 1 D25 Gasket, 5.13 OD x 4.44 ID x .06 thick 070199144 1

Code 02= RNNS D05 Shut-Off Valve 332949151 1 D25 Gasket, 7.42 OD x 5.91 ID x .06 thick 070199152 1 D26 Gasket, 10.75 OD x 5.66 ID x .06 thick 070199035 2

D25

D25

D26

D05

D05

Page 18: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 18

Refrigeration SectionOil Line

E1610/ E1610/ E1610/ E2010/ C1810 C1810 C2010 C2010

E1610/ E2010/ E2410/ C2010 C2010 C2410 E2410/ C2410

YMO-1 OL07 OL20

OL01OL20

Code 02 JNNS MNNS RNNS Code 10 / Code 28 Ref. Part Part No. Description Number OL01 Shut-Off Valve 735039953 1 1 1 1

YMO-1 Solenoid Valve, 1.125 331451005 1 1 YMO-1 Solenoid Valve, 1.375 331451006 1 1

OL07 Sight Glass, 1.125 330508602 1 1 OL07 Sight Glass, 1.375 015997808 1 1

OL20 Ring Seal 736017605 2 2 2 2

Page 19: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 19

Refrigeration SectionEvaporator and Condenser

To identify any other components pertaining to the Evaporator or Condenser, please contact Daikin Applied.

Part Part Qty. Description Number Sensor Well 332948751 4

Page 20: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 20

VFD

Part Part Qty. Description Code 109 Number VFD 380, 400, 460V VFD102N132T4 332948542 1 VFD 380, 400, 460V VFD102N160T4 332948543 1 VFD 380, 400, 460V VFD102N200T4 332948551 1 VFD 380, 400, 460V VFD102N250T4 332948552 1 VFD 380 V VFD102N315T4 332948553 1

VFD 575V VFD102N132T7 332948545 1 VFD 575V VFD102N160T7 332948546 1 VFD 575V VFD102N200T7 332948554 1 VFD 575V VFD102N250T7 332948555 1 VFD 575V VFD102N315T7 332948556 1 VFD 575V VFD102N400T7 332948557 1

VFD

Page 21: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 21

Valves and Flow Switch

Ref. Part Part Qty. No. Description Number F21 Evaporator Shut-Off Valve 735039964 1 F24 Evaporator Relief Valve 735045829 2

F31 Condenser Shut-Off Valve 735039964 1 F34 Condenser Relief Valve 735045834 2

SK03 Shut-Off Valve 735039929 5 SK04 Valve Core 047135507 4 SK05 Valve Cap 032943500 3

N/S Flow Switch with Adapter 331893901 2 Flow Switch Cable, 15M 349906901 2

SK04

SK04

F21F24

F34

F31

SK03

SK03

SK03SK05

SK05SK04

SK03

SK04

SK05

N/S= Not shown

Page 22: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 22

InsulationCompressor Motor, Evaporator Vessel & Head

Code 02 Part Part JNNS MNNS RNNS Description Number Single Insulation, Compressor Motor 047662050 25 sq ft 28 sq ft 30 sq ft (Code 72= H, J) Double Insulation, Compressor Motor 047662050 56 sq ft 62 sq ft 68 sq ft (Code 72= 3, K)

Code 10 Part Part E1610 E2010 E2410 Description Number Insulation, Evap Vessel 047662050 66 sq ft 81 sq ft 96 sq ft

Insulation, Evap Head 047662050 6 sq ft 9 sq ft 10 sq ft

Page 23: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 23

InsulationCompressor Sound Enclosure

N/S= Not shown

Code 02 Ref. Part Description Quantity No. IN01 Insulation Panel, Base 1 332950700 332950701 332950702 IN02 Insulation Panel, Discharge End 1 332950733 332950734 332950735 IN03 Insulation Panel, Suction End RH 1 332950710 332950711 332950712 IN04 Insulation Panel, Suction End LH 1 332950720 332950721 332950722 IN05 Insulation Panel, Corners 4 332950730 332950731 332950732 IN06 Insulation Panel, Door 2 332950750 332950751 332950752 IN07 Insulation Panel,Top, Discharge End 1 332950745 332950746 332950747 IN08 Insulation Panel, Top, Suction End 1 332950740 332950741 332950742 IN09 Insulation Panel, Base Cover 1 -- -- 332950709 N/S Gasket, Black Neoprene .75 x .125 070199209 070199209 070199209 24 ft. 25 ft. 26 ft. N/S Edging Gasket with Metal Core 4 ft. 332945380 332945380 332945380 N/S Panel Latch 8 331995102 331995102 331995102

JNNS MNNS RNNS

IN01

IN04

IN02

IN09

IN06

IN03

IN08

IN07

IN05

RNNS only

Page 24: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 24

Unit ControlsDevice ID Label

For any control component not detailed on the following pages, refer to the Device ID label found inside the control panel (sample shown below) or contact Daikin Applied with the Control Box GOI number and/or the Unit GO number and Unit serial number.

S a m p l e

S a m p l e

Page 25: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 25

Unit ControlsControl Box Layout Diagram

GRF1

GLG1

DS1

Q12

F120A

KT2

K11 T1F10

F11

UC

SAUNITSW

RR

CC1

EEXV1

CT-GFR1

M10

F120B

COMM

K13F121A

F121B T2

Q13

Page 26: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 26

Unit ControlsCommon Control Box Components

Schem. Part Part Qty. Sym. Description Number CC1 Circuit Control Module 193407501 1

CT-GFR1 Sensor, Ground Fault 349937411 1

DS1 Disconnect Switch, 250A (380, 400, 460V) * 300061925 1 DS1 Disconnect Switch, 250A (575V) * 193551602 1 DS1 Disconnect Switch, 400A * 193551701 DS1 Disconnect Switch, 600A * 193551801 1

EEXV1 Evaporator Expansion Valve Module 193407901 1 Cable for Evap Expansion Valve 349945083 1

F13 Switch, High Pressure, 270 psi (not shown on diagram) 074796310 1

GFR1 Relay, Ground Fault 193466201 1 GLG1 Ground Lug 349938012 1

K11 Relay, Emergency Stop,120VAC, 3PDT 349934923 1 Socket for Emergency Stop Relay 349935021 1

K13 Relay, High Pressure Switch 349934721 1 Socket for High Pressure Switch Relay 300044070 1

KT2 Thermostat, Disc 120/240 VAC, N.O. 193418404 1

LCD1 Door Mounted Display (not shown on diagram) 193408002 1 HMI Cable for Door Mounted Display 193423901 1

M10 Control Box Exhaust Fan, 300 CFM, 120VAC 193419102 1 Exhaust Fan Cord, 72 inches 193420402 1 Exhaust Fan Guard, 6.7 inch diameter 193420302 1

Q11 Push Button Switch, Emergency Stop, Door Mount (not shown on diagram) 193441102 1

RES50 Resistor, 50 ohm (not shown on diagram) 349945090 1

RR Rapid Restore Module 193407701 1

SA Surge Absorber 332606801 1

UC Unit Controller, MTIII 193407201 1 Battery for Unit Controller 193409001 1

UNIT SW Unit Switch 802005045 1

50%SV-1 75%SV-1 Solenoid Connector with MOV (not shown on diagram) 331996402 3 100%SV-1 YMO1 Solenoid Connector with MOV (not shown on diagram) 331996402 1

*To determine correct DS1, see the Control Box label or contact Daikin Applied.

Page 27: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 27

Unit ControlsTransformers, Fuses, Sensors, Transducers

Schem. Part Part Qty. Sym. Description Number T1 Transformer 1KVA, 380V - 120V 349984101 1 T1 Transformer 1KVA, 460V - 120V 099477105 1 T1 Transformer 1KVA, 575V - 120V 099477305 1 T1 Transformer 1KVA, 400V/50 Hz - 120V 193566001 1

T2 Transformer 100VA, 120/240V - 24V 099477123 1

F10 Fuse- Vent Fan Time Delay, 2A 349937116 1

F11 Fuse- 120V Control Circuit Time Delay 10A 349937131 1

F120A,B Fuse- T1 Transformer, Primary Time Delay, 5A 349937124 2 Q12 Fuse- T1 Transformer, Secondary Midget, Time Delay, 12A 349937033 1

F121A,B Fuse- T2 Transformer, Primary Time Delay 4A 349937123 2 Q13 Fuse- T2 transformer, Secondary Midget, Delay, 6A 349937027 1

Schem. Part Part Qty. Sym. Description Number EP-1 Transducer- Low Pressure 333992043 1

OP-1, CP-1 Transducer- High Pressure 333992042 2

N/S Cable for Transducers, 20 ft. (includes Boot) 335793003 4 N/S Cable for Transducers, 25 ft. (includes Boot) 335793004 4N/S = Not Shown

Schem. Part Part Qty. Sym. Description Number CEWT, CLWT, EEWT, ELWT, Temperature Sensor, 25 ft. 332544305 7 DT-1, LT-1, ST-1

Page 28: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 28

Ref. Description Part Qty. No. Number COMM BACnet MS/TP Installation Kit 335788902 1

BACnet MS/TP

Ref. Description Part Qty. No. Number COMM MODBUS Installation Kit 335788903 1

MODBUS

Ref. Description Part Qty. No. Number COMM LonMark Installation Kit 335788901 1

LonMark

Unit ControlsCommunication Modules

Ref. Description Part Qty. No. Number COMM BACnet IP Installation Kit 335788904 1

BACnet IP

Page 29: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 29

Field Installed Accessories

Rapid Restore Field Install Kit

Description Part No. Rapid Restore Field Install Kit 193503108

Ground Fault Relay Kit

Description Part No. Ground Fault Relay Kit 349982802

Page 30: Navigator Water-Cooled Screw Compressor Chiller · Water Cooled World VFD Screw Chiller, WWV Vintage A Rev. D 03/2020 RPL 7000534 / Page 6 22 Evaporator Leaving Water Temperature

Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs.To Locate A Distributor, Go To www.DaikinApplied.com or Call 1-800-37PARTS

Critical Daikin Applied OEM PartsAre What Your HVAC Unit Needs!

Daikin Water-Cooled Screw ChillerWWV

Compressors JNNS, MNNS, RNNSVintage A

7000534 Rev. D 03/20 CPL Page 1 of 1

CRITICALCOMPONENTS UNIT SIZE VOLTAGE PART NUMBERCONTROLS

UC MTIII Unit Controller ALL ALL 193407201 Battery for MTIII Unit Controller ALL ALL 193409001

EEXV1 Electronic Expansion Valve Module ALL ALL 19340790

KT2 Thermostat, Disc ALL ALL 193418404

EP-1 Transducer- Low Pressure ALL ALL 333992043 OP-1,CP-1 Transducer- High Pressure ALL ALL 333992042

F13 Switch- High Pressure ALL ALL 074796310

UNIT SW Unit Switch ALL ALL 802005045

COMPRESSORS Compressor JNNS 460V 332948653 Compressor MNNS 460V 332948663 Compressor RNNS 460V 332948673