Solar Turbines TITAN 130 - Фонд промышленных...
Transcript of Solar Turbines TITAN 130 - Фонд промышленных...
Solar Turbines
A Caterpillar Company
TITAN 130
Gas Turbine Generator Set
General SpecificationsTitan™ 130 Gas Turbine• Industrial, Single-Shaft,
Simple-Cycle• Axial Compressor
-14-Stage- Variable Inlet Guide Vanes
and 5 Stators-Compression Ratio: 17:1- Inlet Airflow:
48.0 kg/sec (105.8 Ib/sec)- Speed: 11,220 rpm- Vertically Split Case
• Combustion Chamber- Single, Annular-Type- Conventional or Lean-Premixed,
Dry, Low Emission (SoLoNOx™)- 21 Fuel Injectors (Conventional)- 14 Fuel Injectors (SoLoNOx)- Torch Ignitor System
• Turbine- 3-Stage, Axial-Flow- Speed: 11,220 rpm
• Bearings- Radial: 3 Tilt-Pad with
Proximity Probes- Thrust: 1 Tilt-Pad with RTD Probes
• Coatings- Compressor: Inorganic Aluminum- Turbine Blades and Nozzles:
Precious Metal Diffusion Aluminide• Vibration Transducer Type
- Velocity- Proximity Probes
Reduction Drive• Epicyclic Type• 1500 or 1800 rpm (50 or 60 Hz)
• Accessory Power Take-Off• Clockwise Rotation
Generator• Type: Salient Pole, 3 Phase, 6 Wire,
Wye Connected, Synchronous, withBrushless Exciter
• Construction Options- Open Drip Proof- Weather Protected II (WPII)- Totally Enclosed Water/Air Cooled
• Sleeve Bearings• Voltage Regulation
- Solid-State Regulation withPermanent Magnet Generator
• Insulation/Rise Options- NEMA Class F with F Rise- NEMA Class F with В Rise
• Voltages: 11,000 to 13,800 Volts• Frequency: 50 or 60 Hz
Key Package Features
• Base Frame with Drip Pans• 316L Stainless Steel Piping <4"• Compression-Type Tube Fittings• Digital Display Panel• Electrical System
- NEC, Class I, Group D, Div 2• PLC-Based Microprocessor
Control System• Control System
- Freestanding Control Console(Optional)
- Color Video Display- Vibration Monitoring- 24-VDC Controls Powered by 120-
VDC Battery/Charger System- Gas Turbine and Generator
Temperature Monitoring
- Serial Link Supervisory Interface- Turbine Performance Map- Historical Displays- Printer/Logger- Predictive Emissions Monitoring- Field ProgrammingStart System- Direct Drive ACFuel Systems- Natural Gas- Distillate- Dual (Gas/Distillate)Integrated Lube Oil System- Turbine-Driven Main Pump- AC Motor-Driven Pre/Post Pump- DC Motor-Driven Backup PumpOil System Options- Oil Cooler- Oil Heater- Tank Vent Separator- Flame TrapCompressor CleaningSystem Options- On-Crank- On-Crank/On-Line- Cleaning TankAir Inlet and ExhaustSystem OptionsEnclosure and Associated OptionsFactory Testing of Turbineand PackageDocumentation- Drawings- Quality Control Data Book- Inspection and Test Plan- Test Reports- Operation and Maintenance
Manuals
Ua
Solar Turbines
A Caterpillar Company
TITAN 130
Gas Turbine Generator Set
PerformanceNo Inlet/Exhaust Losses,Relative Humidity 60%,Natural Gas Fuel withLHV = 31.5 to 43.3 MJ/nm3
(800 to 1100Btu/scf)
Nominal Rating - ISOAt 15°C(59°F), Sea Level
Output Power13500 kWe
Heat Rate10810kJ/kWe-hr(10,250 Btu/kWe-hr)
Exhaust Flow179 770 kg/hr (396,390 Ib/hr)
Exhaust Temperature489°C (913°F)
Available Power
20
DCШ
ОСШШCD
ОСШIa_
55(188) _
18
16
14
12
10• ».; >. § ••.
•?,% - ̂ - -J '4. f L is ran i *. • Ь '
-40 (-40) -20 (-4) 0(32) 20(68) 40(104)INLET AIR TEMPERATURE, "C f F) Dsi30GS-oo2M
Package Dimensions
14630mm(481)
Typical Weight: 86 163 kg (190,000 Ib)Width: 3180 mm (10'5") DS130GS-003M
Solar Turbines IncorporatedP.O. Box 85376San Diego, CA 92186-5376 U.S.A.
Caterpillar is a trademark of Caterpillar Inc.Solar, Titan and SoLoNOxare trademarks of Solar Turbines Incorporated.Specifications subject to change without notice. Printed in U.S.A.© 1999 Solar Turbines Incorporated. All rights reserved.DS130GS/999/2.SM
FOR MORE INFORMATIONTelephone: (+1) 619-544-5352Telefax: (+1) 619-544-2633Internet: www.solarturbines.com