SEACOR GALE CLASS 245 LIFTBOAT - SEACOR Marine · seacor gale class 245’ liftboat class 245’...
3
www.seacorliftboats.com SEACOR GALE CLASS 245’ LIFTBOAT CLASS 245’ LIFTBOAT SEACOR GALE LEG NUMBER OF LEGS 3 LEG LENGTH 245 ft. 74.7 m LEG DIAMETER 72 in 1.8 m LEG WALL 1-1/2 in 3.8 cm LEG TOWER HEIGHT 20 ft. 6.1 m TRIANGLE 84 P/S x 107 AFT 25.6 m P/S x 32.6 m AFT HULL LENGTH 137.5 ft. 41.9 m LENGTH (BARGE ONLY) 132 ft. 40.2 m BEAM 98 ft. 29.9 m BEAM (BARGE ONLY) 92 ft. 28 m HULL DEPTH 13 ft. 4 m DESIGN DRAFT 8.46 ft. 2.6 m REGISTERED TONNAGE 173 t / 126 t INTERNATIONAL TONNAGE 1,303 t / 390 t PAD PAD LENGTH 40 ft. 12.2 m PAD WIDTH 16 ft. 4.9 m PAD DEPTH 4 ft. 1.2 m PAD LOADING N/A DECK LOADING N/A Raked at both ends CRANE PORT STARBOARD MAKE Nautilus Nautilus MODEL 1400L-95 200BT70/100 LOAD RATINGS 250 TONS 30 TONS BOOM TYPE Lattice Telescoping BOOM LENGTH 100 ft. / 30.5 m 100 ft. / 30.5 m CRANE INST. TYPE Pedestal Pedestal ALL PUBLISHED LOAD RATINGS ARE BASED UPON A 20 FT. / 6.1 M RADIUS PROPULSION MAINS - MAKE Caterpillar MAINS - MODEL 3512 HORSEPOWER 1600 BOW THRUSTER EQUIPPED NO CLUTCH MAKE/REDUCTION 5:1 DECK TOTAL DECK AREA 6,550 ft 2 608.5 m 2 APPROXIMATE USABLE DECK AREA 5,500 ft 2 511 m 2 MAXIMUM DECKLOAD 950,000 lbs. 430,912 kg GENERATORS GENERATOR ENGINE MAKE Caterpillar GENERATOR ENGINE MODEL 3412 GENERATOR OUTPUT Two (2) 175 kw AUX GENSET EQUIPPED FULLY EQUIPPED Output : 95 kw CAPACITIES DIESEL FUEL 15,000 USG 56.8 m 3 POTABLE WATER 42,410 USG 160.5 m 3 WATERMAKER EQUIPPED N/A ELECTRONIC AIDS & COMMUNICATIONS COMPASS FULLY EQUIPPED GPS/DGPS FULLY EQUIPPED RADAR(S) FULLY EQUIPPED FATHOMETER FULLY EQUIPPED LOUDHAILER FULLY EQUIPPED SATELLITE PHONE FULLY EQUIPPED PRIVATE FREQ RADIOTELEPHONE FULLY EQUIPPED VHF RADIO FULLY EQUIPPED SINGLE SIDEBAND RADIO FULLY EQUIPPED GMDSS FULLY EQUIPPED PERSONNEL ACCOMMODATIONS TOTAL ACCOMMODATIONS 45 VIP ACCOMMODATIONS 2 CREW ACCOMMODATIONS 9 CONTRACTOR ACCOMMODATIONS 34 TRANSIT PASSENGERS 36 GALLEY & DINING FULLY EQUIPPED TV LOUNGE FULLY EQUIPPED LAUNDRY FACILITY FULLY EQUIPPED AIR CONDITION / HEATER Standard Electrical Commercial Units HELIPORT N/A PERFORMANCE ESTIMATED SPEED 5 mph / 4.34 knots 8 kph MAX SEPARATION, PAD TO DECK 225 ft. 68.6 m MAX WORKING WATER DEPTH 180 ft. 54.9 m MIN WORKING WATER DEPTH 13 ft. 4 m MAX JACKING SOFT BOTTOM 5 ft. 1.5 m SEA STATES HARD BOTTOM 4 ft. 1.2 m DOCUMENTATION CLASS ABS FLAG/PORT OF REGISTRY USA / New Orleans, LA SOLAS YES USCG INSPECTED OFFICIAL NUMBER 1124970 IMO 8765541 CALL SIGN WDG 3600 VESSEL DELIVERY DATE 2002 BUILDER BOLLINGER SHIPYARD ZERO DISCHARGE CAPABLE YES ZERO DISCHARGE READY NO This specification is preliminary and subject to change without notice. Exact tank capacities, deadweight, deck cargo capacity and other figures that have been calculated and may change when the actual vessel is delivered. r101115
Transcript of SEACOR GALE CLASS 245 LIFTBOAT - SEACOR Marine · seacor gale class 245’ liftboat class 245’...
www.seacorliftboats.com
SEACOR GALE CLASS 245’ LIFTBOAT
CLASS 245’ LIFTB
OAT SEACOR GALE
LEG
NUMBER OF LEGS 3 LEG LENGTH 245 ft. 74.7 m LEG DIAMETER 72 in 1.8 mLEG WALL 1-1/2 in 3.8 cmLEG TOWER HEIGHT 20 ft. 6.1 mTRIANGLE 84 P/S x 107 AFT 25.6 m P/S x 32.6 m AFT
HULL
LENGTH 137.5 ft. 41.9 mLENGTH (BARGE ONLY) 132 ft. 40.2 mBEAM 98 ft. 29.9 mBEAM (BARGE ONLY) 92 ft. 28 mHULL DEPTH 13 ft. 4 mDESIGN DRAFT 8.46 ft. 2.6 mREGISTERED TONNAGE 173 t / 126 t INTERNATIONAL TONNAGE 1,303 t / 390 t
PAD
PAD LENGTH 40 ft. 12.2 mPAD WIDTH 16 ft. 4.9 mPAD DEPTH 4 ft. 1.2 mPAD LOADING N/A DECK LOADING N/A Raked at both ends
CRANE PORT STARBOARD
MAKE Nautilus NautilusMODEL 1400L-95 200BT70/100LOAD RATINGS 250 TONS 30 TONSBOOM TYPE Lattice TelescopingBOOM LENGTH 100 ft. / 30.5 m 100 ft. / 30.5 mCRANE INST. TYPE Pedestal PedestalALL PUBLISHED LOAD RATINGS ARE BASED UPON A 20 FT. / 6.1 M RADIUS
PROPULSION
MAINS - MAKE Caterpillar MAINS - MODEL 3512 HORSEPOWER 1600 BOW THRUSTER EQUIPPED NO CLUTCH MAKE/REDUCTION 5:1
DECK
TOTAL DECK AREA 6,550 ft2 608.5 m2
APPROXIMATE USABLE DECK AREA 5,500 ft2 511 m2
MAXIMUM DECKLOAD 950,000 lbs. 430,912 kg
GENERATORS
GENERATOR ENGINE MAKE Caterpillar GENERATOR ENGINE MODEL 3412 GENERATOR OUTPUT Two (2) 175 kw AUX GENSET EQUIPPED FULLY EQUIPPED Output : 95 kw
CAPACITIES
DIESEL FUEL 15,000 USG 56.8 m3
POTABLE WATER 42,410 USG 160.5 m3
WATERMAKER EQUIPPED N/A
ELECTRONIC AIDS & COMMUNICATIONS
COMPASS FULLY EQUIPPED GPS/DGPS FULLY EQUIPPED RADAR(S) FULLY EQUIPPED FATHOMETER FULLY EQUIPPED LOUDHAILER FULLY EQUIPPED SATELLITE PHONE FULLY EQUIPPED PRIVATE FREQ RADIOTELEPHONE FULLY EQUIPPED VHF RADIO FULLY EQUIPPED SINGLE SIDEBAND RADIO FULLY EQUIPPED GMDSS FULLY EQUIPPED
PERSONNEL ACCOMMODATIONS
TOTAL ACCOMMODATIONS 45 VIP ACCOMMODATIONS 2 CREW ACCOMMODATIONS 9 CONTRACTOR ACCOMMODATIONS 34 TRANSIT PASSENGERS 36 GALLEY & DINING FULLY EQUIPPED TV LOUNGE FULLY EQUIPPED LAUNDRY FACILITY FULLY EQUIPPED AIR CONDITION / HEATER Standard Electrical Commercial UnitsHELIPORT N/A
PERFORMANCE
ESTIMATED SPEED 5 mph / 4.34 knots 8 kphMAX SEPARATION, PAD TO DECK 225 ft. 68.6 mMAX WORKING WATER DEPTH 180 ft. 54.9 mMIN WORKING WATER DEPTH 13 ft. 4 mMAX JACKING SOFT BOTTOM 5 ft. 1.5 mSEA STATES HARD BOTTOM 4 ft. 1.2 m
DOCUMENTATION
CLASS ABS FLAG/PORT OF REGISTRY USA / New Orleans, LASOLAS YES USCG INSPECTED OFFICIAL NUMBER 1124970 IMO 8765541 CALL SIGN WDG 3600 VESSEL DELIVERY DATE 2002 BUILDER BOLLINGER SHIPYARD ZERO DISCHARGE CAPABLE YES ZERO DISCHARGE READY NO
This specification is preliminary and subject to change without notice. Exact tank capacities, deadweight, deck cargo capacity and other figures that have been calculated and may change when the actual vessel is delivered.
r101115
www.seacorliftboats.com
SEACOR GALE CLASS 245’ LIFTBOAT
CLASS 245’ LIFTB
OAT SEACOR GALE
MODEL - NAUTILUS 1400-95 MARINE CRANEPORT CRANE MAIN HOIST INTERMEDIATE HOIST AUXILIARY HOIST STATIC RATING DYNAMIC RATINGRADIUS 12 PART 10 PART 8PART 6 PART 4 PART 12 PART 10 PART 8 PART 6 PART 4 PART STATIC DYNAMIC PERSONNEL STATIC DYNAMICIN FEET RATING RATING RATING RATING RATING20 500,000 422,562 343,082 256,984 168,856 330,893 330,893 330,893 256,984 168,856 40,000 26,667 10,207 9,333 3,39725 404,992 404,992 343,082 256,984 168,856 267,528 267,528 267,528 256,984 168,856 40,000 26,667 10,207 9,333 3,39730 338,863 338,863 338,863 256,984 168,856 223,442 223,442 223,442 223,442 168,856 40,000 26,667 10,207 9,333 3,39735 290,380 290,380 290,380 256,984 168,856 192,120 192,120 192,120 192,120 168,856 40,000 26,667 10,207 9,333 3,39740 253,309 253,309 253,309 253,309 168,856 166,406 166,406 166,406 166,406 168,856 40,000 26,667 10,207 9,333 3,39745 224,042 224,042 224,042 224,042 168,856 146,895 146,895 146,895 146,895 146,895 40,000 26,667 10,207 9,333 3,39750 200,346 200,346 200,346 200,346 168,856 131,097 131,097 131,097 131,097 131,097 40,000 26,667 10,207 9,333 3,39755 180,767 180,767 180,767 180,767 168,856 118,045 118,045 118,045 118,045 118,045 40,000 26,667 10,207 9,333 3,39760 164,316 164,316 164,316 164,316 168,856 107,077 107,077 107,077 107,077 107,077 40,000 26,667 10,207 9,333 3,39765 150,296 150,296 150,296 150,296 150,296 97,731 97,731 97,731 97,731 97,731 40,000 26,667 10,207 9,333 3,39770 138,204 138,204 138,204 138,204 138,204 89,669 89,669 89,669 89,669 89,669 40,000 26,667 10,207 9,333 3,39775 127,666 127,666 127,666 127,666 127,666 82,644 82,644 82,644 82,644 82,644 40,000 26,667 10,207 9,333 3,39780 118,398 118,398 118,398 118,398 118,398 76,465 76,465 76,465 76,465 76,465 40,000 26,667 10,207 9,333 3,39783 110,181 110,181 110,181 110,181 110,181 70,987 70,987 70,987 70,987 70,987 40,000 26,667 10,207 9,333 3,39790 102,841 102,841 102,841 102,841 102,841 66,094 66,094 66,094 66,094 66,094 40,000 26,667 10,207 9,333 3,39795 96,240 96,240 96,240 96,240 96,240 61,693 61,693 61,693 61,693 61,693 40,000 26,667 10,207 9,333 3,397100 86,041 86,041 86,041 86,041 86,041 54,894 54,894 54,894 54,894 54,894 40,000 26,667 10,207 9,333 3,397102 70,834 70,834 70,834 70,834 70,834 44,756 44,756 44,756 44,756 44,756 40,000 26,667 10,207 9,333 3,397
HEELPIN 16 FT. ABOVE DECK AND 6 FT. 1 IN. FROM BOW1. MAIN HOIST CAPACITIES ARE BASED ON 1-1/4” DIAMETER DYFORM 34 HSLR WIRE ROPE. (BREAKING STRENGTH = 220,320 LBS.) 2,850 FT. OF WIRE ROPE IS REQUIRED 2. INTERMEDIATE HOIST CAPACITIES ARE BASED ON FOUR PART REEVING OF 3/4” DIAMETER, DYFORM 18 HSLR WIRE ROPE (BREAKING STRENGTH = 64,800 LBS.) 1,085 FT. OF WIRE ROPE IS REQUIRED. 3. AUXILIARY HOIST CAPACITIES ARE BASED ON ONE PART REEVING OF 3/4” DIAMETER, DYFORM 18 HSLR WIRE ROPE (BREAKING STRENGTH 64,800 LBS.) 450 FT. OF WIRE ROPE IS REQUIRED. 4. ALL RATINGS IN ACCORDANCE WITH API SPECIFICATION 20 (SPEC 2C), FIFTH EDITION, APRIL 3, 1995.5. THE ABOVE RATINGS ARE CONSIDERED NET RATINGS AS THE MAIN LOAD BLOCK WEIGHT OF 7,400 LBS. INTERMEDIATE LOAD BLOCK WEIGHT OF 785 LBS. AND AUXILIARY LOAD BLOCK WEIGHT OF 210 LBS. HAVE BEEN SUBTRACTED 6. DYNAMIC RATINGS ARE BASED ON A DYNAMIC COEFFICIENT OF 2.0
RETRACTED 70 FT. MAX REACH 6-PART MAIN AUXILIARY LIFTSRADIUS ANGLE STATIC DYNAMIC STATIC DYNAMIC PERSONNEL IN FEET DEGREES9 82.6 60,000 40,000 5,040 5,040 1,84010 82 60,000 40,000 5,040 5,040 1,84015 78 60,000 40,000 5,040 5,040 1,84020 74 60,000 40,000 5,040 5,040 1,84025 69 60,000 40,000 5,040 5,040 1,84030 65 60,000 40,000 5,040 5,040 1,84035 61 53,271 35,081 5,040 5,040 1,84040 56 45,862 30,141 5,040 5,040 1,84045 51 40,150 26,333 5,040 5,040 1,84050 45 35,611 23,307 5,040 5,040 1,84055 39 31,917 20,845 5,040 5,040 1,84060 32 28,851 18,801 5,040 5,040 1,84065 23 26,263 17,075 5,040 5,040 1,84070 0 17,869 11,479 5,040 5,040 1,840
NOTES: 1. Main hoist capacities are based on a six part reeving of 3/4” diameter, dyform 18 hslr wire rope (breaking strength = 64,800 lbs.) 1,547 Ft. Of wire rope is required. 2. Auxiliary hoist capacities are based on one part reeving of 1/2” diameter, dyform 18 hslr wire rope (breaking strength = 29,200 lbs.) 383 Ft. Of wire rope is required.3. All ratings in accordance with api specification 20 (spec 20) fifth edition, april 3, 1995 4. The above ratings are considered net ratings as the main load Block weight of 1,300 lbs. And the overhaul ball weight of 321 lbs. Has already been deducted.
EXTENDED 100 FT. MAX REACH 6-PART MAIN AUXILIARY LIFTSRADIUS ANGLE STATIC DYNAMIC STATIC DYNAMIC PERSONNEL IN FEET DEGREES12.8 82.5 19,036 12,257 5,040 5,040 1,84015 81 18,726 12,051 5,040 5,040 1,84020 79 18,239 11,725 5,040 5,040 1,84025 76 17,458 11,205 5,040 5,040 1,84030 73 16,930 10,853 5,040 5,040 1,84035 70 16,457 10,538 5,040 5,040 1,84040 67 16,056 10,271 5,040 5,040 1,84045 64 15,717 10,045 5,040 5,040 1,84050 60 15,432 9,855 5,040 5,040 1,84055 57 15,414 9,843 5,040 5,040 1,84060 54 15,396 9,830 5,040 5,040 1,84065 50 15,377 9,818 5,040 5,040 1,84070 46 15,359 9,806 5,040 5,040 1,84075 42 15,341 9,794 5,040 5,040 1,84080 38 15,323 9,782 5,040 5,040 1,84085 33 15,304 9,770 5,040 5,040 1,84090 27 15,286 9,757 5,040 5,040 1,84095 19 15,268 9,745 5,040 5,040 1,840100 0 9,450 5,867 5,040 5,040 1,840
www.seacorliftboats.com
SEACOR GALE CLASS 245’ LIFTBOAT
CLASS 245’ LIFTB
OAT SEACOR GALE
30 TON HYDRAULIC CRANENAUTILUS 200BT-70/100
BRONZE BELL
NAUTILUS 1400L-100150 TON CRANE
3435
RUBBERSTERN BUMPER
8'-6" ABV MN DK
MN DK.
01 DK.
17'-0" ABV MN DK02 DK.
13232833 3132 30 29 27 26 25 24 1822 21 20 19 17 16 15 14
03 DK.25'-3" ABV MN DK
NAME
12 11 10 89 7 6 5 34 2 1
REF. LINE
0
72" LEG(TYP)
BOW BUMPER
BASELINE
GALE
RUBBER
8070
5060
10 20
40
30
0
Houma, La.Systems, Inc.
HydraulicApplied
FOR PERSONNEL-HANDLINGPERSONNEL IF USED ANDAPPROVED FOR HANDLING
WITH #25672 INSTRUCTIONSMAINTAINED IN ACCORDANCE
HOISTS
Applied
Houma, La.
Hydraulic
MARINE CRANES
40
Systems, Inc.
P/N: N45916-001
3020
100
5060
8070
BALLAST 11P
BALLAST 11S
RUDDER COMPT (S)
2SVOID
32
VOID2P
ZERO DISCHARGE TANK 2S
BALLAST 10S
STB'D ENGINE ROOM
30 29 27 25 24 2223 21
BALLAST 4SBALLAST 6SBALLAST 7S
1820 19 16 1315 14 12 11
VOID 1S
BALLAST 3S
ZERO DISCHARGE TANK 1S
BALLAST 2S BALLAST 1S
10 89 7 6 45 3 2 1
CL OF VESSEL
0
RUDDER COMPT (P)
FUEL OIL 1P
BALLAST 10P
ZERO DISCHARGE TANK 2P
PORT ENGINE ROOM
BALLAST 4PBALLAST 6PBALLAST 7P BALLAST 3P
VOID 1P
BALLAST 2P
BALLAST 1P
ZERO DISCHARGE TANK 1PBALLAST 12P
BALLAST 12S
3435 33
FRESH WATER
9,825 GAL 1S
FRESH WATER7,150 GAL P/SFUEL OIL 1S
BALLAST5P
BALLAST5S
8SBALLAST FRESH WATER
2S9,980 GAL
FRESH WATER2P
8PBALLAST
1P
7,150 GAL P/S 9,980 GAL 9,825 GAL
O.W. (FLAT 30" ABOVE HULL BTM.)290 GAL LUBE OIL
1410 GAL
DIRTY OIL1410 GAL
HYD OIL JACKING SYS1400 GAL
1500 GALHYD OIL CRANE
5780 GAL
7840 GAL
BALLAST 9P BELOW
BALLAST 9S BELOW
2915 GAL
2915 GAL
262831 17
SUMP
SUMP
HOLD PLAN
CABINETS ABV
WASH BASIN
32 3026 23
DN
DN
STERN BUMPERS
W/ VISE
E. FUEL CONNECTION.D. COMPRESSED AIR CONNECTION.
WORK BENCH
20 19 18 17 16 15 14
DECK AREA 8400 SQ. FT.
13 12 11 10 9 8 7 6
C. FRESH WATER CONNECTION.B. FIRE MAIN SERVICE CONNECTION.A. ELECTRICAL PANEL(S).SHIPS SERVICE BLDG HOUSING;
5 4 3 2 1 0
UP
RUBBER BOW BUMPERS
16' X 40' PADS TYP
INTAKE LOUVERS P/S
INTAKE FAN
INTAKE FAN
BHD TO RUN 36" ABV. MN DK P/S
UP
35 33
RUBBER
T.O
.
CL OF VESSEL
(STAINLESS STEEL)RADIATOR RACK
NAUTILUS 1400L-100150 TON CRANE
REF. FRZ.
SOLAS APPROVED RESCUE BOAT DAVIT
A-PACKW/LAUNCH CRADLE & SOLAS(3) 25 MAN LIFE RAFT
SOLAS APPROVED RESCUE BOAT W/
HOSE REEL
3304 EMERG. GENSET VENTILATION TRUNK ENG. RM. NATURAL EXHAUST
ENG. RM. NATURAL EXHAUSTVENTILATION TRUNK
(STAINLESS STEEL)BOOM REST
LINE OF 1/2" INSERT PLATE
(3) 25 MAN LIFE RAFTW/LAUNCH CRADLE & SOLASA-PACK
3'x 3' SOFT PATCH(KEEP AREA CLEAR)
(KEEP AREA CLEAR)3'x 3' SOFT PATCH
30 TON HYDRAULIC CRANENAUTILUS 200BT-70/100
REF-/
FREZ
LANDING ZONE
WINCH
ANCHOR
COU
NTE
R W
/ST
OW
AGE
BLW
.
TABLE &SETTEE
MAIN DECK PLAN
DRY
TABLE & SETTEE
T.O
. ICE MAKER
REMOVABLE
BLW.
MACH. ABV./MILK
A/C
TABLE & SETTEE
T.O.
LKRS
WA
SHW
ASH
WA
SH
D.F.
DRY
DRY
BENCH
LKRS
TABLE & SETTEE BLW
TABLE & SETTEE
ISLA
ND W
/ ALU
MPO
T RA
CK A
BV
DBL DEEP SINK
W/ SOLAS APVDSRV THRU WINDOW
CLOSURE
A/C
V.L.UP
WATERDISPENSER
TRANSFORMER
REMOVABLE
T.O.
T.O
.
GALLEYMESS
2' X 3'PASS THRU
LOUNGE
COOLER FRZR
GA
LLEY
PAN
TRY
FID
DLE
Y RM
LKRC02
GEN RMEMERGENCY
MESS
CHANGEROOM
49"
MIN
49"MIN
49"
MIN
OUTLINE OF O2 DK. ABV.
