R0hi · 2021. 6. 15. · .03 HP Max. CFM 800 SONE 612 SONE 459 230 600 3.3 3.2 535 366 700 4.1 3.8...
Transcript of R0hi · 2021. 6. 15. · .03 HP Max. CFM 800 SONE 612 SONE 459 230 600 3.3 3.2 535 366 700 4.1 3.8...
R0
hi
I.
a’
0 0
•Ic)
CD•
•CD oW
1.
Standard motors normally stocked—
• Single phase 1/50 HPto 1/2HP-ll5voltopen• Single phase 1/4 HP to 1 HP-115/230 volt open• Three phase 1/2 HP to 2 HP-208/230/460 volt
open
Two speed, totally enclosed and explosion proofmotors available for many sizes and units. Consultyour Quietaire representative for details.
NOTE: 200/208 volt single phase is not a standardand should be avoided. 115 volt single phase or200/208 volt three phase should be used.
DONT OVERSIZE MOTORS
Motors run most efficiently at their rated output and atlow loads, power factors decrease. Standard Openmotors have a minimum service factor of 1.15 whichprovides insurance for system variations.
AVOID TOTALLY ENCLOSED MOTORS
Quietaires ventilator motors are mounted in enclosedcompartments protected from exhaust air The Quietaire
wheel design provides positive flow of outside airthrough the compartment for motor cooling. Enclosedmotors are rarely justified and if used, would run hot-ted, less efficiently and have a shorter life.
GENERALComplete performance data for each size is shownon pages 4 through 14. In addition to tabular data,performance curves for each size at various speedsare shown for easy visual interpolation. Threetypicalsystem curves are also superimposed on the fancurves for guidance.
I1OSE LEVELS
Noise levels are listed in sones which offer a linearrelationship between values. Sone values are at 5feet from fan inlet and do not represent room sones.See AMCA Bulletin 302 for application details.
Tip speeds are not a valid indication of noiseproduced between units of different designs. TheQuietaire wheel design will be quieter even at higherspeeds due to the smooth flow through the wheeland inlet.
STANDARD FEATURES
Models QWDB & QWBB
• Integral overload protection on standard single phase motors• Aluminum non-sparking, non-overloading, backwardly inclined impeller• Safety disconnect, except with explosion proof motors• Belt driven units feature adjustable speed drives• Efficient, deep spun venturi
C
MOTORS
SELECT STANDARD MOTORS
• Galvanized bird screen
2
CENTRIFUGAL WALL EXHAUSTER
Model QWDB—Direct Drive
Quietaire’s Direct Drive Wall Exhausters are available in six
sizes with capacities to 2600 CFM. Direct drive reduces
maintenance. Optional electronic speed control increases
flexibility by providing variable performances over an
extended range.
Model QWBB—BeIt Drive
Quietaire’s Belt Drive Wall Exhausters are available in five
sizes with capacities to 7200 GEM. Belt driven unitsfeature wide performance capabilities and readily available
motor selections.
; I
3
Model QWDB — Size 06
PERFORMANCE DATA
176S
S .7)
CEPTIFIED /mines
fliPOVEEflTtO COnTROLRSSOCIRTIOT. Inc
The Quietaire Corp. certifies that the models
shown here are licensed to bear the AMC’
Seal. The ratings shown are based on tes
made in accordance with AMCA Standaa. .‘
210 and AMCA Standard 300 and comply -
with the requirements of the AMCA Certified
Ratings Program.
SIZEMOTOR
HP RPMCFM
SONECFM
SONE
STATIC PRESSURE, Inches W. G.
CFMSONE
o 1 1/8 1/4 3/8 1/2 518 3/4 7/8
CFMSONE
CFMSONE
CFMSONE
CFMSONE
CFMSONE
CFMSONE
50006-A3 1 /50 HP 1.5with Speed Control Std. Mtr
6001341.9
700156 44
06-03 1 /28 HP 2.3 2 1Sid. Mtr. 178 88or 800
2.8 2.706-A3
or
900201 127 24
1/50 HP 3.3 3.3 3.0with Speed Control Std. Mtr.
1 000223 161 6638 38 34
1I5OHP 227’ 167 75 .06-A3* 1025 --,. . - .. S
‘.-
55WaiisMax. 39 .35 .
..
06-03 1/28HP 245 192 111 28with Speed Control Std MIr
1 1004 3 40 39
1/28 HP .20- . ‘:J32 : 48 1..‘ 95wattstvia
11504 46 44 40267 220 152 70
12004.8 4.9 4.7 4.3
1300290 247 189 115 44
06-B2 1 /40 HP 5.3 5.4 54 49 4.7with Speed Control Std MIr
1 400312 273 223 158 87 295.9 5.9 6.0 5.7 5.3 5.4
1500334 299 254 198 133 696.4 6.4 65 6.4 6.0 5 7
06-B2* 1/40 HP110 Watts Max
1600357 324 28470 7fl 71
Note: Performance shown is for Centrifugal Wail Ventilators without ducts.AMCA Seal for sound rating does not apply to units with speed control
* RPM is nominal and the performance is based on actual speed of test.The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard301. Values shown are for installation type A: free inlet fan sone levels.Ratings include the effect of a birdscreen.
114 57
1.0
718
3/4
518
1/2
318
1/4
iia
100 200 300 400 500
CUBIC FEET PER MINUTE
PERFORMANCE DATAModel QWDB—Size 08
337 241 982
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.AMCA Seal for sound rating does not apply to units with speed control.
* RPM is nominal and the performance is based on actual speed of test.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard301. Values shown are for installation type A: free inlet fan sone levels.
Ratings include the effect of a birdscreen.
The Quietaire Corp. certifies that the models
shown here are licensed to bear the AMCA
Seal. The ratings ehown are based on tests
made in accordance with AMCA Standard
2t0 sod AMCA Standard 300 and comply
with the requirements of the AMCA Certified
Rstings Program.
STATIC PRESSURE. Inches W. G.
MOTOR NOMINAL CFM CFM CFM CFM CFM CFM CFM CFM CFM
SIZE HP RPM SONE SONE SONE SONE SONE SONE SONE SONE SONE
0 1/8 1/4 3/8 1/2 5/8 3/4 7/8 1
150400
1/5OHP 18708-A3500
1 5with Speed ControlStd. Mtr.
225 38600
19 13
08-A3or
08-D3
with Speed Control
7001/50 HPStd. Mir.
or1/28 HPSid. Mtr
2622.3
1191.9
900
300 184800
28 2.5
412 33842 42
1.0
7/8
3/4
5/8
1/2
318
1/4
1/8
1 1
Model QWDB-08
fl Direct Drive
Z4’)L_____,LOOQJN:\
N
500 1,000
CUBIC FEET PER MINUTE
5
Model QWDB—Size 10
PERFORMANCE DATA
332 1813.9 3.7 3.2
715 664 603 5387.7 7.5 7.4 7.2753 706 - 648 587 523 446
8.3 8.1 7.9 7.8 7.5 72
• 1/12HP 796 752 698 641 582 5171670
8.9 8.7 8.6 8.4 8.2 7.9
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.AMCA Seal for sound rating does not apply to units with speed control.
The Quietaire Corp. certifies that the models-- -
shown here are licensed to bear the AMaSeal. The ratings Shown are based on temade in accordance with AMCA Standaro
-
210 and AMCA Standard 300 and complywith the requirements of the AMCA CertifiedRatings Program.
_______
STATIC_PRESSURE, Inches W. G.
0 1/8 1/4 3/8 112 5/8 314 7/8 1 4MOTOR NOMINAL CFM CFM CFM CFM CFM CFM CFM CFM CFMV
SIZE HP RPM SONE SONE SONE SONE SONE SONE SONE SONE SONE
500
60286 73
10-03 1/28 HP0
2.3 1.8with Speed Control Std. Mtr.
700194
2.8 2.4
ann 381 2683.4 3.1
10-E2or
10-03with Speed Control
9001/22 HPStd. Mtr.
or1/28 HPStd. Mtr.
11/12 HPMtr. or
11/20 HP Std.Mtr. or
1/22 HPA4..
or10-E2
10-112 I
477 391 2831000
4.3 3.9524 449 358 21951 49 4.6 4.2
1• 529 454 . .: . .
.5.2 5.0 ,
i:E•
1200572 504 424 325 1455.7 5.5 5.3 5.0 4.6
1300620 558 486 405 2896.4 6.2 6.0 5.7 5.3
1400667 612 545 474 388 25570 69 6.7 6.4 6.1 58
‘ 691 • 54 ‘ 507 429 3191450
74 68 65 62d Cc -01
1500
1/12 HPStd. Mtr.
1600
467 373 2296.9 6.6 6.3
763 716 659 600 537 463 363 2148.4 8.2 8.1 7.9 7.7 7.4 7.0 6.8
3406.9
* RPM is nominal and the performance is based on actual speed of test.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard
301. Values shown are for installation type A: free inlet fan sone levels.
Ratings include the effect of a birdscreen.
435 3207E 7.3
500 1,000
CUBIC FEET PER MINUTE
PERFORMANCE DATA
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.AMCA Seal for sound rating does not apply to units with speed control.
* RPM is nominal and the performance is based on actual speed of test.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard
301. Values shown are for installation type A: free inlet fan sone levels.
Ratings include the effect of a birdscreen.
‘4
Cl,w
C)zuJ
D00LU
0.C.)I4
Model QWDB — Size 12
SIZEMOTOR
HP
NOINAL
RPM
STATIC PRESSURE, Inches W. G.
12-J4with Speed Control
500382
0 1/8 1/4 318 1/2 5/8 3/4 I 7/8 1
CFM CFM CFM CFM CFM CFM
SONE SONE SONE SONE SONE SONE
1/8 HPStd. Mtr..03 HPMax.
CFMSONE
800
CFMSONE
612
CFMSONE
459 230600
3.3 3.2535 366
7004.1 3.8
470
12-J3with Speed Control
231
12-L5with Speed Control
1.0
7/8
3,4
5/8
1/2
3/8
1/4
1/8
1,000 2,000
CUBIC FEET PER MINUTE
The Quietsire Corp. certifies that the models
shown here are licensed to bear the AMCA
Seal. The ratings shown are based on tests
made in accordance with AMCA Standard
210 and AMCA Standard 300 and comply
with the requirements of the AMCA Certified
Ratings Program.
7
Model QWDB—Size 15
PERFORMANCE DATA
500817 4084.1 3.3
600980 6715.2 4.5
7001143 881 551
6.4 5.9 5.21307 1083 839 400
7.6 7.4 6.5 5.6
1S-J4* 1/81105 1201 974 685
15-L3with Speed Control
1470 1279 1059 818 3028.9 8.9 7.9 7.4 6.0
1633 1469 1266 1074 816 29010.2 10.4 8.81756 1608 1
1/4HP 1075112 116
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.AMC4 Seal for sound rating does not apply to units with speed control.
* RPM is nominal and the performance is based on actual speed of test.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard301. Values shown are for installation type A: tree inlet tan sone levels.
Ratings include the effect of a birdscreen.
Cl
The Quietaire Corp. certifies that the modelsshown here are hceflsed to bear the AMCSeal The ratings shown are based on testsmade in accordance with AuCA Standard210 and AMCA Standard 300 and complywith the requirements of the AMCA Certifiedatings Program.
_______
STATIC_PRESSURE, Inches W. G.
0 1/8 1/4 318 1/2 5/8 3/4 7/8 1
MOTOR NOUINAL CFM CFM CFM CFM CFM CFM CFM CFM CFM
SIZE HP RPM SONE SONE SONE SOME SOME SONE SONE SONE SONE
400
1 5-J4with Speed Control
1/8 HPStd. Mtr..09 HPMax.
800
1/4 HPStd. Mtr..17 HP
900
1000
1239..9.9$I
1,000 2,000
CUBIC FEET PER MINUTE
PERFORMANCE DATA
18-L4
______
with Speed Control
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.AMCA Seal for sound rating does not apply to units with speed control.
* RPM is nominal and the performance is based on actual speed of test.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard1. Values shown are for installation type A: free inlet fan sone levels.
\. ,atings include the effect of a birdscreen.
C,
0wzC.)zU.’
z0a)U.’
$ 0.C.)
Model QWDB—Size 18
SIZEMOTOR
HP
STATIC PRESSURE. Inches W. G.
350 833:
0 1/8 1/4 3/8 112 5/8 3/4 7/8 1NOIINAL CFM CFM CFM CFM CFM CFM CFM CFM CFM
RPM SONE SONE SONE SONE SONE SONE SONE SONE SONE
1/4 HPStd. Mtr..16 HPMax.
4004.0 4.1
4501070 609
4.6 4.8
5001198 8125.3 5.5
5501318 984 371
6.0 6.2 6.2
6001438 1140 682
6.8 6.9 7.0
6501558 1286 922 270
7.5 7.7 7,8 7.8
7001678 1427 1122 633
8.3 8.4 8.6 8.61798
011564
02
38 BHP MaxI 1170
1300 914 307pA
1.0
718
3,4
518
1/2
3/8
1/4
1/8
1,000 2,000
CUBIC FEET PER MINUTE
3,000
The Quietaire Corp. certifies that the modelsshown here are licensed to bear the AMCASeal. The ratings shown are based on testsmade in accordance with AMCA Standard210 and AMCA Standard 300 and complywith the requirements of the AMCA CertifiedRatings Program.
9
PERFORMANCE DATA
Model QWBB—Size 12RPM RANGE — Motor HP STATIC PRESSURE, INCHES W. G.
Ki K2 K3 14 M5 P6 0 1/8 1/4 3/8 1/2 5/8 314 1 1-1/4
1/6 1/6 1/6 1/41/31/2 RPM CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP E..- -- - - -
— Sone Sone Sone Sane Sane Sone Sone Sone Sone Sone
[
800612 .02 470 .02 231 .02
49 4.6 4.6
980750 .03 638 .04 506 .05 283 .04
64 6.1 6.0 6.0
1130865 .05 769 .06 664 .07 534 .07 324 .06
7.7 7.5 7.3 7.3 7.3
1220934 .07 846 .08 750 .08 642 .09 494 .09
8.5 8.3 8.1 8.0 8.1
13201010 .08 930 .09 842 .10 749 .11 636 .11 477 .11 231 .08
— —
— 95 9,3 9.0 8.9 8.9 8.9 8.9
13801056 .09 980 11 897 .12 809 .12 709 .13 577 .13 387 .11
— —— 10.1 9.8 9.6 9.5 9.4 9.5 9.5
15101155 .12 1086 .14 1011 .15 933 .16 850 .16 753 .17 630 .16 224 .12
—
—11.3 11.1 10.9 10.7 10.7 10.6 10.7 10.6
16201240 .15 1176 .17 1107 .18 1035 .19 960 .20 878 .20 783 .21 505 .19
— —
— 12.4 12.2 12.0 11.9 117 11.7 11.7 11.7
17301324 .19 1264 .20 1200 .22 1134 .23 1065 .24 993 .25 913 .25 706 .25 372 .20
— — —— 13.6 13.4 13.2 13.0 12.9
-
12.8 12.7 12.8 12.7
18201393 .22 1337 .23 1276 .25 1213 .26 1149 .27 1082 .28 1010 .29 838 .29 583 .27 178 .18
— —— 14.5 14.3 14.1 14.0 13.8 13.7 13.6 13.6 13.7 13.5
19101462 .25 1408 .27 1351 .26 1291 .30 1231 .31 1168 .32 1103 .33 953 .34 750 33 446 .27
— — — —
— 15.4 15.3 15.1 14.9 14.8 14.6 14.6 14.5 14.6 14.5
20001530 .29 1480 .31 1425 .32 1369 .34 1311 35 1252 .36 1191 .37 1057 .39 888 39 652 .35
— — — — —
— 1 6.4 16.3 1 6.1 - 15.9 1 5.7 15.6 1 5.5 154 1 5.5 155
20901 599 .33 1551 .35 1 499 .37 1446 .38 1 391 .40 1 335 .41 1277 .42 1155 .44 1009 .44 818 .43
— — — —
— 1 7.4 1 7.3 1 7.1 16.9 1 6.7 1 6.6 16.5 16.4 16.4 16.4
0UIIC,zUI
DU’0LU
0C)I
IU,
2181668 .37 1622 .39 1573 .41 1522 .43 1469 .44 1416 .46 1362 .47 1248 .49 1118 .50
018.4 18.3 18.1 17.9 17.8 17.6 17.5 17.3 17.3
957 ,.5Q
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.
BHP does not include drive losses.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard
301. Values shown are for installation type A: free inlet fan sone levels.
Ratings include the effect of a birdscreen.
2.0
1%
1½
11/4
1.0
3/4
1/2
1/4
1,000 2,000
CUBIC FEET PER MINUTE
The Quietaire Corp. certifies that theshown here are licensed to bear the ,r
Seal. The ratings shown are basedmade in accordance with AMCA StN210 and AMCA Standard 300 and comply
With the requirements of the AMCA Certified
Ratings Program.
10
PERFORMANCE DATA
Model QWBB—Size 15
0 1/8 1/4 3/8 1/2 5/8 3/4 1 1-1/4 1-1/2
1062 .03 778 .04 307 .03650 5.8 5.2 4.7
1405 .07 1 202 .08 974 .09 685 .09860
8.4 8.3 7.3 6.8
F
1748 .13 1599 .15 1409 .16 1229 .17 1032 .17 716 .161070
1 1.2 1 1.5 1 0.6 9.8 9.4 8.71830 .15 1691 .17 1509 .18 1335 .19 1159 .19 920 .19 494 16
112011 9 12.2 11.5 1 0.6 1 0.1 9.7 8.4
1911 .17 1 781 .19 1609 .20 1 439 .21 1 275 .22 1 081 .22 774 .201170
— — —
— 12.6 1 3.0 1 2.3 11 5 1 0.8 1 0.5 981983 .19 1871 22 1707 .23 1542 .24 1385 .25 1217 .25 983 .24
1220— 1 3.3 1 3.8 132 1 2.3 11.7 1 1.3 10.8
2058 .21 1 942 .24 1 784 .25 1 623 .26 1471 .27 1315 .28 1118 .28 327 .191260
— — —.
— 13.9 1 4.4 1 3.8 13.0 1 2.3 1 1.9 11.5 8.92124 .23 2013 .26 1862 26 1704 .29 1555 .29 1408 .30 1236 .30 614 .25
1300—
— 14.4 15.0 14.5 13.7 13.0 12.5 12.1 10.42205 .26 2100 .29 1957 .31 1805 32 1659 .33 1519 .33 1367 .34 889 .31
1350— —
— 15.2 1 5.8 15.4 14.6 13.9 13.3 1 2.9 11.82369 .32 2274 .36 2145 .38 2004 .39 1864 .40 1732 .41 1600 .42 1275 .42 665 .34
1450— — — —
— 16.7 17.3 17.1 16.4 15.7 15.0 14.5 13.8 12.02516 .39 2429 .43 2311 .45 2179 .46 2046 .47 1918 .48 1795 .49 1 531 .51 1131 .48 375 .35
1540— — — —
— 18.1 1 8.7 1 8.6 1 8.0 1 7.3 1 6.6 160 15.3 14.4 11.52630 .44 2549 .48 2438 .51 2314 .53 2186 .54 2062 55 1942 .56 1702 .57 1390 .57 860 .50
1610— — — — -
— 19.2 19.8 19.8 19.3 18.6 17.9 17.3 16.4 15.8 14.2‘ 2761 .51 2685 .56 2583 .59 2466 .60 2344 .62 2224 .63 2108 .64 1882 .66 1628 .67 1252 64
1 690 21 22 22 21 21, 19.5 18.5 17.8 17.2 16.32875 .58 2804 63 2707 .66 2597 68 2481 .69 2365 .70 2251 .71 2034 .74 1807 75 1511 .75
1 760 22 24 24 22.0 22 21 21 19.1 18.4 17.8
Cl)Lu
C-)zuJ
D00uJ
0C-)I
(RPM RANGE — Motor HP
Ki K2 L3 M4 P5 R6
/6 1/6 1/4 1/3 1/2 3/4 RPM CFMBHP CFMBHP CFMBHPSone Sone Sone
STATIC PRESSURE. INCHES W. G.
CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHPSone Sone Sone Sone Sane Sone Sone
Mote: Peormance shown is for Centrifugal Wall Ventilators without duds.
BHP does not include drive losses.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard301. Values shown are for installation type A: free inlet fan sone levels.
Ratings include the effect of a birdscreen.
2.0
1 3/
11/2
11/a
1.0
3/4
1/2
1/4
I CED /RATIAGS
.4
1,000 2,000
CUBIC FEET PER MINUTE
3,000
The Quietaire Corp. certifies that the modelsshown here are licensed to bear the AMCASeal. The ratings shown are based on testsmade in accordance with AMCA Standard210 and AMCA Standard 300 and complywith the requirements of the AMCA CertifiedRatings Program.
11
Model QWBB—Size 18
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.
PERFORMANCE DATA
BHP does not include drive losses.
The sound ratings shvn are loudness values in fan sones at 5 ft., calculated per AMCA Standard301. Values shown are for installation type A: tree inlet fan sone levels.
Ratings include the effect of a birdscreen.
The Quietaire Corp. certifies that the models —
shown here are licensed to bear the AMC,r’Seal. The ratings shown are based on te(
made in accordance with AMCA Standa
210 and AMCA Standard 300 and compl’—
with the requirements ot the AMCA Certified
Ratings Program.
RPM RANGE — Motor HP STATIC PRESSURE, INCHES W. G.
1(1 1(2 L3 M4 P5 R6.S7 0 118 1/4 .3/8 1/2 5/8 3/4 1 1-1/4
1161161/41131123/41 RPM CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMi
- -— Sone Sane Sane Sone Sane Sane Sone Sone Sone Sone--
I 6101462 .06 1 170 .06 734 .06
J 6.9 7.1 7.2
7401774 .10 1537 .11 1265 .12 863 .11
J — — —
— 8.9 9.1 9.2 9.2
8402013 .15 1805 .16 1586 .17 1308 .17 918 .16 355 .12
— — —
— 10.5 10.7 10.8 10.9 10.9 10.9
9102181 18 1988 .20 1792 .21 1562 .22 1263 .21 857 .19
— — —— 11.7 — 11 9 12.0 12.1 12.1 12.1
9602301 .22 2118 .23 1935 .25 1728 .25 1472 .25 1138 .24 695 .21
— —
— 12.6 12.7 12.8 12.9 13.0 13.0 13.0
9902373 .24 2195 .25 2018 .27 1823 .28 1587 .28 1287 .27 896 .25
—— 13.1 13.2 13.4 13.5 13.5 13,6 13.6
10502517 .28 2348 .30 2183 .32 2006 .33 1801 .33 1552 .33 1238 .32
—
— 14.2 14.3 14.4 14.5 14.6 14.6 14.7
11002636 .33 2476 .34 2318 .36 2153 .37 1968 .38 1749 .38 1482 .37 742 .31
.— — —
— 15.1 15.2 15.3 15.4 15.5 15.6 . 15.6 15.6
11602780 .38 2627 .40 2478 .42 2325 .43 2157 .45 1966 .45 1740 .45 1138 .40
— —
— 16.2 16.3 16.4 1 6.5 1 6.6 1 6.7 1 6.7 16.7
12102900 .43 2753 .45 2611 .47 2465 .49 2309 .50 2135 .51 1934 .51 1417 .48 .680 .39
— — —
— 17.1 1 7.2 1 7.3 1 7.4 1 7.5 17.6 1 7.6 17.7 1 7.7
13003116 54 2979 .56 2846 .58 2712 .60 2572 .61 2422 .63 2254 .63 1844 .62 1290 .57 538 .45
—
— 18.8 1 8.9 19.0 1 9.1 19.2 1 9.3 1 9.3 194 1 9.5 1 9.4
13803307 .64 3178 .67 3052 .69 2927 .71 2799 .73 2662 .74 2515 .75 2169 .76 1722 .73 1137 .65
— — —
— 21 21 21 21 21 21 21 21.0 21.0 22
14503475 .75 3352 .77 3232 .80 3113 .82 2992 .84 2866 .85 2732 .87 2426 .88 2046 .87 1563 .81
— — — —
— 22 22 22 22.0 23 23 23 23 23 233643 .86 3525 .89 3410 .91 3297 .94 3183 .96 3065 .97 2941 .99 2666 1.01 2336 1.01 1927 .98
— 1520 24 24 24 — 24 24 24 24 24 24 24
2.0
1/4
1½
11/4
1.0
3/4
I,’
/_____ Model QWBB-18Belt DriveI “%..7d
— II 4i /
s—.. /L /
I—.—, i. I/ .-c j_.
I •—.-j ,,
0 pc__.L________J00_.
\1 U
1,000 2,000 3,000 4,000
CUBIC FEET PER MINUTE
PERFORMANCE DATA
Model QWBB—Size 21
0 118 1/4 318 112 518 3/4 1 1-1/4 1-1/2
CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHPSone Sone Sone Sone Sone Sone Sone
5202063 .08 1733 .09 1375 .11
7.7 7,6 7.6
612420 .12 2142 .14 1851 .16 1520 .17
— — — —
— 0 94 94
7002777 .18 2539 .21 2285 .23 2028 .25 1728 .26 1287 .25
— —
— 11.3 11.3 11.3 11.3 11.3 11.3
2935 .22 2712 .24 2472 .27 2232 .29 1971 .30 1632 .30
— - —
— 4012.2 12.2 12.2 12.1 12.1 12.2
7703054 .24 2840 .27 2610 .30 2380 .32 2139 .34 1848 .34 1441 .33
—
— 12.9 12.9 12.8 12.8 12.8 12.8 12.8
813213 .28 3011 .31 2792 34 2573 .36 2351 .39 2102 40 1 783 .40
— —
- 01 3.8 1 3.8 1 3.7 1 3.7 13.7 13.7 1 3.7
893491 .36 3306 .40 3107 .42 2905 .45 2703 .48 2494 50 2258 .51
— — —
- 01 5.4 1 5.4 1 5.3 15.3 1 5.3 1 5.3 1 5.3
9403729 .44 3558 .48 3372 .51 3182 .54 2994 .57 2804 .59 2603 .62 2095 .62
— —
— 16.7 16.8 16.7 16.7 16.7 16.6 16.6 16.7
1003967 .53 3807 .57 3634 .60 3456 .64 3278 .67 3101 .70 2920 .72 2508 .76 1916 .72
-— —
— 018.2 18.2 18.2 18.1 18.1 18.1 18.1 18.1 18.1
1054165 62 4014 .66 3850 .69 3681 .73 3511 .76 3343 .79 3173 .82 2807 .87 2335 .87
— — — — -
- 01 9.4 1 9.4 1 9.4 19.4 1 9.3 1 9.3 1 9.3 1 9.3 1 9.3
4363 .71 4220 .75 4064 .79 3903 .82 3742 .86 3580 .89 3419 .93 3085 .98 2687 1.01 2141 .971 100 21 21 21 .21 21 21 21 :21 21 21
— — — —
- 64601 .83 4466 .88 4319 .92 4168 95 4015 .99 3861 1.03 3709 1.06 3399 1.13 3058 1.17 2631 1.17
— — — — —
- 110 23 23 23 23 23 22.0 22.0 22.0 220 22.0
4760 .92 4629 .97 4489 1 01 4343 1.05 4195 1.09 4046 1.12 3899 1.16 3602 1.23 3286 1.28 2911 1.31
— — — — —
- 1200 24 24 24 24 24 24 23.0 23 0 23.0 23.0
4998 1.07 4874 1.12 4741 1 16 4603 1.20 4462 1.24 4321 1.28 4180 1.32 3899 1.39 3609 1 46 3287 1.50
— — — — —
— 1260 25 25 25 25 25 25 25 25 25 25
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.
C,
Cowx0zw
Cl)CoU.’
aC)I-.
I.Cn
1RPM RANGE — Motor HP
.1 M2 P3 R4 $5 T6
i14 1/3 1/2 3/4 1 1½ RPM CFM BHPSone
CFM BHPSone
STATIC PRESSURE. INCHES W. G.
CFM BHPSone
BHP does not include drive losses.
The sound ratings shown are loudness values in fan sones at 5 ft. calculated per AMCA Standard301. Values shown are for installation type A: free inlet tan sone levels.
Ratings include the effect of a birdscreen.
1,000 2,000 3,000 4,000
CUBIC FEET PER MINUTE
The Quietaire Corp. certifies that the models
shown here are licensed to bear the AMCA
Seal. The ratings shown are based on tests
made in accordance with AMCA Standard
210 and AMCA Standard 300 and comply
with the requirements of the AMCA Certified
Ratings Program.
13
Model QWBB—Size 24
0
cnLUxC-)zLU
00LU
0C-)I4I0
PERFORMANCE DATA
RPM RANGE — Motor HP STATIC PRESSURE, INCHES W. G.
Ml P2 R3 S4 T5 V6 0 1/8 1/4 3/8 1/2 5/8 3/4 1 1-1/4 1-1I’
1/3 1/2 3/4 1 1½ 2 RPM CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP CFMBHP. -
— Sone Sone Sone Sone Sane Sone Sone Sone Sone Sone
4102912 .09 2403 .12 1839 .13
6.2 5.9 4.7
4803410 .15 2970 .18 2546 .20 1966 .21
— —
— 7.6 7.4 6.6 5.5
563978 .24 3600 .27 3234 .30 2860 .33 2349 .34
9.3 9.2 8.8 7.9 6.8
5904191 .28 3832 .31 3482 .35 3137 .38 2719 .40
1 0.0 9.9 9.5 8.8 7.7
6404546 .35 4216 .39 3889 .43 3575 .47 3239 .50 2806 .51
— —
— 11.2 11.1 10.8 10.2 9.3 8.3
6904901 .44 4596 .49 4289 .52 3995 .56 3701 .60 3367 .63 2932 .64
— — —— 12.3 12.3 12,0 11.6 10.9 10.0 9.0
7305185 .53 4897 .57 4606 .61 4325 .65 4050 .70 3759 .73 3413 .76
— — —
— 13.3 13.2 13.0 12.7 12.1 11.3 10.3
7705470 .62 5197 .66 4920 .71 4651 .75 4390 .80 4125 .84 3831 .88 3009 .88
— — — —
— 14.2 1 4.2 14 0 1 3.7 13.2 1 2.5 1 1.7 1 0.0
8005683 .69 5420 .74 5154 .79 4893 .83 4641 .88 4389 .92 4121 .97 3428 1.00
— —— 15.0 14.9 14.8 14.5 14.1 13.5 12.7 11.0
8405967 .80 5717 .85 5463 .90 5213 .95 4971 1.00 4732 1.05 4487 1.09 3909 1.16 3029 1.11
— — — —— 16.0 15.9 15.8 15.6 15.2 14.7 14.0 12.4 10.9
8806251 .92 6013 .98 5770 1.03 5530 1.08 5297 1.13 5068 1.18 4839 1.23 4333 1.31 3640 1.32
— — — —
— 17.0 16.9 16.9 16.7 16.3 15.9 15.3 13.8 12.2
9206535 1.05 6308 1.11 6076 1.16 5845 1.21 5620 1.27 5400 1.32 5182 1.37 4723 1.47 4150 1.52 3316 146
— — —
— 18.0 18.0 17.9 17.7 17.5 17.1 16.6 15.2 13.7 12.3
9606819 1 .20 6602 1.26 6379 1.31 6158 1.37 5940 1.42 5728 1.47 5519 1.53 5092 1.64 4597 1.72 3932 1.72
— — — —
— 19.1 19.0 19.0 18.8 18.6 18.3 17.8 16.6 15.2 13.7
10207245 1.44 7041 1.50 6832 1.56 6623 1.62 6416 1.67 6214 1.73 6016 1.79 5621 1.91 5199 2.01
— — — — —
— 21 21 21 21 21 20.0 1 9.6 18.6 1 7.44688 2.01
15.9
Note: Performance shown is for Centrifugal Wall Ventilators without ducts.
BHP does not include drive losses.
The sound ratings shown are loudness values in fan sones at 5 ft., calculated per AMCA Standard
301. Values shown are for installation type A: free inlet fan sone levels.
Ratings include the effect of a birdscreen.
2.0
1 3/4
1½
11/4
1.0
Model QWBB-24Belt Drive r /
—-—-__-.---
/K’4-c_:;____
2,000
IR I
The Quietaire Corp. certifies that the mr
shown here are licensed to bear the A
Seal. The ratings Shown are based on 1.made in accordance with AMCA Standa.ru
210 and AMCA Standard 300 and comply
with the requirements of the AMCA Certified
Ratings Program.
4,000 6,000
CUBIC FEET PER MINUTE
DIMENSIONS
*Minimum wall opening size.
Model QWDB — Direct Drive
CONDUITLOCATION
—
(Sizes 12-18)
t
SAME DAMPER ANDGRILLE ARRANGEMENT
ASSHOWNABOVE
H
VIEW: FF,OM OUTSIDE OF BU!LDINC
*Minimum wall opening size.
Model QWBB — Belt Drive
CONDUITLOCATION(Size 24)
INSIDEWALL
OPENING—F
FORDAMPER
ANDGRILLE
VIEW: FROM OUTSIDE OF BUILDING
MODEL C
fIq)
-
F G “,
QWBB12 21¾ 36 35 12 15 131/4 1½QWBB15 25½ 40 39 15 20 .080 .080 151/4 1½QWBB18 27½ 43 42 18¾ 22 gauge gauge 16¾ 1½
QWBB21 281/s 48 47 20 26 Alum. Alum. 18¾ 1½
0WB824 33 58 57 211/2 32 221/4 1½
A
DIMENSIONS Inches)MODEL A B C D* F G H V
• QWDB 06 10½ 23 22 101/4 10 051 ga. 8i—051LQYDB 08 111/s 231/2 221/2 10 1/4 10 .063 8/4 I —
gaugeQWDB 10 12% 24 23 101/4 12 pa.Alum 91/s I —
Alum. —-I--————I QWDBi 20 36 35 12 15 — .080 13¼ I 1½
QWDB15 22¾ 40 39 15 20 063 gauge 151/4 I 1½
WDB 18 25½ 43 42 13¾ 22 a.Al urn Alum.
15
TYPICAL SPECIFICATIONSCentrifugal Power Wall Ventilators shall be Quietaires Model Horsepower and noise levels shall not exceed the values
QWDB, direct drive, or Model QWBB, belt drive, as shown shown and oversize motors will not be acceptable.
on plans and schedules. Ventilators shall be furnished with acceptable electrica)”
Ventilato- covers shall be spun aluminum specifically disconnect and birdscreen. Single phase motors sha
designed to withstand high wind loads. Wheels shall be have integral overload protection. V-belt drives shall be
backwardly inclinded. adjustable.
The motor and drive compartment shall be positively Performance ratings shall be AMCA certified for air and
externally ventilated. Drive components shall be isolated sound.
from the structure. Bearings shall be designed for 200,000hours operation.
WARRANTYWarranty and DiscIaimer Ouietaire Corporation extends this limited warranty to the original buyer and warrants that products manufactured by Quietaire shall be free from original defects in workmanShrp\
and materials for one year from date of shipment, provided same have been properly stored, installed service, maintained and operated. This warranty shall not apply to products which have been altered or
repaired in any way so as to effect its performance, without Quietaire’s express authorization, or altered or reliability, nor which have been improperly installed or subjected to misuse, negligence, or acci
dent, or incorrectly used in combination with other substances. The Buyer assumes all risks and liability for results of; use of the products. Warranties on purchased parts, such as electric motor and controls
are limited to the terms of warranty extended by our supplier.
Umitation Of Remedy And Damages: All claims under this warranty must be made in writing and Qelive,ed to Quietaire Corporation 505 North Hutchesor’., Houston, Teuas 77003 within 15 days after
discovery of she defect and prior to ‘he expiration of one year from the date of shipment by Quietaire of the product claimed defective, and Buyer shall be barred from any remedy if Buyer fails to make such
claim within such perrod
Within 30 days after receipt of a timely claim, Quietaire shall have the option either to inspect the product while ri Buyer’s possession or ro reguest Buyer to return the product to Quietaire at Buyer’s expense
for inspection by Quietaire. Quietaire shall replace, or at its option repair, free of charge, any product it determines to be defective, and it shall ship the repaired or replacement product to Buyer P.O B point
of shipment; provided, however, it circumstances are such as Qsietaire judgment to prohibit repair or replacement to remedy the warranted defects, the buyers soie and eaclunive remedy shall be a reiar’,d to
the buyer of any part of the invoice price, paid to Ouietaire for the defective product or pars.
Ouietarre is nst responsible for the cost of removal of the defective product or part, damages due to removal, or any expenses incurred in shipping the product or part to or from Quietaire plant, nr the in
stallation of the repaired or replaced product or part
Implied warranties, when applicable, shall commence upon the name date as the express warranty provided above, and shall except for warranties of title, estend only for the duration of the eupress warranty
provided above, Some states do not allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you. The only remedy provided to you under an applicable implied warranty and the express warranty shall be the remedy provided under the express warranty, subject to the terms and conditions contained therein, Quietaire shall not be liable for incidental and consequentiallosses and damages under the express warranty, any applicable implied warranty, or claims for negligence, escept to the extent that his limitation is found to be unenforceable under applicable state law.
Some states do not allow exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. The warranty gives you specific legal rights, and you may
also have other rights which vary from state to state.
No employee, agent, dealer, or other person is authorized to give any warranties on behalf of Quietaire or to assume for Quietaire any other liability in connection with any of its products escept in writing and
signed by an officer of Quietaire.
Technical Advice And Recommendation. Disclaimer: Notwithstanding any past practice or dealings or any custom of the trade, sales shall not include the furnishing of technical advice or assistance or
system design. Any such assistance shall be at Quixtaire sole option and may be subject to additional charge
Quietaire assumes no obligation or liability on account of any recommendations, opinions. or advice as to the choice, installation or use of products Any such recommendations, opinions oradvice aregiven
and shall be accepted at your own risk and shall not constitute any warranty or guarantee of ouch products or their performance.
505 N. Hutcheson • Houston, Texas 77003 • Phone 713/228-9421 • Fax 713/228-9425