Practical Final Work
-
Upload
thanhhotboy98 -
Category
Documents
-
view
218 -
download
0
Transcript of Practical Final Work
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 1/15
Country: Language:
37th International Chemistry Olympiad
Taipei, Taiwan
Practical ExaminationTuesday, 19 July !!"
1
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 2/15
Country: Language:
Important #emar$s
The plastic bag you got upon entering the laboratory is the unknown samples for experiment2. Put it inside the basket on your bench for later use.
At all times while you are in the laboratory you should wear safety spectacles or your own
spectacles if they have been approved.
Eating of any kind of food is strictly prohibited in the laboratory.
When you enter the laboratory check the place of the safety shower.
Participants are expected to work safely to behave socially and to keep e!uipment and work
environment clean. "o not hesitate to ask a laboratory assistant if you have any !uestions
concerning safety issues.
%or$ may only &e'in when the start si'nal is 'i(en)
#ou have $ hours to complete all of the experimental tasks and record your results on the
answer sheets. There will be a pre%warning &' minutes before the end of your time. #ou must
stop your work immediately after the stop command is given. A delay in doing this by $
minutes will lead to cancellation of the current task and will result in (ero points for that task.
This practical examination comprises two experiments) In order to use the a(aila&le
time e**iciently, you will start wor$in' on the or'anic chemistry experiment up to the
point where you are instructed to wor$ on the analytical chemistry experiment) Then
you will *inish the wor$ on the or'anic chemistry experiment) The second part o* the
or'anic experiment +experiment 1 will need at least 1 hour)
-se only the pen and calculator pro(ided)
Write your name and personal identification code )in the back of your name card* on every
answer sheets.
All results must be written in the answer boxes on the answer sheets. "ata written elsewhere
will not be marked. "o not write anything in the back of your answer sheets. +f you need more
paper for working or a replacement answer sheet re!uest it from the laboratory assistant.
When you have finished the examination you must put all answer sheets into the envelope
provided. ,nly papers in the envelope will be marked.
"o not leave the examination room until you have permission to do so.
-se only the tools provided.
There are total " pages of answer sheets . for organic and 1 for analytical experiment
respectively.
blank draft papers )will not be marked* are provided more are available on re!uest
2
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 3/15
Country: Language:
An official English%language version is available only on re!uest.
/isposal o* waste chemicals, spills, and 'lassware
There are three waste containers in the lab one for organic filtrates and organic washings one for
solid wastes and one for broken glass.
Cleanin' up
Please keep your work area clean. Wipe your lab bench with a wet tissue when you are finished.
3
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 4/15
Country: Language:
4
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 5/15
Country: Language:
Or'anic synthesis
Equipment list
e!uipment /o. e!uipment /o.
0ot plate1stirrer with stand Weighing paper '
3tirrer 2 3ample vial )2' m4*
(blue label labelled with your
student code and 1H NMR)
3tirrer retriever 3hared by
2 persons
3ample vial )2' m4*
(pink label labelled with your
student code and [α]D)
5iltration pump 3hared by
2 persons
6lass rod
7lamp with holder & 3patula 2
thermometer 3epta 2
Pasteur pipette $ Water bath )stainless steel*
Pipette bulb 2 +ce bath )3tyrofoam*
6raduated cylinder )' m4* /eedle
6raduated cylinder)2$ m4* Water bottle with "eioni(ed 02,
8ound bottom flask )2$ m4* 6love )cotton* pair
8ound bottom flask )$' m4* 6love )latex* on central bench
5ilter 5ritted )$' m4*
(labelled with your student code)
5lask holder pc
5ilter 5ritted )9' m4*
(labelled with your student code)
Paper towel roll
5iltration flask with rubber )2$' m4* :imwipes box
7ondenser 6lass funnel
Teflon sleeve for condenser
(you can trim off 1 cm from the smaller
end for a better fit)
;eaker )<'' m4*
3afety goggles ;eaker )'' m4*
5
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 6/15
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 7/15
Country: Language:
8isk statements
8 0ighly flammable.
8 2' 0armful by inhalation.
8 22 0armful if swallowed.
8 2$ Toxic if swallowed.
8 & 7ontact with acids liberates toxic gas.
8 &2 7ontact with acid liberates very toxic gas.
8 & 7auses burns.
8 &$ 7auses severe burns.
8 &= +rritating to eyes.
8 &9 +rritating to respiratory system.
8 &< +rritating to skin.
8 ' 4imited evidence of a carcinogenic effect
8 8isk of serious damage to the eyes.
8 & Cay cause sensiti(ation by skin contact.
8 $' Dery toxic to a!uatic organisms.
8 $2 0armful to a!uatic organisms.
8 $& Cay cause long%term adverse effects in the a!uatic environment.
7ombination of risk statements
8 2'12122 0armful by inhalation in contact with skin and if swallowed.
8 &=1&91&< +rritating to eyes respiratory system and skin.
3afety statements
3 9 :eep container tightly closed.
3 & :eep away from food drink and animal foodstuffs.
3 = :eep away from sources of ignition % /o smoking.
3 22 "o not breathe dust.
3 2& "o not breathe gas1fumes1vapour1spray )appropriate wording to be specified by the
manufacturer*.
3 2&.2 "o not breathe vapor.
3 2 Avoid contact with skin.
3 2= +n case of contact with eyes rinse immediately with plenty of water and seek medical
advice.
3 2< After contact with skin wash immediately with plenty of soap%suds.
3 &' /ever add water to this product.
!
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 8/15
Country: Language:
3 &= Wear suitable protective clothing.
3 &9 Wear suitable gloves.
3&? Wear eye 1 face protection.
3 +n case of fire and1or explosion do not breathe fumes.
3 $ +n case of accident or if you feel unwell seek medical advice immediately )show the label
where possible*.
3 =' This material and its container must be disposed of as ha(ardous waste.
3 = Avoid release to the environment. 8efer to special instructions 1 3afety data sheets.
7ombination of safety statements
3 212$ Avoid contact with skin and eyes.
3 &=1&91&? Wear suitable protective clothing gloves and eye1face protection.
3 &=1&9 Wear suitable protective clothing and gloves.
3 &91&? Wear suitable gloves and eye1face protection.
"
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 9/15
Country: Language:
Experiment 1
The 0ynthesis o* /,2Phenyl'lycine and Its Enantiomeric #esolution
,ne of the enantiomeric forms of phenylglycine is an important raw material for the preparation
of β%lactam antibiotics. +ndustrial production of optically active phenylglycine is prepared by the
Andeno process. The starting ben(aldehyde was treated with 07/1/0& following hydrolysis to give
the racemic "4%phenylglycine. The desired enantiomeric phenylglycine was then resolved by )B*%
camphorsulfonic acid @)B*%73A.
#
#
#H70,
1$ H%N& NH32$ Hydrolysis
D&'henyl*lycine
Rh catalystH%##NH4
(+ndeno rocess)
;en(aldehyde "4%phenylglycine ;en(oylformic acid
+n this experiment you are going to synthesi(e racemic "4%phenylglycine )also referred to as
8% and 3% isomers respectively* from an alternative method called reductive amination. Treatment
of ben(oylformic acid under 8h metal cataly(ed conditions gives "4%phenylglycine. The racemic
"4%phenylglycine is resolved by the treatment of )B*%73A in water. The solubility of "%
phenylglycine•)B*%73A salt is $.9$ g1''g 02, while that of 4%phenylglycine•)B*%73A salt is $'
g1''g 02, at 2$ F7. The chemical yield and the optical purity of the diastereomeric salt will be
measured.
EPE#I4E5T6 P#OCE/-#E
Caution 8ou ha(e to wear latex 'lo(es durin' all operation *or practical tas$ 1)
0tep 1) Preparation o* /,2phenyl'lycine
The following pre-weighted chemicals can be used directly without further weighing:
Benzoylformic Acid; Ammonium Formate; Rh Catalyst; !"-camphorsulfonic acid #!"-
C$A%&
. To a $' m4 round%bottomed flask is added a magnetic stirring bar pre%weighed )approximate
,
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 10/15
Country: Language:
.<' g exact mass will be on your sample bottle write down the mass on your answer sheet
and get the lab assistant to confirm the weight.* of ben(oylformic acid )5OTE irritant' do not
contact with s(in* 9.$9 g of ammonium formate )07,2/0* &9.2 mg of 8h catalyst )5OTEthe catalyst is wrapped in a wei'hin' paper in a plastic &a') andle with care:* and 22 m4
of the pre%mixed solvents at ambient temperature.
2. Put a reflux condenser )use the Teflon sleeveG you can trim off cm from the smaller end for a
better fit* into the neck of the flask and plug the condenser with a septum. 5or pressure
e!uilibration put a needle in the septum before starting the heating. 7lamp the apparatus
tightly to the stand in your hot plate1stirrer. Put the flask onto a hot water bath @hot water
provided by the organi(er and stir the reaction mixture gently. ) 5OTE the sol(ent is air
cooled, so there is no tap water runnin' throu'h the condenser) * The temperature of the
water bath needs to be maintained in the range of =< to 92 F7 by adHusting the thermostat of the
hot plate1stirrer.
&. The mixture will become cloudy and the color of the solution will change from clear yellowish to
dark%greenish when the product starts to precipitate )generally re!uiring 2$ I &$ minutes*. The
hot water bath should then be removed and the solution allowed to stir in the water bath
)ambient temperature* for an additional ' minutes.
. Add $ m4 of deioni(ed water to the resulting mixture and stir for ' minutes.
$. Pre%weigh the bigger fritted glass funnel )labelled with your student code* and get the lab
assistant to confirm the weight. -se the stir bar retriever to remove the stir bar. 7ollect the
product by filter suction through a fritted glass funnel under a reduced pressure )rotary aspirator
apparatus*. Wash the solid four times thoroughly with ethanol )' m4 each*. 5or each washing
brea( the aspirator pressure use a glass rod to perturb the solid when adding ethanol and
reapply the rotary aspirator.
=. 5or rapid drying you have to spread the product over the fritted glass funnel. 5or drying give
the fritted glass funnel to the lab assistant. The product is dried in the oven at '' F7 for .$
hour.
)uring the drying period you can start wor(ing on *+periment , Analytical
*+periment" and you will be notified when your product is ready& $tep , ofe+periment will need at least hour&
1-
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 11/15
Country: Language:
9. Weigh the dried product @)"4*%phenylglycine record the data and calculate the chemical yield)based on the starting ben(oylformic acid*. 6et the lab assistant to confirm the weight. The
purity of the product will be determined by 0 /C8 spectrum analysis. Turn in the product in a
vial )&lue la&el with 0 /C8 and your student code* to the lab assistant and receive a new
batch of "4%phenylglycine for step 2.
0tep ) Enantiomeric resolution o* /,2phenyl'lycine &y +;2camphorsul*onic acid <+;2C06=
. To a 2$ m4 round%bottomed flask add the pre%weighed sample of "4%phenylglycine provided
)The exact mass will be on your sample bottle write down the mass on your answer sheet and
get the lab assistant to confirm the weight*. To this add the pre%weighed )B*%camphorsulfonic
acid @)B*%73A ).<' g*. 7lamp the apparatus tightly to a stand in a magnetic stirrer. Add
deioni(ed water ) m4* and place the flask in a hot water bath and heat it to a temperature in
the range of ?' I '' F7. :eep the mixture at this temperature for ' minutes until it turns
clear.
2. 8emove the hot water bath and allow the mixture to cool down to ambient temperature for
'I$ minutes. With the flask plugged with a septum cool the flask in ice bath )3tyroform* for
$ minutes. 7rystals should appear in about 2' minutes if not you may ask for seed crystals to
induce the crystalli(ation.
&. Pre%weigh the smaller fritted glass funnel )labelled with your student code* and get the lab
assistant to confirm the weight. 7ollect the product by filtering the solution through a fritted
glass funnel under a reduced pressure. Wash the solid thoroughly two times with ice cooled
distilled water )$ m4 each*.
. 5or drying give the fritted glass funnel to the lab assistant. The product will be dried over in
oven at '' F7 for 2' min. #ou will be notified when your product is ready. Weigh the product
and get the lab assistant to confirm the weight. 8ecord the data and calculate the chemical
yield )based on starting "4%phenylglycine*.
$. The optical purity of the diastereomeric salt will be measured using an accurate polarimeter
apparatus by the examination committee. Transfer the dried product to a sample vial )pin$la&el labelled with @α" and your student code* and give the sample vial to the lab assistant)
11
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 12/15
Country: Language:
The organi(ation committee will weigh an appropriate amount of the product )'.'$$ I '.'=$g*
for measurement of optical purity.
The organization committee will weigh the resolved product (from the fritted glass funnel) for
students who fail to finish the procedure in time. However, 1 penalty points will be ta!en.
12
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 13/15
Country: Language:
Experiment
Identi*ication o* -n$nown Inor'anic 0amples
5ote
)* This practical exercise is a kind of Jspot testK. #ou can do it on the pallet or on a sheet of black
film )for white precipitate*.
)2* Please check all items written in the e!uipment and reagent list.
)&* Please chec$ care*ully the code num&er o* the un$nown sample with the Chec$ ist
accompanied with your un$nown samples)
)* The volume of each unknown solution is about .$ m4 )about &' drops*. 5o more rea'ents or
samples will &e pro(ided.
)$* ;e sure to confirm your results before writing your answers in the blanks of the Answer 3heet.
)=* Cake sure the switch on the battery box is closed.
)9* 8ou will 'et > points *or each correct identi*ication)
Introduction
There are 2 unknown samples in your plastic bag:? unknown solutions are in droppers and
& unknown solids are in vials. All unknown samples are numbered with a & digit code. Please
check the number with the ist o* -n$nown Inor'anic 0amples carefully then write your student
code and name on the list. )The list is accompanied with your unknown samples* Each vial
contains about 2' mg of crystals or powder of one pure compound. Each dropper contains about
.$ m4 solution of one pure compound dissolved in distilled water. The concentration of unknown
solutions is in the range of '.'$ to '.$ C )mol14*.
The unknown samples are as follows>
07l 02,2 023, Ln7l2 /037/
/a,0 /a27,& /a23,& ;a7l2 :5e)7/*=
5ote
)* Two unknown samples are duplicates.
)2* The hydrated 02, of crystal is omitted in the formulas listed above.
13
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 14/15
Country: Language:
,n your lab bench there is a plastic basket which contains the e!uipments unknown
samples and reagents to be used in this task.
E!uipment list
e!uipment /o. e!uipment /o.
Pt wire electrode Au wire electrode
;attery case ;attery 2
Pallet ;lack film )round*
3cissors "ropper ) m4* $
7offee stirrer 2
8eagent list
8eagent 7onc. 8eagent 7onc.
:+ '.C pp )phenolphthalein* '.'%
5e7l& '.C 3tarch solution '.'%
8isk and safety statements
7hemicals 5ormula 8isk statements 3afety statements
0ydrochloric acid 07l &=1&91&< 2=
3ulfuric acid 023, &$ 2=%&'%$
3odium hydroxide solution /a,0 &$ 2=%&=1&91&?%$
0ydrogen peroxide solution 02,2 22% 2=%&?
3odium carbonate solution /a27,& &= 22%2=
;arium chloride solution ;a7l2 2'%2$ $
3odium sulfite solution /a23,& &%&=1&91&< 2=%&=
Linc chloride solution Ln7l2 22%&%$'1$& 2=%&=1&91&?%$%='%=
Potassium
hexacyanoferrate )++*
solution
:5e)7/*= &2 22%212$
Ammonium thiocyanate
solution
/037/ 2'12122%&2%$21$& &%=
+ron )+++* chloride )solid* 5e7l& 22%& 2=%&=1&91&?%$
14
8/13/2019 Practical Final Work
http://slidepdf.com/reader/full/practical-final-work 15/15
Country: Language:
Potassium iodide )solid* :+ % 22%212$ M
3tarch solution % % %
Phenolphthalein indicator ' &=1&9
,- -se the four reagents provided and mutual reactions among the unknown samples and the
simple electrolysis apparatus to identify each unknown sample and write your answer )& digit
code* in the blanks of your answer sheet.
,-, +n this practical work you have performed a series of tests to identify )or confirm* the
unknowns. 3how the reactions involved by way of chemical e!uations.
A. Write the electrolysis e!uation that would help you confirm that an unknown sample is
Ln7l2.
;. Write one e!uation that shows how to clean the deposit of Ln on the electrode )limited to
the items provided in this task*.
15
Note
+.ter you ha/e .inished your wor0& lease ut the two electrodes (t and +u wires) and two
batteries bac0 in their ori*inal lastic ba*s& resecti/ely& then return all euient and rea*ents
(include un0nown sales) to the ori*inal laces (in the lastic bas0et)$