8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 1/203

0 - VAUXHALL Astra

VAUXHALL Astra

Owner’s ManualModel Year 2010Edition: August 2009

TS 1680-A-10

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 2/203

Introduction ....................................

In brief ............................................

Keys, doors and windows ............ 1

Seats, restraints ........................... 3

Storage ........................................ 5

Instruments and controls .......... ... 6

Lighting ...................................... 10

Climate control ........................... 11

Driving and operating ................. 12

Vehicle care ............................... 14

Service and maintenance .......... 18

Technical data ........................... 18

Customer information ................ 19

Index .......................................... 19

Contents

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 3/203

2 Introduction

Introduction

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 4/203

Introduction

Vehicle specific data

Please enter your vehicle's data onthe previous page to keep it easilyaccessible. This information is

available in the sections "Service andmaintenance" and "Technical data"as well as on the identification plate.

Introduction

Your vehicle is a designedcombination of advanced technology,safety, environmental friendlinessand economy.

This Owner's Manual provides youwith all the necessary information toenable you to drive your vehiclesafely and efficiently.

Make sure your passengers areaware of the possible risk of accidentand injury which may result fromimproper use of the vehicle.

You must always comply with the

specific laws and regulations of thecountry that you are in. These lawsmay differ from the information in thisOwner's Manual.

When this Owner's Manual refers toa workshop visit, we recommend your Vauxhall Authorised Repairer.

 All Vauxhall Authorised Repairers

provide first-class service atreasonable prices. Experiencedmechanics trained by Vauxhall workaccording to specific Vauxhallinstructions.

The customer literature pack shouldalways be kept ready to hand in thevehicle.

Using this manual

■ This manual describes all optionsand features available for thismodel. Certain descriptions,including those for display andmenu functions, may not apply toyour vehicle due to model variant,country specifications, specialequipment or accessories.

■ The "In brief" section will give youan initial overview.

■ The table of contents at thebeginning of this manual and withineach section shows where theinformation is located.

■ The index will enable you to searcfor specific information.

■ This Owner's Manual depicts left-hand drive vehicles. Operation is

similar for right-hand drive vehicles■ The Owner's Manual uses the

factory engine designations. Thecorresponding sales designationscan be found in the section"Technical data".

■ Directional data, e.g. left or right, ofront or back, always relate to thedirection of travel.

■ The vehicle display screens maynot support your specific language

■ Display messages and interior labelling are written in bold letters

Danger, Warnings andCautions

9 Danger

Text marked 9  Danger providesinformation on risk of fatal injury.Disregarding this information mayendanger life.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 5/203

4 Introduction

9 Warning

Text marked 9  Warning providesinformation on risk of accident or 

injury. Disregarding thisinformation may lead to injury.

Caution

Text marked Caution providesinformation on possible damage tothe vehicle. Disregarding thisinformation may lead to vehicle

damage.

Symbols

Page references are indicated with3. 3 means "see page".

Thank you for choosing a Vauxhall.

We wish you many hours of pleasurable driving.

Your Vauxhall Team

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 6/203

Introduction

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 7/203

6 In brief

In brief

Initial drive information

Vehicle unlocking

Press button c to unlock the doorsand load compartment. Open thedoors by pulling the handles. To openthe tailgate, pull the button under thetailgate moulding.

Radio remote control 3 18, Centrallocking system 3 20, Loadcompartment 3 22.

Seat adjustment

Seat positioning

Pull handle, slide seat, releasehandle.

Seat position 3 34, Seat adjustment3 35.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 8/203

In brief

Seat backrests

Pull lever, adjust inclination andrelease lever. Allow the seat toengage audibly.

Seat position 3 34, Seat adjustment3 35.

Seat height

Lever pumping motionup = seat higher  down = seat lower 

Seat position 3 34, Seat adjustment3 35.

Seat inclination

Lever pumping motionup = front end higher  down = front end lower 

Seat position 3 34, Seat adjustment3 35.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 9/203

8 In brief

Head restraint adjustment

Press the button, adjust height andengage.

Head restraints 3 33.

Seat belt

Pull out the seat belt and engage inbelt buckle. The seat belt must not betwisted and must fit close against thebody. The backrest must not be tiltedback too far (maximum approx. 25 °).

To release belt, press red button onbelt buckle.

Seat position 3 34, Seat belts3 38, Airbag system 3 41.

Mirror adjustment

Interior mirror

To reduce dazzle, adjust the lever onthe underside of the mirror housing.

Interior mirror 3 27, Automatic anti-dazzle interior mirror 3 28.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 10/203

In brief

Exterior mirrors

Select the relevant exterior mirror andadjust it.

Convex exterior mirrors 3 26,Electric adjustment 3 26, Foldingexterior mirrors 3 26, Heatedexterior mirrors 3 27.

Steering wheel adjustment

Unlock the lever, adjust the steeringwheel, then engage the lever andensure it is fully locked.

Do not adjust the steering wheelunless the vehicle is stationary andthe steering wheel lock has beenreleased.

 Airbag system 3 41, Ignitionpositions 3 123.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 11/203

10 In brief

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 12/203

In brief 1

Instrument panel overview

1 Light switch ........................ 104Headlight rangeadjustment ......................... 105

Front fog lights ................... 109Rear fog light ...................... 109Instrument illumination ....... 110

2 Side air vents ...................... 119

3 Turn and lane-changesignals, headlight flash,low beam and high beam ... 109Exit lighting ......................... 112Parking lights ...................... 110

Driver Information Center ...... 874 Cruise control ..................... 135

5 Instruments .......................... 76

6 Horn ..................................... 70Driver airbag ........................ 42

7 Driver Information Center ...... 87

8 Steering wheel controls ........ 69

9 Windscreen wiper,

windscreen washer system, headlight washer system, rear wiper ................ 71

10 Centre air vents .................. 119

11 Infotainment system ............. 10

12 Info-Display .......................... 89

13  Anti-theft alarm systemstatus LED ........................... 24

14 Central locking system .......... 20Hazard warning flashers .. .. 108Control indicator for airbagdeactivation .......................... 82Control indicator for frontpassenger seat belt .............. 81

15 Sport mode ........................ 134Tour mode .......................... 134Traction Control system .... . 132

Electronic stability control . . 133Ultrasonic parking assist ... . 137Lane departure warning .... . 138

16 Front passenger airbag ........ 42

17 Glovebox .............................. 51

18 Climate control system ........ 114

19  AUX input, USB input ........... 10

20 Selector lever, manual

transmission ....................... 129 Automatic transmission ...... 126

21 Cigarette lighter .................... 75

22  Accelerator pedal ............... 122

23 Ignition switch withsteering wheel lock ........ .... 12

24 Brake pedal ........................ 13

25 Clutch pedal ....................... 12

26 Steering wheel adjustment ... 627 Storage compartment,

fuse box ............................. 16

28 Bonnet release lever .......... 14

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 13/203

12 In brief

Exterior lighting

Turn light switch

Auto = Automatic light control:Headlights are switched onand off automatically.

7 = activation or deactivation of the automatic light control

8 = sidelights9 = headlights

Press light switch> = front fog lights r = rear fog light

Lighting 3 104.

Headlight flash, high beam andlow beam

headlight flash = pull lever high beam = push lever  low beam = push or pull lever  

 Automatic light control 3 104, Highbeam 3 105, Headlight flash 3 105.

Turn and lane-change signals

lever up = right turn signallever down = left turn signal

Turn and lane-change signals3 109, Parking lights 3 110.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 14/203

In brief 1

Hazard warning flashers

Operated with the¨ button.Hazard warning flashers 3 108.

Horn

Pressj.

Washer and wiper systems

Windscreen wiper

2 = fast1 = slowP = timed interval wiping or 

automatic wiping with rainsensor 

§ = off  

For a single wipe when the

windscreen wiper is off, press thelever down.

Windscreen wiper 3 71, Wiper blade replacement 3 152.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 15/203

14 In brief

Windscreen and headlightwasher systems

Pull lever.

Windscreen and headlight washer system 3 71, Washer fluid 3 151.

Rear window wiper and washersystems

Push the rocker switch to activate therear window wiper:

upper position

= continuousoperation

lower position

= intermittentoperation

middleposition

= off  

Push lever.

Washer fluid is sprayed on the rear window and the wiper wipes a fewtimes.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 16/203

In brief 1

Climate control

Heated rear window, heatedexterior mirrors

The heating is operated by pressingtheÜ button.

Heated rear window 3 30.

Demisting and defrosting thewindows

Press buttonV.

Set the temperature control to thehighest level.

Coolingn on.

Heated rear windowÜ on.

Climate control system 3 114.

Transmission

Manual transmission

Reverse: with the vehicle stationarydepress the clutch pedal, pull up thebutton on the selector lever andengage the gear.

If the gear does not engage, set thelever to neutral, release the clutchpedal and depress again; then repeagear selection.

Manual transmission 3 129.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 17/203

16 In brief

Automatic transmission

P = parkR = reverseN = neutralD = drive

Manual mode: move selector lever from D to the left.

 < = higher gear ] = lower gear 

The selector lever can only be movedout of P when the ignition is on andthe brake pedal is applied. To engageP or R, push the release button.

 Automatic transmission 3 126.

Starting off

Check before starting off■ Tyre pressure and condition3 166, 3 194.

■ Engine oil level and fluid levels3 149.

■ All windows, mirrors, exterior lighting and number plates are freefrom dirt, snow and ice and areoperational.

■ Proper position of mirrors, seats,and seat belts 3 26, 3 34,3 39.

■ Brake function at low speed,particularly if the brakes are wet.

Starting the engine

■ Turn key to position 1■ move the steering wheel slightly to

release the steering wheel lock

■ operate clutch and brake

■ automatic transmission in P or N

■ do not accelerate

■ diesel engines: turn the key toposition 2 for preheating and wait

until control indicator ! goes out■ turn key to 3 and release

Starting the engine 3 123.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 18/203

In brief 1

Parking

■ Always apply the parking brake. Activate the manual parking brakewithout pushing the release button. Apply as firmly as possible ona downhill slope or uphill slope.Depress foot brake at the sametime to reduce operating force.

For vehicles with electrical parkingbrake pull switchm.

■ Switch off the engine. Turn theignition key to 0 and remove it. Turnthe steering wheel until the steering

wheel lock is felt to engage.For vehicles with automatictransmission, the key can only beremoved when the selector lever isin the P position.

■ If the vehicle is on a level surface or uphill slope, engage first gear or setthe selector lever to P beforeswitching off the ignition. On an

uphill slope, turn the front wheelsaway from the kerb.

If the vehicle is on a downhill slope,engage reverse gear or set theselector lever to P before switching

off the ignition. Turn the frontwheels towards the kerb.

■ Lock the vehicle with button e onthe radio remote control.

 Activate the anti-theft alarm system3 24.

■ Do not park the vehicle on an easilyignitable surface. The hightemperature of the exhaust systemcould ignite the surface.

■ Close the windows and the sunroof.

■ The engine cooling fans may runafter the engine has been switched

off 3 148.■ After running at high engine speeds

or with high engine loads, operatethe engine briefly at a low load or run in neutral for approx.30 seconds, before switching off inorder to protect the turbocharger.

Keys, locks 3 18, Laying the vehicleup for a long period of time 3 147.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 19/203

18 Keys, doors and windows

Keys, doors andwindows

Keys, locks ................................... 18

Doors ........................................... 22

Vehicle security ............................ 23

Exterior mirrors ............................ 26

Interior mirrors ............................. 27

Windows ...................................... 28

Roof ............................................. 30

Keys, locks

Keys

Replacement keys

The key number is specified in theCar Pass or on a detachable tag.

The key number must be quotedwhen ordering replacement keys as itis a component of the immobiliser system.

Locks 3 181.

Key with foldaway key section

Press button to extend. To fold thekey, f irst press the button.

Car Pass

The Car Pass contains securityrelated vehicle data and shouldtherefore be kept in a safe place.

When the vehicle is taken toa workshop, this vehicle data isneeded in order to perform certainoperations.

Radio remote control

Used to operate:

■ Central locking system

■ Anti-theft locking system

■ Anti-theft alarm system

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 20/203

Keys, doors and windows 1

■ Power windows

■ Sunroof 

The radio remote control has anapproximate range of up to 65 ft

(20 metres). It can be restricted byexternal influences. The hazardwarning flashers confirm operation.

Handle with care, protect frommoisture and high temperatures andavoid unnecessary operation.

FaultIf the central locking system cannotbe operated with the radio remote

control, it may be due to the following:

■ Range exceeded

■ Battery voltage too low

■ Frequent, repeated operation of theradio remote control while not inrange, which will require re-synchronisation

■ Overload of the central locking

system by operating at frequentintervals, the power supply isinterrupted for a short time

■ Interference from higher-power radio waves from other sources

Unlocking 3 20.

Basic settingsSome settings can be changed in themenu Settings in the Info-Display.

Vehicle personalisation 3 99.

Radio remote control batteryreplacementReplace the battery as soon as therange reduces.

Batteries do not belong in householdwaste. They must be disposed of atan appropriate recycling collectionpoint.

Key with foldaway key section

Extend the key and open the unit.Replace the battery (battery typeCR2032), paying attention to theinstallation position. Close the unitand synchronise.

Radio remote controlsynchronisation After replacing the battery, unlock thdoor with the key in the driver's doorlock. The radio remote control will bsynchronised when you switch on thignition.

Memorised settingsWhenever the key is removed fromthe ignition lock, the following settingare automatically remembered by thkey:

■ Lighting

■ Infotainment system

■ Central locking system

■ Sport mode settings■ Comfort settings

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 21/203

20 Keys, doors and windows

The saved settings are automaticallyused the next time the memorised keyis inserted into the ignition lock andswitched to position 1.

Precondition is, that Personalization

by driver, or depending on the displaytype, Personalization by remotecontrol in the personal settings of theInfo-Display is activated. This must beset for each used key. Vehiclepersonalisation 3 99

Vehicle personalisation 3 99.

Central locking system

Unlocks and locks doors, loadcompartment and fuel filler flap.

 A pull on an interior door handleunlocks the respective door. Pullingthe handle once more opens the door.

NoticeIn the event of an accident in whichairbags or belt pretensioners are

deployed, the vehicle isautomatically unlocked.

Unlocking

Press button c.Two settings are selectable:

■ To unlock only the driver's door ,load compartment and fuel filler flap, press button c once. To unlockall doors, press button c twice,

or 

■ press button c once to unlock alldoors, load compartment and fuelfiller flap.

The setting can be changed in themenu Settings in the Info-Display.Vehicle personalisation 3 99.

The setting can be saved for the keybeing used, Memorised settings3 19.

Locking

Close doors, load compartment andfuel filler flap.

Press button e.If the driver's door is not closedproperly, the central locking systemwill not work. Activation or 

deactivation of this function can bechanged in the menu Settings in theInfo-Display. Vehicle personalisation3 99.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 22/203

Keys, doors and windows 2

Unlocking and opening thetailgate

Press button cwhen the ignition is off.The tailgate is released to beunlocked and opened by pushing thetouchpad switch under the tailgatemoulding.

Central locking buttonsLocks or unlocks all doors, the loadcompartment and fuel filler flap from

the passenger compartment.

Press the e button to lock.

Press the c button to unlock.

When the key is in the ignition lock,locking is only possible if all doors areclosed.

Fault in radio remote controlsystem

Unlocking

Manually unlock the driver's door byturning the key in the lock. Switch onthe ignition and press the centrallocking button c to open all doors,load compartment and fuel filler flapTo deactivate the anti-theft lockingsystem, switch on the ignition.

Locking

Manually lock the driver's door byturning the key in the lock.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 23/203

22 Keys, doors and windows

Fault in central locking system

Unlocking

Manually unlock the driver's door byturning the key in the lock. The other 

doors can be opened by pulling theinterior handle twice. The loadcompartment and fuel filler flapcannot be opened. To deactivate theanti-theft locking system, switch onthe ignition 3 24.

Locking

Push inside locking knob of all doorsexcept driver's door. Then close the

driver's door and lock it from theoutside with the key. The fuel filler flapand tailgate cannot be locked.

Child locks

9 Warning

Use the child locks whenever children are occupying the rear seats.

Using a key or suitable screwdriver,turn the child lock in the rear door tothe horizontal position. Door cannot

be opened from the inside. For deactivation turn the child lock to thevertical position.

Doors

Load compartment

Tailgate

Opening

 After unlocking pull the button under the tailgate moulding and open thetailgate.

Central locking system 3 20.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 24/203

Keys, doors and windows 2

Closing

Use one of the interior handles.Do not pull the button under themoulding whilst closing as this willunlock tailgate again.

Central locking system 3 20.

General hints for operatingtailgate

9 Warning

Do not drive with the tailgate openor ajar, e.g. when transportingbulky objects, since toxic exhaustgases, which can not be seen or smelled, could enter the vehicle.This can cause unconsciousnessand even death.

Caution

Before opening the tailgate checkoverhead obstructions, such asa garage door, to avoid damage of the tailgate. Always check themoving area above and behind thetailgate.

Notice

The installation of certain heavyaccessories onto the tailgate mayaffect its ability to remain open.

Vehicle security

Anti-theft locking system

9 Warning

Do not use the system if there arepeople in the vehicle! The doorscannot be unlocked from theinside.

The system deadlocks all the doors All doors must be closed otherwisethe system cannot be activated.

If the ignition was on, the driver's doomust be opened and closed once sothat the vehicle can be secured.

Unlocking the vehicle disables themechanical anti-theft locking systemThis is not possible with the centrallocking button.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 25/203

24 Keys, doors and windows

Activating

Press e on the radio remote controltwice within 15 seconds.

Anti-theft alarm system

The anti-theft alarm system iscombined with the anti-theft lockingsystem.

It monitors:

■ Doors, tailgate, bonnet

■ Passenger compartment includingadjoining load compartment

■ Vehicle inclination, e.g. if it is raised

■ Ignition

Activation■ Self-activated 30 seconds after 

locking the vehicle (initialisation of the system)

■ Directly by pressing e on the radioremote control once more after locking

NoticeChanges to the vehicle interior suchas the use of seat covers, and openwindows or sunroof, could impair thefunction of passenger compartmentmonitoring.

Activation without monitoring ofpassenger compartment andvehicle inclination

Switch off the monitoring of passenger compartment and vehicleinclination when people or animalsare being left in the vehicle, becauseof high volume ultrasonic signals,movements triggering the alarm andwhen the vehicle is on a ferry or train.

1. Close tailgate, bonnet, windowsand sunroof.

2. Press buttono. LED in thebuttono illuminates for maximum 10 minutes.

Keys, doors and windows 2

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 26/203

3. Close doors.

4. Activate the anti-theft alarmsystem.

Status message is displayed in theDriver Information Center.

Status LED

Status LED is integrated in the sensor on top of the instrument panel.

Status during the first 30 seconds of anti-theft alarm system activation:

LEDilluminates

= test, arming delay.

LED flashes

quickly

= doors, tailgate or 

bonnet notcompletely closed,or system fault.

Status after system is armed:

LED flashesslowly

= system is armed.

LED flashesquickly

3 times after unlocking

= system is disarmed.

Seek the assistance of a workshop inthe event of faults.

DeactivationUnlocking the vehicle deactivatesanti-theft alarm system.

AlarmWhen triggered, the alarm sounds viaa separate battery-backed power sounder, and the hazard warning

lights flash simultaneously. Thenumber and duration of alarm signalare stipulated by legislation.

The alarm can be silenced bypressing any button of the radio

remote control or by switching on thignition.

The anti-theft alarm system can bedeactivated only by pressing buttonc or by switching on the ignition.

Immobiliser

The system is part of the ignition loc

and checks whether the vehicle isallowed to be started with the keybeing used.

The electronic immobiliser is going tbe activated automatically after thekey has been removed from theignition lock.

If the control indicator d flashes whethe ignition is on, there is a fault in th

system; the engine cannot be startedSwitch off the ignition and then repeathe start attempt.

26 Keys, doors and windows

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 27/203

If the control indicator continuesflashing, attempt to start the engineusing the spare key and seek theassistance of a workshop.

Notice

The immobiliser does not lock thedoors. You should always lock thevehicle after leaving it and switch onthe anti-theft alarm system 3 20,3 24.

Control indicator d 3 85.

Exterior mirrors

Convex shape

The convex exterior mirror reducesblind spots. The shape of the mirror makes objects appear smaller, whichwill affect the abilty to estimatedistances.

Electric adjustment

Select the relevant exterior mirror byturning the control to left (L) or right(R). Then swivel the control to adjustthe mirror.

In position 0 no mirror is selected.

Folding

For pedestrian safety, the exterior mirrors will swing out of their normalmounting position if they are struckwith sufficient force. Reposition themirror by applying slight pressure tothe mirror housing.

Keys, doors and windows 2

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 28/203

Electric folding

Turn control to7

, then push thecontrol down. Both exterior mirrorswill fold.

Push the control down again - bothexterior mirrors return to their originalposition.

If an electrically folded mirror ismanually extended, pressing downthe control will only electrically extend

the other mirror.

Heated

Operated by pressing theÜ button.Heating works with the enginerunning and is switched off automatically after a short time.

Interior mirrors

Manual anti-dazzle

To reduce dazzle, adjust the lever othe underside of the mirror housing.

28 Keys, doors and windows

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 29/203

Automatic anti-dazzle

Dazzle from following vehicles atnight is automatically reduced.

Windows

Manual windows

The door windows can be opened or closed with the window winders.

Power windows

9 Warning

Take care when operating thepower windows. Risk of injury,particularly to children.

If there are children on the rear seats, switch on the child safetysystem for the power windows.

Keep a close watch on thewindows when closing them.Ensure that nothing becomestrapped in them as they move.

Switch on ignition to operate power windows.

Operate the switch for the respectivewindow by pushing to open or pulling

to close.Pushing or pulling gently to the firstdetent: window moves up or down aslong as switch is operated.

Pushing or pulling firmly to the seconddetent and then releasing: windowmoves up or down automatically withenabled safety function. To stopmovement, operate the switch once

more in the same direction.

Keys, doors and windows 2

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 30/203

Safety functionIf the window glass encountersresistance above the middle of thewindow during automatic closing, it isimmediately stopped and opened

again.

Override safety functionIn the event of closing difficulties dueto frost or the like, pull and hold theswitch. The window moves up withoutsafety function. To stop movement,release and pull the switch oncemore.

Child safety system for rearwindows

Press switchz to deactivate rear door power windows, the LEDilluminates. To activate, press zagain.

Operating windows from outsideThe windows can be operatedremotely from outside the vehicle.

Press and hold c button to openwindows.

Press and hold e button to close

windows.

Release button to stop windowmovement.

OverloadIf the windows are repeatedlyoperated within short intervals, thewindow operation is disabled for some time.

Initialising the power windowsIf the windows cannot be closedautomatically (e.g. after disconnecting the vehicle battery),a warning message or a warning codis displayed in the Driver InformationCenter.

Vehicle messages 3 91.

 Activate the window electronics asfollows:

1. Close doors.

2. Switch on ignition.

3. Close the window completely ankeep the switch pulled for additional 2 seconds.

4. Repeat for each window.

30 Keys, doors and windows

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 31/203

Heated rear window

Operated by pressing theÜ button.Heating works with the enginerunning and is switched off automatically after a short time.

Depending on the engine type, theheated rear window comes onautomatically when the diesel particlefilter is being cleaned.

Sun visorsThe sun visors can be folded down or swivelled to the side to preventdazzling.

Sun visors swivelled to the side canbe adjusted in length.

If the sun visors have integral mirrors,the mirror covers should be closedwhen driving.

Roof

Sunroof

9 Warning

Take care when operating thesunroof. Risk of injury, particularlyto children.

Keep a close watch on themovable parts when operatingthem. Ensure that nothingbecomes trapped in them as theymove.

Switch on ignition to operate thesunroof.

Keys, doors and windows 3

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 32/203

Open or closePressp or r gently to the first

detent: sunroof is opened or closedwith enabled safety function as longas the switch is operated.

Pressp or r firmly to the seconddetent and then release: the sunroof is opened or closed automaticallywith enabled safety function. To stopmovement, operate the switch oncemore.

Raise or closePressq or r: sunroof is raised or closed automatically with enabledsafety function.

If the sunroof is raised, it can beopened in one step by pushingp.

SunblindThe sunblind is manually operated.

Close or open the sunblind by sliding.When the sunroof is open, thesunblind is always open.

General hints

Safety function

If the sunroof encounters resistanceduring automatic closing, it isimmediately stopped and opened

again.Override safety function

In the event of closing difficulties dueto frost or the like, hold the switchr pressed to the second detent.The sunroof closes without safetyfunction. To stop movement, releasethe switch.

Closing sunroof from outsideThe sunroof can be closed remotelyfrom outside the vehicle.

Press and hold e button to close thesunroof.

Release the button to stop themovement.

Initialising of the roof

If the sunroof cannot be closed (e.g.after disconnecting the vehiclebattery), activate the sunroof electronics as follows:

■ If sunroof is closed, keep the switcr

pressed for 10 seconds.■ If sunroof is open, keep the switchr pressed until sunroof is fullyclosed. Then release switch shortland press it again for 10 seconds.

32 Keys, doors and windows

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 33/203

Relearning of safety function

If the sunroof does not close correctlyafter initialising:

1. Open sunroof fully by pressingswitchp.

2. Release switch and then pressagain switchp gently to the firstdetent for approx. 30 seconds.The switch can be released, whenthe sunroof is in closed position.

Seats, restraints 3

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 34/203

Seats, restraints

Head restraints ............................ 33

Front seats ................................... 34

Rear seats ................................... 38

Seat belts ..................................... 38

 Airbag system .............................. 41

Child restraints ............................. 45

Head restraints

Position

9Warning

Only drive with the head restraintset to the proper position.

The upper edge of the head restraintshould be at upper head level. If this

is not possible for extremely tallpeople, set to highest position, andset to lowest position for small people.

Adjustment

Head restraints on front seats

Height adjustment

Press the button, adjust height andengage.

Active head restraints on front seats

In the event of a rear-end impact, thfront parts of the active headrestraints are moved slightlyforwards. Thus the head is supporteso that the risk of whiplash injury isreduced.

34 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 35/203

Notice Approved accessories may only beattached, if the seat is not in use.

Head restraints on rear seats

Height adjustment

Pull the head restraint upwards or press the catch to release and pushthe head restraint downwards.

Removal

Press both catches, pull the head

restraint upwards and remove.

Front seats

Seat position

9 Warning

Only drive with the seat correctlyadjusted.

■ Sit with buttocks as far back againstthe backrest as possible. Adjust the

distance between the seat and thepedals so that legs are slightlyangled when pressing the pedals.Slide the front passenger seat asfar back as possible.

■ Sit with shoulders as far backagainst the backrest as possible.Set the backrest rake so that it ispossible to easily reach thesteering wheel with arms slightly

bent. Maintain contact betweenshoulders and the backrest whenturning the steering wheel. Do notangle the backrest too far back. Werecommend a maximum rake of approx. 25°.

■ Adjust the steering wheel 3 69.

■ Set seat height high enough tohave a clear field of vision on all

sides and of all display instruments.There should be at least one handof clearance between head and theroof frame. Your thighs should restlightly on the seat without pressinginto it.

■ Adjust the head restraint 3 33.

■ Adjust the height of the seat belt3 39.

■ Adjust the thigh support so thatthere is a space approx. two fingerswide between the edge of the seatand the hollow of the knee.

Seats, restraints 3

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 36/203

■ Adjust the lumbar support so that itsupports the natural shape of thespine.

Seat adjustment

9 Danger

Do not sit nearer than 10 inches tothe steering wheel, to permit safeairbag deployment.

9 Warning

Never adjust seats while driving asthey could move uncontrollably.

Seat positioning

Pull handle, slide seat, releasehandle.

Seat backrests

Pull lever, adjust inclination andrelease lever. Allow the backrest toengage audibly.

36 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 37/203

Seat height

Lever pumping motion

up = seat higher  down = seat lower 

Seat inclination

Lever pumping motion

up = front end higher  down = front end lower 

Lumbar support

 Adjust lumbar support using four-wayswitch to suit personal requirements.

Moving support up and down: pushswitch up or down. Increasing anddecreasing support: push switchforwards or backwards.

Seats, restraints 3

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 38/203

Adjustable thigh support

Pull the lever and slide the thigh

support.

Armrest

Push button and fold armrestupwards. Under the armrest there isa storage compartment.

Heating

 Adjust heating to the desired settingby pressing the ß button for therespective seat one or more timeswith the ignition on. The controlindicator in the button indicates thesetting.

Prolonged use of the highest settingfor people with sensitive skin is notrecommended.

Seat heating is operational whenengine is running.

38 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 39/203

Rear seats

Armrest

Fold armrest down. The armrestcontains cupholders and a storagebox.

Seat belts

The seat belts are locked duringheavy acceleration or deceleration of the vehicle holding the occupants inthe sitting position. Thereby the risk of injury is considerably reduced.

9 Warning

Fasten seat belt before each trip.

In the event of an accident, peoplenot wearing seat belts endanger their fellow occupants andthemselves.

Seat belts are designed to be used byonly one person at a time. They arenot suitable for people smaller than5 ft. Child restraint system 3 45.

Periodically check all parts of the belt

system for damage and proper functionality.

Have damaged componentsreplaced. After an accident, have thebelts and triggered belt pretensionersreplaced by a workshop.

NoticeMake sure that the belts are notdamaged by shoes or sharp-edged

objects or are trapped. Prevent dirtfrom getting into the belt retractors.

Seat belt reminder X 3 81.

Belt force limitersOn the front seats, stress on the bodyis reduced by the gradual release of the belt during a collision.

Belt pretensionersIn the event of a head-on or rear-endcollision of a certain severity, the frontseat belts are tightened.

Seats, restraints 3

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 40/203

9 Warning

Incorrect handling (e.g. removal or fitting of belts) can trigger the beltpretensioners.

Deployment of the belt pretensionersis indicated by illumination of controlindicator v 3 81.

Triggered belt pretensioners must bereplaced by a workshop. Beltpretensioners can only be triggeredonce.

NoticeDo not affix or install accessories or other ob jects that may interfere withthe operation of the beltpretensioners. Do not make anymodifications to belt pretensioner components as this will invalidatethe vehicle type approval.

Three-point seat belt

Fastening

Withdraw the belt from the retractor,guide it untwisted across the bodyand insert the latch plate into thebuckle. Tighten the lap belt regularlywhilst driving by pulling the shoulder belt. Seat belt reminder 3 81.

Loose or bulky clothing prevents thebelt from fitting snugly. Do not place

objects such as handbags or mobilephones between the belt and your body.

9 Warning

The belt must not rest against hardor fragile objects in the pockets of your clothing.

40 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 41/203

Height adjustment

1. Pull belt out slightly.

2. Press button.

3. Adjust height and engage.

 Adjust the height so that the belt liesacross the shoulder. It must not lie

across the throat or upper arm.Do not adjust while driving.

Removing

To release belt, press red button onbelt buckle.

Seat belts on the rear seatsThe seat belt for the rear centre seatcan only be withdrawn from theretractor if the backrest is in the rear position.

Seats, restraints 4

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 42/203

Using the seat belt while pregnant

9 Warning

The lap belt must be positioned aslow as possible across the pelvisto prevent pressure on theabdomen.

Airbag system

The airbag system consists of a number of individual systemsdepending on the scope of 

equipment.When triggered the airbags inflatewithin milliseconds. They also deflateso quickly that it is often unnoticeableduring the collision.

9 Warning

If handled improperly the airbag

systems can be triggered in anexplosive manner.

NoticeThe airbag systems and beltpretensioner control electronics arelocated in the centre console area.Do not put any magnetic objects inthis area.

Do not stick anything on the airbagcovers and do not cover them withother materials.

Each airbag is triggered only once.Have deployed airbags replaced bya workshop. Above that it might benecessary to have the steeringwheel, the instrument panel, parts o

the panelling, the door seals,handles and the seats replaced.

Do not make any modifications tothe airbag system as this willinvalidate the vehicle type approva

Control indicator v for airbag system3 81.

42 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 43/203

Front airbag system

The front airbag system consists of one airbag in the steering wheel andone in the instrument panel on thefront passenger side. These can be

identified by the word AIRBAG.

There are also warning labels on bothsides of the sunblind on the frontpassenger side.

The front airbag system is triggered in

the event of a front-end impact of a certain severity. The ignition needsto be switched on.

The inflated airbags cushion theimpact, thereby reducing the risk of 

injury to the upper body and head of the front seat occupantsconsiderably.

9 Warning

Optimum protection is onlyprovided when the seat is in theproper position 3 34.

Keep the area in which the airbaginflates clear of obstructions.

Fit the seat belt correctly andengage securely. Only then theairbag is able to protect.

Side airbag system

Seats, restraints 4

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 44/203

The side airbag system consists of anairbag in each front seat backrest.This can be identified by the wordAIRBAG.

The side airbag system is triggered in

the event of a side impact of a certainseverity. The ignition needs to beswitched on.

The inflated airbags cushion theimpact, thereby reducing the risk of injury to the upper body and pelvis in

the event of a side-on collisionconsiderably.

9 Warning

Keep the area in which the airbaginflates clear of obstructions.

NoticeOnly use protective seat covers thathave been approved for the vehicle.Be careful not to cover the airbags.

Curtain airbag system

The curtain airbag system consists of an airbag in the roof frame on eachside. This can be identified by theword AIRBAG on the roof pillars.

The curtain airbag system is triggeredin the event of a side-on impact of a certain severity. The ignition needsto be switched on.

The inflated airbags cushion theimpact, thereby reducing the risk of 

injury to the head in the event of a side-on impact considerably.

9 Warning

Keep the area in which the airbaginflates clear of obstructions.

The hooks on the handles in theroof frame are only suitable for 

hanging up light articles of clothing, without coat hangers. Donot keep any items in theseclothes.

44 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 45/203

Airbag deactivation

The front passenger airbag systemhas to be deactivated if a childrestraint system is to be fitted on thisseat. The side airbag and curtain

airbag systems, the belt tensionersand all driver airbag systems willremain active.

The front passenger airbag systemcan be deactivated via a key-operated switch on the right side of 

the instrument panel.

Use the ignition key to choose theposition:

* = front passenger airbag isdeactivated and will not inflatein the event of a collision.

Control indicator * illuminatescontinuously. A child restraintsystem can be installed inaccordance with thechart Child restraint installationlocations 3 47. No adultperson is allowed to occupythe front passenger seat.

V = front passenger airbag isactive. A child restraint system

must not be installed.

9 Danger

Risk of fatal injury for a child usinga child restraint system together with activated front passenger airbag.

Risk of fatal injury for an adultperson with deactivated frontpassenger airbag.

 As long as the control indicator * isnot illuminated, the front passenger airbag system will inflate in the eventof a collision.

If both control indicators areilluminated at the same time, there isa system failure. The status of thesystem is not discernible, thereforeno person is allowed to occupy thefront passenger seat. Contacta workshop immediately.

Consult a workshop immediately, if none of the two control indicators isilluminated.

Change status only when the vehicleis stopped with the ignition off.

Seats, restraints 4

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 46/203

Status remains until the next change.

Control indicator for airbagdeactivation 3 82.

Child restraints

Child restraint systems

We recommend the Vauxhall childrestraint system which is tailored

specifically to the vehicle.When a child restraint system is beingused, pay attention to the followingusage and installation instructionsand also those supplied with the childrestraint system.

 Always comply with local or nationalregulations. In some countries, theuse of child restraint systems is

forbidden on certain seats.

9 Warning

When using a child restraintsystem on the front passenger seat, the airbag systems for the

front passenger seat must bedeactivated; if not, the triggering of the airbags poses a risk of fatalinjury to the child.

This is especially the case if rear-facing child restraint systems areused on the front passenger seat.

Selecting the right system

Children should travel facingrearwards in the vehicle as long aspossible. This makes sure that thechild's backbone which is still veryweak is under less strain in the evenof an accident.

Children under the age of 12 yearsthat are smaller than 5 ft are onlyallowed to travel in a restraint system

that is suitable for the child. Suitableare restraint systems that comply witECE 44-03 or ECE 44-04. Sincea proper position of the belt is rarelypossible with a child that is smaller 

46 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 47/203

than 5 ft, we advise strongly to use anappropriate child restraint system,even though this might due to the ageof the child no longer be legallybinding.

Ensure that the child restraint systemto be installed is compatible with thevehicle type.

Ensure that the mounting location of the child restraint system within thevehicle is correct.

 Allow children to enter and exit thevehicle only on the side facing awayfrom the traffic.

When the child restraint system is notin use, secure the seat with a seat beltor remove it from the vehicle.

NoticeDo not stick anything on the childrestraint systems and do not cover them with any other materials.

 A child restraint system which hasbeen subjected to stress in anaccident must be replaced.

Seats, restraints 4

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 48/203

Child restraint installation locations

Permissible options for fitting a child restraint system

Weight and age class

On front passenger seat

On rear outboard seats On rear centre seatctivated airbag deactivated airbag

Group 0: up to 10 kg

or approx. 10 months

X U1 U2 U

Group 0+: up to 13 kg

or approx. 2 years

X U1 U2 U

Group I: 9 to 18 kg

or approx. 8 months to 4 years

X U1 U2 U

Group II: 15 to 25 kg

or approx. 3 to 7 years

X X U U

Group III: 22 to 36 kg

or approx. 6 to 12 years

X X U U

1 = Only if front passenger seat airbag systems are deactivated. If the child restraint system is being secured using a threepoint seat belt, move seat height adjustment to uppermost position and ensure that vehicle safety belt runs forwardfrom the upper anchorage point.

2 = Seat available with ISOFIX and Top-Tether mounting brackets.U = Universal suitability in conjunction with three-point seat belt.X = No child restraint system permitted in this weight class.

48 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 49/203

Permissible options for fitting an ISOFIX child restraint system

Weight class Size class Fixture On front passenger seat On rear outboard seats On rear centre seat

Group 0: up to 10 kg E ISO/R1 X IL X

Group 0+: up to 13 kg E ISO/R1 X IL X

D ISO/R2 X IL X

C ISO/R3 X IL X

Group I: 9 to 18 kg D ISO/R2 X IL X

C ISO/R3 X IL X

B ISO/F2 X IL, IUF X

B1 ISO/F2X X IL, IUF X A ISO/F3 X IL, IUF X

IL = Suitable for particular ISOFIX restraint systems of the 'specific-vehicle', 'restricted' or 'semi-universal' categories.The ISOFIX restraint system must be approved for the specific vehicle type.

IUF = Suitable for ISOFIX forward-facing child restraint systems of universal category approved for use in this weightclass.

X = No ISOFIX child restraint system approved in this weight class.

Seats, restraints 4

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 50/203

ISOFIX size class and seat device A – ISO/F3 = Forward-facing child restraint system for children of maximum size in the weight class 9 to 18 kg.B – ISO/F2 = Forward-facing child restraint system for smaller children in the weight class 9 to 18 kg.B1 – ISO/F2X = Forward-facing child restraint system for smaller children in the weight class 9 to 18 kg.C – ISO/R3 = Rear-facing child restraint system for children of maximum size in the weight class up to 13 kg.D – ISO/R2 = Rear-facing child restraint system for smaller children in the weight class up to 13 kg.E – ISO/R1 = Rear-facing child restraint system for young children in the weight class up to 13 kg.

50 Seats, restraints

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 51/203

ISOFIX child restraint systems

Fasten vehicle-approved ISOFIX

child restraint systems to the ISOFIXmounting brackets. Specific vehicleISOFIX child restraint systempositions are marked in the table byIL.

ISOFIX mounting brackets areindicated by a label on the backrest.

Top-tether fastening eyes

Top-tether fastening eyes are markedwith the symbol: for a child seat.

In addition to the Isofix mountingfasten the Top-tether strap to the Top-tether fastening eyes. The strap mustrun between the two guide rods of thehead restraint.

ISOFIX child restraint systems of universal category positions aremarked in the table by IUF.

Storage 5

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 52/203

Storage

Storage compartments ................ 51

Load compartment ....................... 62Roof rack system ......................... 67

Loading information ..................... 68

Storage compartments

Glovebox

The glovebox features a pen holder,a card holder and a place to storecoins.

The glovebox shelf can be removed.

The glovebox should be closed whilstdriving.

Cupholders

Cupholders are located in the centre

console.

52 Storage

Depending on the version

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 53/203

Depending on the version,cupholders are located under a cover in the centre console. Slide cover backwards.

 Additional cupholders are located inthe rear armrest. Fold down thearmrest.

Sunglasses storage

Fold down and open.

Do not use for storing heavy objects.

Underseat storage

Lift at recess and pull out. Maximum

load: 3 kg. To close, push in andengage.

Depending on the version, the tyrerepair kit is stowed in the underseatstorage.

Storage 5

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 54/203

Armrest storage

Storage in the front armrest

Push button to fold up the armrest.

Storage in the rear armrest

Fold down armrest and open cover.

Close cover before folding thearmrest up.

Centre console storage

Front consoleSlide cover backwards.

Push button to remove the cupholde

54 Storage

A further storage compartment is

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 55/203

 A further storage compartment islocated under the shelf. Fold up theshelf.

Rear console

Pull out the drawer.

Caution

Do not use for ash.

Rear carrier system

The rear carrier system (Flex-Fix

system) allows bikes to be attached toa pull-out carrier integrated into thevehicle floor.

The maximum load is 40 kg.

If not in use, the carrier system can beslid back into the vehicle floor.

 A multifunction box is offered as anaccessory for the rear carrier system.The transportation of other objects isnot permitted.

There must not be any objects on thebicycles that could become looseduring transportation.

ExtendingOpen the tailgate.

9 Warning

No people may remain in theextension zone of the rear carrier system, risk of injury.

Pull release lever up. The systemdisengages and travels quickly out of the bumper.

Storage 5

Open out the bulb holder on the bac

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 56/203

Completely pull out the rear carrier system until you hear it engage.

Ensure that it is not possible to pushin the rear carrier system withoutpulling the release lever again

9 Warning

It is only permissible to fit objectsto the rear carrier system if thesystem has been correctlyengaged. If the rear carrier system

will not engage correctly, do not fitobjects to the system and slide thesystem back. Seek the assistanceof a workshop.

Install the tail lights

First remove the rear (1), then the

front (2) tail light from the recesses.

Open out the bulb holder on the bacof the tail light completely.

Push the clamping lever down andpush the bulb holder into the retaineuntil it hits the stop.

Perform this procedure for both taillights.

56 Storage

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 57/203

Check the cable and light position tomake sure these are correctlyinstalled and are securely located.

Lock the rear carrier system

Swivel the left clamping lever (1) back

first, followed by the right clampinglever (2) until they stop. Bothclamping levers must pointbackwards, otherwise safefunctionality is not guaranteed.

NoticeClose the tailgate!

Unfold pedal crank recesses

Fold one or both pedal crank

recesses upwards until the diagonalsupport engages.

Storage 5

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 58/203

Remove the pedal crank mounts fromthe pedal crank recesses.

Adapting the rear carrier systemto a bicycle

Press the release lever and withdrawthe wheel recesses.

Push the release lever on the strapretainer and remove the strapretainer.

58 Storage

Prepare the bicycle for Attaching a bicycle to the rear

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 59/203

attachment

Rotate the left pedal (without a chaincog) vertically downwards. The pedalon the left pedal crank must behorizontal.

The front bicycle must have its frontwheel facing left.

The rear bicycle must have its frontwheel facing right.

carrier system

With the rotary lever on the pedalcrank recess, roughly adapt theadjustable pedal crank unit to theprotrusion of the pedal crank.

If the bicycle has straight pedalcranks, unscrew the pedal crank unitcompletely (position 5).

If the bicycle has curved pedalcranks, screw in the pedal crank unitall the way (position 1).

Storage 5

Put on the bicycle. The pedal crank Place the wheel recesses such that

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 60/203

y phere must be placed in the pedalcrank recess opening as shown in theillustration.

Caution

Make sure that the pedal does nottouch the surface of the rear endcarrier. Otherwise the bottombracket might be damaged duringthe transport.

Insert pedal crank mount into outer rail of each pedal crank recess fromabove and slide downwards till atleast underneath the notching.

 Attach the pedal crank by rotating theattachment screw on the pedal crankmount.

the bicycle is more or less horizontaHere, the distance between thepedals and the tailgate should be atleast 2 inches.

Both bicycle tyres must be in the

wheel recesses. In order to preventdamage, neither the pedal bearinghousing on the bicycle nor the pedacrank is allowed to be touching thepedal crank recess.

 Align the bicycle in the longitudinaldirection of the vehicle: Slightlyloosen the pedal mount.

60 Storage

Place the bicycle upright using the Secure both bicycle wheels to wheel Hold on to the bicycle, loosen the

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 61/203

rotary lever on the pedal crankrecess.

If the two bicycles obstruct oneanother, the relative positions of thebicycles can be adapted by adjusting

the wheel recesses and the rotarylever on the pedal crank recess untilthe bicycles no longer touch oneanother. Make sure there is sufficientclearance to the vehicle.

Tighten the attachment screw for thepedal bearing mount to its maximumpoint.

recesses using strap retainers.

Check the bicycle to make sure it issecure.

The settings for the wheel recesses

and on the rotary lever on the pedalcrank recess should be noted andsaved for each bicycle. Correctpresetting will facilitate refitting of thebicycle.

Removing a bicycle from the rearcarrier system

Undo strap retainers on both bicycletyres.

attachment screw for the pedalbearing mount, then lift the pedalbearing mount to remove it.

Retracting the rear carrier system

Push the pedal crank mounts into thepedal crank recess.

Storage 6

Press release lever and slide in wheelll h f h ill

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 62/203

Insert the strap retainer and pulltightly downwards as far as possible.

recesses all the way as far as they willgo.

Disengage the locking lever on thediagonal support and fold both pedalcrank recesses down.

9 Warning

Risk of pinching.

Swivel first the right clamping lever (1) forwards, followed by the leftclamping lever (2), until they can be

engaged in their respective recesses

62 Storage

Push the clamping lever down andll b th li ht t t f th

Load compartment

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 63/203

pull both light supports out of therecesses.

Fold in the bulb holders on the backsof the tail lights.

First place the front (1) tail light, thenthe rear (2) tail light in the recessesand push down as far as possible.Push cables all the way into all guidesin order to prevent damage.

Open the tailgate.

Push the release lever up and pushthe system into the bumper until itengages.

Release lever must return to originalposition.

9 Warning

If the system cannot be correctlyengaged, please seek theassistance of a workshop.

Folding down rear seat backrestsThe rear seat backrest is divided intotwo parts. Both parts can be folded

down.Remove the load compartment cover if necessary.

Press and hold the catch, then pushthe head restraints down.

Fold up the rear armrest.

Storage 6

Guide the seat belts through sidesupports to protect them against

Ensure that the seat belts of theoutboard seats are placed in the

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 64/203

supports to protect them againstdamage. When folding the backrests,pull the seat belts along with them.

Pull the release lever on one or bothsides and fold down the backrests

onto the seat cushion.

If the vehicle is to be loaded via a rear door, take the seat belt out of the seatbackrest guide and put it behind theretainer like shown in the illustration.

To fold up, raise the backrests andguide them into an upright positionuntil they engage audibly.

outboard seats are placed in thecorresponding belt guides.

The backrests are properly engagedwhen the red marks on both sidesnear the release lever are no longer visible.

9 Warning

Never drive the car if the backrestsare not securely locked intoposition, as this increases the riskof personal injury or damage to theload or car in the event of heavybraking or a collision.

Opening the pass-through in therear centre backrestFold down the rear armrest.

Pull the grip and open the cover.

Suitable for loading long, narrowobjects.

64 Storage

Ensure that the cover engages after folding up

Load compartment cover

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 65/203

folding up.

The closed cover can be securedfrom the side of the loadcompartment. Turn the knob 90°:

knobhorizontal

= cover secured fromthe side of thepassenger room

knobvertical

= cover not secured

Storage in the load compartment

Depending on the version, a storagecompartment is located under theload compartment cover.

Do not place any objects on the cover.

Removing

Unhook retaining straps from tailgate.

Lift cover at the rear and pull it fromthe side guides.

FittingEngage cover in side guides and folddownwards. Attach retaining straps totailgate.

Storage 6

Rear floor storage cover Height adjustable cover Lifting

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 66/203

The rear floor cover can be lifted and

hooked in with the strap.

Caution

Only use the hook for mountingthe rear floor cover and the heightadjustable cover.

The height adjustable cover can be

mounted in three positions:■ directly above the rear floor cover 

(1),

■ in a middle position (2)

■ or in an upper position (3).

Caution

Ensure that the front and rear end

of the height adjustable cover areattached to the same level.

To lift the cover to a higher level, pu

the strap backwards and lift the rearedge of the cover on thecorresponding supports.

66 Storage

Lowering Notice■ If mounted in position or the

Lashing eyes

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 67/203

To lower the cover, pull the strap

backwards and push down the frontcenter of the cover at the same time.

Caution

Do not lower the height adjustablecover to position 1 in vehiclesequipped with subwoofer. Thesubwoofer could be damaged.

■ If mounted in position 2 or 3, thespace between the rear floor cover and the height adjustablecover can be used as a stowagecompartment.

■ The height adjustable cover canbe lifted and hooked in with thestrap when it is mounted inposition 1 or 2.

■ If mounted in position 2, an almostcompletely flat load bay is createdif the rear seat backrests arefolded forwards.

■ The height adjustable cover is

able to withstand a load of no morethan 100 kg.

■ Opening the side covers (e.g.when exchanging the rear lightbulbs) is only possible with theheight adjustable cover mountedin position 1 or 2.

The lashing eyes are designed to

secure items against slippage, e.g.using lashing straps or luggage net.

Storage 6

Warning triangle First aid kit Roof rack system

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 68/203

Stow the warning triangle in the space

behind the strap on the right side of the load compartment.

Stow the first aid kit in the stowage

behind the warning triangle.Before first use push the interior trimoutwards at the perforated line to getaccess to the stowage.

Roof rack

For safety reasons and to avoiddamage to the roof, the vehicleapproved roof rack system isrecommended.

Follow the installation instructionsand remove the roof rack when not iuse.

Detach the cover from each mountin

point by using a coin.

68 Storage

Loading information ■ Secure loose objects in the loadcompartment to prevent them from

plate 3 186) and the EC kerbweight.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 69/203

■ Heavy objects in the loadcompartment should be placedagainst the seat backrests. Ensurethat the backrests are securelyengaged. If objects can be stacked,heavier objects should be placed atthe bottom.

■ Secure objects with lashing strapsattached to the lashing eyes 3 66. Attach the height adjustable cover in the lowest position (1) 3 65.

co pa t e t to p e e t t e osliding.

■ When transporting objects in theload compartment, the backrests of the rear seats must not be angled

forward.■ Do not allow the load to protrude

above the upper edge of thebackrests.

■ Do not place any objects on theload compartment cover or theinstrument panel, and do not cover the sensor on top of the instrumentpanel.

■ The load must not obstruct theoperation of the pedals, parkingbrake and gear selector lever, or hinder the freedom of movement of the driver. Do not place anyunsecured objects in the interior.

■ Do not drive with an open loadcompartment.

■ The payload is the differencebetween the permitted grossvehicle weight (see identification

weight.

To calculate the EC kerb weight,enter the data for your vehicle in theWeights table, in the introductionsection.

The EC kerb weight includesweights for the driver (68 kg),luggage (7 kg) and all fluids (tank90 % full).

Optional equipment andaccessories increase the kerbweight.

■ Driving with a roof load increasesthe sensitivity of the vehicle tocross-winds and has a detrimentaleffect on vehicle handling due tothe vehicle's higher centre of gravity. Distribute the load evenlyand secure it properly with retainingstraps. Adjust the tyre pressure andvehicle speed according to the loadconditions. Check and retighten thestraps frequently.

The permissible roof load is 75 kg.The roof load is the combinedweight of the roof rack and the load.

Instruments and controls 6

Instruments and Controls Steering wheel controls

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 70/203

controls

Controls ....................................... 69Warning lights, gauges andindicators ..................................... 76

Information displays ..................... 87

Vehicle messages ........................ 91

Trip computer ............................... 97

Vehicle personalisation ................ 99

Steering wheel adjustment

Unlock lever, adjust steering wheel,then engage lever and ensure it isfully locked.

Do not adjust steering wheel unlessvehicle is stationary and steeringwheel lock has been released.

The Infotainment system, the cruise

control and a connected mobilephone can be operated via thecontrols on the steering wheel.

Further information is available in thInfotainment system manual.

Cruise control 3 135.

70 Instruments and controls

Heated steering wheel Horn

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 71/203

 Activate heating by pressing *

button. Activation is indicated by theLED in the button.

The recommended grip areas of thesteering wheel are heated quicker and to a higher temperature than the

other areas.

Pressj.

Instruments and controls 7

Windscreen wiper/washer Adjustable wiper interval Automatic wiping with rain sensor

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 72/203

Windscreen wiper

2 = fast1 = slowP = timed interval wiping§ = off  

For a single wipe when thewindscreen wiper is off, press thelever down.

Do not use if the windscreen is frozen.

Switch off in car washes.

Wiper lever in position P.

Turn the adjuster wheel to adjust thedesired wipe interval:

shortinterval

= turn adjuster wheelupwards

longinterval

= turn adjuster wheeldownwards

P = automatic wiping with rain

sensor The rain sensor detects the amount owater on the windscreen andautomatically regulates the frequencof the windscreen wiper.

72 Instruments and controls

Adjustable sensitivity of the rainsensor

Windscreen and headlightwasher

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 73/203

Turn the adjuster wheel to adjust thesensitivity:

lowsensitivity

= turn adjuster wheeldownwards

highsensitivity

= turn adjuster wheelupwards

Keep the sensor free from dust, dirtand ice.

Pull lever. Washer fluid is sprayedonto the windscreen and the wiper wipes a few times.

If the headlights are on, washer fluidis also sprayed onto the headlights. Afterwards the headlight washer system is inoperative for 2 minutes.

Instruments and controls 7

Rear window wiper/washer Outside temperature

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 74/203

Push the rocker switch to activate the

rear window wiper:upper position

= continuousoperation

lower position

= intermittentoperation

middleposition

= off  

Push lever. Washer fluid is sprayedonto the rear window and the wiper wipes a few times.

The rear window wiper comes onautomatically when the windscreenwiper is switched on and reverse gear is engaged.

 Activation or deactivation of thisfunction can be changed in the menuSettings in the Info-Display.

Vehicle personalisation 3 99.

The rear window washer system isdeactivated when the fluid level islow.

 A drop in temperature is indicated

immediately and a rise in temperaturafter a time delay.

If outside temperature drops to 3 °Cthe symbol4 illuminates in the DriveInformation Center with Uplevel-Display or in the Info-Display asa warning for icy road conditions. 4remains illuminated untiltemperatures reach at least 5 °C.

74 Instruments and controls

Set date and timePress the CONFIG button. The menu

■ Set date format: Changesindication of date between MM/DD/

and

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 75/203

 Additionally a warning message isdisplayed in the Driver InformationCenter with Uplevel-Display.

9 Warning

The road surface may already beicy even though the displayindicates a few degrees above0 °C.

Clock

Date and time are shown in the Info-Display.

Settings is displayed.

Select Time & Date.

Selectable setting options:

■ Set time: Changes the time shownon the display.

■ Set date: Changes the date shownon the display.

■ Set time format: Changesindication of hours between 12hours and 24 hours.

YYYY and DD.MM.YYYY.

■ Display digital clock: Switches on/off indication of time on the display.

■ RDS clock synchronization: The

RDS signal of most VHFtransmitters automatically sets thetime. RDS time synchronisationcan take a few minutes. Sometransmitters do not send a correcttime signal. In such cases, it isrecommended to switch off automatic time synchronisation.

Vehicle personalisation 3 99.

Instruments and controls 7

Power outlets  A further 12 V power outlet is locatedin the rear console. Fold the cover downwards

Cigarette lighter

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 76/203

 A 12 V power outlet is located in thefront console.

downwards.

Do not exceed the maximum power consumption of 120 watts.

With ignition off the power outlets are

deactivated. Additionally the power outlets are deactivated in the event of low battery voltage.

Electrical accessories that areconnected must comply with theelectromagnetic compatibilityrequirements laid down in DIN VDE40 839.

Do not connect any current-deliveringaccessories, e.g. electrical chargingdevices or batteries.

Do not damage the outlet by usingunsuitable plugs.

The cigarette lighter is located in thefront console.

Press in cigarette lighter. Switches oautomatically once the element isglowing. Pull out lighter.

Ashtrays

Caution

To be used only for ash and not for combustible rubbish.

76 Instruments and controls

Warning lights, gaugesand indicators

Odometer

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 77/203

The portable ashtray can be placed inthe cupholders.

Speedometer

Indicates vehicle speed.

The bottom line displays the recordeddistance.

Trip odometer

The top line displays the recordeddistance since the last reset.

To reset, hold the reset knobdepressed for a few seconds with theignition on.

Instruments and controls 7

Tachometer Fuel gauge Engine coolant temperaturegauge

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 78/203

Displays the engine speed.

Drive in a low engine speed range for each gear as much as possible.

Caution

If the needle is in the red warningzone, the maximum permittedengine speed is exceeded. Engineat risk.

Displays the fuel level in the tank.

Control indicator i illuminates if thelevel in the tank is low. Refuelimmediately.

Never run the tank dry.

Because of the fuel remaining in thetank, the top-up quantity may be lessthan the specified tank capacity.

Displays the coolant temperature.left area = engine operating

temperature not yetreached

centralarea

= normal operatingtemperature

right area = temperature too high

78 Instruments and controls

CautionIn the Uplevel-Display the remainingoil life duration is displayed in the

.

Turn the adjuster wheel to select theoil life system.

For the system to work properly it

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 79/203

If engine coolant temperature istoo high, stop vehicle, switch off engine. Danger to engine. Checkcoolant level.

Service display

The engine oil life system lets youknow when to change the engine oiland filter. Based on drivingconditions, the interval at which anengine oil and filter change will beindicated can vary considerably.

Vehicle Information Menu.

In the Midlevel-Display the remainingengine oil duration is displayed by thecontrol indicator I, thereby the

ignition has to be switched on butengine not running.

The menu and function can beselected via the buttons on the turnsignal lever.

To display the remaining engine oilduration:

Press the MENU button to select theVehicle Information Menu.

For the system to work properly, itmust be reset every time the engineoil is changed. Seek the assistance of a workshop.

Press the SET/CLR button to resetwhile applying the brake pedal.Thereby the ignition has to beswitched on but engine not running.

When the system has calculated thatengine oil life has been diminished,Change Engine Oil Soon or a warningcode appears in the Driver Information Center. Have engine oil

and filter changed by a workshopwithin one week or 300 miles(whichever occurs first).

Driver Information Center 3 87.

Service information 3 183.

Control indicators

The control indicators described are

not present in all vehicles. Thedescription applies to all instrumentversions. When the ignition is

Instruments and controls 7

switched on, most control indicatorswill illuminate briefly as a functionalitytest.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 80/203

test

The control indicator colours mean:

red = danger, importantreminder 

yellow = warning, information, faultgreen = confirmation of activationblue = confirmation of activationwhite = confirmation of activation

80 Instruments and controls

Control indicators in the instrument cluster

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 81/203

Instruments and controls 8

Control indicators in the centreconsole

Bulb replacement 3 153, Fuses3 160.

Turn signals 3 109

Flashes

 After starting off when the seat belt iunfastened.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 82/203

Turn signalO illuminates or flashes green.

Illuminates brieflyThe parking lights are switched on.

Flashes A turn signal or the hazard warningflashers are activated.

Rapid flashing: failure of a turn signallight or associated fuse, failure of turnsignal light on trailer.

Turn signals 3 109.

Seat belt reminder

Seat belt reminder on front seatsX for driver's seat illuminates or flashes red.

k for front passenger seat illuminatesor flashes red, when seat is occupied.

Illuminates

 After the ignition has been switchedon until the seat belt has been

fastened.Flashes

 After having started the engine for a maximum of 100 seconds until theseat belt has been fastened.

Seat belt status on rear seatsX flashes or illuminates.

Illuminates

 After the ignition has been switchedon when the seat belt has beenfastened.

Fastening the seat belt 3 39.

Airbag and belt tensioners

v illuminates red.

When the ignition is switched on, thecontrol indicator illuminates for approx. 4 seconds. If it does notilluminate, does not go out after 4 seconds or illuminates whilstdriving, there is a fault in the airbagsystem. Seek the assistance of a workshop. The airbags and beltpretensioners may fail to trigger in thevent of an accident.

Deployment of the belt pretensioneror airbags is indicated by continuousillumination of v.

82 Instruments and controls

9 Warning

Have the cause of the fault

Charging system

p illuminates red.

Ill i t h th i iti i

Flashes when the engine isrunningFault that could lead to catalytic

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 83/203

Have the cause of the faultremedied immediately bya workshop.

Belt pretensioners, airbag system3 38, 3 41.

Airbag deactivation

V illuminates yellow.

The front passenger airbag isactivated.

* illuminates yellow.

The front passenger airbag isdeactivated 3 44.

9 Danger

Risk of fatal injury for a child usinga child restraint system together with activated front passenger airbag.

Risk of fatal injury for an adultperson with deactivated frontpassenger airbag.

Illuminates when the ignition isswitched on and goes out shortly after the engine starts.

Illuminates when the engine isrunningStop, switch off engine. Battery is notcharging. Engine cooling may beinterrupted. The brake servo unit maycease to be effective. Seek theassistance of a workshop.

Malfunction indicator light

Z illuminates or flashes yellow.

Illuminates when the ignition isswitched on and goes out shortly after the engine starts.

Illuminates when the engine isrunningFault in the emission control system.The permitted emission limits may be

exceeded. Seek the assistance of a workshop immediately.

Fault that could lead to catalyticconverter damage. Ease up on theaccelerator until the flashing stops.Seek the immediate assistance of 

a workshop.

Service vehicle soon

g illuminates yellow.

 Additionaly a warning message or a warning code is displayed.

The vehicle needs a service.

Seek the assistance of a workshop.

Vehicle messages 3 91.

Brake and clutch system

R illuminates red.

Illuminates when the manual parkingbrake is released if the brake andclutch fluid level is too low 3 151.

Instruments and controls 8

9 Warning

Stop Do not continue your

Electrical parking brake fault

j illuminates or flashes yellow.

 ABS. The brake system remainsoperational but without ABSregulation.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 84/203

Stop. Do not continue your  journey. Consult a workshop.

Illuminates after the ignition is

switched on if the manual parkingbrake is applied 3 131.

Electrical parking brake

m illuminates or flashes red.

IlluminatesElectrical parking brake is applied3 131.

FlashesElectrical parking brake is not fullyapplied or released. Switch onignition, press foot brake pedal andattempt to reset the system by firstreleasing and then applying theelectrical parking brake. If m remainsflashing, do not drive and seek the

assistance of a workshop.

IlluminatesElectrical parking brake is operatingwith degraded performance 3 131.

FlashesElectrical parking brake is in servicemode. Stop vehicle, apply andrelease the electrical parking brake toreset.

9 Warning

Have the cause of the fault

remedied immediately bya workshop.

Antilock brake system (ABS)

u illuminates yellow.

Illuminates for a few seconds after theignition is switched on. The system isready for operation when the control

indicator goes out.If the control indicator does not go outafter a few seconds, or if it illuminateswhile driving, there is a fault in the

 Antilock brake system 3 130.

Upshift

[ illuminates green.

Due to a high engine speed an upshiis recommended for economicalreasons.

Variable effort steering

c illuminates yellow.

Fault in variable effort steeringsystem. This may lead to a partial ocomplete failure of the steeringsupport. Consult a workshop.

Vehicles with engine A 20 DTH:

Failure in the electronic steeringsupport. This may lead to a higher steering effort at low vehicle speed.Consult a workshop.

Lane departure warning

) illuminates green or yellow or flashes yellow.

84 Instruments and controls

Illuminates greenSystem is switched on and ready tooperate.

Electronic Stability Control

b illuminates or flashes yellow.

Preheating

! illuminates yellow.

Preheating is activated Only

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 85/203

Illuminates yellowNo lane marking is detected.

Flashes yellowSystem recognizes an unintendentlane change.

Ultrasonic parking assist

r illuminates yellow.

Fault in system

or 

Fault due to sensors that are dirty or covered by ice or snow

or 

Interference due to external sourcesof ultrasound. Once the source of interference is removed, the systemwill operate normally.

Have the cause of the fault in the

system remedied by a workshop.Ultrasonic parking assist 3 137.

Illuminates A fault in the system is present.Continued driving is possible. Driving

stability, however, may deterioratedepending on road surfaceconditions.

Have the cause of the fault remediedby a workshop.

FlashesThe system is actively engaged.Engine output may be reduced andthe vehicle may be brakedautomatically to a small degree.

Electronic Stability Control off

n flashes yellow.

The system is deactivated.

Traction Control system off

kflashes yellow.

The system is deactivated.

Preheating is activated. Onlyactivates when outside temper atureis low.

Diesel particle filter

% illuminates or flashes yellow.

The diesel particle filter requirescleaning.

Continue driving until% goes off. If possible do not allow engine speed todrop below 2000 rpm.

IlluminatesThe diesel particle filter is full. Startcleaning process as soon aspossible.

FlashesThe maximum filling level of the filter is reached. Start cleaning processimmediately to avoid damage to theengine.

Diesel particle filter 3 124.

Instruments and controls 8

Tyre pressure monitoringsystem

w illuminates or flashes yellow

Illuminates when the engine isrunning

Check oil level before seekingassistance of a workshop 3 149.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 86/203

w illuminates or flashes yellow.

IlluminatesTyre pressure loss. Stop immediately

and check tyre pressure.

FlashesFault in system or tyre withoutpressure sensor mounted (e.g. sparewheel). After 60 - 90 seconds thecontrol indicator illuminatescontinuously. Consult a workshop.

Engine oil pressureI illuminates red.

Illuminates when the ignition isswitched on and goes out shortly after the engine starts.

Caution

Engine lubrication may be

interrupted. This may result indamage to the engine and/or locking of the drive wheels.

1. Depress clutch.

2. Select neutral gear, set selector lever to N.

3. Move out of the flow of traffic asquickly as possible without

impeding other vehicles.4. Switch off ignition.

9 Warning

When the engine is off,considerably more force is neededto brake and steer.

Do not remove key until vehicle is

stationary, otherwise the steeringwheel lock could engageunexpectedly.

Low fuel

i illuminates yellow.

Level in fuel tank is too low.

Catalytic converter 3 125.

Bleeding the diesel fuel system3 152.

Immobiliser

d flashes yellow.

Fault in the electronic immobiliser 

system. The engine cannot bestarted.

Reduced engine power

# illuminates yellow.

The engine power is limited. Consula workshop.

Apply footbrake- illuminates yellow.

86 Instruments and controls

Brake pedal needs to be depressedto release the electrical parking brake3 131.

Control indicator f flashes for approx.4 seconds after the ignition isswitched on as a reminder that thesystem has been activated 3 106

Rain sensor

< illuminates green.

The automatic rain sensor is

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 87/203

Exterior light

8 illuminates green.

The exterior lights are on 3 104.

l illuminates green.

The automatic light control isswitched on 3 104.

High beam

C illuminates blue.

Illuminated when high beam is on andduring headlight flash 3 105.

Adaptive forward lighting

f illuminates or flashes yellow.

IlluminatesFault in system.

Seek the assistance of a workshop.

FlashesSystem switched to symmetrical lowbeam.

system has been activated 3 106.

 Automatic light control 3 104.

Daytime running light@ illuminates green.

The daytime running light is on.

Fog light

> illuminates green.

The front fog lights are on 3 109.

Rear fog light

 r illuminates yellow.

The rear fog light is on 3 109.

Low washer fluid

G illuminates yellow.

The washer fluid level is low.

Washer fluid 3 151.

The automatic rain sensor isactivated 3 71.

Cruise controlm illuminates white or green.

Illuminates whiteThe system is on.

Illuminates green A certain speed is stored.

Cruise control 3 135.

Door open

h illuminates red.

 A door or the tailgate is open.

Instruments and controls 8

Information displays

Driver Information Center

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 88/203

The Driver Information Center (DIC)is located in the instrument cluster between speedometer andtachometer. It is available asMidlevel-Display or Uplevel-Display.

The following main menus,depending on the vehicleconfiguration, can be selected:

■ Vehicle Information Menu■ Trip/Fuel Information Menu

Some of the displayed functions differ between vehicle driving and standstilland some functions are only activewhen the vehicle is driving.

Vehicle personalisation 3 99.Memorised settings 3 19.

Selecting menus and functionsThe menus and functions can beselected via the buttons on the turnsignal lever.

Press the MENU button to switchbetween the menus or to return froma submenu to the next higher menulevel.

88 Instruments and controls

Turn the adjuster wheel to highlighta menu option or to set a numericvalue.

■ Battery Voltage: Display of batteryvoltage.

■ Speed Warning: If exceeding thepreset speed a arning chime ill

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 89/203

Press the SET/CLR button to selecta function or to confirm a message.

Vehicle Information MenuPress the MENU button to select theVehicle Information Menu.

Turn the adjuster wheel to select oneof the submenus. Press the SET/CLR button to confirm.

Follow the instructions given in thesubmenus.

Submenus can be:

■ Unit: Displayed units can bechanged.

■ Tire Pressure: 3 167.

■ Remaining Oil Life: 3 78

■ Coolant Temperature: Display of engine coolant temperature. 3 77

■ Relearn Remote Key: Relearn after battery replacement.

■ Compass: Display of compass incombination with navigationsystem.

preset speed a warning chime willbe activated.

■ Language: Displayed language can

be changed.Selection and indication can bedifferent between Midlevel- andUplevel-Display.

Trip/Fuel Information Menu

Trip/Fuel Information Menu, TripComputer 3 97.

Traffic sign assistant 3 94.

Instruments and controls 8

Tyre pressure monitoring system3 167.

Depending on the Infotainmentsystem, the Graphic-Info-Display isavailable in two versions.

Colour-Info-Display

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 90/203

Graphic-Info-Display, Colour-Info-Display

Depending on the vehicle

configuration the vehicle hasa Graphic- or Colour-Info-Display.The Info-Display is located in theinstrument panel above the faceplateof the Infotainment system.

Graphic-Info-Display

Graphic-Info-Display indicates:■ time 3 74

■ outside temperature 3 73

■ date 3 74

■ Infotainment system, seedescription for Infotainment system

■ settings for vehicle personalisation3 99

The Colour-Information-Displayindicates in colour:

■ time 3 74

■ outside temperature 3 73

■ date 3 74

■ Infotainment system, seedescription for Infotainment system

■ navigation, see description for Infotainment system

■ system settings

90 Instruments and controls

■ vehicle messages 3 91

■ settings for vehicle personalisation3 99

Th f i f i d h i i

Selecting with the Infotainmentsystem

Press (the outer ring)

■ To select or activate the markedoption

T fi t l

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 91/203

The type of information and how it isdisplayed depend on the equipmentof the vehicle and the settings made.

Selecting menus and settingsMenus and settings are accessed viathe display.

Selections are made via:

■ menus

■ function buttons and multifunctionknob of the Infotainment system

Select a function via the Infotainment

system buttons. The menu of theselected function is displayed.

The multifunction knob is used toselect an item and to confirm.

Multifunction knob

The multifunction knob is the centralcontrol element for the menus:

Turn

■ To mark a menu option■ To set a numeric value or to display

a menu option

■ To confirm a set value

■ To switch a system function on/off 

BACK button

Press button to:

■ exit a menu without changingsettings

■ return from a submenu to a higher menu level

■ delete a last character ina character sequence

Press and hold the button for a fewseconds to delete the entire entry.

Vehicle personalisation 3 99.

Memorised settings in the vehicle key3 19.

Instruments and controls 9

Vehicle messages

Messages are indicated mainly in theDriver Information Center (DIC) in

Vehicle messages on theMidlevel-Display

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 92/203

Driver Information Center (DIC), insome cases together with a warningand signal buzzer.

Press the SET/CLR button to confirma message.

Call up multiple messages one after another by pushing the MENU button.

The vehicle messages are displayed

as code numbers.

No. Vehicle message

1 Change engine oil

2 No radio remote controldetected, depress clutch pedalfor a restart

3 Engine coolant level low

4 Air conditioning off 

92 Instruments and controls

No. Vehicle message

5 Steering wheel is locked

6 Depress brake pedal to release

No. Vehicle message

20 Right low beam failure

21 Left front sidelight failure

No. Vehicle message

48 Clean side blind zone alertsystem

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 93/203

6 Depress brake pedal to releaseelectrical parking brake

7 Turn steering wheel, switchignition off and then on

8 Switch ignition off and then on,repeat breath test

9 Turn steering wheel, startengine again

11 Brake pads worn

12 Vehicle overloaded

13 Compressor overheated

15 Centre high-mounted brakelight failure

16 Service brake lights

17 Headlight levelling malfunction

18 Left low beam failure

19 Rear fog light failure

21 Left front sidelight failure

22 Right front sidelight failure

23 Reversing light failure

24 Number plate light failure

25 Left front turn signal failure

26 Left rear turn signal failure

27 Right front turn signal failure

28 Right rear turn signal failure

29 Check trailer brake light

30 Check trailer reversing light

31 Check left trailer turn signal

32 Check right trailer turn signal

33 Check trailer rear fog light

34 Check trailer rear light

35 Replace battery in radio remotecontrol

49 Lane departure warningunavailable

50 Activated pedestrian protectionsystem, reset bonnet

51 Compass unavailable

53 Tighten gas cap

54 Water in diesel fuel filter 

55 Diesel particle filter is full3 124

56 Tyre pressure imbalance onfront axle

57 Tyre pressure imbalance onrear axle

58 Tyres without TPMS sensorsdetected

59 Open and then close driver 

window

Instruments and controls 9

No. Vehicle message

60 Open and then close frontpassenger window

No. Vehicle message

78 Service pedestrian protectionsystem

Vehicle messages on theUplevel-Display

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 94/203

61 Open and then close rear leftwindow

62 Open and then close rear rightwindow

65 Theft attempted

66 Service theft alarm system

67 Service steering wheel lock

68 Service power steering

69 Service suspension system

70 Service level control system

71 Service rear axle

74 Service AFL

75 Service air conditioning

76 Service side blind zone alertsystem

77 Service lane departure warning

79 Top up engine oil

80 Change transmission fluid

81 Service transmission

82 Change engine oil soon

83 Service adaptive cruise control

84 Engine power is reduced

95 Service Airbag

The vehicle messages are displayed

as text. Follow the instructions givenin the messages.

The system displays messagesregarding the following topics:

■ Fluid levels

■ Anti-theft alarm system

■ Brakes

■ Drive systems

■ Ride control systems

■ Cruise control

94 Instruments and controls

■ Object detection systems

■ Lighting, bulb replacement

■ Wiper/washer system

■ D i d

Warning chimes

When starting the engine or whilstdriving

Traffic sign assistant

FunctionalityThe traffic sign assistant systemd d i d ffi i i

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 95/203

■ Doors, windows

■ Radio remote control

■ Seat belts■ Airbag systems

■ Engine and transmission

■ Tyre pressure

■ Diesel particle filter 

Vehicle messages on the Colour-Info-DisplaySome important messages appear 

additionally in the Colour-Info-Display. Press the multifunction knobto confirm a message. Somemessages are only popped up for a few seconds.

■ If seat belt is not fastened.

■ If a door or the tailgate is not fully

closed when starting off.■ If a certain speed is exceeded with

parking brake applied.

■ If a programmed speed isexceeded.

■ If a warning message or a warningcode appears in the Driver Information Center.

■ If the parking assist detects an

object.

When the vehicle is parked and/orthe driver's door is opened■ When the key is in the ignition lock.

■ With exterior lights on.

detects designated traffic signs viaa front camera and displays them inthe Driver Information Center.

Traffic signs, which will be detected,are

■ speed limit

■ no passing

■ end of speed limit

■ end of no passing

Speed limit signs are displayed in theDriver Information Center until thenext speed limit sign or end of speedlimit is detected.

Instruments and controls 9

The system is active at an indicatedspeed above 9 mph and is active upto a speed of 124 mph depending onthe lighting conditions. At night the

t i ti t d f 99

Traffic signs are displayed on thepage Traffic sign detection in the TripFuel Information Menu, chosen viathe adjuster wheel on the turn signal 3 87

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 96/203

No passing signs have priority abovespeed limits.

Combinations of both signs in the

display are possible.

system is active up to a speed of 99mph.

 As soon as the speed becomesslower than 22 mph the display will bereset and the content of the traffic signpage will be cleared. The nextrecognized speed indication will bedisplayed.

Display indication

lever 3 87.

When another function on the DriveInformation Center menu wasselected and then Traffic signdetection page is chosen again, thelast recognized traffic sign will bedisplayed.

If the system is deactivated, thecontent of the traffic sign page iscleared, indicated by the followingsymbol:

96 Instruments and controls

The content of the traffic sign page isalso cleared during driving by pushingthe SET/CLR button on the turn signallever.

Popup function FaultThe traffic sign assistant system maynot operate correctly when:

■ the area of the windscreen, where

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 97/203

Speed limits and no passing signs aredisplayed as popup on each page of the menu.

The popup function can be selectedby pushing the SET/CLR button on

the turn signal lever. Activation will beindicated by the icon in the display.

Popup indication is displayed for approx. 8 seconds in the Driver Information Center.

,the front camera is located, is notclean

■ traffic signs are completely or partially covered or badlydiscernible

■ there are adverse environmentalconditions like heavy rain, snow,direct sunlight or shadows. In thiscase No Traffic Sign Detection dueto Weather is indicated on thedisplay

■ traffic signs are incorrectly mountedor damaged

■ traffic signs do not comply with theVienna Convention on traffic signs

Instruments and controls 9

Caution

The system is intended to help thedriver within a defined speed

Trip computer

The menus and functions can beselected via the buttons on the turn

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 98/203

d e a de ed speedrange to discern certain trafficsigns. Do not ignore traffic signs

which are not displayed by thesystem.

The system does not discern anyother traffic signs that might giveor end a speed limit.

Do not let this special featuretempt you into taking risks whendriving.

 Adapt speed always to the road

conditions.

The driver assistance systems donot relieve the driver from fullresponsibility of vehicle operation.

signal lever.

Press the MENU button to select theTrip/Fuel Information Menu.

Turn the adjuster wheel to select onof the submenus:

■ Trip computer 1

■ Trip computer 2■ Range

■ Average consumption

■ Instantaneous consumption

■ Average speed

■ Digital speed

■ Traffic sign assistant

98 Instruments and controls

Average consumptionDisplay of average consumption. Themeasurement can be reset at anytime.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 99/203

The information of the two tripcomputers can be reset separately,making it possible to display different

trip distances.To reset, press the reset knob or press the SET/CLR button for a fewseconds.

RangeRange is calculated from current fueltank content and currentconsumption. The display showsaverage values.

 After refuelling, the range is updatedautomatically after a brief delay.

When the fuel level in the tank is low,a message appears in the Driver Information Center and in the Info-Display.

 Additionally the control indicator i in

the fuel gauge illuminates.

To reset, press the SET/CLR buttonfor a few seconds.

Instantaneous consumptionDisplay of the instantaneousconsumption.

Average speedDisplay of average speed. Themeasurement can be reset at anytime.

To reset, press the SET/CLR button

for a few seconds.

Digital speedDisplay of the instantaneous digitalspeed.

Traffic sign assistantIndicates detected traffic signs for a current route section 3 94.

Instruments and controls 9

Vehicle personalisation

The vehicle's behaviour can bepersonalised via changing the

tti i th I f Di l

Personal settings in the Graphic-Info-Display

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 100/203

settings in the Info-Display.

Some of the personal settings for 

different driver can be memorisedindividual for each vehicle key.Memorised settings 3 19

Depending on vehicle equipment andcountry-specific regulations some of the functions described below mightnot be available.

Some functions are are onlydisplayed or active when the engine

is running.

Press the CONFIG button. The menu

Settings is displayed.

The following settings can beselected by turning and pushing themultifunction knob:

■ Sport mode settings

■ Time Date

■ Radio settings

■ Phone settings

■ Vehicle settings

■ Restore factory settings

In the corresponding submenus thefollowing settings can be changed:

100 Instruments and controls

Sport mode settings

The driver can select the functionswhich will be activated in Sport mode3 134.

■ D i

Vehicle settings

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 101/203

■ Sport suspension: Dampingbecomes harder.

■ Sport powertrain performance: Accelerator pedal and gear changecharacteristics become moreresponsive.

■ Sport steering: Steering supportreduced.

■ Swap backlight colour main instr.:Change of instrument illuminationcolour.

■ Restore factory settings: Reset allfunctions to factory settings.

Time Date

See Clock 3 74.

Radio settings

See description for Infotainmentsystem.

Phone settingsSee description for Infotainmentsystem.

■ Climate and air quality

Auto fan speed: Modifies the fan

regulation.Climate control mode: Activate or deactivate cooling.

Auto heated seats: Activate or deactivate automatic seat heating.

Auto demist: Supports windscreendehumidification by forcing outsideair and auto air conditioning mode.

Auto rear demist: Automaticactivation of rear heated window.

■ Comfort settings

Chime volume: Change the volumeof warning chimes.

Personalization by driver: Activateor deactivate the personalisationfunction.

Rear auto wipe in reverse: Activateor deactivate automaticallyswitching on of the rear windowwiper when reverse gear isengaged.

■ Languages

Selection of the desired language.

Instruments and controls 10

■ Park assist / Collision detection

Park assist: Activate or deactivatethe ultrasonic parking assist .

■ Exterior ambient lighting

Personal settings in the Colour-Info-Display

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 102/203

Exterior lighting by unlocking: Activate or deactivate the welcome

lighting.Duration upon exit of vehicle: Activate or deactivate and changethe duration of exit lighting.

■ Remote locking, unlocking, starting

Remote unlock feedback: Activateor deactivate the hazard warningflasher feedback whilst unlocking.

Remote door unlock: Change theconfiguration to unlock only thedriver's door or the whole vehiclewhilst unlocking.

Auto relock doors: Activate or deactivate the automatic relockfunction after unlocking withoutopening the vehicle.

■ Restore factory settings

Restore factory settings: Reset allsettings to the default settings.

Press the CONFIG button. The menu

Settings is displayed.

The following settings can beselected by turning and pushing themultifunction knob:

■ Sport mode settings

■ Time & Date

■ Radio settings

■ Phone settings

■ Navigation settings

■ Vehicle settings

■ Display settings

■ Restore factory settings

In the corresponding submenus thefollowing settings can be changed:

102 Instruments and controls

Sport mode settings

The driver can select the functionswhich will be activated in Sport mode3 134.

■ : Damping

Navigation settings

See description for Infotainmentsystem.

Vehicle settings

Auto rear demist: Automaticactivation of rear heated window.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 103/203

■ Sport suspension: Dampingbecomes harder.

■ Sport powertrain performance: Accelerator pedal and gear changecharacteristics become moreresponsive.

■ Sport steering: Steering supportreduced.

■ Swap backlight colour main instr.:Change of instrument illuminationcolour.

■ Restore factory settings: Reset allfunctions to factory settings.

Time & Date

See Clock 3 74.

Radio settings

See description for Infotainmentsystem.

Phone settingsSee description for Infotainmentsystem.

■ Climate and air quality

Auto fan speed: Modifies the fanregulation.

Climate control mode: Activate or deactivate cooling.

Auto heated seats: Activate or deactivate automatic seat heating.

Auto demist: Supports windscreendehumidif ication by forcing outsideair and auto air conditioning mode.

■ Comfort settings

Chime volume: Change the volumeof warning chimes.

Rear auto wipe in reverse: Activateor deactivate automaticallyswitching on of the rear windowwiper when reverse gear isengaged.

■ Languages

Selection of the desired language.

■ Park assist / Collision detection

Park assist: Activate or deactivatethe ultrasonic parking assist .

Instruments and controls 10

■ Exterior ambient lighting

Exterior lighting by unlocking: Activate or deactivate the welcomelighting.

:

Display settings

Selectable display settings:

■ Day mode: Optimisation for daylight conditions.

■ O ti i ti f

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 104/203

Duration upon exit of vehicle: Activate or deactivate and changethe duration of exit lighting.

■ Lock / Unlock / Start

Remote unlock feedback: Activateor deactivate the hazard warningflasher feedback whilst unlocking.

Remote door unlock: Change theconfiguration to unlock only thedriver's door or the whole vehiclewhilst unlocking.

Auto relock doors: Activate or deactivate the automatic relockfunction after unlocking withoutopening the vehicle.

Personalization by remote control: Activate or deactivate thepersonalisation function.

■ Restore factory settings

Restore factory settings: Reset allsettings to the default settings.

■ Night mode: Optimisation for darkness.

■ Automatic mode: The displaychanges mode when the vehiclelights are switched on/off.

104 Lighting

Lighting

Exterior lighting .......................... 104

Exterior lighting

Light switch

In the Driver Information Center withUplevel-Display, the current status of the automatic light control isdisplayed.

When switching on ignition, automatic

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 105/203

te o g t g 0

Interior lighting ........................... 110

Lighting features ........................ 112

Turn light switch:AUTO = Automatic light control:

Headlights are switchedon and off automaticallydepending on externallight conditions.

0 = Activation or deactivationof the automatic lightcontrol. Switch turns back

to AUTO.8 = Sidelights9 = Headlights

When switching on ignition, automaticlight control is active.

Control indicator 8 3 86.

Tail lightsTail lights are shining together withheadlights and sidelights.

Automatic light control

Lighting 10

Automatic light control functionWhen the automatic light controlfunction is switched on, the systemswitches with running enginebetween daytime running light and

High beam Headlight range adjustment

Manual headlight rangeadjustment

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 106/203

y g gautomatic headlight in dependence of lighting conditions.

Daytime running light

Daytime running light increasesvisibility of the vehicle during daylight.

Tail lights are not on.

Automatic headlight activation

During poor light conditions theheadlights are switched on.

Tunnel detectionWhen a tunnel is entered theheadlights are switched on withoutdelay.

 Adaptive forward lighting 3 106.

To switch from low to high beam,push lever.

To switch to low beam, push lever again or pull.

Headlight flash

To activate the headlight flash, pulllever.

To adapt headlight range to thevehicle load to prevent dazzling: turknob to required position.

0 = front seats occupied1 = all seats occupied2 = all seats occupied and load

compartment laden3 = driver's seat occupied and load

compartment laden.Dynamic automatic headlightlevelling 3 104.

106 Lighting

Headlights when drivingabroad

The asymmetrical headlight beamextends visibility at the edge of theroad at the passenger side

Vehicles with Xenon headlightsystem

For deactivation operate the sameprocedure as described above. f willnot flash when function isdeactivated.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 107/203

road at the passenger side.

However, when driving in countries

where traffic drives on the oppositeside of the road, adjust the headlightsto prevent dazzling of oncomingtraffic.

Vehicles with halogen headlightsystemHave the headlights adjusted bya workshop.

 Adapting the distribution of the

headlight beam:1. Pull headlight flash lever.

2. Switch on ignition.

3. Hold headlight flash lever. After approx. 5 seconds the controlindicator f starts flashing and anacoustic signal sounds.

Control indicator f 3 86.

Every time the ignition is switched on,f flashes as a reminder for approx.4 seconds.

Adaptive forward lighting

The Adaptive forward lightingfunctions are only available with Bi-Xenon headlights. Light range, lightdistribution and intensity of light arevariably triggered depending on thelight conditions, weather and roadtype.

 All lighting functions are available inlight switch position AUTO. Thelighting functions

■ Dynamic curve lighting

■ Corner lighting

■ Reversing function

■ Dynamic automatic headlightlevelling

are also available in light switchposition9.

Lighting 10

Playstreet lighting Activated automatically at low speedup to approx. 20 mph. The light beamis turned at an angle of 8° to theroadside.

Adverse weather lighting Activated automatically up to a speedof approx. 43 mph, when the rainsensor recognizes condensation or the wiper operates continuously. The

di ib i d i i f

Corner lightingOn tight bends or when turning,depending on the steering angle or the turn signal light, an additional lefor right reflector is switched on whicill i h d h i h l

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 108/203

Town lighting

 Activated automatically at a speedrange between approx. 25 and34 mph and when street lights aredetected by the light sensor. The lightrange is reduced by an extended lightdistribution.

Country lighting Activated automatically at a speedrange between approx. 34 and

70 mph. The beam of light and thebrightness is different between leftand right side.

Motorway lighting Activated automatically at a speedabove approx. 70 mph and minimalsteering movements. It switches ondelayed or directly when vehicle ispowerfully accelerated. The lightbeam is longer and brighter.

range, distribution and intensity of light is regulated variably depending

on visibility.

Dynamic curve lighting

The light beam pivots based onsteering wheel angle and speed,improving lighting in curves.

Control indicator B 3 86.

illuminates the road at the right anglto the direction of travel. It is activate

up to a speed of 25 mph.Control indicator B 3 86.

Reversing functionIf the headlights are on and reversegear is engaged, both corner lightsare switched on. They remainilluminated for 20 seconds after disengaging reverse gear or driving

faster than 10 mph forward.High Beam AssistThis feature allows high beam asmain driving light by night and whenvehicle speed is faster than 25 mphIt switches to low beam when thecamera in the windscreen detects thlights of oncoming or precedingvehicles, in urban areas, if the vehicl

speed is slower than 12 mph, or if it

108 Lighting

foggy or snowy. If there are norestrictions detected, the systemswitches back to high beam.

The green control indicator lilluminates continuously when the

7

Dynamic automatic headlightlevellingTo prevent oncoming traffic fromdazzle, headlight levelling isautomatically adjusted based on

f

Hazard warning flashers

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 109/203

assist is activated, the blue one 7illuminates when high beam is on.

Control indicator l 3 86.

If a headlight flash is activated whenthe high beam is on, the high beamassist will be deactivated.

If a headlight flash is activated whenthe high beam is off, the high beamassist will stay activated.

The high beam assist is activated by

pushing the indicator lever twice.To deactivate push indicator lever once. It is also deactivated, whenfront or rear fog lights are switchedon.

The latest setting of the high beamassist will remain after the ignition isswitched on again.

inclination information measured byfront and rear axle, acceleration or 

deceleration and vehicle speed.

Fault in Adaptive forward lightingsystemWhen the system detects a failure inthe Adaptive forward lighting system,the system moves to a preset positionto avoid dazzling of oncoming traffic.If this is not possible the affected

headlight will be automaticallyswitched off. In any case oneheadlight will stay on. A warning isdisplayed in the Driver InformationCenter.

Operated with the¨ button.

In the event of an accident with airbag

deployment the hazard warningflashers are activated automatically.

Lighting 10

Turn and lane-change signals Move the lever to the resistance pointand hold for longer indication.

Switch the turn signal off manually bymoving the lever to its originalposition.

Rear fog lights

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 110/203

lever up = right turn signallever down = left turn signal

If the lever is moved past theresistance point, the turn signal isswitched on constantly. When thesteering wheel moves back, the turnsignal is automatically deactivated.

For three flashes, e.g. when changinglanes, press the lever until resistanceis felt and then release.

Having a trailer connected, turn signalflashes for six times when pressingthe lever until resistance and thenrelease.

Front fog lights

Operated with the> button.

Light switch in position Auto:switching on front fog lights will switchheadlights on automatically.

Operated with the r button.

Light switch in position Auto:

switching on rear fog light will switchheadlights on automatically.

Light switch in position8: rear foglight can only be switched on withfront fog lights.

The vehicle rear fog light isdeactivated when towing.

110 Lighting

Parking lights Reversing lights

The reversing light come on when theignition is on and reverse gear isselected.

Interior lighting

Instrument panel illuminationcontrol

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 111/203

When the vehicle is parked, theparking lights on one side can be

activated:1. Switch off ignition.

2. Move turn signal lever all the wayup (right parking lights) or down(left parking lights).

Confirmed by a signal and thecorresponding turn signal controlindicator.

Misted light covers

The inside of the light housing maymist up briefly in poor, wet and coldweather conditions, in heavy rain or after washing. The mist disappearsquickly by itself; to help switch on theheadlights.

Brightness of the following lights canbe adjusted when the exterior lightsare on:

■ Instrument panel illumination

■ Steering wheel controls

■ Info-Display

■ Infotainment system operation

elements■ Climate control operation elements

■ Illuminated switches

Lighting 11

Turn knobk and hold until the desiredbrightness is obtained.

Interior lights

During entry and exit of the vehicle,

Operate rocker switch:

w = automatic switching onand off.

pressu = on.pressv = off.

Reading lights

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 112/203

the front and rear courtesy lightsautomatically switch on and then off after a delay.

NoticeIn the event of an accident withairbag deployment the courtesylights are turned on automatically.

Front courtesy light

Rear courtesy lights

Illuminate in conjunction with the frontcourtesy light depending on rocker switch position.

Operated withs andt buttons infront and rear courtesy lights.

Sunvisor lights

Illuminates when the cover is opened

112 Lighting

Lighting features

Centre console lighting

Spotlight incorporated in the interior lighting comes on when headlights

it h d

The following lights will additionallyswitch on when the driver's door isopened:

■ All switches

■ Driver Information Center 

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 113/203

are switched on.

Entry lighting

Welcome lightingHeadlights, tail lights, reversing lights,number plate lights, instrument panellight, interior lights and puddle lightsare switched on for a short time byunlocking the vehicle with the radioremote control. This function

facilitates locating the vehicle when itis dark.

The lighting switches off immediatelywhen the ignition is turned to position1.

 Activation or deactivation of thisfunction can be changed in the menuSettings in the Info-Display. Vehiclepersonalisation 3 99.

The settings can be saved for the keybeing used 3 19.

■ Door pocket lights

Exit lighting

The following lights switch on if thekey is removed from the ignitionswitch:

■ Interior lights

■ Instrument panel light

■ Puddle lights

They will switch off automatically after a delay. Theatre lighting is activatedif the driver's door is opened duringthis time.

Headlights, tail lights, reversing lightsand number plate lights illuminate thesurrounding area for an adjustabletime after leaving the vehicle.

Switching on

1. Switch off ignition.

2. Remove ignition key.

3. Open driver's door.

4. Pull turn signal lever.

5. Close driver's door.

If the driver's door is not closed the

lights switch off after two minutes.

Lighting 11

Exit lighting is switched off immediately if the turn signal lever ispulled while the driver's door is open.

 Activation, deactivation and durationof this function can be changed in themenu in the Info-Display

In the second stage a message whichconfirms the activation of the batterydischarge protection will be displayedin the Driver Information Center.

Switching off electric lights

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 114/203

menu Settings in the Info Display.Vehicle personalisation 3 99.

The settings can be saved for the keybeing used 3 19.

Battery discharge protection

Battery state of charge functionThe function guarantees longestbattery life via a generator withcontrollable power output and

optimised power distribution.To prevent discharge of the batterywhen driving, following systems arereduced automatically in two stagesand finally switched off:

■ Auxiliary heater 

■ Heated rear window and mirrors

■ Heated seats

■ Fan

To prevent discharge of the batterywhen the ignition is switched off,some interior lights are switched off automatically after some time.

114 Climate control

Climate control

Climate control systems ............. 114

Air vents 119

Climate control systems

Heating and ventilation system

Heating will not be fully effective untilthe engine has reached normaloperating temperature.

Air distribution s = to windscreen and front door 

i d

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 115/203

 Air vents ..................................... 119

Maintenance .............................. 120

Controls for:■ Temperature

■ Air distribution

■ Fan speed

■ Demisting and defrosting

Heated rear windowÜ 3 30.

Temperature

red = warmblue = cold

windowsM = to head area via adjustable air 

ventsK = to foot well

Intermediate settings are possible.

Fan speed Adjust the air flow by switching the fanto the desired speed.

Demisting and defrosting

■ Press buttonV: fan automaticallyswitches to higher speed, the air distribution is directed towards thewindscreen.

■ Set temperature control to warmestlevel.

■ Switch on heated rear windowÜ.

■ Open side air vents as required and

direct them towards the door windows.

Climate control 11

Air conditioning system The air conditioning system cools anddehumidifies (dries) when outsidetemperature is a little above thefreezing point. Thereforecondensation may form and drip fromunder the vehicle.

■ Coolingn on.

■ Air circulation system4 on.

■ Press air distribution switch M.

■ Set temperature control to coldestlevel.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 116/203

 Additional to the heating andventilation system, the air 

conditioning system has:n = cooling4 = air recirculation

Heated seats ß 3 37, Heatedsteering wheel * 3 70.

CoolingnOperated with then button and isfunctional only when the engine and

fan are running.

If no cooling or drying is required,

switch the cooling system off to savefuel.

Air recirculation system 4Operated with the4 button.

9 Warning

The exchange of fresh air isreduced in air recirculation mode.In operation without cooling the air humidity increases, so thewindows may mist up. The qualityof the passenger compartment air deteriorates, which may cause thevehicle occupants to feel drowsy.

Maximum coolingBriefly open the windows so that hot

air can disperse quickly.

■ Set fan speed to highest level.

■ Open all vents.

116 Climate control

Demisting and defrosting thewindowsV

Electronic climate controlsystem

The dual zone climate control allowsdifferent climatisation temperaturesfor driver and front passenger side.

t = automatic air recirculationV = demisting and defrosting

Heated rear windowÜ 3 30.

The preselected temperature isautomatically regulated. In the

t ti d th f d d i

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 117/203

■ Press buttonV: fan automatically

switches to higher speed, the air distribution is directed towards thewindscreen,

■ Switch coolingn on.

■ Set temperature control to warmestlevel.

■ Switch on heated rear windowÜ.

■ Open side air vents as required anddirect them towards the door windows.

Controls for:

■ Temperature on driver side

■ Air distribution

■ Fan speed

■ Temperature on front passenger side

AUTO = automatic modeu  = manual air recirculation

automatic mode the fan speed and air 

distribution automatically regulate theair flow.

The system can be manually adaptedvia the use of air distribution and air flow controls.

Each change of settings is shown in

the Info-Display for a few seconds.

Climate control 11

The electronic climate control systemis only fully operational when theengine is running.

For correct operation do not cover thesensor on the instrument panel .

Basic setting for maximum comfort:

■ Press AUTO button, the air conditioning is activatedautomatically.

■ Open all air vents.

■ Set the preselected temperatures

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 118/203

Automatic mode AUTO ■ Set the preselected temperaturesfor driver and front passenger usingthe left and right rotary knob to22 °C.

The fan speed regulation in automaticmode can be changed in the menuSettings.

Vehicle personalisation 3 99.

 All air vents are actuatedautomatically in automatic mode. The

air vents should therefore always beopen.

Temperature preselectionTemperatures can be set to thedesired value.

If the minimum temperature is set, thclimate control system runs atmaximum cooling.

If the maximum temperature is set,

the climate control system runs atmaximum heating.

Demisting and defrosting thewindowsV■ Press buttonV.

■ Press cooling buttonn.

■ Temperature and air distributionare set automatically and the fan

runs at high speed.

118 Climate control

■ Switch on heated rear windowÜ.

■ To return to automatic mode: pressbuttonV or AUTO.

Manual settingsClimate control system settings canb h d b ti ti th b tt

Pressing the lower button longer, fanand cooling are switched off.

Pressing the upper button longer, thefan runs with maximum speed.

To return to automatic mode: Pressbutton.

The air conditioning system cools anddehumidifies (dries) when outsidetemperature is above a specific level.Therefore condensation may formand drip from under the vehicle.

If no cooling or drying is required,

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 119/203

be changed by activating the buttons

and rotary knobs as follows.Changing a setting will deactivate theautomatic mode.

Press lower button x for decreasingfan speed or upper button x for increasing. The fan speed is indicated

by the number of segments in thedisplay.

AUTO button.

Air distributionPress  s, M or K for desiredadjustment. Activation is indicated bythe LED in the button.

 s = to windscreen and front door windows.

M = to head area via adjustable air vents

K = to foot well.

Combinations are possible.

Return to automatic air distribution:Press button AUTO.

Cooling Activate or deactivate with the nbutton.

switch the cooling system off to save

fuel.

Air recirculation mode

9 Warning

The exchange of fresh air isreduced in air recirculation mode.In operation without cooling the air humidity increases, so the

windows may mist up. The qualityof the passenger compartment air deteriorates, which may cause thevehicle occupants to feel drowsy.

Climate control 11

Basic settingsSome settings can be changed in themenu Settings in the Info-Display.Vehicle personalisation 3 99.

Auxiliary heater

Air vents

Adjustable air vents

 At least one air vent must be openwhile the cooling is on.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 120/203

Automatic air recirculation tThe automatic air recirculationsystem has an air quality sensor which can switch automatically to

recirculation. Activation is indicated by the LED inthe button.

Switch to manual air recirculation asnecessary.

Manual air recirculation u Press button once to activate themanual air recirculation mode.

 Activation is indicated by the LED inthe button.

Air heaterQuickheat is an electric auxiliary air heater which warms up thepassenger compartment morequickly.

To open the vent, turn the adjuster wheel towards the bigger W symbol.

120 Climate control

9 Warning

Do not attach any objects to theslats of the air vents. Risk of damage and injury in case of anaccident.

Maintenance

Air intake

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 121/203

Direct the flow of air by tilting andswivelling the slats.

To close the vent, turn the adjuster wheel towards the smaller W symbol.

Comfort mode ;Using the comfort mode the air flow isdistributed smoothly in diversedirections. The air vents are fixed andcannot be adjusted manually.

Turn the adjuster wheel toposition ;.

Fixed air vents Additional air vents are locatedbeneath the windscreen and door windows and in the foot wells.

The air intake in front of thewindscreen in the enginecompartment must be kept clear toallow air intake. Remove any leaves,dirt or snow.

Pollen filter

The pollen filter cleans dust, soot,pollen and spores from the air 

entering the vehicle through the air intake.

Climate control 12

Air conditioning regularoperation

In order to ensure continuouslyefficient performance, cooling mustbe operated for a few minutes oncea month, irrespective of the weather 

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 122/203

pand time of year. Operation with

cooling is not possible when theoutside temperature is too low.

Service

For optimal cooling performance, it isrecommended to annually check theclimate control system, starting threeyears after initial vehicle registration,including:

■ Functionality and pressure test

■ Heating functionality

■ Leakage check

■ Check of drive belts

■ Cleaning of condenser andevaporator drainage

■ Performance check

122 Driving and operating

Driving andoperating

Driving hints ............................... 122

Driving hints

Control of the vehicle

Never coast with engine notrunningMany systems will not function in this

Starting and operating

New vehicle running-in

Do not brake unnecessarily hard for the first few journeys.

During the first drive, smoke may

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 123/203

g

Starting and operating ............... 122Engine exhaust .......................... 124

 Automatic transmission .............. 126

Manual transmission .................. 129

Brakes ........................................ 130

Ride control systems ................. 132

Cruise control ............................. 135

Object detection systems ........... 137

Fuel ............................................ 140

Towing ....................................... 142

Many systems will not function in this

situation (e.g. brake servo unit, power steering). Driving in this manner isa danger to yourself and others.

PedalsTo ensure the pedal travel isuninhibited, there must be no mats inthe area of the pedals.

g , yoccur because of wax and oilevaporating off the exhaust system.Park the vehicle in the open for a while after the first drive and avoidinhaling the fumes.

Fuel and engine oil consumption maybe higher during the running-inperiod.

Driving and operating 12

Ignition switch positions Starting the engine Before restarting or to switch off theengine, turn the key back to 0.

Automatic Starter ControlThis function controls the engine staprocedure. The driver does not haveto hold the key in position 3. Once

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 124/203

0 = Ignition off 1 = Steering wheel lock released,

ignition off 2 = Ignition on, for diesel engine:preheating

3 = Starting

Manual transmission: operate clutch.

 Automatic transmission: operate

brake and move the selector lever toP or N.

Do not accelerate.

Diesel engine: turn the key to position2 for preheating until controlindicator ! goes out.

Turn the key briefly to position 3 andrelease: an automatic procedureoperates the starter with a short delay

as long as the engine is running, see Automatic Starter Control.

applied, the system will go on startin

automatically until the engine isrunning. Because of the checkingprocedure, the engine starts runningafter a short delay.

Reasons for engine not starting canbe:

■ Clutch pedal not operated (manuatransmission).

■ Brake pedal not operated or selector lever not in P or N(automatic transmission).

■ Timeout occurred.

Overrun cut-off

The fuel supply is automatically cut oduring overrun, i.e. when the vehicleis driven with a gear engaged but

accelerator is released.

124 Driving and operating

Parking

■ Do not park the vehicle on an easilyignitable surface. The hightemperature of the exhaust systemcould ignite the surface.

■ Always apply parking brake.

■ Lock the vehicle and activate theanti-theft alarm system.

NoticeIn the event of an accident withairbag deployment the engine isturned off automatically, if thevehicle is coming to a stillstand

Engine exhaust

9 Danger

Engine exhaust gases containpoisonous carbon monoxide,

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 125/203

Manual parking brake without

pressing release button. Apply asfirmly as possible on downhill or uphill slopes. Depress the footbrake at the same time to reduceoperating force.

■ Switch off the engine and ignition.Turn the steering wheel until thesteering wheel lock engages.

■ If the vehicle is on a level surface or uphill slope, engage first gear or setthe selector lever to P beforeswitching off the ignition. On anuphill slope, turn the front wheelsaway from the kerb.

If the vehicle is on a downhill slope,engage reverse gear or set theselector lever to P before switchingoff the ignition. Turn the front

wheels towards the kerb.

vehicle is coming to a stillstand

within a certain time.

poisonous carbon monoxide,

which is colourless and odourlessand could be fatal if inhaled.

If exhaust gases enter the interior of the vehicle, open the windows.Have the cause of the faultrectified by a workshop.

 Avoid driving with an open loadcompartment, otherwise exhaustgases could enter the vehicle.

Diesel particle filter

The diesel particle filter system filtersharmful soot particles out of theexhaust gases. The system includesa self-cleaning function that runsautomatically during driving withoutany notification. The filter is cleanedby periodically burning off the soot

particles at high temperature. Thisprocess takes place automaticallyunder set driving conditions and may

Driving and operating 12

take up to 25 minutes. Typically itneeds between 7 and 12 minutes.Fuel consumption may be higher during this period. The emission of smells and smoke during this processis normal.

Is Full. See Owner's Manual or warning code 55 appears in the Driver Information Center.

% illuminates when diesel particlefilter is full. Start cleaning process assoon as possible.

% flashes when diesel particle filter

Cleaning takes place quickest at higengine speeds and loads.

The control indicator % extinguisheas soon as the self-cleaningoperation is complete.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 126/203

Under certain driving conditions, e.g.short distances, the system cannotclean itself automatically.

If the cleaning of the filter is requiredand if previous driving conditions didnot enable automatic cleaning, it willbe indicated by the control indicator 

%. Simultaneously Particulate Filter

% flashes when diesel particle filter 

has reached the maximum fillinglevel. Start cleaning processimmediately to avoid damage to theengine.

Cleaning processTo activate cleaning process,continue driving, keep engine speedabove 2000 revolutions per minute.Shift down if necessary. Dieselparticle filter cleaning is then started.

If g illuminates additionally,cleaning is not possible, seek theassistance of a workshop.

Caution

If the cleaning process isinterrupted, there is a risk of provoking severe engine damage.

Catalytic converter

The catalytic converter reduces theamount of harmful substances in theexhaust gases.

Caution

Fuel grades other than those listedon pages 3 140, 3 188 coulddamage the catalytic converter or 

electronic components.Unburnt petrol will overheat anddamage the catalytic converter.Therefore avoid excessive use of the starter, running the fuel tankdry and starting the engine bypushing or towing.

In the event of misfiring, uneven

engine running, a reduction in enginperformance or other unusualproblems, have the cause of the fau

126 Driving and operating

rectified by a workshop as soon aspossible. In an emergency, drivingcan be continued for a short period,keeping vehicle speed and enginespeed low.

Automatic transmission

The automatic transmission permitsautomatic gearshifting (automaticmode) or manual gearshifting(manual mode).

Selector lever

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 127/203

Transmission display

The mode or selected gear is shownin the transmission display.

P = park position, wheels arelocked, engage only when thevehicle is stationary and the

parking brake is appliedR = reverse gear, engage only

when the vehicle is stationaryN = neutralD = automatic mode with all gears

The selector lever is locked in P andcan only be moved when the ignitionis on and the brake pedal is applied.

Driving and operating 12

Do not accelerate while engaginga gear. Never depress the accelerator pedal and brake pedal at the sametime.

When a gear is engaged, the vehicleslowly begins to creep when thebrake is released.

Manual mode

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 128/203

Without applied brake pedal thecontrol indicator j illuminates.

If the selector lever is not in P whenthe ignition is switched off, the control

indicator j and P flash.To engage P or R, push the releasebutton.

The engine can only be started withthe lever in position P or N. Whenposition N is selected, press the brakepedal or apply the parking brakebefore starting.

Engine brakingTo utilise the engine braking effect,select a lower gear in good time whendriving downhill, see manual mode.

Rocking the vehicleRocking the vehicle is onlypermissible if the vehicle is stuck insand, mud or snow. Move the selector 

lever between D and R in a repeatpattern. Do not race the engine andavoid sudden acceleration.

Parking Apply the parking brake and engageP.

The ignition key can only be removedwhen the selector lever is in positionP.

Move selector lever out of position Dtowards the left and then forwards obackwards.

 < = Shift to a higher gear.

] = Shift to a lower gear.

If a higher gear is selected whenvehicle speed is too low, or a lower gear when vehicle speed is too highthe shift is not executed. This cancause a message in the Driver-Info-Display.

128 Driving and operating

In manual mode no automatic shiftingto a higher gear takes place at highengine revolutions.

Electronic driving programmes

■ Following a cold start, the operatingtemperature programme increases

Fault

In the event of a fault,g illuminates. Additionally a code number or a vehicle message is displayed in theDriver Information Center. Vehiclemessages 3 91.

The transmission no longer shifts

1. Apply the parking brake.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 129/203

temperature programme increases

engine speed to quickly bring thecatalytic converter to the requiredtemperature.

■ The automatic neutral shift functionautomatically shifts to idling whenthe vehicle is stopped witha forward gear engaged and thebrake pedal is pressed.

■ When Sport mode is engaged, the

vehicle shifts at higher enginespeeds (unless cruise control ison). Sport mode 3 134.

■ Special programmes automaticallyadapt the shifting points whendriving up inclines or down hills.

KickdownIf the accelerator pedal In automatic

mode is pressed down completely,the transmission shifts to a lower gear depending on engine speed.

The transmission no longer shifts

automatically. Continued travel ispossible with manual shifting.

Only the highest gear is available.Depending on the fault, 2nd gear mayalso be available in manual mode.Shift only when vehicle is in standstill.

Have the cause of the fault remediedby a workshop.

Interruption of power supply

In the event of an interruption of power supply, the selector lever cannot be moved out of the Pposition. The ignition key cannot beremoved from the ignition lock.

If the battery is discharged, start thevehicle using jump leads 3 177.

If the battery is not the cause of thefault, release the selector lever.

2. Release the selector lever trimfrom the centre console at thefront, fold it upwards and rotate it

to the left.

Driving and operating 12

Manual transmission Caution

It is inadvisable to drive with handresting on the selector lever.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 130/203

3. Insert a screwdriver into theopening as far as it will go andmove the selector lever out of P or N. If P or N is engaged again, the

selector lever will be locked inposition again. Have the cause of the power supply interruptionremedied by a workshop.

4. Mount the selector lever trim ontothe centre console and refit.

To engage reverse, with the vehiclestationary pull up the button on the

selector lever and engage the gear.If the gear does not engage, set thelever in neutral, release the clutchpedal and depress again; then repeatgear selection.

Do not grind the clutch unnecessarily.

When operating, depress the clutchpedal completely. Do not use the

pedal as a foot rest.

130 Driving and operating

Brakes

The brake system comprises twoindependent brake circuits.

If a brake circuit fails, the vehicle canstill be braked using the other br akecircuit. However, braking effect is

 ABS starts to regulate brake pressureas soon as a wheel shows a tendencyto lock. The vehicle remainssteerable, even during hard braking.

 ABS control is made apparentthrough a pulse in the brake pedaland the noise of the regulation

Fault

9 Warning

If there is a fault in the ABS, thewheels may be liable to lock dueto br aking that is heavier than

l Th d t f ABS

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 131/203

circuit. However, braking effect is

achieved only when the brake pedalis depressed firmly. Considerablymore force is needed for this. Thebraking distance is extended. Seekthe assistance of a workshop beforecontinuing your journey.

When the engine is not running, thesupport of the brake servo unitdisappears once the brake pedal has

been depressed once or twice.Braking effect is not reduced, butbraking requires significantly greater force. It is especially important to bear this in mind when being towed.

Control indicator R 3 82.

Antilock brake system

 Antilock brake system (ABS)prevents the wheels from locking.

process.For optimum braking, keep the brakepedal fully depressed throughout thebraking process, despite the fact thatthe pedal is pulsating. Do not reducethe pressure on the pedal.

Control indicator u 3 83.

Adaptive brake light

During full braking, all three brakelights flash for the duration of ABScontrol.

normal. The advantages of ABSare no longer available. Duringhard braking, the vehicle can nolonger be steered and mayswerve.

Have the cause of the fault remediedby a workshop.

Driving and operating 13

Parking brake

Manual parking brake

Electrical parking brake Before leaving the vehicle, check thelectrical parking brake status.

Control indicator m 3 82.

Releasing

Switch on ignition. Keep foot brakepedal depressed and then pushswitchm

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 132/203

 Always apply parking brake firmly

without operating the release button,and apply as firmly as possible ona downhill or uphill slope.

To release the parking brake, pull thelever up slightly, press the releasebutton and fully lower the lever.

To reduce the operating forces of theparking brake, depress the foot brakeat the same time.

Control indicator R 3 82.

Applying when vehicle is stationary

Pull switchm, the electrical parkingbrake operates automatically with an

adequate force. For maximum force,e.g. parking with trailer or on inclines,pull switchm twice.

The electrical parking brake canalways be activated, even if theignition is off.

Do not operate electrical parkingbrake system too often withoutengine running because this willdischarge the battery.

switchm.

Drive away function

Depressing clutch pedal (manualtransmission) or engaging drive gea(automatic transmission) and thendepressing the accelerator pedalreleases the electrical parking brakeautomatically. This is not possiblewhen the switch is pulled.

This function also helps driving awaon inclines.

 Aggressive drive away may reducelife time of wear parts.

Dynamic braking when vehicle ismoving

When the vehicle is moving and theswitchm is kept pulled, the electricaparking brake system will deceleratethe vehicle, but will not applystatically.

132 Driving and operating

 As soon as the switchm is released,dynamic braking will be stopped.

Fault

Failure mode of electrical parkingbrake is indicated by a controlindicator j and by a code number or a vehicle message which is displayed

Brake assist

If the brake pedal is depressedquickly and forcefully, maximumbrake force is automatically applied(full braking).

Maintain steady pressure on thebrake pedal for as long as full braking

Ride control systems

Traction Control system

Traction Control system (TC)improves driving stability whennecessary, regardless of the type of road surface or tyre grip, by

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 133/203

g p y

in the Driver Information Center.Vehicle messages 3 91.

 Apply electrical parking brake: pulland hold the switchm for more than5 seconds. If control indicator milluminates, electrical parking brake isapplied.

Release electrical parking brake:push and hold the switchm for more

than 2 seconds. If control indicator m goes out, electrical parking brakeis released.

Control indicator m flashes: electricalparking brake is not fully applied or released. When continuouslyflashing, release electrical parkingbrake and retry applying.

p g g

is required. Maximum brake force isautomatically reduced when thebrake pedal is released.

Hill start assist

The system helps driving away oninclines at a constant speed byholding the vehicle. After the parkingbrake is disengaged and the foot

brake pedal is released, the brakesare released after a 2 second delay.

preventing the drive wheels fromspinning.

 As soon as the drive wheels starts tospin, engine output is reduced andthe wheel spinning the most is brakedindividually. This considerablyimproves the driving stability of thevehicle on slippery road surfaces.

TC is operational as soon as the

control indicator b extinguishes.When TC is active b flashes.

Driving and operating 13

9 Warning

Do not let this special safetyfeature tempt you into taking riskswhen driving.

 Adapt speed to the roadconditions.

TC is reactivated by pressing the bbutton again.

TC is also reactivated the next timethe ignition is switched on.

Electronic Stability Control

Electronic Stability Control (ESC)

9 Warning

Do not let this special safetyfeature tempt you into taking riskswhen driving.

 Adapt speed to the roadconditions.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 134/203

conditions.

Control indicator b 3 84.

Deactivation

TC can be switched off when spinningof drive wheels is required: press

button b shortly.

Control indicator k illuminates.

Electronic Stability Control (ESC)

improves driving stability whennecessary, regardless of the type of road surface or tyre grip. It alsoprevents the drive wheels fromspinning.

 As soon as the vehicle starts toswerve (understeer/oversteer),engine output is reduced and thewheels are braked individually. This

considerably improves the drivingstability of the vehicle on slippery roadsurfaces.

ESC is operational as soon as thecontrol indicator b extinguishes.

When ESC is active b flashes.

conditions.

Control indicator b 3 84.

Deactivation

For very high-performance drivingESC can be deactivated: hold button

b depressed for approx. 7 seconds.

Control indicator n illuminates.

134 Driving and operating

ESC is reactivated by pressing theb button again. If the TC system waspreviously disabled, both TC andESC are reactivated.

ESC is also reactivated the next timethe ignition is switched on.

In each driving mode Flex Ridenetworks the following electronicsystems:

■ Continuous Damping Control.

■ Accelerator Pedal Control.

■ Steering Control.

■ Automatic transmission

SPORT mode

The settings of the systems areadapted to a sportier driving style:

■ Damping of shock absorbers reactsstiffer to provide better contact withthe road surface.

■ The engine reacts more quickly to

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 135/203

Interactive driving systemFlex RideFlex Ride driving system allows thedriver to select between three drivingmodes:

■ SPORT mode: press buttonSPORT, LED illuminates.

■ TOUR mode: press button TOUR,

LED illuminates.■ Normal mode: both buttons

SPORT and TOUR are notpressed, no LED illuminates.

Deactivate SPORT mode and TOURmode by pressing correspondingbutton once more.

■ Automatic transmission.the accelerator pedal.

■ Steering support is reduced.

■ Shift points of automatictransmission occur later.

■ Having SPORT mode activated,the illumination of main instrumentschanges from white to red.

TOUR mode

The settings of the systems areadapted to a comfort driving style:

■ Damping of shock absorbers reactssofter.

■ Accelerator pedal reacts withstandard settings.

■ Steering support is in standardmode.

Driving and operating 13

■ Shift points of automatictransmission occur in a comfortmode.

■ Illumination of main instruments iswhite.

Normal mode

 All settings of the systems are

into sporty settings. The DMCchanges to Sport mode in case of very sporty driving behaviour.

If, for example, TOUR mode isselected and whilst driving ona winding road a sudden hard brakeis necessary, DMC will detect thedynamic vehicle condition and

Cruise control

The cruise control can store andmaintain speeds of approx. 20 to120 mph. Deviations from the storedspeeds may occur when driving uphior downhill.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 136/203

g y

adapted to standard values.

Drive mode controlWithin each manual selected drivingmode SPORT, TOUR or Normal, theDrive Mode Control (DMC) detectsand analyses continously the realdriving characteristic, responses bythe driver, and the active dynamicstate of the vehicle. If necessary thecontrol unit of DMC automaticallychanges the settings within theselected driving mode or whenrecognising greater variations, thedriving mode is changed for thelength of variation.

If, for example, Normal mode isselected and DMC detects a sportydriving behaviour, DMC changesseveral settings of the Normal mode

dynamic vehicle condition andchanges the settings for suspensionto SPORT mode to increase vehiclestability.

When the driving characteristic or thedynamic vehicle state returns toformer state, DMC will change thesettings to the preselected drivingmode.

Personalised settings in the SportmodeThe driver can select the functions of the SPORT mode when SPORTbutton is pushed. These settings canbe changed in the menu Settings inthe Info-Display. Vehiclepersonalisation 3 99

For safety reasons the cruise controcannot be activated until the footbrake has been operated once.

Do not use the cruise control if it is noadvisable to maintain a constantspeed.

136 Driving and operating

With automatic transmission, onlyactivate cruise control in automaticmode.

Control indicator m 3 86.

ActivationPress rocker switch m down, controlindicator m illuminates white.

 Alternatively accelerate to the desiredspeed and store by turning to RES/+.

Reduce speedWith cruise control active, hold thumbwheel turned to SET/- or briefly turnto SET/- repeatedly: speeddecreases continuously or in small

Deleting the stored speedThe stored speed will be deleted bypressing buttony or switching off ignition.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 137/203

 Accelerate to the desired speed andturn thumb wheel to RES/+ or SET/-,the current speed is stored andmaintained. Control indicator milluminates green. Accelerator pedalcan be released.

Vehicle speed can be increased bydepressing the accelerator pedal.When the accelerator pedal is

released, the previously stored speedis resumed.

The speed cannot be increased byturning the thumb wheel to RES/+while first gear is selected.

Increase speedWith cruise control active, hold thumbwheel turned to RES/+ or briefly turn

to RES/+ repeatedly: speedincreases continuously or in smallincrements.

increments.

DeactivationPress rocker switch m up, controlindicator m goes out. Cruise control isdeactivated.

 Automatic deactivation:

■ vehicle speed below approx.20 mph,

■ the brake pedal is depressed,

■ the clutch pedal is depressed,

■ selector lever in N,

■ the Traction Control system or Electronic Stability Control isoperating.

Resume stored speedTurn thumb wheel to RES/+ ata speed above 20 mph. The storedspeed will be obtained.

Driving and operating 13

Object detection systems

Parking assist

park assist the system consists of four additional ultrasonic parking sensorsin the front bumper.

Control indicator r 3 84.

Activation

 An obstacle is indicated by a buzzinsound. The interval between thesounds becomes shorter as thevehicle gets closer to the obstacle.When the distance is less than 1 ft,the buzzing is continuous.

Deactivation

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 138/203

The parking assist makes parkingeasier by measuring the distancebetween the vehicle and obstacles,and giving acoustic signals. It is thedriver, however, who bears fullresponsibility for the parkingmanoeuvre.

The system consists of four ultrasonicparking sensors in the rear bumper. If 

the vehicle is equipped with a front

When reverse gear is engaged, thesystem is activated automatically.

The front parking assist can also beactivated at a low speed by pressingther button.

 An illuminated LED in the parkingassist button indicates that the

system is ready to operate.

Deactivate the system by pressingther button.

The LED in the button will go out anPark Assist Off will be displayed in thDriver Information Center.

The system is deactivatedautomatically at a certain speed.

Fault

In the event of a fault in the system,r illuminates and a message isdisplayed in the Driver InformationCenter.

 Additionally,r illuminates or a vehicle message is displayed in thDriver Information Center if a malfunction of the system due totemporary conditions like snow

covered sensors is detected.Vehicle messages 3 91.

138 Driving and operating

Important hints for using theparking assist systems

9 Warning

Under certain circumstances,various reflective surfaces onobjects or clothing as well as

Caution

Performance of the sensor can bereduced when sensors arecovered, e.g. by ice or snow.

Performance of the parking assistsystems can be reduced by a level

NoticeThe parking assist systemautomatically detects factory-fittedtowing equipment. It is deactivatedwhen the connector is plugged in.

Sensor could detect a nonexistingobject (echo disturbance) caused byexternal acoustical or mechanic

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 139/203

j gexternal noise sources may causethe system to fail to detectobstacles.

Special attention has to be paid tolow obstacles which can damagethe lower part of the bumper. If such obstacles leave the detectionarea of the sensors duringapproach of the vehicle,

a continuous warning tone willsound.

change of the sensors due toheavy loading.

Special conditions apply if thereare taller vehicles involved (e.g.off-road vehicles, mini vans,vans). Object identification in theupper part of the vehicle cannot beguaranteed.

Objects with a very small reflection

cross section, like objects of narrow size or soft materials, maynot be detected by the system.

Parking assist systems are noteffective in assisting drivers inavoiding a collision withunexpected objects.

disturbances.

Lane departure warning

The lane departure warning systemobserves the lane markings in whichthe vehicle is driving via a frontcamera. The system is detecting lanechanges and warns the driver in theevent of an unintended lane change

by visual and acoustic signals.Criteria for the detection of anunintended lane change are

■ no operation of turn signals

■ no brake pedal operation

■ no active accelerator operation or speeding-up

■ no active steering

If the driver is active, no warning willbe issued.

Driving and operating 13

Activation When the system recognizes anunintended lane change, the controlindicator ) changes to yellow andflashes. Simultaneously a chimesound is activated.

FaultThe lane departure warning systemmay not operate correct when:

■ the windscreen is not clean

■ there are adverse environmentalconditions like heavy rain, snow,direct sunlight or shadows

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 140/203

The lane departure warning system isactivated by pressing the ) button.The illuminated LED in the button

indicates that the system is switchedon. When the control indicator ) inthe instrument cluster illuminatesgreen, the system is ready to operate.

The system is only operatable atvehicle speeds above 37 mph and if lane markings are available.

DeactivationThe system is deactivated bypushing ) button. Deactivation isindicated by a message in the Driver Information Center.

It is also not ready to operate atspeeds below 37 mph.

■ no lane marking can be detected

If lane departure warning systemdetects one of this conditions, controindicator ) illuminates yellow.

140 Driving and operating

Fuel

Fuel for petrol engines

Only use unleaded fuel that complieswith DIN EN 228.

Equivalent standardised fuels with anethanol content of max. 10 % by

a biodiesel (= FAME according toEN14214) content of max. 7% byvolume (like DIN 51628 or equivalentstandards) may be used.

Do not use marine diesel oils, heatingoils or entirely or partially plant-baseddiesel fuels, such as rape seed oil or bio diesel, Aquazole and similar 

Refuelling

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 141/203

volume may be used. In this case onlyuse fuel that complies withDIN 51625.

Use fuel with the recommendedoctane rating 3 188. Use of fuel withtoo low an octane r ating can reduceengine power and torque and slightlyincreases fuel consumption.

Caution

Use of fuel with too low an octanerating could lead to uncontrolledcombustion and engine damage.

Fuel for diesel engines

Only use diesel fuel that complieswith DIN EN 590. The fuel must have

low sulphur content (max. 10 ppm).Equivalent standardised fuels with

diesel-water emulsions. Diesel fuelsmust not be diluted with fuels for petrol engines.

The flow and filterability of diesel fuelare temperature-dependent. Whentemperatures are low, refuel withdiesel fuel with guaranteed winter properties.

9 Danger

Before refuelling, switch off engineand any external heater s withcombustion chambers. Switch off any mobile phones.

Follow the operating and safetyinstructions of the filling stationwhen refuelling.

Driving and operating 14

9 Danger

Fuel is flammable and explosive.No smoking. No naked flames or sparks.

If you can smell fuel in your vehicle, have the cause of this

Fuel consumption - CO2-

Emissions

The determination of fuelconsumption is regulated byEuropean directive715/2007 692/2008 A.

The directive is oriented to actual

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 142/203

remedied immediately bya workshop.

Fuel filler flap is located at right rear side of vehicle.

The fuel filler flap can only be opened

if the vehicle is unlocked. Release thefuel filler flap by pushing the flap.

The fuel filler cap can be retained inthe bracket on the fuel filler flap.

Caution

Wipe off any overflowing fuelimmediately.

Fuel filler capOnly a genuine fuel filler cap providesfull functionality. Diesel-enginedvehicles have special fuel filler caps.

driving practices: Urban driving israted at approx. 1/3 and extra urban

driving with approx. 2/3. Cold starts

and acceleration phases are alsotaken into consideration.

The specification of CO2 emission is

also a constituent of the directive.

The figures given must not be taken

as a guarantee for the actual fuelconsumption of a particular vehicle.Furthermore, fuel consumption isdependent on personal driving styleas well as road and traffic conditions

 All values are based on the EU basemodel with standard equipment.

The calculation of fuel consumptiontakes into account the vehicle's kerb

weight, ascertained in accordance

142 Driving and operating

with the regulations. Optionalequipment may result in slightlyhigher fuel consumption and CO2

emission levels and a lower maximumspeed.

Fuel consumption, CO2 emissions

3 190.

Towing

General information

Only use towing equipment that hasbeen approved for your vehicle.Entrust retrofitting of towingequipment to a workshop. It may be

t k h th t

For trailers with low driving stabilityand trailers with a permitted grossvehicle weight of more than 1300 kgthe use of a stabiliser is stronglyrecommended when driving above50 mph.

If the trailer starts snaking, drive moreslowly, do not attempt to correct the

t i d b k h l if

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 143/203

necessary to make changes thataffect the cooling system, heatshields or other equipment.

Fitting of towing equipment couldcover the opening of the towing eye.If this is the case use the coupling ballbar for towing. Always keep thecoupling ball bar in the vehicle.

Installation dimensions of factory-

fitted towing equipment 3 196.

Driving characteristics andtowing tips

Before attaching a trailer, lubricatethe coupling ball. However, do not doso if a stabiliser, which acts on thecoupling ball, is being used to reducesnaking movements.

steering and brake sharply if necessary.

When driving downhill, drive in thesame gear as if driving uphill anddrive at a similar speed.

 Adjust tyre pressure to the valuespecified for full load 3 194.

Trailer towingTrailer loadsThe permissible trailer loads arevehicle and engine-dependentmaximum values which must not beexceeded. The actual trailer load isthe difference between the actualgross weight of the trailer and theactual coupling socket load with the

trailer coupled.

Driving and operating 14

The permissible trailer loads arespecified in the vehicle documents. Ingeneral, they are valid for gradientsup to max. 12 %.

The permitted trailer load applies upto the specified incline and up to analtitude of 3300 ft above sea level.Since engine power decreases as

ltit d i d t th i

The maximum permissible verticalcoupling load is specified on thetowing equipment identification plateand in the vehicle documents1). Always aim for the maximum load,especially in the case of heavytrailers. The vertical coupling loadshould never fall below 25 kg.

Stowage of coupling ball bar

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 144/203

altitude increases due to the air becoming thinner, therefore reducingclimbing ability, the permissible grosstrain weight also decreases by 10 %for every 3300 ft of additional altitude.The gross train weight does not haveto be reduced when driving on roadswith slight inclines (less than 8 %, e.g.motorways).

The permissible gross train weightmust not be exceeded. This weight isspecified on the identification plate3 186.

Vertical coupling loadThe vertical coupling load is the loadexerted by the trailer on the couplingball. It can be varied by changing theweight distribution when loading thetrailer.

Rear axle loadWhen the trailer is coupled and thetowing vehicle fully loaded, thepermissible rear axle load (seeidentification plate or vehicledocuments) may be exceeded by60 kg, the gross vehicle weight ratingmay be exceeded by 60 kg. If thepermissible rear axle load isexceeded, a maximum speed of 60 mph applies.

Towing equipment

Caution

When operating without a trailer,remove the coupling ball bar.

The bag with the coupling ball bar isstowed in the rear stowagecompartment on the floor.

Stick the strap through the lashingeye and tighten the strap to securethe bag.

1) Value was not available at time of printing.

144 Driving and operating

Fitting the coupling ball bar Checking the tensioning of thecoupling ball bar

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 145/203

Disengage and fold down the socket.Remove the sealing plug from theopening for the coupling ball bar and

stow it.

■ Red marking on rotary knob mustpoint towards green marking on

coupling ball bar.■ The gap between the rotary knob

and the coupling ball bar must beapprox. 6 mm.

■ The key must be in position c.Otherwise, the coupling ball bar mustbe tensioned before being inserted:

■ Unlock coupling ball bar by turningkey to position c.

■ Pull out rotary knob and turnclockwise as far as it will go.

Inserting the coupling ball bar

Driving and operating 14

Insert the tensioned coupling ball bar in the opening and push firmlyupwards until it audibly engages.

The rotary handle snaps back into itsoriginal position resting against thecoupling ball bar without a gap.

9 Warning

 Attach breakaway stopping cable toeye.

Check that the coupling ball bar iscorrectly installed

■ Green marking on rotary knob mustpoint towards green marking oncoupling ball bar.

■ There must be no gap between the

Dismounting the coupling ball ba

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 146/203

Do not touch rotary handle duringinsertion.

Lock the coupling ball bar by turningthe key to position e. Remove the keyand close the protective flap.

Eye for break-away stopping cable

■ There must be no gap between therotary handle and the coupling ballbar.

■ The coupling ball bar must be firmlyengaged in the opening.

■ The coupling ball bar must belocked and the key removed.

9 Warning

Towing a trailer is permitted onlywhen a coupling ball bar is fittedcorrectly. If the coupling ball bar does not engage correctly, seekthe assistance of a workshop.

Open the protective flap and turn thekey to position c to unlock thecoupling ball bar.

Pull out rotary handle and turnclockwise as far as it will go. Pull oucoupling ball bar downwards.

Insert sealing plug in opening. Foldaway socket.

Insert cover in bumper: Insert guideof cover into bumper, first in the fronand then in the rear and engage.Compress cover in a slightly bent

position while doing so.

146 Driving and operating

Trailer stability assist

If the system detects snakingmovements, engine power is reducedand the vehicle/trailer combination isselectively braked until the snakingceases. While system is working keepsteering wheel as still as possible.

Trailer stability assist (TSA) is

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 147/203

Trailer stability assist (TSA) isa function of the Electronic StabilityControl 3 133.

Vehicle care 14

Vehicle care

General Information ................... 147

Vehicle checks ........................... 148

Bulb replacement ....................... 153

Electrical system 160

General Information

Accessories and vehiclemodifications

We recommend to use genuine partsand accessories and factoryapproved parts specific for your 

vehicle type We cannot assess ort li bilit f th d t

■ Drain the washer fluid reservoir.

■ Check the coolant antifreeze andcorrosion protection.

■ Adjust tyre pressure to the valuespecified for full load.

■ Park the vehicle in a dry, wellventilated place. Engage first or 

reverse gear or set selector lever t

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 148/203

Electrical system ........................ 160Vehicle tools .............................. 166

Wheels and tyres ....................... 166

Jump starting ............................. 177

Towing ....................................... 179

 Appearance care ....................... 181

vehicle type. We cannot assess or guarantee reliability of other products- even if they have a regulatory or otherwise granted approval.

Do not make any modifications to theelectrical system, e.g. changes of electronic control units (chip tuning).

Vehicle storage

Storage for a long period of timeIf the vehicle is to be stored for severalmonths:

■ Wash and wax the vehicle.

■ Have the wax in the enginecompartment and underbodychecked.

■ Clean and preserve the rubber 

seals.

■ Change the engine oil.

reverse gear or set selector lever tP. Prevent the vehicle from rolling

■ Do not apply the parking brake.

■ Open the bonnet, close all doorsand lock the vehicle.

■ Disconnect the clamp from thenegative terminal of the vehiclebattery. Beware that all systems arnot functional, e.g. anti-theft alarm

system.

Putting back into operationWhen the vehicle is to be put back intoperation:

■ Connect the clamp to the negativeterminal of the vehicle battery. Activate the electronics of thepower windows.

■ Check tyre pressure.

■ Fill up the washer fluid reservoir.

148 Vehicle care

■ Check the engine oil level.

■ Check the coolant level.

■ Fit the number plate if necessary.

End-of-life vehicle recovery

Information on end-of-life vehiclerecovery centres and the recycling of 

end-of-life vehicles is available on our

Vehicle checks

Performing work

9 Danger

The ignition system and Xenonheadlights use extremely highvoltage. Do not touch.

Bonnet

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 149/203

end-of-life vehicles is available on our website. Only entrust this work to anauthorised recycling centre.

9Warning

Only perform engine compartmentchecks when the ignition is off.

The cooling fan may startoperating even if the ignition is off.

Opening

Pull the release lever and return it toits original position.

Vehicle care 14

ClosingBefore closing the bonnet, press thesupport rod into the holder.

Lower the bonnet and allow it to dropinto the catch. Check that the bonnetis engaged.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 150/203

Push the safety catch to the right andopen the bonnet.

Secure the bonnet support rod.

Engine oilThe engine oil level is checkedautomatically, Vehicle messages3 91. However, check the engine oillevel manually on a regular basis toprevent damage to the engine.

Check with the vehicle on a levelsurface. The engine must be atoperating temperature and switched

off for at least 5 minutes.Pull out the dipstick, wipe it clean,insert it to the stop on the handle, pullout and read the engine oil level.

Insert dipstick to the stop on thehandle and make half a turn.

Different dipsticks are useddepending on engine variant.

150 Vehicle care

When the engine oil level hasdropped to the MIN mark, top upengine oil.

Fit the cap on straight and tighten it.

Engine coolant

The coolant provides freezeprotection down to approx. -28 °C.

Caution

Only use approved antifreeze

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 151/203

We recommend the use of the samegrade of engine oil that was used atlast change.

The engine oil level must not exceedthe MAX mark on the dipstick.

Caution

Overfilled engine oil must bedrained or suctioned out.

Capacities 3 193.

Only use approved antifreeze.

Coolant level

Caution

Too low a coolant level can causeengine damage.

If the cooling system is cold, thecoolant level should be above thefilling line mark. Top up if the level islow.

9 Warning

 Allow the engine to cool beforeopening the cap. Carefully openthe cap, relieving the pressureslowly.

To top up use a 1:1 mixture of released coolant concentrate mixed

with clean tap water. If no coolantconcentrate is available, use cleantap water. Install the cap tightly. Have

Vehicle care 15

the coolant concentration checkedand have the cause of the coolantloss remedied by a workshop.

Washer fluid

a vehicle message is displayed in theDriver Information Center. Vehiclemessages 3 91.

Continued driving is possible buthave the brake lining replaced assoon as possible.

Once new brake linings are installed,do not brake unnecessarily hard for the first few journeys.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 152/203

Fill with clean water mixed witha suitable quantity of windscreenwasher fluid which containsantifreeze.

Brakes

In the event of minimum thickness of the brake lining,g illuminates.

 Additionally a code number or 

the first few journeys.

Brake fluid

9 Warning

Brake fluid is poisonous andcorrosive. Avoid contact with eyes,skin, fabrics and painted surfaces.

The brake fluid level must be betweethe MIN and the MAX marks.

When topping up, ensure maximumcleanliness as contamination of thebrake fluid can lead to brake system

malfunctions. Have the cause of theloss of brake fluid remedied bya workshop.

Only use high-performance brakefluid approved for the vehicle, Brakeand clutch fluid 3 184.

Battery

The vehicle battery is maintenance-free.

152 Vehicle care

Batteries do not belong in householdwaste. They must be disposed of atan appropriate recycling collectionpoint.

Laying up the vehicle for more than4 weeks can lead to batterydischarge. Disconnect the clamp fromthe negative terminal of the vehicle

battery.

Wiper blade replacement

Wiper blades on the windscreen

Wiper blade on the rear window

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 153/203

yEnsure the ignition is switched off befor e connecting or disconnectingthe vehicle battery.

The anti-theft alarm siren must bedeactivated as follows: Switch theignition on then off, disconnect thevehicle's battery within 15 seconds.

Battery discharge protection 3 113.

Diesel fuel system bleeding

If the tank has been run dry, the dieselfuel system must be bled. Switch onthe ignition three times for 15 secondsat a time. Then start the engine for a maximum of 40 seconds. Repeatthis process after no less than

5 seconds. If the engine fails to start,seek the assistance of a workshop.

Lift the wiper arm, press button todisengage the wiper blade andremove.

Lift wiper arm. Disengage wiper bladeas shown in illustration and remove.

Vehicle care 15

Bulb replacement

Switch off the ignition and switch off the relevant switch or close the doors.

Only hold a new bulb at the base! Donot touch the bulb glass with barehands.

Use only the same bulb type for replacement

Headlights have separate systems for low beam 1 (outer bulbs) and highbeam 2 (inner bulbs).

Low beam

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 154/203

y ypreplacement.

Replace headlight bulbs from withinthe engine compartment.

Halogen headlights

1. Rotate the cap 1 anti-clockwiseand remove it.

2. Rotate the bulb holder anti-clockwise to disengage. Withdrawthe bulb holder from the reflector

154 Vehicle care

3. Detach the bulb from the bulbholder and replace the bulb.

4. Insert the bulb holder, engagingthe two lugs into the reflector androtate clockwise to secure.

5. Rotate the bulb carrier clockwiseas far as it will go.

6. Fit the cap and rotate clockwise.

3. Detach the bulb from the bulbholder and replace the bulb.

4. Insert the bulb holder, engagingthe two lugs into the reflector androtate clockwise to secure.

5. Rotate the bulb carrier clockwiseas far as it will go.

6. Fit the cap and rotate clockwise.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 155/203

pHigh beam

1. Rotate the cap 2 anti-clockwiseand remove it.

2. Rotate the bulb holder anti-

clockwise to disengage. Withdrawthe bulb holder from the reflector.

pSidelights/Daytime running light

1. Rotate the cap anti-clockwise andremove it. Use the screwdriver torotate the cap.

2. Press latches and withdraw thebulb holder from the reflector.

Vehicle care 15

3. Remove the bulb from the socketand replace the bulb.

4. Insert the bulb holder into thereflector. Fit the cap and rotateclockwise.

Front turn signal

3. Disengage the bulb holder fromthe plug connector by pressingthe retaining lug.

4. Remove and replace the bulbholder with bulb.

5. Attach the plug connector.

6. Insert the bulb holder into the

reflector.7 Svivel the spring clip forwards an

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 156/203

The bulbs are accessible from thebeneath the vehicle.

1. Disengage the spring clip andthen swivel it backwards.

2. Pull the bulb holder with bulb outof the reflector.

7. Svivel the spring clip forwards anengage.

Xenon headlights

9 Danger

Xenon headlights work under 

extremely high electrical voltage.Do not touch. Have bulbs replacedby a workshop.

156 Vehicle care

Fog lights 1. Turn the bulb holder anti-clockwise and remove it from thereflector.

Tail lights

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 157/203

The bulbs are accessible frombeneath the vehicle. 2. Disengage the bulb holder from

the plug connector by pressing

the retaining lug.3. Remove and replace the bulb

holder with bulb.

4. Attach the plug connector.

5. Insert the bulb holder into thereflector.

6. Turn the bulb holder anti-clockwise and engage.

1. Release the cover and remove it.

Vehicle care 15

2. Unscrew the plastic securing nutfrom the inside by hand.

7. Remove and replace the bulb.

Tail lights (1)

Brake light (2)

Turn signal light (3)

8. Insert the bulb holder into the tailight assembly and screw intoplace. Connect the wiring plug

and press the cable into theretainer. Install the tail light

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 158/203

3. Remove the tail light assembly.Make sure that the cable ductremains in position.

4. Detach the cable from theretainer.

5. Detach the wiring plug from thebulb holder.

6. Unscrew the three screws witha coin and remove the bulbholder.

retainer. Install the tail lightassembly in the body and tightenthe securing nut. Close the coveand engage.

9. Switch on the ignition, operateand check all lights.

158 Vehicle care

Tail lights in the tailgate frame 5. To replace the tail light (1),remove and replace the bulb

To replace the rear fog light (2),push the bulb slightly into thesocket, rotate anti-clockwise,remove and replace the bulb.

6. Insert the bulb holder into the taillight assembly. Install the tail light

assembly in the tailgate andtighten the screws Attach the

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 159/203

1. Open the tailgate and remove thethree covers.

2. Unscrew the three screws and

remove.3. Remove the tail light assembly.

Make sure that the cable ductremains in position.

4. Press the retaining lug andremove the bulb holder from thetail light assembly.

tighten the screws. Attach thethree covers.

7. Switch on the ignition, operateand check all lights.

For replacing the tail light bulb andreverse light bulb on the right side of the tailgate frame, proceed in thesame way.

Side turn signal lights

Have bulbs replaced by a workshop.

Vehicle care 15

Number plate light Load compartment lightHave bulbs replaced by a workshop

Instrument panel illumination

Have bulbs replaced by a workshop

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 160/203

1. Insert screwdriver in recess of thecover, press to the side andrelease spring.

2. Remove the bulb holder downwards, taking care not to pullon the cable.

3. Disengage the retaining lug andremove the bulb holder from thewiring plug.

4. Remove and replace the bulbholder with bulb.

5. Connect the wiring plug to thebulb holder.

6. Push the bulb holder into thehousing and close the cover.

Interior lights

Courtesy light, reading lightsHave bulbs replaced by a workshop.

160 Vehicle care

Electrical system

Fuses

Data on the replacement fuse mustmatch the data on the defective fuse.

There are three fuse boxes in thevehicle:

■ in the front left of the enginecompartment,

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 161/203

■ in the interior behind the storagecompartment, or, in right-handdrive vehicles, behind theglovebox,

■ behind a cover on the left side of theload compartment.

Before replacing a fuse, turn off the

respective switch and the ignition.

 A blown fuse can be recognized by itsmelted wire. Do not replace the fuseuntil the cause of the fault has beenremedied.

Some functions are protected byseveral fuses.

Fuses may also be inserted without

existence of a function.

Fuse extractor A fuse extractor may be located in thefuse box in the engine compartment.

Vehicle care 16

Engine compartment fuse box

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 162/203

Place the fuse extractor on thevarious types of fuse from the top or side, and withdraw fuse. The fuse box is in the front left of the

engine compartment.

Disengage the cover, lift it upwards

and remove.

162 Vehicle care

No. Circuit

1 Engine control module

2 Lambda probe

3 Fuel injection, ignition system

4 Fuel injection, ignition system

5  – 

Mirror heating

No. Circuit

17 Transmission control module

18 Heated rear window

19 Front power windows

20 Rear power windows

21  ABS

Left high beam (Halogen)

No. Circuit

34  – 

35 Power windows

36  – 

37 Canister vent solenoid

38 Vacuum pump

Fuel system control module

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 163/203

6 Mirror heating

7 Fan control

8 Lambda probe, engine

9 Rear window sensor 

10 Battery sensor 

11 Trunk release

12  Adaptive forward lightingmodule

13  – 

14 Rear window wiper 

15 Engine control module

16 Starter 

22 Left high beam (Halogen)

23 Headlamp washer system

24 Right low beam (Xenon)

25 Left low beam (Xenon)

26 Fog lights

27 Diesel fuel heating

28  – 

29 Electrical parking brake

30  ABS

31  – 

32  Airbag

33  Adaptive forward lighting

39 Fuel system control module

40 Windscreen washer, Rear window washer system

41 Right high beam (Halogen)

42 Radiator fan

43 Windscreen wiper 

44  – 

45 Radiator fan

46  – 

47 Horn

48 Radiator fan

49 Fuel pump

Vehicle care 16

No. Circuit

50 Headlamp levelling

51  Air shutter 

52 Blow by heater 

53 Transmission control module,Engine control module

54 Wiring monitoring

Instrument panel fuse box

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 164/203

 After having changed defective fusesclose the fuse box cover and engageit by pressing.

If the fuse box cover is not closedcorrectly, malfunction may occur.

The fuse box is behind the storage

compartment in the instrument panel.Open the compartment and push it tothe left to unlock. Fold thecompartment down and remove it.

In right-hand drive vehicles, the fusebox is located behind a cover in theglovebox. Open the glovebox, thenopen the cover and fold it down.

164 Vehicle care

No. Circuit

10 Door locks

11 Interior fan

12  – 

13  – 

14 Diagnostic connector Airbag

No. Circuit

25  – 

26  – 

Load compartment fuse box

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 165/203

No. Circuit

1 Displays

2 Exterior lights

3 Exterior lights

4 Radio

5 Infotainment system

6 Power outlet front

7 Power outlet rear seat

8 Left low beam

9 Right low beam

15  Airbag

16  – 

17  Air conditioning system

18  – 

19 Stop lights, back-up lights,interior lights

20  – 

21 Instrument

22 Ignition switch

23 Body control unit

24 Body control unit

The fuse box is on the left side of theload compartment behind a cover.Remove the cover.

Vehicle care 16

No. Circuit

1 Trailer module

2 Trailer outlet

3 Parking assist

4  – 

5  – –

No. Circuit

18  – 

19 Steering wheel heating

20 Sunroof 

21 Seat heating

22  – –

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 166/203

6    

7  – 

8  Anti-theft alarm system

9  – 

10  – 

11 Trailer module, Trailer socket

12  – 

13 Trailer outlet

14  – 

15  – 

16  – 

17  – 

23    

24  – 

25  – 

26  – 

27  – 

28  – 

29  – 

30  – 

31  Amplifier, Subwoofer 

32  Active damping system, Lanedeparture warning

166 Vehicle care

Vehicle tools

Tools

Vehicles with tyre repair kit

Wheels and tyres

Tyre condition, wheel conditionDrive over edges slowly and at rightangles if possible. Driving over sharpedges can cause tyre and wheeldamage. Do not trap tyres on the kerbwhen parking.

Regularly check the wheels for damage Seek the assistance of

Tyre designations

E.g. 215/60 R 16 95 H

215 = Tyre width, mm60 = Cross-section ratio (tyre

height to tyre width), %R = Belt type: RadialRF = Type: RunFlat16 = Wheel diameter, inches

95 = Load index e.g. 95 isequivalent to 690 kg

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 167/203

The tools and tyre repair kit are ina storage compartment below thefloor cover in the load compartment.

Vehicles with spare wheelThe jack, the tools and a strap for securing a damaged wheel are ina storage compartment below thespare wheel in the load compartment.Spare wheel 3 175.

damage. Seek the assistance of a workshop in the event of damage or unusual wear.

Winter tyres

Winter tyres improve driving safety attemperatures below 7 °C and should

therefore be fitted on all wheels.Tyres of size 205/55 R 16,225/45 R 18, 235/40 R 19 and235/45 R 18 must not be used aswinter tyres.

In accordance with country-specificregulations, affix the speed sticker inthe driver's field of view.

q gH = Speed code letter 

Speed code letter:

Q = up to 100 mphS = up to 112 mphT = up to 118 mphH = up to 130 mph

V = up to 150 mphW = up to 168 mph

Tyre pressure

Check the pressure of cold tyres atleast every 14 days and before anylong journey. Do not forget the sparewheel. This also applies to vehicleswith tyre pressure monitoring system.

Unscrew the valve cap.

Vehicle care 16

9 Warning

If the pressure is too low, this canresult in considerable tyre warm-up and internal damage, leading totread separation and even to tyreblow-out at high speeds.

If the tyre pressure shall be reducedor increased on a vehicle with tyre

it i t it h

The menu can be selected by thebuttons on the turn signal lever.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 168/203

Tyre pressure 3 194 and on the labelon the front left door frame.

The tyre pressure data refers to coldtyres. It applies to summer and winter tyres.

 Always inflate the spare tyre to thepressure specified for full load.

The ECO tyre pressure serves toachieve the smallest amount of fuelconsumption possible.

Incorrect tyre pressures will impair safety, vehicle handling, comfort andfuel economy and will increase tyrewear.

pressure monitoring system, switchoff ignition.

Tyre pressure monitoringsystem

The tyre pressure monitoring systemchecks the pressure of all four wheelsonce a minute when vehicle speedexceeds a certain limit.

 All wheels must be equipped withpressure sensors and the tyres musthave the prescribed pressure.

The current tyre pressures can beshown in the Vehicle InformationMenu in the Driver Information

Center.

Press the MENU button to select theVehicle Information Menu.

168 Vehicle care

Control indicator w 3 85.

Vehicle messages 3 91.

If the tyre pressure shall be reducedor increased, switch off ignition.

If a complete set of wheels withoutsensors is mounted (e.g. four winter tyres), a message is displayed in theDriver Information Center. The tyrepressure monitoring system is notoperational. Retrofitting of sensors is

The tyre pressure monitoring systemvalve cores and sealing rings must bereplaced each time the tyres arechanged.

Adaptive threshold functionThe tyre pressure monitoring systemautomatically detects if the vehicle isdriven with a tyre pressure

appropriate for a load of up to3 people or for a full load.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 169/203

Turn the adjuster wheel to select thetyre pressure monitoring system.

System status and small pressuredifferences are displayed bya warning message with the

corresponding tyre flashing in theDriver Information Center.

Furthermore considerable pressuredifferences between the tyres on oneaxle are displayed by a warningmessage in the Driver InformationCenter.

Major pressure differences areindicated additionally by the control

indicator w.

p gpossible.

 A spare wheel or temporary sparewheel is not equipped with pressuresensors. The tyre pressuremonitoring system is not operationalfor these wheels. Control indicator willuminates. For the further three

wheels the system remainsoperational.

The use of commercially availableliquid tyre repair kits can impair thefunction of the system. Factoryapproved systems can be used.

External high-power radio equipmentcould disrupt the tyre pressuremonitoring system.

If the tyre pressure shall be reduced,switch off ignition before reducing.

Auto learn function After changing wheels the vehicle hasto be stationary for approx. 20minutes, before the system

recalculates. The following relearnprocess takes up to 10 minutes of driving with a speed of minimum12 mph. In this case$ can bedisplayed or pressure values canswap in the Driver Information Center.

If problems occur during the relearnprocess a warning message isdisplayed in the Driver Information

Center.

Vehicle care 16

Temperature compensationCold tyres decrease the tyrepressure, warm tyres increase thetyre pressure. The tyre pressuremonitoring system considers thiseffect for the warning messages.

The tyre pressure value displayed inthe Driver Information Center shows

the actual tyre pressure. Therefore itis important to check tyre pressurewith cold tyres

Changing tyre and wheel size

If tyres of a different size than thosefitted at the factory are used, it may bnecessary to reprogramme thespeedometer as well as the nominatyre pressure and make other vehiclmodifications.

 After converting to a different tyre

size, have the label with tyrepressures replaced.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 170/203

with cold tyres.

Tread depth

Check tread depth at regular intervals.

Tyres should be replaced for safetyreasons at a tread depth of 2-3 mm(4 mm for winter tyres).

The legally permissible minimumtread depth (1.6 mm) has beenreached when the tread has worndown as far as one of the tread wear indicators (TWI). Their position is

indicated by markings on thesidewall.

If there is more wear at the front thanthe rear, swap round front wheels andrear wheels. Ensure that the directionof rotation of the wheels is the sameas before.

Tyres age, even if they are not used.We recommend tyre replacement

every 6 years.

9 Warning

Use of unsuitable tyres or wheelsmay lead to accidents and willinvalidate the vehicle typeapproval.

Wheel covers

Wheel covers and tyres that arefactory approved for the respectivevehicle and comply with all of therelevant wheel and tyre combinationrequirements must be used.

If the wheel covers and tyres used arnot factory approved, the tyres must

not have a rim protection ridge.

170 Vehicle care

Wheel covers must not impair brakecooling.

9 Warning

Use of unsuitable tyres or wheelcovers could lead to suddenpressure loss and therebyaccidents.

Tyre chains

 Always use fine mesh chains that addno more than 10 mm to the tyre treadand the inboard sides (including chainlock).

9 Warning

Damage may lead to tyre blowout.

Tyre chains are not permitted on tyresof size 215/60 R 16 and

9 Warning

Do not drive faster than 50 mph.

Do not use for a lengthy period.

Steering and handling may beaffected.

If you have a flat tyre: Apply the parking brake and engagefirst gear reverse gear or

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 171/203

Tyre chains are only permitted on thefront wheels.

225/50 R 17.

The use of tyre chains is not permittedon the temporary spare wheel.

Tyre repair kit

Minor damage to the tyre tread or 

sidewall can be repaired with the tyrerepair kit.

Do not remove foreign bodies fromthe tyres.

Tyre damage exceeding 4 mm or thatis at tyre's side wall near the rimcannot be repaired with the tyre repair kit.

first gear, reverse gear or P.

The tyre repair kit is in a compartmentunder the floor cover in the loadcompartment.

Vehicle care 17

1. Take the tyre repair kit from thecompartment.

2. Remove the compressor.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 172/203

3. Remove the electrical connectioncable and air hose from the

stowage compartments on theunderside of the compressor.

4. Screw the compressor air hose tothe connection on the sealantbottle.

5. Fit the sealant bottle into theretainer on the compressor.

Set the compressor near the tyrein such a way that the sealantbottle is upright.

6. Unscrew valve cap from defectivtyre.

7. Screw the filler hose to the tyrevalve.

8. The switch on the compressor 

must be set to J.

9. Connect the compressor plug tothe power outlet or cigarettelighter socket.

To avoid discharging the batterywe recommend running theengine.

172 Vehicle care

14. Detach the tyre repair kit. Pushcatch on bracket to removesealant bottle from bracket. Screwtyre inflation hose to freeconnection of sealant bottle. Thisprevents sealant from escaping.Stow tyre repair kit in loadcompartment.

15. Remove any excess sealantusing a cloth.

16 Take the label indicating

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 173/203

10. Set the rocker switch on thecompressor to I. The tyre is filledwith sealant.

11. The compressor pressure gaugebriefly indicates up to 6 bar whilst

the sealant bottle is emptying(approx. 30 seconds). Then thepressure starts to drop.

12. All of the sealant is pumped intothe tyre. Then the tyre is inflated.

13. The prescribed tyre pressureshould be obtained within 10minutes. Tyre pressure 3 194.When the correct pressure is

obtained, switch off thecompressor.

If the prescribed tyre pressure isnot obtained within 10 minutes,remove the tyre repair kit. Movethe vehicle one tyre rotation.Reattach the tyre repair kit andcontinue the filling procedure for 

10 minutes. If the prescribed tyrepressure is still not obtained, thetyre is too badly damaged. Seekthe assistance of a workshop.

Drain excess tyre pressure withthe button over the pressureindicator.

Do not run the compressor longer than 10 minutes.

16. Take the label indicatingmaximum permitted speed fromthe sealant bottle and affix in thedriver's field of view.

17. Continue driving immediately sothat sealant is evenly distributedin the tyre. After driving approx.

6 miles (but no more than 10minutes), stop and check tyrepressure. Screw compressor air 

Vehicle care 17

hose directly onto tyre valve andcompressor when doing this.

NoticeThe driving characteristics of therepaired tyre is severely affected,therefore have this tyre replaced.

If unusual noise is heard or thecompressor becomes hot, turncompressor off for at least 30minutes.

The built-in safety valve opens ata pressure of 7 bar.

Note the expiry date of the kit After

Wheel changing

Some vehicles are equipped witha tyre repair kit instead of a sparewheel 3 170.

Make the following preparations andobserve the following information:

■ Park the vehicle on a level, firm annon-skid surface. The front wheelmust be in the straight-aheadposition.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 174/203

If tyre pressure is more than 1.3bar, set it to the correct value.Repeat the procedure until thereis no more loss of pressure.

If the tyre pressure has fallenbelow 1.3 bar, the vehicle mustnot be used. Seek the assistanceof a workshop.

18. Stow away tyre repair kit in loadcompartment.

Note the expiry date of the kit. After this date its sealing capability is nolonger guaranteed. Pay attention tostorage information on sealantbottle.

Replace the used sealant bottle.Dispose of the bottle as prescribed

by applicable laws.The compressor and sealant can beused from approx. -30 °C.

The adapters supplied can be usedto pump up other items e.g.footballs, air mattresses, inflatabledinghies etc. They are located on theunderside of the compressor. Toremove, screw on compressor air 

hose and withdraw adapter.

■ Apply the parking brake andengage first gear, reverse gear orP.

■ Remove the spare wheel 3 175.

■ Never change more than one wheeat once.

■ Use the jack only to change wheein case of puncture, not for seasonal winter or summer tyrechange.

■ If the ground on which the vehicleis standing is soft, a solid board(max. 0.4 inches / 1 cm thick)should be placed under the jack.

■ No people or animals may be in th

vehicle when it is jacked-up.

174 Vehicle care

■ Never crawl under a jacked-upvehicle.

■ Do not start the vehicle when it israised on the jack.

■ Clean wheel nuts and thread beforemounting the wheel.

3. Ensure the jack is correctlypositioned under the relevantvehicle jacking point.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 175/203

1. Disengage wheel nut caps witha screwdriver and remove. Pull off the wheel cover with the hook.Vehicle tools 3 166.

 Alloy wheels: Disengage wheelnut caps with a screwdriver andremove. To protect the wheel,place a soft cloth between the

screwdriver and the alloy wheel.

2. Install the wheel wrench ensuringthat it locates securely and looseneach wheel nut by half a turn.

4. Set the jack to the necessaryheight before positioning it directly

below the jacking point in

Vehicle care 17

a manner that prevents it fromslipping.

10. Align the valve hole in the wheelcover with the tyre valve beforeinstalling.

Install wheel nut caps.

11. Stow the replaced wheel 3 175and the vehicle tools 3 166.

12. Check the tyre pressure of theinstalled tyre and also the wheel

nut torque as soon as possible.

Have the defective tyre renewed or i d

Rear arm position of the liftingplatform centrically under the recessof the sill.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 176/203

 Attach jack handle and with the jack correctly aligned rotatehandle until wheel is clear of theground.

5. Unscrew the wheel nuts.

6. Change the wheel.

7. Screw on the wheel nuts.

8. Lower vehicle.

9. Install the wheel wrench ensuringthat it locates securely and tighteneach nut in a crosswisesequence. Tightening torque is140 Nm.

repaired.

Jacking position for lifting platform

Front arm position of the liftingplatform at the underbody.

Spare wheel

Some vehicles are equipped witha tyre repair kit instead of a sparewheel.

The spare wheel can be classified aa temporary spare wheel dependingon the size compared to the other mounted wheels and countryregulations.

176 Vehicle care

The spare wheel has a steel rim.

The use of a spare wheel that issmaller than the other wheels or incombination with winter tyres couldaffect driveability. Have the defectivetyre replaced as soon as possible.

compartment after having changedwheels, it needs to be secured witha strap. Vehicle tools 3 166

Temporary spare wheelThe use of the temporary spare wheelcould affect driveability. Have thedefective tyre renewed or repaired assoon as possible.

Only mount one temporary sparewheel. Do not drive faster than50 mph Take curves slowly Do not

Stowing a damaged wheel A damaged wheel must be stowed inthe load compartment and securedwith a strap. Tools 3 166

1. Position the wheel on one side of the load compartment.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 177/203

The spare wheel is located in the loadcompartment beneath the floor covering. It is secured in the recesswith a wing nut.

The spare wheel well is not designedfor all permissible tyre sizes. If a wheel wider than the spare wheelhas to be stowed in the load

50 mph. Take curves slowly. Do notuse for a long period of time.

Tyre chains 3 170.

Directional tyresFit directional tyres such that they rollin the direction of travel. The rolling

direction is indicated by a symbol(e.g. an arrow) on the sidewall.

The following applies to tyres fittedopposing the rolling direction:

■ Driveability may be affected. Havethe defective tyre renewed or repaired as soon as possible.

■ Do not drive faster than 50 mph.

■ Drive particularly carefully on wetand snow-covered road surfaces.

2. Stick the loop end of the strapthrough the according lashing eyeat the front.

3. Stick the hook end of the strapthrough the loop and pull it untilthe strap is fastened securely tothe lashing eye.

Vehicle care 17

Jump starting

Do not start with quick charger.

 A vehicle with a discharged batterycan be started using jump leads andthe battery of another vehicle.

9 Warning

Be extremely careful when startingwith jump leads. Any deviation

■ A discharged battery can alreadyfreeze at a temperature of 0 °C.Defrost the frozen battery beforeconnecting jump leads.

■ Wear eye protection and protectivclothing when handling a battery.

■ Use a booster battery with thesame voltage (12 Volts). Its

capacity (Ah) must not be muchless than that of the dischargedbattery.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 178/203

4. Insert the strap through thespokes of the wheel as shown inthe illustration.

5. Stick the hook end through theaccording lashing eye at the rear.

6. Tighten the strap and secure itusing the buckle.

j p yfrom the following instructions canlead to injuries or damage causedby battery explosion or damage tothe electrical systems of bothvehicles.

9 Warning

 Avoid contact with eyes, skin,fabrics and painted surfaces. Thefluid contains sulphuric acid whichcan cause injuries and damage inthe event of direct contact.

■ Never expose the battery to naked

flames or sparks.

■ Use jump leads with insulatedterminals and a cross section of aleast 16 mm2 (25 mm2 for dieselengines).

■ Do not disconnect the dischargedbattery from the vehicle.

■ Switch off all unnecessary electricaconsumers.

■ Do not lean over the battery durin jump starting.

■ Do not allow the terminals of onelead to touch those of the other lead.

178 Vehicle care

■ The vehicles must not come intocontact with each other during the jump starting process.

■ Apply the parking brake,transmission in neutral, automatictransmission in P.

3. Connect the black lead to thenegative terminal of the booster battery.

4. Connect the other end of the blacklead to a vehicle grounding point,such as the engine block or anengine mounting bolt. Connect asfar away from the dischargedbattery as possible, however atleast 2 ft.

Route the leads so that they cannott h t ti t i th i

4. Switch on electrical consumers(e.g. headlights, heated rear window) of the vehicle receivingthe jump start.

5. Reverse above sequence exactlywhen removing leads.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 179/203

Lead connection order:

1. Connect the red lead to thepositive terminal of the booster battery.

2. Connect the other end of the redlead to the positive terminal of thedischarged battery.

catch on rotating parts in the enginecompartment.

To start the engine:

1. Start the engine of the vehicleproviding the jump.

2. After 5 minutes, start the other 

engine. Start attempts should bemade for no longer than 15seconds at an interval of 1 minute.

3. Allow both engines to idle for approx. 3 minutes with the leadsconnected.

Vehicle care 17

Towing

Towing the vehicle

Caution

Drive slowly. Do not drive jerkily.Excessive tractive force candamage the vehicle.

When the engine is not running,considerably more force is needed t

brake and steer.To prevent the entry of exhaust gasefrom the towing vehicle, switch on th

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 180/203

Disengage cap at bottom and removedownwards.

The towing eye is stowed with thevehicle tools 3 166.

Screw in the towing eye as far as it willgo until it stops in a horizontalposition.

 Attach a tow rope – or better still a towrod – to the towing eye.

The towing eye must only be used for towing and not for recovering thevehicle.

Switch on ignition to release steeringwheel lock and to permit operation of brake lights, horn and windscreenwiper.

Transmission in neutral.

gair recirculation and close thewindows.

Vehicles with automatic transmissionThe vehicle must be towed facingforwards, not faster than 50 mph nofurther than 60 miles. In all other 

cases and when the transmission isdefective, the front axle must beraised off the ground.

Seek the assistance of a workshop.

 After towing, unscrew the towing eye

Insert cap below and close cap.

180 Vehicle care

Towing another vehicleCaution

Drive slowly. Do not drive jerkily.Excessive tractive force candamage the vehicle.

 After towing, unscrew the towing eye.

Insert cap below and engage cap.

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 181/203

Disengage the cap at the bottom andremove downwards.

The towing eye is stowed with thevehicle tools 3 166.

Screw in the towing eye as far as it willgo until it stops in a horizontalposition.

The lashing eye at the rear underneath the vehicle must never be

used as a towing eye. Attach a tow rope – or even better a tow bar – to the towing eye.

The towing eye must only be used for towing and not for recoveringa vehicle.

Vehicle care 18

Appearance care

Exterior care

LocksThe locks are lubricated at the factoryusing a high quality lock cylinder grease. Use de-icing agent only whenabsolutely necessary, as this has

a degreasing effect and impairs lockfunction. After using de-icing agent,have the locks regreased by

and rear window wiper must beswitched off. Remove antenna andexternal accessories such as roof racks etc.

If you wash your vehicle by hand,make sure that the insides of thewheel housings are also thoroughlyrinsed out.

Clean edges and folds on openeddoors and the bonnet as well as theareas they cover.

H th d hi f ll d

Polishing and waxingWax the vehicle regularly (at thelatest when water no longer beads).Otherwise, the paintwork will dry out

Polishing is necessary only if the painhas become dull or if solid depositshave become attached to it.

Paintwork polish with silicone forms

a protective film, making waxingunnecessary.

Plastic body parts must not be treate

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 182/203

a workshop.

WashingThe paintwork of your vehicle isexposed to environmental influences.Wash and wax your vehicle regularly.When using automatic vehiclewashes, select a programme thatincludes waxing.

Bird droppings, dead insects, resin,pollen and the like should be cleanedoff immediately, as they containaggressive constituents which cancause paint damage.

If using a vehicle wash, comply with

the vehicle wash manufacturer'sinstructions. The windscreen wipers

Have the door hinges of all doorsgreased by a workshop.

Do not clean the engine compartmentwith a steam-jet or high-pressure jetcleaner.

Thoroughly rinse and leather-off the

vehicle. Rinse leather frequently. Useseparate leathers for painted andglass surfaces: remnants of wax onthe windows will impair vision.

Exterior lightsHeadlight and other light covers aremade of plastic. Do not use anyabrasive or caustic agents, do not usean ice scraper, and do not clean themdry.

with wax or polishing agents.

Windows and windscreen wiperbladesUse a soft lint-free cloth or chamoisleather together with window cleane

and insect remover.When cleaning the rear window,make sure the heating element insidis not damaged.

For mechanical removal of ice, usea sharp-edged ice scraper. Press thscraper firmly against the glass sothat no dirt can get under it andscratch the glass.

182 Vehicle care

Clean smearing wiper blades witha soft cloth and window cleaner.

SunroofNever clean with solvents or abrasiveagents, fuels, aggressive media (e.g.paint cleaner, acetone-containingsolutions etc.), acidic or highlyalkaline media or abrasive pads. Do

not apply wax or polishing agents tothe middle part of the sunroof.

UnderbodySome areas of the vehicle underbodyhave a PVC undercoating while other critical areas have a durableprotective wax coating.

 After the underbody is washed, checkthe underbody and have it waxed if necessary.

Bitumen/rubber materials coulddamage the PVC coating. Haveunderbody work carried out bya workshop

The instrument panel should only becleaned using a soft damp cloth.

Clean fabric upholstery witha vacuum cleaner and brush.Remove stains with an upholsterycleaner.

Clean seat belts with lukewarm water or interior cleaner.

Caution

Close Velcro fasteners as open

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 183/203

Wheels and tyresDo not use high-pressure jetcleaners.

Clean rims with a pH-neutral wheelcleaner.

Rims are painted and can be treated

with the same agents as the body.

Paintwork damageRectify minor paintwork damage witha touch-up pen before rust forms.Have more extensive damage or rustareas repaired by a workshop.

a workshop.

Before and after winter, wash theunderbody and have the protectivewax coating checked.

Towing equipmentDo not clean the coupling ball bar witha steam-jet or high-pressure jetcleaner.

Interior care

Interior and upholsteryOnly clean the vehicle interior,including the instrument panel fasciaand panelling, with a dry cloth or 

interior cleaner.

Close Velcro fasteners as openVelcro fasteners on clothing coulddamage seat upholstery.

The same applies to clothing withsharp-edged objects, like zips or belts or studded jeans.

Plastic and rubber partsPlastic and rubber parts can becleaned with the same cleaner asused to clean the body. Use interior cleaner if necessary. Do not use anyother agent. Avoid solvents and petrolin particular. Do not use high-pressure jet cleaners.

Service and maintenance 18

Service andmaintenance

General information ................... 183

Recommended fluids, lubricantsand parts .................................... 184

General information

Service information

In order to ensure economical andsafe vehicle operation and tomaintain the value of your vehicle, itis of vital importance that allmaintenance work is carried out at the

proper intervals as specified.The detailed, up-to-date serviceschedule for your vehicle is availableat the workshop

Make sure that the Service andWarranty Booklet is completedcorrectly as continuous proof of service is essential if any warranty ogoodwill claims are to be met, and isalso a benefit when selling thevehicle.

Service interval with remaining

engine oil life durationThe service interval is based onseveral parameters depending onusage

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 184/203

at the workshop.

Service display 3 78.

Service intervalsMaintenance of your vehicle isrequired every 20,000 miles or after 

1 year, whichever occurs first, unlessotherwise indicated by the oil lifesystem.

Service display 3 78.

ConfirmationsConfirmation of service is recorded inthe Service and Warranty Booklet.The date and mileage is completedwith the stamp and signature of the

servicing workshop.

usage.

The engine oil life system lets youknow when to change the engine oil

Service display 3 78.

184 Service and maintenance

Recommended fluids,lubricants and parts

Recommended fluids andlubricants

Only use products that have beentested and approved. Damageresulting from the use of non-

approved materials will not becovered by the warranty.

The new engine oil GM-Dexos 2 is of the highest quality available at themoment. If it is unavailable, engineoils of other listed qualities have to beused.

Engine oil quality

GM-Dexos2

= Petrol and dieselengines

GM-LL- A-025 = Petrol engines

GM-LL-B-025

= Diesel engines

Use of ACEA A1/B1 and A5/B5engine oil is expressly forbidden,since they can cause long-termengine damage under certainoperating conditions.

Engine oil additives

The use of engine oil additives couldcause damage and invalidate the

warranty.Engine oil viscosity

Use only engine oil viscosities SAE

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 185/203

9 Warning

Operating materials arehazardous and could bepoisonous. Handle with care. Payattention to information given on

the containers.

Engine oilEngine oil is identified by its qualityand also its viscosity. Quality is moreimportant than viscosity whenselecting which engine oil to use.

B 025

Topping up engine oil

Engine oils of different manufacturersand brands can be mixed as long asthey comply with the required engineoil (quality and viscosity).

If engine oil of the required quality isnot available, a maximum of 1 litre of  ACEA A3/B4 or A3/B3 grade may beused (only once between each oilchange). The viscosity should be of the correct rating.

y g0W-30, 0W-40, 5W-30 or 5W-40.

The SAE viscosity rating defines theability of an oil to flow. When cold, oilis more viscous than when hot.

Multigrade oil is indicated by two

figures. The first figure, followed bya W, indicates low temperatureviscosity and the second figure thehigh temperature viscosity.

Coolant and antifreezeUse only silicate-free long life coolant(LLC) antifreeze.

The system is factory filled withcoolant designed for excellent

corrosion protection and frost

Service and maintenance 18

protection down to approx. -28 °C.This concentration should bemaintained all year round.

Coolant additives intended to giveadditional corrosion protection or sealagainst minor leaks can causefunction problems. Liability for consequences resulting from the useof coolant additives will be rejected.

Brake and clutch fluidUse only brake fluid which exceedsDOT4 requirements

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 186/203

DOT4 requirements.

Over time, brake fluid absorbsmoisture which will reduce brakingeffectiveness. The brake fluid shouldtherefore be replaced at the specifiedinterval.

Brake fluid should be stored ina sealed container to avoid water absorption.

Ensure brake fluid does not becomecontaminated.

186 Technical data

Technical data

Vehicle identification .................. 186

Vehicle data ............................... 188

Vehicle identification

Vehicle Identification Number

Identification plate

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 187/203

The Vehicle Identification Number isvisible through the windscreen.

The identification plate is located onthe front left door frame.

Technical data 18

Information on identification label:

1 = Manufacturer 2 = Type approval number 3 = Vehicle Identification Number 4 = Permissible gross vehicle

weight rating5 = Permissible gross train weight6 = Maximum permissible front axle

load

7 = Maximum permissible rear axleload

8 = Vehicle-specific or countryspecific data

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 188/203

specific data

The combined total of front and rear axle loads must not exceed thepermissible gross vehicle weight. For example, if the front axle is bearing itsmaximum permissible load, the rear axle can only bear a load that is equalto the gross vehicle weight minus thefront axle load.

The technical data is determined inaccordance with EuropeanCommunity standards. We reservethe right to make modifications.Specifications in the vehicledocuments always have priority over 

those given in this manual.

188 Technical data

Vehicle dataEngine data

Sales designation 1.4 1.6

Engine identifier code A14XER A16XER

Number of cylinders 4 4

Piston displacement [cm3] 1398 1598

Engine power [kW] 74 85

at rpm 1) 6000

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 189/203

Torque [Nm] 130 155

at rpm 1) 4000

Fuel type Petrol Petrol

Octane rating RON

recommended 95 95

possible 98 98

possible 91 91

Oil consumption [l/1000 km] 0.6 0.6

1) Value was not available at time of printing.

Technical data 18

Sales designation 1.7 1.7 2.0 Turbo

Engine identifier code A17DTJ A17DTR A20DTH

Number of cylinders 4 4 4

Piston displacement [cm3] 1686 1686 1956

Engine power [kW] 81 92 118

at rpm 3800 4000 4000

Torque [Nm] 260 280 350

at rpm 1700-2550 2000-2700 1750-2500

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 190/203

Fuel type Diesel Diesel Diesel

Oil consumption [l/1000 km] 0.6 0.6 0.6

190 Technical data

Performance

Hatchback

Engine A14XER A16XER

Maximum speed2) [mph]

Manual transmission 3)

 Automatic transmission –  

Engine A17DTJ A17DTR A20DTH

M i d2) [ h]

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 191/203

Maximum speed2) [mph]

Manual transmission 3) 3) 3)

 Automatic transmission –    –  3)

Fuel consumption - CO2-emissions

HatchbackManual transmission / automatic transmission.

2) The maximum speed indicated is achievable at kerb weight (without driver) plus 200 kg payload. Optional equipment

could reduce the specified maximum speed of the vehicle.3) Value was not available at time of printing.

Technical data 19

To convert l/100 km into mpg, divide 282 by the number of litres/100 km.

Engine A14XER A16XER A17DTJ A17DTR A20DTH

urban [l/100 km] 4)/–  4)/4) 4)/–  4)/–  4)/4)

extra-urban [l/100 km] 4)/–  4)/4) 4)/–  4)/–  4)/4)

total [l/100 km] 4)/–  4)/4) 4)/–  4)/–  4)/4)

CO2 [g/km] 4)/–  4)/4) 4)/–  4)/–  4)/4)

Vehicle weight

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 192/203

Kerb weight, basic model without any optional equipment

Hatchback Engine Manual transmission Automatic transmission

without/with air conditioning

[kg]

 A14XER 1373/1388 –  

 A16XER 1393/1408 –/1443

 A17DTJ 1503/1518 –  

 A17DTR 1503/1518 –  

 A20DTH 1503/1518 –/1590

4) Value was not available at time of printing.

192 Technical data

Kerb weight, basic model with all optional equipment

Hatchback Engine Manual transmission Automatic transmission

without/with air conditioning

[kg]

 A14XER –/1545 –  

 A16XER –/1578 –/1617

 A17DTJ –/1684 –  

 A17DTR –/1689 –  

 A20DTH –/1711 –/1731

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 193/203

Vehicle dimensions

Hatchback

Length [mm] 4419

Width without exterior mirrors [mm] 1814

Width with two exterior mirrors [mm] 2013

Height (without antenna) [mm] 1510

Length of load compartment floor [mm] 836

Length of load compartment with folded rear seats [mm] 1549

Load compartment width [mm] 1027

Load compartment height [mm] 774

Technical data 19

Hatchback

Height of load compartment opening 772

Wheelbase [mm] 2685

Turning circle diameter [m] 11.5

Capacities

Engine oil

Engine A14XER A16XER

including Filter [l] 3 75 5 0

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 194/203

including Filter [l] 3.75 5.0

between MIN and MAX [l] 1.0 1.0

Engine A17DTJ A17DTR A20DTH

including Filter [l] 5.4 5.4 4.5between MIN and MAX [l] 1.0 1.0 1.0

Fuel tank

Petrol/diesel, nominal capacity [l] 56

194 Technical data

Tyre pressures

Hatchback

Comfort with up to 3 people ECO with up to 3 people With full load

Engine Tyres front rear front rear front rear

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

 A14XER 205/60 R16, 220/2.2 (32) 220/2.2 (32) 260/2.6 (38) 240/2.4 (35) 230/2.3 (33) 270/2.7 (39)215/60 R16,

215/50 R17

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 195/203

 A16 XER 205/60 R16, 220/2.2 (32) 220/2.2 (32) 260/2.6 (38) 240/2.4 (35) 230/2.3 (33) 270/2.7 (39)

215/60 R16,

215/50 R17,

225/45 R18,

235/40 R19

Technical data 19

Comfort with up to 3 people ECO with up to 3 people With full load

Engine Tyres front rear front rear front rear

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

[kPa/bar]([psi])

 A17DTJ,

 A17DTR,

 A20DTH

215/60 R16, 230/2.3 (33) 230/2.3 (33) 270/2.7 (39) 250/2.5 (36) 240/2.4 (35) 280/2.8 (41)

225/50 R17,

235/45 R18

235/40 R19 240/2.4 (35) 220/2.2 (32) – – 250/2.5 (36) 290/2.9 (42)

 All Temporary spare 420/4.2 (61) 420/4.2 (61) – – 420/4.2 (61) 420/4.2 (61)

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 196/203

wheel

196 Technical data

Towing hitch installation dimensions

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 197/203

Customer information 19

Customerinformation

Vehicle data recording andprivacy ....................................... 197

Vehicle data recordingand privacy

Event data recorders

The vehicle has a number of sophisticated systems that monitor and control several vehicle data.Some data may be stored during

regular operation to facilitate repair of detected malfunctions, other data isstored only in a crash or near crashevent by systems commonly calledevent data recorders (EDR)

■ with the consent of the vehicleowner or, if the vehicle is leased,with the consent of the lessee,

■ in response to an official request opolice or similar government office

■ as part of the manufacturer'sdefense in case of legalproceedings,

■ as required by law.In addition, the manufacturer may usthe collected or received data

■ for the manufacturer's research

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 198/203

event data recorders (EDR).

The systems may record data aboutthe condition of the vehicle and how itwas operated (e.g. engine speed,brake application, seat belt usage).To read this data special equipmentand access to the vehicle is required.This will take place when the vehicleis serviced in a workshop. Some datais electronically fed into GM globaldiagnostic systems. Themanufacturer will not accessinformation about a crash event or share it with others except

needs,

■ to make it available for researchneeds where appropriateconfidentiality is maintained andneed is shown,

■ to share summary data which is notied to a specific vehicle with otheorganisations for researchpurposes.

198

Index A Accessories and vehicle

modifications .......................... 147 Adaptive forward lighting .... . 86, 106 Adjustable air vents ................... 119 Airbag and belt tensioners ........... 81 Airbag deactivation ................ 44, 82 Airbag system .............................. 41 Air conditioning regular 

operation ................................ 121 Air conditioning system .............. 115 Air intake .................................... 120 Air quality sensor........................ 116Antilock brake system 130

Bonnet ....................................... 148Brake and clutch system ............. 82Brake assist ............................... 132Brake fluid .................................. 151Brakes ............................... 130, 151Bulb replacement ....................... 153

CCapacities .................................. 193Car Pass ...................................... 18Catalytic converter ..................... 125Central locking system ................ 20Centre console lighting .............. 112Centre console storage ............... 53

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 199/203

 Antilock brake system ................ 130 Antilock brake system (ABS) ....... 83 Anti-theft alarm system ................ 24 Anti-theft locking system .............. 23 Apply footbrake ............................ 85  Armrest................................... 37, 38

 Armrest storage ........................... 53  Ashtrays ....................................... 75 Automatic anti-dazzle .................. 28 Automatic light control ............... 104 Automatic transmission .......... ... 126  Auxiliary heater........................... 119

BBattery ....................................... 151

Battery discharge protection ...... 113

gChanging tyre and wheel size .. . 169Charging system .......................... 82Child locks ................................... 22Child restraint installation

locations ................................... 47

Child restraint systems ................ 45Cigarette lighter ........................... 75Climate control ............................. 15Clock............................................. 74Code............................................. 91Control indicators.......................... 78Control of the vehicle ................. 122Convex shape .............................. 26Cruise control ...................... 86, 135Cupholders .................................. 51Curtain airbag system .................. 43

19

DDanger, Warnings and Cautions .. . 3Daytime running light.................... 86Diesel fuel system bleeding ....... 152Diesel particle filter............... 84, 124Door open .................................... 86Driver Information Center............. 87Driving characteristics and

towing tips .............................. 142

EElectric adjustment ...................... 26Electrical parking brake................ 83Electrical parking brake fault..... ... 83

Event data recorders.................. 197Exit lighting ................................ 112Exterior care .............................. 181Exterior light ................................. 86Exterior lighting ............................ 12

FFault ........................................... 128First aid kit ................................... 67Fixed air vents ........................... 120Fog light ....................................... 86Fog lights ................................... 156Folding ......................................... 26Front airbag system ..................... 42

HHalogen headlights .................... 15Hand brake................................. 13Hazard warning flashers ............ 10Headlight flash ........................... 10Headlight range adjustment ... .. . 10Headlights when driving abroad 10Head restraint adjustment .............Head restraints ............................ 3

Heated ......................................... 2Heated rear window ..................... 3Heated steering wheel ................. 7Heating ........................................ 3Heating and ventilation system 11

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 200/203

p gElectronic climate control

system .................................... 116Electronic driving programmes .. 128Electronic Stability Control . . 84, 133Electronic Stability Control off....... 84

End-of-life vehicle recovery ....... 148Engine compartment fuse box ... 161Engine coolant ........................... 150Engine coolant temperature

gauge ....................................... 77Engine data ............................... 188Engine exhaust .......................... 124Engine oil ................................... 149Engine oil pressure ...................... 85Entry lighting .............................. 112

Front fog lights ........................... 109Fuel consumption - CO2-

Emissions ....................... 141, 190Fuel for diesel engines .............. 140Fuel for petrol engines ............... 140

Fuel gauge ................................... 77Fuses ......................................... 160

GGeneral information ................... 142Glovebox ..................................... 51Graphic-Info-Display, Colour-

Info-Display .............................. 89

Heating and ventilation system . 11Height adjustable rear floor cover 6High beam ........................... 86, 10Hill start assist ........................... 13Horn ....................................... 13, 7

IIdentification plate ..................... 18Ignition switch positions ............. 12Immobiliser ............................ 25, 8Instrument panel fuse box ......... 16Instrument panel illumination ..... 15Instrument panel illumination

control .................................... 11Instrument panel overview ........... 1Interactive driving system........... 13

200

Interior care ............................... 182Interior lights ...................... 111, 159Interruption of power supply ..... . 128Introduction .................................... 3ISOFIX child restraint systems .... 50

JJump starting ............................. 177

K

Keys ............................................. 18

LLane departure warning... ... . 83, 138Lashing eyes ............................... 66

Mirror adjustment ........................... 8Misted light covers ..................... 110

NNew vehicle running-in .............. 122Number plate light ..................... 159

OOdometer ..................................... 76Outside temperature .................... 73

Overrun cut-off ........................... 123

PParking ................................ 17, 124Parking assist ............................ 137

Reading lights ............................ 111Rear carrier system...................... 54Rear floor storage cover .............. 65Rear fog light ............................... 86Rear fog lights ........................... 109Rear window wiper/washer .......... 73Recommended fluids and

lubricants ................................ 184Reduced engine power................ 85

Refuelling ................................... 140Reversing lights ......................... 110Roof rack ..................................... 67

S

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 201/203

Lashing eyes ............................... 66Light switch ................................ 104Load compartment ................ 22, 62Load compartment cover ............. 64Load compartment fuse box ...... 164Loading information ..................... 68

Low fuel ....................................... 85Low washer fluid .......................... 86

MMalfunction indicator light ............ 82Manual anti-dazzle ...................... 27Manual mode ............................. 127Manual transmission .................. 129Manual windows .......................... 28Memorised settings...................... 19

Parking assist ............................ 137Parking brake ............................ 131Parking lights ............................. 110Particulate filter........................... 124Performance .............................. 190Performing work ........................ 148

Pollen filter ................................. 120Power outlets ............................... 75Power windows ............................ 28Preheating ................................... 84

QQuickheat................................... 119

RRadio remote control ................... 18

Rain sensor.................................. 86

Seat adjustment ....................... 6, 35Seat belt ........................................ 8Seat belt reminder ....................... 81Seat belts ..................................... 38Seat position ................................ 34

Selector lever ............................. 126Service ............................... 121, 183Service display ............................ 78Service information .................... 183Service vehicle soon .................... 82Side airbag system ...................... 42Side turn signal lights ................ 158Spare wheel ............................... 175Speedometer ............................... 76Starting off ................................... 16Starting the engine .................... 123

20

Steering wheel adjustment ..... . 9, 69Steering wheel controls ............... 69Sunglasses storage ..................... 52Sunroof ........................................ 30Sunvisor lights ........................... 111Sun visors .................................... 30Symbols ......................................... 4

TTachometer ................................. 77

Tail lights ................................... 156Three-point seat belt .................... 39Tools .......................................... 166Top-tether fastening eyes ............ 50T i th hi l 180

Turn signal ................................... 81Tyre chains ................................ 170Tyre designations ...................... 166Tyre pressure ............................ 166Tyre pressure monitoring

system............................... 85, 167Tyre pressures ........................... 194Tyre repair kit ............................. 170

UUltrasonic parking assist .............. 84Underseat storage ....................... 52Upshift.......................................... 83Using this manual .......................... 3

Washer and wiper systems ........ . 1Washer fluid ............................... 15Wheel changing ......................... 17Wheel covers ............................. 16Wheels and tyres ....................... 16Windscreen wiper/washer ........... 7Winter tyres ............................... 16Wiper blade replacement ......... . 15

XXenon headlights ....................... 15

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 202/203

Towing another vehicle ........... .. 180Towing equipment ..................... 143Towing hitch installation

dimensions ............................. 196Towing the vehicle ..................... 179

Traction Control system ............. 132Traction Control system off........... 84Traffic sign assistant..................... 94Trailer stability assist ................. 146Trailer towing ............................. 142Transmission ............................... 15Transmission display ................. 126Tread depth ............................... 169Trip computer .............................. 97Trip odometer .............................. 76Turn and lane-change signals .. . 109

VVariable effort steering................. 83Vehicle dimensions .................... 192Vehicle Identification Number .... 186Vehicle messages ....................... 91Vehicle personalisation ............... 99Vehicle specific data ...................... 3Vehicle storage........................... 147Vehicle unlocking ........................... 6Vehicle weight ........................... 191Ventilation................................... 114

WWarning chimes ........................... 94

Warning triangle .......................... 67

202

8/3/2019 Manual AstraJ 08

http://slidepdf.com/reader/full/manual-astraj-08 203/203