Lawn and Garden Tractors - Wheel Horse Tractor Manual ... · PDF fileLawn and Garden Tractors...
10
Lawn and Garden Tractors MODELS • I Wheel-Horse Products, Inc. SOUTH BEND, INDIANA 46614 www.MyWheelHorse.com
Transcript of Lawn and Garden Tractors - Wheel Horse Tractor Manual ... · PDF fileLawn and Garden Tractors...
Lawn and Garden Tractors
MODELS
• I
Wheel-Horse Products, Inc. SOUTH BEND, INDIANA 46614
www.MyWheelHorse.com
77
5
7
I t.)
39
I 4
8!i
S4
42
~ 9 2
29
32
51
52
14
5073
TR
AN
SMIS
SIO
N
22
7
78
73
66
_---63
,.,
www.MyWheelHorse.com
Ilem
No.
1
2
3
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
I
I I
PARTS LIST FOR 5073 TRANSMISSION When ordering parts always list Part No. and name of part.
Parts available only through Authoriz:ed Dealers.
(Specifications subject 10 change wilhoul nOlice.l
Part No.
8163
1533
1532
1542
1526
1529
1461
1213
3915
6941
1523
1531
1303
8050
8051
7196
8053
8056
7199
7200
933209
Description
Case R.H.
Ball Bearing 1)1 1.0.
Needle Bearing 1" 1.0.
Needle Bea ring %" 1.0.
Needle Bearing lYa 1.0.
Needle Bearing Y4 1.0.
Seal % Shaft
I Seal 1 Ya Shaft
Dowel Pin
Case l.H.
Needle Bearing Y4 1.0.
Needle Bearing % 1.0.
Seal - Shaft - Brake Y4 End Cap R.H.
End Cap l.H.
Gear - Differential Ring
Gear - Axle
Gear - Differential Pinion
Washer - Thrust
Body
Roll Pin ~ x )1
7235 Spring - Cylindrical
908138·4 Bolt Hex %-16 x 3~
915663·4 Nut Elastic Stop %.16
920009.4 Washer % SAE
7202 Axle - Rear R.H.
7203 Axle - Rear l.H.
7169 Snap Ring Heavy Duty
7201
7418
7204
1518
5175
7205
7206
7207
7208
7209
3517
3518
1243
7213
7214
Shaft - Input
Washer - Thrust
Gear and Spline
Needle Bearing % 1.0.
Pinion - Gear and Spline
Gea r - Sliding
, Gear I
- Reduction
I Needle Bearing % 1.0. x y, Shaft - Reduction Gea r
Shift Fork
Boll - Stop
Spring - Stop
Plug
Bolt - Detent
i Shift Lever I
I I
No. Req'd.
1
2
2
1
2
1
1
2
2
1
I
1
1
1
I
I
2
10
2
2
1
5
5
10
1
1
2
1
1
1
1
I
1
2
1
I
3
2
1
1
I
-3-
Item
No.
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
Port No.
5173 , ! 5174 !
I
5615
5616
3503
933156
5614
7269
3525
1504
3527
9840
937014
4204
1516
3909
9839
5951
9600
908032-5
2844
9593
908002·4
920081·4
9598
943460
943420
3912
I I Description
Gear - Hi and 2nd
Gear - low and Reverse
Rail - Front Shift
Rail - Rear Shift
Shift Fork
Roll Pin Ya x 1
Pin - Shift Stop
Gear and Beo ring Complete , I Gear - Cluster
I
I
I
•
Bearing - Bronze· % 1.0.
Gear - Reduction
Shaft - Cluster Gear & Broke
Key #9 Woodruff
Gear - Reverse Idler
8ushing - Bronze )1" 1.0.
Shaft
Gear 44T - lIT
Washer - Double "0"
I Drum - Brake I
Bolt - Nylok %.16 x %
Washer - Special
Brake Band and Lining
Bolt Hex ~-20 x % Lackwasher ~"
Plate - Parking Brake Stop
Plug ~Pipe
Plug % Pipe
Gasket
908043.4 Bolt Hex %-16 x 3)1
908038-4 Bolt Hex % -16 x 2
915113-6
943338
943004
6155
1935
5632
1239
915111-4
3577
1001
7217
933184
Nut Hex %.16 Nylok
Nipple Clos.. )1 Pipe
Coupling )1 Pipe
Dipstick
Decal
Shift Stick
Set Screw Dog Point
Nut Hex ~-20
Boot
Knob
Handle - Shift
Roll Pin K6 x %
I
I No.
Req'd. I
I I
1
2
2
1
1
1
2
1
1
1
1
1
I
1
1
1
1
1
1
2
2
1
1
1
1
1
5
6
1
I
1
1
1
1
1
1
2
1
1
www.MyWheelHorse.com
I ..... I
252
251
253
80
27
248
\ 6
I 27
25
0
POW
ER
TAK
E-O
FF
38
39
28
29
256
185
•
44
30
24
254
264
265
266 26
27
219
218
35 31 83
-i1
34
40
215
9
9
216
214 ST
EER
ING
&
WH
EEL
AS
S'Y
.
235 10
223
222
221
220
www.MyWheelHorse.com
27J
\ (
1 100 e
) I(
207-_....::
2 1
55
203 199 /
200
-5-
125
71_
205
~
13-
8
121
102 267 268
129
202
lIO
MAIN FRAME, FENDE
www.MyWheelHorse.com
. , .,
70 22 ;~O \19 I
185
"":::"'6
1
- -7 11
,
5
. HOOD ASS/Y.
<::--50
35
175
74
186
73
, ,
14
11
, 00
75 7
52
269 144 142
145
-6-
1
85
143
41
71
158 157
243
188
'----160
72
70
www.MyWheelHorse.com
TRACTOR PARTS LIST FOR RAIDER 12 (1-6251) & RAIDER 10 (1-6051)
Item No.
I 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68
Part No,
9789 7881 900196-4 915661-4 682S 908017-4 915112-6 908034-4 915663-4 6727 908032-4 920009-4 920083-4 7492 90986:l-5 937010 908033-6 6465 937022 909554 915236-4 5638 1030 1481 6216 908015-4 920082-4 5630 5631 5618 6396 6397 908035-4 7447 1085 909848-5 6469 5210 1278 932035-4 6472 5628 5629 915002-6 9757 4899 933158 7451 911404-4 915113-6 2593 9599 1861 932017-4 1014 5544 2267 5448 4438 5449 933168 3624 3578 3680 6542 933506-4 5640 2179
,
See Page 9 for Raider 12 (I -6253)
When ordering parts always list Part No. and name of part.
Parts available only through Authorized Dealers.
(Specifications subject 10 change withoul nolice'!
Description
Frame Hoodstand Bolt - Carriage X-20 x % Nut Elastic Stop X-20 Dust Cover Bolt ~6-18 x % Nut Nylok ~6-18 Bolt Hex %-16 x 1 Nut Elastic Stop %-16 Cam Arm Bolt Hex % -16 x % Washer % SAE lockwasher % Pulley - Transmission Set Screw Nylok ~6-18 x ~6 Key - Woodruff ~2 x % Bolt Nylok %-16 x Ys Hub Wheel Key - Woodruff Set Screw Squa re %-16 x I Nut Hex %-16 Jam Axle - Front Grease Fitting Grease Fitting 45" Pin and Plate Bolt Hex ~,-18 x~ Lockwa sher X6 Spindle R.H, Spindle LH. "E" Ring % Shaft Support Steering Bushing Bolt Hex %-16 x 1 ~,;; Shaft - Upper Steering Collar Set Screw - Nylok X-20 x Steering Shaft - Lower Washer Shim (.015) Washer Shim (.050) Cotter Pin K6 x IX 8earing and Housing Ball Joint R.H. Ball Joint L.H. Nut Nylok %-24 Idler Arm and Shaft Arm Clutch Rod Pivot Roll Pin Ys x l!i Pulley - Idler
X
Solt Hex %-16 x 1 % Special Nut Nylok %-16 Rod and Guide Rod - Brake Stud - Clutch Rod Coller Pin Ys x 1 Spring - Clutch Lever and Knob 8rake Pedal - Clutch Lift Lever Plunger Rod Roll Pin ~2 x lK6 Spring Guide - Plunger Rod Cap Plunger Rod Grip - Handle Hairpin Cotter Quadrant
teq·d. Req'd. l-h251 l-h051
I I I 1
2 2 4 4 1 1 6 7 8 8
10 14 19 15
1 , I 6 6 2 2
' 10 10 I I 3 3 I I 4 4 2 2 2 2 2 2 2 2 I 1
, 3 3 1 I I 1 4 4
14 15 I 1 1 1 3 3 I I 1 I 4 4 I 1 2 2 2 2 I 1
, 3 3 3 3 1 1
, 1 I 1 I I I 4 4 I 1 1 1 2 2 1 1 1 1 1 1 1 I I I I 1 3 3 I 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 1 2 2 I I
Ilem Na.
ParI No. Description
Req'd. Req'd. l-h251 1-6051
69 5280 Knob Height Control 1 1 70 8277 Conduit - Cable 1 1 71 1644 Hitch 1 1 72 1647 Pin I 1 73 936125 Snap Ring % Shaft 3 3 74 8272 Spacer 2 2 75 7781 Battery Box 1 1 76 7779 Link - Battery Clamp 1 ' I 77 915111-6 Nut - Nylok X-20 4 4 78 5450 Housing Control Panel 1 1 79 100498 Support - Fuel Tank I I 80 908016-4 Bolt Hex X6-18 x % 7 7 81 960152-4 Bolt Whizlock X-20 x % 4 4 82 5606 Tape - Hood Insulator 1 1 83 5409 8ush ing - Nylon 1 1 84 5439 Grommet - Rubber 'I 1 85 7917 Panel - Complete I 1 86 5442 Speed Nut # 10-16 4 4 87 926374 Screw-Self Top #10-16 4 4 88 935085-4 PI ug - Bullon 1 1 89 100327 Fuel Filter 1 1 90 9212 Fuel Hose 1 1 91 8022* Fuel Tank 1 1 92 8026 Clamp - Tank 1 1 93 1789 Cap - Fuel Tank ,1 1 94 910841-4 Bolt X-20 x 'X 1 1 95 915515-4 Nut Square X-20 1 1 96 8023 Fuel Valve 1 1 97 100088 Hose Fuel 1 1 98 4256 Clip - Hose 3 2 99 920008-4 Washer ~6-18 1 1
100 915662-4 Nut Elastic Stop ~6-1 8 1 1 101 950153 Clamp - Corbin ?{6 Dia. 6 6 102 9653 Engine 10 H.P. Lauson "B" 0 1 103 9651 Engine 12 H,P. Kahler 1 0 104 5189 Spacer - Valve 1 1 105 908036-4 Bolt Hex %-16 x 1 ~ 2 2 106 7467 Base - Engine 0 1 107 8215 Fuel Hose 1 1
108 943335-4 Nipple % Pipe x 5 1 I 109 5222 Elbow 90" 1 1 110 5224 Cap % Pipe 1 1 111 908033-4 Bolt Hex % -16 x Ys 0 2 112 ' 100330 Muffler I 1 113 943364-4 Nipple I" Close Pipe 0 1 114 943026-4 Elbow 1" Pipe x 90" 0 1 115 100329 Clamp I 1 116 100090 Nipple - Special 0 1 117 7466 Pulley - Engine 1 1 118 6507 Key X x X x ~ 1 1 119 7888 Control - Choke "B" Engine 0 1 120 100570 Control - Throttle 0 1 121 100566 Control - Choke 1 0 122 100536 Control - Throttle 1 0 123 920127-4 Lockwasher?{6 2 2 124 1364 Nut - Round ?{6-18 2 2 125 8362 Switch Ignition 1 1 126 7261 Nut Hex Special ?{6-24 1 1 127 920159-4 Lockwasher?{6 1 1 128 5451 Insulator - Switch 1 1 129 7262 Key - Ignition 2 2 130 5480 Cigar Lighter - Complete 1 1 131 5481 Knob and Plug 1 1 132 5483 Shell 1 1 133 5482 Socket 1 1 134 915562 Nut #8 - 32 Brass 2 2 135 920078-4 Lockwasher #8 1 1
Rod Height Control "_l~I-,-_1 _ __13_6 __ -L ___ 2_87_9 ____ -L_C_Ii_p. ____________________ ~_2_~ * See Note Page 9
-7-
www.MyWheelHorse.com
TRACTOR PARTS LIST FOR RAIDER 11 (1-6151) & RAIDER 10 (1-6051)
Item No.
137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199
200 201
See Page 9 for Raider 12 (1.6253)
When ordering parts always list Part No. and name of part.
Parts available only through Authorized Dealers.
rSpecillcotions subject to change without notice.J
Part No.
96015·4 5431 9435 8824 100502 8518 100446 8560 9155 7223 7226 7227 7228 7075 7229 7184 8468 3023 7618 8519 8021 8041 8042 8043 8044 6922 910808·4 915551·4 920079·4 9756 908045·4 920084·4 920040·4 7463 960175·4 7454 7455 7456 900214·4 7464 MW·8863 5977 7617 932008·4 7616 908005·4 7882 7220 960151·4 7611 7879 908182·4 4937 5667 9661 9662 900038·4 915112.4
9663 9664 9665 9699 9766
Description
Screw )~ ·20 x % Whizlack Nut Hex Spetial Y. ·20 Fuse Fused Connector Bat1ery Wiring Harness Wire - Battery to Ground Wiring Harness Cover - Battery Terminal Reflector Housing & Socket Wire and Terminal Spring Bulb (# 1156) Lens
, Screw # 6·32 x % Special Switch Harness Clip Wire
, Connector - Three Wire Clip Toil light Complete Base - Tail Light Cover - Tail light Bulb - Tail light Mounting Pad Connector - Two Wire Bolt Pan Head # 10-32 x Ys Nut Hex # 10·32 lockwasher # 10 Belt Guard Bolt Hex ~6-14 x % lockwasher ?{6 Washer ?{6 U.S, Bracket - Footrest Bait - Whizlock ~6·18 x Yz Footrest R.H. Footrest LH. Bracket - Footrest Anchor 80lt Ca rriage ~6- 18 x % latch - Fender Spring Fender latch Bushing - Nyliner Pin ~6 Rod End Cotter Pin ~l x % Bracket Fender Latch Screw y. -20 x 1 Hex Stop - Fender Latch Cover Plate Bolt Whizlock y. .20 x ~2
Fender , Bushing
Bolt Hex %-24 x % Spacer Bumper - Rubber Seat Base Spacer Bol t Co rriage ~6- 18 x 1 Nul Hex X6-18 Cushion - Seat Cushion - Back Knob - Back Adjusting Hood
5457
900037·4 i
Bracket - Grill Pivot R .H.
Bushing - Hood Hinge Bolt Carrioge X.-1B x %
,
Req·d. Req·d. 1·6251 1·6051
1 1 1 1 1 o 1 1 1 1 2 2 2 1 4 1 1 6 1 3 1 1 1 1 1 1
2 2 2
1 1
1 1 1
5 1 1 2
2 1
1 1
1 3 1 2 1 1 9 1
2
2 2
4 1 2 4
4 1
1 1 1 1
2 4
o o 1 1
1 1 1 o 1 1 2 2
2 1 4 1 1 6 1 3 1 1 1 1 1 1
2 2 2 1
1 1 1
1 5 1 1
2 2 1
1 1 1
3 1 2 1
1
9
1 2
2 2 4 1
2 4 4 1
1
1 1
1 2
4
Item No.
202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223
224 225 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 243 244 245 246 247 248 249 250 251 252 253 254 255 256 257 258 259 260 261 262 263 264 265 266
- 8 -
Part No.
9704 9767 5467 5469 933182 5468 915932.4 5466 5522 5438 5437 6710 933512.4 6712 4497 8174 6714 MW-4564 5432 5433 5434 5435 1004 9797 9652 4999 9792 5435 2844 7747 7420 7469 933215 937014 7896 7468 100000 9994 100190 7183 7472 8138 7421 1813 7473 7661 908046-4 915833 909880-5 4355 2709 4383 6655 6658 6659 9209 6662 6663 5196 936032 5197 5194 6656 4365 6657
,
Denription
Rod - Pivot Bracket Grill Pivol LH. lever - Hood Latch Knob Roll Pin K6 x Ys Roller - Steel Nul High Crown # 10-24 Speed Nut Push On y. Dia. Rod - Hood latch Ornament - Hood Speed Nut Push On Va Dia. Latch and Shaft Hairpin - Cotter Plate - R.H. Mounting Plate - LH . Mounting Bracket and Pin Bushing " E" Ring % Wheel and Tire Complele Wheel Tire 23 x 8.50-12 Valve Lug Bolt Wheel ~6-20 Wheel, Tire and Valve Wheel Ball Bearing Tire 16 x 5.50-8 Valve Washer Hub - Cap Sleering Wheel Insert Roll Pin ~ x 1Y. Key #9 Woodruff Washer - Bowed Callor - Steering Decal - Hood Trim Decal - Raider "12" Decal - Raider 1/10" Decal - Shifl Pattern Decal - Seat lalch Decal - Fender Decal - Steering Wheel Tool Pin IJV U Belt Plale and Rod Boll Hex ~6-14 x 1 Nut Conlok %-16 Sel Screw %-16 x % Clutch Rod Knob Bracket Clutch Plate Complete Race - Bea ring Retainer - Bearing Race HOUSing Clutch Bearing Seal 8011 Bearing Snap Ring 1 % Bore
: Shaft - Clutch Decal - Clutch Adjuslment Plate - Clutch Facing Rivel
Req'd. Req 'd. 1·6251 1-60S1
1 1 1 1 1 , 1 1 1 1 1 2 2 2 2 2 2 1 1 1 1 2 2 I 1 1 1 1 1 1 1
1 1 1 1 1 1
2 I 2 2 2 2 2 2 2
10 , 10 2 2 2 2 4 4 2 2 2 2 2 2 2 2 1 1 1 1
1 1 1 1 1 1 1
2 2 o 1 1 1
1 1
1
2 o 2
1 1 1
1 1
1 1
1 1 1 1
2 2 1 . 0 1 1 1 1 1 1 1 1
1 1
2 2 1 1 1 1 1 1
1
1 1
1 1 1
1 1 1 1
1 1
6 6
www.MyWheelHorse.com
Raider 10 &. 12 Tractors
SUPPLEMENTAL PARTS LIST
Two new Lauson engines, model HH100-115145
"C" (10 h.p.) and model HH120-120129C (12 h.p.),
were introduced into this line as mid year changes.
Raider 10 model number remained 1-6051 as it was
with the HH 1 00-115145 "B" engine. Model number
1-6253 was assigned to the Raider 12 with Lauson
engine to differentiate it from the Raider 12 (1-6251)
with Kohler engine.
The special parts list below applies only to model
1-6253 and model 1-6051 with "C" engine_ For parts
not listed, refer to the 1-6051 column on pages 7 & 8
for both models_ The engine model number is stamped
on a serial plate attached to the engine shroud.
Item No.
8
9
13
111
239
267
268
269
270
Part No.
908034-4
915663-4
920083-4
908033-4
9994
100770
100774
100758
100720
271 100572
272 100427
273 9170
Note from Page 7:
Description
Bolt - Hex %-16 X I
Nut - Elastic Stop % -16
lockwasher %
Bolt - Hex %-16 x Ys Decal - Raider "12"
Engine
Engine
10 H,P, lauson
12 H.P_ lousan
Wiring Harness
Assembly - Choke Control
Req'd, Req'd. 1-6051 1-6253 w/'"("
Eng .
10 10
11 11
14 14
6 6
2 0
o 1
1
I
I
Tank - Fuel 1
o 1
1
I
1
I
Wire - Fuel Tank Hold-Down 1
! 1 , Spring ~ _____ _ __________ • • _ ..1...1 _ L....
When stock of 8022 is exhausted, 100572 Fuel Tank, with 100427 Hold-Down Wire, 9170 Spring and Service Bulletin No. 122 will be furnished,
LITHO IN U, S, A, Revised 3-70 -9- FORM NO_ A-5203
www.MyWheelHorse.com
•
•
Printed in U. S. A. REVISED 3·70 FORM NO. A·5203
www.MyWheelHorse.com
