Enabling open science€¦ · Enabling open science Katarzyna Gaca-Zając, PhD Eng. [email protected]
^GACA AMO-386F€¦ · & Certification IAW NAS-410or EN-4179, Eye NDT written practice, Eye TPM...
Transcript of ^GACA AMO-386F€¦ · & Certification IAW NAS-410or EN-4179, Eye NDT written practice, Eye TPM...
^GACAUuxaJl (jljj hl)<LoLaJl4—Il^JIGeneral Authority of Civil Aviation
Number: AMO-386F
Date: 23 Aug 2017
This certificate is issued to
GA Telesis Engine Services (GATES)whose primary address and contact information is
Teknikontie 5, FIN-01530 VantaaFinland
Upon finding that its organization complies in all respects with the requirements of the
General Authority of Civil Aviation Regulations relating to the establishment of an Air
Agency, and is empowered to operate an approved Repair Station under GACAR Part 145
subject to the ratings, conditions and limitations described in the GACA Operations
Specifications document. This certificate, unless cancelled, suspended, or revoked shall
continue in effect until 23 Nov 2018.
This certificate is not transferable and any changes in the basic facilities, or in the location
thereof, must be immediately reported to the appropriate office ofthe General Authority ofCivil
Aviation.
By direction of t
ABDULLAHXftJBARAK^HAGALG.M. AIRWORTHINESS
AVIATION STANDARDS
GENERAL AUTHORITY OF CIVIL AVIATION
KINGDOM OF SAUDI ARABIA
ACA-SSAT_AW_C_8000-4_V.O (01 MARCH 2016)
RGACAGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
Al. ISSUANCE AND APPLICABILITY.
Template Revision Number: 2.0 Template Release Date: 06/08/2016
These operations specifications are issued to GA Telesis Engine Services (GATES), a GACAR Part
145 repair station, certificate number, AMO-386F. The Repair Station Certificate holder shall conduct
operations in accordance with GACAR Part 145 and these operations specifications at the location
listed below.
The certificate holder's address:
Teknikontie 5, FIN-01530 Vantaa
Finland
b. These operations specifications are issued as part of this Repair Station Certificate, and are in
effect as of the date signed by the President or his representative. This certificate and operations
specifications shall remain in effect until the expiration date, surrendered by the operator, or
terminated by the President, whichever comes first.
GA Telesis Engine Services (GATES) 145.A.001 - 1 Identification No: AMO-386F
^lGACAOUXOJI pljl hil rf ftlnlld i.qIIGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
1. Issued by the General Authority of Civil Aviation.
2. These Operations Specifications are approved by the President.
23 Aug 2017Sulaiafah Al-Hazmi I//, Date
3. I hereby accept and receive the Operations Specifications in this paragraph
GA Telesis Engine Services (GATES) 145.A.001 - 2 Identification No: AMO-386F
UGACAi/uaaII ijl)J_klJJ <3 nip II a 'hqHGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
A3. RATINGS AND LIMITATIONS.
Template Revision Number: 4.0 Template Release Date: 15/02/2017
a. The certificate holder is authorized to perform maintenance, preventative maintenance and
alterations under the limited ratings specified in Tables 1-5 below subject to the provisions of
GACAR Part 145 and the limitations specified:
Authorized
NO
Authorized
YES
YES
YES
Make
Make
GE/ Snecma
General
Electric
Pratt &
Whitney
Table 1 - Airframe Limited Ratings
Model Limitations
Table 2 - Engine Limited Ratings
Model
CFM56-5B/5C,CFM56-7B
CF6-80C2
PW2040
Limitations
Limited to the performance of maintenance, preventive
maintenance, alteration, repair/ overhaul and test.
Maintenance to be accomplished in accordance with
manufacturer's current technical data, air carrier's manual
and /or operator maintenance program or other technical
data acceptable to GACA.
Limited to the performance of maintenance, preventive
maintenance, alteration, repair/ overhaul and test.
Maintenance to be accomplished in accordance with
manufacturer's current technical data, air carrier's manual
and /or operator maintenance program or other technical
data acceptable to GACA.
Limited to the performance of maintenance, preventive
maintenance, alteration, repair/ overhaul and test.
Maintenance to be accomplished in accordance with
manufacturer's current technical data, air carrier's manual
and /or operator maintenance program or other technical
data acceptable to GACA.
GA Telesis Engine Services (GATES)145.A.003 - 1
Identification No: AMO-386F
BGACAijuxaJI gl>i H1J <t_olaJI 4 lifl.llGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
Table 3 - APU Limited Ratings
Authorized Make Model Limitations
NO
Table 4 - Propellar Limited Ratings
Authorized Make Model Limitations
NO
Table 5 - Other Limited Ratings
Authorized Scope of Work Make/Model Limitations
NO INSTRUMENTS
NO RADIO
EQUIPMENT
YES ACCESSORIES From the
accepted
Capability
List, as
Amended.
Limited to the performance of maintenance to those accessories
listed in GA Telsis Engine Services capability list revision 26
dated 15 Nov 2015 as revised and accepted by the GACA.
NO LANDING
GEAR
COMPONENTS
NO FLOATS
YES NON
DESTRUCTIVE
INSPECTION,
TESTING and
PROCESSING
- Liquid Penetrant Inspection - IAW EN4179 / ASTM. E1417- Magnetic Particle Inspection - IAW EN4179 / ASTM. El444- Eddy Current Inspection - IAW EN4179 / GE SPM 70-32 / CFMSPM 70-38
- Ultrasonic Inspection - IAW EN4179 / GE SPM 70-32 / CFM SPM70-35
- Radiographyic Inspection - IAW EN4179 / ASTM El742 / ASTM.E2014
All Non-Destructive Inspection, Testing and Processing listed abovemust be accomplished in accordance with appropriate and currentdata that has been approved or accepted by GACA.
All Non-Destructive Inspection, Testing & Personnel Qualifications& Certification IAW NAS-410 or EN-4179, Eye NDT writtenpractice, Eye TPM section 7 and FANR reg. - X ray.
GA Telesis Engine Services (GATES)145.A.003-2
Identification No: AMO-386F
HGAUAi/uaaJI obi hi) 4_olaJi a 114JIGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
Table 5 - Other Limited Ratings
Authorized Scope of Work Make/Model Limitations
NO EMERGENCY
EQUIPMENT
NO ROTOR
BLADES
NO AIRCRAFT
FABRIC WORK
NO AIRCRAFT
PAINTING
b. The certificate holder is authorized to perform the following specialized services in Table 6below in accordance with the specified specification and subject to the provisions of GACARPart 145 and the limitations specified:
Table 6 - Limited Ratings, Specialized Services
SpecializedService
Specification Limitations
PLATING NA IAW GE SPM 70-45-00/CFM SPM 70-61-00
Welding NA IAW ISO 24394 / AWS D17.1 / GE SPM 70-41 -00 / CFM SPM 70-45-00
Heat treatment NA IAW GE SPM 70-44-00 / CFM SPM 70-49-00
Shot peening NA IAW GE CFM 70-47-00 / CFM SPM 70-52-00
Plasma spray NA IAW GESPM 70-49-00 / CFMSPM 70-48-00
Machining NA IAW GE SPM 70-00-03 / CFM SPM 70-44-00
Painting NA IAW GE SPM 70-43-00 / SPM 70-64-00
Balancing NA IAW Applicable Maintenance Data
GA Telesis Engine Services (GATES)145.A.003-3
Identification No: AMO-386F
UGACAOuxeJI q!>j.HAJ d„oLaJI 4—li^JIGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
1. Issued by the General Authority of Civil Aviation.2. These Operations Specifications are approved by the President.
23 Aug 2017
Sularman Al-Hazm Date
3. I hereby accept and receive the Operations Specifications in this paragraph.
GA Telesis Engine Services (GATES)145.A.003-4
Identification No: AMO-386F
^GACAtjuxoJI ijij' 1-^li 4_olnJI 4__iigJIGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
A6. MANAGEMENT AND DESIGNATEDPERSONNEL
Template Revision Number: 2 Template Release Date: 06/08/2016
a. The certificate holder is authorized the personnel listed in Table 1 below in the GACAR Part
145 required management and designated positions:
Table 1 - Management and Designated Personnel
Position Title Name Company Equivalent Position Title
Accountable Executive Carsten Holm Managing Director
Management Representative Carsten Holm Managing Director
Repair Station Manager Mikko Saviaro Head of Production
Manager of Quality Ville Salonen Quality Manager
GA Telesis Engine Services (GATES) 145.A.006- 1 Identification No: AMO-386F
^GACAiJVJXaJI tjl>ihU 4__oLoJI 4 u-qJIGeneral Authority of Civil Aviation
OPERATIONS SPECIFICATIONS
1. Issued by the General Authority of Civil Aviation.
2. These Operations Specifications are approved by the President.
Sulsuman A
23 Aug 2017
Date
3. I hereby accept and receive the Operations Specifications in this paragraph.
GA Telesis Engine Services (GATES) 145.A.006- 2 Identification No: AMO-386F