Electrical Center Identification Views - JustAnswer · Grounds > Component Locator > Electrical...
Transcript of Electrical Center Identification Views - JustAnswer · Grounds > Component Locator > Electrical...
2004 Chevrolet Tahoe : Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, Relays, Power And
Grounds > Component Locator > Electrical Center Identification Views
Electrical Center Identification Views
ELECTRICAL CENTER IDENTIFICATION VIEWS
Table 1: Fuse Block - Underhood Label Usage
Table 2: Fuse Block - Underhood - C1
Table 3: Fuse Block - Underhood - C2
Table 4: Fuse Block - Underhood - C3
Table 5: Fuse Block - Underhood - C4
Table 6: Fuse Block - Underhood - C5
Table 7: Fuse Block - Underhood - C6
Table 8: Fuse Block - Underhood - C7
Table 9: Fuse Block - Underhood - C9
Table 10: Fuse Block - Left I/P Label Usage
Table 11: Fuse Block - Left I/P - C1
Table 12: Fuse Block - Left I/P - C2
Table 13: Fuse Block - Left I/P - C3
Table 14: Fuse Block - Left I/P - C4
Table 15: Relay Block - Body Label Usage
Table 16: Relay Block - I/P - C1
Table 17: Relay Block - I/P - C3
Table 18: Relay Block - I/P - C4
Table 19: Relay Block - I/P - C7 (Z82 w/Electric Trailer Brake Jumper Installed)
Table 20: Relay Block - I/P - C8 (w/VYU)
Table 21: Relay Block - I/P - C9 (Except Y91)
Table 22: Relay Block - I/P - C10
Table 23: Fuse Block - Right I/P - C1 Wire Entry
Table 24: Fuse Block - Right I/P - C2
Table 25: Fuse Block - Right I/P - C4
Table 26: Fuse Block - Right I/P - C5
Table 27: Fuse Block - Right I/P - C6 (w/CF5 and U01)
Table 28: Fuse Block - Right I/P - C7
Table 29: Fuse Block - Right I/P - C8
Table 30: Junction Block - Rear Lamps - C1
Table 31: Junction Block - Rear Lamps - C2
Table 32: Junction Block - Rear Lamps - C3
Table 33: Junction Block - Rear Lamps - C4
Fuse Block - Underhood Label
Listen
Page 1 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Fuse Block - Underhood Label Usage
Fuse Rating Description
STUD # 1 40A Trailer Wiring, Automatic Level Control (ALC) Compressor Relay
MBEC 1 50A SEAT CB, RT DOOR CB
BLOWER 40A Blower Motor
LBEC 2 50A LOCKS Fuse, DDM Fuse, PDM Fuse, ECC Fuse, AUX PWR 2 Fuse
STUD # 2 30A Trailer Wiring
ABS 60A Electronic Brake Control Module (EBCM)
VSES/ECAS 60A Electronic Brake Control Module (EBCM)
IGN A 40A Ignition Switch RUN, START, RUN/START/ACCY
IGN B 40A Ignition Switch RUN/ACC, RUN/START
LBEC 1 50A FLASH Fuse, TBC 2A Fuse, TBC 2B Fuse, TBC 2C Fuse, LT DOORS Fuse
TRL PARK 15A Trailer Wiring
RR PARK 10A Exterior Lamps - Right Rear, Clearance Lamps - Right
LR PARK 10A Exterior Lamps - Left Rear, Clearance Lamps - Left
PARK LP Relay --TRLR PARK Fuse, LR PARK Fuse, RR PARK Fuse, FRT PARK, INT PARK Fuse,
DRL Relay (Export)
STARTER Relay
-- Starter
INTPARK 10A ID Lamp
STOP LP 25A Stop Lamp Switch
TBC BATT 10A Body Control Module (BCM), PASS-Key Module
SUNROOF 25A Sunroof Relay
SEO B2 30A Roof Beacon Relay
4WS 15ARear Wheel Steering Control Module, Evaporative Emission (EVAP) Canister Vent
Solenoid
RR HVAC 30A HVAC Control Assembly - Rear Auxiliary
Listen
Page 2 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Fuse Rating Description
AUX PWR 20A Accessory Power Outlets, Auxiliary Power Outlets
IGN 1 Relay -- SBA Fuse, ETC/ECM Fuse, PCM 1 Fuse, INJ 1 Fuse, INJ 2 Fuse
PCM 1 15APowertrain Control Module (PCM), Mass Air Flow (MAF) Sensor, Evaporative
Emission (EVAP) Canister Purge Solenoid, Fuel Composition Sensor, Secondary Fuel Pump Relay
ETC/ECM 15A Throttle Actuator Control (TAC)
INJ 1 15A Fuel Injectors - Odd-Numbered, Ignition Coils - Odd-Numbered
INJ 2 15A Fuel Injectors - Even-Numbered, Ignition Coils - Even-Numbered
IGN E 10AA/C COMP Relay, Park/Neutral Position (PNP) Switch, Turn Signal/Multifunction
Switch, Headlamp Leveling Components
RTD 30AAutomatic Level Control (ALC) Compressor, Electronic Suspension Control (ESC)
Module
TRL B/U 10A Body Control Module (BCM), Trailer Wiring, Back-up Alarm
PCM B 20A Powertrain Control Module (PCM)
PRIME F/PMP Relay
-- Fuel Pump
O2A 15A Heated Oxygen Sensors - Before the Catalytic Converter
B/U LP 20A Park/Neutral Position (PNP) Switch
RR DEFOG 30A DEFOG Relay
HDLP - HI Relay
-- HI HDLP - LT Fuse, HI HDLP - RT Fuse
O2B 15A Heated Oxygen Sensors - After the Catalytic Converter
SIR 15AInflatable Restraint Sensing and Diagnostic Module (SDM), Memory Seat Module -
Passenger, Inside Rearview Mirror
FRT PARK 10A Park/Turn Signal Lamps - Front, Marker Lamps - Front
DRL Relay -- DRL Fuse
SEO IGN 10A DEFOG Relay, Instrument Panel Cluster (IPC), Rear Object Sensor Control Module
TBC IGN 1 10A Body Control Module (BCM)
HI HDLP - LT 10A Headlamp - High Beam - Left
LH HID 20A Headlamp Ballast - Left
DRL 10A DRL Relay (Domestic), Daytime Running Lamps (Export)
IPC/DIC 10A Instrument Panel Cluster (IPC)
HVAC/ECAS 10A HVAC Control Module
CIG LTR 15A Cigar Lighter, Data Link Connector (DLC)
HI HDLP - RT 10A Headlamp - High Beam - Right
HDLP - LOW Relay
-- LO HDLP - LT Fuse
A/C COMP Relay
-- A/C Compressor Clutch Assembly
A/C COMP 10A A/C COMP Relay
RR WPR 25A Window Wiper Module - Rear
RADIO 15A Entertainment System Components
SEO B1 15AInstrument Panel Cluster (IPC), Rear Fog Lamp Relay, Overhead Console, Roof
Beacon Switch
LO HDLP - LT 10A Headlamp - Low Beam - Left, Headlamp Ballast - Left
BTSI 10A Stop Lamp Switch
CRANK 10A Powertrain Control Module (PCM)
LO HDLP - RT 10A Headlamp - Low Beam - Right, Headlamp Ballast - Right
FOG LP Relay -- FOG LP Fuse
Listen
Page 3 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Fuse Rating Description
FOG LP 15A FOG LP Relay
HORN Relay -- HORN Fuse
W/S WASH Relay
-- W/S WASH Fuse
W/S WASH 15A W/S WASH Relay
INFO 15AVehicle Communication Interface Module (VCIM), Rear Seat Entertainment (RSE)
Assembly, Remote Playback Device - CD Player
RADIO AMP 30A Audio Amplifier
RH HID 20A Headlamp Ballast - Right
HORN 15A Horn - Left, Horn - Right
EAP 15A Electronic Adjustable Pedals (EAP) Relay
TREC 30A Transfer Case Encoder Motor, Transfer Case Shift Control Module
SBA 15A Supplemental Brake Assist Pump Motor
Fuse Block - Underhood Top View
Click to Enlarge
Fuse Block - Underhood Bottom View
Listen
Page 4 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Fuse Block - Underhood - C1
Click to Enlarge
Connector Part
Information
• 12193905 • 68-Way F Metri-Pack 280 Series Flexlock
(GRY)
Pin Wire Color Circuit No. Function
A1 ORN 3940 Battery Positive Voltage (w/JF4)
A2 -- -- Not Used
A3 YEL 5 Crank Voltage
A4 ORN 2040 Battery Positive Voltage (w/YE9)
A5 ORN 4340 Battery Positive Voltage
A6 PNK 39 Ignition 1 Voltage
A7 YEL 1139 Ignition 1 Voltage
A8 LT GRN/BLK 584 A/T Shift Lock Control Switch Supply Voltage
Listen
Page 5 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part
Information
• 12193905 • 68-Way F Metri-Pack 280 Series Flexlock
(GRY)
Pin Wire Color Circuit No. Function
A9 PNK 3 Ignition 1 Voltage
A10 ORN 1740 Battery Positive Voltage
A11 DK GRN 1433 Not Used
A12BRN 2409 Interior Park Lamps Supply Voltage
BRN 2409 Interior Park Lamps Supply Voltage (w/U01)
B1 ORN 1640 Battery Positive Voltage (w/NP1/NP8/NR4)
B2 ORN 2268 Windshield Washer Relay Control
B3DK GRN/WHT 1317 Fog Lamp Relay Control
DK GRN/WHT 1317 Fog Lamp Relay Control
B4-B7 -- -- Not Used
B8 ORN 1840 Battery Positive Voltage
B9 BLK/WHT 1969Headlamp Relay Control/Headlamp High Beam Relay
Control
B10 -- -- Not Used
B11 ORN 3840 Battery Positive Voltage (w/CF5)
B12 RED 142 Battery Positive Voltage
C1 ORN 1640 Battery Positive Voltage (w/NP8)
C2 ORN 3240 Battery Positive Voltage
C3BLK 28 Horn Relay Control
BLK 28 Horn Relay Control
C4-C8 -- -- Not Used
C9 PNK 1020 Off/Run/Crank Voltage
C10 ORN 1040 Battery Positive Voltage
C11 -- -- Not Used
C12 PPL 420 TCC Brake Switch/Cruise Control Release Signal
D1-D2 -- -- Not Used
D3 PNK/WHT 1970 Headlamp Low Beam Relay Control
D4ORN 340 Battery Positive Voltage
ORN 340 Battery Positive Voltage (w/UQ3/UQ5)
D5ORN 640 Battery Positive Voltage
ORN 640 Battery Positive Voltage
D8-D9 -- -- Not Used
D10 PNK 639 Ignition 1 Voltage
D11 -- -- Not Used
D12ORN 1140 Battery Positive Voltage
ORN 1140 Battery Positive Voltage (w/T89)
E1-E2 -- -- Not Used
E3 LT GRN /BLK 592 DRL Relay Control
E4ORN 4540 Battery Positive Voltage
ORN 4540 Battery Positive Voltage (w/8S8)
E5 -- -- Not Used
E6 BRN/WHT 1571 Traction Control Switch Signal (w/NW7)
E7 LT BLU 1320 CHMSL Supply Voltage/Stop Lamp Supply Voltage
E8-E9 -- -- Not Used
Listen
Page 6 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part
Information
• 12193905 • 68-Way F Metri-Pack 280 Series Flexlock
(GRY)
Pin Wire Color Circuit No. Function
E10 DK BLU 2115 Right Turn Signal Lamps Supply Voltage
E11 ORN 2340 Battery Positive Voltage (w/VYU)
E12 -- -- Not Used
F1 PNK 139 Ignition 1 Voltage
F2 ORN 3740 Battery Positive Voltage
F3 LT BLU 2114 Left Turn Signal Lamps Supply Voltage
F4 -- -- Not Used
F5
PNK 739 Ignition 1 Voltage
PNK 739 Ignition 1 Voltage (w/8S8)
PNK 739 Ignition 1 Voltage (w/Z75)
F6PNK 639 Ignition 1 Voltage (w/o 8S8)
PNK 639 Ignition 1 Voltage
F7 ORN 2840 Battery Positive Voltage (w/o 8S8)
F8-F9 -- -- Not Used
F10 GRY 1524 Backup Lamp Supply Voltage
F11 WHT 1080 Park Lamp Relay Control
F12 ORN 1540 Battery Positive Voltage
Fuse Block - Underhood - C2
Click to Enlarge
Connector Part Information • 12193906 • 68-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
A1-A2 -- -- Not Used
A3 DK GRN 59 A/C Compressor Clutch Supply Voltage
A4-A6 -- -- Not Used
A7 DK GRN/WHT 465 Fuel Pump Relay Control - Primary
A8 -- -- Not Used
A9 PNK 1339 Ignition 1 Voltage
Listen
Page 7 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 12193906 • 68-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
A10 LT BLU 1320 CHMSL Supply Voltage/Stop Lamp Supply Voltage
A11 GRY 1524 Trailer Backup Lamp Supply Voltage
A12PNK 439 Ignition 1 Voltage (w/EVA)
PNK 439 Ignition 1 Voltage (w/L59)
B1-B2 -- -- Not Used
B3BLK/WHT 1695 Axle Switch Signal (w/NP2)
BLK/WHT 1695 Axle Switch Signal (w/NP2)
B4-B6 -- -- Not Used
B7 BLK 550 Ground
B8ORN 440 Battery Positive Voltage - PCM
ORN 440 Battery Positive Voltage - PCM
B9 PNK 1039 Ignition 1 Voltage
B10PNK 439 Ignition 1 Voltage - MAF Sensor
PNK 439 Ignition 1 Voltage - PCM
B11-B12 -- -- Not Used
C1-C2 -- -- Not Used
C3
DK GRN/
WHT 459 A/C Compressor Clutch Relay Control
C4-C9 -- -- Not Used
C10PNK 1039 Ignition 1 Voltage
PNK 1039 Ignition 1 Voltage (w/o L18)
C11 -- -- Not Used
C12 PPL 420 TCC Brake Switch/Cruise Control Release Signal
D1-D2 -- -- Not Used
D3 LT GRN 275 Park Neutral Position Switch Park Signal
D4-D5 -- -- Not Used
D8PNK 539 Ignition 1 Voltage - HO2S Bank 2 Sensor 1
PNK 539 Ignition 1 Voltage - HO2S Bank 1 Sensor 1
D9 PNK 1239 Ignition 1 Voltage
D10PNK 1039 Ignition 1 Voltage - Fuel Injector 1 (w/o L18)
PNK 1039 Ignition 1 Voltage
D11 PPL 6 Starter Solenoid Crank Voltage
D12 YEL/BLK 625 Starter Enable Relay Control
E1-E5 -- -- Not Used
E6PNK 1239 Ignition 1 Voltage - Fuel Injector 2 (w/o L18)
PNK 1239 Ignition 1 Voltage - Fuel Injector 4
E7PNK 1539 Ignition 1 Voltage (All except L18 w/o NC1)
PNK 1539 Ignition 1 Voltage
E8-E9 -- -- Not Used
E10PNK 1239 Ignition 1 Voltage - Fuel Injector 6 (w/o L18)
PNK 1239 Ignition 1 Voltage - Fuel Injector 8 (w/o L18)
E11PNK 1020 Off/Run/Crank Voltage
PNK 1020 Off/Run/Crank Voltage
E12 -- -- Not Used
Listen
Page 8 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 12193906 • 68-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
F1-F2 -- -- Not Used
F3 PPL 806 Crank Voltage
F4-F7 -- -- Not Used
F8 PNK 839 Ignition 1 Voltage
F9 PNK 639 Ignition 1 Voltage
F10 -- -- Not Used
F11 DK GRN 1433 Park/Neutral Start Switch Signal
F12 -- -- Not Used
Fuse Block - Underhood - C3
Click to Enlarge
Connector Part Information • 12193916 • 32-Way F Metri-Pack 280 Series (RED)
Pin Wire Color Circuit No. Function
A1-A2 -- -- Not Used
A3 DK BLU 2115 Right Turn Signal Lamps Supply Voltage
A4ORN 2640 Battery Positive Voltage
ORN 2640 Battery Positive Voltage (w/NYS)
A5 PPL 420 TCC Brake Switch/Cruise Control Release Signal
A6 -- -- Not Used
B1 BLK/WHT 1695 Axle Switch Signal (w/NP2)
B2 ORN 2440 Battery Positive Voltage (w/Z55)
B3 LT BLU 2114 Left Turn Signal Lamps Supply Voltage
B4-B5 -- -- Not Used
B6 BRN 2109 Trailer Park Lamps Supply Voltage
C1 -- -- Not Used
C2LT GRN 1624 Trailer Backup Lamps Supply Voltage
LT GRN 1624 Trailer Backup Lamps Supply Voltage (w/8S3)
C5 -- -- Not Used
C6 BRN/WHT 2609 Right Rear Park Lamps Supply Voltage
Listen
Page 9 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fuses, ...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 12193916 • 32-Way F Metri-Pack 280 Series (RED)
Pin Wire Color Circuit No. Function
D1-D6 -- -- Not Used
E1-E2 -- -- Not Used
E3 PNK 439 Ignition 1 Voltage (w/NQZ)
E4BLK 550 Ground
BLK 550 Ground (w/JH2)
E5-E6 -- -- Not Used
F1GRY 120 Fuel Pump Supply Voltage
GRY 120 Fuel Pump Supply Voltage (w/NQZ)
F2-F3 -- -- Not Used
F4 LT BLU 1320 CHMSL Supply Voltage/Stop Lamp Supply Voltage
F5 -- -- Not Used
F6 BRN 2509 Left Rear Park Lamps Supply Voltage
Fuse Block - Underhood - C4
Click to Enlarge
Connector Part Information • 12193914 • 32-Way F Metri-Pack 280 Series (GRN)
Pin Wire Color Circuit No. Function
A1-A2 -- -- Not Used
A3DK BLU 2115 Right Turn Signal Lamps Supply Voltage
DK BLU 2115 Right Turn Signal Lamps Supply Voltage (w/o Z75)
A4 BLK 550 Ground
A5 -- -- Not Used
A6DK GRN 1329 Horn Fuse Supply Voltage
DK GRN 1329 Horn Fuse Supply Voltage (w/7Z1)
B1 -- -- Not Used
B2DK BLU 545 DRL Supply Voltage
DK BLU 545 DRL Supply Voltage
B3-B6 -- -- Not Used
C1 BRN 2309 Front Park Lamps Supply Voltage (w/Z75)
Listen
Page 10 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 12193914 • 32-Way F Metri-Pack 280 Series (GRN)
Pin Wire Color Circuit No. Function
BRN 2309 Front Park Lamps Supply Voltage (w/VYU)
C2 -- -- Not Used
C5BRN 2309 Front Park Lamps Supply Voltage (w/VYU)
BRN 2309 Front Park Lamps Supply Voltage (w/Z75)
C6 RED 228 Windshield Washer Pump Control
D1 -- -- Not Used
D2 ORN 3540 Battery Positive Voltage (w/TT6)
D3-D5 -- -- Not Used
D6PPL 34 Fog Lamps Supply Voltage (w/T96)
PPL 34 Fog Lamps Supply Voltage (w/T96)
E1LT BLU 2114 Left Turn Signal Lamps Supply Voltage (w/o Z75)
LT BLU 2114 Left Turn Signal Lamps Supply Voltage
E2
DK GRN/
WHT 711 Left Headlamp High Beam Supply Voltage
E3
LT GRN/
BLK 311 Right Headlamp High Beam Supply Voltage
E4-E5 -- -- Not Used
E6 ORN 3640 Battery Positive Voltage (w/TT6)
F1-F3 -- -- Not Used
F4 YEL 712 Left Headlamp Low Beam Supply Voltage
F5 TAN/WHT 312 Right Headlamp Low Beam Supply Voltage
F6 -- -- Not Used
Fuse Block - Underhood - C5
Click to Enlarge
Connector Part Information • 15393171 • 2-Way F J-Type (GRY)
Pin Wire Color Circuit No. Function
A RED 842 Battery Positive Voltage
B RED 542 Battery Positive Voltage
Listen
Page 11 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Fuse Block - Underhood - C6
Click to Enlarge
Connector Part Information • 15393172 • 2-Way F J-Type (LT GRN)
Pin Wire Color Circuit No. Function
A RED 642 Battery Positive Voltage
B -- -- Not Used
Fuse Block - Underhood - C7
Click to Enlarge
Connector Part Information • 15393168 • 2-Way F J-Type (BLK)
Pin Wire Color Circuit No. Function
A RED 342 Battery Positive Voltage
B RED 42 Battery Positive Voltage
Fuse Block - Underhood - C9
Listen
Page 12 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part Information • 15393170 • 2-Way F J-Type (WHT)
Pin Wire Color Circuit No. Function
A RED 442 Battery Positive Voltage
B RED 4042 Battery Positive Voltage (w/VSES)
Fuse Block - Left I/P Label
Click to Enlarge
Fuse Block - Left I/P Label Usage
Fuse Rating Description
RR WPR Fuse 15A Rear Wiper/Washer Switch
SEO ACCY Fuse 10A Upfitter Provisions
WS WPR Fuse 25A Windshield Wiper Motor Module
TBC ACCY Fuse 10A Body Control Module (BCM)
IGN 3 Fuse 10AHVAC Components, Electronic Suspension Control (ESC) Components, Heated
Seat Modules - Rear, Rear Wheel Steering Control Module
4WD Fuse 15A Front Axle Actuator, Transfer Case Shift Control Switch
HTR/AC Fuse 30A HVAC Control Module
Listen
Page 13 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Fuse Rating Description
LOCK Relay -- Door Lock Actuator - Liftgate, Door Latch Assembly - LR/RR
HVAC 1 Fuse 10A HVAC Control Module, HVAC Actuators
L DOOR 12-WAY - BLACK
-- Fuse Block - Left I/P C4 (Driver Door Harness)
CRUISE Fuse 10A Cruise Control Switch, Steering Wheel Speed/Position Sensor
UNLOCK Relay -- Door Lock Actuator - Liftgate, Door Latch Assembly - LR/RR
RR FOG LP Relay -- Rear Fog Lamps (Export)
BRAKE Fuse 10AStop Lamp Switch, Electronic Brake Control Module (EBCM), Traction Control
Switch
DRIVER UNLOCK Relay
-- Not Used
PDM Fuse 10A Front Passenger Door Module (FPDM)
IGN 0 Fuse 10A Passlock Sensor, Automatic Transmission, Powertrain Control Module (PCM)
TBC IGN 0 Fuse 10A Body Control Module (BCM)
VEH CHMSL Fuse 10A Center High Mounted Stop Lamp (CHMSL)
LT TRLR ST/TRN Fuse
10A Trailer Wiring
LT TRN Fuse 10ATurn Signal Lamps - Left, Marker Lamps - Left, Driver Door Module (DDM),
Instrument Panel Cluster (IPC)
VEH STOP Fuse 15A Tail/Stop and Turn Signal Lamps - Rear, Throttle Actuator Control (TAC)
BODY 12-WAY BROWN
-- Fuse Block - Left I/P C3 (Body Harness)
RT TRLR ST/TRN Fuse
10A Trailer Wiring
RT TRN Fuse 10ATurn Signal Lamps - Right, Marker Lamps - Right, Front Passenger Door Module
(FPDM), Instrument Panel Cluster (IPC)
DDM Fuse 15A Driver Door Module (DDM)
AUX PWR 2 Fuse 20A Accessory Power Outlet - D-Pillar
LOCKS Fuse 20A Door Lock/Unlock Relays
ECC Fuse 10A HVAC Control Assembly - Rear Auxiliary
TBC 2C Fuse 15A Body Control Module (BCM)
FLASH Fuse 25A Turn Signal/Hazard Flasher Module
CB LT DOORS 25A Window Switch - LR, Driver Door Module (DDM)
TBC 2B Fuse 15A Body Control Module (BCM)
TBC 2A Fuse 15A Body Control Module (BCM)
Fuse Block - Left I/P Top View
Listen
Page 14 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Fuse Block - Left I/P Bottom View
Click to Enlarge
Fuse Block - Left I/P - C1
Listen
Page 15 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part Information • 12193906 • 68-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
A1 -- -- Not Used
A2 GRY/BLK 255 Power Door Lock Fuse Supply Voltage
A3 -- -- Not Used
A4 TAN/BLK 254 Power Door Unlock Fuse Supply Voltage
A5 -- -- Not Used
A6 DK BLU 2115 Right Turn Signal Lamps Supply Voltage
A7 ORN 4240 Battery Positive Voltage
A8 YEL 1618 Trailer Left Rear Turn/Stop Lamp Supply Voltage
A9 DK GRN 1619 Trailer Right Rear Turn/Stop Lamp Supply Voltage
A10 -- -- Not Used
A11DK BLU 2115 Right Turn Signal Lamps Supply Voltage
DK BLU 2115 Right Turn Signal Lamps Supply Voltage
A12 RED 42 Battery Positive Voltage
B1 YEL 143 Accessory Voltage
B2 YEL 43 Accessory Voltage
B3YEL 1977 Rear Fog Lamp Relay Control (w/T96)
YEL 1977 Rear Fog Lamp Relay Control (w/T96)
B4-B7 -- -- Not Used
B8 WHT 17 Stop Lamp Switch Signal
B9-B11 -- -- Not Used
B12 ORN 2140 Battery Positive Voltage
C1 -- -- Not Used
C2 BRN 141 Ignition 3 Voltage (w/CJ3)
C3 -- -- Not Used
C4 BRN 41 Ignition 3 Voltage
C5 BRN 441 Ignition 3 Voltage (w/JL4-NR4)
C8 LT BLU 1620 Trailer CHMSL Supply Voltage
C9-C12 -- -- Not Used
D1 YEL 243 Accessory Voltage
Listen
Page 16 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 12193906 • 68-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
D2 -- -- Not Used
D3BRN 341 Ignition 3 Voltage
BRN 341 Ignition 3 Voltage
D4 -- -- Not Used
D5BRN 441 Ignition 3 Voltage
BRN 441 Ignition 3 Voltage
D8-D9 -- -- Not Used
D10 BLK/WHT 1851 Ground
D11 -- -- --
D12 BRN 541 Ignition 3 Voltage (906 w/NYS)
E1 -- -- Not Used
E2BRN 241 Ignition 3 Voltage (w/NP1/NP2/NP8)
BRN 241 Ignition 3 Voltage (w/NP1/NP2/NR4)
E3 RED 122 Rear Fog Lamp Supply Voltage (w/T96)
E4GRY 118 Left Front Door Speaker Output (-)
GRY 118 Left Front Tweeter Speaker Output (-) (UQ7 w/Y91)
E5 BRN 1046 DDM Class 2 Serial Data
E6 -- -- Not Used
E7 PNK 1691 Automatic Day/Night Mirror Low Reference (w/DL3)
E8 WHT 530 Ignition 0 Voltage
E9 ORN 4540 Battery Positive Voltage-Export Only
E10 RED 842 Battery Positive Voltage
E11 ORN 4040 Battery Positive Voltage
E12 ORN 2240 Battery Positive Voltage
F1 YEL 343 Accessory Voltage (w/E52)
F2 -- -- Not Used
F3LT BLU 2114 Left Turn Signal Lamps Supply Voltage
LT BLU 2114 Left Turn Signal Lamps Supply Voltage
F4 GRY 1690 Automatic Day/Night Mirror Signal (w/DL3)
F5TAN 201 Left Front Door Speaker Output (+)
TAN 201 Left Front Tweeter Speaker Output (+) (UQ7 w/Y91)
F6 BLK 1050 Ground
F7 BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/o YE9)
F8 PNK 1020 Off/Run/Crank Voltage
F9LT BLU 1320 CHMSL Supply Voltage/Stop Lamp Supply Voltage
LT BLU 1320 CHMSL Supply Voltage/Stop Lamp Supply Voltage (w/T89)
F10-F12 -- -- Not Used
Fuse Block - Left I/P - C2
Listen
Page 17 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part
Information
• 12193930 • 6-Way F Metri-Pack 280 Series Flexlock
(BLK)
Pin Wire Color Circuit No. Function
A ORN 300 Ignition 3 Voltage
B LT GRN 1427 Right Turn Signal Switch Signal
C DK GRN 1428 Left Turn Signal Switch Signal
D WHT 111 Hazard Switch Signal
E WHT 1390 Off/Run/Crank Voltage
F BRN 4 Accessory Voltage
Fuse Block - Left I/P - C3
Listen
Page 18 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part Information • 12194035 • 12-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
A BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/o YE9)
B -- -- Not Used
C ORN 1240 Battery Positive Voltage
D BLK 1050 Ground
E -- -- Not Used
F ORN 4140 Battery Positive Voltage
GTAN 201 Left Front Speaker Output (+) (w/UQ3)
TAN 201 Left Front Speaker Output (+)
H PNK 1691 Automatic Day/Night Mirror Low Reference (w/DL3)
J BRN 1046 DDM Class 2 Serial Data
K GRY 1690 Automatic Day/Night Mirror Signal (w/DL3)
LGRY 118 Left Front Speaker Output (-) (w/UQ3)
GRY 118 Left Front Speaker Output (-)
M LT BLU 2114 Left Turn Signal Lamps Supply Voltage
Fuse Block - Left I/P - C4
Listen
Page 19 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part
Information
• 15328768 • 12-Way F Metri-Pack 280 Series Flexlock
(BRN)
Pin Wire Color Circuit
No.
Function
A -- -- Not Used
B BRN 541 Ignition 3 Voltage
CBRN 541 Ignition 3 Voltage (w/Z75)
BRN 541 Ignition 3 Voltage
D ORN 3140 Battery Positive Voltage (w/CJ2)
ETAN 294 Door Lock Actuator Unlock Control
TAN 294 Door Lock Actuator Unlock Control
F TAN 294Door Lock Actuator Unlock Control (All Except Avalanche
Escalade EXT)
G ORN 3040 Battery Positive Voltage
H LT BLU 1620 Trailer CHMSL Supply Voltage
J -- -- Not Used
KGRY 295 Left Rear Door Lock Actuator Lock Control
GRY 295 Right Rear Door Lock Actuator Lock Control
L GRY 295 Door Lock Actuator Lock Control
M ORN 1240 Battery Positive Voltage
Relay Block - Body Label
Listen
Page 20 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Relay Block - Body Label Usage
Fuse Rating Description
SEO - 6-WAY - BLK
-- Relay Block - Body C8
TRAILER - 6-WAY - BRN
-- Relay Block - Body C7
UPFIT - 4-WAY - CRM
-- Trailer Provisions
SL RIDE - 6-WAY - GRY
-- Relay Block - Body C5
HDLNR 2 - 6-WAY - CRM
-- Relay Block - Body C4
BODY - 12-WAY - WHT
-- Relay Block - Body C10
DEFOG Relay -- RR DEFOG Fuse
HDLNR 1 - 12-WAY - BRN
-- Relay Block - Body C3
SPARE - RELAY -- Not Used
CB - SEAT 30ASeat Adjuster Switch - Driver, Memory Seat Module, Lumbar Bolster Switch -
Front Passenger, Seat Adjuster Switch - Front Passenger
CB - RT DOOR 25A Front Passenger Door Module (FPDM), Window Switch - RR
SPARE - 4-WAY - GRY
-- Not Used
INFO - 12-WAY - BLK
-- Relay Block - Body C9
Listen
Page 21 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Relay Block - Body Top View
Click to Enlarge
Relay Block - Body Bottom View
Click to Enlarge
Relay Block - I/P - C1
Listen
Page 22 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part
Information
• 12193905 • 68-Way F Metri-Pack 280 Series Flexlock
(GRY)
Pin Wire Color Circuit No. Function
A1LT GRN 24 Backup Lamp Supply Voltage - BCM
LT GRN 24 Backup Lamp Supply Voltage - Junction Block - Rear
A2 -- -- Not Used
A3 BLK/WHT 1704 Low Reference
A4
DK GRN/
WHT 636 Ambient Air Temperature Sensor Signal
A5BLK/WHT 1851 Ground
BLK/WHT 1851 Ground
A6 WHT 193 Rear Defog Relay Control
A7 -- -- Not Used
A8BRN/WHT 230 Instrument Panel Lamps Dimming Control
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/Y91)
A9 YEL 1139 Ignition 1 Voltage
A10 -- -- Not Used
A11BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/NP1/NP8/NR4)
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/VSES)
A12 GRY/BLK 690 Courtesy Lamp Supply Voltage
B1 PNK 1045 Serial Communications Circuit (w/o Y91)
B2 ORN 3740 Battery Positive Voltage (UQ7 w/o Y91)
B3BLK/WHT 1851 Ground
BLK/WHT 1851 Ground
B4 -- -- Not Used
B5BLK/WHT 1851 Ground
BLK/WHT 1851 Ground
B6 ORN 1840 Battery Positive Voltage
B7 RED 642 Battery Positive Voltage
B8 BRN/WHT 230 Instrument Panel Lamps Dimming Control
Listen
Page 23 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part
Information
• 12193905 • 68-Way F Metri-Pack 280 Series Flexlock
(GRY)
Pin Wire Color Circuit No. Function
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/JL4)
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/NYS)
B9DK GRN/WHT 817 Vehicle Speed Signal (UQ7 w/Y91)
DK GRN/WHT 817 Vehicle Speed Signal
B10 -- -- Not Used
B11 ORN 3240 Battery Positive Voltage (w/o Y91)
B12 -- -- Not Used
C1 ORN 340 Battery Positive Voltage (w/YE9)
C2BRN/WHT 230 Instrument Panel Lamps Dimming Control
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/YE9)
C3BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/YE9)
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/U1S)
C4 ORN 1732 Inadvertent Power Supply Voltage
C5 BLK/WHT 1851 Ground
C8BRN/WHT 230 Instrument Panel Lamps Dimming Control
BRN/WHT 230 Instrument Panel Lamps Dimming Control
C9 ORN 1340 Battery Positive Voltage
C10 BRN 2409 Interior Park Lamps Supply Voltage
C11
ORN 1732 Inadvertent Power Supply Voltage (w/Y91)
ORN 1732Inadvertent Power Supply Voltage (Avalanche/Escalade
EXT)
C12 -- -- Not Used
D1 WHT/BLK 5515 Inside Air Temperature Sensor Assembly Control (w/CJ2)
D2 BRN/WHT 230 Instrument Panel Lamps Dimming Control
D3BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/T89/-Y91)
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/UM8)
D4 ORN 1732 Inadvertent Power Supply Voltage
D5BLK/WHT 1851 Ground
BLK/WHT 1851 Ground (w/U42)
D8BLK/WHT 1851 Ground
BLK/WHT 1851 Ground (w/Y91)
D9 BLK 1050 Ground
D10 BRN 2409 Interior Park Lamps Supply Voltage (906 w/NYS)
D11 -- -- Not Used
D12 ORN 2340 Battery Positive Voltage (w/VYU)
E1 BRN 718 Low Reference (w/CJ2)
E2 PNK 1691 Automatic Day/Night Mirror Low Reference (w/DL3)
E3 -- -- Not Used
E4PPL/WHT 1382 LED Dimming Signal
PPL/WHT 1382 LED Dimming Signal (w/NP1/NP8/NR4)
E5BLK/WHT 1851 Ground (w/AU3/-YE9)
BLK/WHT 1851 Ground (w/UQ7/Y91)
E6DK GRN/WHT 817 Vehicle Speed Signal
DK GRN/WHT 817 Vehicle Speed Signal (w/NYS)
Listen
Page 24 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part
Information
• 12193905 • 68-Way F Metri-Pack 280 Series Flexlock
(GRY)
Pin Wire Color Circuit No. Function
E7PPL/WHT 1382 LED Dimming Signal
PPL/WHT 1382 LED Dimming Signal
E8BLK/WHT 1851 Ground - BCM - C2
BLK/WHT 1851 Ground - BCM - C3
E9 -- -- Not Used
E10 RED 242 Battery Positive Voltage
E11-E12 -- -- Not Used
F1 DK GRN 734 Inside Air Temperature Sensor Signal (w/CJ2)
F2 GRY 1690 Automatic Day/Night Mirror Signal (w/DL3)
F3 PNK 739 Ignition 1 Voltage
F4 TAN/WHT 1384 Selective Ride Control Switch Signal
F5BLK/WHT 1851 Ground (w/NP1/NP8)
BLK/WHT 1851 Ground (w/U2K/U2L & Y91)
F6PPL/WHT 1382 LED Dimming Signal (w/Z75 or T79)
PPL/WHT 1382 LED Dimming Signal (w/NYS)
F7ORN 4540 Battery Positive Voltage
ORN 4540 Battery Positive Voltage (w/ T79)
F8BLK/WHT 1851 Ground (w/ Y91)
BLK/WHT 1851 Ground (Export Only)
F9 LT BLU 1620 Trailer CHMSL Supply Voltage
F10 DK BLU 47 Trailer Auxiliary Supply Voltage (w/o LU3)
F11 YEL 243 Accessory Voltage
F12 -- -- Not Used
Relay Block - I/P - C3
Click to Enlarge
Listen
Page 25 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part
Information
• 15328768 • 12-Way F Metri-Pack 280 Series Flexlock
(BRN)
Pin Wire Color Circuit No. Function
A LT GRN 24 Backup Lamp Supply Voltage
B ORN 4540 Battery Positive Voltage
C BLK 1050 Ground
D -- -- Not Used
E YEL 1139 Ignition 1 Voltage
F DK GRN 2308 Passenger Air Bag OFF Indicator Control (w/ALO)
G BLK/WHT 1704 Low Reference (w/YE9)
H DK BLU 2307 Passenger Air Bag ON Indicator Control (w/ALO)
J -- -- Not Used
K DK GRN/WHT 636 Ambient Air Temperature Sensor Signal (w/YE9)
LGRY/BLK 690 Courtesy Lamp Supply Voltage
GRY/BLK 690 Courtesy Lamp Supply Voltage (Avalanche/Escalade EXT)
M ORN 1732 Inadvertent Power Supply Voltage
Relay Block - I/P - C4
Click to Enlarge
Connector Part
Information
• 12193922 • 6-Way F Metri-Pack 280 Series Flexlock
(CRM)
Pin Wire Color Circuit No. Function
ABRN/WHT 230 Instrument Panel Lamps Dimming Control (w/YE9)
BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/C36 or C69)
B PNK 1691 Automatic Day/Night Mirror Low Reference (w/DL3)
C GRY 1690 Automatic Day/Night Mirror Signal (w/DL3)
D DK GRN 734 Inside Air Temperature Sensor Signal (w/CJ2)
Listen
Page 26 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part
Information
• 12193922 • 6-Way F Metri-Pack 280 Series Flexlock
(CRM)
Pin Wire Color Circuit No. Function
E BRN 718 Low Reference (w/CJ2)
F WHT/BLK 5515 Inside Air Temperature Sensor Assembly Control (w/CJ2)
Relay Block - I/P - C7 (Z82 w/Electric Trailer Brake Jumper Installed)
Click to Enlarge
Connector Part
Information
• 12193924 • 6-Way F Metri-Pack 280 Series Flexlock
(BRN)
Pin Wire Color Circuit No. Function
A BRN 2409 Interior Park Lamps Supply Voltage
B RED 242 Battery Positive Voltage
C DK BLU 47 Trailer Auxiliary Supply Voltage
D LT BLU 1620 Trailer CHMSL Supply Voltage
E -- -- Not Used
F BLK 1050 Ground
Relay Block - I/P - C8 (w/VYU)
Listen
Page 27 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part Information • 12193930 • 6-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
A ORN 2340 Battery Positive Voltage
B-D -- -- Not Used
E ORN 4540 Battery Positive Voltage
F BLK 1050 Ground
Relay Block - I/P - C9 (Except Y91)
Click to Enlarge
Listen
Page 28 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 12194035 • 12-Way F Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
A -- -- Not Used
B PNK 1045 Serial Communications Circuit
C -- -- Not Used
D ORN 3740 Battery Positive Voltage (UQ7)
EORN 340 Battery Positive Voltage (w/UK6)
ORN 340 Battery Positive Voltage (w/U2K/U2L)
F-G -- -- Not Used
HORN 3240 Battery Positive Voltage (w/UE1)
ORN 3240 Battery Positive Voltage (w/UE1)
J ORN 3240 Battery Positive Voltage (w/U42)
KBLK/WHT 1851 Ground (UE1)
BLK/WHT 1851 Ground (w/U42)
L BLK/WHT 1851 Ground (w/UE1)
MBLK/WHT 1851 Ground (UQ7)
BLK/WHT 1851 Ground (w/U2K/U2L)
Relay Block - I/P - C10
Click to Enlarge
Connector Part
Information
• 15357030 • 12-Way F Metri-Pack 280 Series Flex-Lock
(WHT)
Pin Wire Color Circuit No. Function
AORN 4540 Battery Positive Voltage - LR Heated Seat Module (w/Y91)
ORN 4540 Battery Positive Voltage - RR Heated Seat Module (w/Y91)
B GRY/BLK 690 Courtesy Lamp Supply Voltage (Suburban/Escalade ESV)
CGRY/BLK 690 Courtesy Lamp Supply Voltage - LR Door
GRY/BLK 690 Courtesy Lamp Supply Voltage - RR Door
D DK GRN 2308 Passenger Air Bag OFF Indicator Control (w/ALO)
E ORN 1440 Battery Positive Voltage
F BRN/WHT 230 Instrument Panel Lamps Dimming Control
Listen
Page 29 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part
Information
• 15357030 • 12-Way F Metri-Pack 280 Series Flex-Lock
(WHT)
Pin Wire Color Circuit No. Function
BRN/WHT 230 Instrument Panel Lamps Dimming Control
G DK BLU 2307 Passenger Air Bag ON Indicator Control (w/ALO)
H ORN 1440 Battery Positive Voltage
J DK GRN/WHT 817 Vehicle Speed Signal (w/Z75)
K ORN 1340 Battery Positive Voltage
L PPL 293 Rear Defog Element Supply Voltage
MYEL 1139 Ignition 1 Voltage
YEL 1139 Ignition 1 Voltage (w/ALO)
Fuse Block - Right I/P Top View
Click to Enlarge
Fuse Block - Right I/P Bottom View
Click to Enlarge
Fuse Block - Right I/P - C1 Wire Entry
Listen
Page 30 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 15401495 • 48-Way M Metri-Pack 280 Series (BLK)
Pin Wire Color Circuit No. Function
2ADK GRN 117 Right Front Speaker Output (-)
DK GRN 117 Right Front Speaker Output (-) (UQ7 w/Y91)
2BLT GRN 200 Right Front Speaker Output (+)
LT GRN 200 Right Front Speaker Output (+) (UQ7 w/Y91)
2C-2E -- -- Not Used
2F BLK 1050 Ground
4A BLK 1050 Ground
4BORN 52 Blower Motor High Control (w/CJ3)
GRY/BLK 2337 Lower Right Air Temperature Sensor Signal (w/CJ2)
4CPPL 73 Medium 3 Blower Motor Control (w/CJ3)
BRN 718 Low Reference (w/CJ2)
4D RED 542 Battery Positive Voltage
4ETAN 63 Auxiliary Blower Motor Medium 1 Control (w/CJ3)
PPL 1838 Recirculation Door Position Signal (w/CJ2)
4F PPL/WHT 760 Auxiliary Front Blower Motor Switch Signal (w/CJ2)
4G YEL 60 Blower Motor Low Control (w/CJ3)
4H -- -- Not Used
4J LT BLU/BLK 1688 5-Volt Reference (w/CJ2)
4K LT BLU 72 Medium 2 Blower Motor Control (w/CJ3)
4L YEL 1791 Low Reference (w/CJ2)
4M -- -- --
5A -- -- --
5B LT GRN 2275 Mode Door Position Signal (w/CJ2)
5C TAN 2273 Mode Door Control (w/CJ2)
5D DK BLU 1199 Left Air Temperature Door Control (w/CJ2)
5E LT BLU 733 Left Air Temperature Door Position Signal (w/CJ2)
5F -- -- Not Used
6A ORN 3840 Battery Positive Voltage (w/CF5)
6B BRN 2409 Interior Park Lamps Supply Voltage
6C BLK 1050 Ground
6D DK BLU 1353 RAP Supply Voltage (w/CF5)
6E BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/CF5)
6F -- -- Not Used
7A -- -- Not Used
7B TAN 1047 PDM Class 2 Serial Data
7C ORN 4240 Battery Positive Voltage
7D -- -- Not Used
7E ORN 1340 Battery Positive Voltage
7F DK BLU 2115 Right Turn Signal Lamps Supply Voltage
8A WHT/BLK 2339 Lower Left Air Temperature Sensor Signal (w/CJ2)
8B -- -- Not Used
8C BRN 341 Ignition 3 Voltage
8D DK BLU 1646 Right Air Temperature Door Position Signal (w/CJ2)
8E WHT/BLK 1236 Right Air Temperature Door Control (w/CJ2)
8F DK GRN 1614 Recirculation Door Control (w/CJ2)
Listen
Page 31 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Fuse Block - Right I/P - C2
Click to Enlarge
Connector Part
Information
• 12193930 • 6-Way F Metri-Pack 280 Series Flexlock
(BLK)
Pin Wire Color Circuit No. Function
ADK GRN 117 Right Front Speaker Output (-)
DK GRN 117 Right Front Speaker Output (-) (w/UQ3)
BLT GRN 200 Right Front Speaker Output (+)
LT GRN 200 Right Front Speaker Output (+) (w/UQ3)
C-E -- -- Not Used
FBLK 1050 Ground
BLK 1050 Ground (w/o YE9)
Fuse Block - Right I/P - C4
Listen
Page 32 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part
Information
• 12194037 • 12-Way F Metri-Pack 280 Series Flexlock
(BRN)
Pin Wire Color Circuit
No.
Function
A BLK 1050 Ground
BGRY/BLK 2337 Lower Right Air Temperature Sensor Signal (w/CJ2)
ORN 52 Blower Motor High Control (w/CJ3)
C
BRN 718Low Reference - Air Temperature Sensor - Lower Left
(w/CJ2)
BRN 718Low Reference - Air Temperature Sensor - Lower Right
(w/CJ2)
PPL 73 Medium 3 Blower Motor Control (w/CJ3)
D RED 542 Battery Positive Voltage
EPPL 1838 Recirculation Door Position Signal (w/CJ2)
TAN 63 Auxiliary Blower Motor Medium 1 Control (w/CJ3)
F PPL/WHT 760 Blower Motor Speed Control (w/CJ2)
G YEL 60 Blower Motor Low Control (w/CJ3)
HLT BLU/BLK 1688 5-Volt Reference - Air Temperature Actuator - Left (w/CJ2)
LT BLU/BLK 1688 5-Volt Reference - Air Temperature Actuator - Right (w/CJ2)
JLT BLU/BLK 1688 5-Volt Reference - Mode Actuator (w/CJ2)
LT BLU/BLK 1688 5-Volt Reference - Recirculation Actuator (w/CJ2)
K -- -- Not Used
LYEL 1791 Low Reference - Recirculation Actuator (w/CJ2)
YEL 1791 Low Reference - Mode Actuator (w/CJ2)
MYEL 1791 Low Reference - Air Temperature Actuator - Left (w/CJ2)
YEL 1791 Low Reference - Air Temperature Actuator - Right (w/CJ2)
Fuse Block - Right I/P - C5
Listen
Page 33 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part
Information
• 12193924 • 6-Way F Metri-Pack 280 Series Flexlock
(BRN)
Pin Wire Color Circuit No. Function
A -- -- Not Used
B LT GRN 2275 Mode Door Position Signal (w/CJ2)
C TAN 2273 Mode Door Control (w/CJ2)
D DK BLU 1199 Left Air Temperature Door Control (w/CJ2)
E LT BLU 733 Left Air Temperature Door Position Signal (w/CJ2)
F -- -- Not Used
Fuse Block - Right I/P - C6 (w/CF5 and U01)
Click to Enlarge
Connector Part
Information
• 12193929 • 6-Way F Metri-Pack 280 Series Flexlock (LT
GRN)
Pin Wire Color Circuit No. Function
A ORN 3840 Battery Positive Voltage (w/CF5)
B BRN 2409 Interior Park Lamps Supply Voltage (w/U01)
C
BLK 1050 Ground (w/CF5)
BLK 1050 Ground (w/CF5)
BLK 1050 Ground (w/NYS)
D DK BLU 1353 RAP Supply Voltage (w/CF5)
E BRN/WHT 230 Instrument Panel Lamps Dimming Control (w/CF5)
F -- -- Not Used
Fuse Block - Right I/P - C7
Listen
Page 34 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part
Information
• 12193922 • 6-Way F Metri-Pack 280 Series Flexlock
(CRM)
Pin Wire Color Circuit No. Function
A -- -- Not Used
B TAN 1047 PDM Class 2 Serial Data
C ORN 4240 Battery Positive Voltage
D -- -- Not Used
E ORN 1340 Battery Positive Voltage
F DK BLU 2115 Right Turn Signal Lamps Supply Voltage
Fuse Block - Right I/P - C8
Listen
Page 35 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part
Information
• 12193928 • 6-Way F Metri-Pack 280 Series Flexlock
(GRY)
Pin Wire Color Circuit No. Function
A WHT/BLK 2339 Lower Left Air Temperature Sensor Signal (w/CJ2)
BBRN 341 Ignition 3 Voltage (w/CJ2)
BRN 341 Ignition 3 Voltage (w/CJ2)
CBRN 341 Ignition 3 Voltage (w/CJ2)
BRN 341 Ignition 3 Voltage (w/CJ2)
D DK BLU 1646 Right Air Temperature Door Position Signal (w/CJ2)
E WHT/BLK 1236 Right Air Temperature Door Control (w/CJ2)
F DK GRN 1614 Recirculation Door Control (w/CJ2)
Junction Block - Rear
Listen
Page 36 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Junction Block - Rear Lamps - C1
Click to Enlarge
Connector Part Information • 15305595 • 8-Way F GT 280 Sealed (BLU)
Pin Wire Color Circuit No. Function
A LT BLU 2114 Left Turn Signal Lamps Supply Voltage
B LT BLU 1320 Stop Lamp Supply Voltage
C LT GRN 24 Backup Lamp Supply Voltage
D BRN/WHT 2609 Right Rear Park Lamps Supply Voltage
E BLK 1750 Ground
F -- -- Not Used
G BRN 2509 Left Rear Park Lamps Supply Voltage
H DK BLU 2115 Right Turn Signal Lamps Supply Voltage
Junction Block - Rear Lamps - C2
Click to Enlarge
Listen
Page 37 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Connector Part Information • 15305596 • 7-Way F GT 280 Series (GRY)
Pin Wire Color Circuit No. Function
A BLK 1750 Ground
B BLK 1750 Ground
C BLK 1750 Ground
D LT BLU 1320 CHMSL Supply Voltage/Stop Lamp Supply Voltage
E BRN 2509 Left Rear Tail Lamps Supply Voltage
F LT GRN 24 Backup Lamp Supply Voltage
G -- -- Not Used
H LT BLU 2114 Left Turn Signal Lamps Supply Voltage
Junction Block - Rear Lamps - C3
Click to Enlarge
Connector Part Information • 15305599 • 8-Way F GT 280 Series (BRN)
Pin Wire Color Circuit No. Function
A BRN/WHT 2609 Right Rear Park Lamps Supply Voltage
B -- -- Not Used
C BLK 1750 Ground
D BLK 1750 Ground (906 w/NYS)
E BLK 1750 Ground (906 and NYS)
F -- -- Not Used
G BRN 2509 Left Rear Park Lamps Supply Voltage
H BLK 1750 Ground
Junction Block - Rear Lamps - C4
Listen
Page 38 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...
Click to Enlarge
Connector Part Information • 15305597 • 7-Way F GT 280 Series (BLK)
Pin Wire Color Circuit No. Function
A LT BLU 1320 Stop Lamp Supply Voltage
B BRN/WHT 2609 Right Rear Park Lamps Supply Voltage
C BLK 1750 Ground
D BLK 1750 Ground
E LT GRN 24 Backup Lamp Supply Voltage
F DK BLU 2115 Right Turn Signal Lamps Supply Voltage
G -- -- Not Used
H BLK 1750 Ground
Listen
Page 39 of 392004 Chevrolet Tahoe - Chassis Electrical > Fuses, Relays, Power And Grounds > Fus...
9/20/2015http://content.chiltonsonline.com/(S(atonzd45u0rn4a2gwbbysg45)F(ovHEroP-FjDOTIN-_...