SOWARDSCURRIE

AGUILAARCHITECTS

Architects, Planners& Interior Designers

MURRAY E. NELSON

GOVERNMENT AND

CULTURAL CENTER

MONROE COUNTY, FL

GENERATOR DESIGN

TO: Monroe County Fleet Management3583 S. Roosevelt Blvd Quotation # PS24165QKey West, FL 33040- March 18, 2014Tel: (305)-292-3571 Fax: (305)-292-3529Attn: Mr. Roy Sanchez

We are pleased to offer this Quotation as detailed below

Amount Description Each Extended

1 54,900 54,900

Under FSA Contract No. 13-11-0904, Spec #49 "Low Bid"

1 48,580 48,580

Vibration Isolation Mounts

element to be serviced without draining all of engine coolant.Overflow see through containment container mounted and installed.

equipped with four (4) area service lights that are prewired to a 0-60 D.c timer.

Breaker is prewired to single 1200amp compression lug connection box with safety shut-offswitch which will shut the unit down and open the breaker if door is open while running.

Trailer and subbase shall be finished painted a two part epoxy paint that will help protectcomponents from earlier failure due to corrosion. Standard 7 pin connector and reverseelectric dump valve.

One (1) 50amp, 120/240vac, 1ph receptacle. Each receptacle is protected by a singlebreaker located in the load center.

One complete operation and maintenance manuals to be sent after completion underseparate cover with as-built.One lockable Aluminum storage box.Two (2) Year, Tradewinds Standby Warranty

103,480Inc. Inc.Inc. Inc.

103,480

Price Validity:Wire-Transfer:

45 days; 15% Cancellation Charge for Restocking.Tradewinds Power Corp Division of Southeast Diesel CorpF/B/O Wells Fargo BankAcct# 4945741023 ABA# 121000248 Paul Staples

Onsite Start-up and building load testDelivery to Key West, Fl. Curbside. Fuel by othersTotalState & Local Tax as ApplicableEstimated Shipping date from receipt of order: 12 - 14 weeks.

Switch in NEMA 3r cover box.Oil and Water Drain Lines with Brass Ball Valves and Bulk Head Fittings.Initial Fill of Oil and AntifreezeFull load factory test of generator set and operation test of each system.

Sub Total, FOB our warehouse, Miami, Florida

gauge and have a low fuel level alarm, tank drain, tank fill, suction and return lines.

Distribution panel to include two (2) Duplex Receptacle with GFI Trips and breakers, Two (2) non-GFI Duplex Receptacle with Breakers, One (1)120vac, 1ph, 30amp, receptacle, 120/240vac, 1ph, 30amp receptacle, and

Two Thumb screws are provided for remote start stop contacts of Transfer

Finished Painted a standard white PPG Powder Coat finish. The enclosure is wind load

18,000lb, Steel, D.O.T. Approved, street legal trailer with Dual Torque Spring Axels, Surge Brakes, Fenders, two (2) rear mounted jack stands, tongue mounted trailerleveler, running lights with reverse lights, military hitch, safety chains, and a 500 gallonsteel fuel tank. The fuel tank will be equipped with a mechanical and electrical fuel level

Frequency Meter, Ammeter & Voltmeter with Phase Selector Switch, EngineCool Down Timer, Remote "E" Stop Contacts, Remote Auto Start Control, LowFuel Level Alarm, Breakers for A/C and D/C, and a Emergency Stop Push Button.

Optional Equipment included in above pricing:

connection to standard 120vac, 1ph, 20amp service via extension cord.

Model TP150 Mobile Generator Base Awarded Tradewinds Generator Set

Cost Adder for Model T400-M-FS Approved Tradewinds Generator Set;

Amp Load Capacity: 867; Load Bank tested.

400 KW (500 KVA) Standby Power; 350 KW (438 KVA) Prime Power

Amp Load Capacity: 602; Load Bank tested.400 KW (500 KVA) Standby Power; 350 KW (438 KVA) Prime Power

277/480 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor

120/208 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor

400 KW (500 KVA) Standby Power; 350 KW (438 KVA) Prime Power120/240 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power FactorAmp Load Capacity: 751; Load Bank tested.Perkins Diesel engine, Model 2206D.E13TAG2 TIER 3 @ 1800 RPM complete with12 Volt Electrics, Radiator & GuardOversized Brushless Single Bearing Alternator with a PMG and volts per hertz trackingAutomatic Voltage Regulator, Special Insulation: Vacuum Pressure Impregnation and Rubber

Tradewinds NFPA 110 Digital Instrument/Control Panel with Safety ShutdownsComplete with DC Voltmeter, Hourmeter, Oil and Temperature Gauges

Wet Battery, Battery Rack, and Battery CablesThermostatically Controlled Jacket Water Heater with brass ball valves to enable heater

120vac, 20amp, Duplex electrical outlet mounted inside of weather enclosure and in a NEMA 3r box wired to the external of the weather enclosure to a standard 3 prong plug for

rated at 150mph and has an estimated noise level of 75dba at 21'. Enclosure will be

1200amp, Main line generator breaker to be provide for 208 and 240vac with 12vdc shunt trip.

Steel Exhaust Flex, Critical Exhaust muffler and aluminized rain cap mounted and installedin turn hood of enclosure. Turn hood will be treated with a sound attenuating material..125 (1/8"), 5058 Marine Grade Aluminum, Sound attenuated weather Enclosure withvertical discharge air, stainless steel hardware, Keyed alike and removable doors, and

5820 NW 84th Avenue Miami, Florida 33166Tel 305-592-9745 FAX 305-592-7461

www.tradewindspower.com

FiltersPump Sets

Power UnitsGenerator Sets

Automatic Engine Controls

Q0071679

1

12/11/2014

TBA QUOTE Paul Staples Net 30 days NOTAX

Q0071679 Tradewinds Power Corp PPADD To Be Advised

ReprintQuote

15157MONROE COUNTY FLEET MANAGEMENTACCOUNTS PAYABLES3583 S. ROOSEVELT BLVDKEY WEST, FL 33040

15157TBA

(305) 292-3572 (305) 292-3529

Date

Tax CodeTermsSalespersonShip DateCustomer PO Number

Ship ViaFreightWarehouseDocument

Item Number / Description

Page

Quantity ExtensionPerPriceUM Wgt

Sold To: Ship To:

Phone:Fax:Fax:

Phone:

DELETE AFTER SET UP EA 13,094.0013094.001 EADUMMY ITEM .0

Note: To install a Double Wall Diesel Fuel Tank on a Tradewinds, trailer mounted generator, model TJ400E-60T3GT, purchased under Monroe County's P.O. #00048940. Which includes: a 475 Gallon Fuel Tank, Double wall, UL142 approved, with anti-corrosion paint5 Gallon Anti Spill containment (FDEP)Pick-up and Delivery of the generator (point of reference: 87831 Overseas Hwy).

Lead Time: +/- 5 weeks, due to the construction of the fuel tank.

aleagQUOTED BY:01/12/2015EXPIRES:

13,094.00 13,094.00 0.00 0.00

ALL RETURNS ARE ONLY VALID FOR 30 DAYS

.0

Merchandise

2023_12

Tax Total DueAdd On Charges

Approx Total Weight:

*Stand by ratings are applicable for the duration of any power outage. No overload is available at these ratings. Prime ratings are continuous per BS 5514, DIN 6271, ISO3046 & IEC 34-1. Overload capacity on prime-power ratings is 10% for one hour in each twelve hours of operation. All single phase ratings are based on a 1.0 power factor, three (3) phase ratings based on a 0.8 power factor. Ratings are established based on 85°F ( 29°C ) and an elevation of 1,000 feet ( 305 meters ). Please consult your Tradewinds representative for information concerning derates for temperature, altitude & humidity.

• Tier III Industrial Diesel Engine • AC, Single Bearing direct coupled Alternator with Class ‘H’ insulation, Sized for 130°C Temperature Rise. • Control Panel (NFPA/UL Approved) mounted to Alternator

with Auto-Start -Stop with access door to allow exterior viewing.

• Emergency Stop Push Button • Dual Voltage Generator providing 480 and 208 volts • Mainline Circuit Breaker with Shunt Trip • Engine and Alternator mounted to sub base on vibration

Isolators. • Radiator sized for 120°F ambient clearance • High Coolant Temp., Low Oil pressure safety shutdowns. • Dry Type Air Cleaner. • 24-VDC Starter, Engine mounted Battery Charging Alter-

nator, Battery Cables and Rack along with Grounding Strap.

• Weather Protective Enclosure constructed of Marine

Grade Aluminum 0.125 thickness, SS Hardware White Powder Coat Paint Finish on both sides Sound Insulation resistant to high temperatures, fuel and oil. Hinged / Removable / Keyed-alike Doors Residential rated interior mounted exhaust silencer kit Vertical radiator and exhaust discharge • Oil & Coolant Drain Lines with Brass Ball Check Valves • Thermostatically Controlled Jacket Water Heater • Starting Batteries • Automatic Battery Charger 6 Amp 12V Output 115VAC • Cam-Loc Connection Box • 120V Receptacle for Battery Charger and / or Coolant heater. • Triple Axle Trailer with Spare tire -DOT approved dual Torsion type Axle 20000 pounds cap. 500 Gal Steel Fuel tank, with key-locked Fuel Filler cap and Manual Fuel level Gauge

Tradewinds Power Corp • 5820 NW 84th Ave • Miami, FL 33166 • 800-223-3289 www.tradewindspower.com

Voltage Ph Hz Standby Output

kW (kVA) Prime Output

kW (kVA) Max Amp Output

Number of Wires

208 1 60 300 (375) 300 (375) 1042 7

480 3 60 300(375) 300 (375) 451 7

Power When You Need It!

Power When You Need It!

Power When You Need It!

Power When You Need It!

Generator Ratings @ 1800 RPM

Standard Generator Set Features

Sample Unit

Tradewinds Power Corp • 5820 NW 84th Ave • Miami, FL 33166 • 800-223-3289 www.tradewindspower.com

Specifications are subject to change without notice

Agency Approvals : UL 508 R CSA C22.2 No 14 NFPA 110 CE Compliance : EC LVD-73/23/EEC EN 61000-6-4:2001 EMC EN 50178:1997 EMC- 89/336/EEC EN 610000 6-2:2001 EMC Immu-nity

DGC2020 Microprocessor Based, Navigation key with

large LCD display Event Recording Transfer Switch Control (main failures) SAE J1939 CANBUS Communication Multilingual Capability Suitable for Rental application Remote Communication capability ( optional)

Operational features • Alternator Protection: under/over voltage, under/over frequency. • Engine Protection: Low oil pressure, High coolant temperature,Over speed & over crank, Sender Unit failure, Fuel Leak / Fuel

sender Failure, Battery Charger Failure • All protections are programmable as Alarms

or Pre-alarms

• Operating Power: Nominal 12-24 Vdc

Consumption 14.2W run Mode •Metering ( ample range ): Volts, Current, Hz, Watts, VA, Pf Oil Pressure, Coolant Temperature, RPM,

DC Volts, Fuel Level, Engine running time.

• Engine Control with Timers • External remote start input (on or off load) • 16 programmable contact inputs. • 7 Contact outputs

Power When You Need It!

Power When You Need It!

Power When You Need It!

Power When You Need It!

Model: Perkins 2206D-E13TAG2 or John Deere 6135HF485 Turbo Charged, Air to Air , 6 cylinder in-line, 4 stroke Unit injection, Valves per cylinder: 2 intake / 2 exhaust Governor type - Electronic; ECU Frequency Regulation: Isochronous, Steady-State

Fuel Consumption US gal. ( Liters ) /hr @ 1800 RPM STANDBY 50% load - 13.7 ( 52 ) 75% load - 20 (78) 100% load - 27 ( 103) General: Oil Filter Air Filter– Dry element type Electrical system: 12VDC Starter, SRC 920amp @ 32 F° Recommended Battery size: 950 CCA Fuel Type: BS 2869: Part 2 1998 Class A2 or BS EN590 or JP8

Engine Specifications

Marathon Electric : Type: Dual Voltage / Brushless, Pole: 4Pole Rotating Field, Voltage regulation: + / - 1%, Volts/Hertz, Electronic, EMI filtered Class Insulation: ‘H’ to NEMA MG-1-1.66 Rated Temp. Standby : 130 C° Rise / 40 C° Ambient Coupling: SAE Adapter, Flexible Disc, Direct. Load acceptance: One Step, 100% per NFPA 110

Features: Self ventilated drip-proof construction. Superior voltage waveform achieved by a 2/3 pitch and skewed rotor. Vacuum-impregnated windings with fungus-resistant epoxy for dependability and long-life. Compliance with NEMA, IEEE and ANSI standards for temp. rise. Sustained short-circuit capability enabling down-line circuit breakers to trip without collapsing the generator field. No load to full-load regulation of +/- 2%.

Alternator Specifications

Control Panel Specifications

One complete set Owners/Operators, Engine, Alternator and Accessory manuals

Nominal Dimensional Specification

TJ400MG_2_10