a380-Level i - Ata 33 Lights
-
Upload
abolfazl-mazloomi -
Category
Documents
-
view
473 -
download
78
description
Transcript of a380-Level i - Ata 33 Lights
-
A380TECHNICAL TRAINING MANUAL
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
-
This document must be used for training purposes only
Under no circumstances should this document be used as a reference
It will not be updated.
All rights reservedNo part of this manual may be reproduced in any form,
by photostat, microfilm, retrieval system, or any other means,without the prior written permission of AIRBUS S.A.S.
-
LEVEL I - ATA 33 LIGHTSLights System Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2Cockpit Lighting System Presentation . . . . . . . . . . . . . . . . . . . . . . . . 4Cabin Lighting System Presentation . . . . . . . . . . . . . . . . . . . . . . . . . 12Cargo & Service Compartments Lighting System Presentation . . . . 28Exterior Lighting System Presentation . . . . . . . . . . . . . . . . . . . . . . . 44Emergency Lighting System Presentation . . . . . . . . . . . . . . . . . . . . . 66Lights System Maintenance (1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
TABLE OF CONTENTS Mar 21, 2006Page 1
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
-
LIGHTS SYSTEM INTRODUCTIONGeneral
The A/C lighting system, which supplies internal and externalillumination, is composed of these subsystems:- the cockpit lighting system,- the cabin lighting system,- the cargo and service compartments lighting system,- the exterior lighting system,- the emergency lighting system.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
LIGHTS SYSTEM INTRODUCTION Mar 15, 2006Page 2
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33Z1
0000
0000
1
-
GENERAL
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
LIGHTS SYSTEM INTRODUCTION Mar 15, 2006Page 3
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33Z1
0000
0000
1
-
COCKPIT LIGHTING SYSTEM PRESENTATIONGeneral
The cockpit lighting system offers the crew the most suitable lightingenvironment to carry out their mission. It allows the crew to easily seeall equipment details, inscriptions and indications, whatever the level ofdarkness and in all flight conditions.For this, the cockpit lighting system is composed of:- the cockpit general illumination,- the instrument and panel integral lighting,- the annunciator light test and dimming.A big improvement of the cockpit lighting system is the exclusive useof Light Emitting Diode (LED) technology in order to improve the cockpitlighting homogeneity. In addition, this technology increases the sourcelifetime and reduces its thermal dissipation.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 4
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
GENERAL
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 5
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
COCKPIT LIGHTING SYSTEM PRESENTATIONCockpit General Illumination
The ambient lighting is made up of three ceiling lighting strips locatedon each side of the overhead panel.The ambient lighting is adjustable from the center pedestal using theAMBIENT LT potentiometer.Four lights installed under the glareshield structure do the main instrumentpanel lighting.These lights are adjustable from the center pedestal using the MAIN PNLFLOOD LT potentiometer.In addition, on the overhead panel, the STORM switch adjusts the ambientand the main instrument panel lighting to its maximum brightness.The center pedestal illumination is done by one reading light located onthe overhead panel.This light is adjustable thanks to the PEDESTAL FLOOD LTpotentiometer located on the pedestal itself.A set of four lights under the base of each pilot's seat is installed for thefloor lighting of the CAPT and F/O.In addition, on each side, one light lights up the side console and anotherone the briefcase storage area.These lights are adjustable for each pilot through the three-positionCONSOLE & FLOOR LT switch located on both sides of the maininstrument panel.One light supplies an illumination of the standby compass. The pilot eyereference device is made of three balls: two red and one translucent white.A white LED lights up the translucent white ball from the inside.The ICE IND & STBY COMPASS switch, located on the overhead panelcontrols these lights.Note that the following lights are also installed in the cockpit:- map lights,- sliding table lights,- pilot reading lights,- maintenance console light,
- third, fourth and fifth occupant reading lights.Each one of these lights is controlled by an associated potentiometer.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 6
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
COCKPIT GENERAL ILLUMINATION
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 7
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
COCKPIT LIGHTING SYSTEM PRESENTATIONInstrument and Panel Integral Lighting
The aim of the instrument and panel integral lighting is to enable thecrew to read indications and to identify controls on the various cockpitpanels in dark conditions.For that, the INTEG LT potentiometer located on the center pedestal,controls, via a dimming control unit, the brightness level of all the lightedplates and Liquid Crystal Display (LCD) backlighting. They are integratedwithin control panels and other lighted equipment located on the overheadpanel, the main instrument panel and the pedestal.In addition, both potentiometers situated under the glareshield, control,via the dimming control unit, the lighting level of all the lighted platesand LCD backlighting located on the glareshield.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 8
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
INSTRUMENT AND PANEL INTEGRAL LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 9
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
COCKPIT LIGHTING SYSTEM PRESENTATIONAnnunciator Light Test and Dimming
The ANN LT switch located on the overhead panel is used to control thebrightness level of all annunciator lights installed in the cockpit. Inaddition, it helps the flight crew to test all annunciator lights status. Thiscontrol is done either through the dimming control unit for allannunciators located on the glareshield, the main instrument panel andthe pedestal, or directly for the annunciators located on the overheadpanel.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 10
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
ANNUNCIATOR LIGHT TEST AND DIMMING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
COCKPIT LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 11
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P1
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONGeneral
The cabin lighting system supplies illumination to the whole cabin withthe most suitable lighting environment in order to give the passengers asense of well being during various flight phases.The cabin crew, the passengers, the maintenance crew and the cockpitcrew interface through the Cabin Intercommunication Data System (CIDS)with the cabin lighting system which is a fully CIDS controlled andmonitored system.The cabin lighting system is composed of:- the cabin general illumination,- the lavatory lighting,- the reading and work lights,- the stand-alone signs.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 12
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
GENERAL
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 13
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONCabin General Illumination
The cabin general illumination is composed of:- the cabin decks general lighting,- the spotlights,- the staircase lighting.
Cabin Decks General LightingThe cabin decks general lighting is composed of the AdvancedIllumination Ballast Units (AIBUs), each one is equipped with onefluorescent tube supplying an advanced dimming capability (from100 to 0.1%).In baseline configuration, four light strips are installed in the upperdeck and six in the main deck. Each light strip can be separately andzone wise scenario controlled.Note that for light effects like mood lighting, the single ballast unitcan be replaced either by a double unit or by a hybrid unit withred/green/blue Light Emitting Diodes (LEDs).In all cases, the cabin decks general lighting is controlled from theFAPs, the optional Additional Attendant Panels (AAPs) and theoptional mini FAPs through the CIDS network.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 14
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN GENERAL ILLUMINATION - CABIN DECKS GENERAL LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 15
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONCabin General Illumination (continued)
SpotlightsThe aim of the LED spotlights is to carry out light in cabin areas wheregeneral lighting is not installed or where special attraction is desired,like in entrances, cross aisles, and staircase areas. In fact the numberand the position of these spotlights depend on the customer's cabinlayout. They may participate in light scenarios and are dimmable likethe whole cabin general illumination.The spotlights are controlled from the FAPs, the optional AAPs andthe optional mini FAPs through the CIDS network and tailoredinterfaces called Spot Array Light Supply Adapters (SALSAs). Eachadapter can supply up to 12 spotlights in designated areas.Note that a second type of spotlight with an identical appearance hasan integrated emergency light.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 16
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN GENERAL ILLUMINATION - SPOTLIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 17
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONCabin General Illumination (continued)
Staircase LightingThe aim of the staircase lighting is to create a smooth transition fromupper deck to main deck light settings or scenarios.The staircase lighting system is divided into the step illumination andthe ceiling illumination.The step illumination is done by Understep LED LIghts (ULLIs),which are installed below the footboard edge of each step and whichgive sufficient illumination to the steps for safe use in all conditions.Each staircase has one STair ELectrical Load Adapter (STELLA) tosupply the related ULLIs.The cockpit staircase ceiling is illuminated by a short AIBU. Instandard configuration, the ceiling of the FWD and the AFT staircaseis lighted by spotlights, which are powered by SALSAs. Note that asan option, it is possible to bring colored light into the FWD and theAFT staircase ceiling using a COntour LED LIght (COLLI).The staircase lighting system can be controlled from the FAPs, theoptional AAPs and the optional mini FAPs through the CIDS network.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 18
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN GENERAL ILLUMINATION - STAIRCASE LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 19
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONLavatory Lighting
General illumination in the lavatories is achieved by AIBUs with afluorescent tube installed on the ceiling. Additional LED lights areinstalled for the mirrors and the wash tables.In normal operation, the lavatory lighting level is predefined and dependson the status of the door locking mechanism (OPEN, CLOSED,LOCKED).Moreover, it can also be switched on and off from the FAPs, the optionalAAPs and the optional mini FAPs through the CIDS network.For cleaning and maintenance purpose, the lavatory lighting can beswitched to 100% brightness from outside the lavatory compartment.This control is either centralized from the FAPs, the optional AAPs andthe optional mini FAPs or individual from the optional 100% light switch.In all cases, the lavatory lighting is controlled through a specific adaptercalled LAvatory Interface and Light Adapter (LAILA).
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 20
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
LAVATORY LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 21
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONReading Lights
The reading and work lights are composed of:- the passenger reading lights,- the attendant work lights.
Passenger LED Reading LightsThe passenger LED reading lights come on in a limited area in frontof the passenger seats. For each of them, one LED reading light isinstalled in the related Passenger Service Unit (PSU).The passenger LED reading lights can be switched on and offindividually from each seat through a related P/B on the PSU and onthe seat itself. In addition, they can also be switched on and off andscenario controlled for the whole cabin or zone through the FAPs, theoptional AAPs and the optional mini FAPs.The passenger LED reading lights are controlled through the CIDSnetwork and/or through the Passenger Interface and Supply Adapters(PISAs), one per PSU.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 22
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
READING LIGHTS - PASSENGER LED READING LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 23
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONReading Lights (continued)
Attendant Work LightsThe attendant work lights are installed for the attendant seats areasand special working areas.The attendant work lights can be individually switched on and offfrom the related P/B. They can also be switched from the FAPs, theoptional AAPs and the optional mini FAPs through the CIDS network.In both cases, the attendant work lights are supplied either by PISAs,when the light is installed in a PSU, or by Stand-Alone PISAs (StAPISAs), when the light is installed in any other location.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 24
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
READING LIGHTS - ATTENDANT WORK LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 25
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CABIN LIGHTING SYSTEM PRESENTATIONStand-Alone Signs
Stand-alone signs are installed in areas where passengers are allowed tostay under calm flight conditions and in staircase areas.Three types of signs make sure that information is available in all cabinareas: lavatory occupied, No Smoking (NS)/Fasten Seat Belts (FSB) andReturn To Seat (RTS). The backlighting system of these lighted signs isbased on LED technology.The NS/FSB and RTS signs are controlled manually from the cockpit orautomatically according to the A/C configuration acquired from the A/Csystems. In both cases this control is done through the CIDS.The lavatory occupied signs are lighted up by red or green LEDs in allflight phases, depending on the condition of the assigned lavatorycompartment.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 26
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
STAND-ALONE SIGNS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CABIN LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 27
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P2
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONGeneral
To help servicing, maintenance and handling operations, cargocompartments and service areas are equipped with lighting facilities, partof the cargo and service compartments lighting system. This system alsosupplies electrical power outlets in these compartments and areas usedfor portable maintenance lights.The cargo and service compartment lighting system is composed of:- the service area lighting,- the air conditioning duct and accessory compartment lighting,- the lower deck cargo compartment lighting,- the avionics compartment lighting,- the wheel well lighting.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 28
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
GENERAL
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 29
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONService Area Lighting
The water and waste bay, the rear fuselage bay and the APU compartmentare equipped with a lighting system to help maintenance operations.This system is called service area lighting. It uses Light Emitting Diodes(LEDs) as light sources except in the APU compartment where halogenbulbs are installed due to the high environment temperature.Each bay and compartment lighting is controlled by one switch. Inaddition, three 28 VDC outlets are installed to supply portable handservice lights.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 30
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
SERVICE AREA LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 31
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONAir Conditioning Duct and Accessory Compartment Lighting
The air conditioning duct and accessory compartment have a 28 VDCoutlet installed for a portable maintenance light.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 32
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
AIR CONDITIONING DUCT AND ACCESSORY COMPARTMENT LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 33
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONLower Deck Cargo Compartment Lighting
The lower deck cargo compartment lighting system is composed of:- the panel lights,- the loading area lights,- the cargo compartment ceiling lights.
Panel LightsThe panel lights supply sufficient illumination to the cargo dooroperation panels and the cargo loading control panels. A total of fourLED lights are installed, one on each panel. Note that the panel lightscome on automatically when the ground service network is energized.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 34
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
LOWER DECK CARGO COMPARTMENT LIGHTING - PANEL LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 35
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONLower Deck Cargo Compartment Lighting (continued)
Loading Area LightsThe loading area lights supply sufficient illumination to the FWD andaft cargo compartment door areas, inside and outside, to help theloader driver, during loading/unloading at night. These lights help theloader to read the labels and to accurately position his vehicle.The loading area lights are composed of two High Intensity Discharge(HID) lights installed in the lining of the cargo compartments, abovethe FWD and the aft cargo doors.Each light is manually controlled, when the door is opened, by oneswitch located on the related cargo door operation panel, and isautomatically switched off when the door closes.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 36
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
LOWER DECK CARGO COMPARTMENT LIGHTING - LOADING AREA LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 37
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONLower Deck Cargo Compartment Lighting (continued)
Cargo Compartment Ceiling LightsThe cargo compartment ceiling lights supply sufficient illuminationfor the handling of the bulk, the aft and the FWD cargo compartmentareas.
Each light is composed of two fluorescent tubes associated to avariable frequency ballast unit.These lights are controlled by a switch located inside each relatedcargo compartment, close to the door on the right hand side.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 38
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
LOWER DECK CARGO COMPARTMENT LIGHTING - CARGO COMPARTMENT CEILING LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 39
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONAvionics Compartment Lighting
The avionics compartment lighting system supplies illumination andelectrical power for hand service lights to the main avionics compartmentand the upper avionics compartment to help in maintenance operations.The main avionics compartment lighting is composed of seven LEDdome lights, one 28 VDC outlet, one 115 VAC outlet and four controlswitches.In addition, the upper avionics compartment lighting is composed of twoLED dome lights, one 28 VDC outlet, one 115 VAC outlet and one controlswitch.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 40
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
AVIONICS COMPARTMENT LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 41
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEM PRESENTATIONWheel Well Lighting
To help in maintenance operations, the wheel well lighting systemsupplies illumination and electrical power for portable hand service lightsin the Nose and Main Landing Gear (NLG and MLG) bays, to theassociated wheels and in the belly fairing.The system uses LED as light sources except for the NLG wheel lightingwhere one HID light is installed.Note that the MLG wheel lighting is done by both HID taxi aid cameralights installed in the lower surface of the wings, which belong to theexterior lighting system. In addition, 28 VDC outlets and 115 VAC outletsare installed to supply portable hand service lights.A total of six switches located on the steering disconnect panel and onthe wing ground door opening panel control the wheel well lightingsystem.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 42
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
WHEEL WELL LIGHTING
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
CARGO & SERVICE COMPARTMENTS LIGHTING SYSTEMPRESENTATION
Mar 15, 2006Page 43
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P3
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONGeneral
The exterior lighting system is composed of the following functions:- anti-collision lights,- navigation and obstruction lights,- logo lights,- wing and engine scan lights,- runway turnoff lights,- taxi aid camera lights,- landing lights,- taxi and takeoff lights.Note that a new improvement of the exterior lighting system is the useof Light Emitting Diode (LED) and High Intensity Discharge (HID)technologies. These technologies reduce power consumption and increasesource lifetime and lighting quality.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 44
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
GENERAL
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 45
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONGeneral Architecture
The exterior lighting system is manually controlled from the cockpitEXTerior LighTs panel via the Avionics Data Communication Network(ADCN) and the secondary electrical power distribution.Note that a direct backup connection to the secondary electrical powerdistribution is also supplied in case of total ADCN failure.Moreover, the secondary electrical power distribution includes specificcontrol logics which take into account some A/C system configurationsto control certain exterior lights.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 46
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
GENERAL ARCHITECTURE
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 47
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONAnti-Collision Lights
The anti-collision lights are composed of:- the anti-collision strobe lights,- the anti-collision beacon lights.
Anti-Collision Strobe LightsThe anti-collision strobe lights prevent collisions in flight.One xenon white flashing strobe light is installed in each wing tipleading edge and one rear facing in the tail cone.The STROBE switch located on the EXTerior LighTs panel controlsthese lights. Note that on ground, in AUTO position, these lights areswitched off automatically.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 48
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
ANTI-COLLISION LIGHTS - ANTI-COLLISION STROBE LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 49
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONAnti-Collision Lights (continued)
Anti-Collision Beacon LightsTwo LED red flashing beacon lights are installed on the upper fuselageand one is installed on the lower fuselage.The BEACON switch located on the EXTerior LighTs panel controlsthese lights.The three beacon lights flash together with the strobe lights. Inaddition, the wing tip strobe lights give an extra flash in the middleof each flashing interval.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 50
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
ANTI-COLLISION LIGHTS - ANTI-COLLISION BEACON LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 51
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONNavigation and Obstruction Lights
The navigation lights give a visual indication of the aircraft position anddirection in flight and on ground.The navigation lights circuit is composed of one forward facing lightmounted in each wing tip (RH: green, LH: red), and one rearward facingwhite light installed in the tail cone. In addition, a white obstruction lightmounted on each wing tip fence, supplements the navigation lights onthe ground to help safety clearance for other airfield users.The obstruction lights are automatically switched off in flight. The NAVswitch located on the EXTerior LighTs panel controls both lightingsystems.The navigation and obstruction lights systems use LED technology.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 52
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
NAVIGATION AND OBSTRUCTION LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 53
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONLogo Lights
One logo light unit (comprising two HID lights) installed on each sideof the Trimmable Horizontal Stabilizer (THS) illuminates the airlineLogo.The LOGO switch located on the EXTerior LighTs panel controls theselights. Note that in AUTO position, the logo lights are controlledautomatically according to the aircraft configuration.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 54
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
LOGO LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 55
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONWing and Engine Scan Lights
The wing and engine scan lights help the flight crew to visually detectice on the engine air intakes and leading edges.For that, a HID wing scan light and a HID engine scan light are installedon each side of the FWD fuselage.The WING switch located on the EXTerior LighTs panel controls theselights.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 56
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
WING AND ENGINE SCAN LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 57
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONRunway Turnoff Lights
Two HID runway turnoff lights are installed on the Nose Landing Gear(NLG) to provide illumination of the runway lateral areas.The RWY TURN OFF & CAMERA switch located on the EXTeriorLighTs panel controls these lights. Note that the runway turnoff lightsare switched off automatically in flight.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 58
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
RUNWAY TURNOFF LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 59
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONTaxi Aid Camera Lights
The taxi aid camera lights supply illumination of the areas observedthanks to the External Taxi Aid Camera System (ETACS).Two HID lights, installed in the bottom of the front fuselage, illuminatethe taxiway in the vicinity of the NLG. In addition, two HID lights,installed in the lower surface of the wings, illuminate the taxiway in thevicinity of the Main Landing Gear (MLG).The RWY TURN OFF & CAMERA switch located on the EXTeriorLighTs panel controls these lights.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 60
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
TAXI AID CAMERA LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 61
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONLanding Lights
Two fixed position HID landing lights installed on each wing root leadingedge, give a FWD illumination of the landing area when the A/C is inapproach.The LAND switch located on the EXTerior LighTs panel controls theselights.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 62
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
LANDING LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 63
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EXTERIOR LIGHTING SYSTEM PRESENTATIONTaxi and Takeoff Lights
One HID taxi light is installed on each wing root leading edge to do theillumination of the taxiway and the runway during taxi and takeoff phases.In addition, three HID takeoff lights, installed on the NLG, supplyillumination during high speed takeoff phase to identify any obstructionon the runway.The NOSE switch located on the EXTerior LighTs panel controls taxiand takeoff lights.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 64
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
TAXI AND TAKEOFF LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EXTERIOR LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 65
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P4
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONGeneral
The emergency lighting system is designed to give sufficient illuminationto the cabin, to identify the emergency exit areas and to fulfil safe andquick escape from the A/C in emergency conditions. The system mustbe efficient in darkness and/or in case of smoked cabin, even if no A/Cpower supply is available.The Emergency Power Supply Units (EPSUs) are the heart of theemergency lighting system. They interface with the cockpit crew, thecabin crew, the Cabin Intercommunication Data System (CIDS), someA/C systems and the emergency lights.The lights are composed of:- the cabin ceiling emergency lights,- the staircase emergency lights,- the cockpit way lights,- the floor path marking system- the emergency slide lights,- the emergency door lights,- the exit signs.Note that to reduce operating costs and to improve reliability, allemergency lights use Light Emitting Diode (LED) technology.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 66
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
GENERAL
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 67
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONGeneral Architecture
The emergency lighting system can be controlled manually, either fromthe cockpit by the EMERgency EXIT LighTs and the cockpit way lightswitches, or from the cabin by the EMERgency lighting switch on theFAPs and a second cockpit way light switch.It can also be controlled automatically according to the A/C configurationby the CIDS network and by some A/C systems like the Doors and SlidesManagement System (DSMS) and the Electrical Power Generation System(EPGS).In all cases, the emergency lighting system is electrically powered by theEPGS through 18 EPSUs.If no AC power is available, each EPSU is able to supply the attachedemergency lighting components for at least ten minutes of operationthanks to its integrated battery.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 68
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
GENERAL ARCHITECTURE
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 69
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONCabin Ceiling Emergency Lights
The cabin ceiling emergency lights include:- the ceiling emergency LED lights,- the emergency spotlights.
Ceiling Emergency Led LightsThe Ceiling Emergency LED LIght (CELLI) strips supply a minimumof illumination to the main aisles of the upper and main decks whenthe corresponding EPSUs receive a manual or an automatic activationfrom the related activation devices.Note that two EPSUs supply each CELLI strip for redundancy reasons.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 70
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
CABIN CEILING EMERGENCY LIGHTS - CEILING EMERGENCY LED LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 71
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONCabin Ceiling Emergency Lights (continued)
Emergency SpotlightsIn baseline configuration LED spotlights are used in cross aisles,staircase areas and entrances. Most of these spotlights are equippedwith integrated emergency LED lights to bring light out in these areaswhen the emergency lighting system is activated manually orautomatically from the related activation devices via the EPSUs.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 72
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
CABIN CEILING EMERGENCY LIGHTS - EMERGENCY SPOTLIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 73
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONStaircase Emergency Lights
The staircase emergency lighting is integrated in the Understep LEDLIght (ULLI) and installed under each step in all staircases. Thus, eachULLI strip contains two separate circuits for general and emergencylighting.For redundancy reasons, each ULLI emergency lighting circuit is suppliedby two EPSUs when a manual or an automatic activation is received fromthe related activation devices.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 74
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
STAIRCASE EMERGENCY LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 75
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONFloor Path Marking System
The Floor Path Marking System (FPMS) will guide the passengers to thenext exit under smoke conditions.The system is composed of- the seat mounted floodlights for illumination of the main aisles,- the wall mounted floodlights for illumination of areas in front ofmonuments like galleys and lavatories,- the edge mounted floodlights for illumination of areas in front ofmonuments, used in narrow places where seat mounted floodlights donot fit,- the exit identifiers for illumination of door areas.Each FPMS component uses LED technology and is powered forredundancy reasons by two EPSUs when the emergency lighting systemis activated manually or automatically from the related activation devices.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 76
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
FLOOR PATH MARKING SYSTEM
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 77
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONEmergency Slide Lights & Emergency Door Lights
The escape slide LED lights, light the escape path on the wing in frontof doors 3, the escape slides and the areas in front of the slides when theyare deployed. The lights are integrated in the slides and are powered byEPSUs when an automatic activation is received from the relatedactivation devices.The emergency door light is integrated at the edge frame of each door 3in the main deck to bring light onto the adjacent overwing area in orderto guide the passengers to the emergency slides. It is equipped with whiteLEDs and is powered by the EPSU installed at the related door 3 whenan automatic activation is received from the related activation devices.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 78
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY SLIDE LIGHTS & EMERGENCY DOOR LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 79
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONCockpit Way Lights
When entering or going out the A/C with general lights in MAIN OFFstatus, the flight crew can put the light on in the way to the cockpit or tothe exit door M1L with cockpit way lights.These lights are composed of emergency ULLIs installed under each stepof the cockpit staircase and one emergency spotlight located above thecockpit staircase.They are temporarily battery powered from the EPSU at door M1L whenactivation is received from one of the control switches located at the doorM1L and in the frame of the cockpit door.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 80
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
COCKPIT WAY LIGHTS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 81
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EMERGENCY LIGHTING SYSTEM PRESENTATIONExit Signs
There are three kinds of signs for the exit, all equipped with LEDtechnology.The exit location signs, which are visible from every point of the cabin,are installed on the ceiling to indicate the position of the exit areas.Moreover, the exit marking signs are installed right above the exits toclearly indicate the position of the doors.Additional exit signs are also necessary to guide passengers either fromthe stairs or from the dead end of the FWD upper cabin deck to the firstavailable exit.All exit signs are powered from EPSUs when the emergency lightingsystem is activated manually or automatically from the related activationdevices.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 82
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
EXIT SIGNS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
EMERGENCY LIGHTING SYSTEM PRESENTATION Mar 15, 2006Page 83
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P5
0000
0000
1
-
LIGHTS SYSTEM MAINTENANCE (1)Lights System Safety Items
When you work on the lights system, make sure that you obey all theAMM safety precautions. This will prevent injury to persons and/ordamage to the A/C. Here is an overview of the main safety precautionsrelative to the lights system.High Intensity Discharge (HID) lamps contain mercury. If an arc tubebreaks, it is possible that the operator absorbs some mercury through theskin.In consequence, always wear safety gloves.HID lamps have very high temperature in working condition; 800C onthe outer bulb and 240C on the base.To prevent burns, let the bulb cool down for three minutes after theswitching off and disconnection before removal.HID lamps emit some UV rays.Thus, as a precaution, always wear safety UV glasses because of sunburnand conjunctivitis issues.The capacitor in the electrical circuit of the strobe light can keep a highvoltage charge for some minutes.In consequence, do not remove the strobe light for a minimum of tenminutes after you de-energize the electrical circuit.
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
LIGHTS SYSTEM MAINTENANCE (1) Mar 15, 2006Page 84
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P6
MA
INT0
001
-
LIGHTS SYSTEM SAFETY ITEMS
MAINTENANCE COURSE - T1 & T2 (RR / Metric)LEVEL I - ATA 33 Lights
LIGHTS SYSTEM MAINTENANCE (1) Mar 15, 2006Page 85
A380 TECHNICAL TRAINING MANUALL0
Y06
082
- L0D
T0T0
- LM
33P6
MA
INT0
001
-
AIRBUS S.A.S.31707 BLAGNAC cedex, FRANCE
STMREFERENCE L0Y06082
MARCH 2006PRINTED IN FRANCEAIRBUS S.A.S. 2006
ALL RIGHTS RESERVED
AN EADS JOINT COMPANYWITH BAE SYSTEMS
Table of ContentsLights System IntroductionGeneral
Cockpit Lighting System PresentationGeneralCockpit General IlluminationInstrument and Panel Integral LightingAnnunciator Light Test and Dimming
Cabin Lighting System PresentationGeneralCabin General IlluminationCabin Decks General LightingSpotlightsStaircase Lighting
Lavatory LightingReading LightsPassenger LED Reading LightsAttendant Work Lights
Stand-Alone Signs
Cargo & Service Compartments Lighting System PresentationGeneralService Area LightingAir Conditioning Duct and Accessory Compartment LightingLower Deck Cargo Compartment LightingPanel LightsLoading Area LightsCargo Compartment Ceiling Lights
Avionics Compartment LightingWheel Well Lighting
Exterior Lighting System PresentationGeneralGeneral ArchitectureAnti-Collision LightsAnti-Collision Strobe LightsAnti-Collision Beacon Lights
Navigation and Obstruction LightsLogo LightsWing and Engine Scan LightsRunway Turnoff LightsTaxi Aid Camera LightsLanding LightsTaxi and Takeoff Lights
Emergency Lighting System PresentationGeneralGeneral ArchitectureCabin Ceiling Emergency LightsCeiling Emergency Led LightsEmergency Spotlights
Staircase Emergency LightsFloor Path Marking SystemEmergency Slide Lights & Emergency Door LightsCockpit Way LightsExit Signs
Lights System Maintenance (1)Lights System Safety Items