Post on 23-Feb-2018
7/24/2019 3.Properties of Hardened Concrete
1/35
3. Properties of Hardened coConcrete technology and masonry structures
7/24/2019 3.Properties of Hardened Concrete
2/35
3.1.1. Deformation of hardened conc
to calculate the deformation and deflection of structural members, we have t
the relation between stress and strain.
concrete behaves nearly elastically when load is first applied.
However, under sustained loading, concrete exhibits creep,
i.e. the strain increases with time under a constant stress, even at very low
normal environmental conditions of temperature and humidity.
7/24/2019 3.Properties of Hardened Concrete
3/35
3.1.2. Modulus of elasticity
oncrete shows nonlinear and
behavior, i.e. a permanent deformatio
after removal of load as shown
"he slope #modulus of elasticity.
"he elastic modulus of concrete in comp
$c %&'''
Figure :stress and strain diagram for concrete
7/24/2019 3.Properties of Hardened Concrete
4/35
"ypes of modulus of elasticity of concrete
(tatic modulus of elasticity
). *nitial tangent modulus of elasticity #at origin
+. "angent modulus of elasticity # at any point
. (ecant modulus of elasticity # slope of line connecting a specified point andorigin
D. hord modulus of elasticity: found out with refenrence to the chord
Dynamic modulus of elasticity
lexural modulus of elasticity
7/24/2019 3.Properties of Hardened Concrete
5/35
Dynamic modulus of elasticity
Static modulus of elasticity does not truly represent the elastic beconcrete.
modulus of elasticity from # non!destructive testing of concrete.
"he modulus of elasticity can be determined by sub-ecting the concrete
longitudinal vibration at their natural freuency.
involves the determination of either resonant freuencythrough a spec
or pulse velocity travelling through the concrete. +y making use of theparameters modulus of elasticity can be calculated from the following
Ed % Kn2L2p where : where Edis the dynamic modulus of elasticit
constant, nis the resonant freuency/ 0 is the length of specimen/ an
density of concrete.
7/24/2019 3.Properties of Hardened Concrete
6/35
!ltrasonic pulse elocity e"uipment #nding dynamic modulus of elasticity
7/24/2019 3.Properties of Hardened Concrete
7/35
3.2.1 creep
*t is 2the time!dependent
part of the strain resulting
from stress
"his is also known as plastic
flow or time yield
increase in strain under sustained constant
stress after taking into account other time
dependent deformations not associated with
stress.Time
7/24/2019 3.Properties of Hardened Concrete
8/35
Factors a$ecting creep
C%&&'
S(%&)*(+
Sti$erthe a
+igher the olumeof a
+igher the modulus of e
-o,er ,ater cement ra
+ence decreases in ,ater cem
Creep is smaller ,hen concrete is cu
7/24/2019 3.Properties of Hardened Concrete
9/35
Shrinage
Caused by loss of ,ater by eaporation or by hydration of
Contraction of concrete due to loss of moisture is called sh
(ypes
/. 'lastic shrinage
0. /utogenous shrinage
C. Drying shrinage
D. Carbonation shrinage
&. (hermal shrinage
7/24/2019 3.Properties of Hardened Concrete
10/35
-oss of,ater &aporation
/bsorptionby
aggregate
'lastic shrinage
hile the cement paste is plastic it undergoes olumetric c,ater due to loss of ,ater
/ complete preention of eaporation immediately after careduces
preention
Coering,ith
polyethylene
oring atnight
7/24/2019 3.Properties of Hardened Concrete
11/35
/utogenous shrinage
&en ,hen no moisture moement to or from the set concpossible autogenous shrinage occurs
(his is caused by loss of ,ater used up in hydration
f there is a continuous supply of ,ater to the concrete durconcrete e4pands due to absorption of ,ater by the cemenprocess is no,n as s,elling
7/24/2019 3.Properties of Hardened Concrete
12/35
Drying shrinage
ithdra,al of ,ater form hardened concrete stored in unscauses drying shrinage
Since hydration of cement is an eerlasting process 5 the dshrinage is also an eer lasting process
Simply the shrinage taen place after the concrete has sehardened
7/24/2019 3.Properties of Hardened Concrete
13/35
(hermal shrinage
6olumetric change due to decrease in temperatures
&4ample can be taen as a roof slab or road paement e4pthe day and undergoes thermal shrinage during night
7/24/2019 3.Properties of Hardened Concrete
14/35
Factors in7uencing shrinage
Depends on the relatie humidity
ater cement ratio
7/24/2019 3.Properties of Hardened Concrete
15/35
Fatigue of concrete
Static fatigue or creep rupture : failure occurs under a sus8or a slo,ly increasing load9 near5 but belo, the strength
Fatigue :failure occurs under cyclic or repeated loading
%epeated loadings can be seen in many structures for e4amroads5 air #eld paement
7/24/2019 3.Properties of Hardened Concrete
16/35
Fatigue failure
Concrete specimen subected toalterations of compressie stress
Stress strain cure :concaeto,ards the strain a4is: linear :concae to,ards the stress a4is
Stress strain cure of under cyclic compres
loading
7/24/2019 3.Properties of Hardened Concrete
17/35
&$ect of porosity
7/24/2019 3.Properties of Hardened Concrete
18/35
&$ect of porosity
(he hydrated cement contains : solid product of hydration ,hich is held physically or is adsorbed on the large surfacehydrates this ,ater is called gel ,ater also called gel pores
6olume of solid products of hydration < 8olume of dry cem,ater 9
oids or capillary pores
= the residual space taes the form of oids or capillary po 'orosity depends upon ,ater?cement ratio and degree of h
7/24/2019 3.Properties of Hardened Concrete
19/35
'orosity erses compressie st
Porosity 4log scale5 ! per cent
7/24/2019 3.Properties of Hardened Concrete
20/35
&$ect of ,ater?cement ratio
/bram@s la, A
=for any gien condition of test the strength of ,ell compa,ith good ,orability depends upon the BC cement ratio the mi4 is ,orable>. +e presented his classic la, in the fo
S
here 4 ,aterBcement ratio by olume and / and 0 are
S compressie strength of concrete
= ,hich simply says that the strength is inersely proportionacement ratio
7/24/2019 3.Properties of Hardened Concrete
21/35
&$ect of aggregate siEe
0arger si6e larger strength7 7
8es upto some extent
+ut as larger maximum si6e gives lower surface area for developments of
is responsible for the lower strength of the concrete
(econdly bigger aggregate si6e causes a more heterogeneity in the concre
prevent the uniform distribution of load when stressed
7/24/2019 3.Properties of Hardened Concrete
22/35
Durability of concrete
t is the ability to resist ,eathering action5 chemical attacany other process of deterioration
Durable concrete ,ill retain its original form5 "uality and se,hen e4posed to its enironment
=no material is inherently8 naturally 9 durable>
7/24/2019 3.Properties of Hardened Concrete
23/35
&nironmental related causes oconcrete durability problems
(emperature
Moisture
'hysical factor
Chemical factor
0iological factors
7/24/2019 3.Properties of Hardened Concrete
24/35
Cracks in concrete
0l d t
7/24/2019 3.Properties of Hardened Concrete
25/35
0leed at
Top of Slab
Inhibited by Fly ash
7/24/2019 3.Properties of Hardened Concrete
26/35
'lastic shrinage occurs ,hen the concretebleed ,ater too "uicly from its surface antherefore dries rapidly
7/24/2019 3.Properties of Hardened Concrete
27/35
'lastic settlement : Settlement ,hile thconcrete is still settling. (his happens,hen the concrete coer oer thereinforcement is too small5 or the mi4contains too many #nes or the mi4 is toslo, in releasing its bleed ,ater.t cracoccur ,hen concrete is
7/24/2019 3.Properties of Hardened Concrete
28/35
(hermal cracing
Surface Disintegrati
7/24/2019 3.Properties of Hardened Concrete
29/35
Surface Disintegrati
Dusting
mproperB-ac of Curing
+igh Surface BC
Carbonation
Fresh /ir
Spallin
7/24/2019 3.Properties of Hardened Concrete
30/35
Spallin
mproper curing
%apid eaporation
Sealing surfaceprematurely
(oo lo, ,Bc ratio
/ggregate Contamination
FreeEing
Plastic Shrinkage Crack
7/24/2019 3.Properties of Hardened Concrete
31/35
PlasticShrinkageCrack
Occur when rate of evaporation
exceeds rate of bleed
CraEin
7/24/2019 3.Properties of Hardened Concrete
32/35
CraEin
mproper Curing
%apid surfacedrying
erGFinishing
(oo long a delay from#nal tro,eling to
application of curingcompound
+igh BC ratio
=0lessing> Surface
mproperly Designed Structural Cracs
7/24/2019 3.Properties of Hardened Concrete
33/35
mproperly Designed Structural Cracs
7/24/2019 3.Properties of Hardened Concrete
34/35
=Hour dreams are lie the cement. f you,ater it ,ith actions5 it becomes a hardconcrete mass. 0ut if you leae it e4poseand un,atered5 the air ,ill easily blo, ita,ayI>J sraelmore/yior
http://www.goodreads.com/author/show/7023141.Israelmore_Ayivorhttp://www.goodreads.com/author/show/7023141.Israelmore_Ayivorhttp://www.goodreads.com/author/show/7023141.Israelmore_Ayivorhttp://www.goodreads.com/author/show/7023141.Israelmore_Ayivorhttp://www.goodreads.com/author/show/7023141.Israelmore_Ayivor7/24/2019 3.Properties of Hardened Concrete
35/35