County of San Diego DEPARTMENT OF
ENVIRONMENTAL HEALTH UST and Used Oil Regulations Update
Ag Water Quality Research and Education Program Meeting
June 15, 2004
Underground Fuel Storage Tanks in Agriculture
June 15, 2004Lisa Leondis
Abbreviations & Definitions UST = underground storage tank HMD = Hazardous Materials Division “Farm” a place of agricultural production
which has annual sales of agricultural products of $1000 or more.
Exemptions LG Bulletin 109-1 (7-94) HSC 25281(x)
Farm Tanks are exempt from state UST regulations
“Farm Tank” means a tank that: • is located on a farm • holds < 1100 gal. motor vehicle fuel • fuel used primarily for agricultural purposes • fuel is not held for resale.
Exemptions Home Heating Oil Tanks are exempt from
state UST regulations “Heating Oil Tank” means a tank:
• located on a farm or at a personal residence• that holds < 1100 gal. of home heating oil • which is used consumptively at the premises
Exemptions Exempt Farm Tanks are not subject to UST
installation, operating and closure requirements.
SWQCB maintains authority to require clean up or other pollution prevention measures if the tanks threaten water quality.
There is no exemption from liability.
How to Obtain Exemption Complete the “Claim of Exemption from
Underground Storage Tank Regulations and Law” form.
Submit to HMD at the address on the form. Provides concurrence that HMD agrees that
tank is exempt, may be needed for real estate transactions, lenders, etc.
Loss of Exemption
If the tank is changed to a regulated use: an operating permit must be obtained, or the tank system must be closed in
accordance with HSC Chapter 6.7.
Loss of Exemption
If a tank has lost its exemption, do not remove the tank system without a removal permit.
Contact the HMD Duty Desk at 619-338-2231 and request information on
UST removal.
A Regulated UST
Regulated USTs To obtain an operating permit from HMD,
tanks must comply with 1998 upgrades: Corrosion protection Spill buckets on fill tubes Overfill prevention Striker plates for “stickable” openings Leak detection for pressurized piping
Regulated USTsAdditional requirements: Secondary containment and testing for
tanks, piping and dispensers Annual testing and certification of the
monitoring system Monitoring and Emergency Release Plans Certification of Financial Responsibility
Special Concern
USTs within 1000 feet of a public drinking well must use enhanced leak detection with Tracer technology.
Any questions about exempt or regulated USTs so far?
Training Plus RegulationsNew for USTs
May 13, 2004Sylvia Mosse
Changes, how do we get the word out??
UST Training Plus Regulations•Effective May 8, 2004
•Implements training requirements found in SB 989
•Clarifies double-wall pressurized piping monitoring
•Addresses materials compatibility and permeability
SB 989 Required Training For:•UST Owners and Operators
•UST Service Technicians
•UST Installers, and
•UST Inspectors
“…..meet minimum industry–established training standards..” HSC 25284.1(a)(4)(A)(i)Adds 23 CCR Section 2715
Owner Requirements:A signed statement must be submitted to the local agency, which:
•indicates UST Owner understands and is in compliance with all applicable UST requirements•identifies the designated UST operator(s) for each facility owned
Any change of the designated operator must be reported to the local agency within 30 days of the change.
Effective January 1, 2005
Designated UST Operator Definition
An individual designated by the owner to have responsibility for:
•Training facility employees, and
•Conducting monthly visual inspections
The Designated Operator is not considered the UST “operator” as defined in HSC Chapter 6.7, although the same person may hold both positions.
Designated UST Operator Requirements
•Pass the California UST System Operator exam administered by International Code Council (ICC) Effective January 1, 2005
•Perform monthly visual inspections for each facility and maintain a log
Effective January 1, 2005
•Provide on-the-job training for facility employees
Effective July 1, 2005
Designated UST Operator Facility Employee Training:
•Operation of the UST system consistent with facility’s best management practices
•Monitoring equipment operation and alarm response
•Spill/overfills response procedures
•Emergency contact information Effective July 1, 2005
Topics required to be covered:
Designated UST OperatorICC UST System Operator Exam
•Access Candidate Bulletin at www.iccsafe.org
•Promissor testing center in San Diego (Computer based testing center)
•$70.00 cost
•Open book test
•All required references for the California UST Operator are available for free on the web
Designated UST OperatorICC UST System Operator Exam
• 20%: Tanks, piping containment, monitoring systems and operation authority
• 30%: Operating Requirements
• 25%: Release detection
• 17%: Record keeping
• 8%: release reporting and confirmation
Topics
Designated UST OperatorICC UST System Operator Exam
• California Code of Regulations Title 23• California Health & Safety Code Chapter 6.7• Straight Talk on Tanks EPA 510-B-97-007• Operating and Maintaining UST Systems EPA 510-B-00-008• Dollars & Sense EPA 510-K-95-004
Direct link to all references on our website: http://www.sdcounty.ca.gov/deh/hmd/docs/ust-training-requirements-04-30-04.doc
Designated UST OperatorMonthly Visual Inspection
• Review UST Alarm History• Inspect Spill Containers and UDC• Inspect containment sumps that have had an alarm, no service visit, and check for proper placement of sensors (lowest point).• Check to assure that all required testing and maintenance have been completed• Verify that all appropriate facility employees have been trained
Designated UST OperatorMonthly Visual Inspection Report
•Provide a copy of the report each month to owner or operator
•Alert the owner/operator of any condition requiring follow-up
The owner or operator shall maintain a copy of the report and all attachments for the previous 12 months
Designated UST Operator Facility Employee Training
• an individual who is employed onsite, and
• may be called upon to respond to spills, overfills and other UST system problems
The “Facility Employee” is not considered the UST “operator” as defined in HSC Chapter 6.7, although the same person may hold both positions.
Definition of Facility Employee:
Designated UST Operator Facility Employee Training
•Operation of the UST system consistent with facility’s Best Management Practices
•Monitoring equipment operation and alarm response
•Spill/overfills response procedures
•Emergency contact information Effective July 1, 2005
Training Topics required:
Designated UST Operator Facility Employee Training
• Required within 30 days of hire for new employee
• Must be conducted every 12 months
• At least one trained facility employee must be present during normal operating hours
• A list of trained facility employees shall be maintained onsite and include:
Training datesHiring dates for all employees hired after 7/1/05
Frequency of UST Training/Certification
• Designated UST Operators, Service Technicians, Installers, and Inspectors must be re-trained/re-certified every 24 months.
• Facility Employees must be re-trained annually
23 CCR 2631.1Compatibility and Permeability
UST Owner/operator must provide local agency with the compatibility and permeability testing results for UST components, upon request.
•Results to include list of compatible products tested and the measured product permeation rates, if such testing is required by the industry code or engineering standard used to evaluate the component.
Required for new UST system components installedafter July 1, 2004
23 CCR 2636 (f) Monitoring of Double-walled Pressurized Piping
Requires automatic line leak detectors for all double-walled pressurized piping
•Mechanical or Electronic LLD can be used
•Added in response to sensor study findings•Consistent with recent API recommendation
Effective November 9, 2004
Monitoring of Double-walled Pressurized Piping
Modifies the annual 0.1 gph piping test equivalent alternative:
• Requires a continuous monitoring system that: Stops the flow of the product at the dispenser when a leak is detected within the UDC, and Provides “fail-safe” pump shut-down when a leak is detected at any other point in the piping system (turbine and transition sumps)
Effective May 8, 2004
Monitoring of Double-walled Pressurized Piping
Monitoring system will shut down the turbine pump in the event of:
• A power outage
• When the monitoring system fails or is disconnected
Definition of Fail-safe
You can find the new regulations (and a whole lot more!) on the SWRCB website:
http://www.swrcb.ca.gov/cwphome/ust/
Used Oil Regulations
June 15, 2004Lisa Leondis
What is Used Oil?
Any oil refined from crude oil, or any synthetic oil, that has been used, and as a result of use or consequence of extended storage, or spillage, has been contaminated with physical or chemical impurities.
What is Used Oil?Vehicle crankcase oilEngine lubricating oils Transmission fluidsGearbox & differential oilsHydraulic oilsCompressor oilsTurbine, Bearing & Gear oilsTransformer/Electrical oils Refrigeration oilsMetal working oils
What is not Used Oil? Antifreeze, brake fluid, other auto wastes Fuels: gasoline, diesel, kerosene… Grease, Solvents Oils mixed with hazardous waste Oils with >1000 ppm total halogens or > 5ppm PCBs Wastewater with small amounts of used oil Cooking oils
Regulatory Status & Labeling Used oil shall be managed as a hazardous
waste (HSC 25250.4). Must be labeled “used oil” Must be stored in tanks or containers Containers and tanks must include the
accumulation start date Containers must also include the
generator’s name and address, physical state, hazardous properties, and be closed.
Improper Storage of Used Oil & Filters
No labels Open containers Containers in poor
condition
Used Oil Container Labeling (a good start)
Used Oil Container Labeling
Portable Tanks DTSC is working on
portable tank regulations.
For the meantime, these are regulated as containers.
Labeling of Tanks
Accumulation (Storage) Time Used oil may be accumulated on site for 90 to 365
days depending on the total amount of hazardous waste produced by the generator in any given month.
90 days for LQGs (>270 gal. or 2,200 lbs/mo.) 180 days for SQGs (<270 gal. or 2,200 lbs/mo.) or 270 days for SQGs if waste is transported 200+ miles 365 days under satellite accumulation (<55 gal.,
direct supervision, at the point of generation)
Record keeping Hazardous waste manifests, disposal
records must be kept on site for 3 years. If self-hauling, keep a record of how much
used oil is transported, when, and to what collection center.
For used oil and used oil filters Documents exempt status, if applicable
EPA ID Numbers All generators of hazardous waste, even if
exempt, need to obtain an EPA ID number. The only exceptions are households, silver
only (photographic) waste, and sponsored collection events.
Take application form if you need to obtain an EPA ID number.
Exemptions Household (do-it-yourselfers) are exempt
from regulation, but must take used oil to a used oil collection center.
HMD exempts farms that generate < 5 gal/ month and < 50 gallon per year from obtaining a hazardous materials permit (UPFP) if the used oil is generated incidental to farming operations and is managed/recycled properly.
When is FARM used oil not exempt? If more than 5 gal/month or more than 50
gal/year are generated, or If 55 gallons or more are accumulated on
site a any one time If the used oil generation in not incidental
to farming A hazardous materials permit from the
HMD (UPFP) must be obtained annually.
Disposal/Transportation Options Registered Hazardous Waste Haulers – using consolidated manifest Self-Hauling: up to 55 gallons, but make sure the
collection center can accept/handle drums Mobile Maintenance Operations – these have their
own requirements County of San Diego “CESQG” program – if less
than 27 gal. or 220 lbs. of hazardous waste is generated each month, special rates are available. Call our contractor at 800-714-1195.
CESQG Program
Must generate less than 27 gallons or 220 pounds of hazardous waste per month.
Radioactive, infectious, and explosive wastes are not accepted.
Appointments are required. Call phone number on flyer to get started.
Used Oil Filters Must be drained of all free flowing oil Labeled as “Drained Used Oil Filters” with
initial date of accumulation Stored in rain-proof, non-leaking, tightly
sealed containers Up to one ton may be stored for one year Must be recycled (scrap metal)
Universal Waste CRTs may not be disposed of to landfills -
must be recycled - see brochure. Other universal wastes include batteries,
fluorescent lamps, non-empty aerosol cans, and many other items.
Businesses are currently regulated. Household exemptions expire 2-8-06.
Top Related