Parts ManualGenerator Setwith PowerCommand 3201 Controller
DQKAA (Spec A−D)DQKAB (Spec A−D)
EnglishOriginal Instructions 2-2016 961−0210 (Issue 19)
Copyright 2016 Cummins Inc. 1
The following symbols are used in Cummins PowerGeneration manuals to alert users to the potentiallydangerous conditions relating to maintenance ofequipment and replacement of parts. Please readand observe.
This symbol warns of immediatehazards which will result in severepersonal injury or death.
This symbol refers to a hazard orunsafe practice which can resultin severe personal injury or death.
This symbol refers to a hazard orunsafe practice which can resultin severe personal injury or prod-uct or property damage.
To avoid errors or delay in filling your parts order, al-ways give the MODEL, SPEC NO. and SERIAL NO.from the Cummins Power Generation nameplate.
For handy reference, insert your nameplate in-formation in the spaces below.
MODEL AND SPEC NO.
SERIAL NO.
DIGITAL CONTROL SOFTWARE VERSIONAND DATE (IF APPLICABLE)
Contact with USED ENGINE OILS has been identified by a United States federal agency and some USAstate agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engineoils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.
Contact with ASBESTOS has been identified by a United States federal agency and some USA state agen-cies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all neces-sary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilationand wear protective gloves, masks and clothing!
Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified bya United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVETOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all nec-essary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation andwear protective gloves, masks and protective clothing!
PSP-1
Service and repair of Cummins Power Generation equipment must be performed by trained, experiencedpersonnel only. Improper service or repair may result in property damage, severe personal injury ordeath. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANTSAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.
2Copyright 2016 Cummins Inc.
Introduction
This catalog applies to Cummins Power Generation Generator Model DQKAA and DQKAB as listed in the Generator SetData Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference numbercorresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentionedin the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sidesare determined by facing the engine end (front) of the set unless noted in the description column.
Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All otherengine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturer’snameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in orderingreplacement parts.
Cummins Power GenerationGenerator Model
Cummins Engine Model
DQKAA QSK60−G7
DQKAB QSK60−G7
Generator Set Data Table
Model and Electrical Data BatteryModel andSpecification Watts Volts Hertz Wire Phase
BatteryVoltage
1750DQKAA/* 1,750,000 # 60 4L, 6L 3 24VDC
2000DQKAB/* 2,000,000 # 60 4L, 6L 3 24VDC
* − The diagonal line (/) in the model and specification number separates generator set characteristics from thespecification number and letter. The specification number denotes customer requested options or deviations from thestandard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes.
# − 380−13,800V (Refer to Genset Data Sheet).
Index
Copyright 2016 Cummins Inc. 3
BBelt, 18
Belt, Fan, 6
Block, Terminal − Engine Coolant Heater Control,13
Box, Control, 52
Box, Control − Installation, 48
Box, Entrance, 27 , 28
Box, Entrance − Assembly − Bottom Entry, 35 ,37
Box, Entrance − Assembly − Top Entry, 31 , 33
Box, Terminal − Generator Heater, 43
Box, Terminal − MV7 Alternators, 39
Box, Terminal − P7 Alternators, 38
Breaker, Circuit, 77
CCable, Battery, 6
Cage, Card − Control, 53
Cartridge, Heater − Generator Heater, 43
Cleaner, Air, 8 , 9
Control, Engine Coolant Heater, 13
Cover, Control − Engine Coolant Heater, 11
DDetectors, Resistive Temperature, 49
Door, Control, 51
FFan, 18
Fan−Drive, 20
Filter, Fuel, 7
GGenerator, 45
Generator Installation, 44
Lug, Solderless, 62
Guard−Kit, 19
HHarness, Wiring − AC, 79
Harness, Wiring − Control, 79
Harness, Wiring − Engine, 80
Harness, Wiring − Low Coolant Level Sensor, 14
Heater, Control, 47
Heater, Engine Coolant, 11
Heater, Generator, 43
Hose Assembly, Engine Coolant Heater, 11
Housing, Terminal, 41 , 42
IIsolator, 26
KKit Heater, Relay, 43
Kit, Contro, 85
Kits, 85
LLabels, Control Box, 54
Labels, Miscellaneous, 84
Lug, Solderless, 61
MModule, Audible Alarm, 59
Module, Bus PT, 56
Module, PT/CT, 57
Muffler, 78
PPaint, 5
Parts, External Engine, 6
Index
Copyright 2016 Cummins Inc. 4
PCB Assy, 85
Pyrometer, 60
RRadiator, 18 , 21 , 22 , 23
Radiator, Remote, 17
Relay, Alarm, 55
Relay, Customer, 55
Relay, Ground Fault, 58
Relay, Power − Engine Coolant Heater Control,13
Relay, Run, 55
SSealant, Thread, 5
Sensor, Low Coolant, 14
Shim, Generator Mounting, 24 , 25
Socket, Relay, 55
Spacer, Engine Mounting, 24 , 25
Spacer, Generator Mounting, 24 , 25
Switch, Key Operator, 83
Switch, Trip Alarm or Auxiliary Contact − CircuitBreaker, 77
TTransformer, 63
Transformer − P6/P7, 65 , 66
Transformer − P80LV, 67 , 68
Transformer − P80MV, HV, 69 , 71
Transformer −P7, 64
Transformer, Current − Differential, 75
Trip, Shunt − Circuit Breaker, 77
Tube Assembly, Engine Coolant Heater, 11
Tube, Radiator J/W L/H, 18
Tube, Radiator J/W R/H, 18
WWiring Harness Control, 81 , 82
5Copyright 2016 Cummins Inc.
Abbreviations
Some of the following abbreviations may be used throughout this Parts Catalog:
AC Alternating CurrentAmp AmpereA/R As RequiredAVR Automatic Voltage RegulatorAWG American Wire GaugeDC Direct CurrentDeg DegreeEFC Electronic Fuel ControlEIT External/Internal ToothEPROM Erasable Programmable Read
Only MemoryET External ToothGFI Ground Fault InterrupterID Inside DiameterIEC International Electrotechnical CommissionIT Internal ToothkW KilowattLPG Liquid Petroleum GasLT LeftM(meter number) Meter
mm MillimeterMOH Mobile Off HighwayNFS Not For SaleNPT National Pipe ThreadOD Outside Diameteroz. OuncePC Printed CircuitPh PhasePMG Permanent Magnet GeneratorPT/CT Potential Transformer/Current
TransformerRFI Radio Frequency InterferenceRT RightSpec SpecificationThk ThickUL Underwriters Laboratories Inc.UNC Union National CoarseUNF Union National FineVAC Volts Alternating CurrentVDC Volts Direct CurrentW/(ET, IT, EIT) With
Paint and Thread Sealant
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
Onan Green Enamel(Non−Metallic)
525−0305 − 12 oz. PressurizedSpray Can
525−0306 − Quart Can525−0304 − Gallon Can
518−0601 − Sealant, Thread (6 ml Tube)
6Copyright 2016 Cummins Inc.
External Engine Parts
3456
7
89
8
10 13
14
1516
18
11 12 2 1
17
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 502−1479 1 Adapter (M27 to 3/4)2 504−0251 1 Valve, Ball3 856−0013 2 Washer, Lock − W/EIT (1/2)4 526−2140 2 Washer, Flat (M12)5 850−2012 2 Washer, Lock − Spring (M12)6 800−2111 2 Screw, Cap − Hex Head (M12 x
1.75 x 25)7 416−0680 2 Cable, Battery − Starters8 416−1096 2 Cable, Jumper9 416−0639 4 Cable, Battery
10 416−1019 2 Boot, Battery − Red11 503−2386 − Hose − Bulk (Order by the Foot
− 3 Feet Rquired)
12 503−0398 1 Clamp, Hose13 337−0090−01 1 Strap, Electrical14 416−1084−01 2 Boot, Starter − Red15 502−1589 1 Elbow, Tube16 416−0632 1 Cable, Starter17 509−0353 1 Seal, O Ring18 Belt, Fan
0511−0161−25 1 Used on 40 Bearward Radiator Only
0511−0161−27 1 Used on IEA 50 Radiator Only
7Copyright 2016 Cummins Inc.
Fuel Filter
1
2
3
4
5
6
7
8
9
10 11
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 149−2792 1 Filter, Fuel2 149−2800−02 1 Bracket, Fuel Filter3 502−1588 1 Elbow, Tube4 501−0970−01 1 Line, Fuel5 800−0050 11 Screw, Cap − Hex Head
(3/8−16 x 1)6 526−0030 11 Washer, Flat (3/8)
7 850−0050 11 Washer, Split − Lock (3/8)8 505−0023 1 Bushing, Reducer (1-1/4 x 1)9 502−1592 1 Elbow, Tube
10 496418300 1 Harness, Accessory − FuelFilter
11 496416300 2 Harness, Extension − FuelFilter
8Copyright 2016 Cummins Inc.
Air Cleaner
11
2
2
3
4
5
6
7
8
9
10
11
11
11
11
11
11
11
11
12
13
1415
1626
17
2021
22
2318
24
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 503−2102 4 Elbow, Reducer − 902 503−0970−01 4 Elbow3 503−1705 2 Hose (7”)4 104−3518−02 2 Tube, Air Cleaner5 104−3504−02 1 Bracket, Air Cleaner − Vertical
Right6 104−3506−02 1 Bracket, Air Cleaner − Plate7 104−3507−02 1 Bracket, Air Cleaner − Angle8 104−3505−02 1 Bracket, Air Cleaner − Vertical
Left9 821−6003−02 41 Screw, Hex Head (M8 x 1.25 x
20)10 140−3508−02 1 Bracket, Air Cleaner − Top11 503−1870−14 18 Clamp, Hose12 503−1870−11 4 Clamp, Hose13 140−3517−02 1 Bracket, Air Cleaner14 140−3516−02 2 Tube, Air Cleaner
15 140−3515−02 2 Tube, Air Cleaner16 140−3288−02 4 Housing, Air Cleaner − Flame
Retardant17 140−1260 4 Fitting, Safety Filter18 870−2065−03 3 Nut, Hex − Flange19 517−0080 4 Plug, Tapered (Not Illustrated)20 800−2201 4 Screw, Cap − Hex Head (M20 x
2.5 x 35)21 850−2020 4 Washer, Lock (M20)22 155−4101 2 Shield, Heat23 098−7954 1 Label, Information24 140−3546−02 1 Bracket, Air Cleaner − Angled25 503−1870−13 2 Clamp (Not illustrated, fitment
with 140−3517−02)26 A029Y303 4 Element, Replacement (Not
Illustrated) (Fleetguard PartNumber)
9Copyright 2016 Cummins Inc.
Heavy Duty Air Cleaner
1,2,
3,
4, 5,
6,
7,
9,
10
11,
12,
13
14
15,
16,
25,
17
20,21
22
23
18,
24,
20,21
34
31
20
29
20
26
30
19,20
28,27
28,27
23
23, 25,26
2323
8
24,
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 140−3640−02 1 Bracket, Air Filter2 140−3641−02 1 Bracket, Air Filter3 140−3642−02 1 Bracket, Air Filter4 140−3948−02 1 Bracket, Air Filter5 140−3947−02 1 Bracket, Air Filter6 140−3582−02 1 Bracket, Air Filter7 140−3507−02 1 Bracket, Air Filter8 140−3644−02 1 Bracket, Air Filter9 140−2099 8 Band, Mounting
10 140−3230 4 Filter, Air11 503−1485 1 Elbow, 9012 503−1721 3 Hose, Hump13 A026H421 2 Tube, Air Filter14 140−3913−17 1 Filter, Air15 503−0970−01 3 Elbow16 503−2012 4 Elbow, Reducer17 140−3913−16 2 Filter, Air
18 140−3565−02 1 Bracket, Tube19 503−1870−11 4 Clamp, Hose20 503−1870−14 15 Clamp, Hose21 503−1870−16 4 Clamp, Hose22 155−4101 2 Shield, Heat23 821−6003−02 31 Screw, Hex Head24 526−2120 1 Washer, Flat25 800−2086 16 Screw, Hex Head26 870−2203 16 Nut, Hex Flange27 850−2020 4 Washer, Lock28 800−2201 4 Screw, Hex Head29 140−2098 4 Hood, Air Inlet30 517−0080 2 Plug, Plastic31 A026H422 1 Tube, Air Filter32 140−1260 2 Fitting, Filter33 140−1548 2 Indicator, Service34 140−3913−11 1 Tube, Air
Copyright 2016 Cummins Inc. 10
Engine Coolant Heater
1
1
2
2
3
4 5
6
76
8
910
11
12
13
14
15
16
1718 19
20
21
22
2324
25
26
27
32
282930
31
Copyright 2016 Cummins Inc. 11
Engine Coolant Heater
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Bracket, Water Heater130−4546 2 Non−IBC SeismicA030A089 2 IBC Seismic
2 Heater, Water333−0677−01 2 4990 Watts333−0677−02 2 6420 Watts
3 154−3161 1 Manifold, Heater4 130−6491 1 Tube, Heater5 130−6493 1 Tube, Heater6 502−1704 2 Hose, Connector7 505−2112 1 Adapter, Pipe (M42 x 1 NPT)8 504−0213 2 Valve, Ball9 509−0379 1 Seal, O-Ring
10 130−6490 1 Tube, Water Heater11 319−6838 1 Cover, Control12 130−6489 1 Tube, Water Heater13 130−6492 1 Tube, Water Heater14 518−0548−24 2 Clamp, Hose15 332−2634 3 Clamp, “J”16 1 Control Assembly, Heater
(See Separate Page forComponents)
17 503−3062−01 9 Hose, Silicone − Rubber18 503−2157−02 18 Clamp, Hose19 128−0108 16 Insulation, Hose20 509−0378 1 Seal, O−Ring (M42)21 155−3021 2 Clamp, Water Heater22 870−0550−09 4 Nut, Hex Flange (3/8−16)23 130−5089−04 1 Tube Assembly, Heater24 509−0283−01 1 Seal, Rect. Ring25 501−0744−05 1 Hose Assembly, Coolant26 870−0131 6 Nut, Hex − W/ET (#8−32)27 502−1318 1 Adapter, Pipe (M14 x 1/4)28 821−5002−03 4 Screw, Hex Head SEMS
(1/4−20 x 5/8”)29 526−0128 2 Washer, Flat30 821−6003−02 11 Screw, Hex Head SEMS (M8 x
1−1/4 x 20)31 815−0539 6 Screw, Cross Recessed
(#8−32 x 5/8”)32 A030X518 1 Switch, Temperature
12Copyright 2016 Cummins Inc.
Coolant Heater Control
14
16
1520
22
23
21
17
18
19
1
2
2
3
3
4
5
6
7
7
8
9
10
11
12
13
24
25
26
27
28
29
29
30
31
13Copyright 2016 Cummins Inc.
Coolant Heater Control
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−4787−02 1 Box, Terminal2 130−4552 2 Cover, Coolant Heater3 331−0555 5 Nut, Connector Lock (3/4−14)4 517−0138−02 2 Plug, Hole (Fits 1−1/8” Hole)5 332−1469 1 Strip, Marker6 332−1468 1 Block, Terminal − 12 Place
(TB1)7 307−3089 2 Relay, Power8 815−0447 2 Screw, Machine − Round Head
− Cross Recessed W/IT −(#8−32 x 3/4”)
9 332−3440 2 Jumper, Terminal10 331−0042 1 Connector, Wiring − DC −
Romex (3/4”)11 338−4995−03 1 Harness, Wiring − Eng.12 338−4995−05 1 Harness, Wiring − Eng.13 338−4986 1 Harness, Wiring − (Includes
Parts Marked *)14 357−0030 1 * Rectifier (6 Amp)15 323−1491 3 * Pin, Contact16 323−1492 4 * Socket, Contact17 323−1494 1 * Connector, Receptacle (3 Pin)
18 323−1502 1 * Wedge, Receptacle19 323−1504 2 * Connector, Plug (2 Pin)20 323−1500 2 * Wedge, Plug21 323−1652 1 * Connector, Plug − 2−Way (2
Pin)22 323−1718 2 * Pin, Contact23 323−1445 2 * Seal, Cable24 815−0203 1 Screw, Machine − Round Head
W/ET (#10−32 x 7/8”)25 856−0003 1 Washer, ET Lock (#10)26 871−0010 1 Nut, Hex Brass (#10−32)27 526−0049 2 Washer, Flat Brass (#10)28 870−0131 1 Nut, Hex w/ ET (#10−32)29 815−0446 4 Screw, Round Head − Cross
Recessed − Thread Cutting −W/IT (#8−32 x .50)
30 098−7244 1 Label, Danger31 098−2235−02 1 Label, Ground
* − Parts Included In 338−4986 Wiring Harness
14Copyright 2016 Cummins Inc.
Low Coolant Level Sensor
1
2
345
6
789
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 193−0602 1 Sensor, Level − Coolant2 338−4858 1 Harness, Engine − Low Coolant
(Includes the Following Items)3 323−2432 1 Connector, Plug4 323−2430 2 Seal, Connector
5 323−2431 1 Connector, Receptacle6 898−1195−02 A/R Sleeving, Convoluted7 323−1549 1 Connector, Receptacle8 323−1547 1 Wedge, Receptacle9 323−1591 2 Plug, Seal
15Copyright 2016 Cummins Inc.
This Page Intentionally Left Blank.
16Copyright 2016 Cummins Inc.
Remote Radiator
47
17
41
42
43
4445
4648
8911
1213161821
312427321130
26293328
7810
48
12356
23
3435
1415
14151920
342536373839
40
17Copyright 2016 Cummins Inc.
Remote Radiator
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−5458−02 1 Bracket, Support2 526−0399−75 2 Washer, Flat (M16)3 800−6284−01 2 Screw, Cap − Hex Head (M16 x
2 x 180)4 130−5281−02 1 Bracket, Guard5 526−0399−64 2 Washer, Flat (M12)6 800−3017−54 2 Screw, Cap − Hex Head (M12 x
1.75 x 30)7 130−6518−02 1 Cover, Guard − Left8 821−6003−01 18 Screw, Hex Head (M8 x 1.25 x
16)9 130−6519−02 1 Cover, Guard
10 130−6520−02 1 Cover, Guard11 Screw, Hex Head (M8 x 1.25 x
25)821−6003−03 3 Without Flanges821−6003−03 5 With Flanges
12 502−1326 1 Adapter, Pipe (M33 x 3/4)13 505−0754 1 Nipple, Pipe (3/4 x 6.00)14 503−2129−04 2 Line, Radiator Vent15 502−1318 2 Adapter, Pipe (M14 x 1/4)16 505−0051 1 Elbow, Street − 90 (3/4)17 338−4858 1 Harness, Wiring − Low Coolant
Level (Includes PartsMarked *)
18 504−0171 1 Valve19 309−0635−02 1 Valve, Check20 505−0153 1 Coupling, Reducer (3/8 x 1/4)21 505−0324 1 Nipple, Half (3/8)22 370−4081 8 Spacer − CT (Not Shown)23 526−0393 3 Washer, Flat (M10)24 130−4517 1 Tube, Water Inlet − With
Flanges25 A026E452 3 Tube, Water Outlet − With
Flanges26 130−7097−02 1 Tube, Water Inlet − With
Flanges
27 503−1726 1 Hose, Radiator (5.00 x 6.00) −With Flanges
28 503−1728 1 Hose, Radiator (3.00 x 5.50) −With Flanges
29 503−1872−05 2 Clamp, Hose − With Flanges30 503−1872−09 2 Clamp, Hose − With Flanges31 130−8092−02 1 Bracket, Tube − With Flanges32 155−3290 1 Clamp, Muffler (5 in. Dia.) −
With Flanges33 155−3289 1 Clamp, Muffler (3 in. Dia.) −
With Flanges34 130−3684 6 Gasket, Connection − With
Flanges35 130−5084−02 3 Tube, Water Outlet − With
Flanges36 800−3017−41 9 Screw, Cap − Hex Head (M10 x
1.5 x 45) − With Flanges37 526−0399−62 9 Washer, Flat (M10) − With
Flanges38 850−0114−55 9 Washer, Lock − Split (M10) −
With Flanges39 862−0026−56 9 Nut, Hex (M10 x 1.5) − With
Flanges40 503−2129−05 1 Line, Radiator Vent41 323−2432 1 * Connector, Plug42 323−2433 2 * Contact, Socket43 323−2430 2 * Seal, Connector44 323−2431 1 * Connector, Receptacle45 323−2275 2 * Contact, Pin46 323−1549 1 * Connector, Receptacle47 323−1547 1 * Wedge, Receptacle48 323−1591 1 * Plug, Seal
* − Parts Included In 338−4858 Wiring Harness
18Copyright 2016 Cummins Inc.
RadiatorDQKAB − Enhanced High Ambient
2, 56
810
15
1413 12
11
4
1
43,
9
9
9
7
9
77
23
22
11
11
18
21,
207
9
7
9
7
24
26
27
28
11
810
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 A030D337 1 Radiator2 A030S345 1 Bracket, Pipe3 130−5356 2 Pipe (I.D. 127)4 503−1872−01 3 Clamp, Hose5 A030S350 1 Pipe (Bottom)6 503−2661 2 Clamp, Hose7 503−2658 9 Pipe (I.D. 76.2)8 A029Y804 2 Vent, Line9 503−2641 18 Clamp, Hose
10 A029Y814 2 Vent, Line11 A029Y817 3 Vent, Line12 130−5714 1 Duct, Transition R/H13 A030S325 2 Guard, Fan14 A030S327 2 Guard, Fan15 130−7407 2 Cap, Radiator
16 A029B928 1 Belt (Not Shown)17 130−5554 1 Fan (Not Shown)18 130−5420 37 Screw, with Washer (M8 x 25)19 A030S420 1 Pipe (I.D. 127)20 503−2693 3 Clamp, U−Bolt21 130−5354 1 Hose, J/W 4”22 130−6743 1 Tube, Radiator J/W R/H23 130−6742 1 Tube, Radiator J/W L/H24 130−8238 1 Hose, J/W25 A030S346 51 Screw, with Washer (M6 x 20)26 503−1872−05 2 Clip, 95−11727 SP64430 1 Clamp, U−Bolt 4”28 A030S415 1 Pipe (I.D. 127)29 A029X986 1 Sight Gauge (Mounted to Top
Tank)
19Copyright 2016 Cummins Inc.
Guard−Kit
7
5
1
2
34
6
8
9
10
11
12
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 A030S330 1 Guard (Bottom RH)2 A030S331 1 Guard (Top)3 A030S337 1 Guard (Front)4 A030S338 1 Guard (Bottom)5 A030S339 1 Guard (Infill RH)6 A030S342 1 Guard (Extension)
7 A030S343 1 Guard (Infill Angle)8 130−5841 1 Guard Belt (Rear)9 130−6758 1 Bracket, Radiator
10 130−5886 1 Bracket, Radiator11 130−5888 1 Bracket, Radiator12 130−5846 1 Bracket, Fan Guard
20Copyright 2016 Cummins Inc.
Fan−Drive
1
2
REF PART QTY. PARTNO. NO. USED DESCRIPTION
1 512−0309 1 Pulley2 511−0161−27 1 Belt−V Ribbed
21Copyright 2016 Cummins Inc.
Radiator (40)
16 1718
19 20
21
12
1
14
3
5
5
4
14
7
15
11
268
9
10
13
13
268
22
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
179−4759 1 Radiator − Complete1 A029B928 1 Belt2 130−5420 37 Bolt, C/W Washer (M8 x 25)3 800−2175 12 Bolt (M16 x 50)4 860−2034 12 Nut, Nyloc (M16)5 526−0038 24 Washer, Flat (M16)6 130−6748 4 Duct, Radiator (Trans Frame
Side)7 130−6749 2 Gauge, Sight8 130−5419 23 Nut, Comby (M8)9 130−8150 1 Slab, J/W Radiator (Consists
of 4 Cores − P/N 130−5709)10 130−8143 1 Slab, LTA Radiator (Consists
of 4 Cores − P/N 130−5710)
11 130−6764 4 Stoneguard12 130−5554 1 Fan13 A030S325 2 Guard, Fan14 A030S327 2 Guard, Fan15 130−5325 2 Cap, Radiator (110 KPA)16 098−5822 4 Label (Lifting/Warning)17 098−4730 4 Label (Hot Pressurized
Coolant)18 098−6775 4 Label (Water Drain)19 098−5393 2 Label (Rotating Fan)20 098−4732 2 Label (Voltage & Rotating
Parts)21 098−8432 1 Label (Grease)22 541−1684 1 Kit, LTA and J/W Gasket
22Copyright 2016 Cummins Inc.
Radiator Hoses (40)
18
19
1210
12
10
10
10
10
12
12
12
10
12
24
22
20
3
3
4
4
52
1
11 8
79
136
21151623
17
14
2526
27
28
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 A030S345 1 Bracket, Support2 SP64430 1 Clamp, U-Bolt (4”)3 130−5356 2 Hose, J/W (127 ID)4 503−2692 4 Clip (133−155)5 A030S415 1 Pipe, J/W (127 OD)6 503−2693 3 U-Bolt7 A030S350 1 Pipe, J/W (Bottom)8 503−2661 2 Clip (95−117)9 130−5354 1 Hose, J/W
10 130−5353 9 Hose, Radiator (3”)11 A030S346 1 Pipe, LTA (Bottom)12 503−2641 18 Clip (70−92)13 130−6740 3 Bracket, Pipe Support14 130−8238 1 Pipe, LTA (Top)
15 526−0219 60 Washer, Flat (1/2)16 526−2342 6 Washer, Flat (M12)17 403−6151 3 Strip, Foam18 130−6742 1 Pipe, J/W (Top L/H)19 130−6743 1 Pipe, J/W (Top R/H)20 130−5713 1 Line, J/W Vent21 130−6744 3 Bracket, Pipe Support22 A030S414 1 Line, LTA Vent23 130−5419 23 Nut, Comby (M8)24 130−5714 1 Line, LTA Vent25 503−2452 2 Hose (25.4 I/D)26 503−1872−01 4 Clamp27 503−2451 2 Hose (57.2 I/D)28 503−1872−04 4 Clamp
23Copyright 2016 Cummins Inc.
Radiator Guards (40)
912
31216
1512
712
612
101 8
14512
11
131
1412
212
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 130−5420 37 Bolt, C/W Washer (M8 x 25)2 A030S330 1 Guard, Bottom R/H Panel3 860−2033 2 Nut, Comby (M6)4 130−5419 23 Nut, Comby (M8)5 130−6752 1 Guard, Radiator (Lower Rear)6 130−5841 1 Guard, Radiator (Upper Rear)7 A030S331 1 Guard, Top Panel8 A030S337 1 Guard, Front Panel
9 A030S338 1 Guard, Bottom Panel10 130−5846 1 Guard, Side Bracket (L/H)11 130−5886 1 Guard, Side Bracket (R/H)12 130−5418 51 Bolt, C/W Washer (M6 x 20)13 130−6762 1 Guard, Side Bracket (R/H)14 A030S339 1 Guard, Infill Panel (R/H)15 A030S342 1 Guard, Extension Panel16 A030S343 1 Guard, Infill Angle
24Copyright 2016 Cummins Inc.
Skid
1
2
3
4
4
5
5
5
6
7
8
9
9
1011
11
12
12
13
14
15
16
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 SkidA030A665 1 Radiator SkidA030C149 1 Remote Radiator Skid
2 800−3047−04 2 Screw, Cap − Hex Head (M20 x2.5 x 100)
3 403−4332 2 Spacer, Engine Mounting (1” IDx 5” OD x 2−9/32” Thk)
4 860−2023−01 6 Nut, Hex (M20 x 2.5)5 526−0399−76 12 Washer, Flat (M20)6 800−2206 8 Screw, Cap − Hex Head (M20 x
2.5 x 60)7 800−2208 4 Screw, Cap − Hex Head (M20 x
2.5 x 70)8 800−3047−03 4 Screw, Cap − Hex Head (M20 x
2.5 x 130)9 526−0460−02 4 Washer, Generator Mounting
10 800−3048−04 4 Screw, Cap − Hex Head (M24 x3 x 120) − P80 Alternators
11 526−0399−78 4 Washer, Flat (M24)12 860−2024−01 4 Nut, Hex (M24 x 3)13 232−4061 4 Spacer, Generator Mounting
(1−1/16” ID x 5” OD x 2−1/8”Thk) − P7 Alternators
14 800−3048−02 4 Screw, Cap − Hex Head (M24 x3 x 160) − P7 Alternators
15 Shim, Generator Mounting(Quantity Used As Required)
232−3710−01 1 .0239” Thk232−3710−02 1 .0747” Thk232−3710−03 1 .1345” Thk232−3710−07 1 .0149” Thk
16 Line, Fuel − Flexible501−0918 1 Fuel In501−0919 1 Fuel Out
25Copyright 2016 Cummins Inc.
Skid (IBC)
1
2
3
4
4
5
5
5
6
7
8
9
9
1011
11
12
12
13
14
15
16
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 A030A665 Skid2 800−3047−04 2 Screw, Cap − Hex Head (M20 x
2.5 x 100)3 403−4332 2 Spacer, Engine Mounting (1” ID
x 5” OD x 2−9/32” Thk)4 860−2023−01 6 Nut, Hex (M20 x 2.5)5 526−0399−76 12 Washer, Flat (M20)6 800−2206 8 Screw, Cap − Hex Head (M20 x
2.5 x 60)7 800−2208 4 Screw, Cap − Hex Head (M20 x
2.5 x 70)8 800−3047−03 4 Screw, Cap − Hex Head (M20 x
2.5 x 130)9 526−0460−02 4 Washer, Generator Mounting
10 800−3048−04 4 Screw, Cap − Hex Head (M24 x3 x 120) − P80 Alternators
11 526−0399−78 4 Washer, Flat (M24)12 860−2024−01 4 Nut, Hex (M24 x 3)13 232−4061 4 Spacer, Generator Mounting
(1−1/16” ID x 5” OD x 2−1/8”Thk) − P7 Alternators
14 800−3048−02 4 Screw, Cap − Hex Head (M24 x3 x 160) − P7 Alternators
15 Shim, Generator Mounting(Quantity Used As Required)
232−3710−01 1 .0239” Thk232−3710−02 1 .0747” Thk232−3710−03 1 .1345” Thk232−3710−07 1 .0149” Thk
16 Line, Fuel − Flexible501−0918 1 Fuel In501−0919 1 Fuel Out
26Copyright 2016 Cummins Inc.
Isolator
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 A030S164 1 Isolator (Spec A−D)2 402−0750−01 1 Isolator (Spec E)
27Copyright 2016 Cummins Inc.
Entrance Box
12
3
4
5
6 7
8
9
10
11
12
13
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5161−02 1 Box, Circuit Breaker2 319−5084−02 1 Panel, Terminal3 319−5171−02 1 Cover, Circuit Breaker − Bottom
Entrance4 319−5162−02 1 Cover, Circuit Breaker − Top
and Bottom Entrance5 319−5088−02 1 Cover, Circuit Breaker6 821−6003−02 69 Screw, Hex (M8 x 1.25 x 20)7 A034K745 1 Bracket, Circuit Breaker8 319−5102−04 1 Stiffener, Cover
9 821−6002−03 8 Screw, Hex (M6 x 1 x 16)10 098−6635 1 Label, Ground11 319−5163−02 1 Cover, Circuit Breaker −
Adapter Plug − Top andBottom Entrance
12 319−5176−06 1 Cover, Circuit Breaker − Front13 Label, Danger
098−5347 1 English098−5347−02 1 French
28Copyright 2016 Cummins Inc.
Entrance Box
3
7
9 2
6
6
5
9
12
1213
7
12
1514
16
11
11
1
10
8
12
4
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 330−0169−02 1 Box, Outlet2 330−0172−02 1 Cover, Outlet Box3 330−0181−02 1 Cover, Outlet Box4 330−0170−02 1 Cover, Outlet Box5 330−0171−02 1 Cover, Outlet Box6 319−5877 2 Stiffener, Cover7 319−5988−02 2 Panel, Output Box8 319−5989−02 1 Panel, Output Box9 319−6049−02 2 Panel, Output Box
10 319−6045−02 1 Panel, Output Box11 319−5897−02 2 Panel, Mounting12 821−6003−02 124 Screw, Hex Head (M8 x 1.25 x
20)13 856−0008 4 Washer, Lock − W/EIT (5/16)14 850−0114−05 2 Washer, Lock − Split (1/4)15 856−0006 2 Washer, Lock − W/EIT (1/4)16 800−0310−03 4 Screw, Cap − Hex Head
(1/4−20 x 5/8)
29Copyright 2016 Cummins Inc.
This Page Intentionally Left Blank.
30Copyright 2016 Cummins Inc.
Entrance Box AssemblyTop Entry
Illustration #1
1
23
27
23 18
4
23 6
22
25
3548
28
202138
48
4343
42
41
26
202138
46
46
47
10113337
36
17
35
33
22
6
19
16
29 30 3132
226
2449
52
31Copyright 2016 Cummins Inc.
Entrance Box AssemblyTop Entry
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5895−02 2 Channel, Support2 872−0036 4 Standoff3 319−5896 4 Plate, Mounting4 337−3772 1 Bus, Bar5 332−4134 8 Lug, Cable6 821−6003−02 52 Screw, Hex Head (M8 x 1.25 x
20)7 526−0399−20 16 Washer, Flat (3/8) (Not Shown)8 851−0022 16 Washer, Spring (3/8) (Not
Shown)9 800−0310−36 32 Screw, Cap − Hex Head
(3/8−16 x 1)10 850−0114−54 8 Washer, Lock − Split (M12)11 862−0026−55 8 Nut, Hex (M8 x 1.25)12 800−2112 20 Screw, Cap − Hex Head (M12 x
1.75 x 30)13 851−0048−03 25 Washer, Belleville (M12)14 860−2010 20 Nut, Hex (M12 x 1.75)15 526−2140 20 Washer, Flat (M12)16 319−5887−02 1 Panel17 319−5987−02 2 Panel, Output Box18 508−1057 1 Grommet19 330−0186 2 Cover, Outlet Box20 800−3017−56 24 Screw, Locking − Flange (M12
x 1.75 x 40)21 526−0399−64 32 Washer, Flat22 856−0008 5 Washer, Lock − W/EIT (5/16)23 856−0013 1 Washer, Lock − W/EIT (1/2)24 850−0050 36 Washer, Lock − Spring (3/8)25 319−6050−02 1 Bracket, Terminal Block26 337−3789 1 Bus, Bar (MV/HV)27 337−3788 1 Bus, Bar (MV/HV)28 337−3814 1 Bus, Bar (MV/HV)29 335−0251−01 1 Cable − Assembly
30 335−0251−02 1 Cable − Assembly31 335−0251−03 1 Cable − Assembly32 335−0251−04 1 Cable − Assembly33 821−6003−03 8 Screw, Hex Head (M8 x 1.25 x
25)34 098−5822 2 Label, Warning − Lifting35 335−0249−02 1 Cable − Assembly36 337−3785 1 Bus, Bar − Ground37 526−0399−60 8 Washer, Flat (M8)38 850−0114−56 24 Washer, Lock − Split (M12)39 870−2055 8 Nut, Hex (M8 x 1.25) (Not
Shown)40 098−7902−03 1 Label, Logo41 319−6229−02 1 Bracket, Cable42 319−6587 1 Channel, Mounting43 332−4170 4 Clamp, Cable44 098−5347 1 Label, Danger45 098−5347−02 1 Label, Danger − French46 Label, Marker (10 Characters
Per Card) (Quantity Used AsRequired)
098−5854−06 4 Marked “L”098−5854−07 1 Marked “1”098−5854−08 1 Marked “2”098−5854−09 1 Marked “3”098−5854−10 1 Marked “0”
47 098−6635 1 Label, Ground48 332−2921 2 Clamp, J49 800−0051 4 Screw, Cap − Hex Head
(3/8−16 x 1-1/4)50 800−0050 32 Screw, Cap − Hex Head
(3/8−16 x 1)51 526−0030 32 Washer, Flat (3/8)52 862−0003 4 Nut, Hex (3/8−16)
32Copyright 2016 Cummins Inc.
Entrance Box AssemblyTop Entry
Illustration #2
22
22 19
42
43
6
41
6
17
46
46
48
48
35
24
12
131514
14
15
5 1314
34
40
44
45
50
51
33Copyright 2016 Cummins Inc.
Entrance Box AssemblyTop Entry
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5895−02 2 Channel, Support2 872−0036 4 Standoff3 319−5896 4 Plate, Mounting4 337−3772 1 Bus, Bar5 332−4134 8 Lug, Cable6 821−6003−02 52 Screw, Hex Head (M8 x 1.25 x
20)7 526−0399−20 16 Washer, Flat (3/8) (Not Shown)8 851−0022 16 Washer, Spring (3/8) (Not
Shown)9 800−0310−36 32 Screw, Cap − Hex Head
(3/8−16 x 1)10 850−0114−54 8 Washer, Lock − Split (M12)11 862−0026−55 8 Nut, Hex (M8 x 1.25)12 800−2112 20 Screw, Cap − Hex Head (M12 x
1.75 x 30)13 851−0048−03 25 Washer, Belleville (M12)14 860−2010 20 Nut, Hex (M12 x 1.75)15 526−2140 20 Washer, Flat (M12)16 319−5887−02 1 Panel17 319−5987−02 2 Panel, Output Box18 508−1057 1 Grommet19 330−0186 2 Cover, Outlet Box20 800−3017−56 24 Screw, Locking − Flange (M12
x 1.75 x 40)21 526−0399−64 32 Washer, Flat22 856−0008 5 Washer, Lock − W/EIT (5/16)23 856−0013 1 Washer, Lock − W/EIT (1/2)24 850−0050 36 Washer, Lock − Spring (3/8)25 319−6050−02 1 Bracket, Terminal Block26 337−3789 1 Bus, Bar (MV/HV)27 337−3788 1 Bus, Bar (MV/HV)28 337−3814 1 Bus, Bar (MV/HV)29 335−0251−01 1 Cable − Assembly
30 335−0251−02 1 Cable − Assembly31 335−0251−03 1 Cable − Assembly32 335−0251−04 1 Cable − Assembly33 821−6003−03 8 Screw, Hex Head (M8 x 1.25 x
25)34 098−5822 2 Label, Warning − Lifting35 335−0249−02 1 Cable − Assembly36 337−3785 1 Bus, Bar − Ground37 526−0399−60 8 Washer, Flat (M8)38 850−0114−56 24 Washer, Lock − Split (M12)39 870−2055 8 Nut, Hex (M8 x 1.25) (Not
Shown)40 098−7902−03 1 Label, Logo41 319−6229−02 1 Bracket, Cable42 319−6587 1 Channel, Mounting43 332−4170 4 Clamp, Cable44 098−5347 1 Label, Danger45 098−5347−02 1 Label, Danger − French46 Label, Marker (10 Characters
Per Card) (Quantity Used AsRequired)
098−5854−06 4 Marked “L”098−5854−07 1 Marked “1”098−5854−08 1 Marked “2”098−5854−09 1 Marked “3”098−5854−10 1 Marked “0”
47 098−6635 1 Label, Ground48 332−2921 2 Clamp, J49 800−0051 4 Screw, Cap − Hex Head
(3/8−16 x 1-1/4)50 800−0050 32 Screw, Cap − Hex Head
(3/8−16 x 1)51 526−0030 32 Washer, Flat (3/8)52 862−0003 4 Nut, Hex (3/8−16)
34Copyright 2016 Cummins Inc.
Entrance Box AssemblyBottom EntryIllustration #1
1
23
26
11 9 10
8
321335
6 7
54
333445
3852
36
31
30 39
3032
3035
43
1335
1335
13
40
13
1335
32
35
24
28
27 27
25
23
41
47
48
49
35Copyright 2016 Cummins Inc.
Entrance Box AssemblyBottom Entry
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5895−02 2 Channel, Support2 872−0036 4 Standoff3 319−5896 4 Plate, Mounting4 337−3780 1 Bus, Bar5 337−3766 1 Bus, Bar6 337−3772 1 Bus, Bar7 337−3773 1 Bus, Bar8 335−0251−06 1 Cable − Assembly9 335−0251−07 1 Cable − Assembly
10 335−0251−08 1 Cable − Assembly11 335−0251−05 1 Cable − Assembly12 332−4134 8 Lug, Cable13 821−6003−02 57 Screw, Hex Head (M8 x 1.25 x
20)14 526−0399−20 16 Washer, Flat (3/8)15 851−0022 16 Washer, Spring (3/8)16 800−0310−36 32 Screw, Cap − Hex Head
(3/8−16 x 1)17 850−0114−54 8 Washer, Lock − Split (M12)18 862−0026−55 8 Nut, Hex (M8 x 1.25)19 800−2112 20 Screw, Cap − Hex Head (M12 x
1.75 x 30)20 851−0048−03 25 Washer, Belleville (M12)21 860−2010 20 Nut, Hex (M12)22 526−2140 20 Washer, Flat (M12)23 332−4160−02 1 Housing, Terminal − Duct24 332−4161−02 1 Housing, Terminal − Duct25 332−4176−02 1 Housing, Terminal − Duct26 319−5887−02 1 Panel27 332−4178−02 2 Housing, Terminal Base28 332−4177−02 1 Housing, Terminal − Duct29 319−5987−02 2 Panel, Output Box30 821−6003−01 4 Screw, Hex Head (M8 x 1.25 x
16)31 508−1057 1 Grommet32 330−0186 2 Cover, Outlet Box
33 800−3017−56 24 Screw, Locking − Flange (M12x 1.75 x 40)
34 526−0399−64 32 Washer, Flat35 856−0008 6 Washer, Lock − W/EIT (5/16)36 856−0013 1 Washer, Lock − W/EIT (1/2)37 850−0050 36 Washer, Lock − Spring (3/8)38 335−0249−01 1 Cable, Ground39 319−6050−02 1 Bracket, Terminal Block40 821−6003−03 8 Screw, Hex Head (M8 x 1.25 x
25)41 098−5822 2 Label, Warning − Lifting42 337−3785 1 Bus, Bar − Ground43 337−0049 1 Strap, Bond44 526−0399−60 8 Washer, Flat (M8)45 850−0114−56 24 Washer, Lock − Split (M12)46 870−2055 8 Nut, Hex (M8 x 1.25) (Not
Shown)47 098−7902−03 1 Label, Logo48 098−5347 1 Label, Danger49 098−5347−02 1 Label, Danger − French50 Label, Marker (10 Characters
Per Card) (Quantity Used AsRequired)
098−5854−06 4 Marked “L”098−5854−07 1 Marked “1”098−5854−08 1 Marked “2”098−5854−09 1 Marked “3”098−5854−10 1 Marked “0”
51 098−6635 1 Label, Ground52 332−2921 1 Clamp, J53 800−0051 4 Screw, Cap − Hex Head
(3/8−16 x 1-1/4)54 800−0050 32 Screw, Cap − Hex Head
(3/8−16 x 1)55 526−0030 32 Washer, Flat (3/8)56 862−0003 4 Nut, Hex (3/8−16)
36Copyright 2016 Cummins Inc.
Entrance Box AssemblyBottom EntryIllustration #2
38
42
50
50
13171844
13171844
50
50
51
38
42
11
5
1637
23
2120 22
19
12
2120
22
19
23
23
29
533756
3754
55
37Copyright 2016 Cummins Inc.
Entrance Box AssemblyBottom Entry
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5895−02 2 Channel, Support2 872−0036 4 Standoff3 319−5896 4 Plate, Mounting4 337−3780 1 Bus, Bar5 337−3766 1 Bus, Bar6 337−3772 1 Bus, Bar7 337−3773 1 Bus, Bar8 335−0251−06 1 Cable − Assembly9 335−0251−07 1 Cable − Assembly
10 335−0251−08 1 Cable − Assembly11 335−0251−05 1 Cable − Assembly12 332−4134 8 Lug, Cable13 821−6003−02 57 Screw, Hex Head (M8 x 1.25 x
20)14 526−0399−20 16 Washer, Flat (3/8)15 851−0022 16 Washer, Spring (3/8)16 800−0310−36 32 Screw, Cap − Hex Head
(3/8−16 x 1)17 850−0114−54 8 Washer, Lock − Split (M12)18 862−0026−55 8 Nut, Hex (M8 x 1.25)19 800−2112 20 Screw, Cap − Hex Head (M12 x
1.75 x 30)20 851−0048−03 25 Washer, Belleville (M12)21 860−2010 20 Nut, Hex (M12)22 526−2140 20 Washer, Flat (M12)23 332−4160−02 1 Housing, Terminal − Duct24 332−4161−02 1 Housing, Terminal − Duct25 332−4176−02 1 Housing, Terminal − Duct26 319−5887−02 1 Panel27 332−4178−02 2 Housing, Terminal Base28 332−4177−02 1 Housing, Terminal − Duct29 319−5987−02 2 Panel, Output Box30 821−6003−01 4 Screw, Hex Head (M8 x 1.25 x
16)31 508−1057 1 Grommet32 330−0186 2 Cover, Outlet Box
33 800−3017−56 24 Screw, Locking − Flange (M12x 1.75 x 40)
34 526−0399−64 32 Washer, Flat35 856−0008 6 Washer, Lock − W/EIT (5/16)36 856−0013 1 Washer, Lock − W/EIT (1/2)37 850−0050 36 Washer, Lock − Spring (3/8)38 335−0249−01 1 Cable, Ground39 319−6050−02 1 Bracket, Terminal Block40 821−6003−03 8 Screw, Hex Head (M8 x 1.25 x
25)41 098−5822 2 Label, Warning − Lifting42 337−3785 1 Bus, Bar − Ground43 337−0049 1 Strap, Bond44 526−0399−60 8 Washer, Flat (M8)45 850−0114−56 24 Washer, Lock − Split (M12)46 870−2055 8 Nut, Hex (M8 x 1.25) (Not
Shown)47 098−7902−03 1 Label, Logo48 098−5347 1 Label, Danger49 098−5347−02 1 Label, Danger − French50 Label, Marker (10 Characters
Per Card) (Quantity Used AsRequired)
098−5854−06 4 Marked “L”098−5854−07 1 Marked “1”098−5854−08 1 Marked “2”098−5854−09 1 Marked “3”098−5854−10 1 Marked “0”
51 098−6635 1 Label, Ground52 332−2921 1 Clamp, J53 800−0051 4 Screw, Cap − Hex Head
(3/8−16 x 1-1/4)54 800−0050 32 Screw, Cap − Hex Head
(3/8−16 x 1)55 526−0030 32 Washer, Flat (3/8)56 862−0003 4 Nut, Hex (3/8−16)
38Copyright 2016 Cummins Inc.
Terminal BoxP7 Alternators
1
2
3
4
5
6
6
7
8
910
7
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5080−02 1 Panel, Terminal − Front2 319−5081−02 1 Panel, Terminal − Back3 319−5082−02 1 Panel, Terminal − Left4 319−5085−02 1 Panel, Terminal − Right5 319−5083−02 1 Panel, Terminal − Top6 821−6003−02 52 Screw, Hex Head (M8 x 1.25 x
20)
7 319−5097−02 2 Panel, Terminal8 319−5489−02 4 Box, Terminal − Spacer9 800−2061 12 Screw, Hex Head (M8 x 40)
10 526−0399−60 12 Washer, Flat (M8)
39Copyright 2016 Cummins Inc.
Terminal BoxMV7
1
2
3
4
5
6
6
6
7
7
8
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5427−02 1 Panel, Terminal2 319−5428−02 1 Panel, Terminal3 319−5429−02 1 Panel, Terminal4 319−5430−02 1 Panel, Terminal5 319−5083−02 1 Panel, Terminal
6 821−6003−02 44 Screw, Hex Head (M8 x 1.25 x20)
7 319−5097−02 2 Panel, Terminal8 821−6004−01 4 Screw, Hex Head (M10 x 1.5 x
20)
40Copyright 2016 Cummins Inc.
Terminal Housing
1
2
3
4
5
6
7
7
7
8
8
8
8
9
1011
12
12
12
12
13
13
1314
15
16
18
19
20
21
2223
24
25 26
27
28
29
30
31
32 33
34
41Copyright 2016 Cummins Inc.
Terminal Housing
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 332−3967−02 1 Housing, Terminal2 332−3969−02 1 Housing, Terminal − Top3 332−3970−02 1 Housing, Terminal − Front −
Low Voltage Bottom Entry4 A032Y595 1 Bus, Bar − Ground5 332−3978−02 2 Housing, Terminal − Base6 821−6003−02 58 Screw, Hex Head (M8 x 1.25 x
20)7 800−2114 A/R Screw, Cap − Hex Head (M12 x
1.75 x 40)8 860−2010 A/R Nut, Hex (M12 x 1.75)9 332−3976−02 3 Housing, Terminal − Low
Voltage Bottom Entry10 337−3662 8 Insulation, Bus Bar11 337−3661 8 Bus, Bar12 526−0219 A/R Washer, Flat (1/2)13 851−0023 A/R Washer, Spring (1/2)14 332−3976−02 3 Housing, Terminal − Low
Voltage Top Entry15 337−3813 24 Bus, Bar − Low Voltage Top
Entry16 337−3673 12 Bus, Bar − Low Voltage Top
Entry17 800−2118 A/R Screw, Cap − Hex Head (M12 x
1.75 x 60) (Not Shown)18 406−1015 2 Handle, Door19 517−0136 2 Plug, Hole20 070−2002−02 2 Extrusion, Aluminum − Low
Voltage Top Entry
21 332−4054−02 2 Housing, Terminal − Brace −Low Voltage Top Entry
22 332−2898 1 Clamp, Loop − Low VoltageTop Entry
23 856−0013 4 Washer, Lock − W/EIT24 319−4363−02 1 Panel, Filler25 098−7902−04 1 Label, Logo26 332−4060 1 Insulator, Cable − Low Voltage
Top Entry27 332−4062−02 1 Housing, Terminal − Right Side28 332−4063−02 1 Housing, Terminal − Left Side29 098−6635 1 Label, Ground30 Label, Marker (10 Characters
Per Card) (Quantity Used AsRequired)
098−5854−06 4 Marked ”L”098−5854−07 1 Marked ”1”098−5854−08 1 Marked ”2”098−5854−09 1 Marked ”3”098−5854−10 1 Marked ”0”
31 508−0305−01 − Edging − Bulk (Order by theFoot − 3 Feet Required)
32 098−5387 1 Label, Danger33 800−2543−13 32 Screw, Cap − Hex Head (M12 x
1.75 x 80)34 517−0136 2 Plug, Hole − Low Voltage Top
Entry
42Copyright 2016 Cummins Inc.
Terminal Housing
12
34
4
3
4
4
5
6
7
8910
11
1818
19
20
21
22
24 23
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 332−3967−02 1 Housing, Terminal2 332−3970−02 1 Housing, Terminal3 332−3978−02 2 Housing, Terminal4 821−6003−02 56 Screw, Hex Head (M8 x 1.25 x
20)5 406−1015 2 Handle, Door6 332−3990−02 2 Housing, Terminal7 332−3969−02 1 Housing, Terminal8 718−1076 16 Screw, Cap − Hex Head (M12 x
1.75 x 40)9 526−0219 32 Washer, Flat (1/2)
10 750−1010 16 Nut, Hex (M12 x 1.75)11 319−4363−02 1 Panel, Filler12 870−2065−03 4 Nut, Hex − Flange (Not Shown)13 332−4053 2 Insulator, Cable (Not Shown)14 332−4059−02 1 Housing, Terminal − Duct (Not
Shown)
15 332−4058−02 1 Housing, Terminal − Duct (NotShown)
16 332−4055−02 2 Housing, Terminal − Bracket(Not Shown)
17 070−2002−01 4 Extrusion, Aluminum (NotShown)
18 517−0136 2 Plug, Hole19 098−5387 1 Label, Danger20 508−0305−01 − Edging − Bulk (Order by the
Foot − 3 Feet Required)21 098−7902−04 1 Label, Logo (White)22 098−8280 1 Label, Information23 332−4062−02 1 Housing, Terminal (Right Side)24 332−4063−02 1 Housing, Terminal (Left Side)25 A030X518 1 Switch, Temperature (not
shown)
43Copyright 2016 Cummins Inc.
Generator Heater
9
17
2
15
1110 13
4
12
56
87
16
14
3
9
1
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
541−1416 1 * Kit Heater, Relay1 Cartridge, Heater (300 Watt)
333−0438−05 1 120 Volt333−0438−06 1 240 Volt
2 232−3849 1 Bracket, Mounting − Heater3 332−3024−14 2 Clamp, Loop4 822−3075 6 Screw, Machine − Slotted Pan
Head (M4 x 16mm)5 856−0021 2 Washer − W/EIT (M4)6 860−2005 2 Nut, Hex (M4)7 850−2005 2 Washer, Lock − Spring (M5)8 860−2006 2 Nut, Hex (M5)9 800−2008 2 Screw, Cap − Hex Head (M5 x
16mm)
10 850−2003 1 Washer, Lock − Spring (M3)11 822−3047 1 Screw, Machine − Pan Head
(M3 x 20mm)12 508−0228 1 Grommet13 332−3023 1 Block, Terminal14 A030F216 1 Sleeving − Heater Leads (59”)15 330−0142 1 Box, Terminal16 517−0021 1 Plug, Dot Button17 330−0141−01 Cover Assy
1 Cover, Box1 Gasket, Cover
* − Available for failed units, models DQKAA and DQKAB. Not required for functioning units.
44Copyright 2016 Cummins Inc.
Generator Installation
12
3
4
5
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 526−0399−64 16 Washer, Flat2 800−2543−07 16 Screw, Cap − Hex Head (M12 x
1.75 x 55)
3 526−0416 12 Washer, Flat (5/8)4 805−2022 12 Bolt, Place5 332−3196 1 Clamp, “J”
45Copyright 2016 Cummins Inc.
Generator
Generator component parts cannot be ordered from Cummins Power Generation. Refer to the Newage nameplateand supply all available information. Contact your nearest Newage distributor for assistance in ordering componentparts. For COMPLETE generator replacement use the 200−XXXX−XX Cummins Power Generation identificationnumber listed below.
NOTE: From Field Flash Titled “Hardened Cartridge for Alternator Bearing UPDATE”Kit to replace a Standard or Hardened Cartridge. The new kit includes a new bearing andcartridge.
0541−1217 Alternator Kit for HC−7 or MV−7 or P70541−1218 Alternator Kit for Frame 8 Mark10541−1219 Alternator Kit for P80
Cummins PowerGeneration
Identification Number
GeneratorModel
Number orFrame/Core
200−3095−01 P80R
200−3095−02 P80S
200−3095−04 P80R
200−3095−05 P80S
200−3095−08 P80S
200−3095−16 P80R
200−3095−17 P80S
200−3095−19 P80R
200−3095−20 P80S
200−3095−23 P80S
200−3095−76 P80T
200−3095−77 P80T
200−3117−04 P80R
200−3117−34 P80R
200−3117−35 P80S
200−3117−37 P80R
200−3117−38 P80S
Continued...
46Copyright 2016 Cummins Inc.
Generator
Cummins PowerGeneration
Identification Number
GeneratorModel
Number orFrame/Core
Continued...
200−3117−39 P80T
200−3117−46 P80T
200−3117−47 P80T
200−3128−03 P7D
200−3128−04 P7E
200−3128−05 P7F
200−3128−06 P7G
200−3128−09 P7D
200−3128−10 P7E
200−3128−11 P7F
200−3128−12 P7G
200−3128−21 P7D
200−3128−22 P7E
200−3128−23 P7F
200−3128−24 P7G
200−3128−27 P7D
200−3128−28 P7E
200−3128−29 P7F
200−3128−30 P7G
200−3128−58 P7E
200−3132−08 MV734H
200−3180−34 MVSI804R1
200−3180−64 HVSI804R1
200−3180−67 HVSI804R1
200−3180−76 LVSI804T1
200−3180−77 LVSI804T1
200−3180−78 MVSI804T1
200−3180−79 HVSI804T1
47Copyright 2016 Cummins Inc.
Control Heater
1
2
3
4
5
6
7
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Heater Assembly, Control − 150Watt
333−0645−01 1 120 Volt333−0645−02 1 240 Volt
2 818−1150−02 2 Rivet, Drive
3 332−3125−01 2 Block, Terminal4 332−3126−01 1 Endplate, Terminal5 098−6195 2 Label, Caution6 332−4002 1 Block, Terminal − Ground7 307−2968−04 3 Relay, Power (K14, K15 and K20)
48Copyright 2016 Cummins Inc.
Control Box Installation
1
2
3
4
56
7
89
14
ÂÂ
ÂÂÂÂ
3
9
1516
10
11
12
17 9
1819
19
13
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−6136−02 2 Bracket, Control2 319−6137−02 2 Bracket, Control3 821−6003−02 3 Screw, Hex Head (M8 x 1.25 x
20)4 402−0666−01 4 Isolator, Vibration5 526−0324 4 Washer, Flat (3/8)6 815−0776 4 Screw, Hex − Flange Head (M8
x 1.25 x 45)7 818−0231−02 8 Rivet, Pop8 337−0049 1 Strap, Bond9 853−2008 4 Washer, Lock − W/ET (M8)
10 526−0128 2 Washer, Flat
11 800−3017−41 4 Screw, Cap − Hex Head (M10 x1.5 x 45)
12 870−2056 4 Nut, Lock − Flange (M10 x 1.5)13 503−1418 2 Hose, Fuel14 A041S508 1 Label, Caution15 337−3466−01 1 Strap, Bond16 526−2100 1 Washer, Flat (M8)17 800−2060 1 Screw, Cap − Hex Head (M8 x
1.25 x 35)18 870−2055 1 Nut, Locking − Flange (M8 x
1.25)19 821−6004−01 8 Screw, Hex Head (M10 x 1.5 x
20)
49Copyright 2016 Cummins Inc.
Resistive Temperature Detectors
2
2
1
3
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Detectors, Resistive Detectors− Package − P7
179−3696−01 1 Without Mounting Plate179−3696−02 1 With Mounting Plate
2 Screw, Cap − Hex Head − P7821−6001−03 3 Screw, Hex head
3 193−0458−02 1 Detector, Temperature − Frame8
50Copyright 2016 Cummins Inc.
Control Door
1
23
4
5
6
6
7
8
9
10
11
12
1314
1516
17
18
19
20
21
22
23
23
24
25
26
27
28
29
30
3132
33
3434
34
51Copyright 2016 Cummins Inc.
Control Door
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5018−02 1 Door, Control Box2 332−1911 15 Spacer, LED3 300−5180 1 Board, Printed Circuit −
Bargraph4 300−5179 1 Board, Printed Circuit −
Operator Panel − Digital5 326−0230 1 Display, Digital6 823−0001−01 12 Screw, Pan Head − Thread
Forming (M3 x 0.5 x 6)7 526−2303 1 Washer, Double Hole8 860−2006 3 Nut, Hex (M5 x .8)9 870−2064−01 9 Nut, Nyloc (M4)
10 870−2062 3 Nut, Nylon − Lock (M5)11 300−5685−01 Display, Control12 300−5181 1 Board, Printed Circuit −
Software Panel13 300−4306 1 Regulator, Auto Voltage14 872−0019−01 2 Standoff15 A052Y984 1 Light, Panel16 322−0017 1 Lamp, Panel17 406−0930 1 Latch, Door (1/4 Turn)18 406−0932−02 1 Latch, Cam (Single Point)19 322−0488 4 Lens, LED
20 319−4918−02 1 Bracket, Printed Circuit Board21 815−0796 4 Screw, Pan Head − Thread
Cutting (4−24 x 5/16)22 425−1799 2 Clamp, Cable23 870−2062 4 Nut, Nylon − Lock (M5)24 332−0052 1 Clip, Wire25 406−0810 2 Hinge, Block26 821−6001−01 4 Screw, Hex Head (M5 x 0.8 x
10)27 508−1186 2 Bumper28 405−7779 1 Gasket, Enclosure29 319−5194 1 Cover, Printed Circuit Board30 319−5193 1 Bracket, Control31 A035H895 1 Harness, Switch32 A035H893 1 Switch, Pushbutton33 A029R718 1 Harness, Control34 338−4649−01 1 Harness, Control (Parts Below
Included )323−1839 1 Connector, Six Pin308−1688 1 Socket, Terminal308−1085 1 Switch, Selector308−1182 1 Switch, Pushbotton
52Copyright 2016 Cummins Inc.
Control Box
1
2
3
4
5
6
6
7
89
10
11
12
12
13
14
1415
16
1718
19
20
20
21
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 A043M148 1 Box, Control2 098−8121 1 Label, Information3 818−1150−02 2 Rivet, Drive4 A029D229 1 Rail, Terminal5 815−0793−02 2 Screw, Flange Head (M5 x 0.8
x 10)6 823−0002−05 24 Screw, Pan Head − Torx −
Thread Forming (M4 x 0.7 x14)
7 332−2878 2 Block, Terminal8 338−4315 1 Harness, Lonworks9 098−6635 1 Label, Ground
10 517−0133 8 Plug, Hole
11 870−2062 2 Nut, Nylon − Lock (M5)12 853−2008 2 Washer, Lock − W/ET (M8)13 337−0049 1 Strap, Ground14 870−2055 2 Nut, Lock − Flange (M8)15 821−2045 1 Screw, Locking − Flange (M8 x
1.25 x 16)16 526−0008 2 Washer, Flat (M5)17 319−5135−02 1 Bracket, Cable18 819−1157 2 Screw, Pan Head − Cross
Recessed (M6 x 1 x 50)19 A029R718 1 Control, Harness20 526−0115 2 Washer, Flat21 338−4363 1 Harness, Meter
53Copyright 2016 Cummins Inc.
Card Cage
1
2
3
4
5
6
7
8
8
9
10
11
12
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 319−5096−02 1 Frame, Cabinet2 363−0183 1 Heatsink, Genset3 541−0809 1 Board, Printed Circuit − NCM4 327−1390 1 Board, Printed Circuit −
Backplane5 815−0948 8 Screw, Torq (M4 x 6)6 Guide, Metal Guide
406−0916 4 Left Side406−0917 4 Right Side
7 815−0949 16 Screw (4−40 x 1/4)8 815−0947 8 Screw (M3 x 10)9 319−5079 2 Cover, Control − Blank
10 Board, Printed Circuit − ParallelGenset
327−1376−01 1 Full Feature (Supports PTCPower Transfer Control)(Marked #2)
327−1376−02 1 Depop Feature (PTC PowerTransfer Control NotSupported)(Marked #1)
11 323−1848 2 Cover, 96-Pin Header12 327−1392 1 Board, Printed Circuit − Genset
Base
54Copyright 2016 Cummins Inc.
Control Cabinet Labels
1 2 3 4 5
6
6
7
8 910
11
12
12
13
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 098−6074−02 1 Label, Warning2 098−6118 1 Label, Cabinet3 098−7902−03 1 Label, Logo (White)4 098−5759 1 Label, Warning5 098−4732 1 Label, Warning6 098−5387 2 Label, Danger7 098−8143 1 Label, Information8 098−8093 1 Label, Caution9 098−8097 1 Label, Information
10 098−8098 1 Label, Instruction11 098−8099 1 Label, Danger12 098−8100 1 Label, Warning
13 Label, Warning098−8104−01 1 380 Volts AC098−8104−02 1 400 Volts AC098−8104−03 1 415 Volts AC098−8104−04 1 440 Volts AC098−8104−05 1 480 Volts AC098−8104−06 1 600 Volts AC098−8104−07 1 3300 Volts AC098−8104−08 1 4160 Volts AC098−8104−09 1 6000 Volts AC098−8104−10 1 6300 Volts AC098−8104−11 1 6600 Volts AC098−8104−12 1 7200 Volts AC098−8104−13 1 10000 Volts AC098−8104−14 1 10500 Volts AC098−8104−15 1 11000 Volts AC098−8104−16 1 11400 Volts AC098−8104−17 1 12470 Volts AC098−8104−18 1 13200 Volts AC098−8104−19 1 13800 Volts AC
55Copyright 2016 Cummins Inc.
Customer Relays
12
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Relay (24 Volt)307−1056 1 Alarm Relay (K16)307−1056−01 3 Run Relay (K11,12,13)
2 Socket, Relay323−1410−01 1 Alarm Relay323−1410−01 3 Run Relay
56Copyright 2016 Cummins Inc.
Bus PT Module
1
2
23
4
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Board, Printed Circuit − Bus PTModule
300−4985−01 1 120 Volts300−4985−02 1 240 Volts300−4985−03 1 346 Volts
2 870−2062 2 Nut, Nylon − Lock (M5)3 872−0019−01 2 Standoff4 319−5060 1 Guard, Electrical
57Copyright 2016 Cummins Inc.
PT/CT Module
1234
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Board, Printed Circuit − PT/CTModule
300−4308−01 1 120 Volts300−4308−02 1 240 Volts300−4308−03 1 346 Volts
2 870−2062 2 Nut, Nylon − Lock (M5)3 872−0019−01 1 Standoff4 332−0052 1 Clip, Wire
58Copyright 2016 Cummins Inc.
Ground Fault Relay
1
2
3
4
5
6
7
6
7
8
9
1011
12
13
14
15
16
17
17
17
17
18
19
19
20
21
21
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 307−3003−01 1 Relay, Ground Fault2 301−6987 1 Bracket, Watts Transducer3 821−0017 2 Screw, Locking (5/16−18 x 1/2)4 870−0257 2 Nut, Self-Locking (5/16−18)5 402−0354 4 Mount, Shock6 853−0005 8 Washer, Lock − W/ET (#8)7 870−0221 8 Nut, Hex − W/ET (#8−32)8 338−4408 1 Harness, Relay9 332−2420 2 Mount, Cable Tie
10 319−5038−02 1 Plate, Mounting − Relay11 315−1605−01 1 Transformer, Current (Used
With 4 Pole SeparatelyDerived Transfer Switch)
12 821−0010 2 Screw, Locking (1/4−20 x 1/2)
13 870−0212 2 Nut, Self-Locking (1/4−20)14 338−4386 1 Harness, Meter − Resistor15 315−1622 1 * Bracket, Transformer − Current16 315−1621 1 * Transformer, Current17 526−0003 8 * Washer, Flat (3/16)18 812−0094 2 * Screw, Slotted − Round Head
(#8−32 x 3.50)19 850−0025 4 * Washer, Lock − Split (#8)20 812−0082 2 * Screw, Slotted − Round Head
(#8−32 x .75)21 860−0008 4 * Nut, Hex (#8−32)
* Used With 3 Pole Non-Separately Derived Transfer Switch
59Copyright 2016 Cummins Inc.
Audible Alarm Module
1
2
34
5
6
7
8
9
10
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 098−7719−01 1 Label, Alarm2 338−4351 1 Harness, Alarm (Includes the
Following Parts)3 323−1899−01 3 Connecter, LED4 322−0491 3 Lamp, LED − High Intensity5 322−0493−05 1 Lens, LED (Amber)
6 322−0493−04 1 Lens, LED (Green)7 322−0493−06 1 Lens, LED (Red)8 308−1105 1 Switch, Toggle9 333−0654 1 Alarm, Audible
10 895−0401 1 Gasket, Audible Alarm
60Copyright 2016 Cummins Inc.
Pyrometer
1
2
3
4
5
6
7
8
9
10
11
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 098−7720−01 2 Label, Exhaust − Pyrometer2 A043T369 2 Contol, Temperature3 A046J227 1 Harness, Meter − Pyrometer
(Labeled)4 A046J229 1 Harness, Meter − Pyrometer
(Labeled)5 193−0493−01 2 Sender, Temperature
6 098−8157 3 Label, Instruction7 518−0350 9 Clamp8 821−6003−01 9 Screw9 505−2138 2 Adapter, Pipe (1/8 x M16)
10 098−8184 1 Label, Instruction − Switch11 155−4529 1 Elbow, Exhaust − Outlet
61Copyright 2016 Cummins Inc.
Solderless Lug
1 2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 332−3653 1 Lug, Solderless 2 332−2770−01 1 Lug, Solderless
62Copyright 2016 Cummins Inc.
Solderless Lug
1
2345
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 853−2008 1 Washer, Lock − W/ET2 332−2001 1 Lug, Solderless3 850−0114−54 1 Washer, Lock
4 526−0399−60 1 Washer, Flat5 800−2063 1 Screw, Cap − Hex Head
63Copyright 2016 Cummins Inc.
Transformer
1
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 302−2058−36 3 Transformer, Current − 670:1 2 319−7151 1 Base, Transformer
64Copyright 2016 Cummins Inc.
TransformerP7
12 3
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 302−2058−32 A/R Transformer, Current − 5750:12 319−5740−03 1 Base, Transformer
3 821−6002−02 8 Screw, Hex Head (M6)
65Copyright 2016 Cummins Inc.
TransformerP6/P7
11
10
9
8
3
4
6
5
1
2
7
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Dual Metering/DifferentialCurrent Transformer
315−1640−01 A/R 7000:1/5000:5315−1640−02 A/R 7000:1/4000:5315−1640−03 A/R 6000:1/5000:5315−1640−04 A/R 6000:1/4000:5315−1640−05 A/R 6000:1/3500:5315−1640−06 A/R 5000:1/3500:5315−1640−07 A/R 5000:1/3000:5
2 Line Side Differential CurrentTransformer
315−1618−05 A/R 5000/5315−1618−01 A/R 4000/5315−1618−02 A/R 3500/5315−1618−03 A/R 3000/5
3 332−2879−02 1 Rail, Terminal4 332−2878 2 Block, Terminal5 332−3125−01 12 Block, Terminal6 332−3126−01 1 Block, Terminal7 338−4477 1 Harness, Transformer8 821−6001−03 2 Screw, Hex Head9 850−0114−52 2 Washer, Lock
10 862−0026−53 2 Nut, Hex11 226−4696 6 Lead, Ground
66Copyright 2016 Cummins Inc.
TransformerP6/P7
1
234
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, Current315−1610−02 A/R 7000/1315−1610−03 A/R 6000/1315−1610−04 A/R 5000/1
2 800−2044 12 Screw, Cap − Hex Head (M6 x70)
3 526−0399−58 12 Washer, Flat4 850−0114−53 12 Washer, Lock
67Copyright 2016 Cummins Inc.
TransformerP80LV
1
2
34
4
45
678
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, Current315−1616−01 3 5000/5315−1616−02 3 4000/5315−1616−03 3 3500/5
2 338−4471 1 Harness, AC3 518−0515 8 Clip, Wire4 870−2065−03 15 Nut, Hex − Flange
5 821−6003−02 2 Screw, Hex Head (M8 x 1.25 x20)
6 526−0399−60 12 Washer, Flat7 851−0048−01 12 Washer, Belleville8 520−2651−01 24 Stud (M8 x 1.25)9 332−4044 3 Jumper, Terminal (Not Shown)
10 338−5072 1 Harness−AC(CT) (Not Shown)
68Copyright 2016 Cummins Inc.
TransformerP80LV
1
245
4678 3
4
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, Current315−1609−02 A/R 7000/1315−1609−03 A/R 6000/1
2 338−4470 1 Harness, AC3 518−0515 5 Clip, Wire4 870−2065−03 15 Nut, Hex − Flange
5 821−6003−02 2 Screw, Hex Head (M8 x 1.25 x20)
6 526−0399−60 12 Washer, Flat7 851−0048−01 12 Washer, Belleville8 520−2651−01 12 Stud (M8 x 1.25)
69Copyright 2016 Cummins Inc.
TransformerP80MV, HV
1
2
34
3
56
7
8
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, Current315−1617−02 3 700/5315−1617−04 3 500/5315−1617−05 3 400/5315−1617−07 3 250/5315−1617−09 3 150/5315−1617−10 3 120/5
2 338−4471 1 Harness, AC
3 518−0515 5 Clip, Wire4 870−2065−03 15 Nut, Hex − Flange5 821−6003−02 2 Screw, Hex Head (M8 x 1.25 x
20)6 526−0399−60 12 Washer, Flat7 851−0048−01 12 Washer, Belleville8 520−2651−01 24 Stud (M8 x 1.25)9 332−4044 3 Jumper, Terminal (Not Shown)
70Copyright 2016 Cummins Inc.
TransformerP80MV, HV
1
2
3
4
3
56
7
8
4
7
6
9
6
116
7
10
71Copyright 2016 Cummins Inc.
TransformerP80MV, HV
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, Current315−1608−03 A/R 800/1315−1608−05 A/R 400/1315−1608−07 A/R 250/1315−1608−08 A/R 200/1
2 338−4470 1 Harness, AC3 518−0515 5 Clip, Wire4 870−2065−03 27 Nut, Hex − Flange5 821−6003−02 2 Screw, Hex Head (M8 x 1.25 x
20)
6 526−0399−60 60 Washer, Flat7 851−0048−01 48 Washer, Belleville8 520−2651−01 12 Stud (M8 x 1.25)9 800−2075 12 Screw, Cap − Hex Head (M8 x
1.25 x 130)10 800−2061 24 Screw, Cap − Hex Head (M8 x
1.25 x 40)11 332−4043 12 Clamp, Cable
72Copyright 2016 Cummins Inc.
TransformerDifferential MV, HV
1
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, Current315−1690−01 3 C20/200:5315−1690−03 3 C20/300:5315−1672−06 3 800:1
2 Bracket−Transformer315−1703−02 1 non−slotted315−1685−02 1 slotted
73Copyright 2016 Cummins Inc.
This Page Intentionally Left Blank.
74Copyright 2016 Cummins Inc.
Differential Current Transformer
9
10
8
2
4
5
17
6
8
10
11
12
3
13
14
15
12
16
17
75Copyright 2016 Cummins Inc.
Differential Current Transformer
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Transformer, CurrentCT1,CT2,CT3)
302−1945−06 3 Ratio 400/5302−1945−07 3 Ratio 500/5
2 813−0098 12 Screw, Machine − Round Head(#10−32 x 3/8”)
3 319−1265 1 Bracket, Current Transformer4 850−0030 12 Washer, Lock − Spring (#10)5 526−0008 12 Washer, Flat (#10)6 517−0090 A/R Plug, Hole (Fits 5/16” Hole)
(Quantity Used As Required)7 319−3297 6 Bracket, Foot
8 800−0039 6 Screw, Cap − Hex Head(5/16−18 x 3−1/2”)
9 526−0022 12 Washer, Flat (5/16”)10 850−0045 6 Washer, Lock − Spring (5/16”)11 862−0015 6 Nut, Hex (5/16−18)12 332−2879−02 1 Rail, Terminal13 332−2878 2 Block, Terminal14 332−3125−01 6 Block, Terminal15 332−3126−01 1 Block, Terminal16 338−4475 1 Harness, Transfer − Differential17 226−4696 3 Lead − GND
76Copyright 2016 Cummins Inc.
Circuit Breaker
1
29
14
14
13
15
15
19
27
23
4
34
21
21
22
36
37
5
25
2624
7
20
8
28
5354
55 5657
58
59
4445
4243
4041
30
10
323331
12 13
16
14
15
17
18
35
21
39
22
38
324445
32
33
60
6162
63
3
6
6
6
29
46
52
5051
48
47
49
66
64
65
67
6869
77Copyright 2016 Cummins Inc.
Circuit Breaker
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Breaker, Circuit − 3 Pole (UL &IEC) (Includes MountingHardware)
320−2164−03 1 1600 Amp320−2164−02 1 2000 Amp320−2164−01 1 2500 Amp
2 319−5161−02 1 Box, Circuit Breaker3 319−5084−02 1 Panel, Terminal4 319−5171−02 1 Cover, Circuit Breaker − Top5 319−5088−02 1 Cover, Circuit Breaker − Bottom6 821−6003−02 54 Screw, Hex Head (M8 x 1.25 x
20)7 Cover, Circuit Breaker
319−5176−04 1 Left Side Installation319−5176−05 1 Right Side Installation
8 319−5078−04 1 Cup, Switch9 319−5177−02 1 Bracket, Circuit Breaker
10 232−4131 2 Spacer, Mounting Foot11 098−8144 1 Label, Information − Service
Disconnect12 332−2744−07 2 Standoff, Insulator13 332−2512 5 Standoff, Insulator14 850−0050 7 Washer, Lock − Split (3/8)15 800−0048 7 Screw, Cap − Hex Head
(3/8−16 x .75)16 332−2743−07 1 Standoff, Insulator17 850−0060 1 Washer, Lock − Split (1/2)18 800−0090 1 Screw, Cap − Hex Head
(1/2−13 x 1.00)19 337−3626 1 Bus, Bar − Ground20 526−0423 2 Washer, Flat21 851−0048−02 7 Washer, Belleville (3/8)22 800−0050 3 Screw, Cap − Hex Head
(3/8−16 x 1”)23 332−3039 7 Lug, Solderless24 800−0028 5 Screw, Cap − Hex Head
(5/16−18 x 1”)25 851−0048−01 7 Washer, Belleville (5/16)26 862−0015 7 Nut, Hex (5/16)27 815−0261 2 Screw, Hex Washer Head −
Thread Forming (1/4−20 x.50)
28 319−5102−03 1 Stiffener, Cover29 821−6002−04 10 Screw, Hex Head (M6 x 1 x 20)30 337−3618 6 Bus, Bar − Breaker31 800−0094 24 Screw, Cap − Hex Head
(1/2−13 x 2)32 851−0048−03 28 Washer, Belleville (1/2)33 862−0005 27 Nut, Hex (1/2)34 337−3623 1 Bus, Bar − Neutral35 337−3624 1 Bus, Bar − Neutral36 337−3631 2 Bus, Bar − Neutral37 337−3625 1 Bus, Bar − Jumper38 337−3627 1 Bus, Bar − Neutral39 800−0052 4 Screw, Cap − Hex Head
(3/8−16 x 1.5)40 Bus, Bar − Breaker
337−3620−02 2 Left Side Insulation337−3620−02 1 Right Side Insulation
41 Bus, Bar − Breaker337−3621−02 2 Left Side Insulation337−3621−02 1 Right Side Insulation
42 337−3619−01 1 Bus, Bar − Breaker43 337−3619−02 1 Bus, Bar − Breaker44 Bus, Bar − Breaker
337−3620−01 1 Left Side Insulation337−3620−01 2 Right Side Insulation
45 Bus, Bar − Breaker337−3621−01 1 Left Side Insulation337−3621−01 2 Right Side Insulation
46 800−0093 4 Screw, Cap − Hex Head(1/2−13 x 1.75)
47 098−7701 1 Label, Neutral Disconnect48 098−7700 1 Label, Bonding − Jumper49 098−8149 1 Label, Information − Lug
Installation50 098−6635 1 Label, Ground51 098−6865 1 Label, Conduit Location52 Label, Marker (10 Characters
Per Card) (Quantity Used AsRequired)
098−5854−06 4 Marked “L”098−5854−07 1 Marked “1”098−5854−08 1 Marked “2”098−5854−09 1 Marked “3”098−5854−10 1 Marked “0”
53 Lead (Quantity Used AsRequired)
226−4894−08 1 23”226−4894−02 1 18”
54 718−1076 30 Screw, Cap − Hex Head (M12 x1.75 x 40)
55 860−2010 30 Nut, Hex (M12)56 850−2012 30 Washer, Lock − Split (M12)57 526−2140 30 Washer, Flat (M12)
Accessories, Circuit Breaker:58 320−2196−01 2 Switch − Used as a Trip
Alarm or Auxiliary Contact59 320−2196−02 1 24 Volt Shunt Trip60 332−3949 8 Lug, Cable − Solderless61 800−0054 16 Screw, Cap − Hex Head
(3/8−16 x 2.00)62 851−0022 16 Washer, Spring (3/8)63 862−0003 16 Nut, Hex (3/8)64 337−3736 1 Bus, Bar − Ground65 800−0030 2 Screw, Cap − Hex Head
(5/16−18 x 1-1/4)66 800−2063 2 Screw, Cap − Hex Head (M8 x
50)67 821−6003−03 6 Screw, Cap − Hex Head (M8 x
1.25 x 25)68 Label, Warning
098−2304 2 English098−2304−01 2 French
69 Label, Danger098−5347 1 English098−5347−02 1 French
78Copyright 2016 Cummins Inc.
Muffler
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 1 Muffler155−2341−10 1 Residential155−2342−10 1 Critical
79Copyright 2016 Cummins Inc.
Wiring HarnessAC
1
2
3
4
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 Harness, AC (Includes PartsListed Below)
338−4317 1 Frame 7, 6 and 5 LVAlternators
338−4316 1 Frame 8 Alternators338−4463−01 1 Set Mounted Integrated
PCC II Controls With P7 LV Alternators
338−4463−02 1 Set Mounted IntegratedPCC3201 Controls WithP7 & MV7 Alternators
2 323−1643−01 1 Housing, Plug and Cap3 323−1644−03 1 Housing, Plug and Cap4 323−1648 15 Socket, Terminal
80Copyright 2016 Cummins Inc.
Wiring HarnessEngine
1
4
6
2
3
5
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 338−4707 1 Harness, Engine (IncludesParts Listed Below)
2 323−2280 3 Socket, Contact3 416−1021−03 4 Boot, Ring − Red
4 323−1582−02 1 Plug, Connector (12 Place)5 323−2299 6 Socket, Contact6 323−1583 1 Wedge, Plug
81Copyright 2016 Cummins Inc.
Wiring HarnessControl
4
2 3
5
67
8
910
1112
13
1416
19
21
222326
283132
3334
37
38
394041
42
44
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 338−4744 1 Harness, Control (IncludesParts Listed Below)
2 323−1605−01 2 Connector, Plug3 323−1605−03 1 Connector, Plug4 323−1582 1 Plug, Pin5 323−1583 1 Wedge, Plug6 323−1623 1 Connector, Plug7 323−1624 1 Wedge, Plug8 323−1841 2 Connector, Contact9 323−1836 1 Connector, Contact
10 323−1837 2 Connector, Contect11 323−1492 21 Socket, Terminal12 323−1614−01 71 Socket, Terminal13 307−2968−04 4 Relay, Power14 357−0030 1 Rectifier, Silicon15 323−1835−02 22 Contact, Socket16 332−1992 18 Terminal, Receptacle17 332−1993 1 Terminal, Receptacle (not
shown)18 332−3058 8 Splice, Butt (not shown)19 332−0607 7 Terminal, Block20 332−1043 23 Terminal, Jumper (not shown)21 323−1847−01 13 Pin, Contact22 323−1843 2 Grommet
23 323−1605−04 1 Plug, Grommet24 332−0418−01 5 Splice, Parallel (not shown)25 898−0860 A/R Tube (not shown)26 098−7594−01 3 Label27 323−2275 6 Pin, Contact (not shown)28 323−1494 2 Connector, Receptacle29 334−0761 A/R Wire (not shown)30 308−1180 1 Switch, Pushbutton (not shown)31 323−1580−02 1 Socket, Receptacle32 323−1581 1 Wedge, Receptacle33 321−0416−01 1 Fuse34 321−0415 1 Fuse, Holder35 332−3491−01 2 Pin, Terminal (not shown)36 323−2277 8 Socket, Contact (not shown)37 332−2974 25 Spade, Terminal38 898−1195−04 A/R Sleeve39 323−1503 2 Plug, Wedge40 323−1493 2 Plug, Connector41 323−1888 1 Connector, Boot42 898−0861 A/R Sleeve, Insulated43 323−2280 4 Socket, Contact (not shown)44 898−1195−03 A/R Sleeve, Convoluted45 332−1506 1 Splice, Window (not shown)
82Copyright 2016 Cummins Inc.
Wiring HarnessControl
4
2 3
5
67
8
910
1112
13
1416
19
21
222326
283132
3334
37
38
394041
42
44
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 A029R718 1 Harness, Control (IncludesParts Listed Below)
2 323−1605−01 2 Connector, Plug3 323−1605−03 1 Connector, Plug4 323−1582 1 Plug, Pin5 323−1583 1 Wedge, Plug6 323−1623 1 Connector, Plug7 323−1624 1 Wedge, Plug8 323−1841 2 Connector, Contact9 323−1836 1 Connector, Contact
10 323−1837 2 Connector, Contect11 323−1492 21 Socket, Terminal12 323−1614−01 71 Socket, Terminal13 307−2968−04 4 Relay, Power14 357−0030 1 Rectifier, Silicon15 323−1835−02 22 Contact, Socket16 332−1992 18 Terminal, Receptacle17 332−1993 1 Terminal, Receptacle (not
shown)18 332−3058 8 Splice, Butt (not shown)19 332−0607 7 Terminal, Block20 332−1043 23 Terminal, Jumper (not shown)21 323−1847−01 13 Pin, Contact22 323−1843 2 Grommet
23 323−1605−04 1 Plug, Grommet24 332−0418−01 5 Splice, Parallel (not shown)25 898−0860 A/R Tube (not shown)26 098−7594−01 3 Label27 323−2275 6 Pin, Contact (not shown)28 323−1494 2 Connector, Receptacle29 334−0761 A/R Wire (not shown)30 308−1180 1 Switch, Pushbutton (not shown)31 323−1580−02 1 Socket, Receptacle32 323−1581 1 Wedge, Receptacle33 321−0416−01 1 Fuse34 321−0415 1 Fuse, Holder35 332−3491−01 2 Pin, Terminal (not shown)36 323−2277 8 Socket, Contact (not shown)37 332−2974 25 Spade, Terminal38 898−1195−04 A/R Sleeve39 323−1503 2 Plug, Wedge40 323−1493 2 Plug, Connector41 323−1888 1 Connector, Boot42 898−0861 A/R Sleeve, Insulated43 323−2280 4 Socket, Contact (not shown)44 898−1195−03 A/R Sleeve, Convoluted45 332−1506 1 Splice, Window (not shown)
83Copyright 2016 Cummins Inc.
Key Operator Switch
1
2
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 308−1045 1 Switch, Key Operator 2 308−1046 2 Key
84Copyright 2016 Cummins Inc.
LabelsMiscellaneous
1 2 3 4 5 6
7 8 10 11
12
9
13
14
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 098−4730 A/R Label, Warning2 098−6775 1 Label, Water Drain and Oil
Drain3 098−4500 2 Label, Prototype Tested4 098−4798 5 Label, Warning5 098−5842 2 Label, Caution6 098−5347 A/R Label, Danger7 098−5759 A/R Label, Warning8 098−5822 A/R Label, Warning9 Label, Logo
098−7902−03 A/R 100mm x 310mm098−7902−04 A/R 152mm x 471mm
10 098−6074−02 1 Label, Warning
11 098−6650−01 A/R Label, Danger12 Label, Insert
098−7883−01 1 Portuguese098−7883−02 1 French098−7883−04 1 Dutch098−7883−05 1 German098−7883−07 1 Swedish098−7883−08 1 Italian098−7883−09 1 Czech098−7883−10 1 Finnish
13 098−8160 1 Label, Information14 098−8220 2 Label, Information
85Copyright 2016 Cummins Inc.
Kits
REF PART QTY PART REF PART QTY PARTNO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1 541−0814−01 1 Kit, Control2 541−0814−02 1 Kit, Control3 327−1309 1 PCB Assy (Annunciator)4 543−0088 1 Kit, Filter
5 541−0809 1 Kit, Control
86Copyright 2016 Cummins Inc.
This Page Intentionally Left Blank.
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
87Copyright 2016 Cummins Inc.
0503−2641, 18
0503−2661, 18
0503−2692, 22
0511−0161−25, 6
0511−0161−27, 6
070−2002−01, 42
070−2002−02, 41
098−2235−02, 13
098−2304, 77
098−2304−01, 77
098−4500, 84
098−4730, 21 , 84
098−4732, 21 , 54
098−4798, 84
098−5347, 27 , 31 , 33 , 35 ,37 , 77 , 84
098−5347−02, 27 , 31 , 33 ,35 , 37 , 77
098−5387, 41 , 42 , 54
098−5393, 21
098−5759, 54 , 84
098−5822, 21 , 31 , 33 , 35 ,37 , 84
098−5842, 84
098−5854−06, 31 , 33 , 35 ,37 , 41 , 77
098−5854−07, 31 , 33 , 35 ,37 , 41 , 77
098−5854−08, 31 , 33 , 35 ,37 , 41 , 77
098−5854−09, 31 , 33 , 35 ,37 , 41 , 77
098−5854−10, 31 , 33 , 35 ,37 , 41 , 77
098−6074−02, 54 , 84
098−6118, 54
098−6195, 47
098−6635, 27 , 31 , 33 , 35 ,37 , 41 , 52 , 77
098−6650−01, 84
098−6775, 21 , 84
098−6865, 77
098−7244, 13
098−7594−01, 81 , 82
098−7700, 77
098−7701, 77
098−7719−01, 59
098−7720−01, 60
098−7883−01, 84
098−7883−02, 84
098−7883−04, 84
098−7883−05, 84
098−7883−07, 84
098−7883−08, 84
098−7883−09, 84
098−7883−10, 84
098−7902−03, 31 , 33 , 35 ,37 , 54 , 84
098−7902−04, 41 , 42 , 84
098−7954, 8
098−8093, 54
098−8097, 54
098−8098, 54
098−8099, 54
098−8100, 54
098−8104−01, 54
098−8104−02, 54
098−8104−03, 54
098−8104−04, 54
098−8104−05, 54
098−8104−06, 54
098−8104−07, 54
098−8104−08, 54
098−8104−09, 54
098−8104−10, 54
098−8104−11, 54
098−8104−12, 54
098−8104−13, 54
098−8104−14, 54
098−8104−15, 54
098−8104−16, 54
098−8104−17, 54
098−8104−18, 54
098−8104−19, 54
098−8121, 52
098−8143, 54
098−8144, 77
098−8149, 77
098−8157, 60
098−8160, 84
098−8184, 60
098−8220, 84
098−8280, 42
098−8432, 21
128−0108, 11
130−3684, 17
130−4517, 17
130−4546, 11
130−4552, 13
130−5084−02, 17
130−5089−04, 11
130−5281−02, 17
130−5325, 21
130−5353, 22
130−5354, 22
130−5356, 18 , 22
130−5418, 23
130−5419, 21 , 22 , 23
130−5420, 18 , 21 , 23
130−5458−02, 17
130−5554, 18 , 21
130−5709, 21
130−5710, 21
130−5713, 22
130−5714, 18 , 22
130−5841, 19 , 23
130−5846, 19 , 23
130−5886, 19 , 23
130−5888, 19
130−6489, 11
130−6490, 11
130−6491, 11
130−6492, 11
130−6493, 11
130−6518−02, 17
130−6519−02, 17
130−6520−02, 17
130−6740, 22
130−6742, 18 , 22
130−6743, 18 , 22
130−6744, 22
130−6747, 21 , 23
130−6748, 21
130−6749, 21
130−6752, 23
130−6758, 19
130−6762, 23
130−6764, 21
130−7097−02, 17
130−7407, 18
130−8092−02, 17
130−8143, 21
130−8150, 21
130−8238, 18 , 22
140−1260, 8 , 9
140−1548, 9
140−2098, 9
140−2099, 9
140−3230, 9
140−3288−02, 8
140−3504−02, 8
140−3505−02, 8
140−3506−02, 8
140−3507−02, 8 , 9
140−3508−02, 8
140−3515−02, 8
140−3516−02, 8
140−3517−02, 8
140−3518−02, 8
140−3546−02, 8
140−3565−02, 9
140−3582−02, 9
140−3640−02, 9
140−3641−02, 9
140−3642−02, 9
140−3644−02, 9
140−3913−11, 9
140−3913−16, 9
140−3913−17, 9
140−3947−02, 9
Part No. Page Part No. Page Part No. Page Part No. Page
Numerical Index
88Copyright 2016 Cummins Inc.
140−3948−02, 9
149−2792, 7
149−2800−02, 7
154−3161, 11
155−2341−10, 78
155−2342−10, 78
155−3021, 11
155−3289, 17
155−3290, 17
155−4101, 8 , 9
155−4529, 60
179−3696−01, 49
179−3696−02, 49
179−4759, 21
193−0458−02, 49
193−0493−01, 60
193−0602, 14
200−3095−01, 45
200−3095−02, 45
200−3095−04, 45
200−3095−05, 45
200−3095−08, 45
200−3095−16, 45
200−3095−17, 45
200−3095−19, 45
200−3095−20, 45
200−3095−23, 45
200−3095−76, 45
200−3095−77, 45
200−3117−04, 45
200−3117−34, 45
200−3117−35, 45
200−3117−37, 45
200−3117−38, 45
200−3117−39, 46
200−3117−46, 46
200−3117−47, 46
200−3128−03, 46
200−3128−04, 46
200−3128−05, 46
200−3128−06, 46
200−3128−09, 46
200−3128−10, 46
200−3128−11, 46
200−3128−12, 46
200−3128−21, 46
200−3128−22, 46
200−3128−23, 46
200−3128−24, 46
200−3128−27, 46
200−3128−28, 46
200−3128−29, 46
200−3128−30, 46
200−3128−58, 46
200−3132−08, 46
200−3180−34, 46
200−3180−64, 46
200−3180−67, 46
200−3180−76, 46
200−3180−77, 46
200−3180−78, 46
200−3180−79, 46
226−4696, 65 , 75
226−4894−02, 77
226−4894−08, 77
232−3710−01, 24 , 25
232−3710−02, 24 , 25
232−3710−03, 24 , 25
232−3710−07, 24 , 25
232−3849, 43
232−4061, 24 , 25
232−4131, 77
300−4306, 51
300−4308−01, 57
300−4308−02, 57
300−4308−03, 57
300−4985−01, 56
300−4985−02, 56
300−4985−03, 56
300−5179, 51
300−5180, 51
300−5181, 51
300−5685−01, 51
301−6987, 58
302−1945−06, 75
302−1945−07, 75
302−2058−32, 64
302−2058−36, 63
307−1056, 55
307−1056−01, 55
307−2968−04, 47 , 81 , 82
307−3003−01, 58
307−3089, 13
308−1045, 83
308−1046, 83
308−1105, 59
308−1180, 81 , 82
308−1182, 51
309−0635−02, 17
315−1605−01, 58
315−1608−03, 71
315−1608−05, 71
315−1608−07, 71
315−1608−08, 71
315−1609−02, 68
315−1609−03, 68
315−1610−02, 66
315−1610−03, 66
315−1610−04, 66
315−1616−01, 67
315−1616−02, 67
315−1616−03, 67
315−1617−02, 69
315−1617−04, 69
315−1617−05, 69
315−1617−07, 69
315−1617−09, 69
315−1617−10, 69
315−1618−01, 65
315−1618−02, 65
315−1618−03, 65
315−1618−05, 65
315−1621, 58
315−1622, 58
315−1640−01, 65
315−1640−02, 65
315−1640−03, 65
315−1640−04, 65
315−1640−05, 65
315−1640−06, 65
315−1640−07, 65
315−1672−06, 72
315−1685−02, 72
315−1690−01, 72
315−1690−03, 72
315−1703−02, 72
319−1265, 75
319−3297, 75
319−4363−02, 41 , 42
319−4787−02, 13
319−4918−02, 51
319−5018−02, 51
319−5038−02, 58
319−5060, 56
319−5078−04, 77
319−5079, 53
319−5080−02, 38
319−5081−02, 38
319−5082−02, 38
319−5083−02, 38 , 39
319−5084−02, 27 , 77
319−5085−02, 38
319−5088−02, 27 , 77
319−5096−02, 53
319−5097−02, 38 , 39
319−5102−03, 77
319−5102−04, 27
319−5135−02, 52
319−5161−02, 27 , 77
319−5162−02, 27
319−5163−02, 27
319−5171−02, 27 , 77
319−5176−04, 77
319−5176−05, 77
319−5176−06, 27
319−5177−02, 77
319−5193, 51
319−5194, 51
319−5427−02, 39
319−5428−02, 39
319−5429−02, 39
319−5430−02, 39
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
89Copyright 2016 Cummins Inc.
319−5489−02, 38
319−5740−03, 64
319−5877, 28
319−5887−02, 31 , 33 , 35 ,37
319−5895−02, 31 , 33 , 35 ,37
319−5896, 31 , 33 , 35 , 37
319−5897−02, 28
319−5987−02, 31 , 33 , 35 ,37
319−5988−02, 28
319−5989−02, 28
319−6045−02, 28
319−6049−02, 28
319−6050−02, 31 , 33 , 35 ,37
319−6136−02, 48
319−6137−02, 48
319−6229−02, 31 , 33
319−6587, 31 , 33
319−6838, 11
319−7151, 63
320−2164−01, 77
320−2164−02, 77
320−2164−03, 77
320−2196−01, 77
320−2196−02, 77
321−0415, 81 , 82
321−0416−01, 81 , 82
322−0017, 51
322−0488, 51
322−0491, 59
322−0493−04, 59
322−0493−05, 59
322−0493−06, 59
323−1410−01, 55
323−1445, 13
323−1491, 13
323−1492, 13 , 81 , 82
323−1493, 81 , 82
323−1494, 13 , 81 , 82
323−1500, 13
323−1502, 13
323−1503, 81 , 82
323−1504, 13
323−1547, 14 , 17
323−1549, 14 , 17
323−1580−02, 81 , 82
323−1581, 81 , 82
323−1582, 81 , 82
323−1582−02, 80
323−1583, 80 , 81 , 82
323−1591, 14 , 17
323−1605−04, 81 , 82
323−1614−01, 81 , 82
323−1623, 81 , 82
323−1624, 81 , 82
323−1643−01, 79
323−1644−03, 79
323−1648, 79
323−1652, 13
323−1718, 13
323−1835−02, 81 , 82
323−1836, 81 , 82
323−1837, 81 , 82
323−1841, 81 , 82
323−1843, 81 , 82
323−1847−01, 81 , 82
323−1848, 53
323−1888, 81 , 82
323−1899−01, 59
323−2275, 17 , 81 , 82
323−2277, 81 , 82
323−2280, 80 , 81 , 82
323−2299, 80
323−2430, 14 , 17
323−2431, 14 , 17
323−2432, 14 , 17
323−2433, 17
326−0230, 51
327−1309, 85
327−1376−01, 53
327−1376−02, 53
327−1390, 53
327−1392, 53
330−0141−01, 43
330−0142, 43
330−0169−02, 28
330−0170−02, 28
330−0171−02, 28
330−0172−02, 28
330−0181−02, 28
330−0186, 31 , 33 , 35 , 37
331−0042, 13
331−0555, 13
332−0052, 51 , 57
332−0418−01, 81 , 82
332−0607, 81 , 82
332−1043, 81 , 82
332−1468, 13
332−1469, 13
332−1506, 81 , 82
332−1911, 51
332−1992, 81 , 82
332−1993, 81 , 82
332−2001, 62
332−2420, 58
332−2512, 77
332−2634, 11
332−2743−07, 77
332−2744−07, 77
332−2770−01, 61
332−2878, 52 , 65 , 75
332−2879−02, 65 , 75
332−2898, 41
332−2921, 31 , 33 , 35 , 37
332−2974, 81 , 82
332−3023, 43
332−3024−14, 43
332−3039, 77
332−3058, 81 , 82
332−3125−01, 47 , 65 , 75
332−3126−01, 47 , 65 , 75
332−3196, 44
332−3440, 13
332−3491−01, 81 , 82
332−3653, 61
332−3949, 77
332−3967−02, 41 , 42
332−3969−02, 41 , 42
332−3970−02, 41 , 42
332−3976−02, 41
332−3978−02, 41 , 42
332−3990−02, 42
332−4002, 47
332−4043, 71
332−4044, 67 , 69
332−4053, 42
332−4054−02, 41
332−4055−02, 42
332−4058−02, 42
332−4059−02, 42
332−4060, 41
332−4062−02, 41 , 42
332−4063−02, 41 , 42
332−4134, 31 , 33 , 35 , 37
332−4160−02, 35 , 37
332−4161−02, 35 , 37
332−4164−02, 35 , 37
332−4170, 31 , 33
332−4176−02, 35 , 37
332−4177−02, 35 , 37
333−0438−05, 43
333−0438−06, 43
333−0645−01, 47
333−0645−02, 47
333−0654, 59
333−0677−01, 11
333−0677−02, 11
334−0761, 81 , 82
335−0249−01, 35 , 37
335−0249−02, 31 , 33
335−0251−01, 31 , 33
335−0251−02, 31 , 33
335−0251−03, 31 , 33
335−0251−04, 31 , 33
335−0251−05, 35 , 37
335−0251−06, 35 , 37
335−0251−07, 35 , 37
Part No. Page Part No. Page Part No. Page Part No. Page
Numerical Index
90Copyright 2016 Cummins Inc.
335−0251−08, 35 , 37
337−0049, 35 , 37 , 48 , 52
337−0090−01, 6
337−3466−01, 48
337−3618, 77
337−3619−01, 77
337−3619−02, 77
337−3620−01, 77
337−3620−02, 77
337−3621−01, 77
337−3621−02, 77
337−3623, 77
337−3624, 77
337−3625, 77
337−3626, 77
337−3627, 77
337−3631, 77
337−3661, 41
337−3662, 41
337−3673, 41
337−3736, 77
337−3766, 35 , 37
337−3772, 31 , 33 , 35 , 37
337−3773, 35 , 37
337−3780, 35 , 37
337−3785, 31 , 33 , 35 , 37
337−3788, 31 , 33
337−3789, 31 , 33
337−3813, 41
337−3814, 31 , 33
338−4315, 52
338−4316, 79
338−4317, 79
338−4351, 59
338−4363, 52
338−4386, 58
338−4408, 58
338−4463−01, 79
338−4463−02, 79
338−4470, 68 , 71
338−4471, 67 , 69
338−4475, 75
338−4477, 65
338−4649−01, 51
338−4707, 80
338−4744, 81
338−4858, 14 , 17
338−4986, 13
338−4995−03, 13
338−4995−05, 13
338−5072, 67
357−0030, 13 , 81 , 82
363−0183, 53
370−4081, 17
402−0354, 58
402−0666−01, 48
402−0750−01, 26
403−4332, 24 , 25
403−6151, 22
405−7779, 51
406−0810, 51
406−0916, 53
406−0917, 53
406−0930, 51
406−0932−02, 51
406−1015, 41 , 42
416−0632, 6
416−0639, 6
416−0680, 6
416−1019, 6
416−1021−03, 80 , 81 , 82
416−1084−01, 6
416−1096, 6
425−1799, 51
496416300, 7
496418300, 7
501−0744−05, 11
501−0918, 24 , 25
501−0919, 24 , 25
501−0970−01, 7
502−1318, 11 , 17
502−1326, 17
502−1479, 6
502−1588, 7
502−1589, 6
502−1592, 7
502−1704, 11
503−0398, 6
503−0970−01, 8 , 9
503−1418, 48
503−1485, 9
503−1705, 8
503−1721, 9
503−1726, 17
503−1728, 17
503−1870−11, 8 , 9
503−1870−13, 8
503−1870−14, 8 , 9
503−1870−16, 9
503−1872−01, 18 , 22
503−1872−04, 22
503−1872−05, 17 , 18
503−1872−09, 17
503−2012, 9
503−2102, 8
503−2129−04, 17
503−2129−05, 17
503−2157−02, 11
503−2386, 6
503−2451, 22
503−2452, 22
503−2641, 22
503−2658, 18
503−2661, 22
503−2693, 18 , 22
503−3062−01, 11
504−0171, 17
504−0213, 11
504−0251, 6
505−0023, 7
505−0051, 17
505−0153, 17
505−0324, 17
505−0754, 17
505−2112, 11
505−2138, 60
508−0228, 43
508−0305−01, 41 , 42
508−1057, 31 , 33 , 35 , 37
508−1186, 51
509−0283−01, 11
509−0353, 6
509−0378, 11
509−0379, 11
511−0161−27, 20
512−0309, 20
517−0021, 43
517−0080, 8 , 9
517−0090, 75
517−0133, 52
517−0136, 41 , 42
517−0138−02, 13
518−0350, 60
518−0515, 67 , 68 , 69 , 71
518−0548−24, 11
518−0601, 5
520−2651−01, 67 , 68 , 69 ,71
525−0304, 5
525−0305, 5
525−0306, 5
526−0003, 58
526−0008, 52 , 75
526−0022, 75
526−0030, 7 , 31 , 33 , 35 ,37
526−0038, 21
526−0049, 13
526−0115, 52
526−0128, 11 , 48
526−0219, 22 , 41 , 42
526−0324, 48
526−0393, 17
526−0399−20, 31 , 33 , 35 ,37
526−0399−58, 66
526−0399−60, 31 , 33 , 35 ,37 , 38 , 62 , 67 , 68 , 69 , 71
526−0399−62, 17
526−0399−64, 17 , 31 , 33 ,35 , 37 , 44
526−0399−75, 17
526−0399−76, 24 , 25
526−0399−78, 24 , 25
Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
91Copyright 2016 Cummins Inc.
526−0416, 44
526−0423, 77
526−0460−02, 24 , 25
526−2100, 48
526−2120, 9
526−2140, 6 , 31 , 33 , 35 ,37 , 77
526−2303, 51
526−2342, 22
541−0809, 53 , 85
541−0814−01, 85
541−0814−02, 85
541−1416, 43
541−1684, 21
543−0088, 85
718−1076, 42 , 77
750−1010, 42
800−0028, 77
800−0030, 77
800−0039, 75
800−0048, 77
800−0050, 7 , 31 , 33 , 35 ,37 , 77
800−0051, 31 , 33 , 35 , 37
800−0052, 77
800−0054, 77
800−0090, 77
800−0093, 77
800−0094, 77
800−0310−03, 28
800−0310−36, 31 , 33 , 35 ,37
800−2008, 43
800−2044, 66
800−2060, 48
800−2061, 38 , 71
800−2063, 62 , 77
800−2075, 71
800−2111, 6
800−2112, 31 , 33
800−2114, 41
800−2118, 41
800−2201, 8 , 9
800−2206, 24 , 25
800−2208, 24 , 25
800−2543−07, 44
800−2543−13, 41
800−3017−41, 17 , 48
800−3017−54, 17
800−3017−55, 35 , 37
800−3017−56, 31 , 33 , 35 ,37
800−3047−03, 24 , 25
800−3047−04, 24 , 25
800−3048−02, 24 , 25
800−3048−04, 24 , 25
800−6284−01, 17
805−2022, 44
812−0082, 58
812−0094, 58
813−0098, 75
815−0203, 13
815−0261, 77
815−0446, 13
815−0447, 13
815−0539, 11
815−0776, 48
815−0793−02, 52
815−0796, 51
815−0947, 53
815−0948, 53
815−0949, 53
818−0231−02, 48
818−1150−02, 47 , 52
819−1157, 52
821−0010, 58
821−0017, 58
821−2045, 52
821−5002−03, 11
821−6001−01, 51
821−6001−03, 49 , 65
821−6002−02, 64
821−6002−03, 27
821−6002−04, 77
821−6003−01, 17 , 35 , 37 ,60
821−6003−02, 8 , 9 , 11 , 27 ,28 , 31 , 33 , 35 , 37 , 38 , 39
, 41 , 42 , 48 , 67 , 68 , 69 ,71 , 77
821−6003−03, 17 , 31 , 33 ,35 , 37 , 77
821−6004−01, 39 , 48
822−3047, 43
822−3075, 43
823−0001−01, 51
823−0002−05, 52
850−0025, 58
850−0030, 75
850−0045, 75
850−0050, 7 , 31 , 33 , 35 ,37 , 77
850−0060, 77
850−0114−05, 28
850−0114−52, 65
850−0114−53, 66
850−0114−54, 31 , 33 , 35 ,37 , 62
850−0114−55, 17
850−0114−56, 31 , 33 , 35 ,37
850−2003, 43
850−2004, 43
850−2005, 43
850−2012, 6 , 77
850−2020, 8 , 9
851−0022, 31 , 33 , 35 , 37 ,77
851−0023, 41
851−0048−01, 67 , 68 , 69 ,71 , 77
851−0048−02, 77
851−0048−03, 31 , 33 , 35 ,37 , 77
852−0026−55, 31 , 33 , 35 ,37
853−0005, 58
853−2008, 48 , 52 , 62
856−0003, 13
856−0006, 28
856−0008, 28 , 31 , 33 , 35 ,37
856−0013, 6 , 31 , 33 , 35 ,37 , 41
860−0008, 58
860−2005, 43
860−2006, 43 , 51
860−2010, 31 , 33 , 35 , 37 ,41 , 77
860−2023−01, 24 , 25
860−2024−01, 24 , 25
862−0003, 31 , 33 , 35 , 37 ,77
862−0005, 77
862−0015, 75 , 77
862−0026−53, 65
862−0026−56, 17
870−0131, 11 , 13
870−0212, 58
870−0221, 58
870−0257, 58
870−0550−09, 11
870−2055, 31 , 33 , 35 , 37 ,48 , 52
870−2056, 48
870−2062, 51 , 52 , 56 , 57
870−2064−01, 51
870−2065−03, 8 , 42 , 67 ,68 , 69 , 71
870−2203, 9
871−0010, 13
872−0019−01, 51 , 56 , 57
872−0036, 31 , 33 , 35 , 37
895−0401, 59
898−0860, 81 , 82
898−0861, 81 , 82
898−1195−02, 14
898−1195−03, 81 , 82
898−1195−04, 81 , 82
A026E452, 17
A026H421, 9
A026H422, 9
A029B928, 18 , 21
A029D229, 52
A029R718, 51 , 52 , 82
A029X986, 18
A029Y303, 8
A029Y804, 18
A029Y814, 18
Part No. Page Part No. Page Part No. Page Part No. Page
Numerical Index
92Copyright 2016 Cummins Inc.
A029Y817, 18
A030A089, 11
A030A665, 24 , 25
A030C149, 24
A030D337, 18
A030F216, 43
A030S164, 26
A030S325, 18 , 21
A030S327, 18 , 21
A030S330, 19 , 23
A030S331, 19 , 23
A030S337, 19 , 23
A030S338, 19 , 23
A030S339, 19 , 23
A030S342, 19 , 23
A030S343, 19 , 23
A030S345, 18 , 22
A030S346, 18 , 22
A030S350, 18 , 22
A030S414, 22
A030S415, 22
A030X518, 11 , 42
A032Y595, 41
A034K745, 27
A035H893, 51
A035H895, 51
A041S508, 48
A043M148, 52
A043T369, 60
A046J227, 60
A046J229, 60
A052Y984, 51
SP64430, 18 , 22
power.cummins.comCopyright � 2016 Cummins Inc. All rights reserved.
Cummins Power Generation, the “C” logo, and Cummins are trademarks of Cummins Inc.
PowerCommand, AmpSentry, InPower and “Our energy working for you.” are trademarks of Cummins Power Generation Inc.
Other company, product, or service names may be trademarks or service marks of others.
Specifications are subject to change without notice.
Top Related