WORKSHOP SAFETYTeknik Kendaraan RinganSemester 1st Class XDasar Kompetensi KejuruanSK-KD 7th

Teknologi dan Rekayasa

DIAGRAM ALUR PENCAPAIAN KOMPETENSI

Teknologi dan RekayasaDress and AppearanceLoose clothingshirts tuckedSleeves buttoned or rolledDo you look like a Technician Prepared to work on todays cars?

Teknologi dan Rekayasa

Dress and Appearance. Teknologi dan RekayasaOr a Mechanic of the 70s ?Your appearance is a reflection of your pride

Dress and Appearance. Teknologi dan RekayasaYou will get the level of job that you look likeIs he going to work on my $35,000 dollar car?What about visiting employers?

HairTeknologi dan RekayasaLong hair tied or put under cap

JewelryTeknologi dan RekayasaWatchesRingsBraceletsHave you ever seen a mechanic with a missing finger?Electrical short to ground!Zap!!!

Your EyesTeknologi dan RekayasaInjuries are usually permanentOSHA approved safety glassesSide shieldsFace shieldsAir gunsMetal chipsCo-workersSolderingGrinders

Electrical CordsTeknologi dan RekayasaFrayedshocked . . . wet floorPlug insthree prongsfor a good groundCarefully string cords so they dont get tripped over

Air EquipmentTeknologi dan RekayasaKeep hoses in good repairBlow gunspointing at someoneSafety glassesSkin cutsSpinning bearings

Vehicles in the shopTeknologi dan RekayasaWindows down!

Parking brake on!

In park!

SpillsTeknologi dan RekayasaClean up right awaySocksCat litterEmpty drain pan as soon as possiblein approved containersWork area must be clean before you go home each evening!

CreepersTeknologi dan RekayasaNever leave them laying on the floorstand them upplace under the vehicle if necessary

Always keep walkways clear between carscreepers, tools cords, spills

Vehicle hoistsTeknologi dan RekayasaCar must be centeredby where the weight is..

Correct lift pointsTeknologi dan RekayasaThe lift pads must all be screwed in or out so that they contact the car at the same time

Jacking a vehicleTeknologi dan RekayasaCorrect lift points ONLYcoded for the different types of lifts

Always use approved standsTeknologi dan RekayasaNever fully extend a jack standJust use a larger jack standCaution Floor cracks when lifting the 2nd half of the car

LiftingTeknologi dan RekayasaNever lift this wayUse your kneesYour 1 in diameter back bone is all there is

Save your backTeknologi dan RekayasaLift anithing this way

BatteriesTeknologi dan RekayasaHydrogen fumesWhen?ChargingDischargingHydrogen Bomb?Negative cable 1st off - last on

BatteriesTeknologi dan RekayasaBefore disconnecting a battery have all accessories offHood lights etc.Blow across the batteryMemory saverPosition yourself strategicallyIf a battery blows upFlush eyesflush flush flush flush flush flush flush flush You will need helpThen worry about the acid on the caror another student can take care of thatTools on a batteryUsing tools near a battery

Engine Fans and BeltsTeknologi dan RekayasaNever stand in line with them with the engine running

Work LightTeknologi dan RekayasaNever leave a drop light on the carpet, on a seat or on the plastic dashUse a rough service bulb, 60 watts max..Use a Fluorescent Work Light or a LED light

Shop VentilationTeknologi dan RekayasaCarbon MonoxideAlways use exhaust hosesConnect to in floor ventsKeep vents closed when not in useConnect to over head hoses

Effects of low tire pressure OverinflationTeknologi dan RekayasaClose your eyesImagine, What would it be like to. . . . . .go through life knowing that your actions resulted in the permanent disability or even the death of one of your customers or co-workers

Thanks very muchPresented by Aloysius Sudibyo SMK Negeri 1 MagelangSources CBC Automotive

Teknologi dan Rekayasa

************