Wiring Manual - Amick Racing
Transcript of Wiring Manual - Amick Racing
Wiring ManualPackaged Gas/Electricwith ReliaTel™ Controls3 - 10 Tons
November 2004
Models:(60 Hz)YSC036A*R - YSC120A*RYHC033A*R - YHC120A*R
Y_C-SVE002B-EN
2 Y_C-SVE002B-EN
Introduction
Literature Change History
Y_C-SVE-002A-EN (Nov. 2003)Updated wiring diagrams.
Y_C-SVE-002B-EN (Nov. 2004)Updated wiring diagrams.
Overview of Manual
This manual provides wiring diagramsfor unit models listed on the front page.Refer to the Table of Contents for properwiring diagrams.
NOTICE:Warnings and Cautions appear atappropriate sections throughout this
manual. Read these carefully.
WARNING– Indicates apotentially hazardous situationwhich, if not avoided, could result indeath or serious injury.
CAUTION – Indicates apotentially hazardous situationwhich, if not avoided, may result inminor or moderate injury. It may alsobe used to alert against unsafepractices.
CAUTION – Indicates a situationthat may result in equipment orproperty-damage-only accidents.
Y_C-SVE002B-EN 3
Contents
Literature Change History .............................................. 2
Warnings and Cautions .................................................. 2
Model Number Description ............................................ 5
Power SchematicsDiagram 1 ....................................................................... 6Power Schematic - 230v/60hz/1ph2 - 5 Ton Single Stage Gas Heat / Direct Drive Motor4366-1002
Diagram 2 ....................................................................... 8Power Schematic - 230v/60hz/1ph2 - 5 Ton Single Stage Gas Heat / Oversize Drive Motor4366-1018
Diagram 3 ..................................................................... 10Power Schematic - 230v/60hz/3ph2 - 5 Ton Single Stage Gas Heat / Direct Drive Motor4366-1000
Diagram 4 ..................................................................... 12Power Schematic - 230v/60hz/3ph2 - 5 Ton Single Stage Gas Heat / Oversize Drive Motor4366-1017
Diagram 5 ..................................................................... 14Power Schematic - 230v/60hz/3ph2 - 7.5 Ton Single Stage Gas Heat / Belt Drive Motor4366-1016
Diagram 6 ..................................................................... 16Power Schematic - 230v/60hz/3ph7.5 - 10 Ton Gas Heat / Dual Compressor4366-1033
Diagram 7 ..................................................................... 18Power Schematic - 460-575v/60hz/3ph2 - 3 Ton Single Stage Gas Heat / Direct Drive Motor4366-1004
Diagram 8 ..................................................................... 20Power Schematic - 460-575v/60hz/3ph4 - 5 Ton Single Stage Gas Heat / Direct Drive Motor4366-1032
Diagram 9 ..................................................................... 22Power Schematic - 460-575v/60hz/3ph4 - 5 Ton Single Stage Gas Heat / Oversize Drive Motor .4366-1011
Diagram 10 ................................................................... 24Power Schematic - 460-575v/60hz/3ph2 - 7.5 Ton Single Stage Gas Heat / Belt Drive Motor4366-1005
Diagram 11 ................................................................... 26Power Schematic - 460-575v/60hz/3ph7.5 - 10 Ton Gas Heat / Dual Compressor4366-1034
Connection SchematicsDiagram 12 ................................................................... 28Connection Schematic - 230v/60hz/1phSingle Stage Gas Heat / Direct Drive4366-1501
Diagram 13 ................................................................... 30Connection Diagram - 230v/60hz/1phSingle Stage Gas Heat / Oversize Motor4366-1520
Diagram 14 ................................................................... 32Connection Diagram - 230v/60hz/3phSingle Stage Gas Heat / Direct Drive4366-1503
Diagram 15 ................................................................... 34Connection Diagram - 230v/60hz/3phSingle Stage Gas Heat / Oversize Motor4366-1504
Diagram 16 ................................................................... 36Connection Diagram - 230v/60hz/3phSingle Stage Gas Heat / Belt Drive4366-1522
Diagram 17 ................................................................... 38Connection Diagram - 230v/60hz/3ph6 - 7. 5 Ton Gas Heat / Single Compressor4366-1539
Diagram 18 ................................................................... 40Connection Diagram - 230v/60hz/3ph7. 5 - 10 Ton Gas Heat / Dual Compressor4366-1530
Diagram 19 ................................................................... 42Connection Diagram - 460-575v/60hz/3ph2 - 3 Ton Single Stage Gas Heat / Direct Drive4366-1514
Diagram 20 ................................................................... 44Connection Diagram - 460-575v/60hz/3ph4 - 5 Ton Single Stage Gas Heat / Direct Drive4366-1518
Diagram 21 ................................................................... 46Connection Diagram - 460-575v/60hz/3ph4 - 5 Ton Single Stage Gas Heat / Oversize Motor4366-1515
4 Y_C-SVE002B-EN
Contents
Diagram 22 ................................................................... 48Connection Diagram - 460-575v/60hz/3phSingle Stage Gas Heat / Belt Drive4366-1516
Diagram 23 ................................................................... 50Connection Diagram - 460-575v/60hz/3ph6 - 7.5 Ton Gas Heat / Single Compressor4366-1540
Diagram 24 ................................................................... 52Connection Diagram - 460-575v/60hz/3ph7.5 - 10 Ton Gas Heat / Dual Compressor4366-1532
Control SchematicsDiagram 25 ................................................................... 54Control Schematic2 - 5 Ton Single Stage Gas Heat / Direct Drive4366-1006
Diagram 26 ................................................................... 56Control Schematic2 - 7.5 Ton Single Stage Gas Heat / Belt Drive or Oversize Motor4366-1015
Diagram 27 ................................................................... 58Control Schematic 7.5 - 10 Ton Gas Heat / Dual Compressor4366-1042
Novar SchematicsDiagram 28 ................................................................... 60Novar 2024
Diagram 29 ................................................................... 61Novar 3051
Through The Base Utilities SchematicDiagram 30 ................................................................... 62
CO2 Sensor / Ventilation Override Schematic
Diagram 31 ................................................................... 63
Y_C-SVE002B-EN 5
Model Number Description
DIGIT 1 - Unit Function
Y = DX Cooling, Gas Heat
DIGIT 2 - Efficiency
S = Standard EfficiencyH = High Efficiency
DIGIT 3 - Airflow
C = Convertible
DIGITS 4,5,6 - Nominal Gross Cooling
Capacity (MBh)
033 = 3-Ton036 = 3-Ton043 = 4-Ton048 = 4-Ton060 = 5-Ton063 = 5-Ton072 = 6-Ton090 = 7½-Ton, Single Compressor092 = 7½-Ton, Dual Compressors102 = 8½-Ton120 = 10-Ton
DIGIT 7 - Major Design Sequence
A = First
DIGIT 8 - Unit Voltage
1 = 208-230/60/13 = 208-230/60/34 = 460/60/3W= 575/60/3K = 380/60/3
DIGIT 9 - Unit Controls
E = ElectromechanicalR = ReliaTel™Microprocessor
DIGIT 10 - Heating Capacity
L = LowM = MediumH = HighX = Low, Stainless Steel Heat ExchangerY = Medium, Stainless Steel Heat
ExchangerZ = High, Stainless Steel Heat Exchanger
DIGIT 11 - Minor Design Sequence
A = First Sequence
Y S C 036 A 3 R L A ** C 0 0 0 C 1 0 0 0 1 A 1
1 2 3 4,5,6 7 8 9 10 11 12,13 14 15 16 17 18 19 20 21 22 23 24 25
DIGITS 12, 13 - Service Sequence
** = Factory Assigned
DIGIT 14 - Fresh Air Selection
0 = No Fresh AirA = Manual Outside Air Damper 0-50%B = Motorized Outside Air Damper 0-50%C = Economizer, Dry Bulb 0-100%
without Barometric ReliefD = Economizer, Dry Bulb 0-100%
with Barometric ReliefE = Economizer, Reference Enthalpy
0-100% without Barometric ReliefF = Economizer, Reference Enthalpy
0-100% with Barometric ReliefG = Economizer, Comparative Enthalpy
0-100% without Barometric ReliefH = Economizer, Comparative Enthalpy
0-100% with Barometric Relief
DIGIT 15 - Supply Fan/Drive Type/Motor
0 = Standard Drive1 = Oversized Motor2 = Optional Belt Drive Motor
DIGIT 16 - Hinged Service AccessFilters
0 = Standard Panels/Standard FiltersA = Hinged Access Panels/Standard FiltersB = Standard Panels/2” Pleated FiltersC = Hinged Access Panels/2” Pleated Filters
DIGIT 17 - Condenser Coil Protection
0 = Standard Coil1 = Standard Coil with Hail Guard2 = Epoxy Coated Condenser Coil3 = Epoxy Coated Condenser Coil with
Hail Guard
DIGIT 18 - Through the Base Provisions
0 = No Through the Base ProvisionsA = Through the Base ElectricB = Through the Base Gas PipingC = Through the Base Electric and Gas Piping
DIGIT 19 - Disconnect/Circuit Breaker
(3 phase only)
0 = No Disconnect or Circuit Breaker1 = Non-Fused Disconnect
2 = Circuit Breaker
DIGIT 20 - Convenience Outlet
0 = No Convenience OutletA = Unpowered Convenience OutletB = Powered Convenience Outlet
(3 phase only)
DIGIT 21 - Communications Options
0 = No Communications Interface1 = Trane Communications Interface2 = LonTalk® Communications Interface3 = Novar 2024 Controls4 = Novar 3051 Controls
DIGIT 22 - Refrigeration System Option
0 = Standard Refrigeration SystemA = Thermal Expansion Valve (TXV)B = Dehumidification (Hot Gas Reheat Coil)
DIGIT 23 - Refrigeration Controls
0 = No Refrigeration Control1 = High Pressure Control2 = Frostat3 = Crankcase Heater4 = High Pressure Control and Frostat5 = High Pressure Control and Crankcase
Heater6 = Frostat and Crankcase Heater7 = High Pressure Control, Frostat and
Crankcase Heater
DIGIT 24 - Smoke Detector
0 = No Smoke DetectorA = Return Air Smoke DetectorB = Supply Air Smoke DetectorC = Supply and Return Air Smoke
Detectors
DIGIT 25 - Monitoring Controls
0 = No Monitoring Control1 = Clogged Filter Switch2 = Fan Failure Switch3 = DischargeAir Sensing Tube4 = Clogged Filter Switch and Fan Fail
Switch5 = Clogged Filter Switch and Discharge
Air Sensing Tube6 = Fan Fail Switch and Discharge Air
Sensing Tube7 = Clogged Filter and Fan Fail Switches
and Discharge Air Sensing Tube8 = Novar Return Air Sensor
6 Y_C-SVE002B-EN
Diagram 1Power Schematic - 230v/60hz/1ph3 - 5 Ton Single Stage Gas Heat / Direct Drive Motor4366-1002
Y_C-SVE002B-EN 7
8 Y_C-SVE002B-EN
Diagram 2Power Schematic - 230v/60hz/1ph2 - 5 Ton Single Stage Gas Heat / Oversize Motor4366-1018
Y_C-SVE002B-EN 9
10 Y_C-SVE002B-EN
Diagram 3Power Schematic - 230v/60hz/3ph2 - 5 Ton Single Stage Gas Heat / Direct Drive Motor4366-1000
Y_C-SVE002B-EN 11
12 Y_C-SVE002B-EN
Diagram 4Power Schematic - 230v/60hz/3ph2 - 5 Ton Single Stage Gas Heat / Oversize Motor4366-1017
Y_C-SVE002B-EN 13
14 Y_C-SVE002B-EN
Diagram 5Power Schematic - 230v/60hz/3ph2 - 7.5 Ton Gas Heat / Belt Drive or Oversize Motor4366-1016
Y_C-SVE002B-EN 15
16 Y_C-SVE002B-EN
Diagram 6Power Schematic - 230v/60hz/3ph 7.5 - 10 Ton Gas Heat / Dual Compressor4366-1033
Y_C-SVE002B-EN 17
18 Y_C-SVE002B-EN
Diagram 7Power Schematic - 460-575v/60hz/3ph3 Ton Single Stage Gas Heat / Direct Drive Motor4366-1004
Y_C-SVE002B-EN 19
20 Y_C-SVE002B-EN
Diagram 8Power Schematic - 460-575v/60hz/3ph4 - 5 Ton Single Stage Gas Heat / Direct Drive Motor4366-1032
Y_C-SVE002B-EN 21
22 Y_C-SVE002B-EN
Diagram 9Power Schematic - 460-575v/60hz/3ph4 - 5 Ton Single Stage Gas Heat / Oversize Motor4366-1011
Y_C-SVE002B-EN 23
24 Y_C-SVE002B-EN
Diagram 10Power Schematic - 460,575v/60hz/3ph2 - 7. 5 Ton Gas Heat / Belt Drive Motor4366-1005
Y_C-SVE002B-EN 25
26 Y_C-SVE002B-EN
Diagram 11Power Schematic - 460,575v/60hz/3ph7. 5 - 10 Ton Gas Heat / Belt Drive Motor4366-1034
Y_C-SVE002B-EN 27
28 Y_C-SVE002B-EN
Diagram 12Connection Schematic - 230v/60hz/1ph3 - 5 Ton Single Stage Gas Heat / Direct Drive4366-1501
Y_C-SVE002B-EN 29
30 Y_C-SVE002B-EN
Diagram 13Connection Diagram - 230v/60hz/1ph3 - 5 Ton Single Stage Gas Heat / Oversize Motor4366-1520
Y_C-SVE002B-EN 31
32 Y_C-SVE002B-EN
Diagram 14Connection Diagram - 230v/60hz/3ph3 - 5 Ton Single Stage Gas Heat / Direct Drive4366-1503
Y_C-SVE002B-EN 33
34 Y_C-SVE002B-EN
Diagram 15Connection Diagram - 230v/60hz/3ph3 - 5 Ton Single Stage Gas Heat / Oversize Motor4366-1504
Y_C-SVE002B-EN 35
36 Y_C-SVE002B-EN
Diagram 16Connection Diagram - 230v/60hz/3ph3 - 5 Ton Single Stage Gas Heat / Belt Drive4366-1522
Y_C-SVE002B-EN 37
38 Y_C-SVE002B-EN
Diagram 17Connection Diagram - 230v/60hz/3ph6 - 7.5 Ton Gas Heat / Single Compressor4366-1539
Y_C-SVE002B-EN 39
40 Y_C-SVE002B-EN
Diagram 18Connection Diagram - 230v/60hz/3ph7.5 - 10 Ton Gas Heat / Dual Compressor4366-1530
Y_C-SVE002B-EN 41
42 Y_C-SVE002B-EN
Diagram 19Connection Diagram - 460-575v/60hz/3ph3 Ton Gas Heat / Direct Drive4366-1514
Y_C-SVE002B-EN 43
44 Y_C-SVE002B-EN
Diagram 20Connection Diagram - 460-575v/60hz/3ph4 - 5 Ton Gas Heat / Direct Drive4366-1518
Y_C-SVE002B-EN 45
46 Y_C-SVE002B-EN
Diagram 21Connection Diagram - 460-575v/60hz/3ph4 - 5 Ton Gas Heat / Oversize Motor4366-1515
Y_C-SVE002B-EN 47
48 Y_C-SVE002B-EN
Diagram 22Connection Diagram - 460-575v/60hz/3ph3 - 5 Ton Gas Heat / Belt Drive4366-1516
Y_C-SVE002B-EN 49
50 Y_C-SVE002B-EN
Diagram 23Connection Diagram - 460-575v/60hz/3ph6 - 7.5 Ton Gas Heat / Single Compressor4366-1540
Y_C-SVE002B-EN 51
52 Y_C-SVE002B-EN
Diagram 24Connection Diagram - 460-575v/60hz/3ph7.5 - 10 Ton Gas Heat / Dual Compressor4366-1532
Y_C-SVE002B-EN 53
54 Y_C-SVE002B-EN
Diagram 25Control Schematic -2 - 5 Ton Single Stage Gas Heat / Direct Drive4366-1006
Y_C-SVE002B-EN 55
56 Y_C-SVE002B-EN
Diagram 26Control Schematic -2 - 5 Ton Single Stage Gas Heat / Belt Drive or Oversize Motor4366-1015
Y_C-SVE002B-EN 57
58 Y_C-SVE002B-EN
Diagram 27Control Schematic -7.5 -10 Ton Gas Heat4366-1042
Y_C-SVE002B-EN 59
60 Y_C-SVE002B-EN
Diagram 28Novar Schematic -2024
Y_C-SVE002B-EN 61
Diagram 29Novar Schematic -3051
62 Y_C-SVE002B-EN
Diagram 30Through The Base Utilities Schematic -
Y_C-SVE002B-EN 63
Diagram 31CO2 Sensor / Ventilation Override Schematic
64 Y_C-SVE002B-EN
The manufacturer has a policy of continuous product and product data improvement and reserves the right to changedesign and specifications without notice.
Literature Order Number
File Number
Supersedes
Stocking Location
Y_C-SVE002B-EN
New
Webb Mason
SV-UN-Y_C-SVE002B-EN 11/04