Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase...
-
Upload
nicolas-ratkovich -
Category
Documents
-
view
1.997 -
download
5
description
Transcript of Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase...
![Page 1: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/1.jpg)
www.mbr-network.eu
Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling
and experimental validation
Nicolás Ratkovich
Faculty of Bioscience EngineeringGhent University
May 3rd 2010, Ghent - Belgium
![Page 2: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/2.jpg)
2
IntroductionWaste water treatment processes• Goals
- Produce clean effluent- Recover nutrients and energy from waste stream
• Biological treatment - Conventional Activated Sludge (CAS) – Gravity-based separation
Air
Influent
Bioreactor
Effluent
Settler
![Page 3: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/3.jpg)
3
IntroductionWaste water treatment processes (cont.)• Biological treatment (cont.)
- Membrane Bioreactor (MBR) – Filtration-based separation
Immersed
Side-streamAir
Influent
Bioreactor
Effluent
Membrane
Air
Influent
Bioreactor
Effluent
![Page 4: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/4.jpg)
4
IntroductionWaste water treatment processes (cont.)• Comparison (pros & cons)
CAS MBR
Sludge production ↑ ↓
Effluent quality ↓ ↑
Disinfection ↓ ↑
Footprint ↑ ↓
Problem Settling Fouling
Energy consumption ↓ ↑
Cost ↓ ↑
![Page 5: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/5.jpg)
5
IntroductionMBR economics
![Page 6: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/6.jpg)
6
IntroductionMBR economics• Energy
- MBR > CAS- MBR ≈ CAS + TT
• Total cost- MBR > CAS- MBR ≈ CAS + TT
• Effluent quality- MBR > CAS- MBR = CAS + TT
TT: Tertiary treatment (polishing)
O&
M c
osts
bre
akdo
wn
($/m
3 )
0.15
0.10
0.05
0.00
CAS MBR CAS+TT
Cote et al. (2004)
Energy optimization (air sparging)
![Page 7: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/7.jpg)
7
IntroductionMembrane fouling (drawback)• Caused by attachment of…
- suspended solids and - soluble substances
• Mechanisms of fouling:
Pore blocking
Cake build up
Clean membrane
Resistances
Relaxation
Mem
bran
e
Operation
Filtration
Backwash
![Page 8: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/8.jpg)
8
IntroductionAir sparging• Used as fouling control• Gas-liquid (two-phase) flow in
vertical tubes• Slug flow
• Advantages- Airlift (buoyancy)- Scouring effect (shear stress)
Gas slug
Air flow
![Page 9: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/9.jpg)
9
Biology
Filtration
Hydrodynamics Particle size distribution
Influent
TMP - Flux
Effluent
Motivation
• Membrane Fouling- Scouring effect (shear)- Particle removal
• Energy consumption- Aeration (air sparging)- Viscosity
![Page 10: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/10.jpg)
10
Outline
![Page 11: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/11.jpg)
11
Objectives
To observe and measure…• Behaviour of developed gas slug• Shear stress using Shear Probes (SP)• Gas slug rising velocity using High Speed Camera (HSC)
To develop…• CFD and empirical models
To quantify…• Pressure drop and energy consumption of the system
![Page 12: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/12.jpg)
12
IntroductionSlug flow• 3 Zones• Large shear stress values• Dynamic shear stress
*Taha & Cui, 2006
Falling film zone
Wake zone
Liquid slug zone
![Page 13: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/13.jpg)
13
Experimental set-upTube diameter:• 9.9 mm
Fluids used:• Water + electrolyte
Flow rates:• Liquid: 0.1 - 0.5 l⋅min-1
• N2: 0.1 - 0.3 l⋅min-1
![Page 14: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/14.jpg)
14
Experimental set-up at UBC (SP)Electrolyte solution• Cathode (probes):• Anode (pipe fitting):
Shear probe (magnitude)
( ) ( ) −− →+ 46
36 CNFeeCNFe
( ) ( ) eCNFeCNFe 36
46 +→ −−
Shear stress
0.00
0.10
0.20
0.30
0.40
0.50
0.60
0.70
0 0.2 0.4 0.6 0.8 1
Time (s)
Volta
ge (V
)
Probe 1
0
0.2
0.4
0.6
0.8
1
0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1
Time (s)
Shea
r str
ess
(Pa)
Probe 1
![Page 15: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/15.jpg)
15
Experimental set-up at UBC (SP)2 Shear probes (flow direction)
Two voltage signals
Gas slug Gas slug
Shear stress
![Page 16: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/16.jpg)
16
Experimental measurements
Experimental measurements• i.e. 0.11 - 0.06 m s-1 (water-N2)
-3
-2.5
-2
-1.5
-1
-0.5
0
0.5
1
1.5
2
4 4.5 5 5.5 6 6.5 7
Time (s)
Shea
r str
ess
(Pa)
Shear probe
![Page 17: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/17.jpg)
17
Experimental measurements
0
0.05
0.1
0.15
0.2
0.25
0.3
0.35
0.4
0.45
-3 -2 -1 0 1 2 3
Shear stress (Pa)
Freq
uenc
y (-)
Liquid slug
Gasslug
Shear stress Histogram (SSH)• i.e. 0.11 - 0.06 m s-1 (water-N2)
![Page 18: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/18.jpg)
18
Experimental measurements
Liquid 0.1 l·min-1
0
0.1
0.2
0.3
0.4
0.5
-3 -2 -1 0 1 2 3
Shear stress (Pa)
Freq
uenc
y
Gas 0.1 l/minGas 0.2 l/minGas 0.3 l/min
![Page 19: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/19.jpg)
19
Computational Fluid DynamicsCFD model• Numerical methods and algorithms• Analyze problems that involve fluid flows• Interaction of liquid-gas
![Page 20: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/20.jpg)
20
Computational Fluid DynamicsSlug flow CFD model• Fluids flow in a vertical tube
- Superficial velocities (gas + liquid)- Volume fraction
• Validated against…- Shear stress measurements (SP)- Gas slug rising velocity (HSC)
![Page 21: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/21.jpg)
21
Validation SP and HSC with CFD
-3.5
-3
-2.5
-2
-1.5
-1
-0.5
0
0.5
1
1.5
0 0.05 0.1 0.15 0.2 0.25 0.3 0.35 0.4
Time (s)
Phas
e, V
eloc
ity (m
/s),
Shea
r str
ess
(Pa)
PhaseVelocityShear stress
wall
![Page 22: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/22.jpg)
22
Validation SP and HSC with CFDLiquid slug: well predictedGas slug: shifted to the left
Liquid 0.1 l·min-1
0
0.1
0.2
0.3
0.4
0.5
-3 -2 -1 0 1 2 3
Shear stress (Pa)
Freq
uenc
y
Exp 0.1 l/minExp 0.2 l/minExp 0.3 l/minSim 0.1 l/minSim 0.2 l/minSim 0.3 l/min
![Page 23: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/23.jpg)
23
Validation SP and HSC with CFDTB rising velocity (9.9 mm)
• Theoretical values- C = 1.2- k = 0.35
y = 1.00x + 0.41R2 = 0.99
y = 1.04x + 0.30R2 = 0.99
0
0.2
0.4
0.6
0.8
1
1.2
0 0.1 0.2 0.3 0.4 0.5 0.6
Um/(gd)0.5
UTB
/(gd)
0.5
HSCSim
( ) ( )k
dgu
Cdg
U mTB += 5.05.0
[ ] 5.0345.02.1 dguu mTB +=
![Page 24: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/24.jpg)
24
Shear Stress HistogramsEmpirical model• Correlate shear stress with…
- Magnitude - Direction- Gas-liquid flow rates
• Occurrence of both peaks (height + width) - Better fouling control (Ochoa et al. 2007)
• Bimodal SSH based on Gaussian distribution
0
0.05
0.1
0.15
0.2
0.25
0.3
-3 -2 -1 0 1 2 3
Shear stress (Pa)
Freq
uenc
y
0
0.05
0.1
0.15
0.2
0.25
-3 -2 -1 0 1 2 3
Shear stress (Pa)
Freq
uenc
y
0
0.05
0.1
0.15
0.2
0.25
0.3
-3 -2 -1 0 1 2 3
Shear stress (Pa)
Freq
uenc
y
= +
Gas slug Liquid slug
![Page 25: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/25.jpg)
25
Bimodal distributionSSH• liquid-gas flow rates that equilibrates the peaks
0
0.05
0.1
0.15
0.2
0.25
0.3
-3 -2 -1 0 1 2 3
Shear stress (Pa)
Rel
ativ
e fr
eque
ncy
(-)
0.1 - 0.43 l/min0.2 - 0.49 l/min0.3 - 0.54 l/min0.4 - 0.58 l/min0.5 - 0.63 l/minLiq - gas
![Page 26: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/26.jpg)
26
16000
17000
18000
19000
20000
21000
22000
0 0.1 0.2 0.3 0.4 0.5 0.6
Liquid flow rate (L/min)
Tota
l pre
ssur
e dr
op (P
a)
Gas flow 0.0 L/minGas flow 0.1 L/minGas flow 0.2 L/minGas flow 0.3 L/min
Pressure drop and energy consumptionPressure drop
7 %
![Page 27: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/27.jpg)
27
0
0.05
0.1
0.15
0.2
0.25
0 0.1 0.2 0.3 0.4 0.5 0.6
Liquid flow rate (L/min)
E pum
p (W
)
Gas flow 0.0 L/minGas flow 0.1 L/minGas flow 0.2 L/minGas flow 0.3 L/min
Pressure drop and energy consumptionPump power
7 %
![Page 28: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/28.jpg)
28
0
0.05
0.1
0.15
0.2
0.25
0 0.1 0.2 0.3 0.4 0.5 0.6
Liquid flow rate (L/min)
E blo
wer
(W)
Gas flow 0.0 L/minGas flow 0.1 L/minGas flow 0.2 L/minGas flow 0.3 L/min
Pressure drop and energy consumptionBlower power
70 %
![Page 29: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/29.jpg)
29
0
0.05
0.1
0.15
0.2
0.25
0.3
0.35
0.4
0 0.1 0.2 0.3 0.4 0.5 0.6
Liquid flow rate (L/min)
E tot
al (W
)
Gas flow 0.0 L/minGas flow 0.1 L/minGas flow 0.2 L/minGas flow 0.3 L/min
Pressure drop and energy consumptionTotal power
25 %
![Page 30: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/30.jpg)
30
Pressure drop and energy consumptionOptimal bimodal SSH• Pressure drop: ↓ 4 %• Pump power: ↑ 2 %
↑ gas flow ↓ fouling does not result in large increase in energy consumption
13000
13500
14000
14500
15000
15500
16000
0 0.1 0.2 0.3 0.4 0.5 0.6
Liquid flow rate (L/min)
Tota
l pre
ssur
e dr
op (P
a)
0
0.1
0.2
0.3
0.4
0.5
0.6
Ener
gy c
onsu
mpt
ion
(W)
Total pressure dropEpumpEblowerEtotal
• Blower power: ↑ 9 %• Total power: ↑ 2 %
![Page 31: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/31.jpg)
31
PhD thesis structure
![Page 32: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/32.jpg)
32
Objectives
CFD modelling of Norit Airlift system• Membrane module
- Membrane resistance (1 tube)- Bundle of tubes (700 tubes)
• Air diffuser- Ring aerator- Disk aerator
• Modelling exercise- In-situ measurement is tough
![Page 33: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/33.jpg)
33
Norit airlift systemMembrane module• Length 3 m• 700 tubes• ID 5.2 mm
![Page 34: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/34.jpg)
34
Membrane Module (1 tube)Membrane tube• 3D single UF tube
- Hydrodynamics- Filtration- Single phase flow
• Membrane resistance- Viscous resistance (Darcy’s law)- Inertial resistance
Permeateoutlet
waterinlet
wateroutlet
Membranetube
Outsidevolume
![Page 35: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/35.jpg)
35
Membrane Module (700 tubes)Membrane module• Step-wise extrapolated to 700 tubes• Two resistances
- Membrane resistance- Bundle of tubes resistance
CFD model• Calibrated in single-phase flow
- Mass balance to determine resistance values (TMP + Flux)
![Page 36: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/36.jpg)
36
Air diffusersTwo types• Ring aerator
• Disk aerator
Water inlet
Ringaerator
outlet
Diskaerator
![Page 37: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/37.jpg)
37
Air diffusersRing aerator
Module
Red 0.05 – Blue 0 volume fraction of air
Air diffuser
Disk aeratorModule
Air diffuser
Inlet of membrane module
![Page 38: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/38.jpg)
38
Module + air diffuserModule + air diffuser• Ring aerator:
- Air near the wall
• Disk aerator:- Air in the bulk
Red 0.2 – Blue 0 volume fraction of air
Diffuser0.5 m
MembraneModule
3 m
Disk Ring
Disk aerator
Ringaerator
Water inlet
![Page 39: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/39.jpg)
39
Outline
![Page 40: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/40.jpg)
40
Objectives
Sludge rheology• Viscosity• Delft Filtration Characterization method (DFCm) unit• Activated sludge rheological model
![Page 41: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/41.jpg)
41
Sludge RheologyViscosity• It describes a fluid's internal resistance to flow• Why is it important…
- To characterize hydraulic regime near membrane.- Design of equipment (e.g. mixing, pumping, aeration devices)
k
![Page 42: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/42.jpg)
42
Activated sludge• Pseudoplastic (Power-law)
- or
Sludge RheologyViscosity (cont.)• Relation between shear stress ( ) and shear rate ( ):
- Newtonian (e.g. water, oil)- Non-Newtonian (e.g. blood, toothpaste, ketchup & activated sludge)
τ γ
Flow behaviour index (Pa·s)Flow consistency index (-)
nkγτ =
k
n
1−= nkγη ( )TSSfnk =&
![Page 43: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/43.jpg)
43
Sludge RheologyRotational rheometers:• Torque is correlated to viscosity• Drawback
- Measurement ex-situ- Eddies formation
Tubular (capillary) rheometers:• Pressure drop is correlated to viscosity• Drawback
- Large sludge samples• Advantage:
- Measurement on-site• Can the DFCm unit be used as a
tubular rheometer?
Pout
Pin
CFV
TMP J
CFVSa
mpl
e
![Page 44: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/44.jpg)
44
Sludge RheologyViscosity in a tube
0
0.002
0.004
0.006
0.008
0.01
0.012
0.014
0.016
0 2 4 6 8 10 12 14 16 18 20
TSS (g/l)
App
aren
t vis
cosi
ty (P
a s)
Experimental dataThis workRosenberger et al. (2006)Pollice et al. (2007)Water
![Page 45: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/45.jpg)
45
ConclusionsModelling of slug flow• SSH used to represent slug flow• First peak (liquid slug) is properly captured by the CFD model• Second peak (gas slug) is shifted to the left
• SSH with two balanced peaks is desirable- To decrease/control fouling- However, more energy is required
Modeling of airlift MBR (modelling exercise)• Step-wise extrapolation was made for the tube-bundle (700) and
membrane resistance.• Two types of diffusers were modeled
- Disk aerator provides a better dispersion of air within the module than the ring aerator.
![Page 46: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/46.jpg)
46
ConclusionsSludge rheology• A new rheological model for MBR activated sludge is presented
based on the data collected using the DFCm.• It was found that the previous models underestimate the data
collected from different MBR plants.- Difference in sludge composition and apparatus used
![Page 47: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/47.jpg)
47
PerspectivesSludge rheology• Model that includes floc structure, size, strength, etc.
Two-phase flow• Varying thermo-physical properties to study coalescence effects.
Shear stress for non-Newtonian liquids• Electrolyte solution mix with a non-Newtonian liquid (e.g. CMC)
Air diffusers• To study the air distribution in non-Newtonian fluids.
![Page 48: Understanding hydrodynamics in membrane bioreactor systems for wastewater treatment:two-phase empirical and numerical modelling and experimental validation](https://reader033.fdocuments.us/reader033/viewer/2022051413/557c9e2fd8b42aee3b8b4761/html5/thumbnails/48.jpg)
48
Thank you for your attention