TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED...

12
1 Volume 217 - July, 2015 Mitsubishi Concept XR−PHEV II page 1 S Vehicle Technical Info.................. S Techline Information................... S MEDIC Information.................... S Tips From the Toolman................ S Training News...........................S Bulletin Review ............................. page 6 page 9 page 10 page 6 page 6 NOTE: The mark is used as a reminder, indicating an article that has been repeated from a previous issue of Tech Talk. TT GROUP 13 � Fuel DTC P0442: EVAPORATIVE EMISSION CONTROL SYSTEM LEAK DETECTED (SMALL LEAK) — 2013-15 Outlander Sport/RVR. The vent solenoid bracket attached to the evaporative canister may be susceptible to bending and cause DTC P0442 to be stored in the ECM. During DTC P0442 troubleshooting, a visual inspection of the vent solenoid bracket may assist in proper diagnosis. Bent bracket Also, inspect the hose clamps around the evaporative canister and ensure they are positioned correctly. If either of these conditions are present, repositioning the part(s) may correct the issue. You can force the monitor to run to determine if the repair was effective. DTC P0606 AFTER ENGINE REPAIRS 2008-15 Lancer Evolution. When diagnosing a DTC P0606 (Powertrain Control Module Main Processor Malfunction) on the subject vehicles, especially after an engine repair (short block, cylinder head, etc.), inspect the spark plug insulator (porcelain) closely and check for looseness or damage. Also, check the ground electrode for proper alignment (not off-centered) and the spark plug gap is correct. ENGINE STALL/PCV HOSE DISCONNECTION — 2014-15 Mirage (equipped with CVT, built before 1/19/2015). If a customer complains of engine stalling at an idle, and/or a DTC is set (P0171 or P0300), the PCV hose may have become detached from the inlet manifold. If the PCV hose is detached, reattach it, reprogram the ECM with TSB-15-13-001, and conduct the relearning procedure. The reprogramming will help prevent PCV hose detachment. TT GROUP 14 � Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports a lost coolant overflow bottle cap, be advised that the existing cap (no tether) has been superseded by a cap with a retaining tether (P/N 1375A429). This will prevent accidental loss or misplacement of the cap during coolant level adjustments. 1375A429 Volume 217 - July, 2015 Mitsubishi Concept XR−PHEV II

Transcript of TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED...

Page 1: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

11

page 1� Vehicle Technical Info..................

� Techline Information...................

� MEDIC Information....................

� Tips From the Toolman................

� Training News...........................…

� Bulletin Review.............................

page 6

page 9

page 10

page 6

page 6

NOTE: The � mark is used as a reminder,indicating an article that has been repeated froma previous issue of Tech Talk.

TT

GROUP 13 � FuelDTC P0442: EVAPORATIVE EMISSIONCONTROL SYSTEM LEAK DETECTED(SMALL LEAK) — 2013-15 Outlander Sport/RVR.The vent solenoid bracket attached to theevaporative canister may be susceptible tobending and cause DTC P0442 to be stored in theECM. During DTC P0442 troubleshooting, avisual inspection of the vent solenoid bracketmay assist in proper diagnosis.

Bent bracket

Also, inspect the hose clamps around theevaporative canister and ensure they arepositioned correctly. If either of these conditionsare present, repositioning the part(s) may correctthe issue. You can force the monitor to run todetermine if the repair was effective.

DTC P0606 AFTER ENGINE REPAIRS —2008-15 Lancer Evolution. When diagnosing aDTC P0606 (Powertrain Control Module MainProcessor Malfunction) on the subject vehicles,especially after an engine repair (short block,cylinder head, etc.), inspect the spark pluginsulator (porcelain) closely and check forlooseness or damage. Also, check the groundelectrode for proper alignment (not off-centered)and the spark plug gap is correct.

ENGINE STALL/PCV HOSE DISCONNECTION— 2014-15 Mirage (equipped with CVT, built before1/19/2015). If a customer complains of enginestalling at an idle, and/or a DTC is set (P0171 orP0300), the PCV hose may have becomedetached from the inlet manifold. If the PCVhose is detached, reattach it, reprogram the ECMwith TSB-15-13-001, and conduct the relearningprocedure. The reprogramming will helpprevent PCV hose detachment.

TT

GROUP 14 � Engine CoolingSUPERSEDED COOLANT OVERFLOWBOTTLE CAP — 2013-15 Outlander Sport/RVR.If a customer reports a lost coolant overflowbottle cap, be advised that the existing cap (notether) has been superseded by a cap with aretaining tether (P/N 1375A429). This willprevent accidental loss or misplacement of thecap during coolant level adjustments.

1375A429

Volume 217 - July, 2015

Mitsubishi Concept XR−PHEV II

1

page 1� Vehicle Technical Info..................

� Techline Information...................

� MEDIC Information....................

� Tips From the Toolman................

� Training News...........................…

� Bulletin Review.............................

page 6

page 9

page 10

page 6

page 6

NOTE: The � mark is used as a reminder,indicating an article that has been repeated froma previous issue of Tech Talk.

TT

GROUP 13 � FuelDTC P0442: EVAPORATIVE EMISSIONCONTROL SYSTEM LEAK DETECTED(SMALL LEAK) — 2013-15 Outlander Sport/RVR.The vent solenoid bracket attached to theevaporative canister may be susceptible tobending and cause DTC P0442 to be stored in theECM. During DTC P0442 troubleshooting, avisual inspection of the vent solenoid bracketmay assist in proper diagnosis.

Bent bracket

Also, inspect the hose clamps around theevaporative canister and ensure they arepositioned correctly. If either of these conditionsare present, repositioning the part(s) may correctthe issue. You can force the monitor to run todetermine if the repair was effective.

DTC P0606 AFTER ENGINE REPAIRS —2008-15 Lancer Evolution. When diagnosing aDTC P0606 (Powertrain Control Module MainProcessor Malfunction) on the subject vehicles,especially after an engine repair (short block,cylinder head, etc.), inspect the spark pluginsulator (porcelain) closely and check forlooseness or damage. Also, check the groundelectrode for proper alignment (not off-centered)and the spark plug gap is correct.

ENGINE STALL/PCV HOSE DISCONNECTION— 2014-15 Mirage (equipped with CVT, built before1/19/2015). If a customer complains of enginestalling at an idle, and/or a DTC is set (P0171 orP0300), the PCV hose may have becomedetached from the inlet manifold. If the PCVhose is detached, reattach it, reprogram the ECMwith TSB-15-13-001, and conduct the relearningprocedure. The reprogramming will helpprevent PCV hose detachment.

TT

GROUP 14 � Engine CoolingSUPERSEDED COOLANT OVERFLOWBOTTLE CAP — 2013-15 Outlander Sport/RVR.If a customer reports a lost coolant overflowbottle cap, be advised that the existing cap (notether) has been superseded by a cap with aretaining tether (P/N 1375A429). This willprevent accidental loss or misplacement of thecap during coolant level adjustments.

1375A429

Volume 217 - July, 2015

Mitsubishi Concept XR−PHEV II

273083 TT NL.indd 1 7/28/15 1:57 AM

creo
Page 2: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

2

RADIATOR CONDENSER TANK HOSEFITTING COOLANT SEEPAGE/LEAK —2013-15 Outlander Sport/RVR. If a vehicle isleaking coolant from the radiator condenser tankat the hose connection, remove the hose fromtank and inspect the hose fitting for flash or othercondition that inhibits the hose from sealing tothe hose fitting. If necessary, repair the hoseconnection to ensure a good sealing surface. It isvery important to obtain a good sealing surfacebetween the hose and hose connection as the clipinstalled on the hose from the factory is forretention only, and not for sealing of the hose tohose connection. Once the hose connection hasbeen repaired, reinstall the hose to tank using anappropriate hose clamp.

TT

GROUP 23 − Automatic Transmission

A/T SHIFT LEVER CHILD PARTS AVAILABLEAS SERVICE PARTS — 2013-15 OutlanderSport/RVR. It is no longer necessary to replacethe complete shift lever assembly if the repair canbe completed with replacement of the gearshiftlever cover (P/N 2400A577) or A/T shiftindicator slider (P/N 2400A578). These parts areavailable as child parts.

TIN-15-23-001: STUMBLE ONACCELERATION — 2015 Outlander Sport/RVR.TIN-15-23-001 was recently sent to dealers andstates:

Customers may report a momentary stumble orlack of acceleration at low speeds. If contacted bya customer experiencing this condition, pleaseinspect the “Transmission Range Switch andControl Cable Adjustment” on the vehicle.Instructions for this adjustment can be found inthe attached illustration. Test drive the vehicle toconfirm the condition no longer exists. If thecondition is not resolved with this procedure,please contact Techline.

Page 3: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

3

TT

GROUP 31 − Wheel & Tire

TPMS SENSOR RETAINING NUT CAUTION— 2012-16 i-MiEV, 2008-15 Lancer based models,2007-15 Outlander, 2011-15 Outlander Sport/RVR(clamp-in type sensor only). When removing,reinstalling, or replacing the TPMS sensors onthe subject vehicles, torque the retaining nut to8.0 + 0.5 Nm (71 + 4 in-lb). Tightening beyondthis value will deform the TPMS seal and causean air leak. Also, the TPMS sensor seal isnon-reusable and must be replaced wheneverthe TPMS is removed; use tire valve spare partskit 4250B977 to obtain the TPMS sensor seal.

TT

GROUP 34 − Rear Suspension

SHOCK ABSORBER REPLACEMENTWARRANTY POLICY — All Models. When it isnecessary to replace a shock absorber underWarranty, only replace the defective shock.Shocks that are functioning as designed do notneed to be replaced.

TT

GROUP 42 − Body

MUT-3 FORCED POWER MODE - KEYREGISTRATION WHEN ALL KEYS LOST -2014-15 Outlander. The MUT-3 “Forced PowerMode” function allows you to register a new setof keys when a customer brings in a vehicle withall keys lost. When using the “Forced PowerMode” on the 2014-15 Outlander, you mightreceive a “Communication Error” dialogue. Ifyou receive this error, it is possible that theETACS is asleep and the MUT-3 is unable tocommunicate. To resolve this issue, disconnectthe negative battery terminal, wait 30 seconds,then reconnect the battery terminal. You mustthen initiate “Forced Power Mode” on thevehicle within 30 seconds of reconnecting thebattery.

ABNORMAL FRONT DRIVER SIDE POWERWINDOW OPERATION - 2015 OutlanderSport/RVR. If a customer complains of abnormalfront driver side power window operation,please create a video, along with audio, of theabnormal operation. MMNA is investigating theroot cause of door glass function problems thatare not due to loose regulator to glass attachmentfasteners. Include images of the glass andregulator attachment points and the run channelinside the door. Videos can be emailed toTechline at [email protected].

TT

GROUP 51 − Exterior

LOOSE WINDSHIELD WIPER BLADE —2011-15 Outlander Sport/RVR. If a customerreports the windshield wiper blade (rubber) fallsout of the wiper blade assembly, confirm thewiper blade is correctly installed: 1) Ensure thewiper blade backer (metal) is completelyinstalled to the wiper blade. 2) Completely pushthe wiper blade until it engages the retaining tabson both sides of the blade assembly.

1)2)

TT

GROUP 52A − Interior

OUTER REAR SEAT BELT TONGUE SLIDESDOWN SEAT BELT — 2013-15 OutlanderSport/RVR. If the outer rear seat belt tongue isable to slide down the seat belt withouthindrance, it can cause interference between theseat cushion and interior trim. Installation of arear seat belt stopper button (P/N 7000A360) cancorrect this condition. Please referenceTSB-13-52A-001 for more information.

FRONT SEAT SLIDE ADJUSTERREPLACEMENT — 2013-15 OutlanderSport/RVR. If the front seat slide adjusterrequires replacement for any reason (OCM orseat weight sensor failure, problems withmanual/power seat adjustment, etc…), replacethe front seat slide adjuster only. The front seatcushion pad and cover is transferable to the newseat adjuster.

Page 4: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

4

� SEAT CUSHION COVER LOOSE,RETAINING CLIPS DETACHED — 2013-15Outlander Sport/RVR. If a customer reports theseat cushion cover (seat bottom) is loose, checkunder the seat to see if the cover retaining stripsare detached. Over time, the white plastic “Jhooks” can lose their shape and becomedetached, causing the cover to loosen. If you findthat a loose seat cushion cover is caused bydetached cover retaining clips, discuss thepossibility of repair with a local upholstery shopto determine if the cover can be securelyreattached using “hog rings” or some othersuitable retention method. Do not replace thecover unless it cannot be successfully reattachedby an upholstery shop.

Deformed

REPAIR OF UNHOOKED SEAT BOTTOMSPRINGS — 2013-15 Outlander Sport/RVR. It ispossible for the spring assembly that supportsthe front seat cushion to be partially unhookedfrom the seat frame. This condition has thepotential to cause abnormal sounds from theseat. If there is a complaint of noise from the seat,please inspect the spring assembly to ensure it ishooked securely to the frame. If an unhookedspring is discovered, please re-secure andconfirm if the issue has been resolved.

Unhooked Spring

TT

GROUP 54 − Chassis Electrical

INTERCHANGEABLE CONNECTORSBEHIND CENTER INSTRUMENT PANEL —2013-15 Outlander Sport/RVR. There are three16-pin connectors behind the center instrumentpanel that are interchangeable. Improperconnection may disrupt operation of the HVACsystem, hands-free module / microphone andhazard switch. Warnings such as passenger airbag 'OFF' light (SRS DTC B1489), security lightcircuit, and seat belt warning light may alsoappear.

Reference the following information to confirmproper connection of the three interchangeableconnectors.

C-136

C-232

C-205

C-136 16-pin: Tan connector, part of navigationharness. Plugs into the back of the navigationunit for hands-free module / microphoneoperation.

C-232 16-pin: Tan connector, harness has foamshield and runs to the right side of instrumentpanel. Plugs into HVAC controller.

C-205 16-pin: Grey connector, harness has blackshield and runs to the left side of instrumentpanel. Plugs into audio surround panel forhazard switch, air bag warning light and securitylight operation.

Page 5: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

5

� “ENT” BUTTON AVAILABLE FOR MMCSNAVIGATION UNIT — 2008-13 Lancer basedvehicles, 2007-13 Outlander, 2011-13 OutlanderSport/RVR. The enter button (ENT) for vehiclesequipped with “NAVI” is available as a sparepart (P/N 892L45510).

TT

GROUP 55 − Heater, Ventilation & A/C

� WATER SLOSHING SOUND, UNUSUALSMELL OR WET CARPET/FLOOR MAT —2013-15 Outlander Sport/RVR. Subject vehiclesmay have a restricted HVAC drain outlet.Flashing from manufacturing may be partially(or completely) covering the drain inside theHVAC case. If a customer reports he hasexperienced these symptoms consistent with ablocked drain outlet, please remove the drainhose from the outlet (near the accelerator pedal)and use a mirror and light to examine the drainhole to determine if there is an obstruction. If yousee an obstruction, clear the hole (a bent coathanger works well) and insure proper flow fromthe drain with the A/C on.

Shown with acceleratorpedal removed

Drain hose.

Blocked drainwhere upperend of drain

hose attaches.

INSPECTION SHEET FOR A/C COMPRESSORISSUES (CLUTCH SPRING BROKEN) —2014-15 Mirage. MMNA is conducting aninvestigation on all A/C compressor unitsreplaced under Warranty. Dealer techniciansand service advisors are requested to completethe inspection sheet and return it to Techline.The inspection sheet appears later in this TechTalk.

TT

GROUP 66 − AccessoriesACCESSORY REMOTE ENGINE STARTVIDEO AVAILABLE ON MDL — MZ36034EXand MZ360400EX. MMNA created twoprogramming videos to supplement the writteninstructions for remote engine start accessory,one for push start vehicles and the second fornon-push start vehicles. The video will allowtechs to view the entire procedure and helpreduce confusion with the programmingprocess. To access the video on the MDL,navigate to “service" —> “systems" —>“Techline" —> “Techline Videos," and scroll toGeneral Videos —> Remote Engine Start.

TT

Page 6: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

6

HOURS: Monday — Friday

6:30 − 11:30 am & 12:30 − 3:30 pmAll times are Pacific Time

NOTE: Techline is closed every MONDAY 8:30 - 9:00 AMand THURSDAY 9:30 - 10:30 A.M for a staff meeting.

TT

Call the MEDIC Hotline for ALL MEDIC & Scan Tool hardwareor software issues. Call TECHLINE for vehicle technical issues.

As of 6/29/15: Total Hits - 6431 Reflash Database: N15021

MEDIC 3 Version - 3.2 MEDIC 3 Update - 336

MUT-III Version - 31.02 Raider Scan Tool Version - 6.0MEDIC Hotline (800) 846-7575

TT

FILE ATTACHMENTFUNCTIONALITY ON

TECHLINE

Effective 05/13/2015, the Techline Case Interface (on MDL) will have an added feature allowingdealerships to attach files when creating a new case or when updating an existing case. This feature canbe utilized to attach the following types of relevant information to a Techline Case:

1. Photographs

2. Drive Recorder Data Files

3. Customer Questionnaires

4. Diagnostic Checklists

5. Etc.

Please reference the dealer communication email titled “New Feature for Attaching Files WhenCreating or Updating Techline Cases” distributed to service managers on 05/13/2015.

Page 7: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

7

Page 8: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

8

Page 9: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

9

TT

Technical Training Schedule July - August, 2015

Always check the MDL for schedule updates. Mobile Training does not appear on these calendars.Contact your District Parts & Service Manager for information about mobile training in your area.

East Zone - N.J. Tech Training Center East Zone - Atlanta Tech Training Center

West Zone-Dallas Tech Training Center California Technical Training Center

Page 10: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

10

TT

The following information was recently released:

2015 Technical Service Bulletins

Number Title Vehicles Subject

SR-15-001 Raider Clutch InterlockSwitch - Safety RecallCampaign

2006 Raider Instructs dealers to replace the clutchignition switch on vehicles with amanual transmission.

SR-15-002 ETACS ECU - Safety RecallCampaign

2009-10 Lancer, 2010Lancer Sportback, 2010Lancer Evolution, 2009-10Outlander

Instructs dealers to inspect theproduction date stamp on the ETACSECU and replace all units built withina certain production period.

SR-15-003 Front Blower Motor - SafetyRecall Campaign

2009-11 Lancer, 2010-11Lancer Sportback &Evolution, 2009-11Outlander, 2011 OutlanderSport

Instructs dealers to inspect the partnumber label on the front blowermotor and replace it with acountermeasure unit if necessary.

SR-15-007 Raider Driver Side FrontalAir Bag Inflator - SafetyRecall Campaign

2006-09 Raider Instructs dealers to replace the driverside frontal air bag with a new air bagmanufactured by a different supplier,and return the subject air bag per theinstructions in the Parts Informationsection of this bulletin.

TSB-15-00-001 Technical Specifications -2015 Outlander Sport:Revised

2015 Outlander Sport/RVR Includes information for 2.4Lpowertrain models.

TSB-15-00-002 New Model Features andService Information - 2015Outlander Sport: Revised

2015 Outlander Sport Includes information for 2.4Lpowertrain models.

TSB-15-00-003 New Model Features andService Information - 2016Outlander

2016 Outlander Highlights important features andservice information for 2016Outlander.

TSB-15-00-004 Technical Specifications -2016 Outlander

2016 Outlander Includes technical specifications for2016 Outlander.

TSB-15-00-005 General PDI Procedures for2016 Models (except EV andPHEV)

2016 Models except EVand PHEV

Contains general Pre-DeliveryInspection (PDI) procedures for 2016model year Mitsubishi vehicles(except i-MiEV).

TSB-15-13-001 Engine Stall (Low EngineSpeed, High AmbientTemperature)

2014-15 Mirage Provides updated ECMreprogramming that prevents enginestalling at low engine speed, just priorto stopping or during idling, andwhen operated in high ambienttemperature conditions.

TSB-15-13-002 ECM Reprogramming forFalse MIL Illumination withDTC P2097 - Revised

2011-14 Lancer/LancerSportback, 2011-13Outlander, 2011-14Outlander Sport

Addresses false MIL illuminationwith DTC P2097 (Rear Oxygen SensorFeedback Control System Monitoring)stored in the ECM.

TSB-15-23-001 F1CJC/W1CJC CVT-ECUCoding Procedure

2015 Outlander Sport/RVR(with F1CJC & W1CJCtransmissions)

Provides information for initalizingECU to valve body when replacingCVT or CVT-ECU.

TSB-15-23-002 CVT Hydraulic Pressure TestProcedure - SMR

2008-15 Lancer, 2009-15Lancer Sportback, 2008-15Outlander, 2011-14Outlander Sport/RVR

Provides corrected information forhydraulic pressure settings andspecial tools used in CVT hydraulicpressure test.

Page 11: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

11

2015 Technical Service Bulletins (continued)

Number Title Vehicles Subject

TSB-15-23-003 Noise From CVT at AllEngine Speeds

2008-10 Lancer, 2009-10Lancer Sportback, 2008-10Outlander, 2011 OutlanderSport

Provides instructions to remove thetransmission and replace two primarypulley shaft bearings and onesecondary pulley shaft bearing toreduce a clicking noise.

TSB-15-23-004 Continuously VariableTransmission Overhaul -SMR

2008-14 Lancer, 2009-14Lancer Sportback, 2008-14Outlander, 2011-14Outlander Sport

Adds procedures for disassembly,assembly and cleaning transmissioncomponents.

TSB-15-52A-001 Front Seat Belt AttachingInstructions - SMR: Revised

2006-15 Applicable Lancer& Outlander models

Provides correct information for seatbelt attaching methods and tighteningtorque.

TSB-15-52B-001 DTC B1616 Diagnosis Added- SMR

2014-15 Mirage DTC B1616 added to Check Chart forDiagnostic Trouble Codes.

TSB-15-54-001 Hands-Free Module SoftwareUpdate for “Phonebook isEmpty” Message

Applicable 2010-15 modelsequipped with FUSEHands Free Link System

Instructs dealers to update the HFMsoftware that allows voice recognitionto complete before connection to thephone begins.

TSB-15-54-002 Main Drive Battery CannotBe Charged to Full AvailableCapacity - WarrantyExtension

2012-13 i-MiEV Warranty extension for specific caseswhen Main Drive Lithium-ionBattery cannot be charged to fullavailable capacity when properlyconnected to a properly functioningcompatible charger.

TT

The following information was recently released:

2015 Technical Information Notices

Number Title Vehicles Subject

ATIN-14-SC-003-B 2012 i-MiEV UndercarriageRust Service Campaign -Revised

2012 i-MiEV Revised service campaign will clarify repairprocedure to replace under cover only ifground bolts are broken. Under coversplaced under “209-Product Support” partsrestriction. Photos and Techline approvalrequired to complete part request.

ATIN-14-SC-005-B Raider Driver Air BagInflator - Special ServiceCampaign - Revised

2006-07 Raider This campaign is now being expandednationwide. Original regional campaignlimited to vehicles originally sold in or everregistered in Florida, Hawaii, Puerto Rico,and the US Virgin Islands.

ATIN-14-SR-012-D Lancer Passenger SideFrontal Air Bag InflatorSafety Recall Campaign -Revised

2004-06 Lancer,Lancer Evolution,2004 LancerSportback

This campaign is now being expandednationwide and will also include 2006Lancer and Lancer Evolution vehicles.Original regional campaign limited tovehicles originally sold in or ever registeredin Florida, Georgia, Alabama, Mississippi,Louisiana, Texas, South Carolina, PuertoRico, Hawaii, U.S. Virgin Islands, Guam,Saipan and American Samoa.

Page 12: TT GROUP 13 Fuel DTC P0442: EVAPORATIVE EMISSION GROUP 14 ... · GROUP 14 Engine Cooling SUPERSEDED COOLANT OVERFLOW BOTTLE CAP — 2013-15 Outlander Sport/RVR. If a customer reports

12

The information contained in this bulletin is subject to change. For the latest version of this document, go to the Mitsubishi Dealer Link,MEDIC, or the Mitsubishi Service Information website (www.mitsubishitechinfo.com).

� 2015 Mitsubishi Motors North America, Inc.

12

2015 Technical Information Notices (continued)

Number Title Vehicles Subject

ATIN-15-54-002 Main Drive Battery CannotBe Charged to FullAvailable Capacity -Warranty Extension

2012 i-MiEV Warranty extension for specific cases whenMain Drive Lithium-ion Battery cannot becharged to full available capacity whenproperly connected to a properlyfunctioning compatible charger.

ATIN-15-SR-002-A ETACS ECU Safety RecallCampaign

2009-10 Lancer, 2010Lancer Sportback, 2010Lancer Evolution,2009-10 Outlander

Safety Recall Campaign released withprocedure to replace ETACS ECU builtwithin a certain production period.

ATIN-15-SR-003-A Front Blower Motor SafetyRecall Campaign

2009-11 Lancer,2010-11 LancerSportback & Evolution,2009-11 Outlander,2011 Outlander Sport

Safety Recall Campaign released withprocedure to inspect the part number labelon the front blower motor and replace itwith a countermeasure unit if necessary.

ATIN-15-SR-007-B Raider Driver Side FrontalAir Bag Inflator - SafetyRecall Campaign

2006-09 Raider Safety Recall Campaign released withinstructions to replace the driver sidefrontal air bag with a new air bagmanufactured by a different supplier.

TIN-14-SR-012-C Customer Incentive ForLancer Front Passenger AirBag Inflator Safety RecallCampaign SR-14-012

2004-05 Lancer, LancerSportback, LancerEvolution

Notification sent to customers: MasterCardreward card of $40.00 will be sent tocustomer after recall is performed.

TIN-15-22-001 AWC Hydraulic UnitWarranty Extension –Identification of Eligible2015 MY Vehicles

2009-15 LancerRalliart, 2010-11Lancer SportbackRalliart, 2008-15Lancer Evolution

Vehicles eligible for TSB-14-22-005identified. Vehicles equipped withcountermeasure part are ineligible forwarranty extension, and will be deliveredto dealerships without the warrantyextension notification letter in glove box.

TIN-15-23-002 CVT-8 AutomaticTransaxle Assembly -Code 209 Restriction

2015 Outlander Sport(with 2.0L Engine)

Advises CVT-8 automatic transaxleassembly placed on 209 Restriction.Technician should create Techline Caseprior to ordering CVT-8 transaxle assemblyfor warranty repair.

TIN-15-54-001 Playback of Cloud BasedMusic Files Using the USBConnection

All Vehicles with USBMusic PlayerCapability

Audio system will stop or not connectwhen selecting music file stored on theCloud. Alternate methods advised untilcause and countermeasure are found.

TIN-15-SR-001-A Upcoming 2006 RaiderClutch Interlock SwitchSafety Recall Campaign

2006 Raider Fiat Chrysler Automobiles (FCA)announced to NHTSA a safety recallinvolving the clutch interlock switch.

TIN-15-SR-001-B Raider Clutch InterlockSwitch Safety RecallCampaign

2006 Raider Safety Recall campaign released instructingdealers to replace clutch interlock switch onaffected vehicles.

TIN-15-SR-007-A Raider Driver Side FrontalAir Bag Inflator SafetyRecall - Notice to Stop Use- P/N CBRZP401AA

2006-09 Raider Service Campaign SC-14-005REVIIupgraded to Safety Recall. The replacementair bag kit (P/N CBRZP401AA) used toperform the Service Campaign wasdetermined by Takata to be defective.Replacement part from different supplier tobe made available.

273083 TT NL.indd 12 7/28/15 1:57 AM