(total hygiene, anti-stagnation for water, comfort ...
Transcript of (total hygiene, anti-stagnation for water, comfort ...
Electronic Controls & Knee or Foot-operated Controls
Washbasins & Sinks
ELECTRONIC CONTROLS & FOOT OR KNEE-OPERATED CONTROLS(total hygiene, anti-stagnation for water, comfort)
• Deck-mounted Mixers & Taps • Wall-mounted Mixers & Taps (exposed, recessed or through-the-wall)• TEMPOMATIC multifunction for 4 or 8 points-of-use
36/43Electronic Controls
• PREMIX Mixing Valves• Wastes & Floor traps• Aerators, Flow Straighteners, Flexibles, Connectors
65/67Additional Fittings
Foot or Knee-operated Controls 44/45• Knee-operated Time Flow Mixers & Taps• Foot-operated Mixers and Taps• Deck or Wall-mounted Spouts
General Features 32/35
30
Managing the Consumption of Water and the Water BillsHospital facilities consume considerable volumes of water: 300-450 Litres of water on average per personper day in hospitals compared to 137 Litres for domestic use. This excessive consumption is due to theincrease in patient's personal washing at washbasins as well as the rigorous hand washingprotocols for healthcare staff (see page 16/17).Compared to a conventional mixers/taps, DELABIE's electronic mixers/taps optimise water saving and waterbills.
Automatic shut-off and flow rate set at 3 lpm1• Automatic shut-off when hands are removed from the detection zone:- the flow time is reduced to a minimum i.e. wetting and rinsing.- automatic closure removes the risk of waste if the user forgets to turn off the mixer or tap..
2• Constant flow rate set at 3 lpm whatever the water pressure (exclusive to DELABIE),thanks to the new, adjustable flow straightener (DELABIE patented):- Provides maximum user comfort while optimising the water bill.- The flow rate is set at 3 lpm regardless of variations in pressure.The installer or maintenance staff can adjust the flow rate of the flow straightener simply byusing a 2.5mm Allen key. Preset at 3 lpm, the range of adjustment is between 2 and 5 lpm(depending on the model).
The water savings created enable the following:- energy savings: the amount of water saved does not require heating. - equipment savings: lower flow rate and consumption mean that lower capacity pipework andwater heating systems can be installed. In addition, less water in the installation reduces the risk of bacterial development.
Comparison of water consumption in healthcare facilities:
3332
Electronic ControlsElectronic Controls
Water Savings of 90 %
Wetting10 seconds
Soaping20 seconds
Rinsing the hands*15 seconds
Conventional mixers/taps: 9.7 L (45 seconds at 13 lpm).DELABIE mixers/taps:. 3.75 L (45 seconds at 5 lpm)
2.25 L (45 seconds at 3 lpm)
ConventionalMixer
13 lpm
DELABIEMixer5 lpm
DELABIEMixer3 lpm
DELABIEElectronicMixer 3 lpm
9.7 L( 45 sec.)
watersaving
61%
3.75 L(45 sec.) 2.25 L
(45 sec.) 0.7 LWATER SAVING PER OPERATION
watersaving
77%
watersaving
92%
Price per m3 of cold water: €3 ex. VAT/ m3 excludes hot water production costs
Water saving for ahospital with 400 beds
Hospital : Patient Accommodation
Short stay (medical, surgical, gynaecology,
obstetrics, maternity)
Medium / Long stay(follow-up care and rehabilitation,
geriatrics, etc.)
Number of beds 250 150
Point-of-use for hand washing WASHBASIN WASHBASIN
Number of uses / day & bed 6 6
Duration 45 seconds 45 seconds
Number of days used / year 290 290
Consumption / year (brand X)conventional mixer: 13 lpm 4,220 m3 2,532 m3
Consumption / year (DELABIE)DELABIE electronic mixer: 3 lpm
304 m3 183 m3
Annual Water Saving€11,748 €7,047
€18,795
WATER SAVI NG
90%
Rinsing 10 seconds
Wetting5 seconds
Electronic mixers/taps: 0.7 litre (15 seconds at 3 lpm)
Automatic shut-off whenhands are removed
* Average time including misuse (e.g. non-closure after use).
Automatic Opening and Closing without Manual ContactDELABIE's electronic controls are operated by infrared presence detections:- Opens when the detector senses hands in the detection zone- Automatic closure when the hands are removed from the detection zone. The lack of manual contact prevents the transmission of germs by the hands.However, a traditional mixer is contaminated by all manual contact before washing and the user can also catch the germs through manual contact after washing.
Anti-bacterial Duty Flush The two key factors in the development of bacteria (Legionella or other infectious bacteria) in thesystem are stagnant water and temperatures below 50°C.Studies show that those electronic controls that become contaminated do not have automatic dutyflushes. If mixers and taps are used every day there is minimal risk that bacteria will develop.However, if they are not used regularly, which is the case in approximately 20% of hospital rooms,the water in the pipework is not renewed, which inevitably results in bacterial proliferation.
To prevent water stagnation (mixers and taps not used for more than 24 hours), all DELABIEelectronic mixers and taps have an anti-bacterial duty flush. An automatic flush takes place forabout 45 seconds every 24 hours after the last use which will limit the development of bacteria.The duty flush reduces the volume of water, and the length of time it remains in the pipework. Thisavoids stagnation and bacteria don't have time to develop.
Hygienic Flow StraightenerThere is no comparison with a traditional aerator, DELABIE's flow straightener has an honeycomb inscale-proof material (scale build-up is 5 times slower).It reduces water retention and scale build-up, preventing the development of germs.
PEX Flexible HosesThis type of flexible will withstand thermal and chemical shocks undertaken in healthcare facilitiesfor preventative or curative treatments against Legionella.
New Solenoid Valve with PistonThis new DELABIE solenoid valve (patent pending) is supplied with all battery-operated models andreduces niches where bacteria can develop. Water cannot stagnate in the mechanism (it isdrained and renewed with every use) and the self-cleaning calibrated groove limits the deposit ofimpurities. Furthermore, its slow closure eliminates water-hammer.
Total Hygiene
PEX
FLE
XIBLES
Operates without manual contact
Automatic duty flush
New solenoid valve with piston
Specific Developments for Commercial Use
Resistant to intensive use and vandalism- Specially designed: brass body with chrome finish and a shockproof detector.- Reinforced fixing by 2 stainless steel rods and back-nuts.- Tamperproof installation: built-in or through-the-wall installation.
Minimal and easy maintenance - Minimal maintenance: anti-scale flow straightener and mechanism, with a filter for impurities built-in. - Easy maintenance:- direct access to components (batteries and solenoid valves) without dismantling the tap.- LED diagnostics are easy to read, located in the electronic control unit.
Reliable presence detection.DELABIE continues to use the most reliable form of sensor, i.e. active, infrared presencedetection. Highly reliable detection zone is optimised to ensure user comfort. By way ofcontrast, for radar (volumetric detection) the distances are vague and lose their accuracy over time.It needs two people to achieve precise control; plus the movement sensor requires that the handsare kept in motion to maintain the water flow.
3 year warranty against all manufacturing defects.
WARRANTY
• W A R R A
NTY
3 YEARS
Flow straightenerwith flow rate setat 3 lpm
NEW
Examples of water saving in healthcare facilitiesIn healthcare facilities, the purchasing costs of a DELABIE electronic mixer/tap can be spread overthe year thanks to the water savings achieved and the continued savings achieved throughreduced consumption in your facility.
3534
TEMPOMATIC 3 and 4 INTEGRATED BATTERY AND ELECTRONICS
BINOPTIC - TEMPOMATIC - TEMPOMATIC 2SEPARATE ELECTRONIC CONTROL BOX - MAINS OR BATTERY-OPERATED
DELABIE's battery-operated mixers/taps, are programmed with a periodic duty flush to preventwater stagnation in the pipework.
Electronic control with integrated batteryStandard mode, without the option to change the operating mode: automatic shut-off whenhands are removed from sensor field and safety shut-off after 30 seconds, if there is an objectblocking the sensor.
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
InstallationTEMPOMATIC 3 and 4 can be installed in the same way as conventional mixers/taps. Simplyconnect the flexibles, no other installation or adjustment is necessary.
Optimised presence detection and ease of useThe sensor is located at the end of the spout to ensure that the hands are detected in anyposition. On the TEMPOMATIC 3, a diagram on the top cap ensures that the ensures that thesensor is instantly identified.
Replacing the batteryThe sensor will flash for 15 days to indicate that the battery should be changed, afterapproximately 350,000 cycles.Replacing the battery (1 x 6V type 223) is easy, there is no need to remove the mixer/tap orisolate the water supply. Remove the top cap with an Allen key to gain direct access to thebattery.
Common characteristics of all the DELABIE electronic models• Recommended pressure: 1 to 5 bar.• Maximum pressure: 8 bar.• Basic flow rate: 3 lpm at 3 bar.• Maximum hot water temperature: 70°C.• Balance the CW and HW pressure (∆P<1bar).• If necessary, protect the installation withcartridge filters and pressure reducers.
• Waterproof control unit and electronic module.• Solenoid valves will not corrode. • Maximum temperature limiter for HW set at50°C maximum (∆P<1bar).
• Automatic shut-off in case of neglect preventscontinuous flow. Opens again when hands aredetected in the sensor field.
Installation• Water-proof electronic control box IP65.• Control box and solenoid valves can be concealedin a protective box (available on request).
• Electrical supply (230V - 50Hz) without earthconnection. Install a circuit breaker 30 mA before the electronic control box.
• Connect sensor/electronic control box with ananti-interference screened wire: do not cutor lengthen (5m cable available on request).
Maintenance• Low maintenance: anti-scale solenoid valvesand hygienic flow straightener preventimpurity build-up.
• Separate electronic control box with auto-diagnostic LEDs to facilitate servicing.
• Electronic control box, sensor and solenoidvalve can be removed separately.
• If necessary, protect the installation withcartridge filters and pressure reducing valves.
Flashing LED(battery power
check)
TestPiles
Mode Tempo Dist.
CP
LP
EVR M B
2 batteries 3 Vcc
Basin, shower,urinal operatingmode selector
Shut-off delayadjustment
Detection adjustment
Connectors
JumpersCP: short rangeLP: long range
230 Vac
PREMIX
HWCW
MW
DELABIE's electronic controls, either mains (230/12V) or battery-operated (Lithium 6V), areprogrammed with a periodic duty flush to prevent water stagnating in the pipework.
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
VOLUNTARY mode (230/12V models): Voluntary closure by passing a hand in frontof the sensor, or continuous flow for 30 minutes (specifically for surgical protocols,or to evacuate the pipes voluntarily).
2• MONO FUNCTION 230/12V electronic control unit (Ref. 495444RP)Standard mode, without the option to change the operating mode: automatic shut-offwhen hands are removed from sensor field and safety shut-off after 45 seconds if there is anobject blocking the sensor. Option to override the duty flush, or to change to every 12hours (instead of every 24 hours). Products affected: All mains supply 230/12V. models notmentioned for control unit 495445.
3• Lithium 6V BATTERY-OPERATED control unit (Ref. 495446)Standard mode, without the option to change the operating mode: automatic shut-off when hands are removed from sensor field and safety shut-off after 45 seconds if there is an object blocking the sensor.
Ref. 495446
Average life of batteries : 350,000 uses (3 - 6 years*)with LED low battery life indicators.Adjustable detection length: ~ 8 to 35cm(Tempomatic basin)
Detectionadjustment(distance)
Safety transformer230/12Vca
Protective fuse
DiagnosisLEDS
Pin connectors
Ref. 495444RP
Adjustable detection length: ~ 8 to 25cm (basin)
1• Electronic Control Unit 230/12V with multi-function (Ref. 495445) is pre-set in theStandard mode (PROG n° 0).
The coding wheel "PROG" enables the installer to change the mode:- Standard mode with automatic shut-off when hands are removed from sensor field and safety shut-off after 45 seconds, if there is an object blocking the sensor (PROG n° 0).- ON-OFF Mode with voluntary shut-off (PROG n° 4).Products affected: ref.s 495253, 445253, 20164, 20870T1/T3 & 20871T1/T3
Electromagnetic compatability in accordance with EU directive CEM 89/336 CEE.
Reinforced fixing by 2stainless steel rods andback-nuts on all modelswith or without control unit.
TEMPOMATIC, TEMPOMATIC 2 andBINOPTIC mixers are connected to aseparate electronic control unit suppliedby 230/12V mains or a 6V Lithium battery.
Various programme options are available,depending on the model: adjustable detectionrange; automatic or voluntary closure; overridethe duty flush; and increase the duty flushfrequency to every 12 hours.
The TEMPOMATIC multifunction units canoperate either 4 or 8 separate points-of-use (washbasin, urinal and/or WC), savingon installation.
TEMPOMATIC 3 and TEMPOMATIC 4 havean electronic control, solenoid valve and 6VLithium battery integrated within the bodyof the mixer/tap.
• Can be installed on any isolated point-of-use: for new builds as well as renovation;there is no need for electrical connections(saving installation time).
• Easy installation: flexibles are connected tothe pipework in the same way as forconventional mixers/taps. There is no needfor special adjustment, the mixer/tap is readyto operate autonomously for 3-6 years* (theaverage battery life).
Solenoid valvecartridge
Electronics inwaterproofhousing
6V Lithium battery
�
�
�
Cap locked by 2hidden screws
The new solenoid valve with piston (patented) for battery-operated taps, limits bacterial developmentand avoids water hammer when the valve closes:- self-cleaning calibrated groove reduces the build-upof impurities and cleans the mechanism with everyoperation.- water is drained and renewed with every use, preventing any water stagnation.
* Indicative only. Tested under laboratory conditions, subject to battery quality and regular maintenance ofmixers/taps. * For illustration only based on tests undertaken in the laboratory. Battery life will depend on usage, quality of batteries and regular maintenance of mixers and taps.
TEMPOMATIC 3Electronic mixer or tap for washbasins with 6V Lithiumbattery, solenoid valve and electronic controls integrated inthe body of the tap. Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- PEX flexibles with filters and non-return valves on the mixer.- Chrome-plated brass body with reinforced fixings.- Anti-blocking safety and temperature limiter. - Duty flush (~45 seconds every 24 hours after the last use).
• TEMPOMATIC MIX 3 Mixer (with side temperature control)with stopcocks F3/8” 492006with stopcocks 15mm for compression fittings 49200615without stopcocks 492106for longer lever please add LH after the reference LH(hygienic + easy grip for the elderly or weaker patients).
• Robinet TEMPOMATIC 3with stopcocks F3/8” 442006with stopcocks 15mm for compression fittings 44200615without stopcocks 442106
TEMPOMATIC 4Electronic mixer or tap for washbasins with 6V Lithiumbattery, solenoid valve and electronic controls integrated inthe body of the tap. Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- PEX flexibles with filters and non-return valves on the mixer.- Chrome-plated brass body with reinforced fixings.- Anti-blocking safety and temperature limiter*. - Duty flush (~45 seconds every 24 hours after the last use).
• TEMPOMATIC MIX 4 Mixer (with side temperature control)with stopcocks F3/8” 490006with stopcocks 15mm for compression fittings 49000615without stopcocks 490106for longer lever please add LH after the reference LH(hygienic + easy grip for the elderly or weaker patients).
• TEMPOMATIC 4 Tapwith stopcocks F3/8” 440006with stopcocks 15mm for compression fittings 44000615without stopcocks 440106
Reduces the risk of bacterial development:Rilsan connection tube through to the flow straightener andspout with smooth interior: no water retentionpreventing bacterial niches (see page 22).
+ Reduces the risk of bacterial development:Solenoid valve with piston (DELABIE patented): water isdrained and renewed with every use, preventing stagnationin the mechanism (see page 35).
+ Reduces the risk of bacterial development:Solenoid valve with piston (DELABIE patented): water isdrained and renewed with every use, preventing stagnationin the mechanism (see page 35).
3736
Deck-mounted Electronic ControlsDeck-mounted Electronic Controls
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
TEMPOMATIC 3
TEMPOMATIC 2Electronic mixer or tap for washbasins.
Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- PEX flexibles with filters and M1/2” solenoid valves.- Chrome-plated brass body with reinforced fixings.- Anti-blocking safety and temperature limiter*.- Separate electronic control unit IP65, and shockproof sensor.- Duty flush (~45 seconds every 24 hours after the last use).
• TEMPOMATIC MIX 2 Mixer (with side temperature control)mains supply (230/12V transformer included) 494000battery-operated 6V Lithium 494006for longer lever please add LH after the reference LH(hygienic + easy grip for the elderly or weaker patients).
• TEMPOMATIC 2 Tap mains supply (230/12V transformer included) 444000battery-operated 6V Lithium 444006
BINOPTICElectronic mixer or tap for washbasins.
Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- PEX flexibles with filters and M1/2” solenoid valves.- Chrome-plated brass body with reinforced fixings.- Anti-blocking safety and temperature limiter.- Separate electronic control unit IP65, and shockproof sensor.- Duty flush (~45 seconds every 24 hours after the last use).
• BINOPTIC MIX Mixer (with side temperature control)mains supply (230/12V transformer included) 378MCHbattery-operated 6V Lithium 478MCHfor longer lever please add LH after the reference LH(hygienic + easy grip for the elderly or weaker patients).
• BINOPTIC Tapmains supply (230/12V transformer included) 378015battery-operated 6V Lithium 478015
TEMPOMATIC 2
BINOPTIC
+
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
148
74
109
Ø5145°
400
30
3/8"
490006
440006
400
101
116
Ø 56
3/8"
30
max
.
49200640
0
1
01
116Ø 56
3/8"
30
max
.
442006
125 145
1 - 30
103
103
400
12Vca
230Vca 1/2"
46x51
125
145
1 - 30
112
77
400
1/2"
6Vcc
46x51
494000 494006LH
145
125
1 - 30
103
103
400
1/2"12Vca
230Vca
46x51
400
1/2" 6Vcc
77
112
1 - 30
145
125
46x51
444000 444006
1
10
1 - 30
103
103
400
12Vca
230Vca 1/2"
140
48x45 1
10
1 - 30
112
77
400
1/2"
6Vcc
140
48x45
378MCH 478MCHLH
Ø 46
90
1 - 30
103
103
355
1/2"12Vca
230Vca
130 Ø 46
90
355
1/2" 6Vcc
77
112
1 - 30
130
378015 478015
Electromagnetic compatability in accordance with EU directive CEM 89/336 CEE. Electromagnetic compatability in accordance with EU directive CEM 89/336 CEE. THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocols THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocols
TEMPOMATIC 4
148
30 m
ax.
74
109
Ø 5
1 45°
400
3/8"
148
74
109
Ø51
45°
400
30
3/8"
490006LH
400
101
116
Ø 56
3/8"
30
max
.
492006LH
NEW
For general & technical information see pages 32-35.
Options: We recommend installing a thermostatic mixing valve (see p. 65) Wastes (page 66).Copper tails available (page 67).
* Maximum temperature limiter must be removed if a thermostatic mixing valve is installed upstream.
For general & technical information see pages 32-35.
Options: We recommend installing a thermostatic mixing valve (see p. 65). Wastes (page 66).Copper tails available (page 67).
* Maximum temperature limiter must be removed if a thermostatic mixing valve is installed upstream.
TEMPOMATIC PROElectronic mixer or tap for washbasins, sinks or troughs,with removable, swivel spout L.200 H.295, suitable forfitting a sterile filter. Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- PEX flexibles with filters and M1/2” solenoid valves.- Chrome-plated brass body with reinforced fixings.- Separate electronic control unit IP65, and shockproof sensor.- Removable spout (for cleaning and disinfection).- Duty flush (~45 seconds every 24 hours after the last use).- Two operating modes available on 230/12V models:> Standard mode: timed flow, automatic shut-off> VOLUNTARY Mode: voluntary closure or after 30 minutes flow.
• TEMPOMATIC MIX PRO Mixer (with side temperature control)Mains supply (ON/OFF mode) 4952536V Lithium battery-operated 495257for longer lever please add LH after the reference LH(hygienic + easy grip for the elderly or weaker patients).
• Tap TEMPOMATIC PROMains supply (ON/OFF mode) 4452536V Lithium battery-operated 445257
> Other types and sizes of spouts available on request.> For general & technical information see pages 32-35.
Options : - We recommend installing a thermostatic mixing valve (see p. 65)- Wastes (page 66).- Copper tails available (page 67).
38 39
Deck-mounted Electronic ControlsElectronic Controls with Removable Spouts
1-30103
103
400
12Vca
230Vca 1/2"
295
Ø 49 1-30112
77
400
1/2"
6Vc
295
Ø 49
495253 495257LH
1-30
105
105
428
1/2" 12Vca
230Vca
200
295
Ø 49
Ø 50
140
135
400
1/2"6Vcc
77
112
1 - 30
445253 445257
+ Spout with smooth interior: (limits bacterial niches) can beremoved for cleaning and disinfection (see page 22).
TEMPOMATIC Electronic mixer or tap for washbasins, with removablespout L.140 H.140. Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- PEX flexibles with filters and M1/2” solenoid valves.- Chrome-plated brass body with reinforced fixings.- Separate electronic control unit IP65, and shockproof sensor.- Removable spout (for cleaning and disinfection).- Anti-blocking safety and temperature limiter*. - Duty flush (~45 seconds every 24 hours after the last use).
• TEMPOMATIC MIX Mixer (with side temperature control)mains supply (230/12V transformer included) 4950006V Lithium battery-operated 495006
• TEMPOMATIC Tap mains supply (230/12V transformer included) 4450006V Lithium battery-operated 445006
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).- Copper tails available (page 67).
ø 50
140
140
1 - 30
103
103
400
12Vca
230Vca 1/2"
140
140
Ø 50
1 - 30
112
77
400
1/2"
6Vcc
495000 495006
ø 50
140
135
1 - 30
103
103
400
1/2"12Vca
230Vca
Ø 50
140
135
400
1/2"6Vcc
77
112
1 - 30
445000 445006
20164T4
Electronic mixer for washbasins, sinks and troughs,with high, swivel spout, suitable for fitting a sterile filter.Opens/closes by infrared presence detection and temperaturecontrol via long lever L.215 (control by fist or elbow).- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Ceramic cartridge Ø 40 with maximum pre-set temperaturelimiter. - PEX flexibles with filters and M1/2” solenoid valves.- Chrome-plated brass body, base and straight spout. Reinforcedfixing. - Infrared presence detection integrated into the body of the mixerand separate electronic control unit IP65.- Duty flush (~45 seconds every 24 hours after the last use).- Two operating modes available on 230/12V models:> Standard mode: timed flow, automatic shut-off> ON/OFF Mode: voluntary closure or after 30 minutes flow.
• Mains supply (ON/OFF mode)H.160 L.160 20164T1H.300 L.250 20164T4
• 6V Lithium battery-operatedH.160 L.160 20464T1
Operation:
- Temperature control via the control lever.- Water flows when hands or forearm are detected by the sensor.- Choice of shut-off modes, depending on use:- Pre-set mode: closes automatically when hands (or forearm) are removedfrom the detection zone, with safety shut-off after 30 seconds (in case ofneglect/ or an object in the detection zone).
- Surgical hand-washing protocols: voluntary shut-off (on/off mode) passing the hands for a 2nd time 5cm from the detector will result in a 30-minute timed flow (safety).
20164T1
215
160
1/2”
350
Max
. 35
mm
295
160
103
103
230Vca 12Vca
20464T1
215
160
1/2”
160
Ø 50
6V
215
250
300
435
1/2”
350
Max
. 35
mm
103
103
230Vca 12Vca
Smooth body and spout interior: reduces bacterial niches(see page 22).
TEMPOMATIC
+ Reduces the risk of bacterial development:Spout with smooth interior (reduces bacterial niches) can beremoved for cleaning and disinfection (see page 22).
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
TEMPOMATIC PRO
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
Electromagnetic compatability in accordance with EU directive CEM 89/336 CEE.
Spout ADAPTOR (2 pack) 969024.2PConnector M24/100 - M1/2"Adaptor to replace the aerator for rapid fitting of a sterile filter.
1/2”
24x100
969024.2P
SPOUT ADAPTOR FOR STERILE FILTER
THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocolsTHESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocols
MIXER WITH LONG LEVER
Electromagnetic compatability in accordance with EU directive CEM 89/336 CEE.
+
NEW
* Maximum temperature limiter must be removed if a thermostatic mixing valve is installed upstream.
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).- Copper tails available (page 67).
* Maximum temperature limiter must be removed if a thermostatic mixingvalve is installed upstream.
4140
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
150
185
Ø 60
1/2”
12V
230Vca
1/2”
441157
TEMPOMATIC Recessed
TEMPOMATIC Cross Wall 441157
Electronic tap for through-the-wall mounting.- Chrome-plated fixed spout L185mm for partitions ≤ 150mm withanti-rotating pin.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- 12V solenoid valve M1/2" with integrated filter.- Separate electronic control unit.- Mains supply (230/12V transformer included).- Duty flush (~45 seconds every 24 hours after the last use).
> Other spout lengths and panel mounting lengths available onrequest.
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).- Copper tails available (page 67).
TEMPOMATIC 3 wall-mounted with integrated batteryElectronic tap for washbasins, with 6V Lithium battery,solenoid valve and electronic unit incorporated in the bodyof the tap.- Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Chrome-plated brass body, Ø50, L190mm.- Duty flush (~45 seconds every 24 hours after the last use).
• wall-mounted M1/2"* 443006• for panels 1-4mm 443016• for panels 1-22mm 443026
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).- Copper tails available (page 67).
103x
103
171
60
68 14
225
x 2
00
182
x 16
0
447500
TEMPOMATIC Cross Wall
TEMPOMATIC Recessed* 447500Electronic tap with box for recessed installation.- Infrared presence detection. - Recessing box with tamperproof, stainless steel plate,includessolenoid valve M1/2" with filter, PEX flexible, and stopcock. - Chrome-plated fixed spout L. 170mm.- Separate electronic control unit with 230/12V transformer.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Duty flush (~45 seconds every 24 hours after the last use).
*Note : Taps do not have a waterproof recessing box, the installer mustensure that the recessing area is waterproof and that any leaks orcondensation can drain away (cf. installation guide).
> Other spout lengths available on request.> For general & technical information see pages 32-35.
Options: - We recommend installing a thermostatic mixing valve (see p. 65)- Wastes (page 66).- Copper tails available (page 67).
1/2"Ø 50
16 190
443006
TEMPOMATIC 3 Wall-mounted
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
Wall-mounted Electronic TapsWall-mounted Electronic Taps
Wall-mounted TEMPOMATIC 4
TEMPOMATIC 4 wall-mounted with integrated batteryElectronic tap for washbasins, with 6V Lithium battery,solenoid valve and electronic unit incorporated in the bodyof the tap.- Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Chrome-plated brass body. Wall-mounted, M1/2”.- Duty flush (~45 seconds every 24 hours after the last use).
• length 125mm 443406• length 190mm 443506
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).- Copper tails available (page 67).
THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocols THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocols
1/2”
16 190
Ø 51
443506
1/2”
16 125
Ø 51
443406
+ Reduces the risk of bacterial development:Solenoid valve with piston (DELABIE patented): water isdrained and renewed with every use, preventing stagnationin the mechanism (see page 35).
1/2" ø 50
18,6 188
2 max. 230
443016
Electromagnetic compatability in accordance with EU directive CEM 89/336 CEE. Electromagnetic compatability in accordance with EU directive CEM 89/336 CEE.
+ Reduces the risk of bacterial development:Solenoid valve with piston (DELABIE patented): water isdrained and renewed with every use, preventing stagnationin the mechanism (see page 35).
NEW
HTM64 compliant
*HTM64 compliant.
BINOPTIC MIX Cross Wall 379MCH
Electronic tap for mounting on walls from 1-130mm.- Infrared presence detection and temperature adjustment via sidelever.- Chrome-plated spout for installation through-the-wall.- Separate electronic control unit.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- M1/2" solenoid valve with filters. - Mains supply (230/12V transformer included).- Duty flush (~45 seconds every 24 hours after the last use).
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).- Copper tails available (page 67).
43
Multifunction Electronic ControlsWall-mounted Electronic Controls
42
205
250
103
103
190 max.
1/2"
1/2"
ø 40
1/2"
1/2"
205
250
12Vca
1/2"
103
103
230Vca
17,5
Ø 60
BINOPTIC MIX Recessed 379ECMWall-mounted electronic mixer for washbasins. - Infrared presence detection and temperature adjustment via sidelever.- Chrome-plated spout on a stainless steel plate H.180 x L.160mm.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Separate electronic control unit.- M1/2" solenoid valve with filters. - Mains supply (230/12V transformer included).- Duty flush (~45 seconds every 24 hours after the last use).
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).
BINOPTIC Wall-mounted Wall-mounted electronic tap for washbasins. - Infrared presence detection.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Separate electronic control unit.- M1/2" solenoid valve with filters. - Mains supply (230/12V transformer included).- Duty flush (~45 seconds every 24 hours after the last use).
• for recessing, spout L.205/250 379ENC• for walls ≤190mm, spout L.205/250 379DER
> For general & technical information see pages 32-35.Options: - We recommend installing a thermostatic mixing valve (see p. 65)
- Wastes (page 66).
BINOPTIC MIX TC
241
14
60
68
18
6x
16
0
103x
103
130 max.
1/2"103
10
3
ø46
230Vca
12Vca
225
379ECM
379MCH
379ENC
379DERBINOPTIC Cross Wall/Recessed
BINOPTIC MIX Recessed TEMPOMATIC Multifunction
Electronic control unit, with touch-pad or infrared controls linked to solenoid valves, for independant control of 4 or 8 points-of-use simultaneouslyvia one unit, including washbasins, showers and dual-flush WCs.
ELECTRONIC MULTIFUNCTION CONTROL FOR 4 OR 8 POINTS-OF-USE FOR PSYCHIATRIC CARE FACILITIES
Electrical Features: • Protect with a 220V/4AT fuse. • Consumption: 2VA maximum : 36VA pulse. Safety: Protect the installation with a circuit breaker (and ensure installation complies with current
local regulations).
Easy installation(installation guide on request) • Simple to install and maintain:1 electronic control unit instead of 4.
• Quick connection: pre-wired connectors with circuit breakers canbe connected to the outside of the controlunit.
• Time flow control for each point-of-use bypositioning the connectors for each point-of-use: 7, 15, 30 or 45 seconds depending onuse (adjust on the mother board).
Safe and easy maintenance Installation in a service duct allows maintenancewithout user contact.
Anti-bacterial duty flushAutomatic duty flush (~ 45 seconds every 24 hours after the last use):avoids water stagnation and the development of bacteria in the pipework.
Advantages• Anti-ligature format: - wall plate and control pads are flush to thepanel and are made from chrome-platedsolid brass.
- control pads cannot be removed.• Investment savingThe cost of the multifunction assembly 4points-of-use is lower than that of 4 individualelectronic controls.
• Water savingsThe security function (4 activations in lessthan 10 minutes or 10 activations in less than30 minutes at one point-of-use will block thepoint-of-use for 30 minutes) prevents wastagethrough misuse of controls connected to themultifunction unit.
• Various combinationsThe multifunction unit offers a largenumber of combinations:4 washbasins, 2 washbasins + 2 showers,2 washbasins + 1 showers + 1 WC
We recommend wall-mounted spouts see p.45
UsePsychiatric care facilities.
+ Spout with smooth interior (reduces bacterial niches)(see page 22).
+ Spout with smooth interior (reduces bacterial niches)(see page 22).
+ Spout with smooth interior (reduces bacterial niches)(see page 22).
THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocolsElectromagnetic compatability in accordance with EU directive CEM 89/336 CEE.
TEMPOMATIC Multifunction
122
138
168
152
4000
495626CEB
4000
461035CEB
4
4000167 max.
Ø 2
1
Ø 2
4 Ø 6
0
441452TCP
441452
NEWTEMPOMATIC Multi for 4 or 8 points-of-useto supply separate points-of-use simultaneously.
• 4-Way Electronic control unit 230/12V 441452/SEC001to connect up to 4 solenoid valves and through-the-wall controls.
• 8-Way Electronic control unit 230/12V 441453/SEC008to connect up to 8 solenoid valves and through-the-wall controls.
Individual Control UnitsCross wall control for walls up to 165mm thick with chrome-plated wall plate Ø 60/24 and 4m cable with quick-fit connectors.
Washbasin, shower or urinal control
• touch-pad control, cross wall with 4m cable 441452TCP• non-branded touch pad control 165mm cable 441452SR• infra-red control, cross wall with 4m cable 441452DET• 1/2” solenoid valve with 4m cable (6V) 495626CEBfor washbasin, shower or urinal.
Colour-coded markers
• blue disc CW Tempomatic cross wall control 441452B• red disc HW Tempomatic cross wall control 441452R
> Blank wall plates are available on request.> Order each element separately: select the solenoid valve (1/2” or 1”).
4544
Wall or Deck-mounted SpoutsKnee or Foot-operated Controls
SWIVEL SPOUT
Deck-mounted Swivel Spout Ø22 M1/2", chrome-plated, solid brass spout on a base plate. - Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Suitable for fitting a sterile filter.
• Spout L.150 H. 139 1306T1• Spout L.200 H. 259 1306T2• Spout L.300 H. 259 1306T3
THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocols
1306T1
150
139
1/2”
25 m
ax. 300
259
1/2”
25 m
ax.1306T3
TEMPOGENOUKnee-operated time flow valve- Time flow ~15 seconds and pre-set flow rate at 6 lpm.- Control lever reinforced by an internal stainless steel rod.- Wall plate with reinforced fixing via 4 stainless steel screws.- Cold or mixed water supply (see TMVS page 65).• straight model, for inline inlet 735400• straight model with wall plate, 15mm for CF* 735447• straight model, for through-the-wall inlet 734100*CF - compression fitting> Available on request: other lever lengths, and 7 seconds time flow.
MIXFOOTPedal-operated mixer- Instant automatic shut-off.- Half-open for cold water, fully open for mixed water.- Pre-set mixing (adjustable) and flow rate set at 15 lpm. - Pedal can be raised for cleaning the floor. - Supplied with integrated filter.
• floor-mounted, fixed by 4 screws 739100• wall-mounted, fixed by 4 screws 739102(adjustable pedal height)
MONOFOOTPedal-operated valve- Instant automatic shut-off.- Cold or mixed water supply (see TMVS page 65).- Flow rate set at 10 lpm at 3 bar.- Pedal can be raised for cleaning the floor. - Supplied with integrated filter.
• floor-mounted, fixed by 4 screws 736101• wall-mounted, fixed by 4 screws 736102(adjustable pedal height)
739100
739102
MONOFOOT
MIXFOOT
TEMPOGENOU
THESE PRODUCTS WILL WITHSTAND THERMAL AND CHEMICAL SHOCKS subject to compliance with current protocols
+ Spout with smooth interior (reduces bacterial niches)(see page 11).
Ø 80 31
1/2"432
34
1/2"
435Ø 50
734100
735400
736101
736102
Flexible Connectorfor supplying water controls- Stainless steel flexible hose. - Maximum temperature 100°C. - Maximum pressure 10 bar ( flow rate 30 lpm at 3 bar )• FF1/2" L.300mm 811315• FF1/2" L.500mm 811515
> Can be connected to all types of spouts. Other types and lengths offlexibles are available on request.
811315
UNIVERSAL SPOUT
FIXED OR SWIVEL SPOUTS
Deck-mounted Fixed Spout, in chrome-plated brass.Spout L. 140, with reinforced fixing by 3 stainless steel screws.
• with vandal proof aerator 6 lpm 981148• with flow straightener pre-set at 3 lpm 981142
Deck-mounted, Swan Neck Swivel Spout- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).- Fixed with a back-nut. • L. 150 H. 120 967152• L. 200 H. 200 967202
Deck-mounted Fixed Spout Ø16 204001- L. 150 H. 170 in chrome-plated brass.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).
Deck-mounted Swivel Spout Ø16 220000- L. 150 H. 120 in chrome-plated brass.- Flow straightener set at 3 lpm at 3 bar (flow rate can be adjusted ifthe Pressure is < 3 bar).
Universal Wall-mounted Spout Ø18• L. 120 with flow straightener 941120• L. 200 with flow straightener set at 3 lpm 941202
Universal Wall-mounted Spout Ø18 for panels ≤ 10mm• L. 120 with flow straightener set at 3 lpm 941922
1/2"
Ø 50 140
30
120
150
1/2"
ø 50
20
140
11
1/2" Ø 18
58
120
24 120
1/2" Ø 18
5710
981142
220000
941120
941922
15
1/2"
ø 35
170
150
204001
FLEXIBLE CONNECTOR
FIXED OR SWIVEL SPOUT
Wall-mounted Spout Ø32 in chrome-plated solid brass• L. 120 with flow straightener set at 3 lpm 947120• L. 170 with flow straightener set at 3 lpm 947170
Wall-mounted Spout Ø32 with Wall Plate • L. 135 with flow straightener set at 3 lpm 947135• L. 185 with flow straightener set at 3 lpm 947185
Wall-mounted Spout Ø32 for Walls ≤150mm (anti-rotating pin)• L. 185 with flow straightener set at 3 lpm 947157
Vandal Proof Wall-mounted Spout L.70 for Walls (anti-rotating pin)• for walls ≤ 220mm, flow straightener 942200• for panels ≤ 30mm, flow straightener 942040
Reinforced fixing with back-nut and 3 screws 826315(strengthening clamp behind the partition).
> Other lengths available on request.
ECO Flow Straightener set at 3 lpm- Flow straightener pre-set at 3 lpm at 3 bar (DELABIE patented).- Adjustable flow rate 2-5 lpm at 3 bar (depending on the model).- Flow rate can be adjusted by the installer or maintenance staff (seeAllen key ref. C282025, page 25).
• M 24/100, 2 pack 922024.2P• F 22/100, 2 pack 922022.2P
1/2 Ø 32
16 170
1/2 Ø 60 Ø 32
T.C. 185
947170
947157
942200
826315
1/2 Ø 60 Ø 32
23 135
947135
WALL-MOUNTED SPOUTS
ECO FLOW STRAIGHTENER 3 LPM
1/2” Ø 21 Ø 48
220 max. 75 6°
922024
1/2"
Ø 50
150
28
120
967152
NEW
Ø10
7
10x1
1434
3
Copper TailsSoft tempered copper tails to supply sanitary fittings.> Long lasting: will withstand intensive use over time.> Will withstand thermal shocks.> Bactericidal properties: bacteriostatic copper prevents bacterialgrowth and the development of biofilm.
• Ø M10x100 L.364 mm (2 pieces) 811610.2P• Ø M11x100 L.364 mm (2 pieces) 811611.2P
COPPER TAILS 811610.2P
Ø10
7
11x1
1434
3
811611.2P