33'

60"81"

56"

106"196"

87"

88"

9°SUTPHEN SUTPHEN

18"

DWG. NO.:DATEBYDESCRIPTION

THIS PRINT IS PROVIDED ON A RESTRICTED BASIS AND IS NOT TO BE USED IN ANY WAY DETRIMENTAL TO THE INTEREST OF SUTPHEN CORPORATION.

REV.

DIMENSIONS SHOWN ON THIS DRAWING ARE APPROXIMATE AND ARE SUBJECT TO MINOR

DEVIATIONS DURING CONSTRUCTION.IN THE EVENT OF A DISCREPANCY BETWEEN THE

SUTPHEN SPECIFICATIONS AND DRAWING, THE SUTPHEN SPECIFICATIONS SHALL PREVAIL.

DRAWING IS FOR REFERENCE ONLY. SOME ITEMS PROPOSED MAY NOT BE SHOWN OR NOTED.

A RM 04/12/18

DRAWN BY:

R.MILLERDATE:

02/26/18

MFG. FACILITY:

DUBLIN

PENN TOWNSHIP FIRE DEPARTMENTMISHAWAKA, IN

CUSTOM PUMPER - S2 BODYHS-6231

CUSTOMER APPROVAL

NAME:

TITLE:DATE:

REV-A SHOP ORDER

EJECTAUTO

44"

L1 L2

73"24"

9'-8"±2"

R3 R2 R1

HOSE TROUGH

HOSE TROUGH

EMS

D

A15' - 8"

40"h X 40"w X 31"dCOMPT

A1OPENING DIMENSIONS

37.5"w X 32.8"h

REAR STEP COMPARTMENT

ROLL-UPDOORS INSIDE DIMENSIONS

28.7 CU. FT.

61.6"w X 36.8"h X 27.3"d53.4"w X 66"h X 27.3"d

43.1"w X 66"h X 27.3"d

COMPT

COMPT

R1

R3R2

L3L2

OPENING DIMENSIONS

OPENING DIMENSIONSRIGHT SIDE COMPARTMENTS

LEFT SIDE COMPARTMENTS

46.5"w X 57.4"h

33.5"w X 57.4"h53.5"w X 28.2"h

ROLL-UP

DOORS

ROLL-UP

ROLL-UPROLL-UP

DOORS

ROLL-UPROLL-UP

L1

INSIDE DIMENSIONS

INSIDE DIMENSIONS

50.5 CU. FT.

VOLUME

40.8 CU. FT.29.8 CU. FT.

VOLUME

VOLUME

(33"h X 10.5"d UPPER)

(10"h X 10.5"d UPPER)(10"h X 10.5"d UPPER)(10"h X 10.5"d UPPER)

(33"h X 10.5"d UPPER)46.5"w X 57.4"h

33.5"w X 57.4"h53.5"w X 28.2"h 61.6"w X 36.8"h X 10.5"d

53.4"w X 66"h X 27.3"d

43.1"w X 66"h X 27.3"d 31.1 CU. FT.13.8 CU. FT.38.6 CU. FT.

TOTAL: 233.3 CU.FT.

C A B TILT IN ST R UC TION S

C AB T ILT

UP

DOWN

CA B TILT LOCK

DIS EN GAGE EN GA GE

ADJ. SHELF

ADJ. SHELF

ADJ. SHELFADJ. SHELF

600# SLIDE-OUT TRAY

DUAL AIR HORNS FEDERAL Q2B SIREN

5" FRONT SUCTION

WHELEN FREEDOM IV(14) LED LIGHTBAR AUTO-EJECT WHELEN LED

WATER LEVEL 10' X 6" HARD SUCTION HOSE WHELEN L31RED LED BEACON

1,000 GALLONWATER TANK

30 GALLONFOAM TANK

95"

3" DECKGUN DISCHARGE

OVERHEAD STORAGESCBA CYLINDER STORAGE

14°

2-1/2" DIRECT TANK FILLWHELEN LED WATER LEVELWHELEN LED TRAFFIC ADVISOR2-1/2" DISCHARGE

WHELEN M912V LED SCENE

AC CONDENSER

LADDER CHUTE

(3) PIKE POLE TUBES

(1) 10' FOLDING(1) 14' ROOF(1) 24' 2-SECT

(1) BACKBOARD STOR

TWO-TONE CAB PAINTPAINT BREAK OPTION #1WHITE OVER RED

ADJ. SHELF

SLID

E-O

UT

TOO

LBO

ARD

L3

WHEELCHOCKS

EXTERIOR CABCOMPARTMENT

DEFROST FANS

O

1

2

WHELEN PFP212V LED TELE

HOSEBEDDS STOKES300' OF 2-1/2"1,000' OF 5"300' OF 2-1/2"

B CORRECTED WHEELBASE CALL-OUT IN COMPONENT REPORT RM 04/18/18

ADJ. SHELF

ADJ. SHELF

05/07/18RMEXTERIOR CAB COMPT DOORS REVERSE HINGED ; ADD (1) SHELF TO EACH EXTERIOR CAB COMPTC

1

Sutphen Component Report

Dealership: Herb Fire 4 (Paul Werner)

HS-6231 Penn Twp (Mishawaka), IN (S2) Name: Brian Kazmierzak Position: Training Chief Phone: 574-255-5075 Mobile: Email: bkazmierzak@pennfire.org

Order#: SOB001618

Bill To Customer: Penn Twp Fire Dept Contact: Brian Kazmierzak, Training Chief Address: 13960 Jackson Rd Mishawaka, IN 46544

Ship To Customer: Penn Twp Fire Dept Contact: Brian Kazmierzak, Training Chief Address: 13960 Jackson Rd. Mishawaka IN 46544

Comments Project Coordinator: Richie Miller Salesperson: Andy Herb / Paul Werner Revision: **REV-C**

Line Item # Qty Item Description/Comments 1 1 **ENG Facility = Dublin. 2 1 **ENG Truck Series = Program 2 Pumper. 3 10000215 1 STD WIRING SCHEMATIC 4 10010001 1 CHASSIS, CUSTOM 5 1 **REV-B**

**ENG Wheelbase = 196”. 6 1 **ENG AF Number = 54". 7 25010000 1 FRAME, 10" SINGLE RAILS, SINGLE AXLE (50K PSI) 8 45010001 1 FRONT TOW EYES, BELOW BUMPER 9 45010015 1 FRONT TOW EYE FINISH, PAINTED

10 46010000 1 REAR TOW EYES 11 40010250 1 STEERING - ROSS TAS-85 12 22010000 1 DRIVE LINE, SPICER, 1710 SERIES 13 23014120 1 ENGINE, CUMMINS L 9 400HP DOC-DPF-DEF-SCR OBD 14 23029100 1 ENGINE WARRANTY, 5 YEAR, 100,000 MILES FOR CUMMINS L9

2

Line Item # Qty Item Description/Comments 15 23030006 1 AIR INTAKE/EMBER SEPARATOR 16 23031173 1 FUEL FILTER/WATER SEPARATOR, PRIMARY, FLEETGUARD, FS1098 17 23031210 1 FUEL FILTER, SECONDARY, FLEETGUARD, FF63009 18 47012430 1 TRANSMISSION, ALLISON GEN 5, EVS3000 19 23110005 1 JACOBS ENGINE BRAKE FOR CUMMINS L ENGINES 20 47024050 1 TRANSMISSION COOLER 21 47025000 1 TRANSMISSION FLUID, CASTROL TRANSYND 22 47030000 1 ALLISON TOUCH PAD SHIFTER 23 1 **ENG Shifter Pad Gearing = 5 gears open, 6th gear locked. 24 21021200 1 COOLING SYSTEM 25 21030000 1 FAN CLUTCH 26 21030200 1 RADIATOR COOLANT RECOVERY, PRESSURIZED SYST 27 26010010 1 **REV-A**

FUEL TANK, STAINLESS STEEL, 65 GAL

28 26030000 1 FUEL FILL 29 26030100 1 FUEL COOLER 30 24040000 1 DIESEL EXHAUST FLUID TANK 31 1 **ENG DEF Access = DEF Door. 32 13010205 1 **REV-A**

ALTERNATOR, LEECE NEVILLE 320 AMP 4962PA

33 15010500 1 BATTERIES, INTERSTATE TYPE 31 MHD (4) 34 15031700 1 BATTERY JUMPER TERMINALS 35 15031577 1 BATTERY CHARGER, IOTA DLS-45 36 15030430 1 120V SHORELINE INLET, KUSSMAUL SUPER 20 AUTO EJECT 37 1 **ENG Shoreline Inlet Location = Driver's side of Cab, standard location. 38 1 **ENG Shoreline Cover Color = Red.

3

Line Item # Qty Item Description/Comments 39 15030488 1 SPECIAL ITEM, INVERTER IN CAB, SCHUMACHER, 1500W

40 1

**CLAR NOTES, INVERTER -A Schumacher 1500W inverter shall be provided and installed in the cab. -The inverter shall convert 12V power to 120AC household power. -There shall be two outlets on the inverter. -Additional 120V outlets wired to Inverter as called out below.

41 88288888 2 **REV-A** SPECIAL ITEM, 120V DUPLEX OUTLET W / WEATHERPROOF COVER WIRED TO INVERTER – (2)

42 1

**CLAR NOTES, -Nema Number = 5-20 House Plugs. -Installed in liquid tight conduit. -(1) In EMS Cabinet, back wall, high, towards Driver’s side. -(1) In R3 Compartment, inboard wall, low, towards front.

43 14010524 1 **REV-A** FRONT AXLE, MERITOR MFS-20-133A 20,000 LB.

44 41010115 1 **REV-A** SUSPENSION FRONT 20,000 LBS. 54" LEAF

45 41030100 1 SUSPENSION, ENHANCED SYSTEM 46 43010305 1 **REV-A**

FRONT TIRES GOODYEAR 385/65R22.5 LRJ G296 22.5 x 12.25 WHEELS

47 14510530 1 REAR AXLE, MERITOR RS-26-185 27,000 LB. 48 14530100 1 TOP SPEED, 68 MPH 49 14540400 1 VOGEL LUBE SYSTEM SINGLE AXLE 50 42010001 1 SUSPENSION REAR REYCO 27,000 LBS. LEAF 51 44010320 1 TIRES, REAR, GOODYEAR 12R22.5 LRH G622 MUD & SNOW 24,000 - 27,000 GVWR 52 42910200 1 TIRE PRESSURE MONITOR, REAL WHEELS, LED 53 44210100 1 WHEELS, ALUM, ACCURIDE (max 27K rear) 54 44270100 1 HUB COVERS, FRONT & REAR, POLISHED STS (Single Axle) 55 44270300 1 CHROME LUG NUT CAPS, FRONT & REAR (Single Axle) 56 44271100 1 MUD FLAPS, FRONT (PAIR) 57 44271200 1 MUD FLAPS, REAR (PAIR) 58 16010009 1 BRAKES MERITOR SCAM 6" FRT 7" REAR 59 18010041 1 AIR BRAKE SYST 4 TANKS WABCO 1200 DRYER 60 18220500 1 NO ELEC STABILITY CONTROL SYS

4

Line Item # Qty Item Description/Comments 61 18110000 1 WABCO 4 CHANNEL ANTI-LOCK BRAKES 62 53510000 1 COMPRESSION FITTINGS ON AIR SYSTEM (CHASSIS) 63 54010000 1 MISCELLANEOUS ITEMS ON CHASSIS 64 54088888 1 SPECIAL ITEM, WINCH RECEIVER, FRONT 65 54088888 1 SPECIAL ITEM, WINCH RECEIVERS, SIDES 66 54088888 1 SPECIAL ITEM, WINCH RECEIVERS, REAR 67 54088888 1 SPECIAL ITEM, WINCH RECEIVER WIRING X 4 68 1 **ENG Dealer will be providing a Ramsey QM-8000 portable winch.

69 11023250 1 **REV-A** CAB TSAL4E 73" 10" RR 1/2

70 11030025 1 CAB CERTIFICATION - STRUCTURAL INTEGRITY 71 11088888 1 **REV-A**

SPECIAL ITEM, TREADPLATE ON REAR EXTERIOR WALL OF CAB, TOP CORNERS

72 1 **ENG To protect from tele-light heads.

73 11030210 1 **REV-A** EXTERIOR COMPTS, SIDE OF EXT CAB 37" H

74 11088888 1 **REV-C** SPECIAL ITEM, REVERSE HINGE CAB EXTERIOR COMPARTMENT DOORS

75 1 **CLAR NOTES, -Hinge these doors towards the rear of the truck. -This will be opposite of the standard setup. -Customers are looking for quicker/easier access to the compartment while exiting the Cab.

76 81130200 2 **REV-C** ADJUSTABLE SHELF [CAB EXTENSION COMPARTMENTS] (2)

77 1 **CLAR NOTES, -Install (1) Adjustable shelf in each Cab extension compartment. -Install approximately 12” of uni-strut for decent range of height adjustment each side.

78 11031025 1 CAB TILT SYSTEM W/AIR TURN VALVE 79 1 **ENG Cab Tilt Controls = Driver's side Pump Panel. 80 11031100 1 MANUAL BACK-UP TILT SYSTEM 81 11031350 1 CAB DOORS, FULL LENGTH 82 11031419 1 CAB DOOR WINDOWS, MANUAL 83 11031401 1 CAB SIDE WINDOWS, FIXED

5

Line Item # Qty Item Description/Comments 84 11031460 1 NO WINDOWS, BACK WALL OF CAB 85 52010010 1 SYNCHRONIZED ELECTRIC INTERMITTENT WIPERS 86 32588888 1 SPECIAL ITEM, WINDSHIELD WIPER INTERLOCK 87 1 **ENG Wire Windshield Wipers to cut off when Parking Brake is engaged.

88 27022000 1 HANDRAILS, CAB, KNURLED STAINLESS STEEL 89 27088888 1 **REV-A**

SPECIAL HANDRAILS, CAB, KNURLED STAINLESS STEEL, REDUCED HEIGHT HANDRAILS ON SIDE

90 1

**CLAR NOTES, -Front handrails will be 22”. -Rear handrails will be 15.5”. -Shorter handrails will drop the coat hooks closer to the ground. -Install so that the bottom of the handrails are at the standard heights. -Make sure the top edge of each handrail is at the same height as the other handrail.

91 27030600 1 COAT HOOKS FOR GRAB HANDRAILS (4) 92 27030710 1 HANDRAILS, FRONT OF CAB, KNURLED STAINLESS STEEL (PAIR) 93 27030007 1 HANDRAILS, REAR CAB INTERIOR DOOR WINDOW KNURLED STS 94 38010020 1 MIRRORS LANG MEKRA 300 SERIES HEATED & REMOTE 95 11024410 1 RAISED GRILLE, TUBULAR STYLE FACADE (L9) 96 20010085 1 BUMPER, 24" POLISHED STAINLESS STEEL 97 1 **ENG Siren Speaker Perforations = No Speaker Perforations in Bumper. 98 20029800 1 BUMPER SIDES, DIAMONDPLATE 99 20040230 1 STORAGE WELL, DEEP CENTER, 3/4 WIDTH (24" BUMPER)

100 20040295 1 **REV-A** SPECIAL STORAGE WELL COVER, BLACK STRAPS WITH AIRPLANE BUCKLES

101 1 **CLAR NOTES, -Reference HS-5601 Penn Twp, IN. -See Reference Photo #06 on Shared drive.

102 12010500 1 AIR HORNS, DUAL, GROVER #2040 RECTANGULAR 103 1 **ENG Air Horns Location: Inboard in Bumper. 104 12030205 1 AIR HORNS WIRED TO STEERING WHEEL BUTTON 105 12040010 1 MOMENTARY SWITCH ON DASH, OFFICER'S SIDE 106 12510111 1 **REV-A**

ELEC SIREN, WHELEN 295SLSA1

6

Line Item # Qty Item Description/Comments 107 12620200 1 SIREN SPEAKER, 100W, WHELEN, SA314B 108 12670110 1 SIREN SPEAKER(S) INSTALLED BEHIND CAB GRILLE 109 12710100 1 SIREN, FEDERAL Q2B, FLUSH GRILLE MOUNT 110 12730310 1 FOOT SWITCH, OFFICER'S SIDE, FOR MECH SIREN 111 1 **ENG Siren Brake Switch for Driver. 112 1 **ENG Siren Brake Switch for Officer. 113 32520520 1 **REV-A**

HEADLIGHTS, LED, FIRETECH FT-4X6, DUAL STS HOUSINGS

114 1 **ENG Headlight Interior Finish = Chrome. 115 48010300 1 **REV-A**

FRONT TURN SIGNALS, WHELEN 400 SERIES LED (4)

116 31010287 1 INTERIOR, MULTISPEC GRAY SPECKLE PAINT W/GRAY-BLACK DURAWEAR 117 11033202 1 **REV-A**

3/16" SMOOTH ALUM BACK WALL & SIDE WALLS, INSIDE CAB

118 1 **ENG Gray Speckle Paint on Aluminum Panels.

119 11032929 1 DOOR PANEL, FULL STS 120 11032955 1 REFLECTIVE MATL, INTERIOR CAB DOORS, SCOTCHLITE CHEVRONS 121 1 **ENG Reflective Striping Color = Red/White. 122 1 **ENG Reflective Striping Verbiage = “PENN FIRE” 123 31010290 1 CAB INTERIOR FLOOR COVERING, GRAY RUBBERIZED 124 22510100 1 ENGINE ENCLOSURE, FULL SIZE 125 22510531 1 ENGINE ENCLOSURE COVERING, SCORPION GRAY URETHANE BLEND 126 11031670 1 NO STORAGE ON ENGINE ENCLOSURE 127 22610000 1 ENGINE HOOD LIGHT, HALOGEN (1) 128 11031510 1 FLAT WORK SURFACE IN LIEU OF GLOVE BOX 129 30010120 1 INSTRUMENTATION, BEEDE GAUGES W/ CENTER & OVERHEAD CONSOLES 130 1 **ENG Overhead Console Panel's Finish: Black Wrinkle.

7

Line Item # Qty Item Description/Comments

131 1

**ENG Overhead Console Position 1: Switch #1: Master Emergency. Switch #2: L-Tele. Switch #3: R-Tele. Switch #4: Rear Scene. Switch #5: Ground Lights.

132 1 **ENG Overhead Console Position 2: -Traffic Advisor Control Head.

133 1 **ENG Overhead Console Position 3: -HVAC Controls.

134 1 **ENG Overhead Console Position 4: -Chassis Indicator Lights. -Seat Belt Monitor.

135 1 **ENG Overhead Console Position 5: -Officer's side Speedometer.

136 1 **ENG Overhead Console Position 6: -Blank.

137 1 **ENG Overhead Console Position 7: -Blank.

138 1 **ENG Lower Command Console Finish: Gray Urethane. 139 1 **ENG Lower Console Panel's Finish: Black Wrinkle.

140 1 **ENG Lower Console Position 1: -Transmission Touchpad. -Pump Shift.

141 1

**ENG Lower Console Position 2: Switch #1: Jake On/Off. Switch #2: Jake Low/Med/High. Switch #3: High Idle. Switch #4: E Horn / Air Horns Selector. Switch #5: Siren Brake.

142 1 **ENG Lower Console Position 3: -Parking Brake. -Whelen Siren Control Head (non-remote head mounted high on panel). -12V Power Points (called out below).

143 1 **ENG Lower Console Position 4: -Customer Supplied MDT Mount. -(1) Double USB 12V Power Point in bottom corner toward windshield.

144 1 **ENG Lower Console Position 5: Switch #1: Master Emergency. Switch #2: Air Horns. Switch #3: Siren Brake.

145 30010700 1 CAB PUMP SHIFT 146 29910100 1 PROGRAMMABLE LOAD MANAGER, CLASS-1 SUPERNODE II 147 30031100 1 HIGH IDLE SWITCH 148 30031775 1 12V POWER POINTS, (2) 149 1 **ENG Power Point Location #1: Lower Console Position 3, Driver’s corner.

8

Line Item # Qty Item Description/Comments 150 1 **ENG Power Point Location #2: Lower Console Position 3, Officer’s corner. 151 30031802 1 12V DUAL PORT USB POWER POINTS, (2) 152 1 **ENG USB Power Point Location #1: Lower Console Position 3, Officer’s corner.

153 1 **ENG USB Power Point Location #2: Lower Console Position 4, bottom right hand corner.

154 11040000 1 CAB ACCESSORY FUSE PANEL 155 84541540 1 POWER & GROUND STUDS, UPPER COMMAND CONSOLE

156 1 **ENG Requirements (AMPS) for Power/Ground Studs in Upper Command Console: (1) 12-volt 60-amp, direct to the battery. (1) 12-volt 30-amp controlled by the ignition switch. (1) 12-volt 125-amp ground.

157 30110000 1 VEHICLE DATA RECORDER, AKRON/WELDON 158 30088888 1 SPECIAL ITEM, OFFICER'S SIDE SPEEDOMETER 159 1 **ENG Install in Overhead Console Position 5.

160 30088888 1 **REV-A** SPECIAL ITEM, INSTALL CUSTOMER SUPPLIED MDT MOUNT IN LOWER CONSOLE POSITION 4

161 33510030 1 INTERIOR CAB LIGHTS, RED/CLEAR LED (2) 162 34010030 1 INTERIOR CREW LIGHTS, RED/CLEAR LED (2) 163 28010740 1 DEFROSTER, HEATER & A/C (COMPACT) 164 28090003 1 HEAT TO FEET 165 28030500 1 DEFROSTER DUCTWORK, ENTIRE WINDSHIELD 166 28031000 1 **REV-A**

FAN, 12 VOLT, DRIVER'S SIDE

167 28031100 1 **REV-A** FAN, 12 VOLT, OFFICER'S SIDE

168 11031687 1 TOOL MOUNTING PLATE, 25” x 19.5”, TOP OF HEAT/AC UNIT 169 38510075 1 DRIVER'S SEAT, BOSTROM, NAVIGATOR AIR-50RX/D AIR RIDE (DURAWEAR PLUS, LOW SEAM) 170 38320000 1 HELMET STORED IN COMPARTMENT 171 39010130 1 **REV-A**

OFFICER'S SEAT, BOSTROM SIERRA, ABTS HIGH BACK (DURAWEAR) 172 39030010 1 OFFICER’S SEAT COMPT, OPEN FRONT 173 38320000 1 HELMET STORED IN COMPARTMENT

9

Line Item # Qty Item Description/Comments 174 39521205 1 **REV-A**

CREW SEAT 1, BOSTROM SIERRA, ABTS HIGH BACK (DURAWEAR) 175 38320000 1 HELMET STORED IN COMPARTMENT 176 39521206 1 **REV-A**

CREW SEAT 2, BOSTROM SIERRA, ABTS HIGH BACK (DURAWEAR) 177 38320000 1 HELMET STORED IN COMPARTMENT 178 11031828 1 EMS CABINET, FORWARD FACING, DOUBLE ON CREW SEAT RISER (RAISED ROOF)

179 1 **CLAR NOTES, -Outside dimensions of the EMS Cabinet needs to be 18.5” deep. -This will hang slightly over seat riser but is required to store equipment. -EMS Cabinet height needs to go all the way to the ceiling.

180 38320000 1 HELMET STORED IN COMPARTMENT 181 39550100 1 SEAT COLOR, GRAY 182 38410000 1 SEAT BELT WARNING SYSTEM, AKRON / WELDON 183 39710015 1 **REV-A**

CREW SEAT COMPT, FRONT DROP-DOWN DOORS (73" CAB)

184 11031740 1 OVERHEAD STORAGE, FRONT OF 10" RR W/NET 185 60090005 1 PUMP, WATEROUS CSU-1500 SINGLE STAGE 186 60025300 1 GEARBOX, WATEROUS, REAR MOUNTED 187 60026032 1 MECHANICAL PUMP SEAL, WATEROUS 188 60035121 1 PUMP TEST, MISTRAS GROUP, INC 189 61510000 1 AUXILIARY COOLER (HEAT EXCHANGER) 190 62010002 1 STAINLESS STEEL PIPING 191 60088888 1 SPECIAL ITEM, ELKHART VALVES 192 66090010 1 3" TANK-TO-PUMP W/CHECK VALVE 193 61720200 1 VALVE, ELKHART 194 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 195 73090001 1 TANK FILL 2" 196 61720200 1 VALVE, ELKHART 197 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS

10

Line Item # Qty Item Description/Comments 198 61090009 1 PRESSURE GOVERNOR, FIRE RESEARCH, PUMP BOSS 199 61290030 1 **REV-A**

INTAKE PRESSURE CONTROL, ELKHART 40-20

200 63021500 1 6" MAIN SUCTION, LEFT SIDE 201 63090005 1 WATEROUS MONARCH INTAKE VALVE, ELEC (SIDE SUCTION) 202 65090000 1 2.5" LEFT SIDE INLET 203 61720200 1 VALVE, ELKHART 204 61770905 1 ACTUATOR, VALVE, SWING CONTROL 205 60036010 1 THREADS, NST 206 63025500 1 6" MAIN SUCTION, RIGHT SIDE 207 65550910 1 5" FRONT SUCTION, TOP, ELEC OPER 208 63090007 1 ELKHART INTAKE VALVE, ELEC (FRONT SUCTION) 209 65552120 1 SWIVEL, 5" NPT X 6" NST 210 70525900 1 2.5" DISCHARGE, LEFT - POSITION 1 - 30 DEG 211 61720200 1 VALVE, ELKHART 212 61770902 1 **REV-A**

ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 213 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" 214 60036010 1 THREADS, NST 215 70525900 1 2.5" DISCHARGE, LEFT - POSITION 2 - 30 DEG 216 61720200 1 VALVE, ELKHART 217 61770902 1 **REV-A**

ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 218 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" 219 60036010 1 THREADS, NST 220 71025905 1 3" DISCHARGE, RIGHT - POSITION 3 - STRAIGHT 221 71088888 1 SPECIAL ITEM, 4" FLANGE FOR LDH DISCHARGE – STRAIGHT

11

Line Item # Qty Item Description/Comments 222 1

**CLAR NOTES, -The 3" discharge shall terminate with a 4" NST flange off of the valve. -Terminate the discharge straight as the 30 degree droop will be on the Dealer Supplied adapter.

223 61720210 1 VALVE, ELKHART, SLOW CLOSE 224 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 225 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" 226 60036010 1 THREADS, NST 227 71025900 1 2.5" DISCHARGE, RIGHT - POSITION 4 - 30 DEG 228 61720200 1 VALVE, ELKHART 229 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 230 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" 231 60036010 1 THREADS, NST 232 71590000 1 DISCHARGE, 2.5" LEFT REAR 233 61720200 1 VALVE, ELKHART 234 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 235 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" 236 60036010 1 THREADS, NST 237 71890000 1 DISCHARGE 2.5" RIGHT REAR 238 61720200 1 VALVE, ELKHART 239 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 240 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" 241 60036010 1 THREADS, NST 242 72290000 1 1.5" FRONT BUMPER DISCHARGE, 2" PLUMBING 243 61720200 1 VALVE, ELKHART 244 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 245 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5"

12

Line Item # Qty Item Description/Comments 246 60036010 1 THREADS, NST 247 1 **ENG Front Bumper Swivel Location/Side = Driver's side. 248 1 **ENG Front Discharge Swivel Location = In Trough. 249 72590002 1 DECK GUN DISCHARGE 3" 250 61720210 1 **REV-A**

VALVE, ELKHART, SLOW CLOSE

251 61770902 1 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS 252 77090010 1 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" 253 72570100 1 DECK GUN TERMINATION, THREADED

254 1

**CLAR NOTES, -Dealer will install an electric extend-a-gun. -Need module ordered without the standard deck-gun pipe running vertically into the dunnage. -The hole going up to into the dunnage floor for the deck-gun discharge will need to be twice as large as standard to accommodate the larger electric extend-a-gun.

255 72890000 1 CROSSLAYS, TWO 2" W/1.5" SWIVEL 256 1 **ENG Crosslay Hose Load Requirement = 200' of 1.75" Hose, each. 257 61720200 2 VALVE, ELKHART (2) 258 61770902 2 ACTUATOR, VALVE, PUSH/PULL, INNOVATIVE CONTROLS (2) 259 77090010 2 GAUGE, DISCH, INNOVATIVE CONTROLS 2.5" (2) 260 60036010 2 THREADS, NST (2) 261 72910505 1 COVER, ALUM W/VINYL SIDES FOR CROSSLAYS 262 1 **ENG Crosslay/Speedlay Vinyl Ends Color = Red. 263 1 **ENG Crosslay/Speedlay Vinyl Ends Fastener = Bungee with Tabs. 264 72888888 1 SPECIAL ITEM, STAY OPEN LATCH FOR CROSSLAY COVER 265 1 **ENG Cover shall have a latch on it to secure the hard cover in the open position when loading hose. 266 61742000 1 MASTER PUMP DRAIN, MULTIPORT 267 61790500 11 DRAIN VALVES, INNOVATIVE CONTROLS, LIFT-UP (11) 268 73540016 1 ELKHART FOAM SUPPLY SYSTEM W/FLUSH (FOR EXTERNAL EDUCTOR)

13

Line Item # Qty Item Description/Comments 269 73531425 1 FOAM TANK 30 GALLON BUILT INTO BOOSTER TANK 270 74929210 1 WATEROUS PUMP MODULE CONFIGURATION, SIDE MOUNT 271 74914110 1 PRG SM1 - 44" W SIDE MOUNT PUMP PANEL (CROSSLAYS)

272 1

**CLAR NOTES, -Dealer will install an electric extend-a-gun. -Need module ordered without the standard deck-gun pipe running vertically into the dunnage. -The hole going up to into the dunnage floor for the deck-gun discharge will need to be twice as large as standard to accommodate the larger electric extend-a-gun.

273 74930710 1 PANEL FINISH, BRUSHED STS 14 GAUGE (PRG) 274 74931055 1 COLOR CODING (PRG) 275 1 **ENG Color Coding Standard = No.

276 1

**ENG Color Coding Special = -Position #1 Discharge: Yellow. -Position #2 Discharge: White. -Position #3 Discharge: Blue. -Position #4 Discharge: Black. -Front Discharge: Light Green Teal. -Front Crosslay: Orange. -Rear Crosslay: Red. -Left Rear Discharge: Olive Green. -Right Rear Discharge: Blue Teal. -Deck Gun: White. -Tank Fill / Re-Circulate: Green. -Tank to Pump: Red. -Pump Intakes: Maroon.

277 75040200 1 TROUGH IN RUNNING BOARD, LEFT SIDE 278 1 **ENG Specify Hose Type & Capacity Desired for Left Running Board Trough = 25' of 5” Hose. 279 1 **ENG Left Trough Cover = Velcro Straps. 280 75040210 1 TROUGH IN RUNNING BOARD, RIGHT SIDE 281 1 **ENG Specify Hose Type & Capacity Desired for Left Running Board Trough = 25' of 5” Hose. 282 1 **ENG Left Trough Cover = Velcro Straps. 283 75590010 1 PUMP PANEL LIGHTS, LED (PRG) 284 76090002 1 PUMP PANEL GAUGES & CONTROLS (PRG) 285 60088888 1 **REV-A**

SPECIAL ITEM, AUTO PUMP PRIMER WITH GAUGE FOR MAIN SUCTION, TRIDENT 31.011.3

286 60028320 1 (2) PRIMER BUTTONS - MAIN & FRONT SUCTION

287 1 **CLAR NOTES, -Reference HS-5601 Penn Twp, IN. -See Reference Photo #07 on Shared drive.

14

Line Item # Qty Item Description/Comments 288 76025110 1 COMPRESSION FITTINGS ON AIR SYSTEM (PRG PUMP MODULE) 289 76031900 1 AIR HORN PUSH BUTTON SWITCH ON PUMP PANEL

290 1 **ENG Air Horn Push Button Location = -On hinged panel door left of master gauges. -Reference HS-5601 Penn Twp, IN. -See Reference Photo #02 on Shared drive.

291 76590010 1 GAUGES, MASTER, INNOVATIVE CONTROLS, 4" (PRG) 292 77590005 1 GAUGE, WATER LEVEL, FIRE RESEARCH, TANKVISION 293 77532103 1 GAUGE, WATER LEVEL, WHELEN PSTANK LED (3) 294 1 **ENG Whelen Gauge Locations = Driver's side Cab behind Crew Door. 295 1 **ENG Whelen Gauge Locations = Officer's side Cab behind Crew Door. 296 1 **ENG Whelen Gauge Locations = Rear of Body. 297 77590041 1 GAUGE, FOAM LEVEL, FIRE RESEARCH TANKVISION 298 83525000 1 WATER TANK BRAND, UNSPECIFIED 299 83590005 1 WATER TANK, 1000 GAL, POLY

300 1 **CLAR NOTES, -Ensure water tank overfill line doesn’t terminate on top of fuel tank. -Customer is concerned with corrosion of fuel tank.

301 73030300 1 DIRECT TANK FILL 2.5" REAR 302 61720200 1 VALVE, ELKHART 303 61770905 1 ACTUATOR, VALVE, SWING CONTROL 304 80190200 1 BODY S2 - ALUM 43/53 LAD CHUTE 305 80029900 1 BODY SUBFRAME, PUMPER/TANKER 306 81130200 1 ADJUSTABLE SHELF [L1] (1) 307 81130200 1 ADJUSTABLE SHELF [L2] (1) 308 81130200 1 ADJUSTABLE SHELF [L3] (1)

309 1 **CLAR NOTES, -Full width of compartment. -On top of adjustable vertical slide-out panel as shown in Shop Order Drawing.

310 81150000 1 **REV-A** 250# ADJUSTABLE VERTICAL SLIDE-OUT PANEL [L3] (1)

15

Line Item # Qty Item Description/Comments 311 1

**CLAR NOTES, -Will be adjustable full width of compartment. -Beneath adjustable shelf as shown in Shop Order Drawing.

312 81130200 1 ADJUSTABLE SHELF [R1] (1) 313 1 **ENG Shallow shelf installed @ Body Break line.

314 81130200 1 ADJUSTABLE SHELF [R3] (1) 315 1 **ENG Shallow shelf installed @ Body Break line.

316 81150300 1 600# SLIDE-MASTER TRAY [A1] (1) 317 81165705 1 UNISTRUT TRACK IN COMPTS 318 80290015 1 COMPT DOORS, ROM ROLL-UP, SATIN FINISH 319 80225000 1 REAR COMPT DOOR (A1) ROM ROLL-UP, SATIN FINISH 320 84530910 1 COMPT LIGHTING, LED LIGHT STRIPS, 2 PER COMPT 321 81390000 1 HOSEBED, REMOVABLE ALUM FLOORING

322 1

**ENG List the Hose Bed Hose Load Req. = Left-to-Right: -Dealer Supplied Stokes Basket -300’ of 2.5” -1000’ of 5”. -300’ of 2.5”.

323 81410000 1 COVER, VINYL, MAIN HOSE BED 324 1 **ENG Hosebed Cover Color = Red. 325 1 **ENG Hosebed Cover Fastener = Bungee with Tabs. 326 81330302 1 HOSE BED DIVIDERS, ADJ (2) 327 81910100 1 HANDRAILS, KNURLED STS 328 82290010 1 STEPS, FRONT BODY, IC FOLD DOWN W/LIGHT

329 1 **CLAR NOTES, -Driver’s side only. -Delete front-of-Body steps on Officer’s side.

330 82390000 1 STEPS, REAR BODY (8x8)

331 1 **CLAR NOTES, -Driver’s side only. -Delete rear-of-Body steps on Officer’s side.

332 82510000 1 RUB RAILS, ANODIZED ALUM

16

Line Item # Qty Item Description/Comments 333 83089500 1 ALUMINUM TREADPLATE (PRG2) 334 80290013 1 4 SCBA CYLINDER COMPTS (2 RIGHT, 2 LEFT) 335 88520100 1 SUCTION HOSE, (2) 10' SECT 6" KOCHEK LIGHTWEIGHT 336 1 **ENG Suction Hose Location = Above Body Compartments, (1) each side. 337 88540100 1 SUCTION HOSE MOUNTING, DIAMOND PLATE TROUGHS 338 88550300 1 STRAINER NOT PROVIDED 339 89011500 1 ALCO-LITE PEL-24 24'2 SEC & PRL-14 14' ROOF & 10' FOLDING 340 89590002 1 LADDER CHUTE W/BACKBOARD STORAGE

341 1

**CLAR NOTES, -Will also hold (3) pike pole chutes for standard head pikes. -Reference Shop Order Drawing. -Install metal door - with chevrons - hinged inboard. -(1) push button latch (will be different fastener than last truck).

342 84550110 1 LICENSE PLATE BRACKET W/ LIGHT, LED 343 84510100 1 ELECTRICAL DESCRIPTION 344 84520000 1 BACK UP ALARM, ECCO SA917 345 85010302 1 **REV-A**

TAILLIGHTS, WHELEN 600 SERIES, LED STOP/TAIL/TURN/REVERSE, QUAD HOUSING (PAIR)

346 85110100 1 ICC LIGHTS, LED 347 85510200 1 STEP LIGHTS, LED, WHELEN 2G AT PUMP PANEL & REAR BODY

348 1

**CLAR NOTES, -Install light strips for rear of Body down rear extrusions in J-channels. -Be sure to install Officer’s side even though steps have been deleted. -Reference HS-6008 Palm Beach Co, FL. -See Reference Photo #08 on Shared drive.

349 85710010 1 UNDERCARRIAGE GROUND LIGHTS, LED 350 85788888 1 SPECIAL ITEM, SWITCH TO TURN ON GROUND LIGHTS IN CAB

351 1 **CLAR NOTES, -The ground lights shall have a switch in the cab to use as running lights. -Switched in Cab, Overhead Console Position 1.

352 86600000 1 OPTICAL WARNING SYSTEM, UPPER 353 86610130 1 UPPER WARNING LIGHTS, ZONE A (FRONT), WHELEN FREEDOM IV 72" LED LIGHT BAR, F4N7QLED, 14

MODULES 354 1

**ENG Zone A, Upper Lightbar Color / Details = (1) 72" Whelen Freedom IV Lightbar with (12) Red and (2) White LEDs all with Clear lenses. -Reference HS-5601 Penn Twp, IN.

17

Line Item # Qty Item Description/Comments -See Reference Photo #03 on Shared drive. -Add (2) Red LED modules to Reference Photo #03 to make (14) total heads.

355 86699999 1 UPPER WARNING LIGHTS, ZONE B (OFFICER'S SIDE), COVERED BY ZONES A & C 356 86710105 1 UPPER WARNING LIGHTS, ZONE C (REAR), WHELEN LED BEACONS, L31 (PAIR) 357 1 **ENG Zone C, Upper Rear Beacon Color/Details = Red lights / Red lenses. 358 86899999 1 UPPER WARNING LIGHTS, ZONE D (DRIVER'S SIDE), COVERED BY ZONES A & C 359 87100000 1 OPTICAL WARNING SYSTEM, LOWER 360 87110110 1 **REV-A**

LOWER WARNING LIGHTS, ZONE A (FRONT), WHELEN 600 SUPER LED, 60*02F*R (QTY 4)

361 1 **ENG Zone A, Lower Warning Light Color, Lens Color, Details = Red lights / Red lenses.

362 87811130 1 **REV-A** LOWER, ZONE A - MOUNTING LOCATION (DUAL HOUSINGS)

363 1 **ENG Zone A, Lower - Front, Mounting Location = (2) Warnings in top headlight housing, each side.

364 87210100 1 LOWER WARNING LIGHTS, ZONE B (OFFICER'S SIDE), WHELEN 600 SUPER LED, 60*02F*R (QTY 2), ION T-SERIES LED, TLI* (QTY 1)

365 1 **ENG Zone B, Lower Officer's Side Warning Light Color, Lens Color, Details = Red lights / Red lenses. 366 87812110 1 LOWER, ZONE B - MOUNTING LOCATION (PUMPERS, TANKERS)

367 1

**ENG Zone B, Lower - Officer's Side, Mounting Location = (1) Warning light near the front corner of the apparatus. (1) Near the rear axle. (1) Near the rear corner of the apparatus. -Reference Shop Order Drawing for lights and placement.

368 87310100 1 LOWER WARNING LIGHTS, ZONE C (REAR), WHELEN 600 SUPER LED, 60*02F*R (QTY 2) 369 1 **ENG Zone C, Lower Rear Warning Light Color, Lens Color, Details = Red lights / Red lenses. 370 87410100 1 LOWER WARNING LIGHTS, ZONE D (DRIVER'S SIDE), WHELEN 600 SUPER LED, 60*02F*R (QTY 2), ION T-

SERIES TLI* (QTY 1) 371 1 **ENG Zone D, Lower Driver's Side Warning Light Color, Lens Color, Details = Red lights / Red lenses. 372 87814110 1 LOWER, ZONE D - MOUNTING LOCATION (PUMPERS, TANKERS)

373 1

**ENG Zone D, Lower - Driver's Side, Mounting Location = (1) Warning light near the front corner of the apparatus. (1) Near the rear axle. (1) Near the rear corner of the apparatus. -Reference Shop Order Drawing for lights and placement.

374 87537732 1 **REV-A** ADDITIONAL WARNING LIGHTS, WHELEN 600 SUPER LED, 60*02F*R (PAIR) (1)

375 1 **CLAR NOTES, -Red lights / Red lenses. -(1) Pair rear of Body, high, below M9 Scene Lights.

18

Line Item # Qty Item Description/Comments 376 87040000 1 TRAFFIC ADVISOR, WHELEN LED, TAL65 36" 377 1 **ENG Install Control Head in Overhead Console Position 2.

378 86537816 1 **REV-A** SCENE LIGHTS, WHELEN M9 LED, SURFACE MOUNT (PAIR) (1)

379 1 **ENG Light Mounting Location & Switching = -(1) Pair, rear of Body, high. -Switched in Cab, Overhead Console Position 1, "Rear Scene". -Wired to Reverse.

380 88391080 2 **REV-A** LIGHT, WHELEN, PFP2, TELESCOPIC, 12V LED (2)

381 1 **CLAR NOTES, -White housings. -Rear of Cab, (1) each side. -Switched in Cab, Overhead Console Position 1, “L-Tele”, “R-Tele”.

382 89910010 1 CORROSION REDUCTION PROGRAM (PROPOSALS) 383 90010020 1 PAINT SCHEME 384 90030005 1 TWO TONE CAB TO BOTTOM OF WINDSHIELD

385 1

**ENG List Special Paint Details = -Standard Paint Break Option #1. -White over Red. -Reference HS-5601 Penn Twp, IN. -See Reference Photo #05 on Shared drive.

386 90030154 1 PAINT FRAME RAILS & BODY SUBFRAME -BLACK 387 90510100 1 LETTERING, NOT PROVIDED 388 90610200 1 6" SCOTCHLITE STRIPE AROUND TRUCK 389 90630100 2 **REV-A**

1" SCOTCHLITE STRIPE ABOVE OR BELOW - EACH (2)

390 90670020 1 **REV-A** CHEVRON STRIPING, FRONT BUMPER, REFLEXITE

391 1 **ENG Chevron Striping, Rear Body Color = #030 Red Transparent & #L2 Fluorescent Lime. 392 90680120 1 CHEVRON STRIPING, REAR BODY OUTBOARD, REFLEXITE 393 1 **ENG Chevron Striping, Rear Body Color = #030 Red Transparent & #L2 Fluorescent Lime. 394 91010000 1 MISC EQUIP - (1) PINT TOUCH-UP PAINT, STAINLESS STEEL NUTS & BOLTS 395 91030700 1 ZIAMATIC SAC-44 FOLDING WHEEL CHOCKS (PAIR) MTD W/ SQCH-44H HOLDERS 396 1 **ENG Wheel Chock Mounting Locations = Under L1 compartment. 397 99010000 1 MANUALS (1-PRINTED & 1-CD) WITH DVD

19

Line Item # Qty Item Description/Comments 398 99031105 1 PICK-UP UNIT AT FACTORY 399 99510000 1 ONE YEAR WARRANTY 400 PDB000177 1 DEALER SUPPLIED - 4" X 5" STORZ ADAPTER W/30 DEGREE DROOP 401 PDB000214 1 DEALER SUPPLIED - SIGTRONICS HEADSET SYSTEM 402 PDB000176 1 DEALER SUPPLIED - FRONT SUCTION PRE-CONNECT 403 PDB000448 1 DEALER SUPPLIED - BOOSTER REEL, AKRON BRASS, 100’ OF 1.5” 404 PDB000158 1 DEALER SUPPLIED - PORTABLE WINCH – RAMSAY QM8000 405 PDB000216 1 DEALER SUPPLIED - GO LIGHT, SPOTLIGHT 406 PDB000219 1 DEALER SUPPLIED - WHELEN DOMINATOR 407 PDB000060 1 DEALER SUPPLIED - SEVERE DUTY CHASSIS 408 PDB001079 1 DEALER SUPPLIED - DRAIN PROTECTOR 409 PDB000175 1 DEALER SUPPLIED – SIDE VIEW CAMERA 410 PDB000175 1 **REV-A**

DEALER SUPPLIED – BACKUP CAMERA 411 PDB000089 1 DEALER SUPPLIED - TURTLE TILE 412 PDB000217 1 DEALER SUPPLIED - WHELEN MINI LIGHT BARS 413 PDB000183 1 DEALER SUPPLIED - STOKES STORAGE COMPARTMENT

414 1 **CLAR NOTES, -Drop down door hinged at bottom. -Install different style latch than HS-5601.

415 PDB001080 1 DEALER SUPPLIED - DRIP PANS - FMI 416 PDB000523 1 DEALER SUPPLIED - COMMAND LIGHT 12V KNIGHT KL408D-W1

417 1 **CLAR NOTES, -(6) PFP1 12V Light heads on Light Tower. -Install controls in L1 Compartment.

418 PDB888888 1 **REV-A** DEALER SUPPLIED – TRAFFIC CONE MOUNTING ON REAR TAILBOARD

419 PDB888888 1 **REV-A** DEALER SUPPLIED – ELECTRIC DECKGUN, TFT, MONSOON RC DECKGUN (Y4-EL5A)

420 PDB888888 1 **REV-A** DEALER SUPPLIED – ELECTRIC EXTEND-A-GUN, TFT, RC3 (XGA38PL-RL)