TM 11-6625-291-40P_Output_Meters_TS-585_1984.pdf
-
Upload
wurzel1946 -
Category
Documents
-
view
249 -
download
10
Transcript of TM 11-6625-291-40P_Output_Meters_TS-585_1984.pdf
TM 11-6625-291-40P
TECHNICAL MANUAL
GENERAL SUPPORT MAINTENANCEREPAIR PARTS AND SPECIAL TOOLS LIST
FOR
OUTPUT METERSTS-585A/U, TS-585B/U, TS-585C/U
(NSN 6625-00-244-0501)AND
AUDIO LEVEL METER TS-585D/U(NSN 6625-00-684-5438)
HEADQUARTERS, DEPARTMENT OF THE ARMY
6 AUGUST 1984
*TM 11-6625-291-40P
Technical Manual ) HEADQUARTERS) DEPARTMENT OF THE ARMY
No. 11-6625-291-40P) Washington, DC, 6 August 1984
GENERAL SUPPORT MAINTENANCEREPAIR PARTS AND SPECIAL TOOLS LIST
FOROUTPUT METERS TS-585A/U, TS-585B/U, TS-585C/U
(NSN 6625-00-244-0501)AND
AUDIO LEVEL METER TS-585D/U (NSN 6625-00-684-5438)
Current as of 21 June 1984
REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS
You can help improve this manual. If you find any mistakes or ifyou know of a way to improve the procedures, please let us know.Mail your letter, DA Form 2028 (Recommended Changes to Publicationsand Blank Forms), or DA Form 2028-2 located in back of this manuald i r ec t t o : Commander, US Army Communications-Electronics Commandand Fort Monmouth, ATTN: DRSEL-ME-MP, Fort Monmouth, NJ 07703-5007.
IIn either case, a reply will be furnished direct to you.
Table of Contents
I l l u sPage Figure
S e c t i o n I . Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1I I . Repair Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Group 00 Audio Output Meter TS-585A/U . . . . . . . . . . . . . . . . . . . . . . . . .5 Audio Output Meter TS-585A/U, Bottom View of Chassis. . 7 2Audio Output Meters TS-585B/U, C/U and D/U . . . . . . . . . . . . 9 3Audio Output Meter TS-585B/U, Bottom View of Chassis.. 11 4Audio Output Meter TS-585C/U, Bottom View of Chassis. . 13Audio Output Meter TS-585D/U, Bottom View of Chassis. . 15 6Audio Output Meter TS-585B/U, C/U and D/U, Case
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 7Sect ion I I I . Special Tools List (Not applicable)
IV. National Stock Number and Part Number Index . . . . . . . . . . . 18
*This manual supersedes TM 11-6625-291-40P dated 29 April 1977.
i/(ii blank)
5
1
TM 114825=2914(IP
SECTION I
INTRODUCTION1. Scope
This manual lists spares and repair parts;special tools; special test, measurement, anddiagnostic equipment (TMDE), and other specialsupport equipment required for performance ofGeneral Support maintenance of the TS-585A/U,TS-585B/U, TS-585C/U and TS-585D/U. Itauthorizes requisitioning and issue of spares andrepair parts as indicated by the source andmaintenance codes.
2. General
This Repair Parts and Special Tools List is dividedinto the following sections:
a. Section Il. Repair Parts List. A list of sparesand repair parts authorized for use in the perfor-mance of maintenance. The list also includesparts which must be removed for replacement ofthe authorized parts. Parts lists are composed offunctional groups in numeric sequence, with theparts in each group listed in figure and itemnumber sequence.
b. Section Ill. Special Tools List. N o tapplicable.
c. Section IV. National Stock Number and PartNumber Index. A list, in National item identifica-tion number (NIIN) sequence, of all National stocknumbers (NSN) appearing in the listings, followedby a list, in alphameric sequence, of all partnumbers appearing in the listings. National stocknumbers and part numbers are cross-referencedto each illustration figure and item numberappearance.
3. Explanation of Columns
a. Illustration. This column is divided asfollows:
(1) Figure number. Indicates the figurenumber of the illustration on which the item isshown.
(2) Item number. The number used to iden-tify item called out in the illustration.
b. Source, Maintenance, and Recoverability(SMR) Codes.
(1) Source code. Source codes indicate themanner of acquir ing support i tems formaintenance, repair, or overhaul of end items.Source codes are entered in the first and secondpositions of the Uniform SMR Code format asfollows:
Code Definition
PA —Item procured and stocked for antici-pated or known usage.
XB — Item is not procured or stocked. If notavailable through salvage, requisition.
NOTE
Cannibalization or salvage may beused as a source of supply for any itemssource coded above except thosecoded XA and aircraft support itemsas restricted by AR 750-1.
(2) Maintenance code. Maintenance codesare assigned to indicate the levels of maintenanceauthorized to USE and REPAIR support items. Themaintenance codes are entered in the third andfourth positions of the Uniform SMR Code formatas follows:
(a) The maintenance code entered in theth i rd pos i t ion wi l l ind icate the lowestmaintenance level authorized to remove, replace,and use the support item. The maintenance codeentered in the third position will indicate one ofthe following levels of maintenance:
Code Application/Explana tion
O — Support item is removed, replaced,used at the organizational level.
H — Support item is removed, replaced,used at the general support level.
1
(b) The maintenance code entered in thefourth position indicates whether the item is to berepaired and Identifies the lowest maintenancelevel with the capability to perform completerepair (i.e., all authorized maintenance functions).This position will contain one of the followingmaintenance codes:
Code Application/Explana tion
Z – Nonreparable. No repair is authorized.
(3) Recoverability code. Recoverabilitycodes are assigned to support items to indicatethe disposition action on unserviceable items.The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows:
RecoverabilityCode Definition
Z - Nonreparable item. When unser-viceable, condemn and dispose atthe level indicated in position 3.
c. /Vational Stock Number. Indicates the National stock number assigned to the item and willbe used for requisitioning purposes.
d. Federal Supply Code for Manufacturer(FSCM). The FSCM is a 5digit numeric code listedin SB 70841/42 which is used to identify themanufacturer, distributor, or Government agency,etc.
e. Part Number. Indicates the primary numberused by the manufacturer (individual, company,firm, corporation, or Government activity), whichcontrols the design and characteristics of theitem by means of its engineering drawings,specifications, standards, and inspection re-quirements to identify an item or range of items.
NOTE
When a stock numbered item is requisi-tioned, the repair part received mayhave a different part number than thepart being replaced.
f. Description. Indicates the Federal itemname and, if required, a minimum description toidentify the item. In the Special Tools List, the in-itial basis of issue (BOI) appears as the last line in
the entry for each special tool, special TMDE, andother special support equipment. When density ofequipments supported exceeds density spread in-dicated in the basis of issue, the total authoriza-tion is increased accordingly.
g. Unit of Measure (U/M). Indicates the stan-dard of the basic quantity of the listed Item asused in performing the actual maintenance func-tion. This measure is expressed by a two-character alphabetical abbreviation (e.g., ea, in, pr,etc). When the unit of measure differs from theunit of issue, the lowest unit of issue that willsatisfy the required units of measure will berequisitioned.
h. Quantity Incorporated in Unit. Indicates thequantity of the item used in the breakout shownon the illustration figure, which is prepared for afunctional group, subfunctional group, or anassembly. A “V” appearing in this column in lieuof a quantity indicates that no specific quantity isapplicable, (e.g., shims, spacers, etc).
4. Special Information
a. Usable on codes are shown in the descriptioncolumn. Uncoded items are applicable to allmodels. Identification of the usable on codesused in this publication are:
Code Used On
AGM TS-585A/UAGN TS-585/BUAGO TS-585C/UATX TS-585D/U
b. The following publications pertain to theTS-585A/U, TS-585B/U, TS-585C/U and TS-585D/Uand its components:
TM 114825-291-14 Output Meters TS-585A/U,TS-585B/U, TS-585C/U and Audio Level MeterTS-585D/U.
TM 11-6625-291-20P Output Meters TS-585A/U,TS-585B/U, TS-585C/U and Audio Level MeterTS-585D/U.
c. National stock numbers (NSN’S) that aremissing from P source coded items have been ap-plied for and will be added to this TM by futurechange/revision when they are entered in the
2
TM 11-6625-291-40P
TM 11-6625-291-40P
Army Master Data File (AMDF). Until the NSN’Sare established and published, submit exceptionrequisitions to Commander, US Army Communi-cations-Electronics Command, ATTN: DRSEL-MM, Fort Monmouth, NJ 07703 for the part re-quired to support your equipment.
5. How to Locate Repair Parts
a. When National stock number or part numberIs unknown.
(1) First. Using the table of contents, deter-mine the functional group within which the itembelongs. This is necessary since illustrations areprepared for functional groups and listings anddivided into the same groups.
(2) Second. Find the illustration covering thefunctional group to which the item belongs.
(3) Third. Identify the item on the illustrationand note the illustration figure and item number ofthe item.
(4) Fourth. Using the Repair Parts Listing,find the figure and item number noted on theillustration.
b. When National stock number or part numberis known.
(1) First. Using the Index of National StockNumbers and Part Numbers, find the pertinentNational stock number or part number. This indexis in NIIN sequence followed by a list of partnumbers in alphameric sequence, cross-referenced to the illustration figure number anditem number.
(2) Second. After finding the figure and itemnumber, locate the figure and item number in therepair parts list.
6. Abbreviations
Not applicable.
3
TM 11-6625-291-40P
FIGURE 1. AUDIO OUTPUT METER TS-585A/U
4
SECTION II TM 11-6625-291-40F(1)
ILLUSTRATION(A)FIGNo.
1111111111
(2)
SMRCODE
XBHZZPAHZZPAHZZPAHZZPAHZZPAHZZPAOZZPADZZPAHZZPAHZZ
(3)
5305-00-050-20965970-00-356-04665310-00-595-72375305-00-889-31165930-00-254-01715930-00-567-95755355-00-160-68635305-00-889-3002<
5310-00-045-3299~
(4)
FSCM—
17870969060684096906969067685472512725129690696906
A11168-2MS246622-1257-8410MS35333-42MS35206-21346271DH141094104MS35206-242MS35338-42
GROUP 00 OUTPUT METERS TS-585A/U,TS-585B/U AND TS-585C/U ANDMETER, AUDIO LEVEL TS-585D/U
POST,. BINDING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..AGNSCREW, MACHINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . AGN,AGO,ATXINSULATOR, BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AGNWASHER, FLAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SCREW, MACHI NE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SWITCH, ROTARY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. AGH, AGN,AGOKNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SCREW, MACHINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .WASHER, LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5
TM 11-6625-291-40P
FIGURE 2. AUDIO OUTPUT METER TS-585A/U, BOTTOM VIEW OF CHASSIS
6
(1)
ILLUSTRATION
(a)FIGNO.
2
2
2
2
2
2
2
2
2
2
—(b)ITEMNO.—
10
—
SECTION II
(2)
SMRCODE
PAHZZ
PAHZZ
PAHZZ
PAHZZ
PAHZZ
PAHZZ
PAHZZ
PAHZZ
PAHZZ
PAHZZ
(3)
NATIONALSTOCK
NUMBER
9505-00-279-1878
6625-00-265-6665
5905-00-539-2567
5915-00-405-0167
5985-00-279-2393
5915-00-405-0166
5905-00-104-8349
5905-00-935-8545
5905-00-111-4744
(4)
FSCM
81349
81349
98824
81349
17870
17870
17870
81349
81349
81349
(5)
PARTNUMBER
CP29AIEF503M
RC20GF243J
301
RV4LAYSA252A
2981-1
83513-3
1519
RCR20G511J5
RCR20G183JS
RCR20G512JS
TM 11-6625-291-40P
(6)
Description
UNABLE ON CODE
CAPACITOR, FIXED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..AGM
RESISTOR, FIX ED..... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AGM
METER, AUDIO LEVEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..AGM
RESIST OS, VA RI ABLE.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AGM
NETWORK, INPEDANCE.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..AGM
ATTENUATOR, VARIABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AGM
TRANSFORMER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..AGM
RESIS TOR, FIX ED, COMP.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..AGM
RESlSTOR, FIXED, COMP.... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..AGM
RESISTOR, FIXED, COMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AGM
7
—
1
1
1
1
1
1
1
1
1
2
TM 11-6625-291-40P
FIGURE 3. AUDIO OUTPUT METERS TS-585B/U, C/U, AND D/U
TM 11-6625-291-40P
9
S E C T I O N I I
TM 11-6625-291-40P
10
FIGURE 4. AUDIO OUTPUT METER TS-585B/U, BOTTOM VIEW OF CHASSIS
TM 11-6625-291-40P
TM 11-6625-291 -40PS E C T I O N I I
1 1
TM 11-6625-291-40P
FIGURE 5. AUDIO OUTPUT METER TS-585C/U, BOTTOM VIEW OF CHASSIS
1 2
S E C T I O N I I TM 11-6625-291-40P
1 3
TM 11-6625-291-40P
FIGURE 6. AUDIO OUTPUT METER TS-585D/U, BOTTOM VIEW OF CHASSIS
14
S E C T I O N I I TM 11-6625-291-40P
1 5
TM 11-6625-291-40P
FIGURE 7. AUDIO OUTPUT METERS TS-585B/U, C/U, AND D/U, CASE ASSY
1 6
S E C T I O N I I TM 11-6625-291-40P
1 7
1 8
SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX TM 11-6625-291-40P
19/(20 blank)
SECTION IV NATIONAL STOACK NUMBER AND PART NUMBER INDEX TM 11-6625-291-40P
By Order of the Secretary of the Army:
JOHN A. WICKHAM, JR.General, United States Army
Chief of Staff
Official:
ROBERT M. JOYCEMajor General, United States Army
The Adjutant General
DISTRIBUTION:To be distributed in accordance with DA Form 12-36B requirements for
TS-585A-D/U.
✩ U.S. GOVERNMENT PRINTING OFFICE : 1993 0 - 342-421 (62035)
PIN : 0 2 3 1 8 8 - 0 0 0