The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

17
The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution Zaki Ahmad * , Anwar Ul-Hamid, Abdul-Aleem B.J. Department of Mechanical Engineering, King Fahd University of Petroleum and Minerals, Dhahran 31261, Saudi Arabia Received 28 June 1999; accepted 5 September 2000 Abstract Alloying with scandium has a strong in¯uence on the strengthening and weight saving characteristics of Al±2.5Mg alloys. Scandium addition 0.1±0.3 wt.%) to Al±2.5Mg alloys does not introduce any appreciable loss in their resistance to corrosion in 3.5 wt.% NaCl. The corrosion behavior of these alloys is not signi®cantly aected by age hardening. Because of a unique combination of outstanding mechanical properties and a good resistance to corrosion Al±Mg alloys containing scandium represent a major improvement over the more familiar Al± Mg alloys. Ó 2001 Elsevier Science Ltd. All rights reserved. Keywords: Corrosion; Al±Mg±Sc; Age-hardening; Microstructure; Pitting potential; Polarization 1. Introduction The quest for high performance aluminum alloys has led to the emergence of new alloys such as Al±Be, Al±Li, Al metal matrix composites MMCs) and powder met- allurgy 7xxx and 2xxx series alloys. The family of Al±Li alloys oers the potential for weight savings in aircraft structures due to density reduction and stiness im- provement [1,2]. An alternate to lithium is magnesium, a strong solid solution strengthener, however, it has not been possible to produce competitive Al±Mg alloys that would match the level of strength, despite signi®cant density reductions. www.elsevier.com/locate/corsci Corrosion Science 43 2001) 1227±1243 * Corresponding author. Tel.: +96-63-860-2540; fax: +96-63-860-2949. E-mail address: [email protected] Z. Ahmad). 0010-938X/01/$ - see front matter Ó 2001 Elsevier Science Ltd. All rights reserved. PII:S0010-938X00)00147-5

Transcript of The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

Page 1: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

��� �������� ������� � ������� ������� ������ � ������ ������ �������� �������

���� ����� �� ���� ��������� ���������� !"!

���������� ��� ������ ������������ ���� �� � ���������� �������� ��� ��������� � � ��� ������

���� !��"��

#������� �$ "�� %&&&' ����(��� � )�(����� ����

��������

������* ���� ������� ��� � ����* �+���� � ��� ����*����* �� ���*�� ����*

��������������� � ��#�!�,* ������! )������ ������� -�!%.�!/ ��!01 �� ��.�!�,* ������ ����

�� �������� �� �((������� ���� � ����� ��������� �� �������� � /!� ��!0 2�3�! ���

�������� ������� � ����� ������ �� �� ��*�4����� �5����� � �*� ������*! ������ � �

��6�� �������� � ��������* ��������� (��(������ �� � *��� ��������� �� ��������

��.,* ������ ������* ������� ��(����� � ��7�� ��(������� ���� ��� ���� ������� ��.

,* ������! � ���% 8������� )����� 9��! ��� ��*��� ��������!

���$���% 3�������' ��.,*.)�' �*��������*' ,�������������' :����* (�������' :�����;����

� ���� ������

��� 6���� �� ��*� (�� ������ ������� ������ ��� ��� �� ��� ����*��� � �������� ���� �� ��. �� ��.9�� �� ����� �����< ���(������ -,,3�1 �� (����� ���������*� =<<< �� �<<< ������ ������! ��� ����� � ��.9� ������ �5��� ��� (������� �����*�� ����*� � ������ � ���������� ��� �� ������ �������� �� ���5��� ���(������� >%��?! � �������� �� ������� �� ��*������ � ����* ����� �����������*������ �������� �� ��� �� �� (������ �� (������ ���(������� ��.,* ���������� ����� ����� ��� ����� � ����*��� ���(��� ��*�4��� ������ ���������!

���!��������!���@������@������

3������� )����� A/ -���%1 %��=.%�A/

�3�����(���* ������! ���!B C&D�D/�$D����A�' �<B C&D�D/�$D���&A&!

�&���� �������% �����;E� �(�!���!�� -�! �����1!

��%��&/$F@�%@G � ��� ��� ������ � ���% 8������� )����� 9��! ��� ��*��� ��������!

:HHB )��%� �&/$F-�� 1��%A=��

Page 2: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

)������ ��� � �(����� ��*�4���� �� �� �<����� ��� ����*����* ����� � ��� �������* ������� -,*� 3�� �� )�� ,� ���!1 � ������� ������ >/�A?! � ��.,* �����������* �!/ ��!0 )� ������ � ����� ����*�� � /�� ,:�� ����� ����� �������*�� � �������� ��� ������ >�?! ��� ���������� �������� � (��(������ �����*�� ���� � ��� ��/)� (����(����� ���� �� ����� ��� ��(������������ ��������� �������� ���(�������� >D?! ��� ����*����* �5��� �((���� ��� ���� ��(����������)� ����� -�!�.�!D ��!01! �������� ��� ������� � ;������� �� ������� ����� ��(������ �� ���� ��� ���� (��(������ ���� � ������ ������� ����� -�!%.�!%� ��!01>=?! ��� �<����* (������� � ������� � ��.,*.)� ������ �� ������� ����� � �<������� �������� � (������� �� ��������� (��(������ ������� �� �������� ����� ������� (�� ������ � ��������� ��������! H� �� ����� ��� � (���� ������� ���������� ��� �������� (�� ������ � ��.,*.)� ������! :��������� ������*��������� ����� ��� �������� �� ����� ��� �������� ������� � ����� ���� ������*������� �������� � /!� ��!0 � ������ ��������! ��� �������� ������� � ����������� ��� �� �� (��������� ������*����!

� ������������ ����� �

������� ������ ���� ���� �!% �� �!/ ��!0 )� �������� ���� ���� � ������������* � � �����������;�� ������ ������� ���� � ��*� �����(����! ������*���� ������� (����� ��� �������� � ��������� ���� ��� *�������� � 9�����,������ % I�����! ��� ������� (����� ��� ������� � � ��� � (��� ��������� (������ �� ��� ��� ������ �� ��((�� � � ���� ������� � ��*�! ��� ����� �������� ���� � � ��((�� ����! ��� ���(��� ������ ��� ��� ������ ���� ������ �� J���(���! )������� ���(��� ���� �*�� � � ��� ��� �� %�� %��� %�/ �� %�A ��! �������� ��������;�� �� % � �� A$��3 (���� �� �*�* �� �&��3!��� ����� ���(������� � ��.,*.)� ������ �� ����� �������� ������� ���

���� ������� � ���� ���� ��� *��� � ���� %!����� ������� ������� �� ����*���� �� ����� % ������� ������ ������* ����

���� � ����������� ��*�* ��� �!% �� �!/ ��!0 ��� ����*���� �� ������ �� / ��A ���(��������!

� �������� �����������

)(������ �������* %� �� � �������� ���� ���� �� ��������������� �������*���� �� ���*�� ���� �������! ���� ���� (������� ���� /��� A�� �� D�� �� )�3(�(�� ���* ���������;�� ����� �� �������! J��� (������* ��� ��� ���� � D �������� (����! ��� �(������ ���� ������ ���� ���������;�� ������ ����� ���������� �� ����� �� %� � � ��� ���!

% 9����� ,����� . K��(���;;������ #���� �� :��� ��� �D� ����$�� �������!

%��$ '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 3: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

� ������������ ����� ���

+(�( 0��� � ��� �������

��� ���� � �������� � ��� �������� (������ � �<(����� ��� ���������� ������� ���*�� ���� ������ � ��������� ���� �)�, I/%�=� (������� >$?!)(������ � 6�����(������ ���� ����!

+(�( �����1���� ������������

��� (������������ (�����;���� ����������� ���� ���� � ��������� �����)�, ������� (������� I��$= >&? -������� (������� �� ������ (������������(�����;���� ����������1!��� �(����� �� (�����;�� �� % � �� �%��� �L ���� ���(��� �� � ��������� �������

��������� � /!� ��!0 2�3�! :�����;���� �� �������� �� � ��� ���� � %� �L@���� ������� � ��� ��� �������� ���� � ����( ���� � ��� ������� �������* ������� � (����*� �� �������! ��� ��� �� �������� � ��� �� ������� ��� (����* (��������� ������� � ��� ������� �������� ���� ��� ������ ���(� �� � ���� ����� �����!��� (�������� (������� -�((1 �� ��������� � ��� ���������� � ��� ������� �����(�����;���� ����� ���� ��� ������ ����� (�����;���� �����!

+(�( ������������� �2��������

��� ��� ��� ���(����*� � ��� �������� ���(��� ��� ������*���� � � ����*������� ��������(�! ,������������� ������� ���� �������� � � 8M) ������ ����F���� ��((�* ��(��������! )(������ ���� *���� ���� /��� A�� �� D�� *��� ��;�������� �� (������� ���� � D �� ������ (����! )(������ ���� ����� �� %���� �� (�� � � ���(��� �� ���� � �������� � D� ��! J�� 4�� ����* � %� �L�� ��� ���� ��*�����*� *� �� %� ��� ��� ��� ��� ��� �((���� � ��� ����� ����(�� ������ ��������!

���� %

2����� ���(������ � ������� ������

����� ��(� )� J� 3� , ,* 3� � �� )� �� �����

D�D% �!D . �!�= %!� %!� �!% �!�� �!% . . ��

���� �!�� �!A� �!% �!�% �!� �!%� �!% �!&A . . ��

D�%/ �!D �!� %!� �!$ �!$ �!% �!�� �!% . . ��

��.�!�,*.

�!%)�

�!�� �!A� �!% �!�% �!� �!%� �!% �!&A �!% �!& ��

��.�!�,*.

�!%�)�

�!�� �!A� �!% �!�% �!� �!%� �!% �!&A �!%� �!& ��

��.�!�,*.

�!/�)�

�!�� �!A� �!% �!�% �!� �!%� �!% �!&A �!/� �!& ��

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %��&

Page 4: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

� ������� �� ���������

3(�( ��� ������ ���������

��� ��������� (��(������ � ��.,*.)� ������ ��� (�������� �5����� � ������*������� � ,*� ��� �� �� )�! ,�*����� �������� ��� ����*�� � /� ,:� �� ����������� � %0 >%�?! �������� ������ ������������;���� �� ���� �� � ����*�����!)������ �������� ��� ����*�� � �� ,:� �� ���� �!%0 ������� >=?! ������� ������ �� � *��� ��4��!9������ ������� � ��� ��������� (��(������ � ��� ��� ������ ���� ��������!

��� �������* ����� / �!� ���� �<������ ��� � �! �������� ������ �� ��7������� ����� � ��������� ���� �)�, �����* (��������� >$�&?! ��� ������� ��� ��������;�� � ���� �! ��� ������� �������� ��� ��� �� �5��� � )� �� � (��������*�����! H� ��� �� ���� � ����� ������*����� ���� ������� �������(������� ��� ���� ����� ������� �������� �� ��*� (�� ������ ������� ����������� ��������� ��5�� ��� ��*������� � ��������� (��(������ �� �������� ����(�������� >%%?!

3(�( ������������� ��� ������ ��� ���

,�������������� ��������� (��� � ������ ���� � ��� �������� � ��.,*.)�������! J�*! % ����� ��� �������������� � ��.,*.�!%�)� ����� � ��� �*� ������* �� %�A ��! ��� �����*���� (����(����� ���������� ����� J�� )� �� �� �� ����� 8M) �������! J�*! � ����� ������ (����(����� -�����1 ������* ��� )� �� ��!��� ���������� � 4� (����(������ � ��/)� �� ����������� ��� ���� � �8,�����*��(� -J�*! /1! ��� (��* ��� � ��� *��� �������� � ��/)� (����(�������� ���� � J�*! A! ��� ���� ���������� ��� ��((����� � ����� ������*����� ����������� ������� �8, ������� >D�%%�%�?!

3(�( *����� �������

��� �������� ������� ���� ������� � ��� (����B ���*�� ���� ������� �� ���������������� �������! ��� ���*�� ���� ������� �������� � /!� ��!0 2�3� ������ ������� �������� ���� ��������� ���� �������� �<(����� (�����! J�� ������� ��� ��������� ���� � ����� ������* �!% ��!0 )� ��������� ��� �!A �� %!AA ��� -�!�/$ ��

���� �

,�������� (��(������ � ��.,*.)� ������

2�! ����� ����*���� N���� ����*�� -���1 �������� ������ ����*�� -���1 8��*���� -01

% ��.�!�,* �/ /% %A

� ��.�!�,*.�!%)� �&!/ /$!� %�!�

/ ��.�!�,*.�!%�)� /%!/ /&!� &!�

A ��.�!�,*.�!/�)� /= A%!� &!�

%�/� '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 5: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

�!��/ ��@����1 � ��� � �<(����� (����� � $�� �! ���� ���� �� ������ � ��.,*������ �� �� �� ��������� �� ��� ���� ���� �( � � ��(��< (��������� 4�� � ������������� -�����O/ � /��O1 �� ������� -�����O/ ���O1! � ������ ����� �� ���������� ��� ���� � �<��� ������� �� ��� ������� �<��� ���� ��� 7��� �6���� ��� ����� �<��� ���������� �� ��� �<��� ������� ���� ��� >%/?! ��� ����� � ��(��< 4�� ����� ��� ��7��� � ������� �������� � ��� (��� >%/�%A?! ��� ��� ��� � ����� � ���

J�*! %! )8, ���*� � ��.�!�,*.�!%�)� ����� � ��� �*� ������* �� %�A �� �� �D��3! ��� (����(���������� ��� (������ � J�� )� �� ��!

J�*! �! )8, ���*� � ��.�!�,*.�!%�)� ����� �����* ��� (����(����� ������� � ��� �� �� )�!

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %�/%

Page 6: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

�����4�� �� � ������� � � 4�� � ������� � ��� ����* �� ���� � J�*! �! ����������� ���� � ������ ������* �!%.�!/ ��!0 )� ������ � �������� � /!���!0 � 2�3� �� A�� � ��� *��� � ���� /! ����� �� �� � �((������� ������� ���� �������� ���� � ������� � �!% �� �!%� ��!0 )�! ��� ����� �� � ���*�� ��������� ��� �������� ���� � ������� � �!/ ��!0 )� �� �� ������� ���������! ����������� ���� � ��� ����� ���� ��5���� ������ � ������� ������ � (�����;����������� �� ���� � ����� A �� �! )������� (�����;���� ������ ��� ���� � J�*! D!H� �� ������� ��� ����� A �� � ���� �*� ������* ���� �� ���� � (��������5��� � ��� �������� ��������� � ��� ������! 9������ ������� ���� �!/ ��!0 )������� ��� ���� �������!��� �������� ���� �� �������� ���*���� � ����* �!%.�!%� ��!0 )�� �������� ���

������� �� �� ��*�4���! )������ ������� ���� �� �((��� �� ������� ��� ��������� ���� �� ����� ������� � ��������� ������� ������ �� ���� � �����(���� �������� ����� � ������ ����� ����� D�%/ �� D�D% � ������� ���������-���� D1 � /!� ��!0 2�3�! H� �� � ������� ���� ��� �������� ����� ��� �������6��� �� ����� ��� ��� �������� ����� � ���� ������� ������� ������ � ���������������!

J�*! /! �8, �����*��(� � ��.�!�,*.�!/)� ����� �����* � ��*� ���������� ������ �� ��� ��*���

��������!

%�/� '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 7: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

3(�(�( !��& ����������� �5��� � �*�* �������� � ��� (����* (������� � ��� ������ �� ���� �

���� =! ��� �5��� � �*� ������* � ��� �������� ����� �� �� ���� ��*�4��� ������ � ��� ������ (�����;���� ���*���� -J�*! =1! ��� (����* (�������� ��� ��

J�*! A! �8, �����*��(� � ��.�!�,*.�!/)� ����� � ��� %�A �� �� �D��3 �����* ��� (��* ��� �

��*��� ������ � ��/)� (����(�����!

J�*! �! )8, ���*� �����* ��� ��� ��� � ��.�!�,*.�!%�)� ������� � ���������� ������� � ��� ����*!

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %�//

Page 8: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

��*�4����� �5����� �� ���� � ��� ��(���� ������� � ����� � -���� =1! ,������������ ����������� �������� ���� ��.�!�,* ������ ������* �!%.�!/ ��!0 )���� �� ���� ���(����� �� �*� ������*! ���� �� ����������� � J�*! $ ����� �����

���� /

3������� ���� � ��.,*.)� ������ � /!� ��!0 � 2�3� ������ � ���*�� ���� �����6�� -� ��� A�� �1

����� 3������� ����

��@���� ����

��.�!�,* �!��/ %!A==

��.�!�,*.�!%)� �!�/% %!&$�

��.�!�,*.�!%�)� �!�AD �!&%A

��.�!�,*.�!/�)� �!�/$ �!AD

���� � �����*���� (�� �6���� ��������� (�� ���!

���� A

)������ � ������� � (�����;���� ��������� ���������� � ��.,*.)� ����� � /!� ��!0 2�3�

)��(�� ��(� �� ������*

����

�-� � �1 -�L1 �( -�����1 � -�@���1 3������� ����

��@���� �(��

��.�!�,*.�)� -� ��1 ��&�!% %!%�8��A A!�=8��D �!��� %!&D

��.�!�,*.�!%�)� -� ��1 �$=$!% =!A�8��/ =!%�8��D �!�/$ %!���

��.�!�,*.�!%�)� -� ��1 �&��!& &!%=8��/ $!&&8��D �!��A �!%/�

��.�!�,*.�!/�)� -� ��1 �D&=!/ �!%&8��A D!%&8��D �!��A �!%/�

��.,*.�!%�)� -%� ��1 �$=D!� �!&�8��/ %!�&8��D �!�/& %!�A%

��.,*.�!%�)� -%�� ��1 �$�=!= =!=�8��/ A!//8��D �!��� %!&$%

��.,*.�!%�)� -%�A ��1 �$D�!D =!A%8��/ �!$&8��D �!�DA �!�/

��(� � ���� (�� ����!

���� �

)������ � ������� � (������������ (�����;���� -��J89 �������1 � ��.,*.)� ����� � /!� ��!0

2�3�

)��(�� ��(� ��

������* ����

��� � ��-�L1

��3� -�L@

������1

3�3 -�L@

������1

� -�@���1 3������� ����

��@���� �(�

��.�!�,*.�)� -�

��1

�$$�!�%��!&

�&D!D A!�%8��D �!��� %!&/D

��.�!�,*.�!%�)�

-� ��1

�$=$!%���!%

/�D!� D!DD8��D �!�=/ �!$�=

��.�!�,*.�!%�)�

-� ��1

�&�D!=/D/!D

/&$!% �!�%8��D �!�D� �!/DD

��.�!�,*.�!/�)�

-� ��1

�D/%!A&&�!�

$=�!� A!/%8��D �!�/� %!%$A

��.,*.�!%�)� -%�

��1

�$==!/%�D!&

%=D A!DD8��D �!�A& %!&%=

��.,*.�!%�)� -%��

��1

�=$D!$&�!/

AD�!/ D!�/8��D �!�=� �!=�D

��.,*.�!%�)� -%�A

��1

�$/$/�&!$

/�&!$ �!/�8��D �!�D$ �!D&

���3 . ����� �� �� ������! 3�3 . �������� �� �� ������!

%�/A '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 9: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

��� �5��� � �*�* ���� � �������������! J������ ���� ���� ��*� ����������� � )� -�!/.�!D ��!01 �� � (��*����!:����* ������� ���� �������� � ��� �������� �)�, ������ (�����;����

�����6���! � ��(���� ������ (�����;���� ���*��� �� ���� � J�*! &! ��� ���*���

J�*! D! 3����� (������������ (�����;���� ���*��� � ��.�!�,*.)�-�!%.�!/1 ������ � /!� ��!0 �

2�3�!

���� D

3������� ����� � ���������� ������� ������

����� ����*���� 3������� ���� -��@����1

D�D% �!%�& >%�?

���� -� ��1 �!�=% >%D?

/��/ �!�=� >%D?

D�D/ �!%�& >%D?

D�%/ �!�$& >%=?

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %�/�

Page 10: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

����� (����* (������� -�(1� (�������� (������� -�((1 �� �������� (�������-�����1! :����* (������� -�(1 �� ��� ��(�������� �<(�������� ���������� ��������������� � (�� ��������! :�������� (������� -�((1 �<���� ����� ��� �<��� ������������ �� �����������! :��� �� �� ������� �� (��(�*��� ���� �((! �� ��� (����*(������� -�(1 �������� (����* �����(������� ���������! ��� (����* (������� -�(1 � ��� ��� ������ �� ���� � ���� $!)������ )� ����� �� ���� � ������ % �� � ���� �� �5��� ��� (����* (�������!

��� (����* (������� ���� �� ����� ���� �*����� ���� �������* )� ����� ��

���� =

:����* (������� -�(1 �� (�������� (������� -�((1 � ��.�!�,*.�!%)� ����� � /!� ��!0 2�3� �*�

������� �� %�� %�� �� %�/ ��

)��(�� �( -L1 �(( -L1 ����� -L1

�� �������� ��!=D% ��!$�D ��!$/%%� �� ��!D/$ ��!$�$ ��!=��%�� �� ��!=/� ��!$�� ��!$%�%�/ �� ��!=A/ ��!$/� ��!$A&

J�*! =! 3����� (������������ (�����;���� ���*��� � ��.�!�,*.�!%)� ����� �����* ��� �5��� �

�*� ������*!

%�/D '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 11: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

���� � ����� A! � ���� �*����� (������� ��*�4�� � ������ ������� ���������� � (��� >%D?! ��� (����* (������� �<������ � ��� ������ ���� ��� ������������ ����� � ���� �*����� �� �( �� *��� (����* (�� ������! ��� (����* (��������� � ��.,*.)� ������ �� / �� A ��� (������� �� ����� � ��� �������! ��� (����*

J�*! $! L������ ������� �� �*� ������* ���� -��1 �� ��.�!�,*.�!%�)� �����!

J�*! &! :������� ������ (�����;���� ���*��� �� ��.�!�,*.�!%�)� � /!� ��!0 2�3�!

���� $

:����* (������� -�(1 �� (�������� (������� -�((1 � ��.�!�,*.)�-�.�!/1 ����� � /!� ��!0 2�3�

����� �( -L1 �(( -L1 ����� -L1

��.�!�,*.�)� ��!��% ��!D&= ��!DA/��.�!�,*.�!%)� ��!�=$ ��!=%/ ��!D�&��.�!�,*.�!%�)� ��!�%$ ��!D&A ��!D�$��.�!�,*.�!/�)� ��!D=� ��!=�& ��!=A�

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %�/=

Page 12: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

(�������� � ���� �������� ������� ������ ����� ��� ��� �� �<���� � *������������ �� (����* � /!� ��!0 2�3� ��� *��� � ���� & �� ���(�����!H� �� ������� ���� ��� (����* (������� � ������ �� / �� A ��� �� ����� �6��� �� ��

���� (������� ���(���� �� ��� (����* (������� � ������ ������ � ���� &!��� (����* ���(����*� � ��.,*.)� ������ �� ������� � )8, �� ���� �

J�*�! %�.%�! H���*���� ���(�� ���������*��(��� (��� ��� ������� � ��� ��� ��� � ������! ��� ��� ��� ���(����*� ���� �� ����� ���� � ������� � )� -�!/ )�1 �����!H���*���� ���������*��(��� (��� �� ���� �� ���� �����(������� (��� �� � ������� ������ A -�!/ )�1 -J�*! %�1! ��� (�� ��(��� � ��� ��� ������ ������*���� ��� ���� ����� %�!��� (��� � ����� ��� ��� �� / �� A ��� ������� �� ������� ���(���� �� ����� %

-����.� )�� J�*! %/1! ��� ��<���� (�� ��(��� ���(��� ������� ���� ��� (����*��(��� ������� � ��������� ������ D�D% �� D�%/ ��������� � ��� ������!#������ � ��� ������*���� ���� ���� ��.,*.)� ������ �5�� � *��� ��������� ��(����* � /!� ��!0 2�3�! H� ��� �� ���� � �8, ������� �������� ������� ������/)� (����(������ ��� � � ���� ����� ��;� -$.%� �1 �� ���� ��� ������� ���� ���

���� &

)������� �( ������ � ���� �������� ������� ������ � /!� ��!0 2�3�

����� ����*���� �( 4 �� )38 #� �����

�� D�D% ��!DD& >%=?

�� D�%/ ��!D$$ >%=?

�� ���A ��!�A� >%$?

�� �A�D ��!D&� >%$?

J�*! %�! :���������*��(� � ��.�!�,*.�!%)� �����* ���������*��(��� (����* -%���1!

%�/$ '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 13: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

J�*! %%! :���������*��(� � ��.�!�,*.�!%�)� �����* ���������*��(��� (����* -%���1!

J�*! %�! :���������*��(� � ��.�!�,*.�!%�)� �����* �����(������� (��� -%���1!

���� %�

:�� ��(��� � ��.,*.)� ������ � /!� ��!0 2�3�

����� �����*� (�� ��(�� -��1 ,�<���� (�� ��(�� -��1

% &� %$�

� �� %%�

/ =� %�$

A %$ /�

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %�/&

Page 14: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

�����< >%%?! O� ����� �<(��� ���� +��� �� ������ ������������� �� ��� (����(������@�<���@����������� ���� ��� � ��.,*.)� ������ ���(���� �� ������ ���A� D�D%�� D�%/ ����� ����� ���*� ��;� (����(������ � 3���� �� 3�,*���! H� ��� ������ ���� � ������� � ��;� � 3���� �� 3�,*��� (����(����� ��������� ��� (����*(������� �� �������� ��� �����(������� �� (����*! H� ��� �� ���� ���� ���*������ � ������������� � ����� �A�D (������ ������ ����� �� ������� (����* >%&?!��� (������ � 3�,*��� ������������ � �� �%�A ������ �<������ (����* ������� ������ ������������� ������� �� (����(�����@�<���@����������� ���� ��� >��?! ���(����* (������� -�(1 �� �������� (������� -�����1 ����� ���� �*����� ���� �������� � ��� (����(����� ��;�! ��� (����* (������� � ��.�!�,*.)� ������ �� ���*�������� (������� ��� ��� (����* (�������� � ������� ������ ���� � ���� & �������**���� ���� ��� (����(����� ��;� �� �� � � ��P���� ��;� �� �+���� ��� (����*(�������!,��� �������������� ������� ����� � ����� �� �������� ��� ���� � ��/)�

(����(����� � (����* ���(����*� � ��� ������! ��� ����������( ����� ��������������� �� (����* ���(����*� ��� �� �� ���� ���������� ��� � ���������������� ������! ��� ������� � ������*����� �� ���� ��� (����* ���(����*� � ������� ������ ��(��� �(� ��� ��������������� ������� � �����<� ������ �������������� ����� ���(������ �� ��;� � ����*����� � ����������! ���������������� (������ ������ ����� �� (�� ��������! ��� ������� � �<���4�� ����� ��� (��� �� ���� � J�*! %A! :��� ��� ������� � � ����� *��������(������ � ��-O�1/ ����� ������4�� �(� ����*! ��� ��-O�1/ *�� ��� �� � �������� � � �����(���(����� ������� ���� ��<���� �� ������ (���! 3�����* � (��� � ��-O�1/ ��� �� �� ����� �� �� *����� * ����� � ��� ���������� >�%?! ���*�������� ��-O�1/ ����� �� (��(�� ��� � (��� ����� �( ��������� �� ������ �

J�*! %/! :���������*��(� � ��.�!�,*.�)� �����* ���( ���������*��(��� (��� -%���1! � ��*��� ������

��������� �� �������!

%�A� '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 15: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

��� ��� � ����������* -J�*! %�1! H� ��� �������� �� � ���� ��� � ������;�� ���������!��� ������*����� �������� ���� ���� ���� ��.,*.)� ������ ���� � *���

��������� �� ������;�� ��������! ��� �� ���� � �������� ���(��� ���� ��� ���������* ��������� �� (������� (��(������ � ��� ������ ������� ������� ��������� ����� ������ ��� ��*��� (������* ����� ���������! �������� ������� ���� ���� �������������� ������� �������� ������� �� ����� �� ���� �<(���� ��� ���� � ������� � ������� ��*����� ������!

J�*! %�! :���������*��(� � ��.�!�,*.�!/)� �����* ��� ������* -%���1!

J�*! %A! :���������*��(� � ��.�!�,*.�!%�)� �����* ������* � (��� � *�������� ��-O�1/!

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %�A%

Page 16: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

� �����������

O ��� ���� � ��� ������� ������ ��� ��� ������*������ ��� ������* ��� ������ ���������B

%! ������� � �!%.�!/ ��!0 ������� ��������� � ���������� ��*� ����� � ����*�� ���.,* ������ �� ���� � ��� ��(�������� � ��������� (��(������!

�! :����(������ � ��/)� (����� � ��.�!�,*.)� ������ �5��� ��� �������� �������� ����� ������! ����� (����(������ ��� ���� ���(����� �� ��� ����*����* � ��������� �� ���� � ��� (��* ��� � ��� *��� ��������!

/! )������ ������� -�!%.�!/ ��!01 ���� �� �������� �� �((������� ������� ���� �������� ���� � ��.,* ������! ��.�!�,*.)� -�!%.�!/1 ������ �5�� � ����� ���������� �� �������� �� ���(���� �� ���� �5���� � ��(����� ���������� �������� ������ ���� �� ����� D�D%� D�%/� �A�D� ���!

A! ��� ��.�!�,*.)� ������ �<���� ����*���� ���������*��(��� (��� ���� ����� (����*��(���! ��� (����* (�������� � ��� ������ ��� ������� �� � ���� (������� ����(���� �� ���������� ��.,* ������!

�! ������ � � ��6�� �������� � ��������* ��������� (��(������ �� �*��� ��������� �� ��������� ��.�!�,*.)� -�!%.�!/1 ������ ��(����� � ��7�� ���(������� ���� ��� ���� ������� ��.,* ������!

����� �� !������

��� ������� ��� *���� �� �� M�! ������� 9�*� � ������� I������� )������� �� (������* ���� � ��� ��������� �� �� ��� ������� �������� ���(������! ���������� ��������*� ��� �<(�������� ���� �������� � ,�! ,! )����� 8*�����3������� 9�������� �� KJ�:,! Q� ��� ���� ���� �� �� ,�! �����#����� H!,������� �� ��� ��������� � �������*��(��� ���(�� (��(������! ��� ��((���(������� � KJ�:, �� ��*��� �((��������!

��"�������

>%? 9!�! Q������ �) :���� /D%&%$%� %&=�!

>�? ,!8! M����� )!L! :��������� 9!)! ���(���� )��! :��! M��� �D -%&$%1 /AA!

>/? ,!8! M����� "! M���������;� 9!)! ���(���� 3����! ������! �A -%&$A1 %/��!

>A? L!H! 8��*�� L!L! ��������� �!M! #�������� ,����! )��! ���� �������� /A -%&&�1 /=!

>�? !�! :������ �!J! ����� :! 2����� "! ,����! )��! /� -%&&�1 A��!

>D? #!#! )������� 3!9! "���� ,�����! ����! �%� -%&&�1 A�%!

>=? L!H! 8��*�� L!L! ��������� �!M! #�������� ,������������� ������������� O������ % -%&&�1 �A!

>$? �)�,B #��������� :������� I/%�=� -=$1 �� H������� 3������� �����* � ,������ ����

��� � )�������� ����! / �� �� :��� %�� %&&$!

>&? �)�,B #��������� :������� I��$= �� ,���* :������������ �� :������������ :�����;����

,���������� ���� ��� � )�������� ����! / �� �� :��� %�� %&&$!

>%�? M����� #! "���(� -8�!1� ������� �� ������� ������� �), )(������� ������� �),8� %&&D!

>%%? )! K������ �� ��! :���! )���! �/%% -%&&A1 �$D%!

%�A� '( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+�

Page 17: The corrosion behavior of scandium alloyed Al 5052 in neutral sodium chloride solution

>%�? 2! ����� ,!�! ��(���� "! ,����! )��! �� -%&$�1 /%%!

>%/? #!K! ����� :���! #���� )��! 9��! ��/D -%&�D1 D$!

>%A? "!8! M������ Q!8! #������ 3������� %� -%&�D1 /%!

>%�? )!2! ����� ,!K! )���((�� "! ,����! )��! �D -%&&%1 A&&%!

>%D? I! L����������� K!)! L����������� :���! H�! 3�*! ,������� 3�����! %&$=� (! %�$=!

>%=? �! ������ �! !"! ������ K�3)� :��7��� J��� #�(��� �#%A�D�� %&&&!

>%$? :!O! ���;������ 3������� AD -%&&�1 A��!

>%&? "!J! ,�H����� �!�! 9��� )!9! I�����*�� #!K! 3����� 3������� AD -%&&�1 %%!

>��? "!J! ,�H����� �!�! 9��� )!9! I�����*�� #!K 3����� �������� #�(���� 2)Q3� �# $=�/�D� %&$=!

>�%? �!M! �����*�� 8! 9�����;��� #!M! :���� 3�����! )��! �% -%&&�1 %!

'( ! ��� �� ��( ) *����� ������ +� ,�--�. ���/#��+� %�A/