The 22 - fiac-thailand.com
Transcript of The 22 - fiac-thailand.com
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
The 22nd Food Innovation Asia Conference 2020
“Innovation for Future Food and Nutrition Security”
18-19 June 2020
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
TABLE OF CONTENTS
Conference Program ............................................................................................................................. i
About Conference .............................................................................................................................viii
Organizing Committee ........................................................................................................................ ix
Sciencetific Committee ....................................................................................................................... ix
Competition Committee ...................................................................................................................... xi
Opening Remark: FoSTAT President ................................................................................................ xii
Welcome Message: Thammasat University ..................................................................................... xiii
Welcome Message: Mahasarakham University ................................................................................ xiv
Welcome Message: Ubon Ratchathani University ............................................................................ xv
Keynote Speakers ............................................................................................................................... 16
Keynote Speakers: Prof. Dr. Chris Elliott .......................................................................................... 17
The global food supply system: the massive challenges (and opportunities) caused by COVID-19
........................................................................................................................................................ 17
Keynote Speakers: Prof. Dr. Weon-Sun Shin .................................................................................... 18
Future perspectives for active ageing ............................................................................................. 18
Keynote Speakers: Assist. Prof. Dr. Takeshi Zendo .......................................................................... 19
Bacteriocin-producing lactic acid bacteria : their production, application and future research trend
for food industry............................................................................................................................. 19
Keynote Speakers: Prof. Dr. Tuantong Jutagate ................................................................................ 20
Biodiversity for food security: The Mekong fish perspective ....................................................... 20
Division A .......................................................................................................................................... 21
Food Chemistry, Nutrition, and Analysis ...................................................................................... 21
O5-AB ................................................................................................................................................ 22
Pepsinogens and pepsins from lizardfish (Saurida micropectoralis) stomach: Purification and some
biochemical properties ................................................................................................................... 22
O15-AB .............................................................................................................................................. 23
Gelation of threadfin bream ( Nemipterus spp. ) surimi with various NaCl contents under high
intensity ultrasound ........................................................................................................................ 23
O57-AB .............................................................................................................................................. 24
Purification, Identification and Characterization of Antioxidant Peptides from Tilapia
(Oreochromis niloticus) Protein Hydrolysate ................................................................................. 24
O104-AB ............................................................................................................................................ 26
Chemical and Functional Properties of Banana Flour (Kluai Namwa) at Different Ripening Stage
........................................................................................................................................................ 26
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
O17-AP .............................................................................................................................................. 27
Separation and characterization of fat, protein and chitosan from Eri silkworm pupae (Philosamia
ricini) .............................................................................................................................................. 27
O66-AP .............................................................................................................................................. 28
Antioxidant properties of mulberry leaf using ultrasound-assisted extraction .............................. 28
O67-AP .............................................................................................................................................. 29
Effect of Extraction Conditions on Bioactive Compounds of Barley (Hordeum vulgare L.) and Sun
Protection Factor (SPF) Determination of Barley-Virgin Oil Based Cosmetic Emulsion ............ 29
O51-AJ ............................................................................................................................................... 30
Effect of extraction solvent on the total phenolic content, carotenoid and antioxidant activity of
Australian chia seed (Salvia hispanica L.) oil ............................................................................... 30
O127-AJ ............................................................................................................................................. 31
Investigation of hydrolyzed ceramide in Thai color rice (Oryza sativa L.) and by-products ........ 31
P4-AB................................................................................................................................................. 32
Classification of Residual Protease in Recovered Protein from Japanese Anchovy (Engraulis
japonicus) Using Salt Water Treatment ......................................................................................... 32
P9-AB................................................................................................................................................. 33
Influence of Ultrasound to the Activity and Conformational Changes of Purified Pepsin from the
Stomach of Lizardfish (Saurida micropectoralis) ......................................................................... 33
P10-AB............................................................................................................................................... 34
Ultrasonic-assisted biodiesel production process from used cooking oil using lipase from Nile
tilapia viscera ................................................................................................................................. 34
P19-AB............................................................................................................................................... 35
Chemical and Antioxidative Changes of Beadless Barb during Fermentation of Fish Paste (Ka-pi-
plaa) ............................................................................................................................................... 35
P20-AB............................................................................................................................................... 36
Effect of Steam Cooking on Polyphenolic Compounds and Antioxidant Capacities of Purple Sweet
Potato and Purple Yam .................................................................................................................. 36
P43-AB............................................................................................................................................... 37
Antioxidant Activities and Mineral Contents of Protein Hydrolysates Derived from Skipjack Tuna
Fish Bone ....................................................................................................................................... 37
P72-AB............................................................................................................................................... 38
Physicochemical and Hardness Properties of Rice-based Food Gel Using Different Brown Rice
Cultivars ......................................................................................................................................... 38
P103-AB............................................................................................................................................. 39
Structural Changes of Surimi Added Ascorbic Acid and Hydrogen Peroxide .............................. 39
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
P107-AB............................................................................................................................................. 40
Chemical and Cellular Antioxidant Activities of Corn Gluten Meal Hydrolysate ........................ 40
P26-AP ............................................................................................................................................... 41
Studies on the optimum condition for the extraction of commercial dried Roselle ( Hibiscus
sabdariffa) extract .......................................................................................................................... 41
P42-AP ............................................................................................................................................... 42
Fuel Properties of Biodiesel Produced from the Used Cooking Oil Catalyzed by Nile Tilapia
Viscera Lipase under Ultrasonication ............................................................................................ 42
P60-AP ............................................................................................................................................... 43
Production of collagen hydrolysate from jellyfish using trypsin and alcalase with antioxidative
activities in lipid emulsions system ............................................................................................... 43
P63-AP ............................................................................................................................................... 44
Physical and Nutritional Qualities of Blenderized Diets from Natural Ingredients ...................... 44
P71-AP ............................................................................................................................................... 45
Melanogenesis by peptide derived from bee pollen ( Apis mellifera) in murine melanoma cells (B16F10) ......................................................................................................................................... 45
P74-AP ............................................................................................................................................... 46
Simultaneous determination of different forms of vitamin D in foods by liquid chromatography
tandem mass spectrometry (LC-MS/MS) ...................................................................................... 46
P76-AP ............................................................................................................................................... 47
Effect of Enzymatic Extraction Method on the Chemical Properties of Partially Defatted and
Defatted Rice Bran Protein Hydrolysates ...................................................................................... 47
P80-AP ............................................................................................................................................... 48
Nutritive values of indigenous plants in Kanchanaburi province .................................................. 48
P88-AP ............................................................................................................................................... 49
Effect of Pressure and Temperature on Fat Removal of Silkworm Pupae (Bombyx mori L.) by
Supercritical Carbon Dioxide Extraction ....................................................................................... 49
P126-AP ............................................................................................................................................. 50
Quality of Nipa Palm Syrup from Different Batches of Production .............................................. 50
P145-AP ............................................................................................................................................. 51
Yield, Morphology and Crystallinity of Cellulose from Soybean Hulls using Pressure Microwave-
Assisted Extraction ........................................................................................................................ 51
P59-AJ ................................................................................................................................................ 52
Investigation of hydrolyzed ceramide in Thai color rice (Oryza sativa L.) and by-products ........ 52
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
Division B .......................................................................................................................................... 53
Food Processing and Engineering .................................................................................................. 53
O70-BB .............................................................................................................................................. 54
Subcritical ethanol extraction of oil from coconut meal ................................................................ 54
O140-BB ............................................................................................................................................ 55
Production of D-tagatose from D-galactose by subcritical aqueous ethanol ................................. 55
O53-BP............................................................................................................................................... 56
Optimization of Pectin Extraction from Green Mature Garcinia atroviridis Rind using Response
Surface Methodology ..................................................................................................................... 56
O81-BP............................................................................................................................................... 57
Optimization of hydrothermal technique for the production of nanocellulose from bamboo shoot
shell ................................................................................................................................................ 57
O83-BP............................................................................................................................................... 58
Effects of High-Pressure Processing on Textural Properties of Threadfin Bream Surimi Gel ...... 58
O111-BP............................................................................................................................................. 59
Effect of Preparation Methods on β-Cyclodextrin Encapsulated Holy Basil (Ocimum Sanctum
Linn) Essential Oil Properties ........................................................................................................ 59
O139-BP............................................................................................................................................. 60
Effects of Pasteurization and High Pressure Processing on Quality of Sweetened Condensed Rice-
Cereal Milk .................................................................................................................................... 60
P11-BB ............................................................................................................................................... 61
A mixture design approach on the texture of food gel bead made from tapioca flour, soy flour and
cane sugar ....................................................................................................................................... 61
P62-BB ............................................................................................................................................... 62
Surface Modification to Reduce Deposition Flux of Spray Dried Noni (Morinda Citrofolia L.)
Juice ............................................................................................................................................... 62
P77-BB ............................................................................................................................................... 63
Effect of spray drying conditions on microencapsulation of bioactive compounds extracted from
cassava leaf .................................................................................................................................... 63
P137-BB ............................................................................................................................................. 65
Acne gel production from pickled mango seed ............................................................................. 65
P13-BP ............................................................................................................................................... 66
The quality of Palm sap sugar powder producing by using a prototype drying machine .............. 66
P44-BP ............................................................................................................................................... 67
Physical and Chemical Properties of Arabica Coffee in Ywangan Township, Myanmar ............. 67
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
P125-BP ............................................................................................................................................. 68
Factors affecting yield of protein hydrolysate extracted from porcine placenta ............................ 68
P128-BP ............................................................................................................................................. 69
Effect of oyster extract corn flour and sugar on rheological properties of oyster sauce ............... 69
P138-BP ............................................................................................................................................. 70
Non-Dairy Low Fat Ice Cream Produced from Germinated Tubtim Chumpare Rice .................. 70
P136-BJ .............................................................................................................................................. 71
Survivability of Lactobacillus acidophilus and quality attributes of puffed pounded-unripe rice
supplemented with probiotics using a fluidized-bed coating method ............................................ 71
Division C .......................................................................................................................................... 72
Food Product Development, Sensory, and Consumer Research .................................................... 72
O22-CP............................................................................................................................................... 73
Development of silken tofu coagulated by glucono-delta-lactone for consumers with mastication
and swallowing problems............................................................................................................... 73
O65-CP............................................................................................................................................... 74
Bread quality as affected by sorghum and breadfruit flours as wheat substitutes ......................... 74
O99-CP............................................................................................................................................... 75
Effect of red jasmine brown rice flour on quality of gluten-free noodles ...................................... 75
O122-CP............................................................................................................................................. 76
Physicochemical and sensorial properties of date palm syrup made from premature fruit drop, fresh
and dried date pulp ......................................................................................................................... 76
P68-CB ............................................................................................................................................... 77
Development of Complete Balanced Nutrition Instant Diet for Dysphagia Patients with Various
Rice Powder Concentrations .......................................................................................................... 77
P92-CB ............................................................................................................................................... 78
Effect of syrup concentration, pasteurized time, and pasteurized temperature on Longkong in syrup
product and its shelf life ................................................................................................................. 78
P64-CP ............................................................................................................................................... 79
Stability of β-carotene Encapsulated in Plant-Based Emulsions: Impact of Nanofibrillated Cellulose
Concentration ................................................................................................................................. 79
P69-CP ............................................................................................................................................... 80
Rheological and physicochemical properties of ice cream fortified with freeze-dried mulberry
powder ............................................................................................................................................ 80
P73-CP ............................................................................................................................................... 81
Effects of pineapple juice and commercial meat tenderizeron quality of beef jerky ..................... 81
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
P84-CP ............................................................................................................................................... 82
Healthy Processed Cheese Analogue Product Concept Development and Sensory Evaluation of
Prototype Product on Oil Replacement .......................................................................................... 82
P90-CP ............................................................................................................................................... 83
Effect of sucralose substitution on moisture transfer and physicochemical characteristics of Marian
plum leather.................................................................................................................................... 83
P106-CP ............................................................................................................................................. 84
Application House of Quality in Strawberry Topping Sauce ........................................................ 84
P129-CP ............................................................................................................................................. 85
KJ method and Sensory Characterization of minced pork containing different fat content .......... 85
P132-CP ............................................................................................................................................. 86
Effect of Banana Flour Substitution on the Quality Characteristics of Gluten-Free Bread ........... 86
P134-CP ............................................................................................................................................. 87
Effect of Reducing Sodium Chloride and Phosphate in Thai Chicken Sausage (Kai-Yor) ........... 87
P21-CJ ................................................................................................................................................ 88
Product qualities and sensory evaluation of high protein snack bar incorporated with pea protein
isolate ............................................................................................................................................. 88
P25-CJ ................................................................................................................................................ 89
Effect of Jerusalem artichoke (Helianthus tuberosus) powder on quality of glass noodles .......... 89
P28-CJ ................................................................................................................................................ 90
Production and quality evaluation of low GI waffle from whole wheat flour supplemented with RS
IV and Sacred lotus stamen ............................................................................................................ 90
P41-CJ ................................................................................................................................................ 91
Effect of Partial Substitution of Riceberry Rice Flour on Rice Noodles Quality .......................... 91
Division D .......................................................................................................................................... 92
Food Microbiology, Food Biotechnology, Fermentation .............................................................. 92
O108-DB ............................................................................................................................................ 93
Development of innovative Amazake from Portuguese Chestnuts using controlled fermentation
conditions ....................................................................................................................................... 93
O24-DP .............................................................................................................................................. 94
Bioinformatic Tools and in-vitro analysis for screening of potential Bacillus probiotic used as a
food supplement ............................................................................................................................. 94
O85-DP .............................................................................................................................................. 95
Chemical characterization and antibacterial activity against foodborne pathogens of biosurfactant
from Aureobasidium melanogenum ............................................................................................... 95
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
O98-DP .............................................................................................................................................. 96
Improved survival of Candida tropicalis TISTR 5922 Starter Culture with Difference Form ..... 96
O100-DP ............................................................................................................................................ 97
The effect of pineapple waste extracts on quality of probiotic yogurt ........................................... 97
O120-DP ............................................................................................................................................ 98
Effect of Saccharomyces Sp. No.9 on Physicochemical Characteristics of Aged Roselle Wine and
Its Consumer Preference ................................................................................................................ 98
P27-DB............................................................................................................................................... 99
Fermentation of Haematococcus pluvialis in brewery wastewater for biomass production and
nutrients removal............................................................................................................................ 99
P119-DB........................................................................................................................................... 100
Development of an innovative fermented paste from green tomato to produce new foods with added
nutritional value ........................................................................................................................... 100
P49-DP ............................................................................................................................................. 101
in vitro Inhibitory impact of vapor phase – acetic acid, lactic acid and citric acid on Staphylococcus
aureus isolated from fresh-cut jackfruit ....................................................................................... 101
P101-DP ........................................................................................................................................... 102
Effect of basil seed mucilage on physicochemical and biological properties of probiotic yogurt
...................................................................................................................................................... 102
P121-DP ........................................................................................................................................... 103
Antimicrobial Effects of Tannic Acids and Licorice Extract ...................................................... 103
(Glycyrrhiza glabra L.) as a potential application for antimicrobial biodegradable film ............ 103
P143-DJ ............................................................................................................................................ 104
Evaluation of prebiotic potential of Spirogyra sp., Cladophora sp., Caulerpa lentillifera and
Caulerpa corynephora. ................................................................................................................ 104
Division E ........................................................................................................................................ 105
Related Food Topics (Food Packaging, Food Safety & Quality, Food Laws & Regulations, Food
Policy, etc.) .................................................................................................................................. 105
P75-EB ............................................................................................................................................. 106
Development of bioplastic active packaging to inhibit fungal growth in bakery product using cast-
extrusion ....................................................................................................................................... 106
P141-EB ........................................................................................................................................... 107
Preparation of Specific Antibody-Conjugated Ferromagnetic Nanoparticles for the Detection of
Campylobacter jejuni in Immunomagnetic Separation (IMS) System ........................................ 107
P18-EP ............................................................................................................................................. 108
Effect of Cereal Types on the Properties of Agar Based Edible Film ......................................... 108
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
P40-EP ............................................................................................................................................. 109
Effects of surfactant-modified cellulose nanocrystals on properties of soy protein-based composite
film ............................................................................................................................................... 109
P82-EP ............................................................................................................................................. 110
Comparison of high pressure processing and thermal pasteurization to inactivate Escherichia coli
O157:H7 in guava and coriander juices ....................................................................................... 110
P86-EP ............................................................................................................................................. 111
Development of Colorimetric Film with Butterfly Pea (Clitoria ternatea L.) Extract for Application
in Intelligent Packaging ............................................................................................................... 111
P87-EP ............................................................................................................................................. 112
Effects of Domestic Single Parcel Delivery on Integrity of Packaging System .......................... 112
P95-EP ............................................................................................................................................. 113
Effect of Polybutylene Succinate Film Incorporated with Vanillin Against Escherichia coli and
Staphylococcus aureus ................................................................................................................. 113
P97-EP ............................................................................................................................................. 114
Effects of pH on the Seal Strength, Physical, and Mechanical Properties of the Mung Bean (Vigna
radiata) Protein Isolate Film ........................................................................................................ 114
P146-EP ........................................................................................................................................... 115
Determination of pH-dye Based Smart Label for Monitoring Seafood Product Quality ............ 115
P112-EJ ............................................................................................................................................ 116
Effective Microbial Disinfection in Food Industry with Hydroxyl Radical Fumigation ............. 116
List of Authors ................................................................................................................................. 117
List of Reviewers ............................................................................................................................. 121
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
i
CONFERENCE PROGRAM
June 18, 2020
Session 1: Opening remark and Keynote Speeches
MC: Dr. Nopparat Plucktaveesak
Faculty of Science and Technology, Thammasat University
Log in: 09.40-10.00
10.00 -10.15 Opening remark
By Assistant Professor Dr. Anadi Nitithamyong
President of Food Science and Technology Association of Thailand
(FoSTAT)
10.15-10.30 Keynote speech 1: The global food supply system: the massive challenges
(and opportunities) caused by COVID-19
By Professor Dr. Chris Elliott, The Institute for Global Food Security (IGFS)
Queen's University Belfast, Northern Ireland
10.35-10.50 Keynote speech 2: Future perspectives for active ageing
By Professor Dr. Weon-Sun Shin, Department of Food and Nutrition,
College of Human Ecology, Hanyang University, Korea
10.55-11.10 Keynote speech 3: Bacteriocin-producing lactic acid bacteria: their
production, application and future research trend for food industry
By Assistant Professor Dr. Takeshi Zendo, Department of Bioscience
and Biotechnology, Faculty of Agriculture, Kyushu University, Japan
11.15-11.30 Keynote speech 4: Biodiversity for food security: The mekong fish
perspective
By Professor Dr. Tuantong Jutagate, Ubon Ratchathani University, Thailand
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
ii
June 18, 2020
Session 2: Oral presentation of Division A (Food Chemistry, Nutrition, and Analysis)
Chair: Asst. Prof. Dr. Utai Klinkesorn, Kasetsart University
Co-Chair: Assoc. Prof. Dr. Sirithon Siriamornpun, Mahasarahkham University
Log in: 12.50-13.00
13.00-13.05 Session introduction
13.05–13.15 O5-AB: Pepsinogens and pepsins from lizardfish (Saurida
micropectoralis) stomach: Purification and some biochemical properties
By Sakonwat Kuepethkaew, Thaksin University
13.15-13.25 O15-AB: Gelation of threadfin bream (Nemipterus spp.) surimi with
various NaCl contents under high intensity ultrasound
By Ling Tang, Suranaree University of Technology
13.25-13.35 O57-AB: Purification, identification and characterization of antioxidant
peptides from tilapia (Oreochromis niloticus) protein hydrolysate
By Xiaogang Zhang, Suranaree University of Technology
13.35-13.45 O66-AP: Antioxidant properties of mulberry leaf using ultrasound-assisted
extraction
By Supasit Insang, Chulalongkorn University
13.45-13.55 O104-AB: Chemical and functional properties of banana flour (Kluai
Namwa) at different ripening stage
By Nur-asikin Masaesa-I, Prince of Songkla University
13.55-14.05 O127-AJ: Investigation of hydrolyzed ceramide in Thai color rice (Oryza
sativa L.) and by-products
By Chawin Paosila, Kasetsart University
14.05-14.15 O67-AP: Effect of extraction conditions on bioactive compounds of barley
(Hordeum vulgare L.) and sun protection factor (SPF) determination of
barley- virgin oil based cosmetic emulsion
By Pongsakorn Vithayanon, Assumption University
14.15-14.25 O17-AP: Separation and characterization of fat, protein and chitosan from Eri
silkworm pupae (Philosamia ricini)
By Thanapon Pattanasatian, King Mongkut's University of Technology
Thonburi
14.25-14.35 O51-AJ: Effect of extraction solvent on the total phenolic content, carotenoid
and antioxidant activity of Australian chia seed (Salvia hispanica L.) oil
By Izzreen Ishak, National University of Malaysia
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
iii
June 18, 2020
Session 3: Oral presentation of Division B (Food Processing and Engineering)
Chair: Dr. Jatuporn Aroonkamonsri, Rajamangala University of Technology Tawan-ok
Co-Chair: Dr. Krittiya Khuenpet, Thammasat University
Log in: 14.20-14.30
14.30-14.35 Session introduction
14.35-14.45 OB111: Effect of preparation methods on β-cyclodextrin encapsulated holy
basil (Ocimum Sanctum Linn.) essential oil properties
By Wantanee Noichinda, Chulalongkorn University
14.45-14.55 OB53: Optimization of pectin extraction from green mature Garcinia
atroviridis rind using response surface methodology
By Gerry Renaldi, Prince of Songkla University
14.55-15.05 OB70: Subcritical ethanol extraction of oil from coconut mealBby
Thussanee Plangklang, Silpakorn University
15.05-15.15 OB140: Production of D-tagatose from D-galactose by subcritical aqueous
ethanol
By Neeranuch Milasing, Silpakorn University
15.15-15.25 OB81: Optimization of hydrothermal technique for the production of
nanocellulose from bamboo shoot shell
By Kanjana Manamoongmongkol, King Mongkut’s Institute of Technology
Ladkrabang
15.25-15.35 OB83: Effects of high-pressure processing on textural properties of threadfin
bream surimi gel
By Boodasayapuk Buasakchai, Thammasat University
15.35-15.45 OB139: Effects of pasteurization and high pressure processing on quality of
sweetened condensed rice-cereal milk
By Rawiporn Polpued, Thammasat University
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
iv
June 19, 2020
Session 6: Oral Competition
Chair: Assoc.Prof. Dr. Jirawat Yongsawatdigul, Suranaree University of Technology
Co-Chair: : Asst. Prof. Dr Wiriya Onsa-ard, Ubon RatchathanUniversity
Dr. Teerarat Likitwattanasade, Mahidol University
Log in: 8.50-9.00
09.00-09.05 Session introduction
09.05-09.15 OC22: Development of silken tofu coagulated by glucono-delta-lactone for
consumers with mastication and swallowing problems
By Thanakorn Wongprasert, Chulalongkorn University
09.20-09.30 OD85: Chemical characterization and antibacterial activity against foodborne
pathogens of biosurfactant from Aureobasidium melanogenum
By Vipawan Jandee, Thammasat University
09.35-09.45 OA51: Effect of extraction solvent on the total phenolic content, carotenoid
and antioxidant activity of Australian chia seed (Salvia hispanica L.) oil
By Izzreen Ishak, National University of Malaysia
09.50-10.00 OC122: Comparison of date palm syrup made from premature fruit drop,
fresh and dried date pulp
By Kittanan Burapalit, Assumption University
10.05 -10.15 OD24: Bioinformatic tools and in-vitro analysis for screening of potential
Bacillus probiotic used as a food supplement
By Gauri Khullar, Chulalongkorn University
15.05-15.20 ORAL and POSTER Awards PRESENTATION
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
v
June 19, 2020
Session 7: Poster Competition
Chair: Asst. Prof. Dr. Orn-in Prachaiyo, Naresuan University
Co-Chair: Asst. Prof. Dr. Panchaporn Tadpitchayangkun Promchote,
Ubon Ratchatani Univeristy
Log in: 10.20-10.30
10.30-10.35 Session introduction
10.35-10.45 P9-AB: Influence of ultrasound to the activity and conformational changes
of purified pepsin from the stomach of lizardfish (Sauridamicropectoralis)
By Acting Sub Lt. Sakonwat- Kuepethkaew, Thaksin University
10.50-11.00 P75-EB: Development of bioplastic active packaging to inhibit fungal growth
in bakery product using cast-extrusion
By Ms. Atcharawan Srisa, Kasetsart University
11.05-11.15 P95-EP: Effect of Polybutylene succinate film incorporated with vanillin
against Escherichia coli and Staphylococcus aureus
By Ms. Natticha Leaktong, Kasetsart University
11.20-11.30 P141-EB: Preparation of specific antibody-conjugated ferromagnetic
nanoparticles for the detection of Campylobacter jejuni in immunomagnetic
separation (IMS) system
By Mr. Pattarapong Wenbap, King Mongkut's University of Technology
Thonburi
15.05-15.20 ORAL and POSTER Awards PRESENTATION
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
vi
June 19, 2020
Session 4: Oral presentation of Division C (Food Product Development, Sensory, and
Consumer Research)
Chair: Dr. Aussama Soontrunnarudrungsri, Kasetsart University
Co-Chair: Asst. Prof. Dr. Manatchaya Sungsri-in, Mahasarakham University
Log in: 12.50-13.00
13.00-13.05 Session introduction
13.05-13.15 OC65: Bread quality as affected by sorghum and breadfruit flours as wheat
substitutes
By Fahrunnisa Adzqia, Kasetsart University
13.15-13.25 OC99: Effect of red jasmine brown rice flour on quality of gluten-free
noodles
By: Patomporn Waewkum, Ubon Ratchathani University
13.25-13.35 OC22: Development of silken tofu coagulated by glucono-delta-lactone for
consumers with mastication and swallowing problems
By: Thanakorn Wongprasert, Chulalongkorn University
13.35-13.45 OC122: Comparison of date palm syrup made from premature fruit drop,
fresh and dried date pulp
By Kittanan Burapalit, Assumption University
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
vii
June 19, 2020
Session 5: Oral presentation of Division D (Food Microbiology, Food Biotechnology,
Fermentation)
Chair: Assoc. Prof. Dr. Pravate Tuitemwong, King Mongkut's University of Technology Thonburi
Co-Chair: Asst. Prof. Dr. Awanwee Petchkongkaew, Thammasat University
Log in: 13.50-14.00
14.00-14.05 Session introduction
14.05-14.15 OD24: Bioinformatic tools and in-vitro analysis for screening of potential
Bacillus probiotic used as a food supplement
By Gauri Khullar, Chulalongkorn University
14.15-14.25 OD100: The effect of pineapple waste extracts on quality of probiotic yogurt
By Sreymom Hun, Mae Fah Luang University
14.25-14.35 OD120: Effect of Saccharomyces sp. No.9 on physicochemical characteristics
of aged roselle wine and its consumer preference
By Kotchakorn Sereephantwong, Assumption University
14.35-14.45 OD108: Development of innovative amazake from Portuguese chestnuts using
controlled fermentation conditions
By Marisa Santos, Universidade de Lisboa
14.45-14.55 OD98: Improved survival of Candida tropicalis TISTR 5922 starter culture
with difference form
By Natwaran Nukrohwad, Prince of Songkla University
14.55-15.05 OD85: Chemical characterization and antibacterial activity against foodborne
pathogens of biosurfactant from Aureobasidium melanogenum
By Vipawan Jandee, Thammasat University
15.05-15.20 ORAL and POSTER Awards PRESENTATION
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
viii
ABOUT CONFERENCE
The conference will provide opportunity to meet and share experiences as well as strengthen
networking among international food scientists and scientists in related fields from academia,
government and food industries. The objective is to highlight significant developments in research
and innovations in food science and technology with an emphasis on innovative ASEAN food
research towards the World. The conference will feature a series of presentations and discussions in
plenary, concurrent and poster sessions, informal gatherings, competitions and exhibitions.
Division (A) Food Chemistry, Nutrition, and Analysis
Division (B) Food Processing and Engineering
Division (C) Food Product Development, Sensory, and Consumer Research
Division (D) Food Microbiology, Food Biotechnology, Fermentation
Division (E) Related Topics (Food Packaging, Food Safety & Quality, Food Laws & Regulations,
Food Policy, etc.)
Division (F) Industrial session
Organisers:
Food Science and Technology Association of Thailand (FoSTAT)
Agro-Industry Academic Council Association (AIAC)
Mahasarakham University
Thammasat University
Ubon Ratchathani University
AOAC Thailand Section
Support By:
Informa markets
The Federation of the Institute of Food Science and Technology in ASEAN (FIFSTA)
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
ix
ORGANIZING COMMITTEE
1. Assistant Professor Dr. Anadi Nitithamyong (Chair) Thailand
2. Associate Professor Dr. Anuvat Jangchud (Vice Chair) Thailand
3. Ms. U-sarat Bunnag (Committee) Thailand
4. Associate Professor Dr. Saiwarun Chaiwanichsiri (Committee) Thailand
5. Associate Professor Dr. Warangkana Sompongse (Committee) Thailand
6. Dr. Narintorn Boonbrahm (Committee) Thailand
7. Associate Professor Dr. Anuchita Moongngarm (Committee) Thailand
8. Assistant Professor Dr. Manatchaya Sangsriin (Committee) Thailand
9. Associate Professor Dr.Wirote Youravong (Committee) Thailand
10. Assistant Professor Dr.Mutita Meenune (Committee) Thailand
11. Assistant Professor Dr.Suched Samuhasaneeto (Committee) Thailand
12. Ms.Tin Swe Aye (Committee) Republic of the Union of Myanmar
13. Professor Dr. Umar Santoso (Committee) Republic of Indonesia
14. Ms. Viengxay Vansilalom (Committee) Lao People's Democratic Republic
15. Dr. Yew Ming Koh (Committee) Malaysia
16. Dr. Lotis Francisco (Committee) Republic of the Philippines
17. Mr. Richard Khaw (Committee) Republic of Singapore
18. Dr. Luu Dzuan (Committee) Socialist Republic of Vietnam
19. Mr. Kong Thong (Committee) Kingdom of Cambodia
20. Ms. Shisa Wiboonchat (Committee) Thailand
SCIENCETIFIC COMMITTEE
Associate Professor Dr. Saiwarun Chaiwanichsiri (Chair)
Associate Professor Dr. Jirawat Yongsawatdigul (Vice Chair)
Assistant Professor Dr. Bootsrapa Leelawat
Assistant Professor Dr. Duljira Sukboonyasatit
Assistant Professor Dr. Suched Samuhasaneetoo
Dr. Chutima Thongkaew
Associate Professor Dr. Suntaree Suwonsichon (Secretary)
Assistant Professor Dr. Kitipong Assatarakul (Assistant Secretary)
FIAC Scientific Division
(A) Food Chemistry, Nutrition and Analysis
• Assistant Professor Dr. Utai Klinkesorn (Chair)
• Associate Professor Dr. Sirithorn Siriamornpun (Vice Chair)
• Assistant Professor Dr. Tatdao Paseephol (Vice Chair)
• Associate Professor Dr. Saroat Rawdkuen
• Assistant Professor Dr. Suched Samuhasaneetoo
• Assistant Professor Dr. Uthaiwan Suttisansanee
• Assistant Professor Dr. Kriskamol Na Jom
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
x
(B) Food Processing and Engineering
• Dr. Jatuporn Aroonkamonsri (Chair)
• Dr. Krittiya Khuenpet (Vice Chair)
• Associate Professor Dr. Jirarat Anuntagool
• Associate Professor Dr. Weerachet Jittanit
• Assistant Professor Dr. Wiriya Onsa-ard
(C) Food Product Development, Sensory, and Consumer Research
• Dr. Aussama Soontrunnrudrungsri (Chair)
• Assistant Professor Dr. Manatchaya Sangsri-in (Vice Chair)
• Associate Professor Dr. Hathairat Rimkeeree
• Assistant Professor Dr. Parinda Penroj
• Assistant Professor Dr. Varapha Kongpensook
• Assistant Professor Dr. Siwat Thaiudom
(D) Food Microbiology, Food Biotechnology, Fermentation
• Associate Professor Dr. Pravate Tuitemwong (Chair)
• Assistant Professor Dr. Awanwee Petchkongkaew (Vice Chair)
• Professor Dr. Sirirat Rengpipat
• Associate Professor Dr. Worapot Suntornsuk
• Assistant Professor Dr. Warapa Mahakarnchanakul
• Assistant Professor Dr. Nujarin Jongruja
• Dr. Wiboonkiet Moleeratanond
(E) Related Topics (Food Packaging, Food Safety & Quality, Food Laws & Regulations, Food
Policy, etc.)
• Associate Professor Dr. Adisorn Swetwiwathana (Chair)
• Miss Kingkan Pongtong (Vice Chair)
• Assistant Professor Dr. Pairote Wongputtisin
• Assistant Professor Dr. Aphacha Jindaprasert
• Dr. Umarphorn Chadseesuwan
• Dr. Sarisa Suriyarak
(F) Industrial session
• Assitant Professor Dr. Weerawatee Utto (Chair)
• Assitant Professor Dr. Ekasit Onsa-ard (Vice Chair)
• Professor Dr. Sakamon Devahastin
• Assitant Professor Dr. Pisit Dhamvithee
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
xi
COMPETITION COMMITTEE
(1) Poster Presentation Competition Commitee
• Assistant Professor Dr. Ornin Prachaiyo (Chair)
• Associate Professor Dr. Wannee Jirapakku
• Assistant Professor Dr. Parinda Penroj
• Assistant Professor Dr. Phisut Naknean
• Assistant Professor Dr. Samak Rakmae
• Assistant Professor Dr. Supawan Thawornchinsombut
• Dr. Sarisa Suriyarak
• Assistant Professor Dr. Panchaporn Promchote (Secretary)
• Assistant Professor Dr. Wachirapan Boonyaputthipong (Assistant Secretary)
(2) Oral Presentation Competition Committee
• Associate Professor Dr. Jirawat Yongsawatdigul (Chair)
• Associate Professor Dr. Nantawan Therdthai
• Associate Professor Dr. Jirarat Anuntagool
• Assistant Professor Dr. Kitaya Vongkamjan
• Dr. Magnus Bergvist
• Dr. Teerarat Likitwattanasade (Secretary)
• Assistant Professor Dr. Wiriya Onsa-ard (Assistant Secretary)
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
xii
OPENING REMARK: FOSTAT PRESIDENT
Asst. Prof. Dr. Anadi Nitithamyong
President of Food Science and Technology
Association of Thailand (FoSTAT)
Distinguished speakers, FIAC 2020 committees, colleagues, ladies and gentlemen.
On behalf of the Food Science and Technology Association of Thailand or FoSTAT, I
am pleased to welcome you to the Food Innovation Asia Conference 2020. The
conference and competition programs will be convened during 18-19 June 2020.
At this time of the COVID-19 pandemic, the Organizing Committees have decided to
go on with the new format of the conference this year. In order to ensure the safety of
all speakers and participants as well as to conform with the social distancing policy of
the Government, here we are today for the first online Food Innovation Asia
Conference.
FoSTAT is very proud to, once again, help organize the Food Innovation Asia
Conference 2020. This year, FoSTAT collaborates with the Agro-Industry Academic
Committee (AIAC), Mahasarakham University, Thammasat University, Ubon
Ratchathani University, AOAC Thailand and the Federation of the Institute of Food
Science and Technology in ASEAN (FIFSTA) to organize the scientific events where
there will be numerous technical paper presentations along with oral and poster
presentation competition for graduate students.
I wish to thank Informa Markets - Thailand who has been one of the key partners in
supporting our activities. We are certain that this year will be another successful year
bringing all science, technology, and innovation to the food industry. I wish all the
success of Food Innovation Asia Conference in many years to come.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
xiii
WELCOME MESSAGE: THAMMASAT UNIVERSITY
Assist. Prof. Dr. Nuttanont Hongwarittorrn
Dean, Faculty of Science and Technology,
Thammasat University, THAILAND
Greeting to …
On behalf of the Faculty of Science and Technology, Thammasat University, I am honored to invite
you to the Food Innovation Asia Conference (FIAC) 2020 with the theme “Innovation for Future
Food and Nutrition Security”. Under the situation of the COVID-19 pandemic, this conference turns
to a virtual platform linking together researchers, experts, academics, students, and professionals from
all over the world to present research findings, exchange ideas, as well as discover new opportunities
and broaden their knowledge in various aspects of sciences and technologies.
With the variety of interesting topics to be discussed and expertise of local and international scholars
presenting and participating in the conference, I sincerely hope that this conference will prove a
productive platform and provide positive impact on our scientific temper and research.
Please enjoy networking and thank you for your participation.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
xiv
WELCOME MESSAGE: MAHASARAKHAM UNIVERSITY
Assoc. Prof. Dr. Anuchita Moongngarm
Dean, Faculty of Technology,
Mahasarakham University, THAILAND
Dear Colleagues and Conference Participants
I am honoured and delighted to warmly welcome you to the
Food Innovation Asia Conference (FIAC) 2020.
FIAC is one of the largest international conferences in Asia for researchers, scientists, professors, and
students in the field of food science and technology, nutrition, and other related fields. In this year’s
conference, we have adopted the theme “Innovation for Future Food and Nutrition Security”
which is going to be held during 18-20 June 2020. In the beginning, we intended to hold the
conference in Bangkok, Thailand. Unfortunately, due to the spread of COVID-19 around the world,
the organising committee has decided to change the conference to the virtual conference. However,
the conference program still includes keynote lectures by prominent speakers, oral and poster
presentations. I am extremely happy that our conference has been designed to offer a comprehensive
range of sessions such as Food chemistry and analysis, Food microorganism, Innovation in food
technology, Nutrition, and other related fields. The conference still offers opportunities to exchange
scientific ideas and create networks between people from several organizations as well as between
young scientists and professionals. I also wish you have a good time and opportunity to connect with
experts from the scientific and entrepreneur community through their lectures and presentations.
I do hope the conference will be of professional and personal benefits to all of us as we proceed with
our innovation work towards a future food and nutrition that is sustainable and capable of providing
food and nutrition security for all.
On behalf of the Faculty of Technology, Mahasarakham University, I would like to thank the Food
Science and Technology Association of Thailand (FoSTAT) for inviting us to co-organize the FIAC
2020, together with Thammasat University and Ubon Ratchathani University. We apologize for any
inconvenience. I wish to all of us fruitful discussions, interesting findings, and networking
opportunities.
Thank you
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
xv
WELCOME MESSAGE: UBON RATCHATHANI UNIVERSITY
Dr. Narintorn Boonbrahm
Dean, Faculty of Agriculture,
Ubon Ratchathani University, THAILAND
Warmly Greeting to
Chairman of the Food Science and Technology Association Thailand, Colleagues, All conference
participants
As a co-host, it is my pleasure to welcome food scientists, technologists, researchers, academicians,
officials, and business delegates from all over Asia to attend the Food Innovation Asia Conference
2020 (FIAC2020) held on 18th-19th June, 2020, Bangkok, Thailand. The FIAC2020 purposely is to
make the venue for sharing research insights as well as cutting edge technologies in food and agro-
industry. The conference participants also can make and strengthen networks for future
collaborations. In 2020, the conference emphasizes on innovations and equally important related
aspects including biodiversity for ensuring food and nutrition securities which are inseparable
fundamentals for global development.
At present, the world has been tested by our mother nature to encounter inevitable difficulties emerged
with the COVID-19 pandemic situations. The securities in food supplies and their nutritional values
recently have gained immense interests from all international communities in order to make their
supplies sufficiently available for their own members. These interests have monumental impacts
which could be carried on for a certain period until the pandemic medically becomes subsided. Under
our recent global situation, food technology and its related disciplines have been proven their essences
and importance as foundations of human wellness and livelihoods.
Faculty of Agriculture, Ubon Ratchathani University has operated undergraduate, master and doctoral
degrees in Food Technology since 1997. Our academic staff have undertaken a range of processed
food product research with focuses on improving commercialized opportunities for indigenous and
local foods. Our university is situated in the lower part of the Northeast region sharing natural borders
with Laos and Cambodia or known as Mekhong sub-region. Please do visit us and make future food
and agro-industry research and development collaborations.
On behalf of Faculty of Agriculture, Ubon Ratchathani University, I would like to thank you Food
Science and Technology Association Thailand as well as other two co-hosts Thammasat University
and Mahasarakam University for inviting our university to join one of the great international food
technology conferences. Our faculty staff and I wish the FIAC2020 conference successful, and our
conference hosts and participants to have great health.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
16
KEYNOTE SPEAKERS
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
17
KEYNOTE SPEAKERS: PROF. DR. CHRIS ELLIOTT
The global food supply system: the massive challenges (and
opportunities) caused by COVID-19
Prof. Dr. Chris Elliott
Institute for Global Food Security,
Queen’s University, Belfast, UK
ABSTRACT:
The range of issues facing our global food supply system are enormous. Among these the impact of
climate change, pollution and water shortages are the most pressing. How we produce enough food
in a sustainable way was already considered one of the planet’s biggest issues before the onset of
the coronavirus pandemic. In the short term this new threat has wreaked havoc in terms of
fragmenting supply chains, labour issues and the safety and provenance of what we eat. The
pandemic has brought about massive changes in terms of what we eat and how we purchase our
food. These changes are likely to be very long lasting. The impact of a poor diet, particularly in
terms of those who suffer metabolic diseases has been shown by the death toll caused by this
population by COVID-19.
Yet with crisis comes opportunities, opportunities to make our food system more sustainable, more
transparent and safer. We live in the era of the 4th industrial revolution where digital technologies
coupled to scientific innovations can deliver massive advances in terms of our food system. This
keynote lecture will outline a number of these opportunities.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
18
KEYNOTE SPEAKERS: PROF. DR. WEON-SUN SHIN
Future perspectives for active ageing
Prof. Dr. Weon-Sun Shin
Department of Food and Nutrition
College of Human Ecology, Hanyang University, Korea
ABSTRACT:
Global population continues to age due to falling birth rate, rising life expectancy, and the ageing of
the baby boomers. The surge in elderly single person households are forcing seniors’ life, expecting
growth of 130% over 2010-2030. In a few years, baby boomers are entering into elderly age that
want to remain highly active based on holistic and wellness trends. This new senior generation in a
super-aged society will be characterized by having the economic means to enjoy themselves through
consumption of goods, value-added foods, participation in entertainment and engagement in cultural
activities. WHO defines healthy age as the process of developing and maintaining the functional
ability that enables wellbeing in older age. In the process of ageing, there are obvious functional
decline (mobility, eyesight, oral health, GI health and cognitive function) as important determinants
of food consumption. Living independency of the elderly with a good health condition pays less
socio-economic cost, suggesting that the well-designed meal plan should be considered. To prevent
undernutrition and functional decline in ageing, eating capabilities including oral health (chewing
& swallowing) and gastro-intestinal functions should be concerned. Taking this into account,
sustaining the elderly active and healthy is the key agenda in super-aged society, whose success
requires a multidisciplinary approach that should be based mainly on prevention.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
19
KEYNOTE SPEAKERS: ASSIST. PROF. DR. TAKESHI ZENDO
Bacteriocin-producing lactic acid bacteria : their production,
application and future research trend for food industry
Assist. Prof. Dr. Takeshi Zendo
Department of Bioscience and Biotechnology,
Faculty of Agriculture, Kyushu University, Japan
ABSTRACT:
A wide variety of bacteria including lactic acid bacteria (LAB) have been found to produce
ribosomally synthesized antibacterial peptides, bacteriocins. LAB bacteriocins inhibit the growth of
Gram-positive bacteria and are thought to contribute to preservation of fermented foods. LAB
bacteriocins generally exert antibacterial activity through quick action on bactetrial cell membrane
and can be degraded easily by intestinal digestive enzymes without leaving residues to the
environment, which lets them considered as safe antimicrobial agents. In particular, nisin A, the
most representative bacteriocin produced by some strains of Lactococcus lactis, has been utilized as
a food preservative in more than 50 countries. Based on its safety, we have also developed various
applications of nisin A including non-food applications such as oral care agents. For further
extensive applications of LAB bacteriocins, we are screening new LAB isolates for novel
bacteriocin production. We developed a rapid screening system to evaluate bacteriocins, enabled us
to discover various novel LAB bacteriocins such as lacticin Q and lactocyclicin Q. In addition, some
LAB strains isolated from Thai fermented products were found to produce novel bacteriocins.
Especially, Enterococcus faecium NKR-5-3 isolated from Pla-ra were found to produce five
bacteriocin peptides, one of which was identified as a novel circular bacteriocin termed enterocin
NKR-5-3B. Various bacteriocins and bacteriocin-producing LAB strains allow us to select suitable
ones as safe preservatives and antimicrobial starter cultures, respectively, according to their
characteristics to satisfy our varied purposes.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
20
KEYNOTE SPEAKERS: PROF. DR. TUANTONG JUTAGATE
Biodiversity for food security: The Mekong fish perspective
Prof. Dr. Tuantong Jutagate
Fisheries Program, Faculty of Agriculture
Ubon Ratcathani University
ABSTRACT:
Fish diversity in the Mekong River is unrivaled to elsewhere and maintained by the ecosystem
complexity in the river basin. There are more than 850 fish species taxonomically recorded and
comprised from the dwarfs, which the matured sizes are less than 4 cm, to the giants such as Mekong
giant catfish, whom the size can be over 300 cm. The Mekong River is also the home of the world’s
largest inland fishery. It is estimated that about 1.2 million tons of fishes are exploited each year
and, hence, the consumption of freshwater fishes of the Mekong’s people is ranked top of the world.
Not only the protein that these fishes provide but also the minerals and trace elements that the
Mekong’s people can take from them and used to combat malnutrition. Numbers of local wisdom
on preserving fish such as drying, salting, and smoking have been developed to prevent spoilage
since the ancient time. Moreover, the modern preserving and processing are also applied for fish
preservation. Sustaining the fish diversity and fishery are challenged in the Mekong nowadays due
to multiple pressures and, inevitably consequent to the food fishes. Collaboration between the “fish”
and “food” scientists is crucially urgent to secure the aquatic biodiversity integrity as well as the
wellbeing and food security of the Mekong people.
Keywords: fishery, protein, preserving fish
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
21
DIVISION A
Food Chemistry, Nutrition, and Analysis
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
22
O5-AB
Pepsinogens and pepsins from lizardfish (Saurida micropectoralis)
stomach: Purification and some biochemical properties
Sakonwat Kuepethkaew1, Srinivasan Damodaran2,
Hideki Kishimura3 and Sappasith Klomklao 4*
1 Biotechnology Program, Faculty of Agro and Bio Industry,
Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung, 93210, Thailand
2 Department of Food Science, University of Wisconsin-Madison,
Madison, WI, 53706, USA
3 Laboratory of Marine Chemical Resource Development, Faculty of Fisheries Sciences,
Hokkaido University, Hakodate, Hokkaido, 041-8611, Japan
4 Department of Food Science and Technology, Faculty of Agro and Bio Industry,
Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung, 93210, Thailand
*Tel.:+66 7469 3996, E-mail: [email protected]
ABSTRACT:
One major pepsinogen, PG-I, and two minor pepsinogens, PG-II and PG-III, were purified from the
stomach of lizardfish (Saurida micropectoralis) by ammonium sulfate precipitation and
chromatographic separation on CM-Cellulose and Sephadex G-75. Based on the Native-PAGE and
zymography, three purified PGs showed a single band with pepsin (P) activity. The molecular
weights (MW) of the three purified PGs were 38 kDa (PG-I) and 36.5 kDa (PG-II and PG-III) as
determined by SDS-PAGE. PG-I till PG-III converted into the corresponding pepsins at pH 2.0 with
MWs of 32 kDa (P-I), 31 kDa (P-II), and 30 kDa (P-III). Optimum pHs of the three enzymes were
2.0-3.5, and optimum temperatures were 40-50oC, using hemoglobin as substrate. All three pepsins
were strongly inhibited by pepstatin A, whist partially inhibited by ethylenediaminetetraacetic acid.
Divalent cations (CaCl2, CoCl2, CuCl2, FeCl2, and MnCl2) showed slightly stimulated; however,
ATP had no impact on pepsins activities. From the Lineweaver-Burk double reciprocal plots, the
kinetic constants of Km and Kcat of three pepsins (P-I, P-II, and P-III) for hemoglobin were calculated
as 107.64 µM, 32.68 s-1; 252.65 µM, 27.30 s-1 and 276.61 µM, 18.30 s-1, respectively. The N-
terminal amino acid sequence of 15 residues of three PG isoforms had high homology to those of
other fish PGs.
Keyword: Purification, Biochemical properties, Lizardfish, Stomach, Pepsin
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
23
O15-AB
Gelation of threadfin bream (Nemipterus spp.) surimi with various
NaCl contents under high intensity ultrasound
Ling Tang, Jirawat Yongsawatdigul*
School of Food Technology, Institute of Agricultural Technology, Suranaree University of
Technology, Nakhon Ratchasima 30000, Thailand.
* Tel.: +66 4422 4359, E-mail: [email protected]
ABSTRACT:
To meet consumers’ demand of sodium reduction in food, production of low/ reduced- salt surimi
gel has been explored. Effects of high intensity ultrasound ( HIU) treatments ( ultrasonic intensity
of 10.01, 13.28 and 16.45 W/cm2, 30 min) on gelation of threadfin bream (Nemipterus spp.) surimi
with various NaCl contents (0.5, 1 and 2% NaCl) were investigated. Salt-soluble protein (SSP)
content of surimi paste at 0.5% NaCl increased with increasing ultrasonic intensity (p<0.05), while
a decrease in SSP content at 1 and 2% NaCl was observed at higher intensity ( 16. 45 W/ cm2) . Surface hydrophobicity of surimi pastes at 3 studied NaCl contents increased after HIU treatments,
accompanied by a decrease in Ca2+ - ATPase activity, indicating greater protein unfolding and
conformational changes induced by HIU. Textural properties and color of surimi gels at 0.5% NaCl
were improved with increasing ultrasonic intensity (p<0.05). However, HIU treatments resulted in
inferior gels at 1 and 2% NaCl, suggesting that an excessive denaturation of protein was likely to
occur at higher NaCl contents (1 and 2% NaCl). Trichloroacetic acid (TCA)-soluble oligopeptide
content of surimi gels slightly increased after HIU treatments, imp l y i ng proteolysis under HIU. Fourier transform infrared ( FT- IR) spectroscopy showed that α- helix content of surimi gels
decreased with an increase in ultrasonic intensity and NaCl content, confirming that HIU treatments
induced protein unfolding to a greater extent and a more pronounced effect was observed at higher
NaCl content. The results suggested that low-salt surimi gel could possibly be produced using HIU
technology.
Keywords: Gelation; High intensity ultrasound; NaCl; Threadfin bream surimi
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
24
O57-AB
Purification, Identification and Characterization of Antioxidant
Peptides from Tilapia (Oreochromis niloticus ) Protein Hydrolysate
Xiaogang Zhang1, Parinya Noisa2, Jirawat Yongsawatdigul1*
1School of Food Technology, Institute of Agricultural Technology,
Suranaree University of Technology
111 University Avenue, Nakhon Ratchasima 30000, Thailand
2 School of Biotechnology, Institute of Agricultural Technology,
Suranaree University of Technology
111 University Avenue, Nakhon Ratchasima 30000, Thailand
*Tel.: +66 4422 4359, E-mail: [email protected]
ABSTRACT: Purification and identification of antioxidant peptides presented in the protein hydrolysate or
digesta are crucial to understand the exact peptides possessing antioxidant activity in the biological
system. Characterization of antioxidant peptides from the digesta of protein hydrolysate are more
biologically relevant. However, purification and identification of digesta peptides pose challenges
due to peptides derived from digestive enzymes. In silico gastrointestinal (GI) digestion can be used
to predict the potential cleavage site of peptides under GI digestion and to reveal possible peptide
digesta, which could be more physiological relevant . In this study, tilapia muscle protein was
hydrolyzed by Alcalase to 35% degree of hydrolysis (DH) and then purified by size exclusion
chromatography (SEC) and dual reversed phase chromatography (RPC and re-RPC). The fractions
displayed higher 2,2'-azino-bis (3-ethylbenzothiazoline-6-sulfonic acid) diammonium salt radical
cation (ABTS•+) scavenging capacity were selected for peptide identification by LC -MS/MS. Finally, 9 peptides were selected for further in silico GI digestion, and total 15 peptides containing
parent peptides and their digesta were synthesized and characterized. Six Cys- and 4 Tyr-containing
peptides showed an EC50 for ABTS•+ scavenging capacity from 2 – 17 µM which were comparable
with that of Trolox, ascorbic acid (AsA), gallic acid (GA) or glutathione (GSH). But the EC50 values of 5 Lys-containing peptides were higher than 250 µM. Peptide digesta, namely SC, CH, and PGY showed better or comparable EC50 values to their respective parent peptides but showed better
intracellular ROS scavenging capacity on the HepG2 cell model assay. SC, CH, and PGY induced
different gene expression of antioxidant enzymes. When cells were treated with the peptide and
followed by 2,2′-azobis (2-methylpropionamidine) dihydrochloride (AAPH) to induce oxidative
stress, PGY was the best peptide stimulating the expression of CAT (catalase gene) and SOD1
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
25
(superoxide dismutase gene) but suppressed the expression of GPx1 (glutathione peroxidase gene). Our results indicated that peptides derived from tilapia muscle proteins can mitigate the
intracellular oxidative stress by ROS scavenging and /or modulation of expression of antioxidant
enzymes.
Keyword: Purification, Antioxidant peptides, In silico digestion, Reactive oxygen species (ROS), Gene expression
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
26
O104-AB
Chemical and Functional Properties of Banana Flour (Kluai Namwa)
at Different Ripening Stage
Nur-asikin Masaesa-I, Netnapis Ongsuwan, Chumpon Numuang and Taewee Karrila*
Department of Food Science and Nutrition, Faculty of Science and Technology,
Prince of Songkla University, Pattani Campus, Thailand, 94000
* Tel: +66 7333 4609 E-mail: [email protected]
ABSTRACT:
Flour from “Kluai Namwa” banana [Musa sapientum Linn (ABB group)] has recently received
attention in the context of making functional food products. As a climacteric fruit, the banana fruit
changes in its chemical composition via biochemical reactions during ripening. This affects the
properties of flour made from it, and the match of this flour with applications. The objective of this
study was to assess the chemical and functional properties of banana flour as affected by different
stages of banana ripening. Banana flours were prepared from 3 stages of ripening, based on peel
color, such as: stage 1 (BF1) with totally green peel, stage 2 (BF2) with peel green with trace of
yellow, and stage 3 (BF3) with peel 2/3 green and 1/3 yellow. The banana flours were characterized
for chemical properties (amylose, reducing sugar and total phenolic content), pasting properties
using rapid visco analyzer (RVA), and gelatinization temperature and enthalpy using differential
scanning calorimetry (DSC), as well as swelling power, solubility, gel hardness and syneresis. The
results showed that ripening stage influences both chemical and functional properties of banana
flour. Amylose content of banana flour decreased (14.95±0.52%, 10.41±0.52%, and 6.47±0.41% for
BF1, BF2 and BF3, respectively) while reducing sugar increased (1.08±0.04, 8.30±0.016 and
24.58±0.14 g glucose/100 g sample for BF1, BF2 and BF3, respectively) with the increasing of
ripening stage. The total phenolic contents of BF1, BF2 and BF3 were 60.97±0.01, 478.48±0.01 and
152.32±0.00 g gallic/100 g sample, respectively. Gelatinization enthalpy of BF3 was lower than
those of BF2 and BF1. Regarding the RVA viscosities, the results showed significant decreases in
all viscosity parameters with the increasing of ripening stage (p<0.05). This was similar to gel
hardness but opposite trend to water solubility. Gel syneresis of BF3 (33.23±0.44%) was higher than
that of BF2 (18.19±0.72%) and BF1 (8.70±0.77%) (p<0.05). The information obtained from this
study can be used to select/sort banana fruits and prepare most suited flour for specific applications.
Keywords: Climacteric fruit, ripening stage, banana flour, pasting properties, functional properties
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
27
O17-AP
Separation and characterization of fat, protein and chitosan from Eri
silkworm pupae (Philosamia ricini)
Thanapon Pattanasatian* and Worapot Suntornsuk
Department of Microbiology, King Mongkut's University of Technology Thonburi,
126 PrachaUthit Rd., Bangmod, Thungkru, Bangkok 10140, Thailand
*Tel.: +66 4970 4835, E-mail: [email protected]
ABSTRACT:
Eri silkworm pupa (Philosamia ricini) is a main by-product from sericulture industry and has high
nutritional values. It is the good sources of biomolecules such as protein, lipid and carbohydrate
which could be utilized for many industrial applications. Proximate analysis of Eri silkworm pupae
and fractionation of their biomolecules were carried out in this study. The pupae contained 67%
protein, 16% fat, 5% fiber and 6% ash on dry weight basis. Lipid extraction was performed by
hexane extraction and its extraction yield was 13% on dry weight basis. Linolenic acid which is an
essential ω-3 fatty acid was the main fatty acid (46%). Proteins were isolated by isoelectric point
method. Protein yield was 9% on dry weight basis. The main amino acids were aspartic acid (12 g/
100 g protein) and glutamic acid (11 g/100 g protein). Chitosan yield deacetylated from chitin of
pupae protein-free residue by NaOH was found at 3%. Therefore, important biomolecules could be
effectively fractionated from the pupae at the possible yields to be applied in the industries.
Keyword: Eri silkworm pupae; Lipid extraction; Protein precipitation; Chitosan
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
28
O66-AP
Antioxidant properties of mulberry leaf using ultrasound-assisted
extraction
Supasit Insang1, Kitipong Assatarakul1*
1Department of Food Technology, Faculty of Science, Chulalongkorn University
Phyathai Rd. Wangmai, Pathumwan, Bangkok, 10330, Thailand
*Tel. +66 2218 5515, E-mail: [email protected]
ABSTRACT:
Mulberry leaf commonly consumed in Asia contains a high amount of bioactive compounds with
health-beneficial functions. The purpose of this study was to determine the effects of ethanol
concentration (0, 40 and 80% v/v) and temperature (30, 40 and 50°C) using ultrasound-assisted
extraction on total phenolic content (TPC), flavonoids content (TFC) and antioxidant activities by
2,2-diphenyl-1-picrylhydrazyl (DPPH) scavenging and ferric reducing antioxidant power (FRAP)
assays of mulberry leaf extract. Results showed that TPC, TFC, DPPH and FRAP values of mulberry
leaf extract were significantly different (P<0.05) in various conditions of extraction. It was found
that extraction at temperature 40°C displayed the highest antioxidant by DPPH and FRAP assays
with the value of 657.76 ± 2.30 μmol trolox equivalent/g and 891.16 ± 4.90 μmol trolox equivalent/g,
respectively compared to other conditions. The extract from 40% ethanol and 50°C had the greatest
total phenolic content (1106.05 ± 2.54 mg gallic acid equivalent (GAE)/100g), while the lowest total
phenolic content was achieved from the extract from 0% ethanol and 30°C (429.66 ± 3.33 GAE/100
g). The highest flavonoid content was observed from the extract with 0% ethanol concentration and
temperature of 40°C (2.57 ± 0.04 mg quercetin equivalent (QCE)/100 g) and the lowest flavonoid
content was recorded with the temperature of 30°C at 80% ethanol concentration (0.89 ± 0.12
QCE/100 g). This study illustrates that mulberry leaf extract could be a great source of natural
antioxidants that may be applied for the development of healthy products.
Keyword: Mulberry leaf, Ultrasound-assisted extraction, Flavonoid compounds, Phenolic
compounds, Antioxidant activity.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
29
O67-AP
Effect of Extraction Conditions on Bioactive Compounds of Barley
(Hordeum vulgare L.) and Sun Protection Factor (SPF) Determination
of Barley-Virgin Oil Based Cosmetic Emulsion
Pongsakorn Vithayanon1, Tatsawan Tipvarakarnkoon1, Waralee Watcharin2,
and Sireerat Laodheerasiri2*
1Department of Food Biotechnology
2 Department of Agro-Industry
Faculty of Biotechnology, Assumption University, Bangkok, Thailand
*Tel.: + 66 2300 4543 Ext.3790, E-mail: [email protected]
ABSTRACT:
Barley (Hordeum vulgare L.) is the main source of several bioactive compounds e.g. phenolic
compounds, flavonoids that could absorb the ultraviolet (UV) light. The virgin oils also contain
photo-protective compounds that absorb UV radiation. This study aimed to analyze the effect of
barley extraction condition on the total phenolic content, total flavonoid content and antioxidant
activity, furthermore, the sun protection factor (SPF) of extracted barley and virgin oils were
determined. The oil in water (o/w) cosmetic emulsion was formulated to study the efficiency of
virgin oil types which could aid the physical sunscreen, benzophenone-3, to enhance the SPF. The
occlusion factor indicated the prevention of dehydration of water from the skin. Extracted barley at
45°C without microwave preheating revealed the highest total phenolic content (19.62±1.35 mg
GAE/g) whereas 45°C extraction of 2 minutes microwave preheating showed the highest total
flavonoid content (430.92±1.91 mg QE/g). Radical scavenging DPPH reported the optimum
extraction temperature at 45°C which microwave preheating 5 minutes showed the highest the half-
maximal inhibitory concentration value (IC50) at 6.23±0.41 mg TE/g. The sun protection factor
(SPF) of 10% (w/v) of extracted barley and virgin avocado oil (VAO) were 6.12±0.05 and 8.71±0.37
respectively, whereas virgin coconut oil and virgin olive oil were 2.00±0.08 and 0.71±0.01
respectively. The SPF obtained from cosmetic emulsions E1, E4, and E6 have higher SPF, above
SPF of 5.5, when compared to E2, E3, E5, E7, and E8. The SPF ranged from 4.31 to 5.64. Virgin
oils significantly enhanced the benzophenone-3 to exhibit UV absorption. The pH was in the range
of alkaline cosmetics which designated to people with psoriasis therapy. All formulae showed
occlusion factor varied from 41.81 to 75.40 % within 48 hrs.
Keyword: Barley, virgin oil, cosmetic emulsion, sun protection factor, occlusion factor
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
30
O51-AJ
Effect of extraction solvent on the total phenolic content, carotenoid
and antioxidant activity of Australian chia seed (Salvia hispanica L.)
oil
1,2 Ishak, I. , *1Ghani, M.A. and 1Yuen, J.Z.
1Department of Food Science, Faculty of Science and Technology, Universiti
Kebangsaan Malaysia, 43600 Bangi, Selangor, Malaysia
2Halal Products Research Institute, Universiti Putra Malaysia, Putra Infoport,
43400 UPM Serdang, Selangor, Malaysia
*E-mail: [email protected]
ABSTRACT:
The oil yield, total phenolic content (TPC), total carotenoid content (TCC) and antioxidant activity
of Australian chia seed (Salvia hispanica L.) oil under solvents polarity and extraction times were
studied. The chia seed oils were obtained by using organic solvents in the Soxhlet method with
different extraction times including acetone 4 hrs (A4), acetone 8 hrs (A8) and n-hexane 8 hrs (H8)
as a control. The extraction yield for the control sample (36.1%) showed significant (p ≤ 0.05) higher
than A4 (33.53%) and A8 (33.73%). TPC for chia seed oil (A4) was significantly higher (p ≤ 0.05)
than A8 and H8. Meanwhile, chia seed oil (A8) contained the highest TCC over A4 and H8. The
antioxidant activity of chia seed oils was determined by DPPH (2-diphenyl-1-picrylhydrazyl)
scavenging activity, FRAP (Ferric reducing antioxidant power assay), BCBA (Beta-carotene
bleaching assay) and TBA (Lipid Peroxidation Inhibition Assay), respectively. Chia seed oil
obtained by acetone for 4 hrs revealed higher antioxidant capacities (DPPH, BCBA and TBA) when
compared with oils from A8 and H8. However, chia seed oils by n-hexane extraction for 8 hrs
showed the lowest phenolic and carotenoid contents as well as antioxidant capacities. The
correlation between the antioxidants content and the antioxidant activities were conducted to
determine their relationship. TPC and TCC were strongly correlated with BCBA (r = 0.999) and
TBA (r = 0.997). The results confirmed Australian chia seed oil obtained by acetone for 4 hrs had
higher contents of phenolic, carotenoid and antioxidant activity compared to n-hexane extracted due
to high polarity of acetone to the antioxidant compounds. In conclusion, acetone can be applied as
an alternative extraction solvent to produce high antioxidant activity of Australian chia seed oil.
Keywords: Chia seed oil, antioxidant activity, total phenolic content, total carotenoid content,
acetone, hexane
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
31
O127-AJ
Investigation of hydrolyzed ceramide in Thai color rice (Oryza sativa
L.) and by-products
Paosila, C., Rumpagaporn, P. and *Na Jom, K.
Department of Food Science and Technology, Faculty of Agro-Industry, Kasetsart University
50 Ngam Wong Wan Road, Lad Yao, Chatuchak, Bangkok 10900, Thailand
*E-mail: [email protected]
ABSTRACT:
Ceramide is sphingolipid, which provides health benefits. Gas chromatography coupled with flame
ionized detector (GC-FID) was developed for targeted analysis of hydrolyzed ceramide in color rice
and by-products. Method validation was done by means of linearity, repeatability and %recovery.
R2 of 0.99 by means of linearity equation of the method was obtained. The recovery was in the range
of 69.85 – 108.73% with RSD of normalized peak area lower than 10%. Hydrolyzed ceramide was
found in unpolished rice, both glutinous and non-glutinous rice and its by-products including,
defatted rice bran, rice bran wax and rice bran oil. The relationship between varieties of rice color
and ceramide content was classified using principal component analysis (PCA) into 2 groups,
including dark and pale color rice group. The highest levels of hydrolyzed ceramide as 21.11+0.02
mg/100g was found in Mali Nil Surin (MNS), a black non-glutinous rice. Whereas, a white non-
glutinous rice named Seebukantang (SBK) contained the lowest content of hydrolyzed ceramide as
12.69+0.03 mg/100g. The amount of ceramide in by-products found in defatted rice bran, rice bran
oil and rice bran wax was 17.43±0.38, 14.67±0.16 and 12.54±0.41 mg/100g, respectively.
Keywords: Ceramide, Hydrolyzed ceramide, GC-FID, Color rice, Rice by-products, PCA
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
32
P4-AB
Classification of Residual Protease in Recovered Protein from
Japanese Anchovy (Engraulis japonicus) Using Salt Water Treatment
Nonthacha Thanathornvarakul1, Kigen Takahashi1 and Kazufumi Osako1*
1Department of Food Science and Technology,
Tokyo University of Marine Science and Technology
4-5-7, Konan, Minato-ku, Tokyo, 108-8477, Japan
*Tel.: +81 3 5463 0620, E-mail: [email protected], [email protected]
ABSTRACT:
Japanese anchovy (Engraulis japonicus) is a small pelagic fish and found around Japan, China and
South East Asia. To increase the utilization of this fish as a raw material of heat induced gel
product, protein was extracted from whole fish by using salt solution. However, this fish has high
autolytic activity that might retain in recovered protein and affect protein characteristics during
recovery process. The objective of present study was to clarify the effect of recovery process on
the protein pattern and identify proteases type which involve in protein autolysis during recovery
process. Moreover, the gel foaming ability of recovered protein with or without added protease
inhibitor were also determined in this study. Minced fish was homogenized with NaCl solution and
then diluted the supernatant 10 times with water to acquire recovered protein. SDS-PAGE and
zymography technique were used to determine the protein pattern of sample at each step and
identified protease type. To produce heat induced gel, recovered protein with or without protease
inhibitor was prepared by ground with NaCl. Recovered protein paste was incubated at 40 ºC for
30 min and final cooking was performed at 90 ºC for 30 min. The degradation of myosin heavy
chain (MHC) was found at dehydration step. The results from reaction model between crude
enzyme and actomyosin correlated with the results from zymography technique. The degradation
of MHC could be prevented by trypsin inhibitor from soybean. The main protease type involve in
protein autolysis during recovery process was serine protease with approximate molecular weights
of 42 and 18 kDa. The gel forming ability of recovered protein was improved significantly (p ≤
0.05) when mixed recovered protein with trypsin inhibitor from soybean before the dehydrating
step at 4 ºC. These results indicate that serine proteases are the main protease involving in autolysis
of protein during the protein recovery process and the gel forming ability of the recovered protein
from Japanese anchovy can be enhanced by using serine protease inhibitors.
Keyword: Recovered protein, Salt water treatment, Protease type, Gel forming ability
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
33
P9-AB
Influence of Ultrasound to the Activity and Conformational Changes
of Purified Pepsin from the Stomach of Lizardfish (Saurida
micropectoralis)
Sakonwat Kuepethkaew1, Arthittaya Thuanthong1,
Srinivasan Damodaran2, Soottawat Benjakul3 and Sappasith Klomklao4*
1 Biotechnology Program, Faculty of Agro and Bio Industry,
Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung, 93210, Thailand
2 Department of Food Science, University of Wisconsin-Madison,
Madison, WI, 53706, USA
3 Department of Food Technology, Faculty of Agro-Industry,
Prince of Songkla University, Hat Yai, Songkhla, 90110, Thailand
4 Department of Food Science and Technology, Faculty of Agro and Bio Industry,
Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung, 93210, Thailand
*Tel.:+66 7469 3996, E-mail: [email protected]
ABSTRACT:
Pepsin is one of the major fish digestive proteolytic enzymes, commonly used for industrial
applications. Pepsin was highly purified from lizardfish (Saurida micropectoralis) stomach by
ammonium sulfate precipitation and several chromatographies. Considering the commercial
importance of proteases, it is necessary to find an effective method to improve the activity of the
protease. This study investigated the effect of ultrasound on the activity and conformational changes
of purified pepsin from the lizardfish stomach. Ultrasound had an effect on the activity of pepsin.
The highest enzyme activity was achieved when the sample was treated with ultrasound at 180 W,
24 kHz, and 35oC for 30 min with an enhancement of 38.09% compared with the untreated pepsin.
The conformational changes of pepsin were analyzed by attenuated total reflection-Fourier
transform infrared spectroscopy (ATR-FTIR) and fluorescence spectroscopy. Results indicated that
the activation of pepsin induced by ultrasound was presumably due to the decrease of tryptophan on
the pepsin surface. Therefore, ultrasound is a possible way to activate pepsin from the stomach of
lizardfish to increase its application in the food industry.
Keyword: Ultrasound, Pepsin, Lizardfish, Conformational changes, Enzyme activity
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
34
P10-AB
Ultrasonic-assisted biodiesel production process from used cooking oil
using lipase from Nile tilapia viscera
Jaran Patchimpet1, Kanokphorn Sangkharak2, Sappasith Klomklao3*
1 Biotechnology Program, Faculty of Agro and Bio Industry, Thaksin University, Phatthalung Campus, Pa-Phayom 93210, Thailand.
2 Department of Chemistry, Faculty of Science, Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung 93210, Thailand.
3 Department of Food Science and Technology, Faculty of Agro and Bio Industry,
Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung 93210, Thailand.
*Tel.:+66 7469 3996, E-mail: [email protected]
.
ABSTRACT:
Biodiesel is a renewable fuel, constituting an alternative to petroleum-based diesel fuel. Biodiesel
is better for environmentally sensitive areas because of its biodegradability, non-toxic nature and
low emission profile. This work investigated the biodiesel production with used cooking oil (UCO)
and methanol through transesterification using lipase from the viscera of Nile tilapia (Oreochromis
niloticus) under the effect of ultrasonic irradiation. The influence of experimental conditions such
as ultrasonic frequency, irradiation time and temperature on biodiesel yield was investigated. The
methyl ester contents in the reaction mixture were quantified using a gas chromatography. The
results showed that the use of ultrasound decreased the reaction time from 28 h to 3 h with the use
of an ultrasonic frequency of 16 kHz, a methanol to oil molar ratio of 4:1, a lipase concentration of
30 kUnit and a 40C reaction temperature. The efficacy of using ultrasound was also compared with
conventional stirring under the optimum operating conditions. Ultrasonic coupled with stirring
explained the further improvement in the transesterification of UCO with methanol using lipase with
the highest yield of 97.59%. Therefore, ultrasound-assisted lipase-catalyzed transesterification of
used cooking oil with methanol would be a promising alternative for conventional methods.
Keyword: Lipase, Nile tilapia, Used cooking oil, Biodiesel, Ultrasound
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
35
P19-AB
Chemical and Antioxidative Changes of Beadless Barb during
Fermentation of Fish Paste (Ka-pi-plaa)
Pakteera Sripokar1, Donhareed Lahtee2, Egon Bech Hansen3 Jarurat Panyo2
and Sappasith Klomklao2*
1 Biotechnology Program, Faculty of Agro- and Bio-Industry, Thaksin University,
Phatthalung Campus, Phatthalung, 93210, Thailand
2 Department of Food Science and Technology, Faculty of Agro- and Bio-Industry,
Thaksin University, Phatthalung Campus, Phatthalung, 93210, Thailand
3 Technical University of Denmark, National Food Institute, 2800, Søborg, Denmark
*Tel.: +66 7460 9618, E-mail: [email protected]
ABSTRACT:
Thai traditional fermented fish paste (Ka-pi-plaa) is widely consumed as condiment and seasoning
ingredient in southern of Thailand. Ka-pi-plaa is obtained through fermentation of fish with 15-25%
salt under ambient conditions. Chemical and antioxidative changes in beadless barb (Anematichthys
apogon) during production of Ka-pi-plaa including autolysis, salting, drying and fermentation were
monitored. Changes of colors values were observed as a reduction of -L*-value during fermentation.
However, a* and b*-values increased as increasing fermentation time (p<0.05). This was correlated
with the increase in browning intensity assessed by absorbance at 420 nm (A420) (p<0.05). pH of
samples slightly decreased after drying and fermenting steps. This was related with the increase in
titratable acidity. The continuous increases in formal nitrogen, ammonia nitrogen and amino
nitrogen contents were noticed throughout all processes (p<0.05). This suggested the formation of
peptides and free amino acids via the protein hydrolysis by the action of both microbial and
indigenous proteases. Increasing antioxidative activities of Ka-pi-plaa were observed during
fermentation as evidenced by the increase in 2,2-diphenyl-l-picrylhydrazyl (DPPH), 2,2-azino-bis
(3-ethylbenzthiazoline-6-sulphonic acid (ABTS), ferric reducing antioxidant power (FRAP) and
metal chelating activity (p<0.05). Antioxidant activities of Ka-pi-plaa were more likely governed
by the low molecular weight peptides, amino acids as well as Maillard reaction products generated
during fermentation. In summary, this indicated that Ka-pi-plaa from beadless barb was good
sources of nutrients as well as natural antioxidants. These changes were governed by both
endogenous and microbial enzymes.
Keywords: Beadless barb, Thai fermented fish paste, Ka-pi-plaa
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
36
P20-AB
Effect of Steam Cooking on Polyphenolic Compounds and Antioxidant
Capacities of Purple Sweet Potato and Purple Yam
Dewi Cakrawati1, Subin Srivichai1 and Parichat Hongsprabhas1,*
1Department of Food Science and Technology, Kasetsart University
50 Ngamwongwan Road, Bangkok 10900, Thailand
*Tel.:+66 2562 5043, E-mail: [email protected]
ABSTRACT:
Introduction: Sweet potato (Ipomoea batatas) and yam (Dioscorea alata) are among the top ten
most important staple foods in the world. Some varieties of these tubers have rich purple color,
making them a good source for starch and antioxidative anthocyanins. However, these tubers need
to be cooked prior to consumption, which could induce the changes in contents and conformations
of anthocyanins in cooked tubers. It was hypothesized that cooking at the household level could
affect the polyphenolic compounds and antioxidant capacities of purple sweet potato and purple
yam differently although anthocyanins in both plants contain cyanidin as the core flavylium ion.
Materials and Methods: Both purple sweet potato and yam tubers were steam cooked for at least 30
min to ensure gelatinization of starch for acceptable eating qualities. The raw and cooked tubers
were dried at 40 C for 24 h to reduce moisture to 10-11%, ground and sieved prior to analyses. The
samples were evaluated for polyphenolic compounds and antioxidant capacities using Trolox
equivalent antioxidant capacity (TEAC – electron transfer mechanism) and Crocin assay (hydrogen
atom transfer mechanism). Results: It was found that raw purple sweet potato contained higher
levels of total phenolic compound and flavonoid, as well as Crocin antioxidant capacity than did
raw yam (P<0.05). Tubers in both plants contained similar content of monomeric anthocyanins
(P>0.05). Steam cooking drastically increased those compounds and TEAC in cooked purple sweet
potato, suggesting that steam cooking liberated polyphenols and antioxidant capacity in cooked
purple sweet potato to be readily available prior to consumption. Nonetheless, steam cooking did
not affect total phenolic, polyphenolic contents, TEAC and Crocin antioxidant capacities of cooked
purple yam (P>0.05). Nonetheless, LCMS-IT-TOF revealed that anthocyanin called alatanins in
cooked purple yam were reduced from those found in raw purple yam, particularly alatanin B. The
alatanin profile was also altered after purple yam was steam cooked. Conclusion: This study revealed
species-dependent of anthocyanin sources and different thermal stability of anthocyanins in colored
tubers. This could be due to their difference in the types and degree of glycosylation and acylation,
as well as the presence of other nutrients during cooking.
Keyword: alatanin, anthocyanin, antioxidant, sweet potato, yam
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
37
P43-AB
Antioxidant Activities and Mineral Contents of Protein Hydrolysates
Derived from Skipjack Tuna Fish Bone
Valeeratana Jaiboon1, Wunwiboon Garnjanagoonchorn1, Jirawat Yongsawatdigul2,
Pramvadee Y. Wongsaengchantra3,4, and Teerarat Likitwattanasade4*
1Global Innovation Center, Thai Union Group PCL.,
27th Floor S.M. Tower, Phaholyothin Road, Phaya Thai District, Bangkok, 10400, Thailand
2School of Food Technology, Institute of Agricultural Technology,
Suranaree University of Technology, Nakhon Ratchasima, 30000, Thailand
3Center for Excellence in Protein and Enzyme Technology, Faculty of Science, Mahidol
University, Bangkok, 10400, Thailand
4* Department of Biotechnology, Faculty of Science, Mahidol University,
Bangkok, 10400, Thailand
*Tel.: +66 2201 5310, E-mail: [email protected]
ABSTRACT:
Enzymatic hydrolysis is a process extensively used to recover and enhance the nutritional value of
protein. Tuna fish bone is a coproduct of the tuna canning industry, accounting for 15% of the body
weight. Pre-cooked fish bone could be an important source of protein and minerals. Thus, this study
reported the antioxidant activities and mineral content of fish bone hydrolysates. Pre-cooked fish
bones from skipjack tuna (Katsuwonus pelamis) were decalcified by acid and commercial alkaline
protease hydrolyzed for 6 h. The hydrolysate from decalcified fish bone exhibited a higher degree
of hydrolysis (DH) and protein (nitrogen) recovery than that from the original non-decalcified fish
bone. DH and protein recovery of decalcified fish bone hydrolysate were 35% and 79%, respectively. The decalcified fish bone hydrolysate showed potent ferric reducing antioxidant power (FRAP)
(1.14 mg Trolox per g fish bone) and ABTS radical scavenging activity (52.6 mg Trolox per g fish
bone) after 2 h of hydrolysis. Furthermore, the fish bone hydrolysate contained a substantial amount
of iron and selenium (16.8 and 0.47 mg per 100 g dry basis hydrolysate, respectively). These results
indicate that fish bone hydrolysate could be a potential health promoting ingredient with antioxidant
activity and additional benefits of iron and selenium.
Keyword: Tuna, Fishbone, Hydrolysate, Antioxidant activity, Minerals
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
38
P72-AB
Physicochemical and Hardness Properties of Rice-based Food Gel
Using Different Brown Rice Cultivars
Numphung Rungraung, Kanokporn Mantham, Ploypailin Akanitkul, Varongsiri
Kemsawasd, Pamarin Waimaleongora-Ek, and Thunnalin Winuprasith*
Institute of Nutrition, Mahidol University,
Salaya, Nakhon Pathom 73170, Thailand.
* Tel.: +66 2800 2380 ext. 123, E-mail: [email protected]
ABSTRACT:
This study aimed to investigate the effects of brown rice powder from three various rice
cultivars (Brown rice powder (BRP); Khao Dawk Mali 105, Red rice powder (RRP); Hom Mali Dang,
and Purple rice powder (PRP); Riceberry) on physicochemical and hardness properties of rice gel.
Nine formulas of shelf-stable rice-based food gel product were formulated using each rice powder
cultivars at three different levels (6, 8, and 10 % w/w) using a water spray retort as a sterilization
process. The main ingredients were rice powder, maltodextrin, sugar, coconut oil, and soy powder.
The formulation based on energy and macronutrients of the product. The caloric density was 1 kcal/g
and the energy distribution from protein, carbohydrate, and fat were in the range between 10-15%,
55-60%, and 25-30% Physicochemical properties, including pH, total soluble solids (TSS), color,
oil syneresis, and hardness, of the products were examined. The results showed that the different
color rice cultivar at different levels did not significantly (p>0.05) affect pH of the food gel products
while TSS were slightly increased with increasing level of rice powder. The lightness (L*) values
of the food gel were significantly (p≤0.05) increased with increasing level of BRP whereas redness
(a*) and yellowness (b*) did not significantly different. However, increasing level of RRP and
PRP did not significantly affect the color values of food gel. The products using BRP and RRP
at 8% and 10% did not found any phase separation. On the other hand, the oil syneresis was
found in the products using PRP at every level. Hardness values of all food gels varied from 1,500
to 4,000 N/m2 that could be categorized into level 4 (i.e. soft foods that do not require chewing) of
Universal design (UD) food. This information may be useful for the development of texture-
modified food for the elderly using BRP and RRP as a source of carbohydrate.
Keywords: Texture, Food gel, Brown rice cultivars, Elderly
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
39
P103-AB
Structural Changes of Surimi Added Ascorbic Acid and Hydrogen
Peroxide
Danou Pao1 and Jirawat Yongsawatdigul1*
1School of Food Technology, Institute of Agricultural Technology
111 University Avenue, Muang District, Nakhon Ratchasima, 30000, Thailand
* Tel.:+66 94 534 8668, E-mail: [email protected]
ABSTRACT:
The objective of this study was to investigate the combined effect of ascorbic acid (AsA) and
hydrogen peroxide (H2O2) on gel-forming ability of lizardfish (LZ) and threadfin bream (TB) surimi.
Combination of 0.15% AsA and 0.1% H2O2 greatly increased breaking force and distance of LZ
surimi by 300% and 55%, respectively. Combination of 0.2% AsA and 0.15% H2O2 resulted in the
maximum breaking force and distance of TB surimi gel improvement with 150% and 90% increase,
respectively. Polymerization of myosin heavy chain was promoted with increasing AsA and H2O2.
Total sulfhydryl groups drastically reduced with combination of AsA and H2O2. Fourier-transform
infrared (FT-IR) spectroscopy revealed a decrease in α-helix and an increase in β-sheet content as AsA
and H2O2 increased in both species. Hydrophobic interaction involvements and conformation of
disulfide bonds increased with addition of these additives, as revealed by Raman spectroscopy.
Based on principal component analysis (PCA), textural characteristics were positively correlated
with β-sheet content. Our study suggested that combination of AsA and H2O2 greatly enhanced
surimi gel formation. It should be emphasized that both additives induced disulfide and hydrophobic
interactions.
Keyword: ascorbic acid; hydrogen peroxide; gel-forming ability; protein structure
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
40
P107-AB
Chemical and Cellular Antioxidant Activities of Corn Gluten Meal
Hydrolysate
Phiromya Chanajon1, Parinya Noisa2, and Jirawat Yongsawatdigul1*
1School of Food Technology, Institute of Agricultural Technology
111 University Avenue, Muang District, Nakhon Ratchasima, 30000, Thailand
2School of Biotechnology, Institute of Agricultural Technology
111 University Avenue, Muang District, Nakhon Ratchasima, 30000, Thailand
*Tel.:+66 94 534 8668, E-mail: [email protected]
ABSTRACT:
Neurocognitive disorder is a group of symptoms that cause by brain aging and commonly happened
in the elderly, typically associated with increasing level of oxidative stress and inflammation of
nerve cells in central nervous system. Recently, antioxidant properties of food peptide have been
reported. In addition, antioxidant properties of food peptides have been demonstrated to reduce
oxidative stress in animal model. Corn gluten meal ( CGM) is a by- product from corn starch
processing, which is rich in protein. Normally, CGM was used for animal feed production. Although
antioxidant activity of CGM hydrolysate have been reported, but only few studies with brain
functions were reported. Therefore, the objectives of this study are to determine chemical and
cellular antioxidant activities of CGM hydrolysate. Moreover, the stability of these peptides against
digestive enzymes as well as bioactive properties after gastrointestinal (GI) digestion would be
determined. CGM was hydrolyzed by pepsin (CGM-H) and following by in vitro GI digestion. Then,
both samples were determined antioxidant activities and the effect on oxidative stress of
neuroblastoma cells; SH-SY5Y. Results showed that both of CGM- H and hydrolysate digesta exhibited cation (2,2’-Azino-bis (3-ethylbenzothiazoline-6-sulfonic acid; ABTS) radical
scavenging, ferric reducing, and hydroxyl radical scavenging activities. In addition, both CGM-H
and its digesta protected hydrogen peroxide ( H2O2) - induced SH- SY5Y cells at the maximum
concentration of 12.5% (v/v) and reduced intracellular reactive oxygen species (ROS) at the same
concentration. Furthermore, peptides from CGM-H and digesta appeared to protect H2O2-induced
SH-SY5Y cells by increasing gene expression of catalase (CAT) at concentration of 0.78% (v/v) . Therefore, CGM could be a potential material for bioactive peptides production, which is a means
to valorize CGM.
Keyword: Antioxidant peptide, Corn gluten meal, Neuroblastoma cells, In vitro GI digestion
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
41
P26-AP
Studies on the optimum condition for the extraction of commercial
dried Roselle (Hibiscus sabdariffa ) extract
Kakanang Ruchain1, Chaowanee Chupeeruch1, Nattira On-nom1,
Rungrat Chamchan1, Chanakan Khemthong1 and Uthaiwan Suttisansanee1 *
1 Institute of Nutrition, Mahidol University,
999 Phutthamonthon 4Rd., Nakhon Pathom, 73170, Thailand
*Tel.: +66 8205 7627, E-mail: [email protected]
ABSTRACT
Roselle is an herbal plant rich in anthocyanin and has been recognized as a source of antioxidants. However, the rate of anthocyanin destruction depends on many factors such as pH, temperature,
intermolecular co pigmentation, ascorbic acid, oxygen, etc. Therefore, the study aimed to determine
physical and chemical properties, bioactive compound and antioxidant activities of commercial
dried roselle extracts in Thailand and to optimize conditions for water extraction of dried roselle. The results showed that pH, total acidity and total soluble solid of commercial dried roselle extracts
were in range of 2.50-2.59, 1.27-1.31% and 2.87-3.47°Brix, respectively. The color of dried roselle
extracts was brilliant red color. Total phenolic contents, total flavonoid contents, total anthocyanin
contents and antioxidant activities by FRAP, ORAC and DPPH assay of the extracts were in range
of 0.56-10.48 mg GAE/g DW, 8.99-20.15 mg QE/g DW, 0.01-0.29 mg/100g DW, 50.63-173.34 µmol
TE/ g DW, 203. 60- 468. 05µmol TE/ g DW and 1. 83- 2. 49 µmol TE/ 100g DW, respectively. The
optimum condition for water extraction of dried roselle was 1:20 ratio at 90°C for 15 min due to the
presence of total anthocyanins and antioxidant activities. pH, total acidity and total soluble solid of
dried roselle extract from the optimum condition were 2.50, 6.67% and 1.71°Brix, respectively. Total
anthocyanin contents and antioxidant activities by ORAC were 1.28 mg/100g DW and 1637.58 mg
TE/g DW, respectively. Therefore, dried roselle extracts have potential to be used as functional
ingredient.
Keyword: roselle ( Hibiscus sabdariffa L. ) , total anthocyanins, total phenolic compound, total
flavonoid compound, antioxidant activities.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
42
P42-AP
Fuel Properties of Biodiesel Produced from the Used Cooking Oil
Catalyzed by Nile Tilapia Viscera Lipase under Ultrasonication
Jaran Patchimpet1, Kanokphorn Sangkharak2, Sappasith Klomklao3*
1Biotechnology Program, Faculty of Agro and Bio Industry,
Thaksin University, Phatthalung Campus, Pa-Phayom 93210, Thailand.
2 Department of Chemistry, Faculty of Science, Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung 93210, Thailand.
3 Department of Food Science and Technology, Faculty of Agro and Bio Industry,
Thaksin University, Phatthalung Campus, Pa-Phayom, Phatthalung 93210, Thailand.
*Tel.:+66 7469 3996, E-mail: [email protected]
ABSTRACT:
Optimized synthesis of biodiesel from used cooking oil with methanol through transesterification
using lipase from Nile tilapia viscera under ultrasonication was successfully carried out and a higher
yield was obtained. The eventual biodiesel product was characterized for fuel properties and
compared to standard specifications. The attenuated total reflection-Fourier transform infrared
spectroscopy (ATR-FTIR) was applied to ensure the conversion of used cooking oil into biodiesel.
The results indicated that the transesterification process is a successful means to alter the fuel
properties of oil and transfer them into a more valuable fuel. The fatty acid methyl ester content was
97.59% (w/w) analyzed by gas chromatography. The properties of the obtained biodiesel (viscosity,
acid value, water content, iodine value, density, pour point and cloud point) satisfy the EN 14214
and ASTM D 6751 standards. Therefore, the obtained biodiesel could be used as an alternative for
diesel in the automotive industry.
Keyword: Lipase, Nile tilapia, Used cooking oil, Biodiesel, Ultrasonication
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
43
P60-AP
Production of collagen hydrolysate from jellyfish using trypsin and
alcalase with antioxidative activities in lipid emulsions system
Samart Sai-Ut1*
1Department of Food Science, Faculty of Science, Burapha University
169 Long-Hard Bangsaen Road, Saensook, Chon Buri, 20131, Thailand
*Tel.:+66 93 698 5692, E-mail: [email protected]
ABSTRACT:
Oxidation in biological cell promoted by free radicals has been involved in many health problem.
Healthy food with antioxidative activity can prevent the cell damage from those reactive species
and reduce oxidative stress. This research investigated the production of collagen hydrolysate from
jellyfish that inhibits the oxidation of lipid in the emulsion system. For the production of jellyfish
collagen, salted jellyfish was treated by with 1.0 M NaOH and extracted with acetic acid (0.5 M) at
45°C for 24 hours. The jellyfish collagen extract was hydrolyzed with trypsin or alcalase (1:50 and
1:100 enzyme to substrates ratio (E/S)) for 2 hours at pH of 7.8 and 7.0, and temperature of 50°C
and 55°C, respectively. Collagen hydrolysate (CH) hydrolyzed by trypsin with 1:50 (E/S) showed
the highest α amino acid content (0.649 µmole L-leucine/mg sample) and antioxidant activity (396
µmole TE/mg protein). The CH produced by trypsin and alcalase had no significantly different in
hydrophobicity and protein solubility (P > 0.05). The CH produced by trypsin had higher in ABTS
radical antioxidant activity than that of alcalase (P > 0.05). This showed that the type of enzyme
used for hydrolysate production played an important role in the antioxidant activity. The CH
produced by trypsin was added in emulsion system at the concentration of 1.0% and 2.0%,
respectively. Addition of the CH had reduced lipid oxidation determined by conjugated diene (CD)
and peroxide value (PV) assays, when compare to control. After 14 days storage o f the lipid
emulsion samples with 1.0% CH, the formation of peroxide was present less than that of the
emulsion samples without the CH. Jellyfish CH digested by trypsin could inhibit lipid oxidation in
lipid emulsion system during 2 weeks. Thus, the CH from jellyfish may be used as antioxidant for
preventing lipid oxidation in emulsion system.
Keyword: collagen hydrolysate, jellyfish, antioxidant, lipid oxidation, emulsion
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
44
P63-AP
Physical and Nutritional Qualities of Blenderized Diets from Natural
Ingredients
Atchara Kangboonma1,2 and Jirarat Anuntagool1,2*
1Department of Food Science, Faculty of Science, Chulalongkorn University
254 Phyathai Road, Patumwan District Bangkok 10330, Thailand
2Medical Foods Research Group, Faculty of Science, Chulalongkorn University,
254 Phyathai Road, Patumwan, Bangkok 10330, Thailand
*Tel.: +66 2218 5536, E-mail: [email protected]
ABSTRACT:
Enteral nutrition for those who cannot consume regular food can be prepared from commercial
powdered nutrition or by blenderizing fresh natural ingredients. Those from fresh natural ingredients
are frequently preferred for they can satisfy the need for ingredient varieties. However, difficulty in
estimation of nutritional quality and physical property, especially flow property, can arise when the
ingredients are varied to meet satisfaction. This study aimed to analyze the physical and nutritional
qualities of different blenderized diets prepared from natural ingredients. The control formula (CF),
which was obtained from Ramathibodi Hospital’s book on Diets for Healthy and Therapy, provides
around 59 kcal per 100 grams, with 60%, 34%, and 4% energy from carbohydrates, protein and fat,
respectively. CF had low crude fiber content (0.1 %db) with a viscosity of 0.13 Pa·s at 32.5 s-1 shear
rate. Eight (8) different blenderized diets (BD) were formulated based upon the control formula, but
with addition of vegetables and fruits, including banana, pumpkin, sweet potato, papaya, pineapple
and guava. The viscosity of BDs ranged from 0.13 to 0.50 Pa·s at 32.5 s-1 shear rate. They also had
significant different (p ≤ 0.05) physical qualities which include flow behavior index (n; 0.55 to 0.95),
consistency index (K; 0.14 to 2.17 Pa·sn), pH (5.9 to 6.9), color (90° to 98° hue angle and 11 to 15
chroma) and total acidity (0.10 to 0.30% citric acid equivalent). All BDs had significant different
proximate compositions (p ≤ 0.05) which consist of moisture content (0.85 to 0.88 %wb), ash (1.70
to 2.60 %db), crude protein (25 to 40 %db), crude fat (2 to 7 %db), crude fiber (0.10 to 5.80 %db)
and carbohydrates (50 to 70 %db). The formulas provide 44 to 59 kcal 100 per grams diet, with 50
to 70%, 25 to 40%, and 2 to 7% energy from carbohydrates, protein and fat, respectively. All
formulas contain higher crude fiber content (1.0 to 5.5 %db) compared to the control formula.
Keyword: Enteral nutrition, Blenderized diets, Natural raw materials, and Flow property
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
45
P71-AP
Melanogenesis by peptide derived from bee pollen (Apis mellifera) in
murine melanoma cells (B16F10)
Papassara Sangtanoo1, and Aphichart Kanchanatat1*
1 Institute of Biotechnology and Genetic Engineering, Chulalongkorn University,
254 Phayathai Road, Pathumwan, Bangkok 10330, Thailand
* E-mail: [email protected]
ABSTRACT: Melanin plays a role in determining human skin color of a person, and a large amount of melanin
makes the skin color look darkened. Melanin is synthesized in the melanosome of melanocytes by a
process known as melanogenesis. Microphthalmia-associated transcription factor (MITF) is known
as a mater regulator of three major melanogenic enzymes. It also regulates the transcription of three
major melanogenic enzymes, tyrosinase (TYR), tyrosinase-related protein-1 (TRP-1) and tyrosinase-related protein-2 (TRP-2). In this study, we investigated the inhibitory effect of peptide on
melanogenesis and its mechanism in B16F10 cells. In cultivated cells, the melanogenesis
regulatory effect of peptide was evaluated using cell viability, melanin content and intracellular
tyrosinase activity in B16F10 melanoma cells. The expression of MITF, TYR, TRP-1 and TRP-2
were also examined. In addition, the expression of melanogenesis-related proteins was determined
by real-time PCR. The results demonstrated that peptide reduced melanin content and inhibited
intracellular tyrosinase activity. The cytotoxic effect of peptide on B16F10 cell proliferation were
dose-dependent, and the low concentration range peptide (0.17-0.35 µg mL-1) did not produce cytotoxic
effect against B16F10 murine melanoma cells. At lower concentrations ranging from 0.17 and 0.35
µg mL-1, showed no cytotoxic effect with percentage of cell viability at 94.85% and 81.48%,
respectively. The results demonstrated that concentrations of peptide (0.17, 0.35, 0.70 and 1.40 µg
mL-1) showed melanin content at 78.76, 72.98, 66.67, 37.88 %, respectively. The results indicated that
peptide treatment significantly reduced cellular tyrosinase activity. Real-time PCR results revealed
a down-regulation of the mRNAs of these proteins. The peptide reduced the mRNA expression of
TYR, TRP-1, TRP-2 and MITF in melanogenesis. Therefore, the peptide could be developed as
tyrosinase inhibitor and formulated in skin-whitening products for cosmetic or therapeutic use.
Keyword: melanogenesis, bee pollen, L-tyrosine, L-DOPA, B16F10 melanoma cell
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
46
P74-AP
Simultaneous determination of different forms of vitamin D in foods
by liquid chromatography tandem mass spectrometry (LC-MS/MS)
Philipda Suthipibul1, Kunchit Judprasong1*, Sitima Jittinandana1, Nipa Rojroongwasinkul1,
Boonsong Ongphiphadhanakul2, Piyanut Sridonpai1, and Chanika Chimkerd1
1Institute of Nutrition, Mahidol University, Puttamonthon 4 Rd.,
Salaya, Phutthamonthon, Nakhon Pathom 73170, Thailand
2Faculty of Medicine Ramathibodi Hospital, Mahidol University,
270 Rama VI Road, Ratchatewi, Bangkok 10400, Thailand
* E-mail: [email protected]
ABSTRACT:
Introduction. There are two major forms of vitamin D found in foods namely: cholecalciferol
(vitamin D3) and ergocalciferol (vitamin D2), formed by 7-dehydrocholesterol and ergosterol as
precursors, respectively. To determine vitamin D status in human body, 25-hydroxy-vitamin D3
(25-OH D3) and 25-hydroxy-vitamin D2 (25-OH D2) are commonly used as biomarkers. Previous
studies have reported that standard methods of high performance liquid chromatography (HPLC)
have been used to determine vitamin D in foods two sets (one for D3 and another for D2) and could
have analysed only two forms. This study aims to simultaneously determine six forms of provitamin
D and vitamin D, including vitamin D2, vitamin D3, ergosterol, 7-dehydrocholesterol, 25-OH D2 and
25-OH D3 in foods by liquid chromatography tandem mass spectrometry (LC-MS/MS). Method.
About 1±0.1 g of dried sample was saponified and extracted using pentane-ether (80:20) without
using solid-phase extraction (SPE) before injection. The extract was collected and dried under
nitrogen. Different forms of vitamin D were separated using ultra pressure liquid chromatography
(UPLC) and quantitated using LC-MS/MS. Results. Calibration curves for all forms of vitamin D
showed good linearity (R2 values greater than 0.99). Good precision for fish and mushroom was
obtained with a relative standard deviation of less than 15%. Limits of detection (LOD) of 25-OH
D3, 25-OH D2, 7-dehydrocholesterol, ergosterol, vitamin D3 and vitamin D2 were 0.09, 0.14, 0.12,
0.36, 0.05 and 0.06 μg/100g, respectively and limits of quantitation (LOQ) were 0.29, 0.47, 0.40,
1.19, 0.18 and 0.20 μg/100g, respectively. Accuracy performance of this method was performed
using standard reference material (NIST-1846, infant formula) and the result of vitamin D3 showed
no significant difference (p>0.05) from that of certified value. Conclusion. This study demonstrated
that the developed method could detect not only the major forms of vitamin D, but also their
precursors and biomarkers with good reliable results. The LC-MS/MS method is, therefore, the
most suitable for studying different forms of vitamin D in foods with good sensitivity, precision,
and accuracy.
Keyword: Vitamin D, Simultaneous detection, LC-MS/MS
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
47
P76-AP
Effect of Enzymatic Extraction Method on the Chemical Properties of
Partially Defatted and Defatted Rice Bran Protein Hydrolysates
Panchanit Eiam-o-pas1, Kamolwan Jangchud1* and Sunee Nitisinprasert2
1 Department of Product Development, Faculty of Agro-Industry, Kasetsart
University 50 Ngamwongwan Rd., Bangkok, 10900, Thailand
2 Department of Biotecnology, Faculty of Agro-Industry, Kasetsart University
50 Ngamwongwan Rd., Bangkok, 10900, Thailand
*Tel.: +66 2562 5007, E-mail: [email protected]
ABSTRACT: Rice bran is a by-product from milling process consisting of 12-15% protein and 15-20% fat
content. In addition, partially defatted rice bran (PB) and defatted rice bran (DF) are the by-
product from rice bran oil industry which can be used to produce protein hydrolysate. Therefore,
the aim of this study was to investigate the effect of hydrolysis times (2, 4 and 6 h) and rice
bran type (PB and DB) on protein content, total phenolic content (TPC) and antioxidant activities
(ABTS and FRAP) of protein hydrolysate using Alcalase hydrolysis. The increasing in
hydrolysis time significantly (P<0.05) increased DH, hydrolysate yield, protein content, TPC
and antioxidant activities of partially defatted and defatted rice bran protein hydrolysate; PBPH
and DBPH, respectively. At the same hydrolysis time, rice bran type had no significantly
(P≥0.05) effect on hydrolysate yield. Protein content of DBPH (25.57%-29.11%) tended to be
higher than that of PBPH (24.07%-25.52%). Moreover, TPC content of DBPH had higher than
that of PBPH. Therefore, both PB and DB can be used as raw material for protein hydrolysate
production.
Keywords: Protein hydrolysate, Partially defatted rice bran, Defatted rice bran, Alcalase,
Antioxidant activity
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
48
P80-AP
Nutritive values of indigenous plants in Kanchanaburi province
Pichakorn Kongprapun1, Kunchit Judprasong1*, Nongnuch Sungayuth2, Monruedee
Sukprasansap1, Piyanut Sridonpai1, and Chanika Chimkerd1
1Institute of Nutrition, Mahidol University, Puttamonthon 4 Rd., Salaya,
Phutthamonthon, Nakhon Pathom 73170, Thailand
2Division of Science and Liberal Arts, Mahidol University,
Kanchanaburi 71150, Thailand
* E-mail; [email protected]
ABSTRACT:
Introduction. Nutritive values of plants are important information for various users as key nutrients
for good health. Most of indigenous foods in communities of Thailand are lack information of
nutritive values due to their huge biodiversity. This study aims to study major nutrients, minerals
and vitamin C contents of locally consumed indigenous plants at conserve area of Plant Genetic
Conservation Project under the Royal initiative of Her Royal Highness Princess Maha Chakri
Sirindhorn in Electricity Generating Authority of Thailand, Srinakarindr Dam, Kanchanaburi
province. Method. Young edible shoot and leaves of indigenous plants from five varieties (Melientha
suavis Pierre (Pak-Wan-Pa), Albizia lebbeck (L.) Benth (Ta-Kuk), Mearua siamensis (Kurz.) Pax
(Jang), Kaempferia galanga (L.) (Wan-Pro), and Hymenodictyon orixense (Roxb.) Mabb (Som-
Kob)) were collected from three sources (n=3) from 5 routes around conservative study areas
during January-August 2019. Edible portion of each sample was freshly homogenized for nutrients
and vitamin C determination. All analyses were performed using well -validated method at
accredited ISO/IEC 17025 laboratory at Institute of Nutrition, Mahidol University. Results. Young
shoot and leaves of Jang, Ta-Kuk, and Pak-Wan-Pa contained high amounts of protein (9.51+1.24,
7.70+0.94, and 5.97+0.85 g/100g edible portion fresh weight, FW). These plants also provided
considerable amount of dietary fiber (10.29+1.75, 5.35±0.21, and 4.95±0.47 g/100g FW,
respectively). All studied plants had low amount of fat (< 1 g/100g FW) and carbohydrate (1-9
g/100g FW). Macro mineral found in studied plants was potassium (>200 mg/100g FW) followed
by calcium (40-180 mg/100g FW) and phosphorus (32-140 mg/100g FW). Ta-kuk contained
extraordinary amount of vitamin C (212±32 mg/100g FW) followed by Pak-Wan-Pa (146±19
mg/100g FW). Conclusion. Some indigenous plant, Pak-wan-pa as examples, become a commercial
plant for growing and consuming for general consumer with lack of beneficial information. The
scientific information from this study is strongly supported not only for local area but also for the
Thai population. These indigenous plants should be promoted for conservation, commercialized
growing, utilizing and consumption for nutrition well-being. Further studies on health promotion
and disease prevention as well as development of value-added product for trade should be carried
on.
Keyword: Indigenous plants, major nutrients, mineral, vitamin
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
49
P88-AP
Effect of Pressure and Temperature on Fat Removal of Silkworm
Pupae (Bombyx mori L.) by Supercritical Carbon Dioxide Extraction
Pattanawich Joopawang1 and Warangkana Sompongse2*
1Department of Food Science and Technology,
Faculty of Science and Technology, Thammasat University
99, Phaholyothin Road, Khlong Luang, Pathum Thani, 12120, Thailand
2Department of Food Science and Technology,
Faculty of Science and Technology, Thammasat University
99, Phaholyothin Road, Khlong Luang, Pathum Thani, 12120, Thailand
*Tel.:+66 2564 4486, E-mail: [email protected]
.
ABSTRACT:
Edible insects are an alternative source of protein, but are not widely accepted. Silkworm pupae
(Bombyx mori L.) are a by-product of silk production, and are used as feed or consumed in roasted
form. The silkworm pupae are high in protein and fat (47-55% and 30-32%, respectively). Extraction
of fat improves the usability of insect powder. Solvent extraction is an effective method, but solvent
may remain after treatment. Supercritical carbon dioxide extraction is an alternative method, being
non-toxic and providing solvent separation. This study investigated the optimum condition for
supercritical carbon dioxide extraction (SCDE) of fat from silkworm pupae at pressures of 200 and
300 bar and temperatures of 40, 50 and 60 oC. Solvent extraction with ethanol was used as a control.
The fat content remained in sample following ethanol extraction was 21.45±6.86%, decreased from
that of the freeze dried silkworm pupae 45%. Using SCDE, the remained fat content increased as
the pressure and temperature increased. At 200 bar and 40 oC, the remaining fat content was
26.33±3.17%, it was not significantly different (p ≤ 0.05) from ethanol solvent extraction. The
particles size of the defatted silkworm pupae powder before sieving showed a range of sizes with a
broad distribution. After sieving through 60 mesh (250 µm), the particle size was more consistent.
The results suggest that, SCDE is an alternative method for fat extraction and the sieving through a
60 mesh aperture makes the product more consistent.
Keyword: Silkworm pupae, Fat Extraction, Supercritical Fluids
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
50
P126-AP
Quality of Nipa Palm Syrup from Different Batches of Production
Yosephine Adela Djohan1 and Mutita Meenune1*
1Department of Food Technology, Prince of Songkla University
15 Karnjanavanich Road, Hatyai, 90110, Thailand
*Tel.:+ 66 82 676 1521, E-mail: [email protected]
ABSTRACT:
Nipa palm syrup is expected to have a minimum total soluble solid of 65°Brix as regulated in Thai
Community Product Standard, a 5-hydroxymethylfurfural content of 40.00 mg/kg or less as
referred in Codex Alimentarius, moisture content of 35% or less, water activity below 0.85 and
total sugar content above 60%. This research was conducted to characterize Nipa palm syrup
obtained from different batches of production to monitor its quality consistency. The samples of
Nipa palm syrup were taken from six production batches. Total soluble solid of the six samples were
varied from 66.5 to 73.3°Brix, which is above the minimum limitation set in Thai Community
Product Standard. The moisture content and water activity of the samples were varied from 27.42
to 30.89% and from 0.778 to 0.820, respectively. All samples met the standard of moisture content
and water activity. The total sugar contents of the samples were 63.43-72.76% w/w, which is higher
than the minimum value of 60%. The HMF content of all samples were varied from 3.13 to 25.29
mg/kg which were within the limitation in Codex Alimentarius. pH of the six samples were varied
from 4.87 to 5.38, while the total acid contents were in the range of 0.22-0.34% as lactic acid. The
total soluble solid is related to the total sugar content of the syrup, while 5-hydroxymethyl furfural
content is positively related with acidity. The six samples were significantly different from each
other in all quality attributes (p<0.05), but all of them are qualified according to the standards.
Keyword: Nypa fruticans, Nipa palm, Syrup, Quality, 5-Hydroxymethylfurfural
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
51
P145-AP
Yield, Morphology and Crystallinity of Cellulose from Soybean Hulls
using Pressure Microwave-Assisted Extraction
Lamnambhorn Sobmor1 and Kittichai Banjong1*
1Faculty of Agro-Industry, King Mongkut’s Institute of Technology Ladkrabang
Bangkok, 10520, Thailand.
*E-mail: [email protected]
ABSTRACT:
Chiang Mai 60 is a common Thai soybean variety, cultivated in northern Thailand, for its high
yield in both rainy and dry seasons and resistance to soybean rust disease. Soybean hulls are a
processing by-product and were chosen as raw materials for cellulose production. Cellulose was
extracted from the hulls using acid and alkaline digestion in pressure microwave -assisted
extraction. Cellulose yield was measured, the physicochemical properties were characterized by
determining color, scanning electron microscopy, energy-dispersive X-ray spectroscopy (EDS) and
X-ray diffraction (XRD). Cellulose yield was 28.0 ± 0.8% (w/w dry basis). The color (CIE L*
value) was significantly improved by microwave assisted extraction (p <0.05), Chroma showed
orange-brown tones and hue had a yellow color. SEM morphological analysis confirmed the
presence of cellulose. EDS showed that the primary macronutrients were C, O, P and K; secondary
macronutrients were Ca and S and micronutrients included B, Si and Na. XRD diffraction showed
that the crystallinity index was equal to α-cellulose (67%).
Keyword: Cellulose, Soybean hulls, Pressure microwave-assisted extraction
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
52
P59-AJ
Investigation of hydrolyzed ceramide in Thai color rice (Oryza sativa
L.) and by-products
Paosila, C., Rumpagaporn, P. and *Na Jom, K.
Department of Food Science and Technology, Faculty of Agro-Industry,
Kasetsart University50 Ngam Wong Wan Road, Lad Yao, Chatuchak,
Bangkok 10900, Thailand
*E-mail: [email protected]
ABSTRACT:
Ceramide is sphingolipid, which provides health benefits. Gas chromatography coupled with flame
ionized detector (GC-FID) was developed for targeted analysis of hydrolyzed ceramide in color rice
and by-products. Method validation was done by means of linearity, repeatability and %recovery.
R2 of 0.99 by means of linearity equation of the method was obtained. The recovery was in the range
of 69.85 – 108.73% with RSD of normalized peak area lower than 10%. Hydrolyzed ceramide was
found in unpolished rice, both glutinous and non-glutinous rice and its by-products including,
defatted rice bran, rice bran wax and rice bran oil. The relationship between varieties of rice color
and ceramide content was classified using principal component analysis (PCA) into 2 groups,
including dark and pale color rice group. The highest levels of hydrolyzed ceramide as 21.11+0.02
mg/100g was found in Mali Nil Surin (MNS), a black non-glutinous rice. Whereas, a white non-
glutinous rice named Seebukantang (SBK) contained the lowest content of hydrolyzed ceramide as
12.69+0.03 mg/100g. The amount of ceramide in by-products found in defatted rice bran, rice bran
oil and rice bran wax was 17.43±0.38, 14.67±0.16 and 12.54±0.41 mg/100g, respectively.
Keywords: Ceramide, Hydrolyzed ceramide, GC-FID, Color rice, Rice by-products, PCA
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
53
DIVISION B
Food Processing and Engineering
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
54
O70-BB
Subcritical ethanol extraction of oil from coconut meal
Thussanee Plangklang and Pramote Khuwijitjaru*
Department of Food Technology, Faculty of Engineering and Industrial
Technology, Silpakorn University, Nakhon Pathom, 73000, Thailand
*E-mail: [email protected]
ABSTRACT:
Coconut meal from coconut milk process still contains relatively high amount of lipid which can
be further extracted using suitable solvent. This work aimed to evaluate the feasibility of subcritical
ethanol extraction of oil from coconut meal in a batch-type vessel. Coconut meal with an oil
content of 19.85% (w.b.) was treated with subcritical ethanol at various ethanol concentrations (80-
100%), solvent-solid ratios (8:1, 10:1, and 15:1 v/w), temperatures (80−120 °C), and times (0−45
min). The highest oil recovery (81.49%) was obtained from the extraction with 100% ethanol and
solvent-solid ratio of 8:1 (v/w) at 100 °C for 45 min which did not significantly differ from those
obtained at 120 °C for 15−45 min. The oils obtained from every extraction condition was slightly
yellow and clear. The chemical properties, including peroxide value, saponification value,
unsaponifiable matter and fatty acid profile of the oils conformed to the Asian and Pacific Coconut
Community (APCC) standard, while free fatty acid values of all samples were above the maximum
standard limit. The total phenolic content (g gallic acid equivalent (GAE)/g oil) and DPPH
radical-scavenging activity (% inhibition) of the oils from the subcritical ethanol extraction at 100
°C, 45 min (47.80 g GAE/g oil, 51.06%) and 120 °C, 15 min (26.80 g GAE/g oil, 33.15%) were
significantly higher than that of the soxhlet extraction using hexane for 45 min (13.67 g GAE/g
oil, 8.45%). The results indicated that subcritical ethanol extraction has a potential to extract oil
from coconut meal with a higher antioxidant activity compared to the conventional solvent
extraction, in short extraction time.
Keyword: coconut oil, subcritical fluid extraction, solvent extraction, antioxidant activity
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
55
O140-BB
Production of D-tagatose from D-galactose by subcritical aqueous
ethanol
Neeranuch Milasing and Pramote Khuwijitjaru*
Department of Food Technology, Faculty of Engineering and Industrial
Technology, Silpakorn University, Nakhon Pathom 73000 THAILAND
*E-mail: [email protected]
ABSTRACT:
D-Tagatose is a rare natural ketohexose which can be used as a low-caloric sweetener. It can
be produced by an isomerization reaction of the corresponding aldose, D-galactose by three
different methods, i.e. enzymatic, chemical, and subcritical fluid treatments. This work
investigated the isomerization of D-galactose to D-tagatose under subcritical aqueous ethanol
conditions in 10 mL stirred-vessel at the substrate D-galactose concentration of 5% (w/v), and
temperature of 200ºC, where the ethanol concentration and reaction time were varied between 60,
80, and 95% w/w; and 0, 5, 10, 15, 20 min. The treated solution was analyzed for remaining D-
galactose, and produced D- tagatose and D-talose, 5-hydroxymethylfurfural (5-HMF) and pH
value. The result showed that D- galactose decreased with increasing reaction time, but
increased with increasing ethanol concentration, at the reaction time of 20 min. The remaining
D-galactose concentration were 44, 58, and 82 % at the ethanol concentrations of 60, 80, 95 %
(w/w), respectively. The conversion of D- galactose increased with increasing reaction time,
but decreased with increasing ethanol concentration. The products of the isomerization reaction
was D-tagatose with the side product, D- talose. The yield of D-tagatose increased with increasing
reaction time, with the highest of 6% at 60% (w/w) ethanol, and reaction time of 20 min. 5-HMF
and acids were formed as byproducts from degradation reactions of the monosaccharides. 5-
HMF content increased with increasing reaction time but decreased with increasing ethanol
concentration. pH value slightly decreased with increasing residence time. The results indicated
that the ethanol concentration of 60 % (w/w) promoted both the isomerization of D-galactose to D-
tagatose and the degradation of monosaccharides.
Keyword: D-tagatose, D-galactose, rare sugar, subcritical aqueous ethanol, isomerization
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
56
O53-BP
Optimization of Pectin Extraction from Green Mature Garcinia
atroviridis Rind using Response Surface Methodology
Gerry Renaldi1* and Rajnibhas Sukeaw Samakradhamrongthai1,2
1Department of Food Technology, Faculty of Agro-Industry, Prince of Songkla University
15 Karnjanavanich Rd., Hat Yai, 90110, Thailand
2Agro-Industrial Product Development Research Unit, Faculty of Agro Industry,
Prince of Songkla University
15 Karnjanavanich Rd., Hat Yai, 90110, Thailand
*Tel.:+66 98 720 6465, E-mail: [email protected]
ABSTRACT:
Garcinia atroviridis (Som Khaek) is a fruit found in Southern Thailand and frequently used for
various purposes. Pectin is a polysaccharide found in plants widely applied in food and
pharmaceutical industries. This study was aimed to investigate pectin extraction from the rind of
green mature Garcinia atroviridis using three different factors: concentration of citric acid (50-
100 mM), extraction time (30-60 min), and extraction temperature (70-90 oC). The Box- Behnken
Design (BBD) was used to optimize the conditions for pectin extraction over Response
Surface Methodology (RSM). The yield recovery and degree of esterification (DE) were the main
criteria in this experiment. The optimum pectin extraction condition was under the condition of
93.00 mM of citric acid for 59.49 min at 89.21 oC, resulting in high pectin yield recovery
(7.40±0.18%) with DE at 64.60±1.8%. The extracted pectin was analyzed for equivalent weight,
methoxyl content, and anhydrouronic acid (AUA) content. The results showed that the
extracted pectin from the rind of green mature Garcinia atroviridis using optimized condition
consisted of 387.88±20.99 of equivalent weight, 7.75±0.77% of methoxyl content, and
89.47±2.54% of AUA content. The outcome from the extraction suggested green mature
Garcinia atroviridis can be used as pectin source. The analysis of pectin properties also
revealed that the extracted pectin from the rind of green mature Garcinia atroviridis can
be classified as high methoxyl pectin which can be used as an alternative raw material in fruit
preserved product such as jam and jellies to create good quality product for consumer using
local ingredient.
Keywords: Garcinia atroviridis, Pectin, Methoxyl, Box-Behnken Design, Response Surface
Methodology
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
57
O81-BP
Optimization of hydrothermal technique for the production of
nanocellulose from bamboo shoot shell
Kanjana Manamoongmongkol1, Pongsert Sriprom1*, Rachit Suwapanich1, Panadda
Nonthanum1 and Lamphung Phumjan1
1Department of Food Industry, Faculty of Food Industry,
King Mongkut’s Institute of Technology Ladkrabang
Lat Krabang, Bangkok, 10520, Thailand
*Tel.:+66 94 385 2442, E-mail: [email protected]
ABSTRACT:
The optimization condition of nanocellulose produced from bamboo shoot shell using hydrothermal
technique was studied. The operating process of nanocellulose contains 2 main steps including the
delignification of bamboo shoot shell and the production of nanocellulose. The delignification of
bamboo shoot shell was carried out using 5%NaOH and 4%H2O2 treatment. The hydrothermal
condition of the production of nanocellulose was optimized using Box-Behnken design based on the
yield. The optimum nanocellulose yield of 96.33% was obtained at a temperature of 120°C, the
pressure at 1 bar, the reaction time of 2 h 5 min, and the cellulose weight of 5 g. The optimization
was verified by repeating the experiment using optimum conditions to confirm accuracy.
Keyword: bamboo shoot shell, nanocellulose, hydrothermal, optimization
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
58
O83-BP
Effects of High-Pressure Processing on Textural Properties of
Threadfin Bream Surimi Gel
Boodasayapuk Buasakchai1, Phatthira Sutloet1 and Warangkana Sompongse1*
1Department of Food Science and Technology,
Faculty of Science and Technology, Thammasat University
99 Phaholyothin Road, Khlong Luang, Pathumthani 12120 Thailand
*Tel.:+66 2564 4486, Email: [email protected]
ABSTRACT: Improving the texture of surimi- based products without use of additives or hydrocolloids is a
challenge. This research investigated high-pressure processing ( HPP) at 150 and 300 MPa and
holding times of 5, 10 and 15 min of threadfin bream (Nemipterus hexodon) surimi gel. The textural
properties improved after HPP at 150 MPa, but decreased at 300 MPa. HPP at 150 MPa for 15 min
was the optimum condition to improve for gel strength and water holding capacity. This condition
was used to investigate the effects setting conditions (40ºC/30 min, 90ºC/20 min, and 40ºC/30 min
followed by 90ºC/20 min). Breaking force and gel strength of pressurized samples were higher than
the non-pressurized control. The expressible water content and total sulfhydryl decreased when HPP
was applied. Setting at 40ºC for 30 min followed by 90ºC for 20 min after HPP at 150 MPa optimized
gel formation.
Keyword: Threadfin bream surimi, High pressure, Gelation, Surimi gel, Textural property
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
59
O111-BP
Effect of Preparation Methods on β-Cyclodextrin Encapsulated Holy
Basil (Ocimum Sanctum Linn) Essential Oil Properties
Wantanee Noichinda1 and Inthawoot Suppavorasatit1*
1Department of Food Technology, Faculty of Science, Chulalongkorn University
Phyathai Rd. Wangmai, Pathumwan, Bangkok, 10330, Thailand
*Tel. +66 2218 5515-6 E-mail: [email protected]
ABSTRACT:
Holy basil (Ocimum sanctum Linn.) essential oil is responsible for characteristic odors, which are
popular and used as food flavorings and preservatives. The inclusion complex of essential oil with
β-cyclodextrin (β-CD) is one of encapsulation techniques to protect against compounds
decomposition in essential oil and to increase solubility in water. The objective of this study was to
study the effect of preparation conditions on properties of encapsulated holy basil essential oil with
β-CD. The properties of the inclusion complexes including encapsulation efficiency, loading
capacity, moisture content, and solubility were measured. The percentage of encapsulation
efficiency and loading capacity were ranged from 5.77 to 15.46 and 5.28 to 9.32, respectively. The
highest efficiency was achieved by sample prepared at atmospheric pressure for 2 h. The moisture
contents and solubility were found no significantly different among preparation conditions.
Moreover, surface morphology and physical interaction on the capsules were evaluated by scanning
electron microscopy (SEM) and fourier-transform infrared spectroscopy (FTIR). The results
indicated that the inclusion complexes had changed in particle size and shape. In addition, FTIR
spectroscopy showed that the holy basil essential oil was well encapsulated in the cavity of β-CD.
The appropriate condition for preparation of inclusion complex can be used to produce encapsulated
holy basil essential oil and apply into various food and beverage industries.
Keywords: holy basil, essential oil, beta-cyclodextrin, encapsulation, inclusion complex
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
60
O139-BP
Effects of Pasteurization and High Pressure Processing on Quality of
Sweetened Condensed Rice-Cereal Milk
Rawiporn Polpued1 and Krittiya Khuenpet1*
1Department of Food Science and Technology,
Faculty of Science and Technology, Thammasat University, Rangsit Centre
Khlong Nueng, Khlong Luang, Pathum Thani 12120, Thailand
*Tel.:+66 2564 4440, E-mail: [email protected]
ABSTRACT: The objective of this research was to study effect of pasteurization and high pressure processing on
physical and sensorial properties of sweetened condensed rice-cereal milk (SCRM). One SCRM
sample was conventionally pasteurized at 63 °C for 30 min and other four samples were treated by
applying high pressure processing (HPP) at 300, 400, 500 and 600 MPa for 10 min. The result
showed that pasteurized SCRM samples had lightness (L*), greenness (a*) and whiteness values
greater than HPP SCRM samples which were 85.17, -0.45 and 83.11, respectively. The increase of
high pressure application significantly affected the color values of the HPP samples. The higher in
lightness (L*) and greenness (a*) values were observed when the high pressure was applied at 600
MPa for 10 min. However, there was no significant difference in greenness (a*) among HPP SCRM
samples. The water activity, total soluble solid and solubility index of all samples were in the ranges
of 0.980-0.982, 24-25 °Brix and 0.2 ml. The viscosity values of HPP SCRM samples at 300 and 400
MPa (1,441.67 and 1,440.00 cP, respectively) were higher than SCRM pasteurized with the
conventional method (1,217.50 cP). The Herschel-Bulkley model was found to describe the flow
behaviour of pasteurized and HPP samples with the flow behaviour index (n) in the range of 0.30-
0.34. There was no significant difference in yield stress (σo) between HPP SCRM samples and
commercial sweetened condensed milk. The SCRM pasteurized by conventional method obtained
greater sensorial scores in rice flavor, sweetness, oiliness, viscosity and overall acceptability at the
level of slightly like.
Keyword: Conventional, Herschel-Bulkley model, High pressure processing, Pasteurization,
Sweetened condensed milk
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
61
P11-BB
A mixture design approach on the texture of food gel bead made from
tapioca flour, soy flour and cane sugar
Nattagan Chantagith1, Natnaree Katkaew1, Panida Rattanapitigorn1*
1 Division of food Science and Technology, Faculty of Agro-Industry,
Chiang Mai University 155 Moo2, MaeHae, Mauang Chiang Mai,
Chiang Mai, Thailand 50100
*E-mail: [email protected]
ABSTRACT:
An extreme vertices design for a mixture of three components was used to find out optimum
proportion of tapioca flour (mass fraction of 0.5000-1.0000), soy flour (mass fraction of 0-0.5000),
and cane sugar (mass fraction of 0-0.1000) in food gel bead system. Nine compositions of the three
components were prepared. Pasting profiles of the powder mixtures were analyzed by Rapid Visco
Analyzer and texture profiles of fresh, chilled, and rehydrated- freeze-dried tapioca flour-soy flour-
cane sugar (TF-SF-CS) gel beads were evaluated using a texture analyzer. Increase in the proportion
of soy flour in the range of 0.1125-0.5000 decreased peak viscosity, breakdown, final viscosity, and
setback value. Using tapioca flour in the proportion of 0.8125-1.0000 gave the lowest hardness of
fresh TF-SF-CS gel beads (92.00-283.00 g-force). Soy flour in the proportion of 0.1125-0.500
exhibited lower texture profiles (hardness, cohesiveness, springiness, gumminess, chewiness, and
resilience) than those of pure tapioca flour for chilled and rehydrated-freeze-dried gel beads.
Significant relationships among pasting profiles of TF-SF-CS mixtures and texture profiles of fresh,
chilled, rehydrated-freeze-dried beads were found. This implied a functional role of soy flour in food
gel beads. In conclusion, soy flour can act as anti-retrogradation for TF-SF-CS gel beads stored
under chill condition (4 ºC for 7 days) and in freeze-drying conditions. The small amount of cane
sugar did not affect retrogradation of starch in the TF-SF-CS gel bead system.
Keyword: food gel bead, soy flour, cane sugar, pasting profile, anti-retrogradation
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
62
P62-BB
Surface Modification to Reduce Deposition Flux of Spray Dried Noni
(Morinda Citrofolia L.) Juice
Abidin N. Z., Zubairi, S.I.* & Hashim, H.*
1Department of Food Sciences, Faculty of Science & Technology,
Universiti Kebangsaan Malaysia, 43600 UKM Bangi, Selangor
*Tel.:+603 8921 5989, E-mail: [email protected]
ABSTRACT:
Spray drying is widely spread technique for drying of liquid products especially fruit juices such as
noni juice. However, during spray drying of noni juice stickiness problem commonly occurs due to
low molecular weight sugars (sucrose, glucose and fructose). The aim of the present research was
to determine the impact of Teflon surface modification on the yield of spray dried Noni juice and
deposition flux. Different exposure time of feed spray was undertaken prior to adhesion flux
weight determination. Three different sets of inlet temperature (100 oC, 150 oC and 190 oC) and
exposure times (of 15 min, 30 min, 60 min, 75 min, 90 min and 115 min) were tested. Samples
were evaluated for contact angle, weight of adhesion flux, hygroscopicity and moisture content.
There was a sudden increased in deposition flux (p<0.05) as the temperature increased. At 150 and
190°C, the weight of deposition flux was not significant (p>0.05) for both plate materials. The
borosilicate plates (BP) registered up to 80% deposit removal whilst Teflon plate (TP) recorded
only 20%. Physical observation of the Teflon plates showed that some areas of the plate (100 °C)
were fully clear from any particles. Nevertheless, for the borosilicate glass plates, the primary
adhered particles tend to retain and smeared along the plates. In addition, there was a substantially
negative relationship between the contact angle and adhesion weight, (r = -0,924, p<0.01). The
negative connection suggests that by increasing the contact angle, the adhesion weight will
decrease and vice versa. The contact angle of the Teflon (PTEFE) surface was approximately 117.2
± 1.4°, which provided an excellent hydrophobic surface. In this research, the powder with the
lowest amount of hygroscopicity was gained at 190 oC using the Teflon plate. For that reason,
surface modification was indeed amplified the surface hydrophobicity thus decreasing the
deposition flux
Keyword: adhesion, deposition flux, spray drying, stickiness, teflon, yield
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
63
P77-BB
Effect of spray drying conditions on microencapsulation of bioactive
compounds extracted from cassava leaf
Ploypailin Akanitkul, Numphung Rungraung, Uthaiwan Suttisansanee,
Varongsiri Kemsawasd, Thunnalin Winuprasith*
Institute of Nutrition, Mahidol University,
Salaya, Nakhon Pathom 73170, Thailand.
*Tel.: +66 2800 2380 ext. 123, E-mail: [email protected]
ABSTRACT:
This research aimed to investigate the effect of ratio of cassava leave extract in oil-in-water (O/W) emulsion and optimize spray drying condition. Ethanol extract of cassava (Manihot esculenta Crantz) leaf extracts (CLE) at 10% (w/w) could be dissolved in rice bran oil. To prepare the stable oil-in-water
(O/W) emulsions using 1% (w/w) Tween 60 as an emulsifier using a high speed blender at a speed of
10,000 rpm for 3 min, the appropriate concentration of oil containing CLE in the emulsions was varied
at 2.5% (w/w) and 5.0% (w/w). No phase separation occurred in the 2.5% O/W emulsion after storage at
room temperature (25 C) for 24 hours. Hence, the 2.5% O/W emulsion containing CLE was spray-dried using 10% maltodextrin as encapsulating agent at different inlet/ outlet temperatures at
150/80°C, 165/80°C, and 180/80°C. The product yields, physicochemical properties (color, moisture
content, water activity) and antioxidant activities of the microencapsulation CLE powder were
examined. The results showed that the production yields were 86.44% , 85.45% , and 87.3% with the
inlet temperature of 150°C, 165°C, and 180°C, respectively, indicating that there was no significant
difference (p > 0.05) in product yields between each inlet temperature. The product color was green
color. The lightness (L*) decreased and the magnitude of a* and b* values increased with increasing
the inlet temperature. All processing conditions could produce the CLE powder with moisture
content and water activity below 4% (dry weight) and 0.2, respectively. The antioxidant activities
were analyzed by 2,2-diphenyl-1-picrylhydrazyl (DPPH) radical scavenging assay, Ferric reducing
antioxidant power (FRAP) assay and Oxygen radical absorbance capacity (ORAC) assay. There was
no significant difference in antioxidant activities measured by DPPH assay which were in range
between 0.20 to 0.22 mol/100 g (dry weight). The highest antioxidant activities measured by FRAP
and ORAC were 245 and 2,050 µmol/100 g (dry weight) which were found in the CLE powder using
inlet temperature at 150°C. Summary, the best encapsulation condition was atomization of the 2.5% (w/w) O/W emulsion containing CLE (10% in oil phase) at 150 °C and 10 % (w/w) maltodextrin. The
mean particle size of CLE powder was 305 m. The CLE powder product by spray drying can be
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
64
used as an alternative choice as a functional ingredient for functional drinks due to its antioxidant
activities.
Keywords: Microencapsulation, Spray dry, Cassava leaf extract, antioxidant activities
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
65
P137-BB
Acne gel production from pickled mango seed
Kalranath Suwapanichkittikorn1, Suwatchai prapar1, Pongprom ponpermpoon1,
Pongsert Sripron2, and Rachit Suwapanich2,*
1Saint Louis School Chachoengsao, Chachoengsao, 24000, Thailand
2Program of Food Process Engineering, Faculty of Food Industry, King
Mongkut’s Institute of Technology Ladkrabang, 10520, Thailand
*Tel.:+66 89 173 6863, E-mail: [email protected]
ABSTRACT:
Mango is the main economic plant of Chachoengsao province, which is consumed fresh and
processed to add value, for example, pickled mango. The processing will cause the leftover such as
peel and seeds, which are wastes in the processing industry and causing environmental problems.
Therefore, this project was interested to use leftover seeds from the factory as the studied issue. The
purpose is to study and to evaluate the effectiveness of pickled Chok Anan mango seed extract for
inhibiting the growth of microorganisms on the facial skin and to determine the ration and develop
the acne gel extracted from pickled mango seed product. The organizer experimented by extracted
with 95% ethanol in the ratio of 2:40 and 2:80 g/ml. The concentration of 50, 5 and 0.5 mg/ml were
compared to study the important compound in pickled mango seed. Acne gels are made by
determining the ratio of the extract and based gel in 1:3, 2:3, 3:3 and 4:3 ml/g, to test the
effectiveness of the extract and the acne gel extracted from pickled mango seed in inhibiting the
growth of microorganism on the facial skin using Agar disc diffusion method. The result showed
the acne gel extracted from 2:80 g/ml ratio at 50 mg/ml concentration has a clear zone diameter of
around 1.62 cm. The acne gel extracted from 2:40 g/ml ratio at 50 mg/ml concentration has clear
zone diameter around 1.30 cm. While the acne gel extracted from pickled mango seed which the
extract was from 2:40 g/ml ratio at 50 mg/ml concentration, showed the widest clear zone diameter
at 0.70 cm from the 4:3 ml/g ratio. When compared with the control acne gel, the control has a clear
zone diameter of around 0.78 cm. The acne gel extracted from pickled mango seed was less effective
than the control acne gel only 0.08 cm which indicated that there is the possibility of using the
extract from pickle mango seed to develop the acne gel.
Keyword: Pickled mango seed, facial skin, Acne gel
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
66
P13-BP
The quality of Palm sap sugar powder producing by using a prototype
drying machine
Ratana Sananmuang1*
1Department of Chemistry, Faculty of Science, Naresuan University,
99 Moo 9, Thapho, A. Muang, Phitsanulok 65000, Thailand
*Tel.:+66 5596 3425, E-mail:[email protected]
ABSTRACT:
The aims of this research were to build the prototype drying machine for making a palm sap
powder and determine the qualities of this sugar powder including moisture content, amount of
reducing sugar, total soluble solid and its color. The results showed that the prototype drying
machine had good efficiency. The time-consuming of making 20 L of palm sap juice to be powder
was 9-21 min (average value 14.88 ± 4.68). The consumption of electricity was only one unit
which it approximately cost 5 Baht, while that of man-power use took about 90-120 min and cost
100 Baht. The moisture content, amount of reducing sugar and total soluble solid of sugar powder
were 37.78%, 5.80% (or 186.25 ± 13.62 mg/100 mL), and 80.34 ± 1.96 ºBrix, respectively. The
color showed that sugar powder was golden brown, more red, and quite dark yellow that contained
L*, a*, b* color values of 51.76, 4.01, and 19.12, respectively. Overall, this prototype drying
machine for making a palm sap powder has less time-consuming and energy consumption.
Keyword: Moisture, Palm sap, Production, Prototype drying machine, Reducing sugar, Sugar
powder
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
67
P44-BP
Physical and Chemical Properties of Arabica Coffee in Ywangan
Township, Myanmar
Sai Aung Moon1 and Piyaporn Cheamchaitrakun1,2*
1School of Agro-Industry, Mae Fah Luang University 2Tea and Coffee Institute, Mae Fah Luang University
Chiang Rai 57100, Thailand
* Tel.:+66 5391 6752, E-mail: [email protected]
ABSTRACT:
Coffee processing is the main important step to obtain a good green coffee bean and to prevent fruit
spoilage by unfavorable fermentation. The objective of this research was to study the effect of
different coffee processing methods; dry process (DP), wet process (WP), and honey process (HP)
under three factories on the physical and chemical properties of green coffee bean. Coffee green
beans (C. Arabica var. Catuai) were collected from three factories at Ywangan Township, Myanmar.
The sample was prepared by three different processing methods, and analyzed the physicochemical
properties including bulk density, color, moisture content (MC), protein, lipid and fatty acid were
investigated. The result showed that color values for L*,a*, b*, C* and H ̊ were influenced by DP,
WP and HP. DP (14.73-14.86 %) had higher protein content on compared in the WP (13.43-14.21
%), and HP (14.14-14.63 %). Lipid content on WP (12.90-13.33 %) was higher than HP (12.54-
12.63 %) and DP (11.98-12.35 %). Palmitic (C16:0) and linoleic (C18:2) acid was the main fatty
acids and determined as a coffee flavor and aroma. Palmitic (C16:0) of DP (55.23-56.10%) was
higher than WP (53.73-55.47%) and HP (55.03-55.93%) which can provide bitter and sweeter taste.
Linoleic (C18:2) of WP (23.33-23.7 %) was lower than HP (23.77-24.00 %) and DP (23.57-24.57
%) which can provide more acidity. Thus, the different coffee processing methods were significantly
affected (p ≤ 0.05) on physical and chemical properties such as protein, lipid and fatty acids, but no
significant difference (p ≥ 0.05) on density.
Keyword: Arabica coffee, Coffee processing, Myanmar, Physicochemical properties
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
68
P125-BP
Factors affecting yield of protein hydrolysate extracted from porcine
placenta
Thanaboon Theerapattarasakul1, Supanut Leelapunnawut1, Chotika Viriyarattanasak2,
and Punchira Vongsawasdi1*
1 Department of Microbiology, King Mongkut’s University of Technology
Thonburi, 126 Prachautis Rd, Bangkok 10140, Thailand
2 Pilot Plant Development and Training Institute, King Mongkut’s University of
Technology Thonburi, Bangkhuntien, Bangkok 10140, Thailand
*E-mail: [email protected]
ABSTRACT:
Porcine placenta is such abundant source of bioactive compounds and hormones. It therefore is of
interest for an industrial production of protein hydrolysate. Typically, its production yield is
influenced by various factors such as characteristics of placenta, enzyme activity, and hydrolysis
time. This study aimed to investigate factors affecting the production yield, degree of hydrolysis
(DH), and scavenging activity of hydrolysate. The studied factors were (1) blood remaining in
placenta vs washing placenta and (2) particle size of placenta. Results demonstrated that DH of the
hydrolysate from placenta containing blood was 28.89±8.39% which was significantly lower than
those from washed placenta (33.01±6.69%) (P≤0.05). Pre-treatment via washing raw materials
could slightly improve yield and scavenging activity from 14.45±0.31% to 16.99±3.66% and
78.85±4.38% to 80.93±4.03%, respectively. Protein hydrolysate from smaller particle size (width
0.4±0.1 cm; length 1.3±0.6 cm) of placenta provided greater DH (39.38±0.63%), comparing to
those from larger particle size (width 0.9±0.5 cm; length 3.5±1.8 cm) (P≤0.05). The yield and
scavenging activity of hydrolysate from smaller particle were 19.33±2.45% and 70.89±7.48%,
respectively, while those from larger particle were 14.52±1.46% and 71.83±6.49%, respectively.
According to validation in an industrial scale, size reduction process could improve 2 .5% of
production yield, comparing a common manufacturing process.
Keyword: blood remaining, particle size, yield, protein hydrolysate, porcine placenta
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
69
P128-BP
Effect of oyster extract corn flour and sugar
on rheological properties of oyster sauce
Pattra Sangsopa1 and Bootsrapa Leelawat1*
1Department of Food Science and Technology,
Faculty of Science and Technology, Thammasat University,
Pathum Thani, 12120, Thailand.
*Tel.:+66 2564 4440, E-mail: [email protected]
ABSTRACT:
The objective of this research was to study the effect of three independent variables including oyster
extract (9-30%), corn flour (2-5%) and sugar (8-15%) on rheological properties of oyster sauce using
the central composite design (CCD). The relationship between independent variables and dependent
variables including yield stress, consistency coefficient, flow behaviour index and flow rate of oyster
sauce were evaluated by response surface methodology (RSM). The oyster sauce prepared from
different ingredients showed a Herschel Bulkley and shear thinning behaviour. The relationship
between the three independent variables and yield stress together with consistency coefficient was
explained by the quadratic model, whereas the relationship with flow behaviour index as well as
distance to flow was explained by the linear model. The regression equation demonstrated that the
effect of corn flour on consistency coefficient, yield stress, flow behaviour index and distance to
flow was greater than oyster extract and sugar. The increasing ratio of corn flour resulted in
increasing consistency coefficient while decreasing yield stress, flow behaviour index and distance
to flow.
Keyword: oyster sauce, rheological properties, shear thinning, corn flour, central composite design
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
70
P138-BP
Non-Dairy Low Fat Ice Cream Produced from
Germinated Tubtim Chumpare Rice
Thidaporn Meesin1, Sasithorn Wanchum1, Suthee Pungboonya1 and Sirinda Kusump1*
1Department of Food Science and Technology,
Faculty of Science and Technology, Thammasat University,
Patumthani, 12120, Thailand
*Tel.:+66 84 025 4683, E-mail:[email protected]
ABSTRACT Ice cream made with rice has been popular among those who love ice cream and are lactose
intolerant. Colored rice has been used in the ice cream formulation for increasing antioxidant
activity of the ice cream. Tubtim Chumpare rice is a newly developed colored rice cultivar which
is high in antioxidants. The objective of this study was to investigate the possibility of using
germinated Tubtim Chumpare rice as an ingredient in non-dairy low fat rice ice cream. The ice
cream was formulated using 3-6% rice milk (contributing to 0.39-0.78% rice solid), 3% rice bran
oil, 3% inulin, sucrose, glucose corn syrup, stabilizer and emulsifier. Tubtim Chumpare rice grains
were germinated, ground, and sieved before mixing with other ingredients. The rice ice cream
samples were kept frozen at -18 C. The results showed that viscosity of the rice ice cream mix
increased with increasing germinated rice content (p<0.05). Overrun of the ice cream tended to
decrease with increasing germinated rice content while first drip and acidity increased with
increasing germinated rice content (p<0.05). Sensory evaluation revealed that ice cream produced
with 4 and 5% germinated rice milk had highest score in color and texture attributes (p<0.05).
Germinated Tubtim Chumpare rice at the concentration of 0.65% rice solid content can be
considered for formulating non-dairy low fat rice ice cream
Keyword: diary-free, lactose-free, gluten-free, and frozen dessert
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
71
P136-BJ
Survivability of Lactobacillus acidophilus and quality attributes of
puffed pounded-unripe rice supplemented with probiotics using a
fluidized-bed coating method
1,*Duangkhamchan, W., 2Itsaranuwat, P.
1Research Unit of Process Design and Automation, Faculty of Engineering,
Mahasarakham University, Kamriang, Kantarawichai, Maha Sarakham 44150, Thailand
2Department of Biotechnology, Faculty of Technology, Mahasarakham
University, Kamriang, Kantarawichai, Maha Sarakham 44150, Thailand
*E-mail: [email protected]
ABSTRACT:
Value-added breakfast cereals are receiving increased interest due to changes in lifestyles and
modern trends of health awareness among consumers. Among various cereal grain products, puffed
pounded-unripe rice (PPUR) was chosen because of its excellent health beneficial properties.
Feasibility of supplementing the probiotic bacteria Lactobacillus acidophilus (LA5) into PPUR was
investigated using a fluidized-bed coating method. Suitable fermentation conditions were tested
based on a pH criterion of 4.5. Three types of cell host solutions including sucrose, skim milk and
maltodextrin were examined as suitable carriers, and optimal coating condition was determined.
Product qualities were evaluated for stability. Results showed that milk fermented for 24 hr gave the
highest viable cell count of approximately 109 to 1010 CFU ml-1 when optimally mixed with
distilled water at milk:water ratio of 45:105 (mL:mL). Skim milk was determined as the most
suitable host giving the highest retention of LA5 cell count. Coating condition at a feed rate of 10
ml min-1, coating time of 5 min and constant temperature at 50°C gave the highest survival rates of
LA5. Moisture contents and water activity (aw) values of all coated products ranged 3.38-3.72 %wb
and 0.201-0.232, respectively. Regarding textural properties, coated PPUR showed increased
hardness and crispiness compared with uncoated samples, while variation of coating conditions had
no significant effects. Dynamic changes in viable LA5 cell count, textural properties, aw, peroxide
value and thiobarbituric acid values fitted well with various kinetic orders. Findings indicated the
feasibility of adding probiotics to dry products associated with suitable coating solution and offered
guidance for product development and process design.
Keywords: Lactobacillus acidophilus, wet granulation, survivability, value-added cereal
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
72
DIVISION C
Food Product Development, Sensory, and Consumer Research
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
73
O22-CP
Development of silken tofu coagulated by glucono-delta-lactone for
consumers with mastication and swallowing problems
Thanakorn Wongprasert1, Inthawoot Suppavorasatit1*
1Department of Food Technology, Faculty of Science, Chulalongkorn University
Phyathai Rd. Wangmai, Pathumwan, Bangkok, 10330, Thailand
*Tel. +66 2218 5515-6 Fax. +66 2254 4314, E-mail: [email protected]
ABSTRACT:
The objective of this research was to develop silken tofu formulation with glucono- delta-lactone
(GDL) compared with Universal Food Design (UD) standard, which is suitable for consumers with
mastication and swallowing problems. In order to develop high quality silken tofu coagulated by
GDL, the parameters affecting texture of silken tofu was studied. The result showed that GDL gave
the best quality silken tofu using soymilk with ratio of bean to water at 1:6. The optimal coagulation
temperature and GDL concentration were determined. The most appropriate GDL concentration and
temperature and were at 0.3 mg GDL/100 mL soymilk and 80 ºC with 35 minutes holding time,
respectively. With these optimal parameters, texture of silken tofu was soft, but a syneresis problem
was occurred. Thereby, adding 5% acid-treated tapioca starch could stabilize silken tofu with low
syneresis. Hardness of developed silken tofu was 2.5 N, which meets the requirement of UD Level
3. The results of this research can help to improve the quality of traditional silken tofu and used this
formulation to develop functional high protein soy-based gel products in the future.
Keyword: silken tofu, GDL, modified starch, tofu texture
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
74
O65-CP
Bread quality as affected by sorghum and breadfruit flours as wheat
substitutes
Fahrunnisa Adzqia1, Masubon Thongngam2 and Suntaree Suwonsichon1*
1Department of Product Development, Faculty of Agro-Industry,
Kasetsart University, Bangkok, 10900, Thailand
2Department of Food Science and Technology, Faculty of Agro-Industry,
Kasetsart University, Bangkok, 10900, Thailand
*Tel.:+66 2562 5017, E-mail: [email protected]
ABSTRACT:
Bread, a bakery product from wheat, is consumed worldwide as a basic food. Nevertheless, wheat
cannot grow well in Asia and also has a negative effect on consumers who suffer from Celiac
disease. Therefore, wheat substitution in bread is needed. This study investigated the potential use
of sorghum and breadfruit flours as wheat substitutes in bread. Sorghum flour was studied at 20%
and 30% substitution levels; while breadfruit flour was used at 5% and 10% substitution levels.
Various bread qualities were assessed, including weight loss, specific volume, top crust and crumb
color and texture in terms of hardness, gumminess, chewiness, cohesiveness, springiness and
resilience. Results showed that the weight loss decreased significantly (p<0.05) at 30% sorghum
flour substitution level while the specific volume of bread decreased significantly (p<0.05) with
each increased sorghum flour level. Bread crumb lightness (L*) tended to reduce while redness (a*)
and yellowness (b*) tended to increase with the increase of sorghum flour levels. Hardness,
gumminess and chewiness values tended to increase with increased sorghum flour levels although
the difference was not significant (p>0.05). Whereas cohesiveness, springiness and resilience of the
bread decreased significantly (p<0.05) with increased sorghum flour levels. For breadfruit flour,
weight loss and specific volume of bread decreased significantly (p<0.05) with each increased
breadfruit flour level. Crumb color of bread prepared from breadfruit-wheat composite flour was
redder (increased a*) and yellower (increased b*) than that of the control bread. For texture,
hardness and chewiness of bread increased significantly (p<0.05); while cohesiveness, springiness
and resilience decreased significantly (p<0.05) with each increased substitution level. Gumminess
of the bread increased significantly (p<0.05) at 10% substitution level. Based on the results,
sorghum flour could substitute wheat flour at 20% level to get desirable bread volume without
sacrificing its texture quality. Breadfruit flour, on the other hand, had tremendously adverse effects
on bread volume and texture quality. It could be used at no more than 5% substitution level.
Keyword: Sorghum, Breadfruit, Composite flour, Bread, Texture
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
75
O99-CP
Effect of red jasmine brown rice flour on quality of gluten-free
noodles
Patomporn Waewkum1* and Jittra Singthong1
1Department of Agro-Industry, Faculty of Agriculture, Ubon Ratchathani University
Warinchamrap, Ubon Ratchathani, 34190, Thailand
*E-mail: [email protected], [email protected]
ABSTRACT:
Red jasmine brown rice (Oryza sativa L.) is one of pigmented brown jasmine rice that crop in
Thailand. Brown rice have nutritious components and health beneficial more than white rice. The
aim of this study was to investigate the effect of red jasmine brown rice flour (RJB) 0-50% on quality
of gluten-free noodles. The result showed the pasting properties and thermal properties of mixed
gluten-free noodle flours. Increasing of RJB results in peak viscosity and breakdown increase
(p≤0.05) while final viscosity, setback and Te significantly decreased. RJB added in mixed noodle
flours were not effect to pasting temperature, To, Tp and ∆H (p>0.05). The cooking qualities of RJB
noodles showed that cooking yield and water absorption decreased, whereas cooking loss increased
at high RJB. The hardness and springiness decrease when adding more RJB. For the color
parameters redness (a*) and yellowness (b*) trend to increase, but whiteness (L*) decrease. The
result of sensory evaluation showed that color, odor, texture and overall acceptance of 10-20% RJB
flour were non-significant with control (p>0.05) except appearance. The result of this study showed
that RJB can use to improve the quality of gluten-free noodles and other products.
Keyword: Red jasmine brown rice flour, Gluten-free noodles, Cooking properties, Textural
properties
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
76
O122-CP
Physicochemical and sensorial properties of date palm syrup made
from premature fruit drop, fresh and dried date pulp
Kittanan Burapalit1*, Kamolnate Kitsawad1 and Tatsawan Tipvarakarnkoon1
1Department of Food Biotechnology, Faculty of Food Biotechnology,
Assumption University, Bangkok 10240, Thailand
* Tel.:+66 94 441 5149, E-mail: [email protected]
ABSTRACT:
This study aimed to examine physicochemical and sensorial properties of date syrup made from
Barhee cultivar of premature fruit drop and to compare with those made of fresh and dried date fruit
pulp. They are different by levels of ripening and grading of date palm fruits (fresh date, premature
fruit drop, and dried date). The properties of date syrup (80° ‘Brix) were investigated including total
solid (TS), pH, color, viscosity, sugar profile, overall yield from date pulp, and yield lost by filtration
of date syrup. Fifty consumers were asked to rate the intensity and their liking products using rate-
all-that-apply (RATA). The results showed that premature date fruit drop syrup showed different
properties from fresh date and dried date syrup in terms of pH and total solid. However, the
physicochemical properties sensorial properties of fresh date and premature fruit drop syrup were
similar. They showed brighter in color and more yellow (L* = 2.53-3.350, b* = 4.36-5.78) than dried
date syrup (L* = 0.90, b*= 1.56) but lower overall yield percentage. In terms of sensorial
characteristics, the color and flavor intensity of fresh date and premature fruit syrup were not different
however dried date syrup was slightly higher. Although the physicochemical and sensorial
characteristics of syrup were different, the consumer preference was comparable (7.04 – 7.26 out of
9).
Keyword: Date fruit, Phoenix dactylifera L., Premature fruit drop, Date syrup, Rate-all-that-apply
(RATA)
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
77
P68-CB
Development of Complete Balanced Nutrition Instant Diet for
Dysphagia Patients with Various Rice Powder Concentrations
Niramol Muangpracha1, Numphung Rungraung1 and Thunnalin Winuprasith1*
1Institute of Nutrition, Mahidol University,
Salaya, Nakhon Pathom 73170, Thailand.
* Tel.: +66 2800 2380 ext. 123, E-mail: [email protected]
ABSTRACT:
The purpose of the development of a complete balanced nutrition instant product was for dual uses
as a blenderized diet for enteral tube feeding and oral drink for dysphagia patients. This research
aimed to study the effect of Thai Jasmine rice (Khao Dawk Mali 105) powder on properties and
nutrition profile of the complete balanced nutrition instant product. The rice powder was milled
through a 75 m mesh sieve (mesh number 200). The main ingredients included whey protein isolate,
sugar, maltodextrin, and rice powder. Five formulations were prepared by varying amounts of rice
powder at 4 g (7%), 8 g (12%), 12 g (17%), 16 g (22%) and 20 g (27%) per serving. One sachet of
instant powder was mixed with 180 ml drinking water at 60 0C. No phase separation occurred after
storage for 6 hours. The viscosity at constant shear rate of 100 s-1 increased from 0.0585 Pa.s to 0.694
Pa.s whereas the flow rate decreased from 103.44 ml/min to 0.19 ml/min with an increasing amount
of rice powder. All five formulated products can be classified according to the International
Dysphagia Diet Standardization Initiative (IDDSI) at level 0 to level 3. The products provided caloric
density of approximately 1.0-1.1 kcal/ml and the energy distribution recommendation by Dietary
Reference Intake (DRI) from protein, carbohydrate and fat were approximately in the range between
10 to 15%, 45 to 65% and 25 to 30%, respectively. The results from this study can lead to a potential
application of using rice powder as a viscosity and texture modifier in food products for dysphagia
patients.
Keyword: Rice powder, Dysphagia, IDDSI, Texture modifier
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
78
P92-CB
Effect of syrup concentration, pasteurized time, and pasteurized
temperature on Longkong in syrup product and its shelf life
Jaruwan Maneesri1*, Soraya Docar1 and Koriyoh Kalupae1
1Department of Food Science and Nutrition, Faculty of Science and Technology,
Prince of Songkla University, Pattani 94000, THAILAND
*Tel.:+66 86 749 5985, E-mail: [email protected]
ABSTRACT:
Longkong (Lansium domesticum Corr) is plant a species economy with popularity consumed,
especially in southern provincial of Thailand. One plant can produce fruit increased every year
according to age. Longkong fruit cannot be kept. It was ripen and easily spoiled. Therefore, longkong
in syrup product was develop. This aimed of research to the effect of syrup concentration,
temperature, time for pasteurization and shelf life of longkong in syrup product. Longkong fruit in
differents concentration of syrup (40, 50 and 60% (w/v)) and store at room temperature for 24 hours
were analyzed to chemical and physical quality. There was no significantly change in pH, firmness,
and brown color. However, total soluble solid was increased. The sensory tests found that longkong
in 50% syrup concentration was accepted to color, tast, flovour, texture, sweetness and overall. Then,
longkong in syrup product was pasteurizated at 70 and 80 °C for 10 and 20 min. It found that pH, total
soluble solids and firmness of longkong in syrup product were closely at 3.87+0.14-3.95+0.13,
22.6+1.0-23.0+1.0 °Brix and 1.52+0.5-1.69+0.69 N, respectively. Total viable count was less than
25 cfu/g. Therefore, pasteurization was selected at 80 °C for 10 min. Because the product was not
different chemical and physical characteristics. The shelf life of product at 4 °C and room temperature
(27.5±1.6 °C) for 4 weeks were studied. The result show that pH in longkong and syrup value were
4.13 and 3.94 at 0 week. At 1-4 weeks, pH of longkong and syrup value were 3.83+0.08-3.96+0.02
and 3.62+0.04-3.75+0.01, respectively. While, pH was a few decreased but the total soluble solids
and firmness were not significantly (p<0.05). The shelf life at room temperature was effect to
browning color. The microbial quality include total variable count, Staphylococcus aureus,
Escherichia coli, yeast and mold were detected. Yeast and mold were exceed the standard 4 weeks
of store at 4 °C and room temperature (27.5±1.6 °C). It was is 3.8×103 cfu/g and 4.9×103 cfu/g,
respectively.
Keyword: Longkong, Syrup, Pasteurization, Shelf life
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
79
P64-CP
Stability of β-carotene Encapsulated in Plant -Based Emulsions : Impact
of Nanofibrillated Cellulose Concentration
Ichlasia Ainul Fitri1, Wiphada Mitbumrung1, and Thunnalin Winuprasith1*
1Institute of Nutrition, Mahidol University, Nakhon Pathom 73170, Thailand
* Tel: +66 92 435 4343, E-mail: [email protected]
ABSTRACT:
The influence of concentration of nanofibrillated cellulose (NFC) on stability of 10% of oil-in-water
(O/W) emulsions containing β-carotene using tween 20 as an emulsifier was examined. The
concentrations of NFC were varied at 0.05, 0.10, and 0.20% (w/w). There was a progressive increase
in particle size (d43) of the emulsions with increasing NFC concentration caused by bridging
flocculation induced by NFC. Addition NFC decreased the value of L* due to the white and turbid
color from native NFC but total colour difference (ΔE) between the emulsions containing NFC and
the one without NFC was not noticeable by visual observation. No creaming occurred in all emulsions
after storage for 7 days. The stability of β-carotene increased with increasing NFC concentration
because of less surface area interacting with unappropriated environment such as temperature and
light during measuring. From all results, it can be indicated that NFC can be used as natural stabilizer
to increase the emulsion and -carotene stability. Moreover, NFC at concentration of 0.10% is
preferred to use as stabilizer in these emulsions. This experiment provides useful information for
further applications especially colloidal delivery system for bioactive compound.
Keywords: Emulsions, β-carotene, Nanofibrillated cellulose, Stability
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
80
P69-CP
Rheological and physicochemical properties of ice cream fortified with
freeze-dried mulberry powder
Pathompol Suwanmongkol1, Pornrat Sinchaipanit1*, Napassorn Peasura 1 and
Anantita Sangsuriyawong1
1 Institute of Nutrition, Mahidol University
999 Phutthamonthon 4 Rd., Salaya, Phutthamonthon,
Nakhon Pathom, 73170, Thailand.
*Tel.:+66 2800 2380, E-mail: [email protected]
ABSTRACT:
The objective of this study was to evaluate the changing in rheological property and physical
attributes including sensory analysis of ice cream fortified with freeze-dried mulberry. Preliminary
studies were conducted to determine the basic ice cream formula and appropriate levels of freeze-
dried mulberry addition. Different levels of mulberry at 0 (control), 2, 4, and 6% were fortified ice
cream. The rheological and physical properties including sensory evaluation were monitored. The
resu l t s showed that the storage modulus (G′) and loss modulus (G″) of ice cream mix tended to
increase with the greater addition of mulberry powder. The obvious reduction of hardness of ice cream
with adding mulberry powder at level 2, 4, and 6% were indicated and compared to the control. All
mulberry ice cream treatments showed significant increases in melting resistance (p≤0.05) than
control but among different levels of mulberry addition were not significant. Increment of freeze-
dried mulberry did not significantly increase the %overrun. The slightly lower pH ice cream was
acquired when added higher mulberry powder. The red-purple color of mulberry ice cream was
showed, agree on the value of the lightness (L*) and yellowness (b*) deceased but the redness (a*)
value increase. Fortified 2% freeze-dried mulberry powder was the best acceptance for mulberry ice
cream by panelists (n=30, 9 point hedonics scale).
Keyword: Mulberry, Ice cream, Functional food, Rheological property, Sensory acceptance
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
81
P73-CP
Effects of pineapple juice and commercial meat tenderizeron quality of
beef jerky
Teepanee Pinitjun1, Thongchai Suwonsichon1 and Suntaree Suwonsichon1*
1Department of Product Development, Faculty of Agro-Industry, Kasetsart University
50 Ngamwongwan Rd., Bangkok, 10900, Thailand
*Tel.:+66 2562 5017, E-mail: [email protected]
ABSTRACT:
The objective of the study was to determine the effects of pineapple juice of varying total soluble
solid (TSS) contents (12 and 16 o Brix) and concentration levels (5 and 10%) and commercial meat
tenderizer added during marination on quality, especially texture, of beef jerky prepared from beef
round. Beef jerky marinated without pineapple juice and commercial meat tenderizer served as the
control sample. Results showed that samples marinated with pineapple juice tended to have slightly
lower pH than other treatments. Moisture contents were not significantly different (P>0.05) among
samples. Water activity of the samples varied in the range of 0.45-0.57. Beef jerky samples that were
marinated with pineapple juice and commercial meat tenderizer had significantly lower (P<0.05) hardness, gumminess, chewiness and shear force values as determined by a texture analyzer than the
control. Such effects more evident for the samples marinated with pineapple juice (both 12 and 16
Brix) at 10% level than other marination treatments. While springiness and cohesiveness of the
samples marinated with pineapple juice and commercial meat tenderizer were higher (P<0.05) than
those of the control. Results from descriptive sensory analysis revealed that all beef jerky samples
marinated with pineapple juice were rated lower in toughness, hardness, cohesiveness, firmness,
chewiness, roughness, cohesiveness of mass and chew count, but higher in sour aromatic, sour taste,
astringent, prickly and powdery than the control and commercial meat tenderizer. Four samples
including the control, and beef jerky marinated with 12 °Brix pineapple juice at 5 and 10 %levels and
commercial meat tenderizer were selected and tested with consumers. Results showed that beef jerky
marinated with 12 oBrix pineapple at 5 and 10% levels were less preferred to the control in all aspects,
due to the detection of powdery texture in the samples marinated with pineapple juice. Whereas beef
jerky samples marinated with commercial meat tenderizer received higher (P≤0.05) liking score for
tenderness than the control and no powdery texture was detected in the sample.
Keyword: Beef jerky, Meat Tenderness, Marination, Pineapple, Meat tenderizer.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
82
P84-CP
Healthy Processed Cheese Analogue Product Concept Development and
Sensory Evaluation of Prototype Product on Oil Replacement
Pachara Pomsang1 and Chaleeda Borompichaichartkul1*
1Department of Food Technology, Faculty of Science,
Chulalongkorn University. Phayathai Rd., Wangmai, Pathumwan,
Bangkok, 10330, Thailand.
*Tel.: +66 2218 5515-6, E-mail: [email protected]
ABSTRACT:
This research was aimed to study a possibility of developing healthy processed cheese products by
surveying Thai consumer demand and study their behavior as well as their attitude toward processed
cheese product. The target were consumers who had concern about their health. The research was
divided into first survey on target consumers and second study on opportunity of substitution of
milk fat in prototype with healthy oil by sensory evaluation. From the result, it showed that more
than 72% from 422 targeted consumers had positive buying intention and interested in product with
antioxidants and omega fatty acid supplement. Sliced processed cheese with right flavor and texture
were expected. Sensory evaluation of the substitution of milk fat in cheese prototype by healthy oil
was done by 64 untrained panelists, using 6-hedonic scales and just-about-right (JAR) by descriptive
data, net score, and penalty analysis (mean drop). Rice bran oil (RBO), soybean oil (SBO), palm oil
(PO), and fish oil (FO) were selected to produce prototype for milk fat replacement study and
acceptance evaluation. The panelists had positive liking of oil replacements, excepted FO prototype.
RBO sample got the overall liking score that was close to the control (commercial product (COM)),
followed by SBO, PO, and FO. However, penalty analysis found that RBO was too strong of
firmness and too weak of oiliness. RBO sample were too weak of color, aroma, and cheese flavor
similar to SBO and PO prototypes. FO sample was too oily also too strong color and aroma. Hence,
the developed prototype products need to improved cheddar flavor as well as color and aroma. The
information obtained from this study was used to develop healthy processed cheese products that
conform to FDA standards and acceptable to the consumer’s health concept.
Keyword: Processed cheese, product development, sensory evaluation.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
83
P90-CP
Effect of sucralose substitution on moisture transfer and
physicochemical characteristics of Marian plum leather
Mintra Nugthum1, Pitiporn Ritthiruangdej1* and Nantawan Therdthai1
1Department of Product Development, Faculty of Agro-Industry,
Kasetsart University, Chatuchak, Bangkok, 10900 Thailand
*Tel.:+66 2562 5004, E-mail: [email protected]
ABSTRACT:
Marian plum is a tropical fruit which is highly perishable by nature and therefore presents great extent
of postharvest losses. Making of fruit leather from fresh fruits is an effective way to preserve the
product. Nowadays consumer awareness about health risks of diets high in sugar have increased
d r am a t i ca l ly. Therefore, this research aimed to produce a reduced sugar Marian plum leather by
partially replacing 25, 50, and 75% of the sucrose contained in the control leather with an equivalent
sweetness from the sucralose. Moisture transfer of Marian plum leathers during drying at 60 C was
verified to fit the Newton drying kinetic model . The values for coefficient of determination and
drying rate were in the range 0.787-0.947 and 0.0034-0.0056 s-1, respectively. Results indicated that
the increment in replacement of sucrose with sucralose substantially increased drying rate. In
addition, the optimum drying time to reach 10% moisture content predicted by the models was used
to prepare the final four leathers, and subsequently their chemical and physical characteristics were
analyzed. Results showed that there were no significant differences (P>0.05) in pH value (3.80-3.89)
and moisture content (9.93-10.63%) between control leather and leathers prepared with increasing
amounts of sucralose as sucrose replacer. With increase in replacement of sucrose with sucralose the
values for lightness (L*), redness (a*), yellowness (b*) and cutting force increased while the values
of browning index, reducing sugar and total sugars decreased. Based on the reduction of sugar level
and drying time, the sucralose showed potential for the use in reduced sugar Marian plum leathers.
Keywords: Fruit leather, Reduced sugar, Marian plum, Kinetic model, Drying
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
84
P106-CP
Application House of Quality in Strawberry Topping Sauce
Lattapol Boonditsataporn1, and Suteera Vatthanakul1*
1Department of Food Science and Technology, Thammasat University,
Pathumthani 12121, Thailand
*Tel.: +66 9013 7887, E-mail: [email protected]
ABSTRACT:
Fruit topping sauce is a processed fruit product that is uses for topping on desserts. Nowadays, fruit
topping sauce have many flavors depending on the type of processed fruit and also consumer’s
preference variables. House of Quality (HOQ) is the interesting technique that can be used to study
requirement and preferences of consumer on products. It is a powerful technique for analyzing the
satisfaction and requirement of consumers. Currently, there has no research that used HOQ in fruit
topping sauces. Therefore, the objective of this research was to study on the behavior and requirement of consumers on strawberry topping sauces products by using HOQ technique. In this study, data was
collected with 200 consumers who were Thammasat University students. All of them consumed
strawberry topping sauce. Most of them were aged between 18-25 years old and had income 0-15,000 baht per month. For the behavior of consumers in topping sauce, they ate topping sauces 1-2
times a month with 37 percentage preferred to eat strawberry flavors. The most popular carrier
consumed topping sauce with bread, ice cream and crepes, and ate topping sauce when going to a
dessert shop or relaxing time. From the analysis with HOQ, the result found that 5 factors affected
on needs of consumers. There were the nutritional value, product value, application, product quality
and taste of product. In addition, the consumers needed of topping sauces should contain vitamins,
had natural colors and also beautiful colors. As a result, the HOQ technique can be applied to improve
and developed new topping products that meet the consumer needs.
Keyword: House of quality, Consumer behavior, Consumer satisfaction, Topping sauce, and Fruit
sauce
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
85
P129-CP
KJ method and Sensory Characterization of minced pork containing
different fat content
Phamorndech Tovaravirat1, and Suteera Vatthanakul1*
1Department of Food Science and Technology, Thammasat University
Pathum Thani, 12120, Thailand
*Tel.: +66 9013 7887, E-mail: [email protected]
ABSTRACT:
Minced pork is common food due to its fair price, nutrient-rich, and delicious food that can use in
variable dishes. To increase consumer preferred in minced pork and also reduce food waste in the
market, The Kawakita Jiro method (KJ method) used as a qualitative research method to gain an
understanding of the characterization of minced pork that consumer preferred. KJ method is the tool
that wildly use in generate idea, problem-solving, and analysis the group discussion, that can use in
a new type of field research concept or teamwork concepts for creativity. An eight participants were
recruited then separate into 2 groups according to the frequency to consume minced pork in a week:
Group 1 was highly consumed pork group (higher than 3 times/week) and Group 2 was a plant-base
pork consumed. Each group was written information about minced pork in small note then grouping
these information and naming group title. After that, each group were asked to draw affinity diagram
which better understand the response. The result showed that minced pork must be contained as low
in fat content and can used as main ingredient in a variety of dishes. Then sensory evaluation with
100 consumers was performed to find out the preference of 100 consumer in different fat contained.
Grinded red pork meat and grinded pork back fat was mixed at 0%, 10%, 20%, and 30%. The result
showed that there were no significantly different (p>0.05) in sensory hedonic score however, minced
pork that contained 10% fat should be selected as the optimum fat level according to its highest in the
hedonic score mean for flavor, texture, taste, and overall liking attributes in all 4 treatments.
Keyword: Minced pork, KJ method, and Sensory evaluation
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
86
P132-CP
Effect of Banana Flour Substitution on the Quality Characteristics of
Gluten-Free Bread
Isaya Pootongpong1 and Wilailuk Chaiyasit1*
1Division of Food Science and Technology, Faculty of Science and Technology,
Thammasat University, Pathum Thani, 12120, Thailand
*Tel.:+66 2564-4486, E-mail: [email protected]
ABSTRACT:
As the current worldwide incidence of celiac disease increases continuously, an increasing demand
for good quality gluten-free products especially bread is rising. Unripe bananas contain a high
proportion of resistant starch, non-starch polysaccharides and various vitamins and minerals. The
objective of this research was to evaluate the effect of mixed gluten-free flour substitution by unripe
banana (Musa sapientum L.) flour (BF) at 0, 30 and 60%w/w on the quality characteristics of gluten-
free bread (GFB). Results showed that both dough and bread quality characteristics were affected by
the level of banana flour replacement. Dough stickiness increased (p<0.05) from 28.56 to 35.16 g as
the BF substitution increased from 0 to 60%. Specific volume, height, and cohesiveness of GFB
decreased with increasing of BF substitution level although no significant difference (p>0.05)
between the samples at 30% substitution and control. Hardness and chewiness of GFB increased with
the increasing of the substitution. The substitution also increased a* of bread crumb but decreased L*
of that. Sensory evaluation results revealed that even though colour and appearance acceptability of
GFB containing BF were lower than that of the control, no significant different of that in flavour,
taste, texture and also overall acceptability. Therefore, it is possible to use BF to increase the value
of GFB.
Keyword: Gluten-free bread, Unripe banana, Banana flour, Egg white
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
87
P134-CP
Effect of Reducing Sodium Chloride and Phosphate in Thai Chicken
Sausage (Kai-Yor)
Ausanee Attawasu1, Suteera Vatthanakul1 and Prapasri Theprugsa1*
1Department of Food Science and Technology,
Faculty of Science and Technology, Thammasat University
99, Phahonyothin Road, Khlong Luang, Pathum Thani, 12120, Thailand
*Tel.:+66 4075 1355, E-mail: [email protected]
ABSTRACT:
Sodium chloride (NaCl) and phosphate are commonly used in Thai chicken sausage
(Kai-Yor) as a food additive, mainly for improving the physical properties of the product. However,
excessive use of NaCl and phosphate are harmful to consumers’ health. This study investigated the
effects of reducing NaCl (0.53, 0.79 or 1.05 %w/w) and phosphate (0.10, 0.15 or 0.20 %w/w) on the
physical and sensory properties. The results revealed that cooking loss (CL), texture and sensory
attributes were adversely affected when NaCl and phosphate levels were reduced. Increased CL was
observed when NaCl or phosphate reduced while hardness, gumminess, and chewiness decreased
when reducing NaCl and phosphate levels. The sensory test showed that the highest overall liking
score was found in the sample with NaCl 1.05 %w/w and phosphate 0.20 %w/w (F1), there was no
significant difference (p>0.05) between Kai-Yor with NaCl 0.79 %w/w and phosphate 0.15 %w/w
(F5). A principal component analysis (PCA) was used to identify the relationship between the
physical and sensory properties of Kai-Yor. The results of the PCA showed the final two components.
F5 was related to the first component that was positively correlated with hardness gumminess
chewiness texture and juiciness as F1. Therefore, the condition of 0.79% NaCl and 0.15% of
phosphate was possible solutions to reduce NaCl and phosphate content without affecting consumer
acceptance.
Keyword: Kai Yor, Sausage, Phosphate, Sodium chloride.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
88
P21-CJ
Product qualities and sensory evaluation of high protein snack bar
incorporated with pea protein isolate
Sunyalak Gunyaphan1, Nattira On-nom1, Uthaiwan Suttisansanee1, Rungrat Chamchan1,
Chanakan Chemthong1, Chaowanee Chupeeruch1*
1Institute of Nutrition, Mahidol University.
999 Phutthamonthon 4 Rd., Salaya, Phutthamonthon,Nakhon Pathom 73170, Thailand
*Tel.:+66 92 998 5282, E-mail: [email protected]
ABSTRACT:
Snack bars are convenient and nutritious food composed of several ingredients. It also can be
supplemented by some health-promoting substances such as pea protein isolate (PPI). The aim of this
study was to formulate a high-protein snack bar using pea protein isolate using INMUCAL-Nutrients
V.4.0. Moreover, the product qualities of PPI snack bars in term of physical and sensory qualities and
nutritive values were also determined. Protein content of the PPI snack bars (20-25 g per 100 g
sample) was criteria for the formulation. As the result the physical qualities of PPI snack bars showed
that water activity was below 0.7, therefore snack bars should be stable against microbial growth. No
significant difference was found in color values between the PPI snack bar and the control formula
but PPI snack bars had higher hardness than the control formula. The energy, carbohydrate, protein,
fat and dietary fiber of PPI snack bar was 439.40 kcal, 46.88 g, 22.20 g 18.12 g and 7.17 g per 100 g,
respectively. Moreover, it had balanced energy distribution of carbohydrate: protein: fat at 54:25:21.
The results from the sensory evaluation indicated that the liking score of appearance, color, odor,
taste texture and overall liking of PPI snack bars were higher than 7 (like moderately). Therefore, PPI
appears to be an alternative ingredient used to improve the nutritional quality of the high protein diet
bar.
Keywords: snack bar, pea protein isolate (PPI), product qualities, nutritive values, sensory
evaluation
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
89
P25-CJ
Effect of Jerusalem artichoke (Helianthus tuberosus) powder on quality
of glass noodles
*Singthong, J. and Thongkaew, C.
Department of Agro-Industry, Faculty of Agriculture, Ubon Ratchathani University,
Warinchamrap, Ubon Ratchathani, 34190 THAILAND
*E-mail: [email protected]
ABSTRACT:
The Jerusalem artichoke (Helianthus tuberosus) tuber is a vegetable with a low caloric value and a high
content of inulin, vitamins and minerals. The purpose of this study was to establish the physical and
chemical properties of Jerusalem artichoke powder (JA powder). The results have indicated that
moisture, ash, crude fiber, protein, lipid and carbohydrate contents were 6.71, 3.54, 2.83, 7.58, 0.28 and
79.04 %, respectively. The Jerusalem artichoke stored carbohydrates in the form of inulin instead of
starch. Total dietary fiber (TDF), soluble dietary fiber (SDF) and insoluble dietary fiber (IDF) of JA
powder were 53.11, 40.07 and 13.04%, respectively. Total sugar, total phenolic compound (TPC) and
antioxidant activity by DPPH of JA powder were 0.92 mg fructose/g sample, 6.58 mg GAE/g sample
and 93.74 mg TEAC/g sample, respectively. Furthermore, this research reports the designed of
experimental for optimizing JA powder on quality of glass noodles using three independent variables:
JA powder concentration (0-3%), alginate concentration (1.5-2.5%) and calcium concentration (1-3%).
Optimized condition for the glass noodles was 3% JA powder, 2% alginate and 3% calcium. This
optimization revealed that glass noodles had more fiber and sugar including good texture and consumer
acceptance. The microstructure of glass noodles addition with JA powder were smaller porosity
compared to glass noodles without JA powder (commercially glass noodle).
Keywords: Jerusalem artichoke, Glass noodles, Alginate, Optimization conditions
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
90
P28-CJ
Production and quality evaluation of low GI waffle from whole wheat
flour supplemented with RS IV and Sacred lotus stamen
Nichaputh Kaewmak1, Chaowanee Chupeeruch1, Uthaiwan Suttisansanee1,
Dalad Siriwan2, Rungrat Chamchan1, Chanakan Khemthong1 and Nattira On-nom1*
1 Institute of Nutrition, Mahidol University,
999 Phutthamonthon 4Rd., Nakhon Pathom, 7317, Thailand
2Institute of Food Research and Product Development,
Kasetsart University, Bangkok, 10900, Thailand
*Tel.+66 81 981 2631, E-mail: [email protected]
ABSTRACT:
Waffle is one popular product which is consumed by the various age groups due to the crispy texture
and sweet taste. However, waffle is classified as high glycemic index food (≥70). Thus, this study
aimed to develop a low glycemic index (GI) waffle from whole wheat flour supplemented with RS
IV and sacred lotus stamen (SLSP). The low GI waffle was formulated by substituting whole wheat
flour with 35, 45 and 55% of RS IV. Then, the formula with high overall liking score was continued
to develop by fortification with 30, 35 and 40% of SLSP. The physical and sensory qualities were
determined. Moreover, the low GI waffle with SLSP was evaluated on nutritional values, GI, total
phenolic contents (TPCs) and antioxidant activities. The results showed that low GI waffle with SLSP
could successfully developed by substituted whole wheat flour with 55 and 40% of RS IV and SLSP,
respectively. The product could be claimed as high fiber and was classed as low GI product.
Moreover, the TPCs and Antioxidant activities of low GI waffle with SLSP was higher than the
control waffle formula. Therefore, it seemed that RS IV and SLSP could enhance the nutritional
quality of the product with the consumer acceptability.
Keyword: Type IV resistant starch (RS IV), Sacred lotus stamen, Antioxidant activities, Total phenolic
contents, Glycemic index (GI)
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
91
P41-CJ
Effect of Partial Substitution of Riceberry Rice Flour on Rice Noodles
Quality
*Thongkaew, C., Singthong, J.
Department of Agro-Industry, Faculty of Agriculture, Ubon Ratchathani University,
Ubon Ratchathani, CO 34190 Thailand
*E-mail: [email protected]
ABSTRACT:
Rice is a major economic potential plants in Ubon Ratchathani province, Thailand. Riceberry rice is
a good source of vitamins, minerals and bioactive compounds. Ubon rice noodle is a local wisdom of
indigenous food as one tambon one product (OTOP). The objective of this research was focused on
development of Ubon rice noodles with riceberry rice flour (RRF) to obtain the higher value product.
The results show that RRF contains 9.50% protein, 6.38% fat, and 23.33% amylose. The study of
bioactivity of RRF revealed that total phenolic, flavonoids and anthocyanin content were 495 mg
gallic acid equiv./100g, 400 mg quercetin equiv./100g and 263.73 mg Cy-3-G equiv./100g,
respectively. Peak viscosity, gelatinization temperature and enthalpy increased with increasing RRF.
The optimum ratio of RRF was 20% supplemented into Ubon rice noodles showed overall acceptance
including good cooking quality, texture and consumer acceptance. The result of this study could be
used as knowledge in food application as functional foods, especially in development of Ubon rice
noodles to promote economic potential of local community.
Keywords: Ubon rice noodles, Riceberry rice, Physicochemical properties, Bioactivity
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
92
DIVISION D
Food Microbiology, Food Biotechnology, Fermentation
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
93
O108-DB
Development of innovative Amazake from Portuguese Chestnuts using
controlled fermentation conditions
Marisa Santos1*
, Stefano Banfi2, Mariana Mota
1, Anabela Raymundo
1 and Catarina Prista
1
1LEAF - Linking Landscape, Environment, Agriculture and Food, Research
Center of Instituto Superior de Agronomia, Universidade de Lisboa Tapada da Ajuda, 1349-017 Lisboa, Portugal
2Universitá Degli Studi Di Milano, Facoltà di Scienze Agrarie e Alimentari Via
Celoria, 2 - 20133 Milan
*E-mail: [email protected]
ABSTRACT:
The increasing interest of consumers for innovative, diverse, healthy and flavourful foods is an
opportunity for the development of products that are in line with the new food trends. The new fermented foods combined with the cultural and economic importance of using local crops can help
to meet these new tendencies of consumption. Amazake is a traditional Japanese fermented product prepared from rice and is usually consumed as a hot beverage or a sweetener. The inoculation of
Aspergillus spp. fungi in the form of rice koji (rice with fungi hypha and spores grown at its surface),
promotes enzymatic hydrolysis of starch and proteins present in the rice, resulting in a sweet and more nutritious food product. Following the eastern knowledge of Amazake production, a new
fermented product was developed using Portuguese chestnuts. The fermentation contributes to a decline of anti -nutritional factors while increasing digestibility and anti-oxidant properties and aims
to provide healthier and more nutritive ways for chestnut consumption. Production of two different Amazake varieties was tested, using as inoculum rice koji or chestnut koji. The Amazake evolution
was assessed during 24 hours for both products and compared in terms of chemical characteristics, colour, texture and linear viscoelastic behaviour. An increase in the free sugar, protein and organic
acids content was observed for both rice and chestnut koji Amazake varieties, with evolution of the
products to darker colours. A decrease in texture parameters was observed with a higher decrease in firmness after 24 hours (16.52 N to 2.88 N) for Amazake made with rice koji compared to chestnut
koji (9.19 N to 3.47 N). From 15 to 24 hours, low variations were observed in the texture parameters. Viscoelastic moduli also decreased after 24 hours, reflecting a reduction in the structure degree for
both Amazake. Our results shown that chestnut can be an innovative alternative to rice Amazake with healthy promising characteristics. This product can be used to prepare sweet beverages or can replace
refined sugars through incorporation in products as sweet snacks and cookies.
Keyword: Innovative functional food; Asian-derivative fermented products; Aspergillus spp; natural
sweetener
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
94
O24-DP
Bioinformatic Tools and in-vitro analysis for screening of potential
Bacillus probiotic used as a food supplement
Gauri Khullar1*, Cheunjit Prakitchaiwattana 1, 2 and Pinidphon prombutara3
1Department of Food Technology, Faculty of Science,
Chulalongkorn University, Patumwan, Bangkok 10330, Thailand
2The Development of Foods and Food Additive from Innovative Microbial Fermentation Research Group, Faculty of Science, Chulalongkorn University, Bangkok 10330, Thailand
3Omis Science and Bioinformatics Center Faculty of Science, Chulalongkorn University,
Patumwan, Bangkok 10330, Thailand
*Tel.: +66 2218 5515, E-mail: [email protected]
ABSTRACT: Bacillus spore-forming species found in traditional Asian and African recipes and aquatic gut microbiota
have been lately exploited for their use in commercialized food products and used for human dietary
benefits. Their stability and viability under harsh conditions including low pH, high heat tolerance, low
nutrient availability, etc. have made them an attractive choice as food supplements over the traditional
Lactobacillus and Bifidobacterium species. Furthermore, survival in their spore form has given them an
added benefit of being stored indefinitely on the shelf under room temperature. In this study, three strains
(6-2, 63-11 and 78-1), isolated from traditional fermented fish (Pla-ra) were identified and characterized
for their potential probiotic properties using in-vitro Analysis along with Whole Genome Sequencing
(WGS) and Computational tools. They were identified as Bacillus velezensis, Bacillus infantis and
Bacillus amyloliquefaciens having an ANI value of 98.53, 91.21 and 94.17, respectively. Based on the
preliminary screening the strains showed no hemolytic activity (except 78-1), moderate (6-2 & 78-1) to
high (63-11) susceptibility towards clinically important antibiotics, moderate (6-2 & 63-11) to high (78-
1) tolerance to gastric juice, low (6-2 & 78-1) to moderate (63-11) tolerance to bile salt, moderate (63-11)
to high (6-2 & 78-1) antimicrobial activity and moderate (6-2) to high (63-11 & 78-1) surface
hydrophobicity towards standard organic solvents. The bioinformatics analysis results of whole genome
sequencing showed that the three isolated strains were predicted as a non-human pathogen, and their
genomes do not contained any acquired antibiotic resistant genes. However, virulence factors analysis
tool revealed the presence of hemolytic III homolog gene in B. infantis (63-11) and Hemolysin III gene
in B. velezensis (78-1) and B. amyloliquefaciens (6-2). Taken together, these results indicate that B.
infantis (63-11) was found to be the most potential probiotic candidate.
Keyword: Probiotics, Bacillus, Whole Genome Sequencing, In-vitro, Antimicrobial Resistance
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
95
O85-DP
Chemical characterization and antibacterial activity against foodborne
pathogens of biosurfactant from Aureobasidium melanogenum
Vipawan Jandee1 and Pumnat Chuenchomrat1*
1Department of Food Science and Technology, Faculty of Science and Technology,
Thammasat University, Pathumthani, 12120 Thailand
*Tel.:+66 81 818 5219, E-mail: [email protected]
ABSTRACT:
Yeasts were isolated from coconut milling machines. To screen extracellular biosurfactant producing
yeast, each isolate was cultured in potato dextrose broth (PDB) to collect cell free culture broth (CFCB) for surface tension measurement. The lowest surface tension of 32.7 mN/m was observed in
CFCB of CC-001 isolate. This isolate was molecular identified as Aureobasidium melanogenum.
Biosurfactant of CC-001 was extracted by 3 methods of ethyl acetate extraction, cold acetone precipitation, acid precipitation combined with chloroform: methanol (2:1) extraction, and then
evaluated surface active activity by oil-displacement test. According to the results, ethyl acetate extraction was suitable method for CC-001 biosurfactant achievement. TLC and FTIR indicated that
CC-001 biosurfactant was glycolipid biosurfactant. Moreover, 50 mg/ml CC-001 biosurfactant showed complete growth inhibition against foodborne pathogenic bacteria of Bacillus cereus ATCC
11778, Listeria monocytogenes DMST 17303, Staphylococcus aureus ATCC 25923, Escherichia coli ATCC 6795, Salmonella Typhimurium ATCC 13311, and Vibrio parahaemolyticus ATCC 17802.
Keyword: Aureobasidium melanogenum, glycolipid biosurfactant, chemical characterization, antimicrobial activity, foodborne pathogenic bacteria
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
96
O98-DP
Improved survival of Candida tropicalis TISTR 5922 Starter Culture
with Difference Form
Natwaran Nukrohwad1, Jaruwan Maneesri1*
1Department of Food Science and Nutrition, Faculty of Science and Technology,
Prince of Songkla University, Pattani 94000, Thailand
*Tel.:+66 86 749 5985 , E-mail: [email protected]
.
ABSTRACT: Candida tropicalis TISTR 5922 used as starter culture in Ka-nom Tuay-fu production which it was
Thai traditional food. Starter culture was developed into a powder form. But powder form was
disadvantages in storage. It can be stored for a period of 3 months and the survival rate is only 7.27
logCFU/g. The present study focuses on the effect of two different form (rod from and pill form) of
starter culture and drying condition at 40, 50 and 60°C 24 hr on cell survival of C. tropicalis TISTR
5922 starter culture. The results showed that cell viability of all treatment were decreased and not
found at drying 60 ºC for 4 hr. Pill form and drying at 40 °C 24 hr were well form for ready to use.
It had high cell survival 99.27% (1.63×108 CFU/g). The moisture content and water activity at
7.62±0.91% and 0.41±0.00 respectively. Rod form at 40 °C 20 hr was low moisture content and
water activity 6.94±0.59% and 0.36±0.06, respectively. Starter culture was survival 97.77%
(7.6×107 CFU/g). It good quality to storage for long time.
Keyword: Form, Candida tropicalis, Survival, Temparature
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
97
O100-DP
The effect of pineapple waste extracts on quality of probiotic yogurt
Sreymom Hun1, Phunsiri Suthiluk1 and Nattaya Konsue1*
1 Program in Food Technology, School of Agro-Industry,
Mae Fah Luang University, Chiang Rai 57100, Thailand
*Tel.: +66 5391 6750, E-mail: [email protected]
ABSTRACT:
Probiotic yogurt is a kind of fermented dairy products which contains living microorganisms that
provide health advantage to human. Prebiotics are a source of dietary fiber which stimulates growing
and activities of bacteria in host-colon. The objectives of this study were to investigate properties of
pineapple fruitlet (PF) and peel (PP) fiber extract, and their effects on physico-chemical properties of
yogurt. The peel and fruitlet of “Phulae” pineapple, were collected from local fresh-cut factory in
Chiang Rai province. Raw materials were dried at 50°C for 24 hours prior to extraction by using 80%
ethanol. Dietary fiber and proximate content of extracts were analysed using enzymatic and AOAC
standard methods, respectively. PP extract contained 81.24% total dietary fiber (TDF) which included
both insoluble dietary fiber (IDF) and soluble dietary fiber (SDF) being 80.32% and 0.91%,
respectively. On the other hand, TDF, IDF and SDF content in PF extract were 48.29%, 46.97 % and
1.33%, respectively. PF fiber had significantly higher moisture (9.38 ± 0.08%), protein (5.64 ±
0.28%), ash (13.62 ± 0.28%), water holding capacity (13.94 ± 0.007%), SDF (1.33 ± 0.76%) and 1,1-
diphenyl-2-picrylhydrazine (DPPH) radical scavenging activities (2.06 ± 0.17µMTE/g) compared to
PP fiber. Therefore, PF fiber was chosen to be added into yogurt at different concentrations (1, 2 and
3%). Lactobacillus delbrueckii subsp. Bulgaricus (LB) and Streptococcus thermosphilus (ST) were
employed as yogurt starter and Lactobacillus casei (LC) was served as a probiotic. Yogurt fortified
with 1%, 2% and 3% of PF fiber had pH value in range of 4.53-4.64, 4.49-4.64 and 4.34-4.60
respectively, whilst pH value in control sample (0% PF fiber) was 4.52-4.63 throughout 28 days of
storage. There was a significant difference (p<0.05) of acidity of 3% PF fiber yogurt compared with
1%, 2% and control samples. The firmness and consistency of yogurt containing 1% and 2% of PF
fiber were higher (p<0.05) than those in control and 3% PF fiber, respectively. The decrease in
syneresis compared to control was observed in all concentrations of PF fiber including 1% (31.15-
34.88%), 2% (28.71-32.00%) and 3% (25.11-28.99%). As a result, the additional of 1% and 2% of
PF fiber could reduce the syneresis and improve the firmness and consistency of yogurt.
Keyword: Prebiotic, Pineapple waste, Yogurt
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
98
O120-DP
Effect of Saccharomyces Sp. No.9 on Physicochemical Characteristics of
Aged Roselle Wine and Its Consumer Preference
Kotchakorn Sereephantwong1, Siriwan Panprivech2, and Viyada Kunathigan1*
1 Department of Food Biotechnology, School of Biotechnology, Assumption
University, Bangkok, Thailand
2 Department of Agro - Industry, School of Biotechnology, Assumption
University, Bangkok, Thailand
ABSTRACT:
Roselle wine has been produced as alternatives to red grape wine in the region where red grape
is not easy to find. Quality improvement of Roselle wine is needed to make Roselle wine more
competitive in the market. Aging technique was commonly used to improve quality of grape wine
which could be as beneficial to the improvement of Roselle wine. In this research,
Saccharomyces sp. No.9, previously isolated from the aged wine in the cellar was used to test its
effect on physicochemical characteristics of aged Roselle wine during 6-month bottle aging. The 6-
month aged wine was further subjected to the consumer preferences. The base wine was prepared
by fermenting Roselle extract with Premier Rouge (UCD904) yeast. Saccharomyces sp. No.9 starter
culture was added to filtered base wine as aging inoculum. The results showed that Roselle wine
aged with Saccharomyces sp. No.9 had significantly lower in sugar content, and higher in alcohol
content than control wine (p<0.05). During aging for 6 months, level of phenolic compound and
color enhancement (red pigment) were influence by Saccharomyces sp. No.9, however there were
no significant difference after aged for 6 months (p<0.05). On the other hand, Roselle wine aged
with aging yeast had more red pigments and lower hue than the control wine which may cause by
slow reduction rate of anthocyanins. From consumer preference test, 43% of panels preferred
control wine (aged 6 months without aging yeast) over the aged Roselle wine with addition of aging
yeast, probably because of sweetness and sourness. Therefore, the Saccharomyces sp. No.9 has
potential to be used as aging yeast in the aging process to improve the wine quality, because it
effects on physicochemical components especially alcohol content and color of wine however
the improvement in term of sensory will needed to be addressed.
Keyword: Roselle wine, Aging yeast, Saccharomyces sp., anthocyanin
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
99
P27-DB
Fermentation of Haematococcus pluvialis in brewery wastewater for
biomass production and nutrients removal
Siao-Ming Yap1, 2, John Chi-Wei Lan2, Hui-Suan Ng1 and Hip-Seng Yim1*
1Department of Food Science and Nutrition, Faculty of Applied Sciences, UCSI
University, No. 1, Jalan Menara Gading, UCSI Heights, 56000 Cheras,
Kuala Lumpur, Malaysia
2 Biorefinery and Bioprocess Engineering Laboratory,
Department of Chemical Engineering and Materials Science, Yuan Ze
University, No. 135, Yuandong Rd, Zhongli District, Taoyuan City, Taiwan
*Tel.: +603 9101 8880, E-mail: [email protected]
ABSTRACT:
Microalgae wastewater treatment is an economic and eco-friendly biotechnology process due to the
capability of microalgae in assimilating excess nutrients such as nitrogen (N) and phosphorus (P)
from the wastewater to grow. Integration of microalgae fermentation with wastewater treatment
provides a promising approach for bioactive compounds production with potential benefits for human
health. Haematococcus pluvialis is a green freshwater microalgae species, well-known for its ability
to produce natural astaxanthin which is a strong antioxidant with great potential to be used as an agent
to fight against free-radical associated diseases. The present study aims to investigate the biomass
production and nutrients removal efficiency of H. pluvialis cultivated in the mixture of Bold’s Basal
Medium (BBM) and different concentration of brewery wastewater (BW) (25%, 50%, 75% and
100%). The total reducing sugar, nitrogen and phosphorus removal efficiency of H. pluvialis were
determined on the day-14 of cultivation. The results showed that maximal biomass production of 29
x 10⁵ cells/mL was attained in the 50% BW cultures with total reducing sugar, nitrogen and
phosphorus removal efficiency at 91%, 56% and 13%, respectively. Following this, the 50% BW
cultures was then selected and inoculated into 100% BW supplemented with brewer’s spent grain
(BSG) at different concentration (0.5 g/L, 1.0 g/L, 1.5 g/L and 2.0 g/L). The highest biomass
production of 60 x 10⁶ cells/mL was achieved in 100% BW supplemented with 2.0 g/L BSG. Results
revealed that H. pluvialis can be grown in both mixtures containing BBM and BW as well as 100%
BW supplemented with BSG. However, further studies are still needed to enhance the biomass
production and nutrients removal efficiency by H. pluvialis in brewery wastewater.
Keywords: Haematococcus pluvialis, biomass production, nutrient removal, Brewery wastewater,
wastewater treatment
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
100
P119-DB
Development of an innovative fermented paste from green tomato to
produce new foods with added nutritional value
Rafaela Santos1*, Sara Simões1, João Santos Silva2, Isabel Sousa1, Mariana Mota1,
Catarina Prista1 and Anabela Raymundo1
1LEAF (Linking Landscape Environment Agriculture and Food) Research
Center, Instituto Superior de Agronomia, Universidade de Lisboa
Tapada da Ajuda, Lisboa, 1349-017, Portugal.
2Centro de Competências para o Tomate Industria (CCTI) Quinta das Pratas
2070-158 Cartaxo, Portugal.
*E-mail: [email protected]
ABSTRACT:
Green tomatoes represent one of the biggest by-products of the tomato industry, which focuses mainly
on the commercialization of fully ripe fruits and their transformation into products, such as paste and
dried tomatoes. The use of the green tomatoes rejected by the industry represents a sustainable
solution for the development of new products, adding value to this agriculture residue. In line with
this approach, the GreenTaste project aims to promote the use of green tomatoes as a raw-material,
through the production of an innovative intermediate food product – fermented green tomato paste.
The selection of six yeast strains was based on their growth performance on green tomato solid media.
Yeast strains were then tested for their fermentative potential at 25ºC, on green tomato paste, in the
absence and in the presence of 2% (w/w) NaCl. Throughout fermentation, the ability of the different
yeasts to grow/ferment tomato paste was assessed by microbiological (cell viability, CFU/mL),
physico-chemical (pH, potentiometer; ºBrix, refractometer; phenolic compounds, spectrophotometer;
colour, CIELab method; texture, TPA; and linear viscoelastic behaviour, SAOS) and sensorial
analyses.The results showed that fermentations performed without salt, produced pastes with higher
values of phenolic compounds and firmness, stronger internal structure and more pronounced colour
evolution. Furthermore, in the presence of 2% (w/w) NaCl, different properties were observed in
pastes fermented by Kluyveromyces marxianus and Pichia membranifaciens. K. marxianus
originated the paste with highest pronounced colour evolution and content of phenolic compounds,
presenting the lowest internal structure and firmness values. The results from physico-chemical and
sensorial analyses revealed that salt concentration and yeast strain had an effect on the characteristics
of fermented tomato pastes. In terms of sensory analysis, the presence of salt resulted in the
fermented pastes with the most appreciated attributes.The yeasts producing the most promising
fermented pastes, will be further tested in consortium with lactic acid bacteria (previously selected),
and solanine and tomatine glycoalkaloids content evaluated. The final fermented paste developed will
be incorporated into foods/beverages, such as: apple juice and balsamic vinegar. This will contribute
to improve the nutritional properties of the products, due to the benefits associated to fermentation
processes.
Keyword: Green tomato; by-product; sustainability; fermentation; innovative food.
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
101
P49-DP
in vitro Inhibitory impact of vapor phase – acetic acid, lactic acid and
citric acid on Staphylococcus aureus isolated from fresh-cut jackfruit
Uraiwan Podjanee1 and Warawut Krusong1*
1Faculty of Agro-Industry, King Mongkut’s Institute of Technology Ladkrabang,
Bangkok 10520, Thailand *Tel.: +66 86 375 3160, E-mail: [email protected]
ABSTRACT:
The purpose of this study was to investigate the in vitro inhibitory impact of vapor phase- acetic acid
(AA), lactic acid (LA) and citric acid (CA) on Staphylococcus aureus contaminated on fresh-cut
jackfruit. The contamination survey of S. aureus was conducted by 30 samples fresh-cut jackfruit in
the local market, Ladkrabang district, Bangkok. S. aureus was found in 40% of samples (12/30).
Then, two inhibitory treatments in vitro on isolated S. aureus were carried out including agar disc
diffusion and vapor exposure. Results of agar diffusion on Tryptone Soya Agar (TSA) found that
inhibition zone of 10% of AA, LA, and CA on growth of S. aureus was 2.09 ± 0.05 cm, 1.46± 0.04
cm and 1.24± 0.06 cm, respectively. AA caused the strongest effect than LA and CA. For vapor
exposure treatment, the suspension of S. aureus at low (103 CFU/ml) and high (106 CFU/ml) were
spread on TSA plate and placed in vapor exposure box (0.25x0.30x0.25 m) at 30°C. To generate the
evaporated vapor of each acid solution, the ambient cleaned air was pumped to 500 ml liquid solution
at 10% v/v concentration in a 1,000 ml closed bottle. Then, the delivery of vapor phase of each acid
from the headspace of the bottle was pump into the box. Results revealed that AA vapor provided the
strongest inhibitory effect on S. aureus when compared with LA and CA vapors at 120 min exposure
period. Complete inhibition after treatment with AA vapor at 20 min exposure period (0.65 ± 0.05
mM AA content) for low inoculation and at 30 min (0.99 ± 0.02 AA content) for high inoculation
were observed. The effectiveness of inhibitory impact on S. aureus showed that AA is suitable to
apply as a bio-control agent to reducing the potential pathogen contamination of fresh-cut jackfruit
product.
Keyword: Staphylococcus aureus, vapor phase, acetic acid, lactic acid, citric acid, fresh-cut jackfruit
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
102
P101-DP
Effect of basil seed mucilage on physicochemical and biological
properties of probiotic yogurt
Kamonchanok Khanngern1, Pawunrut Laojun1 and Nattaya Konsue1*
1Food Science and Technology Program, School of Agro-Industry Mae Fah Luang University
333 Moo1, Thasud, Muang, Chiang Rai, 57100, Thailand
*Tel.:+66 5391 6750, E-mail: [email protected]
ABSTRACT:
Yogurt is a healthy food that offers many health benefits. The main quality attribute of set yogurt is
syneresis which can affect consumer acceptance. The aim of this research was to study the effect of
basil seed mucilage (BSM) on physicochemical and biological properties of probiotic yogurt. BSM
was used as a prebiotic for improving the stability of lactic acid bacteria and reducing syneresis in
probiotic yogurt. Lactobacillus bulgaricus and Streptococcus thermophilus were used as starter
culture whereas Lactobacillus acidophilus was served as probiotic bacteria. Chemical composition,
swelling capacity and the effect on bacteria stability of BSM were investigated. Protein, fat, total
dietary fiber, moisture, and ash content of BSM were 0.49, 0.51, 84.44, 2.15 and 1.10%, respectively.
Yogurts were produced with BSM (1, 2, and 3%, w/v), and without BSM as the control. Color,
syneresis, firmness, acidity and pH including microbial changes of probiotic yogurt during storage at
5°C for 28 days were determined. It was found that addition of BSM led to darker color of yogurt.
However, syneresis was decreased while the firmness increased with increasing BSM concentration.
During 14 days storage, firmness decreased and in comparison to the control sample, pH rapidly
decreased to 4.6 when BSM was incorporated. Moreover, the population of probiotic bacteria in the
control sample was lower than that in yogurt containing BSM and the number was relatively stable
during storage.
Keyword: Basil seed mucilage, prebiotics, probiotics, probiotic yogurt, yogurt
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
103
P121-DP
Antimicrobial Effects of Tannic Acids and Licorice Extract
(Glycyrrhiza glabra L.) as a potential application for antimicrobial
biodegradable film
Pattra Maneesin1*, Supatjaree Ruengsomwong2 and Phattraraporn Riangpirom1
1Thai Packaging Centre,
Thailand Institute of Scientific and Technological Research (TISTR) 196
Phahonyothin road, Chatuchak, Bangkok 10900, Thailand
*Tel.:+66 2 579 1121 ext. 3201, E-mail: [email protected]
2Biodiversity Research Centre,
Thailand Institute of Scientific and Technological Research (TISTR) 35 Mu 3 Technopolis,
Tambon Khlong Ha, Amphoe Khlong Luang Pathum Thani 12120,Thailand
ABSTRACT:
In order to obtain natural antimicrobial substances for fabrication of antimicrobial biodegradable
film, determination of antimicrobial effects of some herbs and spices, as well as their derivatives was
investigated. Tannic acids are polymer of gallic acid molecules and glucose which have
antimicrobial effect and can be found in some plants e.g. guava, tea leaves, grape and tamarind seed
etc. Thus, inhibitory effects of tannic acid and licorice (Glycyrrhiza glabra L.) extract against four
foodborne bacteria including E. coli ATCC 8379, S. aureus ATCC 6538, S. Enteritidis TISTR 518
and B. cereus TISTR 2372 were carried out. Minimum inhibitory concentrations (MIC) and minimum
bactericidal concentrations (MBC) of licorice extract and tannic acid against four bacteria were
investigated. The results showed that tannic acid had better inhibitory effects against all test bacteria
than the licorice extract did as indicated by their MIC and MBC values. The MIC of tannic acid
against E. coli ATCC 8379, S. aureus ATCC 6538, S. Enteritidis TISTR 518 and B. cereus TISTR
2372 were 1.9531, 0.1221, 0.9765 mg/ml, and 61.0352 µg/ml, respectively. In addition, MBC of the
tannic acid against the test bacteria were 1.9531, 0.4883, 3.9063 and 0.1221 mg/ml, respectively. Of
the test bacteria, B. cereus TISTR 2372 was the most sensitive to both licorice extract and tannic
acid. Accordingly, preliminary study on antimicrobial biodegradable film based on polylactic acid
(PLA) and chitosan incorporated with tannic acid will be carried out.
Keyword: Antimicrobial effect, Tannic acid, Licorice extract, minimum inhibitory concentration
(MIC), minimum bactericidal concentration (MBC)
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
104
P143-DJ
Evaluation of prebiotic potential of Spirogyra sp., Cladophora sp.,
Caulerpa lentillifera and Caulerpa corynephora .
1,*Chadseesuwan, U., 2Puthong, S. and 1Deetae, P.
1 Faculty of Food industry, King Mongkut’s Institute of Technology Ladkrabang,
Bangkok 10520, Thailand
*E-mail: [email protected]
2 Institute of Biotechnology and Genetic Engineering, Chulalongkorn University,
Bangkok 10330, Thailand
ABSTRACT:
The aim of this research was to evaluate the prebiotic potential of two freshwater macroalgae
(Spirogyra sp., Cladophora sp.) and two saltwater macroalgae (Caulerpa lentillifera and Caulerpa
corynephora) aqeous extracts using in vitro fermentation. Total soluble carbohydretes of macroalgaes
were obtained after extraction with 75oC of water for 1 h. The concentration of total sugar and
reducing sugar were 0.764 and 0.197 mg/g in Spirogyra sp., 0.368 and 0.082 mg/g in Cladophora
sp., 0.484 and 0.055 mg/g in Caulerpa lentillifera, and 0.253 and 0.037 mg/g in Caulerpa
corynephora, respectively. Degree of polymerization (DP) that refers to the size of oligosaccharide,
were 3.8, 4.5, 8.9 and 6.9, respectively. The prebiotic activity was assessed by the change of bacterial
population. Sample extracts from macroalgaes were tested for growth stimulation effect on probiotic,
Lactobacillus plantarum TISTR862, and pathogen, Escherichia coli TISTR073. Results
demonstrated that population of L. plantarum TISTR862 and E. coli TISTR073 were higher in sample
extracts from freshwater than saltwater macroalgae. The prebiotic activity score was calculated based
on the change of growth in probiotic and pathogen after 24 h of incubation time. The highest score
was obtained from Caulerpa corynephora extracts (1.10) follow by Caulerpa lentillifera extracts
(0.77), Cladophora sp. extracts (0.173) and Spirogyra sp. extracts (0.07). In comparison with
commercial culture (L. casei, L. lactis, Streptococcus thermophilus and Bifidobacterium), addition of
3.5% Caulerpa lentillifera extracts resulted in the same prebiotic activity score as 3.5% FOS. Our
study demonstrated that Caulerpa lentillifera aqueous extracts could be a prebiotic substance.
Keywords: Caulerpa corynephora, Caulerpa lentillifera, Cladophora sp., Spirogyra sp., Prebiotic
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
105
DIVISION E
Related Food Topics (Food Packaging, Food Safety & Quality, Food
Laws & Regulations, Food Policy, etc.)
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
106
P75-EB
Development of bioplastic active packaging to inhibit fungal growth in
bakery product using cast-extrusion
Atcharawan Srisa1 and Nathdanai Harnkarnsujarit 1,2*
1Department of Packaging and Materials Technology, Faculty of Agro-Industry,
Kasetsart University 50 Ngam Wong Wan Rd. Ladyao District,
Chatuchak, Bangkok 10900, Thailand
2Center for Advanced Studies for Agriculture and Food, Kasetsart University
50 Ngam Wong Wan Rd., Ladyao, Chatuchak, Bangkok 10900, Thailand
*Tel.: +66 2562 5045, E-mail: [email protected]
ABSTRACT:
Mold spoilage and staling are major factors affecting shelf-life of bread and bakery products. Active
packaging with antimicrobial agents potentially extends shelf-life of foods without direct addition of
additives into bulk food products. Moreover, global environmental concern drives research and
development of bioplastic and biodegradable packaging to replace petroleum-based plastic. This
study aims to develop biodegradable antifungal films based on poly(lactic acid) (PLA), and
poly(butylene adipate-co-terephthalate) (PBAT) blends at PLA:PBAT ratios of 60:40
(PLA60/PBAT40) and 40:60 (PBAT60/PLA40) with incorporated trans-cinnamaldehyde as
antifungal agent. Films were produced by cast-extrusion and characterized for morphology,
mechanical, and barrier properties. The antifungal efficiency was determined in sliced bread stored
at 30 ± 2 ºC. In addition, qualities of packaged bread namely microbial count, water activity, texture,
and crystallinity were determined. Scanning electron microscopy showed that addition of 2% trans-
cinnamaldehyde enhanced smooth surface microstructures and compatibility of PLA60/PBAT40, and
PBAT60/PLA40 blends film. However, increased trans-cinnamaldehyde concentration caused phase
separation contributed to loss of mechanical and barrier properties. The addition of trans-
cinnamaldehyde significantly decreased tensile strength in PLA60/PBAT40 and PBAT60/PLA40
film. Plasticization of 5% trans-cinnamaldehyde significantly increased water vapor permeability of
PLA60/PBAT40 film. Oxygen permeability of PBAT60/PLA40 film increased with increased trans-
cinnamaldehyde due to phase separation. Mold growth was found on bread after 3 days of storage,
while films containing trans-cinnamaldehyde (> 2%) effectively inhibited microbial growth over 21
days. Release of trans-cinnamaldehyde from films contributed to significant antifungal properties.
Moreover, hardness and crystallinity of packaged bread were modified. Water activity of bread
decreased during storage in concurrent with an increased crystallinity and crumb hardness.
Accordingly, incorporation of trans-cinnamaldehyde into biodegradable films via conventional
extrusion effectively produced bioplastic antifungal films that potentially extended shelf-life of
bakery products.
Keyword: Trans-cinnamaldehyde, Antifungal film, Biodegradable, Active packaging, Bread
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
107
P141-EB
Preparation of Specific Antibody-Conjugated Ferromagnetic
Nanoparticles for the Detection of Campylobacter jejuni in
Immunomagnetic Separation (IMS) System
Pattarapong Wenbap1, Taradon Luangtongkum2, Pongsak Khunrae1,
Triwit Rattanarojpong1 and Pravate Tuitemwong1*
1 Department of Microbiology, Faculty of Science,
King Mongkut's University of Technology Thonburi, Bangkok 10140, Thailand
*Tel.:+66 2470 8887, E-mail: [email protected]
2 Department of Veterinary Public Health, Faculty of Veterinary Science,
Chulalongkorn University, Bangkok 10330, Thailand
ABSTRACT:
Recently, the export of frozen chicken and processed chicken of Thailand is ranked as third largest
exporter worldwide. Occasionally, the imports of chicken products are rejected by trading partners of
several countries because of unqualified or Campylobacter jejuni contaminated products. For this
situation, specific antibody-conjugated ferromagnetic nanoparticles, anti-MEA FMNs, were prepared
in this work in order to be used as an immunomagnetic separation (IMS) system for accurate rapid
detection of C. jejuni. Therefore, the ferromagnetic nanoparticles (FMNs) with the particle size of
72 nm were synthesized by Polyol Technique and coated with anti-multiepitopes antigen (MEA)
polyclonal antibody. The result revealed that antibody concentration at 64.0 μg/mL was optimum for
the conjugation to FMNs and the capacity of conjugation was 26.67 g of antibody per 1 mg of FMNs
(approximately 83%). Using 20 μg of anti-MEA FMNs, it found that a maximal capture of C. jejuni
cells was 3.54×102 CFU when using the initial bacterium concentration of 106 CFU/mL after culturing
on selective modified charcoal cefoperazone desoxycholate agar (mCCDA). On the other hand, using
higher amount of anti-MEA FMNs (40 and 60 μg) reduced the capture efficiency. SEM analysis
showed that anti-MEA FMNs could attach bacterial cells with aggregative appearance of bacterial
cell as larger ellipse-like shape. These finding confirmed that anti-MEA FMNs had immunological
activity to bind with target bacterial cells. The rapid IMS system could reduce time and step of
detection especially enrichment step. Moreover, the IMS system is expected to combine with specific
PCR assay for species identification which is useful and effective for detection of C. jejuni in chicken
product.
Keyword: Campylobacter jejuni, rapid detection, ferromagnetic nanoparticles, immunomagnetic
separation, chicken product
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
108
P18-EP
Effect of Cereal Types on the Properties of Agar Based Edible Film
Siriwan Tungsangprateep 1*, Penchom Photjanataree1, Waree Jaruwattanayon1,
Jiraporn Khongchan1, Duangsamorn Suthisut2 and Panunya Pobsuk2
1Thai Packaging Centre, Thailand Institute of Scientific and Technological Research
196 Paholyothin Rd., Chatuchak, Bangkok,10900, Thailand
2Post-harvest and Processing Research and Development Office, Department of Agriculture
50 Paholyothin Rd., Chatuchak, Bangkok, 10900, Thailand
*Tel.:+66 2579 1121 ext. 3202, E-mail: [email protected]
ABSTRACT: The objective of this study was to investigate the effect of cereal types on the properties of agar
edible film. Cereal grains such as khao saohai rice, glutinous rice, mung bean, soy bean and peanut
bean are used to blend with agar-based film in order to reduce the price of agar film . They are also
abundant and nutritious as compared with agar. The mechanical properties in terms of tensile
strength, elongation and puncture strength as well as oxygen barrier properties were evaluated.
Results found that agar-cereal blended films had different mechanical properties due to their
different chemical composition and properties. Agar-mung bean film and agar-khao saohai film
possessed superior tensile and puncture strength than those of other blended films . The tensile and
puncture strength of agar-mung bean film and agar-khao saohai film were 13.853 MPa and 12.092
MPa, 0.028 J. and 0.032 J., respectively. Furthermore, oxygen transmission rate of both films were
less than 0.5 mm/m2.day, indicating their superior barrier to oxygen.
Keyword: Cereals, Agar, Edible film, Packaging
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
109
P40-EP
Effects of surfactant-modified cellulose nanocrystals on properties of
soy protein-based composite film
Mathaporn Wongoun1 and Thanachan Mahawanich1*
1Department of Food Technology, Faculty of Science, Chulalongkorn University
Phayathai Road, Wangmai, Pathumwan, Bangkok 10330, Thailand
*Tel.: +66 2218 5247, E-mail: [email protected]
ABSTRACT:
Soy protein has a potential to be used as polymeric base for edible and biodegradable film.
However, soy protein film still has a limitation in its moisture barrier and mechanical properties.
Nano- and micro-particle reinforcement is among the techniques that have been used to improve
such properties of various biopolymer films. This study therefore aimed to investigate the effect of
surfactant-modified cellulose nanocrystals on properties of soy protein isolate film. Cellulose
nanocrystals (CNC) were prepared in the laboratory from microcrystalline cellulose using acid
hydrolysis. Since nano-particles are generally prone to self-aggregation, the CNC obtained was
further modified using either non-ionic surfactant (glycerol monostearate, GMS) or ionic surfactant
(sodium stearoyl lactylate, SSL) at 1, 5, and 10% by weight of CNC. Different amount of surfactant-
modified CNCs (5, 10 and 15% of total weight) was added into soy protein-based film-forming
solution, which was later casted into a thin film. It was revealed that the size of CNC and surfactant-
modified CNC particles was in a range of 67.4-605.0 nm. Regarding the zeta potential, a key
indicator conferring the stability of a colloidal dispersion, the greatest negative values were observed
in those CNCs modified using 10% GMS (-69.9 mV) and 10% SSL (-84.5 mV). Addition of surfactant-modified CNCs to soy protein film was shown to significantly improved the film properties,
specifically at 15% reinforcement. The films added with GMS- and SSL-modified CNCs at 15% level
had the lowest transparency, water solubility, and water vapor permeance. Tensile strength of such
films was shown to be about 1.6 times greater than the non-reinforced control. Elongation at break,
on the other hand, tended to decrease upon increasing modified CNC content but all reinforced films
were still higher in elongation at break as compared to the control. CNCs modified with different
surfactants produced a film similar in properties. This study, therefore, demonstrated that surfactant-modified CNCs could improve light barrier, moisture barrier, as well as tensile properties of soy
protein film.
Keyword: cellulose nanocrystal, nanocrystalline cellulose, nanoparticle, nanocomposite, protein film
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
110
P82-EP
Comparison of high pressure processing and thermal pasteurization to
inactivate Escherichia coli O157:H7 in guava and coriander juices
Napassawan Fungsoongnoen*, Racha Tepsorn and Peamsuk Suvanakuta
Food science and Technology Department, Thammasat University
99 Paholyothin Rd., Klong luang, Pathumthani, 12121, Thailand
*Tel.:+66 89 142 5629, E-mail: [email protected]
ABSTRACT:
E.coli O157:H7 is a main foodborne pathogen in the group of Enterohemorrhagic E.coli that is
extremely harmful to humans because these strains can produce Shiga toxin, which cause diarrhea,
hemorrhagic colitis, and hemolytic-uremic syndrome (HUS). Fruit and vegetable juice are a risk of
this contamination. The objectives of this research were to study the effect of high pressure process
on the survival of E.coli O157: H7 and to compare the efficiency of high pressure processing and
heat processing impact on inactivation of E.coli O157: H7 in guava and coriander juice. The results
shown that the application of pressure of 200 MPa was not enough to inhibit E.coli O157: H7 in
both guava and coriander juice, however the pressure above 400 MPa obtained about 7.0 log
reduction in guava juice and 4.0 log reduction in coriander juice. E.coli O157:H7 was entirely
eliminated by heat processing. High pressure above 400 MPa was the pressure level that has an
efficiency equivalent to heat treatment at 95oC for 5 min to inhibit E.coli O157: H7 for guava juice.
However, both of guava and coriander juices that underwent pasteurization and high pressure
process have a shelf-life of 10 days at 4°C.
Keyword: High pressure processing, E.coli O157:H7, guava juice, coriander juice
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
111
P86-EP
Development of Colorimetric Film with Butterfly Pea (Clitoria ternatea
L.) Extract for Application in Intelligent Packaging
Siriyupa Netramai1*, Thitisilp Kijchavengkul1,
Chatatorn Kham-ngam2, Pimnaphat Sirinupong2, Siraphop Kwanmuang2,
Hayati Samsudin3, and Sittiwat Lertsiri4
1School of Bioinnovation and Bio-based Product Intelligence,
Faculty of Science, Mahidol University, Nakhon Pathom, 73170, Thailand
2School of Interdisciplinary Studies, Mahidol University Kanchanaburi Campus,
Kanchanaburi, 71150, Thailand
3School of Industrial Technology, Universiti Sains Malaysia,
Penang, 11800, Malaysia
4Department of Biotechnology, Faculty of Science, Mahidol University,
Bangkok, 10400, Thailand
*Tel.:+668 1297 4697, E-mail: [email protected]
ABSTRACT:
Colorimetric film consisting of carbohydrate-based materials (carboxymethyl cellulose, carrageenan,
and pectin) and color extract from butterfly pea (Clitoria ternatea L.) flower was developed.
Response surface modelling and desirability analysis were used to optimize 1) color change in
response to pH and 2) solubility of the film. It was found that addition of butterfly pea extract did
not significantly affect important properties of base film. The color of developed film changed from
magenta to purple to blue, as pH of the surrounding increased from 2.0 to 7.0, through structural
transformation of delphinidin based anthocyanin observed from IR spectra of the films at pH values
of 2.0, 3.0, 5.0, and to 7.0. Sensory testing to determine the consumers’ ability to differentiate colors
of the films between pH 2.0 to 7.0 was conducted with untrained panelists (n = 50), using ‘Two out
of five’ difference test. The results showed that ≥50% of panelists could differentiate the differences
of the film’ colors at all pH pairs. The film was assembled into pH indicator to determine its
potential use as part of intelligent packaging for some short shelf-life foods. The indicators attached
onto the foods’ surfaces showed potential for the application as they changed color to those similar
to films immersed in colorless pH buffers of similar pH values.
Keyword: pH-sensitive material, Clitoria ternatea L., Anthocyanin, Biobased
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
112
P87-EP
Effects of Domestic Single Parcel Delivery on Integrity of Packaging
System
Siriyupa Netramai1, Thitisilp Kijchavengkul1*, Siraphop Kwanmuang2, Pongsapop
Kanjanapanjapol2, Nedchanok Chanachot2, Tanainun Srisakkrapikoop2,
Yardtip Wattanapanich2, Jiratchaya Sangphuek2, and Hayati Samsudin3
1School of Bioinnovation and Bio-based Product Intelligence,
Faculty of Science, Mahidol University, Nakhon Pathom, 73170, Thailand
2School of Interdisciplinary Studies, Mahidol University Kanchanaburi Campus,
Kanchanaburi, 71150, Thailand
3School of Industrial Technology, Universiti Sains Malaysia,
Penang, 11800, Malaysia
*Tel.: +66 90 986 5764, E-mail: [email protected]
ABSTRACT:
This research qualitatively studies effects of temperature fluctuation and mechanical force
encountered during domestic, ground delivery of single parcel, via postal service, on packaging
system of food product. Food simulants were packed in commercially available bags made from
paper, polyamide 12, biaxial-oriented poly(propylene) (BOPP), and metalized BOPP and laminated
foil structures. The packed samples were then sent, as cushioned or uncushioned parcels from Sai-
Yok, Kanchanaburi to residential area in Klongsan, Bangkok, via express mail service (EMS) and
registered mail service (RMS). From visual observation, it was found that parcels sent via EMS had
higher level of damages as compared to those of RMS. Physical damages frequently observed on
distribution packaging, i.e. corrugated box, included crush, bloat, puncture, and dent; and damages
found on many primary packaging, i.e. commercial bags, included pinhole and flex crack. Barrier to
moisture of most bag samples significantly decreased after ground delivery, especially, those made
from metalized BOPP, packed in the uncushioned parcels. Water vapor transmission rate (WVTR)
of uncushioned metalized BOPP bag increased from 9.0010-3 to 31.2210-3 g•d-1•bag-1 (P<0.05).
Cushioning the products, with bubble wrap, significantly reduced physical damages observed on-,
and caused lesser effect on water vapor transmission rate of studied primary packaging systems.
These findings can be used to further develop optimized packaging system for domestic ground
delivery of food product via postal service.
Keyword: Ground delivery, Single parcel, Distribution hazard, Packaging, Cushioning material
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
113
P95-EP
Effect of Polybutylene Succinate Film Incorporated with Vanillin
Against Escherichia coli and Staphylococcus aureus
Natticha Leaktong1, Noppadon Kerddonfag2, Vanee Chonhenchob1 and Pattarin Leelaphiwat1*
1Department of Packaging and Materials Technology,
Faculty of Agro-Industry, Kasetsart University
Lat Yao, Chatuchak, Bangkok, 10900, Thailand
2Polymer Research Unit, National Metal and Materials Technology Center
(MTEC), Klong Luang, Pathumthani, 12120, Thailand
*Tel.:+66 2562 5049, E-mail: [email protected]
ABSTRACT:
Antimicrobial packaging is a kind of active packaging which provides the special functions of
microbial growth inhibition in order to extend shelf life and prevent the loss of product quality.
Moreover, due to the environmental concern, biodegradable plastic became one of the alternatives to
reduce single-use plastics (SUP) for food packaging. Therefore, this study focused on the innovative
development of antimicrobial packaging by vanillin-incorporated polybutylene succinate (PBS)
films. Escherichia coli (E. coli) (negative-gram bacteria) and Staphylococcus aureus (S. aureus)
(positive-gram bacteria) were tested in antimicrobial activities. The incorporated film was produced
by blown film extrusion at different vanillin concentrations (5, 7.5, and 10% w/w). These treatments
of antimicrobial films were developed based on the minimum inhibitory concentrations (MIC). These
MIC results showed that the lowest MIC at 3% w/w was affected to E. coli growth. Moreover, the
lowest MIC at 12% w/w was inhibited S. aureus. Inhibition abilities against bacteria growth of films
by direct contact in liquid media method and vapor diffusion method were investigated. According
to remaining vanillin content result, vanillin content was reduced 10-20% approximately. For
antimicrobial result, the two methods obtained populations and diameter of colonies of bacteria which
were converted into antimicrobial index. The result of inhibition ability against E. coli and S. aureus
growth by direct contact in liquid media method exhibited that the populations of both strains
decreased with the increase of vanillin concentrations and at 10% w/w of vanillin, inhibition ability
was highest among all concentrations. Moreover, inhibition of E. coli was more effective than S.
aureus because E. coli was more susceptible. Similarly, vapor diffusion method results reviewed that
E. coli and S. aureus were still inhibited in comparison with control, but in case of S. aureus, vanillin
concentration factor was not influenced. Therefore, the incorporation of vanillin in PBS film can be
a great option as antimicrobial packaging for food in the future.
Keyword: active packaging, antimicrobial packaging, vanillin, polybutylene succinate,
biodegradable film
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
114
P97-EP
Effects of pH on the Seal Strength, Physical, and Mechanical Properties
of the Mung Bean (Vigna radiata) Protein Isolate Film
Nattakit Sapnoy1, Tshering Lhamo1, and Wantida Homthawornchoo1, 2, *
1Food Science and Technology Program, School of Agro-Industry
Mae Fah Luang University, Chiang Rai, 57100 Thailand
2Innovative Food Packaging and Biomaterials Unit (IFP)
Mae Fah Luang University, Chiang Rai, 57100 Thailand
*Tel.:+66 5391 6751, E-mail: [email protected]
ABSTRACT:
This research was focused on studying the effects of pH on the seal strength, physical, and
mechanical properties of the mung bean protein isolate (MPI) film. The MPI films were prepared by
air-dried casting method at 6 % w/v of MPI, obtained from different pH (i.e., 8, 9, and 10,
respectively). The test results showed that with the increase in pH, the MPI films became darker
with an increased a*, and b* toward red and yellow color, respectively. The thicknesses of all MPI
films were in the range of 71.67 – 72.15 m and did not significantly change. The tensile strength
(TS) and the elongation at break (EAB) of the developed films were significantly (p < 0.05)
increased with the increased pH. However, the different pH, as well as the different sealing times
(i.e., 1.30 s, 1.45 s, 2 s) did not significantly alter the seal strength of the sachets made from the
films. When compared to the seal strength of the commercial low-density polyethylene (LDPE)
plastic bag, the seal strength of the MPI film was significantly (p < 0.05) lower than that of the
commercial LDPE plastic (p < 0.05). Moreover, the MPI film of pH 9 demonstrated a significantly
higher film solubility (FS) in water than those of the films of pH 8, and pH 10. The FS of the MPI
films were also found to dissolve faster in the water of higher temperatures (i.e., 30, 60, and 90 °C,
respectively). This suggested that the MPI film of pH 9 has the potential to be applied as a fast -
dissolving and edible food packaging.
Keywords: Mung bean protein isolate, edible film, fast-dissolving film, seal strength, water solubility
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
115
P146-EP
Determination of pH-dye Based Smart Label for Monitoring Seafood
Product Quality
Ratchaneewan Kulchan1*, Waree Jaruwattanayon 1 and Bunrit Phraelai 1
1Thai Packaging Centre, Thailand Institute of Scientific and Technological Research
196 Phahonyothin Ladyao Chatuchuk Bangkok 10900, Thailand
*Tel.:+66 2579 1121 ext.3205, E-mail: [email protected]
.
ABSTRACT:
The smart label was developed in order to evaluate the degree of quality of seafood during storage
and distribution. Microorganism -Listeria monocytogenes, Salmonella spp., Staphylococcus aureus,
Yersinia Enterocolitica, Bacillus cereus, Enterococcus spp., Escherichia coli are main types that
effect on quality of seafood products. Three smart labels were selected to detect compounds in
seafood products: T1 was blending of acid-base dyes between bromocresol green and brilliant, T2
was blending of acid-base dyes between bromocresol purple and haema, and T3 was haema. The dye
solution and labels were initially used to evaluate sensitivity to metabolites of acetic acid over the
range of concentration. Subsequently, three types of smart labels, T1, T2 and T3, were produced to
monitor freshness of boiled shrimp, fresh shrimp and fresh fish. The potential of smart labels was
studied based on kinetic approach to correlate the response of these 3 labels to the change during
spoilage. In addition, the smart labels were studied humidity and temperature stabilities. The results
showed that the change in colour of smart label was directly proportional to metabolites and microbial
growth. T3 and T1 showed colour change response product deterioration. Total colour difference
(TCD) value of T3 were 37.87, 27.54 and 19.14 and TCD value of T1 were 18.27, 12.94 and 26.84
for boiled shrimp, fresh shrimp and fresh fish respectively. For the evaluation of humidity and
temperature stabilities of smart labels, they were found that temperature had more pronounced effect
than humidity especially T2 and T3, so the labels were suggested to store at temperature lower than
30 oC; nevertheless, for the application with seafood under virtual store simulation, it would be stored
at 5 oC. This experiment could confirm that dye and mixed dye smart label could be applied with food
package referred to intelligent packaging.
Keyword: Smart packaging, Seafood, Indicator, Intelligent Packaging, Microbial growth
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
116
P112-EJ
Effective Microbial Disinfection in Food Industry with Hydroxyl
Radical Fumigation
Sangadkit, W1,*. and Kongtrub, J. 2
1Food Safety Management, Fermentation Technology Division, Faculty of Food Industry,
King Mongkut’s Institute of Technology Ladkrabang, Chalong Krung Rd,
Bangkok 10520, Thailand
2Department of Biochemistry, Faculty of Science, Burapha University,
169 Long-Hard Bangsaen Road, Saensook, Muang, Chon Buri 20131, Thailand
*E-mail: [email protected]
ABSTRACT:
Hydrogen peroxide (H2O2) fumigation has recently been explored and tested to be a good fumigant
replacement of formaldehyde. This technique has been proven safer, less irritating and requires
shorter exposure times. Surface disinfection has long been implemented with toxic formaldehyde or
35% peroxide (H2O2). The results showed that they could be replaced with a safer and stronger
oxidizing agent, activated H2O2 in a vaporized form. Aerosolization by aerosol generators have been
used to produce aerosols containing hydroxyl radicals of hydrogen peroxide. The dispersal of this
highly oxidizing mist of micron-size droplets destroyed Escherichia coli/coliform (E. coli/coliform)
and Aspergillus niger (A. niger) colonies that have been artificially spiked on surfaces. The
experiments demonstrated efficient disinfection by integrating 1 to 5% H2O2 fumigation with ozone
(O3) and ultraviolet light (UV-C). Studies with E. coli/coliform and A. niger showed some
disinfection with either O3 or UV-C. Combining H2O2 fumigation with both O3 and UV-C exposure
considerably accelerated the microbial inactivation. This approach allowed fast disinfection with 1 to
5% H2O2, while offering cheaper and safer disinfection for healthcare settings.
Keywords: Surface disinfection, Hydrogen peroxide, Fumigation, Ozone, Ultraviolet
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
117
LIST OF AUTHORS
A
Abidin N. Z. ................................................ 62
Anabela Raymundo ............................. 93, 100
Anadi Nitithamyong ................................... xii
Anantita Sangsuriyawong ........................... 80
Anuchita Moongngarm ............................. xiv
Aphichart Kanchanatat ................................ 45
Arthittaya Thuanthong ................................ 33
Atchara Kangboonma ................................. 44
Atcharawan Srisa ...................................... 106
Ausanee Attawasu ....................................... 87
B
Boodasayapuk Buasakchai .......................... 58
Boonsong Ongphiphadhanakul ................... 46
Bootsrapa Leelawat ..................................... 69
Bunrit Phraelai .......................................... 115
C
Catarina Prista ..................................... 93, 100
Chadseesuwan, U. ..................................... 104
Chaleeda Borompichaichartkul ................... 82
Chanakan Chemthong ................................. 88
Chanakan Khemthong ........................... 41, 90
Chanika Chimkerd ................................ 46, 48
Chaowanee Chupeeruch .................. 41, 88, 90
Chatatorn Kham-ngam ............................. 111
Cheunjit Prakitchaiwattana ......................... 94
Chotika Viriyarattanasak............................. 68
Chumpon Numuang .................................... 26
D
Dalad Siriwan .............................................. 90
Danou Pao ................................................... 39
Deetae, P. .................................................. 104
Dewi Cakrawati........................................... 36
Donhareed Lahtee ....................................... 35
Duangkhamchan, W. ................................... 71
Duangsamorn Suthisut .............................. 108
E
Egon Bech Hansen ...................................... 35
F
Fahrunnisa Adzqia ...................................... 74
G
Gauri Khullar .............................................. 94
Gerry Renaldi .............................................. 56
Ghani, M.A. ................................................ 30
H
Hashim, H. .................................................. 62
Hayati Samsudin ............................... 111, 112
Hideki Kishimura ........................................ 22
Hip-Seng Yim ............................................. 99
Hui-Suan Ng ............................................... 99
I
Ichlasia Ainul Fitri ...................................... 79
Inthawoot Suppavorasatit ..................... 59, 73
Isabel Sousa .............................................. 100
Isaya Pootongpong ...................................... 86
Ishak, I. ....................................................... 30
Itsaranuwat, P. ............................................ 71
J
Jaran Patchimpet ................................... 34, 42
Jarurat Panyo .............................................. 35
Jaruwan Maneesri ................................. 78, 96
Jiraporn Khongchan .................................. 108
Jirarat Anuntagool ...................................... 44
Jiratchaya Sangphuek ............................... 112
Jirawat Yongsawatdigul ...... 23, 24, 37, 39, 40
Jittra Singthong ........................................... 75
João Santos Silva ...................................... 100
John Chi-Wei Lan ....................................... 99
K
Kakanang Ruchain ...................................... 41
Kalranath Suwapanichkittikorn .................. 65
Kamolnate Kitsawad ................................... 76
Kamolwan Jangchud ................................... 47
Kamonchanok Khanngern ........................ 102
Kanjana Manamoongmongkol .................... 57
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
118
Kanokphorn Sangkharak ....................... 34, 42
Kanokporn Mantham .................................. 38
Kazufumi Osako ......................................... 32
Kigen Takahashi ......................................... 32
Kitipong Assatarakul................................... 28
Kittanan Burapalit ....................................... 76
Kittichai Banjong ........................................ 51
Kongtrub, J. ............................................... 116
Koriyoh Kalupae ......................................... 78
Kotchakorn Sereephantwong ...................... 98
Krittiya Khuenpet ........................................ 60
Kunchit Judprasong............................... 46, 48
L
Lamnambhorn Sobmor ............................... 51
Lamphung Phumjan .................................... 57
Lattapol Boonditsataporn ............................ 84
Ling Tang .................................................... 23
M
Mariana Mota ...................................... 93, 100
Marisa Santos .............................................. 93
Masubon Thongngam ................................. 74
Mathaporn Wongoun ................................ 109
Mintra Nugthum .......................................... 83
Monruedee Sukprasansap ........................... 48
Mutita Meenune .......................................... 50
N
Na Jom, K. ............................................ 31, 52
Nantawan Therdthai .................................... 83
Napassawan Fungsoongnoen .................... 110
Napassorn Peasura ...................................... 80
Narintorn Boonbrahm ................................. xv
Nathdanai Harnkarnsujarit ........................ 106
Natnaree Katkaew ....................................... 61
Nattagan Chantagith .................................... 61
Nattakit Sapnoy ......................................... 114
Nattaya Konsue ................................... 97, 102
Natticha Leaktong ..................................... 113
Nattira On-nom ............................... 41, 88, 90
Natwaran Nukrohwad ................................. 96
Nedchanok Chanachot .............................. 112
Neeranuch Milasing .................................... 55
Netnapis Ongsuwan .................................... 26
Nichaputh Kaewmak .................................. 90
Nipa Rojroongwasinkul .............................. 46
Niramol Muangpracha ................................ 77
Nongnuch Sungayuth .................................. 48
Nonthacha Thanathornvarakul .................... 32
Noppadon Kerddonfag .............................. 113
Numphung Rungraung .................... 38, 63, 77
Nur-asikin Masaesa-I .................................. 26
Nuttanont Hongwarittorrn ........................ xiii
P
Pachara Pomsang ........................................ 82
Pakteera Sripokar ........................................ 35
Pamarin Waimaleongora-Ek ....................... 38
Panadda Nonthanum ................................... 57
Panchanit Eiam-o-pas ................................. 47
Panida Rattanapitigorn ................................ 61
Panunya Pobsuk ........................................ 108
Paosila, C. ............................................. 31, 52
Papassara Sangtanoo ................................... 45
Parichat Hongsprabhas ............................... 36
Parinya Noisa ........................................ 24, 40
Pathompol Suwanmongkol ......................... 80
Patomporn Waewkum ................................ 75
Pattanawich Joopawang .............................. 49
Pattarapong Wenbap ................................. 107
Pattarin Leelaphiwat ................................. 113
Pattra Maneesin ........................................ 103
Pattra Sangsopa ........................................... 69
Pawunrut Laojun ....................................... 102
Peamsuk Suvanakuta ................................ 110
Penchom Photjanataree ............................. 108
Phamorndech Tovaravirat ........................... 85
Phatthira Sutloet .......................................... 58
Phattraraporn Riangpirom ........................ 103
Philipda Suthipibul ..................................... 46
Phiromya Chanajon .................................... 40
Phunsiri Suthiluk ........................................ 97
Pichakorn Kongprapun ............................... 48
Pimnaphat Sirinupong .............................. 111
Pinidphon prombutara ................................ 94
Pitiporn Ritthiruangdej ............................... 83
Piyanut Sridonpai .................................. 46, 48
Piyaporn Cheamchaitrakun ......................... 67
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
119
Ploypailin Akanitkul ............................. 38, 63
Pongprom ponpermpoon ............................. 65
Pongsak Khunrae ...................................... 107
Pongsakorn Vithayanon .............................. 29
Pongsapop Kanjanapanjapol ..................... 112
Pongsert Sriprom......................................... 57
Pongsert Sripron .......................................... 65
Pornrat Sinchaipanit .................................... 80
Pramote Khuwijitjaru ............................ 54, 55
Pramvadee Y. Wongsaengchantra .............. 37
Prapasri Theprugsa ...................................... 87
Pravate Tuitemwong ................................. 107
Pumnat Chuenchomrat ................................ 95
Punchira Vongsawasdi ................................ 68
Puthong, S. ................................................ 104
R
Racha Tepsorn........................................... 110
Rachit Suwapanich ................................ 57, 65
Rafaela Santos ........................................... 100
Rajnibhas Sukeaw ....................................... 56
Ratana Sananmuang .................................... 66
Ratchaneewan Kulchan ............................. 115
Rawiporn Polpued ....................................... 60
Rumpagaporn, P. ................................... 31, 52
Rungrat Chamchan .......................... 41, 88, 90
S
Sai Aung Moon ........................................... 67
Sakonwat ..................................................... 22
Sakonwat Kuepethkaew .............................. 33
Samakradhamrongthai ................................ 56
Samart Sai-Ut .............................................. 43
Sangadkit, W ............................................. 116
Sappasith Klomklao ............ 22, 33, 34, 35, 42
Sara Simões ............................................... 100
Sasithorn Wanchum .................................... 70
Siao-Ming Yap ............................................ 99
Singthong, J. .......................................... 89, 91
Siraphop Kwanmuang ....................... 111, 112
Sireerat Laodheerasiri ................................. 29
Sirinda Kusump........................................... 70
Siriwan Panprivech ..................................... 98
Siriwan Tungsangprateep .......................... 108
Siriyupa Netramai ............................. 111, 112
Sitima Jittinandana ...................................... 46
Sittiwat Lertsiri ......................................... 111
Soottawat Benjakul ..................................... 33
Soraya Docar .............................................. 78
Sreymom Hun ............................................. 97
Srinivasan Damodaran .......................... 22, 33
Stefano Banfi .............................................. 93
Subin Srivichai ............................................ 36
Sunee Nitisinprasert .................................... 47
Suntaree Suwonsichon .......................... 74, 81
Sunyalak Gunyaphan .................................. 88
Supanut Leelapunnawut .............................. 68
Supasit Insang ............................................. 28
Supatjaree Ruengsomwong ...................... 103
Suteera Vatthanakul ........................ 84, 85, 87
Suthee Pungboonya .................................... 70
Suwatchai prapar ........................................ 65
T
Taewee Karrila ............................................ 26
Tanainun Srisakkrapikoop ........................ 112
Taradon Luangtongkum ............................ 107
Tatsawan Tipvarakarnkoon .................. 29, 76
Teepanee Pinitjun ....................................... 81
Teerarat Likitwattanasade ........................... 37
Thanaboon Theerapattarasakul ................... 68
Thanachan Mahawanich ........................... 109
Thanakorn Wongprasert ............................. 73
Thanapon Pattanasatian .............................. 27
Thidaporn Meesin ....................................... 70
Thitisilp Kijchavengkul .................... 111, 112
Thongchai Suwonsichon ............................. 81
Thongkaew, C. ...................................... 89, 91
Thunnalin Winuprasith ............. 38, 63, 77, 79
Thussanee Plangklang ................................ 54
Triwit Rattanarojpong ............................... 107
Tshering Lhamo ........................................ 114
U
Uraiwan Podjanee ..................................... 101
Uthaiwan Suttisansanee ............ 41, 63, 88, 90
V
Valeeratana Jaiboon .................................... 37
Vanee Chonhenchob ................................. 113
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
120
Varongsiri Kemsawasd ......................... 38, 63
Vipawan Jandee .......................................... 95
Viyada Kunathigan ..................................... 98
W
Wantanee Noichinda ................................... 59
Wantida Homthawornchoo ....................... 114
Waralee Watcharin ...................................... 29
Warangkana Sompongse ....................... 49, 58
Warawut Krusong ..................................... 101
Waree Jaruwattanayon ...................... 108, 115
Wilailuk Chaiyasit ....................................... 86
Wiphada Mitbumrung, 79
Worapot Suntornsuk ................................... 27
Wunwiboon Garnjanagoonchorn ................ 37
X
Xiaogang Zhang .......................................... 24
Y
Yardtip Wattanapanich ............................. 112
Yosephine Adela Djohan ............................ 50
Yuen, J.Z. .................................................... 30
Z
Zubairi, S.I. ................................................. 62
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
121
LIST OF REVIEWERS Name Organization Associate Professor Dr. Adisorn Swetwiwathana King Mongkut's Institute of Technology Ladkrabang
Assistant Professor Dr. Anadi Nitithamyong Mahidol University
Assistant Professor Dr. Angkana Chantarapopnpan Mahasarakham Unveristy
Associate Professor Dr. Anna Iwaniak Warmia and Mazury University in Olsztyn
Dr. Atittaya Tandhanskul Assumption University
Dr. Aussama Soontrunnarudrungsri Assumption University
Assistant Professor Dr. Awanwee Petchkongkaew Thammasat University
Assistant Professor Dr. Charin Techapun Chiang Mai University
Associate Professor Dr. Cheunjit Prakitchaiwattana Chulalongkorn University
Assistant Professor Dr. Chirat Sirimuangmoon Mae Fah Luang University
Dr. Churairat Moukamnerd Chiang Mai University
Dr. Chutamat Niwat Mae Fah Luang University
Dr. Coen Govers Wageningen University
Associate Professor Dr. Panuwat Suppakul Kasetsart University
Assistant Professor Dr. Ekasit Onsaard Ubon Ratchathani University
Dr. Hong Yang Huazhong Agricultural University
Assistant Professor Dr. Inthawoot Suppavorasatit Chulalongkorn University
Dr. Jatuporn Aroonkamonsri Rajamangala University of Technology Tawan-ok
Dr. Jedsada Tipmontien King Mongkut's University of Technology North Bangkok
Dr. Jintana Sripui Khon Kaen University
Assistant Professor Dr. Jirawan Oonmetaaree Nakhon Ratchasima Rajabhat University
Assistant Professor Dr. Jittra Singtong Ubon Ratchathani University
Associate Professor Dr. Kaemwich Jantama Suranaree University of Technology
Associate Professor Dr. Kanitha Tananuwong Chulalongkorn University
Assistant Professor Dr. Kanokrat Limpisophon Kasetsart University
Assistant Professor Dr. Ketinun Kittipongpittaya King Mongkut's University of Technology North Bangkok
Associate Professor Dr. Khongsak Srikaeo Pibulsongkram Rajabhat University
Assistant Professor Dr. Kiattisak DUANGMAL Chulalongkorn University
Assistant Professor Dr. Kitipong Assatarakul Chulalongkorn University
Dr. Kittipong Promyo Suranaree University of Technology
Assistant Professor Dr. Kriskamol Na Jom Kasetsart University
Dr. Kullanart Tongkhao Kasetsart University
Associate Professor Dr. Manat Chaijan Walailak University
Assistant Professor Dr. Nantarat Na Nakornpanom Srinakharinwirot University
Assistant Professor Dr. Naphatrapi Luangsakul King Mongkut's Institute of Technology Ladkrabang
Dr. Nattapol Tangsuphoom Mahidol University
Dr. Nattaya Konsue Mae Fah Laung University
Dr. Nittaya Phungam Rajamangkala University of Technology Isan
Dr. Orachorn Mekkerdchoo King Mongkut's Institute of Technology Ladkrabang
Assistant Professor Dr. Pairote Wongputtisin Maejo University
Dr. Panadda Nonthanum King Mongkut’s Institute of Technology Ladkrabang
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
122
Name Organization Assistant Professor Dr. Panchaporn Tadpitchayangkool
Promchote
Ubon Ratchathani University
Assistant Professor Dr. Patchanee Yasurin Assumption University
Dr. Patcharee Prasajak King Mongkut's University of Technology North Bangkok
Associate Professor Dr. Patcharin Raviyan Faculty of Agro-Industry, CMU
Dr. Patcharin Siringan Suranaree University of Technology
Dr. Patimakorn Pasuwan Khon Kaen University
Assistant Professor Dr. Phanat Kittiphattanabawon Thaksin University
Assistant Professor Dr. Phisut Naknaen Srinakharinwirot University
Dr. Pichamon Limcharoenchat Maejo University
Dr. Pimnibha Hirunsorn Khon Kaen University
Assistant Professor Dr. Pittaya Chaikham Phranakhon Si Ayutthaya Rajabhat University
Assistant Professor Dr. Piyarach Kullamethee King Mongkut's University of Technology North Bangkok
Assistant Professor Dr. Pongsak Khunrae King Mongkut's University of Technology Thonburi
Assistant Professor Dr. Pongtep Wilaipun Kasetsart University
Assistant Professor Dr. Prasert Hanmoungjai Chiang Mai University
Dr. Pumnat Chuenchomrat Thammasat University
Assistant Professor Dr. Ratchada Tangwongchai Khon Kaen University
Assisstant Professor Dr. Ratchadaporn Oonsrivilai Suranaree University of Technology
Professor Dr. Ravi Gooneratne Lincoln University
Assistant Professor Dr. Rungarun Sasanatayart Mae Fah Luang University
Assistant Professor Dr. Rungtiwa Wongsagonsup Mahidol University
Associate Professor Dr. Saowanee Lerdworasirikul Kasetsart University
Associate Professor Dr. Sappasith Klomklao Thaksin University
Dr. Sarisa Suriyarak Chulalongkorn University
Assistant Professor Dr. Saroat Rawdkuen Mae Fah Luang University
Assistant Professor Dr. Siriporn Riebroy Kim Kasetsart University
Assistant Professor Dr. Sirirat Deeseenthum Mahasarakham Unveristy
Professor Dr. Sirirat Rengpipat Chulalongkorn University
Dr. Sirirung Wongsakul Mae Fah Luang University
Associate Professor Dr. Sirithon Siriamornpun Mahasarakham Unveristy
Assistant Professor Dr. Sitthipong Nalinanon King Mongkut's Institute of Technology Ladkrabang
Assisstant Professor Dr. Siwat Thaiudom Suranaree University of Technology
Dr. Somporn Katekaew Khon Kaen University
Dr. Sorraya Khiewnavawongsa Chiang Mai University
Assistant Professor Dr. Srikanjana Klayraung Maejo University
Assistant Professor Dr. Sriwiang Tipkanon King Mongkut's University of Technology North Bangkok
Assistant Professor Dr. Suched Samuhasaneetoo Silpakorn University
Associate Professor Dr. Sudarat Jiamyangyuen Naresuan University
Dr. Sukhuntha Osiriphun Chiang Mai University
Assistant Professor Dr. Sukon Tantipaibulvut King Mongkut's University of Technology Thonburi
Dr. Sumaporn Kasemsumran Kasetsart University
Assistant Professor Dr. Sunanta Tongta Suranaree University of Technology
The 22nd Food Innovation Asia Conference 2020 (FIAC 2020) Innovation for Future Food and Nutrition Security
18-19 June 2020
123
Name Organization Assistant Professor Dr. Sunee Eadmusik King Mongkut's University of Technology North Bangkok
Associate Professor Dr. Suntaree Suwonsichon Kasetsart University
Dr. Supaporn Sophonputtanaphoca Srinakharinwirot University
Assistant Professor Dr. Supawan Thawornchinsombut Khon Kaen University
Associate Professor Dr. Suppasil Maneerat Prince of Songkla University
Dr. Suriyan Supapvanich King Mongkut's Institute of Technology Ladkrabang
Dr. Suthaya Phimphilai Maejo University
Assistant Professor Dr. Suthisa Khampaka Suranaree University of Technology
Assistant Professor Dr. Tantawna Pirak Kasetsart University
Assistant Professor Dr. Tatdao Paseephol Mahasarakham Unveristy
Dr. Teeranun Janjarasskul Chulalongkorn University
Assistant Professor Dr. Teerarat Itthisoponkul Srinakharinwirot University
Dr. Tippapha Pisithkul Maejo University
Dr. Tiraporn Julyusan Suranaree University of Technology
Assistant Professor Dr. Tri Indrarini Wirjantoro Chiang Mai University
Dr. Umarphorn Chadseesuwan King Mongkut's Institute of Technology Ladkrabang
Dr. Utoomporn Surayot Chiang Mai University
Assistant Professor Dr. Vichai Leelavatcharamas Khon Kaen University
Assistant ProfessorWachira Jirarattanarangsri Chiang Mai University
Dr. Wachirapan Boonyaputthipong Ubon Ratchathani University
Associate Professor Dr. Wannee Jirapakkul Kasetsart University
Associate Professor Dr. Warangkana Sompongse Thammasat University
Associate Professor Dr. Waree Tiyaboonchai Naresuan University
Associate Professor Dr. Weerachet Jittanit Kasetsart University
Assistant Professor Dr. Weerasak Lertsiriyothin Suranaree University of Technology
Assistant Professor Dr. Weerawate Utto Ubon Ratchathani University
Assistant Professor Dr. Wichai Soemphol Khon Kaen University
Assistant Professor Dr. Wichamanee Yuenyongputtakal Burapha University
Associate Professor Dr. Wichittra Daengprok Maejo University
Dr. Wilailuk Chaiyasit Thammasat University
Dr. Wilawan Sintuprapa Kasetsart University
Assistant Professor Dr. Worawan Panpipat Walailak University
Dr. Yaowapa Lorjaroenphon Kasetsart University
Assistant Professor Dr. Yuthana Phimolsiripol Chiang Mai University