Technical Support Document Draft Air Emission Permit No ... · direct fired natural gas heating...

Technical Support Document, Permit Number: 10900032-102 of 9

Technical Support Document

For Draft Air Emission Permit No. 10900032-102

This technical support document (TSD) is intended for all parties interested in the draft permit and to meet the requirements that have been set forth by the federal and state regulations (40 CFR § 70.7(a)(5) and Minn. R. 7007.0850, subp. 1). The purpose of this document is to provide the legal and factual justification for each applicable requirement or policy decision considered in the preliminary determination to issue the draft permit. 1. General information

1.1 Applicant and stationary source location:

Table 1. Applicant and source address

Applicant/Address

Stationary source/Address (SIC Code: 2023 - Dry, Condensed, and Evaporated Dairy Products)

Kerry Ingredients and Flavours Inc One Millington Rd Beloit, Wisconsin 53511

Kerry Ingredients and Flavours Inc 2402 7th St NW Rochester, MN 55901-7536

Contact: Brian Morgan Phone: 507-254-9214

1.2 Facility description

This facility processes food ingredients and frozen cultures. The primary source of emissions is from drying food ingredients and packaging the dried ingredients. The main emissions are particulate matter (PM, PM10, and PM2.5) from two spray dryers and material handling for product packaging. Wet scrubbers and a venturi scrubber are used to control particulate emissions from the dryers, and fabric filters are used to control particulate emissions from material handling. The facility also has natural gas combustion emissions (primarily NOx and CO) from the two dryers, three 25 million BTU/hr boilers, one existing 30.4 million BTU/hr boiler, one 30.4 million BTU/hr boiler to be constructed, and space heaters. The facility also contains several units classified as insignificant activities as identified in Appendix A.

1.3 Description of the activities allowed by this permit action The MPCA has a combined operating and construction permitting program under Minn. R. ch. 7007, and under Minn. R. 7007.0800. Under that authority, this permit action authorizes construction. Based on a reopening initiated by MPCA, this major amendment permit action modifies the required operating parameters for venturi scrubber TREA 17. The new range pressure drop range is 5.0 - 15 inches water, and the new water flow rate minimum is 545 gallons/minute. These parameters are based on the operating parameters during the most recent performance test demonstrating compliance with applicable limits.

This permit action also rolls in a minor amendment that includes the addition of two new 30.4 million BTU/hr natural gas-fired boilers and corresponding stacks. This permit action also includes the installation of one 2.25 Million BTU/hr direct fired air heating unit and four indirect air heating units that qualify as insignificant activities.

1.4 Description of notifications and applications included in this action


Table 2. Notifications and applications included in this action

Date received Application/notification type and description 02/07/2019 Permit Reopening (IND20190001) 07/05/2018 Minor Amendment (IND20180001)

1.5 Facility emissions:

Table 3. Title I emissions summary

Pollutant

Unlimited potential emissions from the modification (tpy)

Limited potential emissions from the modification (tpy)

NSR/112(g) threshold for new major source (tpy)

NSR/112(g) review required? (yes/no)

PM 2.15 2.15 250 No PM10 2.15 2.15 250 No PM2.5 2.15 2.15 250 No NOX 11.91 11.91 250 No SO2 0.17 0.17 250 No CO 11.54 11.54 250 No Ozone (VOC) 1.55 1.55 250 No Lead 0 0 250 No CO2e* 33,900 33,900 100,000 No Highest individual HAP (Hexane) 1.41 1.41 10 No Total HAPs 1.48 1.48 25 No

*Carbon dioxide equivalents as defined in Minn. R. 7007.0100.

Table 4. Non-title I emissions increase summary

Pollutant

After change (lb/hr)

Before change (lb/hr)

Net change* (lb/hr)

Insignificant modification thresholds (lb/hr <)

Minor and moderate amendment thresholds (lb/hr < or >)

Type of amendment (minor or moderate)

PM10 0.49 0.00 0.49 0.855 3.42 Insignificant NOx 2.72 0.00 2.72 2.28 9.13 Minor SO2 0.04 0.00 0.04 2.28 9.13 Insignificant CO 2.63 0.00 2.63 5.70 22.80 Insignificant VOC 0.35 0.00 0.35 2.28 9.13 Insignificant Lead 0.00 0.00 0.00 0.025 0.11 Insignificant

*The term ‘Net Change’ is not equivalent to ‘Net Emissions Increase’ as defined at 40 CFR Section 52.21(b)(3).


Table 5. Total facility potential to emit summary

PM

tpy PM10 tpy

PM2.5 tpy

SO2 tpy

NOx tpy

CO Tpy

CO2e tpy

VOC tpy

Single HAP (Hexane) tpy

All HAPs tpy

Total Facility Limited Potential Emissions

160 70.0 71.2 0.470 62.1 53.8 93,500 4.32 1.41 1.48

Total Facility Actual Emissions (2018)

10.3 5.47 5.47 0.061 10.2 8.50 * 0.558 *

* Not reported in MN emission inventory.

Table 6. Facility classification

Classification Major Synthetic minor/area Minor/area PSD X Part 70 Permit Program X Part 63 NESHAP X

1.6 Changes to permit

• This permit has been updated to match MPCA’s current TEMPO language and guidance. • This permit reopening changes the TREA 17 pressure drop range limit from 15 to 100 inches of

water column (in. w.c.) to a range of 5.0 to 15 in. w.c., and lowers the minimum water flow rate limit from 565 gallons per minute (gpm) to 545 gpm, based on operating parameters measured during the most recent performance test.

• EQUIs 44 and 45 (Boilers 5 and 6) were added to the permit as part of the minor permit amendment received 7/5/2018. These natural gas-only boilers each have a maximum heat input capacity of 30.4 mmBTU/hr, and vent to new stacks STRU 31 and STRU 32, respectively. These boilers are subject to NSPS subpart Dc – Standards of Performance for Small Industrial-Commercial-Institutional Steam Generating Units. The requirements for this NSPS include notification of construction and startup, as well as recordkeeping of fuel usage. EQUI 44 (Boiler 5) is currently operational, and the notification requirements are complete.

• EQUI 46 (Boiler Room AHU) was added to the permit as part of the minor permit amendment. This direct fired natural gas heating unit has a maximum heat input capacity of 2.25 mmBTU/hr, and vents to STRUs 15, 17, 18, and new STRUs 31-34.

• The minor amendment also includes the addition of four new indirect natural gas fired air handling units which qualify as insignificant activities. Each AHU has a capacity of 800,000 BTU/hr.

2. Regulatory and/or statutory basis

2.1 New source review (NSR)

The permit carries forward limits on the facility such that it is a nonmajor source under New Source Review regulations. No changes are authorized by this permit.

2.2 Part 70 permit program


The permit carries forward limits on the facility such that it is a nonmajor source under the Part 70 permit program.

2.3 New source performance standards (NSPS)

This permit action includes the addition of two boilers each subject to New Source Performance Standards, Subpart Dc – Standards of Performance for Small Industrial-Commercial-Institutional Steam Generating Units. The requirements for boilers that exclusively fire natural gas are monthly fuel use logs and startup notifications.

2.4 National emission standards for hazardous air pollutants (NESHAP)

The facility remains an area source under the NESHAP program.

2.5 Environmental Justice This facility is located in an area of environmental justice concern. This means that it is in a location that satisfies one or more of the following criteria: • 40% or more residents report income levels less than 185% of the national poverty level • 50% or more of the residents are people of color • The facility is in or near a federally recognized tribal area This facility falls into the first criteria category, with 40% or more residents reporting income levels less than 185% of the national poverty level. The MPCA’s mission is to protect and improve our environment and enhance human health, and the agency is committed to ensuring that pollution does not have a disproportionate impact on any group of people-the principle of environmental justice. The MPCA defines environmental justice as the fair treatment and meaningful involvement of all people regardless of race, color, national origin, or income with respect to the development, implementation, and enforcement of environmental laws, regulations, and policies. The impacts of pollution vary across Minnesota, and historical inequities have exposed some populations such as people of color, low-income households, and people with underlying health issues to greater health impacts from pollution. The Agency attempts to involve communities in these areas earlier and more frequently in the permitting process and expand overall public involvement. The Agency also works with permittees to understand and address community concerns, and establish and enhance relationships with the surrounding community. For this project, no additional outreach was completed, due to the small scale of the project and insignificant emissions increases, which led to negligible air impacts as a result of the changes to the facility.

2.6 Regulatory Overview

Table 7. Regulatory overview of units affected by the modification/permit amendment

Subject item* Applicable regulations Rationale EQUI 18 Minn. R. 7011.0610 Standards of Performance for Direct Heating Equipment.

• Construction of the unit was on or after July 9, 1969; • The unit burns gaseous fuel; • The facility is located outside of the Twin Cities; and • The facility has less than or equal to 250 MMBtu/hr of indirect and direct heating equipment.


Subject item* Applicable regulations Rationale EQUI 43 Minn. R. 7011.0515 Standards of Performance for New Indirect Heating Equipment.

• construction of the unit was on or after January 31, 1977; • the unit burns gaseous fuels; • the facility is located inside the cities in Table II of the rule; • the unit capacity is less than or equal to 250 MMBtu/hr; and • the facility has less than or equal to 250 MMBtu/hr of indirect heating equipment.

EQUIs 44 and 45

40 CFR pt. 60, subp. Dc Standards of Performance for Small-Industrial-Commercial- Institutional Steam Generating Units. • Construction of each unit was on or after June 9, 1989; • Each unit has a maximum design capacity of greater than or equal to 10 MMBtu/hr, but less than or equal to 100 MMBtu/hr; and • Each unit burns natural gas as defined in 40 CFR § 60.41c

EQUI 46 Minn. R. 7011.0610 Standards of Performance for Direct Heating Equipment. • Construction of the unit was on or after July 9, 1969; • The unit burns gaseous fuel; • The facility is located outside of the Twin Cities; and • The facility has less than or equal to 250 MMBtu/hr of indirect and direct heating equipment.

TREA 17 Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i); To avoid major source under 40 CFR 70.2

Prevention of Significant Deterioration (PSD). Control efficiency and other operating parameter requirements to limit PM/PM10/PM2.5 PTE to avoid major source classification under NSR and Part 70. Permit specifies that any replacement scrubber must meet the TREA 17 requirements.

*Location of the requirement in the permit (e.g., EQUI 1, STRU 2, etc.).

3. Technical information

3.1 Calculations of potential to emit and emissions increase analysis Attachment 1 to this TSD contains the Title I emissions increase calculations for the modifications made under the minor permit amendment. These calculations demonstrate that this modification is not a major source or modification for PSD. Attachment 1 also contains the non-Title I calculations for this modification which demonstrate that the modification qualifies for a minor amendment under Minn. R. 7007.1450. EQUIs 44 and 45, Boilers Unrestricted PTE in tpy was calculated using emission factors found in AP-42 Section 1.4. Emission rates in lb/hr were determined using the maximum capacity of each boiler and those emission factors. There were no controlled emissions calculated, as no limits on operation or control equipment were attached to the boilers. EQUI 46, Air Handling Unit


Unrestricted PTE in tpy was calculated using emission factors found in AP-42 Section 1.4. Emission rates were determined using the maximum capacity of the air handling unit and those emission factors. There were no controlled emissions calculated, as no limits on operation or control equipment were attached to the air handling unit.

3.2 Monitoring In accordance with the Clean Air Act, it is the responsibility of the owner or operator of a facility to have sufficient knowledge of the facility to certify that the facility is in compliance with all applicable requirements.

In evaluating the monitoring included in the permit, the MPCA considered the following:

• The likelihood of the facility violating the applicable requirements. • Whether add-on controls are necessary to meet the emission limits. • The variability of emissions over time. • The type of monitoring, process, maintenance, or control equipment data already available for the

emission unit. • The technical and economic feasibility of possible periodic monitoring methods. • The kind of monitoring found on similar units elsewhere.

The table below summarizes the monitoring requirements associated with this amendment. Table 8. Monitoring

Subject item* Requirement (rule basis)

What is the monitoring Why is this monitoring adequate?

TREA 17 Control Efficiency for PM ≥ 94% (Minn. R. 7011.0070-7011.0080, Title I Condition: Avoid major source under 40 CFR § 52.21(b)(1)(i))

Daily pressure drop monitoring, Recordkeeping, O & M, inspections

Monitoring based on the Minnesota Performance Standard for Control Equipment is adequate to have a reasonable assurance of compliance.

Control Efficiency for PM10 ≥ 84% (Minn. R. 7011.0070-7011.0080, Title I Condition: Avoid major source under 40 CFR § 52.21(b)(1)(i), To avoid major source under 40 CFR § 70.2)




EQUI 18 – R2 Large Delaval Dryer

Particulate Matter <= 0.30 grains per dry standard cubic foot exhaust gas. Opacity <= 20 percent opacity except for one six-minute period per hour of not more than 60 percent opacity. (Minn. R. 7011.0610, subps. 1 & 2)

Recordkeeping: monthly fuel records

These units use natural gas only; therefore, the likelihood of violating either of the emission limits is very small. The Permittee can demonstrate that these units will continue to operate such that emissions are well below the emission limits by only burning natural gas. Design based PTE, using AP-42, is 28.6 lbs/hr of PM compared to the rule limit of 2290 lbs/hr of PM.

PM < 10 micron <= 8 pounds per hour as a total for STRU 20 and 21 (Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000, To avoid major source under 40 CFR 70.2 & Minn. R. 7007.0200)

Recurring performance testing (EPA Methods 5 and 202)

Performance testing at worst-case conditions is the most direct method for determining compliance with an emission standard when a CEMS is not available. Testing frequencies are typically set at 12, 36, or 60-month increments. Past test results, applicable rules, potential emissions, location of source, and past compliance history play a factor in setting the testing frequency. This permit requires testing to measure the PM10 emission rate (lb/hr) from EQUI 18 within 365 days of permit issuance and every 60 months thereafter. This frequency was chosen because the most recent performance test was not conducted at worst-case operating conditions as required by Minn. R. 7017.2025, subp. 2. In addition to recurring performance testing, other limits at TREA 2, TREA 5, TREA 6, and TREA 7(and associated monitoring) ensure that this applicable requirement is being met.

EQUI 43 – R3 Spray Dryer

Filterable Particulate Matter <= 0.40 pounds per million Btu heat input. Opacity <= 20 percent opacity except for one six-minute period per hour of not more than 60 percent opacity. (Minn. R. 7011.0515, subps. 1 & 2)

Recordkeeping: monthly fuel records

The combustion unit uses natural gas; therefore, the likelihood of violating either of the emission limits is very small. The Permittee can demonstrate that this unit will continue to operate such that emissions are well below the emission limits by only burning natural gas. Design based PTE for each unit, using AP-42, is 0.0075 lbs/MMBtu of PM compared to the rule limit of 0.4 lbs/MMBtu of PM.




EQUI 46 - Boiler Room AHU

Opacity ≤ 20% PM, variable with airflow (Minn. R. 7011.0610, subp. 1(A))

None This unit uses natural gas only; therefore, the likelihood of violating either of the emission limits is very small. The Permittee can demonstrate that this unit will continue to operate such that emissions are well below the emission limits by only burning natural gas. Design based PTE, using AP-42, is 0.02 lb/hr of PM. Applicable rule limit at maximum airflow (stack gas flow of 8,400 cfm through maximum stack gas flow of 12,500 cfm) is 6.5 to 8.3 lb/hr.

*Location of the requirement in the permit (e.g., EQUI 1, STRU 2, etc.).

3.3 Insignificant activities Kerry Ingredients and Flavours Inc has several operations which are classified as insignificant activities under the MPCA’s permitting rules. These are listed in Appendix A to the permit. The following insignificant activities are included in this modification. Table 9. Insignificant activities

Insignificant activity General applicable emission limit Discussion

Individual units with potential emissions less than 2000 lb/year of certain pollutants

Opacity ≤ 20% PM ≤ 0.4 lb/MMBtu (Minn. R. 7011.0515)

This modification adds four natural gas-fired indirect heating units, each with a maximum heat input of 800,000 BTU/hr. The Permittee can demonstrate that these units will operate such that emissions are well below the emission limits by only burning natural gas. Design based PTE, using AP-42, is 0.0075 lb/mmBTU of PM.

3.4 Permit organization

This permit meets the MPCA Tempo Guidance for ordering and grouping of requirements as well as the use of permit appendices.

3.5 Comments received This section will be completed after the referenced review periods.

4. Permit fee assessment This permit action is a reopening with a minor amendment rolled in, neither of which require additional points to be assessed. This action includes the addition of new units subject to 40 CFR pt. 60, subp. Dc, however, existing emission units at the facility were already subject to this standard, so no additional points were assessed.

5. Conclusion Based on the information provided by Kerry Ingredients and Flavours Inc the MPCA has reasonable assurance that the proposed operation of the emission facility, as described in the Air Emission Permit No. 10900032-102 and this TSD, will not cause or contribute to a violation of applicable federal regulations and Minnesota Rules. Staff members on permit team: Benton Campbell (Permit Engineer)

Ross Provow (Compliance) Adriane Lorsung (Peer Reviewer) Curt Stock (Performance Testing)


Michaela Leach (Permit Writing Assistant) Laurie O’Brien (Administrative Support)

TEMPO360 Activities: Minor Amendment (IND20180001), Permit Reopening (IND20190001)

Attachments: 1. PTE and Emissions Increase of Affected Units Calculation Spreadsheets

2. Subject item inventory and requirements report 3. Permit Reopening- Notice of Compliance 4. Manufacturer information for boiler emissions

Kerry Ingredients and Flavours Inc.Permit No. 10900032‐102 Technical Support Document

Attachment 1 PTE and Emissions Increase of Affected Units Calculation Spreadsheets

Kerry Ingredients & Flavours Inc. Emission Unit Specific InformationAQ Facility and File Number: 10900032 44 AP-42 Section 1.4Potential-to-Emit Emission Calculations - Criteria Pollutants and GHG Manufacturer's Information

Not Applicable.

Max. rated capacity (Btu/hr) 30,400,000 30,400,000 2,250,000 3,200,000Max. rated capacity (MMBtu/hr) 30.40 30.40 2.25 3.20Fuel type Natural Gas Natural Gas Natural Gas Natural GasHeating value, natural gas (Btu/scf) 1,020 1,020 1,020 1,020Natural gas consumption rate (scf/hr) 29,804 29,804 2,206 3,137Stack Flow Rate (scfm) 9,761 9,761 8,400-12,500 7,000Hours of Operation (hr) 8,760 8,760 8,760 8,760

CO (lb/MMscf) 84.00 84.00NOX (lb/MMscf) 100.00 100.00PM (Total) (lb/MMscf) 7.60 7.60 7.60 7.60PM10 (lb/MMscf) 7.60 7.60 7.60 7.60PM25 (lb/MMscf) 7.60 7.60 7.60 7.60SO2 (lb/MMscf) 0.60 0.60 0.60 0.60VOC (lb/MMscf) 5.50 5.50 5.50 5.50CO2 (lb/MMBTU) 116.73 116.73 116.73 116.73CH4 (lb/MMBTU) 2.20E-03 2.20E-03 2.20E-03 2.20E-03N2O (lb/MMBTU) 2.20E-04 2.20E-04 2.20E-04 2.20E-04CO (lb/MMBtu) 0.037 0.037NOX (lb/MMBtu) 0.036 0.036

Total

STRU 15, STRU 17, STRU 18,

STRU 31-34

None None None

IAs Added

Includes 4 NG indirect air heating

unitsControl equipment

Boiler 5 Boiler 6Boiler Room

AHU

EQUI 44 EQUI 45 EQUI 46

STRU 31 STRU 32

Name UnitsEmission unit ID

Stack/Vent number

Total


STRU 31-34

None None None

IAs Added




AHU


STRU 31 STRU 32


Stack/Vent number

Emission RateCO (lb/hr) 1.12 1.12 0.19 0.26 2.70NOX (lb/hr) 1.09 1.09 0.22 0.31 2.72PM (lb/hr) 0.23 0.23 0.02 0.02 0.49PM10 (lb/hr) 0.23 0.23 0.02 0.02 0.49PM25 (lb/hr) 0.23 0.23 0.02 0.02 0.49SO2 (lb/hr) 0.02 0.02 1.32E-03 1.88E-03 0.04VOC (lb/hr) 0.16 0.16 0.01 0.02 0.36CO2 (lb/hr) 3,549 3,549 262.65 373.54 7733.50CH4 (lb/hr) 0.07 0.07 4.95E-03 0.01 0.15N2O (lb/hr) 0.01 0.01 4.95E-04 7.04E-04 0.01

Potential EmissionsCO (tpy) 4.93 4.93 0.81 1.15 11.82NOX (tpy) 4.79 4.79 0.97 1.37 11.93PM (tpy) 0.99 0.99 0.07 0.10 2.16PM10 (tpy) 0.99 0.99 0.07 0.10 2.16PM25 (tpy) 0.99 0.99 0.07 0.10 2.16SO2 (tpy) 0.08 0.08 0.01 0.01 0.17VOC (tpy) 0.72 0.72 0.05 0.08 1.56CO2 (tpy) 15,543 15,543 1,150 1,636 33872.71CH4 (tpy) 0.29 0.29 0.02 0.03 0.64N2O (tpy) 0.03 0.03 2.17E-03 3.08E-03 0.06

Total


STRU 31-34

None None None

IAs Added




AHU


STRU 31 STRU 32


Stack/Vent number

GHG Carbon Dioxide Equivalent EmissionsCO2 (GWP = 1) (ton CO2e/yr) 15,543 15,543 1,150 1,636 33872.71CH4 (GWP = 25) (ton CO2e/yr) 7.32 7.32 0.54 0.77 15.96N2O (GWP = 298) (ton CO2e/yr) 8.73 8.73 0.65 0.92 19.02Total (ton CO2e/yr) 15,559 15,559 1,152 1,638 33907.69

Uncontrolled EmissionsCO (tpy) 4.93 4.93 0.81 1.15 11.82NOX (tpy) 4.79 4.79 0.97 1.37 11.93PM (tpy) 0.99 0.99 0.07 0.10 2.16PM10 (tpy) 0.99 0.99 0.07 0.10 2.16PM25 (tpy) 0.99 0.99 0.07 0.10 2.16SO2 (tpy) 0.08 0.08 0.01 0.01 0.17VOC (tpy) 0.72 0.72 0.05 0.08 1.56CO2 (tpy) 15,543 15,543 1,150 1,636 33872.71CH4 (tpy) 0.29 0.29 0.02 0.03 0.64N2O (tpy) 0.03 0.03 2.17E-03 3.08E-03 0.06

Kerry Ingredients & Flavours Inc.AQ Facility and File Number: 10900032 44Source Summary - HAPs

Benzene 4.20E-05 6.26E-05 6.26E-05 6.59E-06 1.74E-04Dichlorobenzene 2.40E-05 3.58E-05 3.58E-05 3.76E-06 9.93E-05

Formaldehyde 1.50E-03 2.24E-03 2.24E-03 2.35E-04 6.21E-03Hexane 3.60E-02 5.36E-02 5.36E-02 5.65E-03 1.49E-01

Naphthalene 1.22E-05 1.82E-05 1.82E-05 1.91E-06 5.05E-05POM (PAHs) 1.76E-06 2.63E-06 2.63E-06 2.77E-07 7.30E-06

Toluene 6.80E-05 1.01E-04 1.01E-04 1.07E-05 2.81E-04Arsenic Compounds 4.00E-06 5.96E-06 5.96E-06 6.27E-07 1.65E-05

Beryllium Compounds 2.40E-07 3.58E-07 3.58E-07 3.76E-08 9.93E-07Cadmium Compounds 2.20E-05 3.28E-05 3.28E-05 3.45E-06 9.10E-05Chromium Compounds 2.80E-05 4.17E-05 4.17E-05 4.39E-06 1.16E-04

Cobalt Compounds 1.68E-06 2.50E-06 2.50E-06 2.64E-07 6.95E-06Manganese Compounds 7.60E-06 1.13E-05 1.13E-05 1.19E-06 3.14E-05

Mercury Compounds 5.20E-06 7.75E-06 7.75E-06 8.16E-07 2.15E-05Nickel Compounds 4.20E-05 6.26E-05 6.26E-05 6.59E-06 1.74E-04

Selenium Compounds 4.80E-07 7.15E-07 7.15E-07 7.53E-08 1.99E-06TOTAL HAPS 3.78E-02 5.63E-02 5.63E-02 5.92E-03 1.56E-01

















Permit Allowable Potential to Emit (tpy)

Total Emissions Added (Including IAs

added)Pollutant

Emission Rate (lb/hr)

Sum of Insignificant Activities

Unrestricted Potential to Emit (tpy)


Boiler 5 Boiler 6 Boiler Room AHU

Boiler 5 EQUI 44Assumptions:Total Heat Input Capacity 30.40 MMBtu/hr

Heating Value1 1,020 btu/scfPotential Throughput 2.980E-02 MMscf/hr

Natural Gas Emissions

Pollutant Emission Factor2

(lb/MMScf)Emission Factor

UnitEmission Factor Source

Potential Emissions (lb/hr)

Potential to Emit(tpy)

Limited Potential to Emit (tpy)

Benzene 2.10E-03 lb/MMscf AP-42 Table 1.4-3 6.26E-05 2.74E-04 2.74E-04Dichlorobenzene 1.20E-03 lb/MMscf AP-42 Table 1.4-3 3.58E-05 1.57E-04 1.57E-04Formaldehyde 7.50E-02 lb/MMscf AP-42 Table 1.4-3 2.24E-03 9.79E-03 9.79E-03Hexane 1.80E+00 lb/MMscf AP-42 Table 1.4-3 5.36E-02 2.35E-01 2.35E-01Naphthalene 6.10E-04 lb/MMscf AP-42 Table 1.4-3 1.82E-05 7.96E-05 7.96E-05POM (PAHs) 8.82E-05 lb/MMscf AP-42 Table 1.4-3 2.63E-06 1.15E-05 1.15E-05Toluene 3.40E-03 lb/MMscf AP-42 Table 1.4-3 1.01E-04 4.44E-04 4.44E-04Arsenic 2.00E-04 lb/MMscf AP-42 Table 1.4-4 5.96E-06 2.61E-05 2.61E-05Beryllium Compounds 1.20E-05 lb/MMscf AP-42 Table 1.4-4 3.58E-07 1.57E-06 1.57E-06Cadmium Compounds 1.10E-03 lb/MMscf AP-42 Table 1.4-4 3.28E-05 1.44E-04 1.44E-04Chromium Compounds 1.40E-03 lb/MMscf AP-42 Table 1.4-4 4.17E-05 1.83E-04 1.83E-04Cobalt Compounds 8.40E-05 lb/MMscf AP-42 Table 1.4-4 2.50E-06 1.10E-05 1.10E-05Manganese Compounds 3.80E-04 lb/MMscf AP-42 Table 1.4-4 1.13E-05 4.96E-05 4.96E-05Mercury Compounds 2.60E-04 lb/MMscf AP-42 Table 1.4-4 7.75E-06 3.39E-05 3.39E-05Nickel Compounds 2.10E-03 lb/MMscf AP-42 Table 1.4-4 6.26E-05 2.74E-04 2.74E-04Selenium Compounds 2.40E-05 lb/MMscf AP-42 Table 1.4-4 7.15E-07 3.13E-06 3.13E-06

5.63E-02 2.46E-01 2.46E-01

Boiler 6 EQUI 45Assumptions:Total Heat Input Capacity 30.40 MMBtu/hr










5.63E-02 2.46E-01 2.46E-01

HAPS

TOTAL HAPS

TOTAL HAPS

HAPS

Boiler Room AHU EQUI 46Assumptions:Total Heat Input Capacity 2.25 MMBtu/hr










4.16E-03 1.82E-02 1.82E-02

IA Sums 4 New NG Indirect HeatersAssumptions:Total Heat Input Capacity 3.20 MMBtu/hr 4 heaters x 800,000 BTU/hr each










5.92E-03 2.59E-02 2.59E-02

TOTAL HAPS

HAPS

TOTAL HAPS

HAPS

Kerry Ingredients & Flavours Inc.AQ Facility and File Number: 10900032 44Emissions increase determinationsPre-Project Emissions

EQUI 44 EQUI 45 EQUI 46 IA NG Heaters

PTE PTE PTE PTE PTE(tpy) (tpy) (tpy) (tpy) (tpy)

PM -- -- -- -- --PM10 -- -- -- -- --PM2.5 -- -- -- -- --NOX -- -- -- -- --SO2 -- -- -- -- --CO -- -- -- -- --VOC -- -- -- -- --Lead -- -- -- -- --Fluorides -- -- -- -- --Sulfuric Acid Mist -- -- -- -- --Hydrogen Sulfide (H2S) -- -- -- -- --Total Reduced Sulfur including H2S -- -- -- -- --Total Reduced Sulfur Compounds including H2S -- -- -- -- --MWC Organics -- -- -- -- --MWC Metals -- -- -- -- --MWC Acid Gas -- -- -- -- --MSW Landfill Gas -- -- -- -- --CO2e -- -- -- -- --

Pollutant

Emission from all Units affected by the

modification

Post-Project Emissions

PTE PTE PTE PTE(tpy) (tpy) (tpy) (tpy) (tpy)

PM 0.99 0.99 0.07 0.10 2.16PM10 0.99 0.99 0.07 0.10 2.16PM2.5 0.99 0.99 0.07 0.10 2.16NOX 4.79 4.79 0.97 1.37 11.93SO2 0.08 0.08 0.01 0.01 0.17CO 4.93 4.93 0.81 1.15 11.82VOC 0.72 0.72 0.05 0.08 1.56Lead -- -- -- -- --Fluorides -- -- -- -- --Sulfuric Acid Mist -- -- -- -- --Hydrogen Sulfide (H2S) -- -- -- -- --Total Reduced Sulfur including H2S -- -- -- -- --Total Reduced Sulfur Compounds including H2S -- -- -- --

--MWC Organics -- -- -- -- --MWC Metals -- -- -- -- --MWC Acid Gas -- -- -- -- --MSW Landfill Gas -- -- -- -- --CO2e 15,559 15,559 1,152 1638 33908

Emission from all Units affected by the

modification

IA NG HeatersPollutant


Project Emission Changes

PTE PTE PTE PTE PTE

(tpy) (tpy) (tpy) (tpy) (tpy)

PM 0.99 0.99 0.07 0.10 2.16 25PM10 0.99 0.99 0.07 0.10 2.16 15PM2.5 0.99 0.99 0.07 0.10 2.16 10NOX 4.79 4.79 0.97 1.37 11.93 40SO2 0.08 0.08 0.01 0.01 0.17 40CO 4.93 4.93 0.81 1.15 11.82 100VOC 0.72 0.72 0.05 0.08 1.56 40Lead -- -- -- -- -- 0.6Fluorides -- -- -- -- -- 3Sulfuric Acid Mist -- -- -- -- -- 7Hydrogen Sulfide (H2S) -- -- -- -- -- 10Total Reduced Sulfur including H2S -- -- -- -- -- 10Total Reduced Sulfur Compounds including H2S -- -- -- -- -- 10MWC Organics -- -- -- -- -- 10MWC Metals -- -- -- -- -- 0MWC Acid Gas -- -- -- -- -- 40MSW Landfill Gas -- -- -- -- -- 15CO2e 15,559 15,559 1,152 1638 33908 75,000

250250250250

100,000

250250250250

250

250250250250250

250250250

Answered "No" to CH-04 question 3 or GI-09C

Section A

Threshold for major sources

Significant Emission Rates

for major sources (tpy)

Pollutant

Thresholds for minor sources ("No" to CH-04

question 5 or 6 or "No" to GI-09 question C4 or C5)

(tpy)

EQUI 44 EQUI 45 EQUI 46 IA NG HeatersEmission from all

Units affected by the modification

Kerry Ingredients & Flavours Inc.AQ Facility and File Number: 10900032 44Amendment Threshold Calculations

PM10 NOx SO2 CO VOC Lead(tpy) (tpy) (tpy) (tpy) (tpy) (tpy)

EQUI 44 0.23 1.09 0.02 1.12 0.16 --EQUI 45 0.23 1.09 0.02 1.12 0.16 --EQUI 46 0.02 0.22 0.00 0.19 0.01 --

Sum of IAs 0.02 0.31 0.00 0.26 0.02 --0.49 2.72 0.04 2.70 0.36 0.00

Insign Amendment Thresholds 0.855 2.28 2.28 5.7 2.28 0.025

Minor Amendment Thresholds 3.42 9.13 9.13 22.8 9.13 0.11

Kerry Ingredients and Flavours Inc.Permit No. 10900032‐102Technical Support Document

Attachment 2 Subject Item Inventory and Requirements Report

Subject Item Category Description Subject Item Type Description

Activity Insignificant Air Emissions Activity

Agency Interest Conventional Site

Component Group Air Component Group

Equipment Boiler

Dryer/Oven, indirect fired

Dryer/Oven, unknown firing method

Material Handling Equipment

Other Combustion

Other Emission Unit

Structure Building

Stack/Vent

Total Facility Air Quality Total Facility

Treatment 001-Wet Scrubber - High Efficiency

018-Fabric Filter - Low Temp, T<180 Degrees F

053-Venturi Scrubber

1

1

1

1

8

5

1

1

5

22

8

1

1

5

4

Overview of SI's (count) by type

Agency Interest: Kerry Ingredients and Flavours IncAgency Interest ID: NoneActivity: IND20190001 (None)

Details for:SI Category: AllSI Type: All

Agency Interest Name Subject Item ID SI Designation and Description

Kerry Ingredients andFlavours Inc

ACTV3NullAll IA's

AISI732NullNull

COMG5GP002New Indirect Heating Equipment

EQUI3EU015Main Office Space Heater

EQUI13EU001Boiler 1 Cleaver Brooks


EQUI17EU003Boiler 3 - Cleaver Brooks

EQUI18EU005Large Delaval Spray Dryer

EQUI31EU014R1 Package (from Spray Dryer)

EQUI32EU010Wet Blend Bag Dump

EQUI33EU011Wet Blend Bag Dump 1

EQUI34EU012Dry Blending

EQUI35 EU013Dry Packaging

List of SIs

Agency Interest: Kerry Ingredients and Flavours IncAgency Interest ID: 732Activity: IND20190001 (Permit Reopening)

Details for:SI Category: NoneSI Type: All

Agency Interest Name Subject Item ID SI Designation and DescriptionKerry Ingredients andFlavours Inc


EQUI35EU013Dry Packaging

EQUI36EU016R200 room East Wall Space Heater

EQUI37EU017Solaronics - R200 room West WallSpace Heater

EQUI38EU018Ammonia Compressor Room EastWall Space Heater

EQUI39EU019Hallway outside R300 room SpaceHeater

EQUI40EU020Hallway outside liquid packingroom Space Heater

EQUI41EU021Hallway next to shipping/receivingSpace Heater

EQUI42EU022Shipping receiving - South WallSpace Heater

EQUI43NullR3 Spray Dryer

EQUI44NullBoiler 5

EQUI45NullBoiler 6

EQUI46NullBoiler Room AHU

STRU1 SV016IR Space Heater

List of SIs




EQUI46NullBoiler Room AHU

STRU1SV016IR Space Heater




STRU9SV010Wet Blend Bag Dump 1


STRU11SV012Dry Blend

STRU12SV013Dry Packaging

STRU13SV014R1 Package

STRU14SV015Main Office Space Heater

STRU15SV001Boiler 1

STRU16SV002Boiler 2

STRU17 SV003Boiler 3

List of SIs




STRU16SV002Boiler 2

STRU17SV003Boiler 3

STRU18SV004Boiler 4

STRU20SV007Large Delaval Spray Dryer Stack 1


STRU22NullR3 Dryer Stack

STRU23NullAdministration offices and labsbuilding

STRU24NullR201 Fermenter Building

STRU25NullWarehouse, Cultures, & dry blendpackaging building

STRU26NullR2 Dryer building

STRU27NullBoiler and Utilities Building

STRU28NullEvaporator and R1 Dryer building

STRU29NullWet Blending Building

STRU30 NullSTRU Dryer Building

List of SIs





STRU30NullSTRU Dryer Building

STRU31NullBoiler 5 Stack


STRU33NullBoiler Room Exhaust 1 Stack


STRU35NullR3 Dryer – product handling

TFAC110900032Kerry Ingredients & Flavours Inc

TREA2CE004Wet Scrubber - High Efficiency




TREA8CE010Fabric Filter - Low Temperature,i.e., T<180 Degrees F

TREA9 CE011Fabric Filter - Low Temperature,i.e., T<180 Degrees F

List of SIs




TREA8

CE010Fabric Filter - Low Temperature,i.e., T<180 Degrees F





TREA17NullVenturi Scrubber

List of SIs



Subject Item ID Within 50 miles of these borders Program Description Sub Program Description Sub Program Start Date Sub Program End Date SIC / NAICS

AISI732 Iowa Null New Source Review - Synthetic Minor 9/12/1995 Null 2023 - Dry, Condensed, and..

11/27/2012 11/27/2012 120000 AM 2023 - Dry, Condensed, and..

NSPS 8/14/2017 Null 2023 - Dry, Condensed, and..

Part 63 Area 8/14/2017 Null 2023 - Dry, Condensed, and..

Part 70 Synthetic Minor 9/12/1995 Null 2023 - Dry, Condensed, and..


Wisconsin Null New Source Review - Synthetic Minor 9/12/1995 Null 2023 - Dry, Condensed, and..


NSPS 8/14/2017 Null 2023 - Dry, Condensed, and..

Part 63 Area 8/14/2017 Null 2023 - Dry, Condensed, and..

Part 70 Synthetic Minor 9/12/1995 Null 2023 - Dry, Condensed, and..


AISI Conventional Site


Details for:SI Category: Agency InterestSI Type: Conventional Site

Agency Interest Na.. Activity ID Subject Ite..Subject Item Type Description Subject Item ID SI Designation and Description Status Desc..Sub Attribute Description


IND20190001 Activity Insignificant Air Emissions Activity ACTV3 NullAll IA's

Active /Existing

Minn. R. 7007.1300, subp. 3(E)

Minn. R. 7007.1300, subp. 3(F)

Insignificant air emissions activity


Details for:SI Category: ActivitySI Type: Insignificant Air Emissions Activity

Agency Interest Name Subject Item ID SI Designation and Description Group Member ID (padded)


COMG5 GP002New Indirect Heating Equipment

EQUI3

EQUI14

EQUI36

EQUI37

EQUI38

EQUI39

EQUI40

EQUI41

EQUI42

Component Group (Members)

Agency Interest: Kerry Ingredients and Flavours IncAgency Interest ID: 732Activity: None (Permit Reopening)

Details for:SI Category: Component GroupSI Type: Air Component Group

Subject ItemCategory Description

Subject Item TypeDescription Subject Item ID

Subject ItemDesignation Subject Item Description Pollutant

Potential (lbs/hr)

Unrestricted Potential

(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide

Carbon Dioxide Equivalent

Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Dioxide

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron

Polycyclic organic matter

Selenium compounds

Sulfur Dioxide

Toluene

Volatile Organic Compounds

EQUI14 EU004 Boiler 4 Cleaver Brooks 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Dioxide

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI17 EU003 Boiler 3 - Cleaver Brooks 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.148.3e-050.015

5.86e-072.15e-06

0.190.190.19

0.00552.460.01

5.13e-051.49e-050.055

6.35e-069.28e-060.0440.05

0.001832.05e-063.42e-05

2.07

2,9312.69e-052.93e-075.13e-054.88e-062.93e-05

0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.148.3e-050.015

5.86e-072.15e-06

0.190.190.19

0.00552.460.01

5.13e-051.49e-050.055

6.35e-069.28e-060.0440.05

0.001832.05e-063.42e-05

2.07

2,9312.69e-052.93e-075.13e-054.88e-062.93e-05

0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.148.3e-050.015

5.86e-072.15e-06

0.190.190.19

0.00552.460.01

5.13e-051.49e-050.055

6.35e-069.28e-060.0440.05

0.001832.05e-063.42e-05

2.07

2,9312.69e-052.93e-075.13e-054.88e-062.93e-05

PTE by subject item

Agency Interest: NoneAgency Interest ID: 732Activity: None (Permit Reopening)

Details for:SI Category: EquipmentSI Type: All




Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Equipment Boiler EQUI17 EU003 Boiler 3 - Cleaver BrooksHexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Dioxide

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI44 Null Boiler 5 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron

Selenium compounds

Sulfur Dioxide

Toluene

Total Polycyclic aromatic hydrocarbons


EQUI45 Null Boiler 6 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron

Selenium compounds

Sulfur Dioxide

Toluene



0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.590.0003640.065

2.57e-069.43e-06

0.820.820.820.02410.80.02

0.0002256.53e-05

0.242.78e-054.06e-050.1930.20.01

8.99e-060.000159.06

12,85012,836

0.0001181.28e-060.0002252.14e-050.000128

0.148.3e-050.015

5.86e-072.15e-06

0.190.190.19

0.00552.460.01

5.13e-051.49e-050.055

6.35e-069.28e-060.0440.05

0.001832.05e-063.42e-05

2.07

2,9312.69e-052.93e-075.13e-054.88e-062.93e-05

0.721.14e-050.000440.078

3.11e-060.990.990.990.0294.79

0.0002727.9e-050.29

3.37e-054.92e-05

0.230.240.01

1.09e-050.000181

4.9315,55915,543

0.0001421.55e-060.0002722.59e-050.000155

0.721.14e-050.000440.078

3.11e-060.990.990.990.0294.79

0.0002727.9e-050.29

3.37e-054.92e-05

0.230.240.01

1.09e-050.000181

4.9315,55915,543

0.0001421.55e-060.0002722.59e-050.000155

0.162.61e-060.0001010.0187.1e-070.230.230.23

0.00671.09

6.21e-051.8e-050.067

7.69e-061.12e-05

0.050.06

0.002222.48e-064.14e-05

1.12

3,5493.25e-053.55e-076.21e-055.91e-063.55e-05

0.721.14e-050.000440.078

3.11e-060.990.990.990.0294.79

0.0002727.9e-050.29

3.37e-054.92e-05

0.230.240.01

1.09e-050.000181

4.9315,55915,543

0.0001421.55e-060.0002722.59e-050.000155

0.721.14e-050.000440.078

3.11e-060.990.990.990.0294.79

0.0002727.9e-050.29

3.37e-054.92e-05

0.230.240.01

1.09e-050.000181

4.9315,55915,543

0.0001421.55e-060.0002722.59e-050.000155

0.162.61e-060.0001010.0187.1e-070.230.230.23

0.00671.09

6.21e-051.8e-050.067

7.69e-061.12e-05

0.050.06

0.002222.48e-064.14e-05

1.12

3,5493.25e-053.55e-076.21e-055.91e-063.55e-05

PTE by subject item






Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Equipment Boiler EQUI45 Null Boiler 6Total Polycyclic aromatic hydrocarbons


Dryer/Oven, indirectfired

EQUI43 Null R3 Spray Dryer 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Dioxide

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


Dryer/Oven, unknownfiring method

EQUI18 EU005 Large Delaval Spray Dryer1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


Material HandlingEquipment

EQUI31 EU014 R1 Package (from SprayDryer)

Particulate Matter

PM < 2.5 micron

PM < 10 micron

EQUI32 EU010 Wet Blend Bag Dump Particulate Matter

PM < 2.5 micron

PM < 10 micron

EQUI33 EU011 Wet Blend Bag Dump 1 Particulate Matter

PM < 2.5 micron

PM < 10 micron

EQUI34 EU012 Dry Blending Particulate Matter

PM < 2.5 micron

PM < 10 micron

EQUI35 EU013 Dry Packaging Particulate Matter

PM < 2.5 micron

0.720.720.16

0.470.000298

0.052.1e-067.73e-0629.5130.7829.710.0198.580.02

0.0001845.34e-05

0.192.28e-053.33e-050.1580.165

0.006577.36e-060.000123

7.2110,23610,2269.64e-051.05e-060.0001841.75e-050.000105

0.470.000298

0.052.1e-067.73e-06184.4530.78495.230.0198.580.02

0.0001845.34e-05

0.192.28e-053.33e-050.1580.165

0.006577.36e-060.000123

7.2110,23610,2269.64e-051.05e-060.0001841.75e-050.000105

0.116.8e-050.01

4.8e-071.76e-06

6.747.036.78

0.00441.96

0.00444.2e-051.22e-05

0.045.2e-067.6e-060.0360.03780.00151.68e-062.8e-051.652,3372,3352.2e-052.4e-074.2e-054e-062.4e-05

0.470.000298

0.052.1e-067.73e-0635.6935.69125.920.028.59

0.0001845.34e-05

0.192.28e-053.33e-050.1580.165

0.006577.36e-060.000123

7.2110,22610,2269.64e-051.05e-060.0001841.75e-050.000105

0.470.000298

0.052.1e-067.73e-0635.6935.69125.920.028.59

0.0001845.34e-05

0.192.28e-053.33e-050.1530.165

0.006577.36e-060.000123

7.2110,22610,2269.64e-051.05e-060.0001841.75e-050.000105

0.116.8e-050.01

4.8e-071.76e-06

8.158.1528.750.00441.96

4.2e-051.22e-050.0445.2e-067.6e-060.0360.03780.00151.68e-062.8e-051.652,3352,3352.2e-052.4e-074.2e-054e-062.4e-05

0.180.180.18

0.180.180.18

0.0410.0410.041

0.10.10.1

0.10.10.1

0.0240.0240.024

0.10.10.1

0.10.10.1

0.0240.0240.024

0.180.180.18

0.180.180.18

0.0410.0410.041

0.180.180.18

0.180.180.18

0.0410.0410.041

PTE by subject item






Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Equipment Material HandlingEquipment

EQUI35 EU013 Dry PackagingParticulate Matter

PM < 2.5 micron

PM < 10 micron

Other Combustion EQUI3 EU015 Main Office Space Heater 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI36 EU016 R200 room East WallSpace Heater

1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI37 EU017 Solaronics - R200 roomWest Wall Space Heater


Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

0.180.180.18

0.180.180.18

0.0410.0410.041

0.0159.271e-060.0016

6.544e-082.405e-07

0.0210.0210.021

0.000620.27

5.726e-061.663e-060.00627.09e-071.036e-060.0049080.005148

0.0002045142.291e-073.818e-06

0.233283273e-06

3.272e-085.726e-065.454e-073.272e-06

0.0159.271e-060.0016

6.544e-082.405e-07

0.0210.0210.021

0.000620.27

5.726e-061.663e-060.00627.09e-071.036e-060.0049080.005148

0.0002045142.291e-073.818e-06

0.233283273e-06

3.272e-085.726e-065.454e-073.272e-06

0.003452.117e-060.0003761.494e-085.491e-080.004770.004770.004770.0001410.0627

1.307e-063.798e-070.001411.619e-072.366e-070.0011210.0011754.669e-055.23e-088.716e-070.0527

74.76.848e-077.471e-091.307e-061.245e-077.471e-07

0.0003838.692e-074.18e-056.1e-092.25e-080.0005290.0005290.0005291.56e-050.006975.368e-071.559e-070.0001566.65e-089.71e-08

0.0004601560.0004826411.91732e-052.15e-083.579e-070.00585

8.38.3

2.812e-073.1e-09

5.368e-075.11e-083.068e-07

0.0003838.692e-074.18e-056.1e-092.25e-080.0005290.0005290.0005291.56e-050.006975.368e-071.559e-070.0001566.65e-089.71e-08

0.0004601560.0004826411.91732e-052.15e-083.579e-070.00585

8.38.3

2.812e-073.1e-09

5.368e-075.11e-083.068e-07

0.0003241.984e-073.53e-051.4e-095.1e-090.0004470.0004470.0004471.32e-050.005881.226e-073.56e-080.0001321.52e-082.22e-08

0.0001050580.0001101924.3774e-064.9e-098.17e-080.00494

76.42e-087e-10

1.226e-071.17e-087e-08

0.0003838.692e-074.18e-056.1e-092.25e-080.0005290.0005290.0005291.56e-050.006975.368e-070.00016030.0001566.65e-089.71e-08

0.0004601560.0004826411.91732e-052.15e-083.579e-070.00585

8.38.3

2.812e-073.1e-09

5.368e-075.11e-083.068e-07

0.0003838.692e-074.18e-056.1e-092.25e-080.0005290.0005290.0005291.56e-050.006975.368e-070.00016030.0001566.65e-089.71e-08

0.0004601560.0004826411.91732e-052.15e-083.579e-070.00585

8.38.3

2.812e-073.1e-09

5.368e-075.11e-083.068e-07

0.0003241.984e-073.53e-051.4e-095.1e-090.0004470.0004470.0004471.32e-050.005881.226e-073.66e-050.0001321.52e-082.22e-08

0.0001050580.0001101924.3774e-064.9e-098.17e-080.00494

76.42e-087e-10

1.226e-071.17e-087e-08

PTE by subject item






Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Equipment Other Combustion EQUI37 EU017 Solaronics - R200 roomWest Wall Space Heater

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI38 EU018 Ammonia CompressorRoom East Wall SpaceHeater


Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI39 EU019 Hallway outside R300room Space Heater


Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI40 EU020 Hallway outside liquidpacking room SpaceHeater


0.0003838.692e-074.18e-056.1e-092.25e-080.0005290.0005290.0005291.56e-050.006975.368e-070.00016030.0001566.65e-089.71e-08

0.0004601560.0004826411.91732e-052.15e-083.579e-070.00585

8.38.3

2.812e-073.1e-09

5.368e-075.11e-083.068e-07

0.0003838.692e-074.18e-056.1e-092.25e-080.0005290.0005290.0005291.56e-050.006975.368e-070.00016030.0001566.65e-089.71e-08

0.0004601560.0004826411.91732e-052.15e-083.579e-070.00585

8.38.3

2.812e-073.1e-09

5.368e-075.11e-083.068e-07

0.0003241.984e-073.53e-051.4e-095.1e-090.0004470.0004470.0004471.32e-050.005881.226e-073.66e-050.0001321.52e-082.22e-08

0.0001050580.0001101924.3774e-064.9e-098.17e-080.00494

76.42e-087e-10

1.226e-071.17e-087e-08

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0004312.646e-074.71e-051.868e-096.864e-090.0005960.0005960.0005961.76e-050.007841.634e-074.747e-080.0001762.023e-082.957e-080.00014010.00014695.837e-066.537e-091.089e-070.00659

9.348.56e-089.339e-101.634e-071.556e-089.339e-08

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0004312.646e-074.71e-051.868e-096.864e-090.0005960.0005960.0005961.76e-050.007841.634e-074.747e-080.0001762.023e-082.957e-080.00014010.00014695.837e-066.537e-091.089e-070.00659

9.348.56e-089.339e-101.634e-071.556e-089.339e-08

PTE by subject item






Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Equipment Other CombustionEQUI39 EU019

Hallway outside R300room Space Heater Volatile Organic Compounds

EQUI40 EU020 Hallway outside liquidpacking room SpaceHeater


Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI41 EU021 Hallway next toshipping/receiving SpaceHeater


Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


EQUI42 EU022 Shipping receiving - SouthWall Space Heater


Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury Compounds

Methane

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0004312.646e-074.71e-051.868e-096.864e-090.0005960.0005960.0005961.76e-050.007841.634e-074.747e-080.0001762.023e-082.957e-080.00014010.00014695.837e-066.537e-091.089e-070.00659

9.348.56e-089.339e-101.634e-071.556e-089.339e-08

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0004312.646e-074.71e-051.868e-096.864e-090.0005960.0005960.0005961.76e-050.007841.634e-074.747e-080.0001762.023e-082.957e-080.00014010.00014695.837e-066.537e-091.089e-070.00659

9.348.56e-089.339e-101.634e-071.556e-089.339e-08

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0004312.646e-074.71e-051.868e-096.864e-090.0005960.0005960.0005961.76e-050.007841.634e-074.747e-080.0001762.023e-082.957e-080.00014010.00014695.837e-066.537e-091.089e-070.00659

9.348.56e-089.339e-101.634e-071.556e-089.339e-08

PTE by subject item






Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Equipment Other Combustion EQUI42 EU022 Shipping receiving - SouthWall Space Heater

Mercury Compounds

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron


Selenium compounds

Sulfur Dioxide

Toluene


Other Emission Unit EQUI46 Null Boiler Room AHU 1,4-Dichlorobenzene (para-)

Arsenic compounds

Benzene

Beryllium Compounds

Cadmium compounds

Carbon Dioxide


Carbon Monoxide

Chromium compounds

Cobalt compounds

Formaldehyde

HAPs - Total

Hexane

Manganese compounds

Mercury

Methane

Naphthalene

Nickel compounds

Nitrogen Oxides

Nitrous Oxide

Particulate Matter

PM < 2.5 micron

PM < 10 micron

Selenium compounds

Sulfur Dioxide

Toluene



0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0005111.159e-065.57e-058.181e-093.006e-080.0007060.0007060.0007062.08e-050.009297.158e-072.079e-070.0002088.862e-081.295e-070.00061350.00064352.556e-052.863e-084.772e-070.007811.111.1

3.749e-074.09e-097.158e-076.817e-084.09e-07

0.0004312.646e-074.71e-051.868e-096.864e-090.0005960.0005960.0005961.76e-050.007841.634e-074.747e-080.0001762.023e-082.957e-080.00014010.00014695.837e-066.537e-091.089e-070.00659

9.348.56e-089.339e-101.634e-071.556e-089.339e-08

0.0538.46e-073.26e-050.00582.3e-070.0730.0730.0730.00220.97

2.01e-055.85e-060.022

2.49e-063.64e-06

0.020.02

0.0007198.05e-071.34e-05

0.811,1521,150

1.05e-051.15e-072.01e-051.92e-061.15e-05

0.0538.46e-073.26e-050.00582.3e-070.0730.0730.0730.00220.97

2.01e-055.85e-060.022

2.49e-063.64e-06

0.020.02

0.0007198.05e-071.34e-05

0.811,1521,150

1.05e-051.15e-072.01e-051.92e-061.15e-05

0.0121.93e-077.44e-060.00135.25e-080.0170.0170.0170.00050.22

4.6e-061.34e-060.005

5.69e-078.32e-070.003940.004130.0001641.84e-073.06e-06

0.190

2632.41e-062.63e-084.6e-064.38e-072.63e-06

PTE by subject item



Pollutant

Subject ItemCategoryDescription Subject Item Type Description Subject Item ID

Subject ItemDesignation Subject Item Description

Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

1,4-Dichlorobenzene(para-)

Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks

EQUI14 EU004 Boiler 4 Cleaver Brooks

EQUI17 EU003 Boiler 3 - Cleaver Brooks

EQUI44 Null Boiler 5


Dryer/Oven, indirect fired EQUI43 Null R3 Spray Dryer

Dryer/Oven, unknown firing meth..EQUI18 EU005 Large Delaval Spray Dryer

Other Combustion EQUI3 EU015 Main Office Space Heater

EQUI36 EU016 R200 room East Wall Space Heater

EQUI37 EU017 Solaronics - R200 room West Wall Space Heater

EQUI38 EU018 Ammonia Compressor Room East Wall Space Heater

EQUI39 EU019 Hallway outside R300 room Space Heater

EQUI40 EU020 Hallway outside liquid packing room Space Heater

EQUI41 EU021 Hallway next to shipping/receiving Space Heater

EQUI42 EU022 Shipping receiving - South Wall Space Heater

Other Emission Unit EQUI46 Null Boiler Room AHU

Arseniccompounds

















Benzene Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Beryllium Equipment Boiler EQUI14 EU004 Boiler 4 Cleaver Brooks

BerylliumCompounds
















Cadmiumcompounds














0.0001280.0001282.93e-050.0001280.0001282.93e-050.0001280.0001282.93e-050.0001550.0001553.55e-050.0001550.0001553.55e-050.0001050.0001052.4e-050.0001050.0001052.4e-053.272e-063.272e-067.471e-073.068e-073.068e-077e-083.068e-073.068e-077e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-081.15e-051.15e-052.63e-062.14e-052.14e-054.88e-062.14e-052.14e-054.88e-062.14e-052.14e-054.88e-062.59e-052.59e-055.91e-062.59e-052.59e-055.91e-061.75e-051.75e-054e-061.75e-051.75e-054e-065.454e-075.454e-071.245e-075.11e-085.11e-081.17e-085.11e-085.11e-081.17e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-081.92e-061.92e-064.38e-070.0002250.0002255.13e-050.0002250.0002255.13e-050.0002250.0002255.13e-050.0002720.0002726.21e-050.0002720.0002726.21e-050.0001840.0001844.2e-050.0001840.0001844.2e-055.726e-065.726e-061.307e-065.368e-075.368e-071.226e-075.368e-075.368e-071.226e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-072.01e-052.01e-054.6e-061.28e-061.28e-062.93e-071.28e-061.28e-062.93e-071.28e-061.28e-062.93e-071.55e-061.55e-063.55e-071.55e-061.55e-063.55e-071.05e-061.05e-062.4e-071.05e-061.05e-062.4e-073.272e-083.272e-087.471e-093.1e-093.1e-097e-103.1e-093.1e-097e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-101.15e-071.15e-072.63e-080.0001180.0001182.69e-050.0001180.0001182.69e-050.0001180.0001182.69e-050.0001420.0001423.25e-050.0001420.0001423.25e-059.64e-059.64e-052.2e-059.64e-059.64e-052.2e-053e-063e-066.848e-07

2.812e-072.812e-076.42e-082.812e-072.812e-076.42e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-08

PTE by pollutant



Pollutant



Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)


















Arseniccompounds

















Benzene Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Beryllium Equipment Boiler EQUI14 EU004 Boiler 4 Cleaver Brooks

BerylliumCompounds
















Cadmiumcompounds














0.0001280.0001282.93e-050.0001280.0001282.93e-050.0001280.0001282.93e-050.0001550.0001553.55e-050.0001550.0001553.55e-050.0001050.0001052.4e-050.0001050.0001052.4e-053.272e-063.272e-067.471e-073.068e-073.068e-077e-083.068e-073.068e-077e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-081.15e-051.15e-052.63e-062.14e-052.14e-054.88e-062.14e-052.14e-054.88e-062.14e-052.14e-054.88e-062.59e-052.59e-055.91e-062.59e-052.59e-055.91e-061.75e-051.75e-054e-061.75e-051.75e-054e-065.454e-075.454e-071.245e-075.11e-085.11e-081.17e-085.11e-085.11e-081.17e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-081.92e-061.92e-064.38e-070.0002250.0002255.13e-050.0002250.0002255.13e-050.0002250.0002255.13e-050.0002720.0002726.21e-050.0002720.0002726.21e-050.0001840.0001844.2e-050.0001840.0001844.2e-055.726e-065.726e-061.307e-065.368e-075.368e-071.226e-075.368e-075.368e-071.226e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-072.01e-052.01e-054.6e-061.28e-061.28e-062.93e-071.28e-061.28e-062.93e-071.28e-061.28e-062.93e-071.55e-061.55e-063.55e-071.55e-061.55e-063.55e-071.05e-061.05e-062.4e-071.05e-061.05e-062.4e-073.272e-083.272e-087.471e-093.1e-093.1e-097e-103.1e-093.1e-097e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-101.15e-071.15e-072.63e-080.0001180.0001182.69e-050.0001180.0001182.69e-050.0001180.0001182.69e-050.0001420.0001423.25e-050.0001420.0001423.25e-059.64e-059.64e-052.2e-059.64e-059.64e-052.2e-053e-063e-066.848e-07

2.812e-072.812e-076.42e-082.812e-072.812e-076.42e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-08

PTE by pollutant



Pollutant



Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Cadmiumcompounds

Equipment Other CombustionEQUI39 EU019 Hallway outside R300 room Space Heater





Carbon Dioxide Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Carbon DioxideEquivalent

















CarbonMonoxide

















Chromiumcompounds

















Cobaltcompounds










3.749e-073.749e-078.56e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-081.05e-051.05e-052.41e-0612,83612,8362,93112,83612,8362,93112,83612,8362,93115,54315,5433,54915,54315,5433,54910,22610,2262,33510,22610,2262,33532732774.78.38.378.38.3711.111.19.3411.111.19.3411.111.19.3411.111.19.3411.111.19.341,1501,15026312,85012,85012,85012,85012,85012,85015,55915,55915,55915,55910,23610,2362,33710,22610,2262,3353283288.38.38.38.311.111.111.111.111.111.111.111.111.111.11,1521,15209.069.062.079.069.062.079.069.062.074.934.931.124.934.931.127.217.211.657.217.211.650.230.230.0527

0.005850.005850.004940.005850.005850.004940.00780.00780.006590.00780.00780.006590.00780.00780.006590.00780.00780.006590.00780.00780.006590.810.810.19

0.000150.000153.42e-050.000150.000153.42e-050.000150.000153.42e-050.0001810.0001814.14e-050.0001810.0001814.14e-050.0001230.0001232.8e-050.0001230.0001232.8e-053.818e-063.818e-068.716e-073.579e-073.579e-078.17e-083.579e-073.579e-078.17e-084.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-071.34e-051.34e-053.06e-068.99e-068.99e-062.05e-068.99e-068.99e-062.05e-068.99e-068.99e-062.05e-061.09e-051.09e-052.48e-061.09e-051.09e-052.48e-067.36e-067.36e-061.68e-067.36e-067.36e-061.68e-062.291e-072.291e-075.23e-08

PTE by pollutant



Pollutant



Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Cadmiumcompounds

Equipment Other CombustionEQUI39 EU019 Hallway outside R300 room Space Heater





Carbon Dioxide Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks

































CarbonMonoxide

















Chromiumcompounds

















Cobaltcompounds










3.749e-073.749e-078.56e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-081.05e-051.05e-052.41e-0612,83612,8362,93112,83612,8362,93112,83612,8362,93115,54315,5433,54915,54315,5433,54910,22610,2262,33510,22610,2262,33532732774.78.38.378.38.3711.111.19.3411.111.19.3411.111.19.3411.111.19.3411.111.19.341,1501,15026312,85012,85012,85012,85012,85012,85015,55915,55915,55915,55910,23610,2362,33710,22610,2262,3353283288.38.38.38.311.111.111.111.111.111.111.111.111.111.11,1521,15209.069.062.079.069.062.079.069.062.074.934.931.124.934.931.127.217.211.657.217.211.650.230.230.0527

0.005850.005850.004940.005850.005850.004940.00780.00780.006590.00780.00780.006590.00780.00780.006590.00780.00780.006590.00780.00780.006590.810.810.19

0.000150.000153.42e-050.000150.000153.42e-050.000150.000153.42e-050.0001810.0001814.14e-050.0001810.0001814.14e-050.0001230.0001232.8e-050.0001230.0001232.8e-053.818e-063.818e-068.716e-073.579e-073.579e-078.17e-083.579e-073.579e-078.17e-084.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-071.34e-051.34e-053.06e-068.99e-068.99e-062.05e-068.99e-068.99e-062.05e-068.99e-068.99e-062.05e-061.09e-051.09e-052.48e-061.09e-051.09e-052.48e-067.36e-067.36e-061.68e-067.36e-067.36e-061.68e-062.291e-072.291e-075.23e-08

PTE by pollutant



Pollutant



Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Cobaltcompounds

Equipment Other CombustionEQUI3 EU015 Main Office Space Heater









Formaldehyde Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















HAPs - Total Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Hexane Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Manganesecompounds

















Mercury Equipment Other Emission Unit EQUI46 Null Boiler Room AHU

MercuryCompounds





2.15e-082.15e-084.9e-092.15e-082.15e-084.9e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-098.05e-078.05e-071.84e-07

0.010.010.001830.010.010.001830.010.010.001830.010.010.002220.010.010.00222

0.006570.006570.00150.006570.006570.0015

0.0002045140.0002045144.669e-051.91732e-051.91732e-054.3774e-061.91732e-051.91732e-054.3774e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-060.0007190.0007190.000164

0.20.20.050.20.20.050.20.20.050.240.240.060.240.240.060.1650.1650.03780.1650.1650.0378

0.0051480.0051480.0011750.0004826410.0004826410.0001101920.0004826410.0004826410.0001101920.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.0001469

0.020.020.004130.1930.1930.0440.1930.1930.0440.1930.1930.0440.230.230.050.230.230.050.1580.1580.0360.1580.1530.036

0.0049080.0049080.0011210.0004601560.0004601560.0001050580.0004601560.0004601560.0001050580.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.0001401

0.020.020.003944.06e-054.06e-059.28e-064.06e-054.06e-059.28e-064.06e-054.06e-059.28e-064.92e-054.92e-051.12e-054.92e-054.92e-051.12e-053.33e-053.33e-057.6e-063.33e-053.33e-057.6e-061.036e-061.036e-062.366e-079.71e-089.71e-082.22e-089.71e-089.71e-082.22e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-083.64e-063.64e-068.32e-072.49e-062.49e-065.69e-072.78e-052.78e-056.35e-062.78e-052.78e-056.35e-062.78e-052.78e-056.35e-06

PTE by pollutant



Pollutant



Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Cobaltcompounds

Equipment Other CombustionEQUI3 EU015 Main Office Space Heater









Formaldehyde Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















HAPs - Total Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Hexane Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Manganesecompounds

















Mercury Equipment Other Emission Unit EQUI46 Null Boiler Room AHU

MercuryCompounds






0.010.010.001830.010.010.001830.010.010.001830.010.010.002220.010.010.00222

0.006570.006570.00150.006570.006570.0015

0.0002045140.0002045144.669e-051.91732e-051.91732e-054.3774e-061.91732e-051.91732e-054.3774e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-060.0007190.0007190.000164

0.20.20.050.20.20.050.20.20.050.240.240.060.240.240.060.1650.1650.03780.1650.1650.0378

0.0051480.0051480.0011750.0004826410.0004826410.0001101920.0004826410.0004826410.0001101920.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.0001469

0.020.020.004130.1930.1930.0440.1930.1930.0440.1930.1930.0440.230.230.050.230.230.050.1580.1580.0360.1580.1530.036

0.0049080.0049080.0011210.0004601560.0004601560.0001050580.0004601560.0004601560.0001050580.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.0001401

0.020.020.003944.06e-054.06e-059.28e-064.06e-054.06e-059.28e-064.06e-054.06e-059.28e-064.92e-054.92e-051.12e-054.92e-054.92e-051.12e-053.33e-053.33e-057.6e-063.33e-053.33e-057.6e-061.036e-061.036e-062.366e-079.71e-089.71e-082.22e-089.71e-089.71e-082.22e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-083.64e-063.64e-068.32e-072.49e-062.49e-065.69e-072.78e-052.78e-056.35e-062.78e-052.78e-056.35e-062.78e-052.78e-056.35e-06

PTE by pollutant



Pollutant



Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

MercuryCompounds

Equipment BoilerEQUI17 EU003 Boiler 3 - Cleaver Brooks













Methane Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Naphthalene Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Nickelcompounds

















NitrogenDioxide





Nitrogen OxidesEquipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks













3.37e-053.37e-057.69e-063.37e-053.37e-057.69e-062.28e-052.28e-055.2e-062.28e-052.28e-055.2e-067.09e-077.09e-071.619e-076.65e-086.65e-081.52e-086.65e-086.65e-081.52e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-08

0.240.240.0550.240.240.0550.240.240.0550.290.290.0670.290.290.0670.190.190.040.190.190.044

0.00620.00620.001410.0001560.0001560.0001320.0001560.0001560.0001320.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0220.0220.005

6.53e-056.53e-051.49e-056.53e-056.53e-051.49e-056.53e-056.53e-051.49e-057.9e-057.9e-051.8e-057.9e-057.9e-051.8e-055.34e-055.34e-051.22e-055.34e-055.34e-051.22e-051.663e-061.663e-063.798e-071.559e-071.559e-073.56e-080.00016030.00016033.66e-052.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-085.85e-065.85e-061.34e-060.0002250.0002255.13e-050.0002250.0002255.13e-050.0002250.0002255.13e-050.0002720.0002726.21e-050.0002720.0002726.21e-050.0001840.0001844.2e-050.0001840.0001844.2e-055.726e-065.726e-061.307e-065.368e-075.368e-071.226e-075.368e-075.368e-071.226e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-072.01e-052.01e-054.6e-06

0.020.020.010.020.020.010.020.020.010.020.020.004410.810.82.4610.810.82.4610.810.82.464.794.791.094.794.791.098.588.581.968.598.591.960.270.270.0627

0.006970.006970.005880.006970.006970.005880.009290.009290.007840.009290.009290.00784

PTE by pollutant



Pollutant



Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

MercuryCompounds

Equipment BoilerEQUI17 EU003 Boiler 3 - Cleaver Brooks













Methane Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Naphthalene Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Nickelcompounds

















NitrogenDioxide





Nitrogen OxidesEquipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks













3.37e-053.37e-057.69e-063.37e-053.37e-057.69e-062.28e-052.28e-055.2e-062.28e-052.28e-055.2e-067.09e-077.09e-071.619e-076.65e-086.65e-081.52e-086.65e-086.65e-081.52e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-08

0.240.240.0550.240.240.0550.240.240.0550.290.290.0670.290.290.0670.190.190.040.190.190.044

0.00620.00620.001410.0001560.0001560.0001320.0001560.0001560.0001320.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0220.0220.005

6.53e-056.53e-051.49e-056.53e-056.53e-051.49e-056.53e-056.53e-051.49e-057.9e-057.9e-051.8e-057.9e-057.9e-051.8e-055.34e-055.34e-051.22e-055.34e-055.34e-051.22e-051.663e-061.663e-063.798e-071.559e-071.559e-073.56e-080.00016030.00016033.66e-052.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-085.85e-065.85e-061.34e-060.0002250.0002255.13e-050.0002250.0002255.13e-050.0002250.0002255.13e-050.0002720.0002726.21e-050.0002720.0002726.21e-050.0001840.0001844.2e-050.0001840.0001844.2e-055.726e-065.726e-061.307e-065.368e-075.368e-071.226e-075.368e-075.368e-071.226e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-072.01e-052.01e-054.6e-06

0.020.020.010.020.020.010.020.020.010.020.020.004410.810.82.4610.810.82.4610.810.82.464.794.791.094.794.791.098.588.581.968.598.591.960.270.270.0627

0.006970.006970.005880.006970.006970.005880.009290.009290.007840.009290.009290.00784

PTE by pollutant



Pollutant



Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Nitrogen OxidesEquipment Other CombustionEQUI39 EU019 Hallway outside R300 room Space Heater





Nitrous Oxide Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















ParticulateMatter








Material Handling Equipment EQUI31 EU014 R1 Package (from Spray Dryer)

EQUI32 EU010 Wet Blend Bag Dump

EQUI33 EU011 Wet Blend Bag Dump 1

EQUI34 EU012 Dry Blending

EQUI35 EU013 Dry Packaging










PM < 2.5 micron Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks





















PM < 10 micron Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks















0.009290.009290.007840.009290.009290.007840.009290.009290.007840.970.970.220.0240.0240.00550.0240.0240.00550.0240.0240.00550.0290.0290.00670.0290.0290.00670.0190.0190.00440.020.020.0044

0.000620.000620.0001411.56e-051.56e-051.32e-051.56e-051.56e-051.32e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-050.00220.00220.00050.820.820.190.820.820.190.820.820.190.990.990.230.990.990.2329.71495.236.78125.92125.9228.750.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.0410.0210.0210.00477

0.0005290.0005290.0004470.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0730.0730.0170.820.820.190.820.820.190.820.820.190.990.990.230.990.990.2330.7830.787.0335.6935.698.150.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.0410.0210.0210.00477

0.0005290.0005290.0004470.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0730.0730.0170.820.820.190.820.820.190.820.820.190.990.990.230.990.990.2329.51184.456.7435.6935.698.150.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.0410.0210.0210.00477

0.0005290.0005290.000447

PTE by pollutant



Pollutant



Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Nitrogen OxidesEquipment Other CombustionEQUI39 EU019 Hallway outside R300 room Space Heater





Nitrous Oxide Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















ParticulateMatter






















PM < 2.5 micron Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks





















PM < 10 micron Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks















0.009290.009290.007840.009290.009290.007840.009290.009290.007840.970.970.220.0240.0240.00550.0240.0240.00550.0240.0240.00550.0290.0290.00670.0290.0290.00670.0190.0190.00440.020.020.0044

0.000620.000620.0001411.56e-051.56e-051.32e-051.56e-051.56e-051.32e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-050.00220.00220.00050.820.820.190.820.820.190.820.820.190.990.990.230.990.990.2329.71495.236.78125.92125.9228.750.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.0410.0210.0210.00477

0.0005290.0005290.0004470.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0730.0730.0170.820.820.190.820.820.190.820.820.190.990.990.230.990.990.2330.7830.787.0335.6935.698.150.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.0410.0210.0210.00477

0.0005290.0005290.0004470.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0730.0730.0170.820.820.190.820.820.190.820.820.190.990.990.230.990.990.2329.51184.456.7435.6935.698.150.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.0410.0210.0210.00477

0.0005290.0005290.000447

PTE by pollutant



Pollutant



Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

PM < 10 micron Equipment Other CombustionEQUI36 EU016 R200 room East Wall Space Heater








Polycyclicorganic matter














Seleniumcompounds

















Sulfur Dioxide Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Toluene Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Total Polycyclicaromatichydrocarbons

Equipment Boiler EQUI44 Null Boiler 5



Volatile OrganicCompounds







0.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0730.0730.017

9.43e-069.43e-062.15e-069.43e-069.43e-062.15e-069.43e-069.43e-062.15e-067.73e-067.73e-061.76e-067.73e-067.73e-061.76e-062.405e-072.405e-075.491e-082.25e-082.25e-085.1e-092.25e-082.25e-085.1e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-092.57e-062.57e-065.86e-072.57e-062.57e-065.86e-072.57e-062.57e-065.86e-073.11e-063.11e-067.1e-073.11e-063.11e-067.1e-072.1e-062.1e-064.8e-072.1e-062.1e-064.8e-07

6.544e-086.544e-081.494e-086.1e-096.1e-091.4e-096.1e-096.1e-091.4e-09

8.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-092.3e-072.3e-075.25e-080.0650.0650.0150.0650.0650.0150.0650.0650.0150.0780.0780.0180.0780.0780.0180.050.050.010.050.050.01

0.00160.00160.0003764.18e-054.18e-053.53e-054.18e-054.18e-053.53e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-050.00580.00580.0013

0.0003640.0003648.3e-050.0003640.0003648.3e-050.0003640.0003648.3e-050.000440.000440.0001010.000440.000440.0001010.0002980.0002986.8e-050.0002980.0002986.8e-059.271e-069.271e-062.117e-068.692e-078.692e-071.984e-078.692e-078.692e-071.984e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-073.26e-053.26e-057.44e-061.14e-051.14e-052.61e-061.14e-051.14e-052.61e-068.46e-078.46e-071.93e-07

0.590.590.140.590.590.140.590.590.140.720.720.160.720.720.16

PTE by pollutant



Pollutant



Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

PM < 10 micron Equipment Other CombustionEQUI36 EU016 R200 room East Wall Space Heater






















Seleniumcompounds

















Sulfur Dioxide Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks
















Toluene Equipment Boiler EQUI13 EU001 Boiler 1 Cleaver Brooks

















Equipment Boiler EQUI44 Null Boiler 5










0.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0730.0730.017

9.43e-069.43e-062.15e-069.43e-069.43e-062.15e-069.43e-069.43e-062.15e-067.73e-067.73e-061.76e-067.73e-067.73e-061.76e-062.405e-072.405e-075.491e-082.25e-082.25e-085.1e-092.25e-082.25e-085.1e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-092.57e-062.57e-065.86e-072.57e-062.57e-065.86e-072.57e-062.57e-065.86e-073.11e-063.11e-067.1e-073.11e-063.11e-067.1e-072.1e-062.1e-064.8e-072.1e-062.1e-064.8e-07

6.544e-086.544e-081.494e-086.1e-096.1e-091.4e-096.1e-096.1e-091.4e-09

8.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-092.3e-072.3e-075.25e-080.0650.0650.0150.0650.0650.0150.0650.0650.0150.0780.0780.0180.0780.0780.0180.050.050.010.050.050.01

0.00160.00160.0003764.18e-054.18e-053.53e-054.18e-054.18e-053.53e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-050.00580.00580.0013

0.0003640.0003648.3e-050.0003640.0003648.3e-050.0003640.0003648.3e-050.000440.000440.0001010.000440.000440.0001010.0002980.0002986.8e-050.0002980.0002986.8e-059.271e-069.271e-062.117e-068.692e-078.692e-071.984e-078.692e-078.692e-071.984e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-073.26e-053.26e-057.44e-061.14e-051.14e-052.61e-061.14e-051.14e-052.61e-068.46e-078.46e-071.93e-07

0.590.590.140.590.590.140.590.590.140.720.720.160.720.720.16

PTE by pollutant



Pollutant



Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)


EquipmentBoiler EQUI45 Null Boiler 6












0.470.470.110.470.470.110.0150.0150.00345

0.0003830.0003830.0003240.0003830.0003830.0003240.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.0004310.0530.0530.012

PTE by pollutant



Pollutant



Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)


EquipmentBoiler EQUI45 Null Boiler 6












0.470.470.110.470.470.110.0150.0150.00345

0.0003830.0003830.0003240.0003830.0003830.0003240.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.0004310.0530.0530.012

PTE by pollutant



Pollutant Subject Item IDSubject ItemDesignation Subject Item Description

Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)


EQUI3 EU015 Main Office Space Heater




EQUI18 EU005 Large Delaval Spray Dryer








EQUI43 Null R3 Spray Dryer



EQUI46 Null Boiler Room AHU

Total

Arseniccompounds

















Total

Benzene EQUI3 EU015 Main Office Space Heater
















Total

Beryllium EQUI14 EU004 Boiler 4 Cleaver Brooks

Total

BerylliumCompounds
















Total

Cadmiumcompounds



3.272e-063.272e-067.471e-070.0001280.0001282.93e-050.0001280.0001282.93e-050.0001280.0001282.93e-050.0001050.0001052.4e-053.068e-073.068e-077e-083.068e-073.068e-077e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-084.09e-074.09e-079.339e-080.0001050.0001052.4e-050.0001550.0001553.55e-050.0001550.0001553.55e-051.15e-051.15e-052.63e-06

0.0009214310.0009214310.0002108845.454e-075.454e-071.245e-072.14e-052.14e-054.88e-062.14e-052.14e-054.88e-062.14e-052.14e-054.88e-061.75e-051.75e-054e-065.11e-085.11e-081.17e-085.11e-085.11e-081.17e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-086.817e-086.817e-081.556e-081.75e-051.75e-054e-062.59e-052.59e-055.91e-062.59e-052.59e-055.91e-061.92e-061.92e-064.38e-07

0.0001539080.0001539083.51237e-055.726e-065.726e-061.307e-060.0002250.0002255.13e-050.0002250.0002255.13e-050.0002250.0002255.13e-050.0001840.0001844.2e-055.368e-075.368e-071.226e-075.368e-075.368e-071.226e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-070.0001840.0001844.2e-050.0002720.0002726.21e-050.0002720.0002726.21e-052.01e-052.01e-054.6e-06

0.0016174790.0016174790.0003690691.28e-061.28e-062.93e-071.28e-061.28e-062.93e-073.272e-083.272e-087.471e-091.28e-061.28e-062.93e-071.28e-061.28e-062.93e-071.05e-061.05e-062.4e-073.1e-093.1e-097e-103.1e-093.1e-097e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-104.09e-094.09e-099.339e-101.05e-061.05e-062.4e-071.55e-061.55e-063.55e-071.55e-061.55e-063.55e-071.15e-071.15e-072.63e-08

7.93437e-067.93437e-061.8158405e-063e-063e-066.848e-07

Total PTE by pollutant


Details for:SI Category: NoneSI Type: None


Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Cadmiumcompounds

















Total

Carbon Dioxide EQUI3 EU015 Main Office Space Heater
















Total


















Total

CarbonMonoxide

















Total

Chromiumcompounds





0.0001180.0001182.69e-050.0001180.0001182.69e-050.0001180.0001182.69e-059.64e-059.64e-052.2e-052.812e-072.812e-076.42e-082.812e-072.812e-076.42e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-083.749e-073.749e-078.56e-089.64e-059.64e-052.2e-050.0001420.0001423.25e-050.0001420.0001423.25e-051.05e-051.05e-052.41e-06

0.0008467370.0008467370.00019335132732774.7

12,83612,8362,93112,83612,8362,93112,83612,8362,93110,22610,2262,3358.38.378.38.3711.111.19.3411.111.19.3411.111.19.3411.111.19.3411.111.19.34

10,22610,2262,33515,54315,5433,54915,54315,5433,5491,1501,150263

91,595.191,595.120,959.4328328

12,85012,85012,85012,85012,85012,85010,22610,2262,3358.38.38.38.311.111.111.111.111.111.111.111.111.111.1

10,23610,2362,33715,55915,55915,55915,5591,1521,1520

91,682.191,682.14,6720.230.230.05279.069.062.079.069.062.079.069.062.077.217.211.65

0.005850.005850.004940.005850.005850.004940.00780.00780.006590.00780.00780.006590.00780.00780.006590.00780.00780.006590.00780.00780.006597.217.211.654.934.931.124.934.931.120.810.810.19

52.550752.550712.035533.818e-063.818e-068.716e-070.000150.000153.42e-050.000150.000153.42e-05





Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

Chromiumcompounds















Total

Cobaltcompounds

















Total

Formaldehyde EQUI3 EU015 Main Office Space Heater
















Total

HAPs - Total EQUI3 EU015 Main Office Space Heater
















Total

Hexane EQUI3 EU015 Main Office Space Heater






0.000150.000153.42e-050.0001230.0001232.8e-053.579e-073.579e-078.17e-083.579e-073.579e-078.17e-084.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-074.772e-074.772e-071.089e-070.0001230.0001232.8e-050.0001810.0001814.14e-050.0001810.0001814.14e-051.34e-051.34e-053.06e-06

0.0010783200.0010783200.0002460392.291e-072.291e-075.23e-088.99e-068.99e-062.05e-068.99e-068.99e-062.05e-068.99e-068.99e-062.05e-067.36e-067.36e-061.68e-062.15e-082.15e-084.9e-092.15e-082.15e-084.9e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-092.863e-082.863e-086.537e-097.36e-067.36e-061.68e-061.09e-051.09e-052.48e-061.09e-051.09e-052.48e-068.05e-078.05e-071.84e-07

6.471025e-056.471025e-051.4748785e-050.0002045140.0002045144.669e-05

0.010.010.001830.010.010.001830.010.010.00183

0.006570.006570.00151.91732e-051.91732e-054.3774e-061.91732e-051.91732e-054.3774e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-062.556e-052.556e-055.837e-060.006570.006570.00150.010.010.002220.010.010.00222

0.0007190.0007190.0001640.0642296600.0642296600.0131786300.0051480.0051480.001175

0.20.20.050.20.20.050.20.20.05

0.1650.1650.03780.0004826410.0004826410.0001101920.0004826410.0004826410.0001101920.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.00014690.00064350.00064350.0001469

0.1650.1650.03780.240.240.060.240.240.060.020.020.00413

1.4393307821.4393307820.3518598840.0049080.0049080.0011210.1930.1930.0440.1930.1930.0440.1930.1930.0440.1580.1530.036





Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

HexaneEQUI18 EU005 Large Delaval Spray Dryer












Total

Manganesecompounds

















Total

Mercury EQUI46 Null Boiler Room AHU

Total

MercuryCompounds
















Total

Methane EQUI3 EU015 Main Office Space Heater
















Total

Naphthalene EQUI3 EU015 Main Office Space Heater







0.0004601560.0004601560.0001050580.0004601560.0004601560.0001050580.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.00014010.00061350.00061350.0001401

0.1580.1580.0360.230.230.050.230.230.050.020.020.00394

1.3838958111.3788958110.3099716171.036e-061.036e-062.366e-074.06e-054.06e-059.28e-064.06e-054.06e-059.28e-064.06e-054.06e-059.28e-063.33e-053.33e-057.6e-069.71e-089.71e-082.22e-089.71e-089.71e-082.22e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-081.295e-071.295e-072.957e-083.33e-053.33e-057.6e-064.92e-054.92e-051.12e-054.92e-054.92e-051.12e-053.64e-063.64e-068.32e-07

0.0002923180.0002923186.670085e-052.49e-062.49e-065.69e-072.49e-062.49e-065.69e-077.09e-077.09e-071.619e-072.78e-052.78e-056.35e-062.78e-052.78e-056.35e-062.78e-052.78e-056.35e-062.28e-052.28e-055.2e-066.65e-086.65e-081.52e-086.65e-086.65e-081.52e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-088.862e-088.862e-082.023e-082.28e-052.28e-055.2e-063.37e-053.37e-057.69e-063.37e-053.37e-057.69e-06

0.0001976850.0001976854.512345e-050.00620.00620.001410.240.240.0550.240.240.0550.240.240.0550.190.190.044

0.0001560.0001560.0001320.0001560.0001560.0001320.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.0001760.0002080.0002080.000176

0.190.190.040.290.290.0670.290.290.0670.0220.0220.005

1.7095521.7095520.3905541.663e-061.663e-063.798e-076.53e-056.53e-051.49e-056.53e-056.53e-051.49e-056.53e-056.53e-051.49e-055.34e-055.34e-051.22e-051.559e-071.559e-073.56e-08





Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

NaphthaleneEQUI36 EU016 R200 room East Wall Space Heater











Total

Nickelcompounds

















Total

NitrogenDioxide





Total

Nitrogen OxidesEQUI3 EU015 Main Office Space Heater
















Total

Nitrous Oxide EQUI3 EU015 Main Office Space Heater
















Total

ParticulateMatter





0.00016030.00016033.66e-052.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-082.079e-072.079e-074.747e-085.34e-055.34e-051.22e-057.9e-057.9e-051.8e-057.9e-057.9e-051.8e-055.85e-065.85e-061.34e-06

0.0006297080.0006297080.0001436935.726e-065.726e-061.307e-060.0002250.0002255.13e-050.0002250.0002255.13e-050.0002250.0002255.13e-050.0001840.0001844.2e-055.368e-075.368e-071.226e-075.368e-075.368e-071.226e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-077.158e-077.158e-071.634e-070.0001840.0001844.2e-050.0002720.0002726.21e-050.0002720.0002726.21e-052.01e-052.01e-054.6e-06

0.0016174790.0016174790.0003690690.020.020.010.020.020.010.020.020.010.020.020.00440.080.080.03440.270.270.062710.810.82.4610.810.82.4610.810.82.468.598.591.96

0.006970.006970.005880.006970.006970.005880.009290.009290.007840.009290.009290.007840.009290.009290.007840.009290.009290.007840.009290.009290.007848.588.581.964.794.791.094.794.791.090.970.970.22

60.4503960.4503913.813660.000620.000620.0001410.0240.0240.00550.0240.0240.00550.0240.0240.00550.020.020.0044

1.56e-051.56e-051.32e-051.56e-051.56e-051.32e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-052.08e-052.08e-051.76e-050.0190.0190.00440.0290.0290.00670.0290.0290.00670.00220.00220.0005

0.17195520.17195520.03945540.0210.0210.004770.820.820.190.820.820.19





Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)

ParticulateMatter




EQUI31 EU014 R1 Package (from Spray Dryer)
















Total

PM < 2.5 micron EQUI3 EU015 Main Office Space Heater





















Total

PM < 10 micron EQUI3 EU015 Main Office Space Heater





















Total










0.820.820.19125.92125.9228.750.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.041

0.0005290.0005290.0004470.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.00059629.71495.236.780.990.990.230.990.990.230.0730.0730.017

160.908588626.42858836.7566440.0210.0210.004770.820.820.190.820.820.190.820.820.1935.6935.698.150.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.041

0.0005290.0005290.0004470.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.00059630.7830.787.030.990.990.230.990.990.230.0730.0730.017

71.74858871.74858816.4066440.0210.0210.004770.820.820.190.820.820.190.820.820.1935.6935.698.150.180.180.0410.10.10.0240.10.10.0240.180.180.0410.180.180.041

0.0005290.0005290.0004470.0005290.0005290.0004470.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.0005960.0007060.0007060.00059629.51184.456.740.990.990.230.990.990.230.0730.0730.017

70.478588225.41858816.1166442.405e-072.405e-075.491e-089.43e-069.43e-062.15e-069.43e-069.43e-062.15e-069.43e-069.43e-062.15e-067.73e-067.73e-061.76e-062.25e-082.25e-085.1e-092.25e-082.25e-085.1e-09





Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)









Total

Seleniumcompounds

















Total

Sulfur Dioxide EQUI3 EU015 Main Office Space Heater
















Total

Toluene EQUI3 EU015 Main Office Space Heater
















Total





Total











3.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-093.006e-083.006e-086.864e-097.73e-067.73e-061.76e-06


8.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-098.181e-098.181e-091.868e-092.1e-062.1e-064.8e-073.11e-063.11e-067.1e-073.11e-063.11e-067.1e-072.3e-072.3e-075.25e-08

1.8478545e-051.8478545e-054.21758e-060.00160.00160.0003760.0650.0650.0150.0650.0650.0150.0650.0650.0150.050.050.01

4.18e-054.18e-053.53e-054.18e-054.18e-053.53e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-055.57e-055.57e-054.71e-05

0.050.050.010.0780.0780.0180.0780.0780.0180.00580.00580.0013

0.45876210.45876210.10298219.271e-069.271e-062.117e-060.0003640.0003648.3e-050.0003640.0003648.3e-050.0003640.0003648.3e-050.0002980.0002986.8e-058.692e-078.692e-071.984e-078.692e-078.692e-071.984e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-071.159e-061.159e-062.646e-070.0002980.0002986.8e-050.000440.000440.0001010.000440.000440.0001013.26e-053.26e-057.44e-06

0.0026174040.0026174040.0005982771.14e-051.14e-052.61e-061.14e-051.14e-052.61e-068.46e-078.46e-071.93e-07

2.3646e-052.3646e-055.413e-060.0150.0150.003450.590.590.140.590.590.140.590.590.140.470.470.11

0.0003830.0003830.0003240.0003830.0003830.0003240.0005110.0005110.000431





Potential (lbs/hr)


(tons/yr)

Potential Limited

(tons/yr)

Actual Emissions

(tons/yr)











Total

0.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.0004310.0005110.0005110.000431

0.470.470.110.720.720.160.720.720.160.0530.0530.012

4.2213214.2213210.978253




Subject ItemCategoryDescription

Subject Item TypeDescription Subject Item ID SI Designation and Description Relationship

Related SubjectItem ID % Flow

Related Subject ItemType Description

Related SubjectItem Designation

Start Date (RelatedSubject Item)

End Date (RelatedSubject Item)

Equipment Boiler EQUI13EU001Boiler 1 Cleaver Brooks

sends to STRU15 100 Stack/Vent SV001 5/4/2004 Null





EQUI44NullBoiler 5

sends to STRU31 100 Stack/Vent Null 11/8/2019 Null

EQUI45NullBoiler 6


Dryer/Oven,indirect fired

EQUI43 NullR3 Spray Dryer

is controlledby

TREA17 100 053-Venturi Scrubber Null 7/19/2017 Null


Dryer/Oven,unknown firingmethod

EQUI18 EU005Large Delaval Spray Dryer

is controlledin parallel by

TREA2 25001-Wet Scrubber - HighEfficiency

CE004 5/4/2004 Null


CE007 5/4/2004 Null


CE008 5/4/2004 Null


CE009 5/4/2004 Null


STRU21 50 Stack/Vent SV008 5/4/2004 Null

Material HandlingEquipment

EQUI31 EU014R1 Package (from Spray Dryer)

is controlledby

TREA12 100018-Fabric Filter - LowTemp, T<180 Degrees F

CE014 9/30/2013 Null


EQUI32 EU010Wet Blend Bag Dump

is controlledby


CE010 9/30/2013 Null


EQUI33 EU011Wet Blend Bag Dump 1

is controlledby


CE011 9/30/2013 Null


EQUI34 EU012Dry Blending

is controlledby


CE012 9/30/2013 Null


EQUI35 EU013Dry Packaging

is controlledby


CE013 9/30/2013 Null


Other Combustion EQUI3EU015Main Office Space Heater




EQUI37EU017Solaronics - R200 room West Wall Sp..


EQUI38EU018Ammonia Compressor Room East W..


EQUI39EU019Hallway outside R300 room Space H..


EQUI40EU020Hallway outside liquid packing room ..


EQUI41EU021Hallway next to shipping/receiving S..


EQUI42EU022Shipping receiving - South Wall Spac..


Other EmissionUnit

EQUI46 NullBoiler Room AHU



SI - SI relationships



Subject ItemCategoryDescription

Subject Item TypeDescription Subject Item ID SI Designation and Description Relationship

Related SubjectItem ID % Flow

Related Subject ItemType Description

Related SubjectItem Designation

Start Date (RelatedSubject Item)

End Date (RelatedSubject Item)

Equipment Other EmissionUnit

EQUI46 NullBoiler Room AHU

sends toSTRU15 20 Stack/Vent SV001 11/8/2019 Null



STRU31 18 Stack/Vent Null 11/8/2019 Null




SI - SI relationships



Aboveground Storage Tanks, General

Agency Interest: NoneAgency Interest ID: NoneActivity: None (None)

Details for:SI Category: EquipmentSI Type: Aboveground Storage Tank

Subject ItemTypeDescription Subject Item ID SI Designation and Description Manufacturer Model

Max DesignCapacity

Max DesignCapacity Units(numerator)

Max DesignCapacity Units(denominator) Material

ConstructionStart Date

OperationStart Date

ModificationDate

Subject toCSAPR?

ElectricGeneratingCapacity(MW)

MaterialHandlingEquipment

EQUI31EU014R1 Package (from Spray Dryer)

Camfil Farr GS4 2400 cubic feet minutes Product 8/1/2012 10/1/2012 Null Null Null

EQUI32EU010Wet Blend Bag Dump


EQUI33EU011Wet Blend Bag Dump 1




EQUI35EU013Dry Packaging


Other EmissionUnit EQUI46

NullBoiler Room AHU

Johnston Rapid 4060 2.25million Britishthermal units

hours Heat 7/1/2018 6/26/2019 Null Null Null

Emission Units 1


Details for:SI Category: NoneSI Type: Material Handling Equipment & Other Emission Unit

Subject Item TypeDescription Subject Item ID SI Designation and Description Manufacturer Model

Max DesignCapacity

Max DesignCapacity Units(numerator)

Max DesignCapacity Units(denominator) Material

ConstructionStart Date

OperationStart Date

ModificationDate

Boiler EQUI13EU001Boiler 1 Cleaver Brooks

Cleaver Brooks CB293-600 25million Britishthermal units

hours Heat 6/1/1970 12/1/1970 Null


Cleaver Brooks CB.100-600 25million Britishthermal units

hours Heat 6/1/1977 12/1/1977 Null


Cleaver Brooks CB.100-600 25million Britishthermal units

hours Heat 6/1/1977 12/1/1977 Null

EQUI44NullBoiler 5

Johnston PFTA-750 30.4million Britishthermal units

hours Heat 7/1/2018 6/26/2019 Null

EQUI45NullBoiler 6

Johnston PFTA-750 30.4million Britishthermal units

hours Heat TBD TBD Null

Dryer/Oven, indirectfired EQUI43

NullR3 Spray Dryer

GLM Hydro/Lubbers Tall Form 20million Britishthermal units

hours Heat TBD TBD Null

Dryer/Oven, unknownfiring method EQUI18

EU005Large Delaval Spray Dryer

Deleval 168-44 20million Britishthermal units

hours Heat 1/1/1976 2/1/1976 Null


McQuay RPS-035DLA 0.64million Britishthermal units

hours Heat 8/1/2012 10/1/2012 Null


SolaronicsDetroit RadiantProducts

0.06million Britishthermal units

hours Heat 12/1/1991 1/1/1992 Null

EQUI37EU017Solaronics - R200 room West Wall S..

SolaronicsDetroit RadiantProducts


hours Heat 12/1/1991 1/1/1992 Null


Lambert Modine 0.08million Britishthermal units

hours Heat 12/1/1991 7/1/2000 Null


LambertDetroit RadiantProducts


hours Heat 12/1/1991 1/1/1992 Null

EQUI40EU020Hallway outside liquid packing roo..



hours Heat 12/1/1991 1/1/1992 Null

EQUI41EU021Hallway next to shipping/receiving ..



hours Heat 12/1/1991 1/1/1992 Null

EQUI42EU022Shipping receiving - South Wall Spa..

Lambert Modine 0.08million Britishthermal units

hours Heat 12/1/1991 7/1/2000 Null

Emission Units 2


Details for:SI Category: EquipmentSI Type: Boiler, Dryer/Oven, indirect fired, Dryer/Oven, unknown firing method and 1 more

Subject Item TypeDescription Subject Item ID SI Designation and Description

FiringMethod Engine Use

EngineDisplacement

EngineDisplacementUnits

Subject toCSAPR?

ElectricGeneratingCapacity(MW)

Boiler EQUI13EU001Boiler 1 Cleaver Brooks

Not coalburning

Null Null Null N Null


Not coalburning



Not coalburning


EQUI44NullBoiler 5

Not coalburning


EQUI45NullBoiler 6

Not coalburning


Dryer/Oven, indirectfired EQUI43

NullR3 Spray Dryer

Not coalburning

Null Null Null Null Null

Dryer/Oven, unknownfiring method EQUI18

EU005Large Delaval Spray Dryer

Not coalburning



Not coalburning



Not coalburning


EQUI37EU017Solaronics - R200 room West Wall S..

Not coalburning



Not coalburning



Not coalburning


EQUI40EU020Hallway outside liquid packing roo..

Not coalburning


EQUI41EU021Hallway next to shipping/receiving ..

Not coalburning


EQUI42EU022Shipping receiving - South Wall Spa..

Not coalburning


Emission Units 2 (continued)


Details for:SI Category: EquipmentSI Type: Boiler, Dryer/Oven, indirect fired, Dryer/Oven, unknown firing method and 1 more

Fugitive Sources


Details for:SI Category: FugitiveSI Type: Air Landfill, Cooling Tower, Data Acquisition System and 9 more

Subject ItemTypeDescription Subject Item ID SI Designation and Description Height

Units(height) Length

Units(length) Width

Units(width)

Building STRU23NullAdministration offices and labs building

28 feet 88 feet 86 feet

STRU24NullR201 Fermenter Building


STRU25NullWarehouse, Cultures, & dry blend packa..


STRU26NullR2 Dryer building


STRU27NullBoiler and Utilities Building


STRU28NullEvaporator and R1 Dryer building




STRU30NullSTRU Dryer Building


Buildings, General


Details for:SI Category: StructureSI Type: Building

Subject ItemTypeDescription Subject Item ID SI Designation and Description

Stack Height(feet)

StackDiameter(feet)

Stack Length(feet)

Stack Width(feet)

Stack Flow Rate(cubic ft/min)

DischargeTemperature(°F)

Flow Rate/TempInformationSource Discharge Direction

Stack/Vent STRU1SV016IR Space Heater

55 Null 2.5 2.5 11000 150 EstimateUpwards with a cap onstack/vent


30 2.7 Null Null 5600 150 ManufacturerUpwards with a cap onstack/vent




55 Null 2.5 2.5 11000 150 ManufacturerUpwards with a cap onstack/vent


14 Null 0.58 0.58 1400 75 Manufacturer Horizontally



STRU11SV012Dry Blend


STRU12SV013Dry Packaging


STRU13SV014R1 Package


STRU14SV015Main Office Space Heater

15 Null 0.25 1.5 5600 91.4 ManufacturerUpwards with no cap onstack/vent

STRU15SV001Boiler 1

27 2 Null Null 8400 380 ManufacturerUpwards with a cap onstack/vent

STRU16SV002Boiler 2


STRU17SV003Boiler 3


STRU18SV004Boiler 4



80 Null 4 5 40000 110 ManufacturerUpwards with a cap onstack/vent


80 Null 4 5 40000 110 ManufacturerUpwards with a cap onstack/vent

STRU22NullR3 Dryer Stack

110 0.83 Null Null 225 470 ManufacturerUpwards with no cap onstack/vent




27.46 2.33 Null Null 9761 303 ManufacturerUpwards with a cap onstack/vent


27.46 Null 3.21 3.21 12500 68 Estimate Horizontally


27.46 Null 3.21 3.21 12500 68 Estimate Horizontally

STRU35NullR3 Dryer – product handling

110 3.83 Null Null 59000 230 Test dataUpwards with no cap onstack/vent

Stack/Vent, General


Details for:SI Category: StructureSI Type: Stack/Vent


InstallationStart Date

PollutantControlled

CaptureEfficiency(%)

DestructionCollectEfficiency(%)

Subject toCAM?

Large orOther PSEU?Efficiency Basis

Scrubber MinimumPressure Drop (in.of water column)

ScrubberMaximumPressureDrop (in. of ..

MinimumLiquid FlowRate(gal/min)

001-WetScrubber -HighEfficiency

TREA2 CE004Wet Scrubber - High Efficiency

Delaval 168-44 NullParticulateMatter

100 90 No Null Mfr/Vendor dataNull Null Null

PM < 2.5micron


PM < 10micron





PM < 2.5micron


PM < 10micron





PM < 2.5micron





PM < 2.5micron


PM < 10micron


053-VenturiScrubber

TREA17 NullVenturi Scrubber

Mikropul Model54/132

TBDParticulateMatter

100 94 No NullControlEquipment Rule

5 90 545

PM < 10micron

100 84 No NullControlEquipment Rule

5 90 545

Scrubbers, General


Details for:SI Category: TreatmentSI Type: 001-Wet Scrubber - High Efficiency & 053-Venturi Scrubber

Other Control Equipment


Details for:SI Category: TreatmentSI Type: 004-Gravity Collector - High Efficiency, 005-Gravity Collector -Medium Efficiency, 006-Gravity Collector - Low Efficiency and 55 more


InstallationStart Date

PollutantControlled

CaptureEfficiency(%)

DestructionCollectEfficiency(%)

Subject toCAM?

Large orOther PSEU?

EfficiencyBasis

Fabric FilterMinimumPressureDrop (in. of ..

Fabric FilterMaximumPressureDrop (in. of ..

Bag leakdetector inuse?

018-FabricFilter - LowTemp, T<180Degrees F

TREA8 CE010Fabric Filter - Low Temperature, i.e., T<180Degrees F

Null Null NullParticulateMatter

80 99 No Null Other 0.5 3.8 Yes

PM < 2.5micron


PM < 10micron





PM < 2.5micron


PM < 10micron





PM < 2.5micron


PM < 10micron





PM < 2.5micron


PM < 10micron





PM < 2.5micron


PM < 10micron


Fabric Filters, General


Details for:SI Category: TreatmentSI Type: 018-Fabric Filter - Low Temp, T<180 Degrees F

Direct Flame Afterburners, General


Details for:SI Category: TreatmentSI Type: 021-Direct Flame Afterburner, 022-Direct Flame Afterburner withHeat Exchanger, 131-Thermal Oxidation and 1 more


Attachment 3 Notice of Compliance

t-enf-iii-9a · 1/18/18 · LB 1064

February 7, 2019

Richard K. Anderson, CHMM - Site HSE Manager Kerry Ingredients and Flavours Inc 2402 7th Street NW Rochester, MN 55901-7536

RE: Notice of Compliance for the October 4-5, 2018, PM < 10 micron, PM < 2.5 micron, Particulate Matter, Pressure Drop, Process Throughput, Water flow rate Performance Test of the Dryer Scrubbers, Large Delaval Spray Dryer, R3 Spray Dryer, Venturi Scrubber Pursuant to Air Emission Permit Number 10900032-101

Dear Richard K. Anderson:

Minnesota Pollution Control Agency (MPCA) performance test staff reviewed the final test report for the performance test conducted at Kerry Ingredients and Flavours Inc located in Rochester, Minnesota. The test report was submitted November 12, 2018.

Summary of performance test results

Emission unit tested

Limitation basis Pollutant and emission limit Test result

Compliance status

Large Delaval Spray Dryer EQUI 18 EU005

Process Throughput <= 3357 pounds per hour 8-hour block average for the large dryer (EQUI 18). [Minn. R. 7017.2025, subp. 3]

Process Throughput 1665 lbs/hour

Compliant

PM < 10 micron <= 8.0 pounds per hour as a total for the 2 stacks (STRU 20 and 21) for the Large Delaval Spray Dryer (EQUI 18). [Title I Condition: Avoid major modification under 40 CFR 52.21(b)(2) and Minn. R. 7007.3000, Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000, To avoid major source under 40 CFR 70.2 & Minn. R. 7007.0200]

PM < 10 micron 4.7 lbs/hour

Compliant

Particulate Matter <= 0.30 grains per dry standard cubic foot of exhaust gas unless required to further reduce emissions to comply with the less stringent limit of either Minn. R. 7011.0730 or Minn. R. 7011.0735. [Minn. R. 7011.0610, subp. 1(A)(1)] (Limit calculated from Table 2: 20.5 lbs/hour based on combined airflows from STRU 20 and 21)

Particulate Matter 3.5 lbs/hour

Compliant

Dryer Scrubbers COMG 2 GP004

Pressure Drop >= 8.75 inches of water column for TREA 2, 5, 6, and 7, unless a new range is set pursuant to Minn. R. 7017.2025, subp. 3. This pressure drop applies to each large dryer scrubber. [Title I Condition: Avoid major modification under 40 CFR 52.21(b)(2) and Minn. R. 7007.3000, Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000, To avoid major source under 40 CFR 70.2 & Minn. R. 7007.0200]

Pressure Drop 12.5 inches of water column

Compliant

(All scrubbers were compliant with limit)

Richard K. Anderson, CHMM - Site HSE Manager Page 2 February 7, 2019

Emission unit tested

Limitation basis Pollutant and emission limit Test result

Compliance status

Dryer Scrubbers COMG 2 GP004

Water flow rate >= 73.4 gallons per minute for TREA 2, 5, 6, and 7, unless a new minimum is set pursuant to Minn. R. 7017.2025, subp. 3. This water flow rate applies to each large dryer scrubber. [Title I Condition: Avoid major modification under 40 CFR 52.21(b)(2) and Minn. R. 7007.3000, Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000, To avoid major source under 40 CFR 70.2 & Minn. R. 7007.0200]

Water flow rate 76 gallons per minute

Compliant

(All scrubbers were compliant with limit)

R3 Spray Dryer EQUI 43

Process Throughput <= 4409 pounds per hour 8-hour block average. [Minn. R. 7017.2025, subp. 3]

Process Throughput 3345 lbs/hour

Compliant

PM < 2.5 micron: The Permittee shall conduct a performance test due 180 calendar days after Permit Issuance Date to verify the PM 2.5 emission factor of 7.03 lb/hr. [Minn. R. 7017.2020, subp. 1]

PM < 2.5 micron 2.1 lbs/hour

Verified

PM < 10 micron: The Permittee shall conduct an initial performance test due 180 calendar days after Initial Startup Date to verify the PM10 emission factor of 6.74 lb/hr. [Minn. R. 7017.2020, subp. 1, Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000, To avoid major source under 40 CFR 70.2 & Minn. R. 7007.0200]

PM < 10 micron 2.1 lbs/hour

Verified

Particulate Matter: The Permittee shall conduct an initial performance test due 180 calendar days after Initial Startup Date to verify the PM emission factor of 6.67 lb/hr. [Minn. R. 7017.2020, subp. 1, Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000]

Particulate Matter 1.8 lbs/hour

Verified

Venturi Scrubber TREA 17

Pressure Drop >= 15 and <= 100 inches of water, unless a new range is set pursuant to Minn. R. 7017.2025, subp. 3 based on the values recorded during the most recent MPCA-approved performance test where compliance was demonstrated. The new range shall be implemented upon receipt of the Notice of Compliance letter granting preliminary approval. The range is final upon issuance of a permit amendment incorporating the change. The Permittee shall record the pressure drop at least once every 24 hours when in operation. [Minn. R. 7011.0080, Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000, To avoid major source under 40 CFR 70.2 & Minn. R. 7007.0200]

Pressure Drop 8.8 inches of water column

Verified

Water flow rate >= 565 gallons per minute 3-hour rolling average, unless a new limit is set pursuant to Minn. R. 7017.2025, subp. 3, based on the values recorded during the most recent MPCA-approved performance test where compliance was demonstrated. The new limit shall be implemented upon receipt of the Notice of Compliance letter granting preliminary approval. The limit is final upon issuance of a permit amendment incorporating the change. [Minn. R. 7011.0080, Title I Condition: Avoid major source under 40 CFR 52.21(b)(1)(i) and Minn. R. 7007.3000, To avoid major source under 40 CFR 70.2 & Minn. R. 7007.0200]

Water flow rate 551 gallons per minute

Verified


Table References:

Particulate Matter includes filterable plus organic condensable particulate matter as determined by EPAMethods 5 and 202.

PM10 and PM2.5 as determined by EPA Methods 5 and 202.

The tests were conducted while operating at the rates in the table above. Operating limits based on these conditions are defined in Item 1 of this letter.

In addition, please be advised of the following:

1. The following operating limit applies pursuant to Minn. R. 7017.2025, subp. 3 and any additionalapplicable requirement. This limit supersedes any previous operating limit in the permit and doesnot serve to relax any other limit or requirement. This letter grants preliminary instruction tooperate at the new rate. The limit is final upon issuance of a permit amendment incorporating thechange.

Emission unit Operating limit

R3 Spray Dryer EQUI 43 Venturi Scrubber TREA 17

Pressure Drop >= 5.0 and <= 90.0 inches of water. Read and record the pressure drop across the scrubber every 24 hours if in operation

Water flow rate >= 545 gallons per minute 3-hour rolling average

The Regulated Party may not operate an emission unit at a less stringent rate than that listed in the table above unless it conducts a performance test at an alternate rate, MPCA performance test staff determines compliance at that rate for the emission unit, and a Notice of Compliance with approval to operate at the new rate is received.

Ongoing compliance with the operating limit will be determined using the same data acquisition and reduction as was used during the performance test. If an operating limit is exceeded, it must be reported in accordance with the deviation reporting requirements of Minn. R. 7007.0800, subp. 6(A).

2. The Emission Inventory rule, Minn. R. 7019.3000 to 7019.3100, requires the calculation of emissionsbased on an established hierarchy. In the absence of Continuous Emission Monitor data meeting therequirements of Minn. R. 7019.3040, a performance test must be used. When a performance test forparticulate matter, carbon monoxide, nitrogen oxides, sulfur oxides, volatile organic compounds orlead is conducted and meets the requirements of Minn. R. 7017.2001 to 7017.2060, the results must beused to calculate emissions, unless specified otherwise by Minn. R. 7019.3000 to 7019.3100. It is theRegulated Party’s responsibility to ensure the results of performance tests are accounted for in theirannual emission inventory submittal. Note that the final decision to approve the emission factor for anygiven inventory year will be made by the MPCA Emission Inventory Coordinator.


If you have questions or comments regarding the content of this letter, please contact me at 651-757-2757.

Sincerely,

Curtis H. Stock This document has been electronically signed.

Curtis H. Stock Pollution Control Specialist Senior Land & Air Compliance Section Industrial Division

CHS:se

cc: Activity ID REP20180002 @ 732


Attachment 4 Manufacturer information for boiler emissions

MODEL: PFTA 750-4

Ratings & Performance Data

MODEL: PFTA 750-4 Nozzle Loadings

300 Pine Street P.O. Box 300 Ferrysburg, MI 49409-0300 Telephone: (616) 842-5050 Net: www.johnstonboiler.com

Printed Feb. 2008

Distributed By:

4-Pass Steam Packaged Firetube Boiler

Maximum Allowable Load on Boiler Steam Nozzle 15# Design 150# Design 200# Design 250# Design 300# Design FRRF, lb 6,235 4,695 6,590 8,260 9,810 MRCM, in-lb 50,040 58,795 83,190 109,040 142,075 MRLM, in-lb 79,540 48,155 67,575 90,300 104,430

Horsepower 750 Steam Storage, ft3 148.8 Natural Gas Flow, SCFH (1,000 Btu/ft3)** 30,263 Steam Disengaging Area, ft2 125.1 Combustion Air (15% Excess), SCFM*** 5,538 Total Heating Surface, ft2 3,727 Flue Gas Flow Rate, lb/hr*** 26,391 Furnace Outside Diameter, in 49.5 Stack Flue Gas Velocity, ft/min*** 2,231 Furnace Heat Release Rate, Btu/ft3 hr** 161,000 #2 Oil Flow, gal/hr (140,000 BTU/gal)** 208.3 Total Combustion Volume, ft3 252.5 #6 Oil Flow, gal/hr (150,000 BTU/gal)** 192.8 Total Heat Release Rate, Btu/ft3 hr** 120,000 Flue Gas Side Pressure Drop, in. H2O 6.1 Water Content N.W.L., gal 4,084 Water Content Flooded, gal. 5,197 Approx. Dry Weight 15#, lb 51,000 Approx. Operating Weight 15#, lb. 84,200 Approx. Dry Weight 150#, lb 55,300 Approx. Operating Weight 150#, lb. 88,500 Approx. Dry Weight 200#, lb 59,300 Approx. Operating Weight 200#, lb. 92,500 Approx. Dry Weight 250#, lb 63,900 Approx. Operating Weight 250#, lb. 97,100 Approx. Dry Weight 300#, lb 69,400 Approx. Operating Weight 300#, lb. 102,600 Performance Data

Operating Pressure (psig)

Steam Rate (lb/hr)

Natural Gas #2 Oil #6 Oil Stack Temp (F) %Eff Stack Temp (F) %Eff Stack Temp (F) %Eff

10 26,046 280 85.4 289 88.5 296 89.3 50 25,541 337 84.0 346 87.1 354 87.8

100 25,268 377 83.0 386 86.1 394 86.8 150 25,116 405 82.3 414 85.4 422 86.1 200 25,021 427 81.7 436 84.8 445 85.5 250 24,960 445 81.3 454 84.4 463 85.1 300 24,921 461 80.9 470 84.0 480 84.7

*Based on 228°F feedwater and 3% O2, ** Values calculated at 100 psi operating pressure, ***Calculated Firing Natural Gas

Stack Emissions-Natural Gas (1,000 Btu/CF) PPMv lb/hr @ Ton/Yr @ (Corr to 3% O2) lb/MBtu Full Rate Full Rate 110 0.131 3.963 17.358 NOx * 30 0.036 1.081 4.734

9 0.011 0.324 1.420 CO 50 0.037 1.11 4.870 CO2 2.55 lb/lb fuel 119.76 3,624 15,874 H20 2.03 lb/lb fuel 106.16 3,213 14,072 Stack Emissions-#2 Oil** (140,000 Btu/gal) NOx 128 0.174 5.077 22.239 CO 50 0.037 1.071 4.693 CO2 3.20 lb/lb fuel 168.53 4,915 21,527 H20 1.12 lb/lb fuel 71.20 2,076 9,095 * 110 ppm “A” Burner, 30 ppm A-FGR Burner, 9 ppm FIR Burner

**0.02% fuel bound Nitrogen

MODEL: PFTA 750-4 Drawings - 4-Pass Steam Packaged Firetube Boiler

Notes: 150# Steam design shown, all dimensions given in inches. Fuel piping and/or optional boiler trim may increase overall width. Specifications subject to change to incorporate engineering advances. *May vary on low-NOx designs

Base Diagram Connection & Opening Schedule Conn. Description Type Qty

FW Feedwater Inlet 2.00 FNPT 2 MS* Main Steam 8.00 300# RF 1 CB Continuous Blowoff 1.00 FNPT 1 BD Blowdown Outlet 2.00 FNPT 2 MW Manway 12 X 16 1 HH Hand Hole 4 X 6 7

*12.00 150#RF Flange on 15 psig Design

Thermal Expansion

psig 15 150 200 250 300 Metal TMAX (F) 240 366 388 406 421

L (in) 0.108 0.182 0.196 0.207 0.217

MS (in) 0.014 0.024 0.026 0.027 0.029

HT (in) 0.112 0.190 0.204 0.217 0.228

Technical Support Document Draft Air Emission Permit No ... · direct fired natural gas heating...

Documents

Transcript of Technical Support Document Draft Air Emission Permit No ... · direct fired natural gas heating...