Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability...
Transcript of Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability...
![Page 1: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/1.jpg)
Supporting Information for
Tuning wettability of carbon nanotube arrays for efficient
bifunctional catalysts and Zn-air battery
Weiliang Tian a,c, Haoyuan Li a, Bangchang Qin a, Yuqi Xu a, Yongchao Hao a, Yaping Li a,
Guoxin Zhang a, Junfeng Liu a*, Xiaoming Sun a, b* and Xue Duana
a State Key Laboratory of Chemical Resource Engineering, Beijing University of Chemical
Technology, Beijing 100029, China
b College of Energy, Beijing Advanced Innovation Center for Soft Matter Science and
Engineering, Beijing University of Chemical Technology, Beijing, 100029, China
c Key Laboratory of Chemical Engineering in South Xinjiang, College of Life Science, Tarim
University, Alar 843300, China
*Corresponding Author: E-mail address: [email protected], [email protected]. Tel.:
+86−10−64438991. Fax: +86−10−64438991.
1
Electronic Supplementary Material (ESI) for Journal of Materials Chemistry A.This journal is © The Royal Society of Chemistry 2017
![Page 2: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/2.jpg)
Video Caption
Video S1: hydrophobicity and hydrophilicity of the CNTAs and N-CNTAs.
2
![Page 3: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/3.jpg)
Figures and captions
Figure S1. (a) XRD pattern of VMT/N-CNTAs, N-CNTAs and Co3O4/N-CNTAs (* stands for the (002) peak of CNTs), (b) Raman spectra of CNTAs, N-CNTAs, and Co3O4/N-CNTAs.
3
![Page 4: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/4.jpg)
Figure S2. (a) XPS survey spectra of N-CNTAs-0.5, N-CNTAs, Co3O4 and Co3O4/N-CNTAs; (b-d) N binding energy region of N-CNTAs-0.5 (b), N-CNTAs (c), and Co3O4/N-CNTAs (d).
4
![Page 5: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/5.jpg)
Figure S3. First principles calculation structure diagram: CNTs-water and N-CNTs-water. Gray spheres stand for C atoms, red for O, white for H and blue for nitrogen.
5
![Page 6: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/6.jpg)
Figure S4. Schematic diagram showing the fabrication of 3D structured N-CNTAs decorated with cobalt oxide NPs.
6
![Page 7: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/7.jpg)
Figure S5. SEM images of Fe2O3/N-CNTAs composite.
7
![Page 8: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/8.jpg)
Figure S6. Electrocatalytic ORR and OER activities of Co3O4/N-CNTAs compared with other
samples. (a, b) OER CV (a) and tafel plots (b) of ACNTs, N-CNTAs and Co3O4/N-CNTAs
compared with IrO2/C 20%. (c, d) Durability tests of ORR (c) and OER (d) at 1600 rpm speed of
rotating disc electrode in 0.1 M KOH solution.
8
![Page 9: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/9.jpg)
Rotating-disk voltammetry measurements:
Rotating-disk voltammetry measurements: To further study the ORR electrochemical
procedures of Co3O4/N-CNTAs, we performed rotating-disk electrode (RDE). The RDE current-
potential curves at various rotating speeds are shown in Figure S4a .The limited diffusion currents
are dependent on the rotating rates. The number of electrons involved in the ORR can be
calculated from the Koutecky-Levich (K-L) equation:
(1) J-1=JL-1+JK
-1=(Bω1/2)-1+JK-1
(2) B=0.62nFC0(D0)2/3v-l/6
(3) B=nFkCo
(4) JK-1=J-1-(0.62nFC0(D0)2/3v-l/6ω1/2)-1.
Where J is the measured current density, JK and JL are the kinetic- and diffusion-limiting
current densities, ω is the angular velocity of the disk (ω=2pN, N is the linear rotation speed), n is
the overall number of electrons transferred in oxygen reduction, F is the Faraday constant
(F=96485 C·mol-1), C0 is the bulk concentration of O2, (C0 =1.2x10-6 mo1·cm-3), v is the
kinematic viscosity of the electrolyte (v=0.01 cm2·s-1), Do is the diffusion coefficient of O2 in 0.1
M KOH (1.9x10-5 cm2·s-1). According to Equations (1) and (2), the number of electrons
transferred (n) can be calculated to be 3.93, which indicates that the of Co3O4/N-CNTAs lead to a
four-electron-transfer reaction to reduce directly oxygen into OH-.
9
![Page 10: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/10.jpg)
a b
Figure S7. (a) Polarization curves and (d) K-L plots of Co3O4/N-CNTAs.
10
![Page 11: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/11.jpg)
a b
c d
Figure S8. The ORR 300 oC (a) and 800 oC (b), and OER 300 oC (c) and 800 oC (d) LSV curves
of Fe2O3/N-CNTAs, Co3O4/N-CNTAs, NiO/N-CNTAs, and MnO/N-CNTAs.
11
![Page 12: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/12.jpg)
Figure S9. (a) The galvanostatic discharge curve of the primary zinc-air batteries at the current
density of 5 mA cm-2. (b) Specific capacities of the primary zinc-air batteries normalized to the
mass of the consumed Zn at the current density of 5 mA cm-2.
12
![Page 13: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/13.jpg)
Table S1. The element content of N-CNTAs-0.5, N-CNTAs and Co3O4/N-CNTAs obtained by XPS.
N-CNTAs-0.5Atomic
(%)N-CNTAs
Atomic(%)
Co3O4/N-CNTAsAtomic
(%)
C1s 96.13±1.5 C1s 91.99±1.5 C1s 73.72±1.5N1s 3.87±1.5 N1s 8.01±1.5 N1s 6.95±1.5
Co2p3 8.07±1.5O1s 11.26±1.5
13
![Page 14: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/14.jpg)
Table S2. The binding energy of water and CNTAs or N-CNTAs with different N doping.
N (at. %) ΔE(ads)/eV
0.000 +0.0101803.125 -0.0870086.250 -0.1471739.375 -0.21149412.500 -0.428177
* 2 2( ) ( ) ( )ads A H O A H OE E E E
where A is CNTs or N-CNTs; E(A+H2O) is the total energy of the A with a water
molecule, E(A) is the total energy of CNTs or N-CNTs, and E(H2O) is the total
energy of the H2O.
14
![Page 15: Supporting Information for bifunctional catalysts …Supporting Information for Tuning wettability of carbon nanotube arrays for efficient bifunctional catalysts and Zn-air battery](https://reader036.fdocuments.us/reader036/viewer/2022071105/5fdf229be67462761f1e74bc/html5/thumbnails/15.jpg)
Table S3. The electrochemical performances of the electrocatalysts for bifunctional oxygen
catalysis.
Catalysts EORR/V-3
mA/cm2
EOER/V10
mA/cm2
ΔE/V(EOER-EORR)
CNTAs 0.440N-CNTAs 0.635 1.904 1.269Co3O4/N-CNTAs
0.785 1.662 0.877Pt/C 0.802 1.805 1.003
IrO2/C 0.445 1.700 1.255
15