STANDARD DUTY LOW PROFILE CARRIER PARTS MANUAL...Standard Duty Low Profile Carrier Parts Manual -...
Transcript of STANDARD DUTY LOW PROFILE CARRIER PARTS MANUAL...Standard Duty Low Profile Carrier Parts Manual -...
STANDARD DUTY
LOW PROFILE CARRIER
PARTS MANUAL
5-376-000140Rev 0 - August 01, 2010 © 2010 Jerr-Dan Corporation. All Rights Reserved.
13224 Fountainhead PlazaHagerstown, MD 21742Phone (717) 597-7111
www.jerr-dan.com
Standard Duty Low Profile Carrier Parts Manual - Page 35-376-000140Rev 00 - 08/10
This manual covers the following Jerr-Dan Models:NGAF6T-LP - 6 Ton Low Profile Aluminum Pioneer Fixed Rail SRR6T-LP - 6 Ton Low Profile Steel Removable RailNGADF6T-LP - 6 Ton Low Profile Aluminum Pioneer Dual Angle Fixed Rail SRRD6T-LP - 6 Ton Low Profile Steel SharkNGAR6T-LP - 6 Ton Low Profile Aluminum Pioneer Removable Rail STRB6T-LP - 6 Ton Low Profile Steel B.I.C. TransporterNGAT6T-LP - 6 Ton Low Profile Aluminum Pioneer Transporter
Jerr-Dan Corporation strives to provide information that is accurate, complete and useful. Descriptions and illustrative material containedwithin this manual are as accurate as known at the time of publication and are subject to change, without notice, as a result of continuousproduct improvements. Jerr-Dan reserves the right to amend the information in this document at any time without prior notice.
Information contained in this manual reflects how this vehicle was built at the factory. Modifications or additions by the distributor or owner arenot reflected in this manual.
This parts manual does not include service parts information for the commercial chassis (IHC, Ford, GM, etc.).That information is provided by the chassis manufacturer.
When ordering parts, please refer to your unit’s Serial Number and Model Number. This information is found on the aluminum tag riveted to thefront left corner of the deck as shown below:
Additional or replacement manuals can be ordered by calling Jerr-Dan Parts at 717-597-7111.Price and availability will be quoted at time of the request.
Please report comments and/or errors by contacting Jerr-Dan Corporation’s Technical Publications Department by e-mail [email protected] or by FAX on 717-485-7162.
Manufactured under one or more of the following patents: 5,133,633; 5,575,606; 5,697,741; 5,951,235; 6,231,294 B1; 6,315,515 B1;6,336,783 B1; 6,447,239 B2 and 7,264,305 B2 with other Patents Pending.Jerr-Dan and the Jerr-Dan logo are registered trademarks and Run Hard is a service mark of Jerr-Dan Corporation, Greencastle, PA USA.
The material in this document is confidential and the property of Jerr-Dan Corporation. No part of this document may be photocopied,reproduced or translated to another language without the express written consent of Jerr-Dan Corporation.
SERIAL NO.
MODEL NO.
MANUFACTURED BY:
JLG INDUSTRIES, INC.
1001127221-00
FOR:
Standard Duty Low Profile Carrier Parts Manual - Page 45-376-000140Rev 00 - 08/10
THIS PAGE INTENTIONALLY LEFT BLANK
Standard Duty Low Profile Carrier Parts Manual - Page 55-376-000140Rev 00 - 08/10
INDEX
DESCRIPTION PAGE DESCRIPTION PAGEDeck - 6 Ton Aluminum Fixed Rail Low Profile (NGAF6T-LP) ................................................ 6 - 7Deck - 6 Ton Aluminum Dual Angle Fixed Rail Low Profile (NGADF6T-LP) ........................... 8 - 9Deck - 6 Ton Aluminum Removable Rail Low Profile (NGAR6T-LP) .................................. 10 - 11Deck - 6 Ton Aluminum Transporter Low Profile (NGAT6T-LP) ........................................ 12 - 13Deck - 6 Ton Steel Removable Rail Low Profile (SRR6T-LP) ............................................. 14 - 15Deck - 6 Ton Steel Low Profile Shark (SRRD6T-LP) .......................................................... 16 - 17Deck - 6 Ton Steel Transporter Low Profile (STRB6T-LP) ................................................ 18 - 19Adjustable Roll Cylinder Bracket - Deck ............................................................................. 20 - 21Standard Deck Mounted Headboard ................................................................................... 22 - 23Deluxe Deck Mounted Headboard ...................................................................................... 24 - 25Bucket Rest Headboard ...................................................................................................... 26 - 27Stationary Headboard .......................................................................................................... 28 - 29Worm Gear Winch ............................................................................................................... 30 - 31Worm Gear Winch Cable Roller Guide / Tensioner Plate ................................................... 32 - 33Manual Remote Free Spool - Deck Mounted Headboard ................................................... 34 - 35Manual Remote Free Spool - Stationary Headboard .......................................................... 36 - 37Manual Remote Air Free Spool ............................................................................................ 38 - 39Subframe ........................................................................................................................ 40 - 41Hold Down ........................................................................................................................ 42 - 43Slide Pad ........................................................................................................................ 44 - 45Mud Flap ........................................................................................................................ 46 - 47Lightboxes ........................................................................................................................ 48 - 49Final Assembly ..................................................................................................................... 50 - 51Hydraulic Reservoir and Toolbox / Basket ......................................................................... 52 - 57Toolbox ........................................................................................................................ 58 - 59Toolbox Shelf ........................................................................................................................ 60 - 61Toolbox Light ........................................................................................................................ 62 - 63Toolbox Top Stowage Tray and Marker Lights .................................................................. 64 - 65Dual Controls - 3 Bank ......................................................................................................... 66 - 67Dual Controls - 4 Bank ......................................................................................................... 68 - 69Dual Controls - 5 Bank ......................................................................................................... 70 - 71Hydraulic Components - Standard ...................................................................................... 72 - 75Hydraulic Components - Standard (Hose Track) ............................................................... 76 - 77Hydraulic Components - Hose Routing / Mounting (Ford, GM & IHC) ............................... 78 - 79Hydraulic Components - IRL Wheel Lift with Manual Grids ............................................... 80 - 81Hydraulic Components - Hydraulic Rear Dock Stabilizer ................................................... 82 - 83Hydraulic Components - Stabilizer w/ Reese Hitch or Pintle Hitch Mtg Plate ................... 84 - 85Electrical Components - Standard w/ Deck Mounted Headboard ..................................... 86 - 87Electrical Components - Standard w/ Stationary Headboard ............................................ 88 - 89Electrical Components - Optional (Tail Light Converter) .................................................... 90 - 91Deck Marker Lights .............................................................................................................. 92 - 93Headboard Side Marker Lights ............................................................................................ 94 - 95Additional Deck Marker Lights ............................................................................................. 96 - 97IRL Wheel Lift ....................................................................................................................... 98 - 99
Manual L-Arm Wheel Lift Grid ........................................................................................ 100 - 101Manual T37 Pivoting Wheel Lift Grid .............................................................................. 102 - 103Hydraulic Rear Dock Stabilizer ....................................................................................... 104 - 105Hydraulic Rear Dock Stabilizer w/ Reese Hitch Receiver ............................................ 106 - 107Roll Cylinder Assembly ................................................................................................... 108 - 109Tilt Cylinder Assembly .......................................................................................................110 - 111Wheel Lift Extend Cylinder Assembly ............................................................................. 112 - 113IRL/Stabilizer Cylinder Assembly..... ................................................................................ 114 - 115Stabilizer Cylinder Assembly..... ...................................................................................... 116 - 117Lightbars .................................................................................................................... 118 - 119Switch Panels ................................................................................................................. 120 - 121Work Lights ................................................................................................................... 122 - 123Bolt-On D-Rings .............................................................................................................. 124 - 125Remote Control Operation(s) ......................................................................................... 126 - 127Remote Throttle Control .................................................................................................. 128 - 129Glad Hands and 7-Way Connector ................................................................................ 130 - 131Air Supply Disconnect .................................................................................................... 132 - 133Jump Start Kit ................................................................................................................... 134 - 135Folding Deck Ladder ....................................................................................................... 136 - 137Chains and Straps .......................................................................................................... 138 - 139Decals ................................................................................................................... 140 - 141Accessory Equipment .................................................................................................... 142 - 143Hydraulic Schematic ....................................................................................................... 144 - 148Electrical Schematic .................................................................................................................. 149
Standard Duty Low Profile Carrier Parts Manual - Page 65-376-000140Rev 00 - 08/10
DECK - 6 TON ALUMINUM FIXED RAIL LOW PROFILE (NGAF6T-LP)
ITEM PART NO. DESCRIPTION QTY
1 3097000675 21’ Deck - 96” wide 13097000676 21’ Deck - 102” wide3097000779 22’ Deck - 96” wide3097000780 22’ Deck - 102” wide
2 7679000017 Chain Tray Mat 2
Standard Duty Low Profile Carrier Parts Manual - Page 75-376-000140Rev 00 - 08/10
1
2
DECK - 6 TON ALUMINUM FIXED RAIL LOW PROFILE (NGAF6T-LP)
21’ deck shown
Standard Duty Low Profile Carrier Parts Manual - Page 85-376-000140Rev 00 - 08/10
DECK - 6 TON ALUMINUM DUAL ANGLE FIXED RAIL LOW PROFILE (NGADF6T-LP)
ITEM PART NO. DESCRIPTION QTY
1 3097000681 21’ Deck - 96” wide 13097000682 21’ Deck - 102” wide3097000781 22’ Deck - 96” wide3097000782 22’ Deck - 102” wide
2 7679000017 Chain Tray Mat 2
Standard Duty Low Profile Carrier Parts Manual - Page 95-376-000140Rev 00 - 08/10
2
1
DECK - 6 TON ALUMINUM DUAL ANGLE FIXED RAIL LOW PROFILE (NGADF6T-LP)
21’ deck shown
Standard Duty Low Profile Carrier Parts Manual - Page 105-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 3097000673 21’ Deck - 96” wide 13097000674 21’ Deck - 102” wide3097000777 22’ Deck - 96” wide3097000778 22’ Deck - 102” wide
2 7679000017 Chain Tray Mat 2
DECK - 6 TON ALUMINUM REMOVABLE RAIL LOW PROFILE (NGAR6T-LP)
ITEM PART NO. DESCRIPTION QTYStandard Aluminum Removable Rails:
10 3017000121 Angle Assembly LH Front 111 3017000122 Angle Assembly RH Front 112 3017000129 Angle Assembly LH Rear (21’ deck) 1
3017000131 Angle Assembly LH Rear (22’ deck)13 3017000130 Angle Assembly RH Rear (21’ deck) 1
3017000132 Angle Assembly RH Rear (22’ deck)14 7120000005 Capscrew, 0.50”-13NC x 2.50” 10
Parts Breakdown of Angle Assemblies50 4017001699 Angle LH Front 151 4017001700 Angle RH Front52 4017001707 Angle LH Rear (21’ deck) 1
4017001709 Angle LH Rear (22’ deck)53 4017001708 Angle RH Rear (21’ deck)
4017001710 Angle RH Rear (22’ deck)54 7115183664 Carriage Bolt, 0.50”-13NC x 4.50” 2055 8411080102 Extrusion 1056 4706006228 Plate 1057 7660182601 Locknut, 0.50”-13NC 20
Standard Duty Low Profile Carrier Parts Manual - Page 115-376-000140Rev 00 - 08/10
21’ deck shown
DECK - 6 TON ALUMINUM REMOVABLE RAIL LOW PROFILE (NGAR6T-LP)
2
1
21
01
05
25
41
41
75
65
55
45
1115 31
352
Standard Duty Low Profile Carrier Parts Manual - Page 125-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
DECK - 6 TON ALUMINUM TRANSPORTER LOW PROFILE (NGAT6T-LP)
ITEM PART NO. DESCRIPTION QTY1 3097000679 21’ Deck - 95” wide 1
3097000680 21’ Deck - 102” wide3097000785 22’ Deck - 95” wide3097000786 22’ Deck - 102” wide
2 7679000017 Chain Tray Mat 23 Contact Parts Keruing Board A/R4 7786000007 Screw, 0.31”-18NC x 2.00” A/R
Standard Aluminum Removable Rails:
10 3017000121 Angle Assembly LH Front 111 3017000122 Angle Assembly RH Front 112 3017000129 Angle Assembly LH Rear (21’ deck) 1
3017000131 Angle Assembly LH Rear (22’ deck)13 3017000130 Angle Assembly RH Rear (21’ deck) 1
3017000132 Angle Assembly RH Rear (22’ deck)14 7120000005 Capscrew, 0.50”-13NC x 2.50” 10
Parts Breakdown of Angle Assemblies50 4017001699 Angle LH Front 151 4017001700 Angle RH Front52 4017001707 Angle LH Rear (21’ deck) 1
4017001709 Angle LH Rear (22’ deck)53 4017001708 Angle RH Rear (21’ deck)
4017001710 Angle RH Rear (22’ deck)54 7115183664 Carriage Bolt, 0.50”-13NC x 4.50” 2055 8411080102 Extrusion 1056 4706006228 Plate 1057 7660182601 Locknut, 0.50”-13NC 20
Standard Duty Low Profile Carrier Parts Manual - Page 135-376-000140Rev 00 - 08/10
DECK - 6 TON ALUMINUM TRANSPORTER LOW PROFILE (NGAT6T-LP)
21’ deck shown
2
2
1
21
01
05
25
41
41
75
65
55
45
11
15
31
35
3
4
Standard Duty Low Profile Carrier Parts Manual - Page 145-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY1 3097000745 21’ Deck - 95” wide 1
3097000649 21’ Deck - 102” wide3097000773 22’ Deck - 95” wide3097000774 22’ Deck - 102” wide
DECK - 6 TON STEEL REMOVABLE RAIL LOW PROFILE (SRR6T-LP)
ITEM PART NO. DESCRIPTION QTYStandard Steel Tubular Removable Rails:
10 3017000282 Rail Weldment Front 211 3017000283 Rail Weldment Rear 212 7115181050 Capscrew, 0.50”-13NC x 1.25” 1013 7701000033 End Cap 4
Optional Aluminum Removable Rails:
20 3017000121 Angle Assembly LH Front 121 3017000122 Angle Assembly RH Front 122 3017000129 Angle Assembly LH Rear (21’ deck) 1
3017000131 Angle Assembly LH Rear (22’ deck)23 3017000130 Angle Assembly RH Rear (21’ deck) 1
3017000132 Angle Assembly RH Rear (22’ deck)24 7120000005 Capscrew, 0.50”-13NC x 2.50” 10
Parts Breakdown of Angle Assemblies50 4017001699 Angle LH Front 151 4017001700 Angle RH Front52 4017001707 Angle LH Rear (21’ deck) 1
4017001709 Angle LH Rear (22’ deck)53 4017001708 Angle RH Rear (21’ deck)
4017001710 Angle RH Rear (22’ deck)54 7115183664 Carriage Bolt, 0.50”-13NC x 4.50” 2055 8411080102 Extrusion 1056 4706006228 Plate 1057 7660182601 Locknut, 0.50”-13NC 20
Standard Duty Low Profile Carrier Parts Manual - Page 155-376-000140Rev 00 - 08/10
21’ deck shown with standard removable steel rails on left side and optional aluminum removable rails on right side
DECK - 6 TON STEEL REMOVABLE RAIL LOW PROFILE (SRR6T-LP)
42
21
12 35
32
15
31
01
11
31
1
45
75
65
55
)NWOHS(-MULA TNORF H R02 MULA TNORF H L
)NWOHS(-MULA RAER H RMULA RAER H L22
25
05
)NWOHS(-MULA RAER H RMULA RAER H L
)NWOHS(-MULA TNORF H RMULA TNORF H L
Standard Duty Low Profile Carrier Parts Manual - Page 165-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
DECK - 6 TON STEEL LOW PROFILE SHARK (SRRD6T-LP)
ITEM PART NO. DESCRIPTION QTY1 3097000751 21’ Deck - 95” wide 1
3097000723 21’ Deck - 102” wide3097000775 22’ Deck - 95” wide3097000776 22’ Deck - 102” wide
2 3017000139 Angle Assembly LH (21’ deck) 13017000142 Angle Assembly LH (22’ deck)
3 3017000140 Angle Assembly RH (21’ deck) 13017000143 Angle Assembly RH (22’ deck)
4 7120000005 Capscrew, 0.50”-13NC x 2.50” 10
Parts Breakdown of Angle Assemblies50 4017001717 Angle LH (21’ deck) 1
4017001740 Angle LH (22’ deck)51 4017001718 Angle RH (21’ deck) 1
4017001741 Angle RH (22’ deck)52 7115183664 Carriage Bolt, 0.50”-13NC x 4.50” 2053 8411080102 Extrusion 1054 4706006228 Plate 10
7660182601 Locknut, 0.50”-13NC 20
Standard Duty Low Profile Carrier Parts Manual - Page 175-376-000140Rev 00 - 08/10
DECK - 6 TON STEEL LOW PROFILE SHARK (SRRD6T-LP)
21’ deck shown
3
15
2
05
4
4
25
35
4555
1
7
6
9
8
9
85
7
Standard Duty Low Profile Carrier Parts Manual - Page 185-376-000140Rev 00 - 08/10
DECK - 6 TON STEEL TRANSPORTER LOW PROFILE (STRB6T-LP)
ITEM PART NO. DESCRIPTION QTY
1 3097000728 21’ Deck - 95” wide 13097000729 21’ Deck - 102” wide3097000783 22’ Deck - 95” wide3097000784 22’ Deck - 102” wide
2 Contact Parts Keruing Board A/R3 7786000007 Screw, 0.31”-18NC x 2.00” A/R
ITEM PART NO. DESCRIPTION QTYStandard Steel Tubular Removable Rails:
10 3729000282 Rail Weldment Front (21 & 22’ decks) 211 3729000283 Rail Weldment Rear (21’ & 22’ decks) 212 7115181050 Capscrew, 0.50”-13NC x 1.25” 1013 7701000033 End Cap 4
Optional Aluminum Removable Rails:
20 3017000121 Angle Assembly LH Front 121 3017000122 Angle Assembly RH Front 122 3017000129 Angle Assembly LH Rear (21 deck) 1
3017000131 Angle Assembly LH Rear (22’ deck)23 3017000130 Angle Assembly RH Rear (21 deck) 1
3017000132 Angle Assembly RH Rear (22’ deck)24 7120000005 Capscrew, 0.50”-13NC x 2.50” 10
Parts Breakdown of Angle Assemblies50 4017001699 Angle LH Front 151 4017001700 Angle RH Front52 4017001707 Angle LH Rear (21’ deck) 1
4017001709 Angle LH Rear (22’ deck)53 4017001708 Angle RH Rear (21’ deck)
4017001710 Angle RH Rear (22’ deck)54 7115183664 Carriage Bolt, 0.50”-13NC x 4.50” 2055 8411080102 Extrusion 1056 4706006228 Plate 1057 7660182601 Locknut, 0.50”-13NC 20
Standard Duty Low Profile Carrier Parts Manual - Page 195-376-000140Rev 00 - 08/10
DECK - 6 TON STEEL TRANSPORTER LOW PROFILE (STRB6T-LP)
21’ deck shown with optional removable steel rails on left side and optional aluminum removable rails on right side
42
2 1
1 2 3 5
3 2
1 5
3 1
0 1
1 1
3 1
1
4 5
7 5
6 5
5 5
) N W O H S ( - M U L A T N O R F H R 0 2 M U L A T N O R F H L
) N W O H S ( - M U L A R A E R H R M U L A R A E R H L 2 2
2 5
0 5
)N W O H S ( - M U L A R A E R H R M U L A R A E R H L
) N W O H S ( - M U L A T N O R F H R M U L A T N O R F H L
3 2
Standard Duty Low Profile Carrier Parts Manual - Page 205-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 3017000104 Roll Cylinder Angle 12 7115221650 Capscrew, 0.75”-10NC x 2.00” 43 7660222601 Nut, 0.75”-10NC, Nyloc 4
ADJUSTABLE ROLL CYLINDER BRACKET - DECK
Standard Duty Low Profile Carrier Parts Manual - Page 215-376-000140Rev 00 - 08/10
ADJUSTABLE ROLL CYLINDER BRACKET - DECK
2
3
1
Standard Duty Low Profile Carrier Parts Manual - Page 225-376-000140Rev 00 - 08/10
STANDARD DECK MOUNTED HEADBOARD
ITEM PART NO. DESCRIPTION QTY
1 1001129136 Standard Headboard Weld - 36.50” 1 Black Paint (w/ std remote free spool)
1001129137 Standard Headboard Weld - 36.50” Silver Paint (w/ std remote free spool)
1001129138 Standard Headboard Weld - 45.50” Black Paint (w/ std remote free spool)
1001129139 Standard Headboard Weld - 45.50” Silver Paint (w/ std remote free spool)
1001129144 Standard Headboard Weld - 45.50” Black Paint (w/ air remote free spool)
1001129145 Standard Headboard Weld - 45.50” Silver Paint (w/ air remote free spool)
1001129140 Standard Headboard Weld - 50.50” Black Paint (w/ std remote free spool)
1001129141 Standard Headboard Weld - 50.50” Silver Paint (w/ std remote free spool)
1001129146 Standard Headboard Weld - 50.50” Black Paint (w/ air remote free spool)
1001129148 Standard Headboard Weld - 50.50” Silver Paint (w/ air remote free spool)
1001129142 Standard Headboard Weld - 57.50” Black paint (w/ std remote free spool)
1001129143 Standard Headboard Weld - 57.50” Black paint (w/ std remote free spool)
1001129149 Standard Headboard Weld - 57.50” Black Paint (w/ air remote free spool)
1001129150 Standard Headboard Weld - 57.50” Silver Paint (w/ air remote free spool)
2 4796000037 Gasket 23 7105201650 Capscrew, 0.63”-18NF x 2.00” 44 7950200152 Flatwasher, 0.63” ID 45 7660200035 Nut, 0.63”-18NF 2
* included with Standard Headboard Weld
ITEM PART NO. DESCRIPTION QTY6 4686000295* Panel (36.50” or 45.50” headboard 1
w/ std remote free spool)4686000296* Panel (50.50” or 57.50” headboard
w/std remote free spool)4686000301* Panel (45.50” headboard
w/ air remote free spool)4686000302* Panel (50.50” or 57.50” headboard
w/ air remote free spool)7 4892000008* Tape (36.50” or 45.50” headboard) 48 7759000022* Pop Rivet 8
Standard Duty Low Profile Carrier Parts Manual - Page 235-376-000140Rev 00 - 08/10
STANDARD DECK MOUNTED HEADBOARD
1
2
6
8
53
4
4
37
7
8
Standard Duty Low Profile Carrier Parts Manual - Page 245-376-000140Rev 00 - 08/10
DELUXE DECK MOUNTED HEADBOARD
ITEM PART NO. DESCRIPTION QTY
1 1001129151 Deluxe Headboard Weld - 36.50” 1 Black Paint (w/ std remote free spool)
1001129152 Deluxe Headboard Weld - 36.50” Silver Paint (w/ std remote free spool)
1001129153 Deluxe Headboard Weld - 45.50” Black Paint (w/ std remote free spool)
1001129154 Deluxe Headboard Weld - 45.50” Silver Paint (w/ std remote free spool)
1001129159 Deluxe Headboard Weld - 45.50” Black Paint (w/ air remote free spool)
1001129160 Deluxe Headboard Weld - 45.50” Silver Paint (w/ air remote free spool)
1001129155 Deluxe Headboard Weld - 50.50” Black Paint (w/ std remote free spool)
1001129156 Deluxe Headboard Weld - 50.50” Silver Paint (w/ std remote free spool)
1001129161 Deluxe Headboard Weld - 50.50” Black Paint (w/ air remote free spool)
1001129162 Deluxe Headboard Weld - 50.50” Silver Paint (w/ air remote free spool)
1001129157 Deluxe Headboard Weld - 57.50” Black Paint (w/ std remote free spool)
1001129158 Deluxe Headboard Weld - 57.50” Silver Paint (w/ std remote free spool)
1001129163 Deluxe Headboard Weld - 57.50” Black Paint (w/ air remote free spool)
1001129164 Deluxe Headboard Weld - 57.50” Silver Paint (w/ air remote free spool)
2 4796000037 Gasket 23 7105201650 Capscrew, 0.63”-18NF x 2.00” 44 7950200152 Flatwasher, 0.63” ID 45 7660200035 Nut, 0.63”-18NF 2
ITEM PART NO. DESCRIPTION QTY
6 4686000295* Panel (36.50” or 45.50” headboard 1 w/ std remote free spool)
4686000296* Panel (50.50” or 57.50” headboard w/ std remote free spool)
4686000301* Panel (45.50” headboard w/ air remote free spool)
4686000302* Panel (50.50” or 57.50” headboard w/ air remote free spool)
7 4892000008* Tape (36.50” or 45.50” headboard) 44892000009* Tape (50.50” or 57.50” headboard)
8 7759000022* Pop Rivet 89 3391000020 Screen Weld (36.50” headboard) 1
3391000021 Screen Weld (45.50” headboard)3391000017 Screen Weld (50.50” headboard)3391000022 Screen Weld (57.50” headboard)
10 4796000003 Gasket 111 7759000015 Rivet 6
* included with Deluxe Headboard Weld
Standard Duty Low Profile Carrier Parts Manual - Page 255-376-000140Rev 00 - 08/10
DELUXE DECK MOUNTED HEADBOARD
1
2
6
8
53
44
3
7
7
8
9
11
01
Standard Duty Low Profile Carrier Parts Manual - Page 265-376-000140Rev 00 - 08/10
BUCKET REST HEADBOARD
ITEM PART NO. DESCRIPTION QTY
1 3636000078 Lightbar Mount 22 7115161050 Capscrew, 0.38"-16NC x 1.25" 43 7660161600 Locknut, 0.38"-16NC 44 7950160160 Flatwasher, 0.38” ID 4
Standard Duty Low Profile Carrier Parts Manual - Page 275-376-000140Rev 00 - 08/10
BUCKET REST HEADBOARD
1
12
2
2
3
4
4
4
4 4 4
Standard Duty Low Profile Carrier Parts Manual - Page 285-376-000140Rev 00 - 08/10
STATIONARY HEADBOARD
ITEM PART NO. DESCRIPTION QTY
1 1001129165 Stationary Headboard Weld - 57.00” 1 Black Paint
1001129166 Stationary Headboard Weld - 57.00” Silver Paint
1001129167 Stationary Headboard Weld - 62.00” Black Paint
1001129168 Stationary Headboard Weld - 62.00” Silver Paint
1001129169 Stationary Headboard Weld - 69.00” Black Paint
1001129170 Stationary Headboard Weld - 69.00” Silver Paint
2 7105181650 Capscrew, 0 .50”-20NF x 2.00” 83 7950180153 Flatwasher, 0.50” ID 84 7660182333 Locknut, 0.50”-20NF 85 3391000014 Screen Weld (57.00” headboard) 1
3391000017 Screen Weld (62.00” headboard)3391000018 Screen Weld (69.00” headboard)
6 4796000003 Gasket 17 7759000015 Rivet 68 4705000607 Shim - 0.25” A/R9 4705000608 Shim - 0.12” A/R
Standard Duty Low Profile Carrier Parts Manual - Page 295-376-000140Rev 00 - 08/10
STATIONARY HEADBOARD
12
2
934
8
5
6
7
7
7
Standard Duty Low Profile Carrier Parts Manual - Page 305-376-000140Rev 00 - 08/10
WORM GEAR WINCH
ITEM PART NO. DESCRIPTION QTY
1 7970000121 Winch - 8,000 lb Worm Gear 1 (w/ std remote free spool)
7970000142 Winch - 8,000 lb Worm Gear (w/ air remote free spool)
7970000123 Winch - 10,000 lb Worm Gear (w/ std remote free spool)
7970000140 Winch - 10,000 lb Worm Gear (w/ air remote free spool)
2 7626000014 Orbit Motor 13 7115181250 Capscrew, 0.50”-13NC x 1.50” 24 7950180400 Lockwasher, 0.50” ID 25 7115181464 Carriage Bolt, 0.50”-13NC x 1.75” 3
(steel decks)7115182864 Carriage Bolt, 0.50”-13NC x 3.5”
(steel transporters)7115181864 Carriage Bolt, 0.50”-13NC x 2.25“
(aluminum decks)7115183264 Carriage Bolt, 0.50”-13NC x 4.00”
(aluminum transporters)6 7115181864 Carriage Bolt, 0.50”-13NC x 2.25” 1
(steel decks)7115183264 Carriage, 0.50”-13NC x 4.00”
(steel transporters)7115182264 Carriage Bolt, 0.50”-13NC x 2.75”
(aluminum decks)7115183664 Capscrew, 0.50”-13NC x 4.50”
(aluminum transporters)7 7950180153 Flatwasher, 0.50” ID 48 7660182601 Locknut, 0.50”-13NC 49 4062000318 Bar (transporters only) 2
10 7248000063 Cable, 0.38” dia x 56’ (8,000lb winch) 17248000064 Cable, 0.44” dia x 56’ (10,000lb winch)
Refer to manufacturer’s manual for winch parts list
Standard Duty Low Profile Carrier Parts Manual - Page 315-376-000140Rev 00 - 08/10
9
3
41
8
7
2
5
6
55
WORM GEAR WINCH
8,000 lb winch shown on transporter deck
Item #10, Winch Cable, not shown
Standard Duty Low Profile Carrier Parts Manual - Page 325-376-000140Rev 00 - 08/10
WORM GEAR WINCH CABLE ROLLER GUIDE / TENSIONER PLATE
ITEM PART NO. DESCRIPTION QTY
1 3178000433* Bracket Weld 12 7115181464 Carriage Bolt, 0.50”-13NC x 1.75” 43 7950180153 Flatwasher, 0.50” ID 44 7660182601 Locknut, 0.50”-13NC 45 4706003766 Plate 16 7843000035 Spring 27 4912000130* Roller 18 4806000014* Shaft 19 4912000394* Roller 2
10 4806000011* Shaft 211 7209000011* Bushing 612 7949000034* Spacer 413 7754000022* Retaining Ring 6
* also available in Cable Guide / Tensioner Assembly, P/N 2249000017
Standard Duty Low Profile Carrier Parts Manual - Page 335-376-000140Rev 00 - 08/10
WORM GEAR WINCH CABLE ROLLER GUIDE / TENSIONER PLATE
8,000 lb winch shown
56
10
13
13
2
1
11
11
9
2
7
11
13
12
12
8
3
4
Standard Duty Low Profile Carrier Parts Manual - Page 345-376-000140Rev 00 - 08/10
MANUAL REMOTE FREE SPOOL - DECK MOUNTED HEADBOARD
ITEM PART NO. DESCRIPTION QTY
1 4587000004* Lever 12 4209000328* Bushing 13 7082000010* Nylon Washer 24 7950180161* Flatwasher, 0.50” ID 15 7309000002* Coupling 16 7691000046* Clevis Pin 17 7660182631* Locknut, 0.50”-20NF 18 7950180143* Flatwasher, 0.50” ID 29 4763000348* Rod 1
10 7660180234* Nut, 0.50”-20NF 111 4178000673* Bracket 112 7115150850* Capscrew, 0.31”-18NC x 1.00” 213 7950150161* Flatwasher, 0.31” ID 414 7660152601* Locknut, 0.31”-18NC 215 4209000147* Bushing (worm gear winch) 1
4209000145* Bushing (planetary gear winch)16 7690051274* Pin 217 7949000030* Nylon Washer 118 7843000027* Spring 119 7551000017* Knob 120 4632000009* Trim Lok 1
* also available in complete Remote Free Spool Installation: P/N 2970000021 for 8,000 / 10,000 lb worm gear winch P/N 2970000019 for 8,000 lb planetary gear winch
Standard Duty Low Profile Carrier Parts Manual - Page 355-376-000140Rev 00 - 08/10
1
3
2
3
4
5
6
7
8
89
01
11
21
31
3141
51
61
61
7181
91
02
MANUAL REMOTE FREE SPOOL - DECK MOUNTED HEADBOARD
Standard Duty Low Profile Carrier Parts Manual - Page 365-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 4587000005*# Lever 12 4209000328*# Bushing 13 7082000010*# Nylon Washer 24 7950180161*# Flatwasher, 0.50” ID 15 7309000002*# Coupling 16 7691000046*# Clevis Pin 17 7660182631*# Locknut, 0.50”-20NF 18 7950180143*# Flatwasher, 0.50” ID 29 4763000348*# Rod 1
10 7660180234*# Locknut, 0.50”-20NF 111 4178000674* Bracket (steel decks) 1
4017001499# Bracket (aluminum decks)12 4178000673*# Bracket 113 7115150850*# Capscrew, 0.31”-18NC x 1.00” 214 7950150161*# Flatwasher, 0.31” ID 415 7660152601*# Locknut, 0.31”-18NC 216 4209000147*# Bushing (worm gear winch) 1
4209000145*# Bushing (planetary gear winch)17 7690051274*# Pin 218 7949000030*# Nylon Washer 119 7843000027*# Spring 120 7551000017*# Knob 1
* also available in complete Remote Free Spool Installation - steel deck: P/N 2970000052 for 8,000 / 10,000 lb worm gear winch P/N 2970000050 for 8,000 lb planetary gear winch
# also available in complete Remote Free Spool Installation - aluminum deck : P/N 2970000053 for 8,000 / 10,000 lb worm gear winch P/N 2970000051 for 8,000 lb planetary gear winch
MANUAL REMOTE FREE SPOOL - STATIONARY HEADBOARD
Standard Duty Low Profile Carrier Parts Manual - Page 375-376-000140Rev 00 - 08/10
MANUAL REMOTE FREE SPOOL - STATIONARY HEADBOARD
1
2
3
3
4
5
6
7
8
8
9
01
11
21
3141
51
61
71
81
81
91
71
02
Standard Duty Low Profile Carrier Parts Manual - Page 385-376-000140Rev 00 - 08/10
MANUAL REMOTE AIR FREE SPOOL
ITEM PART NO. DESCRIPTION QTY
1 7565000014 Air line Tubing *2 7935000182 Air Valve 23 7443000364 Fitting 54 7640000002 Air Exhaust Muffler 25 7443000154 Fitting 16 7443000111 Fitting 17 7443000156 Nipple 28 7935000120 Pressure Protection Valve 19 7443000152 Plug 1
10 7443000366 Fitting 111 7935000248 Air Regulator 112 7443000371 Tee 113 7443000365 Fitting 214 8597650001 Loom *15 7935000229 Shuttle Valve 116 7894000004 Tie Strap *17 7443000443 Union 118 7565000016 Airline Tubing *
* - Quantity varies depending on deck length and chassis
Standard Duty Low Profile Carrier Parts Manual - Page 395-376-000140Rev 00 - 08/10
Item #16, Tie Strap, not shown
MANUAL REMOTE AIR FREE SPOOL
LYC RIATROP
TELNI RIATROP
TSUAHXETROP
NWOD SEHCTIWS HTOBHCTULC HCNIW NEHW
DEGAGNE SI)LOOPS EERF TON(
LYC RIATROP
TELNI RIATROP
TSUAHXETROP
KCED NIAM HCNIW
ROF NWOHSNEREFER CE
MORF YLPPUS RIASISSAHC KCURT
351
31 31
3
4
32
21
81
1 1
1
89
11
01
7
56
7
71
1
1 1
2
3
41
3
Standard Duty Low Profile Carrier Parts Manual - Page 405-376-000140Rev 00 - 08/10
SUBFRAME
ITEM PART NO. DESCRIPTION QTY
1 3868000316 Subframe Weld - Standard 13868000318 Subframe Weld - Galvanized
2 3905000014 Trunnion Weld 13 7950160161 Flatwasher, 0.38 ID 14 3320000238 Roll Cylinder Assembly 15 3320000122 Tilt Cylinder Assembly 26 4178000805 Bracket 27 7949000008 Washer, 2.25” ID 28 4691000573 Pin 29 7115162450 Capscrew, 0.38”-16NC x 3.00” 2
10 7660162601 Locknut, 0.38”-16NC 711 7118161026 Capscrew, 0.38”-16NC x 1.25” 112 7189000026 Bumper, Polyurethane 413 7114141450 Capscrew, 0.25”-20NC x 1.75” 214 7660142604 Locknut, 0.25”-20NC 215 7950140143 Flatwasher, 0.25” ID 616 7660222601 Locknut, 0.75”-10NC 417 3691000092 Pin Weld 218 7115221650 Capscrew, 0.75”-10NC x 2.00” 419 7950180153 Flatwasher, .050” ID 1220 7660102604 Locknut, #10-24NC 221 7115161050 Capscrew, 0.38”-16NC x 1.25” 422 4209000337 Bushing 823 3636000144 Mount, Roll Trunnion 224 7701000048 Plug 425 7660202347 Locknut, 0.63”-18NF 826 7114100818 Capscrew, #10-24NC x 1.00” 227 4706006405 Plate, Tray 128 3691000273 Pin Weld 229 7115180650 Capscrew, 0.50”-13NC x 0.75” 230 7949000072 Washer, 0.50 ID 2
ITEM PART NO. DESCRIPTION QTY
31 7950200242 Flatwasher, 0.63 ID 832 7105201850 Capscrew, 0.63”-18NF x 2.25” 833 4209000358 Bushing 234 7115181464 Carriage Bolt, 0.50”-13NC x 1.75” 435 7660182601 Locknut, 0.50”-13NC 8
Standard Duty Low Profile Carrier Parts Manual - Page 415-376-000140Rev 00 - 08/10
SUBFRAME
1010
78
87
6
10
281710
22
22
21
21
1
2
4
5
5
6
10
12
12
1313
14 1415
15
15
33
23
20
24
24
24
25
25
29
3029
29
3132
3231
18
19
18
3519 35
19
1616
3434
34 34
2726
43
43
3
11
30
9
9
23
1935 19
35
Standard Duty Low Profile Carrier Parts Manual - Page 425-376-000140Rev 00 - 08/10
HOLD DOWN
ITEM PART NO. DESCRIPTION QTY1 3558000019* Hold Down Weld 12 4017001271 Angle 23 7105181650 Capscrew, 0.50”-20NF x 2.00” 84 7950180153 Flatwasher, 0.50” ID 85 7660182333 Locknut, 0.50”-20NF 46 4679000332 Wear Pad 27 7274000125 Clamp 88 7120000032 Screw, 0.38”-16NF x 1.75” 89 7701000063 Plug 4
10 4679000221* Wear Pad 211 4812000071* Shim - 0.12” 212 4812000072* Shim - 0.06” 213 7114151218* Capscrew, 0.31”-18NC x 1.50” 414 7660152601* Locknut, 0.31”-18NC 4
* also available in Hold Down Assembly, P/N 3558000019
Standard Duty Low Profile Carrier Parts Manual - Page 435-376-000140Rev 00 - 08/10
HOLD DOWN
3
4
2
5
01
6
7
8
5
3
4
21
41
9
9
1
31
11
Standard Duty Low Profile Carrier Parts Manual - Page 445-376-000140Rev 00 - 08/10
SLIDE PAD
ITEM PART NO. DESCRIPTION QTY
1 4679000145 Wear Pad 142 7118161026 Screw, 0.38”-16NC x 1.25” 424 7660162601 Locknut, 0.38”-16NC 42
Standard Duty Low Profile Carrier Parts Manual - Page 455-376-000140Rev 00 - 08/10
SLIDE PAD
1
1
1
1
1
1
2
2
2
2
2
2
2
33
Standard Duty Low Profile Carrier Parts Manual - Page 465-376-000140Rev 00 - 08/10
MUD FLAP
ITEM PART NO. DESCRIPTION QTY
1 7638000004 Mud Flap 22 4017001742 Plate, LH 13 4017001743 Plate, RH 14 4706006427 Plate 25 7111150864 Carriage Bolt, 0.31”-18NC x 1.00” 86 7660152601 Locknut, 0.31”-18NC 147 7114150818 Capscrew, 0.31”-18NC x 1.00” 68 7950150153 Flat Washer, 0.31” ID 6
Standard Duty Low Profile Carrier Parts Manual - Page 475-376-000140Rev 00 - 08/10
MUD FLAP
67
5
6
41
68
7
2
3
Standard Duty Low Profile Carrier Parts Manual - Page 485-376-000140Rev 00 - 08/10
LIGHTBOXES
ITEM PART NO. DESCRIPTION QTY1 4314000235 Coverplate - Standard 1
4314000072 Coverplate - Galvanized 22 7114140529 Screw, 0.25”-20NC x 0.63” 83 7661000042 U-Nut, 0.25”-20NC 84 7949000023 Nylon Washer, 0.26” ID 85 3178000544 Lightbox - LH 16 3178000545 Lightbox - RH 17 7114150818 Capscrew, 0.31”-18NC x 1.00” 88 7950150153 Flatwasher, 0.31” ID 89 7660152601 Locknut, 0.31”-18NC 8
10 4314000232 Coverplate - Standard 14178000863 Bracket - Galvanized
Standard Duty Low Profile Carrier Parts Manual - Page 495-376-000140Rev 00 - 08/10
10(STD)
6
5
1(GALV)
2
2
2 2
7
3
4
4
4 4
3
9
8
9 8
7
98
9
8
7
2 4
2 4
10(GALV)
3
3
24
24
7
1(STD & GALV)
LIGHTBOXES
Standard Duty Low Profile Carrier Parts Manual - Page 505-376-000140Rev 00 - 08/10
FINAL ASSEMBLY
ITEM PART NO. DESCRIPTION QTY1 3190000058 Bumper Tube Weld - Short - Standard 2
3190000060 Bumper Tube Weld - Short - Galvanized2 7115181064 Carriage Bolt, 0.50”-13NC x 1.25” 83 7660182601 Locknut, 0.50”-13NC 84 7493000023 Grommet 35 7590000343 Marker Light - Red (LED) 46 7590000341 Stop/Tail/Turn Light - Red (LED) 27 7493000010 Grommet 18 7590000103 License Plate Light 19 7011000007 Back-Up Alarm 1
10 7114140528 Screw, 0.25”-20NC x 0.63” 211 7949000023 Nylon Washer, 0.26” ID 1012 7660142601 Locknut, 0.25-20NC 213 7493000002 Grommet 414 7590000340 Marker Light - Red (LED) 315 7493000009 Grommet 416 7590000113 Back-Up Light - White (Std) 217 7701000049 Plug 118 7701000055 Plug 219 7661000064 U-Nut Clip, 0.25”-20NC 820 4314000200 Cover Plate - Standard 2
4314000204 Cover Plate - Galvanized21 7950140000 Lockwasher, 0.25" ID 822 7115140850 Capscrew, 0.25”-20NC x 1.00” 823 7330000428 Reflective Tape 224 7679000020 Non-Skid Pad 2
Standard Duty Low Profile Carrier Parts Manual - Page 515-376-000140Rev 00 - 08/10
FINAL ASSEMBLY
1
1
32
23
24
4
14
9
5
15
5
7
8
6
16
13
15
10
11
12
11
12
18 17
181920
2111
22
Standard Duty Low Profile Carrier Parts Manual - Page 525-376-000140Rev 00 - 08/10
HYDRAULIC RESERVOIR AND TOOLBOX / BASKET
ITEM PART NO. DESCRIPTION QTY*
1 4178000331 Mounting Bracket - Short4178000291 Mounting Bracket - Std4178000339 Mounting Bracket - Long
2 4178000330 Mounting Bracket - Short4178000290 Mounting Bracket - Std4178000338 Mounting Bracket - Long
3 3750000018 Hydraulic Reservoir Assembly4 7183000004+ Breather Filler Cap Assembly5 7470000027+ Level Gauge6 7430000014+ Strainer7 7105181650 Capscrew, 0.50”-20NF x 2.00”8 7950180153 Flat Washer, 0.50” ID9 7660182333 Locknut, 0.50”-20NF
10 7115150850 Capscrew, 0.31”-18NC x 1.00”11 7950150161 Flatwasher, 0.31” ID12 7660152601 Locknut, 0.31”-18NC13 3899000130 Toolbox Assembly - 36” x 18” x 18”
3899000131 Toolbox Assembly - 36” x 18” x 14”3899000132 Toolbox Assembly - 48” x 18” x 18”3899000133 Toolbox Assembly - 60” x 18” x 18”3899000172 Toolbox Assembly - 78” x 21” X 20”
14 4679000256^ Rubber Pad (36” toolbox)4679000257^ Rubber Pad (48” toolbox)4679000258^ Rubber Pad (60” toolbox)4679000322^ Rubber Pad (78” toolbox)
15 7118181216 Capscrew, 0.50”-13NC x 1.50”16 7660182301 Locknut, 0.50”-13NC17 4706002361 Plate18 4017000777 High Mount Angle19 3899000053 Basket - 15” deep
3899000075 Basket - 24” deep
* Quantities vary depending on Hydraulic Tank / Toolbox / Basket mounting configuration.
+ also available in Hydraulic Reservoir Assembly, P/N 3750000018^ included in Toolbox Assembly
ITEM PART NO. DESCRIPTION QTY*
20 4632000015 Moulding - 15” deep basket4632000048 Moulding - 24” deep basket
21 7002000410 Stainless Steel Cover Plate for Basket includes rivets
22 3178000566 Bracket Weldment23 7701000051 Plug
Standard Duty Low Profile Carrier Parts Manual - Page 535-376-000140Rev 00 - 08/10
HYDRAULIC RESERVOIR AND TOOLBOX / BASKET
Item #14, Toolbox Rubber Pad, not shown
Y L N O K N A T C I L U A R D Y H X O B L O O T " 6 3
R I O V R E S E R C I L U A R D Y H / w
1
5
6
9
8 7
2 1
1 1 4
0 1 2
3
1 1
0 1
9
5 1
3
3 1
2 1
8 7
6 1
5 1 1
2
1 1
1 1
Standard Duty Low Profile Carrier Parts Manual - Page 545-376-000140Rev 00 - 08/10
HYDRAULIC RESERVOIR AND TOOLBOX / BASKET
Item #14, Toolbox Rubber Pad, not shown
60" TOOLBOX
w/ HYDRAULIC RESERVOIR
MOUNTED ON DRIVER SIDE
1
2
9
15
7
8
16
8
7
1
12
3
13
11
10
9
60" TOOLBOX
w/ HYDRAULIC RESERVOIR
MOUNTED ON PASSENGER SIDE
9
1516
9
2
87
1011
17
18
7
12
11
10
3
13
1
FRONT
FRONT
11
Standard Duty Low Profile Carrier Parts Manual - Page 555-376-000140Rev 00 - 08/10
HYDRAULIC RESERVOIR AND TOOLBOX / BASKET
TNUOM DRADNATS - XOBLOOT "87RIOVRESER CILUARDYH /wEDIS REVIRD NO DETNUOM
TNUOM ETANRETLA - XOBLOOT "87RIOVRESER CILUARDYH /wEDIS REVIRD NO DETNUOM
518761
22
618
7
9
51
87
61
1
2
931
51
1
51
9
99
22
22
61
87
61
51
8
7
61
51
78
1
932
32
32
32
Standard Duty Low Profile Carrier Parts Manual - Page 565-376-000140Rev 00 - 08/10
HYDRAULIC RESERVOIR AND TOOLBOX / BASKET
Items #14, Toolbox Rubber Pad and #21, Stainless Cover for Basket, not shown
36" HIGH MOUNT TOOLBOX
w/ HYDRAULIC RESERVOIR
36" BASKET
9
131
11
12
11
10
12
18
7
8
3
15
18
2
2
12
9
8
7
1
20
19
10
11
10
11
Standard Duty Low Profile Carrier Parts Manual - Page 575-376-000140Rev 00 - 08/10
THIS PAGE INTENTIONALLY LEFT BLANK
Standard Duty Low Profile Carrier Parts Manual - Page 585-376-000140Rev 00 - 08/10
TOOLBOX
Quantities listed are for one toolbox
ITEM PART NO. DESCRIPTION QTY
1 3899000125 Toolbox Weld (36” toolbox) 13899000126 Toolbox Weld (36” narrow toolbox)3899000128 Toolbox Weld (60” toolbox) 13899000127 Toolbox Weld (48” toolbox) 13899000173 Toolbox Weld (78” toolbox) 1
2 4679000256 Rubber Pad (36” toolbox) 14679000257 Rubber Pad (36” narrow toolbox) 14679000258 Rubber Pad (48” toolbox) 14679000259 Rubber Pad (60” toolbox) 14679000322 Rubber Pad (78” toolbox) 1
3 4796000009 Gasket (36” toolbox) 14796000010 Gasket (48” toolbox) 14796000011 Gasket (60” toolbox) 14796000012 Gasket (78” toolbox) 2
4 9899000014 Toolbox Door Assembly (36” toolbox) 19899000015 Toolbox Door Assembly (48” toolbox) 19899000016 Toolbox Door Assembly (60” toolbox) 19899000023 Toolbox Door Assembly (78” toolbox) 1
ITEM PART NO. DESCRIPTION QTY
Toolbox Door Assembly Components (per door)
101 4706005020 Toolbox Door (36” toolbox) 14706005021 Toolbox Door (48” toolbox) 14706005022 Toolbox Door (60” toolbox) 14706006234 Toolbox Door (78” toolbox) 1
102 7585000019^ Latch (36” & 78”) 17585000019^ Latch (48” & 60”) 2
103 7555000016* Hinge (36” & 78” toolbox) 17555000016* Hinge (60” toolbox) 27555000015* Hinge (48” toolbox) 1
104 7759000020*^ Rivet (36” & 78” toolbox) 187759000020*^ Rivet (48” toolbox) 287759000020*^ Rivet (60” toolbox) 36
105 4178000599* Bracket 2106 7114140465* Carriage Bolt, 0.25”-20NC x 0.50” 4107 7660142604* Locknut, 0.25”-20NC 4108 7592000005^ S Link (36”, 48”, 60” toolbox) 4
7592000005^ S Link (78” toolbox) 8109 7248000114^ Cable (36”, 48” & 60” toolbox) 2
7248000155^ Cable (78” toolbox) 4
* Also available in Toolbox Door Sub Assembly: 9899000020 - 36” Toolbox 9899000021 - 48” Toolbox 9899000022 - 60” Toolbox 9899000024 - 78” Toolbox
^ Also available in Toolbox Door Hardware Kit: 9577030278 - 36” Toolbox 9577030279 - 48” Toolbox 9577030280 - 60” Toolbox 9577030303 - 78” Toolbox
Standard Duty Low Profile Carrier Parts Manual - Page 595-376-000140Rev 00 - 08/10
TOOLBOX
36” Toolbox shown
24
201
601
301
901
701
501
401
3
801
101
1
Standard Duty Low Profile Carrier Parts Manual - Page 605-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 4017001403 Angle 22 4811000841 Shelf (36” toolbox) 1
4811000843 Shelf (48” toolbox)4811000868 Shelf (60” toolbox)
3 7115150850 Capscrew, 0.31”-18NC x 1.00” 44 7950150161 Flatwasher, 0.31” ID 85 7660152601 Locknut, 0.31”-18NC 4
TOOLBOX SHELF
Standard Duty Low Profile Carrier Parts Manual - Page 615-376-000140Rev 00 - 08/10
1
1
2
3
4
3
4
4
5
45
TOOLBOX SHELF
36” Toolbox shown
Standard Duty Low Profile Carrier Parts Manual - Page 625-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 4178000578* Bracket 12 7590000273* Dome Lamp 13 7870000115* Switch 14 7280000007* Wire Mount Clip 35 7661000047* Panel Nut 46 7790100856* Screw, #10 x 0.50” 47 7443000377 Fitting 18 7552000297 Toolbox Light Harness 1
TOOLBOX LIGHT
* included in Toolbox Light Bracket Assembly
Standard Duty Low Profile Carrier Parts Manual - Page 635-376-000140Rev 00 - 08/10
1
2
3 4
5
5
6
6
7
TOOLBOX LIGHT
Item #8, Toolbox Light Harness, not shown48” Toolbox Shown
Standard Duty Low Profile Carrier Parts Manual - Page 645-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 3811000053 Tray Weldment (36” Toolbox) 13811000054 Tray Weldment (48” Toolbox)3811000055 Tray Weldment (60” Toolbox)3811000057 Tray Weldment (78” Toolbox)
2 4706006216 Plate 23 7115160950 Capscrew, 0.38”-16NC x 1.12” 44 7950150161 Flat Washer, 0.38” ID 85 7660162601 Locknut, 0.38”-16NC 46 7493000009 Grommet 27 7493000031 Marker Light - Amber (LED) 28 7493000031 Grommet 29 7552000451 Toolbox Light Tray Harness 1
10 7894000004 Tie Strap 6
TOOLBOX TOP STOWAGE TRAY AND MARKER LIGHTS
Standard Duty Low Profile Carrier Parts Manual - Page 655-376-000140Rev 00 - 08/10
TOOLBOX TOP STOWAGE TRAY AND MARKER LIGHTS
7
6
8
5
4
43
34
1
8
67
2
45
2
WEIV POT
9 01
Standard Duty Low Profile Carrier Parts Manual - Page 665-376-000140Rev 00 - 08/10
DUAL CONTROLS - 3 BANK
ITEM PART NO. DESCRIPTION QTY
1 4263000431 Channel 12 7950180161 Flatwasher, 0.50” ID 43 7660182601 Locknut, 0.50”-13NC 44 4263000430 Channel 15 7790151253 Screw, 0.31”-18NC x 0.75” 126 3935000115 Control Valve 17 7111161050 Capscrew, 0.38”-16NC x 1.25” 48 7950160161 Flatwasher, 0.38” ID 49 7660162601 Locknut, 0.38”-16NC 4
10 4763000280 Control Rod 311 4763000279 Control Rod 312 7690101200 Clevis Pin 313 7691000056 Cotter Pin 314 7115150850 Capscrew, 0.31”-18NC x 1.00” 915 7949000011 Flatwasher, 0.31” ID 916 4831000069 Spacer 917 7660152601 Locknut, 0.31”-18NC 1718 Not Required19 7115150664 Carriage Bolt, 0.31”-18NC x 0.75” 820 7950150000 Washer, 0.31” ID 821 7691000064 Pin 222 7754000009 Retaining Ring 423 7551000018 Control Handle 224 7551000020 Control Handle 225 7551000021 Control Handle 226 4211000001 Bushing 427 7950220141 Flatwasher, 0.75” ID 428 7560000008 Control Hood, LH 1
ITEM PART NO. DESCRIPTION QTY
29 7949000054 Washer, 0.34” ID 830 7330000648 Control Panel, LH 131 7330000649 Control Panel, RH 132 7759000006 Pop Rivet 833 7590000087 Lamp 234 7791060872 Screw, #6 x 0.50” 435 7280000007 Wire Clip 1136 4606000217 Lug 437 7560000007 Control Hood, RH 138 7470000023 Gauge 139 7661000057 Jam Nut, M5 2
Standard Duty Low Profile Carrier Parts Manual - Page 675-376-000140Rev 00 - 08/10
DUAL CONTROLS - 3 BANK
5242
32
22
91 1262 41
7161
5101
71
21
31
11
61
51
41
33
43
0323
5
92
02
71
2313
73
53
23
87
4 69
5
163
22
A
A
71
61
51
41
11
63
91
72
TNORF83
82
93
Standard Duty Low Profile Carrier Parts Manual - Page 685-376-000140Rev 00 - 08/10
DUAL CONTROLS - 4 BANK
ITEM PART NO. DESCRIPTION QTY
1 4263000431 Channel 12 7950180161 Flatwasher, 0.50” ID 43 7660182601 Locknut, 0.50”-13NC 44 4263000430 Channel 15 7790151253 Screw, 0.31”-18NC x 0.75” 126 3935000116 Control Valve 17 7111161050 Capscrew, 0.38”-16NC x 1.25” 48 7950160161 Flatwasher, 0.38” ID 49 7660162601 Locknut, 0.38”-16NC 4
10 4763000280 Control Rod 411 4763000279 Control Rod 412 7690101200 Clevis Pin 413 7691000056 Cotter Pin 414 7115150850 Capscrew, 0.31”-18NC x 1.00” 1215 7949000011 Flatwasher, 0.31” ID 1216 4831000069 Spacer 1217 7660152601 Locknut, 0.31”-18NC 2018 Not Required19 7115150664 Carriage Bolt, 0.31”-18NC x 0.75” 820 7950150000 Washer, 0.31” ID 821 7691000064 Pin 222 7754000009 Retaining Ring 423 7551000018 Control Handle 224 7551000020 Control Handle 425 7551000021 Control Handle 226 4211000001 Bushing 227 7950220141 Flatwasher, 0.75” ID 228 7560000008 Control Hood, LH 129 7949000054 Washer, 0.34” ID 8
ITEM PART NO. DESCRIPTION QTY
30 7330000650 Control Panel, LH (stabilizer) 131 7330000651 Control Panel, RH (stabilizer) 132 7759000006 Pop Rivet 833 7590000087 Lamp 234 7791060872 Screw, #6 x 0.50” 435 7280000007 Wire Clip 1136 4606000217 Lug 437 7560000007 Control Hood, RH 138 7470000023 Gauge 139 7661000057 Jam Nut, M5 2
Standard Duty Low Profile Carrier Parts Manual - Page 695-376-000140Rev 00 - 08/10
DUAL CONTROLS - 4 BANK
4333
92 5
0323
5 2313
73
53
2
3
784
69
1
0271
22
91
5242
3242
63
62 12
2263
91
4151
61
11
01
71
2131
4151
6171
A
A41
51
61
71
11
72
TNORF83
82
93
Standard Duty Low Profile Carrier Parts Manual - Page 705-376-000140Rev 00 - 08/10
DUAL CONTROLS - 5 BANK
ITEM PART NO. DESCRIPTION QTY
1 4263000431 Channel - Standard 14263000776 Channel - Galvanized
2 7950180161 Flatwasher, 0.50” ID 43 7660182601 Locknut, 0.50”-13NC 44 4263000430 Channel - Standard 1
4263000622 Channel - Galvanized5 7790151253 Screw, 0.31”-18NC x 0.75” 126 3935000117 Control Valve 17 7111161050 Capscrew, 0.38”-16NC x 1.25” 48 7950160161 Flatwasher, 0.38” ID 49 7660162601 Locknut, 0.38”-16NC 4
10 4763000280 Control Rod 511 4763000279 Control Rod 512 7690101200 Clevis Pin 513 7691000056 Cotter Pin 514 7115150850 Capscrew, 0.31”-18NC x 1.00” 1515 7949000011 Flatwasher, 0.31” ID 1516 4831000069 Spacer 1517 7660152601 Locknut, 0.31”-18NC 2318 Not Required19 7115150664 Carriage Bolt, 0.31”-18NC x 0.75” 820 7950150000 Washer, 0.31” ID 821 7691000064 Pin 222 7754000009 Retaining Ring 423 7551000018 Control Handle 224 7551000020 Control Handle 425 7551000021 Control Handle 426 7950220141 Flatwasher, 0.75” ID 227 7560000008 Control Hood, LH 128 7949000054 Washer, 0.34” ID 8
ITEM PART NO. DESCRIPTION QTY
29 7330000648 Control Panel, LH 130 7330000649 Control Panel, RH 131 7759000006 Pop Rivet 832 7590000087 Lamp 233 7791060872 Screw, #6 x 0.50” 434 7280000007 Wire Clip 1135 4606000217 Lug 436 7560000007 Control Hood, RH 137 7470000023 Gauge 138 7661000057 Jam Nut, M5 2
Standard Duty Low Profile Carrier Parts Manual - Page 715-376-000140Rev 00 - 08/10
DUAL CONTROLS - 5 BANK
3323
825
9213 7102
1
5
43
63
23
0313
4 71 6151
4101
71
3121
6151
41
22
911252
4232
4252
22
91
53
A
A
71
11
61
51
41
53
62
TNORF
96
87
73
72
83
Standard Duty Low Profile Carrier Parts Manual - Page 725-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - STANDARD
ITEM PART NO. DESCRIPTION QTY
1 See Note 1 PTO 12 7724000126 Pump 13 7115181050 Capscrew 24 7950180000 Lockwasher 25 7445081643 Adapter 16 7443000023 Elbow 17 7443000124 Adapter 18 See Note 1 Supply Hose 19 7443000013 Nipple 1
10 7274000002 Clamp 211 7430000003 Filter Assembly 112 7470000002 Gauge 113 7443000319 Fitting 114 7274000080 Clamp 215 See Note 1 Pressure Hose Assembly 116 See Note 1 Return Hose 117 7443000446 Adapter 118 7445081045 Elbow 319 7445060843 Adapter 420 7445080843 Adapter 221 4567123051* Hose Assembly 122 4567122024* Hose Assembly 123 4567122019 Hose Assembly 224 7935000306 Dual Counterbalance Valve 125 7445060643 Adapter 426 4570000379* Hose Assembly 427 4570000376* Hose Assembly 428 7445060645 Elbow 529 4569432122 Hose Assembly 130 4569433122 Hose Assembly 1
* included in Hose Kit, P/N 4577000013^ also available in Filter Assembly, P/N 7430000003
ITEM PART NO. DESCRIPTION QTY
31 4567430133 Hose Assembly 232 7431000001^ Filter Element 133 7445040443 Adapter 134 4567122039* Hose Assembly 135 7274000063 P-Clamp 136 7115140650 Capscrew, 0.25”-20NC x 0.75” 137 7950140141 Flatwasher, 0.25” ID 138 7660142601 Locknut, .025”-20NC 139 7912000349 Tube Assembly 440 7274000064 Clamp 641 3314000056 Coverplate 242 7115150450 Capscrew, 0.31”-18NC x 0.50” 643 7950160141 Flatwasher, 0.38” ID 6
Note 1: Varies depending on chassis, transmission , PTO type & deck length. Consult factory for part numbers.
Standard Duty Low Profile Carrier Parts Manual - Page 735-376-000140Rev 00 - 08/10
H R - R E D N I L Y C T L I T
R E D N I L Y C L L O R
H L - R E D N I L Y C T L I T
H C N I W
D Y H K N A T
E R U S S E R P E G U A G
F E R
V2
V1
1 A 2 A
1 B 2 B
L A U D B / C
K C O L B
R
S T R O P
S T R O P B
A
RO
LL
TILT
WIN
CH
P
C
1 3 4 2 5 6
7
8
9 01
2 1
1 1
2 3 3 1
4 1 6 1
8 2 9 3
8 2
7 2
8 2 7 2
8 2
4 2
6 2
6 2
6 2
3 2
6 2
8 1
1 3
8 1
1 3
5 1
0 3 9 2 5 2
8 2
1 2 7 1
8 1
9 1 9 1
0 2
0 2
9 1 9 1
4 3
3 3
8 3 5 3 6 3
7 3
4 3 # M E T I , E S O H E G U A G E R U S S E R P R O F P M A L C
9 3 5 2
5 2
5 2
5 2
3 2
2 2 7 2 7 2
See Next Page
HYDRAULIC COMPONENTS - STANDARD
Standard Duty Low Profile Carrier Parts Manual - Page 745-376-000140Rev 00 - 08/10
243414
04
93
93
HYDRAULIC COMPONENTS - STANDARD
Standard Duty Low Profile Carrier Parts Manual - Page 755-376-000140Rev 00 - 08/10
THIS PAGE INTENTIONALLY LEFT BLANK
Standard Duty Low Profile Carrier Parts Manual - Page 765-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - STANDARD (HOSE TRACK)
ITEM PART NO. DESCRIPTION QTY
1 7904000001 Hose Track 12 4706003038 Plate 13 7114101618 Capscrew 44 7660102604 Locknut, #10-24NC 45 7274000038 Clamp 46 7274000039 Clamp Cover 27 7115151650 Capscrew, 0.31”-18NC x 2.00” 28 7950150161 Flatwasher, 0.31” ID 49 7660152601 Locknut, 0.31”-18NC 8
10 7894000004 Tie Strap 1011 7935000306 Counterbalance Valve 112 7115151850 Capscrew, 0.31”-18NC x 2.50” 213 7274000066 Double Clamp 414 7280000013 Clip *
* Quantity varies depending on deck length and deck type.
Standard Duty Low Profile Carrier Parts Manual - Page 775-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - STANDARD (HOSE TRACK)
1 B
2 B
1 3
4
2
0 1
7
6
8 9
5
7
0 1 8 9 7 3
4
5
6
1
3 1
9
8 9
7 3 4
6 1
5
7 3 4
8 9
6 5
0 1
A
A
A - A N O I T C E S
B
B
B - B N O I T C E S
1 1
9 2 1
4 1 4 1
4 1
K C E D D O O W R E B M E M S S O R C
K C E D M U N I M U L A N O I S U R T X E
D O O W & L E E T S M A E B N I A M K C E D
Standard Duty Low Profile Carrier Parts Manual - Page 785-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - HOSE ROUTING / MOUNTING (FORD, GM & IHC)
ITEM PART NO. DESCRIPTION QTY
* Quantity varies depending on deck length and deck type
1 7274000076 Cast Frame Clamp *2 7785152420 Set Screw, 0.31”-18NC x 1.50” *3 7660152601 Locknut, 0.31”-18NC *4 7115151050 Capscrew, 0.31”-18NC x 1.25” *5 7950150161 Flatwasher, 0.31” ID *6 7274000040 Clamp *7 7274000041 Clamp *8 7274000042 Clamp *9 4706003844 Plate *
10 7115151064 Carriage Bolt, 0.31”-18NC x 1.25” *
Standard Duty Low Profile Carrier Parts Manual - Page 795-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - HOSE ROUTING / MOUNTING (FORD, GM & IHC)
TO PUMP
8
12
3
4
3
5
6
12
3
67 4
3
5
12
3
3
5
46
1 6
23
4
3
5
6
109
12
3
43
5
7
3
5 10
6
7
12
3
5
43
5
3
5
1
9
10
2
3
4
3
5
6
7
3
5
12
3
6
9
10
4
7
3
5
3
5
TYPICAL HOSE ROUTING / MOUNTING
Standard Duty Low Profile Carrier Parts Manual - Page 805-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - IRL WHEEL LIFT WITH MANUAL GRIDS
ITEM PART NO. DESCRIPTION QTY1 7443000129 Reducer 22 7445060648 Tee 43 4567123045 Hose Assembly 24 4567122043 Hose Assembly 25 7935000305 Counterbalance Valve 26 7445060645 Elbow 47 4567122014 Hose Assembly 28 7443040843 Adapter 29 4567110034 Hose Assembly 2
10 7445040446 Elbow 2
Standard Duty Low Profile Carrier Parts Manual - Page 815-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - IRL WHEEL LIFT WITH MANUAL GRIDS
5-SECTIONCONTROL VALVE
PORTS
PORTS
R
PB
A
BO
OM
WHEEL LIFTEXTEND / RETRACT
CYLINDER
RO
LL
TIL
T
WIN
CH
V
P
WHEEL LIFTRAISE / LOWERCYLINDER - RH
V
P
WHEEL LIFTRAISE / LOWERCYLINDER - LH
IRL
9
10
109
65
27
6
2 7 6
65
33
4
1
1
2
28
8
4
Standard Duty Low Profile Carrier Parts Manual - Page 825-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - HYDRAULIC REAR DOCK STABILIZER
ITEM PART NO. DESCRIPTION QTY
1 7445060843 Adapter 22 4567122035 Hose Assembly 23 7445060637 Tee 24 4567120019 Hose Assembly 45 7445060645 Elbow 4
Standard Duty Low Profile Carrier Parts Manual - Page 835-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - HYDRAULIC REAR DOCK STABILIZER
PORTS
PORTS
R
P
A
B
RO
LL
TIL
T
WIN
CH
STABILIZERRAISE / LOWERCYLINDER (RH)
STABILIZERRAISE / LOWERCYLINDER (LH)
ST
AB4-SECTION
CONTROL VALVE
2
2
4 4
4
43
3
1
1
5
5
5
5
Standard Duty Low Profile Carrier Parts Manual - Page 845-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - STABILIZER W/ REESE HITCH RECEIVER OR PINTLE HITCH MTG PLT
ITEM PART NO. DESCRIPTION QTY
1 7445060845 Elbow 22 7443000030 Tee 23 4567123050 Hose Assembly 24 4567122046 Hose Assembly 25 7935000305 Counterbalance Valve 26 7445060648 Tee 27 7445060645 Elbow 48 4567122014 Hose Assembly 2
Standard Duty Low Profile Carrier Parts Manual - Page 855-376-000140Rev 00 - 08/10
HYDRAULIC COMPONENTS - STABILIZER W/ REESE HITCH RECEIVER OR PINTLE HITCH MTG PLT
4-SECTIONCONTROL VALVE R
OLL
TIL
T
WIN
CH
PORTS
PORTS
R
PB
A
V
P
STABILIZERRAISE / LOWERCYLINDER - RH
V
P
STABILIZERRAISE / LOWERCYLINDER - LH
ST
AB
1
1
2
2
3
3
4
4
8 76
7
7
786
5
5
Standard Duty Low Profile Carrier Parts Manual - Page 865-376-000140Rev 00 - 08/10
ELECTRICAL COMPONENTS - STANDARD W/ DECK MOUNTED HEADBOARD
ITEM PART NO. DESCRIPTION QTY
1 7552000098 Subframe to Deck Harness 12 7552000074 Subframe to Cab Harness 13 7552000135 Subframe Harness 14 7552000177 Deck Harness (21’ deck) 1
7552000179 Deck Harness (22’ deck)5 7552000166 Winch Lights Harness 16 7552000222 Work Lights on Headboard Harness 17 1001129882^ Breaker Harness 18 7457000004^ Circuit Breaker 19 7790100856^ Screw, #10 x 0.50” 2
10 7345221902^ Terminal 111 7950100151^ Flatwasher, 0.19” ID 212 7280000013 Clip *13 7577000194 Wiring Connector Kit 114 4346000005 Heat Shrink Tubing - 1.50” 5
* Quantity varies depending on deck construction.^ Only used with Jerr-dan Supplied Switch Panels.
Standard Duty Low Profile Carrier Parts Manual - Page 875-376-000140Rev 00 - 08/10
Item #12, Clip and #14, Tubing, not shown.
ELECTRICAL COMPONENTS - STANDARD W/ DECK MOUNTED HEADBOARD
3
1 2
4
5
6
9 8
1011
13CHASSISHARNESS
TO SWITCHPANEL
LIGHTBAR
WINCH WORKLIGHTS
HEADBOARDWORKLIGHTS
7
Standard Duty Low Profile Carrier Parts Manual - Page 885-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 7552000204 Subframe to Cab Harness 12 7552000075 Subframe to Deck Harness 13 7552000135 Subframe Harness 14 7552000177 Deck Harness (21’ deck) 1
7552000179 Deck Harness (22’ deck)5 7552000166 Winch Lights Harness 16 7345241902^ Terminal 17 7457000004^ Circuit Breaker 18 7790100856^ Screw, #10 x 0.50” 29 7345221902^ Terminal 2
10 7950100151^ Flatwasher, 0.19” ID 211 7280000013 Clip *12 7577000194 Wiring Connector Kit 113 4346000005 Heat Shrink Tubing - 1.50” 5
* Quantity varies depending on deck construction.^ Only used with Jerr-dan Supplied Switch Panels.
ELECTRICAL COMPONENTS - STANDARD W/ STATIONARY HEADBOARD
Standard Duty Low Profile Carrier Parts Manual - Page 895-376-000140Rev 00 - 08/10
Item #11, Clip and #13, Tubing, not shown.
ELECTRICAL COMPONENTS - STANDARD W/ STATIONARY HEADBOARD
3
5
87
910
12
TO SWITCHPANEL
LIGHTBAR
4
1
CHASSISHARNESS
2
WINCH WORKLIGHTS
6
Standard Duty Low Profile Carrier Parts Manual - Page 905-376-000140Rev 00 - 08/10
ELECTRICAL COMPONENTS - OPTIONAL (TAIL LIGHT CONVERTER)
ITEM PART NO. DESCRIPTION QTY
1 7552000472 Harness 12 7590000432 Stop/Tail/Turn Light 23 7114101018 Capscrew, #10-24NC x 1.25” 64 7660102604 Locknut, #10-24NC 6
Standard Duty Low Profile Carrier Parts Manual - Page 915-376-000140Rev 00 - 08/10
ELECTRICAL COMPONENTS - OPTIONAL (TAIL LIGHT CONVERTER)
1
3
Max
xim
a
SA
E I6
S2
T2 D
OT
M85
415R
TOP
1
Max
xim
a
SA
E I6
S2
T2 D
OT
M85
415R
TOP
1
2
4
3
2
4
CHASSISHARNESS
SUBFRAMEHARNESS
Standard Duty Low Profile Carrier Parts Manual - Page 925-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 7493000009 Grommet 62 7590000342 Marker Light - Amber (LED) 43 7590000343 Marker Light - Red (LED) 24 7493000010 Grommet 25 7590000339 Marker Light - Amber (LED) 2
DECK MARKER LIGHTS
Standard Duty Low Profile Carrier Parts Manual - Page 935-376-000140Rev 00 - 08/10
DECK MARKER LIGHTS
21
5
4
1
2
1
3
Standard Duty Low Profile Carrier Parts Manual - Page 945-376-000140Rev 00 - 08/10
HEADBOARD SIDE MARKER LIGHTS
ITEM PART NO. DESCRIPTION QTY
1 7493000009 Grommet (36” headboard) 27493000009 Grommet (45”, 50” & 57” headboards) 4
2 7590000342 Marker Light - Amber (LED) 2 (36” headboard)
7590000342 Marker Light - Amber (LED) 4 (45”, 50” & 57” headboards)
3 7552000409 Headboard to Cab Harness 1
Standard Duty Low Profile Carrier Parts Manual - Page 955-376-000140Rev 00 - 08/10
HEADBOARD SIDE MARKER LIGHTS
FOR 36" & 40" HEADBOARD FOR 45", 50" & 57" HEADBOARD
1
1
2
2
2
2
2
2
1
1
1
3
12
12
HEADBOARD
Standard Duty Low Profile Carrier Parts Manual - Page 965-376-000140Rev 00 - 08/10
ADDITIONAL DECK MARKER LIGHTS
ITEM PART NO. DESCRIPTION QTY
1 7493000009 Grommet 42 7590000342 Marker Light - Amber (LED) 43 7552000212 Additional Markers Deck Harness 14 4017001059 Angle 45 7280000018 Wire Clip 16
Standard Duty Low Profile Carrier Parts Manual - Page 975-376-000140Rev 00 - 08/10
ADDITIONAL DECK MARKER LIGHTS
ALUMINUM DECK
STEEL DECK
12
12
12
1
2
2
1
1
2
12
12
3REPLACEMENT FORSTANDARD DECKHARNESS
12
12
12
12
4
4
Item #5, Wire Clip, not shown.
Standard Duty Low Profile Carrier Parts Manual - Page 985-376-000140Rev 00 - 08/10
IRL WHEEL LIFT
ITEM PART NO. DESCRIPTION QTY1 3170000162 Outer Boom Weld - Standard 1
3170000504 Outer Boom Wled - Galvanized2 3911000078 Inner Boom Weld 13 3320000115 Cylinder Assembly 14 4691000296 Pin 15 4691000268 Pin 16 7754000006 Retaining Ring 47 7082000021* Bushing 18 4679000046 Wear Pad 19 4017000739 Angle 2
10 7118140418 Capscrew, 0.25”-20NC x 0.50” 411 7950100151 Washer, 0.19” ID 412 4679000211 Wear Pad 113 3320000114 Cylinder Assembly 214 3691000164 Pin Weld 215 7115160950 Capscrew, 0.38”-16NC x 1.12” 616 7660162601 Locknut, 0.38”-16NC 617 3691000073 Pin Weld 318 3020000102 Arm Weld - Standard 2
3020000131 Arm Weld - Galvanized19 7082000017+ Bearing 420 7082000018+ Bearing 421 3592000040 Link Assembly - Standard 1
3592000066 Link Assembly - Galvanized22 3691000069 Pin Weld 123 7082000016^ Bearing 424 7291000010 4-Way Receptacle 125 7796000048 Gasket 126 7114140528 Screw 227 7660142601 Locknut 2
* included in Inner Boom Weld, P/N 3911000078+ included in Arm Weld, P/Ns 3020000102 & 3020000131^ included in Link Weld, P/Ns 3592000040 & 3592000066
Standard Duty Low Profile Carrier Parts Manual - Page 995-376-000140Rev 00 - 08/10
IRL WHEEL LIFT
7
6
5
6
2
8
3
21
9
1
01
11
46
6
22
61
51
12
32
32
71
3261
51
72
4252
62
31
02
02
41
51
61
71
5161
91
91
81
Standard Duty Low Profile Carrier Parts Manual - Page 1005-376-000140Rev 00 - 08/10
MANUAL L-ARM WHEEL LIFT GRID
ITEM PART NO. DESCRIPTION QTY
1 3913000097 Pivot Tube Weld 1 (w/ ball hitch plate)
3913000100 Pivot Tube Weld (w/ 2” reese receiver)
3913000101 Pivot Tube Weld (w/ 2-1/2” reese receiver)
2 3484000091 Grid Weld - LH 13 3484000090 Grid Weld - RH 14 4691000427 Pivot Pin 15 4949000047 Washer 26 7754000024 Retaining Ring 17 3551000036 T-Handle 28 3511880049 L-Arm Weld - Standard 2
3020000132 L-Arm Weld - Galvanized9 7330000419 Reflective Tape 2
10 7330000420 Reflective Tape - LH 111 7330000432 Reflective Tape - RH 112 3551000011* Cam Lock Assembly 213 7440030000^ Grease Fitting 2
* 3551000011, Cam Lock Assembly, included with 3484000091 & 3484000090, Grid Weld^ 7440030000, Grase Fitting, included with 3551000011, Cam Lock Assembly
Standard Duty Low Profile Carrier Parts Manual - Page 1015-376-000140Rev 00 - 08/10
MANUAL L-ARM WHEEL LIFT GRID
Pivot tube weld with IRL ball hitch mounting plate shown
01
7 9
6
1
3
8
8
117
4
9
5
5
2
21
31
Standard Duty Low Profile Carrier Parts Manual - Page 1025-376-000140Rev 00 - 08/10
MANUAL T37 PIVOTING WHEEL LIFT GRID
ITEM PART NO. DESCRIPTION QTY1 3913000097 Pivot Tube Weld 1
(w/ ball hitch plate)3913000100 Pivot Tube Weld
(w/ 2” reese receiver)3913000101 Pivot Tube Weld
(w/ 2-1/2” reese receiver)2 3484000017* Grid Weld - LH 13 3484000016+ Grid Weld - RH 14 4259000002* Pivot Casting, LH 15 4259000001+ Pivot Casting, RH 16 4691000354*+ Pin 27 4691000357*+ Pin 28 7754000037*+ Retaining Ring 29 3551000036 T-Handle 2
10 4691000186*+ Pin 211 7843000006*+ Spring 212 4763000184*+ Rod 213 4254000005*+ Cap 214 7786000006*+ Screw 215 7843000016*+ Spring 216 4691000183*+ Pin 217 4691000427 Pivot Pin 118 4949000047 Washer 219 7754000024 Retaining Ring 120 7440030000 Grease Fitting 621 3020000029 L-Arm Weld - LH 122 3020000030 L-Arm Weld - RH 123 7330000419 Reflective Tape 224 7330000420 Reflective Tape 1
* also available in Grid Assembly, LH, P/N 3484000047+ also available in Grid Assembly, RH, P/N 3484000046
ITEM PART NO. DESCRIPTION QTY25 7330000432 Reflective tape 126 7950200000 Lockwasher, 0.63” ID 2
Standard Duty Low Profile Carrier Parts Manual - Page 1035-376-000140Rev 00 - 08/10
MANUAL T37 PIVOTING WHEEL LIFT GRID
Pivot tube weld with IRL ball hitch mounting plate shown
81
9
7
22
12
91
1
3
8
71
32
8132
79
2
8
42
4
41
51
61
52
01
11
31 02 02 62
6
502
21
Standard Duty Low Profile Carrier Parts Manual - Page 1045-376-000140Rev 00 - 08/10
HYDRAULIC REAR DOCK STABILIZER
ITEM PART NO. DESCRIPTION QTY
1 3849000043 Stabilizer Weld 12 3320000119 Cylinder Assembly 23 3691000165 Pin Weld 24 3691000073 Pin Weld 25 7115160950 Capscrew, 0.38”-16NC x 1.12” 46 7660162601 Locknut, 0.38”-16NC 47 7082000017* Bearing 4
* included in Stabilizer Weld, P/N 3849000043
Standard Duty Low Profile Carrier Parts Manual - Page 1055-376-000140Rev 00 - 08/10
HYDRAULIC REAR DOCK STABILIZER
35
6
1
6
3
5
24
5
6
7
7
2
4
5
6
Standard Duty Low Profile Carrier Parts Manual - Page 1065-376-000140Rev 00 - 08/10
HYDRAULIC REAR DOCK STABILIZER WITH REESE HITCH RECEIVER
ITEM PART NO. DESCRIPTION QTY
1 3849000044 Stabilizer Weld 1 (with 2.50” Reese Hitch Receiver)
2 3320000114 Cylinder Assembly 23 3691000165 Pin Weld 24 3691000073 Pin Weld 25 7115160950 Capscrew, 0.38”-16NC x 1.12” 46 7660162601 Locknut, 0.38”-16NC 47 7082000017* Bearing 48 7291000010 4-Way Receptacle 19 7796000048 Gasket 1
10 7114140528 Screw, 0.25”-20NC x .63” 211 7660142601 Locknut, 0.25”-20NC 2
* included in Stabilizer Weld, P/N 384900004
Standard Duty Low Profile Carrier Parts Manual - Page 1075-376-000140Rev 00 - 08/10
1
6
6
3 5
2
3
5
24
5
6
7
7
4
56
8
9
10
11
HYDRAULIC REAR DOCK STABILIZER WITH REESE HITCH RECEIVER
Standard Duty Low Profile Carrier Parts Manual - Page 1085-376-000140Rev 00 - 08/10
ROLL CYLINDER ASSEMBLY - P/N 3320000238
ITEM PART NO. DESCRIPTION QTY
1 3071000220 Barrel Weld 12 4763000093 Rod 13 4698000009* Piston 14 7754000013* # Wear Ring 25 7796000064* # Piston Locking “T” Seal 16 7755226609* # Back-Up Ring 27 7755226000* # “O” Ring 18 4553000010^ Head 19 7755338000^ # “O” Ring 1
10 7755338609^ # Back-Up Ring 111 7754000012^ # Wear Ring 112 7796000025^ # Rod Seal 113 7796000008^ # Rod Wiper Seal 114 7754000016 # Retaining Ring 115 7754000027 # Retaining Ring 116 7661000035 Locknut 2
* included in Piston Assembly, P/N 3698000004^ included in Head Assembly, P/N 3553000014# available only in Service Kit #7577250025
Standard Duty Low Profile Carrier Parts Manual - Page 1095-376-000140Rev 00 - 08/10
ROLL CYLINDER ASSEMBLY - P/N 3320000238
1 61261 4 4 75 63 11 5121941 8 3101
Standard Duty Low Profile Carrier Parts Manual - Page 1105-376-000140Rev 00 - 08/10
TILT CYLINDER ASSEMBLY - P/N 3320000122
ITEM PART NO. DESCRIPTION QTY
1 3071000117 Barrel Weld 12 3763000127 Rod Weld 13 4698000007* Piston 14 7754000003* # Wear Ring 25 7796000063* # Piston Locking “T” Seal 16 7755224609* # Back-Up Ring 27 7755224000* # “O” Ring 18 4553000008^ Head 19 7755330008^ # “O” Ring 1
10 7755334609^ # Back-Up Ring 111 7754000004^ # Wear Ring 112 7796000045^ # Rod Seal 113 7796000024^ # Rod Wiper Seal 114 7754000002# Retaining Ring 115 7754000026# Retaining Ring 116 7661000034 Locknut 117 7082000016 Bearing 4
* included in Piston Assembly, P/N 3698000001^ included Head Assembly, P/N 3553000011# available only in Service Kit #7577250042
Standard Duty Low Profile Carrier Parts Manual - Page 1115-376-000140Rev 00 - 08/10
TILT CYLINDER ASSEMBLY - P/N 3320000122
1 16 3 4 5 4 7 6 21114 159 10 12 138 1717
Standard Duty Low Profile Carrier Parts Manual - Page 1125-376-000140Rev 00 - 08/10
WHEEL LIFT EXTEND CYLINDER ASSEMBLY - P/N 3320000115
ITEM PART NO. DESCRIPTION QTY
1 3071000106 Barrel Weld 12 3763000119 Rod Weld 13 4698000015* Piston 14 7754000053* # Wear Ring 25 7796000067* # Piston Locking “T” Seal 16 7755222609* # Back-Up Ring 27 7755222000* # “O” Ring 18 4553000016^ Head 19 7755330000^ # “O” Ring 1
10 7755330609^ # Back-Up Ring 111 7754000054^ # Wear Ring 112 7796000045^ # Rod Seal 113 7796000046^ # Rod Wiper Seal 114 7754000051# Retaining Ring 215 7661000034 Locknut 1
* included in Piston Assembly, P/N 3698000006^ included in Head Assembly, P/N 3553000016# available only in Service Kit #7577250206
Standard Duty Low Profile Carrier Parts Manual - Page 1135-376-000140Rev 00 - 08/10
WHEEL LIFT EXTEND CYLINDER ASSEMBLY - P/N 3320000115
151 4 453 7 6 21414 11 10 1312 89
Standard Duty Low Profile Carrier Parts Manual - Page 1145-376-000140Rev 00 - 08/10
IRL/STABILIZER CYLINDER ASSEMBLY - P/N 3320000114
ITEM PART NO. DESCRIPTION QTY
1 3071000105 Barrel Weld 12 3763000118 Rod Weld 13 4698000007* Piston 14 7754000003* # Wear Ring 25 7796000063* # Piston Locking “T” Seal 16 7755224609* # Back-Up Ring 27 7755224000* # “O” Ring 18 4553000008^ Head 19 7755334000^ # “O” Ring 1
10 7755334609^ # Back-Up Ring 111 7754000004^ # Wear Ring 112 7796000024^ # Rod Seal 113 7796000008^ # Rod Wiper Seal 114 7754000002 # Retaining Ring 115 7754000026 # Retaining Ring 116 7661000034 Locknut 117 7082000016 Bearing 218 7082000018 Bearing 2
* included in Piston Assembly, P/N 3698000001^ included in Head Assembly, P/N 3553000011# available only in Service Kit #7577250024
Standard Duty Low Profile Carrier Parts Manual - Page 1155-376-000140Rev 00 - 08/10
IRL/STABILIZER CYLINDER ASSEMBLY - P/N 3320000114
2117 16 4 453 7 6 181514 11 9 10 12 138
Standard Duty Low Profile Carrier Parts Manual - Page 1165-376-000140Rev 00 - 08/10
STABILIZER CYLINDER ASSEMBLY - P/N 3320000119
ITEM PART NO. DESCRIPTION QTY
1 3071000110 Barrel Weld 12 3763000118 Rod Weld 13 4698000007* Piston 14 7754000003* # Wear Ring 25 7796000063* # Piston Locking “T” Seal 16 7755224609* # Back-Up Ring 27 7755224000* # “O” Ring 18 4553000008^ Head 19 7755334000^ # “O” Ring 1
10 7755334609^ # Back-Up Ring 111 7754000004^ # Wear Ring 112 7796000024^ # Rod Seal 113 7796000008^ # Rod Wiper Seal 114 7754000002 # Retaining Ring 115 7754000026 # Retaining Ring 116 7661000034 Locknut 117 7082000016 Bearing 218 7082000018 Bearing 2
* included in Piston Assembly, P/N 3698000001^ included in Head Assembly, P/N 3553000011# available only in Service Kit #7577250024
Standard Duty Low Profile Carrier Parts Manual - Page 1175-376-000140Rev 00 - 08/10
STABILIZER CYLINDER ASSEMBLY - P/N 3320000119
117 16 454 7 6 3 2 181514 911 128 1310
Standard Duty Low Profile Carrier Parts Manual - Page 1185-376-000140Rev 00 - 08/10
LIGHTBARS
ITEM PART NO. DESCRIPTION QTY
1 7590000363 Lightbar, Amber LED 12 4178000402 Bracket (standard mount) 2
4178000437 Bracket (high mount)3 7115180850 Capscrew, 0.50”-13NC x 1.00” 24 7950180252 Flatwasher, 0.50” ID 25 7950180000 Lockwasher, 0.50” ID 2
Standard Duty Low Profile Carrier Parts Manual - Page 1195-376-000140Rev 00 - 08/10
LIGHTBARS
1
2
2
3
*
*
*
3
4
5
*
*
*
* included in Lightbar
Standard Duty Low Profile Carrier Parts Manual - Page 1205-376-000140Rev 00 - 08/10
SWITCH PANELS
ITEM PART NO. DESCRIPTION QTY1 4178000403 Bracket - 1 Function Switch Panel 12 4178000427 Bracket - 2 Function Switch Panel 13 7870000083 Switch 14 7870000113 Switch Panel - 3 Function, Mini In-Dash 15 7870000100 Switch Panel - 3 Function, In-Dash 16 7870000106 Switch Panel - 5 Function, In-Dash 17 7870000134 Switch Panel - 3 Function, Under Dash 18 7870000137 Switch Panel - 5 Function, Under Dash 19 2870000022 Switch Panel - 3 Function, In-Dash 1
for Ford F650/75010 2870000021 Switch Panel - 5 Function, In-Dash 1
for Ford F650/75011 7870000053 Switch Panel - 3 Function, Under Dash 112 7870000063 Switch Panel - 5 Function, Under Dash 113 7870000076 Switch Panel - 3 Function, In-Dash 1
Standard Duty Low Profile Carrier Parts Manual - Page 1215-376-000140Rev 00 - 08/10
SWITCH PANELS
NOCAEB DOOLF .XUA
OTPDEGAGNE
O
NOCAEB DOOLF .XUA
O O
OTPDEGAGNE
O
NOCAEB
O O
DOOLF .XUA
O
.XUA
O
.XUA
OTPDEGAGNE
NOCAEB DOOLF .XUA .XUA.XUA
O
NOCAEB DOOLF .XUA
O O
OTPDEGAGNE
.XUADOOLFNOCAEB
OTPDEGAGNE
NOCAEB DOOLF .XUA .XUA.XUA
OTPDEGAGNE
NOCAEB DOOLF .XUA
OTPDEGAGNE
DEGAGNEOTP
DOOLF 1.XUA
NOCAEB
DEGAGNEOTP
DOOLF 1.XUA
NOCAEB
2 4
5 6
31
2111
3 331
7 8
9
01
Standard Duty Low Profile Carrier Parts Manual - Page 1225-376-000140Rev 00 - 08/10
WORK LIGHTS
ITEM PART NO. DESCRIPTION QTY
1 7590000223 Work Light 42 4178000402 Bracket 23 7790151253 Screw, 0.31”-18NC x 0.75 44 7493000003 Grommet 25 7552000222 Harness - Headboard Work Lights 1
7552000360 Harness - Headboard Work Lights 1(Bucket Rest Headboard Only)
6 4178000423 Bracket 17 7280000011 Clip - Winch Work Lights 68 7552000166 Harness - Winch Work Lights 19 7590000185 Work Light 2
Standard Duty Low Profile Carrier Parts Manual - Page 1235-376-000140Rev 00 - 08/10
6
1
1
7
1
2
3
4
9
9
WORK LIGHTS
Items #5 & #8, Harness, not shown
Standard Duty Low Profile Carrier Parts Manual - Page 1245-376-000140Rev 00 - 08/10
BOLT-ON D-RINGS
ITEM PART NO. DESCRIPTION QTY
1 3556000019 D-Ring 12 7115182050 Capscrew, 0.50”-13NC x 2.50” 23 7660182601 Locknut, 0.50”-13NC 2
Standard Duty Low Profile Carrier Parts Manual - Page 1255-376-000140Rev 00 - 08/10
BOLT-ON D-RINGS
2
1
3
Standard Duty Low Profile Carrier Parts Manual - Page 1265-376-000140Rev 00 - 08/10
1, 2, 3, 4 OR 5 REMOTE CONTROL OPERATIONS
ITEM PART NO. DESCRIPTION QTY
1 7005000003 Linear Actuator 12V 1*2 4706005361 Plate 23 7115150864 Carriage Bolt, 0.31”-18NC x 1.00” 44 7950150161 Flatwasher, 0.31” ID 45 7660152601 Locknut, 0.31”-18NC 46 4178000664 Bracket 1*7 4178000665 Bracket 1*8 7115150864 Carriage Bolt, 0.31”-18NC x 1.00” 2*9 7660152601 Locknut, 0.31”-18NC 2*
10 4691000141 Pin (3, 4 or 5 section control valve) 14691000373 Pin (6 section control valve)4691000374 Pin (7 section control valve)
11 4211000001 Bushing 4*12 7950220141 Flatwasher, 0.75” ID 413 7754000009 Retaining Ring 214 7295000106 Controller (1 remote operation) 1
7295000108 Controller (2 remote operations)7295000109 Controller (3 remote operations)7295000111 Controller (4 or 5 remote operations)
15 7114100810 Screw, #10-24NC x 1.00” 2 (1 remote operation)
7114100810 Screw, #10-24NC x 1.00” 6 (2, 3, 4, or 5 remote operations)
16 7950140151 Flatwasher, 0.19” ID 2 (1 remote operation)
7950140151 Flatwasher, 0.19” ID 8 (2, 3, 4, or 5 remote operations)
17 7660102604 Locknut, #10-18NC 2 (1 remote operation)
7660102604 Locknut, #10-18NC 6 (2, 3, 4, or 5 remote operations)
* quantities are for 1 remote operation, adjust quantities for 2, 3, 4, or 5 remote operations# included with Controller, item #14
ITEM PART NO. DESCRIPTION QTY18 4706005595 Plate (2, 3, 4, or 5 remote operations) 119 7330000696 Decal - Controller Functions 1
(3, 4, or 5 remote operations)20 9295310032# Transmitter (1 remote operation) 1
9295310033# Transmitter (2 remote operations)9295310034# Transmitter (3 remote operations)9295310036# Transmitter (4 or 5 remote operations)
21 9295310030# Belt Clip 122 9295310042# Rubber Boot (1 or 2 remote operations) 1
9295310029# Rubber Boot (3, 4, or 5 remote operations)23 9295310037# Receiver (1 remote operation) 1
9295310038# Receiver (2 remote operations)9295310039# Receiver (3 remote operations)9295310050# Receiver (4 or 5 remote operations)
24 7552000391 Harness (1 remote operation) 17552000392 Harness (2 remote operations)7552000393 Harness (3 remote operations)7552000426 Harness (4 or 5 remote operations)
Standard Duty Low Profile Carrier Parts Manual - Page 1275-376-000140Rev 00 - 08/10
1, 2, 3, 4 OR 5 REMOTE CONTROL OPERATIONS
One Remote Operation shown
Items #19, Decal - Controller Functions, not shown
NOITAREPO ETOMER 1
SNOITAREPO ETOMER 5 RO ,4 ,3 ,2
2
3
3121
11
01
1
1145
86
7
9
21
3
2
31
45
moc.nad-rrej.www
moc.nad-rrej.www
moc.nad-rrej.www
DEB DEB
DEB BED
324151
6171
913241
51617181
5161
41
5 RO 4 3 2 1 NOITAREPO ETOMER
021222
41 41 021222
42
42
41021222
Standard Duty Low Profile Carrier Parts Manual - Page 1285-376-000140Rev 00 - 08/10
REMOTE THROTTLE CONTROL
ITEM PART NO. DESCRIPTION QTY
1 7346000208 Pressure Switch 12 7552000241 Harness 13 7443000427* Check Valve 14 7445060643* Adapter 15 7443000432 Tee 16 7443000469 Fitting 17 7445040643 Adapter 1
* also available in Check Valve w/ Adapter, P/N 7443000428.
Standard Duty Low Profile Carrier Parts Manual - Page 1295-376-000140Rev 00 - 08/10
REMOTE THROTTLE CONTROL
FER
1 TUPNI
2 TUPNI
3 TUPNI
4 TUPNI
5 TUPNI
6 TUPNI
INP
UT P
LUG
AJA0600YRETTAB
V21+LANIMRET
EJA0600YRETTAB
DNG-LANIMRET
AB
V21+LANIMRET
21 6543
789011121 F KJHG
ABCDE
RE
M M
OD
ULE
NG
V C
HA
SS
IS
ERUSSERPHCTIWS
DRAKCAPROTCENNOC
FER
V21+LANIMRET
KCURTYRETTAB
KCURTYRETTAB
ERUSSERPTROP KCEHC
LLORNOITCNUF
NOITCES
3
4
5
6
12
7
TELTUO/TELNINOITCES
RO
ERIW DER
ERIW KCALB
ERIW DERV21+ OT
YRETTABLANIMRET
ERIW KCALB"C" NIP OT
OTP FO "F" ROROTCENNOC
RO DERKCALB
ERIW
RO DERKCALB
ERIW
GNIRIW LANOITANRETNINOITALLATSNI
GNIRIW RENILTHGIERFNOITALLATSNI
GNIRIW CMG/YVEHCNOITALLATSNI
2FER
GNIRIW ONIHNOITALLATSNI
KCALB/DERDNIHEB ERIW
HSAD
ERIW DERV21+ OT
YRETTABLANIMRET
Standard Duty Low Profile Carrier Parts Manual - Page 1305-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 4178000666* Bracket 12 7115181464* Carriage Bolt, 0.50”-13NC x 1.75” 23 7660182601* Locknut, 0.50”-13NC 24 7346000055+ Electrical Receptacle 7-way Connect 15 7346000078+ Electrical Boot 16 7111150813+ Capscrew, 0.31”-18NC x 1.00” 27 7660152601+ Locknut, 0.31”-18NC 28 7346000132 Electrical Adapter 7 to 4 way 19 7346000157 Electrical Adapter 7 to 6 way 1
10 7312000015^ Gladhand 111 7312000016^ Gladhand 112 7446502518^ Bulkhead Fitting 213 7446382506^ Connector 214 7577000145^ Seal Kit Gladhand 115 7565000014^ Airline Tubing 50 ft16 7312000013^ Union 2
GLAD HANDS AND 7- WAY CONNECTOR
* also available in Bracket Install Glad Hands and 7 Way, P/N 2178000037+ also available in Electrical Install 7 Way Connector, P/N 2346000008^ also available in Glad Hand Install, P/N 2002000016
Standard Duty Low Profile Carrier Parts Manual - Page 1315-376-000140Rev 00 - 08/10
1
2
2
3
4
6
10
1112
13
5
7
GLAD HANDS AND 7- WAY CONNECTOR
Item #8 Electrical Adapter 7 to 4 Way not shownItem #9 Electrical Adapter 7 to 6 Way not shownItem #14, Seal Kit Gladhand; #15, Airline Tubing; & #16, Union not shown
Standard Duty Low Profile Carrier Parts Manual - Page 1325-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 7312000017 Coupling 12 7445080853 Elbow 13 7446502518 Bulkhead Fitting 14 7443000111 Elbow 15 7446382506 Connector 16 7565000014 Airline Tubing 32 ft7 7935000120 Air Valve 18 7443000154 Bushing 19 7443000156 Nipple 1
10 7894000031 Cable Tie 611 7443000366 Fitting 1
AIR SUPPLY DISCONNECT
Standard Duty Low Profile Carrier Parts Manual - Page 1335-376-000140Rev 00 - 08/10
AIR SUPPLY DISCONNECT
1
11
2
3
6
10
5
7
7
9
4
8
SECONDARY
AIR SUPPLY
LEFT HAND SIDE - REAR
TAIL LIGHT HOUSING
12
3
11
6
10
1
6
Standard Duty Low Profile Carrier Parts Manual - Page 1345-376-000140Rev 00 - 08/10
ITEM PART NO. DESCRIPTION QTY
1 7002000386 Jump Start Plug (IHC & Other) 17002000385 Jump Start Plug (Ford & GM)
2 4178000372 Bracket (Ford & Other) 14178000202 Bracket (GM)
3 4178000203 Bracket (GM) 14706003210 Plate (Other)
4 7110140605 Capscrew, 0.25”-20NC x 0.75” 1 (Ford, GM & Other)
5 7950140161 Flatwasher, 0.25” ID (Ford & Other) 17950140161 Flatwasher, 0.25” ID (IHC) 27950140161 Flatwasher, 0.25” ID (GM) 3
6 7660142600 Locknut, 0.25”-20NC (Ford, GM & Other) 17660142600 Locknut, 0.25”-20NC (IHC) 2
7 7115151064 Carriage Bolt, 0.31”-18NC x 1.25” (Other) 28 7950150161 Flatwasher, 0.31” ID (Other) 29 7660152601 Locknut, 0.31”-18NC (Other) 2
10 7115141450 Capscrew, 0.25”-20NC x 1.75” (IHC) 111 7115141650 Capscrew, 0.25”-20NC x 2.00” (IHC) 112 7660140000 Hex Nut, 0.25”-20NC (IHC) 1
7660140000 Hex Nut, 0.25”-20NC (GM) 213 7111140850 Capscrew, 0.25”-20NC x 1.00” (GM) 214 7115181050 Capscrew, 0.50”-13NC x 1.25” (GM) 115 7950180153 Flatwasher, 0.50” ID (GM) 116 7660180000 Hex Nut, 0.50”-13NC (GM) 1
JUMP START KIT
Standard Duty Low Profile Carrier Parts Manual - Page 1355-376-000140Rev 00 - 08/10
JUMP START KIT
1
1
2
23
1
2
1
3
1
1
1
EXISTING BUMPER
MOUNTING HARDWARE
5
4
6
5
4
65
4
6
8
7
9
5
10
65
11
6
12
FORD FRONT BUMPER
IHC FRONT BUMPER
CHEVY FRONT BUMPER
5
13
12
14
15
16
ALL OTHER FRONT BUMPERS
Standard Duty Low Profile Carrier Parts Manual - Page 1365-376-000140Rev 00 - 08/10
FOLDING DECK LADDER
ITEM PART NO. DESCRIPTION QTY
1 3178000555 Bracket Weld 12 3002000009 Ladder Top Weld 13 3002000008 Ladder Bottom Weld 14 7114181418 Capscrew, 0.50”-13NC x 1.75” 45 7950180141 Flatwasher, 0.50” ID 126 7660182601 Locknut, 0.50”-13NC 47 7115180606 Shoulder Bolt, 0.50”-13NC x 0.75” 28 7950160161 Flatwasher, 0.38” ID 29 7660162601 Locknut, 0.38”-16NC 2
Standard Duty Low Profile Carrier Parts Manual - Page 1375-376-000140Rev 00 - 08/10
1
2
3
4
5
5
6
6
5
45
7
7
5
5
5
8
9
FOLDING DECK LADDER
Standard Duty Low Profile Carrier Parts Manual - Page 1385-376-000140Rev 00 - 08/10
CHAINS AND STRAPS
ITEM PART NO. DESCRIPTION QTY1 7262000022* Winch V-Chain 12 7262000056* Front Tie-Down Chain 23 7894000019* Rear Tie-Down Strap 24 7894000020* Rear Tie Down Ratchet 25 7262000040 Wheel Lift Chain 26 7894000034+ Wheel Lift Tire Strap 27 7262000010 Towbar Chain 28 7894000058^ Tire Strap (hydraulic grid) 19 7894000059^ Choker (hydraulic grid) 1
10 7894000028^ Ratchet (hydraulic grid) 111 7561000024^ Forged Hook (hydraulic grid) 112 7115181664 Carriage Bolt, 0.50”-13NC x 2.00” 213 7660180001 Nut, 0.50”-13NC 214 7660182601 Locknut, 0.50”-13NC 215 5525000752 Magnetic Tow Lights 116 7894000073 8 Point Tie-Down Kit 1
* also available in Deck Chain / Tie-Down Kit, P/N 7577000208 ^ also available in Hydraulic Grid Wheel Lift Tie-Down Kit, P/N 7577000376 + also available in Wheel Lift Tie-Down Strap and Ratchet Kit, P/N 7577000242
Standard Duty Low Profile Carrier Parts Manual - Page 1395-376-000140Rev 00 - 08/10
CHAINS AND STRAPS
6
7
1
2
5
3 4
9
8 01
11
5
21
3141
EMARFBUS FO RAER TA XOB NIAHC
51 61
Standard Duty Low Profile Carrier Parts Manual - Page 1405-376-000140Rev 00 - 08/10
DECALS
ITEM PART NO. DESCRIPTION QTY
1 1001127221 Serial Number Tag 12 7330000338 Subframe / Patent Tag 13 7330000502 Decal - Slide Pad / Pivot Joint 14 7330000159 STAR Placard 15 7330000275 Decal - Operator’s Pre-Checklist 16 7330000242 Decal - Free Spool (bolt-on headboard) 1
7330000495 Decal - Free Spool (stationary headboard)7 7330000478 Decal - Lubrication Chart 18 7330000012 Decal - Winch 19 7330000433 Jerr-Dan Nameplate 3
10 7330000143 Decal - Made In The USA 111 7330000044 Decal - Align Arrow, Red 2
7330000045 Decal - Align Arrow, White12 7330000272 Decal - Oil Level 113 7330000330 Decal - Cable Track 114 7330000139 Decal - Checklist Reminder 115 7330000684 Decal - Safety 116 7330000683 Decal - Safety 217 7330000060 Decal - Wheel Lift Hitch 118 7330000036 Secure Vehicle 219 7330000176 Decal - Air Suspension 120 7330000274 Decal - Overloading Tow Option 121 7330000599 Decal - Pinch Point 322 9330740009 Decal Kit - Muncie PTO 123 7759000004 Pop Rivet 1224 7330000675 Decal - Air Free Spool Control, LH 125 7330000676 Decal - Air Free Spool Control, RH 126 7330000176 Decal - Air Suspension 1
Standard Duty Low Profile Carrier Parts Manual - Page 1415-376-000140Rev 00 - 08/10
DECALS
Items #22, Decal Kit - Munice PTO, not shown
A
A
KNAT CILUARDYH
YRANOITATSDRAOBDAEH
EMARFBUS EDIS H L
DRAOBHSAD BAC
A-A NOITCES
KCED - EDIS H LDRADNATS - EDIS BACDRAOBDAEH
EXULED / DRADNATSDRAOBDAEH
TFIL LEEHW DIRG LAUNAM
emarfbuS fo raeR
901
5
432
7
6
132 11
8
9
7
68921
3232
31
41
HCTIH WOT YRANOITATS
DIRG 73-T S L-A DIRG MR S
12)sediS htoB(
5161 61
7112
02
576
EGA W
HCNIWLOOPS EERF
676
CNIW
HCNIWLOOPS EERF
EDIS REVIRDDOOH LORTNOC
EDIS REGNESSAPDOOH LORTNOC
5242
91
92
Standard Duty Low Profile Carrier Parts Manual - Page 1425-376-000140Rev 00 - 08/10
ACCESSORY EQUIPMENT
ITEM PART NO. DESCRIPTION QTY
1 7002000449 Magnetic Tow Lights 12 7002000404 Fire Extinguisher 13 7002000448 Wheel Chock 14 7002000285 Reflective Triangles 15 7002000451 Load Binder - 0.38” Chain 16 Not Required7 7002000521 Remote Control Transmitter Holder 18 7002000447 Valve Stem Extension Kit 19 7002000503 Air Compressor with Hose Reel 1
10 7443000111 Elbow 111 7115161050 Capscrew, 0.38”-16NC x 1.25” 412 7950150161 Flatwasher, 0.31” ID 413 7660162601 Locknut, 0.38”-16NC 414 7115181050 Capscrew, 0.50”-13NC x 1.25” 415 7950180153 Flatwasher, 0.50” ID 816 7660182601 Locknut, 0.50”-13NC 4
Standard Duty Low Profile Carrier Parts Manual - Page 1435-376-000140Rev 00 - 08/10
1
2 3 4
56
7
8
LOCATED INSIDE CAB SHOWN MOUNTED INSIDE 48" TOOLBOX
9101211
131514
16
ACCESSORY EQUIPMENT
Standard Duty Low Profile Carrier Parts Manual - Page 1445-376-000140Rev 00 - 08/10
HYDRAULIC SCHEMATIC
3 Bank Control Valve - No Tow Option
WINCHTILTROLL
V1
B1
B2
A1
A2
V2
B AB A
X
ROLL CYLINDER
TILT CYLINDER
WINCH
TILT CYLINDER
2000 PSI RELIEF
FLOW CONTROLCHECK VALVE
PRESSUREGAUGE
TILT RELIEF ONUNITS WITH INBOARDTILT CYLINDERS ONLY
Standard Duty Low Profile Carrier Parts Manual - Page 1455-376-000140Rev 00 - 08/10
WINCHTILTROLL
V1
B1B2
A1A2
V2
B A B A B A
2000 PSI RELIEF
B A B A
ROLL CYLINDER
TILT CYLINDER
WINCH
TILT CYLINDER
PRESSUREGAUGE
BOOMIN/OUT
BOOMUP/DOWN
BOOMCYLINDER
BOOM IRLCYLINDER
BOOM IRLCYLINDER
FLOW CONTROLCHECK VALVE
TILT RELIEF ONUNITS WITH INBOARDTILT CYLINDERS ONLY
HYDRAULIC SCHEMATIC
5 Bank Control Valve - IRL Tow Option
Standard Duty Low Profile Carrier Parts Manual - Page 1465-376-000140Rev 00 - 08/10
WINCHTILTROLL
V1
B1
B2
A1
A2
V2
B A B AB A B A
FLOW CONTROLCHECK VALVE
2000 PSI RELIEF
STABILIZERUP/DOWN
ROLL CYLINDER
TILT CYLINDER
WINCH
TILT CYLINDER
PRESSUREGAUGE
STABILIZERCYLINDER
STABILIZERCYLINDER
TILT RELIEF ONUNITS WITH INBOARDTILT CYLINDERS ONLY
HYDRAULIC SCHEMATIC
4 Bank Control Valve - Stabilizer Option
Standard Duty Low Profile Carrier Parts Manual - Page 1475-376-000140Rev 00 - 08/10
HYDRAULIC SCHEMATIC
4 Bank Control Valve - Stabilizer with Tow Option
V1
WINCHROLL
B1
B2
A1
A2
V2
B A B AB A B A
TILT 2000 PSI RELIEF
FLOW CONTROLCHECK VALVE
STABILIZERUP/DOWN
ROLL CYLINDER
TILT CYLINDER
WINCH
TILT CYLINDER
PRESSUREGAUGE
STABILIZERCYLINDER
STABILIZERCYLINDER
TILT RELIEF ONUNITS WITH INBOARDTILT CYLINDERS ONLY
Standard Duty Low Profile Carrier Parts Manual - Page 1485-376-000140Rev 00 - 08/10
THIS PAGE INTENTIONALLY LEFT BLANK
Standard Duty Low Profile Carrier Parts Manual - Page 1495-376-000140Rev 00 - 08/10
ELECTRICAL SCHEMATIC
NOITCNUFROLOCTIUCRICDNUORGETIHW1
ECNARAELCNWORB2NRUT/POTS HRNEERG3NRUT/POTS HLWOLLEY4
PU-KCABKCALB5)RFBUS( STHGIL KROWEULB6)RAB-TL( STHGIL KROWTELOIV7
)SROTATOR( NOCAEBYARG8)REHSALF( 1 XUAEGNARO9
01 KCALB/EULB TL NOITPO2 XUAEULB TL11
)GWA61( KLB 5
DNG
GR
Y (C
ENTE
R R
OT)
LT B
LU/B
LK (O
PT)
)GWA61( KLB 5
LT B
LU (O
PT)
KBG
RW
)spmA 79.1( .TL PU-KCAB TFEL
1 W
HT
(10A
WG
)
)GWA61( NRB 2
6 B
LU (1
6AW
G)
)GWA41( LEY 4
)GWA41( NRG 3
)GWA41( THW 1)GWA41( NRB 2
NRUT TFEL
NRUT THGIR
DNUORGECNARAELC
1 W
HT (1
6AW
G)
1 W
HT (1
6AW
G)
2 BR
N (1
6AW
G)
2 BR
N (1
6AW
G)
)GWA61( THW 1
)GWA61( THW 1
EMARFBUSGNIRIWSSENRAH
NOCAEB
DOOLF
XUA
ERAPS
ERAPS
A02
A02
A05
-
YEL
- (18
AW
G)
RE
D +
(18A
WG
)
OR
G (O
UTS
IDE
RO
T)
VLT
(WO
RK
LIG
HTS
DE
CK
)
BLU
(WO
RK
LIG
HTS
SU
BFR
AME
)
RE
D (P
OW
ER
+12
VO
LT)
BRN
(CLE
ARAN
CE) 1
8AW
G
BLK
(GN
D) 1
8AW
G
DNG
DNGYRETTAB
+
DNG
)GWA61( THW 1 )GWA61( NRB 2
)spmA 50.0( .TL REKRAM TNORF THGIR
)GWA61( THW 1
)spmA 01.0( .TL ECNARAELC TNORF THGIR
)GWA61( NRB 2
)GWA61( THW 1
)spmA 01.0( .TL ECNARAELC DIM THGIR
)GWA61( NRB 2
)GWA61( THW 1
)spmA 01.0( .TL ECNARAELC RAER THGIR
)GWA61( NRB 2
)GWA61( THW 1 )GWA61( NRB 2
)spmA 50.0( .TL REKRAM TNORF TFEL
)GWA61( THW 1
)spmA 01.0( .TL ECNARAELC DIM TFEL)GWA61( NRB 2
)GWA61( THW 1
)spmA 01.0( .TL ECNARAELC TNORF TFEL)GWA61( NRB 2
)GWA61( THW 1
)spmA 01.0( .TL ECNARAELC RAER TFEL
)GWA61( NRB 2
)GWA61( NRB 2
)GWA61( ULB 6
)GWA61( THW 1
)spmA 01.0( .TL REKRAM THGIR DRAOBTUO
)GWA61( NRB 2 )GWA61( THW 1
)spmA 01.0( .TL REKRAM THGIR
)GWA61( NRB 2 )GWA61( THW 1)spmA 30.0( .TL LIAT THGIR
)GWA61( NRG 3)spmA 83.0( .TL POTS THGIR
)GWA61( NRB 2 )GWA61( THW 1
)spmA 50.0( .TL TOD)GWA61( NRB 2 )GWA61( THW 1
)spmA 50.0( .TL TOD)GWA61( NRB 2 )GWA61( THW 1
)spmA 50.0( .TL TOD
)GWA61( NRB 2 )GWA61( THW 1)spmA 30.0( .TL LIAT TFEL
)GWA61( LEY 3)spmA 83.0( .TL POTS TFEL
)GWA61( NRB 2 )GWA61( THW 1
)spmA 01.0( .TL REKRAM TFEL
)GWA61( NRB 2 )GWA61( THW 1
)spmA 01.0( .TL REKRAM TFEL DRAOBTUO
DNG
DER
)LANOITPO( KLB/ULB
DNG
DNG
NWOHS SROLOC GNIRIWRAB THGIL ROF ERA
YLNO GNIRIW
.TL KROW DOOLF W55)spmA 05.4(
)2 XUA( ULB
GRO
KLB/DER
LEY
DNG
RAB THGIL DEL MZIRP DAEH-01
THW
DNG
DER
DNG
DER
LIAT/NRUT/POTS DEL TFEL)spmA 51.0/spmA 05.0(
DER
KLB/DER
KLB/LEY
DNG
DNG
DNG
)DNUORG( KLB
DNG
LIAT/NRUT/POTS DEL THGIR)spmA 51.0/spmA 05.0(
KLB/DER
DER
21FER SRENROC TFEL)3( SELUDOM 8FER TNORF
)HCAE spmA 00.1-57.0(
DNG
DER
KLB/DER
RAER & TNORF RETNEC)4( SELUDOM 8FER
)HCAE spmA 57.0(
LEY
.TL KROW DOOLF W55)spmA 05.4(
KLB/LEY
21FER SRENROC THGIR)3( SELUDOM 8FER TNORF
)HCAE spmA 00.1-57.0(
).T.O.D LANOITPO( LEY
NAD-RREJHCTIWSLENAP
OTPTL
OTP OTHCTIWS
GNIRIW KCURT.SSENRAH
ROF GNIRIW/POTS SISSAHC
PUKCAB/LIAT/NRUT.STHGIL DEILPPUS
PMA 05TIUCRICREKAERB
KCED NIAMSSENRAH GNIRIW
EMARFBUS OT BACSSENRAH GNIRIW
LENAP HCTIWS OTBAC KCURT NI
KCURTSSENRAH
.ECAFRETNIREHTAEW DDA
KCAPROTCENNOC
KCURT OT.GNIRIW
.TL DOOH LORTNOC)spmA 82.0(
ESNECIL.TL ETALP)spmA 82.0(
.TL KROW .XUA)spmA 57.2(
CITENGAMSTHGIL WOT
EGNIH
PU KCABMRALA
)spmA 03.0(
THGIL PU-KCAB THGIR)spmA 79.1(
.TL KROW .XUA)spmA 57.2(
.TL DOOH LORTNOC)spmA 82.0(
KCED OT BUSSSENRAH GNIRIW
EDOCKCALB = KLB
NWORB = NRBEULB = ULB
NEERG = NRGDER = DER
WOLLEY = LEYTHGIL = TL
EGNARO = GROTELOIV = TLVETIHW = THW
Standard Duty Low Profile Carrier Parts Manual - Page 1505-376-000140Rev 00 - 08/10
THIS PAGE INTENTIONALLY LEFT BLANK
5376000140- 0