Solid Waste Management Hydrothermal Treatment using Subcritical Water
Transcript of Solid Waste Management Hydrothermal Treatment using Subcritical Water
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
1/20
Solid Waste
Management
Presented By:-
Vijendra Kumar Gupta
Urvashi Tiwari
Prateek Aniruddha Sarin
Kuldeep Singh Bhati
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
2/20
Overview
Introduction
Hydrothermal Treatment by usingSubcritical water
Case study
Comparative study
References
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
3/20
Municipal Solid WasteMunicipal solid waste(MSW), commonly knownas trashor garbage(US), refuseor rubbish(UK)is a waste type consisting of everyday items thatare discarded by the public.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
4/20
Disposal of MSW
Different management/treatment which aregiven to the waste:-
1. Land Filling
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
5/20
Incineration &Gasification
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
6/20
Hydrothermal Treatment UsingSub-critical Water (HTSW)
Hydrothermal treatment technology employs thecombination of heat and water to convert
unutilized resources into uniform product.
Pressurised hot water is known as subcriticalwater.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
7/20
Why subcritical water?
It has hydrolytic and pyrolitic reactioncharacteristics, result from a decrease in thedielectric constant and increase in the ion product
of water at temperatures and pressures below
and near 374oC and 22.1 Mpa.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
8/20
Features of HTSW
No drying process is required prior to HTSW.
Char is produced with minimal carbon loss.
The char produced has a heating value
comparable to that of lignite & brown coal.Liquid filtrate produced has organic compoundssuch as Alcohols, ester, aldehydes etc. which canbe recovered as valuable products.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
9/20
Process Description
This process operates as a batch system.
Municipal Solid Waste (MSW) and distilled water(three times of MSW by mass) are added to anautoclave reactor.
The system is then stirred at 150 rpm.
Steam is now added at T=75-150oC
Now reactor is set at one of the following
conditions-Low Temperature conditions (234oC, 3 MPa)
High Temperature conditions (295oC, 8 MPa)
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
10/20
These conditions are maintained for 5 min in thereactor.
Nitrogen gas (T=75oC ) is then purged into theautoclave reactor in order to discharge theresulting gas.
The resulting mixture (constituting solid, liquidand gas phase) is cooled down in a vapor gascondensing bottles, and non condensable gas
then being collected in Tedlar bag.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
11/20
Setup
In-Hee Hwang, Hiroya Aoyama, Toshihiko Matsuto, Tatsuhiro Nakagishi, Takayuki Matsuo.Recovery of solid fuel from municipal solid waste by hydrothermal treatment using subcriticalwater. Waste Management 32(2012) 410-416.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
12/20
The solid-liquid mixture is collected by rinsingwith distilled water and then filtered with 1micron pore-sized filter paper.
Solid components are then dried for 105oC for 12h, which are then pulverized to grain-sized 500micron particles.
The filtrate obtained is then cooled and scrubbedfiltered with 1 micron pore-sized filter paper.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
13/20
Case Study of AurobindoHostel
1. It accommodates 32 dustbins each producing 5Kg of solid waste daily.
2. Besides this solid waste of mess & canteenconstitute 200 kg on daily basis.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
14/20
Composition of SW
30%
40%
20%
10%
Organic Food WastePlastics/Polythene
Paper waste
Sand & others
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
15/20
Yield at Lower Temperature
0
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1
Paper Food Wood Plastic
Yield 0.66 0.66 0.59 0.98
Yield
Lower Temperature
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
16/20
Yield at High Temperature
0
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1
Paper Food Wood Plastic
Yield 0.66 0.66 0.59 0.98
Yield
High Temperature
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
17/20
Heating Value Produced
Type ofWaste
Amountofwaste(in kg)
HeatingValue inLT (inKJ/kg)
EnergyProducedin LT(in KJ)
HeatingValue inHT (inKJ/kg)
EnergyProducedin HT (inKJ)
Paper 32 13780 260166.40 21359 307569.60
Food 248 24106 3766321.44 24727 3372762.80
Wood 0 21571 0 25724 0
Plastics 64 0 0 0 0
Total 354 4026487.84 3680332.40
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
18/20
Heating Value of LPG= 49742 KJ /kg.
So the energy produced by the char producedfrom solid waste collected from Aurobindo Hostelis equivalent to 74 to 81 kg of LPG which is equalto 5 LPG domestic cylinder(14.2kg).
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
19/20
Comparative StudyParameter Land
fillingIncineration
Gasification HTSW
Installation &OperationalCost
Low High Very High High
EnvironmentalImpact
Affectsland,water andair in localareas.
Affects airand largelyresponsiblefor climatechange.
Pollutes airand adds toglobalwarming.
Low impact.
Service inReturn
Nothing Less energyis recoveredin form of
heat.
High amountof energy isproduced.
Very highamount ofenergy is
produced.Ease ofoperation
Cant be
donelocally.
Cant be
done locally.Cant be
done locallyand specialskills arerequired.
Can be donelocally withless amountof specialskills
required.
-
8/10/2019 Solid Waste Management Hydrothermal Treatment using Subcritical Water
20/20
References
In-Hee Hwang, Hiroya Aoyama, Toshihiko Matsuto, TatsuhiroNakagishi, Takayuki Matsuo. Recovery of solid fuel from municipalsolid waste by hydrothermal treatment using subcritical water.
Waste Management 32(2012) 410-416.Brunner, G., 2009. Near critical and supercritical water. Part I.
Hydrolytic and hydrothermal processes. The Journal ofSupercritical Fluids 47, 373381
Thermochemical Liquidization and Anaerobic Treatment of KichenGarbage. Journal of Fermentation and Bioengineering 83 (5),451455. Shen, D.K., Gu, S., 2009.