Skoda Octavia Worshop Manual

126
Service Workshop Manual OCTAVIA Service Department. Technical Information S00.5102.50.20 Edition 08.96 Heating, Air Conditioning

description

Workshop manual to Skoda Octavia

Transcript of Skoda Octavia Worshop Manual

Page 1: Skoda Octavia Worshop Manual

Service

Workshop Manual�������

Service Department. Technical InformationS00.5102.50.20 Edition 08.96

Heating, Air Conditioning

Page 2: Skoda Octavia Worshop Manual

The Workshop Manual is intended only for use within the ŠKODAOrganisation; it is not permitted to pass it on to third parties.

© 1996 ŠKODA, automobilová a.s. ��������������� �������

Page 3: Skoda Octavia Worshop Manual

������������� ��������������������������� �� ������������

��������� ��!����������"������������� ��������#��������$�%%

� ����# ������ � &'�� �����( �&�����

�)�%* +����������������������� �� ����,��-�,��-�� �)�%) !���������# ��!���������� ����,��-�,��-�

.�� �����!�����- ���%% ����#����� ����������� ��!����������#/*,# ����,��-�,-�-�� �$�%% ��������������������0����� ����,��-�,��-�1 ����� ��������������������0����� ����,��-�,1�-�,*$)%�����-���1�,�*�$�)�%-�

!�����⇒��2�����

3������������ ��������������4��� ��.������5����6����������7�������������������������������������������������� ��

8�������!"����,��-�,1�-�

Page 4: Skoda Octavia Worshop Manual
Page 5: Skoda Octavia Worshop Manual

�������������������������

��������������������������

������ ���������������

�� �������������� ���������������������������� �� �� �� ��������������������� ������������������������������������������������������������������������������������������������ ����� ������������������������� ����� ��������� ���������������������������������������������������������������������� ��� � �����������������������������������!����� ���������� �������������������������������������������������� ��� � "��������������������!���������������������������������������������������������������������������������������������������������� ��� � ��������������������������������!����������� ����������������������������������������������������������������� ����� #�������$����% ������������������������ ������������������������������������������������������������������������� ����� ��������������������� ������������� ���������������������������������������������������������������������������������� ���&� ���� ����������� ���'�(�����)����! ������������� ���������������������������������������������������� ���&� *����������������!��'�(�����)����� ������������� ������������������������������������������������������ ����� *����������������!��'�(�����)����� ����� ������������������������������������������������������������������� ����� ���� ���%����� ��������+������'�(�����)����� ����� �������������������������������������������������� ����� ���������)��)�! ������������� ��������������������������������������������������������������������������������������������� ������ ���������������������!��� ���)��(���,� ��������������������������������������������������������������������������� ������ �����������������������������������!��!��� ���)��(���-�� �������������������������������������������� ������ �������������������������������������!��!��� ���������������������!����,��� ���������� ������ .����������������!����������������!��!��� ���������������������!����,������

�!�(��� �/��0 ������������������������������������������������������������������������������������������������������������������������� ���� � ���������������������!���(�������� ������������������������������������������������������������������������������������ ������ ����������������������������������!����� �������������������������������������������������������������������������� ����1� ����������������������������� ���!!����� ������������������������������������������������������������������������� ����1��� .(��(�$�����!���������� ���!!������-��& ������������������������������������������������������������������������ ����1��!�����������������""�����������#��� �� �$� ��������������������� ����2� ������! �������$���� ���������������������������������������������������� ����0

�$ ���������������� ������%����&����#������'����'��(�����������"��'�������������������������'��������"�����%���������!��)� �$ �*�����&������%�����������������+������������������'��( �$ )� 3������������������!����������������$������������������������������������������������������������������������������ �&��� ������!��!��������������� ������������������������������������������������������������������������������������������������������ �&��� 4�����!��!��������������� ��������������������������������������������������������������������������������������������������������� �&�&� *����������!��5���6���������������������!��������������� ������������������������������������������������� �&�0� 4����!����!�����������!��������������� ���������������������������������������������������������������������������������� �&���� �(��� ��!����!��������������� �������������������������������������������������������������������������������������������������� �&���� 4����������!��!���������� �� ����������������������������������������������������������������������������������������������� �&���� 4����������!��!����������� ������������������������������������������������������������������������������������������������������� �&���� "����������!�����������������(��6����!��������������� ����������������������������������������������������� �&���� �����������6�����!���������������(�� ���6�������� ������������������������������������������������������������ �&��1� ���������������!����������%����������%!���������������������������!��!��������

������� ���������������������������������������������������������������������������������������������������������������������������������������� �&��1� *���������!���������������(�� ������������������������ ������������������������������������������������� �&���� *��������� ��������������������������������������������������������������������������������������������������������������������������������� �&���

������#���⇒���,��&���

Page 6: Skoda Octavia Worshop Manual

������� ����

��������������������������

���������������������������

��������������������������������������������������������������������������� ����������������� !"�#����������������������� �������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������� ��������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������!�����������������������"�������������������������������������������������������������������������������#��������������������������������������������������������������������������������������������������������������� �����������������������������$���%����������������������������������������������������������������������������� �����������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������&'������������������������������������������������������������������������������������������������������������������������&����������������������������$#%��������������������������������� �������������������������������������� !"��#�������������������������������������������&&��������������������������������� ���������� !"��'(��������������&��������������������������������������� ����������������������������������������������������� !"��!�������������������������������������������������������������������������������������������������������(')�&�&&��*����������&&��*������������������������������������ ����������������������������������������� !"�+#)�&�&&��*����������&&��*�������������������&������������������� ��������������������������������� !"�++������������������������������,��������������������� ���&��-�������&�& ��������������������������������� !"�+"������������������������������������������������������������������������������������������������������������������������������������������������(��#����������������������������������������������������������������������������������������������������������������������������(��#���)������������������������������������������������������������������������������������������������������������������(��*��������������+�������,��-���������������*�������������������������������������(��.�����������$�����������������������������������������������������������������������������������������������������������������������'�!��������������������+��������������������������������������������������������������������������������������������������������������������$���������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������/���������������������������������������������������������������������������������������������������������������������������������������������0���������������+���������������������������������������������������������������������������������������������������������������������0�����������������������������������������������������������������������������������������������������������������������������������������&�*���������������������������������������������������������������������������������������������������������������������������������������&�����������������$���%����������������������������������������������������������������������������������������������������(�������������������������������,��������������������� ������������������������������������������������������������� !"�"������������*�������������������������+�����0������������������������������������������������������������������*�������������������������������������������������������������������������������������������������������������������(������������������������������������+�����0��� ���*����������������������1�������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������������'��������������������������������������������������������������������������������������������������������������������������(�*����������������������������������������������������������������������������������������������������������������������(-��0����������������������������&������������������������������������������������������������������������������(-�� ������$�����������$�����������������������������������������������������������������������������������������*������������������������������������������������������������������������������������������������������������������������

Page 7: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�����������������������������

Heating System 80

Servicing heating system

Dash panel vents and air guide ducts

Note:

The air in the passenger compartment flows outof the car through 2 ventilation frames (in theright of the luggage compartment in the area ofthe bumper) ⇒ page 80-3.

1 - Dash panel♦ With integrated air guide ducts for def-

roster nozzles and dash panel vents.

♦ Removing and installing⇒ General Body Repairs; repair group 70

2 - “Side window” defroster nozzle♦ Clipped in place

3 - “Right” dash panel vent♦ Removing and installing

⇒ page 80-3.

Page 8: Skoda Octavia Worshop Manual

�������80 Heating System

������������������������������� Edition 08.96��������������

4 - “Centre right” dash panel vent♦ Removing and installing

⇒ page 80-3.

5 - Trim panel for dash panel inserts♦ Removing and installing

⇒ General Body Repairs; repair group 70

6 - “Left” and “centre left” dash panelvents♦ Removing and installing

⇒ page 80-3.

7 - “Windscreen” defroster nozzle

8 - Air guide duct to dash panel vents♦ Bolted to heating system, with catch

at top.

9 - Air guide duct to defroster nozzles♦ Removing and installing

⇒ page 80-4.

Page 9: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�������������������������������

Heating System 80

Removing and installing “right”dash panel vent

- Remove glove box and right trim panel ofdash panel.

⇒ General Body Repairs, repair group 70.

� - Apply pressure to securing clips -arrows- byhand or with a screwdriver.

Removing and installing “centre”and “left” dash panel vents

- Remove trim panel for dash panel insert.⇒ General Body Repairs; repair group 70.

� - Release catches -arrows-.

Note:

Only the left and centre left dash panel ventsare identical.

Inspecting ventilation frames

� - The sealing lips -B- in the ventilation frame-A- must not be blocked and must close au-tomatically.

Note:

♦ This illustration shows the ventilation frameswith the rear bumper installed.

♦ 2 ventilation frames (on right side only) areinstalled for forced ventilation.

♦ The air guides formed by the trim panel ofthe luggage compartment must not be co-vered over if ventilation of the passengercompartment is to operate properly.

Page 10: Skoda Octavia Worshop Manual

�������80 Heating System

������������������������������� Edition 08.96��������������

Removing and installing air guideduct to defroster nozzles

- Remove dash panel⇒ General Body Repair; repair group 70

� - Remove air guide duct -A- by lifting up.

Page 11: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�������������������������������

Heating System 80

Heating system, heater controls and air guide ducts

Note:

The fresh air is drawn in through a dust andpollen filter; removing and installing⇒ page 80-16.

1 - Heater controls♦ Removing and installing

⇒ page 80-7.♦ Detaching and attaching bowden cab-

les ⇒ page 80-7.♦ Adjusting bowden cables

⇒ page 80-8.

♦ Connection diagram for bowden cab-les ⇒ page 80-8.

♦ Replacing bulb ⇒ page 80-10.

Note:

At the start of production, a bulb is used for illu-minating the rotary switches. Production will beconverted to LEDs at a subsequent date; thesewill then no longer be replaceable.

Page 12: Skoda Octavia Worshop Manual

�������80 Heating System

������������������������������� Edition 08.96��������������

2 - Switch for fresh and recirculated airflap -E159♦ Testing operation ⇒ page 80-13

Notes:

♦ The switch is a fixed element of the heatercontrols.

♦ No recirculated air operation is possible inthe “defrost mode” (the recirculated air modeis switched off about 15° before the air dis-tribution rotary switch reaches the end posi-tion “air supply to windscreen”.

3 - Driver side footwell vent

4 - Rear duct

5 - Connection piece to rear duct

6 - Left cover for footwell vent

7 - Footwell vent♦ Removing and installing

⇒ page 80-15.

Page 13: Skoda Octavia Worshop Manual

������� ������������ �

���������������������������

���������������������������

� �����������♦ ������������� �����⇒������

��♦ �� ������ ����� �� ���� ���

�����������⇒�������♦ ������ �������� �����������

���⇒�������� � ��������������

♦ ������������� �����⇒�������!

♦ "����������� ��������������������� � �������������� ������ ����� ����

�� � ���������������������������������♦ ������������� �����⇒������

#�� � ������ ��� �������!����� ���� �!�"� �����

�#�$%�♦ $�� ������� ���⇒�������%♦ ������������� �����⇒������

�&�& � ������ ��������� ���� ������ ���� '!�(��

�)&%�♦ ������������� �����⇒������

���� � ����������'!�(����#&�

♦ ������������� �����⇒��������

*�����������������!!����������������!�� ��������� ���������'⇒ ���()� ���*��+,�����-����.�

� � /��� � ������� �� ��� ���� � ��������0�'

� ���������������'� 1��� ����������� ����'� $+��� ����� �������������� '

+�����������������������,�(�����'!�������������������!�� �������� ����� ����'

� � 2����������� ���+� �0�������������'� �� ������������'������♦ ������������� � ����� ������ ���� ������

���� ��� ��� � ����� ������ ��� ������ �� � ����

♦ ��� ��������� ������������������ ������������ ����������

Page 14: Skoda Octavia Worshop Manual

�������80 Heating System

����������������������������� Edition 08.96��������������

Connection diagram for bowdencables at heater controls

� - Bowden cable -A- to footwell/defroster flap.

Colour: green

- Bowden cable -B- to central flap.

Colour: yellow

- Bowden cable -C- to temperature flap.

Colour: beige

Connection diagram for bowdencables at heater

� - Bowden cable -A- to footwell/defroster flap.

Colour: green

- Bowden cable -B- to central flap.

Colour: yellow

- Bowden cable -C- to temperature flap.

Colour: beige

Detaching, attaching and adjustingbowden cables at heater

Detaching bowden cables

- Remove footwell vent ⇒ page 80-15.

� - Lever off securing clip -A-.

- Carefully take bowden cable off lever arm-B-.

Page 15: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�������������������������������

Heating System 80

Notes:

♦ Inspect bowden cables before installing;replace any bowden cable which does notoperate freely or is damaged.

♦ After installing the bowden cable, turn rotaryswitch to both end stops (should reach bothend stops).

Attaching bowden cable to temperature flapand adjusting

- Turn rotary switch for temperature flap asfar as the stop in “cold” position.

� - Attach bowden cable to the lever for the tem-perature flap -B-.

- Press lever for temperature flap -B- slightlyin direction of arrow.

- Fix bowden cable sheath in place with se-curing clip -A-.

- Turn rotary switch for temperature flap to bothend stops (should reach both end stops).

Attaching bowden cable to central flap andadjusting

- Turn rotary switch for air distribution to thestop in position “air flow to windscreen”.

� - Attach bowden cable to the lever for the cen-tral flap -C-.

- Press lever for central flap -C- slightly in di-rection of arrow.

- Fix bowden cable sheath in place with se-curing clip -A-.

- Turn rotary switch for air distribution to bothend stops (should reach both end stops).

Page 16: Skoda Octavia Worshop Manual

�������80 Heating System

����������������������������� Edition 08.96��������������

Attaching bowden cable to footwell/defrosterflap and adjusting

- Turn rotary switch for air distribution as faras the stop in position “air flow to wind-screen”.

� - Attach bowden cable to lever for footwell/def-roster flap -B-.

- Press lever for footwell/defroster flap -B-slightly in direction of arrow.

- Fix bowden cable sheath in place with se-curing clip -A-.

- Turn rotary switch for air distribution to bothend stops (should reach both end stops).

Replacing bulb for heater controls

Notes:

♦ Place e.g. a thick cloth between rotary knoband the jaws of the pliers to avoid the rotaryknob being damaged, or use pliers with plas-tic or rubber jaws.

♦ At start of production, a bulb is used for illu-minating the rotary switches. This will be con-verted to LEDs at a later date; these will thenno longer be replaceable.

� - Use pliers to pull rotary knob -A- off the rotaryswitch for fresh air blower.

- Use pointed pliers or a bulb puller to pull bulb-B- out of the socket.

Page 17: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

������������������������������

Heating System 80

Removing and installing fresh airblower -V2

- Remove series resistor -N24 ⇒ page 80-11.

� - Pull fresh air blower -B- down and out of theheater.

- Unplug connector -A- from the fresh air blo-wer.

Separating fresh air blower -V2 and baseplate

� - Remove screw -A-.

- Pull fresh air blower out of the base plate -B-.

Notes:

♦ When installing fresh air blower in the baseplate, ensure the connector -C- is correctlyinstalled.

♦ After installing fresh air blower, ensure it iscorrectly located in the heater.

Removing and installing seriesresistor for fresh air blower -N24

- Remove screw clip for foam cover.

� - Fold foam cover -C- to the side.

- Take connector -A- off the series resistor.

- Remove screw -B- and take off resistormount.

Page 18: Skoda Octavia Worshop Manual

�������80 Heating System

������������������������������ Edition 08.96��������������

Removing series resistor from the resistormount

� - Drill or shear off the securing screws -A-.

- Press back catches -C-.

- Remove series resistor -B-.

Note:

When installing series resistor, attach with 3.2 x10 mm self-tapping screws -D-.

Removing and installingpositioning motor for fresh air andrecirculated air flap -V154

Removing

- Remove glove box.⇒ General Body Repairs; repair group 70

- Set fresh air and recirculated air flap to “re-circulated air” (if possible).

� - Unplug connector -A-.

- Remove bolt -B-.

- Push positioning motor down until the tongue-D- is clear of the slot -E- and push position-ing motor to the outside -direction of arrow-.

Installing

- Set fresh air and recirculated air flap manual-ly to “fresh air”.

- Plug in connector -A-.

� - Operate the fresh air and recirculated airswitch and switch ignition on and off in orderto move lever -F- on positioning motor intocentre position -direction of arrow-.

- Tilt positioning motor down about 45° andinstall.

Page 19: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Heating System 80

Testing operation of the positioningmotor for fresh air and recirculatedair flap -V154 and of switch -E159

Notes:

♦ No recirculated air operation is possible inthe position “air supply to windscreen” (switch-E159- is blocked mechanically by the rotaryswitch) to ensure that misted windows arecleared as rapidly as possible.

♦ Otherwise, the windows might mist up in therecirculated air mode (the moisture in the airin the passenger compartment increases andthen condensates on the windows).

Testing operation of switch -E159 and of po-sitioning motor -V154

- Switch on ignition.

� - Set rotary switch -A- for fresh air blower -V2to stage 3.

- Turn rotary switch -B- for air distribution tothe “air supply to dash panel vents” position.

- Do not operate switch -C- for fresh and re-circulated air flap -E159-.

- The air is drawn in through the dust andpollen filter (fresh air mode, indicator lampin switch must not come on).

- Operate switch -C- (recirculated air mode,indicator lamp in switch should come on).

The air is drawn in from the area of the frontpassenger footwell (recirculated air).

� - Turn rotary switch -B- for air distribution asfar as the stop in position “air supply to wind-screen”.

Indicator lamp in switch -C- should go out,the fresh air and recirculated air flap movesinto fresh air position (switch -C- operatedby rotary switch -B-).

Page 20: Skoda Octavia Worshop Manual

�������80 Heating System

�������������������������������� Edition 08.96��������������

Notes:

♦ If the controls operate properly and the win-dows nevertheless mist up:

- Inspect dust and pollen filter for dirt⇒ page 80-16.

- Inspect forced ventilation ⇒ page 80-3.

♦ If the controls do not operate properly, testswitch -E159.

Testing operation of switch -E159

- Remove glove box.⇒ General Body Repairs; repair group 70.

� - Unplug connector -A- from positioning motorfor fresh air and recirculating air flap -V154.

- Switch on ignition.

- Turn rotary switch for air distribution into “airsupply to dash panel vents” position.

- Do not operate switch -E159 (not pressedin).

Fresh air mode, indicator light in switch mustnot come on.

- Connect voltage tester V.A.G 1527 B bet-ween contacts 1 and 3 at connector -A-.

Indicator lamp in voltage tester should comeon.

- Operate switch -E159 (press).

Recirculating air mode, indicator light inswitch should come on.

Indicator light in voltage tester should go out.

� - Connect voltage tester between contact 2and 3 at connector -A-.

Indicator light in voltage tester should comeon.

Page 21: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Heating System 80

- Turn rotary switch for air distribution as faras the stop in position “air supply to wind-screen”.

Indicator light in switch and in voltage testershould go out.

Notes:

♦ If no fault can be found during this test:

- Inspect fresh air and recirculating air flapto ensure it operates freely.

- Replace positioning motor -V154.

♦ If the controls do not operate properly:

- Test cable connection between -E159 and-V154 for open circuit and short circuit.

- Test voltage supply and earth connectionto switch -E159.

- Replace heater controls.

Removing and installing footwellvent

- Remove centre console.⇒ General Body Repairs; repair group 68

- Remove left cover below dash panel.

� - Remove left cover for footwell vent -E-(2 expanding clips, 2-piece).

- Remove support -D-.

- Remove connection piece -C- between foot-well vent and rear duct.

- Press footwell vent -B- down out of the cat-ches -A- and remove in direction of arrow.

Page 22: Skoda Octavia Worshop Manual

�������80 Heating System

�������������������������������� Edition 08.96��������������

Removing and installing dust andpollen filter

� 1 - Surround

2 - Filter element

3 - Plastic nut

4 - Filter housing with gasket

Removing

- Remove right cover of plenum chamber⇒ General Body Repairs; repair group 66

- Press catches of filter housing in direction ofarrow -B- and remove filter element togetherwith surround.

Installing

- The surround should engage in the first la-mellar segment of the filter element -arrowA-.

Page 23: Skoda Octavia Worshop Manual

������� ������������ �

���������������������������

��������������������������������

����� ������������� ������������������������ !""��#����$%&� �'�$%� �������������� ��������������������������

���������������������������� ���������������� ������ ������������������ �������� ��������� �� ������ ������� ��

������ ��� ������ ��� �����������������������

� ����� � � ������ ������ �������� ������������ ����������� ��������������� !"�

� #����������������� �������������� ������

� �������������������������������������� ���������������������������($��!���$%

$�������������� �������������������������� % ��� �������&� ��������� ������ ������

������������ ������� ���������������⇒ $�����������������)*+*�,����-��������������+./01+���������� !""��#����$%2����$%

� � '����������������������������� ���������������������������������

���������(���� �����)�*+�����*,�3

$ ��������� �������������������)� ��������������

S87–0173

Page 24: Skoda Octavia Worshop Manual

��������� �������� ���

��������������������������

��������������������������������

�������������� ����������� � ����� �� �� ���� �� ��� ���� �� ����

���������������� ��������⇒ ����� �� �������������� �������� �����

� � ��� ����� ������� �� ������������ ������!�������������� ����������� ������������ ��������������� �� ��������� "������������ �����⇒ ����� �� �������������� �������� �����

� � ��� ����� ������� �� ���#��������� ��������⇒������$%�&�

������������� ����� "����������� �� ������ ��⇒������$&�'(

) ���������� ������������*#� ������� �� ���������⇒������$&�&+�

�������� � , ������ ����������������������

� ������������������������������ -�������������� ����!�������� ������� �������� ������������� �������������������

S87–0173

Page 25: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Heating System 80

Removing and installingheater unit

- Remove dust and pollen filter together withhousing ⇒ page 80-16.

- If radio set equipped with anti-theft coding,determine coding.

- Disconnect battery.

- Release pressure in coolant circuit by open-ing the cap at the coolant expansion reser-voir.

� - Pinch off both coolant hoses to the heat ex-changer of the heating system (e.g. withV.A.G 3094) and take off.

Notes:

♦ Connect the coolant hoses the right wayround:

- Coolant hose -A- feed from cylinder head

- Coolant hose -B- return flow to waterpump

♦ Bleed coolant circuit.⇒ Engine, Mechanical Components; repair

group 19

� - Place container below the connection for thehose -B- and carefully blow the coolant outof the heat exchanger through the connectionfor hose -A- (using compressed air).

� - Fold up the pre-punched points -A- of theheat insulating mat and remove the hexagonnuts and washers -B- located behind (tighten-ing torque 15 Nm).

- Remove hexagon nut and washer -C-.

Note:

A seal should be fitted at the washers of thehexagon nuts.

Page 26: Skoda Octavia Worshop Manual

�������80 Heating System

������������������������������ Edition 08.96��������������

- Remove dash panel.⇒ General Body Repairs; repair group 70

- Remove footwell vent ⇒ page 80-15.

- Remove front passenger airbag unit.⇒ Electrical System; repair group 96

- Cover over all opened connectors and air gui-de ducts of the heater unit to prevent anyswarf in getting in.

� - Drill off support for the dash panel with a 7mm drill at the points marked with -A-(connection points).

- Bend part -B- of support at the specifiedbreaking point -C- to the side in direction ofarrow.

Note:

After installing heater unit, bend back part -B-into its original position and bolt the shaped sec-tion marked with broken lines to the holes -A-(e.g. M 6 x 10).

- Separate electrical connection between carand heater unit (plug connection and bolted-on earth cable at A pillar).

� - Remove heater unit in direction of arrow.

Notes re installing:

♦ Inspect all the seals and gaskets on heaterunit for signs of damage before installing andreplace any damaged seals and gaskets.

♦ When inserting the heater unit, inspect theseal at the intake duct; it should be makingcontact with the body.

� ♦ Replace gasket -A- at heat exchanger andensure it is correctly located at the contactsurface -C-.

♦ The flow direction of the coolant is indicatedon the connection of the heat exchanger(arrow -B-).

♦ All the cable straps which have to be takenoff for removing the heater unit, should befitted on again at the same point after assemb-ly.

Page 27: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Heating System 80

Removing and installing heatexchanger of heating system

- Remove heater unit ⇒ page 80-17.

� - Push back catches -B- and pull the heat ex-changer -A- out of the heater unit.

Notes:

♦ If the heat exchanger does not engage pro-perly when being installed in the heating flapbox, it should be attached with 2 suitablescrews -C- (e.g. 3.2 x 20 mm self-tappingscrews).

♦ Ensure that the gasket -D- is correctlyinstalled; it must not be visible after install-ation.

� ♦ Replace gasket -A- and ensure that it iscorrectly installed at the contact surface -C-.

♦ The flow direction of the coolant is markedat the connection of the heat exchanger(arrow -B-).

Page 28: Skoda Octavia Worshop Manual
Page 29: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�����������������������������

Air Conditioning 87

Safety precautions when working on vehicleswith air conditioning and when handling refri-gerant R 134a

The components and the pipe system of the air conditioning are filledwith the refrigerant R 134a (Tetrafluorethane CH

2F-CF

3). This refrigerant

will also be familiar from the trade designations H-FCR 134a or SUVA134a available from Dupont (other trade designations may be common inother countries).

Observe the following safety precautions in respect of refrigerant R134a (additional precautions and regulations may apply in individualcountries):

Should it be necessary to drain the refrigerant circuit for carryingout repairs to the vehicle, hand over the vehicle to an air conditioningservice centre workshop!

Reason:

Only service centre workshops have available the suitable service stationsin order to professionally extract the refrigerant.

If the refrigerant circuit is opened in a service centre workshop, avoidany contact with liquid refrigerant or with refrigerant vapours. Shouldrefrigerant flow out despite observing all the necessary safety pre-cautions, do not inhale the gas/air mixture which is produced. Forthis reason, always switch on the extraction facilities available andprotect your hands with rubber gloves and your eyes with eye pro-tection.

Reason:

The intensive effect of refrigerant on unprotected parts of the bodyproduces frostbite. Refrigerant gas is heavier than air, colourless andodourless and thus displaces the oxygen present in the air without thisbeing perceptible.

Notes:

♦ It is recommended to keep a bottle of eye wash for rinsing out eyesclose at hand. If liquid refrigerant gets into your eyes, rinse out youreyes thoroughly with water for about 15 minutes.

♦ After this, treat your eyes with eye drops and consult a doctor imme-diately even if your eyes are not painful. The doctor should be advisedthat the frostbite has been caused by refrigerant R 134a.

♦ If refrigerant gets onto other parts of your body despite observing allthe necessary safety precautions, these should also be thoroughlyrinsed with cold water immediately for at least 15 minutes.

Page 30: Skoda Octavia Worshop Manual

�������87 Air Conditioning

������������������������������� Edition 08.96��������������

Work on the refrigerant circuit of the air conditioning system shouldonly be carried out in well ventilated areas. Refrigerant must not bestored in lower-level areas (e.g. cellars) and in related exit passagesor window sills.

Reason:

Refrigerant is colourless and odourless. In addition, it is heavier than airand thus displaces the oxygen. This produces the risk of suffocation inpoorly ventilated areas or in assembly pits, without the persons presentbeing able to sense the danger beforehand.

Remedy:

When working on the refrigerant circuit, ensure that there is no assemblypit, shafts or cellar entrances within a surrounding area of 5 m. Switch onthe available extraction equipment.

It is not permitted to carry out any welding or brazing/soldering workon parts of the filled air conditioning system. This also applies towelding and brazing/soldering work on the vehicle if there is a riskof heating parts of the air conditioning system. When carrying outrepair spray-painting, the temperature of the components in thedrying oven or in its preheating zone must not rise above max. 80°C.

Reason:

The heating up of components produces a severe overpressure in thesystem which can result in the pressure relief valve opening. During electricwelding, invisible ultraviolet rays are released which penetrate the refri-gerant hoses and decompose the refrigerant.

Remedy:

Damaged or leaking parts of the air conditioning system must not berepaired by welding or brazing/soldering but should always be replaced.Extract the refrigerant from the refrigerant circuit beforehand using theservice station (hand over vehicle to a service centre workshop).

Although refrigerant is not a fire hazard, it is not permitted to smoke,or to carry out welding or brazing/soldering work in an area in whichrefrigerant is present.

Reason:

Because of the high temperature produced by a naked flame or by hotbodies, the refrigerant gas is chemically split. Inhaling the toxic split pro-ducts which are produced results in an irritating cough and in nausia.

Page 31: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�������������������������������

Air Conditioning 87

Containers filled with refrigerant (e.g. filling cylinder of the servicestation) must in no account be rapidly heated or exposed to thedirect rays of the sun.

On no account fill a container completely with liquid refrigerant. Anadequately large expansion area (gas cushion) has to be availableotherwise the container will rupture if the temperature rises, withdisastrous consequences.

Refrigerant must on no account be filled into systems and containersin which air is present.

Remedy:

Evacuate systems and containers before filling with refrigerant.

Refrigerant must not be drained into the environment but must beextracted from the refrigerant circuit using an extraction or servicestation. The extracted refrigerant is then re-processed locally or re-turned to the manufacturer for disposal in conformity with environ-mental regulations (other or additional regulations may apply in in-dividual countries). For this reason, handle the vehicle to a servicecentre workshop (such workshops have available the necessary fa-cilities and tools).

After emptying the air conditioning system, interrupt the voltagesupply to the magnetic coupling -N25- (e.g. unplug connector fromA/C pressure switch -F129-).

Reason:

Interrupting the voltage supply prevents the compressor being switchedon inadvertently while the refrigerant circuit is empty.

Page 32: Skoda Octavia Worshop Manual

�������87 Air Conditioning

������������������������������� Edition 08.96��������������

Description of the air conditioning system,inspection and repairwork

Operating principle of the air conditioning system

The temperature in the passenger compartment is determined by theheat radiated through the windows and by the heat transmitted by metalparts. It is necessary to remove part of the heat which exists in order tocreate comfortable temperatures on very warm days for the well being ofthe occupants.

As it is known that heat flows towards colder temperature areas, a com-ponent is installed in the car which produces low temperatures, this beingthe evaporator. This component continuously evaporates liquid refrigerant.The heat which it requires for this is drawn from the air which flows throughthe evaporator.

The refrigerant gas together with the heat which it has absorbed is pumpedout of the evaporator by the compressor. The compression work of thecompressor increases the heat content and the temperature of the refri-gerant. It is now considerably higher than the temperature of thesurrounding air.

The higher-temperature refrigerant together with its heat content flows tothe condenser where, because of the temperature difference betweenrefrigerant and surrounding air, the refrigerant transfers heat through thecondenser to the surrounding air and is therefore liquefied.

The refrigerant is thus a means of transporting heat. As it is needed again,it is pumped back to the evaporator.

Page 33: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�������������������������������

Air Conditioning 87

Design of the refrigerant circuit

Note:

♦ All the components of the air conditioningsystem marked with a * as well as all therefrigerant hoses and refrigerant pipes canbe repaired or replaced only in service centreworkshops for the refrigerant first of all hasto be extracted with a service station.

HD = high pressure side

ND = low pressure side

1 - Oil drain plug *

2 - Magnetic coupling -N25

3 - Compressor *

4 - Pressure relief valve *

5 - Condenser *

Page 34: Skoda Octavia Worshop Manual

�������87 Air Conditioning

Edition 01.99��������������

6 - Receiver with drier*

7 - Valve for extracting, filling and meas-uring*♦ High-pressure side

8 - Cap

9 - Connection with valve*

10 - Air conditioning pressure switch-F129- or high-pressure sender -G65-

11 - Expansion valve*

12 - Evaporator*

13 - Cap

14 - Valve for extracting, filling and meas-uring*♦ Low-pressure side

15 - Pre-volume*

�����������������������������

Page 35: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

����������������������������

Air Conditioning 87

Parts of the refrigerant circuit

� Compressor

The compressor is belt-driven from the vehicleengine.

A magnetic coupling -N25- attached to the com-pressor, creates power flow between belt pulleyand compressor shaft when the air conditioningis switched on.

The compressor draws in refrigerant gas fromthe evaporator, compresses it and passes it ontothe condenser.

Note:

The compressor contains refrigerant oil whichcan be mixed with refrigerant R 134a at all tem-peratures.

� Condenser

The condenser transfers heat from the com-pressed refrigerant gas to the surrounding air.

The refrigerant gas condenses when this is doneto form a liquid.

� Receiver

The receiver gathers the liquid drops and thenpasses them in an uninterrupted flow to the ex-pansion valve. Moisture which has penetratedinto the refrigerant circuit during removal andinstallation work, is absorbed in the receiver bya drier.

Page 36: Skoda Octavia Worshop Manual

�������87 Air Conditioning

����������������������������� Edition 08.96��������������

� Expansion valve

The expansion valve atomises the inflowing ref-rigerant and regulates the flow as a function ofthe different pressures so that the vapour, de-pending on the heat transport, does not becomegaseous until it reaches the outlet of the evapo-rator.

� Evaporator

The liquid refrigerant evaporates in the evapora-tor. The heat required for this is drawn from theair as it passes the evaporator ribs. The air coolsdown as this happens. The refrigerant evapo-rates and is drawn in by the compressor togetherwith the heat which it has absorbed in the formof a gas.

Pipes and hoses of the refrigerant circuit

The mixture of refrigerant oil and refrigerant R134a attacks certain metals (e.g. copper) andalloys and dissolves certain hose materials.

For this reason, use only genuine replacementparts.

Page 37: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

�������������������������������

Air Conditioning 87

� O-ring seals

These rings provide a seal at the connectionpoints between the individual components of therefrigerant circuit.

Only O-rings which are resistant to refrigerantR 134a and the related refrigerant oils, may beused.Always use genuine replacement parts.

O-ring seals:

♦ Always use only once and then replace.

♦ Pay attention to the correct diameter -a- and-b-.

♦ Moisten with refrigerant oil before inserting.

Connections for quick-couplingadapters at refrigerant circuit

♦ Only valves and connections which are re-sistant to refrigerant R 134a and the relatedrefrigerant oils, may be used.

♦ Different connections (outer diameter) for thehigh pressure and low pressure sides ensu-res there is no risk of mixing up the connec-tions.

♦ After disconnecting the quick-coupling adap-ter, screw on the caps again to prevent anydirt getting in.

� Connection with high pressure valve

1 - Base with female thread

2 - O-ring:10.8 mm; 1.8 mm

3 - Valvewith groove for O-ring and M8x1 femalethread for cap

4 - O-ring:10.8 mm; 1.8 mm

5 - Cap

Page 38: Skoda Octavia Worshop Manual

�������87 Air Conditioning

������������������������������ Edition 08.96��������������

� Connection with low pressure valve

1 - Base with male thread and groove forO-ring

2 - O-ring:7.6 mm, 1.8 mm

3 - Valve:female thread for M8x1 cap

4 - O-ring for cap:7.6 mm; 1.8 mm

5 - Cap

Parts for protecting refrigerantcircuit

� Pressure relief valve

The pressure relief valve is located at the com-pressor and opens if an excess pressure exists.The refrigerant does not flow out completely. Aplastic washer stuck onto the valve indicateswhether the valve has opened (is pushed off).

Opening pressure: 40 ± 4 barClosing pressure: 32.5 bar

Note:

If the pressure relief valve has opened, deter-mine the cause for the excess pressure in thesystem and rectify.

� Coil for magnetic coupling -N25-

♦ An overheating protection is installed in themagnetic coil. The overheating protection in-terrupts the magnetic coil as soon as themagnetic coupling is heats to an excessiveextent (about 180 °C) (e.g. if the compressoris stiff).

♦ A protective diode is also integrated in themagnetic coil (reduces voltage peaks whichmay arise when the magnetic coupling isswitched off).

Page 39: Skoda Octavia Worshop Manual

������� Air Conditioning 87

Edition 01.99��������������

��������������������������������

Refrigerant circuit switch

� Position A: Air conditioning pressure switch-F129-

♦ Switches magnetic clutch -N25- off throughradiator fan control unit -J293- at a pressureof 3.2 MPa (32 bar).

♦ Switches magnetic clutch -N25- off throughradiator fan control unit -J293- at insufficientpressure (0.12 MPa/1.2 bar), for exampleloss of refrigerant.

♦ Switches the radiator fan into stage 2 throughthe radiator fan control unit at a pressure of1.6 MPa/16 bar (ensures optimal workingpressures of refrigerant.

Position B: High-pressure sender -G65-

The high-pressure sender -G65- detects thepressure in the refrigerant circuit and passeson the pressures detected to the engine controlunit. The latter actuates the necessary stepsthrough the radiator fan control unit -J293-.

♦ In the event of a pressure rise in the refriger-ant circuit, switches the radiator fan -V7- intothe next higher stage.

♦ In the event of an excessively high pressure,switches off the magnetic clutch -N25- (forexample if engine cooling inadequate).

♦ In the event of insufficient pressure, switchesoff the magnetic clutch -N25- (for example ifloss of coolant).

� Radiator fan control unit -J293-

The following are operated through the controlunit:

♦ Magnetic clutch -N25-

♦ Radiator fan -V7- (stages 1 and 2)

� Coolant temperature overheating warningswitch -F14-

Switches the magnetic clutch -N25- off throughthe radiator fan control unit if coolant tempera-ture is 119 °C, and on again at a temperature of112 °C (engine overheating protection).

Page 40: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

� Outside temperature switch -F38-

Switches off the magnetic coupling through theradiator fan control unit at a temperature of2 °C and switches it on again at 5 °C (anti-icingprotection for evaporator).

Properties of refrigerant R 134a

Colour

Refrigerant in the form of the vapour and liquid is colourless like water, asa gas it is invisible.

Vapour pressure

In a completely filled and closed container, vaporous refrigerant evaporatesat the surface in the quantity which becomes liquid again as the vapourparticles combine. This state of equilibrium is produced under pressureand is frequently termed vapour pressure. The vapour pressure is tem-perature-dependent.

Solubility of the refrigerant oil

A small quantity of the special refrigerant oil (poly-alkylene-glycol-oil) re-quired for the compressor for lubricating cylinder walls, also flows withinthe refrigerant circuit and mixes with the refrigerant R 134a.

Temperature in °C Pressure (bar gauge)

-30 0-20 0,3-10 1,00 1,9

+10 3,1+20 4,7+30 6,7+40 9,1+50 12,2+60 15,8+70 20,2

Page 41: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

Displacement of air by gaseous refrigerant

Refrigerant gas is heavier than air and therefore spreads at floor level. Itgathers in inspection pits and displaces the air which is present at suchpoints.

Environmental compatibility

Refrigerant R 134a, to the extent that it reaches the Earth’s atmosphere,contributes to an intensification of the greenhouse effect.

The greenhouse effect of refrigerant R 134a is significantly less than thatof refrigerant R 12.

Toxicity

Refrigerant is non-toxic up to a temperature of 101 °C and - providedproper attention is paid to the instructions for handling refrigerant R 134a- it does not have any detrimental effects on the human body. It is odourless,does not have any irritant effect and is thus panic-proof.

Gaseous or vaporous refrigerant does not affect food and therefore doesnot render them toxic or unsuitable for consumption.

Reaction to plastics

Refrigerant acts as a solvent for certain plastics. Such dissolved plasticsmay be separated out when they cool in the expansion valve and thusblock the valve.For this reason, always use only genuine replacement parts!

Reaction to metals

In its pure state, refrigerant R 134a is chemically stable and does notattack iron or aluminium.Impurities in the refrigerant, e.g. compounds of chlorine, can result, ho-wever, in certain metals and plastics being attacked. This can lead toblockages, leaks or deposits at the piston of the compressor.

Critical temperature/critical pressure

The refrigerant R 134a remains chemically stable up to a gas pressure of39.5 bar (this equals a temperature of 101 °C); above this temperaturethe refrigerant decomposes (refer to Combustibility).

Water content

Water is soluble in liquid refrigerant only in quite small quantities. In con-trast, refrigerant vapour and water vapour mix to the same ratio.

Any water present in the refrigerant circuit is transported as droplets if thedrier in the receiver is saturated. Proper operation of the drier is thereforeno longer assured. This water flows as far as the nozzle of the expansionvalve and is transformed into ice, which in turn reduces the efficiency ofthe cooling system.

Page 42: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

Water destroys the air conditioning system because acids are producedat high pressures and temperatures in combination with other impurities.

Combustibility

Refrigerant is non-combustible. In contrast, it has a fire-retardant or fire-extinguishing effect. Refrigerant is decomposed by flames and glowingsurfaces. Refrigerant is also split by UV light (as produced during electricwelding). In this case, toxic split products (fluorocarbon and traces ofcarbonyl fluoride and fluorine) are produced, although the irritation of themucous membranes does provide sufficient and timely warning.

Filling factor

A vapour space has to be present within the reservoir. The liquid expandsas the temperature rises and the space filled with vapour becomes smaller.At a certain point in time there will only be liquid present in the reservoir.After this moment, only a slight rise in temperature is sufficient to producevery high pressures in the reservoir because the liquid wishes to expandfurther but there is no more space available for this. The forces which areproduced in such a case are sufficiently large to cause the reservoir toburst. To ensure that the reservoir is not overfilled, specifications are laiddown in the compressed gas recirculations in respect of how many kilo-grams of refrigerant may be poured in for each litre of internal volume ofthe reservoir. This “filling factor”, multiplied by the inner volume, producesthe permissible filling capacity, this being 1.15 kg/ltr. in the case of refrige-rant R 134a.

Detection of leaks

The refrigerant circuit may develop a leak, for example as a result ofexternal damage. Detecting minor leaks is only possible using an electronicleak detector, because of the small quantity of refrigerant which flows out.

Properties of the refrigerant oil

An oil with special properties also circulates in the refrigerant circuit forlubricating the compressor.

The principal properties are the high solubility with refrigerant, goodlubrication properties, freedom from acids and absence of moisture.

The poly-alkylene-glycol (PAG) oils which are suitable for the refrigerantR 134a, are highly hygroscopic (water-absorbent) and cannot be mixedwith other oils. For this reason, any opened containers should be sealedagain immediately to prevent moisture getting in. Refrigerant oil ages asa result of moisture and acids, becomes dark, viscous and aggressive tometals.

Notes:

♦ None of the oils used for refrigerant circuits containing refrigerant R12 may be used for refrigerant circuits filled with refrigerant R 134a

♦ Because of its chemical properties, the refrigerant oil must not be dis-posed of together with engine oil or gear oil. Refrigerant oil has to bedisposed of separately as toxic waste.

Page 43: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

Important information regarding work on refrigerantcircuit

♦ Never pour refrigerant R 12 into an air conditioning system designedfor refrigerant R 134a. Likewise, do not pour refrigerant R 134a intoair conditioning systems which use refrigerant R 12 because materialsof the components used in the respective circuits are matched to therelevant refrigerant.

♦ In the same way, the refrigerant oils developed for refrigerant circuitsoperating with R 134a and R 12, must not be mixed.

♦ The components of the refrigerant circuit for refrigerant R 134a areidentified by the inscriptions on green stickers or are designed to eli-minate any risk of confusion with components for refrigerant R 12(e.g. different thread).

♦ On no account may different refrigerants be mixed with each other.

♦ Keep the workbay and all tools clean.

♦ Wear eye protection and protective gloves when handling refrigerantand nitrogen.

♦ Switch on the available extraction equipment.

♦ Use only the service station to drain the refrigerant circuit and do notopen screw unions or replace faulty components until this has beendone.

♦ Seal open components and hoses immediately airtight with caps toprevent moisture and dirt getting in.

♦ Use only materials and tools which have been designed for refrigerantR 134a.

♦ Seal opened containers of refrigerant oil immediately to protect the oilfrom moisture.

♦ Blow through the refrigerant circuit with compressed air and nitrogenif:

- moisture or dirt have got into the refrigerant circuit (e.g. after anaccident),

- the refrigerant oil is dark and viscous,

- too much refrigerant oil is present in the circuit after changing thecompressor,

- the compressor has to be replaced because of an “internal” damage(e.g. noisy or no capacity).

Page 44: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

♦ O-ring seals

- Use only seals which are resistant to refrigerant R 134a and to therelevant refrigerant oil

- Use seals only once

- Oil with refrigerant oil (PAG oil) before installing

- Pay attention to the correct inner diameter

♦ When blowing through components with compressed air nitrogen, al-ways extract the gas mixture which flows out of the components withsuitable extraction equipment (workshop extraction equipment).

♦ After completing repairwork, screw the caps onto the filler valves.

♦ The refrigerant circuit must not be purged with purging product R 11.

♦ Do not add any refrigerant to a filled refrigerant circuit (if it is unclearhow much refrigerant is already in the circuit, empty system, evacuateand re-fill).

Detecting leaks in refrigerant circuit with leak detector

Notes:

♦ Minor leaks in a circuit containing refrigerant R 134a can only bedetected with special leak detectors (e.g. V.A.G 1796).

♦ Carry out leak detection in accordance with the instructions for use ofthe equipment available from the trade.

♦ If the refrigerant circuit is completely empty, pour in about 100 g refri-gerant before carrying out leak detection work.

Service station for draining, evacuating, filling and formeasuring pressure of refrigerant circuit

When carrying out repairs to the refrigerant circuit, it is necessary to openthe circuit. Beforehand, the refrigerant has to be properly extracted, andthe refrigerant circuit filled again after repairs are being completed.

Special equipment is available from the trade for refrigerant R 134a forsuch operations, e.g. V.A.G 1770 and V.A.G 1771.

Page 45: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������������������ ������������

�������������� ������������� ��������� ������ ������������ �������� �� ����������� ��������� ��������������� ���� ���������� ������ ����������� ��� ������ ������� ������ ���� ��������� ������ ��� ����� ���� ������������������� ��� ����� ������������� ������ ����� ������������������������ ������������ ����� ������ �� ��������������������������� ������������������������� �� ������������ �♦ ������������������ ���� ������������� ������������������

������������� ♦ ��� �� �������� ����������� ������� �� � ♦ ������������ ������ ������������ � ��������������������� ��

������������������ ������� �� ������������� ���� �♦ ������������� ������� �� ����������������� ♦ �������� ������ ������������ �������� ������ ������� �� � ♦ ���������������� ������� � �������!����������������� ������� �� ���������� ���� � ������������������� � �������������������� ��� � ������"� ���� ������ ���������������� �� ���� ����� ������������������������������ ������ ������� �� �����������������������#$������%�$�&&$'���������������������� ������������������������������#���������������� ������ ��� �� �����������(���� ��� ������� ������� �� �� ������ ���������������� �������������������������� ������ �������������������������������������� ������������� ���������������������������������������� �������������� ��� ������������������♦ )���#$$�������� ������ ��������� �� ������� �������������� ���� ��

���������������������� ���♦ *������� ����������������� ������� �� �������������������

����������� �� ������� �� ������������� � �������� �� �������������� ���������

Page 46: Skoda Octavia Worshop Manual

�������87 Air Conditioning

������������������������������ Edition 08.96��������������

Filling system

Capacity of refrigerant R 134a ⇒ page 87-20, Capacities

The quantity of refrigerant oil which was extracted should be filled into thesystem again. This instruction applies only in the case where no othercomponents except the receiver was replaced or the refrigerant circuitwas not cleaned with compressed air and nitrogen ⇒ page 87-18, Cleaningrefrigerant circuit with compressed air and nitrogen.Capacity ⇒ page 87-20, Capacities.

Test operation of the air conditioning system and test pressures in therefrigerant circuit as necessary.

Measuring pressure

Appropriate adapters are required for the connection of the pressure gau-ges to the high and low pressure sides (extraction and filling valve).

Cleaning refrigerant circuit with compressed air andnitrogen

♦ Compressed air and nitrogen should be used in order to be able toforce out moisture and other impurities as well as aged refrigerant oilas cleanly as possible, with the minimal loss of refrigerant and withoutpolluting the environment.

♦ First of all, blow out old refrigerant oil and dirt using compressed airand then remove the moisture from components by injecting nitrogen.

♦ Compressed air and nitrogen cannot blow through the compressorand the expansion valve.

♦ Always blow through components in the opposite direction of the flowof the refrigerant.

♦ Use the appropriate adapters for connecting the pressure hose to therefrigerant circuit.

♦ The refrigerant circuit should be first of all cleaned with compressedair and then with nitrogen if

- dirt or other impurities are present in the circuit,

- the vacuum gauge does not indicate a constant readout when eva-cuating a leaktight refrigerant circuit (moisture is present in thecircuit and builds up pressure),

- the refrigerant circuit was open beyond normal removal and ins-tallation time (e.g. following an accident),

Page 47: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

- pressure and temperature measurements in the circuit indicate thatthere is likely to be moisture in the circuit,

- uncertainty exists regarding the quantity of refrigerant oil in the ref-rigerant circuit,

- the compressor had to be replaced because of an internal damage(e.g. noisy or no capacity).

Important!

Carry out work only with pressure reducers for nitrogen cylinders.The gas mixture flowing out of the components should be extractedusing suitable extraction equipment.

Blowing through refrigerant circuit with compressed air nitrogen

- Connect modified filler hose with appropriate adapters to workshopcompressed air system and to the component to be cleaned.

- Switch on extraction system and extract impurities and refrigerant oilwith suction hose.

- Continue injecting compressed air into components until no furtherdirt and refrigerant oil flows out (e.g. check with absorbent paper orwhite cloth.

- Connect pressure reducer to nitrogen cylinder (low pressure = 2 bargauge) and remove moisture from individual components by injectingnitrogen through nitrogen pressure hose and the appropriate adapters(extraction system must be running).

- As it is not possible to provide any accurate figures regarding the quan-tity of refrigerant oil which remains in the compressor, all the oil shouldbe drained from the compressor and the compressor re-filled with ref-rigerant oil. The quantity corresponds to that which is present in thereplacement compressor ⇒ page 87-20, Capacities.

Notes:

♦ It is only possible to drain the oil from the compressor through the filleropening and the compressor therefore has to be removed.

♦ After no further refrigerant oil flows out of the compressor, rotate thecompressor by hand and drain the remaining oil.

The receiver should be replaced each time the refrigerant circuit isopened and should be kept closed for as long as possible in orderto minimise the amount of moisture absorbed in the drier.

Page 48: Skoda Octavia Worshop Manual

�������87 Air Conditioning

Edition 07.99��������������

����������������������������

Capacities

Refrigerant circuit

750+50 g refrigerant R 134a

Note:

When filling refrigerant circuit, always fill up to the upper tolerance limit (refrigerantremains in the filling hoses).

Refrigerant oil

For Sanden or Zexel compressor: 135 ± 15 cm3 PAG oil(Order No. G 052 154 A2).

Oil distribution

The oil which was in the oil pan of the compressor before the air conditioning is firstswitched on, is distributed in the refrigerant circuit as follows:

Compressor approx. 50 %Condenser approx. 10 %Suction hose approx. 10 %Pressure hose -Evaporator approx. 20 %Receiver/drier approx. 10 %

Page 49: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������������������� ��������������

������������������������������������������������������������������

������♦ ���� �������������� � �������� ������������

����������������������������������������� ��������������������� �������������������������� ������������ �������� ��� �������� ������������������������ ������������������������������ ������ ����������������������������

♦ ���������� ����������������������������������������������������������������������������������� ������������ !��

♦ "������������������������������������������� ������������������ � ������������ �����������!

♦ ��������������♦ ����������������������������������♦ �������������������������

Page 50: Skoda Octavia Worshop Manual

�������87 Air Conditioning

Edition 07.99��������������

����������������������������

2 - Air conditioning pressure switch-F129- or high-pressure sender -G65-♦ -G65- is fitted in place of -F129- on

models from Model Year 99 with1.6-ltr./74 kW engine

♦ -G65- is fitted to all models as of ModelYear 2000

♦ -F129- (4-pin plug connection), opera-tion, removing and installing, testing⇒ page 87-24

♦ -G65- (3-pin plug connection), opera-tion ⇒ page 87-11, removing andinstalling, testing ⇒ page 87-25

3 - Expansion valve*♦ Removing and installing heat insula-

tion ⇒ page 87-26

♦ Detaching and attaching refrigerantlines ⇒ page 87-26

♦ Removing and installing⇒ page 87-26

4 - Dust and pollen filter♦ Below plenum chamber cover♦ Removing and installing

⇒ page 80-16

5 - Ambient temperature switch -F38-♦ Switches off magnetic clutch -N25- if

ambient temperature is too low (off at2 °C for models up to Model Year 99,off at 0 °C for models from Model Year2000, on at 5 °C)

♦ Clipped into place in left of plenumchamber

Page 51: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

���������������������������������������������������������

������ ���� �� ���♦ ������������������������ ���

⇒!���"#$%#������ ���&'�� �(��) ��*�)��+,

� ��!�"�#��-./�♦0���1��������2��23��♦$456$�7��28���8��������22 3�28$9%:$�11�12�� ������!����3�����;$2������ <8��8=�11��55>?@�����55%?@A

5BC D#6EF3!��GH5>>"���� ���� �1���GH5>>>��I � ���J +�����(���KLMN�

♦O� �����P� �7P�����<��2E♦Q8��������22 3�28$9%:$�1�8�2��$!��������� ���!�������8��3�8�8��2����� 3���

!�R����(��S��)��JJ� ���T♦U$����V"BC��W5B"��♦ ���8���������X3�V5Y9�♦ �������⇒!���"#$%"

���-��� �'�(*T♦U$����V"B"��W5B:��♦ ���8���������X3�V5:9�

����������������������� �����������

� ������������������� ���������������������� ���������������������������������

����������������������������������������������� ��������

�����&'������T♦Z��������������� ���2��!������P��2E��

⇒ 7������G�28���2� @��$!������♦[���28����������28���2��!��������P��2E��

⇒!���"#$%"♦[���28����������28�����1�������� ����

⇒!���"#$%>♦Z��������������� ���2��!������

⇒!���"#$%>������♦ ����������������������������������⇒\������G�28���2� @��!������♦ ��������������� ��������� ���������������

�������������� �������� �����������������������������������������������������������

♦ ���������������� �������������������������������� ��� ��� ��� �����!��� ��� �� ����������������"������

♦ # �����!�������������������������������� ������� �������������������������������������$����� ������!����������� ����������������������������������������������������������%�����������������������&'�������������� �����������������$���������������������������������!��������������%��)�] *���++�(�+,�L_�

♦����2���

⇒!���"#$a%���������T

♦Z��������������� ���⇒!���"#$a5�%�I�+�����)��,����T

♦Z��������������� ���⇒!���"#$:5

♦Z�! �2���28������1��������2��23�����!�����0�bc�� +��� J����*� ���T

♦d�7$!����3������♦

4���;���2�����1� ����������3����♦e 7�<�3��2�!7��8���

Page 52: Skoda Octavia Worshop Manual

�������87 Air Conditioning

Edition 01.99��������������

������������������������������

Air conditioning pressure switch-F129-

Note:

If the vehicle is equipped with air conditioningwith automatic control (Climatronic), the air con-ditioning pressure switch -F129- is tested by theself-diagnosis ⇒ page 87-47.

Functions

� ♦ Low/high-pressure switch (switch betweencontacts 1 and 2) switches the compressoroff if insufficient or excess pressure exists inrefrigerant circuit.

- Switching pressures (in bar gauge):

- Opens at 1.2 bar (compressor off) andcloses at 2.4 bar (compressor on).

- Opens at 32 bar (compressor off) andcloses at 24 bar (compressor on).

♦ High-pressure switch (switch between con-tacts 3 and 4) switches the radiator fan -V7-to stage 2.

- Switching pressures (in bar gauge):

- Closes at 16 bar (fan stage 2 switchedon).

- Opens at 12.5 bar (fan stage 2 switchedoff).

Removing and installing

� - Separate 4-pin connector and remove pres-sure switch -B- (5 Nm).

Note:

The refrigerant circuit remains closed, connec-tion with valve.

- Replace O-ring seal -A- (10.8 mm; 1.8 m).

Testing operation:

Test conditions

� Air conditioning not operating

� Fresh air blower switch -E9- in position ”1”

� Air conditioning switch -E35- pressed (on)

Page 53: Skoda Octavia Worshop Manual

������� Air Conditioning 87

Edition 01.99��������������

��������������������������������

� - Unplug connector -B- of switch -A- and bridgecontacts 1 and 2 at connector -B-.

- Switch on ignition.

Notes:

♦ If the magnetic clutch clicks when the igni-tion is switched on and off, either the pres-sure in the refrigerant circuit is too low (re-frigerant circuit empty) or the switch is faulty.

♦ Hand over vehicle to a service centre work-shop for testing the pressures in the refrig-erant circuit.

Test conditions

� Air conditioning operating

� Fresh air blower switch -E9- in position ”1”

� Air conditioning switch -E35- pressed (on)

- Remove pressure switch and connect againto the wiring loom.

- Switch on ignition.

Note:

In this state, the magnetic clutch must not click,otherwise the pressure switch -F129- is faulty(although air conditioning is operating).

Air conditioning high-pressuresender -G65-

Removing and installing

� - Separate 3-pin connector and remove pres-sure switch -B- (5 Nm).

- Replace O-ring seal -A- (10.8 mm; 1.8 mm).

Note:

The refrigerant circuit remains closed, connec-tion with valve.

Testing operation:

The high-pressure sender -G65- is the informa-tion provider for the radiator fan control unit-J293- and for the engine control unit. It can onlybe tested by means of the self-diagnosis of theengine control unit ⇒ 1.6-ltr./74 kW Engine,Simos 2 Fuel Injection and Ignition System,Repair Group 01, Self-Diagnosis.

Page 54: Skoda Octavia Worshop Manual

�������87 Air Conditioning

Edition 01.99��������������

��������������������������������

Removing and installing heat insu-lation for expansion valve

� - Compress the two half shells -A- and -B- ofthe heat insulation sufficiently until the twocatches hook in place.

Note:

If the heat insulation is missing or is not prop-erly installed, this can result in a reduction inthe capacity of the air conditioning system(change in the set control characteristic curveas a result of radiated heat).

Detaching and attaching refrigerantlines at expansion valve

(This should only be carried out in a servicecentre workshop!)

- Drain refrigerant circuit.

- Remove heat insulation -A- ⇒ page 87-26.

� - Remove screw -B- (8 Nm) and take off re-frigerant lines -C- and -D-.

Notes:

♦ Replace both O-ring seals -E- (16.7 mm; 1.8mm) and -F- (7.6 mm; 1.8 mm).

♦ Seal open refrigerant lines and connectionsat the expansion valve.

♦ Install refrigerant lines free of stress.

Removing and installing expansionvalve

(This work should only be carried out in aservice centre workshop!)

- Drain refrigerant circuit.

- Detach refrigerant lines at the expansionvalve ⇒ page 87-26.

� - Remove screws -A- (8 Nm).

- Take off expansion valve -B- and threadedplate -E-.

Page 55: Skoda Octavia Worshop Manual

������� Air Conditioning 87

Edition 01.99��������������

�����������������������������

Notes:

♦ Replace both O-ring seals -C- (14.0 mm; 1.8mm) and -D- (10.8 mm; 1.8 mm).

♦ Seal open connections at evaporator.

♦ If the heat insulation is missing or is not prop-erly installed, this can result in a reduction inthe capacity of the air conditioning system(change in the set control characteristic curveas a result of radiated heat).

Inspecting condensation drain, re-moving and installing valve

Inspecting

�� Version -I.-:

- Condensation drain valve -A- must not beblocked by sticky residues and must close;the drain opening must be at the bottom.

� Version -II.-:

- Note: Water drain openings must not beblocked by impurities and must be positionedat the bottom.

Removing and installing

- Open flap -D- of heat insulating mat (atprestamped point) and remove condensa-tion drain valve.

Notes:

♦ Remove condensation drain valve -A- by tak-ing down and out of floor panel; ensure it iscorrectly installed in the cross panel -B- whenre-fitted.

♦ The condensation drain valve must not betouching the flap of the heat insulating mat-D- when installed.

♦ The condensation drain valve must not beblocked by wax or underbody sealant (ver-sion -I.-) or must not be blocked by impuri-ties (version -II.-).

♦ If a complaint exists regarding moisture inpassenger compartment, check to ensurecondensation drain -C- is correctly locatedin the condensation drain valve -A-.

♦ If valve -A- is replaced, fit only valve of ver-sion -II.-.

Page 56: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

Inspecting vacuum relief valve atcompressor

� ♦ Task: to protect the refrigerant circuit fromexcessively high pressures.

♦ The pressure relief valve indicates whetherthe valve has opened. If this is the case, asmall plate stuck onto the valve -arrow- ispushed out.In such cases, the vehicle should be handedover to a service centre workshop.

Disconnecting and connectingcompressor from bracket

Notes:

♦ After taking off compressor, attach to thecompressor bracket e.g. with a wire; do notallow it to hang from the refrigerant pipes

♦ Do not drain refrigerant circuit and do notdisconnect refrigerant hoses from the com-pressor.

♦ Mark direction of running of ribbed V-belt be-fore removing; if belt is fitted on to run in theopposite direction, it may be destroyed.

- Remove ribbed V-belt.⇒ Engine, Mechanical Components; repair

group 13

- Remove cover at bottom and separation bet-ween engine compartment and right wheel-house.

⇒ General Body Repairs; repair group 66

- Take power assisted steering pump off thebracket.

⇒ Running Gear, repair group 48

Note:

Only necessary on engines with PAS pump lo-cated at bottom (e.g. 1.6-ltr. 74 kW; 1.8-ltr. 92kW).

Page 57: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

� - Remove bolts -A- (tightening torque 45 Nm).

Notes:

♦ Push threaded bush -B- fully into the hole ofthe compressor before installing the com-pressor.

♦ When installing the ribbed V-belt, ensure thatit is correctly fitted onto the belt pulley.

Disconnecting and connectingrefrigerant pipes at compressor

(Carry out only in service station workshop!)

- Drain refrigerant circuit.

� - Remove bolts -A- (tightening torque 20 Nm).

- Replace O-ring seals -B- (10.8 mm; 1.8 mm)and -D- (14.3 mm; 2.4 mm).

Notes:

♦ The refrigerant pipe -C- runs to the conden-ser.

♦ The refrigerant pipe -E- comes from the ex-pansion valve.

♦ When fitting on the refrigerant pipes, ensurethe dowel pins -F- are correctly located.

♦ All opened refrigerant pipes and connectionsat the compressor.

Removing and installingcompressor

(Carry out only in service station workshop!)

- Drain refrigerant circuit.

- Disconnect refrigerant pipes from com-pressor ⇒ page 87-29.

Page 58: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

- Disconnect compressor from bracket and fiton ⇒ page 87-28.

Note:

♦ Before first operating the compressor:

- Rotate compressor about 10 revolutionsby hand.

- Start engine with compressor switchedoff.

- Wait until idling speed has stabilised.

- Only now, switch on the compressor andallow it to run at idling speed for at least10 minutes.

Removing and installing receiver

(Carry out only in service station workshop!)

- Drain refrigerant circuit.

� - Remove bolt -E- (tightening torque 15 Nm).

- Take off refrigerant pipes -D-.

- Remove hexagon nut -C-.

- Remove bolt -A- (tightening torque 15 Nm).

- Pull receiver -G- down out of its mounting.

Notes:

♦ Replace both O-ring seals -F- and -B- (10.8mm; 1.8 mm).

♦ Keep receiver closed for as long as possible.Do not remove caps until just before installing(the receiver contains a desiccant bag whichwill become saturated with moisture and thusunusable within a short time if the receiver isleft open.

Page 59: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

Removing and installing condenser

(Carry out only in service station workshop!)

- Drain refrigerant circuit.

- Take condenser together with radiator off thelock carrier.

⇒ General Body Repairs; repair group 50; re-placing lock carrier.

- Take off receiver ⇒ page 87-30.

� - Remove bolt -D- (tightening torque 15 Nm).

- Take off refrigerant pipes -B-.

- Remove bolts -C- (tightening torque 8 Nm).

Notes:

♦ Replace O-ring seal -A- (10.8 mm; 1.8 mm).

♦ When fitting on the refrigerant pipe, ensurethe dowel pin -E- is correctly located.

Page 60: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������������������������������������

��������������������������������������������������������

������♦ ���������������� ����������� ����������

������������������������������������� �������������������

♦ �������������������������������������⇒ ���������������� ���������♦ �� ��������������������������������������

����������� ���������

� ����������!"���!���!�����!���#����♦ ��������������������♦ �����������������������

$ � %�&������♦ ������� �����������♦ !������������"��#��$�%�♦ &���'�����������(�������⇒�)��*��

Page 61: Skoda Octavia Worshop Manual

������� Air Conditioning 87

Edition 07.99��������������

����������������������������

2 - Clutch pulley♦ Removing ⇒ Fig. 2

3 - Shims♦ For setting size of gap between clutch

pulley and belt pulley♦ Size of gap:

0.4 to 0.8 mm♦ Inspecting and setting size of gap

⇒ Fig. 6

4 - Circlip♦ Replace♦ Install the right way round (flat side

facing toward compressor)♦ Ensure correctly located in groove

5 - Belt pulley♦ With interference-fit bearing♦ Do not replace bearing♦ Pulling off ⇒ Fig. 3♦ Fitting on ⇒ Fig. 5♦ Clean contact surface before installing

6 - Circlip♦ Replace♦ Install the right way round (flat side

facing toward compressor)♦ Ensure correctly located in groove

7 - Solenoid coil♦ Installing ⇒ Fig. 4

Notes:

♦ An overheating protection is integrated in thesolenoid coil. The overheating protectioninterrupts the coil as soon as the magneticclutch heats up excessively (approx. 180 °C)(for example if the compressor is stiff).

♦ A protective diode is also integrated in thecoil (reduces voltage peaks which may arisewhen the magnetic clutch is switched off).

8 - Bracket with bolt

9 - Bracket

10 - Bracket

11 - Bolt

12 - Compressor

13 - Sliding bush♦ With thread

� Fig. 1 Removing and fitting on hexagonnut.

Tightening torque 15 Nm.

Notes:

♦ Self-locking, replace.

♦ Use MP 9-601 with pin diameter 6 mm.

Page 62: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

� Fig. 2 Pulling off coupling plate.

Note:

If coupling plate is tight, lever off carefully withtwo screwdrivers -A-.

� Fig. 3 Pulling off belt pulley

- Insert two-legged puller -A- at shoulder -B-and pull off belt pulley.

Notes:

♦ Ensure the puller is correctly located at theshoulder -B- in order to avoid damaging thebelt pulley when it is removed.

♦ Clean contact face before installing.

� Fig. 4 Installing magnetic coil

- Position stud -C- in recess of magnetic coil-A-.

- Ensure the wiring -B- to the magnetic coil-A- is correctly routed.

Page 63: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

� Fig. 5 Fitting on belt pulley

- Position belt pulley flat and use MP 9-400for fitting on.

Note:

Tighten the bolt of MP 9-400 only by hand ontothe compressor shaft.

� Fig. 6 Inspecting and setting size of gap

- Measure dimension “1” between belt pulleyand clutch plate (-B- and -C-) with depth gau-ge -A- (at 3 points).

- Apply 12 V voltage to 2-pin connector -D-(ensure correct polarity of voltage).

- Measure dimension “2” between belt pulleyand clutch plate (-B- and -C-) with depth gau-ge -A- (at 3 points).

- Size of gap (difference between measure-ments “1” and “2”):0.4 to 0.8 mm.

Notes:

♦ The size of the gap must be within the tole-rance around the entire circumference.

♦ The size of the gap can also be measuredwith the compressor installed.

♦ If the size of the gap is not within the per-missible tolerance range, take off clutch plateand adjust size of gap by removing orinserting spacers.

Page 64: Skoda Octavia Worshop Manual

��������� ������������

������������������������

����������������������������������������������������������������

����������������������� ��������� � ������� �������������

������♦ �������������� ����������������������

���������������� �������� ���������� �������������������������������������������������

♦ ������������������������ �������������������� ����� ���������������� � �������� ��������������� ��

♦ �������������������������������������� ������������������

♦ ! ���� ����������������� ���� ��������������������"�����������������������⇒����#$%�&�

♦ ! ��������� ����������� ��� �������� ���� �'������������������(���� ���������� ������ ����������������������� �������� ������)�⇒�����#$%��

Page 65: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������������������������������������

������� �♦ ������������� �����

⇒ ������ ������������������������� ������ �� ��♦ �������������

������������� �� ��♦ ������������� �����⇒������

����� ��� ���������� �� ��♦ ������������� �����⇒������

����������� ����������� ����♦ ���!���� �"� ��#"���$�� �"

��$��� ��� � �������� ����!���(����"#���

♦ %�� ������� ���⇒������&�♦ ������������� �����⇒������

&'���� ���$�%& � �� � ��%��'���

♦ ������������� �����⇒������&&

���� ���$�%& ��"��♦ ������������� �����⇒������

&&(������%�����%� �)♦ ������������� �����⇒������

��♦ (� �"���# �"��� �� �)�� ���

��!����$���⇒�������♦ ������ ��������*����!�����

$���⇒�������♦ (������$����������$����⇒��

�����+'���* �� ��%���%�

♦ ������������� �����⇒�������

♦ (� �"����� �"�����!�����$���⇒�������

♦ ,�)�� �����!����$���⇒�������

♦ ������ ��������*����!�����$���⇒�������

♦ ��������$��$⇒������&�

����� ��� � �������� ����!���&����+#�(�♦ %�� ������� ���⇒������&�

������♦ ���������������� �����������������������

����� �♦ �������� �������������������� �������������

����������� ��������������������������������������������������������������������������������������������� ����� ��� �������������� �������&����+,��

������♦ ���������������� �����������������������

����� �♦ !���������������� ������������"����������

������"��������%%�& �������� �� ��� ���� ����������%�� ���%��� � ��� �������$�- !��%� �'���!%%�& ���������%%�& �����

♦ ������������� �����⇒������&-

���* �� .���� �)♦ ������������� �����⇒������

+�♦ .�������!� "�����������������

�� ��������$������*"��"�� ������ ����

�(��������� ������� !�%� �� ��♦ ������������� �����⇒������

+����- !������������� !������� �� ��♦ ������������� �����⇒������

�����2����� ��� !�%� �� ��

Page 66: Skoda Octavia Worshop Manual

��������� ������������

������������������������

����������������������������������������������������������������

����� ������������ ���������������������������������� !�""# $�%&��' "(#! ! �&" )�"*'+�,'-.� �������������������� ���� �������� ��������������������������������

�� ����⇒�����������������♦ ���������������� ������������������������������� ���������������������������������������

♦ �������������������� ��������������������������������������������������������� ����������� �����������������!����������������������

⇒ ��������������������������� ����������������� �� ������������� ��� ��� ���������������� ����

�������������������������������!�������������������

� � "���������������������������������������!������������������������������#���������$�%�&'�()*������������

������♦ "������ ���� ������� ���� ���� �� ������������� "������������#�������������������������� "������� ���� ���� ������� ����� �������������

♦ ����������� �����������⇒ +����,������������-���������.�������

&�� ���(� "����������������������������������������

������/���������� �� ����������������� �������������!�������#�������������������*���� ������������������������������%��

� ��������!��������������⇒������0�1��� � 2����������������������������������������

�%�������/��������������������� �������������!����� ����������������-�

#������������3 ���4�5�*������#��������������������������������������������$� �������������������������������

Page 67: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

� - Fold up the pre-punched points -A- of theheat insulation mat and remove the hexagonnuts and washers -B- behind them (tighten-ing torque 15 Nm).

- Remove dash panel.⇒ General Body Repairs, repair group 70

- Remove footwell vent ⇒ page 80-15.

- Remove passenger airbag unit.⇒ Electrical System; repair group 96

- Cover over all the opened connectors andair guide ducts of the air conditioner to pre-vent the ingress of swarf.

� - Drill off support for dash panel at the pointsmarked with -A- (connection points) with a 7mm drill.

- Bent part -B- of the support at the specifiedbreaking points -C- to the side in direction ofarrow.

Note:

After installing the he ater unit, bend back thepart -B- into its original position and bolt the sha-ped piece marked in broken lines to the holes-A- (e.g. M 6 x 10).

- Separate electrical connection between ve-hicle and air conditioner (plug connection andbolted-on earth cable at A pillar).

� - Remove air conditioner in direction of arrow.

Notes re installing:

♦ Inspect all gaskets and seals at air conditio-ner before installing and replace any dama-ged gasket or seal.

♦ When installing the air conditioner, inspectthe gasket at the intake duct; it must bemaking contact with the vehicle body.

Page 68: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

� ♦ Replace gasket -A- at heat exchanger andensure that it is correctly located on thecontact surface -C-.

♦ The flow direction of the coolant is markedat the connection of the heat exchanger(arrow -B-).

♦ All the cable straps which had to be takenoff in order to remove the air conditioner,should be fitted on again after assembly atthe same point.

♦ Replace both O-ring seals for the refrigerantpipes and the expansion valve.

♦ Install refrigerant pipes free of stress.

♦ Inspect condensation drain and condensa-tion drain valve to ensure they are correctlyinstalled.

� ♦ Replace gasket -A- and ensure it is correctlyfitted onto the evaporator connection flange.

Removing and installing heatexchanger of air conditioner

(Carry out only in service station workshop!)

- Remove air conditioner ⇒ page 87-38.

� - Press back catches -B- and pull heat exchan-ger -A- out of the air conditioner.

Notes:

♦ If the heat exchanger does not properly en-gage when installing in heating flap box, itshould be attached with 2 suitable screws-C- (e.g. 3.2 x 20 mm self-tapping screws).

♦ Ensure the gasket -D- is correctly installed;it must not be visible after being installed.

Page 69: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

� ♦ Replace gasket -A- and check to ensure it iscorrectly seated on the contact face -C-.

♦ The flow direction of the coolant is markedat the connection of the heat exchanger(arrow -B-).

Page 70: Skoda Octavia Worshop Manual

��������� ������������

������������������������

����������������������������������������������������������������

��������� �� ������� ������ ����� ��� ����� �����

����������� !��"�#���� ⇒$���%&'(%)*+,-./0-1/02/34567♦8�9�99��:;�����"�99��:;���

⇒$���%&'<<=*>?645/6567410-.♦@�9A �!� �!#;B �A#�"⇒C��DEF*����G/6H515/6567I505672-06?44J*K/,?0.-6?L♦M##�!N�"#����$� �#� N�A9���O�#N#��9������9# �$�#��P��"#N�#O�9! �O!;�$9�#��QR*SG0?IGL5.

Page 71: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������������������������������������

���� ���� ���♦ �������������������� �����������⇒�������

♦ ��������� ����������⇒�������

♦ � ������ �������� �� �����������⇒�������

♦ �����������⇒������������ �������

♦ � � ������������♦ ��������� �������� ��� ��������� ����������⇒�������

♦ � ������ �������� �� �����������⇒�������

���������� ♦ �� !��������������⇒������"�

♦ #�� ��������������� ��������������!���� �������� �����������������������������������������������

♦ $������ �� ���� ����� ���������%�������� �

����� ���� ����������!�

♦ &�!�� ��������������!��"#�$��%�♦ '���������!�� ��� �� ����⇒(�)*

�&��'�(��������������������� ��������♦ ���������������������� �����������������

��������� ����������� ��� ����������♦ ��������������� ���������������� ����

�� ��� ����������

�&��'#)������������%������� ��� ���������������� �������������������������������������������� ��� ���������� ���������

Page 72: Skoda Octavia Worshop Manual

��������� ������������

������������������������

����������������������������������������������������������������

��������� �� ������� ��������������� ��� ����� �����

� ��������� �!"�!#������ �!"��$%&!#�'(�&!�$⇒)�"�*+',-./012234516783214351491:;<=>

♦?����� �!"�@�)&$�(&$A&B��!"⇒C�"DE

♦F!�)�%("��G�(�(�! �(�A�H(I$�) �%��H#���"�#J��� �&HH�! �(�A�H((&)����!"�$%&�)�$(��!(KL/M1;<5<1=<=>������614647;93<43=N47O<4O:P357N3<46P32/Q.RS♦F!�)�%(�!"&)�$�(�&!⇒)�"�*T'EU♦V��&@�!"�!#�!�(� �!"

⇒)�"�*T'E-(/W1P5S/X47;93<4Y47O<4O:P357N3<46P32

Page 73: Skoda Octavia Worshop Manual

�������

Edition 08.96��������������

��������������������������������

Air Conditioning 87

5 - Bottom part of the evaporator housing♦ Assembling evaporator housing

⇒ Fig. 1.

6 - Fresh air blower -V2♦ Removing and installing

⇒ page 80-11.

7 - Series resistor for fresh air blower-N24♦ Removing and installing

⇒ page 80-11.

8 - Evaporator♦ Attaching seal to coolant pipes

⇒ Fig. 2.♦ Attaching seal to evaporator

⇒ Fig. 3.

9 - Seal♦ Attaching seal to coolant pipes

⇒ Fig. 2.

10 - Seal♦ Replace.♦ Attaching seal to evaporator housing

⇒ Fig. 4.♦ Seals off connection area of refrige-

rant pipes to engine compartment.

11 - O-ring seal♦ Removing and installing

⇒ page 87-26.

12 - O-ring seal♦ Removing and installing

⇒ page 87-26.

13 - Threaded plate

14 - Expansion valve♦ Disconnecting and connecting refrige-

rant pipes ⇒ page 87-26.♦ Removing and installing

⇒ page 87-26.♦ Removing and installing heat insula-

tion ⇒ page 87-25.

15 - Bolt♦ Tightening torque: 8 Nm

� Fig. 1 Assembling evaporator housing

- Use suitable bolts -A- to screw together thetwo halves of the housing at the attachmentpoints -B- provided.

Note:

The attachment points -B- are provided aroundthe entire circumference.

Page 74: Skoda Octavia Worshop Manual

�������87 Air Conditioning

�������������������������������� Edition 08.96��������������

� Fig. 2 Attaching seal to refrigerant pipesof evaporator

- The refrigerant pipes -C- should be sealedoff to the two halves of the housing -B- withseal -A-.

� Fig. 3 Attaching seal to evaporator

- The evaporator -A- should be sealed off tothe evaporator housing at the top and at bothsides with the seal -B-.

Note:

No seal should be fitted to the bottom of theevaporator (to allow the condensation to drainoff).

� Fig. 4 Attaching seal to evaporator hous-ing

- Replace gasket -A- and ensure it is correctlyfitted onto the evaporator connection flange.

Page 75: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

�������� ���������������������� ��������������������������������� ������ � ���� ������� � �� ��������������������������������� ���������� � ����������������������������� �� ������������� ��������������� � ������� ������ � ����������������������������������������!������������������������������������� � ������������������� ����� ����� ������������ ������� ��������������� �������� �������� � ��� ������ ��� ������ �������������������� ����� ����� ��� ��� ������������������������������ ����������� ����� ���� ����������������������� � ����� ��������� ������������� ����� ����� �� ������� ��� ��������� ���������� �� ���������� ��� !"���#������� � ����������������� ����� �������� ����������������������� ����� ��������������������$������� ����������������������������������%�&�'(���$���� ����������������������������������������� ������������ � ������������ ��� ���������)����� �������� ��*�������������� ������ �������� �������������� � �$���������������� ������������������ �� ����� ������������������*�������������������� ��������� ����������� ������������� �����������$������������������������� �������� �� ���������� �� !"�� � ��������� ��� �� ���� � �� ���������������������(������ ������������ ��� ������������ ������������ ����� ����� ������������ � ������������� ���������� ���� � ������� ���������+� �����������������&���������������� �� �$�� ������������ ������ ��� ����������������� ������ ��������������������������%�&�'�(����

Page 76: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

������������ ����������������������� ��� ���� ����� �������� ��� ����� ��� ���� �������������������� �� ����� �� ��������� ���� ������ ������������������� ������������ ������� �� ����������������������������������������� ��� ������������ ���� ������������������� ����������� ���������������� ���������������� �������������������� �������������!��� �" #� �����

���� �$�������" �����������

�����%� &�� ��������� ������ � ���" ���%� &�� ��������������� �" ���%' (������� ����������" ���%) *��������" ���%� + �������������� �" ���%, +���������" ���%- .�������� �����" ���%/ 0����������� ��� ���������1" ������ ��������� ���������������� ������������1������ ������.($� *�� �� �������������2��� *�� ������ ��� ��������������� ���

��������

Page 77: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

�������� ����������������� ��� �������������� ����������������������������������� ! ""#�$%&'()*$#���#����+ � ,�#�����

-.//0123/4506317089820:20820;<�=>?@AABC/D8070123/4-73:C2;./311./2;.7E/32FGHIJKLMMLNOHNPHQNKRSKJSNQHTUJQHS♦V��� ��������������VW&WX�YYZ♦[��+����� �\��VW&WX�YY�]

� 3#���� ���� ��������������VW&WX�YYZ����+��� �\��VW&WX�YY�]W�(�����������_�������������������������� ��������� �����⇒

)_������+������ ��������� ��������������3���� ����+������W

�(�����������_���3�����a��� ���b����������������c&#]������+��� ����� �d��� �����������������a��eW

�'�� ����������������� ������__������������f_���g�W+W♦

���� ! ""<����*�W� ����������♦

#��������� h����������+������♦

���h�������������♦

#����+ � ♦

,�#h,��a���_ ���$��� ����+��������+�����������__��_��f����������������� ��⇒_�+�b!fig#����+ ����������W

Page 78: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

�������� ���������������������������������������������� ������������������������� ���������������������� ���������→ ���������� ������������������� ���������→!������ ������ �����"����#��$%$&'('))��*+,-./ *�011������'$'''20�11111�������� �������������0��� ��� ����11

������� ♦ ���3453678563993:;4<6=>97?5@@=<5@=ABA5=C@;4785D;@A9=E��785A3@@;F95G=>@5@367856=>97G=4F5AC;475D3>7���AC5@@;4<785HIJKL5E��MN85;<4;7;34?>@7F5@:;7G85D34OP� ♦Q=>97@8=R53GG>CC5D=7785F5<;44;4<3CD>C;4<785AC3<C=?M5S75C4=9@3>CG5@36;4B75C65C54G5TPU�#V4@A5G7�;=<43@7;GG=F95@=4D=9@3R397=<5@>AA9E=4D5=C78G3445G7;34U#,����� ��������������"�� �������������W�� ����������������������'X��Y,�Z���������� ����� �[��� �����������������\��]�-�� ����������������� ��������������������#����#�����→\��

�.���������������_�����'�9;@736785A3@@;F956>4G7;34@;@D;@A9=E5D=675CAC5@@;4<785�����L5E�abcdefgfahfihjeklmcadlb����%$#*������������ ����������������X(#)&'n#*����������������������X(#o$'p#!���� ���������������X(#o&')#q��� �������X(#r$'o#�����������������X(#rn'r#������������X(#rp'(#������ ����������X(#rp%X#.������������������"�� \X(#r)-����������>,s$oon����������������������������������

→\�����������

Page 79: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

�������� ����������������� ��� �������������� ���������������� ����������������� ��� ������

� !"##$%&!' %(&)*!+"+$#,-.���� ���� ��������������/01023445������� ����.��������� ����������6�������������6���7809.���� ������� ��������������������� �-���.��������� ����������⇒:���8;-<=0>

�?�����������:���@-�����A���7���5������� ����BC������-��������������D��� �������������6������A��E0�F�����G����������������BH������� ��-������D�::������������:���0

���������������� ��-�� ���� �→�� ��C�������������������������@F�������������������:��������������������0�F������6���������������::������������-:���@-���A������� ��������������:�����G�����������������G��

⇒J������G��K:���8;-430L&)*!!&M*"������♦ ����� ������� ����������������� �� � ������ ������������������������������������� ����� ���!

"���#��� ��� ��� ���������$ ���������$���� ��������� �♦ �������������������������������#�� � ��� ������� �����%�������������������$�����&�'%(�&)�♦ *� �������� ������������� ���������������� ��������� �♦ �� ������� �$�� ����#����������� ��$��� ��� ������ �� ���$� �� ������� ��������� �+ ���

��� �� � �� ���!�"����♦ ������������� ,���� $����$�� ���������#������������������ ���� ����������#�� �������

�������%-�������������$�����./&�⇒���$ �01��2����� ��������%3 ���� ���� ��+��� �������.0&�⇒��$ �01�45������ ������������� �������$��������������� ��� � �#��� ��� ��� ��� ��� ��� �������%��� �����������.1&������ ��������%6����� �$�.5&�⇒���$ �01�4"��������� ��� �� � ���������������������������$��������������� �� ������������� �����$�����NOPQRST���UVWVXYZZ[\\\\\]_abcdefghijeklmRnnopqOrPSnORssPSqTt_u]_abcdefghijeklvwwedx_cedfywbecihgdewidxzxeb_{kighxixixehkek|t_c}ekixwb~he�edc}ebexx_bx}exzxebefche_cedc}ec}edc}e_bb�ihg_ahf{cihx�\�{�kefhcdbahic

⇒wge��{��\�{thicice�xifxeccihg⇒wge��{��NOrTos�o��sPSqT

Page 80: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

�������� � ������������������� ����������

�� ��������������� �

��������������������� ����������

��� ���������

����������������� ���!��!�������� !��!�����!������������!� �!��� "������������ ��"���� �� �!� ����� ������������� �!!� ����� �������������� ��������"�����#� ���"������������������ ��������� ��$ �������� ���������""� ��!� �������� �� ���� ���"�������"���� ���������� �� �"����������%$ �"����������� � �"�����������"� �!� ����� ���"���� ���� ���� �&��! ���""%'"������"�����(� �"�������� ������& � ����� �%

)���� ����"�����

*��� �������!� �!��� ���������� �!!� ����� ���+����"�����

��������������� $������������ ��� ���������������!,

���⇒�����-��.%� $��&��� �� �����!� �!��� ��!� ����� ��

�!!���� ����/0%� � �!,��������������� �%

� $��������������#�������������� �����&�� "� !��� ��1�������������������!,2⇒�����-��.%

� $������� ����3⇒ ����� �/��&0������(4��!���!��/����/� �� �

� �/���� �5�!���� � $��������������#�������������� �����&��

"� !��� ��1�������������������!,2⇒�����-��.%

� ������&��� �������!� �!��� �!!���� ����/0%

� $������� ����3⇒ ����� �/��&0������(4��!���!��/����/� �� �

� �/���� �5�!���� �� )"���������!������ ������������ ��������� � ����� ���������� ��������%$ �"������ ��

����!����" ����������� �������������� ������� �!�!��#����(����� �������� � ��,�6 (&��! � ��""� �� ��&�� � .�� ����"��������"� �� �%

Page 81: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������

��������� � ������������������� ������������ ������������� ������

�������

����������������� ������

������� ������

������������������ ��������� �� ����������������� ������� ��� �

� ���� ������ !"# � ��� �� �� ������ !��# � ��� ���� ����� !��� � ��� ���� ������ !��$ ������%

&������ �� �� ������ '#�� ������%

( ������������� ������������ �������%

&������ ������� ��� ��� &������ �� �� ������ '#�� ������%)�����%�*�������*+������ �������%

&������ ������� ��� ��� &������ �� �� ������ '#�� ������%

�������������� ������������*������ ��� ��� �&������ �

�� ������ '#�� �� �*���� ��������� ,�*�� ����-

����� ������ � ��+&� �� ��� � ����%�����������./���� �� ��*��� ���0�⇒�������� �"-

�������������� ��� �� �����������*� �� ���� ������������ ����1���������������� �%⇒�������� �#1��*� ������������ ����⇒�������� ��-

2������������.��������� �����0���� ,� �� ���*�����*1���������������� �������� ���� ��� � �1�,�������*��� �����������������������������*��� ����������� ����-

������� �� ������ '#�� ����������%1��������������� �� ,������� �� ����������� ����3���.& *�� �� �����0�⇒�������� ���$�.)����������0�⇒�������� ��-

������������ �-⇒ &������/� ,�4�������1�5��������/�����/�*��

�*�/������6 ��� ����*�� ������������*������ ��� ��� �&������ �

�� ������� �*���� ��������� ,�*������- �����������%-⇒ 5���������%����7��������!� ���#� ������������ �-⇒ &������/� ,�4�������1�5��������/�����/�*��

�*�/������6 ��� ����*�� ������������*������ ��� ��� �&������ �

�� ������� �*���� ��������� ,�*������-�� +�������� �� *������ ����-��-

Page 82: Skoda Octavia Worshop Manual

��������� ������������

������������������������

������������������������������

��������������������������������� ������������ �������

�������

��������������� ���������� ����������!�"#�$�� ������� ��%������ ���& � &��������&�&��

��#����

'�(&��� ��������)���� �����*�#+�$�� ��������&�&��

%������ ���& � &������� ��

��#����

'�(&��� ��������)���� �����*����

�����������������������

$�� ���& � &��� �������& � &������& &�)� �� )��������&������������������� �������� ������

�������� ��

$�� ���& � &��� �������& � &����������& �&�)�� �� )��������&�������������������������� ���������� ����������!�"#�,&��� ��&������ �� �&���*��������-�� &��� �������(�(�!�"#���� ��

$�� ��������&�&�������& &�)�� �� )�������&������� �(&��� ��������� � �&���*�+���*�+����� ��

%�����& � &��� ���� ���& � &������� ������& &�)�� �� )��������&������� ��(&��� ��������� �� �&���*�+���*�+����� ��

��� ������ ����(����#��

������ ��������

� .� �� ���&������� ��(&�)���&��⇒���)���#��+/� ������������&������0'��(����� �(��� �

1��23�⇒���)���#��"/� ������& &�)���(�� )��������&�������� (&�)���

� ��������(&�) ��/� '������������⇒���)���#��"/� ����-��� �� ��� ���&����"�04��&������&�)3

⇒���)���#���/

� ������& &�)���(�� )��������&�������� (&�)���� ��������(&�) ��/

� ,�(������ �� �&��⇒���)���#���/

� '�������!�"#��⇒���)���#���/�/

� ������& &�)���(�� )��������&������� �(&��� �������� �� �&���*�+������� (&�)����� ��������(&��) ��/

� '�������*�+��/⇒ , ���������&�) ���-�5��� &����� ���&�(&�)

��(��&��&�)�6����&����1&�(� � ������& &�)���(�� )��������&������� �(&��� ����

���� �� �&���*�+������� (&�)����� ��������(&��) ��/

� '�������*�+��/⇒ , ���������&�) ���-�5��� &����� ���&�(&�)

��(��&��&�)�6����&����1&�(�

�� ��&���� ��&��(������(�&��4��&������&�)��"-��&������� ��(&�)���&�������(�&�������� �����(�/�4������(�������� ���1� �����(/

�� 7��&��������(���� �����/��/

Page 83: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������

���������� ������������������� ����������������������� ��� �������������

��� ��� �������� ��

������������� � ���� ���������������������� ��� �������������

��� ��� �������� ��

�������������������� ��� �������������� ������ ��������� �� � �!� ����������������������� ��� ���� �����

��� ��� �������� ������ �� � �!� ����������������������� ��� ���� �����

��������!�"

��� ��� �������������� ������ ��������� �� � �!� ������������� ���� ��������������� ��� ���� �������� ��� �������� ������ �� � �!� ������������� ���� ��������������� ��� ���� �����

��������!�"

������������� ��������������#$������� ����!��

%!���&⇒�� ����'(�� ����� �� ����!� �������������� ��� ��

�� ����!����� ���� ��������������#$������� ����!��

%!���&⇒�� ����'(�� ����� �� ����!� �������������� ��� ��

�� ����!����� ���� $��!���������⇒ )!��� ���!�"���*$���� � �����

� ��������������#$������� ����!��%!���&⇒�� ����'(�

� ����� �� ����!� �������������� ��� ���� ����!����� ���

� ��������������#$������� ����!��%!���&⇒�� ����'(�

� ����� �� ����!� �������������� ��� ���� ����!����� ���

� $��!��������⇒�� �����(�

Page 84: Skoda Octavia Worshop Manual

��������� ������������

������������������������

����������������������������

���������������������� ����� ������������������������������ ����������������� � �������������� �������������������������� ������������������������ ������������������ � ������������� �����������

������������

� � �������������������� ���� ��� ����� ���!"�⇒��� ����#$%

� � ��������������������� ���������������������� ���������������%

� � �������������������� ���� ��� ����� ���!"�⇒��� ����#$%

� � ��������������������� ���������������������� ���������������%

� � ��� ��������⇒��� �����$%

�������������� � ����&�'(������������ ���� ��� �����

���!"�⇒��� ����#$%� � ��������������������� �������������������

��� ���������������%� )������ ��� ���� ������� ���� �� ��� ����!���%� � ��� ���� ��������%⇒ *���� +�, ���������-���� ���.�� ���

�����(� � ��� ��&�'(��⇒��� ����'$%

��� ���������������('/-�� ��� ���������&�'(��0

-������ �� �� ������ � ��

� ��������� ��������������������� ���������������������������� ����������/-�� ��� ��������&�'(�

1����� ��������������� ���� �����������2���� ���� ��������

�&�'(������������� ����������� ����������������������������������� �� ����� �� ��� ���� ������������� ������� ����������� �� ��� ����������������� ��� �! ��3 %�%������� ��� ������ �� � ���� � �����'45-0%�������������� ��� ������� ������� ���������� ��������������� ���� ������������������� �����%

���(��������� � �������������� ������������6 �7����������������������

���������������� ����

�0 ����������������� �� � �� ������������� �� � ���� � �����'�5-+��������������������(������%��� ����������������� ������%��� ��%'�,2��3'� ��078%'�,2��38'� ��0������������������� �� �+� �������� ��%#�,2��3�#� ��0��������������%

Page 85: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

���������������������������

���������������� ��������������� ��������������������������������������

���������������

�����������������������������������������

��������������������

�������������������������������������������������������� �������� ������������������������� �����������������!�"������������������� �������� ������������������������� �������������������!�"���!�"��#�� $

���������������������� ������� ��������������������������������������������#�� $������������������������������ �������� ����������������������������������������������������������������������������������� �������� ���������������%� �������������& ������������ ������'!���������#�� $& ������������ ������'!����#�� $

���������������� (��� ���������� �����������������������������# � �������)

� (��� ���������� �����������������������������# � �������)

� *�� ������!�"��⇒�������+��,)�)

� (��� ���������� ���������������������������������������������������������# � ��������)

� *�� ����������⇒�������+�!�)� (��� ���������� ���������������������������������������������������������# � ��������)

� (��� ���������� ���������������������������������������������������������# � ��������)

� *�� ����������⇒�������+�!�)� *�� ����& ������������ ������'!����⇒������+���)

� (���-��� ������#� � ����#�������������#�������.�+�/&�������� ����0�⇒�������+��"-�,�/1����������0�⇒�������+���)

Page 86: Skoda Octavia Worshop Manual

��������� ������������

������������������������

����������������������������

�������������� ������������� �⇒������������

� ���������� ���������� ���� ����⇒������������

� ������!������� ��������������� ���������"�� ����� ���"� ���� �����# !�����$���������

����%�����&���'��⇒������������� ���# ������������������ ��������� ����

��������#�� ������ $��������� ���� ���������� ��()**��⇒�����

����*�� !��+�������!�������# ������� �����������

!���!�,����������������� ��⇒�����������+������� ���� ����⇒������������

��� ������������������������� � ������"������

�������� ���� �������������

��)��-� ���"� ���� �����.

� ��������� ������ ���� ���������� ��()**����+�� ������"������

��� ���� ���#�������������+�� ������"

/��!������� ���� ������"-!��� �� ��������� �� ���# ��������������� �������� ���� ��������� ��()**�

�� ���� ���������� ��()**������"

�. !������������ ���"� ���� ����� ������� ���&"�!�����!������� ����� !���� ���� ���������� � �()**�����"����!�� �����������������!����� ��� ���# �!������� ���������������!����������%���������!���� ������������������0�����������!�����!�� � ��'�����������������0�1��# !�!����������������� ���������� ������� �������!��%�! ���� ���������2 �� ������.�����!����������� !����������%�����#������!�# ���&������ � ���#!���!����� ��� �������� ���&"�!��!����� ����� !���� ���"� ���� ����� ������ ������"�������� ������

Page 87: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

���������������������������������������������� �������������

��������� � ������������������ ��� ���� �������

���������� ��� ���� �������

�������������������� ������ � ���� ������ �� ������ ���� ����������� �� ����������� ���� �����

����� �� �������� ������� � ���������� �������� �! "#��� �������$����� �� %���&��

����� �� ����'

���� ������ � ���� ������ �� ������ ���� ����������� �� ����� ������� �����

����� �� �������� ������� � ���������� �������� �! "#��� �������$����� �� %���&��

����� �� ����'

��������������� ���� ����� ���� �� "(�� ������ ���

%���&$ ⇒ ��� ����!)� ���� ����� �� ���� ����������� ������� ��

����� ���� ����)� ���� ��� �������� �� ���� ����� ���� ��������

⇒ ��� ���*+)� ,���� �������� �- ".��� ������ ��������$

⇒ ��� ���*+)� (����� ����� ⇒ ��� ����� �� ����� �����

���� �! "#��� �������$ ⇒ ��� �����)

� ���� ����� ���� �� "(�� ������ ���%���&$ ⇒ ��� ����!)

� ���� ����� �� ���� ����������� ������� ������� ���� ����)

� ���� ��� �������� �� ���� ����� ���� ��������⇒ ��� ���*+)

� ,���� �������� �- ".��� ������ ��������$⇒ ��� ���*+)

� (����� ����� ⇒ ��� ����- �� ����� ��������� �! "#��� �������$ ⇒ ��� �����)

�� ���� ���� �� �������� �� #��� ������� �!/ .��� ������ �������� �- �� �� ��� ���� ����) #��� ��� ����� ���� %������)

Page 88: Skoda Octavia Worshop Manual

��������� ������������

������������������������

������������������������������

������� ������ ��������������������������������������������������������������� ��!�����"#$"%����������������"&'$("�������� ��!�����"#$"� ���)������������������������������������������������������������� ��!�����"#*'""#*'"��!���+�,"#*'"� ���)-�����.�/0� ��"1���"#$"����2345� ,6� ����,7 ���!���+8

⇒�� ��3*"(9:"1��������� �,��������������� ����,����������������,� �� 6:";�����6��������2<4=�� ��������,� ������8⇒�� ��3*">?:"5��� ��"&'$("

⇒�� ��3*"*9���"#$"⇒�� ��3*"3>:"1���"#*'"����2345� ,6� ����,7 ���!���+8⇒�� ��3*"(9:"1��������� �,��������������� ����,����������������,� �� 6:";�����6��������2<4=�� ��������,� ������8⇒�� ��3*">?:"5��� ��"#*'"

⇒�� ��3*"*9 �,������6����"����294% ����������8⇒�� ��3*"(':

����������������@�AB������������

-� C�����DEFEGHIIJ2'$*<=���� ��!�����"#$"2'$*9=���� ���� �6����"#*'"KLMNOPQRSTUVWQRXYWYZWYXQ[\TRQZRYWWQ[]_aQ[TVZb[WcbVXQT][bRQRdT[XQ[WPY[bceTVebXYf\bWPY[XRWbgReURWhYcYTZPYXf

Page 89: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������������������������������������

��� ��������������������

���� ����������������������������������� ������������ �� ������

�� ������������ ������

������ � �� ����������������������������������� ������������ �� ������

�� ������������ ������

�������� ���� ���� ����������� �� ��������������� ����! ����!�� ������ ���� ����� ����������������������������

�� ������������ ���������� ����!� ����!� ������ ���� ����� ������������������������������

�������"���#

�� ����������� �� ��������������� ����! ����!�� ������ ���� �" � �� ����������������������������

�� ������������ ���������� ����!� ����!� ������ ���� �" � �� ������������������������������

�������"���#

���������� ��� $����������� �����%�&'���������������( �)*�⇒���!��%���+,

� $���� ����!������!�� ������ ������ ���!�� ��������" ���!���,

� $����������� �����%�&'���������������( �)*�⇒���!��%���+,

� $���� ����!������!�� ������ ������ ���!�� ��������" ���!���,

� '�������������⇒���!��%��%+,�,

� $����������� �����%�&'���������������( �)*�⇒���!��%���+,

� $���� ����!������!�� ������ ������ ���!�� ��������" ���!���,

� $����������� �����%�&'���������������( �)*�⇒���!��%���+,

� $���� ����!������!�� ������ ������ ���!�� ��������" ���!���,

� '�������������⇒���!��%���+,�� -������ �#�� �� ��� ����������� ��!,

Page 90: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������������������������������������

Page 91: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

���������������������������������������� ����������������� ��� ������

���������� !"!#$%%&'(()(*+,-.+/0,1-23435-1637�889:;�<��8��==��;�>1.1,?+.@/0?5+,,35-1+,A-+*/1BC-.+,155+,-.+/0,1-DEF((D4C0/-G*/1BC-.+,155+,-.+/0,1-4C0/-G��<�9=H9IJ=��;�D�3A-K1.1,?C,2@/0?5+,,35-1+,AC55+.21,?-+*LMND�3A-*/1BC-.+,155+,-.+/0,1-DEF((DK1-OPQDRS3C2B3CA0.326C/03T/+5UV⇒@C?3QWD'XNDS3@/C53*/1BC-.+,155+,-.+/0,1-DEF((DNY4-3.-O1AZA3/35-+,3C4-3.-O3+-O3.-O34+//+K1,?40,5-1+,A[PWD*+235+,-.+/0,1-

⇒@C?3QWD')ZPXD\,1-1C-3TCA15A3--1,?⇒@C?3QWD']N_abcdefdbg_ahdi_i

������������ ������ ������ � � �� � �� ��� ����������������������� �������������������� ����������������������� �������������� ��������������� ������⇒����������������� �!"♦ #�������������������� �� �����������������

���� � � ������������������������������������� ������������� ���$���������������������� ���$������������� � %�&�"

♦ '������������������������ $ ����(� ������������������������������ � "

♦ ������������������ � ��������������� �)�������� ��������� �$"jk���� ������� �������������lmnonpqrrst�u���� ����k���t�l��� ���l������v������tuul���v�luwxyzn{k���� ���|��� �������������lt�u���� �j��|k���t�l��� ���l������

⇒}t|�y~j���n���tu�����u��}�t��

Page 92: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

������������������ � ������

��������� ������������������� →��������������������

� �� ���� ��������� ��� ��� �������������������������� � �������������������������������

� !����������� "���#$�������������� ����"������#♦ !����������� "��������"������������ "���

�����%&'��⇒�"����&'�(� ♦ ��������� �������)�"� ����������� ♦ $� ������������"������� ����������

�*+� ♦ $� ���� ���������"����������������������

�,+-�������������� ♦ $� ����������� �� � $���� �"�������� ����"���������������� �����

� !����������� "���#� .������������ �������������������������

����������������""�� ��������� "���/������������������ � �� ����"����

� �� ����→���� ������������������ ���� �� ����� ��������� ������ � ����������������������⇒������������������������������������������������������������ ���

� 0��"��������������� "�������������������� ���� ��������������������� ������������ ������ ����� ��������� ������������������� ������������������������������� ����� ����� ���� !����

Page 93: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

��������������� ����������������������

����������� ��������������� �����������������

� ������������������������ ��� ��� ����

�������������������������� ���������������������������������������������������������� ������������������������������������������ ����������������������������������������������������������������������� ������������!� �������������� ������������!"#"$�%&&'�������������� ���������������������(������������(�����)"* ���������������� �������������������������� ���������������������⇒������)+�,-".

� /���������������������� �⇒������)+�&%��������� ��� ������������� ��"

� ����������������� �⇒������)+�0'"� ��1�������⇒������)+�02������������3���������� "

�4�������������� �*����������������.5� ������1� ��������,� ���� ��� �������� 6����������7������������������� �(�����1� �8"

�4�������������� 5� ���������1� ���������������������� ����������������������������������� �(����1� �8"

�����"����������������������������������#�������������������������������������������������������$�%%�����������#��������������������������������������������������������������������������������!

�4�������������� 5�����&�����#������������������������������������������������������������ !�&�����������������������'�#����������#�������������#����� ���������������������� ����������������!

Page 94: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

����������� ���� ��������� �������� ����

����������� � →� � � �

����������������������� ��������������������

��������� ���� ��!

����������������������� ��������������������

����������������������� ��������������������

����������������������� →"��������� ������ ����!

����������������������� ��������������������

� #����������������$% &��� �������� ��'��������(����)

� #����������������$

*������ �����������+�������������������������)"������������������������������ ����� ������������������ �)% � ����→�(��)

� #����������������$% � ��������(���������,��� ������������-*%

�� ��������������� �.�������� �������%� ��'��������(����)

� �������� ������� ����������� �-�������� ���%� ��.������ ���������������)% � ����→�(��)

�������������� ���� ������������������� �������� )

% /��� ���������������������������������+� ��%����� ���� ������� ���� ��� ��� ���� ������ �����⇒�����01%23)

% � ����→�(��)� #����������������$����� ����������������������� "��������� ������������� �����)�� !��"# �$����%�&

� #����������������$% � ��������(���������2��� ������������-� ���

���������� �.�������� �������� ��'�������(����)

� #����������������$% � ����→�(��)

� #����������������$

Page 95: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

��������������� ����� ������ ���� �������������������� ����� ������ �������������

��������������� ����� ������ ���� �����

����������������� ��������� !�������"��#���$���������� ���%����� �� &���������'���� ���� (���"�)*������ ��������� !�� �(�����+�� ���*!���� ������+����� ����������,(�!

����� ����� � �-*.*/0112*������3�4�5�6�47�������♦ ��������������� ���������������������

��������������������������������������������♦ ��������������������������������������������

�������������������������������� !"�♦ #���������������������������������������

$��������������%���������������������������������������

♦ &��������������������������������������������'(�������������)������������������������������������������������������!8���� ������� ����� � �-*.*/0112�������������8��'� �������� ������ �� (�������������#9*:8���� ��+������� ����� � ������� !��+8��'� �������� ������

⇒���+9;!<=*>������ ��������� !����"��#���;���������� ���%8����� ������ &���������'���� ���� (��"�)*

Page 96: Skoda Octavia Worshop Manual

��������� ������������

������������������������

������������������������������

��������� ��������� ��������������������� ����� !��"�����#�����$��� �%����#&'�()*+,����� !��"�����#-�$���#&'�()*+,

.�/������������0-������/���"1��222223�45����6#7#8�)�99:22

→.�/��$����� ,:.22222;� ��!<�=���� > ��" ?-@A:�����!�������22;� ��!<�=���� > ��" ?-@A:�����!�������22

�B��/�����/� ���>C4-������/���"1��� =�D����=���1����/���!��"5��=�=�+�>0&�;=�������������/����!���������/�=�������"1�����������=�/� ���>&4A�� →+�>&

�B��/�����/� ���>C��������������� ����� ����� ������������������������ ����� ��������������� ������������� ����������� ��� ������� �������������� ���EFGHIJKLFGMNOFHPGQNFRQSTU�����♦ ���������� ����� �������� ������� �����

� �� ��� �� ��� � ������������� �����������4.������<�=���� > ��"�� ���6&V&W#**���/ ������//�� D��/�XY.��"������������������Z⇒��$�X)498&

�B��/�����/� ���>C42�� +�> ���/9!���=�!�������YB��/"�� ���/<����1���+Z��/���!��"�=���4��>D��=�=�+�>0&

Page 97: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

�������������������� ���������������� ������������

�������������������� �� ��������������� ������������

�������������������� �� � →� � � �

����� ��� ������������ !�"#$������������ ����

� ���� �������������%& ������ ������������������ ��������'

� ���� �������������%& ( ������ �������)�� �� �������'

� ���� �������������%������♦ ������������� � ��������� ����������

������������⇒��� �������������������� ��������������� ���

♦ �� ����� ������ �������!" ��� ����� ����� ����#���� ����� ������ ���⇒��� ���$%�

♦ &��� �� ���� ����� ��� ���� � �������� ������������'

& #����→����'� ���� �������������%

�����(�� ������)����� ���)��������� ������������'������ ������������� �� � #����↑����� )� #����↓������������ #��������(

Page 98: Skoda Octavia Worshop Manual

��������� ������������

������������������������

������������������������������

����������

�� ��� ��������������������������������� ������������������ ������ ��������������������������������������������� ��������������������������!�"�� ���� ����������#��$�������������%�����&��!������� ����� ����� �� ��� ������ ���� ������������������������������������� ������ ����� ��'��� ������ ������ ����� ���� �������(��)����������! ��������������������������!�����"�� ���� ����������#��$�������������������������� ���� �������� �� ��� ������ ���� �����*�����������!�� �������������������������� �+�������������������� ����������� ����!�� ��������� �*�������!� �������������������������������� ��������������������������,-������������������ �����������������������������������������&� !�������� ������ ����� ��������������������������������������������� �������������������������������������������������� ��� ����������.�/����� �&������������������������� �*��������� !������������ ��� ������ ��0���������01$� ����� *�����������!�� ��������������������������������������&������������������ ������!������������������$ ��' ����������������������������������������������� ��� ����� ���������1�/�������������������� ���������������&� ����������������� ��������������������������!����������������� �%���� ������� ��!��������������� �������� ������������� ������� ��������(���� �������������������������������������������!�&��������� �������������� ����������' ���������������������������� �� ���� �&����������������&�� �� ������������� �2�����0�).������������ ! ������������������������������������ ���� ����������������� ������� ��������(���� ������������������������������������������������������������������������������������ ��������������������������������������������������� ���� ������� ��0)��

��������������������������� �!����������!�� ��

����� 33�

������!����4

Page 99: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������

����������� ����

���

���

���

�������������

���� ����

� � �������������������������� �������������������������� � !�"������������������������##���$"�%����� �������������������������������� ��&' ���� �� (�� ��� ������������#�����������)�������� �������������##����� ������� � �����*��������� ����������� � �������!+,�������� ���������-���������������##�������������-������ � �������� ������ �.���*��������� ����������� � �������!+,������� ������ �����������##�*��������� ����������� � �������!+,�/������������������������������0���!+,� �������������#���������#����!+,�����1�1���-���������������� ����"������ ��� ������������#���������##���!+,� ������*��������� ����������� � �������!+,�/����������)��������������������!+,� ������������#�������������!+,�����1�1���-���������������� ����"������ ��� ����������������������##���!+,� ������2� ���� ����������� � �������!3��������� ���������-���������������##�������������-������ � �������� ������ �.���2� ���� ����������� � �������!3�������� ������ �����������##�2� ���� ����������� � �������!3��/�������������������"��� ���-� ������������������0���!3�� �������������#���������#����!3������1�1���-���������������� ����"������ ��� ������������#���������##���!3�� ������2� ���� ����������� � �������!3��/���������������� ���)���$�� ����-� ��������������������!3�� ������������#�������������!3������1�1���-���������������� ����"������ ��� ����������������������##���!3�� ������

Page 100: Skoda Octavia Worshop Manual

��������� ������������

������������������������

������������������������������

����������� �������������

�������������������

�� ���������������������� ������� ������������������� �!������ "��!#��"�$���������%������ �&��#������������ �� ��� �����'%�������������� ������� ������������������� �� ��� �����$���������%�������������� ������� ���������������������� ���$�������������� �!����������(������"��)%� �!�������������������*+*���#�!�!������ ��������,� ��� ���������!%� �!����������������"��)%�������������� ������� ���������������������� ���$��������! ����� �!���������������"��)%� �!������������������*+*���#�!�!������ ��������,� ��� ���������!%� �!�����������������"��)%��� ,��������� ���������������-��� �!������ "��!#��"�$���������%������ �&��#������������ �� ��� �����'%��� ,��������� ���������������-��� �� ��� �����$���������%��� ,��������� ���������������-������ ���$��� ,������������ �� ����������� �!����������(��-���"��)%� �!�������������-�����*+*���#�!�!������ ��������,� ��� ���������!%� �!������������-���"��)%��� ,��������� ���������������-������ ���$�� �� "����!������������ �� ����������� �!�����������-���"��)%� �!������������-�����*+*���#�!�!������ ��������,� ��� ���������!%� �!�������������-���"��)%���"�� �./ ���"��!����,�/��������� ������"����0���1�,� ,�������� ��,�!� ���������,������������!!� ���)"����2�-�*3,�#��"���� �� "����!�����,���������"����� "������ ���,���� ,�������+�!" ���������"���� ����4�(���!���,��"� �!���������"���� ����4�-�*3,�#��"���������,���,���� "��!#��"� ���4�-���!�4�(�!� ���)���,�#�,� ��������+�!*5��,���� "��!#��"� ���,���������"���� �����4�-���!�4�(�!� ���)�,� "�����#��"�1�,� ����������"��*3,�#��"� ,������ �!"�����������,)����*�4�-����4�(�����"��)��� ��6������)�� �����#��"���� ,���*5���+������������"�� ��!���4�(�� "�������� "��!#��"�� �./%7"� �!���������"���� ����4�-�� "�������� "��!#��"�� �./%8"����,�������������,����� ����4��-����� "��!#��"�� �91�������������%

Page 101: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������

����������� ��������������������

�������� ��������������������������

������������������ ������!"�#�� #������#$%���$&� ##���!��� #��'�� �� �()*+���,���� ������!"�#�� #������#$%���$&� ##���!��� #��'�� �� �()*���-�� �����!"�#�� #��� ���$%./$&� ##���!��� #��'�� �� �()*0'�"�#���#� ������!"�#�� #������#$%�/�$&� ##���!��� #��'�� �� �()*+#��-��� ��,�#$1�$&�"���2�������� �1*3224��13�� ��,�# �#�4�5/16�'�� ��,�# �#�4��1+#��-��� ��,�#$1�$&��� ��'�� �7!��� #��� �1*8�#!���� ��'�#������2#�!�"���2�������9�5�1:��� ����.&!��� #��'�� �4'������� �1*;�������"��<��5:,�$,�<'��'�2�#��������- ��22'��'�$=���$&��>�22*?;�������"��<��5;�������"��<��5;�������"��<��58��������2��!"�#�� #�2��"�,���-&�22>��*@����#&�22>��*A�����#���,�"�#�&�22>��*)��������!"�#�� #����"��<�����������-����&��"����� �"��������2���-����#-������$0��$*&!��� #��'�� �� �B72#�!����������*0������"������#����#�C ���&�22>��*;�������"��<��5;�������"��<��5DEFGHIJKLMKNOHPQRSTMUVVONWKKHRGXYEZUH[O\]_\���WHKPON� �STO<� =�VKPRSRKGabEcXGKLO[UHdOPUSVLOPOGSaeE>�������SKMKNOHPJLKMfghiia

����������������� �������� ���� ������������������������������ ���������������������⇒��������� !

Page 102: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

�������� �������������������� ����������♦ �������������� �������������������������

����������������������������������������������������������

♦ �������!"�#�������������������������������������� ����� ���� �������� ���� ����������������������������� ����������������������$������

♦ �� �� ���������� ��� ����� ����� ���� �������������� �������������������� ���� ���������� ������������� ��������� ������� ������������������� ����� ���� %&������������ ���� ���������������������������'()��������������������$���������������������

♦ *�����������������������������⇒������+��,������

♦ ������������� �����������������������������������������������������������������"����������$!-.$������������������������������������������������������������������������� ������������������ ��� ���� ������������ ���� ������ ������⇒������-.$/0�

Page 103: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

��������� �����������������������������

������ �!!"#$"%&'$%"�!(#)*(#&�+%''#"�,(�-./0"$ ."*'%�!/)'

♦ ��������������� ������������������������������� ������� ������������������������������������ �

$�,(�-./0"$/1 ('#!!'1-'%/!�%'♦ ��������� ����� � ���������������

�� ������������������������������������� !"#$�������������������������������� ������� ������������ �$�������������������������� ��������������������������� ������� ����������� ������������ ����������� ������������� �������� �����������������������

Page 104: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������������� ���� ������������������������ ��������������������������� ����� �����������

♦ �������������� ������������������������������������������������������������������

♦ �������������� ���������������������������������������������������������������

�������� ��������������������������♦ ����������������������������� ����

��������������������!"����������������������� ������������������������#���$��������������� ���� �������������� ���� ����������������������������������

Page 105: Skoda Octavia Worshop Manual

������� Air Conditioning 87

Edition 01.99��������������

��������������������������������

8 - Display„AUTO“: for automatic mode♦ In the automatic mode, the Climatronic

maintains the selected interior tem-perature fully automatically.In this case, the temperature of theair flowing out, the blower speed andthe air distribution are varied automati-cally.

„ECON“: for cooling system off♦ In the ECON mode, only the compres-

sor is switched off; the heating andventilation continue to be controlledautomatically.

„OFF“: entire system switched off♦ Switch off with pushbutton -17-.

9 - Pushbutton for „automatic mode“

10 - Dash panel temperature sensor -G56-and blower for temperature sensor-V42-♦ Installation point for right-hand steer-

ing models

11 - „ECON“ pushbutton♦ In the „ECON“ mode, only the com-

pressor is switched off; the heatingand ventilation continue to be control-led automatically.

12 - Pushbutton for „warmer“

13 - Pushbutton for „colder“

14 - Pushbutton for „air directed to foot-well“

15 - Pushbutton for „air directed to head“

16 - Pushbutton for „blower faster“

17 - Pushbutton for „blower slower“♦ Switching off air conditioning:

Press pushbutton often enough untilthe display „OFF“ appears (blowerspeed: 0).

18 - Pushbutton for „fresh air/recirculatedair“

19 - Dash panel temperature sensor -G56-and blower for temperature sensor-V42-♦ Installation point for left-hand steering

models

Page 106: Skoda Octavia Worshop Manual

��������� ������������

������������������������

������������������������������

�������� �������� �������

����������� ���� �� ������������ ������ ������������� ������ ����������������������� ��� ����������

������♦ ���������������� �����������������������

����������� ��������� �������������������������� �

♦ �������������������������������������������������������������������������������������

⇒ ������������ ����������♦ ���������������������������������������

������������������������������� ������������������������� ��������������������������

Page 107: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

���������������������������

����������������������♦ �������������� ������ ��� �����������������♦ �������������� ������ ���

��������������������♦ �������������� ������ ���� ��� ���������� ����� ������ ��������������������������������������������������������������

♦ ����������������������� �������������������� �������� ��������������� ������

♦ !���������������������������� ����"#$$���������%����� �

♦ �����������������������♦ ���������������������⇒&��'��������������������♦ (��� ��� ������������ ����♦ �������������� ������ ���� ��� �������������� ������������ ���������������� �������������������� ���������!�����"� �

♦ �����������"#$$������������������ ����!)�������������� ��������� �� ������ ��$*� ��� �������� ����������� ���+,#��������������������� ����������������������

♦ �����������������������♦ ����������������������� �������������������� �������� ������������ ��

♦ !����������������$*������������� � ���������� ������ ������ ���-#,./

♦ 0�������������1/���������� ���2� ��������⇒����)��*3��������������14�����������2� �������,⇒����)��*�

������������������#�����$%��♦ �����������"#$$������������������ ����!)�������������� ��������� �� ������ ��$*� ��� �������� ����������� ���+,#��������������������� ����������������������

♦ �����������������������♦ 5����������� � ������ ⇒����)����

♦ ���������������������⇒����)���6

♦ 0�������������1/���������� ���2� ��������⇒����)��*3��������������14�����������2� �������,⇒����)��*�

��&��� �������������������������������♦ 5��� ���/����������♦ 7������ �� ��� � ��� � �� ��� ��������������

♦ ������������������������ ������������

,�������������� �������������'��♦ 8����� ����������������♦ �������� ��� ����������� �������

⇒����)��),'�������������������������������

♦ 9��� ����: ��������%���������������������

���(��������)������� ������������%'�♦ ����������������������� �������������������� �������� ������������ ��

♦ !������������ �� �� ����� � ������������� �� ������ �����������������

♦ �����������������������♦ ���������� �������������%'

⇒ 4���&������;���<��������� ���<�������������������������������� � ���������� ������������ ��6�.���� ��� �'

� ;���������������������� �������� ������'

� �(�������� ����"���♦ 5������� �������� ������ �������������������������

♦ �����������������������♦ ���������⇒����)��)�♦ 9������=������ � ������ �, 14���� �������2⇒����)��*�

Page 108: Skoda Octavia Worshop Manual

��������� ������������

������������������������

���������������������������������������� ��������

♦ �������������������� ���♦!�" #���⇒$��%&

�'�( ����)�*+�� ,*�+�-.�/�♦ ���0�1 ��2 ���������#�2� ��2��3��2�� 4�2���5������������4��3# ������♦ �������������������� ���♦!�5��1���⇒$��%6

�#�����)�*7�+��*��8♦9��33����:13����2♦9��3�#�5 2�� 2♦!�" #����������������⇒5���;<�;=

�/�%�>?��+,��@ ?>�+����/A�♦ �������������������� ���♦!�5��1���⇒5���;<�;&♦B�������C�2� 2"�D�1�� �E=FG���1�������H

⇒5���;<�IJ

���K�*+� @ ?>�+����LM�♦ �������������������� ���♦!�5��1���⇒5���;<�;6♦B�������C�2� 2"�D�1�� �E=FG���1�������H

⇒5���;<�IJ

Page 109: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������

��������������������� ♦ ������������� �����

⇒ ������ ����������������������������������� �������������

���� ��������������� ����������♦����� !"�#�$%&&�'�(�"�!) *�)�(#�+

��� �,-.�����������!�/(�"�� ��� �������0&1�2)!� ����� ���������3#�2�"�45%�����������/������ 2�)���� �!3������ ���

♦���!) *63+��#7��)�* ��)�♦ ������������� �����⇒���-.�.8♦9�!!) *6:;����� !"�#��� 07< �!)� ��⇒���-.�1=��!�� (�"7�"/:>��)��� ���07< �!)� ?5

⇒���-.�1@���A���B� C���♦ 3���7"� !���������������D������������������������������������A���B� C���♦ ������������� �����⇒���-?�@&

�%�A���B� ��� �������������������EF���♦���G6�� !"�##) *H�7"��!I7��!2�##���)�!")3<!)� �����������77"�����3#�2�"������2)!��� �� ����� ���♦

,/�"*� �+����)7� 7�)#�6���� ����� !) <��2)!������� �����7J-?K;���#� ! ����� ���♦���!) *63+��#7��)�* ��)�♦ ������������� �����⇒���95���A���B� LM����� ��������NO��♦���!) *63+��#7��)�* ��)�♦��(#��) *⇒���-.�-5♦9�!!) *6P�"7�"/7< �!)� ?5:>��)��� ���0

⇒���-.�1@�Q�R����S����T��U♦V7!�""�/�W) *'"�(#������#� !��/�

��� �♦ ������������� �����⇒���-.�5?���R����S����T��L�����B� T��X��U♦ :� �� ��� � ��� �� ������� ���

⇒���-.�5?�������T���������������C����♦ ������������� �����⇒���-?�5��� C����������� �������������������E�QY�U♦Z���#�7"�/?=[?@♦ �������� ��) �!�##) *' �� ���

⇒���-.�-5[%�A�T\�D���C��T������� ��T��� �T�������������������������EF]��;�"�7<##+#�W�"�77'�V�[���/�W���"�2�>�[�=������� ��!�"�� ���� (��!��� �

���9_���� ��T>�� �� �����(�"7�"/���� ��������������9

Page 110: Skoda Octavia Worshop Manual

��������� ������������

������������������������

�����������������������������

��������������� ������������������������������⇒�� !"#$$#%�&�'()��*+#','�-*./)��0���#%�+% #%1$+��#%� +12*+%���������3�+�4���'050����6+#'4�% #$#�%�'�����������$1070��8+(��33�4���'090�

� �:�*+'+$�*�-�4�%%�4$#�%090+$3'�12+#'���6�'��8+(�6#'#%������-$�33#�$-'�050��;-��3'�12+#'���6�'070 �6%+% �-$0#% #0'�4$#�%�3+''�60�

�����<��=��>����� ����������>�?���@�?�AB�C�����������������⇒�� !"#$$#%�&�'()��*+#','�-*./)��0���#%�+% #%1$+��#%� +12*+%���D%*�-�4�%%�4$�'070+% '�����14'�6090E4+$42+$$�*F�

Page 111: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

�������� ����������������������� ���������������������� ������ !"�#�$%&!%%! '()%!$*(+,'(-�#.⇒/!*012%%2-34!)56��'(2)7)!8'9:6��; !"2-3(-*2-+%(##2-3*(+,'(-�#�<-'#83=!--�=%!)(%$!!%>�##"�-%%� '�)(;%8)�+�-*�);7?@A;.�B8)-$!!%>�##"�-%%� '�)(%8)�+�-*�);?;@:C(-*'8##!8%!�%,�,!8+2-3;A;.D���������4,�-2-+%(##2-3E !2+%�-)8&&�)+�(#!�%,�$!!%>�##"�-%%� '�)(%8)�+�-*�);7?@A;>2%,!2#.FGHIJKLMNLOKLPQNRRKLMISGTNQKLMNLOOKPSRNUVLKQWXYZWQIMGQ[GT\KQ[]RKHNQTILKILQTIRVLKQW_aaW�������������� ���� �� ��������� ����������������������������������� ������ ������ ���

�� ��♦ ���������������� ������������������������������� ��������������������������������������� �

♦ �������������������������������bcdbe���fdcgbhddijgkldmno�������������� ����������� �����������pmgngqhgrdkstdu������

⇒v-+'�=%2!-(-*w(2-%�-(-=�♦xsmnushjmgnyz{||y����skduqngm}�������khq~jmgn�&'(��������rgm}hdjmgn�������������grqrrdl�hd��

Page 112: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

������� �� �� ���������������� ������������� ����������

�!������"� ���� #����"������������#�"��� "����� �$�����������%����� ���&������%��"�����"������������'�#������ �!���� ����%���������� �(���� ������� )*+,--��.� ���������� �������������"� �����&���"������ ������ �/0��������������1#�������23⇒��%�43�5'����"��/.��������� �� �����%1#��������2(⇒��%�43�5� 6789:;<=>8?@<A<?=<=>B?A?C@D?C:<C;?=E<A<?=<=>;?=AC?9�������������� ���� �� ��������� ����������������������������������� ������ ������ ���

�� ��♦ ���������������� ������������������������������� ��������������������������������������� �

♦ �������������������������������FGHFI���JHGKFLHHMNKOPHQRS�������������� ����������� �����������TQKRKULKVHOWXHY������

♦ �����KQVRULLKQZ����OWVKRKWQKQZ����������VNYH����� ��������� �LWWPV����FWYYHFRL[YWNRH\]GH[VGWNL\���KQVRULLH\������������������������������������������PWJKQZOUYRV_WYHaUPOLH����LHJHYV�������OWVKRKWQKQZ�����%�

♦bRHYKQVRULLKQZ������OWVKRKWQKQZ�������OHYc���������NQFRKWQde)��������� *�⇒�OUZH+,�-.�

Page 113: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

����������� �������������������� ���� ���������������������������� ��� ������ ������������������ �������� ������� ��� ��������� �������������������������� !⇒"�#$%&''&(�)�*+,��-.&*/*�0-12,��3���&(�.(#&(4'.��&(�#.45-.(���6�'.757���*����8.&*7�(#&'&�(�*�(*&�5'!

� �94�.47*�8#*&��*'�7.*�:0��$0(7�&-�-�*.'3&(�*�#:�*.&*:��8:�.-3;3:*��'5�����*3<3!� �=�-.*.'�-�0�7�((�7'&�(3;3!

�9(47*�8���'.''.75&(���'�*�>3!?5�-�4&'&�(&(���'�*&4�0&#�#&('5�5�04&(��:'5�.&*7�(#&'&�(�*!@(�*#�*'�.��&##.�.��A�B���-�4&'&�(&(���'�*#�8(.(#.''5�4.��'&��-0��&'�0'�:'5�45.:'�::*�45.&*C*�7&*70�.'�#.&*:�.-3<33.**�8D3!E� ����D(�8-�4&'&�(&(���'�*&440--�&�#&('5�F*�7&*70�.'�#.&*G-�4&'&�(!?��:.7&�&'.'�&(4'.��.3'&�(�:'5���'�*H�-��.4�-�*:�*�'5�:����8&(�4'�-4:&*4'�:.��A

� �I�0�&(7�((�7'�*3;3.'-�4&'&�(&(���'�*3<3!�=8&'75�(&�(&'&�(!�J-�*.'�:*�45.&*C*�7&*70�.'�#.&*-045�0''�(!�)5�(�&##��-�4&'&�(&4*�.75�#H0(-�0�7�((�7'�*3;3:*��-�4&'&�(&(���'�*3<3!

Page 114: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

� �������������� ��������������������������������������������������������������������������������������������������������������������������������������⇒� � !�! �"� ������������������������#�

�$����������� ���������������������%������� ���&�������� ���������������������������������������� �������'(

⇒� � !�)��*+,-./01203/045266/015+,7+82598+:6277-4/5/-0/01,-5-8;<=>;"�������������#������������ ���?

�@����� ������A�����������������������������������������������������⇒B��#"��� C��DE@����F���!'E@������� ����������� ���������@������������������⇒B��#"��� C��DE@����F���) E@������� ����������� �������������@�����������������������⇒B��#"��� C��DE@����F���!'E@������� ����������� ���������@���������������⇒� � '��G�*+,-./01�H������� �������������

� �I�����������������������#������������ ���������������������%���I�����������(������� ������$�D����������� �����J��K045266/01�������������������������������#��������������������������������� �������'(

⇒� � !�)��

Page 115: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������

����������������������� ������������������ ����������������� �������� ����������� ���� � ��� ���� ���������������������������

�� ���� �������������������������� ��� ���

⇒ ����������������� �� ����!�����"# �� �������������������������

� � ��� �$ ��� �$���� �⇒ ����������������� �� ����!�����%& �� �

������������������$ ��� �$���� � � ��� �$ ��� �������������� �⇒ ����������������� �� ����!�����"# �� �

������������������������ � � ��� ������ �� ���⇒��� �&#�'(���������� ) ��� �����$��� $������'��

� � *� ���$� ����� �����$� ������$����� ������������+������� � ��������,��

� *��$� ��������-����$������������ .������ �����������+������� � ������� ����

�������������������/��� .� �������������������������������� 0������������ ����� ������� ��� ������

�� �� � �� ���� ��� 0����� ����$�� ���������$�����#/

⇒��� �&"�%'�

Page 116: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������

������� ��������������� ����������������������������������������� ��!"# �$%"&'!"(�)�()�$ *⇒+�%,-. .(/0�#12��!".#3#�4!562��7���.(/"(%.(& ")).(/%"&'!"(�)

� �8�!"#" �!)4/9�((�9 .�(7:7*�;(&9#�<��) &7=7" "9'.(/�� �#*�>"1�!�&. .�(.(/�� �#7?7�$$ '��!�#" .(/#�%7@7�, 4#(.(/. *�>"1�!�&. .�(.(/�� �#7?7�$$ '�'�4&.(/*A�������B(& "))" .�(.&!�#$�#��%.( '�&"��<",.( '�#���#&��#%�#*�B(. ." ��"&.9&� .(/$4(9 .�(6?

⇒�!"/�C57D:*EFGHIJKLMKNJKOPMQQJKLMJRSHKNJT����������.(/"(%.(& ")).(/ '�".#9�(%. .�(�#�$ '�U).�" #�(.9&,& ��.&�&&�( .")),.%�( .9") � '" �$ '�".#9�(%. .�(.(/&,& ��<. '�"(4")9�( #�)

⇒�!"/�C57=C*>'��(),%.$$�#�(9�.& '" '��!�#" .(/"(%%.&7!)",4(. 7VC57'"& ���#�����%.(!)"9��$ '�'�" �#9�( #�)&W9"�)�&X*�Y$ �#.(& ")).(/ '�".#9�(%. .�(�#Z.(. ." ��"&.9&� .(/$4(9 .�(6?

⇒�!"/�C57D:*

Page 117: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������������������������������������

����� ������������������������� !""��#����$%&� �'�$%�()*+,)-.+,)/+01⇒2+34567768-9+:;<()=>6:?:+@=AB<()C*+,68->8368D7>..68-3>DE=>8).�F8=.@-G+88)G7+:1

� �H@:8D)83):CIC7E:+@-EJBKC>::+LC>83:)C*+,)1M$��!���$%N8D7>..>76+86D=):O+:*)3687E):),):D)+:3):1P����$%�Q)>D@:):)D6D7>8G)/)7L))87E)G+87>G7D+O7E)D)83):1R=)G6O6G>76+8>7STKUVJ1A111IB1W;XNO7E)D=)G6O6G>76+86D8+7>GE6),)3V�()=.>G)G)87:)+@7.)77)*=):>7@:)D)83):1NO7E)D=)G6O6G>76+86D>GE6),)3V�H)D7L6:68->GG+:368-7+G@::)87O.+L36>-:>*<:)=>6:6O8)G)DD>:41⇒

U@::)875.+LY6>-:>*DZ[.)G7:6G>.5>@.7568368->83567768-\+G>76+8DNO7E)L6:68-6D+1;1V�H)D7U.6*>7:+86GG+87:+.@867⇒=>-)]ACTI687)::+->7)O>@.7*)*+:4_<:)=.>G)6O8)G)DCD>:4

⇒=>-)]ACAJ1

Page 118: Skoda Octavia Worshop Manual

��������� ������������

������������������������

��������������������������������������������������������������

���� ���� �� ���� ��������������������� !�"#$%#&'�"�()*+����,-./01.2010324,22,5/,1.231,6,78,19640:;.2,8.22<,1,.10=2<,,-./01.201<03697>?:@,50-,.91;07892907,1

⇒�/.>,AB:AC?:D7/43>;077,;201?:�3176,78,12<103><EFG.781,50-,?H*�IJ��)*+K762.44.290796/,1=015,8972���1,-,16,018,1?L��I)*+:M,.631,1,6962.7;,N,2O,,72<,;072.;260=2<,6,78,1?P/,;9=9;.2907.2QRGSTEUF???VFRUWK=2<,6/,;9=9;.290796702.;<9,-,8T:@,/4.;,,-./01.2010324,22,5/,1.231,6,7:8,1?K=2<,6/,;9=9;.290796.;<9,-,8T:�,62O9197>.;;01897>20;311,72=40O89.>1.5X1,/.919=7,;,66.1Y?⇒

S311,72,40OZ9.>1.56[\4,;219;.4].342]97897>.78]92297>0;.29076K=2<,O9197>960?_?T:�,62S495.21079;;0721043792⇒�/.>,AB:RV972,110>.2,=.3425,501YaX1,/4.;,9=7,;,6:6.1Y⇒�/.>,AB:BE?

Page 119: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

������������������������������������������������������������

��������� �� ������� ��������������� �

������������� �������������������⇒ �!�"#$"%&�'()**+,-)./0+*),+-),1)23456

♦7� ������!���88�9:;��!�<� ���$���=�>8��!⇒?�!&@A'(/534)54563-,+*.),B)0/,

♦C�8>���������;D��>���⇒?�!&E�'F/+G

♦H� ;���♦I����=��!8��;���<� ������=�>8��!

?�!&JK'F/+G♦I����=��!��� ���L��!����������

?�!&MN'O0+*),+-),♦I����=��!��� ���L��!����������

?�!&M♦I����=��!��� ��<� ������⇒?�!&%

Page 120: Skoda Octavia Worshop Manual

��������� ������������

������������������������

����������������������������������������������������������

����������� ����������������♦ ���������������� ������������

���������⇒������������������������

♦ �� ����������������⇒�������������

������� �� �����������������♦ ���������

$���������♦ ������������������������ ����

��������������♦ ���� ���� �� �! ������ ����������

������

���������������������������♦ "������������������������������

���������⇒���#�������� �������

♦ $ ��� ��������� ��� �!��� �� ��������� �����������

♦ �� ����������������⇒������%&

���!������������������������������"��#�♦ ������ �� &'�&�♦ �� ���� ��� ���������� ������

⇒�������%��

Page 121: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

�����������������������������

������������������ ������������������ ����������������� �����!�"#$���!�%&� "�'��%��$����(���������)�*�#�+�"#��+(�'�"%�%','!�"#$����("$"#��&����'-'.���������/0123045267879:;3:0<4=;=9:0>5=2?;;5724:;@4:@>AB;:;5@;C

�����DE������� ������ ��������♦F56>:;2?;2;5640545G62:937H746@0::;@21I:0>2;=9:0>5=2?;;<930:920:?0>645GC♦ ����2;5640545G62:93?9620?01=2?;@0<;:24G?29G945622?;;<930:920:?0>645GC

�����JK�L������ M����N��������� �N�����������(� ("$�(�#��"#��'O'���!�%&������%����������!�"#$������','�"�����$��P��'-'.

Page 122: Skoda Octavia Worshop Manual

��������� ������������

������������������������

������������������������������

����������������� ���� ��������������������������������� ���������! �!"����� ��#������$��%���&������������������'��!$(�������������� �� ���� �� �� ��������� ��� ����������� ��������� ������������� �� ���������

������)����������� ���� ����������*����+����,�$��%������! �!�'������,����,��-�!������ �!���,�!!�,���!.��!$��.�������������(

������/0���11�������2���� �3����1��4������♦ ������� ������������������� ��������

��������������� ��������������������������������������������������

♦ �� ��������������� ����������������

Page 123: Skoda Octavia Worshop Manual

������� �������������� ��

�������������������������

��������������������������������

�������� ������� �������

������♦ ������������������������������ ���!��"�##���##������������������������������#����!��$��"����������# %����&���������&���������"��$��������������������������%��'���������������##(��������&����������)♦*%���&������ �����(�����"���"��$�����!���#�"���������������������"�������#�����������������+,-.�)♦/� �������������������������"��$��������������������(��)0123435637859:;7537<

♦ ������������� �����⇒��������

♦ ������ ������������� ��� ������������ ������ ��������=1>?97@495AB@B;C5DD5BE6@D63<

♦ ����������������♦ ����� �� ���������������������♦ ��� ��� ������ ����

Page 124: Skoda Octavia Worshop Manual

�������87 Air Conditioning

Edition 07.99��������������

������������������������������3 - Extraction and filling valve*

♦ High-pressure side♦ For extracting, filling and measuring♦ Always screw on cap with seal

4 - Air conditioning pressure switch -F129-or high-pressure sender -G65-♦ -G65- is fitted in place of -F129- on

models from Model Year 99 with 1.6-ltr./74 kW engine

♦ -G65- is fitted to all models as of ModelYear 2000

♦ -F129- (4-pin plug connection), opera-tion, removing and installing, testing⇒ page 87-24

♦ -G65- (3-pin plug connection), opera-tion ⇒ page 87-11, removing andinstalling, testing ⇒ page 87-25

5 - Expansion valve*♦ Removing and installing heat insula-

tion ⇒ page 87-26♦ Detaching and attaching refrigerant

lines ⇒ page 87-26♦ Removing and installing

⇒ page 87-26

6 - Dust and pollen filter♦ Below plenum chamber cover♦ Removing and installing

⇒ page 80-16

Page 125: Skoda Octavia Worshop Manual

������� Air Conditioning 87

Edition 07.99��������������

������������������������������

7 - Condensation drain valve♦ Inspecting, removing and installing

⇒ page 87-27

8 - Coolant temperature warning switch(+119 °C) -F14-♦ In refrigerant circuit♦ -F14- switches magnetic clutch -N25-

off if coolant temperature too high (offat 119 °C, on at 112 °C)

♦ 1.6-ltr./74 kW � Model Year 98and all models � Model Year 99

9 - Radiator fan control unit -J293-♦ Bolted on below battery rack♦ The magnetic clutch -N25- of the

compressor is also operated throughthis control unit

10 - Ambient temperature sensor -G17-♦ Task: operating temperature flap and

fresh air blower as a function of theambient temperature

♦ Emergency mode in the event offailure: fresh air intake duct tempe-rature sensor -G89- performs thistask. If both sensors are faulty, airconditioning continues operating withassumed value of +10 °C; no recir-culated air mode is possible; readoutin display of operating and display unit-E87-: „-“.

♦ Testing: by self-diagnosis♦ Bolted to longitudinal member at front

left

11 - Pressure relief valve*♦ O-ring seal:

8.6 mm; 1.8 mm♦ Tightening torque: 10 Nm♦ Testing ⇒ page 87-28

12 - Oil drain plug*♦ O-ring seal:

8.8 mm; 1.5 mm♦ Tightening torque: 15 Nm

Notes:

For draining refrigerant oil:

- Remove compressor.

- Remove oil drain plug.

- Rotate compressor at clutch plate ofmagnetic clutch in order to accelerate theflowing out of the oil.

13 - Compressor*♦ Removing and installing compressor

bracket ⇒ Engine, Mechanical Com-ponents

♦ Detaching and attaching compressorat bracket ⇒ page 87-28

♦ Detaching and attaching refrigerantlines ⇒ page 87-29

♦ Removing and installing compressor⇒ page 87-29

Notes:

♦ Removing and installing ribbed V-belt.⇒ Engine, Mechanical Components

♦ Mark direction of running of ribbed V-beltbefore removing; if the belt is fitted on to runin the opposite direction, it may be damaged.

♦ The piston stroke of the compressor isvariable and depends on the refrigerantcapacity requested.

♦ If a new compressor is installed or if freshrefrigerant oil is poured into the compressor(e.g. after cleaning refrigerant circuit andemptying compressor through oil drain plug),the compressor should be rotated by handapprox. 10 revolutions after being installed(in order to avoid compressor damage whenfirst operated).

14 - Magnetic clutch -N25-♦ Servicing ⇒ page 87-32

15 - Condenser*♦ Removing and installing

⇒ page 87-31

Page 126: Skoda Octavia Worshop Manual