DVD Portable Player DCP850

All version

3141 785 31651

Version 1.1

TABLE OF CONTENTS Chapter Technical Specification & Service Tips…………..……….. 1 Safety Instructions…………………………………………….. 2 Instruction for Use……………………………………………… 3 Mechanical Instructions………………………………………. 4 Troubleshooting …………………………………………………5 Overall Block Diagram…………………………………………. 6 Electrical Diagram……………………………………………… 7 Exploded View Diagram & Service Part List………………. 8 Revision List……………………………………………………. 9

©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips

Service Manual

1.0 TECHNICAL SPECIFICATION

General Dimensions (W x H x D): 210 x 39 x 178mm Weight: 1.1kg Power supply: DC 6.2-15.0V Power consumption: 9W Operating temp. & RH: -10-50degC / 40-90% Video System NTSC / PAL / AUTO Audio System Output voltage 1kHz: 2+/-0.2V THD 20-20kHz (%): </=3% Dynamic range: >/=70dB Signal/Noise ratio: >/=70dB Frequency response (20-20kHz):

+/-1dB

Channel Separation 1kHz >=60dB Channel Balance 1kHz <2dB Current consumption

DC-IN SUPPLY (9V) Battery Charging Current 450 +/- 50mA

BATT. SUPPLY Power Off Playback with TFT on Playback without TFT on Playback time Headphone out (headphone output load 2x16 ohm) Maximum output power: 10mW Frequency response: +/-1dB SNR (A-wght): >70dB THD (0.2-20kHz): 1% Left-Right Channel Separation:

>/=50dB

Left-Right Channel Balance:

</=1dB

Supported disc type Video Playback Formats:

Audio Playback Formats:

Playback disc type: DVD, Picture-CD, SVCD, Video CD, MP3-CD, CD-R/CD-RW, WMA-CD, DVD-R, DVD-RW, DVD+R, DVD+RW, SD/MMC Card

Video Playback Format: DVD / VCD / JPEG /

MPEG4 / DIVX3,4,5,6 Audio Playback Format: CD/MP3, MP3-DVD,

WMA Disc Diameter 12cm Pixel specification Zero bright-dot & max. 3 dark-dots Factory Service Mode (FSM) To check the software version and change region code of your DVD Portable 1. Power ON the DVD player and open the DVD

door 2. Press the “SETUP” button on remote control,

then select the “Preference MENU” 3. Press the remote button in the sequence as

9 -> 6 -> 5 -> 3 4. The LCD display showed the existing region

code. Press (navigation up) or (navigation down) repeatedly to select the number from 0 to 6.

5. Refer below table for your region code setting

Select “0” setting = Region Free (confidential)

Procedure on how to upgrade the software of the DVD Portable For the best performance of your DVD Portable. Check www.philips.com/support for latest software upgrades available. A) By CD-ROM 1. Download the “PHILIPS.BIN” file from the Philips

support site 2. Unzip the file and then burn it into a CD-ROM to

make a disc for upgrade

1.0 TECHNICAL SPECIFICATION

3. CD-ROM disc name must be “PHILIPS” (otherwise it will not be recognized as a disc for upgrade)

4. Power on the Portable DVD Player with AC/DC adaptor

5. Play CD-ROM for firmware upgrade

Warning: Do not unplug the AC adaptor during firmware upgrade to prevent flash corrupt of the set!!

6. Once upgrade is completed, the player will restart automatically and observed PHILIPS LOGO on the screen.

7. Open the DVD door to remove the disc B) By SD/MMC Card 1. Download the latest “PHILIPS.BIN” from the

Philips support site 2. Unzip the files and then copy into SD/MMC Card

for upgrade 3. Power on the Portable DVD Player with AC/DC

adaptor 4. Change the set from DVD mode to Card mode by

press the “Card” button on remote control 5. Insert the SD/MMC Card on the card slot 6. The set will automatically upgrade Warning: Do not unplug the AC adaptor or remove SD/MMC Card during firmware upgrade to prevent flash corrupt of the set!! 7. Once upgrade is completed, the player will restart

automatically and observed PHILIPS LOGO on the screen.

8. Remove the card from the set Note: If you want to use the same card for audio / video playback on the set, please delete the “PHILIPS.BIN” first. Otherwise, it will be recognized as for software upgrade again.

2.0 SAFTETY INSTRUCTIONS

GB WARNING

All ICs and many other semi-conductors aresusceptible to electrostatic discharges (ESD).Careless handling during repair can reduce lifedrastically.When repairing, make sure that you areconnected with the same potential as the massof the set via a wrist wrap with resistance.Keep components and tools also at thispotential.

F ATTENTION

Tous les IC et beaucoup d’autressemi-conducteurs sont sensibles auxdécharges statiques (ESD).Leur longévité pourrait être considérablementécourtée par le fait qu’aucune précaution n’estprise à leur manipulation.Lors de réparations, s’assurer de bien être reliéau même potentiel que la masse de l’appareil etenfiler le bracelet serti d’une résistance desécurité.Veiller à ce que les composants ainsi que lesoutils que l’on utilise soient également à cepotentiel.

ESD

D WARNUNG

Alle ICs und viele andere Halbleiter sindempfindlich gegenüber elektrostatischenEntladungen (ESD).Unsorgfältige Behandlung im Reparaturfall kandie Lebensdauer drastisch reduzieren.Veranlassen Sie, dass Sie im Reparaturfall überein Pulsarmband mit Widerstand verbundensind mit dem gleichen Potential wie die Massedes Gerätes.Bauteile und Hilfsmittel auch auf dieses gleichePotential halten.

NL WAARSCHUWING

Alle IC’s en vele andere halfgeleiders zijngevoelig voor electrostatische ontladingen(ESD).Onzorgvuldig behandelen tijdens reparatie kande levensduur drastisch doen verminderen.Zorg ervoor dat u tijdens reparatie via eenpolsband met weerstand verbonden bent methetzelfde potentiaal als de massa van hetapparaat.Houd componenten en hulpmiddelen ook opditzelfde potentiaal.

I AVVERTIMENTO

Tutti IC e parecchi semi-conduttori sonosensibili alle scariche statiche (ESD).La loro longevità potrebbe essere fortementeridatta in caso di non osservazione della piùgrande cauzione alla loro manipolazione.Durante le riparazioni occorre quindi esserecollegato allo stesso potenziale che quello dellamassa dell’apparecchio tramite un braccialettoa resistenza.Assicurarsi che i componenti e anche gli utensilicon quali si lavora siano anche a questopotenziale.

“Pour votre sécurité, ces documentsdoivent être utilisés par des spécia-listes agréés, seuls habilités à réparervotre appareil en panne”.

GBSafety regulations require that the set be restored to its originalcondition and that parts which are identical with those specified,be used.

NL

Veiligheidsbepalingen vereisen, dat het apparaat bij reparatie inzijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,identiek aan de gespecificeerde, worden toegepast.

F

Les normes de sécurité exigent que l’appareil soit remis à l’étatd’origine et que soient utiliséés les piéces de rechange identiquesà celles spécifiées.

D

Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zubeachten. Der Original zustand des Geräts darf nicht verändert werden;für Reparaturen sind Original-Ersatzteile zu verwenden.

I

Le norme di sicurezza esigono che l’apparecchio venga rimessonelle condizioni originali e che siano utilizzati i pezzi di ricambioidentici a quelli specificati.

"After servicing and before returning set to customer perform aleakage current measurement test from all exposed metal parts toearth ground to assure no shock hazard exist. The leakage currentmust not exceed 0.5mA."

CLASS 1LASER PRODUCT

3122 110 03420

GB Warning !Invisible laser radiation when open.Avoid direct exposure to beam.

S Varning !

Osynlig laserstrålning när apparaten är öppnad och spärrenär urkopplad. Betrakta ej strålen.

SF Varoitus !

Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiinanäkymättömälle laserisäteilylle. Älä katso säteeseen!

DK Advarse !

Usynlig laserstråling ved åbning når sikkerhedsafbrydere erude af funktion. Undgå udsaettelse for stråling.

When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser

may be received.

2.1 ESD PROTECTION

PREPARATION OF SERVICING

Pickup Head consists of a laser diode that is very susceptible to external static electrocity.

Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement,

its life might be shortened. When replacing, use a conductive mat, soldering iron with ground wire,etc. to

protect the laser diode form damage by static electricity.

And also, the LSI and IC are same as above.

Soldering ironwith ground wireor ceramic type

Ground conductivewrist strap for body.

Conductive matThe ground resistancebetween the ground lineand the ground is less than 10

1M

SAFTY NOTICE

Plug the AC line cord directly into a 120V AC outlet (donot use an isolation transformer for this check). Use anAC voltmeter, having 5000 per volt or more sensitivity.Connect a 1500 10W resistor,paralleled by a 0.15uF150V AC capacitor between a knomn good earth ground(water pipe, conduit, etc.) and all exposed metal parts ofcabinet (antennas, handle bracket, metal cabinetscrewheads, metal overlays, control shafts, etc.).

SAFTY PRECAUTIONS

LEAKAGE CURRENT CHECK

Measure the AC voltage across the 1500 resistor.The test must be conducted with the AC switch on andthen repeated with the AC switch off. The AC voltageindicated by the meter may not exceed 0.3V.A readingexceeding 0.3V indicates that a dangerous potentialexists, the fault must be located and corrected.Repeat the above test with the DVD VIDEO PLAYERpower plug reversed.NEVER RETURN A DVD VIDEO PLAYER TO THECUSTOMER WITHOUT TAKING NECESSARYCORRECTIVE ACTION.

READING SHOULD NOT EXCEED 0.3V

DVD VIDEO PLAYER

AC OUTLET

AC VOLTMETER

Test all exposed metal.Voltmeter Hook-up for Leakage Current Check

0.15uF 150V AC

150010W

(5000 per voltor more sensitivity)

Good earth groundsuch as a water pipe,conduit, etc.

The lightning flash with arrowhead symbol, within anequilateral triangle, is intended to alert the user to thepresence of uninsulated "dangerous voltage" within theproduct's enclosure that may be of sufficient magnitude toconstitute a risk of electric shock to persons.

The exclamation point within an equilateral triangle isintended to alert the user to the presence of importantoperating and maintenance (servicing) instructions in theliterature accompanying the appliance.

3.0 INSTRUCTION FOR USE

4.0 MECHANICAL INSTRUCTION

Disassembly Procedure 1 Remove 6pcs of screws on front side of

bottom cabinet. (Please note the left hand side screw is shorter than others, make sure do not put long screw during re-assembly, otherwise it will damage the middle cabinet!)

2 Remove 2pcs of screw on top side of bottom cabinet.

3 Remove 2pcs of screws on middle cabinet.

4 Open the bottom cabinet carefully, unplug the wire connector of key board from the main board. (left bottom side)

4.0 MECHANICAL INSTRUCTION

5 Unplug another wire connector of Ipod

board from main board. (right top side)

6 To remove main board from cabinet, unplug / disconnect the wires on top side first.

7 And then remove all screws on main board connected with bottom cabinet.

8 To remove battery board and battery from cabinet, remove the screws on battery board connected with bottom cabinet first, and then pull out the battery from taped foam carefully. Make sure battery without damage.

4.0 MECHANICAL INSTRUCTION

9 Be careful not to broken the wire

connection between battery and battery board. Otherwise you can re-soldering them as shown in picture.

10 To remove DVD loader, unplug the wires

connected with main board.

11 And then remove the flex cable on the bottom side.

12 The middle cabinet ass’y overall

4.0 MECHANICAL INSTRUCTION

13 To remove the key board, remove the

screws as shown in picture.

14 To remove the Ipod board, remove the screws on slider cover and then remove some tapes attached on middle cabinet and wires.

15 To remove front cabinet, remove the screw on display frame first. Carefully open the display frame with the catches by screwdriver. (There are six catches as shown in picture)

16 To remove the TFT, de-soldering the wire connected between TFT and TFT board first. (Please note the wire location as shown in picture during re-assembly)

4.0 MECHANICAL INSTRUCTION

17 Unplug the flex cable connected with TFT board at the backside also.

18 To remove the TFT board ass’y, de-soldering the wires between speaker and TFT board. (Black wire is connected to “-ve” port and red wire is connected to “+ve” port)

5.0 TROUBLESHOOTING

SYMPTOM: BATTERY NO POWER

Start

Check Battery capacity?

BATTERY CAN＇T Power ON

Check charging function OK? SET OK?

No Defect, return set to Customer

Check adaptor power-ON OK?no

Check the Power-ON button and cable OK?

Replace Main BoardReplace Button or Cable

yes

Yes

NO

No

Yes

Yes

No

5.0 TROUBLESHOOTING

SYMPTOM: NO IMAGE / NO SOUND

SYMPTOM: NO IMAGE OUTPUT ( THE PANEL SHOW BLUE PICTURE)

Start

Check the external AV Cable TYPEnote and connection is OK?

Replace DVD DriveCheck DVD Drive work?

Replace Main Board

Exchange AV cableNOTE: AV Cable TYPE from outside to Inside L-Audio, R-Audio, Video, Ground

no

yes

no

yes

SYMPTOM: NO SOUND COMES FROM SPEAKER

Start

Check the Connection OK? Reinsertion

Check speaker OK?

Replace Main Board

Change the speaker

no

yes

no

yes

5.0 TROUBLESHOOTING

SYMPTOM: THE DVD DRIVE DOES NOT WORK

SYMPTOM: THE DVD DRIVE DOESN＇T WORK

Start

Replace DVD-Loader

Check the DVD-Loader OK?

Replace main board

NO

Yes

Yes

Cable ReinsertionNOCheck DVD-Loader connection OK?

5.0 TROUBLESHOOTING

SYMPTOM: ADAPTOR CANNOT POWER ON

Start

Check Adaptor OK?

Adaptor can not Power ON

Change adaptor SET OK?

Return set to Customer

NO

Check the Power-ON button and cable OK? Replace Main Board

Replace Button or Cable

Yes

NO

Yes

No

YES

OK

5.0 TROUBLESHOOTING

SYMPTOM: REMOTE CONTROL CANNOT WORK

SYMPTOM: THE REMOTE CONTROL CAN NOT WORK

Start

Check TOP-board OK?

Replace main board

Yes

Yes

Cable ReinsertionNOCheck CABLE form

bottom board to top board connection OK?

Replace IR receiver

Return to custormer

OK

OK

Replace top boardNONO

OK

5.0 TROUBLESHOOTING

SYMPTOM: NO SOUND FROM HEADPHONE

5.0 TROUBLESHOOTING

SYMPTOM: LED DISPLAY FAILURE

SYMPTOM: LED Display Fail

Start

Check TOP-board OK?

Replace main board

NO

Yes

Yes

Cable ReinsertionNOCheck CABLE form Main board to top board connection OK?

Replace LED

Return to custormerOK

Replace top boardNO

OK

OK

5.0 TROUBLESHOOTING

SYMPTOM: KEY & BOTTON FAILURE

SYMPTOM: Key & Botton Fail

Start

Check KEY board OK?

Replace main board

NO

Yes

Yes

Cable ReinsertionNOCheck CABLE form board to board connection OK?

Return to custormerOK

Replace KEY board

OK

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

6.0 OVERALL BLOCK DIAGRAM

OPU

P89LPC936FDH

MOTOR DRIVER

MT1389FEXXXXX-HESL

CARD READER MMC/SD/MS

SDRAM

3 I/O

IR

IR-TAUTO DETECT

24C04

DVD-SVIDEO

INVERT

D3031 + 8D02

IPOD-CVBS IN

4X16

UART

KEY1..12 ADC0/ADC1

FLASH 16M

EEPROM

iPod CHARGEAND POWERCRL

FB-I/O

TFT:7" OR 8.5"

VIDEO SW P74LV4066

DC/DC 3.3V

1.8V

DC9V INDC JACK

POWERON/OFF SW

POWER CONTROL

DC9V

bright VR

WIDE

DVD CVBS

AUDIO SELECTDVD AUDIO

AUDIO OUT

AUDIO LINE OUT

AUDIO SW

AUX-EPORTAUDIO

iPod AUDIO

to RCA jack

ASA LOADER

HOP1200W

POWER DECTETION

POWER CTL

POWER CTL

VIDEO CVBS OUTAVOUT

AUDIO MUTE Ctl

TFT DRIVER BOARD

SPEAKERR/L

SPEAKERR/L

connectorboard

iPod VIDEO

OR Gogear

LI-ON Battery

battery charge board

2000MAH /7"

2400MAH /7"

TFT Video signal (Y/C/CVBS)

TFT POWER 9V

AV-CVBS IN

PM2303-D

VIDEO CVBS OUT

AUDIO AMP

EARPHONE 2

SPEAKERR/L TDA2822M

P74LV4052

VOL AJD VR

EARPHONE 1 NJM4558

O/P

iPod AUDIO

MAIN BOARD

8

8

7

7

6

6

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

VER : 060613 V1

DCP750-DOCKING

PHILIPS SEMICONDUCTORS

A

1 1Monday, January 15, 2007

Title

Size Document Number Rev

Date: Sheet of

UART SEUART RE

IPOD-CVBS

IPOD-CVBS

IPOD/PI_O_R

IPOD/PI_O_L

AUI_O_L

AUI_O_R

IPOD/PI_O_LIPOD/PI_O_R

12V IN

U1123456789101112131415161718192021222324252627282930

GNDA/V GND

Line out - RLine out - LLine in - RLine in - L

N.CVIDEO OUTS-VEDIO CS-VEDIO Y

Serial GND-DSerial TXDSerial RXD

N.CGND

USB GNDN.C

3V3 POWER OUT12V POWER IN12V POWER INUART ENABLE

DATA TPA-5V USB POWER

DATA TPA+USB DATA L-

DATA TPB-USB DATA L+

DATA TPB+INPUT GNDINPUT GND

TP1SDA

TP2SCL

R10 510K

R9

75

R8

10k

R5 22k

R7

10k

R622k

7.0 ELECTRICAL DIAGRAM7.1 IPOD BOARD

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

ADC_KEY1 ADC_KEY2

R157680E

S10 SOURCE SELECT12

R147430E

R156680E

S8 REPEAT12

S12 PLAY/PAUSE12

R1591K

R149270E

S4

DBB1

12

R1601K

S9 NEXT12

S2 STOP12

R151330E

R148270E

R146430E

S6

TIMER

12

S3 PERVIOUS12

R150330E

R155470E

S1 ALARM-112

S5 VOL+12

R153470E

S7POWER ON/OFF

12

S11 VOL -12

7.2 KEY BOARD

1 2 3 4 5 6 7 8

A

B

C

D

87654321

D

C

B

A

C2030.01uF

C2321200P

12

R242NC

12 R237

18K

12

R2323.3K

12

R24

124

K

12

R24010K

12

R233560

C2330.1uF

12

R2311K

C2141uF

C2161uF

C2181uF

12

R224 560

C620.01uF

C223

0.01uF

C222

0.01uF

1 2R221 12K

12 R227

56K

C2070.01uF

1 2R228 20K

C224

0.01uF

1 2

R226 18K

1 2R210 18K

12 R220

24K

1 2R222

24K1 2R223 12K

C208 0.1uF

1 2R211

1M

C2130.01uF

12 R216

8K2

12

R2155K6

C20

268

0P

1 2

R20812K

12 R207

18K

C2300.01uF

C2060.01uF

C22

010

uF/1

6V

C2090.01uF

12 R236

680K

12 R278

39K

12

R27

139

k

12

R27215K

12

R206330

C470.22uF

R252 6K8R253

22K

R238NCR83

1K

R225

56K

C20

50.

047u

FC2211nF

HSYFRPT

CSY

VDD

FRPV

VB

VRVG

VGH

VGL

VCOM

BLKDM1

R202

10M

From: DVD BOARD

C2341uF

C2271uF

C215 1uF/50V

C217 1uF/50V

C219 1uF/50V

LA2 100uH

R212 22k

+5V

+5V

R576100K

R579 100K

R577

100K

R575

100K

+5V

+5V

C2121U

C49

47uF

/10V

C2500.1U

C23

110

uF/1

6V

CA90.1uF

R250560

R574100K

R578100K

+5V

+8V

CA210uF/16V

RA2510K

RA3100K

CA3

0.1uF

CA8 0.22uFLA4

100uH

RA1100

CA120.22uF

CA110.22uF

7.5V

VGH

R2745K6

R273

12K

LA3

FB 2.2K

CA1522P

1 2 346 5 ICA1

9266

CA161nF

CA141u VGL

DA1 DA204

DA6

DA204DA4

DA204

C210680P

VCC

R21747

CA17100uF

LT3100uH

Y

C

WIDE

PH

TINT

CO

N

WIDE

1

3

2

Q3SI2306

CA210.1uF

L2

FB

BRI

CSY

FRPV

C350.01uF

BRI

BLK

VRVGVB

Y

C

HSY

COM

DM1

FRPTC19

10u/16v

R6675

R69

12k

R672K

C41

10u/16v

VR110k

5V

C45

0.01u

C67

1nF

C58

1nF

C601nF

C740.1uF

C571nF

C561nF

D7

1N4148

Q6 D2118R

U1

TL431

R3

560

R110K

R210K

X2023.579MHz

VC

C1

GN

D2

DA

TA3

IR1IR-SENSOR

C40.1uF

R4

47IR+5V IR OUT

C6410uF/16V

CA41uF

CA51uF

R6

BEAD 2.2K

C830.01uF

Y 3

F ADJ44

C 5

ACC FILTER11

APC FILTER15

VCO IN14

VCO OUT16

TINT13

IDENT FILTER4

18

GN

D17

VC

C1

43

VC

C2

25

KIL

LER

FIL

TER

8

R-Y

/B-Y

PH

ASE

12

SW7

EXT

R IN

41

EXT

G IN

40

EXT

B IN

39

S/H

PU

LSE

R33

S/H

PU

LSE

B35

S/H

PU

LSE

G34

PEA

K L

IMTT

ER9

CO

N42

G1 30

GAMMA2 31

RGB AMPLITUDE 10

SUB BRIGHT R 27

SUB BRIGHT B 28

BRIGHT 32

FRP 29

BLK 26

B 24

B DC DET 23G22

G D

C D

ET21

R20

R D

C D

ET19

SYN

C IN

36

SYN

C O

UT

37

SYN

C S

EP38

PIC

TUR

E48

AG

C F

ILTE

R46

CLA

MP

45

CO

LOR

6

AG

C O

UT

47

H2

TRA

P1

U2D3031

CA110uF/16V

7.3 TFT DRIVER BOARD

1 2 3 4 5 6 7 8

A

B

C

D

87654321

D

C

B

A

LT4 FB 0805VGH

VGL

1 2RT19 100

1 2RT20 100

1 2RT25 51K

12

RT9560

1 2

RL6 560

12

CT220.47uF

1 2

RT42 100

1 2RT40 100

1 2

RT39 100

1 2RT36 100

VCC

1 2CT231uF

VCC

12

CT29

680P

12

CT32680P

12

CT44680P

12RT43 2K

12 RT44 560

12RT46 5K6

VCC

1 2RT59 FB 600R

1 239RT62

1 2RT63 39

LT100.82UH

1 2RT64 39

1 2

CT331000P

12

RT4910K

1 2

CT36100P12

RT4839K

1 2

CT371000P

12

RT4739

VCC

GND1 2

RT1560 1 2RT28 2K

1 2RT29 2K

1 2RT30 2K

1 2RT31 2K

12

RT2739

12

CT261000P

VRT410K

12

CT45

100P

12

CT52

56P

12

CT51

56P

12

CT53

56P

12

RT5010K

12 RT52 1M

12RT54 51K

12

RT5320K

1 2CT39 0.1uF

1 2CT40 680P

12

RT5

551

K

+

-

1

2

3

5

4

UT4NJM2107F

1 2

RT573.9K

1 2

RT5668K

12

RT582K

12

CT410.1uF

DT1RLS4148

12CT3

0.1u

F

1 2CT46 27P

GN

D1

DT2

ISV

215

12

CT500.1uF

12

RT67

39K

12

RT6810KVRT5

50K

12

CT490.1uF

12

RT130

12

ZT29.1V

VG

L

+5V

VCC1

VRVGVBCSYDM1BLKHSYFRP

FRDVVDD1VGHVGLVCOM

VRVGVBCSYDM1BLKHSYFRPT

FRDVVDD1VGHVGLVCOMGND

CT1180.1uF

CT18

680P

CT8

680P

CT17

680P RT21 100

CT1161nF

CT1190.1uF

CT550.1uF

CT90.1uF

CT150.1uF

CT161uF

TO: PAGE 1 of 4

TO:CPT PANEL

PHA

SE

GND1

VCC2

VGL3

VGH4

STVR5

STVL6

CKV7

U/D8

OEV9

VCOM10

VCOM11

L/R12

MOD13

OEH14

STHL15

STHR16

CPH317

CPH218

CPH119

VCC20

GND21

VR22

VG23

VBAVDD25

AVSS26

JCPT1

CON26

CSY

2

VC

C1

HPO

13

HPI

14

PDA

15

CK

C16

OSO 17

OSI 18

FD2 19

NC1 20

ZM1 21

ZM0 22

CBG 23

SAM 24

RLC 25

OEH 26

SH2 27

SH1 28

CP3 29

CP2 30

CP1 31

GND 32VC

C33

Q1H

34

RST

35

CPV

36

OE1

37

OE2

38

OE3

39

NC

240

STV

141

STV

242

UD

C43

VP1

44

VP2

45

VP3

46

VP4

47

POI

48

POD49

NC350

NPC51

NC452

G2453

3OE54

NC555

VSY56

HSY57

BLK58

ESY59

COM60

FRP61

NC662

VIY63

GND64

RS4

3

RS3

4

RS2

5

RS1

6

DM

47

DM

38

DM

29

DM

110

SDC

11

DLT

12

U3

8D02

VGLVGH

PANEL VCC

PANEL VCC

VCOM

VCOM

R5

2K

R715K

R815K

R9

470K

R1039K

R1115K

R12 10K

C6

220P

C8220P

Q23904

Q43904

Q73906

R133K3

R632K2

CSY

50/60

CT2100P

L1 FB 600R

7.3 TFT DRIVER BOARD

1 2 3 4 5 6 7 8

A

B

C

D

87654321

D

C

B

A

OU

P1

ENR

2

SST

3

VD

D4

REF

5

AD

J6

FB7

OM

P8

CTI

MR

16

PDR

V_B

15

PDR

V_R

14

CT

13

RT

12

GN

DR

11

PDR

V_C

10

ND

RV

_D9

U7 OZ970

1 7

3 6

T1

.

1

23

4 5

67

8

U4

.

1

23

4 5

67

8

U8

.

2

1J2

.

R3922

R4110K

D15.6V

R4010K

R4210K

D25.6V

C200.047uF

C24330P

C251uF

C260.22uF

C290.1uF

R4768K

R461K

R5068K

C300.1uF

C31470P

C321500PuF

C330.022uF

R5147K

R52100K

Q13906

C340.1uF

R541M

R53 39K

C270.047uF

C2222P/3KV

R43820

R44820

R4810K

L4

100uH

C7100uF/16V

C230.022uF

R4910K

VCC

TFTEN

+5V

+8v

D3

DA204

D4DA204

C531nF

C50100p

C51100p

C521nF

C551nF

C541nF

C1071000p

C10.1u

D59.1V D6

6.2V

C870.1uF

C370.1uF

C282.2uF

C8647uF

C16

2.2uF

7.3 TFT DRIVER BOARD

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

IRIN

RST_MCU

VSCK

8.4V_CHARGE

IPOD/PI_O_L

IPOD/PI_O_R

IPOD-CVBS

MUTE

VSTB

VSDA

VSCK

IRDVD

IRIN

DVDPOWER

SWA

SWB

SWC

GND

IRDVD

VSDA

ADC_KEY2

UART_O_SCLUART_I_SDA

RST_MCUUPDATE_BUPDATE_A

ADC_KEY2

ADC_KEY1

ADC_KEY2ADC_KEY1

UPDATE_B

VSTB

UPDATE_A

WIDE

BackLight_EN

WIDE

8.4V_CHARGE

IPOD-CVBSIPOD/PI_O_L

IPOD/PI_O_RUART_I_SDAUART_O_SCLDET

MUTEBackLight_ENDVDPOWER

DET

ADC_KEY1

SWASWBSWC

IPODPOWER

8.4V_CHARGE 1

IPOD/PI_O_L 4

IPOD/PI_O_R 4

IPOD-CVBS 4

MUTE 4

VSTB 2

VSDA 2

VSCK 2

IRDVD 2

IRIN 4

DVDPOWER 1

SWA 4

SWB 4

SWC 1,4

GND 1,2,3,4,5

WIDE 4

BackLight_EN 4

3V3_CPU

3V3_CPU

3V3_CPU

3V3_CPU3V3_CPU

C93100P

+

C91100u10v

12

R189 220ER209 220E

R15

92K

2

R196

0

D7

R177 0E

R21

12K

2

R181k

C106100P

R201 220E

R192 560E

C99100p

R20

82K

2

R200 220E

C107100P

R16

4N

C

R179 0E

C120100P

R190 560E

R176 220E

C96100P

R16

32K

2

R2031K5

C105100P

C108100P

R181 0E

R17

52K

2

R16

92K

2

R17

02K

2

R17

42K

2

C95100P

JJ2

MCUUPDATE

12345

12345

R182 0E

C110100P

R191 0

R17

32K

2

R180 0ER210 0E

R16

52K

2

C116100P

C50.1uF

R40

2K2

C113100P

J9

3PINCON

123

C920.1uF

C97100P

L291uH

C112100P

R16

62K

2

R195 470E

R197 0

U11P89LPC935

1110

07

0908

060504030201

121314

27262524

18

151617

28

1920212223

P1.3/SDAP1.4

VSS

P3.0/XTAL2P3.1/XTAL1

P1.5/RSTP1.6P1.7P0.0P2.1P2.0

P1.2/SCLP2.2P2.3

P2.6P0.1/AD10P0.2/AD11P0.3/AD12

P1.0/TXD

P2.4P2.5

P1.1/RXD

P2.7

P0.7P0.6VDDP0.5

P0.4/AD14

R194 1M

R186 0E

R16

72K

2

C98100P

C10022p

R17

22K

2

R185 0E

R184 0E

L28 4u7H

XT16M

R187 0E

C117100P

R176 220E

R16

12K

2

C109100P

C119100P

C104100P

C102100P

C10122p

R16

22K

2

J10

12PINCON

123456789

10

R2021K5

C111100P

R21

2K2

7.4 MAIN PCBA

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

SDD3_C

SDD0_C

SDD3_C

YUV7

MSCLK

SDD3_C

SDCMD_C

IO_17

MSD1

SPDATAMSD1

MSD2

MSBS

SDCLK_C

MSBS

SD_CD

SDD2_C

GPIO_4MSD1

SPMCLK

MSD0

MSD0

MSD2

MSCLK

MSD0

MSD2

GPIO_6

HSYNC#

MSBS

SDCMD_C

MSD3

GPIO_3

SDD2_C

ASDAT0ASDAT3

SD_CD

VSYNC#SDD1_C

SDCMD_C

SDD2_C

GPIO_5

ASDAT2ASDAT1

SD_CD

SDD1_CSDD0_C

SDCLK_CDV33

MSCLKMS_3V3

MSD3

MSD3

MS_CD

MS_CD

SDD1_CSDD0_C

GPIO_[3..6]ASDAT[0..3]DV33

GND

MS_3V3

HSYNC# 2

GPIO_6 2

GPIO_3 2

YUV7 2

GPIO_5 2

SPDATA 2

SPMCLK 2

IO_17 2

GPIO_4 2

ASDAT1 2

ASDAT0 2ASDAT3 2

ASDAT2 2

VSYNC# 2

GPIO_[3..6]2ASDAT[0..3]2DV33 1,2,3,4

GND 1,2,3,4,6

DV33

DV33MS_3V3

C88

20pF

R150

10k/NC

R149

10k/NC

C89

20pF

J8

TAI_TWUN_3IN1_CARD

2018

17161413119865

19

1541071232

2221

123

SD-DAT2SD-DAT3

MS-VCCMS-SCLKMS-D3(MS-RESERVED)MS-INSMS-D2(MS-RESERVED)MS-D0(MS_SDIO)MS-D1(MS-VCC)MS-BSMS-GND

MS-GND

SD-CMDSD-GNDSD-VCCSD-CLKSD-GND

SD-DAT0SD-DAT1

SD-CD GNDSD-CD

SD-WPSD-WPGND

RN3 0x41 23 45 67 8

RN5 0x41 23 45 67 8

R155 10k

R148

10k/NC

RN2 0x41 23 45 67 8

R156 10k

R152 10k

RN4 0x41 23 45 67 8

R157 10k

R146 10

C90

20pF

R153 10k

C87

20pF

R154 10k

R151

10k/NC

C86

10pF/NC

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

SWA SWB

0 1

1 0

SWC

0

0

1 0 0

双连电位器

DVD

EPORT

IPOD

DVD_C

YUV[1..3]

DV33

ASDAT0

DV33

89_AL

89_AR

DVD_ML

DVD_MR

DAVCCDV33

ASDAT[0..3]

IPOD/PI_O_L

IPOD-CVBS

IPOD/PI_O_R

MUTE

IRIN

AUDIO-L

SPK_L

SPK_R

AUDIO-RAUDIO-L

SWBDVD_C

SWC

SWA

DVD_CVBS

DVD-Y

E_CVBS

IPOD-CVBS

SWA

SWB

SWC

IPOD/PI_O_R

E_AU_R

DVD_MR

AV33

AU_L_OUT

SWBAU_L_OUT

SWA

AU_R_OUT

E_AU_L

DVD_ML

A_MUTE

MUTE

A_MUTE

SWA

C-TFT

DV33

YUV1

SWC

VEDIO-TFT

SWCSWB

SWB

YUV3YUV2

DVD-Y DVD_CVBS

WIDE

AVCC5

WIDEBRI

SPK_RSPK_L

BackLight_ENIRINAVCC5C-TFTVEDIO-TFT

BackLight_EN

AU_R_OUT

OPREF

IPOD/PI_O_L

AUDIO-R

AVOUT-R

AVOUT-R

AVOUT-L

AVOUT-L

E_CVBS

E_AU_R

E_AU_L

BRI

AVCC5

VEDIO-OUT

GND

GND

YUV[1..3]2

DV331,2,3,5

ASDAT02,5

GND1,2,3,5,6DV331,2,3,5

89_AL2

89_AR2

ASDAT[0..3]2,5

IPOD/PI_O_L 6

IPOD/PI_O_R 6

IPOD-CVBS 6

MUTE 6

IRIN 6SWA 6

SWB 6

SWC 1,6

A_MUTE 1

GND 1,2,3,5,6

WIDE 6

AVCC5 1

BackLight_EN 6

AUD_GNDVGND

AUD_GND

AUD_GND

AUD_GND

+9VIN

+9VIN

AV33

DAVCC

+9VIN

AUD_GND

+9VIN

+9VIN

AV33

AUD_GND

C80

100P

C79

820P

+

-

U8A

NJM4558-SOP-83

21

84

C5922P

C74

100u

16v

D23

OPEN

12

C562000P

C68100u16v

EC7

10uF/16V-D

C62

100u16v

R144

150,1%

R129

10K

C70

100u16v

R122 75

C65

100u16v

EC1410uF/16V-D

EC20

2.2uF/16V-D

D22

OPEN

12

U7 40661234567 8

91011121314IN1

OUT1IN2OUT2CT2CT3VSS IN3

OUT3IN4

OUT4CT4CT1VDD

C84

100P

L21 FB

R92

10K

R128 1k

U9 405212345678 9

10111213141516Y0

Y2YY3Y1INHVEEVSS B

AX3X0

XX1X2

VDD

R100

1k

C78

100P

EC5 10uF/16V-D

Q23

3904

213Q24

3904

213+ EC16

10uF/16V-D

EC1310uF/16V-D

D21

OPEN

12

CC2

0.1uF

+

C5810uF/16V_SMD

R145150,1%

VER1

earphone

1 2 345

6 78

91011

R142

9K1

R98 220R

R133 10k

2822

1234 5

678

+EC2

10uF/16V_SMD

R124 10k

+EC15

10uF/16V_SMD

R88

75

C64

10u/smtC63

0.1u

R113 1k

R138 10K

C81

100P

+ EC610uF/16V_SMD

R126

4.7

EC17 10uF/16V-D

EC1810uF/16V-D

L23 FB0603/2K2

R132100k

C940.1u

R1011k

R131

10K

R10

9

1k

R10

3

1k

C71

0.1u

C72

10u/smt

EC4

10uF/16V-D

R140

9K1

C75

0.1u

R104 10K

C28

0.1uF

R137

4.7

EC3

10uF/16V-D

R1301k

C50

820pF

R87

10K

L25 1.8uH

R96 100K

C5322p

J7

RCA JACK

4

213

6

54

213

6

5

V1 10K

1234567

R13

510

0k

C67150p

C82

100P

R94

75

+EC27

100uF/16v

C39 0.1u

C49150p

EC1010uF/16V-D

R139

10K

CC1

0.1uF

C76

0.1u

EC8 10uF/16V-D

D19

BAT54S

3

1

2

56K FB0603/2K2

C77

820pF

R97

470

+EC12

47uF/16V

EC19

2.2uF/16V-D

+

C5410uF/16V_SMD

C73

150P

C51

100P

L20 FB

C85

100P

R117 10K

R99

1k

EC9 10uF/16V-D

D25

OPEN

12

VER2

earphone

1 2 345

6 78

91011

C61

0.1u

D20

OPEN

12

D24

OPEN

12

R95

9K1

R90 0

L27 1.8uH

C572000P

R116 10kR1141k

R91 0

R110 1k

R143

150,1%

Q24

39042 13

R112

56k

R89 75

U6 40661234567 8

91011121314IN1

OUT1IN2OUT2CT2CT3VSS IN3

OUT3IN4

OUT4CT4CT1VDD

C83

100P

VR110K

3 1

2

R141

75

C48150p

C55

0.1uF

JJ1

FROM DVD&ATSC/DIP13-2.0

234567

1

89

101112131415

VCCGNDGNDWIDEBRIGND

VCC

YCIR+5VIRINBLIGHT-ENSPRSPLSP-GND

C60

0.1u

R125 75

L18 FB0603/2K2

C52

820P

R123 75

L19 FB0603/2K2

R10851k

R1061k

J6

RCA JACK

4

213

6

54

213

6

5

L26 1.8uH

L17 FB0603/2K2

EC11 10uF/16V-D

C66

0.1u

R120 100K

R93

9K1

56K FB0603/2K2

+

-U8B

NJM4558-SOP-85

67

84

R105 10K

EC24 10uF/16V-D

R119 220R

R111 1k

R121 75

R127 1

EC1 10uF/16V-D

C69

0.1u

C47 1uD12

BAT54S3

1

2

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

DRAM

FLASH

TSOP 48 pin

16Mb

IIC

DRAM

FLASH

MA[0..11]

DQM[0..1]BA[0..1]

A[0..20]

CAS#RAS#

DCLKDCKE

CS#

PCE#

PWR#

DQ2

MA10

DBA0

MA2

MA9

DRAS#DCAS#

DQ13

MA11

SDCLK

MA0

MA4

DQ7

DQ14

MA7

DQ9DQ10

DQ1

DQ8

MA1

MA5

DQ4

DQM0

DQ0

DCS#

DQ3

DQ6

MA6

DBA1

MA3DQ5

DCKE

SDCLK

DRAS#

BA0

DCAS#

DCS#

CAS#

DBA1

CS#

DBA0

RAS#

SDCKE

WE#

BA1

DWE#

A11

A17A18

A8

A16

AD3

AD0

AD6

AD1

A15

A13

A3

AD5

A10

A14

A4

PRD#

AD4

AD2

A9

PWR#

A2

A5A6

A12

A1

A7

PCE#

AA20A20

SCL

SDA

AA20

A0

A19

DQ15

DQ12

DQM1

DQ11

DWE#

SDCKE

MA8

WE#

PRD#

SDA

GNDSCL

DV33

AD[0..7]

DQ[0..15]

SCLSDA

AD7

DV33

GND

DCLK

CAS#2

DCLK2DCKE2

WE#2RAS#2

DQM[0..1]2

MA[0..11]2

CS#2

BA[0..1]2

PCE#2

PWR#2A[0..20]2

PRD#2

SCL2

AD[0..7]2

SDA2

DQ[0..15]2

DV33 1,2,4,5

GND 1,2,4,5,6

SD33

SD33

DV33

DV33

DV33

DV33DV33

DV33SD33

SD33

CB44

1000P

L16 FB

CB51

0.1uF

R79 33

+ CE20

100uF/10v

R81 33

CB41

0.1uF

CB60 0.1uF

CB460.1uF

+ CE19

100uF/10v

CB52

1000P

U3

ESMT M12L64164A-7TTSOP54

1

24

12

57

9

810

46

1113

15

16171819

3522

23242526

14

41

293031323334

36

3738

39

40

43

4244

52

4547

49

48505153

54

2021

3

6

27

28

VCC

DQ0DQ1

VSSQ

DQ2DQ3

VCCQ

DQ4DQ5

VSSQ

DQ6DQ7

DQML

WECASRASCS

A11A10/AP

A0A1A2A3

VCC

VSS

A4A5A6A7A8A9

NC

CKECLK

DQMH

NC

VCCQ

DQ8DQ9

VSSQ

DQ10DQ11

VCCQ

DQ12DQ13DQ14DQ15

VSS

BA0/A13BA1/A12

VCCQ

VSSQ

VCC

VSS

R85 0

CB47

0.1uF

CB38

0.1uF

U4

MX29LV160

2524232221201918

8

10

28

4716

29313335

7

26

384042443032

14

3639414345

37

2711

9

34

46

6

45

321

4817

12

A0A1A2A3A4A5A6A7A8

A20

OE

BYTEA18

D0D1D2D3

A9

CE

D4D5D6D7D8D9

WP/ACC

D11D12D13D14D15

VCC

GND1WE

A19

D10

GND2

A10

A12A11

A13A14A15A16A17

RESET

CB43

1000P

U5

EEPROM 24C04SOP8

1234 5

678NC

NCNCGND SDA

SCLWP

VCC

CB48

0.1uF

RN1

33x4

1 23 45 67 8

CB40

0.1uF

CB45

0.1uF

CB53

0.1uF

R83680

CB49

1000P

CB42

1000P

R86

10k

R80 33

CB50

1000PR84680

R78 33

R82 0

CB39

0.1uF

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

1

B C

HITACHIHOP1200/1200N(1240)

3

VIDEO INTERFACE

4

10

22

CE14,CE15,CE16closed to IC'spin

B

9

PD(Monitor)Vcc

8A

Vcc

1

D

HOP1200/1200N(1240)

2

C

PD

17

3

23

AUDIO INTERFACE

15

C

GND

14

19

1213

E

MEMORY

B

GND

Tr+

VR

Vs(Vc)

24 Tr-

11

3

GND(NC)

3906

Very Important toreduce Noise

FLASH

2

20

18

6

Fo+

LD(CD)

EMI ISSUE VERY IMPORTANT

VRF(1.4V)

21

C

Fo-

E

RS-232

16 LD(DVD)

IIC

5

2SB1132

GND

E

7

F

VR

DQM1A18

FOO

F

AS

DA

T3

HSYNC#

A9

IRDVD

A17

LDO2

PLLVDD3

STBY

RFO

LDO_CD

T+

GND

TRO

IO_19

E

MA7

A

MA5

IRD

VD

TEZISLV

MA6

89_A

R

D

WE#

A12

A5

DCKE

ADIN

SP

DA

TA

ASDAT[0..3]

MA2

89_AL

V1P4

MA0

B

TCK

SL+

PW

R#

LDO33

STBY

SL+

FMO

DMSO

MDI1

LDO2

AVCC2

OPO

RFV

DD

3

DQ

4

AS

DA

T1

AD

4

GPI

O_4

AD

3

SP+

MA4

RAS#

VSYNC#

AD

2

JITF

O

V20 VR

EF

SD

A

FMSO

IOA

SP-

AS

DA

T2

DQ

M0

D

MDI1

B

MA8

MA11

A2

CS#

IO_18

BA1

YUV1

DQ

6

GND

A10

A7

C

VSTB

DACVDD3

DV33

LDO1

V2P8

V1P4

A

SPMCLK

OP-

AD

AC

VD

D

DQ11

IO_1

9VSCK

PWR#PR

D#

AD[0..7]

PCE#

DAC

VDD

3

IO_18

TCK

DQ

14

DQ8

BA0

V1P4

F-

XO

LD-CD

DMO

C

V1P4

JITFN

GPIO_[3..6]

A1 DQ13

XI

V20

ADIN

DQ10

URST#

PRD#

UR

ST#

T+ CS#

DQ[0..15]

AD

5

CAS#

VSCK

JITFO

D

V1P4

T-

OP+

AD

6

HSYNC#

RFO A4

YUV7

RAS#

DQ

2

A[0..20]

SP

MC

LK

XI

F

TxD

DACVDD3

V18

A15

SPP-

WE#

V18

SP-

AVCC2

FMO

ASDAT[0..3]

V1P4

LD-DVD

SDA

F+

XO

FMSO

RFV

DD

3

LDO1

IO_17

YUV2

RFV

18

IRDVD

DQ12

DQ

0

MDI2

AS

DA

T0TRSO

GND

SCL

SC

L

GPI

O_3

RFV33

A13

IOA

RX

D

DQ

7

A3

FS

TRO

RFVDD3

TRSO

A14

FOO

MDI2

MA10

DMSO

VSDA

MA9

SP+

A0

YUV[1..3]

SL-

DACVDD3

LIMIT

AVCC1

A8

VREF

PLLV

DD

3

BA[0..1]

AD

7

SL-

T-

PC

E#

A16

YUV3

DV33

RFV33

OPO

SPDATA

B

LIMIT

A20

V2P8

GND

89_A

L

V20

IO_17

MA3

VSYNC#

C

DCLK

A6

DQ9

MA1

TXD

DQ

1

AP

LLV

DD

3

A19

APLLVDD3

VSDA

GPI

O_5

V1P

4

MVCC

AD

0

RFV18

FOSOVSTB

JITF

N

LIMIT

OP+

E

F+

DQM[0..1]

F-

OP-

DQ

3

RFVDD3

CAS#

DQ

5

FOSO

DCKE

MA[0..11]

A

DMO

RFV

DD

3

DQ

15

FSGPI

O_6

ADACVDD

SPP-

DCLK

YUV7

89_AR

AD

1

A11

RxD

TMS

LDO_DVD

TMS

TRIN

LDO_DVD LDO_CD

VSYNC# 5

AD[0..7] 3

ASDAT[0..3] 5

A[0..20] 3

URST# 1

SCL 3

GND 1,3,4,5,6

SDA 3

DCLK 3

IO_17 5

89_AL 4

BA[0..1] 3

CS# 3

VSDA 6

SPMCLK 5

PRD# 3

ASDAT[0..3] 5

GPIO_[3..6] 5

PWR# 3

DCKE 3

RFV33 1

YUV[1..3] 4

YUV7 5

89_AR 4

VSTB 6

DQ[0..15] 3

VSCK 6

SPDATA 5

DQM[0..1] 3

LDO33 1

IRDVD 6

MVCC 1

DV33 1,3,4,5

RAS# 3

HSYNC# 5

CAS# 3

WE# 3

PCE# 3

MA[0..11] 3

DV33

DV33

V18

V18

DV33RFV33

AUD_GND VGND

MVCC

V18

RFV33

V33

MO_VCC

DV33

DV33

V18

DV33

LDO33

DV33

DV33

V18

V18

MO_VCC

DV33

MO_VCC

DV33

LDO33 LDO33

L13

FB

C152200pF

R50 0

R43

0

CB24

0.1uF

R64 33k

R39

6.8

R57 10

CB21

0.1uF

R41 100kCB110.1uF

R36150k

C1910uF/10v

CB22

0.1uF

CB20

0.1uF

Q25

0pen2

13

JRP2

OPEN

1 2

C44

0.015uF

CB90.1uF

J3

5x1 W/HOUSING

12

+ CE810uF/16v

C23

0.04

7uF

+ C1210uF/16v

L15 FB

CB16

0.1uF

J5

4x1 W/HOUSING

1234

CB14

0.1uF

R46 10k

C45150pF

Pin Assignment v1.5

MT1389HD

U1MT1389HD

2

250

345

1

252

253

6789

1011121314151617181920212223

256

2827

3029

3231

43

2625

33343536

4241

45

3940

46

3837

59

75747271706968

52

91

6263

878664

65 8483828173 93

53545556

80

5758

67 9285

6061

76 78 907966 77 94 95 96 97 98 99 100

101

102

103

104

105

116

106

107

244

245

108

109

110

111

112

122

113

114

115

117

118

120

119

121

123

124

125

126

128

127

129

192191190189188187186185184183182181180179178177176175174173172171170169

167168

166165164163162161160159158

156157

155154153152151150

148149

147146145144143

141142

140139138137136

134135

133132131130

249

255

24

254

231

230

238

237

248

247

236

251

246

243

241

242

240

239

234

235

232

224

225

222

221

220

219

226

218

217

215

213

214

204

211

210

209

208

212

207

206

205

203

202

201

200

199

198

197

196

195

194

193

233

44

4748495051

88 89

216

223

228

229

227

DVDA

CR

TPLP

DVDBDVDCDVDD

AGND

OSP

OSN

DVDRFIPDVDRFINMAMBMCMDSASBSCSDCDFONCDFOPTNITPIMDI1MDI2LDO2LDO1

AVD

D3

V2REFOSGND

VREFOV20

TEOFEO

VPLLVSS

RFLVL/RFONCSO/RFOP

TEZISLVOP_OUTOP_INNOP_INP

FOOTRO

VPLLVDD3

TROPENPWMPWMOUT1/V_ADIN9

USB_VSS

FMODMO

IOA5

IOA

20H

IGH

A1

HIG

HA3

HIG

HA4

HIG

HA5

HIG

HA6

HIG

HA7

TMS/V_ADIN5

A17

HIGHA0IOA18

IOA

21A

D6

IOA19

DVD

D3

AD

4A

D3

AD

2D

VS

S

HIG

HA2

DVD

D18

TCK/V_ADIN6TDO/V_ADIN7DVDD18IOA2

AD

1

IOA3IOA4

A16

IOA

0

AD

5

IOA6IOA7

IOC

S#

IOC

E#

DV

SS

AD

0

IOW

R#

IOA

1

UW

R#

UR

D#

DVD

D3

UP

1_2

UP

1_3

UP

1_4

UP

1_5

UP

1_6

UP

1_7

UP

3_0

UP

3_1

UP

3_4

RD

4

UP

3_5

ICE

ADC

VDD

3A

DC

VS

S

PR

ST#

IR INT0

#D

QM

0IO

_19

RD

15

RD

7R

D6

RD

5

RD

3D

VDD

3

RD

1R

D2

RD

0

RD

14R

D13

RD

12R

D11

RD

9R

D10

RD8

DACVSSCYUV1/Y

DACVDDBYUV2/C

DACVSSBYUV3/CVBS

DACVDDAYUV4/G

DACVSSAYUV5/BYUV6/R

VSYNC/V_ADIN1YUV7

HSYNC/V_ADIN2DVSSIO_17

C0/IO_0C1/IO_1DVDD18C2/IO_2C3/IO_3C4/IO_4DVDD3

C5/IO_5

C7/IO_7C6/IO_6

YUVCLK/IO_8Y0/IO_9

Y1/IO_10Y2/IO_11Y3/IO_12Y4/IO_13DVDD18Y5/IO_14Y6/IO_15

DVDD3Y7/IO_16

RA4RA5RA6RA7RA8RA9

DVSSRA11

CKERCLK

DVDD3RA3RA2

RA1DVDD18

RA0RA10

BA1BA0

RCS#

CAS#RAS#

RWE#DQM1

DVDD3IO_18

HR

FZC

IRE

F

SVDD3

RFG

C

RFG

ND

18AD

ACVD

D2

IDA

CE

XLP

PLL

VS

S

RFR

PA

CR

FRPD

C

JITF

N

RFG

ND

RFV

DD

3

LPFO

P

LPFI

PLP

FIN

LPFO

NP

LLV

DD

3

XTA

LIJI

TFO

RFV

DD

18

AR

/SD

ATA

1A

VC

M

AR

F(S

W)

AD

AC

VS

S1

AD

AC

VS

S2

AP

LLV

SS

AL/

SD

ATA

2

AP

LLC

AP

AP

LLV

DD

3

MC

_DA

TA

DVD

D18

AS

DA

TA4

SP

MC

LK

AC

LKA

BC

KAL

RC

KD

VDD

3

AS

DA

TA3

SP

BC

KS

PLR

CK

SP

DA

TA

AS

DA

TA2/

GP

O_0

AS

DA

TA1/

GP

O_1

GPI

O_3

GPI

O_4

RC

LKB/

GPI

O_5

RVR

EF/G

PIO

_6A

SD

ATA

0/G

PO

_2D

ACVD

DC

VR

EF

FSY

UV

0/C

IN

XTA

LO

CAPPAD

USBPUSBMUSB_VDD3FG/V_ADIN8TDI/V_ADIN4

ALE

AD

7

SP

DIF

AR

S/S

DA

TA3

ALF

/(CTR

)AD

ACVD

D1

ALS

/SD

ATA

0

L7 47uH

R77

0

C36 1uF

J4

4x1 W/HOUSING

1234

CB17

5600pFCB180.1uF

CB13

0.1uF

C4 2200pF

R206

NC

CB23

0.1uF

+ CE1747uF/10v

R63 0

R52 0

R44 1

C30 1uF

CB29

0.1uF

C32 1uF

C1110uF/10v

R33 0

R49 0

R51 10K

C14

0.47

uF/N

C

+ CE101000uF/10v

R73 20k

R76

0

C260.1uF

C43

0.1uF

C42

330pF

CB15

0.1uF

C34 120pF/NC

CB36

0.1uF

C41

330pF

R601

R70 0

CB31

0.1uF

TOP

HA1

HEADER 24 SMD0.5 TOP

123456789101112131415161718192021222324

C13

0.1u

F

TP4

R7210k

Q26

open2

13

L12

10uH

CB8

0.1uF

CB35

0.1uF

+ CE11100uF/6.3v

C33 1uF

C370.1uF

R56 10

R207

NC

R35150k

R34

100k

C400.1uF

CB27

0.1uF

C3 390pF

R66 15k

L9

FB

R74 20k

CB100.1uF

+ CE1647uF/10v

+CE1347uF/6.3v

TP5

TP3

ALR

CK

+

CE9100uF/6.3v

CB25

0.1uF

C29 1uF

C9

0.1u

F

R69 10K

TP1

AB

CK

R581

CB33

0.1uF

C31 1uF

R65 NC

R38

15k

CB30

0.1uF

R45 0

TP2

AC

LK

CB26

0.1uF

TP6

CB32

0.1uF

R591

C8

2200pF

C6

0.1uF

C2433pF

CB28

0.1uF

R62 33k

R54 10

Q20

8550(DIP EBC)

2

13

CB34

0.1uF

Q19

3906

C2533pF

TP7

+ CE1847uF/10v

C27

0.1u

F

R37

680k

R67 0

C38

0.1uF

+ CE15100uF/16v

R31 750k

R71 20k

L8 FB

R32 680k

+CE1247uF/6.3v

C21

0.03

3uF

+CE21

NC

CB12

0.1uF

R55 10

R75

10k

L10FB

C17

0.1u

F

R611

L6 150uH

C16

1000

pF

+CE1447uF/6.3v

C7

0.01uF

CB37

0.1uF

C46150pF

R47

2K

C184.7uF

C10

20pF

R48 10K

C22

0.04

7uF

R68 10k

U2

AT5654

1

910

12

32

15

7

1413

21

1920

24

27

6

45

28

8

111718

16

2322

2526

2930

VINFC

PVCC1PGND

VOSL+

CF2CF1

VOTK+

VNFFC

VOFC+VOFC-

PVCC2

PGNDVNFTK

CTK2

BIAS

VOSL

VINSL+VINSL-

STBY

VCC

VOSL-VOLD+VOLD-

VOTK-

VINLDPREGND

CTK1VINTK

G1G2

C35

0.1uF

+CE22NC

L5

FB

Y1

27MHz

C20

0.1u

F

Q21

8550(DIP EBC)

2

13

L14

10uH

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

RESET Circuit

CHARG

DC UNPLUG:PIN3 CONNECT TO GNDDC PLUG IN:PIN3 NO CONNECT

DISCHARG

POWER OFF

POWER ON

battery charge

ipod charge

URST#

LDO33

DV33

RFV33

URST#

URST#

MVCC

LDO33

MVCC

A_MUTE

MUTE1

RFV33

DV33

IPOD_CHARGE

GND

8.4V_CHARGE

DVDPOWER

A_MUTE

DVDPOWER

ON/OFF

ON/OFF

+9VDCIN

B-CHARG SWC

AVCC5

DC_IN

AVCC5

+9VDCIN

B-CHARG

SWC

B-CHARG

8.4V_CHARGE

URST# 2

RFV33 2

GND 2,3,4,5,6

DV33 2,3,4,5

URST# 2

MVCC 2

LDO33 2

8.4V_CHARGE 6

DVDPOWER 6

A_MUTE 4

SWC 4,6

AVCC5 4

RFV33V33

V33

MVCCV33

LDO33V33

3V3_CPU

+9VIN

V18

+9VIN

3V3_CPU

+9VIN

V33DV33

DC_IN

V33

VGNDAUD_GND

+9VIN

R4

910 1%

D1

15V

12

Q9SI2301

CB

20.

1u

Q5

SI2307

+ CE447uF/6.3v

Q17

3906

2 13

Q18

3906

2 13

R5

10K

R30

10k

R28 22k

R9

0

CB59

0.022uF

PC10

100pF

R27 470

R22

10K

+ EC21100uF/10v

D10

5.6V

12

R25 10k

L3

FB

PR1

24k

+

C2

100uF

CB30.1u

+PC6

470uF/10V

12

D11

3.3V

R88

1k1 1%

Q3

3904

J2 switchpower

1

2

3 4

5

6

D3

SK34

1 2

+ CE710uF/16v

Q11

3904

PC5

0.1uF

L33 22uH

CB70.1uF

R8

22K

R16

10K

R53

22K 1%

Q14

3904

+ CE647uF/6.3v

CB60.1uF

D15

4001SMD

1 2

D5

15V

12

Q6

3904

+PC2

10uF/25V

12

R10

4.7k

+ CE247uF/6.3v

D9

1N4148

D16

4001SMD

1 2

PC9 0.022uF

+ EC26

47uF/6.3v

L2

FB

Q15

3904

R1

10K

Q10SI2307

T1 COMM

12

34

Q13

3904

CB40.1uF

PR3 10K

R99 4K7

PC8

1000pF

R24

10K

R11

1k 1%

CB50.1uF

R17

27k

+ CE147uF/10v

PD1 SK3412

+ PC11

10uF/16v

BATTERY

1 2 3 4

R3

0

D6

15V

12

R2

22k 1%

F1

FUSE

Q2SI2307

D2

SK34

12

R6 4k7

Q4

3904

PC7

1000p

PU1

MP1410ES-SOIC8

1

2

3

4

8

7

6

5

BS

VIN

VSW

GND

SYNC

EN

COMP

FB

R20

47k

PC4

0.1uF

D4

4001

12

L4

FB

PR2

10k

R42

10K

+

C110UF/25V

PL1 22uH

R7

10K

R2310k

J1RCA JACK

1

2

3

+ CE347uF/6.3v

PC3

1000pF

Q7

3904

L1

FB

CB

10.

1u

PC1 0.022uF

8.0 SERVICE PART LIST

Electrical Part List:

No. Service

12NC Service Description Photo Pos.

No.

1 996510001972 MAIN PCBA DCP850/12 100

2 996510001511 IPOD PCBA DCP750 110

3 996510001513 KEY PCBA DCP750 120

4 996510001978

TFT DRIVER PCBA DCP850 (WITH HINGE & HINGE HOUSING, SOLDERING IS REQUIRED TO CONNECT WIRE WITH SPEAKERS ON DISPLAY FRAME, REFER TO SECTION 4 ABOVE)

130

5 996510001593

BATTERY & BATT PCBA DCP750 (SOLDERING IS REQUIRED BETWEEN BATTERY AND BATTERY PCBA)

140

8.0 SERVICE PART LIST

Mechanical Part List:

No. Service 12NC

Service Description

Photo Pos. No.

7 996510001973 8.5” PANEL FINAL ASS’Y

200

8 996510001515 DVD LOADER

210

9 996510001519 FFC 24P LINK DVD LOADER

220

10 996510001974 FRONT CABINET DCP850

300

11 996510001975 BOTTOM CABINET DCP850

310

12 996510001977 DISPLAY FRAME WITH SPEAK

320

13 996510001976

MIDDLE CABINET ASS’Y (WITH OPEN BUTTON, MEUN BUTTON, DVD DOOR, SPRINGS, WIRES, TAPES AND HIDDEN SCREW HOLD)

330

8.0 SERVICE PART LIST

Mechanical Part List:

No. Service

12NC Service Description Photo Pos.

No.

14 996510001518 POWER BUTTON

400

14 996510001596 NAVIGATION BUTTON

410

15 996510001597 SLIDER COVER

420

8.0 SERVICE PART LIST

Accessories Part List:

No. Service

12NC Service Description Photo Pos. No.

996510001509 AC ADAPTOR/12

17

996510004261 AC ADAPTOR/05

ACADAPTOR

18 996510000788 AV CORD

AVCABLE

19 996510001510 CAR ADAPTER

CARADAPTOR

20 996510000790 30GB IPOD HOLDER

HOLDER

21 996510000789 REMOTE CONTROL

RC

9.0 REVISION LIST

Version 1.0 (3141 785 31650)

• Initial release DCP850/12 Version 1.0 (3141 785 31651)

• Update section 8 - Add new AC ADAPTER/05 (996510004261) for DCP850/05