Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College...
-
Upload
kory-dawson -
Category
Documents
-
view
214 -
download
1
Transcript of Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College...
![Page 1: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/1.jpg)
Sensors used in ABS (Anti-Lock Braking System)
Dr. Shahin H. BerishaGateWay Community CollegePhoenix, Arizona, USA
![Page 2: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/2.jpg)
What is ABS?
• ABS provides safety• Prevent the wheels from locking• Maintain directional stability• ABS controls each front brake
separately and the rear brakes as a pair• ABS helps to stop a car in shortest
possible distance without locking the wheel and maintaining directional control (Fig. on page 119)
![Page 3: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/3.jpg)
Basic Operation of ABS
• Four wheel ABS use a speed sensor at each wheel, (slide)
• Signal voltage from these sensors is connected to ECU,
• In rapid braking each sensor detect change in speed and send signal to ABS ECU,
• Based on this information the ABS ECU calculates necessary parameters and then provides optimum braking pressure on each wheel.
![Page 4: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/4.jpg)
Components of ABS System
• Speed Sensors monitor wheel speed,• G - Sensor monitors rate of acceleration,• ABS Actuators control brake system pressure,• Control Relay controls Actuator Pump Motor
and Solenoids,• ABS ECU monitors sensor inputs and controls
the Actuator,• ABS Warning Lamp alerts driver to system
conditions. (Fig. On page 125)
![Page 5: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/5.jpg)
Wheel Speed SensorsBasic Operation
• This sensor is an electromagnet in which a ac voltage is induced into the coil (Figure on page
127),• As the sensor rotor rotates it induces the
voltage in the coil of electromagnet,• As the rotation of the sensor rotor
increases, the magnitude and the frequency of induced voltage increases,
• The induced voltage is information feed into ABS ECU.
![Page 6: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/6.jpg)
Deceleration Sensor
• This sensor measures the car’s rate of deceleration to improve braking performance,
• Deceleration sensor is used on all full-time 4WD• The deceleration sensor senses the vehicle’s
rate of deceleration and sends signal to the ABS ECU.
• The ECU compares the rate of deceleration and vehicle speed to determine the precise road surface condition and takes appropriate control measures.
![Page 7: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/7.jpg)
Deceleration SensorBasic Operation
• The LED’s are On when the ignition switch is ON
• When the vehicle’s rate of deceleration changes, the split plate swings in the vehicle’s rear-to-front direction.
• The slits in the slit plate act to expose the light from the LEDs to the phototransistors.
• This movement of slit plate switches the phototransistors ON and OFF. (Figure on page 128)
![Page 8: Sensors used in ABS (Anti-Lock Braking System) Dr. Shahin H. Berisha GateWay Community College Phoenix, Arizona, USA.](https://reader036.fdocuments.us/reader036/viewer/2022082816/56649d205503460f949f51a5/html5/thumbnails/8.jpg)
Semi-Conductor Deceleration Sensor
• Introduced in 1996 Toyota RAV4• Consist of two semiconductor sensors• Each semiconductor is provided with
a mass which exerts pressure based on the deceleration force applied on the vehicle
• The sensor converts the force into electric signal