Samsung 151s (GH15LS)

TFT-LCD MONITORGH15LSGH15ESGH15MS

ManualSERVICETFT-LCD MONITOR CONTENTS

1. Precautions

2. Product Specifications

3. Disassembly & Reassembly

4. Troubleshooting

5. Exploded View & Parts List

6. Electrical Parts List

7. Block Diagram

8. Wiring Diagram

9. Schematic Diagrams

10. Panel Description

GH15LS/GH15ES

GH15MS

1-1-1 Warnings1. For continued safety, do not attempt to modify the

circuit board.

2. Disconnect the AC power and DC Power Jackbefore servicing.

3. When the chassis is operating, semiconductorheatsinks are potential shock hazards.

1-1-2 Servicing the LCD Monitor1. When servicing the LCD Monitor, remove the static

charge by connecting a 10k ohm resistor in serieswith an insulated wire (such as a test probe)between the chassis and the anode lead.(Disconnect the AC line cord from the AC outlet.)

2. It is essential that service technicians have anaccurate voltage meter available at all times. Checkthe calibration of this meter periodically.

1-1-3 Fire and Shock HazardBefore returning the monitor to the user, perform thefollowing safety checks:

1. Inspect each lead dress to make certain that theleads are not pinched or that hardware is notlodged between the chassis and other metal parts inthe monitor.

2. Inspect all protective devices such as nonmetalliccontrol knobs, insulating materials, cabinet backs,adjustment and compartment covers or shields,isolation resistor-capacitor networks, mechanicalinsulators, etc.

3. Leakage Current Hot Check (Figure 1-1): WARNING:Do not use an isolation transformer during this test.Use a leakage current tester or a metering systemthat complies with American National StandardsInstitute (ANSI C101.1, Leakage Current forAppliances), and Underwriters Laboratories (ULPublication UL1410, 59.7).

Figure 1-1. Leakage Current Test Circuit

4. With the unit completely reassembled, plug the ACline cord directly into a 120V AC outlet. With theunit’s AC switch first in the ON position and thenOFF, measure the current between a known earthground (metal water pipe, conduit, etc.) and allexposed metal parts, including: metal cabinets,screwheads and control shafts. The currentmeasured should not exceed 0.5 milliamp. Reversethe power-plug prongs in the AC outlet and repeatthe test.

1-1-4 Product Safety NoticesSome electrical and mechanical parts have specialsafety-related characteristics which are often notevident from visual inspection. The protection they givemay not be obtained by replacing them withcomponents rated for higher voltage, wattage, etc. Partsthat have special safety characteristics are identified by

on schematics and parts lists. A substitutereplacement that does not have the same safetycharacteristics as the recommended replacement partmight create shock, fire and / or other hazards. Productsafety is under review continuously and newinstructions are issued whenever appropriate.

GH15LS/GH15ES/GH15MS 1-1

1 PrecautionsFollow these safety, servicing and ESD precautions to prevent damage and to protect against potential hazards such aselectrical shock.

1-1 Safety Precautions

DEVICEUNDERTEST

TEST ALLEXPOSED METAL

SURFACES

(READING SHOULDNOT BE ABOVE 0.5mA)

LEAKAGECURRENTTESTER

2-WIRE CORD

ALSO TEST WITHPLUG REVERSED

(USING AC ADAPTERPLUG AS REQUIRED) EARTH

GROUND

!

1-2-1 General Servicing Precautions1. Always unplug the unit’s AC power cord from the

AC power source and disconnect the DC PowerJack before attempting to:(a) remove or reinstall any component or assembly,(b) disconnect PCB plugs or connectors, (c) connecta test component in parallel with an electrolyticcapacitor.

2. Some components are raised above the printedcircuit board for safety. An insulation tube or tapeis sometimes used. The internal wiring issometimes clamped to prevent contact withthermally hot components. Reinstall all suchelements to their original position.

3. After servicing, always check that the screws,components and wiring have been correctlyreinstalled. Make sure that the area around theserviced part has not been damaged.

1. Immediately before handling any semiconductorcomponents or assemblies, drain the electrostaticcharge from your body by touching a known earthground. Alternatively, wear a discharging wrist-strap device. To avoid a shock hazard, be sure toremove the wrist strap before applying power tothe monitor.

2. After removing an ESD-equipped assembly, place iton a conductive surface such as aluminum foil toprevent accumulation of an electrostatic charge.

3. Do not use freon-propelled chemicals. These cangenerate electrical charges sufficient to damageESDs.

4. Use only a grounded-tip soldering iron to solder ordesolder ESDs.

5. Use only an anti-static solder removal device. Somesolder removal devices not classified as “anti-static”can generate electrical charges sufficient to damageESDs.

4. Check the insulation between the blades of the ACplug and accessible conductive parts (examples:metal panels, input terminals and earphone jacks).

5. Insulation Checking Procedure: Disconnect thepower cord from the AC source and turn the powerswitch ON. Connect an insulation resistance meter(500 V) to the blades of the AC plug.

The insulation resistance between each blade of theAC plug and accessible conductive parts (seeabove) should be greater than 1 megohm.

6. Always connect a test instrument’s ground lead tothe instrument chassis ground before connectingthe positive lead; always remove the instrument’sground lead last.

6. Do not remove a replacement ESD from itsprotective package until you are ready to install it.Most replacement ESDs are packaged with leadsthat are electrically shorted together by conductivefoam, aluminum foil or other conductive materials.

7. Immediately before removing the protectivematerial from the leads of a replacement ESD,touch the protective material to the chassis orcircuit assembly into which the device will beinstalled.

Caution: Be sure no power is applied to the chassis or circuit and observe all other safety precautions.

8. Minimize body motions when handlingunpackaged replacement ESDs. Motions such asbrushing clothes together, or lifting your foot froma carpeted floor can generate enough staticelectricity to damage an ESD.

1 Precautions

1-2 GH15LS/GH15ES/GH15MS

1-3 Electrostatically Sensitive Devices (ESD) Precautions

Some semiconductor (solid state) devices can be easily damaged by static electricity. Such components are commonlycalled Electrostatically Sensitive Devices (ESD). Examples of typical ESD devices are integrated circuits and some field-effect transistors. The following techniques will reduce the incidence of component damage caused by static electricity.

1-2 Servicing Precautions

WARNING: An electrolytic capacitor installed with the wrong polarity might explode.

Caution: Before servicing units covered by this service manual, read and follow the Safety Precautionssection of this manual.

Note: If unforeseen circumstances create conflict between the following servicing precautions and any of thesafety precautions, always follow the safety precautions.

2 Product Specifications

2-1 Specifications

LCD Panel TFT-LCD panel, RGB vertical stripe, normaly white, 15-Inch viewable, 0.297 (H) pixel pitch

Scanning Frequency Horizontal : 30 kHz ~ 61 kHz (Referring ~ Timing chart, Page 2-3, 2-4)Vertical : 50 Hz ~ 75 Hz (Referring ~ Timing chart, Page 2-3, 2-4)

Display Colors 16,003,008 colors

Maximum Resolution Horizontal : 1024 Pixels Vertical : 768 Pixels

Input Video Signal Analog, 0.714 Vp-p ± 5% positive at 75 Ω, internally terminated

Input Sync Signal Type: Seperate H/V sync, Composite H/V, Sync-on-Green, automatic synchronization without external switch of sync type

Level: TTL level

Maximum Pixel Clock rate 80 MHz

Active Display Horizontal/Vertical 304.1 mm / 228.1 mm

AC power voltage & Frequency AC 90 ~ 264 Volts, 60/50 Hz ~ 12V/3A

Power Consumption 25 W (normal)

Dimensions Unit (W x D x H)With Simple Stand 15.4 x 15.1 x 6.8 Inches (391.4 x 383.6 x 173 mm) 16.5 x 15.2 x 6.8 Inches (417.9 x 386.1 x 173 mm)Without Simple stand 15.4 x 11.5 x 2.5 Inches (391.4 x 292.8 x 64.0 mm) 16.5 x 11.7 x 2.5 Inches (417.9 x 297.9 x 64.2 mm)With Pivot Stand 15.4 x 15.1 x 6.8 Inches (391.4 x 383.6 x 173 mm) 16.5 x 15.2 x 6.8 Inches (417.9 x 386.1 x 173 mm)

15.4 x 17.1 x 6.8 Inches (391.4 x 433.6 x 173 mm) 16.5 x 17.2 x 6.8 Inches (417.9 x 436.1 x 173 mm)Without Pivot Stand 15.4 x 11.5 x 2.5 Inches (391.4 x 292.8 x 64.0 mm) 16.5 x 11.7 x 2.5 Inches (417.9 x 297.9 x 64.2 mm)

Weight (Net/Gross) 4.2 kg (9.3 lbs) / 5.2 kg (11.5 lbs) 4.3 kg (9.5 lbs) / 5.5 kg (12.1 lbs)

Environmental Considerations Operating Temperature : 50 °F ~ 104 °F (10 °C ~ 40 °C)Humidity : 10 % ~ 80 %Storage Temperature : 13 °F ~ 113 °F (-25 °C ~ 45 °C)Humidity : 5 % ~ 95 %

Audio Characteristics (GH15MS) • Built-in Microphone: High-sensitivity condenser microphone (mono)• Audio input: Left/Right Stereo phone jack, 0.5 Vrms• Sound output: 1.0 W (left) + 1.0 W (right)/THD 1% at 8ohm• Frequency response: 80 Hz~20 kHz (at –3dB)• Headphone: Max 50mW output (3.5-pi jack)• Speaker: Internal semi Dome (16ohm x 2)

•GH15LS/GH15ES/GH15MS complies with SWEDAC (MPR II) recommendations for reducedelectromagnetic fields.

•Designs and specifications are subject to change without prior notice.


ItemDescription

GH15LS/GH15ES GH15MS



2-2 Pin Assignments

SyncType

Pin No.

15-Pin Signal Cable Connector

Separate Composite Sync-on-green

123456789

101112131415

RedGreenBlueGNDGND (DDC Return)GND-RGND-GGND-BNo ConnectionGND-Sync./Self TestGNDDDC DataH-Sync.V-Sync.DDC Clock

RedGreenBlueGNDGND (DDC Return)GND-RGND-GGND-BNo ConnectionGND-Sync./Self TestGNDDDC DataH/V-Sync.Not UsedDDC Clock

RedGreen + H/V Sync.BlueGNDGND (DDC Return)GND-RGND-GGND-BNot UsedGND-Sync./Self TestGNDDDC DataNot UsedNot UsedDDC Clock

31.469

31.778

3.813

1.589

26.058

0.318

70.086

14.268

0.064

1.716

11.504

0.985

25.175

Positive

Negative

Separate

fH (kHz)

A µsec

B µsec

C µsec

D µsec

E µsec

fV (Hz)

O msec

P msec

Q msec

R msec

S msec

ClockFrequency(MHz)

PolarityH.Sync

V.Sync

Remark

IBM



Q R S

P

O

Video

Sync Sync

Horizontal Vertical

C D E

P

O

B

A

Video

Sync Sync

Separate Sync

2-3 Timing Chart

This section of the service manual describes the timing that the computer industry recognizes as standardfor computer-generated video signals.

C D

A O

E

B P

Video

Sync Sync

Video

Q R S

A : Line time total B : Horizontal sync width O : Frame time total P : Vertical sync width

C : Back porch D : Active time Q : Back porch R : Active time

E : Front porch S : Front porch

VGA3/60 Hz640 x 480

640/72 Hz640 x 480

640/75 Hz640 x 480

800/56 Hz800 x 600

800/60 Hz800 x 600

VGA1/70 Hz640 x 350

VGA2/70 Hz720 x 400

Table 2-1. Timing Chart

31.469

31.777

3.813

1.589

26.058

0.318

70.087

14.268

0.064

0.858

13.155

0.191

28.322

Negative

Positive

Separate

31.469

31.778

3.813

1.589

26.058

0.318

59.940

16.683

0.064

0.794

15.761

0.064

25.175

Negative

Negative

Separate

37.861

26.413

1.270

3.810

20.825

0.508

72.809

13.735

0.079

0.528

13.100

0.026

31.500

Negative

Negative

Separate

37.500

26.667

2.032

3.810

20.317

0.508

75.000

13.333

0.080

0.427

12.800

0.027

31.500

Negative

Negative

Separate

35.156

28.444

2.000

3.556

22.222

0.667

56.250

17.778

0.057

0.626

17.067

0.028

36.000

Positive

Negative

Separate

37.879

26.400

3.200

2.200

20.000

1.000

60.317

16.579

0.106

0.607

15.840

0.026

40.000

Positive

Positive

Separate

Mode VESA

Timing



fH (kHz)

A µsec

B µsec

C µsec

D µsec

E µsec

fV (Hz)

O msec

P msec

Q msec

R msec

S msec

ClockFrequency(MHz)

PolarityH.Sync

V.Sync

Remark

VESA

800/72 Hz800 x 600

800/75 Hz800 x 600

640/67 Hz640 x 480

832/75 Hz832 x 624

Table 2-1. Timing Chart (Continued)

48.077

20.800

2.400

1.280

16.000

1.120

72.188

13.853

0.125

0.478

12.480

0.770

50.000

Positive

Positive

Separate

46.875

21.333

1.616

3.232

16.162

0.323

75.000

13.333

0.064

0.448

12.800

0.021

49.500

Positive

Positive

Separate

35.000

28.571

2.116

3.175

21.164

2.116

66.667

15.000

0.086

1.114

13.714

0.086

30.240

Negative

Negative

Separate

49.726

20.110

1.117

3.910

14.524

0.559

74.551

13.414

0.060

0.784

12.549

0.020

57.284

Negative

Negative

Separate

Mode MAC.

Timing

Q R S

P

O

Video

Sync Sync

Horizontal Vertical

C D E

P

O

B

A

Video

Sync Sync

Separate Sync

C D

A O

E

B P

Video

Sync Sync

Video

Q R S

A : Line time total B : Horizontal sync width O : Frame time total P : Vertical sync width

C : Back porch D : Active time Q : Back porch R : Active time

E : Front porch S : Front porch

1024/70Hz1024x768

56.476

17.707

1.813

1.920

13.653

0.320

70.069

14.272

0.106

0.513

13.599

0.053

75.000

Negative

Negative

Separate

1024/75Hz1024x768

60.023

16.660

1.219

2.235

13.003

0.203

75.029

13.328

0.050

0.466

12.795

0.017

78.750

Positive

Positive

Separate

1024/60Hz1024x768

48.363

20.677

2.092

2.462

15.754

0.369

60.004

16.666

0.124

0.600

15.880

0.062

65.000

Negative

Negative

Separate

3-1-1 Removing the Stand

1. Remove 4 screws in the hinge area.2. Disconnect Power Cord and Signal Cable.3. Pry it off the back of the monitor.

3-1-2 Main Body Disassembly

1. Remove 2 screws on the two corner of theRear Cover.

2. Remove Rear Cover from the Front Cover.3. Remove 4 screws on the Shield and remove

the shield. 4. Disconnect Inverter wire, Function PCB wire

and Interface wire.Remove 3 screws on the Main PCB andremove 2 screws on the D sub shield.

5. Remove 3 screws on the power PCB andremove 2 screws on the Inverter PCB.

6. Remove the Main PCB Assembly.7. Remove 3 screws on the Function PCB from

locking area of Function knob and removeFunction PCB.

3-1-3 Standard Stand Disassembly1. Remove 2 screws from the Stand front.2. Remove 7 screws from the Stand Bottom.3. Remove Stand Rear from the Stand assembly.4. Remove 5 screws from the Stand assembly.5. Remove the Neck front from the Stand

assembly.6. Remove 2 screws from the Stand assembly.7. Remove Neck Rear from the Stand assembly.8. Remove 4 screws from the Stand assembly.


3 Disassembly and ReassemblyThis section of the service manual describes the disassembly and reassembly procedures for theGH15LS/GH15ES/GH15MS monitor.

WARNING: This monitor contains electrostatically sensitive devices. Use with caution when

handling these components.

3-1 Disassembly

Cautions:1. Disconnect the monitor from the power source before disassembly.2. Follow these directions carefully; never use metal instruments to pry apart the cabinet.


4 Troubleshooting

Notes: 1. Before troubleshooting, setup the PC’s display as below.• Resolution: 1024 x 768• H-frequency: 48 kHz• V-frequency: 60 Hz

2. If no picture appears, make sure the power cord is correctly connected.3. Check the following circuits.

• No raster appears: Audio PCB, SMPS PCB, Main PCB• 12V develop but no screen: Main PCB• 12V does not develop: Audio PCB, SMPS PCB

4. If you push and hold the “EXIT” button for more than 5 seconds, the monitor automatically turns backto the factory preset.

4-1 No Power (GH15LS/GH15ES/GH15MS)

Does proper DC 12 V appear at FT901, FT902 or Pin 1, 2 of CN101?

Check SMPS or CN101.

Yes

No

Does proper DC 3.3 V appear at Pin 7 of CN 101? Check SMPS.

Check IC102 and Q192.

Yes

No

4 Troubleshooting


Check CN102.NoDoes the H-sync pulse

appear at Pin 9 of IC108?

Replace IC108 or check its related circuit.

check CN102.No

Does the H-sync pulseappear at Pin 150 of IC105?

Yes

Yes

No4

Does the V-sync pulse appeaer at Pin 30 of IC301?

2


No

Yes

Does the V-sync pulse appeaer at Pin 148 of IC105?

3


No

Yes

No

Yes


No

Yes

Replace LCD Panel

Yes

1

4-2 No Video

Does the clock pulseappeaer at Pin 44 of IC105?

5

Do the pulse appeaer at Pin 43 of IC105?

6

Does the waveforms appeaer at Pin 3

and 16 of CN201?7

4 Troubleshooting


1 5

6

7

2

3

4

WAVEFORMS

WAVEFORMS

4 Troubleshooting


4-3 User Controls Don’t Work

NoDoes the DC level change atPin 35 and 36 of IC301 when you

push the front panel button?

Check the buttons.(SW801~SW808)

Yes

Refer to 4-4 No OSD Display.

4-4 No OSD

There is video but no OSD.

While pushing a front control button doesany pulse appear at Pin 46,47

and 55, 56 and 63,64 of IC105?5

NoDo sync signals appear at Pin 44,

150 and 43 of IC105?

1

Replace IC105.

3

Yes

Replace IC105 or check itsrelated circuit.


2

Replace CN251.

Replace IC251 and IC252.

Yes

No

5

4 Troubleshooting


4-5 No SOUND (GH15MS)

NoDoes the DC 12V appear at Pin 15, 16 of IC401 and

Pin 5, 6, 7, 8 of Q403?Check Q403, Q401 and related circuit.

Yes

Check CN402 outputs.

NoDoes the sound signal appear atPin 14 and 17 of IC401? Check IC401 and related circuit.

Yes

NoDoes the sound input signalappear at Pin 4 and 9 of IC401?

Check CN401and related circuit.

Yes


4 Troubleshooting

4-6 Microphones Don’t Work

NoDoes the PC’s soundprogram operate well?

Check the PC’s sound programand compatibility.

Yes

OK

NoDoes the External Microphonework? Check the CN803 jack.

Yes

NoIs the connection between the PCand monitor secure?

Connect the cable between the PCand monitor.

Yes

OK

NoCan you hear any sound fromthe Headphones?

Check CN802 on the Audio PCBand related circuit D805, D806,

R811, and R812.

Yes

NoIs the Internal Microphoneconnector attached?

Check the connection betweenCN808 on the Audio PCB and the

Internal Microphone.

Yes

NoDoes the Internal Microphonework? Check Q801 and related circuits.

Yes

4-7 Headphones Don’t Work

GH15LS/GH15ES/GH15MS

Loc. No. Code No. Description Specification Remarks

6-1

CIS BN44-00053A ADAPTOR DPA30L,150S,100-240VAC,47 - 63 HZ,12VDC/3.3VDC,2A/2A,-,30.6,AC-DC,-10~40C,-,-CIS BN72-00209A SUPPORT-POWER GH15LS,ABS+PC,GR37,-,5V,-,-,- SNACIS BN75-00176A UNIT-SHIELD/DSUB GH15LS,-,SPTE T0.5,-,-,-,- SNACIS BN70-00204A SHIELD-D/SUB -,SPTE,-,T0.5,-,-,-,-,- SNACIS BN71-00024A EARTH-PLATE GH17LS,SUS,T0.15,-,-,- SNACN101 3711-004853 CONNECTOR-HEADER BOX,7P,1R,2MM,ANGLE,SN,WHT SNACN102 3701-001219 CONNECTOR-DSUB 15P,3R,FEMALE,ANGLE,AUFIC301 0903-001194 IC-MICROCONTROLLER 3P863,8Bit,SDIP,42P,600MIL,12MHz,ST,CMOS,PLASTIC,5V,-,-40to+85C,1040BYTE,48KBYTE SNAIC301_SOCK 3704-001071 SOCKET-IC 42P,DIP,SN,1.778mmCIS BN46-00008L MICOM-S/W,GOGH GH15LS,-,-,-,-,-,- SNABD181 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD182 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD183 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD201 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD205 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD206 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD301 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD302 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD303 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmBD304 2703-001334 INDUCTOR-SMD 1.5uH,10%,2x1.25x0.85mmC101 2402-000170 C-AL,SMD 1uF,20%,50V,GP,TP,4.3x4.3x5.4,C102 2402-001044 C-AL,SMD 100uF,20%,25V,-,TP,8.3x8.3x6.3C103 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C104 2402-000168 C-AL,SMD 100uF,20%,16V,GP,TP,8.3x8.3x6.3mmC105 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C106 2402-000170 C-AL,SMD 1uF,20%,50V,GP,TP,4.3x4.3x5.4,C112 2409-001029 C-ORGANIC 120uF,20%,6.3V,WT,TP,10.3x10.3x10.3mm,9C131 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C132 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C133 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C134 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C135 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C136 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C137 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C138 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C139 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C140 2402-000168 C-AL,SMD 100uF,20%,16V,GP,TP,8.3x8.3x6.3mmC141 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C142 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C143 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C144 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C145 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C146 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C147 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C148 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C149 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C150 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C151 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C152 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C153 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C154 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C155 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C156 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C157 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C159 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C160 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C161 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C162 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C163 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C164 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C165 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4

6 Electrical Parts List6-1 Main PCB Parts

C166 2203-000280 C-CERAMIC,CHIP 0.01nF,0.5pF,50V,NP0,TP,1608C167 2203-000626 C-CERAMIC,CHIP 0.022nF,5%,50V,NP0,TP,1608C168 2203-000236 C-CERAMIC,CHIP 0.1nF,5%,50V,NP0,TP,1608C169 2203-000236 C-CERAMIC,CHIP 0.1nF,5%,50V,NP0,TP,1608C170 2203-000384 C-CERAMIC,CHIP 0.015nF,5%,50V,NP0,TP,1608C171 2203-000384 C-CERAMIC,CHIP 0.015nF,5%,50V,NP0,TP,1608C172 2203-000384 C-CERAMIC,CHIP 0.015nF,5%,50V,NP0,TP,1608C173 2203-000280 C-CERAMIC,CHIP 0.01nF,0.5pF,50V,NP0,TP,1608C187 2402-000170 C-AL,SMD 1uF,20%,50V,GP,TP,4.3x4.3x5.4,C188 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C189 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C211 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C215 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C216 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C217 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C223 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C227 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C228 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C229 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C230 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C232 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C301 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C302 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C303 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C304 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C311 2203-000626 C-CERAMIC,CHIP 0.022nF,5%,50V,NP0,TP,1608C312 2203-000626 C-CERAMIC,CHIP 0.022nF,5%,50V,NP0,TP,1608C313 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C371 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C372 2203-005005 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608C373 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C374 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608C375 2203-000236 C-CERAMIC,CHIP 0.1nF,5%,50V,NP0,TP,1608CN201 3711-003161 CONNECTOR-HEADER BOX,20P,1R,1.25mm,ANGLE,SN SNACN301 3711-000556 CONNECTOR-HEADER BOX,12P,1R,1.25mm,SMD-A,SN SNACN302 3711-002049 CONNECTOR-HEADER BOX,6P,1R,1.25mm,SMD-A,SN SNAD131 0401-001056 DIODE-SWITCHING MMBD4148SE,75V,200MA,SOT-23,TPD132 0401-001056 DIODE-SWITCHING MMBD4148SE,75V,200MA,SOT-23,TPD133 0401-001056 DIODE-SWITCHING MMBD4148SE,75V,200MA,SOT-23,TPD301 0401-001056 DIODE-SWITCHING MMBD4148SE,75V,200MA,SOT-23,TPD302 0401-001056 DIODE-SWITCHING MMBD4148SE,75V,200MA,SOT-23,TPFT110 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT111 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT112 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT113 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT114 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT901 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT902 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT903 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT904 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT905 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAFT906 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- SNAIC102 1203-001488 IC-POSI.FIXED REG. 7805,T0-252,3P,-,PLASTIC,4.8/5IC105 1003-001377 IC-LCD CONTROLLER GMZAN1,QFP,160P,1102MIL,SINGLE,-,TR,PLASTIC,3.47V,0TO+70C,1.8W,-,LCD CONTROLLERIC108 0803-000122 IC-TTL 74F125,BUFFER,SOP,14P,150MIL,QIC251 1205-001740 IC-TRANSMITTER DS90C385,TSSOP,56P,240MIL,PLASTIC,4V,1.63W,-10 TO +70C,ST,FPD LINK-85MHZ(LVDS)IC371 1103-001023 IC-EEPROM 524C80D81,1028x8Bit,SOP,8P,150MIL,10mS,5V,10%,PLASTIC,0to+70C,110uA,CMOS,TPIC372 1103-001164 IC-EEPROM 24LC21A,128X8BIT,SOP,8P,150MIL,-,5V,10%,PLASTIC,0 TO +70C,100UA,CMOS,TPMP1.0 BN41-00088A PCB MAIN GH15L/M,FR-4,4,-,1.6,120*110*1.6,-,-,-,- SNAQ102 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270Q103 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270

6 Electrical Parts List





Q104 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270Q105 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270Q106 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270Q107 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270Q311 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270Q312 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SC-59,TP,120-270R102 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R104 2007-000102 R-CHIP 100Kohm,5%,1/16W,DA,TP,1608R106 2007-000102 R-CHIP 100Kohm,5%,1/16W,DA,TP,1608R107 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R108 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R109 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R110 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R113 2007-001167 R-CHIP 75ohm,5%,1/16W,DA,TP,1608R114 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R115 2007-001167 R-CHIP 75ohm,5%,1/16W,DA,TP,1608R117 2007-000072 R-CHIP 47ohm,5%,1/16W,DA,TP,1608R118 2007-000072 R-CHIP 47ohm,5%,1/16W,DA,TP,1608R119 2007-000072 R-CHIP 47ohm,5%,1/16W,DA,TP,1608R120 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R121 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R122 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R123 2007-001167 R-CHIP 75ohm,5%,1/16W,DA,TP,1608R124 2007-001167 R-CHIP 75ohm,5%,1/16W,DA,TP,1608R125 2007-001167 R-CHIP 75ohm,5%,1/16W,DA,TP,1608R185 2007-000102 R-CHIP 100Kohm,5%,1/16W,DA,TP,1608R186 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R187 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R188 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R189 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R190 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R203 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R204 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R205 2007-000070 R-CHIP 0ohm,5%,1/16W,DA,TP,1608R207 2007-000070 R-CHIP 0ohm,5%,1/16W,DA,TP,1608R301 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R314 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R316 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R317 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R320 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R321 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R322 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R323 2007-000109 R-CHIP 1Mohm,5%,1/16W,DA,TP,1608R324 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R325 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R326 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R327 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R329 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R330 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R334 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R335 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R336 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R337 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R338 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R339 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R340 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R341 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R343 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R344 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R345 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R346 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608


R347 2007-000084 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608R348 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R349 2007-000075 R-CHIP 220ohm,5%,1/16W,DA,TP,1608R350 2007-000077 R-CHIP 470ohm,5%,1/16W,DA,TP,1608R351 2007-000120 R-CHIP 680ohm,5%,1/16W,DA,TP,1608R362 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R371 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R372 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R373 2007-000092 R-CHIP 15Kohm,5%,1/16W,DA,TP,1608R374 2007-000092 R-CHIP 15Kohm,5%,1/16W,DA,TP,1608R375 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R376 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R377 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R378 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R381 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R901 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R902 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R903 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R904 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R905 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R910 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R911 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R912 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R913 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R918 2007-000092 R-CHIP 15Kohm,5%,1/16W,DA,TP,1608R919 2007-000070 R-CHIP 0ohm,5%,1/16W,DA,TP,1608R973 2007-000075 R-CHIP 220ohm,5%,1/16W,DA,TP,1608R974 2007-000120 R-CHIP 680ohm,5%,1/16W,DA,TP,1608R975 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608R976 2007-000090 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608RA130 2011-000002 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TPRA131 2011-000002 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TPRA132 2011-000002 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TPRA133 2011-000002 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TPRA134 2011-000002 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TPRA136 2011-000002 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TPRA137 2011-000002 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TPRC201 2503-001018 C-NETWORK 15PFX4,10%,50V,-RC202 2503-001018 C-NETWORK 15PFX4,10%,50V,-RC203 2503-001018 C-NETWORK 15PFX4,10%,50V,-RC204 2503-001018 C-NETWORK 15PFX4,10%,50V,-RC205 2503-001018 C-NETWORK 15PFX4,10%,50V,-RC206 2503-001018 C-NETWORK 15PFX4,10%,50V,-RC207 2503-001018 C-NETWORK 15PFX4,10%,50V,-X100 2801-003755 CRYSTAL-SMD 20MHZ,30PPM,28-AAN,20PF,50OHM,TPX311 2801-003773 CRYSTAL-SMD 12MHZ,30PPM,28-AAN,20PF,50OHM,TPZD181 0403-000579 DIODE-ZENER BZX84C5V1,5.1V,5%,200mW,SOT-23ZD182 0403-000579 DIODE-ZENER BZX84C5V1,5.1V,5%,200mW,SOT-23ZD183 0403-000579 DIODE-ZENER BZX84C5V1,5.1V,5%,200mW,SOT-23ZD184 0403-000579 DIODE-ZENER BZX84C5V1,5.1V,5%,200mW,SOT-23ZD185 0403-000579 DIODE-ZENER BZX84C5V1,5.1V,5%,200mW,SOT-23






- BN95-00225A ASSY MANUAL GH15LS,-,-,- GH15LS- BN95-00234A ASSY MANUAL GH15MS,-,-,- GH5MS

BN95-00254A ASSY MANUAL GH15ES,-,-,- GH15ES

CIS BN07-00026A LCD LTM150XH-L01,CZB,8BIT,331.6*254.76*12.5,16.19M,-,0.297*0.297,-,-,AMLCD/1 LVDS,- GH15LS/ES/MSCIS BN44-00056A INVERTER GOGH,SIC1542,48KHZ,12VDC,1.5MARMS,5.6MARMS,48KHZ,37*140*16.0,4LAMP,40~56KV,-,SIC GH15LS/ES/MSCIS BN44-00053A ADAPTOR DPA30L,150S,100-240VAC,47 - 63 HZ,12VDC/3.3VDC,2A/2A,-,30.6,AC-DC,-10~40C,-,- GH15LS/ES/MSM/PCB+PAN BN39-00036A CBF-HARNESS 20P,150MM,BLU/GRY/WHT,UL1571,AWG30,DF14-20S-1.25C GH15LS/ES/MSIN/PCB+M/PCB BN39-00161A CBF HARNESS GH15LS,UL/CSA,UL1061#28,12P/12P,160MM,WHT,AWG28,51021-1200,51021-1200,-,-,1.25MM GH15LS/ES/MSCIS BN39-00114A CBF SIGNAL NL15MO,15P/15P,2990,1830MM,UL2990,IVORY,D-SUB/MALE,-,-,- GH15LS/ES/MS- BN59-00167A PBA SUB-FUNCTION GH15MS,GH15_FUNCTION,-,-,-,-,- GH15LS/ES/MS

- BN59-00168A PBA SUB-PHONE GH15MS,GH15_PHONE,-,-,-,-,- GH15MSCIS BN59-00169A SPEAKER SYSTEM GH15MS,-,-,-,-,-,-,-,RIGHT GH15MSCIS BN59-00169B SPEAKER SYSTEM GH15MS,-,-,-,-,-,-,-,LEFT GH15MS


6-2 Others

6-3-1 Different Part List (GH15ES)

C190 2203-000236 C-CERAMIC,CHIP 100pF,5%,50V,NPO,TP,1608,-C191 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C192 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608,-C193 2203-005005 C-CERAMIC,CHIP 100nF,15%,16V,W5R,TP,1608,1.6mC194 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608,-IC109 1204-000292 IC-VIDEO SYSTEM IC-VIDEO,LM1881M,SOP,8P,150MILR192 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R193 2007-001114 R-CHIP 680Kohm,5%,1/16W,DA,TP,1608R195 2007-000076 R-CHIP 330ohm,5%,1/16W,DA,TP,1608

Location Code Spec. Desc.



6-3-2 Different Part List (GH15MS)

C190 2203-000236 C-CERAMIC,CHIP 100pF,5%,50V,NPO,TP,1608,-C191 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C192 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608,-C193 2203-005005 C-CERAMIC,CHIP 100nF,15%,16V,W5R,TP,1608,1.6mC194 2203-000257 C-CERAMIC,CHIP 10nF,10%,50V,X7R,TP,1608,-C401 2203-005015 C-CERAMIC,CHIP 150nF,+80-20%,16V,Y5V,TP,1608C402 2203-005015 C-CERAMIC,CHIP 150nF,+80-20%,16V,Y5V,TP,1608C403 2203-000236 C-CERAMIC,CHIP 100pF,5%,50V,NPO,TP,1608,-C404 2203-000236 C-CERAMIC,CHIP 100pF,5%,50V,NPO,TP,1608,-C405 2402-000168 C-AL,SMD 100uF,20%,16V,-,8.3x8.3x6.2mm,C406 2402-000108 C-AL,SMD 10uF,20%,16V,WT,TP,4.3x4.3x5.4C407 2203-005005 C-CERAMIC,CHIP 100nF,15%,16V,W5R,TP,1608,1.6mC408 2203-005005 C-CERAMIC,CHIP 100nF,15%,16V,W5R,TP,1608,1.6mC409 2402-000168 C-AL,SMD 100uF,20%,16V,-,8.3x8.3x6.2mm,C410 2401-001363 C-AL 470uF,20%,16V,GP,10x12.5mm,5mmC412 2401-001363 C-AL 470uF,20%,16V,GP,10x12.5mm,5mmC416 2402-000179 C-AL,SMD 47uF,20%,16V,GP,TP,6.3x5.4C420 2402-000147 C-AL,SMD 33uF,20%,25V,-,TP,6.3x5.2,-CN401 3711-004270 CONNECTOR-HEADER BOX,2P,1R,2MM,ANGLE,SNCN402 3711-004386 CONNECTOR-HEADER BOX,3P,1R,2mm,ANGLE,SNFT401 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,-FT402 3301-001145 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,-IC109 1204-000292 IC-VIDEO SYSTEM IC-VIDEO,LM1881M,SOP,8P,150MILIC401 1204-001833 IC-VOLUME CONTROL TDA7496L,DIP,20P,-,PLASTIC,26VQ401 0501-002080 TR-SMALL SIGNAL 2SC2412K,NPN,200mW,SOT-23,TP,1Q403 0505-000275 FET-SILICON SI4435DY,P,-30V,+-8.0A,0.02ohmR192 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R193 2007-001114 R-CHIP 680Kohm,5%,1/16W,DA,TP,1608R195 2007-000076 R-CHIP 330ohm,5%,1/16W,DA,TP,1608R361 2007-000090 R-CHIP 10Kohm,5%,1/16W,DA,TP,1608R380 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R401 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R402 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R403 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R404 2007-000074 R-CHIP 100ohm,5%,1/16W,DA,TP,1608R405 2007-000078 R-CHIP 1Kohm,5%,1/16W,DA,TP,1608R406 2007-000090 R-CHIP 10Kohm,5%,1/16W,DA,TP,1608R412 2007-000102 R-CHIP 100Kohm,5%,1/16W,DA,TP,1608R413 2007-000102 R-CHIP 100Kohm,5%,1/16W,DA,TP,1608R414 2007-000090 R-CHIP 10Kohm,5%,1/16W,DA,TP,1608ZD401 0403-001052 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,SZD402 0403-001052 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S

Location Code Spec. Desc.


7 Block Diagram


8 Wiring Diagram


9 Schematic Diagrams

9-1 Main Part Schematic diagram (GH15LS/GH15ES/GH15MS)

For Japanese OSD

(Hsync)

(Vsync)

R

OSD_IC

OSD S/W

OSD_CLK

G

B

SDA

SCL

U211

TP86

1

120uFC112

6.3V

16V100nF

C146

R107

R113 75

+12V_INV

10K

100

R321 100

R334

1VCC

+3.3V_IN

C170

15pF50VMO

1/16W680

R974

TP904

TP3321

220R973

1/16W

TP945

1

TP333

1

1

100R335

1

TP941

1

TP943

100R329

TP939

5D1D2 6

7D3D4 84 G1

S11

2 S2S33

100

Q191SI4435DY

100R326

R327

100R322

C31222pF50VMO

R323

MO50V22pF

C311

100

1/16W1M

R337

100

R348

1/16W

1K

R320 100

R317

16V

C153100nF

VCC

R330

4.7K

R34

4

1

TP3191

100

TP902

TP938

1

U641

1uFC101

16V10uF

TP9511

4

5

6

7

C142

TP944

1

slcon7pCN101

1

2

3

TP940

1

TP942

1

1

TP926

1

TP3341

1

TP933

1

TP948

TP9521

TP931

1

TP937

TP936

1

4.7K1/16W

+5V_FE

R1081K

1/16W

R189

R187

R205

TP921

1

1/16W

4.7K

TP918

1

TP950

1

1/16W0

TP9251

100 1/16W

R917 100

1.5uH

R203

1

C304

MO50V10nF

BD301

16V

C162100nF

TP313

BD304 1.5uH

D301

1 2

3

VCC VCC

D302

1 2

3

1.5uHBD302

BD303 1.5uH

TP910

1

75R123

C168100pF50VMO

C137100nF

1/16W1KR301

+12V_INV

16V

4

5

6

7

8

9

10

11

12

13

14

1

slcon14p_1CN301

1

2

3

VCC

TP953

1

TP312

TP310

1

R9770

1/16W

10KR976

R34

1

R34

04.

7K

TP949

1

4.7K

TP946

1

TP9471

1/16W22

R183

1

C13610nF

50VMO

RA

130

1

2

3

4

5

6

7

8

TP81

4

5

6

7

8

109

RA

131

1

2

3

56

78

1615

1413

1211

IC107MTV121P-31

12

34

16V

C143

100nF

1

TP3581

TP3591

100

1/16W

TP357

4

5

6

7

8

R192

SUPLECODERC201

1

2

3

1/16W680K

R193

100 1/16W

C193100nF16VMO

1

234 5

678

R204

100R114

IC371M24C08-WMN1T

C139

16V

10uF

8

TP9201

TP3781

CN302slcon8p

1

2

3

4

5

6

7

100R338

100R316

4.7K

VCC VCC

1

TP3621

R34

3

U691

TP3601

TP361

R324 100

WC_ 7

R902 100

24LC21AT-/SNIC372

NC_11

NC_22

NC_33 6SCL

5SDA

8VCC

VSS4

4

5

6

7

8

VCC

SUPLECODERC202

1

2

3

1

R10210K

1

TP711

TP311

1

TP375

1

TP901

MO50V100pF

C169

TP315

1/16W330R195

BLM41P600SFT903 A

1

B2

R186

1/16W

10K

C371

VCC

10uF16V

100R372

C372100nF16VMO

R371100

VCC

C30110uF

16V

100

100R376

15K1/16W

R373

R375

TP9291

1/16W15KR374

R11

010

K

10nF

TP305

1

1

TP3501

C374

MO50V

1

TP3481

TP349

1

U72

1

U71

100R325

TP356

R916

TP3391

0 1/16W

100

R206

TP499

1

+3.3V_S

BD

201

1.5u

H

TP924

1

TP

281

1 1

TP

276

1 1

TP

274

1

TP

275

1/16W0R208

TP

273

U601

TP314

1

R381 100

100nF

+5V_FE

R314 100

1

TP3661

16V

C147

1

U3

1

U4

U621

U2

TP

272

1

U661

1

R202

01/16W

VCC

R919 0 1/16W

U54

D13

2

MM

BD

4148

SE

1

AB2

C3

1

R34

54.

7K

TP3681

TP3691

U67

TP3671

16V

10uF

C1660.01nF50VMO

1

TP3531

C157

1001/16WR181

TP352

R20101/16W

TP3451

TP3461

R97510K

D13

3

A12 B

3

C

1

TP781

MM

BD

4148

SE

C18533pF

50VMO

TP347U551

TP3441

U611

TP3381

TP317

1

TP316

1

R34

74.

7K

Q3112SC2412K-Q

B

C

E

TP3181

R207 0 1/16W

R380 1K

TP3371

R378 100

26

U531

U651

42

17

18

19

20

21 22

23

24

25

12

38

13

39

14

40

15

41

16

33

8

349

35

10

36

11

37

2

28

3

29

4

30

5

31

6

32

7

IC301

KS88P6232N1

27

MO

C232

VCC

VCC

R351

6801/16W

100nF16V

2SC2412K-QQ312B

C

E

R361

10K

MO

VCC

1/16W470R350

U631

50V100pFC375

C189

10nF50VMO

R1821/16W 100

1B2

C3

4.7K

R33

9

D13

1

MM

BD

4148

SE

A

C230100nF16VMO

1

1.5u

HB

D20

5

BD

206

1.5u

H

C21710uF

TP501

C21510uF 10uF

C216

38

VCC1

9 VCC1

26 VCC2

C21110uF

3

TXIN74

6 TXIN87 TXIN9

TXOUT0+47

TXOUT0- 48

45TXOUT1+TXOUT1-

46

41TXOUT2+

42TXOUT2-

37TXOUT3+TXOUT3-

TXIN2123

TXIN2224

TXIN2325

27 TXIN2428 TXIN25

30TXIN26

TXIN2750

55TXIN3TXIN4

56

TXIN52

TXIN6

TXIN11TXIN1211

TXIN1312

TXIN1414

TXIN1515

16 TXIN16

18 TXIN1719 TXIN1820 TXIN19

TXIN254

TXIN2022 PLLGND

PLLGND133

PLLVCC 34

PWRDWN32

17 R_FB

31TXCLKIN

TXCLKOUT+ 39TXCLKOUT-

40

TXIN051TXIN152

8 TXIN10

10

DS90C385MTDIC251

GND15

13 GND2

GND321

29GND4

53GND5

49LVDSGND

43LVDSGND1

LVDSGND236

LVDSVCC44

35

+3.3V_S +3.3V_S

+3.3V_PANEL

TP73

1

ZD181

+5V_FE

10uF16V

C165

C228

100nF16VMO

1/16WR349

220

MO16V100nFC223

C151

1uF

C106

1

TP3291

100nF

16V

1/16W1K

TP330

1

2

3

45

6

7

8

R905

R91

2

LM1881MIC109

R91

11K 1/

16W

1/16

W1K

Q0 Q1

1/16

W1K

R91

0

R336 100

X311HC-49/S-SMD(12MHz,30ppm)

1K 1/16

W

U701 100R904

R91

3

VCC

TP9031 R903 100

U681 100R901

R377100

10KR362

9

10

11

12

13

14

15

d_sub15p1

2

3

4

5

6

7

8

TP511

CN102

4.7K

R34

6

+3.3V_S

VCC

+3.3V_S

MO16V100nFC229

C104100uF

16V

MO50V10nFC135

C13410nF50VMO

MO

C13210nF50VMO

C152

16V

100nF

C181100nF

16V

1

16V

C155100nF

TP909

1

VCC

+3.3V_PANEL

TP53

FT906

BLM41P600S

1A

2B

BLM41P600SFT113

A1

B2

U221

56D2

D3 7

8D4G14

1 S1S22

3 S3

+5V_FE

+5V_FE

SI4435DYQ192

D1

1/16W10KR190

50VMO

C190100pF50V

MO

VCC5

Y4

C19410nF

8

IC106NC7SZ04P5X

A2

GND3

NC1

SUPLECODE

1

2

3

4

5

6

7

MO50V

0.01nFC173

RC205

C172

15pF50VMO

RA

132

1

2

3

4

5

6

7

8

X100

Q0 Q1

TP801

B

C

E

+3.3V_S

AS-20.000-20-FUND-SMD

2SC2412K-QQ106

100nF16V

100nF16V

C138

10KR109

C148

Q1032SC2412K-Q

B

C

E

1/16W

1/16W

100R121

MO50V10nFC131

100R117

1

2

3

4

5

6

7

8

3

4

5

6

7

8

RC203SUPLECODE

TP721

RC204SUPLECODE

1

2

6

GIN7

H8I9

J10K11L12M13N14

N74F125D

IC108

AIN1

BIN2

CIN3

DIN

4

EIN5

FIN

R120100

1/16W

100nF

1/16W0R191

IC102BA17805FP

GND

IN OUT

C159

16V

R12575

A96

97A97

98A98

99A99

75R124

89A89

9 A9

90A90

91A91

92A92

93A93

94A94

95A95

96

81A81

82A82

83A83

84A84

85A85

86A86

87A87

88A88

A74

75

A75

76A

76

77A

77

78A

78

79A

79

8 A8

80

A80

67A

67

68A

68

69A

69

7A7

70A

70

71

A71

72A

72

73A

73

74

A6

60A

60

61A

61

62

A62

63A

63

64A

64

65A

65

66

A66

A52

53A

53

54A

54

55A

55

56A

56

57

A57

58A

58

59A

59

6

45A

45

46A

46

47A

47

48

A48

49A

49

5 A5

50A

50

51A

51

52

A3839

A39

4 A4

40 A40

41A

41

42A

42

43

A43

44A

44

A3031 A3132 A3233 A3334 A3435

A3536 A3637 A3738

23 A2324 A2425 A2526

A2627 A2728 A2829 A29

3A3

30

A16

0

17 A1718 A1819 A19

2 A2

20 A2021

A2122 A22

153

A15

3

154

A15

4

155

A15

5

156

A15

6

157

A15

7

158

A15

8

159

A15

9

16A16

160

A14

6

147

A14

7

148

A14

8

149

A14

9

15 A15

150

A15

0

151

A15

1

152

A15

2

139

A13

9

14 A14

140

A14

0

141

A14

1

142

A14

2

143

A14

3

144

A14

4

145

A14

5

146

131

A13

1

132

A13

2

133

A13

3

134

A13

4

135

A13

5

136

A13

6

137

A13

7

138

A13

8

A12

4

125

A12

5

126

A12

6

127

A12

7

128

A12

8

129

A12

9

13 A13

130

A13

0

117A117

118A118

119A119

12A12

120A120

121

A12

1

122

A12

2

123

A12

3

124

11 A11110

A110

111A11

112A112

113A113

114A114

115A115

116A116

A102

103A103

104A104

105A105

106A106

107A107

108A108

109A109

gmZAN1

IC105

1 A1

10 A10

100A100

101A101

102

1A

2B

10uF16V

C149

FT112

BLM41P600S

16V

C164100nF

3 4

5 6

7 8

16V

C145

100nF

6

7

8

RA136

1 2

RA

133

1

2

3

4

5

RA

134

1

2

3

4

5

6

7

8

R106

100K1/16W

100nF16V

C160

1.5uHBD181

TP74

1

100K

1/16W

R104

+12V_IN

U24

1

ZD185

B

C

E

ZD184

2SC2412K-QQ104

MO50V22pF

C167

C182100nF16VMO

1 2

3 4

5 6

7 8

R184

RA137

A

2B

R18022

1/16W

1/16W1K

FT901BLM41P600S

1AB

2 FT902BLM41P600S

1

FT110

BLM41P600S

1A

2B

7

8

MO50V10nFC103

+3.3V_S

1

2

3

4

5

6

BLM41P600S

FT905 A1

B2

RC207SUPLECODE

TP841

25V

100uFC102

2SC2412K-Q

Q102

B

C

E

+3.3V_IN

U201

+3.3V_S

+3.3V_IN

1uF

C187

1/16W100K

R185

R115

75

50V

MO16V100nF

C227

C161

16V100nF

2122

1.5uHBD183

101112

1314151617

181920

123

45678

9

100R118

slcon22p_1CN201

BLM41P600SFT111

A1

B2

1/16W

100nF

MO50V10nFC133

C140100uF

16V

C150

16V

1

C154

U26

MO50V33pF

C186

16V

100nF

16V10uFC188

B

C

E

FT904BLM41P600S

1A

2B

Q1072SC2412K-Q

VCC

5

6

7

8

TP500

1

C18415pF50V

MO

SUPLECODERC206

1

2

3

4

MO50V10nF 10nF

50VMO

C303

VCC

C302

TP

280

1

16V

10uF

C373

TP

278

1

TP

279

1

VCC

TP

277

1

R379

R918 15K1/16W

65

D2_1

G12

G24

1 S1

3S2

+5V_Touch

1/16W0

Q193SI9933ADY-T1

D1 87D1_1

D2

slcon2p

CN304

1

2

+5V_Touch

R122

1/16W

100

2SC2412K-QQ105B

C

E

C10510nF50VMO

U59

1

C313100nF16VMO

16V

C141100nF

16V10uF

C191 C192

10nF50VMO

16V

100nFC144

16V10uF MO

16V

100nFC180

1.5uH

C183

ZD182

BD182

C156

16V

100nF

10K1/16W

TP751

MO50V15pF

C171

R188

1A

2B

ZD183

C163

FT114BLM41P600S

1/16W

+12V_IN

16V100nF

1

100R119

LED_G

HCLKSWITCH_OFF_N

SW_REG_ENB

PC_BLUE_IN

SW_REG_EN

SOG_CSYNC

DDC_SCL

LED_R

VSYNC_OUT

SOG

U49

KEY2

PC_HSYNC_INPC_VSYNC_IN

HFS

LED_R

LED_G

HDATA0HDATA1HDATA2HDATA3

OSD_SDAOSD_SCL

AUDIO_VOLUME

SOG_CSYNC

AUDIO_MUTE

KEY1

KEY2

M_SCLM_SDA

DDC_SCLDDC_SDA

PC_VSYNC_IN

BL_EN

SOURCE_PC

DDC_SDA

M_SCLM_SDA

SW_REG_EN

LVDS_ENRESETn

DDC_SCL

BRIGHTPANEL_EN

KEY1

PVS

DEN

PHS

HSYNC_PLL

PC_HSYNC_IN

BL_EN

BRIGHT

EG(6)

EG(7)

EB(7:0)

EB(0)

EB(1)

EB(2)

EB(3)

EB(4)

EB(5)

EB(6)

EB(7)

LVDS_EN

DHCLK

PC_GREEN_IN

ER(0)

ER(1)

EG(0)

EG(1)

EB(0)

EB(1)

PVSPHS

ER(7:0)

EG(7:0)

EB(7:0)

ER(7:0)

ER(0)

ER(1)

ER(2)

ER(3)

ER(4)

ER(5)

ER(6)

ER(7)

EG(7:0)EG(0)

EG(1)

EG(2)

EG(3)

EG(4)

EG(5)

SOG

SOG_ZAN1

SW_REG_EN

PC_HSYNC_INHSYNC_PLL

SWITCH_OFF_N

ER(7)

ER(6)

ER(5)

ER(4)

ER(3)

ER(2)

OSD_SDAOSD_SCL

SW_REG_ENB

SW_REG_EN

DDC_SDA

SOURCE_PC

PC_VSYNC_IN

PC_HSYNC_IN

PC_RED_IN

PC_GREEN_IN

EB(7)

EB(6)

EB(5)

EB(4)

EB(3)

EB(2)

EG(7)

EG(6)

EG(5)

EG(4)

EG(2)

EG(3)

PC_BLUE_IN

DHCLK

HDATA1HDATA2HDATA3

PANEL_EN

RESETn

HCLK

SOG_ZAN1

VSYNC_OUT

DEN

HFSHDATA0

PC_RED_IN

PC_GREEN_IN

4

6

5

3

7

1

2

GH15ES/GH15MSonly


1

5 6 7

2 3 4




U30

1

MO16V150nFC402

16V

C408100nF100nF

C407

16V

U17 1

1/16W6.8KR978

100R404

TP22

1

+12V_AUDIO

16V100uFC405

U431

R40610K 10K

R407

100

U40

1

R4021

C404100pF50VMO

16

VS

0V

S1

15

slcon3pCN402

1

2

3

U35

INL

9INR

MUTE12

8N_C

OUTL 17

OUTR14

STBY11

SVR10

5

VAROUT_L

7

VA

RO

UT

_R

6

VOLUME

1GND0

2GND1

3GND213GND3

20GND4

19GND5

18GND6

4

VCC

IC401

TDA7496LU34

1

U57

1

100nFC415

16V

2SC2412K-QQ402

B

C

E

1

R416 100

ZD402

U45

R415

1/16W100K

U50

1

U38

1

A1

B2

16V100uFC409

BLM41P600S

FT402

1

R413

1/16W100K

33uFC420

MO50V100pFC403

U41

1

2

U281

16V

C413100nF

slcon2pCN401

100K1/16W

R412

16V470uFC412

C410470uF16V

1

TP9111

U32

1

U33

U29

1

1/16W1KR405

U18

1

U27

1 1

100R401U31

1

U25

+12V_IN

+12V_AUDIO

C40610uF16V

1

U23 1

TP914

1

U36

1

U37

16V

C414100nF

TP913

1

FT401

BLM41P600S

1A

2B

R403 100

SI4435DY

5D16D2

D3 78D44 G1

S112 S23 S3

2SC2412K-QQ401

B

C

E

Q403

R41710K

U19

1

C401150nF16VMO

U47

1

R41410K

C411

16V

TP912

1

ZD401

100nF

47uFC416

AUDIO_STANDBY

AGNDAGND

AGND

AUDIO_MUTE

AGND

BL_EN

AGND AGND

AGND

AGND

AGND

AGNDAGND AGND AGND

AGND

AGND

AGND

AUDIO_VOLUME

AUDIO_STANDBY

AGND AGND

SW_REG_EN

9-2 Audio Part Schematic diagram (GH15MS only)

Samsung 151s (GH15LS)

Documents

Transcript of Samsung 151s (GH15LS)