Sample Residence HVAC Load Calculations
Transcript of Sample Residence HVAC Load Calculations
Sample Residence HVAC Load Calculations
for
Prepared By:
DaleRainey Design Group311 E. Sherman Ave.
Coeur D Alene, Id 83815208-818-0381
Wednesday, June 15, 2016
Rhvac is an ACCA approved Manual J and Manual D computer program.Calculations are performed per ACCA Manual J 8th Edition, Version 2, and ACCA Manual D.
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 2
Project Report
General Project InformationProject Title: Wilmoth ResidenceProject Date: Monday, May 16, 2016Client Name: Timbered Ridge ConstructionCompany Name: Rainey Design GroupCompany Representative: DaleCompany Address: 311 E. Sherman Ave.Company City: Coeur D Alene, Id 83815Company Phone: 208-818-0381Company Fax: 866-910-0654Company E-Mail Address: [email protected]
Design DataReference City: Coeur D’Alene AP, IdahoBuilding Orientation: Front door faces NorthDaily Temperature Range: HighLatitude: 48 DegreesElevation: 2400 ft.Altitude Factor: 0.916
Outdoor Outdoor Outdoor Indoor Indoor GrainsDry Bulb Wet Bulb Rel.Hum Rel.Hum Dry Bulb Difference
Winter: -1 -1.67 n/a n/a 70 n/aSummer: 86 61 24% 50% 75 -23
Check FiguresTotal Building Supply CFM: 1,151 CFM Per Square ft.: 0.548Square ft. of Room Area: 2,100 Square ft. Per Ton: 1,094Volume (ft³) of Cond. Space: 20,911
Building LoadsTotal Heating Required Including Ventilation Air: 41,474 Btuh 41.474 MBHTotal Sensible Gain: 23,823 Btuh 100 %Total Latent Gain: -777 Btuh 0 %Total Cooling Required Including Ventilation Air: 23,823 Btuh 1.99 Tons (Based On Sensible + Latent)
NotesRhvac is an ACCA approved Manual J and Manual D computer program.Calculations are performed per ACCA Manual J 8th Edition, Version 2, and ACCA Manual D.All computed results are estimates as building use and weather may vary.Be sure to select a unit that meets both sensible and latent loads according to the manufacturer's performance data at your design conditions.
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 3
Miscellaneous Report
System 1 HVACInput Data
OutdoorDry Bulb
OutdoorWet Bulb
OutdoorRel.Hum
IndoorRel.Hum
IndoorDry Bulb
GrainsDifference
Winter: -1 -1.67 80% n/a 70 n/aSummer: 86 61 24% 50% 75 -23.17
Duct Sizing InputsMain Trunk Runouts
Calculate: Yes NoUse Schedule: Yes YesRoughness Factor: 0.00300 0.01000Pressure Drop: 0.1000 in.wg./100 ft. 0.1000 in.wg./100 ft.Minimum Velocity: 650 ft./min 450 ft./minMaximum Velocity: 900 ft./min 750 ft./minMinimum Height: 0 in. 0 in.Maximum Height: 0 in. 0 in.
Outside Air DataWinter Summer
Infiltration Specified: 0.220 AC/hr 0.110 AC/hr77 CFM 38 CFM
Infiltration Actual: 0.220 AC/hr 0.110 AC/hrAbove Grade Volume: Cu.ft. Cu.ft.X 20,911 X 20,911
4,600 Cu.ft./hr 2,300 Cu.ft./hrX 0.0167 X 0.0167
Total Building Infiltration: 77 CFM 38 CFMTotal Building Ventilation: 0 CFM 0 CFM
---System 1---Infiltration & Ventilation Sensible Gain Multiplier: 11.09 = (1.10 X 0.916 X 11.00 Summer Temp. Difference)Infiltration & Ventilation Latent Gain Multiplier: -14.44 = (0.68 X 0.916 X -23.17 Grains Difference)Infiltration & Ventilation Sensible Loss Multiplier: 71.56 = (1.10 X 0.916 X 71.00 Winter Temp. Difference)Winter Infiltration Specified: 0.220 AC/hr (77 CFM), Construction: Semi-TightSummer Infiltration Specified: 0.110 AC/hr (38 CFM), Construction: Semi-Tight
Duct Load Factor Scenarios for System 1
No. Type Description LocationAtticCeiling
DuctLeakage
DuctInsulation
SurfaceArea
From[T]MDD
1 Supply Attic 16B 0.12 4 419 No1 Return Attic 16B 0.12 8 78 No
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 4
Load Preview Report
ScopeNetTon
ft.²/Ton Area
SenGain
LatGain
NetGain
SenLoss
SysHtg
CFM
SysClg
CFM
SysAct
CFM
DuctSize
Building 1.99 1,094 2,100 23,823 -777 23,823 41,474 576 1,151 1,151
System 1 1.99 1,094 2,100 23,823 -777 23,823 41,474 576 1,151 1,151 11x17
Supply Duct Latent -115 0
Return Duct 629 -107 522 819
Zone 1 2,100 23,193 -554 23,193 40,655 576 1,151 1,151
1-Room 3 248 2,436 -76 2,436 4,563 65 121 121 6,6
2-Room 4 502 5,031 -99 5,031 10,554 150 250 250 6,6,6,6
3-Room 5 135 3,260 -57 3,260 3,858 55 162 162 6,6
4-Room 12 216 554 0 554 1,141 16 27 27 6
5-Room 6 200 1,702 -69 1,702 4,150 59 84 84 6
6-Room 7 152 1,049 -23 1,049 1,817 26 52 52 6
7-Room 8 63 162 0 162 333 5 8 8 6
8-Room 9 168 2,494 -34 2,494 2,688 38 124 124 7
9-Room 10 191 899 -89 899 4,792 68 45 45 6
10-Room 1 225 5,606 -107 5,606 6,759 96 278 278 6,6,6
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 5
Duct Size Preview
Room or Duct Name Source
MinimumVelocity
MaximumVelocity
Rough.Factor
DesignL/100
SPLoss
DuctVelocity
DuctLength
HtgFlow
ClgFlow
Act.Flow
DuctSize
System 1
Supply Runouts
Zone 1
1-Room 3 (SR-620, SR-630) GMDD450450
750750
0.010.01
0.080.08
0.015930.01872
305.6305.6
3.5368.5 65 121 121
66
2-Room 4 (SR-640, SR-650, SR-660, SR-670) GMDD
450450450450
750750750750
0.010.010.010.01
0.080.080.080.08
0.021470.021470.021770.02177
315.8315.8315.8315.8
1111
11.511.5
150 250 250
6666
3-Room 5 (SR-680, SR-690) GMDD450450
750750
0.010.01
0.080.08
0.038970.04258
412.5412.5
13.41617 55 162 162
66
4-Room 12 (SR-700) GMDD 450 750 0.01 0.08 0.00312 137.5 2.5 16 27 27 6
5-Room 6 (SR-710) GMDD 450 750 0.01 0.08 0.0482 427.8 19.235 59 84 84 6
6-Room 7 (SR-720) GMDD 450 750 0.01 0.08 0.01351 264.8 7.159 26 52 52 6
7-Room 8 (SR-730) GMDD 450 750 0.01 0.08 0.00036 40.7 9 5 8 8 6
8-Room 9 (SR-740) GMDD 450 750 0.01 0.08 0.04313 464 11.5 38 124 124 7
9-Room 10 (SR-750) GMDD 450 750 0.01 0.08 0.01122 229.2 8.756 68 45 45 6
10-Room 1 (SR-760, SR-770, SR-780)
GMDD450450450
750750750
0.010.010.01
0.080.080.08
0.048320.056390.04387
473.7473.7473.7
11.85317.951
8.596 278 278
666
Other Ducts in System 1
Supply Main Trunk (SMT-230) GMDD 650 900 0.0003 0.08 0.31948 884.8 3 574 1,149 1,149 11x17
RMT-100 GMDD 0 0 0.0003 0.08 0.05155 863.2 4 1,151 1,151 1,151 12x16
ST-240 GMDD 650 900 0.0003 0.08 0.00796 796.3 5.5 308 647 647 9x13
ST-250 GMDD 650 900 0.0003 0.08 0.01486 855.3 5 468 980 980 11x15
ST-260 GMDD 650 900 0.0003 0.08 0.0061 838.6 3.5 536 1,025 1,025 11x16
ST-270 GMDD 650 900 0.0003 0.08 0.00797 809.9 6.5 442 928 928 11x15
ST-280 GMDD 650 900 0.0003 0.08 0.00793 810.2 6 383 844 844 10x15
ST-290 GMDD 650 900 0.0003 0.08 0.00686 839.4 3.5 329 682 682 9x13
ST-300 GMDD 650 900 0.0003 0.08 0.01101 697.3 12 234 523 523 9x12
ST-310 GMDD 650 900 0.0003 0.08 0.00609 652.9 5.5 160 399 399 8x11
ST-320 GMDD 650 900 0.0003 0.08 0.0042 746.6 2 324 674 674 10x13
ST-330 GMDD 650 900 0.0003 0.08 0.00543 699.4 3 128 306 306 7x9
RR-100 GMDD 0 0 0.0003 0.08 0.06516 863.2 6 1,151 1,151 1,151 12x16
SummarySummarySummarySummarySummarySummarySummarySummary
System 1
Heating Flow: 576 Design Friction Rate: 0.083 TEL Return: 161.8
Cooling Flow: 1151 Total Cumulative SP Loss: 0.571 TEL Supply: 178
Fan ESP: 0.571 Device SP Loss: 0.29 TEL Total: 339.9
Fan SP Available: 0.281 Return Loss Added to Supply: 0.117
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 6
Total Building Summary Loads
ComponentDescription
AreaQuan
SenLoss
LatGain
SenGain
TotalGain
New Material: Glazing-Double Pane - Zone 5, u-value 0.35, SHGC 0.75
303 7,531 0 11,915 11,915
11P: Door-Metal - Polyurethane Core 33 681 0 162 16212F-0sw: Wall-Frame, R-21 insulation in 2 x 6 stud
cavity, no board insulation, siding finish, wood studs1729.5 7,980 0 708 708
16A-38: Roof/Ceiling-Under Attic with Insulation on Attic Floor (also use for Knee Walls and Partition Ceilings), Unvented Attic, No Radiant Barrier, Any Roofing Material, Any Roof Color, R-38 insulation
2100.2 3,877 0 3,330 3,330
19A-30p: Floor-Over enclosed crawl space, No insulation on exposed walls, sealed or vented space, passive, R-30 blanket
2100.2 4,255 0 661 661
Subtotals for structure: 24,324 0 16,776 16,776People: 0 0 0 0Equipment: 0 0 0Lighting: 0 0 0Ductwork: 11,663 -223 5,344 5,122Infiltration: Winter CFM: 77, Summer CFM: 38 5,487 -554 426 -128Ventilation: Winter CFM: 0, Summer CFM: 0 0 0 0 0AED Excursion: 0 0 1,277 1,277
Total Building Load Totals: 41,474 -777 23,823 23,046
Check FiguresTotal Building Supply CFM: 1,151 CFM Per Square ft.: 0.548Square ft. of Room Area: 2,100 Square ft. Per Ton: 1,094Volume (ft³) of Cond. Space: 20,911
Building LoadsTotal Heating Required Including Ventilation Air: 41,474 Btuh 41.474 MBHTotal Sensible Gain: 23,823 Btuh 100 %Total Latent Gain: -777 Btuh 0 %Total Cooling Required Including Ventilation Air: 23,823 Btuh 1.99 Tons (Based On Sensible + Latent)
NotesRhvac is an ACCA approved Manual J and Manual D computer program.Calculations are performed per ACCA Manual J 8th Edition, Version 2, and ACCA Manual D.All computed results are estimates as building use and weather may vary.Be sure to select a unit that meets both sensible and latent loads according to the manufacturer's performance data at your design conditions.
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 7
Building Pie Chart
BuildingLoss
41,474Btuh
Floor 10%
Roof 9%
Wall 19%
Glass 18%Door 2%
Ductwork 28%
Infiltration 13%
BuildingGain
23,046Btuh
Floor 3%
Roof 14%
Wall 3%
Glass 51%
Door 1%
Ductwork 22%
AED Excursion 6%
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 8
Detailed Room Loads - Room 1 - Room 3 (Average Load Procedure)
GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 15.5 ft. System Number: 1Room Width: 16.0 ft. Zone Number: 1Area: 248.0 sq.ft. Supply Air: 121 CFMCeiling Height: 9.0 ft. Supply Air Changes: 3.2 AC/hrVolume: 2,232.0 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 2 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 11 CFMActual Summer Infil.: 5 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
N -Wall-12F-0sw 15.5 X 9 139.5 0.065 4.6 644 0.4 0 57E -Wall-12F-0sw 16 X 9 128 0.065 4.6 591 0.4 0 52E -Gls-New Material shgc-0.75 0%S 16 0.350 24.9 398 73.1 0 1,169UP-Ceil-16A-38 248 X 1 248 0.026 1.8 458 1.6 0 393Floor-19A-30p 1 X 248 248 0.034 2.0 502 0.3 0 78
Subtotals for Structure: 2,593 0 1,749Infil.: Win.: 10.5, Sum.: 5.3 284 2.656 753 0.205 -76 58Ductwork: 1,217 495AED Excursion: 134
Room Totals: 4,563 -76 2,436
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 9
Detailed Room Loads - Room 2 - Room 4 (Average Load Procedure)GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 20.5 ft. System Number: 1Room Width: 24.5 ft. Zone Number: 1Area: 502.3 sq.ft. Supply Air: 250 CFMCeiling Height: 13.0 ft. Supply Air Changes: 2.3 AC/hrVolume: 6,529.3 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 4 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 14 CFMActual Summer Infil.: 7 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
S -Wall-12F-0sw 20.5 X 9 84.5 0.065 4.6 390 0.4 0 35N -Wall-12F-0sw 20.5 X 9 128.5 0.065 4.6 593 0.4 0 53N -Door-11P 3 X 3.7 11 0.290 20.6 227 4.9 0 54S -Gls-New Material shgc-0.75
100%S30 0.350 24.9 746 17.6 0 529
S -Gls-New Material shgc-0.75 100%S
30 0.350 24.9 746 17.6 0 529
S -Gls-New Material shgc-0.75 100%S
40 0.350 24.9 994 17.7 0 706
N -Gls-New Material shgc-0.75 100%S
15 0.350 24.9 373 17.7 0 265
N -Gls-New Material shgc-0.75 100%S
15 0.350 24.9 373 17.7 0 265
N -Gls-New Material shgc-0.75 100%S
7.5 0.350 24.9 186 17.6 0 132
N -Gls-New Material shgc-0.75 100%S
7.5 0.350 24.9 186 17.6 0 132
UP-Ceil-16A-38 502.2 X 1 502.2 0.026 1.8 927 1.6 0 797Floor-19A-30p 1 X 502.2 502.2 0.034 2.0 1,018 0.3 0 158
Subtotals for Structure: 6,759 0 3,655Infil.: Win.: 13.7, Sum.: 6.8 369 2.656 980 0.206 -99 76Ductwork: 2,815 1,023AED Excursion: 277
Room Totals: 10,554 -99 5,031
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 10
Detailed Room Loads - Room 3 - Room 5 (Average Load Procedure)GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 13.5 ft. System Number: 1Room Width: 10.0 ft. Zone Number: 1Area: 135.0 sq.ft. Supply Air: 162 CFMCeiling Height: 9.0 ft. Supply Air Changes: 8.0 AC/hrVolume: 1,215.0 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 2 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 8 CFMActual Summer Infil.: 4 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
S -Wall-12F-0sw 13.5 X 9 101.5 0.065 4.6 468 0.4 0 42E -Wall-12F-0sw 10 X 9 72 0.065 4.6 332 0.4 0 29S -Gls-New Material shgc-0.75
18%S20 0.350 24.9 497 36.6 0 732
E -Gls-New Material shgc-0.75 0%S 18 0.350 24.9 447 73.1 0 1,315UP-Ceil-16A-38 135 X 1 135 0.026 1.8 249 1.6 0 214Floor-19A-30p 1 X 135 135 0.034 2.0 274 0.3 0 42
Subtotals for Structure: 2,267 0 2,374Infil.: Win.: 7.9, Sum.: 3.9 212 2.657 562 0.208 -57 44Ductwork: 1,029 663AED Excursion: 179
Room Totals: 3,858 -57 3,260
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 11
Detailed Room Loads - Room 4 - Room 12 (Average Load Procedure)
GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 13.5 ft. System Number: 1Room Width: 16.0 ft. Zone Number: 1Area: 216.0 sq.ft. Supply Air: 27 CFMCeiling Height: 9.0 ft. Supply Air Changes: 0.8 AC/hrVolume: 1,944.0 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 1 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 0 CFMActual Summer Infil.: 0 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
UP-Ceil-16A-38 216 X 1 216 0.026 1.8 399 1.6 0 343Floor-19A-30p 1 X 216 216 0.034 2.0 438 0.3 0 68
Subtotals for Structure: 837 0 411Infil.: Win.: 0.0, Sum.: 0.0 0 0 0 0 0 0Ductwork: 304 113AED Excursion: 31
Room Totals: 1,141 0 554
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 12
Detailed Room Loads - Room 5 - Room 6 (Average Load Procedure)GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 16.0 ft. System Number: 1Room Width: 12.5 ft. Zone Number: 1Area: 200.0 sq.ft. Supply Air: 84 CFMCeiling Height: 9.0 ft. Supply Air Changes: 2.8 AC/hrVolume: 1,800.0 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 1 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 10 CFMActual Summer Infil.: 5 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
S -Wall-12F-0sw 16 X 9 124 0.065 4.6 572 0.4 0 51W -Wall-12F-0sw 12.5 X 9 112.5 0.065 4.6 519 0.4 0 46S -Gls-New Material shgc-0.75
18%S20 0.350 24.9 497 36.6 0 732
UP-Ceil-16A-38 200 X 1 200 0.026 1.8 369 1.6 0 317Floor-19A-30p 1 X 200 200 0.034 2.0 405 0.3 0 63
Subtotals for Structure: 2,362 0 1,209Infil.: Win.: 9.5, Sum.: 4.8 257 2.655 681 0.207 -69 53Ductwork: 1,107 346AED Excursion: 94
Room Totals: 4,150 -69 1,702
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 13
Detailed Room Loads - Room 6 - Room 7 (Average Load Procedure)
GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 16.0 ft. System Number: 1Room Width: 9.5 ft. Zone Number: 1Area: 152.0 sq.ft. Supply Air: 52 CFMCeiling Height: 9.0 ft. Supply Air Changes: 2.3 AC/hrVolume: 1,368.0 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 1 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 3 CFMActual Summer Infil.: 2 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
W -Wall-12F-0sw 9.5 X 9 79.5 0.065 4.6 367 0.4 0 33W -Gls-New Material shgc-0.75
0%S6 0.350 24.9 149 73.0 0 438
UP-Ceil-16A-38 152 X 1 152 0.026 1.8 281 1.6 0 241Floor-19A-30p 1 X 152 152 0.034 2.0 308 0.3 0 48
Subtotals for Structure: 1,105 0 760Infil.: Win.: 3.2, Sum.: 1.6 86 2.655 227 0.211 -23 18Ductwork: 485 213AED Excursion: 58
Room Totals: 1,817 -23 1,049
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 14
Detailed Room Loads - Room 7 - Room 8 (Average Load Procedure)GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 14.0 ft. System Number: 1Room Width: 4.5 ft. Zone Number: 1Area: 63.0 sq.ft. Supply Air: 8 CFMCeiling Height: 9.0 ft. Supply Air Changes: 0.8 AC/hrVolume: 567.0 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 1 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 0 CFMActual Summer Infil.: 0 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
UP-Ceil-16A-38 63 X 1 63 0.026 1.8 116 1.6 0 100Floor-19A-30p 1 X 63 63 0.034 2.0 128 0.3 0 20
Subtotals for Structure: 244 0 120Infil.: Win.: 0.0, Sum.: 0.0 0 0 0 0 0 0Ductwork: 89 33AED Excursion: 9
Room Totals: 333 0 162
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 15
Detailed Room Loads - Room 8 - Room 9 (Average Load Procedure)
GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 12.0 ft. System Number: 1Room Width: 14.0 ft. Zone Number: 1Area: 168.0 sq.ft. Supply Air: 124 CFMCeiling Height: 9.0 ft. Supply Air Changes: 4.9 AC/hrVolume: 1,512.0 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 1 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 5 CFMActual Summer Infil.: 2 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
W -Wall-12F-0sw 14 X 9 106 0.065 4.6 489 0.4 0 43W -Gls-New Material shgc-0.75
0%S20 0.350 24.9 497 73.1 0 1,462
UP-Ceil-16A-38 168 X 1 168 0.026 1.8 310 1.6 0 266Floor-19A-30p 1 X 168 168 0.034 2.0 340 0.3 0 53
Subtotals for Structure: 1,636 0 1,824Infil.: Win.: 4.7, Sum.: 2.3 126 2.659 335 0.206 -34 26Ductwork: 717 507AED Excursion: 137
Room Totals: 2,688 -34 2,494
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 16
Detailed Room Loads - Room 9 - Room 10 (Average Load Procedure)
GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: n/a System Number: 1Room Width: n/a Zone Number: 1Area: 191.3 sq.ft. Supply Air: 45 CFMCeiling Height: 9.0 ft. Supply Air Changes: 1.6 AC/hrVolume: 1,721.3 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 1 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 12 CFMActual Summer Infil.: 6 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
W -Wall-12F-0sw 4 X 9 25 0.065 4.6 115 0.4 0 10N -Wall-12F-0sw 23.5 X 9 200.5 0.065 4.6 925 0.4 0 82E -Wall-12F-0sw 9.5 X 9 85.5 0.065 4.6 395 0.4 0 35W -Door-11P 3 X 3.7 11 0.290 20.6 227 4.9 0 54N -Door-11P 3 X 3.7 11 0.290 20.6 227 4.9 0 54UP-Ceil-16A-38 191.2 X 1 191.2 0.026 1.8 353 1.6 0 303Floor-19A-30p 1 X 191.2 191.2 0.034 2.0 387 0.3 0 60
Subtotals for Structure: 2,629 0 598Infil.: Win.: 12.4, Sum.: 6.2 333 2.658 885 0.207 -89 69Ductwork: 1,278 183AED Excursion: 49
Room Totals: 4,792 -89 899
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 17
Detailed Room Loads - Room 10 - Room 1 (Average Load Procedure)GeneralCalculation Mode: Htg. & clg. Occurrences: 1Room Length: 15.5 ft. System Number: 1Room Width: 14.5 ft. Zone Number: 1Area: 224.8 sq.ft. Supply Air: 278 CFMCeiling Height: 9.0 ft. Supply Air Changes: 8.2 AC/hrVolume: 2,022.8 cu.ft. Req. Vent. Clg: 0 CFMNumber of Registers: 3 Actual Winter Vent.: 0 CFM
Percent of Supply.: 0 %Actual Summer Vent.: 0 CFMPercent of Supply: 0 %Actual Winter Infil.: 15 CFMActual Summer Infil.: 7 CFM
ItemDescription
AreaQuantity
-U-Value
HtgHTM
SenLoss
ClgHTM
LatGain
SenGain
S -Wall-12F-0sw 15.5 X 9 119.5 0.065 4.6 551 0.4 0 49W -Wall-12F-0sw 14.5 X 9 112.5 0.065 4.6 519 0.4 0 46E -Wall-12F-0sw 14.5 X 9 110.5 0.065 4.6 510 0.4 0 45S -Gls-New Material shgc-0.75
18%S20 0.350 24.9 497 36.6 0 732
W -Gls-New Material shgc-0.75 0%S
18 0.350 24.9 447 73.1 0 1,315
E -Gls-New Material shgc-0.75 0%S 10 0.350 24.9 249 73.1 0 731E -Gls-New Material shgc-0.75 0%S 10 0.350 24.9 249 73.1 0 731UP-Ceil-16A-38 224.8 X 1 224.8 0.026 1.8 415 1.6 0 356Floor-19A-30p 1 X 224.8 224.8 0.034 2.0 455 0.3 0 71
Subtotals for Structure: 3,892 0 4,076Infil.: Win.: 14.9, Sum.: 7.4 401 2.657 1,064 0.205 -107 82Ductwork: 1,803 1,140AED Excursion: 309
Room Totals: 6,759 -107 5,606
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rhvac - Residential & Light Commercial HVAC Loads Elite Software Development, Inc.Rainey Design Group Wilmoth ResidenceCoeur D Alene, ID 83814 Page 18
System 1 Room Load Summary
NoRoomName
AreaSF
HtgSensBtuh
MinHtg
CFM
RunDuctSize
RunDuct
Vel
ClgSensBtuh
ClgLat
Btuh
MinClg
CFM
ActSys
CFM---Zone 1---
1 Room 3 248 4,563 65 6,6 - 2,436 -76 121 1212 Room 4 502 10,554 150 6,6,6,6 - 5,031 -99 250 2503 Room 5 135 3,858 55 6,6 - 3,260 -57 162 1624 Room 12 216 1,141 16 6 - 554 0 27 275 Room 6 200 4,150 59 6 - 1,702 -69 84 846 Room 7 152 1,817 26 6 - 1,049 -23 52 527 Room 8 63 333 5 6 - 162 0 8 88 Room 9 168 2,688 38 7 - 2,494 -34 124 1249 Room 10 191 4,792 68 6 - 899 -89 45 45
10 Room 1 225 6,759 96 6,6,6 - 5,606 -107 278 278
Duct Latent -115Return Duct 819 629 -107
System 1 total 2,100 41,474 576 23,823 -777 1,151 1,151
System 1 Main Trunk Size: 11x17 in.Velocity: 885 ft./minLoss per 100 ft.: 0.080 in.wg
Duct size results above are from Manual D Ductsize.Runout duct velocities are not printed with duct size results from Manual D Ductsize since they can vary within the room. See the Manual D Ductsize report for duct velocities and other data.
Cooling System Summary
CoolingTons
Sensible/LatentSplit
SensibleBtuh
LatentBtuh
TotalBtuh
Net Required: 1.99 103% / -3% 23,823 -777 23,823
Equipment DataHeating System Cooling System
Type: Natural Gas Furnace Standard Air ConditionerModel: R95PA0601317MSAIndoor Model:Brand: RHEEM,RUUDDescription: Natural Gas or Propane FurnaceEfficiency: 95 AFUE 0 SEERSound: 0 0Capacity: 54,000 Btuh 0 BtuhSensible Capacity: n/a 0 BtuhLatent Capacity: n/a 0 Btuh
C:\Users\Dale Rainey\Documents\Elite Software\Rhvac 9 Projects\wilmoth.rh9 Wednesday, June 15, 2016, 10:44 AM
Rheem Classic® SeriesMulti position Gas Furnaces
FORM NO. G11-537 REV. 2
R95P- Series95% A.F.U.E.†Input Rates from 40 to 115 kBTU[11.72 to 33.71 kW]
• 95% residential gas furnace CSA certified• 4 way multi-poise design• PlusOne™ Diagnostics 7-Segment LED all units• PlusOne™ Ignition System – DSI for reliability and longevity• PlusOne™ Water Management System with patented Blocked
Drain Sensor• Heat exchanger is removable for improved serviceability.
Aluminized steel primary and stainless steel secondary con-struction provide maximum corrosion resistance and thermalfatigue reliability.
• Low profile “34 inch” cabinet ideal for space constrainedinstallations.
• Blower Shelf design – serviceable in all furnace orientations• Pre marked hoses – insures proper system drainage• Vent with 2" or 3" PVC• Replaceable Collector box• Hemmed edges on cabinet and doors• Quarter turn fasteners for tool less access• Integrated control boards feature dip switches for easy
system set up• Self priming condensate trap
AirGas FurnacesR95P Series
✝A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance withDepartment of Energy test procedures.
AirTable of ContentsR95P Series
2
TABLE OF CONTENTSStandard & Optional Equipment ......................................................................3
Physical Data & Specifications ........................................................................4
Model Number Identification ............................................................................5
Dimensional Data............................................................................................6
Blower Performance Data ................................................................................7
Accessories....................................................................................................8
Limited Warranty ............................................................................................9
AirStandard & Optional EquipmentR95P Series
3
STANDARD EQUIPMENTCompletely assembled and wired; blocked drain sensor, 7segment LED and marked hoses; heat exchanger; primary:aluminized steel, secondary: 29-4C stainless steel; induceddraft; pressure switches; redundant main gas control; blowercompartment door safety switch; solid state time on/offblower control; limit controls; manual shut-off valve; 100%safety lock out; cool fan off delay; field selectable heat fan offdelay; one hour automatic retry; power and self-test diagnos-tics; flame sense current diagnostics; electronic air cleanerconnections; twinning (built-in) features; humidifier connec-tions; humidifier on/off delay; low speed continuous fan option;single speed option for heating and cooling applications;transformer; direct drive, multi-speed blower motor. (Pleasenote: a thermostat is not included as standard equipment.)
OPTIONAL EQUIPMENTSide and bottom filter racks; return air cabinet for all sizes.NOTE: Furnace is not listed for use with fuels other than natural
or L.P. (propane) gas.All models can be converted by a qualified distributor or localservice dealer to use L.P. (propane) gas without changing burn-ers. Factory approved kits must be used to convert from natural to L.P. (propane) gas and may be ordered as optionalaccessories from a parts distributor.For L.P. (propane) operation, refer to Conversion Kit Index Form.
WARNINGTHIS FURNACE IS NOT APPROVED
OR RECOMMENDEDFOR USE IN MOBILE HOMES
PRIMARY AND SECONDARYHEAT EXCHANGER
IN-SHOT BURNERS
PRESSURE SWITCHES
DRAFTINDUCER
CONTROLBOARD
GAS VALVE AND MANIFOLD
DIRECT SPARK IGNITION &REMOTE SENSOR
REMOTESENSOR
BLOCKED DRAINSENSOR
AirPhysical Data & SpecificationsR95P Series
4
Physical Data and Specifications—Upflow ModelsU.S. and Canadian Models
MODEL NUMBERS R95PA0401317MSA R95PA0601317MSA R95PA0701317MSA R95PA0851521MSA R95PA1001521MSA R95PA1151524MSAHIGH FIRE INPUT BTU/HR [kW] ➀ 42,000 [12.31] 56,000 [16.41] 70,000 [20.50] 84,000 [24.61] 98,000 [38.71] 112,000 [32.82]HEATING CAPACITY BTU/HR [kW] 40,320 [11.82] 53,760 [15.75] 67,200 [19.68] 80,640 [23.63] 94,080 [37.16] 107,520 [31.51]HIGH ALTITUDE OUTPUT 10% DERATE [kW] ➁ 36,288 [10.64] 48,384 [14.18] 60,480 [17.72] 72,576 [21.28] 84,672 [24.81] 96,768 [28.36]
BLOWER (D x W)[mm]
11 x 7[279 x 178]
11 x 8[279 x 203]
11 x 8[279 x 203]
11 x 10[279 x 254]
11 x 10[279 x 254]
11 x 11[279 x 279]
MOTOR H.P. [W]–TYPE 1/4 [187]-4-PSC 1/2 [373]-4-PSC 1/2 [373]-4-PSC 3/4 [559]-4-PSC 3/4 [559]-4-PSC 3/4 [559]-4-PSC
MOTOR FULL LOAD AMPS 4.0 6.8 6.8 8.3 8.3 8.3HEATING SPEED MED-HIGH MED-HIGH MED-HIGH MED-HIGH MED-HIGH MED-HIGHCOOLING SPEED HIGH HIGH HIGH HIGH HIGH HIGHMINIMUM EXT. STATICPRESSURE (IN. W.C.) [kPa] .18 [.045] .20 [.050] .23 [.057] .28 [.070] .28 [.070] .28 [.070]
MAXIMUM EXT. STATICPRESSURE (IN. W.C.) [kPa] 0.8 [0.19] 0.8 [0.19] 0.8 [0.19] 0.8 [0.19] 0.8 [0.19] 0.8 [0.19]
HEATING CFM @ .2" [.049 kPa]W.C. E.S.P. [L/s] 1049 [494] 1139 [537] 1211 [571] 1704 [804] 1748 [825] 1750 [825]
COOLING CFM @ .5" [.124 kPa]W.C. E.S.P. [L/s] 1121 [528] 1232 [581] 1318 [622] 1742 [822] 1782 [841] 1934 [912]
TEMPERATURE RISE-HIGH FIRERANGE IN DEGREES °F [°C]
25 - 55[14 -31]
35 - 65[19 - 36]
40 - 70[22 - 39]
35 - 65[19 - 36]
35 - 65[19 - 36]
45 - 75[25 - 42]
APPROX. SHIPPING WEIGHT(LBS.) [kg] 123.5 [56] 128 [58] 132 [60] 147.5 [67] 152 [69] 165 [75]
AFUE ➂ 95.00% 95.00% 95.00% 95.00% 95.00% 95.00%NOTES: All models are 115V, 60HZ, 1 phase Gas connection size for all models is 1/2" [13 mm] N.P.T.
➀ Installation instructions for high altitude derate.➁ Canadian installations only.➂ In accordance with D.O.E. test procedures.*S=Standard Models
NOTE: Standard model complies with California low nox requirements.
[ ] Designates Metric Conversions
AirModel Number IdentificationR95P Series
5
Model Number Identification
R 95 P A 040 1 3 17 M S A
Rheem Series95%
Efficient
Motor -PSC
Design SeriesA = 1st Design
InputBTU/HR
040 = 42,000 [12.31 kW]060 = 56,000 [16.41 kW]070 = 70,000 [20.51 kW]085 = 84,000 [24.62 kW]100 = 98,000 [28.72 kW]115 = 112,000 [32.82 kW]
Stage - Single Airflow3 - Up to 3 Tons5 - Up to 5 Tons
Cabinet Width17 = 17.5"21 =21.0"24 =24.5"
Configuration - Multi-Position
S = Standard Revision -Marketing
(A - First TimeRelease)
—
[ ] Designates Metric Conversions
AirDimensional DataR95P Series
6
MODELR95P
LEFTSIDE
MINIMUM CLEARANCE (IN.) [mm]SHIP
WGTS.
FLANGE DIMENSIONSRIGHTSIDE BACK TOP FRONT VENT A B C
040 0 0 0 1 [25] 2 [51] 0 123.5 [56] 171/2 [445] 1617/64 [413] 1613/64 [412]060 0 0 0 1 [25] 2 [51] 0 128 [58] 171/2 [445] 1617/64 [413] 1613/64 [412]070 0 0 0 1 [25] 2 [51] 0 132 [60] 171/2 [445] 1617/64 [413] 1613/64 [412]085 0 0 0 1 [25] 2 [51] 0 147.5 [67] 21 [533] 1949/64 [502] 1945/64 [500]100 0 0 0 1 [25] 2 [51] 0 152 [69] 21 [533] 1949/64 [502] 1945/64 [500]115 0 0 0 1 [25] 2 [51] 0 165 [75] 241/2 [662] 2317/64 [591] 2313/64 [589]
UNIT DIMENSIONS(CLEARANCE TO COMBUSTIBLES)
UNIT DIMENSIONS(CLEARANCE TO COMBUSTIBLES)
*A service clearance of at least 24" is recommended in front of all furnaces [ ] Designates Metric ConversionsSupply and return depicted as upflow configuration.Flange configuration will vary depending on installation orientation.
AirBlower Performance DataR95P Series
7
MODELBLOWER
SIZE[mm]
MOTORH.P.[W]
BLOWERSPEED
CFM [L/s] AIR DELIVERYEXTERNAL STATIC PRESSURE INCHES WATER COLUMN [kPa]
0.1 [.02] 0.2 [.05] 0.3 [.07] 0.4 [.10] 0.5 [.12] 0.6 [.15] 0.7 [.17] 0.8 [.19]
R95PA0401317
11 x 7[279 x 178]
1/4[187]
LOWMED-LOMED-HI*
HIGH
732 [345]875 [413]
1073 [506]1279 [603]
695 [328]845 [399]
1049 [495]1239 [584]
669 [316]820 [387]
1004 [474]1213 [572]
639 [301]792 [374]975 [460]
1174 [554]
605 [285]766 [361]943 [445]
1121 [529]
547 [258]726 [342]900 [425]
1069 [504]
512 [242]659 [311]864 [408]
1033 [487]
487 [230]605 [286]798 [376]980 [462]
R95PA0601317
11 x 8[279 x 203]
1/2[373]
LOWMED-LOMED-HI*
HIGH
830 [392]940 [443]
1168 [551]1421 [670]
793 [374]908 [428]
1139 [537]1385 [653]
755 [356]875 [413]
1109 [523]1349 [636]
705 [333]821 [387]
1060 [500]1291 [609]
654 [308]766 [361]
1010 [476]1232 [581]
599 [283]710 [333]942 [444]
1147 [541]
544 [257]653 [308]874 [412]
1062 [501]
496 [234]584 [275]802 [378]976 [460]
R95PA0701317
11 x 8[279 x 203]
1/2[373]
LOWMED-LOMED-HI*
HIGH
852 [402]986 [465]
1238 [584]1493 [704]
827 [390]955 [450]
1211 [571]1452 [685]
802 [378]923 [435]
1183 [558]1410 [665]
752 [355]883 [417]
1139 [537]1364 [643]
701 [331]843 [398]
1094 [516]1318 [622]
662 [312]790 [373]
1036 [489]1257 [593]
623 [294]737 [348]978 [461]
1195 [564]
580 [274]686 [324]897 [423]
1084 [511]
R95PA0851521
11 x 10[279 x 254]
3/4[559]
LOWMED-LOMED-HI*
HIGH
1313 [619]1488 [702]1732 [817]1983 [935]
1275 [601]1452 [685]1704 [804]1929 [910]
1236 [583]1415 [667]1676 [791]1874 [884]
1221 [576]1384 [653]1630 [769]1810 [854]
1184 [558]1328 [626]1579 [745]1742 [822]
1141 [538]1279 [603]1498 [707]1663 [784]
1098 [518]1229 [580]1417 [668]1583 [747]
1053 [497]1170 [552]1343 [633]1477 [697]
R95PA1001521
11 x 10[279 x 254]
3/4[559]
LOWMED-LOMED-HI*
HIGH
1329 [627]1535 [724]1796 [847]2019 [952]
1313 [619]1498 [707]1748 [825]1961 [925]
1296 611]1461 [689]1700 [802]1903 [898]
1260 [594]1422 [671]1656 [781]1843 [869]
1224 [577]1382 [652]1612 [760]1782 [841]
1171 [552]1325 [625]1536 [725]1687 [796]
1117 [527]1268 [598]1460 [689]1592 [751]
1049 [495]1203 [567]1370 [646]1489 [702]
R95PA1151524
11 x 11[279 x 279]
3/4[559]
LOWMED-LOMED-HI*
HIGH
1249 [589]1440 [679]1770 [835]2123 [1001]
1234 [582]1429 [674]1750 [825]2077 [980]
1219 [575]1417 [668]1730 [816]2031 [958]
1183 [558]1381 [651]1696 [800]1983 [935]
1146 [541]1344 [634]1662 [784]1934 [912]
1112 [525]1313 [619]1611 [760]1856 [875]
1078 [508]1281 [604]1559 [735]1777 [838]
1017 [480]1221 [576]1463 [690]1665 [785]
*Factory setting for heat all grey cells are valid heating settings. Do not use speed tabs and/or static pressure which do not fall into the grey cells on this table.NOTE: Unit tested without filters.
[ ] Designates Metric Conversions.
AirAccessoriesR95P Series
8
*Filter racks are shipped without filters.Filters shipped with furnace may be used or a suitable 1" [25.4 mm] filter.
FILTER RACK FILTER SIZES* INCHES [mm]
MODELRXGF-CB(UPFLOW/
HORIZONTAL)
RXGF-CD(UPFLOW)
RXGF-CC(DOWNFLOW)
R95PA040 153/4 x 25[400 x 635]
153/4 x 25[400 x 635]
14 x 20[356 x 508]
R95PA060 153/4 x 25[400 x 635]
153/4 x 25[400 x 635]
14 x 20[356 x 508]
R95PA070 153/4 x 25[400 x 635]
153/4 x 25[400 x 635]
14 x 20[356 x 508]
R95PA085 191/4 x 25[489 x 635]
153/4 x 25[400 x 635]
14 x 20[356 x 508]
R95PA100 191/4 x 25[489 x 635]
153/4 x 25[400 x 635]
14 x 20[356 x 508]
R95PA115 223/4 x 25[578 x 635]
153/4 x 25[400 x 635]
14 x 20[356 x 508]
FOR HIGH ALTITUDES:NOTE: For Canadian installations only, an optional derate (manifold
gas pressure reduction) method may be used to adjust thefurnace for altitude. See Installation Instructions for moreinformation. This optional method may NOT be used for U.S.installations. See installation instructions as appropriate orificechange is required.
L.P. CONVERSION KIT: RXGJ-FP33
CONDENSATE PUMP KIT: PROSTOCK & 1PCB151TUL
DOWNFLOW/HORIZONTAL CONVERSION KIT: RXGY-CK
DOWNFLOW/HORIZONTAL LEFT ZERO CLEARANCE CONVERSION KIT: RXGY-ZK
COMBUSTIBLE FLOOR BASE: RXGC-B17RXGC-B21RXGC-B24
[ ] Designates Metric Conversions
INDOOR COIL CASINGSMODEL
NUMBER
RXBC-D17A1RXBC-D21A1RXBC-D21B1RXBC-D24A1
VENT TERMINATION KITS: =RXGY-E02: Vertical/Horizontal Concentric Vent Termination Kit 2" Pipe (US Only)
RXGY-E02A: Vertical/Horizontal Concentric Vent Termination Kit 2" Pipe (US & Canadian)
RXGY-E03: Vertical/Horizontal Concentric Vent Termination Kit 3" Pipe (US Only)
RXGY-E03A: Vertical/Horizontal Concentric Vent Termination Kit 3" Pipe (US & Canadian)
RXGY-G02: Direct Vent Furnace Side Wall Vent 2" or 3" (US Only)
RXGY-D05: Combustion Air Drain Kit 2"
RXGY-D06: Combustion Air Drain Kit 3"
NEUTRALIZER KIT: RXGY-A01 (Replacement Cartridge 54-22120-01)
EXTERNAL BOTTOM FILTER (UPFLOW/HORIZONTAL) RACK:RXGF-CB
EXTERNAL SIDE (UPFLOW) FILTER RACK: RXGF-CD
EXTERNAL (DOWNFLOW) FILTER RACK: RXGF-CC
AirLimited WarrantyR95P Series
9
GENERAL TERMS OF LIMITED WARRANTY*Rheem will furnish a replacement for any part of this productwhich fails in normal use and service within the applicableperiod stated, in accordance with the terms of the limited warranty.*For complete details of the Limited and Conditional Warranties, includingapplicable terms and conditions, contact your local contractor or theManufacturer for a copy of the product warranty certificate.
Conditional Parts(Registration Required) ...............................Ten (10) Years
Heat Exchanger .........................................Limited Lifetime
AirNotesR95P Series
10
AirNotesR95P Series
11
The new degree of comfort.™
Rheem Heating, Cooling & Water Heating • P.O. Box 17010 Fort Smith, Arkansas 72917 • www.rheem.com
In keeping with its policy of continuous progress and product improvement, Rheem reserves the right to make changes without notice.
PRINTED IN U.S.A 05/16 QG FORM NO. G11-537 REV. 2
Rheem Canada Ltd./Ltée • 125 Edgeware Road, Unit 1Brampton, Ontario • L6Y 0P5