SA-SC8/WS8/SS-CT8/TS8 - Diagramasde.comdiagramasde.com/diagramas/audio/SA-SC8 WS8 SS-CT8 TS8...

SA-SC8/WS8/SS-CT8/TS8US Model

Canadian ModelAEP Model

UK ModelE Model

Australian Model

SERVICE MANUAL

SUBWOOFER/SPEAKER SYSYTEMSony CorporationAudio Group

Published by Sony Engineering Corporation

9-961-138-022004I16-1

© 2004.09

• SA-SC8 is composed of following models.

SPECIFICATIONS

Ver 1.1 2004. 09

SA-SC8

FRONT and SURROUND speakers SS-TS8

CENTER speaker SS-CT8

SUBWOOFER SA-WS8

SA-WS8• SA-SC8 is the speaker section in

DAV-FC9/SC8.

Front/SurroundSpeaker system Bass reflexSpeaker unit 70 mm dia. cone type × 2,

25 mm dia. balance domeRated impedance 4 ohmsDimensions (approx.) 250 × 1196 × 250 mm

(w/h/d, Max size with the stand)250 × 646 × 250 mm(w/h/d, Min size with the stand)

Mass (approx.) 3.62 kg

CentreSpeaker system Bass reflexSpeaker unit 70 mm dia. cone type × 2,

25 mm dia. balance domeRated impedance 4 ohmsDimensions (approx.) 379 × 125 × 85 mm

(w/h/d, with the stand)Mass (approx.) 1.07 kg

SubwooferSpeaker system Active subwoofer,

Magnetically shieldedSpeaker unit 20 cm dia. cone typeEnclosure type Advanced SAW type

Amplifier sectionContinuous RMS power output

135 W (8 ohms, 20 Hz -20 kHz, 10% THD)

Power requirements

Australian and Asian models:220 – 240 V AC, 50/60 Hz

Taiwan model: 120 V AC, 50/60 HzOther models: 110 – 120 V/220 – 240 V

AC, 50/60 Hz Power consumption 90 W, 1 W (standby mode)Dimensions (approx.) 230 390 475 mm

(w/h/d) incl. front grilleMass (approx.) 14.5 kg

Design and specifications are subject to change without notice.

EXCEPT US and Canadian models:

120 V AC, 60 HzUS and Canadian models:

150 W (6 ohms,US and Canadian models:20 Hz – 20kHz, 10% THD)

SS-CT8 SS-TS8

SA-SC8/WS8/SS-CT8/TS8

2

TABLE OF CONTENTS

1. DIAGRAMS1-1. CIRCUIT BOARDS LOCATION (SA-WS8) .............. 31-2. PRINTED WIRING BOARDS (SA-WS8) ................... 51-3. SCHEMATIC DIAGRAM (SA-WS8) .......................... 6

2. EXPLODED VIEWS2-1. SS-CT8 (OVER ALL SECTION) ··································· 72-2. SS-TS8 (OVERALL SECTION) ···································· 82-3. SS-TS8 (STAND SECTION) ········································· 92-4. SA-WS8 (OVERALL SECTION) ································ 102-5. SA-WS8 (AMP SECTION) ·········································· 11

3. ELECTRICAL PARTS LIST ········································· 12

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTEDLINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMSAND IN THE PARTS LIST ARE CRITICAL TO SAFEOPERATION. REPLACE THESE COMPONENTS WITH SONYPARTS WHOSE PART NUMBERS APPEAR AS SHOWN INTHIS MANUAL OR IN SUPPLEMENTS PUBLISHED BYSONY.

ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!!

LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LESDIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONTCRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NEREMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONYDONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OUDANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

To Exposed MetalParts on Set

0.15µF 1.5kΩACvoltmeter(0.75V)

Earth Ground

Fig. A. Using an AC voltmeter to check AC leakage.

SAFETY CHECK-OUT

After correcting the original service problem, perform the followingsafety check before releasing the set to the customer:Check the antenna terminals, metal trim, “metallized” knobs, screws,and all other exposed metal parts for AC leakage. Check leakage asdescribed below.

LEAKAGE TEST

The AC leakage from any exposed metal part to earth ground andfrom all exposed metal parts to any exposed metal part having areturn to chassis, must not exceed 0.5 mA (500 microamperes).Leakage current can be measured by any one of three methods.

1. A commercial leakage tester, such as the Simpson 229 or RCAWT-540A. Follow the manufacturers’ instructions to use theseinstruments.

2. A battery-operated AC milliammeter. The Data Precision 245digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of a VOMor battery-operated AC voltmeter. The “limit” indication is 0.75V, so analog meters must have an accurate low-voltage scale. TheSimpson 250 and Sanwa SH-63Trd are examples of a passiveVOM that is suitable. Nearly all battery operated digitalmultimeters that have a 2V AC range are suitable. (See Fig. A)

3


1-1. CIRCUIT BOARDS LOCATION (SA-WS8)

SECTION 1DIAGRAMS

AUTO POWER board

MAIN board

POWER board

LED board

POWER SWITCH board

CONTROL board


4

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• 2 : nonflammable resistor.• 5 : fusible resistor.• C : panel designation.

Note:The components identi-fied by mark 0 or dottedline with mark 0 are criti-cal for safety.Replace only with partnumber specified.

Note:Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepiéce por tant le numérospécifié.

• A : B+ Line.• B : B– Line.• Voltage is dc with respect to ground under no-signal

(detuned) condition.• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Signal path.F : AUDIO

• AbbreviationCND : Canadian model.

Note on Printed Wiring Boards:• X : parts extracted from the component side.• : Pattern from the side which enables seeing.

Ref. No. LocationD201 I-4D202 H-4D303 E-3D304 E-3D305 F-6D306 D-8D501 C-8D502 E-8D503 E-8D504 E-8D505 E-8D506 F-7D507 E-7D601 I-7D602 I-7D603 J-7D604 I-7D605 H-7D606 G-7(D607) J-9<D608> G-8D701 B-5D702 C-5D703 C-5D704 C-5D801 E-10

IC101 C-3IC102 C-2IC104 C-5IC201 H-3IC202 H-1IC203 H-3IC204 H-4IC301 E-2IC701 B-6

Q101 C-1Q301 E-3Q302 E-2Q303 E-2Q304 D-2Q305 D-3Q306 D-3Q307 D-3Q308 E-7Q309 F-6Q310 E-6Q311 E-6Q401 J-3Q402 J-3Q403 J-2Q404 J-5Q501 F-7Q502 E-7Q601 H-7Q602 G-7Q701 B-5Q702 C-6Q703 A-7Q704 A-7Q705 A-7

• SemiconductorLocation

( ) : Except E model< > : E model

55


1

A

B

C

D

E

F

G

H

I

J

2 3 4 5 6 7 8 9 10 11 12 13 14

JW61

R201

CN201

C201

R202

JW64

R221

IC201

IC30

1

IC10

2

IC10

1

IC10

4

IC70

1S7

01

IC203IC204

JW59

C213

JW57

C211 C212

R215

R217

R214

D201R210

JW60

C209

R209

R211

R220 R2

19C2

14

C210

D202

R218 R2

16

R407

Q404

C401

JW56

R406

R404

CN401

Q401Q403

Q402JW55

R405

R402

R401

R403

JW58

R212

R213

C208

RV201

1 5

R205

S201

S201MODE LEVELMUSIC

MOVIE

C204

R208 IC202

C207

R203

C203

R206

C206

C314

R302

C301

R301

R331 R3

32R3

04

R328

R327

C313

R326

R325

C312

JW48

JW32

Q306

Q301

D304

D303

R311

Q302C308

Q303

JW29 JW

30JW

46C3

03 R305

R307

R329

R313

C311

RY301

RY602

T601POWER TRANSFORMER

RY601

D608

R602

C602

JW60

4

JW60

1JW

602

C5

F601

F602

C2

C1

D605

D601

D602

JW60

6

R335

C315

JW50

Q310

Q309

Q311

JW39

JW27

JW26

JW38

R704

R707

R706

Q703

Q704

Q705

R710

D501

R708

JW37

JW25

Q702

JW36

CN502

R141

C118

JW24

JW23

JW22

Q307

R310

R314

Q305

Q304

Q101

R309

R119

C108

J101

IN POWERSAVE

S701LINE

C105

R115

R117

C106R1

13

R123

R122

R126

C111

R125

CN10

1

C110

R124

JW20

R120

C109

R121

JW1R114

C104

R308C511C512

C304

C305

JW21

R118

C107

R116

JW6

JW7

JW8

C307

D701 Q7

01

C701

JW13

JW11JW12 C515

JW10R703

R702R705

R711

R709JW3C516

R701

C513C514

R139

R317

R318

JW9

D702D703D704

JW40

JW41

Q502

JW54

Q501

Q308

R338

R337

C316

D506

D507 C5

08 R504

JW51

C506

C505

D503

D502

CN50

1

T501POWER TRANSFORMER

D505

D306

C503

C606

D606

C604

R601

C601

D604D603

D607

Q601JW609

JW608

C3

CN604

CNT1

CNT2

CN602

AC IN

CN601

JW605

JW600

S601VOLTAGE

SELECTOR

C4

CN605

C605

C603C5

04

R336

Q602

CN701

D504

R503

C317

R340

R339

JW34

JW35

JW33

R320

CN30

1

R330

JW47

R316R312

R324

R315

R306

C306

R323

R322

R321

R333

R303

JW53

C309

JW49

R319

R341

D305

C509 C507

R502

R501

JW52

C501

C502

JW42

JW45

JW44

JW43

JW28

JW15JW19JW14JW18

JW17

JW16

JW5

JW4

C510CN302

C310

C202

R204

JW63

R207JW62

C205

POWER BOARD

MAIN BOARD

CONTROL BOARD AUTO POWER BOARD

13

3 1

1

4

8

5

1

4

8

5

1

4

8

5

1

4

8

5

1

4

8

5

2 1

1

1

5

1 4

6

3

1

2

1

1

2

1

2

4 1

1-680-784- (11)

11

1-684-522- (11)

11

1-680-785-

(11)

11

1-680-786- (11)

111-680-789- (11)

11

1-684-553- (11)

11

8 5

1 4

8 5

1 4

8

6 1

5

1 4 8 5

1 4

LED BOARD

S1POWER

D801ON/STANDBY

CN1

CN801 D801

POWER SWITCH BOARD

(CHASSIS)

(CHASSIS)

1

3

SP5SPEAKER

BLK

+–

RED

BLU

BRN

AUTO OFF

~~

4

5

6

2

3

1

1 2 3

6 5 4

E MODELE MODEL

EXCEPT E MODEL

1-2. PRINTED WIRING BOARDS (SA-WS8) • Refer to page 3 for Circuit Boards Location.

66


1-3. SCHEMATIC DIAGRAM (SA-WS8)

-LK -OPY-M

-OPY-M-FEK

-TP

-72

-72

-FEK

-72

-72

-TP

-TP

-TP

-TK

-NTA2B

-NTA2B

-NTA2B

2SA1015TP-Y

-TK

-TPE2

E MODEL-72

(E)(EXCEPT US,CND,E)

E

E-72

E

-72 -72-F

-P

-F-TP

-TPE2-NTA2B

-NTA2B

-NTA2B

-NTA2B

-Y

MTZJ-T-77-15B

MTZJ-T-77-15B

-F

1M

-O

-72

-72

-P

-P -P

-F -F

-O

-72

-72

-NTA2B

R122C108

R118

R116

C106

R115

C104R114

C105R113

R306

R307

Q303Q302

R308C305

C304

R309 R310 R318

R315

R701

R705

R706

R704

R707

R711

Q308

Q309

Q310

R317

C118R139

R305

R123

R312

R311

CN502

CN302

C317R340

R339

R338

R337

R336

C311

R319

R335

C315

R703C701

D701

C107

C307

C308

R702S701

CN701

R709

IC701(1/2)

IC701(2/2)

R314

Q306

Q305Q304

R404

R405

R403

R402

R401

R406

R407

C511 C110R124 R125

R126

C512

R304

R333

R332 R331

R303

C301 R302 C314

R330

R329

R301

R324

R328 C313

R327 R326 R325

C312R322

R323

R321

R313

CN501

R501

R502

C501

C502

C503

C504

R503

R504

C507

C508

C509

C510

Q101

CN301

CN101

CN801

C201 R202

R201C202 C203

R203

R204

C204

R205

S201

CN201

C211 C213C212

C214

C205 C206

IC202(1/2)

IC202(2/2)

C207

R208

RV201C208

R209

R211

R212

R210 R213

R214

R215

R216

IC204(1/2)

IC204(2/2)

R219 R220

C210

C209

R221

IC203(1/2)

IC203(2/2)

R218

R217

R117

R141

C303

C309

Q301

C306

R316

R119

C109

R120

R121

R320R341

C316

D506

D507

R708R710

IC104

Q307

CN401

Q404

Q403

SP5

CN604

R601

R602

CN605

CN1

S1

C601

C602

C605

C606

CN601

C604

C603

CN602

C2

C1

C5

C513 C5

15

C514

C516

J101 IC101

IC301(1/2)IC301(2/2)

D303

D304

C310

Q401

Q402

C401

IC102(1/2)

IC102(2/2)

C111

Q311 D306 D305

C505

C506

Q501

Q502

D502

D503

D504

D505

T501

Q701

D702

Q702

D703

D704

Q703

Q705

Q704

D801

D605

D606

D601

D602

D603

D604

Q601

Q602

D202

D201

R206

IC201

R207

RY601

T601

F601

JW604

JW600

JW605

JW608

JW609

RY602

JW60

2

JW60

1

S601

D607

D608

C4

C3

RY301

D501

F602

7


1 X-4955-909-1 FRAME ASSY, GRILLE (EXCEPT AEP, UK)1 X-4956-030-1 FRAME ASSY, GRILLE (AEP, UK)2 4-249-787-01 BUFFLE PANEL(CENTER)3 4-249-784-01 SPEAKER CABINET (CT)4 1-694-836-11 TERMINAL, SPEAKER

5 4-249-793-01 STAND (CT)(EXCEPT AEP, UK)

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

5 4-251-101-01 STAND (CT)(AEP, UK)6 4-246-659-01 FOOT (STAND)SP1 1-825-592-11 SPEAKER (7cm)SP2 1-825-591-11 SPEAKER (1.5cm)#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 TT(B)

2-1. SS-CT8 (OVER ALL SECTION)

NOTE:• The mechanical parts with no reference

number in the exploded views are not supplied.• Items marked “*” are not stocked since they

are seldom required for routine service.Some delay should be anticipated when or-dering these items.

• -XX, -X mean standardized parts, so they mayhave some differences from the original one.

• A bbreviationAUS : Australian modelCND : Canadian modelEA : Saudi Arabia modelRU : Russian model

1

#1

#1

#1

#1

#1

#1

#1

#1

SP1

SP2

SP1

2

3

4

not supplied

not supplied

5

6

6

SECTION 2EXPLODED VIEWS

The components identified by mark 0 ordotted line with mark 0 are critical for safety.Replace only with part number specified.

Les composants identifiés par une marque0 sont critiques pour la sécurité.Ne les remplacer que par une pièce portantle numéro spécifié.


8


51 X-4955-907-1 FRAME ASSY, GRILLE52 4-249-757-01 BUFFLE PANEL(FRONT)53 4-249-754-01 SPEAKER CABINET (FR)54 1-694-836-11 TERMINAL, SPEAKER55 4-249-758-01 TERMINAL BASE (FR)

56 4-251-125-01 SCREW (M5X35)57 4-250-938-01 SCREW 3X10 +PTP

58 4-249-768-01 COVERSP3 1-825-592-11 SPEAKER (7cm)SP4 1-825-591-11 SPEAKER (1.5cm)#8 7-685-548-19 SCREW +BTP 3X12 TYPE2 N-S#9 7-685-535-14 SCREW +BTP 2.6X10 TYPE2 N-S

#10 7-685-547-19 SCREW +BTP 3X10 TYPE2 N-S

2-2. SS-TS8 (OVERALL SECTION)

#8

#8

#9

51

52

53

54

56

58

55

57

stand section

SP3

SP4

SP3

#10

#10

#10

#10

#10#10

#10

57

57

Ver 1.1

9


2-3. SS-TS8 (STAND SECTION)


101 4-246-659-01 FOOT (STAND)102 4-249-764-01 POLE103 4-249-769-01 CATCHER

#2 7-682-553-09 SCREW +B 3X20#3 7-682-247-04 SCREW +K 3X6

#3

#3#3

103

102

not supplied

not supplied

not supplied

101

101

101101

101

#2

101


10

2-4. SA-WS8 (OVERALL SECTION)


151 4-250-555-01 PANEL (R), ORNAMENTAL152 4-250-554-01 PANEL (L), ORNAMENTAL153 4-250-556-01 PANEL (T), ORNAMENTAL154 X-4955-975-1 FRAME ASSY, GRILLE155 X-4955-974-1 PANEL ASSY, FRONT

156 4-874-614-21 SCREW (1)(3.5X14), TAPPING157 4-874-614-51 SCREW (1)(3.5X20), TAPPING158 4-874-614-71 SCREW159 4-227-298-01 SHEET160 4-250-551-01 KNOB (VOL)

161 1-684-552-11 LED BOARD162 4-250-552-01 KNOB, PUSH163 1-684-553-11 POWER SWITCH BOARD164 1-680-785-11 CONTROL BOARD165 4-231-866-01 PACKING

SP5 1-529-296-11 SPEAKER (20cm)(EXCEPT US, CND)SP5 1-825-151-11 SPEAKER (20cm)(US, CND)#1 7-685-647-79 SCREW +P 3X10 TYPE2 NON-SLIT#4 7-682-546-04 SCREW +P 3X5#5 7-685-664-79 SCREW +P 4X20 TYPE1

165

155

152

151

153

154

SP5

not supplied

not supplied

159

160

163

156

156157

157

158

162

161

164

#1

#5

#5

#4

not supplied

amp section

11


2-5. SA-WS8 (AMP SECTION)


201 4-235-237-01 FOOT202 1-680-789-11 AUTO POWER BOARD203 1-680-786-11 POWER BOARD204 3-905-609-01 SCREW (TRANSISTOR)

0205 1-696-570-21 CORD, POWER (UK)

0205 1-696-845-31 CORD, POWER (AUS)0205 1-769-744-52 CORD, POWER (AEP, E , EA, RU)0205 1-783-531-11 CORD, POWER (US, CND)* 206 3-703-244-00 BUSHING (2104), CORD

207 A-4747-847-A MAIN BOARD, COMPLETE

208 A-4713-147-A CABINET ASSY, SPEAKER (US, CND)208 A-4741-412-A CABINET ASSY, SPEAKER (EXCEPT US, CND)

0F601 1-532-463-31 FUSE (T1AL/250V)(EXCEPT US, CND, E)0F601 1-532-501-31 FUSE (T0.8AL/250V)(E)0F601 1-533-418-11 FUSE, GLASS CYLINDRICAL(DIA.5)

(2.5A/125V)(US, CND)

0F602 1-532-503-31 FUSE (T1.6AL/250V)(E)0T501 1-435-999-11 TRANSFORMER, POWER (US, CND)0T501 1-437-219-12 TRANSFORMER, POWER (E)0T501 1-437-246-11 TRANSFORMER, POWER

(EXCEPT US, CND, E)0T601 1-435-993-11 TRANSFORMER, POWER (US, CND)

0T601 1-435-994-11 TRANSFORMER, POWER(EXCEPT US, CND, E)

0T601 1-435-995-11 TRANSFORMER, POWER (E)#1 7-685-647-79 SCREW +P 3X10 TYPE2 NON-SLIT#6 7-685-660-19 SCREW +BVTP 4X10 TYPE2 N-S#7 7-685-663-79 SCREW +BVTP 4X16 TYPE2 N-S

201 208

201

202

203

204

207206

T501

not supplied

not supplied

not supplied

not supplied

not supplied

not supplied

not supplied

F601

F602

205

T601

#7

#7#7

#7

#6

#6

#1

#1

#1

#1

#1

#1

#1

#1#1#1

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numéro spécifié.

NOTE:• Due to standardization, replacements in the

parts list may be different from the partsspecified in the diagrams or the componentsused on the set.

• - XX, -X mean standardized parts, so they mayhave some difference from the original one.

• Items marked “*” are not stocked since theyare seldom required for routine service. Somedelay should be anticipated when orderingthese items.

• CAPACITORS:uF: µF

• COILSuH: µH

• RESISTORSAll resistors are in ohms.METAL: metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF: nonflammable

• SEMICONDUCTORSIn each case, u: µ, for example:uA...: µA... , uPA... , µPA... ,uPB... , µPB... , uPC... , µPC... ,uPD..., µPD...

When indicating parts by reference number,please include the board name.

The components identified by mark 0 ordotted line with mark 0 are critical for safety.Replace only with part number specified.

Les composants identifiés par une marque0 sont critiques pour la sécurité.Ne les remplacer que par une pièce portantle numéro spécifié.

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks

12

SECTION 3ELECTRICAL PARTS LIST


• A bbreviationAUS : Australian modelCND : Canadian modelEA : Sudi Arabia modelRU : Russian model

1-680-789-11 AUTO POWER BOARD******************

1-533-217-11 FUSE HOLDER

< CAPACITOR >

0C2 1-113-925-11 CERAMIC 0.01uF 20.00% 250V0C3 1-113-925-11 CERAMIC 0.01uF 20.00% 250V

(EXCEPT E)0C4 1-113-925-11 CERAMIC 0.01uF 20.00% 250V (E)0C5 1-113-924-11 CERAMIC 0.0047uF 20.00% 250V

C601 1-104-666-11 ELECT 220uF 20.00% 25V

C602 1-104-666-11 ELECT 220uF 20.00% 25VC603 1-126-964-11 ELECT 10uF 20.00% 50VC604 1-126-964-11 ELECT 10uF 20.00% 50VC605 1-126-964-11 ELECT 10uF 20.00% 50VC606 1-126-964-11 ELECT 10uF 20.00% 50V

< CONNECTOR >

* CN601 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2PCN602 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P

* CN604 1-564-687-11 PIN, CONNECTOR (3.96mm PITCH) 3PCN605 1-564-507-11 PLUG, CONNECTOR 4P

< DIODE >

D601 8-719-024-99 DIODE 11ES2-NTA2BD602 8-719-024-99 DIODE 11ES2-NTA2BD603 8-719-024-99 DIODE 11ES2-NTA2BD604 8-719-024-99 DIODE 11ES2-NTA2BD605 8-719-068-42 DIODE HZ13BP-TK

D606 8-719-068-42 DIODE HZ13BP-TKD607 8-719-991-33 DIODE 1SS133T-72 (EXCEPT E)D608 8-719-991-33 DIODE 1SS133T-72 (E)

< TRANSISTOR >

Q601 8-729-205-11 TRANSISTOR 2SC1815Y-TPE2Q602 8-729-231-13 TRANSISTOR 2SA1015TP-Y

< RESISTOR >

R601 1-247-843-11 CARBON 3.3K 5% 1/4WR602 1-247-843-11 CARBON 3.3K 5% 1/4W

< RELAY >

0RY601 1-755-458-11 RELAY (EXCEPT E)0RY602 1-755-458-11 RELAY (E)

< SWITCH >

0S601 1-771-474-11 SWITCH, POWER (VOLTAGE CHANGE)(VOLTAGE SELECTOR)(E)

************************************************************

1-680-785-11 CONTROL BOARD**************

< CAPACITOR >

C201 1-130-475-00 MYLAR 0.0022uF 5% 50VC202 1-131-697-31 FILM 0.27uF 5% 50VC203 1-131-697-31 FILM 0.27uF 5% 50VC204 1-126-964-11 ELECT 10uF 20.00% 50VC205 1-131-697-31 FILM 0.27uF 5% 50V

C206 1-131-697-31 FILM 0.27uF 5% 50VC207 1-126-964-11 ELECT 10uF 20.00% 50VC208 1-126-964-11 ELECT 10uF 20.00% 50VC209 1-131-695-11 FILM 0.18uF 5% 50VC210 1-131-696-11 FILM 0.22uF 5% 50V

C211 1-126-964-11 ELECT 10uF 20.00% 50VC212 1-126-964-11 ELECT 10uF 20.00% 50VC213 1-164-159-21 CERAMIC 0.1uF 50VC214 1-164-159-21 CERAMIC 0.1uF 50V

< CONNECTOR >

* CN201 1-564-508-11 PLUG, CONNECTOR 5P

< DIODE >

D201 8-719-991-33 DIODE 1SS133T-77D202 8-719-991-33 DIODE 1SS133T-77

< IC >

IC201 8-759-145-58 IC BA4558IC202 8-759-145-58 IC BA4558IC203 8-759-145-58 IC BA4558IC204 8-759-145-58 IC BA4558

< RESISTOR >

R201 1-249-417-11 CARBON 1K 5% 1/4W FR202 1-249-429-11 CARBON 10K 5% 1/4WR203 1-247-843-11 CARBON 3.3K 5% 1/4WR204 1-249-438-11 CARBON 56K 5% 1/4WR205 1-249-429-11 CARBON 10K 5% 1/4W

R206 1-249-428-11 CARBON 8.2K 5% 1/4W F

AUTO POWER

CONTROL


13


R207 1-249-435-11 CARBON 33K 5% 1/4WR208 1-249-429-11 CARBON 10K 5% 1/4WR209 1-249-429-11 CARBON 10K 5% 1/4WR210 1-249-431-11 CARBON 15K 5% 1/4W

R211 1-249-421-11 CARBON 2.2K 5% 1/4W FR212 1-247-807-31 CARBON 100 5% 1/4WR213 1-249-429-11 CARBON 10K 5% 1/4WR214 1-249-424-11 CARBON 3.9K 5% 1/4W FR215 1-249-424-11 CARBON 3.9K 5% 1/4W F

R216 1-249-429-11 CARBON 10K 5% 1/4WR217 1-249-429-11 CARBON 10K 5% 1/4WR218 1-249-429-11 CARBON 10K 5% 1/4WR219 1-249-428-11 CARBON 8.2K 5% 1/4W FR220 1-249-428-11 CARBON 8.2K 5% 1/4W F

R221 1-247-807-31 CARBON 100 5% 1/4W

< VARIABLE RESISTOR >

RV201 1-225-826-11 RES, VAR, CARBON 20K (LEVEL)

< SWITCH >

S201 1-771-632-12 SWITCH, ROTARY (MODE)************************************************************

1-684-552-11 LED BOARD**********

< CONNECTOR >

* CN801 1-564-518-11 PLUG, CONNECTOR 3P

< DIODE >

D801 8-719-061-31 DIODE SML72420CTH8F (ON/STANDBY)************************************************************

A-4747-847-A MAIN BOARD, COMPLETE*********************

< CAPACITOR >

C104 1-162-286-21 CERAMIC 220PF 10.00% 50VC105 1-126-964-11 ELECT 10uF 20.00% 50VC106 1-162-215-31 CERAMIC 47PF 5% 50VC107 1-162-215-31 CERAMIC 47PF 5% 50VC108 1-131-694-31 FILM 0.15uF 5% 50V

C109 1-131-690-31 FILM 0.068uF 5% 50VC110 1-131-701-31 FILM 0.56uF 5% 50VC111 1-131-691-11 FILM 0.082uF 5% 50VC118 1-126-964-11 ELECT 10uF 20.00% 50VC301 1-131-679-31 FILM 0.01uF 5% 50V

C303 1-126-964-11 ELECT 10uF 20.00% 50VC304 1-162-282-31 CERAMIC 100PF 10% 50VC305 1-162-302-11 CERAMIC 0.0022uF 30.00% 16VC306 1-101-804-00 CERAMIC 10PF 5.00% 500VC307 1-101-810-00 CERAMIC 100PF 5.00% 500V

C308 1-126-934-11 ELECT 220uF 20.00% 10VC309 1-128-560-11 ELECT 22uF 20.00% 100VC310 1-128-560-11 ELECT 22uF 20.00% 100VC311 1-117-165-91 FILM 0.047uF 2.00% 100VC312 1-136-165-00 FILM 0.1uF 5% 50V

C313 1-130-471-00 MYLAR 0.001uF 5% 50VC314 1-131-688-31 FILM 0.047uF 5% 50VC315 1-126-934-11 ELECT 220uF 20.00% 10VC316 1-126-964-11 ELECT 10uF 20.00% 50VC317 1-126-948-11 ELECT 100uF 20.00% 35V

C501 1-117-162-91 FILM 0.01uF 2.00% 100VC502 1-117-162-91 FILM 0.01uF 2.00% 100VC503 1-135-782-11 ELECT CHIP 10000uF 20% 80VC504 1-135-782-11 ELECT CHIP 10000uF 20% 80VC505 1-104-666-11 ELECT 220uF 20.00% 25V

C506 1-104-666-11 ELECT 220uF 20.00% 25VC507 1-126-964-11 ELECT 10uF 20.00% 50VC508 1-126-964-11 ELECT 10uF 20.00% 50VC509 1-126-947-11 ELECT 47uF 20.00% 25VC510 1-126-947-11 ELECT 47uF 20.00% 25V

C511 1-164-159-21 CERAMIC 0.1uF 50VC512 1-164-159-21 CERAMIC 0.1uF 50VC513 1-126-964-11 ELECT 10uF 20.00% 50VC514 1-126-964-11 ELECT 10uF 20.00% 50VC515 1-164-159-21 CERAMIC 0.1uF 50V

C516 1-164-159-21 CERAMIC 0.1uF 50VC701 1-104-661-91 ELECT 330uF 20.00% 16V

< CONNECTOR >

* CN101 1-564-508-11 PLUG, CONNECTOR 5P* CN301 1-564-243-11 PIN, CONNECTOR (3.96mm PITCH) 6P

CN302 1-564-320-00 PIN, CONNECTOR (3.96mm PITCH) 2P* CN501 1-564-687-11 PIN, CONNECTOR (3.96mm PITCH) 3P

CN701 1-564-506-11 PLUG, CONNECTOR 3P

< DIODE >

D303 8-719-991-33 DIODE 1SS133T-72D304 8-719-991-33 DIODE 1SS133T-72D305 8-719-991-33 DIODE 1SS133T-72D306 8-719-991-33 DIODE 1SS133T-72D501 8-719-302-37 DIODE RBV-602

D502 8-719-024-99 DIODE 11ES2-NTA2BD503 8-719-024-99 DIODE 11ES2-NTA2BD504 8-719-024-99 DIODE 11ES2-NTA2BD505 8-719-024-99 DIODE 11ES2-NTA2BD506 8-719-110-41 DIODE MTZJ-T-77-15B

D507 8-719-110-41 DIODE MTZJ-T-77-15BD701 8-719-991-33 DIODE 1SS133T-72D702 8-719-991-33 DIODE 1SS133T-72D703 8-719-991-33 DIODE 1SS133T-72D704 8-719-991-33 DIODE 1SS133T-72

< IC >

IC101 8-759-145-58 IC BA4558IC102 8-759-145-58 IC BA4558IC104 8-759-145-58 IC BA4558IC301 8-759-145-58 IC BA4558IC701 8-759-145-58 IC BA4558

< JACK >

J101 1-770-377-31 JACK, PIN 1P (LINE)

CONTROL LED MAIN


14


< TRANSISTOR >

Q101 8-729-119-78 TRANSISTOR 2SC2785-FQ301 8-729-117-41 TRANSISTOR 2SA1174-PQ302 8-729-117-41 TRANSISTOR 2SA1174-PQ303 8-729-117-41 TRANSISTOR 2SA1174-PQ304 8-729-119-78 TRANSISTOR 2SC2785-F

Q305 8-729-119-78 TRANSISTOR 2SC2785-FQ306 8-729-214-51 TRANSISTOR 2SA1145-OQ307 8-729-270-51 TRANSISTOR 2SC2705-OQ308 8-729-119-78 TRANSISTOR 2SC2785-FQ309 8-729-178-41 TRANSISTOR 2SC2784-P

Q310 8-729-119-78 TRANSISTOR 2SC2785-FQ311 8-729-029-86 TRANSISTOR DTC124ESA-TPQ501 8-729-205-11 TRANSISTOR 2SC1815Y-TPE2Q502 8-729-231-13 TRANSISTOR 2SA1015TP-YQ701 8-729-029-86 TRANSISTOR DTC124ESA-TP

Q702 8-729-119-77 TRANSISTOR 2SA1175TP-FEKQ703 8-729-029-86 TRANSISTOR DTC124ESA-TPQ704 8-729-029-40 TRANSISTOR DTA124ESA-TPQ705 8-729-029-40 TRANSISTOR DTA124ESA-TP

< RESISTOR >

R113 1-249-417-11 CARBON 1K 5% 1/4W FR114 1-249-441-11 CARBON 100K 5% 1/4WR115 1-249-441-11 CARBON 100K 5% 1/4WR116 1-249-429-11 CARBON 10K 5% 1/4WR117 1-247-843-11 CARBON 3.3K 5% 1/4W

R118 1-249-429-11 CARBON 10K 5% 1/4WR119 1-249-418-11 CARBON 1.2K 5% 1/4W FR120 1-249-421-11 CARBON 2.2K 5% 1/4W FR121 1-249-439-11 CARBON 68K 5% 1/4WR122 1-249-417-11 CARBON 1K 5% 1/4W F

R123 1-249-435-11 CARBON 33K 5% 1/4WR124 1-249-424-11 CARBON 3.9K 5% 1/4W FR125 1-249-424-11 CARBON 3.9K 5% 1/4W FR126 1-247-807-31 CARBON 100 5% 1/4WR139 1-249-421-11 CARBON 2.2K 5% 1/4W F

R141 1-247-903-00 CARBON 1M 5% 1/4WR301 1-249-429-11 CARBON 10K 5% 1/4WR302 1-249-429-11 CARBON 10K 5% 1/4WR303 1-249-429-11 CARBON 10K 5% 1/4WR304 1-249-433-11 CARBON 22K 5% 1/4W

R305 1-249-438-11 CARBON 56K 5% 1/4WR306 1-249-411-11 CARBON 330 5% 1/4WR307 1-249-431-11 CARBON 15K 5% 1/4WR308 1-249-408-11 CARBON 180 5% 1/4W F

0R309 1-249-408-11 CARBON 180 5% 1/4W F

0R310 1-249-408-11 CARBON 180 5% 1/4W FR311 1-249-429-11 CARBON 10K 5% 1/4WR312 1-249-433-11 CARBON 22K 5% 1/4W

0R313 1-249-407-11 CARBON 150 5% 1/4W F0R314 1-249-401-11 CARBON 47 5% 1/4W F

R315 1-249-438-11 CARBON 56K 5% 1/4WR316 1-249-419-11 CARBON 1.5K 5% 1/4W F

0R317 1-249-393-11 CARBON 10 5% 1/4W F0R318 1-249-393-11 CARBON 10 5% 1/4W F0R319 1-249-393-11 CARBON 10 5% 1/4W F

0R320 1-217-156-00 METAL 0.22 10% 5WR321 1-249-435-11 CARBON 33K 5% 1/4WR322 1-249-429-11 CARBON 10K 5% 1/4WR323 1-249-415-11 CARBON 680 5% 1/4W FR324 1-249-417-11 CARBON 1K 5% 1/4W F

R325 1-249-417-11 CARBON 1K 5% 1/4W FR326 1-249-417-11 CARBON 1K 5% 1/4W FR327 1-249-429-11 CARBON 10K 5% 1/4WR328 1-249-430-11 CARBON 12K 5% 1/4WR329 1-249-421-11 CARBON 2.2K 5% 1/4W F

R330 1-249-425-11 CARBON 4.7K 5% 1/4W FR331 1-249-417-11 CARBON 1K 5% 1/4W FR332 1-249-431-11 CARBON 15K 5% 1/4WR333 1-249-420-11 CARBON 1.8K 5% 1/4W FR335 1-249-433-11 CARBON 22K 5% 1/4W

R336 1-249-430-11 CARBON 12K 5% 1/4WR337 1-249-438-11 CARBON 56K 5% 1/4WR338 1-249-441-11 CARBON 100K 5% 1/4WR339 1-249-441-11 CARBON 100K 5% 1/4WR340 1-249-433-11 CARBON 22K 5% 1/4W

0R341 1-216-458-11 METAL OXIDE 1.8K 5% 2W0R501 1-249-393-11 CARBON 10 5% 1/4W F0R502 1-249-393-11 CARBON 10 5% 1/4W F

R503 1-249-421-11 CARBON 2.2K 5% 1/4W FR504 1-249-421-11 CARBON 2.2K 5% 1/4W F

R701 1-249-441-11 CARBON 100K 5% 1/4WR702 1-249-417-11 CARBON 1K 5% 1/4W FR703 1-249-430-11 CARBON 12K 5% 1/4WR704 1-249-429-11 CARBON 10K 5% 1/4WR705 1-249-429-11 CARBON 10K 5% 1/4W

R706 1-249-441-11 CARBON 100K 5% 1/4WR707 1-247-903-00 CARBON 1M 5% 1/4WR708 1-249-417-11 CARBON 1K 5% 1/4W FR709 1-249-421-11 CARBON 2.2K 5% 1/4W FR710 1-249-421-11 CARBON 2.2K 5% 1/4W F

R711 1-249-429-11 CARBON 10K 5% 1/4W

< RELAY >

RY301 1-515-920-11 RELAY (24V)

< SWITCH >

S701 1-771-188-11 SWITCH, SLIDE (POWER SAVE)************************************************************

1-680-786-11 POWER BOARD*************

< CAPACITOR >

C401 1-126-947-11 ELECT 47uF 20.00% 16V

< CONNECTOR >

* CN401 1-564-243-11 PIN, CONNECTOR (3.96mm PITCH) 6P



MAIN POWER

15


< TRANSISTOR >

Q401 8-729-141-30 TRANSISTOR 2SC3623ATP-LKQ402 8-729-119-77 TRANSISTOR 2SA1175TP-FEKQ403 8-749-010-25 IC MN2488-OPY-MQ404 8-749-010-26 IC MP1620-OPY-M

< RESISTOR >

R401 1-249-437-11 CARBON 47K 5% 1/4WR402 1-249-421-11 CARBON 2.2K 5% 1/4W FR403 1-249-414-11 CARBON 560 5% 1/4W F

0R404 1-249-408-11 CARBON 180 5% 1/4W F0R405 1-249-408-11 CARBON 180 5% 1/4W F

0R406 1-217-151-00 METAL 0.22 10% 2W0R407 1-217-151-00 METAL 0.22 10% 2W***********************************************************

1-684-553-11 POWER SWITCH BOARD********************

< CAPACITOR >

0C1 1-113-924-11 CERAMIC 0.0047uF 20.00% 250V

< CONNECTOR >

CN1 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P

< SWITCH >

0S1 1-554-920-11 SWITCH, PUSH (AC POWER)(1 KEY)(POWER)***********************************************************

MISCELLANEOUS***************

4 1-694-836-11 TERMINAL, SPEAKER54 1-694-836-11 TERMINAL, SPEAKER

0205 1-696-570-21 CORD, POWER (UK)0205 1-696-845-31 CORD, POWER (AUS)0205 1-769-744-52 CORD, POWER (AEP, E , EA, RU)

0205 1-783-531-11 CORD, POWER (US, CND)0F601 1-532-463-31 FUSE (T1AL/250V)(EXCEPT US, CND, E)0F601 1-532-501-31 FUSE (T0.8AL/250V)(E)0F601 1-533-418-11 FUSE, GLASS CYLINDRICAL(DIA.5)

(2.5A/250V)(US, CND)0F602 1-532-503-31 FUSE (T1.6AL/250V)(E)

SP1 1-825-592-11 SPEAKER (7cm)SP2 1-825-591-11 SPEAKER (1.5cm)SP3 1-825-592-11 SPEAKER (7cm)SP4 1-825-591-11 SPEAKER (1.5cm)SP5 1-529-296-11 SPEAKER (20cm)(EXCEPT US, CND)

SP5 1-825-151-11 SPEAKER (20cm)(US, CND)0T501 1-435-999-11 TRANSFORMER, POWER (US, CND)0T501 1-437-219-12 TRANSFORMER, POWER (E)0T501 1-437-246-11 TRANSFORMER, POWER (EXCEPT US, CND, E)0T601 1-435-993-11 TRANSFORMER, POWER (US, CND)

0T601 1-435-994-11 TRANSFORMER, POWER(EXCEPT US, CND, E)0T601 1-435-995-11 TRANSFORMER, POWER (E)

Ref. No. Part No. Description Remarks



POWER POWER SWITCH


REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.

Ver. Date Description of Revision

1.0 2003.09 New

1.1 2004.09 Addition of Ref. No. 58 COVER for SS-TS8 by change of service

classification (SPM-04104)

SA-SC8/WS8/SS-CT8/TS8 - Diagramasde.comdiagramasde.com/diagramas/audio/SA-SC8 WS8 SS-CT8 TS8...

Documents

Transcript of SA-SC8/WS8/SS-CT8/TS8 - Diagramasde.comdiagramasde.com/diagramas/audio/SA-SC8 WS8 SS-CT8 TS8...