riiZ'JIIIl' !~- Tractor · jj (table of contents) cylinder head lifting eye valve mechat\iism...

391
• riiZ'JIIIl"'" - Tractor { LS Tractor USA, LLC 6900 Corporation Parkway, Battleboro, NC 27809 Phone: 252-984-0700 Fax: 252-984-0701

Transcript of riiZ'JIIIl' !~- Tractor · jj (table of contents) cylinder head lifting eye valve mechat\iism...

  • • riiZ'JIIIl"'"-!~- Tractor

    { ~'

    LS Tractor USA, LLC

    6900 Corporation Parkway,

    Battleboro, NC 27809

    Phone: 252-984-0700

    Fax: 252-984-0701

  • & jJ (Table of Contents)

    CYLINDER HEAD LIFTING EYE VALVE MECHAt\IISM ROCKER COVER & CAMSHAFT ROCKER COVER & CAMSHAFT CRANKCASE ASSY CRAN KCASE' ASSY CRANKCASE ASSY TIMING GEAR CASE & TIMING GEAR FLYWHEEL HOUSING OIL PAN PISTON CONNECTION ROD CRANKSHAFT FLYWHEEL TIMING GEAR CASE & TIMING GEAR CRANKCASE ASSY INLET & OUTLET MANIFOLD EXHAUST MANIFOLD GRP

    • OIL SYSTEM

    OIL SYSTEM

    OIL SYSTEM

    AIR BREATHER

    COOLING SYSTEM

    FU SYSTEM

    FUEL SYSTEM

    FU SYSTEM

    FUEL SYSTEM

    FUEL SYSTEM

    STARTER

    ELECTRIC PARITS

    ALTERNATOR

    ELECTRIC PARITS

    ELECTRIC PARITS

    FUEL PUMP & FILTER

    OVERHAUL GASKET KIT

    FUEL TANK

    ENGINE CONTROL

    ~, MUFFLER

    RADIATOR

    Q116S01-1 Q116S02-1 Q121S01-1 Q115S01-1 Q115S01-2 Q110S01-1 Q110S01-2 Q110S01-3 Q130S01 1 Q155S02-1 Q145S01-1 Q120S02-1 Q120S03-1 Q120S04-1 Q150S01-1 Q130S01-2 Q110S01-4 Q160S01-1 Q165S01 1 Q140S01-1 Q140S01-2 Q140S01-3 Q115S02-1 Q135S01 1 Q125S01-1 Q125S01-2 Q125S01-3 Q125S01-4 Q125S01-5 Q170S01-1 Q180S01-1 Q175S01-1 Q180S01 Q180S01-3 Q125S02-1 Q065S01-1 G040S01-1 G100S01 1 G150S01-1 G170S01-1

    J2020H -1

    23 23,27 23,27 23,27 23,27

    23,27 23,27 23,27 23,27 23,27 23,27 23,27 23 23 23,27 23,27 23,27 23,27 23,27 23,27 23,27 23 23,27 23,27 23,27 23,27 23,27 23,27

    23,27 23,27 23,27 23,27 23,27 23,27 23,27 23

  • .sa--, jJ (Table of Contents)

    AIR CLEANER G190S01-1

    ENGINE FRAME G210S01 1 HST

    HST G270S01-1 23

    TRANSMISSION CASE G280S01-1 23

    MAIN SHAFT G281S01-1 23

    RANGE GEAR SHAFT G285S01-1 23

    PTO DRIVE SHAFT G287S01-1 23

    4WD SHAFT G288S01-1

    4WD SHAFT G288S01

    HST CONTROL G292S01-1 23,HST

    HST CONTROL G292S01-3 HST

    RANGE LEVER G293S01-1 HST

    REAR DIFFERENTIAL G310S01-1

    DIFF-LOCK G320S01-1 HST

    FRONT AXLE ASSY G400S01-1

    FRONT AXLE CASE G400S02-1

    FRONT AXLE CASE G400S02-2

    FRONT DIFFERENTIAL . G400S03-1

    FRONT DRIVE G400S04-1

    REAR AXLE G480S01-1

    FRONT & REAR WHEEL(TIRE) G490S01-2 23x8.5-12/1 16.5

    STEERING CYLINDER & LINES G630S01-1

    STEERING WHEEL & COLUMN G630S02-1

    BRAKE G650S01-1

    BRAKE PEDALS G670S01-1 HST

    ELECTRICAL WIRING G730S01-1 ASAE

    BATTERY G740S01-1

    METER PANEL G750S01-2 ASAE

    METER PANEL G750S01-3

    METER PANEL G750S01-4 HST,ASAE

    LAMP G760S01-1 ASAE

    LAMP G760S01-2 WORK LAMP, B/SOCKET

    LAMP G760S01 SMALL-LAMP

    HYDRAULIC HOUSING G820S01-1

    LIFT CONTROL VALVE & LINK G822S01-1

    TM CONTROL VALVE G822S02-1

    TM CONTROL VALVE G822S02-2

    HYDRAULIC LINES G823S01-1 HST

    HYDRAULIC CONTROL LEVER G825S01-1

    HYDRAULIC CYLINDER G826S01-1

    J2020H - 2

  • ~ ~J (Table of Contents) ,,~

    REMOTE CONTROL VALVE G827S01-1 W / REMOTE CONTROL

    REMOTE CONTROL VALVE G827S01-2 W/0 REMOTE CONTROL HOOD G830S01-3 SMALL-ABS,S-BLUE,EU,LS

    STEP G840S01 HST,S-BLUE

    SEAT G850S01 1 HST,ASAE FENDER G870S01 1 S-BLUE SAFETY FRAME G880S01-3 R/ROPS, FOLDERBLE,ASAE DRAWBAR HITCH G891S01-2 DRAWBAR UPPER & LOWER LINK G896S01-1 CAT 1 LIFT ROD G896S02-1 GENERAL CHECK LINK G896S03-1 C/CHAIN DECAL G980S01-1 EU,LS-USA

    J2020H - 3

  • 23

    ~ E:! [1 011 c CYLINDER HEAD

    Q116S01-1

    r____________________J_____________I ______ JjI9

    II Ii U--7 I I 6 I 3--@l !

    13~ 'I I I

    II

    I !

    I I

    I I

    I I

    II

    I I

    I !

    2 4 . II. . 8. 5 IL__________·_______-'______..,._____- I .

    r lO,~~f:rl. ""' . . Il..~ .,r""~ "" ... FOIlWARO......-:; ,,!JIIr'

    /-"--11

    20090625 J2020H - 4

  • 23

    ~ E:! [1 011 c CYLINDER HEAD

    Q116801-1

    t!:!:2 ~~t'JS! NO. PART NO.

    1 40224996

    2 40055402

    3 *

    4 40224933

    5 40224934

    6 40109172

    7 40224935

    8 40224941

    9 . 10 40224936

    11 40224998

    I

    I

    I

    '='=Gj.-6= PART NAME

    HEAD ASSY,CYLINDER ~E!C" !lIlS ±il;I;t~1

    tLUG-MDOO0245-MAM ~~ ~

    ICAP-SEALING-MF665536-MAM ~El ~

    ISEAT,INLET VALVE

    ISEAT,EXHAUST VALVE

    GUIDE. EXHAUST VALVE HH:l1 ilII!:. :l,OI S

    GUIDE. INLET VALVE ~~ JtOIE::

    JET.COMBUSTION e!± Xii§.

    PLUG TAPER-MS661140-MAM li2ol:::J

    BOLT,CYLINDER HEAD !ill§.

    GASKET.CYLINDER HEAD J,~~

    Arg} *~ 1 *.2~ tll:J} SPEC. QTY I Effective REM.

    1 2008-09-09

    1 2007-06-25

    5 2006-12-13

    3 '000-00-00 i 3 2006-09-09

    3 2007-06-25 1

    3 2008-09-09 I

    3 2008-09-09

    1 2006-11-24

    11 2006-09-09 ...

    1 2008-09-09 1

    I

    -

    !

    ..'

    I I

    i

    I , I

    20090625 J2020H - 5

  • 2.p::r E O~OI LIFTING EYE

    Q116S02-1 23,27

    1-------:2

    20090625 J2020H -6

  • 2.1 II E O~OI LIFTING EYE

    Q116S02-1 23,27

    ~.Q. ~~tLS?_ NO. PART NO.

    1 40225193

    2 40224936

    3 40225166

    I

    !

    IHANGER, ENGINE

    HANGER, ENGIN E

    'BOLT. W!WASHER

    J=j=~'-0

    PART NAME

    !!!IJi

    !!!IJi

    !i~

    . -

    Af2J' *(3' ~£l~ : l:Il.:i1 SPEC. QTY Effective REM.

    1 2007-06-25

    1 2008-09-09

    2 2007-06-25

    I

    .

    I

    I

    •

    I

    •

    •

    1 I I

    20090625 J2020H -7

  • ~ I::::j DU 3-i LI 2i

    VALVE MECHANISM

    Q121S01-1 23,27

    REF; NO. 5 COllIES I N PAl RS.

    20090625 J2020H - 8

  • ~ l:::t Oil:ti LI2i

    VALVE MECHANISM

    Q121S01-1 23,27

    \!:!~ ~~~.2. NO. PART NO.

    1 40109197 IVALVE. INLET

    2 40109192 IVALVE. EXHAUST

    3 40109185 !SPRING. VALVE

    4 40225217 RETAINER, VALVE

    5 40122975 VALVE. LOCK

    6 40055399 SEAL VALVE STEM

    7 40109184 CAP, VALVE

    B 40224999 ROCKER & SHAFT ASSY

    9 40225106

    10 40225184 ,RING. SNAP

    11 40222432 IROCKER ASSY

    12 40152704 ,NUT. JAM

    13 40225032 SCREW, ROCKER

    14 40109195 ROCKER SHAFT

    15 40109196 IBRACKET. ROCKER SHAFT

    16 40225000' ISHAFT ASSY.ROCKER

    17 40225135 ICAP, SEALING

    18 40225099 SPRING, ROCKER

    19 40225100 BRACKET -

    1---'"

    ""'=L>j-.-es = PART NAME

    SJI il!l!:

    HPI il!l!:

    WI""! ~!!.~

    2.1 ElIOILi

    111'71 11M""!

    IIM""!~i!I ~

    ilII""!i!.!I

    i'E7t ~ "l!i :±11;J;ijl

    ~\;Il IS

    l!!!!'7i:±iI:.I1

    L,i'E

    lIi'71 ~7iff

    lIi'71 "l!i!:!.i:}~

    "!7i

  • ~3i 3i ttl & ~ ApI E ROCKER COVER & CAMSHAFT

    Q115S01-1 23,27

    ~ ~. ,5

    INlET NAN IFOLD

    20090625 J2020H -10

  • ~3i 3i I::H & @ Ap:r E

    ROCKER COVER & CAMSHAFT

    Q115S01-1 23,27

    \'!:!:!:2:. ¥~t!j2. NO. PART NO.

    1 40225001

    2 40225002

    :3 40177649

    4 40225162

    5 40055751

    Sj'!ggj I Afg)' PART NAME SPEC.

    COVER A88Y.ROCKER 531 311:11 ~ii;jA11

    GASKET,ROCKER COVER J16'!1!

    ICLIP iii/ilJ

    iSOLT, W/WA8HER ll!§ CAP, OIL FILLER 2li/\llI

    I

    .A2.lo .... = ~~~ tll::il QTY Effective REM.

    1 2008-09-09

    1 2008-09-09

    1 2007-06-25

    4 2007-06-25

    1 2007-06-25

    20090625 J2020H -11

  • 3i 3i I:H & @ API E

    ROCKER COVER & CAMSHAFT

    Q115801-2 23,27

    a

    6----1

    5-{J 2-

    . 3

    j---,--1 .

    20090625 J2020H -12

  • ~71 71 ttl & ~ A~J:I E ROCKER COVER & CAMSHAFT

    Q115S01-2 23,27

    'C!:!£: ~~'e:LQ" NO. PART NO.

    1 40225003

    2 40052815

    3 40224913 jPLATE. THRUST ilOiIOI.5

    4 40152832 !BOLT. W!WASHER il§

    5 40182773 TAPPET Ell:!!

    6 40109201 PUSH 1i!+I ~E

    20090625

    CAMSHAFT

    £F8~ Afg,t'

    l!!i~

    PART NAME SPEC. i QTY

    KEYWOODRUFF-MF47621S-MHI 31

    !

    I

    •

    I

    :

    I

    1

    I

    i*8t ~.9.cgJ l:ll::il Effective REM.

    1 2008-09-09

    1 2007-06-25

    1 12007-06-25

    2 2007-06-25

    6 : 2007-06-25

    6 2007-06-25

    ! I

    I

    I

    :

    I

    I

    -

    J2020H -13

  • 3 €!;I 311 OIA ± ~ ~I

    CRANKCASE ASSY

    Q110S01-1 23,27

    __ L1 __ ~ _______ _ -----, 118 _____ +-2.8__ I

    'j 1 I I I I I I

    19 1I I I I I I 1 1 I

    15 : I

    15 I I I I I I I I I I I I I I I I 1 I I I I

    I I 1:10 """---9 iI I I 120 I f 1, I I I

    I 6 : 1

    I

    !t-4 I

    ] 10---

  • 3~3 71101-"- ~~x~1

    CRANKCASE ASSY

    Q110801 23,27

    ~~N NO. 1 40225005

    2 40052309

    3 40052310

    4 40224945

    5 40109206

    6 40225222

    7 40122980

    8 40225185

    9 . 10 40176092

    11 40225230

    12 40225231

    13 40152860

    14 40225161

    15 40225211

    16 40224964

    17 40225130

    18 40152705

    19 40225136

    20 40224200

    I

    ~~'ii§ PART NAME

    IBLOCK ASSY.CYLINDER ~E:!C-l~~ 3SEf1:fl

    CAP, SEALING ~E! ~

    CAP. SEALING ~

    BOLT. BEARING. CAP HlIOli!4 ~ ~§.

    BUSH, CAMSHAFT ~~ 92:

    RETAINER.OIL LEVEL 2.IEiIOILi • .2i1.l clll:H

    :CAP, SEALING ~i!4 ~

    ICAP, SEALING ~!!l ~

    ,PLUG TAPER-MS661140-MAM fieLJ. I

    !BUSHING, KNOCK .!:r:.3~~

    BUSHING, KNOCK .!:r:.3. ¥~

    BUSHING, KNOCK .!:r:..3 ¥-eJ

    :PLUG, EXPANSION 21"'=l!!!C! fiCl:l

    IPIN. DOWEL Cf'ilJ l!J

    IPIN. DOWEL Cf~ l!J

    !SHAFT ASSY. IDLER OfOl~

  • 3~3 3iIOI A ~~x~1 CRANKCASE ASSY

    Q110801-2 23,27

    20090625 J2020H -16

  • 3~3 7IIOIA ~~x~1

    CRANKCASE ASSY

    Q110801 23,27

    ~2 ¥~~2 NO. PART NO.

    1 40109211 SEAL. SIDE

    2 40224930 SHAFT. OIL FILTER

    3 I

    40109207 CASE. OIL SEAL

    4 40109208 GASKET, OIL SEAL CASE

    5 I 40109203 SEAL, OIL

    6 I 40225143 BOLT i 7 I 40109205 STUD 8 40177599 PLUG, TAPER

    I

    I

    i

    I I

    i

    I I

    I

    !

    I

    1=l=O;j-.-50

    PART NAME

    1!"!1"j Ii1

    2\01 lliEi !l!i

    2~~ 71101~

    2\01 Ii! >1101"'= Jf"'=

    2!l.!~

    ~§

    ~Ei.5.

    li2.~ :::t

    -

    •I

    Afg} SPEC.

    ! .A.2.t i Og~ 1:l1:J:l aTY I Effective REM.

    I 4 iro"~"-,, 1 2007-06-25

    1 2007-06-25

    1 12007-06-25

    1 2007-06-25

    I 5 2007-08-25 i 2 2007-06-25

    1 2007-09-01

    I

    I

    I I

    I ,

    I •

    20090625 J2020H -17

  • 3~3 7iIOI >l ASE ASSY

    Q 1108::-;0)11-=-"33------- CRAN KC .A. ~~ x~1 23,27

    20090625 J2020H -18

  • .3 ~.3 311 01 A 3; ~ x~1 CRANKCASE ASSY

    Q110S01-3 23,27

    \=':!:2 ~§'2j2 NO. PART NO.

    1 40224949

    2 40224950

    3 40224951

    4 4022.4952

    r

    -

    I

    IBEARING SET.MAIN

    BEARING SET.MAIN

    iSEARING SET.MAIN

    IBEARING SET.MAIN

    I

    •I

    . I

    I

    I

    '='''''0;.-13 ""

    PART NAME

    011e.!1li10l~ ~ :STD

    OIleJllilOlilll ~ U.S 0.25

    O1leJIliIOl~ ~ U.S 0.50

    O1leJllilOlilll ~ U.S 0.75

    !

    I

    I

    I

    At\?:!' : A2.~.-= ~.Q.~ tll::il SPEC. QTY Effective REM.

    1 2008-09-09

    1 12008-09-09

    1 I2008-09-09

    I 1 2008-09-09

    I

    :

    I

    I

    I

    •

    I

    .

    20090625 J2020H -19

  • 6012:1 JIOI 31101 A & 6012:1 JIOI TIMING GEAR CASE & TIMING GEAR

    Q130S01-1 23,27

    2 2

    4

    10

    9

    20090625 J2020H - 20

  • aOI~ JIOI 31101 A & aOI~ JIOI TIMING GEAR CASE & TIMING GEAR

    Q130S01-1 23,27

    Itl§. !;f.g~§ NO. PART NO.

    1 40109214

    2 40109210

    3 40152832

    4 40189703

    5 40109217

    6 40225144

    7 40055749

    8 40224954

    9 40109215

    10 40223731

    11 *

    12 40225160

    13 40225227

    14 40225228

    15 40225226

    16 40177629

    17 40175989

    !¥~~ Af@!' PART NAME SPEC.

    I~LATE. FRONT l'!i!I ~ClIOls IGASKET. FRONT PLATE l'!i!Il1t2l10IsJf~:'1!

    !SOLT. W!WASHER !lis

    CASE.GEAR.PTO PTO JIOI 3iIOI~

    iGASKET. GEAR JIOI Jf~:'1!

    ISOLT !lis

    iSEAL.OIL-MD008762-MHI 2~ W

    HOUSING. GEAR ]101 orSf.~

    GASKET, HOUSING o~£?~ Jr~~

    IGASKET Jf~:'1!

    IWASHER, SPRING ~!!:!;;I!?t);j

    BOLT. W/WASHER lis

    STUD ~EI:=

    STUD(BX45) ~El.s(8X45)

    STUD ~El:='

    COVER.OIL PUMP SHAFT "il:li

    NUT L,s

    *~ .g..H.~ 1:l1.::il QTY Effective REM. 1 2007-06-25

    1 12007-06-25

    6 2007-06-25

    1 2008-09-09

    1 2007-06-25

    8 2007-06-25

    1 20Q7-06-25

    1 2007-06-25

    1 2007-06-25

    2 2007-06-25

    3 2007-06-25

    1 2007-06-25

    1 2008-09-09

    1 2007-06-25

    3 2008-09-09

    1 2008-09-09

    3 2008-09-09

    •

    20090625 J2020H - 21

  • 2..~OI i;l o~~~ FlYWHEEL HOUSING

    Q155S02-1 23,27

    20090625 J2020H - 22

  • ~2.~OI~ o~~~ FLYWHEEL HOUSING

    Q155S02-1 23,27

    \:!:!5t 1i?5~2. NO.• PART NO.

    1 40225004

    2 40109204

    3 40225192

    4 40224948

    ._......

    !

    PLATE,REAR

    GASKET. REAR

    PIN.KNOCK

    BOLl FLANGE

    .==OJ-.-5= PART NAME

    ~alOl§

    ~~J.::!::~

    l'.!

    ~i:!!XI i!1§

    Afgf : ,A. a~-.-= ffR~ !:I1::i1 SPEC. aTY Effective REM.

    1 . 2008-09-09

    1 2007-06-25

    1 2008-09-09

    6 2007-06-25

    . .

    I I

    I

    I I

    20090625 J2020H - 23

  • Q145S01-1 23.27

    20090625 J2020H - 24

  • .2 01 PHE:! L..:.! OIL PAN

    Q145S01 23,27

    't::i.2 Sf!~~2 ~~23 I AfgJ *\5 *.Q.~ 1:l1::il NO. PART NO. PART NAME SPEC. • QTY Effective • REM.

    1 40225006 PAN ASSY,OIL 2~l'!! 1 2008-09-09

    2 40179296 Ip",I'> """'a,. 1 2008-09-09 3 40179300 1 .2007-06-25

    4 40152832 .,2'-"::0 15 2007-06-25

    I

    •

    I I I

    I •

    I

    20090625 J2020H - 25

  • Ii:IAE

    PISTON

    Q120S02-1 23,27

    4.5,6---t-'-------H

    1.2'3---:----~

    ·7--___.

    20090625 J2020H - 26

  • lJ.-"1 A..§. _ L.-PISTON

    Q120802-1 23,27

    t~H2 i ~~~2. NO. PART NO.

    I PISTON PISTON

    3 40224960 PISTON

    4 40224955 RING SET. PISTON

    5 40224956----fNG SET. PISTON

    6 40224957 RING SET,PISTON

    7 40109223 PIN, PISTON

    I I

    I i

    I i

    I

    I

    I !

    I

    ~5~ PART NAME

    -

    1I1~l"!

    III~E

    III~E

    \9

    III

    \9

    1I1~!' a

    AfIY I .A. 2.~ , .g.~~ UI.JJ.-'0 SPEC. r QTY Effective REM.

    STO

    iO,S 0.25 O.S 0.50 3 2006-09-09

    STO 3 2006-09-09 '

    O.S 025 3 i 2008-09-09

    O.S 0.50 3 2008-09-09

    3 2007-06-25 I

    I

    I I !

    i

    I !

    I

    I

    I

    I I

    i

    20090625 J2020H - 27

  • 23

    :::u l:Il EI ;::::'I c::../1 -, c:::> .::I::._

    CONNECTION ROD

    Q120S03-1

    4,5,6.7

    20090625 J2020H - 28

  • 23

    3i~~ £c CONNECTION ROD

    Q120S03-1 i:::!.2: !f!~~§. NO. PART NO.

    1 40225008

    2 40153100

    3 40055756

    4 40109123

    5 40109125

    6 40182772

    7 40211678

    ..

    I.

    I

    !

    ROD ASSY,CONNECTING

    NUT, CONNECTING ROD

    ==""-.-5= PART NAME

    ~!iJ{~~=3;;;;~jl

    ~!iJ{~ ~= Li§

    CONROD CAP BOLT-MD021105-MHI ~li!la Ii§

    BEARING SET,CON-ROD IJIleJHlIOi~ !J!! ISTD

    METAL SET, CON-ROD E§= IJII~!J!!§ U.S 0.25

    IMETAL SET. CON-ROD E5.= IJII~!J!!§ ,U.S 0.50

    IMETAL SET, CON-ROD IJIlit !J!!§ U.S 0.75

    I

    I I

    I

    I

    I

    Ng; .Aa~.-= ! i=}g~ l:Il.::iJ. SPEC. • QTY Effective REM•

    3 2008-09-09

    6 2007-06-25

    6 2007-06-25

    3 200B-09-09

    3 2007-06-25

    3 2007-06-2: I 3 2007-06-25

    I I

    I

    I

    20090625 J2020H -29

  • 23 Q120S04-1

    6

    5

    .~

    20090625 J2020H - 30

  • 23

    3~ ~ CRANKSHAFT

    Q120S04-1 tJ.:!.2. ~~Ei~ NO. PART NO.

    1

    \

    402.25009

    2 40052815

    3 40225178

    4 40225180

    5 40225175 I--- .

    6 40225011

    '='=0;.-5= PART NAME

    ICRANKSHAFT 311!l3~

    KEYWOODRUFF-MF476215-MHI ;11

    !WASHER. PLAIN l'lI £II

    ,WASHER. SPRING ""E:\!;! !III

    iNUT L1§

    PULLEY.CRANKSHAFT .311!l.3!llO lill

    I

    Af2J' ..A.a~ '-0 ~.§~ tll:il SPEC. QTY Effective REM.

    1 2008-09-09

    2 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 i 2007-06-25 ...

    1 2008-09-09

    i

    I

    i

    I

    !

    20090625 J2020H - 31

  • ~ 2.~ 01-11 FLYWHEEL·

    Q150801-1 23,27

    20090625 J2020H - 32

  • ~2JOI~ FLYWHEEL

    Q150S01-1

    'i:::!.2:. !T!-3-'i:::!.2. NO. PART NO.

    I=I=Oj -.-3 =

    PART NAME },fg}

    SPEC.

    .A. 2.,-.-= QTY

    .g.H.~

    Effective

    23,27

    tll.JJ. REM.

    1

    2

    3

    4

    40225013

    40225012

    40124113

    40202167

    FLYWHEEL ASSY

    FLYWHEEL SUB ASSY

    BEARING, BALL

    BOLT, DRIVE PLATE

    ~ 2.fOI 11 3> EI :

  • EtOI ~ JIOI 311 alA & EtOI ~ JIOI

    TIMING GEAR CASE & TIMING GEAR

    Q130S01-2 23,27

    20090625 J2020H - 34

  • 801 ~ JIOi 711 OIA & 801 '2:! JIOi

    TIMING GEAR CASE & TIMING GEAR

    Q130S01-2 23,27

    \!is! NO.

    !:F~~5I PART NO.

    t=I=Oj--.5 =

    PART NAME Af2l'

    SPEC.

    .A. 2.~--.= QTY

    .g£i~

    Effective 1:I1.::il

    REM.

    1

    2

    3

    4

    5

    6

    40224966

    40224965

    40194294

    40109239

    40052807

    40109236

    GEAR. CAMSHAFT

    GER. INJECTION PUMP

    GEAR ASSY. IDLER

    GEAR. PRESS OIL PUMP

    BEARING-M D712517 -MHI

    GEAR. CRANKSHAFT

    @~ JIOi

    eJ"'lC! 1OI:!! JIOi

    OfOI~ JIOi ~Elxjl

    2~ 'f!l:!! JIOi

    1fl10i EI

    3~3;l!; JIOi

    Z~56

    Z~56

    Z~39

    Z~28

    Z~28

    1

    1

    1

    1

    2

    1

    2007-06-25

    2007-06-25

    2007-06-25

    2007-06-25

    2007-06-25

    2007-06-25

    20090625 J2020H - 35

  • 3 ~ 3 7f1 0 I.A. ± ~ l~1 CRANKCASE ASSY

    Q110801-4 23,27

    I ' I I 1 1 I I I I I I I I 1 I I I I I I I

    20090625 J2020H - 36

  • 3.~3. 31101 A ±~x~1 CRANKCASE ASSY

    23,27Ql10801-4

    t!:!:s?:1 l¥§t!:!~ NO. :

    1 'RIVENLJI" ,."

    2 IO-RING

    3 IPIN

    4 la-RING

    5 . ,SLEEVE. SPEEDMETER 6 IPLATE

    7 IBOl"

    i

    I

    i

    I

    i

    !

    I

    i

    l i

    i

    i

    i

    ~.

    =no;-'-0= I

    PART NAME .~ OilS

    Sl.\!;I

    ""E;l!Ii!!

    2.~

    1i!;2.1~

    itallOls

    lis

    i

    I

    i

    i

    i

    Afg} *~ ~.2~ \ 1::l1::i2 Effective, REM. t 2007-06-25

    t 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    I

    i i

    I

    i

    i

    I

    I

    i

    I I I 20090625 J2020H - 37

  • ~JI & HHJI []HLI~C

    INLET & OUTLET MANIFOLD

    Q160S01-1 23,27

    20090625 J2020H - 38

  • ~JI & I:JHJI [JHLI~~

    INLET & OUTLET MANIFOLD

    Q160S01-1 23,27

    El£ NO.

    1

    2

    3

    4

    5

    6

    7

    !

    H I

    i

    ~~~:2. PART NO.

    40225014

    40225015

    40109240

    40109241

    40225161

    40225157

    40152858

    COVER ASSY.INLET

    iGASKET.INLET COVER

    !PIPE, INLET

    ,GASKET, INLET PIPE !

    ,BOLT. W/WASHER

    BOLT, W/WASHER

    BOLT, W/WASHER

    t=!=Oj-.00

    PART NAME

    lPI 7i~ ~i!;jA11

    Jf~'l!'

    eJlllfQI~

    SJI l!fOI~ JI~'l!'

    l!;;§

    Afg} SPEC. *~ QTY

    1

    1

    1

    1

    i 5

    1

    I

    1

    i

    r

    I

    i

    *R~ Effective

    : 2008-09-09

    2008-09-09

    2007-06-25

    2007-06-25

    2007-06-25

    2007-06-25 1

    , 2007-06-25 1

    I

    tJl:::tl REM.

    ...

    I I -

    I

    I

    I

    I I 1

    I i

    i

    I I

    I

    I

    I i r -[

    I I

    I I I

    20090625 J2020H - 39

  • I::IH]I OHLI~c

    EXHAUST MANIFOLD GRP

    Q165S01-1 23,27

    . 4~ ~1--3

    2

    6~

    .5~

    20090625 J2020H - 40

  • IlH JI []H LI ~-'=

    EXHAUST MANIFOLD GRP

    Q165S01-1 23,27

    t':!l'2 ~,§t':!.S?. NO. PART NO.

    --~-~~

    1 40225016

    2 40225017

    3 40157936

    4 40225107

    5 40225147

    6 40109247

    I I

    L I 20090625

    I

    I i !

    MANIFOLD,EXHAUST

    ~'§~ PART NAME

    ilIIJI CfJ:It!!

    GASKET,EXHAUST MANF Jf~~

    STUD ~E:lE:

    BOLT If'"

    BOLT lOI:",

    CLAMP iiH!I:5!.

    I

    f..H!J .A. a;....-0 0'='01rr.E'.e 1:l1:il SPEC. QTY Effective REM.

    1

    1

    4 19

    4 l;;uU -U8-U

    2 I ;;UO--U6-;;0 ---~--~~

    I2007-06-25

    I

    i

    i I

    I

    I

    I

    I !

    I I J2D2DH - 41

  • 2~ AIA~

    OIL SYSTEM

    Q140S01-1 23,27

    2

    3

    IIOJE : The $haft and inne.r rotor end gear which are force fitted to each other are. not to be suwl jed individually,

    , ,

    20090625 J2020H - 42

  • 2~ AIA~

    OIL SYSTEM

    Q140S01 1 23.27

    \!IQ: !:f!~~2 NO. PART NO.

    1 40109250

    2 40109249

    3 40225146

    C-' , I

    I

    I I

    PUMP ASSY. OIL

    PACKING, BODY

    BOLT

    i

    I

    I

    !?-~~ PART NAME

    2~ l!!!!. !!;!!I~jl

    ~fq !!!i'i'J

    l!i!§!

    Argj' i *5" I *R~ tll.::il SPEC. aTY I Effective REM.

    I 1 12007-06-25 1 2007-06-25

    3 2008-09-09

    I

    j

    I

    I

    I

    I

    I

    I ,,

    I

    I

    20090625 J2020H -43

  • 2~ AIA~

    OIL SYSTEM

    Q140801-2 23.27

    3-·--- © @

    20090625 J2020H -44

  • 2~ AIA~

    OIL SYSTEM

    Q140S01-2 23,27

    \:1:!.f:l: ~~~:§. NO. PART NO.

    1 40224966

    2 40225176

    3

    I

    40189036

    I

    !

    I

    !

    I

    STRAINER ASSY,Oll

    NUT, JAM

    GASKET

    I

    !

    I

    1:1=01 -.-

  • 23

    2~ AIA~ OIL SYSTEM

    Q140801-3

    ----~5.

    tit FLYI'Il1EEL HOUSING /'

    /4 '.---- 6

    8

    3

    20090625 J2020H -46

  • 23

    2gJ AI.A~ OIL SYSTEM

    Q140801-3

    ~gl J::F.~~.2. PART NO. 1 40219852 VALVE ASSY. RELIEF

    2 40224916 GASKET

    3 40219853 'OILFILTER-MD134953-MHI

    4 40225018 iGAGE & GUIDE ASSY

    5 40225020 iGAGE ASSY,OIL

    40225021 I~UIDE'OIL LEVEL6 7 40176027 .O-RING, LEVEL GAGE

    8 40225169 ISOLT,W/WASHER

    i

    i

    i i

    I

    I

    I

    I--t I

    I

    I

    ==0;-r5= PART NAME

    I

    'i!2.I!! i!M~ ;Ei!:lill !

    J16"!i!

    21!l!liE! ;E\ll);il

    2'iij JlIOIAI ;EliJJ:1I

    2ill ~ICIl JIOIS

    ~1I:!l JlIOIAI 2-liJ

    if§.

    ..

    I

    I

    Af~ SPEC.

    i *l$ I -??:§~ . ell:;} • QTY • Effective I REM.

    i2007-06-25 i i 2007 i

    I 200~ -Ob-~"

    1 2008-09-09

    1 2008-09-09 . 1 2008-09-09

    1 2007-06-25

    1 2008-09-09

    I i

    I I

    i

    I

    I

    I

    I

    I

    20090625 J2020H - 47

  • 01101 l::j 2.1 [-I AIR BREATHER

    23,27 ...Q115802-1

    riff fOR'tlARD

    ..

    INLET MANIFOlD

    20090625 J2020H - 48

  • Oil 01 i:::j 2.1 [-I

    AIR BREATHER

    23,27Q115S02-1

    'C:i.sa !;f.8t~:L2 NO. PART NO.

    1 40156668

    ,

    'BREATHER. PIPE

    ...

    '=' = C>I-.0= PART NAME

    !:!.2.IC., mOl!'!.

    Ng} ACl-.= ~§.~ t:J1.::il SPEC. QTY Effective REM.

    1 1 2007-06-25

    i ...............

    I

    I

    20090625 J2020H - 49

  • YI:JI- AI A Ellc;::,-, _C::::J COOLING SYSTEM

    Q135S01-1 23,27

    ---------------------1

    i f-ll!

    ! ~12!17 I I

    I. !. I : I

    l~ri 130~:: !~-~,l ~...yi

    : . 15 , I

    I () .. ./"" : I . ./"" I

    p>: .

  • 'c!!2t AI A ~ COOLING SYSTEM

    Q135S01-1 23,27

    E:!12. .!:F~t!:!§. NO. PART NO. i

    1 40225206 PUMP ASSY.WATER

    2 40225150 iBOLT, W/WASHER

    3 40225207 'NIPPLE,HOSE

    4 40055385 GASKET, WATER PUMP

    5 40225208 PLATE, WATER PUMP

    6 40109139 GASKET. WATER PUMP

    7 40225170 BOLT, W/WASHER

    8 40225171 BOLT, W/WASHER

    9 40109254 'PULLEY, W/PUMP 89

    10 40225132 THERMOSTAT

    11 . BOLT-MFI40227-MAM 12 40210764 COVER, THERMOSTAT

    13 * CASE ASSY,THERMOSTAT

    14 40122883 ,GASKET, THERMOSTAT

    15 40109259 IGASKET,

    16 !SOL' U~D ,~,

    17 IHOSE

    18 40225128 CLAMP,

    19 40124372 FAN,CooLiNG

    20 40225220 SPACER,FAN

    21 40225154 BOLT, W/WASHER

    22 40055759 V-BELT-MD041704-MHI

    I

    ~~gJ PART NAME

    '

    '

    AWl ~5!!

    liE

    AI.2~5!! 71~

    *@ ZSllllJl 3l101~

    J.~~ AI.2~5!!

    \lilE

    ~2tt!U

    l!l! ~l!IIOIAI

    ii:E

    v- \!!IE !L=990

    I

    I

    I

    I

    Afgj' SPEC.

    i

    .A 2.~ '-0 .f?.s'§ tll.JJ. QTY Effective i REM.

    1 , 2008-09-09 I 2 '2007-06-25 :

    1 2008-09-09'

    1 i2007-06-25

    1 2007-06-26

    1 2007-06-25,

    :3 2007-06-25 I

    1 2007-06-25

    1 2007-06-25

    1 i2008-09-09i

    2 2006-12-13

    1 2007-06-25

    1 2008-09-09

    1 2007-06-25

    1 2007-06-25

    :3 2007-06-25

    1 2008-09-09

    2 2008-09-09

    1 i 2OO8-09-09'

    1 2008-09-09

    4 2007-06-25

    1 2007-06-25

    i

    I I i I

    i

    20090625 J2020H - 51

  • e!.fi AI A~ FUEL SYSTEM

    Q125801-1 23,27

    20090625 J2020H - 52

  • e:!E AI A.~ FUEL SYSTEM

    Q125S01-1 23,27

    \=f:Ii2. NO.

    .!:F~'Cj.2. PART NO.

    t=l "" n;-roo PART NAME

    • Nl?:!'

    SPEC.

    .A. 2.~ -ro

    QTY -?fR~

    Effective tll.:L1

    REM.

    1

    2

    3

    4

    5

    •

    40055776 .GASKET-MD070717-MHI

    40055773 IGASKET-MD068355-MHI

    40055772 INUT-MD068353-MHI

    40224974 IplPE,lNJECTION NO.1

    40224975 PIPE, INJECTION NO.2

    Jf~:'i!

    Jf~:'i!

    l;1§

    ~§ mOli!! NO.1

    \'1£ mOli!! NO.2

    LGX100

    36HP TRACTOR

    36HP TRACTOR

    3

    3

    3

    1

    1

    2006-11-30

    2006-11-30

    2006-11-30

    2008-09-09

    2008-09-09

    6 40224976 PIPE, INJECTION NO.3 ~§ mOIi!! NO,3 1 2008-09-09

    7 . CLAMP(A)-MM430703-MAM i!>!!i!! (Al 2 2006-12-13 8 . CLAMP(B)-MM430614-MAM lUlli!! (B) 2 2006-12-13 9 40225168 BOLT, W/WASHEA W§ 2 2007-06-25

    10 40224973 HOSE ASSY,AIRVENT !!:t,:, 1 2008-09-09

    11 40225213 HOSE,FUEL \'1£ !!:t,:, 1 2008-09-09

    12 40225234 HOSE, FUEL ~£ §,:, 1 2008-09-09

    13 40225236 CLIP ili1;I 4 2007-06-25

    14 40156207 JOINT,TEE ::Eels 1 2008-09-09

    15 40225022 PIPE,FUEL LEAK-OFF 1 2008-09-09

    _.._."

    20090625 J2020H - 53

  • e!.fi AI A I@J FUEL SYSTEM

    Q125S01-2 23,27

    1 lJ--43 ---------J----I-------- ----1

    36

    I ' 39

    , 31} I@) 30 I . 29 I

    ~27 . 20

    ... ·3226 I 29 I 28 :

    ~12 41

    40

    34

    20090625 J2020H - 54

  • 2:!fi AI A~ FUEL SYSTEM

    Q125S01-2 23,27

    tJ:!:2. ~5t:!£ NO. PART NO.

    1 40225024 CASE ASSY,GOVERNOR

    2 · PIN, SPRING 3 · O-RING 4 · PIN, GROOVED 5 · NUT 6 · NUT, JAM 7 · WASHER, SPRING B 40225218 SPRING,GOVERNOR

    9 · BOLT ASSY, HIGH SPEED 10 · SOLT, HIGH SPEED SET 11 · NUT, HIGH SPEED SET 12 · C-RING, TORQUE SET 13 · :C-RING,HIGH SPEED 14 · :COVER, GOVERNOR SHAFT 15 · SHAFT, GOVERNOR 16 · LEVER, GOVERNOR 17 · SPRING, START 18 · LEVER, TENSION 19 40224981 SOLT,lOW IDLE SET

    20 · LEVER, SPEED CONTROL 21 · SHIM, GOVERNOR SHAFT 22 * LEVER, GOVERNOR

    23 · CASE, GOVERNOR 24 · TIE-ROD 25 40225023 SPRING,TIE-ROD

    26 40224987 SPRING SET,TORQUE

    27 · NUT, TORQUE SET 28 40224965 :CASE,TORQUE SPRING

    29 40224966 SPRING,TORQUE

    30 40153098 NUT

    31 40225137 ,SCREW,ADJSUTING

    32 40225221 ISTOPPER,SPRING

    33 40225205 ieOVER, TIE-ROD

    34 40224927 GASKET, TIE-ROD COVER

    35 I 40175954 :BOLT,W!WASHER 36 i 40109273 I:::~~; GOVERNOR CASE 37 40224983 SLIDING

    38 40189031 SLEEVE, SLIDING

    39 40189030 ,WEIGHT ASSY, GOVERNOR

    40 40225144 IBOLT

    41 40224980 iBOlT,GOVERNOR CASE

    42 40224932 COVER, HIGHT SPEED

    43 40224986 Ie"""m,c", '"

    ¥~2'l PART NAME

    JltHl;I 31101~ 3SIl;IXll

    ~.!!E! ~

    2i!!J

    !.!l

    1;15

    'O!ll;l§

    ::::!!~ .2!-kI

    ~!!i!!J 'ill

    .5 3Sill~1

    :;!! ;;§

    :i!~!>l! L,5

    53 ~ C-ilI

    ~~ ~ c-~

    JltH L-J ;!!; :'li tH

    JltH[;J ;!!;

    JltH I.:l ClltH

    ~e§ ~!!~

    E!!{;! ClltH

    ..§

    ~JIIS ClltH

    JftH L-J !II eJ

    JltH[;J ClltH

    JltH 1;1 311 01 ~

    EfOl5S

    ~!!i!!J

    ~~51

    !>l! L-iJj![

    ~!!.'S

    [;J§

    ~3lT

    ~51I1 ~!!~

    EfOi :'litH

    EfOI 5S :'litH )f~

    ~§

    JltH Ll 311 01 ~ Jf~~ ,

    ~2l-Ol\;i 'Ii

    ~i!t01" 8el!:!

    Jf!:HI.:l'illIOI§

    ..§

    lis

    :i!~ :'litH

    71tH

    Af2J !*a 0'="01TT£1.= 1:l1.::il SPEC. QTY Effective REM.

    1 2008-09-09

    1 : 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2006-09-09

    1 2007-06-25

    1 2007-08-25

    1 2007-06-25

    1 2007-06-25

    1 2008-09-09

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2008-09-09

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25 :

    1 2007-06-25

    1 12008-09-09

    1 2008-09-09

    1 ' 2006-09-09

    1 2007-06-25

    1 2008-09-09

    2 2008-09-09

    1 2008-09-09

    1 2008-09-09

    1 2008-09-09

    1 2008-09-09

    1 2007-06-25

    4 2008-09-09

    1 2007-06-25 ;

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    3 2007-06-25

    1 :2008-09-09

    1 2007-06-25

    1 2008-09-09

    I

    20090625 J2020H - 55

  • 2:!E. AI ABI FUEL SYSTEM

    Q125S0)11~-33------ 23,27

    .. .. 0 @)~,~~~ (I 11crlt )2 1 11"

    15

    ~·72:3.4.5 . , ,8.9 .

    J2020H - 56~--------------20090625

  • e:!fi. AI A~ FUEL SYSTEM

    Q125801-3 23,27

    !'l::l2. ! ~~~.2 NO'1 PART NO.

    1

    I 40225194

    2 40225195

    3 40225196

    4 40225197

    5 40225198

    6 40225199

    7 40225200

    8 40225201

    9 40225202

    10 40225143

    11 40225189

    12 40224907

    13 40225190

    14 I

    40224989

    15 40224991

    16 40225025

    I

    I

    I

    i

    I I

    i i

    SHIM

    SHIM

    SHIM

    SHIM

    ISHIM

    ISHIM

    SHIM

    SHIM

    SHIM

    BOLT

    WASHER.SEALING

    WASHER,SEALING

    COLLAR. UNION

    COLLAR, UNION

    VALVE ASSY,CHECK

    SCREW.HOLLOW

    i

    i

    I

    !F~23 PART NAME

    ~

    ~

    ~

    ~

    ~

    ~

    eJ

    ~

    l>l

    i!:E

    2fJ;!

    2fJ;!

    ll.t2.f

    ll.t2.f

    \IlI.'=! ±!3~

    -

    Af~ A2-~-.-= *R~ i 1:11.:il SPEC. QTY Effective· REM.

    T=0.2 AR 2006-09-09

    T=0.3 AR 2006-09-09

    T=0.4 AR 2008-09-09

    I T

    : 0

    . 5 AR 2008-09-09

    i AR 2008-09-09:T-0.6

    T=0.7

    I AR 2008-09-09

    T=0.8 AR 2006-09-09

    T=0.9 I AR 2008-09-09 IT=1.0 AR 2008-09-09

    : 4 2007-06-25 .

    i 2 2008-09-09

    2 2008-09-09

    1 2008-09-09

    i 1 2008-09-09 .

    1 2008-09-09

    I 1 12008-09-09

    I I

    I

    i

    I I I

    i

    I I

    I 1

    !

    I i

    20090625 J2020H - 57

  • e!.fi AI A 81 FUEL SYSTEM

    Q125501-4 23,27

    --..,,I ,I I I

    II I

    r

    31 I I ,[ I 14 , d

    I ! I

    I I

    41 I I I

    I I, I 'I I I I,I I ,1

    I [ [

    I I I

    , I ,I ! I I

    I I [

    I I 1

    I I

    I

    I

    , I ,~~I ,I " I 19 21 20 I ,! I I I

    @

    12

    2 ,~8 I,I j'I

    , II I I ! 10 I

    I I I

    t I 13 I I I I @----222 I' 27' 3.24.25.26 I .28.29,30.31 I I I I . ' 11' ' I~. I I I I . I ! I I I I ! I I . I

    , 1 I ______ JI

    20090625 J2020H - 58

    http:3.24.25.26

  • e:! fi. AlA ~ FUEL SYSTEM

    Q125S01-4 23,27

    !'!:I~ ¥~E!2 iNO. PART NO. i

    1 40225027 IpUMP ASSY,INJ

    2 i · iHOUSING SUB ASSY 3 YOI nFR nFI II,

    4 [SPRING,DI

    5 GASKET. DELIVERY

    6 VALVE SUB ASSY

    7 ELEMENT SUB ASSY

    8 * ISLEEVE. CONTROL

    9 · SEA' SPRING 10 * SPRING. PLUNGER

    11 I TAPPET SUB ASSY 12 RACK ''''''' .Ct-.

    13 · SEA~ SPRING 14 40225104 [a-RING

    15 · IpIN. TAPPET GUIDE 16 40225224 PLATE

    17 * PLATE. ADJUSING

    18 * BOLT. WASHER HEAD

    19 * ,SCREW. AIR BLEEDER -20 40225225 SCREW,HOLLOW

    21 · WASHER, PIPE UNION 22 * SHIM

    23 * ,SHIM

    24 * :SHIM

    25 i * SHIM

    26 * SHIM

    27 * SHIM

    28 · SHIM 29 · SHIM 30 · SHIM 31 · SHIM

    I

    t==t:>I-.-"5= PART NAME

    ilf'i'?il M!2 3Si!HII

    ae, 6!EiJ

    JI::::"'l!

    1!I!!2 M!2 3S";;:'1

    l!l121II!!!§. M!2 3S~AlI

    ~~ ~2.!!:!

    ..::.':!!!.~ Als

    ¥!elA' ::::.!!1l3

    Ell!!! M!:! 3S\!;l~1I

    3S@ i!lI 3S~~11

    ~!!1l3 AI§.

    2'EJ

    Ell!!! JIOI.': t!!

    ¥!21101§.

    3S'2l ~21101§'

    ~§.

    OIIOi !:!2.le, i!§.

    63~

    2f);j

    Sl

    lei

    eJ

    Sl

    Sl

    Sl

    Sl

    Sl

    eJ

    eJ

    Afill i SPEC.

    i

    I

    T=0.20

    T=0.25

    T=0.30

    T=O.35

    T=OAO

    T=OA5

    T=0.50

    T=0.55 : T=0.60

    T=0.65

    i

    I I

    I

    I .A. 2., 0"'='01 1:J1.:il-.-= ."Q= QTY Effective REM.

    i

    1 i 2008-09-09

    2008-09-09

    iLVV -uu-,~

    i'VV 'v-,~

    2007-06-25

    2007-06-25

    3 ~V' ~.

    !~VV N-~~

  • e:! E. AI A Ell FUEL SYSTEM

    Q125S01-5 23,27

    20090625 J2020H - 60

  • e!.fi AIA~ FUEL SYSTEM

    Q125S01-5 23,27

    ~.21 ¥§'~:Lsr!. NO. :

    3 40179904

    4

    5

    I

    i

    ISHAFT,

    !BEARING,

    KEY,

    IBOll ,J'WASHEP

    i

    I

    I i

    I

    i

    \

    i

    i

    '='=01.-50 NAME

    '2:!l!!! IllL!! "I!

    £1M

    31

    Iii§;

    I Af~ , *!?S! ~.e.~ ! 1:I1.::il

    SPEC. ! QTY Effective i REM. ..

    I 1 2008-09-09

    1 2007-06-25

    I 1 2007-06-25

    I i 1 2007-06-25 i

    I 1 2007-06-25

    !

    i

    I I i

    I

    I

    i

    I i

    !

    J 20090625 J2020H - 61

  • AEl-Ei

    STARTER

    Q170801-1 23,27

    4

    3

    20090625 J2020H - 62

  • AEJ-Ef

    STARTER

    Q170S01-1 23,27

    'E':iS!1 ¥~'E':i£ NO. •

    .STARTER ASSY

    BOLl W!WASHER

    IBOLl

    4 40225179 WASHER, SPRING

    5 40224928 GASKET. STARTER

    i

    _ ..

    I I i I

    I I

    I

    I

    '='=01-r-oc PART NAME

    :::::EfEI 3;i;ml

    £fl

  • ~~ DJE ELECTRIC PARITS

    Q180801 1 23,27

    2-----

  • ~~ II~E

    ELECTRIC PARITS

    Q180S01-1 23,27

    \::1:2 5f!§~2 NO. PART NO.

    1 40109514

    2 40225028

    i

    I

    !

    I

    i

    I

    I I

    i

    I

    I i

    I !

    !

    !

    PLUG, GLOW

    PLATE,CONNECTOR

    !

    I

    !

    ! !

    I I

    ==Ol-res = PART NAME

    0I1~ lit'.i:l

    iiClIOIE.

    I

    !

    I

    I

    I

    AfgJ' i*~! ~§~ \ 1:l1..Jl SPEC. • QTY • Effective i REM.

    3 2007-06-25

    1 2008-09-09

    I

    !

    I

    !

    -

    I I

    I i I

    I I 1 I

    i

    II I

    I i

    I

    20090625 J2020H - 65

  • ~~JI ALTERNATOR

    Q175S01-1 23,27

    5

    20090625 J2020H - 66

  • ~~JI ALTERNATOR

    Q175801-1 23,27

    \!j§:/ !"!f'-~~.2 NO. , PART NO.

    1 40109286

    2 40189033

    3 40177604

    4 40177614

    5 40225174

    6 40225179

    7 40225177

    8 40224994

    I

    I !

    I i

    I 20090625

    I ALl IoHNAI UH

    PLATE, ADJUSTING

    WASHER

    80ll FLANGE

    NUT

    WASHER, SPRING

    WASHER, PLAIN

    80lT, ALTERNATOR

    I /

    I

    I

    /

    !

    I i

    I

    ,=,=e>; ...i5= PART NAME

    \1,t('jJI

    3;~ i!ClIOI§.

    £ffll

    l!1§.

    Li§.

    £ffll

    £ffll

    ~~JI.§

    -

    N2! 1 ""'-2.10,"'= .g.~ gj ! tll~ SPEC. i QTY Effective' REM.

    1 2007 06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    ! '~~~~ uo-"..,

    12007-06-25

    ,«uil7 'uo-«!)

    i ryM7-06-2b,

    I i

    !

    I

    I i

    ! I I ,

    I

    I

    i

    Ii

    I

    I I

    !

    I I !

    Ii I I

    I I !

    I

    J2020H - 67

  • ~~ lUE ELECTRIC PARITS

    Q180801-2 23,27

    1

    20090625 J2020H - 68

  • ~~ n~E ELECTRIC PARITS

    Q180S01 23,27

    ~2. i EFg~2. I NO. PART NO.

    1 40189702 "1"1' '"'()''' 2 40156682 NUT

    3 40109136 """ ,,,,n,n

    i

    i

    i

    I I

    I

    i

    I i

    I !

    i

    i

    20090625

    EFg'i13

    I i

    I i

    I i

    N~ SPEC.

    I

    I

    i

    I

    I

    i

    A2.t. j OgOl I !::I1.J1"""0 7T 2 QTY i Effective i REM.

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    I I

    i

    i I

    I i

    I i i

    I

    i i

    ~..

    J2020H - 69

  • ~~ IHE ELECTRIC PARITS

    Q180801-3 23,27

    2 '

    3 4

    20090625 J2020H - 70

  • A.1 AI- --l E L...: d lJ.r-

    ELECTRIC PARITS

    Q180S01-3 23,27

    ~S? \ !¥!8\:2.2. NO. : PART NO.

    1 402251S4

    2 . 3

    I

    40224909

    4 40224995

    i

    i

    I '='=01 I -.5 = PART NAME I

    i

    GAGE UNIT,WATER TEMP

    PLUG-DRAIN-MM316248-MHI

    WASHER. SEALING

    !SWITCH,OIL PRESSURE i

    i

    I i

    i

    i

    1

    i i

    I I

    I

    I I

    Af2l' -"-2.j I O§OI ! tll::il-'0 Tt" = ' SPEC. QTY : Effective REM.

    1 2008-09-09

    2 2006-11-24

    2 2007-06-25

    1 i 2008-09-09

    i

    I i

    I

    i

    I

    I

    I

    i

    i

    I

    !

    I

    20090625 J2020H - 71

  • e!~I!1lI&~EI FUEL PUMP & FILTER

    Q125S02-1 23,27

    . 1

    r -~----_-~-_l_-- __----~--, , , I I I I . I I I I I I I I I

    ,I 2 I I I I J I I I

    0 I II' 6

    1 I I I I I I I I 4 I I 1 I J I I I I : .1 I 'I 1, ~' 5 : I, ~ II I . . 1 , J I I I I, I . I

    I I I 3 , I I I I I I I I I I I __ __ __ I1_- __________ ~ ~

    20090625 J2020H - 72

  • e:!E~II&~E~ FUEL PUMP & FILTER

    Q125S02-1 23,27

    'E!.2 !?~'E!.2 NO. PART NO. ~..

    1 40207336 FILTER ASSY,FUEL

    2 * BODY SUB ASSY

    3 40224977 CAP,FILTER

    4 40223960 IELEMENT

    5 40223871 IO-RING

    6 IO-RING

    i !

    i

    I i

    I

    i

    •

    I I i

    I

    I I

    ! i

    I

    1

    !?~~ I PART NAME

    i ..----~---.--..

    !OlE! ~llH1I

    tlfCI M!2! ~EJA11

    ~

    l1!!21II!1l§

    2i51

    2il!l

    i

    i

    A~2l' SPEC.

    I*s ! ~B:g) I 1:11.:11 . QTY • Effective I REM.

    1 2008-09-09

    1 2008-09-09

    1 2008-09-09

    1 12008-09-09

    1 •2008-09-09 •

    1 2008-09-09

    I

    !

    I I I

    I i

    i !

    I i

    i I

    I

    i

    I I

    i I

    i I

    1 I

    I

    i

    i Il---"

    I I I

    i i

    I

    20090625 J2020H - 73

  • 23

    J~A~ ~

    OVERHAUL GASKET KIT

    Q065S01-1

    1

    ,-----~---~-------------~-l-------~---------~------l I R' I

    I ~ I

    ! 2j ~14; 1

    I \, "tiF -4 I

    : ~.~2a 11 :WI I

    I I

    I I

    I I

    I I

    1 27 I

    I I

    I I

    I I

    f I

    , I

    I 21 I

    I I

    I I

    I I

    I I

    : 11 24 :

    : I

    I !

    I I

    1 :

    i~~~ i

    !~15 i

    !\" !.

    I 17 :

    I \'. I

    i· 'to ;-7:

    ! -30 ~. .... : I, ~ : I I

    I 'fen 10 I

    t ~ 19 . I"

    : ~2 : ! La 2010 1 I I

    I I

    I I

    L ________ ---------- _----~-------- _~ ________ ~

    20090625 J2020H - 74

  • 23

    J~A~ ~ OVERHAUL GASKET KIT

    Q065S01-1 \:!:!.§. ¥~~2 NO. PART NO.

    1 40225029

    2 40055773

    3 40055776

    4 40055399

    5 * 6 . 7 40189036

    8 40179300

    9 40055385

    10 I

    40223731

    11 ! 40224927

    12 40224928

    13 40109139

    :: 40122883 40109204 16 40109208

    17 40109210

    18 40109211

    19 40109215

    20 40109217

    21 40109241

    22 40109249

    23 40109259

    24 40109273

    25 40224998

    26 40225002

    27 40225017

    I I~SKET KIT,OVERHAUL 'GASKET-MD068355-MHI

    GASKET-MD070717-MHI

    SEAL VALVE STEM

    a-RING

    a-RING

    ,GASKET

    a-RING, FILTER CAP

    GASKET, WATER PUMP

    GASKET

    IGASKET, TIE-ROD COVER

    ,GASKET, STARTER

    .GASKET. WATER PUMP

    GASKET. THERMOSTAT

    GASKET, REAR

    GASKET, OIL SEAL CASE

    .GASKET, FRONT PLATE

    SEAL. SIDE

    GASKET. HOUSING

    IGASKET, GEAR

    lGASKET. INLET PIPE

    .PACKING, BODY

    GASKET. THERMO CASE

    '='=04-rC5= PART NAME

    Jf::::,~"15

    fH1 SPEC.

    Jf::::,~ 36HP TRACTOR

    Jf::::'~ LGX100

    1III.!:!.::::'\i!l ~

    2l!J

    2;;,J

    Jf::::,~

    !!lEi 2-81

    >!l2t* l!I:!! Jf::::'~

    Jf::::,~

    601 lEE: 3i!:ll Jf::::,

    ::::,EfEI Jf:::::~

    ~2f* t!lE. ,~~~

    Jf6~ M2:::::!'

    .\itJf::::'~

    2i! 1;1 31101::::' Jf6

    ~\it '!! 211 01 5 Jf:::::~

    ~ei 'II

    !S1'i'~ Jf:::::~

    JIOi Jf:::::~

    !PlllfOI:!! Jf:::::~

    I:JfCI m;~

    1102 311016 Jf6~

    iGASKET, GOVERNOR CASE JfI:HL~ 311016 Jf:::::~

    IGASKET.CYLINDER HEAD Jf:::::~

    I~ASKET'ROCKER COVER Jf:::::~ GASKET,EXHAUST MANF Jf:::::~

    GASKET

    WASHER,

    a-RING, GAGE

    ,

    I

    A 2.~ : i?R~ I I:JI :J-r= QTY • Effective i REM.

    1 12008-09-0~I 3 .2006-11-30, 3 2006-11-30 '

    6 2007-06-25

    1 2007-06-25 ..............

    1 2007-06-25

    1 •2007-06-25

    2 2007-06-25

    1 2007-06-25

    2 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-08-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    4 2007-06-25

    1 2007-06-25

    -1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2007-06-25

    1 2008-09-09

    1 2008-09-09

    1 2008-09-09

    1 2007-06-25

    S 2007-06-25

    1 2007-06-25

    20090625 J2020H - 75

  • e:!.fi ~3 FUEL TANK

    G040S01-1

    1

    h 8

    2-14

    4

    5~

    2

    3

    13

    17

    ~ 12 20 9

    18

    19

    6

    J2020H - 76 20090621 3

  • e1fi ~ FUEL TANK

    G040S01 1

    t::::!£: Sf!§t::::!:2'. NO. PART NO.

    1 40194044

    2 40194055

    3 ! 40201945 4 40006786

    5 40008416

    6 40194082

    7 40194054

    8 40028908

    9 40197609

    10 40012007

    11 40194079

    12 40194078

    13 40009447

    14 40194077

    15 40029008 r-

    16 40217450

    17 40206136

    18 40222018

    19 40152040

    20 40012020

    1

    i

    Sf!§\!! PART NAME

    TANK ASSY-FUEL -G04O ~E~3. ",llI~jl

    ITANK-FUEL-TRG040 ~E~3.

    ICOVER-FUEL TANK-TRG04O ~E ~3. :>HIl

    CAP ASSY -FUEL-G040 I:'JEilll ",1lI~

    ISTRAINER-FUEL TANK-TRG040 2'!E~3. JUI@"

    i~OVER-FUEL- TRG040 I:'JE 7i1:ll iGAUGE-FUEL(J)-TRG750 2'!E JlIOIAI

    BOLT-HEX W/WS-SI53051613 ~§.

    SPONGE-BOnOM-TRG040 SfE! ~f"'X1

    CLAMP-HOSE-TRG970 iUII!!

    HOSE-FUEL-TRG040 2'!E.l!:!.~

    HOSE-RETURN-TRG040 2.1E! .l!:!.~

    NUT-SPEEO-TRG970 ~nt.5 LlS

    HOSE-COVER-TRG040 7i1:ll 2~

    BOLT-HEX W IWs-s159082533 !.Is

    JOINT-FUEL HOSE-TRG100 2!~~6 2Eel§

    IHOSE-FUEL - TRG040

    HOSE-FUEL - TRGI 00 2'!E.l!:!.~

    ICLIP-HOSE-A0640047 \ii1ll2~ -ICLAMP-HOSE-TRG970 ~:!:':; ~~B.

    I

    I

    •

    I

    Afgj' *~ ~R~ 1:l1.::il SPEC. aTY Effective REM. 1 2008-08-26

    1 2008-08-26

    1 2008-08-26

    CE 1 12006-11-30

    1 I 2006-11-30

    I 1 2008-08-26 1 2008-08-26

    M5XPO.8XI6L 5 2006-11-30

    2 2008-08-26

    MIN010/MAX018 2 i 2006-11-S0

    I 1 2008-08-26 1 1 2008-08-26 I

    OAT 4 2006-11-S0

    1 2008-08-26

    M8XP1.25X25L 4 i 2006-11-30

    I 1 2009-01-23 1 1 2009-05-17 .

    1

    1 i 2006-12-13

    MIN08XMAX016 5 2006-11-S0 i

    I

    !

    I

    20090621 J2020H - 77 3

  • A::±::. AI- TI:.J",;:;-, C)A ENGINE CONTROL

    G100S01 1

    3

    A

    J2020H - 78 20090607 6

  • ±~~xl ENGINE CONTROL

    G100501-1

    \!:!:£ Efl €§ £!:L2: NO. PART NO.

    1 40193560

    2 40222902

    3 40030248

    4 40028973

    5 40029040

    6 ! 40028169

    7 40029087

    8 40028172

    9 40008339

    10 40194289

    11 40193558

    12 40011897

    13 40029130

    14 1

    40008389

    15 40029019

    -

    I

    l I

    I I

    I i

    !F~~ Af~ i PART NAME SPEC.

    BRACKET-ACC CABLE-TRG 1 00 3f10l1l!! !:!2.f~

    BRACKET-ACC WIRE-TRGI 00 .as~ £1.0101 ~a~

    RI NG-SNAP-S814005003 ~\:,jJ1!i

    IBOLT-HEX W/WS-S155082533 lis ,M8XP1.25X25L

    1'NUT-HEX SMALL-S313080013 L.~§ ,M8XP1.25

    WASHER-PLN-S3640800 13 ~'

    SCREW-W /WS-S228501 011

  • :1: ~ JI MUFFLER

    G150801-1

    4

    20090315 J2020H - 80

    3

  • :1:: ~ JI

    MUFFLER

    G150S01 1

    \:l:!.2:! .5F~t:i£ NO.

    i PART NO.

    1 40192380

    2 40006941

    3 40029075

    4 40028932

    I

    i

    I i

    9-~~ PART NAME

    MUFFLER ASSY-TRGI50 ':'@JI3Si!:J;\1I

    GASKET-MUFFLER-TRGI50 :j,@JI Jf""!l!

    NUT-FLANGE-S345080013 ~E!!XI Ll~

    ·BOL T -HEX W/WS-S153087533 Ills

    I

    I

    I i

    I

    .---...---.

    I Afgf *151 ~B:~ I t:l1:i1 SPEC. aTY Effective i REM. 1 2008-10-15

    D37Xl.8T 1 2006-11-30

    M8XP1.25 4 2006-11-30 i

    M8XPI 12006-11-30 :

    i i

    I

    !

    i

    i

    I I I i

    I

    1 i

    I )

    I

    : i

    I

    I

    I i

    20090315 J2020H - 81

  • 2.1- CI Ofl 0 I EI

    RADIATOR

    G170801-1

    5

    11

    14

    .~.

    4

    4

    10 18

    7

    20090531 J2020H - 82 7

  • 2.1- CI Oil 0 I E-I

    RADIATOR

    G170801-1

    \:!:is! SF-%§'2t~. NO. PART NO.

    1

    I 40192383

    2 40192385

    3 40028966

    4 40196664

    5 40196371

    6 40192388

    7 40196665

    8 40192387

    9 40192384

    10 40193631

    11 40192381

    12 40192382

    13 40192386

    14 40012013

    15 40028973

    16 40028967

    17 40216030

    18 40222098

    b=I-r15=

    PART NAME . IRADIATOR ASSY-TRGI70 ll2t~ !IDH

    iBOLT-HEX W/WS-SI55062033 Ji§

    SPONGE-RADIATOR-RH-TRG170 ll2t* :2:6(eJ::;»

    HOSE-RADIATOR OUTLET-TRG170 >ll"l*:2:6(iI!::;»

    RUBBER-DAMPER-TRGI70 ~e.!.:i1ff.

    CLAMP-HOSE-TRG970 :2:::::: iiiH!!lE:

    BOLT-HEX W/WS-S155082533 l!!§

    BOLT-HEX W/WS-SI55062533 @§

    SPONGE-SEAL-SIDE-TRG170 lil :::::gAI

    SCREW-TP/CRS-S236601211 63""

    At2:/' *~ 0-01 TTE.", t:l1.::iJ.

    SPEC. QTY Effective REM.

    1 2008-07-14

    1 2008-07-03

    M6XP1X20L 4 2006-11-30

    2 2008-07-13

    1 2008-07-13

    1 2008-07-03

    1 2008-07-13

    1 2009-03-15

    1 2009-03-15

    1 2008-07-03

    1 2007-12-13

    1 2007-12-13

    2 2008-11-30

    MIND27/MAXD50 4 2006-11-30

    M8XP1.25X25L 2 2006-11-30

    M6XP1X25L 2 2006-11-30

    2. 2009-02-15

    2 2009-05-31

    I I I

    I I 20090531 J2020H - 83 7

  • OH Oi 32.1 Li AIR CLEANER

    G190S01-1

    2

    8 , 7

    5 6

    3

    20090125 J2020H - 84

  • 011013. 2.1 L-i

    AIR CLEANER

    G190801-1

    \:':!Si. ~~~.2 NO. i PART NO.

    1 40007597

    2 40199859

    3 40012014

    4 40012013

    5 40199941

    6 40199860

    7 40193633

    8 40028971

    •

    I

    I

    ,=,="'1-r13 =

    PART NAME

    AIR CLEANER-4INCH-TRG190 0I10I3C'.ILi 3"iOIl11

    PIPE-AIR INTAKE-TRG190 11

  • 2!! ~ II ell ~ ENGINE FRAME

    G210801-1 H8T

    1

    h 2 -16

    20 17

    15

    2

    16

    416

    J2020H - 86 20090517 3

  • 2!!~.LL cH~

    ENGINE FRAME

    G210801-1 H8T

    t!:l.2: !;f.~'2:!~ NO. PART NO.

    1 40194090

    2 40194091

    3 40194092

    4 40194093

    5 40029131

    6 40029107

    7 40194094

    8 40194097

    9 40194888

    10 40029008

    11 40199766

    12 40007407

    13 40029075

    14 40079651

    15 40201964

    16 40028974

    17 40193556

    18 40193557

    19 40094279

    20 40029079

    21 40193997

    22 40075780

    23 40029551

    24 40007334

    20090517

    1=1=001 Afgj'-roo

    IPART NAME SPEC.

    ENGINE FRAME ASSY-G210 e!!C! B'2111l1 a;i!J;l;j1

    FRAME-MAIN-TRG21 0 DlleJ B'2111l1 I SUPPORT-FRONT-TRG210 iSl'iilJ' 'i!£,?a;~ XIXI ,

    COVER-FlYWHEEl-TRG21 0 li'2.fOIIl 7l1:H I

    PIN-SNAP-S4430800 13 ""'1!lH!l 'D8XOL

    PIN-HEAD-S427085023 ailS!!! D8X50L

    iHANGER-TRG21 0 ~Jt

    SPRING-HANGER-TRG21 0 ~PI ""':!:!~

    SPRING-TRG210 ""':!:!~

    BOLT-HEX WIWS-S159082533 g .. M8XP1.25X25L

    iCOVER-SPRING-TRG21 0 ~:!:!'i5I 7l1:H

    ISTOPPER-FRONT MOUNT-TRG840 iSl'iilJ' Of~" ~5Il1 OD22XID2XST

    NUT-FLANGE-S3450800 13 liE!! XI L1 .. M8XP1.25

    BOLT-HEX FT-SI63087043 ~§. M8Xl.25PX70l

    iCOVER-FLYWHEEL-TRG21 0 g'2.fOIIl 7l1:H

    iBOLT-HEX WIW8-S155083033 ... M8XP1.25X30L BRACKET-EIG MOUNTING-TR0100

    BRACKET-EIG MOUNTING LH-TR0100

    IBOLT-HEX WIWS-S154122533 llf" M 12XP1.25X25L -,NUT-FLANGE-S346100013 liE!!Xll=I" Ml0XP1.25

    RUBBER-EIG DAMPING-EG0100 ';!tiS! :il!¥

    BOLT-HEX-Sl01123053 If.. M12Xl.75PX30l

    IWASHER-SPR-S361120013 ""'i!!il!l.'i'lM O.D21.5XI.DI2.2X3T

    WEATHER STRIP-U-TRG970 -!lIICi ,3al

    I

    .A 2.~ 0-01 1::J1.J1-ro TT£l.a QTY Effective REM.

    1 2008-08-26 •

    1

    1

    1 2009-03-25

    1 2006-11-30

    1 2006-11-30

    1 2008-08-26

    1 2008-08-26

    2 2008-08-26

    2 2006-11-30

    2 '2008-06-26

    2 2006-11-30

    2 2006-11-30

    2. 2006-11-30

    1 2008-06-23 i

    12 2006-11-30

    1 2009-03-15

    1 2009-03-15

    12 2006-11-30

    6 2006-11-30

    4 2008-10-23

    4 2006-11-30

    4 2006-11-30

    1 2006-11-30

    •

    I I J2020H - 87 3

  • 23

    ~gr Ol~ HST

    G270S01-1

    3

    2

    20080627 J2020H - 88 o

  • ~gJ- Olt! HST

    G270S01-1

    't!:!.2 !:f.~1r!:L2 NO. PART NO.

    1 40193569

    2 40089239

    3 40195438

    4 40029546

    5 40029217

    6 40029228

    7 40195437

    8 40029194

    9 40112210

    >=1="'1--r== PART NAME

    HST UNIT - TRG270

    BOLT-HEX-S 105088043

    BOLT-HEX-TRG270

    WASHER-SPR-S361 080013

    O-RING-S80104601O

    O-RING-S802075010

    SPACER-O-RING GUIDE-TRG270

    O-RING-S801010011

    PIN-PAR-S423061610

    ~~gJ- Ol~ 3S!l:i:~1

    ~.§:

    ~.§:

    6:£~ £1);1

    2.~

    2.~

    6J!110lkl

    2.~

    !!!

    Af2J' SPEC.

    21CC/REV- DAN FOSS

    M8XP1.25X80L

    O.D15.4XI.D8.2X2T

    D45.7XW3.5

    D74.4XW3.1

    D9.8XW1.9

    D6X16L

    .A. 2.,--r= QTY

    1

    2

    2

    4

    2

    1

    1

    1

    1

    ~R~ Effective

    2008-08-26

    2006-11-30

    2008-08-29

    2006-11-30

    2006-11-30

    2006-11-30

    2008-08-26

    2006-11-30

    2006-11-30

    23

    I::ll::il REM.

    -

    20080627 oJ2020H - 89

  • 23

    E E!! .A 0 I~ ~I 0 I .A TRANSMISSION CASE

    G280S01-1

    17

    o

    20080627 oJ2020H - 90

  • 23

    E £!:! A. 01 e! 31101 A.

    TRANSMISSION CASE

    G280S01-1 tIi:2. !F~~.2. ==OJ-'-5= Af\y .A. 2.10-.-= ~B.~ l:l1.:i1 NO. PART NO. PART NAME SPEC. QTY Effective REM.

    1 40197123 CASE-AXLE-TRG280 2!liiil3I101~ 1

    2 40197103 COVER-R/PTO-TRG280 PTO 3ittl 1 2008-11-18

    3 40028951 BOLT-HEX W/WS-S1541 04033 li!1s M10XP1.25X40L 13 12006-11-30

    4

    I

    40196400 COVER-TM FRONT 20PS-TRG280 DICl a!!i3ii:H

    I

    1 2008-11-18

    5 40197104 GAUGE-OIL LEVEL-TRG280 .21i11 21111 )JIOI AI 1 ! 2008-11-18

    6 I 40028949 BOLT-HEX W!WS-S154103033 !M10XP1.25X30L 9 2006-11-30 7 40036251 PIN-PAR-S421081410 ~ DiAB.OX14L 8 2006-11-30

    8 40012624 PLUG-DRAiN-TRG250 m:::l~ iiCl:::l M20X1.5 1 2006-11-30

    9 40012421 SEAL-PLUG-TRG250 loll I~D26.0XID20.0X1.5L 1 2006-11-30 10 40029193 O-RiNG-S801009010 .2i!1 D8.8XW1.9 1 2006-11-30 :

    11 40012846 PLUG-TAPER-A0610167 iliCl:::l iPT1{8 3 2006-11-30

    12 40012884 SEAL-OiL-A0651253 .2gJ {BI *1253 2 2006-11-30

    13 40095160 BOLT-STUD-S167102023 ~E15 li!s Ml0XP1.25X20L 2 2006-11-30

    14 40092238 BOLT-STUD-S139062023 ~E15l!!1s M6XP1X20L 2 2006-11-30

    15 40029244 O-RING-S8040240 1 0 .2ili D23.5XW2 1 2006-11-30

    16 40029246 O-RING-8804026010 .2ili D25.5XW2 1 2006-11-30

    17 40211420 SHIELD-PTO-TRG280 lllEl.2 !i!1:tCII 1

    •

    20080627 J2020H - 91 o

  • 23

    ~~ MAIN SHAFT

    G281801-1

    11

    2

    6

    6

    7

    A

    3 1

    h 2 -10

    20090331 J2020H - 92

  • 23

    ~~ MAIN SHAFT

    G281801-1

    \=Ii£. !¥~~.§: NO. PART NO.

    1 40201559

    2 40201562

    3 40201563

    4 40201560

    5 40029567

    6 40113838

    7 40029114

    8 40194116

    9 40196061

    10 40028969

    11 40028921

    I

    I i

    ==0;,-0= PART NAME

    SHAFT ASSY-MAIN(20PS)-G281 Oil£>! 1ili.:::J:

    SHAFT -FLYWHEEL - TAG281 ii~OI" 2!~ Iili

    SHAFT-MAIN(20PS)-TAG281 OIlel !Ii{2301Sl;)

    JOINT-BALL-MAIN REAR-TRG281 Oilel !Ii 'MiiI li! iEt>!

    'WASHER-PLN-S363060013 !l!£fM

    PI N-HEAD-S427064023 mlE.El

    PIN-SPLlT-S441161613 ~\;ljEl

    ,FAN-HST COOlING-TRG281 HST iii~l!!!

    JOINT-BALL 4WD-FAONT - TRG380 ~l'! WiiI i'i'Lltllill

    BOLT-HEX W/WS-S155081613 I!I§

    BOLT-HEX WIWS-S153082033 ~s.

    I

    I

    !

    I

    ,

    Afg)' I .A 2.~ 0'-' 01 t:l1.:1l,-= 7T22 SPEC. • QTY • Effective I REM .

    1 2008-11-08

    1 2008-11-08

    1 2008-11-08

    IO.D11.5XI.D6.4X1.6T

    1 2008-11-08

    I

    3 2006-11-30 -

    12006-11-30 IP6X40L 3 !D16X16L

    I 3 , 2006-11-30

    1 2008-08-04'

    1 2008-08-04

    M8XP1.25X16L 2 • 2006-11-30

    M8XP 1.25X20L 6 12006-11-30

    I I

    I !

    I I

    .

    I I

    !

    !

    ,

    I

    I

    i

    I

    I

    , I

    20090331 J2020H - 93

  • 23

    ¥~±~

    G285S0J11-=-11_____~R~/ANGE GEAR SHAFT

    4

    3 ~A B

    2

    G310S0L1

    A

    J2020H - 94---------20090510

  • 23

    ¥~~~ RANGE GEAR SHAFT

    G285801-1 ~.2: !f!~~§. NO. PART NO.

    1 40012915

    2 40196977

    3 40196994

    4 40012696

    5 40200875

    ; 40195606 40029270 8 40196978

    9 40200874

    10 40012703

    11 40212343

    12 40198539

    •

    ""=001"'''''0 PART NAME

    BEARING-BALl-A0860060 • 1l110li!! #60060

    GEAR-RANGE DRV(28T)-TRG285 l;''''~::;>§ JI01

    SHAFT-RANGE DRV(18T)-TRG2B8 ¥~~ 1l~ JIOi ~

    BEARING-BALL-A0860040 li1' 1lI101i!! i'IF60040

    SPACER-TRG285 ~1lI101M

    GEAR-RANGE SHIFT - TRG285 !;'''' ,!!; JI01

    RING-SNAP-S81 0022001 !aj

    GEAR-4WO DRV(21 TI-TRG288

    !SPACER-TRG3lO ~rnIOIM

    BEARING-BALL-A0862050 Ii IlI100iilJ #62050

    BEARING-ANGULAR(7203B)-TRG285 Illl00iSl

    RING-SNAP-S81 001500 1 ~\;tiE:! '015

    !

    Af'iY *~ ff.ai§l 1:l1:::il SPEC. QTY Effective REM. 1 2006-11-30

    1 2008-11-18

    1 2006-11-18

    1 2006-11-30

    !2008-11-18

    !2008-1 18

    !2005-1

    !2008-1 18

    1 2008-11-18

    2 2006-11-30

    1 2008-11-18

    1

    I

    I I 20090510

    J2020H - 95

  • ----23

    ~37S:01-~-------~ III EI2 .:;:t.s=.::>

  • 23

    TIl EI.2. =?-~~

    PTO DRIVE SHAFT

    G287S01-1 \::!2: NO.

    !f!~t!:!.2. PART NO.

    t:I=Gl-rCS" = PART NAME

    Af2J' SPEC.

    A 2-~ -r= QTY

    ~B.~ Effective

    tJl::iJ. REM.

    1 40213679 BEARING-BALL-A0863030 l!1 1ll10i il;) 4 2008-11-18

    2 40029298 RING-SNAP-S811055001 ~\:;lj~ ~.g~055 1 2006-11-30

    3 40029271 RING-SNAP-S810025001 ~I;;;!f~ 2t!§:elD25 9 2006-11-30

    4 40196984 GEAR-M/PTO DRV(32T)-TRG287 Ol~ IlIEI2 'i'§ JI 1 2008-11-18

    5 40012715 BEARING-BALL-A0863050 ~ 1ll10iil;) #63050 1 2006-11-30

    6 40161057 RI NG-SNAP-S812030001 ""Ell~ "l§:eld30 1 2006-12-27

    7 40196990 SHAFT-M/PTO MAIN-TRG287 Ol~ IlIEI2 1lI1!:'.! ~ 1

    8 40198670 BEARING-NEEDLE-TRG292 LI~ t:JIIOl~ #K141810 1 2008-11-18

    9 40196993 SHAFT-R/PTO DRV-TRG287 1

    10 40196988 GEAR-PTO SHIFT(35T)-TRG287 JIICl2 ~ JIOi 1 2008-11-18

    11 40029273 RING-SNAP-S81 0030001 ~';;;!f~ =E:I§~D30 1 2006-11-30

    12 40012697 BEARING-BALL-A0860050 'ii 1ll10i~ #60050 3 2006-11-30

    13 40201265 GEAR-R/PTO DRV(14T)-TRG287 ;r

  • .!i::. ~~ =jlC) ~ 4WD SHAFT

    G288801-1

    2

    18

    7

    14 11

    13

    17

    20090331 J2020H - 98

  • ~~ =?~ ~ 4WD SHAFT

    G288801-1

    ~2. ~~t!:!2. ,=,="'1--r05"= Af2J' .A. 2-,--r= ¥i-§'§! 1:J1::il

    NO. PART NO. PART NAME SPEC. QTY Effective REM.

    1 40206648 SHAFT ASSY-4WO ORV-TRG380 4~ 'i'§ '" 2Si1JAjl 1 2008-08-04

    2 40196059 SHAFT-4WO REAR-TRG380 C:!~.sr-l~ N:!!.§ 1 2009-03-31

    3 40196058 HOUSING-BEARING-TRG380 UlIOI~ o~-9!~ 1 2008-08-04

    4 40029265 RING-SNAP-S81 0020001 ~\;lIEi ~~ill020 1 2006-11-30

    5 40052967 BEARING-BALL-A0862044 * Ifli00EI #620400 1 2006-11-30 6 40196061 JOINT-BALL 4WO-FRONT - TRG380 ~~ '1{~ 19WH.:.! 1 2009-03-31

    7 40113838 PIN-HEAO-S427064023 61I-'O!!! 06X40L 1 2006-11-30

    8 40029567 WASHER-PLN-S363060013 l!I£I);I O.011.5XI.06.4X1.6T 1 2006-11-30

    9 40029114 PIN-SPLlT-S441161613 ~\;lI!!! 016X16L 1 2006-11-30

    10 40028974 BOLT-HEX W/WS-S155083033 ~§ M8XP1.25X30L 2 2006-11-30

    11 40196060 SHAFT-4WO FRONT - TRG380 ~~ 2i~ A~:!!g 1 2009-03-31

    12 40196061 JOINT-BALL 4WO-FRONT - TRG380 l:!~ 2i~ ~LII:H~ 1 2008-08-04

    13 40194117 COVER-JOINT - TRG380 .±e.!§ 7i1::H 1 2008-08-04

    14 40113838 PIN-HEAO-S427064023 61I-'O!!! 06X40L 2 2006-11-30

    15 40029567 WASHER-PLN-S363060013 !!l5M O.011.5XI.06.4X1.6T 2 2006-11-30

    16 40029114 PIN-SPLlT-S441161613 ~\;lI!!! 016X16L 2 2006-11-30

    17 40028964 BOLT-HEX W/WS-S155061633 l!f§ M6XP1X16L 2 2006-11-30

    18 40013044 4WO-JOINT ASSY-G380 4i!::;:t.~ '±e.]§'±~ 1 2006-11-30

    -

    20090331 J2020H - 99

  • ~E =?-~ 4WD SHAFT

    G288801-2

    3

    6

    ~

    7

    20080627 oJ2020H -100

  • ~~ =j1~ 4WD SHAFT

    G288801-2

    tJ:iS?:1 ~~t:!2. NO. : PART NO.

    1 I

    40012702

    2 40196996

    3 40029271

    4 40196986

    5 40012696

    6 40012697

    7 40195987

    8 40196973

    9 40198669

    10 40012756

    1=t=E>l -roo PART NAME

    BEARING-BALL-A0862040 Ii IJII00iI!J

    'SHAFT-4WD IDLE(16T)-TAG288

    RING-SNAP-S81 0025001 6\;!j~

    GEAR-4WO IOEL(35T)-TAG288 4E Of 01 Iii )10l

    BEARING-BALL -AQ860040 Ii IJII00iI!J

    BEARING-BALL -AQ860050 Ii 1JI10l~

    GEAR-4WD SHIFT(23T)-TRG286 4!! !l!i JIOl

    SHAFT-4WO-TRG288 4E!l!i

    SPRING-TRG292 .6B'SI

    BALL-STEEL-A067AOO6 c6i4 l\f

    Af~

    ~ til :il

    SPEC. REM.

    *62040 2006-11-30

    1 2008-11-18

    i2!!~i'3D25 5 2006-11-30

    I 1 2008-11-18

    :#60040 2 2006-11-30 i

    #60050 1 2006-11-30

    1 2008-11-18

    1 2008-11-18

    1

    01/4 1 2006-11-30

    ............

    I ! I 20080627 J2020H - 101 o

  • HST ~E~

    HST CONTROL

    G292S01-1 23,HST

    13

    16

    2

    G292S0 L3-8 7

    12

    11

    10

    9

    10

    15

    20090630 J2020H - 102

  • HST ~E~

    HST CONTROL

    G292801 23,H8T

    o.=. 01i=l=~ i I t.:i1:i11¥~~§ -ro= Ng} IAa~'e:!:2 ""-0 ".2""

    SPEC. : QTY Effective: REM.NO. PART NO. PART NAME r--

    1 40195530

    2 40195532

    3 40012922

    4 40028158

    5 I 40029258

    6 I 40196600 BOLT-LINK STOPPER-TRG292 :33 ::Ll11HiH§: 1 2008-08-27 7 40028763 NUT-HEX 2 TY-S3050S0013 L,s IM6X1P 1 2006-11-30

    8 40029543 WASHER-SPR-S3610S0013 ~:!!::;j £1M lo.D12,2XI.D6.1 Xl.5T 1 2006-11-30 ' :

    9 40195512 :BRACKET-NEUTRAL SPRING-TRG292 ~~EI ~cP!l! 1 2008-08-28

    10 40029040 I NUT-HEX SMALL-S313080013 L,s ,M8XP1.25 2 i 2006-11-30

    11 40012133 I~OLT-AOJUST-TRG260 1 008 1 /200S-11-30 12 4022476S 'SPRING-NEUTRAL - TRG292 1 2009-06-30

    13 40028954 BOLT-HEX IMll 1 12006-11-30 I

    14

    15

    40009880

    40012935

    SHAFT-CONTROL - TRG292

    :BUSHING-A0677625

    125.5L

    1#76

    1

    1

    2006-11-30

    2008-11-30 l 16 40029131 PIN-SNAP-S443080013 ~\;lIt!! iD8XOL 1 2006-11 -30 i

    lINK-N EUTRAL-BOU-TRG292

    SHAFT-NEUTRAL-BDU-TRG292

    IBEARING-BALL-A0860002

    WASHER-PLN-S363100013 I 'RING-SNAP-S810010001

    gil;! i!l3

    g~ ~

    .lHIQj~

    lll£fM

    ~\:lI\!;/

    1

    1 2008-08-27

    1#60002

    '~-or I 2006-11-301

    : 1 200S-11-30O.018XI.D10.5X2T

    I "'I §'l!lDl0 2006-11-301

    I ...._-_.

    I

    !

    I

    I I

    I I

    i

    20090630 J2020H -103

  • HST ~E HST CONTROL

    G292so011i=-~3------ HST

    27

    25

    ~12

    22 14 17 15 23 7

    h 8 ~ 11

    ~13 10 8

    21 9 11 \Y ~~~

    5

    J2020H -104~---------20090131

  • HST ~E~ ..~ HST CONTROL

    G292801-3 H8T

    !:':i§1 Sft~t:!£ NO. : PART NO.

    1 I 40195514 2 40195515

    3 40195516

    4 40195517

    5 40195518

    6 40028157

    7 40195519

    8 40195527

    9

    I

    40195528

    10 40029040

    11 * 12 40195520

    13 40029131

    14 40195521

    15 40012681

    16 40029173

    17 40215611

    18 40205707

    19 40012728

    20 40206222

    21 40206221

    22 40206220

    23 40029132

    24 40212455

    25 40028973

    26 40029157

    27 40029265

    '='=04-.

  • .I:F ~~ ClII:H

    RANGE LEVER

    G293801-1 H8T

    15

    20090510 J2020H -106

  • ¥ 'i:!! ~ ell tH

    RANGE LEVER

    G293S01 1 HST

    1::!:2. 9-~1::!2 NO. PART NO.

    1 40195607

    2 40195605

    3 4019560B

    4 40195619

    5 40195617

    6 40195618

    7 40196976

    8 40197110

    9 40029197

    10 40010339

    11 40029203

    12 40011943

    13 40198669

    14 40012756

    15 40029168

    16 40197107

    17 40029261

    '='=0;-.5= PART NAME

    LEVER-SHIFT-4WD-TRG291 4WD~Clll:Il

    LEVER-RANGE-SHIFT - TRG291 ¥\'!"'~ClIIll

    LEVER-PTO-SELECTOR-TRG291

    LEVER-RANGE-TRG293 l7!~~cllH{

    LEVEA-4WD-TRG293 4£! fll= /:I11ll

    LEVER-PTO-TRG293 lIIEI2 Clll:Il

    FORK-PTO-TRG291 lI1E12.!l:3

    BOLT-RANGE SHIFT - TRG291 c.1 CH i!I:§:i!lj

    O-RING-S8Ql 011 010 2i§1

    BALL-SHIFT FORK-CVGOOO 1!!"'.!l:3l!1

    O-RING-SBOl 01501 0 2~

    SPRING-TRG290 ~8il1

    SPRING-TRG292 ~f£~

    BALL-STEEL-A067AOO6 ~Ii! \!!I

    PIN-SPRING-S446062512 ~8il1l!!

    RAIL-PTO SHIFT-TAG291 IIIEI2 \'!'" Clillol

    RING-SNAP-S81 0016001 ~\;lj~

    -

    A.gj' A. 2.~-.= ~2~ l:Il.:il SPEC. aTY Effective REM.

    1

    1

    1

    1 2009-05-10

    1 2009-05-10 1

    1 2009-05-10

    1

    1 2008-11-18

    Dl0.8XW2.4 3 2006-11-30

    1 2006-11-30

    D14.BXW2.4 1 2006-11-30

    Dl.6XD8.75X26.6L 1 2006-11-30

    1

    D114 1 2006-11-30

    D6X25L 3 2006-11-30

    1

    ~1!HID16 1 2006-11-30

    --_.

    20090510 J2020H .107

  • XI-~ ~xl REAR DIFFERENTIAL

    G310S01-1

    6

    14 h

    7 ~18 15

    11

    15

    19

    1 26

    d 28

    21 ~

    20090329 J2020H - 108

    23

  • -l!i:. A~-IAr CI CI A REAR DIFFERENTIAL

    G310801-1

    \:!i:2. ~~\:!i:2 NO. PART NO.

    1 ,

    40196995

    2 40196979

    3 40197120

    4 40012677

    5 40012706

    6 40198543

    7 40196998

    8 40197000

    9 40195609

    10 40197101

    11 40196980

    12 40036061

    13 40012423

    14 40198667

    15 40012699

    16 40012426

    17 40009888

    18 40195610

    19 40197102

    20 40199626

    21 40195611

    22 40029199

    23 40195612

    24 40116150

    25 40029176

    26 40029166

    27 40012949

    28 40012835

    -.

    t=l = 0;.,-5= Atgj' PART NAME SPEC.

    SHAFT-PINION GEAR(6T)-TRG31 0 lllLlei 710i !I!

    GEAR-CROWN RING(37T)-TRG310 3c.fll! 710i

    SHAFT-FINAL '" II' I Hlj;;l

    ''''0'''''._0, ,u.ouuu,

    R~I"'" ''''._0, #62060

    OIFF ASSY-HST REAR-G310 HST!! A!§ 3Sit1:11

    CASE-R/0IFF-TRG310 cia :MIOI:::::

    GEAR-SIDE DIFF(LH)-TRG310 Cia AtOIS 71 0i(3Sf)

    HOLDER-R/OIFF-TRG320 Cia ;1:1;1:101

    GEAR-SIDE DIFF(RH)-TRG31 0 Cia AtOIS JIOi(.

  • x~~ Jl~ ~xl DIFF-LOCK

    G320801-1 H8T

    7

    5

    9

    J2020H - 110 20090510 2

  • jJ~ .::i1 ~ ~ xl DIFF-LOCK

    G320S01 1 HST

    ~£! Ef1~~."§: NO. PART NO.

    1

    I

    40195613

    2 40195614

    3 40113928

    4 40029132

    5 40205707

    6 40029263

    7 40220818

    a 40008381 9 40028709

    10 40029071

    20090510

    !:f!~~ PART NAME

    I~EOAL-R/OIFF-HST- TRG320 LINK-R/oIFF-LOCK-TRG320

    i

    'PIN-HEAO-S4271 02513 Oil:!!!

    PIN-SNAP-S443100013 6EiJ!!!

    SPRING-CRUISE CTRL-TRG292 ~~5J

    RING-SNAP-S810018001 61;;!j!:!J

    BRACKET-SPRING-TRG320 6:!!!:!J!:!2.f'!l!

    PEDAL-DIFF-TRG970 CI:!! ll1Jii!

    SCREW-W/SP&PL WS-S227403011 ::::':::3¥f

    INUT-FLANGE-S34504oo13 li!E!iXJ Us

    J2020H -111

    Afg]' *15 ff2:g,j 1:J1::il SPEC. QTY Effective REM.

    1 2009-03-29

    1 2009-03-29

    D10X25L 2 2006-11-30

    D10XOL 2 2006-11-30

    1 2008-08-27

    1

  • G400S01-1

    6 ~5 4

    ~3 7

    20080627 J2020H -112

  • gtjJ~ ±~x~1 FRONT AXLE ASSY

    G400801-1

    t':!2' !;f.~~£ NO. PART NO.

    1 40195015

    2 40195042

    3 40195049

    4 40195048

    5 40012728

    6 40097105

    7 40029125

    i

    I

    !

    I

    I I

    I=l=~ ..1'5 = Af2J'

    PART NAME ! SPEC. FRONT AXLE ASSY-J-G400 '

  • 2l:xJ~ 31101 A FRONT AXLE CASE

    G400S02-1

    ~2

    3

    3

    20080627 J2020H -114 o

  • ~x~~ 3iIOI A FRONT AXLE CASE

    G400802-1

    \:l:js;;:' l:j'!~\:l:j.§ I l:j'!~'i!l

    I Afg} 1:l1::iJ.

    NO. I *~ I .g.£:'!§J

    SPEC. • QTY Effective REM. I----~-..--.-.. +-----------------~--~---+_-...----.-----._f--+---+--..----\

    PART NO. ! PART NAME

    1 40195024 CASE-F/AXlE-TRG400 'ilt];f~ 3t101~ 1 2008-11-08

    2 40206401 BOLT-HEX WIWS-SI53123543 M12X1.75X35l 8 2008-07-22

    3 40112472 PIN-PAR-S4231 02023 Dl0X20L 2 2006-11-30

    4 40195018 IPINION-RING DRV(11T)-TRG400 1lI11l!! JIOHln) l1T 1 2008-07-22

    5 40195045 COLLAR-TRG400 IOD51.7XID46X3.2T 2 2008-07-22I i6 40012681 BEARING-TAPER-A0670156 ElIOlnJ lila 1lI10ljS

    SPACER-TRG400 ~ll!IOIM7 40195040

    8 40195038 NUT-LOCK/M24-TRG400

    9 40195043 .lINER-TRG400 aOI Li

    2 2006-11-30

    I ; 2008-07-22

    2008-07-22

    OD51.7XID46XO,2T I' 5 ; 2008-07-22 1

    10 40029296 IRING-SNAP-S811052001 ~\Jii!J '2!f@i?!ID52 ~11-30!I 1---+---------+---------------- ~~T-2-li\I-I/--roo"'"· I' I40194976 SEAL-OIL-TRG40011

    I Iii I

    I

    ~~-----------r---------------------------------~!------------~~--~----+__.----

    I

    II I

    /"~,

    ! i I

    0 J2020H - 115

    20080627

  • ~X~ 31lOl A FRONT AXLE CASE

    G400S02-2

    t-12 17 13

    17

    5

    6

    18

    19

    15

    16

    19

    18

    20081108 J2020H - 116

  • ~x~~ ~IOIA FRONT AXLE CASE

    G400S02-2

    ~!:?:1 5f.~~.2. NO.• PART NO.

    1 40195025

    2. 40194978

    3 40152055

    4 40029300

    5 40012918

    6 40029279

    7 40112472

    8 40195028

    9 i 40195027

    10 40195026

    11 40187178

    12 40195039

    13 40029206

    14 40094010

    15 40206416

    16 40188670

    17 40117144

    18

    19

    I

    I I

    1----"

    I

    1=1 = 01 "T"=O Ng}\ PART NAME : SPEC.

    CASE-KING PIN-TRG400 ,!;H!l 31101""

    SEAL-OIL-TRG400 2'i?!§i liuo2xUUf2A

    BEARING-BALL-A0869100 iilIIlII01~ 1#691

    RING-SNAP-S811068001 ""\iii!;! ·"'lg>'1068

    BEARING-BALL-A0869090 li 1il101~ #69090

    RING-SNAP-S81 0045001 ",,\ill.., "'lg>'1045

    PIN-PAR-S4231 02023 ~ Dl0X20L

    COVEA-GEAR CASE-TRG400 J10131101"" '>HIl 1

    iCASE-GEAR-RH-TRG400 JI01 31101""(SF) I

    CASE-GEAR-LH-TRG400 JI01 31101''''(±)l

    BREATHER ASSV-AIR-G400 : 01101 -"".2.IC1 ::l;ilJ:Il1

    PLUG-OIL - TRG400 2'i?! licCl

    ,O-RING-S801 01801 0 2~ o 17.BXW2..4

    BOLT-HEX W/WS-S153103033 _5 Ml0XP1.5X30L

    BOLT-FLANGE(Ml0)-TRG400 fi'5XI_5 M 1 OX1.5Xl OL

    WASHER-A0667010 §i £1M iMl0

    IO-RING-S802085010 21'11 iD84.4XW3.1

    IBOL' FT-8163085543 lis iM8X1

    NUT, 1 TV-S301080043 L15 IM8X1

    I I i

    I

    i

    I

    I

    I

    I I

    I I

    *~ · ~R~.I l:l1.::.J. QTY . Effective. REM. 2 2008-11-08

    2 2008-07-22

    2 2006-12-13

    i 2 2006-11-30

    2 2006-11-30 !

    2 20mHI-301-~~"'~

    4 2006-11-30

    I 2 2008-07-22 1

    1 i 2008-11-08 I

    i 1 2008-11-08

    1 2007-11-19

    1 2008-07-22

    1 2006-11-30

    16 •2006-11-30

    2 2008-07-22 I

    2 a008-10-27

    2 i 2006-11-30

    2 2006-11-30 I

    2006-11-30 I2

    i

    i I

    I !

    I I

    i i

    I i

    i

    !

    I I

    I

    I I

    20081108 J2020H -117

  • Ol--L~ -L.5:.A."-1 :c:: Ar ==i Ar c::::> c::> A

    FRONT DIFFERENTIAL

    G400S03-1

    1

    ~ 2 -11

    2

    11

    9

    8 7

    20080627 J2020H - 118 o

  • 01- -L -L.5:.;:Q--,:r:r:. Ar Ar C) c;:) A

    FRONT DIFFERENTIAL

    G400803-1

    ~§.I !p~~S2. t=l = C>I.-5= Afg,t' .A. a, I O£tQl \-rc> TT e 1::I1.::i2 NO. I PART NO. PART NAME SPEC. aTY i Effective i REM.

    1 40195016 DIFF ASSY-FAONT-G400 CIE,3;il;I;tI1 1 2008-07-22

    2 40195020 CASE-DIFF-TAG400 CIE 31101':' 1 2008-07-22

    3 40195022 GEAA-DIFF SIDE(14T)-TAG400 CIE AfOI= 11 2 2008-07-22

    4 40195023 ILINER-DIFF GEAR-TRG400 CI!! JIOi 2 2008-07-22 '

    5 40195101 'BEAAING-BALL-AoaB0100 liItJllOi\!!! L!faDl 2 '2007-12-26

    6 40198538 RING-SNAP-S81 0017001 ,:,\;l!\!!! 10 2 '2008-03-06

    7 40195019 GEAR-RING(20T)-TRG400 tJll\1l! 120T 1 2008-07-22

    a 40205812 LINEA-MATE GEAR-TRG410 CI!! JIOi -el 2 2008-07-22 I

    9 40195021 GEAR-MATE(10T)-TRG400 1lII0Is JI0i(10T) lOT 2 12008-07-22 I 10 40205811 SHAFT-OIFF-TRG41 0 CIE ll!i 1 ; 2008-07-22 ,

    12 "Q"A~. .6!!~ ~ D4X36L 1 2006-11-30

    I i I I

    I

    I l

    I I

    I II .

    I I

    I

    I I

    1 l

    I

    I I

    I

    I I I

    i

    I

    I I I I

    20080627 o J2020H -119

  • ~:XJ~ =?~~xl FRONT DRIVE

    G400S04-1

    1 , 2

    ~ 3

    6

    15

    20081108 J2020H - 120

  • §Y: :XJ ~ =j1 ~~xl FRONT DRIVE

    G400804-1

    \:':l~1 Sf!~\:':l.2. NO. PART NO.

    -1 40195033

    2 40195034

    3 40029299

    4 40195047

    140012706

    40195029

    40195030

    40012702

    9 40195031

    10 40012714 ..__.

    11 40195046

    12 40195041

    13 40194977

    14 40195032

    15 I 40195035

    I

    I

    I

    I

    I I

    I

    I I

    '='=0;-r-i3= PART NAME

    "--' SHAFT-F{DIFF LH-TRG400 \li;l;f!!; CIE.!!;('Ef)

    SHAFT-FfOlFF RH-TRG400 \li;j;j!!; ClE. !!;(!i»

    RING-SNAP-S811062001 ""''ell!51

    WASHER-THRUST - TRG400 2.fOILi

    BEARING-BALL-A0862060 !!! tlIl~!5I

    GEAR-BEVEL(13T)-TRG400 tlIll!l!JI~(13T)

    GEAR-BEVEL(15T)-TRG400 ilIll!l!JI~(15T)

    IBEARING-BALL-A0862040 Ii tlIl~l1J

    IGEAR-8EVEL(9Tl-TRG400 I:llIi1l!JI~(9T)

    B EARING-8ALL -A0863040 !!! ilII~§l

    WASHER-THRUST - TRG400 2.fOILi

    COLLAR-SET-TRG400 ,\I15!ri2.f

    SEAL-Oll-TRG400 2il~

    IGEAR-8EVEL(38T)-TRG400 I:llIi1l!JI~(38T)

    I"r AFT "/,...,' ,,-TRG'Wv \li ;j;j!!;

    I "fill' *~ ~£iL~ I 1::l1::i1 SPEC. QTY Effective i REM. 1 2008-07-22 ' LH

    1 2008-07-22 RH

    :>;j§il!062 2 2006-11-30

    IOO60.8XI050XlT 3 2008-07-22

    '4162060 6 2006-11-30

    13T 2 2008-07-22

    15T 2 2008-07-22

    *62040 2 ! 2006-11-30

    19T 2 '2008-11-08 !

    1'"'63040 4 2006-11-30 "

    I ()1'l5? ~'>Ill'l, 2 2008-07-22

    4 2008-07-22

    lO35XOD52X12 2 2008-07-22

    1

    38T 2 2008-07-22 I

    2 12008-07-22

    I I I

    I

    I I

    I I

    II

    I

    I l I

    I I I 20081108

    J2020H - 121

  • ~x~ ~s=;:t§ REAR AXLE

    G480S01-1

    7

    5

    20090510 J2020H - 122

  • ~x~~ ~~F?-~ REAR AXLE

    G480801

    ./..-......."

    /'~'-,

    J2020H - 123

    'E:l.~: Ef!~~.2 NO. PART NO.

    1 40197122

    2 40197119

    3 40012916

    4 40029299

    8 40028949

    IBEARING-BALL-A0860070 • IlIIOH.1

    ;RING-SNAP-S811062001 :::::,\:11\9

    5 40028948

    6

    I

    40210229

    7 40028952

    9 i

    40196997

    10 40210228

    i

    ,

    I

    20090510

    !F~2:1 PART NAME

    CASE-FINAL DRIVE(LH)-TRG480 !i;li!Fi'§31101:::::'

    SHAFT-FINAL DRV-TRG481 !i;I~ilt~ 1IILI0I

    IBOLT-HEX W/WS-S1541 02533 lii!§'

    SEAL-OIL-A0651404-TRG481 .2~ ~

    BOLT-HEX W/WS-SI541 04533 !iii§'

    .BOLT-HEX W/WS-S154103033 !iii§'

    CASE-FINAL DRIVE(RH)-TRG480 !i;li!ii:r§3II01:::::'

    AING-SNAP-TRG481 :::::'\:11.,

    i

    I

    I I

    ..---...

    i

    Af2:!' SPEC.

    I .A. 2., ~.e.~ l::J1.Jl I aTY Effective REM.

    1 12008-11-18

    2 2008-11-18

    .#60070 4 2006-11-30

    !

    M10XP1.25X25L 12 .2006-11-30

    2 2008-11-18

    M 1 OXP1.25X45L 17 2006-11-30

    IM1 OXP1 .25X30L

    i

    4 2006-11-30

    I 1

    2 2008-11-18 I

    I I

    i

    I

    i

    l I

    i

    I I I

    i

    I i !

    i

    I I

    I

    I i i I

  • 2f,¥I El-OIOI

    FRONT & REAR WHEEL{TIRE)

    G490801-2 23x8.5-12/12-16.5

    5,6 7 ~

    7- 8

    8

    1,2 n 3- 4

    3

    13 14

    ~

    20080627 oJ2020H -124

  • ~,!f-I El-OIOi

    FRONT & REAR WHEEL(TIRE)

    G490801-2 23x8.5-12/12-16.5

    ~2! ~~I2j.2. I

    !?~~ N2 I *~l ~~~ ! 1:l1:i2 NO. PART NO. PART NAME SPEC. I OTY I Effective' REM.

    1 2010B713 TIRE ASSY-23X8.5-12/L-G490 EWIOl 11("") 1 '2008-10-24

    2 20108714 TIRE ASSY-23X8.5-12/R-G490 ElOIOI 1 2008-10-24

    3 40196674 TIRE-23X8.50-12-TRG490 ElOIOI 1 200B-02-19

    4 40196676 WHEEL ASSY-W7XI2-TRG490 Ij 1 i2008-02-19 I 5 20108715 TIRE ASSY-12XI6.5/L-G490 ElOI smfill(iG) '2008-10-24

    6 20108716 TIRE ASSY-12XI6.5/R-G490 ElOIOI 3"m~il(SF) 12008-1

    :17 40196675 TIRE-I 2X16.5-TRG490 ElOIOI 12ooa-v,,' a

    ! 40196677 WHEEL ASSY-W9. 75X1B.5-TRG490 ~f'i'l as~A11 I "V' -v,,' I~ i

    9 40029551 WASHER-SPR-S361120013 ~B:il;l 5?(M ,O.D21.5XI.DI2.2XST 12 2006-11-30 '

    .§ !

    ! 200B-II-3010 40077348 BOLT-HEX-Sl03123043 M 12Xl.25PXSOL 8 '--'--'-'--'--"- .,

    11 40095244 ,BOLT-STUD-SI67122523 ~E:l!=! ll§ MI2.XP1.25X25L 4 2006-11-30

    12 40028748 NUT-HEX 1 TY-S30212.0043 Li§ MI2Xl.2.5P 4 2006-11-30

    13 40029555 WASHER-SPR-S361160013 5?(M O.D2BXI.DI6.2X4T 12 2006-11-30

    14 ! 40029474 ,BOLT-HEX-S103163043 1i§ ,MI6Xl.5PX30L I B 12006-11-30, 15 40029014 BOLT-STUD-S 167162523 ~ElS 1lI§ M ,5X25L i 4 : 2006-11-30 I 16 40028752 NUT-HEX 1 TY-S302160043 Li§ M

    1 4 2006-11-30

    I I

    ! ! !

    i

    I

    I II ! i

    I I 1i

    i I

    I

    I I I

    ..--.. I

    l i I I I 20080627 o

    J2020H - 125

  • ~ gJ= ~ E:! [, ~ 2H~J STEERING CYLINDER & LINES

    G630S01-1

    13

    h 14-15

    16

    11

    7

    2

    10

    1

    h 2-4

    20080627 oJ2020H -126

  • ~~ ~ E:! [, ~ 2.l-e.!

    STEERING CYLINDER & LINES

    G630S01-1

    ~£ J¥~t::!:2 !:f.~~ I AfgJ A 2., ¥f-B.~ 1 tJl.:i1, .,-= NO. PART NO. PART NAME QTY Effective REM.

    1 40195008 PIPE ASSY-STR "Ei!i :ilgfllfOIE. "E!I 1 2008-12-01

    2 40195004 PIPE-STR 00"'''''' ,~ HC>O"U 1 2008-08-26

    :3 40009978 JOINT-TRG630 1001: 1 2006-11-30

    4 I

    40205704 ,JOINT - TRG630 1 2008-08-26 '

    5 40195011 iHOSE-STR CYL(LH)-TRG630 1 2008-08-26

    6 40195012 HOSE-STR CYL(RH)-TRG630 "Ei!i~!'lCi 2~(RH) 1 2008-08-26

    7 40010149 JOINT - TRG630 "EI'.!§. /PF3/S-PFI/4 2 2006-11-30

    8 40194814 CLAMP-RUBBER-TRG6:30 .:w.~ it~!! I 2 2008-08-26 9

    /

    40195076 IPIPE ASSY-STR DRAIN-G630 "Ei!i E2Ill'.!lIfOIE. "E I 1 2008-08-26 i

    10 40195075 ,PIPE-STR DRAIN-TRG630 "Ei!i S2I11'.! lIfOIE. 1 2008-08-26 '--'--"--"

    11 40009978 JOINT - TAG630 ~~§ OD12XPF3/8 1 2006-11-S0

    12 40205704 JOINT - TRG630 :2E21§ 1 2008-08-26

    13 40200996 CYLINDER ASSY-HYD/STR-G630 "Ei!i ~El[-! "E\l;Ix~1 1 2008-07-22 I

    I /TIE ROO ASSY-END-G610

    ! 2008-07-22 ,14 40200997 SOliEE eJ!E "E!lIJ:lI 2

    15 40194979 ROO ASSY-CYLINDER-G630 "Ei!i aiElCi 3>1!!"~1 I 1 2008-07-22 16 40195036 BRACKET -STA/CYLINDER LH-TRG400 3>i!i ai!'lC-l J:!2

  • STEERING WHEEL & COLUMN

    G630802-1

    13

    14 h 14-15

    4

    h 5-9

    5 1

    h6 2-4

    2

    3

    10

    o

    o

    20090630 J2020H - 128 3

  • STEERING WHEEL & COLUMN

    G630S02-1

    ~.21 !:f!.ilili~2 !:f!.ilili23 l Af2:1 ! Aal; ~ 0Rol 1:l1::i2-r C)- Tr a. i NO. PART NO. PART NAME ! SPEC. I OTY : Effective. REM.

    c------" ' ISTEERING SUB ASSY-G530 I~MO,1 20107783 ~1!IM!:!'~""A41 VULV

    2 40028947 BOLT-HEX W/WS-S1541 02033 lis M 1 OXP 1.25X20L 12005-' 1-30

    3 40194288 UNIT-STEERING-TRG630 ~1f~Ll§ 1 2008-08-26

    4 I 40194287 COLUMN ASSY-STEERING-G630 ~8I'~i!!l~",,~ 1 2008-08-25 ,

    5 40194286 SUPPORT-STEERING UNIT-TRG630 ::i!!ii=}US Ai;!§. I 1 2008-08-26

    ~~"-"~~-'--'

    I SHAFT-STEERING CTRL - TRG530 Z:;81'\!:!s.~ 1 2008-08-26

    7 40012932 BEARING-BALL-A0869044 II IllI00l!;l 4169044 1 2006-11-30

    8, 40029293 \RING-SNAP-S811037001 :::::\;;ll15l "'lg'ElD37 1 2006-11-30 I

    9 40029265 IRING-SNAP-S81 002000 1 :::::\;;lll!;j ,'lD20 I 1 2006-11-30 I

    ! 10 40028947 'BOLT-HEX W/WS-S1541 02033 i!!!:s ,Ml0XP1.25X20L 4 2006-11-30 '

    11 40029553 WASHER-SPR-S361140013 :::::Bil5l S?tkl IO.D24.5XI.DI4.2X3.5T 1 2006-11-30

    12 40029051 NUT-HEX SMALL-S314140013 Cls MI4XP1.5 1 2006-11-30 I

    I13 40194135 IWHEEL ASSY-STEERING-G630 ~~1!~1!fJ:41 1 i 2008-08-26

    IWHEEL-STEERING-TRG630 ~~tI .2008-11-26114 40194136 1

    15 40194137 ICAP-WHEEL - TRG630 ~I:!ttl i:!I i

    2008-11-26 [1

    16 40007532 I~OVER-RUBBER-TRG630 SCSI5-CO ID52 1 2005-11 -3~ I 17 40028163 WASHER-PLN-S363200013 l!lS?tkl O.D34XI.D21X3T 1 2006-11-30 ,

    18

    I

    40029035 [NUT-HEX-S306200043 Lis M20XP1.5 1 2005-11-30 I i

    I-i

    I

    I !

    i I

    I 1 I I i I

    I I

    I I I I I

    i

    !

    I

    !

    I

    I

    i

    I I

    J2020H - 129 20090630 3

  • t:::I 2:11 0 I.3. BRAKE

    G650S01-1

    5

    4

    2,7 (-

  • l:::J 2:11 0 I 3. BRAKE

    G650S01-1

    \'!:!:£ ~~~2 I I=l="l I Afg) ! .A 2!.~ ~R~ I I::ll::il-rae II""Q NO. PART NO. PART NAME I SPEC. QTY Effective. REM. 1 40198665 BRAKE ASSY-LH-TRG650 -'='211013 2!;\l;I:;IH~) 2008-11-18

    2 40198660 PLATE-CAM (LH)-TRG650 Jg liHIIOI§'(~) 2008-11-18

    3

    I 40198663 PLATE-PRESSURE-TRG650 gJ~~ 2008-11-18

    4 40198664 iPLA TE-FRICTION-TRG650 Ofst t!t 3 2008-11-18 .

    5 40198662 iHOLDER-BEARING-TRG650 tl110i~ AIAIQI 1 2008-11-18

    6 40198668 BALL -STEEL(A067 A016)-TRG650 ,6~ 5: 3 2008-11-18

    7 40198661 PLATE-CAM(RHl-TRG650 Jg Ii 2ll01 §.(5Fl 1 2008-11-18

    8 40198666 BRAKE ASSY-RH-TRG650 !:!21101132!;ir;lXfl(5F) 1 2008-11-18

    9 40195616 ARM-8RAKE-LH-TRG650 !:!c1l013 gt 1 2008-11-18

    10 40195615 ARM-BRAKE-RH-TRG650 !:!211013. gt 1 2008-11-18

    11 40029273 RING-SNAP-S81 0030001 ,6\;!1i!;)

  • t::I Cfl 013. lEI ~ BRAKE PEDALS

    G670S01-1 HST

    18

    11

    ~ 12 ~ 15

    17 n 7

    22

    J2020H -132 20090510 3

  • I::::I cllOl3 ml~

    BRAKE PEDALS

    G670801-1 H8T

    1!!S?:1 SF~t:1:2 NO. : PART NO.

    1 40194861

    2 40113926

    3 40029132

    I

    4 40028198

    5 40011962

    6

    I

    40194866

    7 40194863

    8 40194864

    9 40194865

    10 40029179

    11

    I 40210767

    12 40009515

    13 40029047

    14 40011928

    15 40196608

    16 40205707

    17 40008329

    18 I

    40007382

    19 40198667

    20 40012133

    21 i 40029040

    22 40094709

    23 40029079

    i

    I

    20090510

    t=I=C>l'-0= PART NAME

    PEOAL-BRAKE-TRG670 13 1111 it

    PIN-HEAO-S4271 02513

    PIN-SNAP-S4431 00013 i 'WASHER-PLN-S3651 02613 21);j : SPRING-TRG670 6E~

    SHAFT-BRAKE PEDAL-TRG670 '=!.aI0131111>t

  • ~JI HH~ ELECTRICAL WIRING

    .~.

    G730801-1 A8AE

    1

    4

    6

    7~ 'lll1I!~--

    8~=i=

    220090531 J2020H -134

  • ~JII:fH~ ELECTRICAL WIRING

    G730801-1 A8AE

    E:!2: !¥~t::!2. NO. PART NO.

    1 40196931

    2 40007141

    3 40029008

    4 40197105

    5 40196398

    6 40012733

    7 40012938

    8 40012735

    i

    I I i

    ! i

    I 20090531

    I l¥~g!

    IPART NAME HARNESS-FRONT lIGHT(J)-TRG730 ~",gtiHCj

    HARNESS-EARTH-TRG730

  • ~AI BATTERY

    G740S01-1

    4

    3 5

    2

    20080627 oJ2020H - 136

  • ~~AI BATTERY~,

    G740S01-1

    \=l'i= ' ~5:!. ~~~.2. NO. PART NO.

    1 40196657

    2 40196081

    3 40028971

    4 40196814

    I I 9~2i! II Ng} *is ~B.~

    PART NAME SPEC. • QTY Effective I l---'--------LB-A-TT-E-RY---4-SA-H-(-3S-A-H-)--T-RG-7-4-0-------:t->ci-,2.-I----..L3-e-AH/5HR(45AH/20;"lR) 1

    ICLAMP-BATTERY-TRG740 !>!Cil2J ~E!lg I 1

    'BOLT-HEX W/WS-SI55082033 ~§ 'M8XPI 25X20L 1

    ,CABLE-BATTERYH-TRG740 ~[ili'.1 :IIIOI.H 20SQ 1

    ,2006-11-30

    2008-09-01

    2008-08-251

    2008-09-01

    5 40196813 CABLE-BATTERY(+)-TRG740 ~[1I2.1 :IIIOlli(+) 20SQ I 1 i 2008-09-11 I

    I I

    I I

    I !

    20080627 J2020H -137

    tll.J1 REM.

    "'

    /,.,--..."

    0

  • JII JI i!!-~ METER PANEL

    G750801-2 A8AE

    4

    G750S0L3

    /

    6

    20090531 J2020H -138

  • J:l1 J I 1!!-~

    METER PANEL

    G750801-2 A8AE

    Ei.S'?: ~~~£ NO. PART NO.

    1 40029000

    2 4Q196911

    3 4Q029073

    4 4Q194373

    5 40012304

    6 40007081

    7 40029068

    8 4Q029008

    9 40032534

    1---".

    -

    - ..

    ,=,=OJ-.""= PART NAME

    iBOLT-HEX W/WS-SI59062033 i!§ ! :UNIT-FLASHEA(ASAE)-TRG750

    NUT-FLANGE-S345060013 liEl


YIO-390-B SERIES PARTS CATALOG - Lycoming Engines · yio-390-b series parts catalog wide cylinder flange crankcase model engines crankcase, crankshaft and camshaft group crankcase

YIO-390-B SERIES PARTS CATALOG - Lycoming Engines · yio-390-b series parts catalog wide cylinder flange crankcase model engines crankcase, crankshaft and camshaft group crankcase

Retrofit Crankcase Ventilation for Diesel Engines - MDECmdec.ca/2014/S6P2-Stekar.pdf · Diesel Engine Tailpipe PM versus Crankcase PM Emissions ... Mechanical shear (camshaft, valve

Retrofit Crankcase Ventilation for Diesel Engines - MDECmdec.ca/2014/S6P2-Stekar.pdf · Diesel Engine Tailpipe PM versus Crankcase PM Emissions ... Mechanical shear (camshaft, valve

LF160-AH - Tie Down EngineeringLF160-AH 1 Crankcase Assy 2 Crankcase Cover 3 Cylinder Head 4 Crankshaft, Piston, Rod 5 Camshaft and Valve Train 6 Carburetor Assy 7 Fuel Tank 8 Air

LF160-AH - Tie Down EngineeringLF160-AH 1 Crankcase Assy 2 Crankcase Cover 3 Cylinder Head 4 Crankshaft, Piston, Rod 5 Camshaft and Valve Train 6 Carburetor Assy 7 Fuel Tank 8 Air

Plaintiffs Rocker Management, LLC, Rocker Partners, … Share Vacation Club v. ... (Am. Compl. ¶ 10). Plaintiff Rocker Offshore Management Company, Inc. (“Rocker Offshore”) is

Plaintiffs Rocker Management, LLC, Rocker Partners, … Share Vacation Club v. ... (Am. Compl. ¶ 10). Plaintiff Rocker Offshore Management Company, Inc. (“Rocker Offshore”) is

PARTS LIST manual/32416_w52-15.0...TABLE OF CONTENTS 200 Cylinder Block 202 C.vl i nder Head 204 Crankshaft - Piston 206 Valves - Camshaft - Rocker Shaft 208 Timinq Gear Cover 210

PARTS LIST manual/32416_w52-15.0...TABLE OF CONTENTS 200 Cylinder Block 202 C.vl i nder Head 204 Crankshaft - Piston 206 Valves - Camshaft - Rocker Shaft 208 Timinq Gear Cover 210

Camshaft (1)

Camshaft (1)

Adjustable pumping volume through quick, one lever speed ... · PDF fileThe crankshaft, camshaft, rocker arm and rotating parts are supported by multiple-layer bushing. ... Curvas

Adjustable pumping volume through quick, one lever speed ... · PDF fileThe crankshaft, camshaft, rocker arm and rotating parts are supported by multiple-layer bushing. ... Curvas

rt2837.000 RPM Camshaft Kit — Includes camshaft. lifters, springs. retainers. push rods. adjustable rocker arms. Same as above but with springs that allow up to 8.000 RPM. GFMD.6250.W

rt2837.000 RPM Camshaft Kit — Includes camshaft. lifters, springs. retainers. push rods. adjustable rocker arms. Same as above but with springs that allow up to 8.000 RPM. GFMD.6250.W

M.G. MIDGET Mk. II - Holden · 2020. 1. 10. · tive fitting for valve ummg. Sprockets must be removed and assembled together. Camshaft runs in three bear ings in crankcase. Front

M.G. MIDGET Mk. II - Holden · 2020. 1. 10. · tive fitting for valve ummg. Sprockets must be removed and assembled together. Camshaft runs in three bear ings in crankcase. Front

Camshaft & Lifter

Camshaft & Lifter

Lycoming Aircraft Engines Parts Catalog Parts...LYCOMING 0-235 SERIES PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP OIL LEVEL GAGE ASSEMBLIES FIG. PART REF. NUMBER 2 1 75735

Lycoming Aircraft Engines Parts Catalog Parts...LYCOMING 0-235 SERIES PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP OIL LEVEL GAGE ASSEMBLIES FIG. PART REF. NUMBER 2 1 75735

Camshaft Installation Instructions For Installing: Part # 65206 – … · 7 Camshaft removal 4.0 CAMSHAFT INSTALLATION GUIDELINES With a flashlight look down the camshaft bore into

Camshaft Installation Instructions For Installing: Part # 65206 – … · 7 Camshaft removal 4.0 CAMSHAFT INSTALLATION GUIDELINES With a flashlight look down the camshaft bore into

SOHC ENGINE MECHANICAL - matiz-club.com3 Cylinder Head Cover (Euro III) 4 Distributor Case 5 Camshaft 6 Exhaust Rocker Arm 7 Cylinder Head Gasket 8 Cylinder Head 9 Intake Rocker Arm

SOHC ENGINE MECHANICAL - matiz-club.com3 Cylinder Head Cover (Euro III) 4 Distributor Case 5 Camshaft 6 Exhaust Rocker Arm 7 Cylinder Head Gasket 8 Cylinder Head 9 Intake Rocker Arm

I I' §~::~:::::::::::::~~; ::::::::::::::. programs/EMD compact data.pdfGI, At Filter Outlet (to engine) 12- 25 psi N'm Ft·Lbs Camshaft drive housing-to-crankcase 88 65 Oil manifold-to-oil

I I' §~::~:::::::::::::~~; ::::::::::::::. programs/EMD compact data.pdfGI, At Filter Outlet (to engine) 12- 25 psi N'm Ft·Lbs Camshaft drive housing-to-crankcase 88 65 Oil manifold-to-oil

Crankcase Ventilation Manager CVM200 - Cummins … · Crankcase Ventilation Manager CVM200 Crankcase Ventilation Management for Emissions Compliance and a Cleaner Environment CRANKCASE

Crankcase Ventilation Manager CVM200 - Cummins … · Crankcase Ventilation Manager CVM200 Crankcase Ventilation Management for Emissions Compliance and a Cleaner Environment CRANKCASE

CUSTOM-MOLDED SHOE ORDER FORM Apis Footwear Company … · Heel-to-Toe Rocker Severe Angle Rocker Double Rocker Rocker Bar ega v Heel Rocker LOP Rocker 3/4 Steel Shank Full Length

CUSTOM-MOLDED SHOE ORDER FORM Apis Footwear Company … · Heel-to-Toe Rocker Severe Angle Rocker Double Rocker Rocker Bar ega v Heel Rocker LOP Rocker 3/4 Steel Shank Full Length

1978-1979 Honda CX500 Table of Contents E01 Radiator ...ftso.net/cx-gl/parts_manuals/78-79_CX500_Parts.pdf · E06 Valve, Upper Rocker Arm E07 Camshaft, Lower Rocker Arm E08 Clutch

1978-1979 Honda CX500 Table of Contents E01 Radiator ...ftso.net/cx-gl/parts_manuals/78-79_CX500_Parts.pdf · E06 Valve, Upper Rocker Arm E07 Camshaft, Lower Rocker Arm E08 Clutch

E1 CRANKCASE / BR50 ENGINE - motorroller.de · E1 CRANKCASE / BR50 ENGINE No. Part No. Q’TY PART NAME PART NAME REMARK 1 P5061010000 1 RH. CRANKCASE 2 P5062010000 1 LH. CRANKCASE

E1 CRANKCASE / BR50 ENGINE - motorroller.de · E1 CRANKCASE / BR50 ENGINE No. Part No. Q’TY PART NAME PART NAME REMARK 1 P5061010000 1 RH. CRANKCASE 2 P5062010000 1 LH. CRANKCASE

The V8-5V Engine - audipages Homeaudipages.com/files/V8-5VEngine.pdf4 New features – Five-valve cylinder head with roller rocker – Camshaft adjustment – 3-stage variable intake

The V8-5V Engine - audipages Homeaudipages.com/files/V8-5VEngine.pdf4 New features – Five-valve cylinder head with roller rocker – Camshaft adjustment – 3-stage variable intake

CRANKCASE AND REED VALVE ENG - Quality … CRANKCASE AND REED VALVE ENG 4. Tighten: 8 Crankcase holding screws 12 Nm(1.2 m.kg, 8.4 ft.lb) NOTE: Tighten the crankcase holding screws

CRANKCASE AND REED VALVE ENG - Quality … CRANKCASE AND REED VALVE ENG 4. Tighten: 8 Crankcase holding screws 12 Nm(1.2 m.kg, 8.4 ft.lb) NOTE: Tighten the crankcase holding screws