Preservation process Compression Torsion Bending - … or aseptically. ... processing techniques...
Transcript of Preservation process Compression Torsion Bending - … or aseptically. ... processing techniques...
50 AAOS Now May 2011 Research and Quality Research and Quality May 2011 AAOS Now 51
tion of tissue allografts. Grafts such as tendons or pieces of bone for skeletal reconstruction, which are used in structural situations, have to be processed in a manner that does not signi� cantly alter their inherent mechanical proper-ties. These grafts are cleaned and processed using low-dose irradia-tion, a chemical technique, or both to achieve “sterility.”
Allografts may also be processed aseptically without any second-ary attempts at sterilization. These grafts must be rigorously con-trolled for bacterial contamination and are usually stored in a frozen state. Freezing an allograft has little impact on the mechanical properties of the tissue and will diminish its immunogenicity (Table 1). Freezing will affect the viability of articular cartilage un-less some form of cryopreservation is employed.
Tissue can also be freeze dried. Freeze drying further diminishes the immunogenicity of the graft and may be helpful in eliminating the bacterial contamination (Ta-ble 2). It does however, have some negative effect on the mechanical strength of the grafts, especially if rehydration is not done properly in the operating room. Gamma radiation is effective in killing bac-teria, fungi, spores, and, to a lesser degree, viruses. Depending on the dose, however, gamma radiation can weaken the graft. Doses below 1.5 mrad do not seem to adversely affect the tissue strength.
“Nonstructural” products, which do not require mechanical properties, include demineralized
or “� ller” products to encourage new bone growth. An assay of the bioactivity of demineralized bone matrix may be available and should be considered when choos-ing an inductive product. These products can be processed either sterile or aseptically. Gamma irra-diation and excessive heat (> 60 degrees C) is known to dam-age bone proteins. Freezing or freeze drying does not appear to af-fect the healing properties of bone.
ConclusionIn considering the use of allograft tissue for orthopaedic reconstruc-tion procedures, the surgeon must understand both the source and the processing techniques used to pro-duce the graft. Only then can he or she take advantage of this valuable material to rebuild and replace skeletal structures biologically.
NOW
References and resources for this article can be found in the on-line version, available at www.aaosnow.org
Steven Gitelis, MD, and Ross Wilkins, MD, are members of the AAOS Biological Implants Committee. Dr. Gitelis can be reached at [email protected]; Dr. Wilkins can be reached at [email protected]
Disclosure information: Dr. Gitelis—Wright Medical Tech-nology, Inc.; Dr. Wilkins—Wright Medical Technology, Inc., allosource, AATB
Table 1: Mechanical effect of processing on bone
Preservation process Compression Torsion Bending
Deep freezing 120% No change 90%
Freeze-drying 120% 39% 75%
Radiation (6 MRad) 80% 65% 70%
Note: Measures are compared to control (unprocessed allograft bone)
Table 2: Processing effects on bone strength, viability, and immunity
Technique Immunogenicity Mechanical Cartilage Properties Viability
Fresh Strong Normal strength Totally viable
Frozen Partial Normal strength Partially viable
Freeze-drying None Partially weakened Dead
Various preservation processes have different effects on the mechanical prop-erties of bone compared to unprocessed controls, as shown.
Allograft processing techniques may affect bone strength (mechanical prop-erties), immunogenicity, and cartilage viability, as shown.
Fifth Annual
Course DirectorsWalter R. Lowe, M.D.Russell M. Paine, P.T.
InterContinental HoustonHouston, Texas
A Unique Educational Opportunity Featuring Nationally Recognized Sports Medicine Experts
JUNE 3-5, 2011
Presented by
Catch the latest developments!The fifth annual Sports Medicine Symposium of the Americas brings together some of the biggest players in the field to address the latest therapy and technology in a dynamic learning environment. Expert physicians, physical therapists and athletic trainers will cover cutting-edge scientific information, share their experience in treating specific types of patients and offer thought-provoking previews of what the future holds.
Move your knowledge forward with these great symposium features!• Case Presentations• Hands-on Lab Sessions• Authoritative Panel Discussions• Insight on Emerging Technologies and Approaches• Collaborative Sharing of Ideas
AAOS Now_May 2011.indd 51 4/27/2011 3:04:46 PM