OSI Steel Pvt. Ltd.Pune - Kolkata - Delhi

INTRODUCTION OSI Steel Pvt Ltd (OSI) was incorporated as a private limited company for

steel trading. The company then entered into a 50:50 Joint venture with a Japanese Steel Trading House, for promoting Japanese Steel Mills to the Indian customers. In the year 2011 OSI was fortunate to become the direct Trading house for Hyundai Steel, Korea.

The Company 2 Divisions of business:Steel Division

1. Flat Steel - Hyundai Steel, Dongbu Steel, Korea 2. Steel Tubes – Imported and Local 3. Bus Door operating Equipments – Taihei Denki, Japan

Renewable Energy & Disruptive Technologies Division 1. Waste to Energy – in partnership with Eternal Vision, Japan 2. Organic Solar Films – in partnership with Heliatek, Germany 3. Magnesium Air Battery - in partnership with Aqumo Holdings, Japan 4. Small Wind Mills – in partnership with Energy Home, Netherlands 5. Air to Water - in partnership with Rainmaker Worldwide, Netherlands

OSI Steel Pvt Ltd

INTRODUCTION OF Small wind MillsOur Small wind mill technology is in partnership

with – Home Energy, Holland. The company provides innovative & environmentally friendly wind mill solutions.

Wind PowerThe Energy Ball is a spherical small wind turbine and is

in particular suitable for installation in both rural & urban area’s. Since the Energy Ball does not cause any nuisance due to noise or shadow, permits are generally granted faster than comparable small wind turbines..

OSI Steel Pvt Ltd

The Energy Ball

The Energy Ball is installed on a free standing pole with a total height of 10 or 15 meter, or on a flat roof mast with a total height of 3 meters. The advantages of the Energy Ball compared to a conventional wind turbine with propeller are:

No noise; the sound of wind turbines is caused by the air flow at the end of the blades (propellers), by the spherical design of the Energy Ball these ends lack and therefore the Energy Ball is noiseless.

Higher efficiency; the aerodynamic design of the Energy Ball ensures higher efficiency of power generation by surface flows, compared to traditional wind turbines.

Aesthetic design; the shape and appearance of the Energy Ball are excellent suitable for placement near buildings, especially in combination with its quietness. Its design also prevents the formation of shadow. Due to its attractive appearance, the Energy Ball is a great favourite of architects and project developers.

OSI Steel Pvt Ltd

The Energy Ball

OSI Steel Pvt Ltd

Energy Ball V 100

At a wind speed of 17 m/s (wind force 8 Beaufort) the Energy Ball V100 reaches its maximal output, the maximal output of the Energy Ball V100 is 550 Watt. When the Energy Ball V100 is delivering its maximal output, the power supplied to the grid by the WindPower Inverter is 500 W. The Energy Ball V100 is capable of generating 500kWh per annum at a site with an average wind speed of 7 m/s. It is however necessary to install the Energy Ball V100 in an open location on top of a high pole (12 m) to achieve this.

Average annual wind speed( m/s) [Beaufort] Energy / year [kWh]7.5 m/s 4.5 650 kwh7.0 m/s 4.5 500 kwh6.0 m/s 4.0 350 kwh5.0 m/s 3.5 200 kwh4.5 m/s 3.0 150 kwh4.0 m/s 3.0 100 kwh

OSI Steel Pvt Ltd

Energy Ball V200

At a wind speed of 19 m/s (wind force 8 to 9 Beaufort) the Energy Ball V200 reaches its maximal output, the maximal output of the Energy Ball V200 is 2500 W. When the Energy Ball V200 is delivering its maximal output, the power supplied to the grid by the WindPower Inverter is 2250 W. The Energy Ball V200 is capable of generating 1750 kWh per annum at a site with an average wind speed of 7 m/s. It is however necessary to install the Energy Ball V200 in an open location on top of a high pole (15 m) to achieve this.

Average annual wind speed( m/s)[Beaufort] Energy / year [kWh]7.5 m/s 4.5 2200 kwh7.0 m/s 4.5 1750 kwh6.0 m/s 4.0 1000 kwh5.0 m/s 3.5 500 kwh4.5 m/s 3.0 340 kwh4.0 m/s 3.0 240 kwh

OSI Steel Pvt Ltd

Applications

OSI Steel Pvt Ltd

Applications

OSI Steel Pvt Ltd

Applications

OSI Steel Pvt Ltd

Street Lights

Power your street lights sustainably and efficiently with the Home Energy Streetlight!

 Introduction

The Home Energy Streetlight is a clever combination of an Energy Ball and solar modules, thereby making optimal use of the compliment character of these two renewable energy sources.

The Streetlight is capable of converting enough wind and solar energy to not only power  sustainable and energy-efficient LED lighting, but also supply sufficient power to charge for example ◦ An electric bicycle or car. ◦ It can also be equipped with electronic charging points for PC and / or

mobile phone ◦ And can even function as a WiFi hotspot.

OSI Steel Pvt Ltd

Street Lights The Home Energy Streetlight is available in four different versions:

STREETLIGHT SThe Streetlight S is the smallest and is the ideal solution for sustainable streetlights. The Streetlight S consists of an Energy Ball V100 and a 240 Wp solar module, installed on a mast with a length of 9 meters. Optionally the Streetlight S is fitted with a banner, LED fixture or charge point for your electric bicycle, scooter, car or boat.

STREET LIGHT MThe Streetlight M consists of an Energy Ball V100 and two 240 Wp solar panels, installed on a mast with a length of 9 meters. Optionally the Streetlight M can be provided with a banner, LED fixture or mount point for your electric bicycle, scooter, car or boat.

STREETLIGHT LThe Streetlight L consists of an Energy Ball V200 and two 240 Wp solar panels, installed on a mast with a length of 10 meters. Optionally the Streetlight L can be provided with a banner, LED fixture or mount point for your electric bicycle, scooter, car or boat.

STREET LIGHT XLThe Streetlight XL consists of an Energy Ball V100 and three 240 Wp solar panels, installed on a mast with a length of 12 meters. Optionally the Streetlight XL can be provided with a banner, LED fixture or mount point for your electric bicycle, scooter, car or boat.

OSI Steel Pvt Ltd

OSI Steel Pvt Ltd

Applications

Hybrid Street Light

Other Applications Cell phone towers. The ball can be connected to the pole of the cell tower

and can be connected to a battery pack which is used for running the ventilator / router. Below are some pictures of energy balls at telecom sites.

Metro Railway: elevated tracks and metro Stations Elevated Roads & flyovers

OSI Steel Pvt Ltd

Waste To Energy The Waste to Energy Technology is in partnership with Eternal Vision, Japan

The high light of this technology is that it is easy to operate and can be designed to process any type of waste. Further the most important aspect is that unlike the present technologies, this technology can be designed to make a very small size plant for processing just 50 kgs per day and above - up to 50 MT per day.

Some of the major highlights are below: We can supply Small device from 50 kgs per day (8 hrs) and above We can design the device for any specific waste or combination of wastes - The device can process any

type of waste, it can be designed to process a Single waste or mixture of waste The device is very easy to operate, No Engineer or highly skilled required operating the device. Only 2-

3 persons required to run the device No complicated auxiliary equipment like boilers etc is required to generate electricity, or if you use

boilers – you can use the gas to feed your boilers instead of expensive electricity or fuel The device requires very less space – the smallest plant requires only 15 sqm. 99.93% combustion efficiency Left over ash can be used as landfill, or made into bricks or mixed with concrete for use in pavements This technology can be suitable for villages also, where the agricultural waste and other solid waste

can be processed to produce electricity.

OSI Steel Pvt Ltd

Waste To Energy

OSI Steel Pvt Ltd

Organic Solar Films We are the partners to Heliatek Germany, who the makers of ORGANIC Solar

Films - HeliaFilm*. Our Solar films can be used for commercial , residential and Industrial

buildings  and also for the auto sector like  Public Transport (AC Buses),  refrigerated Trucks, Railway coaches etc. Kindly note that these films unlike standard Solar panels, can be DIRECTLY PASTED on glass, steel, aluminium, concrete and even  the bus roofs, without any hassles.

These solar films have very unique features as below: HeliaFilm* are flexible unlike the standard solar films HeliaFilm* can be directly pasted on to steel, aluminium, glass and even

concrete HeliaFilm* are very thin HeliaFilm* are available in several colors HeliaFilm* are more efficient and gives more power during low sunlight and

high temperatures unlike the standard solar films These films are also suitable for: Walkways, Car parking, railway stations, Air

balloons etc.

OSI Steel Pvt Ltd

Organic Solar Films

Glass Facade Street Walkway PVC Membrane

OSI Steel Pvt Ltd

OSI Aqumo Candle We have partnered with a Japanese company to supply- Water activated LED light (Candle) The

Candle is an LED light based on Magnesium Air Battery technology.  People in electricity deficient areas who have poor or no access to electricity, use candles or

kerosene lamps, which is not only harmful but also polluting, and highly subsidised by the government.

Further with disasters, like earth quakes, floods occurring more often, light & communication is one of the most important requirements for mitigation of relief of the affected people.We would like to introduce our economical and safe LED lights for such situations.

  Aqumo Candle.

Water activated LED light 'Aqumo Candle' Aqumo Candle is an LED light based on Magnesium Air Battery technology. 

It is a small and light device activated by water. Add a small amount of water or juice (even saliva) Aqumo Candle

will immediately light up Once activated, The Candle continues to illuminate for two week,

with intermittent dipping In case of emergency even urine or any other liquid can be used to light the candle

OSI Steel Pvt Ltd

OSI Aqumo Candle

Handy type MG-Air battery

Once a large-scale disaster happens, blackout may continue for a week. Handy type MG-Air battery is powerful enough to illuminate rooms or charge smart phones. It is also convenient for outdoor activities

 Next generation Mg-Air Battery A portable electric generator to provide maximum 2A by adding 15% salt water. The power can be adjusted

connecting units in series.

OSI Steel Pvt Ltd

Air To Water

We have partnered with Rainmaker Worldwide, Netherlands for making water out of air. The Rainmaker concept is a system whereby a stand-alone wind turbine is placed in rain lacking regions. This system is especially suited for such environments without proper infrastructure and access to water sources.

Our Partners system, literally, makes freshwater from air! The system’s wind turbine does not drive a generator to produce

electricity, as is commonly the case. Instead it drives a heat pump which is directly powered by the wind turbine’s blades. With the heat pump the water vapour in the air is condensed and collected for domestic drinking water or irrigation purposes.

Operating principleDepending on local ambient temperatures and humidity conditions air always contains a certain amount of water. This makes it possible to make water from air almost anywhere in the world. For example, air at 20 0C and 50% RH (relative humidity) contains approximately 7 grams of water per kilogram of air whereas air of 300C and 50% RH contains almost 14 grams of water/1 kg of air. (1 m3 of air weighs approx. 1.3 kg).

OSI Steel Pvt Ltd

Air To Water

OSI Steel Pvt Ltd

Water to Water

Our Partners concept is based on a modified “standard-type” windmill in which no electricity but heat is produced, through the use of a heat pump. This heat is used in a “flash evaporation” process. In this way different water sources such as sea water or polluted surface water like arsenic, fluoride infected can be purified. A relatively small windmill already has a significant capacity and can be used for drinking water, sanitation water or irrigation.

When Local Water is Available The water production unit is distinct from the Air to Water Solution, even though it

utilizes the same proprietary direct driven compressor system. The Water to Water (WW) Solution is even more energy efficient than the Air to

Water Solution, utilizing a thermal process similar to Multi-Stage Flash (MSF) and Multiple-Effect Distillation (MED), but in a unique hybrid process that utilizes a membrane as well. The process is known as Multi Effect Membrane Distillation (MEMD or MD).

Water that evaporated under low pressure by means of a heat pump condenses again and returns heat to the evaporator. This system makes it possible to desalinate large quantities of water with very little energy. Expected yield is approx. 90000 ltrs per day and mostly dependent on the size and power capacity of the chosen location and installation.

OSI Steel Pvt Ltd

Water to Water

OSI Steel Pvt Ltd

CONTACT USOSI STEEL PVT LTDHead Office Premises No.20, Goldfield Plaza, 45, Sassoon Road, Opposite Wadia College, Pune 411001 Phone: 91- 9975080515

Warehouse Chakan, Pune 410 501 Maharashtra, India

Contact Pradip Saraogi : saraogipradip@gmail.com Rajendra Sangale : sangaler@gmail.com

OSI Steel Pvt Ltd