Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
-
Upload
international-aquafeed-magazine -
Category
Documents
-
view
220 -
download
0
Transcript of Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
1/9
March | April 2014Poultry hydrolysates enhance stress
resistance and stress tolerance in Pacificwhite shrimp
The International magazine for the aquaculture feed industry
International Aquafeed is published six times a year by Perendale Publishers Ltd of the United Kingdom.All data is published in good faith, based on information received, and while every care is taken to prevent inaccuracies,the publishers accept no liability for any errors or omissions or for the consequences of action taken on the basis ofinformation published.Copyright 2014 Perendale Publishers Ltd. All rights reserved. No part of this publication may be reproduced in any formor by any means without prior permission of the copyright owner. Printed by Perendale Publishers Ltd. ISSN: 1464-0058
INCORPORAT ING
F ISH FARMING TECHNOLOGY
http://www.aquafeed.co.uk/http://www.aquafeed.co.uk/ -
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
2/9
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
3/9
Aquaculture is intensifying in
almost all regions of the world
in order to supply the increasing
demands for fish and shrimp.
In Thailand the average stocking den-sity has quadrupled from approximately 40
shrimps/m2 to almost 160 animals/m2.
However, this intensification is often com-
bined to sub-optimal conditions for fish and
shrimps. Problems associated with higher
disease susceptibility have to be faced.
Some of these stress conditions may
be compensated by aquaculture production
practice and/or by an increase use of pharma-ceuticals and antibiotics which in turn affect
food safety.
A ban of antibiotic growth promoters in
many importing countries has forced the indus-
try to search for environmentally friendly alter-
natives. And a natural solution to combat stress
conditions is the use of hydrolyzed proteins.
Fish protein hydrolysates (FH) are consid-
ered as biological active ingredients due to
their beneficial properties to be antioxidative
or antimicrobial (Klompong et al. 2007).The use of FH in diets has proven to
improve growth and performance in fish
for example, Atlantic salmon (Berge and
Storebakken, 1996),
catfish (Herault et
al. 2012) and tiger
prawns P. monodon
(Anggawati et al.
1990) by enhancing
stress resistance and
immunity. Anggawati
et al. (1990) found that
three percent FH was
enough to enhance
shrimp growth.
The immune
boosting effect of FH
is reported due to its
content of peptides,
free amino acids and nucleotides. Although
these peptides can be found in FH, they are
not restricted to marine proteins, only.
Poultry protein derivatives, especially
hydrolyzed poultry proteins, are (as FH) rich
in bioactive peptides, which are able to com-pensate stress conditions.
The benefits of poultry peptidesThe article describes the beneficial effects
of poultry peptides in respect of enhancing
stress resistance/tolerance and immunity in
Pacific white shrimps (Litopenaeus vannamei)
under controlled conditions.
Under controlled laboratory conditions
hydrolyzed poultry peptides (enzymatically
hydrolyzed liver (eL), enzymatically hydro-lyzed meat & bone-mush (eMB)) have been
tested to see the effect on growth perform-
ance in shrimp. The properties of those
peptides are given in Figure 1, indicating the
small molecular size distribution.
Poultry hydrolysates enhance stress resistanceand stress tolerance in Pacific white shrimpby Orapint Jintasataporn Department of Aquaculture, Faculty of Fisheries, Kasetsart University, Bangkok, Thailand and Franz-PeterRebafka, GePro Gefluegel-Protein Vertriebsgesellschaft mbH & Co. KG, Germany
Table 1: Composition of the experimental diets
Raw material Control eL eMB
Fishmeal, tuna 30 7 7
Soybean 9 34 34
Shrimp meal 15 4 4Squid meal 5 1 1
Wheat flour 31.4 29.2 28.85
Hydrolyzed poultryliver
0 5 0
Hydrolyzed poultrymeat & bone
0 0 5
Soy protein isolate 0 6 6
Tuna fish oil 3 3 3
Soya oil 2 2.75 3.1
Squid liver oil 1 1 1
Met + Lys 0 0.45 0.45Mono-cal 1 4 4
Binder 1.7 1.7 1.7
Vitamin-mineralpremix
0.9 0.9 0.9
14 | INTERNATIONAL AQUAFEED | March-April 2014
FEATURE
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
4/9
The trial was conducted in June 2012 at
Kasetsart University, Bangkok, Thailand, by the
Department of Aquaculture, Faculty of Fisheries,
in a complete randomised design (CRD) with
three treatments and four replicates.
Shrimps were fed with isonitrogenous
diets (see Table 1), including the control (50
percent marine protein) and the test diets
with either five percent hydrolyzed poultry
liver or with five percent hydrolyzed poultry
meat & bone-mush.
Pacific white shrimps (Litopenaeus van-
namei) of 3.1+-0.1g were stocked at a density
of 70 animals/m2 in a 240 litre glass container
(aquarium) in brackish water of 12ppt. During
an eight week period, feed was given three
times per day to match 2-2.5 percent body
weight. Two hours after feeding, the uncon-
sumed feed was collected to determine total
feed consumption.
Growth performance was evaluated every
two weeks by collecting data on average daily
gain, feed consumption, feed conversion ratioand survival rate.
An acute salinity and chemical stress test
with a high or low level of salinity and toxic
concentration of nitrite (NO2-) and ammonia
(NH3+) was conducted at the end of four-
week feeding period.
Under salinity stress 30 shrimps per treat-
ment were transferred from a tank with 12ppt
water salinity to tanks of 20ppt for one week
March-April 2014 | INTERNATIONAL AQUAFEED| 15
FEATURE
Naturally ahead
MYCOFIX
Mycoto
xinRisk
Ma
nag eM
en
t
Mycofix
More protective.Mycotoxins decrease performance and interfere
with the health status of your animals.
Mycoxis thesolution for mycotoxin risk management.
mycox.biomin.net
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
5/9
and then moved to with 0ppt or 40ppt saline
water in separate trial for stress test.
In the chemical stress test, 30 shrimpsper treatment were transferred to a tank
with 20ppt salinity for one week and a toxic
concentration of ammonia of 50+- 2ppm
(pH7-8) and in a separate trial of nitrite of
20+-2ppm, respectively.
Nitrite and ammonia concentrations in the
water were controlled daily to maintain the
toxic concentrations. Shrimps were fed oncea day. Mortality rates were recorded daily
during a 10-day test phase.
Typical immunological parameters, such
as hemolymp protein, total hemocyte cell
count, phenol oxidase activity and percentage
of oxyhemocyanin (live cell hemocyte) were
measured. Mortality were recorded daily dur-
ing a 10-day test phase.
After feeding shrimp with the experimental
feed for four weeks, 30 shrimp from eachtreatment were collected to challenge with
White Spot Syndrome Virus (WSSV) and
in a separate trial with Vibrio harveyi by
subcutaneous injection. Mortality rate was
determined daily for a 10-day test phase.
The study was conducted in completely
randomised design (CRD). All data were ana-
lysed by one-way ANOVA. The significance of
differences between means was tested using
Duncans Multiple Range Test at a 95 percent
level of confidence (p
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
6/9
The activity of hemocyte cell in terms of
phenol oxidase activity and percentage ofoxyhemo-cyanin (live cell hemocyte), was
highest (P
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
7/9
The immune responses of shrimp
after challenged with white spot syn-
drome virus (WSSV) showed that thegroup of shrimp fed hydrolysed poultry
products had better immune response
than contro l. The mortal ity rate was 100
percent after 72 hours in all treatments
(see Figure 8).
An important sources ofprotein and energy
According to the result from this study, it canbe concluded that growth of shrimps, immune
responses and mortality rate induced by chemical
stress and disease challenge are related to the
usage and uptake of hydrolysed proteins and
peptides.
Generally, rendered poultry by-products
are important sources of protein and energy.
The enzymatic hydrolysis is widely used
to improve and enhance nutritional and func-
tional properties of feedstuff. During the
enzymatical hydrolyses poultry protein is con-
verted into free amino acids, short peptides
and small molecular proteins.
Based on their good functional properties
and nutritive value, these ingredients are able
to replace or complete fishmeal-based diets
in fish and shrimp feed. (Aguila et al., 2007;
Huong et al., 2012).
Several studies have described the anti-
oxidant activity of protein hydrolysates from
chicken (Wu et al., 2005; Rosa et al., 2008),
tuna liver (Je et al., 2009), sardinelle by-prod-
ucts (Bougatef et al., 2010), backbone of Baltic
cod (Zelechowska et al., 2010) and marine
skin gelatins (Alemn et al., 2011).
Furthermore, free amino acid and small
molecular weight compounds released during
the hydrolysis might also act as feed attract-ants for shrimps, increasing feed intake, weight
gain and enhance shrimp immunity (Hardy,
1991).
When shrimp are exposed to high ammo-
nia and nitrite concentration in water, the
immune response is depressed and mortality
is increased.
Hence, robust and healthy shrimp show
a higher immunity resistance by expressing
typical immune parameters, such as hemo-
lymp protein, total hemocyte cell count,
phenol oxidase activity and percentage of
oxyhemocyanin (live cell hemocyte) than
weaker ones.
Althought L. vannameican adapt to a wide
range of salinity, shrimps are more susceptible
to ammonia toxicity. Shrimps under low salin-
ity spend more energy to compensate their
additional energy demand for regulation of
the osmotic pressure (osmoregulation)(Liu
Chun-Hung et al., 2004; Li et al., 2007).
The results are in accordance with previ-
ous studies by Kvale et al. (2002) with pre-
digested protein in Atlantic halibut and Cahu
et al. (1999) describing effects of hydrolysed
protein in sea bass, revealing that survival in
fish can be improved by supplementing (fish)
protein hydrolysates in the diet.
In conclusion, poultry hydrolysates are
able to enhance stress resistance/tolerance in
Pacific white shrimp (Litopenaeus vannamei)
under salinity change, chemical stress and
disease challenge.
MOREINFORMATION:
GePro Gefluegel-ProteinVertriebsgesellschaft mbH & Co. KG
Im Moore 1
49356 Diepholz
Germany
Website: www.ge-pro.de
Email: [email protected]
18 | INTERNATIONAL AQUAFEED | March-April 2014
FEATURE
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
8/9March-April 2014 | INTERNATIONAL AQUAFEED| 19
FEATURE
www.evonik.com/feed-additives [email protected]
AMINODat Aqua 1.0 Enhance your knowledge about your raw materials.
-
8/12/2019 Poultry hydrolysates enhance stress resistance and stress tolerance in Pacific white shrimp
9/9
www.aquafeed.co.uk
LINKS
See the full issue
Visit the International Aquafeed website
Contact the International Aquafeed Team
Subscribe to International Aquafeed
The Role of prebiotics in
Pangasius production
Poultry hydrolysates enhance stress
resistance & stress tolerance in Pacificwhite shrimp
VOLUME 17 I SSU E 2 2014 - MARC H | APR I L
INCORPORAT ING
FISH FARMING TECHNOLOGY
Microalgae and aquaculturefeed andcycle management
Aquaculture UK our guide to the UK'spremier aquacultureevent
This digital re-print is part of the March | April 2014 edition of International
Aquafeed magazine.
Content from the magazine is available to view free-of-charge, both as a full
online magazine on our website, and as an archive of individual features onthe docstoc website.
Please click here to view our other publications on www.docstoc.com.
To purchase a paper copy of the magazine, or to subscribe to the paper
edition please contact our Circulation and Subscriptions Manager on the link
above.
INFORMATION FOR ADVERTISERS - CLICK HERE
http://www.aquafeed.co.uk/http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/http://www.aquafeed.co.uk/contact.phphttp://www.aquafeed.co.uk/subscriptions.phphttp://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/iaf1102http://www.docstoc.com/profile/Perendalehttp://www.aquafeed.co.uk/advertising.phphttp://www.aquafeed.co.uk/advertising.phphttp://www.docstoc.com/profile/Perendalehttp://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/subscriptions.phphttp://www.aquafeed.co.uk/contact.phphttp://www.aquafeed.co.uk/http://www.aquafeed.co.uk/iaf1102http://www.aquafeed.co.uk/