PIV from lab to large wind tunnel - DLR...
Transcript of PIV from lab to large wind tunnel - DLR...
![Page 1: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/1.jpg)
PIV from lab to large wind tunnel
Markus RaffelDepartment Technical Flows
Institute of Aerodynamics and Flow TechnologyGerman Aerospace Center (DLR)
http://www.dlr.de/asE-mail: [email protected]
![Page 2: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/2.jpg)
M. Raffel > 2Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
In the early 1990’s, the relevant literature was written by Adrian, Riethmuller, and Lourenco (to name just a few). At DLR in Göttingen Jürgen Kompenhans and his former PhD students succeeded measuring in a transonic flow in a wind tunnel, but for three reasons PIV was not ready to be used as a matter of routine. These three problems had to be solved and were solved by the methods described in the following. The system worked pretty well even in the larges wind tunnels until the first cross-correlation video cameras came onto the market in 1996. The author would like to state that - despite of the tons of paper that have been published on the improvement of digital PIV evaluation - the accuracy received with photographic PIV was not far from today's digital PIV. However, the recording of one good PIV image required typically a week of preparation in the wind tunnel, one day for developing and drying the negative, one day for preparing and drying the contact copy and about two days for an optical/digital evaluation.
![Page 3: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/3.jpg)
M. Raffel > 3Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Contents
Particle GeneratorsIt was hard to get enough particles of the right size homogeneously distributed in the laser light sheet, especially in blow-down facilities, at high flow velocities.
Photo Cameras Focussing DeviceAdjusting the set up for best focus meant photographing at different distances between camera and light sheet and analysing the result on the developed film under a microscope Than, going back to the position that seemed to be best and starting the measurement (mostly on the next day).
Rotating MirrorsThe dynamic range of the velocity one could successfully measure was very limited and measuring reverse flows was impossible, as the particle images would have overlapped on the doubly exposed photographic film.
![Page 4: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/4.jpg)
M. Raffel > 4Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 5: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/5.jpg)
M. Raffel > 5Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 6: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/6.jpg)
M. Raffel > 6Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 7: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/7.jpg)
M. Raffel > 7Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 8: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/8.jpg)
M. Raffel > 8Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 9: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/9.jpg)
M. Raffel > 9Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 10: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/10.jpg)
M. Raffel > 10Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 11: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/11.jpg)
M. Raffel > 11Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Particles recorded at appr. 0 m/s flow velocity image shifting with the rotating mirror
![Page 12: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/12.jpg)
M. Raffel > 12Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Calculated image shift
![Page 13: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/13.jpg)
M. Raffel > 13Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Activities between 1991 and 1996
Flow behind a transonic turbine blade model
![Page 14: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/14.jpg)
M. Raffel > 14Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 15: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/15.jpg)
M. Raffel > 15Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 16: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/16.jpg)
M. Raffel > 16Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
PIV Set-up
![Page 17: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/17.jpg)
M. Raffel > 17Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Comparison
Experiment - Numeric
Mach number 0,1
Velocity
color coded
1993
Comparison
Experiment - Numeric
Mach number 0,1
Velocity
color coded
1993
![Page 18: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/18.jpg)
M. Raffel > 18Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 19: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/19.jpg)
M. Raffel > 19Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Stereo PIV results obtained with two 35mm lenses at α
= 11.5°, steady case
![Page 20: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/20.jpg)
M. Raffel > 20Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
“Zoom-PIV”
results obtained with a 100mm lens at α
= 11.5°, steady case
![Page 21: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/21.jpg)
M. Raffel > 21Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
1 mm x 1,2 mm
![Page 22: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/22.jpg)
M. Raffel > 22Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
“μ-PIV”
results obtained with a mirror telescope at α
= 11.5°, steady case.
The magnitude of the velocity has been plotted color coded (color units: c/s). The coordinates x and y are given in millimeters. The origin is placed on the model surface (y), 5% chord length behind the leading edge (x).
X [mm]
Y[m
m]
0.2 0.4 0.6 0.8 1
0
0.2
0.4
0.6
magnitude: 0 0.065 0.13 0.195 0.26 0.325 0.39 0.455 0.52 0.585 0.65
![Page 23: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/23.jpg)
M. Raffel > 23Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
CFD, ELDV and PIV results of the laminar separation bubble at α
= 11.5°; steady case
![Page 24: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/24.jpg)
M. Raffel > 24Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
M. Raffel, K. Mulleners, K. Kindler, H. Richard
Institut für Aerodynamik und Strömungstechnik, Deutsches Zentrum für Luft- und Raumfahrt (DLR),
Bunsenstraße 10, D-37073 Göttingen, Germany
Experimental helicopter aerodynamics at small, large, and full scale
![Page 25: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/25.jpg)
M. Raffel > 25Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 26: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/26.jpg)
M. Raffel > 26Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 27: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/27.jpg)
M. Raffel > 27Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Cameras systems and common support
![Page 28: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/28.jpg)
M. Raffel > 28Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 29: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/29.jpg)
M. Raffel > 29Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 30: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/30.jpg)
M. Raffel > 30Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Infrared Photography, Micro Tufts, Pressures at Model and Tunnel, Hotwire, Hotfilm, SPA, SPR
![Page 31: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/31.jpg)
M. Raffel > 31Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Actual PIV plane locations GOAHEAD
![Page 32: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/32.jpg)
M. Raffel > 32Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 33: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/33.jpg)
M. Raffel > 33Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
February Measurements in AIM
stereoscopic PIV measurements of the tip vortices at hover flight conditions
![Page 34: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/34.jpg)
M. Raffel > 34Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
February Measurements in AIM seeding
![Page 35: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/35.jpg)
M. Raffel > 35Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
February Measurements in AIM seeding
![Page 36: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/36.jpg)
M. Raffel > 36Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
February Measurements in AIM
stereoscopic PIV measurements of the tip vortices at hover flight conditions
![Page 37: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/37.jpg)
M. Raffel > 37Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
![Page 38: PIV from lab to large wind tunnel - DLR Portal25-years-piv.dlr.de/fileadmin/Template/Presentations/L_H08_Raffel.pdf · in the wind tunnel, one day for developing and drying the negative,](https://reader030.fdocuments.us/reader030/viewer/2022040701/5d5c322088c993d2318bbf18/html5/thumbnails/38.jpg)
M. Raffel > 38Symposium 25 Years of PIV in aerodynamics, Göttingen, September 23 - 25, 2009
Aerodynamic PIV measurements performed at DLR after 1996
PIV measurements were performed in low-turbulence, large low-speed, transonic, supersonic, cryogenic, acoustic and other aerodynamic facilities
The velocities measured ranged from mm/s up to km/s
The observation fields sizes varied between 1 mm2 to 10 m2
More recently tomographic and high-speed techniques were applied
PIV has been applied more and more frequently simultaneously with other optical techniques, but PIV gave more data than all other optical techniques like PSP,DGV,LDV,LIF,BOS,… together