Pioneer Service Manual- dvh-3200ub, 3220ub, 3250ub, 3290ub
Transcript of Pioneer Service Manual- dvh-3200ub, 3220ub, 3250ub, 3290ub
ORDER NO.
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, JapanPIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, BelgiumPIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2010
DVH-3200UB/XNUW5
CRT4518
DVD RDS RECEIVER
DVH-3200UB/XNUW5
DVH-3220UB/XNUW5DVD RECEIVER
DVH-3250UB/XNRC
DVH-3250UB/XNRD
DVH-3250UB/XNRI
DVH-3290UB/XNID
This service manual should be used together with the following manual(s):
DTS and DTS Digital Out are registered trademartks and the DTS logos and Symbol are trademarks of DTS, Inc.Manufactured under license from Dolby Laboratories. Dolby, Pro Logic, and the double-D symbol are trademarks of Dolby Laboratories.
Model No. Order No. Mech.Module Remarks
CX-3250 CRT4300 LS1 DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
For details, refer to "Important Check Points for Good Servicing".
K-ZZZ JAN. 2010 Printed in Japan
DVH-3200UB/XNUW52
1 2 3 4
1 2 3 4
C
D
F
A
B
E
SAFETY INFORMATION
Where in a manufacturer’s service documentation, for example in circuit diagrams or listsof components, a symbol is used to indicate that a specific component shall be replaced onlyby the component specified in that documentation for safety reasons, the following symbol shallbe used:
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safety repaircomplex products such as those covered by this manual.Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.If you are not qualified to perform the repair of this product properly and safety, you should not risk trying to do soand refer the repair to a qualified service technician.
CAUTIONDanger of explosion if battery is incorrectly replaced.Replaced only with the same or equivalent type recommended by the manufacture.Discord used batteries according to the manufacture's instructions.
CAUTION:USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
- Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results.
Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
CAUTIONCLASS 1M INVISIBLE LASER RADIATION WHEN OPEN. DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS
2. During repair or tests, do not view laser beam for 10 seconds or longer.
WARNING!The AEL (accessible emission level )of the laser power output is less than CLASS 1but the laser component is capable of emitting radiation exceeding the limit for CLASS 1.A specially instructed person should do servicing operation of the apparatus.
Laser diode characteristicsWave length:
DVD:660 nm to 670 nmCD:780 nm to 800 nm
Focus lens on Maximum output:CD:6.26 mW(Emitting period :9 sec.)
DVD:1.27 mW (Emitting period : unlimited)
Additional Laser Caution
Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD respectively. When Q1103 or Q1104 is shorted between their terminals, the laser diodes for DVD or CD will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam.
DVH-3200UB/XNUW5 3
5 6 7 8
5 6 7 8
C
D
F
A
B
E
[Important Check Points for Good Servicing]In this manual, procedures that must be performed during repairs are marked with the below symbol.Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual.
1 Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2 Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise.
3 Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.Soldering should be finished with the proper quantity. (Refer to the example)
4 Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5 Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.In addition, be sure that there are no pinched wires, etc.
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.If you find a damaged power cord, please exchange it with a suitable one.
9 There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary.
a Safe environment should be secured during servicing.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.Adjustments should be performed in accordance with the procedures/instructions described in this manual.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
DVH-3200UB/XNUW54
1 2 3 4
1 2 3 4
C
D
F
A
B
E
CONTENTS SAFETY INFORMATION..................................................................................................................................... 21. SERVICE PRECAUTIONS............................................................................................................................... 5
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 51.2 NOTES ON SOLDERING .......................................................................................................................... 5
2. SPECIFICATIONS............................................................................................................................................ 62.1 SPECIFICATIONS ..................................................................................................................................... 62.2 DISC/CONTENT FORMAT ........................................................................................................................ 92.3 PANEL FACILITIES.................................................................................................................................. 102.4 CONNECTION DIAGRAM ....................................................................................................................... 14
3. BASIC ITEMS FOR SERVICE........................................................................................................................ 193.1 CHECK POINTS AFTER SERVICING..................................................................................................... 193.2 PCB LOCATIONS .................................................................................................................................... 203.3 JIGS LIST ................................................................................................................................................ 213.4 CLEANING............................................................................................................................................... 21
4. BLOCK DIAGRAM.......................................................................................................................................... 225. DIAGNOSIS.................................................................................................................................................... 28
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 285.2 INSPECTION METHOD OF PICKUP UNIT............................................................................................. 295.3 DIAGNOSIS FLOWCHART ..................................................................................................................... 325.4 ERROR CODE LIST ................................................................................................................................ 595.5 CONNECTOR FUNCTION DESCRIPTION............................................................................................. 62
6. SERVICE MODE ............................................................................................................................................ 636.1 DISPLAY TEST MODE ............................................................................................................................ 636.2 DVD TEST MODE ................................................................................................................................... 64
7. DISASSEMBLY .............................................................................................................................................. 688. EACH SETTING AND ADJUSTMENT ........................................................................................................... 75
8.1 DVD ADJUSTMENT ................................................................................................................................ 758.2 PCL OUTPUT CONFIRMATION.............................................................................................................. 83
9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 849.1 PACKING ................................................................................................................................................. 849.2 EXTERIOR (1) ......................................................................................................................................... 869.3 EXTERIOR (2) ......................................................................................................................................... 889.4 DVD MECHANISM MODULE .................................................................................................................. 90
10. SCHEMATIC DIAGRAM............................................................................................................................... 9410.1 TUNER AMP UNIT (GUIDE PAGE) ....................................................................................................... 9410.2 KEYBOARD UNIT................................................................................................................................ 10010.3 DVD CORE UNIT (GUIDE PAGE) ....................................................................................................... 10210.4 CONNECT PCB................................................................................................................................... 10810.5 WAVEFORMS...................................................................................................................................... 109
11. PCB CONNECTION DIAGRAM...................................................................................................................11211.1 TUNER AMP UNIT................................................................................................................................11211.2 KEYBOARD UNIT .................................................................................................................................11611.3 DVD CORE UNIT ..................................................................................................................................11811.4 CONNECT PCB ................................................................................................................................... 120
12. ELECTRICAL PARTS LIST ........................................................................................................................ 122
DVH-3200UB/XNUW5 5
5 6 7 8
5 6 7 8
C
D
F
A
B
E
1. SERVICE PRECAUTIONS1.1 SERVICE PRECAUTIONS
1.2 NOTES ON SOLDERING
1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual.2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction.3. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit.4. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY" .5. After replacing the pickup unit, be sure to skew adjustment. 6. ICs (IC1011, 1021) and the heat sink becomes hot areas. Be careful not be burn yourself.7. Mechanism cover(Sheet : CNN2525) is NOT reusable. If you removed it, please replace it with the new one.
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden).
The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia.
DVH-3200UB/XNUW56
1 2 3 4
1 2 3 4
C
D
F
A
B
E
2. SPECIFICATIONS2.1 SPECIFICATIONS
DVH-3200UB/XNUW5, DVH-3220UB/XNUW5
Dimensions (W × H × D):DIN
Chassis.................. 178 mm × 50 mm × 163mm
Nose........................ 188 mm × 58 mm × 23 mmD
Chassis.................. 178 mm × 50 mm × 163mm
Nose........................ 170 mm × 48 mm × 23 mmWeight ..................................... 1.4 kg
AudioMaximum power output ....... 50 W × 4Continuous power output ... 22 W × 4 (50 Hz to 15 000
Hz, 5 % THD, 4 ohmload,both channels driven)
Load impedance .................... 4 ohm(4 ohm to 8 ohm allowable)
Preout maximum output level............................................... 2.0 V
Tone controls:Bass
Frequency.............. 100 HzGain ......................... ±12 dB
MidFrequency.............. 1 kHzGain ........................ ±12 dB
TrebleFrequency.............. 10 kHzGain ......................... ±12 dB
DVD PlayerSystem..................................... DVDvideo, DVD-VR, Video
CD, CD, WMA, MP3, AAC,DivX, JPEG system
Region number ..................... 5Usable discs .......................... DVD video, Video CD, CD,
CD-R/RW, DVD-R/RW/RDLFrequency response............. 5 Hz to 44 000 Hz (with DVD,
at sampling frequency 96kHz)
Signal-to-noise ratio............. 96 dB (1kHz) (IEC-A net-work) (RCA level)
Number of channels ............. 2 (stereo)MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)(Windows Media Player)
AAC decoding format...........MPEG-4 AAC (iTunes en-coded only) (.m4a)(Ver. 8.2 and earlier)
DivX decoding format............Home Theater Ver. 3, 4, 5.2,6 (.avi, .divx)
USBUSB standard specification
............................................... USB 2.0 full speedMaximum current supply .... 500 mAUSB Class............................... MSC(Mass Storage Class)File system.............................. FAT16, FAT32MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)(Windows Media Player)
AAC decoding format............MPEG-4 AAC (iTunes en-coded only) (.m4a)(Ver. 8.2 and earlier)
FM tunerFrequency range................... 87.5 MHz to 108.0 MHzUsable sensitivity.................. 9 dBf (0.8 μV/75 ohm,
mono, S/N: 30 dB)Signal-to-noise ratio............. 72 dB (IEC-A network)
MW tunerFrequency range.................... 531 kHz to 1 602 kHz (9 kHz)
530 kHz to 1 640 kHz (10kHz)
Usable sensitivity................... 25 μV(S/N: 20 dB)Signal-to-noise ratio.............. 62 dB(IEC-A network)
LW tunerFrequency range................... 153 kHz to 281 kHzUsable sensitivity.................. 28 μV(S/N: 20 dB)Signal-to-noise ratio............. 62 dB (IEC-A network)
Note
Specifications and the design are subject to mod-ifications without notice.
GeneralRated power source..............14.4 V DC
(allowable voltage range:10.8 V to 15.1 V DC)
Grounding system.................Negative typeMaximum current consumption
...............................................10.0 A
Backup current ...................... 5.0 mA or less
DVH-3200UB/XNUW5 7
5 6 7 8
5 6 7 8
C
D
F
A
B
E
GeneralRated power source............. 14.4 V DC
(allowable voltage range:12.0 V to 14.4 V DC)
Grounding system................ Negative typeMaximum current consumption
...............................................10.0 A
Dimensions (W × H × D):DIN
Chassis.................. 178 mm × 50 mm × 163mm
Nose....................... 188 mm × 58 mm × 23 mmD
Chassis.................. 178 mm × 50 mm × 163mm
Nose........................ 170 mm × 48 mm × 23 mmWeight ..................................... 1.4 kg
AudioMaximum power output ....... 50 W × 4Continuous power output ... 22 W × 4 (50 Hz to 15 000
Hz, 5 % THD, 4 ohm load,both channels driven)
Load impedance ................... 4 ohm(4 ohm to 8 ohm allowable)
Preout maximum output level.............................................. 2.0 V
Tone controls:Bass
Frequency............. 100 HzGain ........................ ±12 dB
MidFrequency............. 1 kHzGain ........................ ±12 dB
TrebleFrequency............. 10 kHzGain ........................ ±12 dB
DVD PlayerSystem..................................... DVD video, DVD-VR, Video
CD, CD, WMA, MP3, AAC,DivX, JPEG system
Region number:for Middle East Asian and South African models
...................................... 2for Southeast Asian models
...................................... 3for South American and Oceanian models
...................................... 4Usable discs .......................... DVD video, Video CD, CD,
CD-R/RW, DVD-R/RW/RDL
Frequency response.............. 5 Hz to 44 000 Hz (with DVD,at sampling frequency 96kHz)
Signal-to-noise ratio.............. 96 dB (1 kHz) (IEC-A net-work) (RCA level)
Number of channels ............ 2 (stereo)MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)(Windows Media Player)
AAC decoding format...........MPEG-4 AAC (iTunes en-coded only) (.m4a)(Ver. 8.2 and earlier)
DivX decoding format...........Home Theater Ver. 3, 4, 5.2,6 (.avi, .divx)
USBUSB standard specification
............................................... USB 2.0 full speedMaximum current supply .... 500 mAFile system.............................. FAT16, FAT32MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)(Windows Media Player)
AAC decoding format...........MPEG-4 AAC (iTunes en-coded only) (.m4a)(Ver. 8.2 and earlier)
FM tunerFrequency range................... 87.5 MHz to 108.0 MHzUsable sensitivity................... 9 dBf(0.8 μV/75 ohm,
mono, S/N: 30 dB)Signal-to-noise ratio............. 72 dB (IEC-A network)
AM tunerFrequency range................... 531 kHz to 1 602 kHz (9 kHz)
530 kHz to 1 640 kHz (10kHz)
Usable sensitivity.................. 25 μV(S/N: 20 dB)Signal-to-noise ratio............. 62 dB (IEC-A network)
Infrared remote controlWavelength............................. 945 nmOutput ......................................typ; 10 mw/sr per Infrared
LED
Note
Specifications and the design are subject to mod-ifications without notice.
DVH-3250UB/XNRC, DVH-3250UB/XNRD, DVH-3250UB/XNRI
Backup current ...................... 5.0 mA or less
DVH-3200UB/XNUW58
1 2 3 4
1 2 3 4
C
D
F
A
B
E
GeneralRated power source..............14.4 V DC
(allowable voltage range:12.0 V to 14.4 V DC)
Grounding system.................Negative typeMaximum current consumption
...............................................10.0 A
Dimensions (W × H × D):DIN
Chassis.................. 178 mm × 50 mm × 163mm
Nose........................ 188 mm × 58 mm × 23 mmD
Chassis.................. 178 mm × 50 mm × 163mm
Nose........................ 170 mm × 48 mm × 23 mmWeight ..................................... 1.4 kg
AudioMaximum power output ....... 50 W × 4Continuous power output ... 22 W × 4 (50 Hz to 15 000
Hz, 5 % THD, 4 ohm load,both channels driven)
Load impedance ................... 4 ohm(4 ohm to 8 ohm allowable)
Preout maximum output level.............................................. 2.0 V
Tone controls:Bass
Frequency............. 100 HzGain ........................ ±12 dB
MidFrequency............. 1 kHzGain ........................ ±12 dB
TrebleFrequency............ 10 kHzGain ........................ ±12 dB
DVD PlayerSystem..................................... DVD video, DVD-VR, Video
CD, CD, WMA, MP3, AAC,DivX, JPEG system
Region number ..................... 5Usable discs .......................... DVD video, Video CD, CD,
CD-R/RW, DVD-R/RW/RDLFrequency response............. 5 Hz to 44 000 Hz(with DVD,
at sampling frequency 96kHz)
Signal-to-noise ratio............. 96 dB (1 kHz) (IEC-A net-work) (RCA level)
Number of channels ............. 2 (stereo)MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3WMA decoding format ......... Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)(Windows Media Player)
AAC decoding format...........MPEG-4 AAC (iTunes en-coded only) (.m4a)(Ver. 8.2 and earlier)
DivX decoding format...........Home Theater Ver. 3, 4, 5.2,6 (.avi, .divx)
USBUSB standard specification
............................................... USB 2.0 full speedMaximum current supply .... 500 mAFile system.............................. FAT16, FAT32MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)(Windows Media Player)
AAC decoding format...........MPEG-4 AAC (iTunes en-coded only) (.m4a)(Ver. 8.2 and earlier)
FM tunerFrequency range................... 87.5 MHz to 108.0 MHzUsable sensitivity.................. 9 dBf (0.8 μV/75 ohm,
mono, S/N: 30 dB)Signal-to-noise ratio............. 72 dB (IEC-A network)
AM tunerFrequency range................... 531 kHz to 1 602 kHz (9 kHz)
530 kHz to 1 640 kHz (10kHz)
Usable sensitivity.................. 25 μV(S/N: 20 dB)Signal-to-noise ratio............. 62 dB (IEC-A network)
Note
Specifications and the design are subject to mod-ifications without notice.
DVH-3290UB/XNID
Backup current ......................5.0 mA or less
DVH-3200UB/XNUW5 9
5 6 7 8
5 6 7 8
C
D
F
A
B
E
2.2 DISC/CONTENT FORMAT
is a trademark of DVD Format/Logo Licensing Corporation.
DVH-3200UB/XNUW510
1 2 3 4
1 2 3 4
C
D
F
A
B
E
2.3 PANEL FACILITIES
Head unit
traPtraP
1 DISP/ / SCRL 8 Detach button
2 SRC / OFF 9AUX input jack (3.5mm stereo jack)
3MULTI-CONTROL(M.C.)
a USB port
4 Disc loading slot b (list)
5
1 to 6• 1 / S.Rtrv / DVD
MENU• 2 / PAUSE• 3 / BOOKMARK• 4 / AUDIO• 5 / / SUB
TITLE• 6 / / ANGLE
c / / /
6 (eject) d BAND / ESC
7 CLOCK
CAUTIONUse an optional Pioneer USB cable (CD-U50E) toconnect the USB audio player/USB memory asany device connected directly to the unit will pro-trude out from the unit and may be dangerous.Do not use unauthorized products.
Note
The function of DISP/ / SCRL is different de-pending on the setting of the display connection(refer toV.OUT (display connection)).
traPtraP
1 DISP/ / SCRL 8 Detach button
2 SRC / OFF 9AUX input jack (3.5mm stereo jack)
3MULTI-CONTROL(M.C.)
a USB port
4 Disc loading slot b (list)
5
1 to 6• 1/S.Rtrv• 2/PAUSE• 5/• 6/
c / / /
6 (eject) d BAND / ESC
7 TA / AF
DVH-3200UB/XNUW5DVH-3220UB/XNUW5
DVH-3250UB/XNRCDVH-3250UB/XNRDDVH-3250UB/XNRIDVH-3290UB/XNID
Fastening the front panelIf you do not plan to detach the front panel, the front panel can be fastened with supplied screw.
Screw
UW5: BPZ20P060FTC (Screw)Other models: CXX2204 (Service screw)
DVH-3200UB/XNUW5 11
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Remote control
Button names DVH mode DVD and S-DVDmode
1 SOURCEPress to cycle through all the available sources. Press and hold to turn the sourceoff.
2 ATTPress to quickly lower the volume level by about 90%. Press once more to returnto the original volume level.
3 VOLUME Press to increase or decrease volume.
4
AUDIO Press to change the audio language/audio system during DVD playback.
SUBTITLE Press to change the subtitle language during DVD playback.
ANGLE Press to change the viewing angle during DVD playback.
5 AUTO PLAY Press to turn the DVD auto-playback function on or off.
6 RETURN Press to display the PBC (playback control) menu during PBC playback.
7 BOOKMARKPress to operate the preprogrammed func-tions for each source. (Refer toUsing thePGM button)
Press to turn the bookmark functionon or off. For details, refer to Resumeplayback (Bookmark).
8Remote control operationmode switch
Switch the operation mode betweenDVD, S-DVDand DVH modes. Normally, setto DVH. For details, refer toUsing the remote control operation mode switch onthe next page.
9 CM BACK / CM SKIP Press to skip progressively backward/forward through the video playing.
10 DIRECT Press to select channels directly. Not used.
11 A.MENU Press to select various sound quality controls.
12 FUNC Press to select functions.
13 0 to 10, CLEAR
Press0 to 9 to input numbers. Buttons 1to 6 can operate the preset tuning for thetuner. Press CLEAR to clear the inputnumbers.
Press to select a menu item on avideo CD featuring PBC (playbackcontrol).
DVH-3200UB/XNUW512
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Button names DVH mode DVD and S-DVDmode
14 BANDPress to select among two FM bands andMW/LW bands and to cancel controlmodes of functions.
Press to switch between media filetypes.
15 DISPPress to turn the information display on or off when the video is displayed.Depending on the selected source, pressing this button can switch the display in-dication.
16
PLAY/PAUSE ( )
REVERSE ( )
FORWARD ( )
PREVIOUS ( )
NEXT ( )
STEP( / )
Press to move ahead one frame at a time during DVD/VideoCD playback. Pressand hold for one second to activate slow playback.If a DVD-VR disc contains a still image, press while displaying a still image toswitch to the next image or video.
STOP ( .kcabyalppotsotsserP.desutoN)
17
Move the thumb pad
Functions are the same as M.C. on thehead unit.Move to operate fast forward, reverse andtrack search controls. Also used for con-trolling functions.
Use to select a menu on the DVDmenu.
Click the thumb padClick to display the track title list, folderlist or file list depending on the source.
Click to select a menu on the DVDmenu.
18MENU Press to display the DVD menu during DVD playback.
TOP MENU Press to return to the top menu during DVD playback.
Press to switch sequentially between playback and pause.
Press to perform fast reverse.
Press to perform fast forward.
Press to return to the previous track (chapter).
Press to go to the next track (chapter).
Using the remote controloperation mode switchThere are three remote control operationmodes on the remote control. If you want tooperate this unit by remote control, turn themode switch to DVH mode. In this case, boththe head unit’s buttons and the remote controlcan control this unit.
DVH mode operationWhen operating this unit by remote control,the mode is normally switched toDVH.• The thumb pad on the remote control can
perform the same operations as M.C. onthe head unit.
DVD mode operationIf you switch the mode toDVD, the thumb padand 0 to 10 operations are changed for theDVD player.
• When you want to operate the follow-ing functions, switch the mode to DVD:
• When operating the DVD menu by usingthe thumb pad.
• When operating the PBC menu by using 0to 10.
• When specifying title or track by using 0 to10.
• When operating the DVD setup menu byusing the thumb pad.
S-DVDmode operationWhen using the remote control with this unit,there is no need to switch to S-DVDmode.
DVH-3200UB/XNUW5 13
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Display indication
Indicator Operation
1Main dis-play sec-tion
• Tuner: band and frequency• RDS: program service name,
PTY information and other lit-eral information
• Built-in DVD player and USB:elapsed playback time and lit-eral information
2 (artist)played.
3 (disc)The disc (album) name is dis-played.
4 (song)
The track (song) name is dis-played.
viewing the file name list of discand a USB storage device.
5An upper tier of folder or menuexists.
6 (list) The list function is operated.
7A lower tier of folder or menu ex-ists.
8 LOC The local seek tuning is on.
9LOUD
(loudness)The loudness is on.
a(TA)
indicatorTA function is on.
b(TP)
indicatorA TP station is tuned in.
c(AF)
indicatorAF (alternative frequenciessearch) function is on.
d (stereo)The selected frequency is beingbroadcasted in stereo.
Indicator Operation
1Main dis-play sec-tion
• Tuner: band and frequency• Built-in DVD player and USB:
elapsed playback time and lit-eral information
2 (artist)The disc (track) artist name is dis-played.
3 (disc)The disc (album) name is dis-played.
4 (song)
The track (song) name is dis-played.A playable file is displayed duringviewing the file name list of discand a USB storage device.
5An upper tier of folder or menuexists.
6 (folder) The list function is operated.
7A lower tier of folder or menu ex-ists.
8 LOC The local seek tuning is on.
9LOUD
(loudness)The loudness is on.
a (stereo)The selected frequency is beingbroadcasted in stereo.
b (repeat) Track or folder repeat is on.
c(ran-
dom)Random play is on.
Note
When you set the display connection (refer toV.OUT (display connection)) to on, theindicators of 2 to 7 do not appear.
e (repeat) Track or folder repeat is on.
f(ran-
dom)Random play is on.
DVH-3200UB/XNUW5DVH-3220UB/XNUW5
DVH-3250UB/XNRC, DVH-3250UB/XNRD,DVH-3250UB/XNRI, DVH-3290UB/XNID
DVH-3200UB/XNUW514
1 2 3 4
1 2 3 4
C
D
F
A
B
E
2.4 CONNECTION DIAGRAM
Po
wer
cab
le c
on
nec
tio
n
1* 3*
2* 4*
Not
e:D
epen
ding
on
the
kind
of v
ehic
le, t
he
func
tion
of 2
* an
d 4*
may
be
diffe
rent
. In
this
cas
e, b
e su
re to
con
nect
1*
to 4
* an
d 3*
to 2
*.
Con
nect
lead
s of
the
sam
e co
lor
to e
ach
othe
r.
Yel
low
(2*
) B
ack-
up (
or
acce
ssor
y)
Red
(4*
)A
cces
sory
(or
back
-up)
Yel
low
(1*
) C
onne
ct to
the
cons
tant
12
V s
uppl
y te
rmin
al.
Red
(3*
) C
onne
ct to
term
inal
con
trol
led
by ig
nitio
n sw
itch
(12
V D
C).
ISO
con
nect
orN
ote:
In s
ome
vehi
cles
, the
ISO
con
nect
or
may
be
divi
ded
into
two.
In th
is c
ase,
be
sure
to c
onne
ct to
bot
h co
nnec
tors
.
Spe
aker
lead
s W
hite
:Fr
ont l
eft
Whi
te/b
lack
:Fr
ont l
eft
Gra
y:Fr
ont r
ight
G
ray/
blac
k:Fr
ont r
ight
G
reen
:R
ear
left
Gre
en/b
lack
:R
ear
left
Vio
let:
Rea
r rig
ht
Vio
let/b
lack
:R
ear
right
Bla
ck (
chas
sis
grou
nd)
Con
nect
to a
cle
an, p
aint
-fre
e m
etal
loca
tion.
Fuse
(10
A)
Fuse
res
isto
rB
lue/
whi
teC
onne
ct to
sys
tem
con
trol
term
inal
of t
he
pow
er a
mp
(max
. 300
mA
12
V D
C).
Blu
e/w
hite
(6*
) C
onne
ct to
aut
o-an
tenn
a re
lay
cont
rol
term
inal
(m
ax. 3
00 m
A 1
2 V
DC
).
The
pin
pos
ition
of t
he IS
O c
onne
ctor
will
di
ffer
depe
nds
on th
e ty
pe o
f veh
icle
. Con
nect
5*
and
6*
whe
n P
in 5
is a
n an
tenn
a co
ntro
l ty
pe. I
n an
othe
r ty
pe o
f veh
icle
, nev
er c
onne
ct
5* a
nd 6
*.
Yel
low
/bla
ckIf
you
use
an e
quip
men
t with
Mut
e fu
nctio
n, w
ire
this
lead
to th
e A
udio
Mut
e le
ad o
n th
at
equi
pmen
t. If
not,
keep
the
Aud
io M
ute
lead
free
of
any
con
nect
ions
.
Thi
s pr
oduc
tA
nten
na ja
ck
Wire
d re
mot
e in
put
Har
d-w
ired
rem
ote
cont
rol a
dapt
or c
an
be c
onne
cted
(so
ld s
epar
atel
y).
Blu
e/w
hite
(5*
)
DVH-3200UB/XNUW5,DVH-3220UB/XNUW5
DVH-3200UB/XNUW5 15
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Co
nn
ecti
ng
to
sep
arat
ely
sold
po
wer
am
p
Blu
e/w
hite
Con
nect
to s
yste
m c
ontr
ol te
rmin
al o
f the
po
wer
am
p (m
ax. 3
00 m
A 1
2 V
DC
).
Blu
e/w
hite
(6*
) C
onne
ct to
aut
o-an
tenn
a re
lay
cont
rol
term
inal
(m
ax. 3
00 m
A 1
2 V
DC
).
The
pin
pos
ition
of t
he IS
O c
onne
ctor
w
ill d
iffer
dep
ends
on
the
type
of
vehi
cle.
Con
nect
5*
and
6* w
hen
Pin
5
is a
n an
tenn
a co
ntro
l typ
e. In
ano
ther
ty
pe o
f veh
icle
, nev
er c
onne
ct 5
* an
d 6*
.
Blu
e/w
hite
(5*
)
Thi
s pr
oduc
tR
ear
outp
ut
Con
nect
with
RC
A c
able
s (s
old
sepa
rate
ly)
Per
form
thes
e co
nnec
tions
whe
nus
ing
the
optio
nal a
mpl
ifier
.
Pow
er a
mp
(sol
d se
para
tely
)
Sys
tem
rem
ote
cont
rol
Rea
r sp
eake
rR
ear
spea
ker
DVH-3200UB/XNUW516
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Po
wer
cab
le c
on
nec
tio
n
Bla
ck (
chas
sis
grou
nd)
Con
nect
to a
cle
an, p
aint
-fre
e m
etal
loca
tion.
Yel
low
Con
nect
to th
e co
nsta
nt 1
2 V
sup
ply
term
inal
.
Red
Con
nect
to te
rmin
al c
ontr
olle
d by
igni
tion
switc
h (1
2 V
DC
).
Fuse
(10
A)
Fuse
res
isto
r
Thi
s pr
oduc
t
Ant
enna
jack
B C p teThi
s pr
oduc
t
Ant
enna
jack B
lue/
whi
teC
onne
ct to
sys
tem
con
trol
term
inal
of t
he
pow
er a
mp
or a
uto-
ante
nna
rela
y co
ntro
l te
rmin
al (
max
. 300
mA
12
V D
C).
th
giR
tfeL
Fro
nt s
peak
erF
ront
spe
ker
Rea
r sp
eake
r
Whi
teG
ray
Gra
y/bl
ack
Whi
te/b
lack
Gre
enV
iole
t
Gre
en/b
lack
Vio
let/b
lack
Rea
r sp
eake
r
With
a 2
spe
aker
sys
tem
, do
not c
onne
ct
anyt
hing
to th
e sp
eake
r le
ads
that
are
not
co
nnec
ted
to s
peak
ers.
(RC
, ID
)(R
D, R
I)
DVH-3250UB/XNRC,DVH-3250UB/XNRD,DVH-3250UB/XNRI,DVH-3290UB/XNID
DVH-3200UB/XNUW5 17
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Co
nn
ecti
ng
to
sep
arat
ely
sold
po
wer
am
p
Thi
s pr
oduc
tR
ear
outp
utB
lue/
whi
teC
onne
ct to
sys
tem
con
trol
term
inal
of t
he
pow
er a
mp
or a
uto-
ante
nna
rela
y co
ntro
l te
rmin
al (
max
. 300
mA
12
V D
C).
Thi
s pr
oduc
tR
ear
outp
ut
(RC
, ID
)
(RD
, RI)
Con
nect
with
RC
A c
able
s (s
old
sepa
rate
ly)
Per
form
thes
e co
nnec
tions
whe
nus
ing
the
optio
nal a
mpl
ifier
.
Pow
er a
mp
(sol
d se
para
tely
)
Sys
tem
rem
ote
cont
rol
Rea
r sp
eake
rR
ear
spea
ker
DVH-3200UB/XNUW518
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Wh
en u
sin
g a
dis
pla
y co
nn
ecte
d v
ideo
ou
tpu
ts
WA
RN
ING
Nev
er in
stal
l the
dis
play
in a
loca
tion
whe
re it
is v
isib
le to
the
driv
er w
hile
driv
ing.
Dis
play
with
RC
A
inpu
t jac
ks(s
old
sepa
rate
ly)
To v
ideo
inpu
t
RC
A c
able
(s
old
sepa
rate
ly)
1.5
mT
his
prod
uct
Vid
eo o
utpu
t
All model commonness
Thi
s pr
oduc
tV
ideo
out
put
Aud
io in
put
Inpu
t the
sou
nd fr
om
exte
rnal
dev
ices
(e.
g. T
V).
Thi
s pr
oduc
tV
ideo
out
put
(RC
, ID
)
(RD
, RI)
(UW
5)
DVH-3200UB/XNUW5 19
5 6 7 8
5 6 7 8
C
D
F
A
B
E
3. BASIC ITEMS FOR SERVICE3.1 CHECK POINTS AFTER SERVICING
To keep the product quality after servicing, please confirm following check points.
No. Procedures Item to be confirmed1 Confirm whether the customer complain has
been solved.If the customer complain occurs with thespecific media, use it for the operation check.
The customer complain must not bereappeared.Display, video, audio and operations must benormal.
2 DVD Measure playback error rates at theinnermost and outermost tracks by using thetest mode with the following disc.DVD test disc (TDV-582)
Deterioration of mecha-drive can bechecked.The error rate must be less than thethreshold value.(Refer to the chapter of DIAGNOSIS for thethreshold value.)
3 DVD Play back a DVD.(Menu operation; Title/chapter search)
Display, video, audio and operations must benormal.
4 CD Play back a CD.(Track search)
Display, audio and operations must benormal.
5 FM/AM tuner Check FM/AM tuner action.(Seek, Preset)Switch band to check both FM and AM.
Display, audio and operations must benormal.
6 Check whether no disc is inside the product. The media used for the operating check mustbe ejected.
7 Appearance check No scratches or dirt on its appearance afterreceiving it for service.
For check items concerning image and voice, please refer to the followings:
Check items concerning image Check items concerning voiceBlock-noise DistortionCrosscut noise NoiseDot noise Low volumeDistorted image (Image skip) High volumeLow brightness Changes in levelToo bright Pause of soundColor fadingPartial discoloration
DVH-3200UB/XNUW520
1 2 3 4
1 2 3 4
C
D
F
A
B
E
3.2 PCB LOCATIONS
A
B Keyboard Unit
C
Tuner Amp Unit
DVD Core Unit
D Connect PCB
A:DVH-3200UB/XNUW5B:DVH-3220UB/XNUW5C:DVH-3250UB/XNRCD:DVH-3250UB/XNRDE:DVH-3250UB/XNRIF:DVH-3290UB/XNIDUnit Number : QWM3138(A,B)Unit Number : QWM3139(C)Unit Number : QWM3140(D)Unit Number : QWM3141(E)Unit Number : QWM3142(F)Unit Name : Tuner Amp Unit Unit Number :Unit Name : Keyboard UnitUnit Number : YWX5007Unit Name : DVD Core UnitUnit Number :Unit Name : Connect PCB
DVH-3200UB/XNUW5 21
5 6 7 8
5 6 7 8
C
D
F
A
B
E
3.3 JIGS LIST
3.4 CLEANING
- Grease List NameGreaseGreaseGreaseLocking agentsBondBond
Jig No.GEM1024GEM1038GEM10451401MGEM10331530
RemarksDVD Mechanism ModuleDVD Mechanism ModuleDVD Mechanism ModuleSkew adjustment (1401M:produced by THREE BOND)Skew adjustmentSkew adjustment (1530:produced by THREE BOND)
Disc TDV-582 Skew adjustment, Check points after servicing, Inspection method of Pickup UnitDisc TCD-782 Inspection method of Pickup Unit
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools:
Portions to be cleaned Cleaning toolsDVD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008
DVH-3200UB/XNUW522
1 2 3 4
1 2 3 4
C
D
F
A
B
E
4. BLOCK DIAGRAM
JA4711
2,3
3
1
TU3.3
VDD
ANTENNAC
E2
SL
TUN
PC
KC
E1
TUN
PD
I
TUN
PD
O
SYS+B
VDD VIN
ON/OFF
2VDD1
TUNER AMP UNITA
BUP
AMUTE
48MUTECN101
1
42
25
17
2322
7
VD5
AMUTERXLS1STANDBY
IRQPWTXLS1
VDCONT5
8 1
12 4MS5→SRXSTANBY13 12
3611
Q111
SYS+B
XRESET
45ACCPW
19DSENS
5SWVDD
SYSPW
USBCTL
XRES9 11
10 8IRQPWR
D+D-
S→MS5TX113
23
5
1291
113
1211
43
59
46
24SYNC
VDCONT8
3442
404133
Q112
Q321
BUP
VD5
1
VD5
Q1051
Q1052
4A3A1A
1A2A4A
4Y3Y1Y
1Y2Y4Y
P1191
P1121
P1131
LSL
LSV
IECOUT
LOUT
19 COMPOSIT
OPT3
OPT2(OPTOUT)
B2B1 D-
D+
1OE2OE
A1A2
12
5
4
VDD
USBVINEN
VDD5
VD
VDD 5V
ILMPW3
50
IL
82 1
FLG3USBFLG
85
BUP VIN
CONTROLVOUT
BUP
4
ROT0
ROT1 1
2
DPDT
KYDT 30
29
Q
8
7
VCCCL1
VCC
5VCCCL2
10CL1
3CL2
27EN2
34SYNC
41EXTVCC
26EN1
VD3
3
1
ON/OFF
VINVOUT
46
1
Q1191
OUTL2
OUTH2
48SW2
15
12
Q1151
OUTL1
OUTH1
13SW1
TC7SET08FUS1IC311
1|3
3V→5VIC111
TC74VHCT08AFTS1
5V→3VIC112
TC74VHC08FTS1
TC7MBL6126SFKIC122
D/D CONVERTERIC1103
BD9013KV
VD8
VD 3VIC1111
S-1200B33-M5
SYS+BIC1021
NJM2388F84
TUNER 3IC1011
NJM2885DL
R5523IC1
S-
FMRF
ANT adjRF adj
FM ANT
T51 CF52
RFG
ND
OS
CG
ND
DG
ND
AU
DIO
GN
D
NC
VC
C
VD
D_3
.3
3.3V 2.5VIC4
2.5VIC2
NC
CE
2
RO
M_V
DD SL DI
CK
CE
1
LDE
T
DO
RD
S_C
K
RD
S_D
ATA
RD
S_L
OC
K
RD
S_H
SLK
7 6 13 5 10 9 8 11 14 18 19 20 21
1
3
2 12 15 22 16 4 17
IC13.3V
AM ANT FMRFATT
LPFOSC
IC3EEPROM 5.0V
IC5
ATT
MIXER, IF AMP
DET, FM MPX,RDS DECODER
23Lch
FM/AM TUNER UNIT
3.3V→2.5V
5V→3.3V
:DVH-3200UB/XNUW:DVH-3220UB/XNUW
A
:DVH-3250UB/XNRC:DVH-3250UB/XNRD
BA
B
A
B
LDE
T
RD
S_D
ATA
RD
S_L
OC
K
RD
S_C
K
RD
S_H
SLK
:DVH-3250UB/XNR:DVH-3290UB/XNID
C
FE
IC231NJM4558MD
1OUT1IN+13
C FVCR IN VCRL4
JA282(1/2)
OUTIN4 2
75ΩDRIVER +6dB AMPIC181
TK15405BMI
ACPEG525A:
BD
SYSTEMCONTROLLER
IC601(2/2)
E F
CN1901C
VDD
PEG524A8:
DVH-3200UB/XNUW5 23
5 6 7 8
5 6 7 8
C
D
F
A
B
E
BSENS
ASENS 18
17
6Front_L
7Rear_L
5
3
21
23
FL+
FL-
RL+
RL-
IN1_L1
IN2_L
FLIN12
RLIN14
22
4 STBY
MUTE
3
1
TUNL
KEYAD89
KEYD90
25B.REMOTE
10
12
11
9
4
CN821
SL
CE1TUNPDO
TUNPDI
95
10
63
64
84
66
TUNPCK65
CE1
TUNPDO
TUNPDI
TUNPCK
SL
BUP
6,20
RL-
RL+
FL-
FL+
RCA OUT
GND
BREM
CE2CE2
1
ACC 5
1B.U
VCC1/2,3/4
49AMPPWVDD3
5
OPT-OUT
JA321
RESET
VDD
VDD 3VVIN
ON/OFF
VOUT
MUTE
BSENS
ASENS
6
17
1614
18
7
12
4
19
3
20
OPT3OPT2(OPTOUT)
32
1
JA331
KEYDKEYAD
32
1
3
Q282
RL
2VGND
8
BUP
2VDD1
IN4+_L4
CN701
1VOUT
RL
Vo
SWDVDD
TU3.3
DPDT
KYDT
USB5V
D-D+
ROT0
ROT1
DSENS
BUP
2
LSL
AUXL
VD5
SYS+B
31
Q1051
52VDD
USB 5VVINEN
VOUT 5
VDD 5V
ILM+B
1
FLG3
VOUT
4
AUXL
ILM+BQ1061
AVSIVCRL
2
VST,VCK,VDT
+B218F84
TUNER 3VIC1011
NJM2885DL1-33
Q1062
SWDVDDQ1041
R5523N001BIC1101
RESETIC661
BD4835G
IC1001S-1200B33-M5
RFGND REMOTEWIRED
ELECTRONIC VOLUME/SOURCE SELECTOR
IC201PML014A
AMPIC271
PA2030A
Q261(1/2)
Q261(2/2)
Q781TELIN
36 7TELM
TELM
CONNECTORPOWER
Q751(2/2)
Q751(1/2)
-3200UB/XNUW5-3220UB/XNUW5-3250UB/XNRC-3250UB/XNRD-3250UB/XNRI-3290UB/XNID
RDS-LOCK79
RDS-HSLK81
RDS-DATA80
RCK72
LDET73
RDS_LOCK
RDS_HSLK
RDS_DATA
RDS_CK
LDET
Q401
Q402
A
B
APEG524A8:CPEG525A:
BD
SYSTEMCONTROLLER
IC601(1/2)
E F
A B
JA282(2/2)
A B
GND
3 IN3_L
VMUTE70
Q291BUP Q292
C F
ILM+B
CN1821
KYDT
SWVDD
DPDT
AUXL
DSEN
USB5V
D+D-
ROT1
ROT0
7
4
17
19
3
20
6
18
16
12
14
A
B
RED/GREEN
ILLUMI
CD
F
E
BLUE
KEY MATRIX
1
2
4
5 KDT2
KST1
S1845ROTARY COMMANDER
KDT0-3,KST0-420
18
17
1056
SI/P43
SO/P44
V3VDD
INT1/PWC/P42
LCD DRIVER/KEY CONTROLLER
IC1801PD6497A
SWVDD
3 1
REMOTE CONTROLSENSORIC1802
GP1UXC14RK
CN1911
USB
USB5V
D+D-
1
32
LCDLCD1801
AUXV/SOURCE
CN1901
4
B
FRONTAUXAUXL 2
AUXR 3AUXGND 1
KEYBOARD UNIT
VDD1
DVH-3200UB/XNUW524
1 2 3 4
1 2 3 4
C
D
F
A
B
E
SS
USB_
TRTR
TRT
S
E
F+E
D
COMST
CMST
IE
TR
NRES
HWP(HW+),HWM(HW-)
HVP(HV+),HVM(HV-)
HUP(HU+),HUM(HU-)
HWP(HW+),HWM(HW-)
HVP(HV+),HVM(HV-)
HUP(HU+),HUM(HU-)
NRES
70 NRES
IC
I12 RESET
89
12
567
34
12
3231
272628
14
VHALFTDFD
CRGDRV
MDCONT1CONT2
FOPFOMTOPTOM
V
CTL1CTL2
FG
FCO+FCO-TKO-TKO+
FCINSLIN
VCTKIN
LDINSPIN
W
HB
SL/LDO-SL/LDO+
VU
SLOPOUT
CN1201
CN101
CN701
CRG/LE+
COIL_U
1718
166
3
4
5
987
HALL_BIAS-HALL_BIAS+
COIL_V
COIL_W
67127126
66
716463
FGCONT2CONT1
12EJ
08EJ
HOME
62
MDLDIN
CRGDRVFDTD
343635
33
55
49
65
CRG/LE- 110 VHALF
DVD CORE UNIT
VCC5
BRGY
CRG-CRG+
V COIL VU COIL UW COIL W
VUW
H- HALL BIAS-H+
H-H+ HALL BIAS+
HOME
8SNS
DSCSNS
HOME
8cm
12cm(DSCSNS)
CONNECT PCB
SPINDLE MOTOR
LS1 MECHA UNIT
21
313
16
15
14
101112
123
410
123
410
MLOADING/CARRIAGE
H3
H2
H1
MOTOR
HOMES101
8cmS102
12cmS103
D
C
FLASH 16MIC1401
CWW1753
FLASH 16MIC1402
CWW1754
NRES
NRES 12 RESET
SDRAMIC1480
K4S641632N-LC75
MOTOR DRIVERIC1201
BD8231EFV
VIDEO+AUDIC1501
MN2DS0018M
DVH-3200UB/XNUW5 25
5 6 7 8
5 6 7 8
C
D
F
A
B
E
AVCC5
VOUTL 7BCK
LRCKDATA
MD
1
32
13
LOUT
MLMC
SCK
SRCK
LRCKADOUT
SDODAC
LTDACSCKDAC
DACCK
USB_CLOCK
1514
16
149
150151
57
5658
148
50 2
SRCKADOUT
SDODACLRCK
LTDACSCKDAC
DACCK
TRCSTTRCDATA3TRCDATA2TRCDATA1TRCDATA0
TRCCLKEXTRG0
1234
9
7
12
8
13
56
Q1104Q1102
VREFVCC5
CN1101
CN1951
78LD
F+H_G+HE+G_E+F
F+H/G+HE+G/E+F
LPCO2
8
23
4
1415
12
1817
13
2022
7
5
11
Q1103Q110165LD
VCCVref
LPCO1
TRCDATA2 79TRCDATA3
TRCDATA0
TRCST80
77
81
TRCCLK 76
SDATASCLOCK
SDATA 73
SCLOCK 72
EXTRG0
F+H_G+HE+G_E+F
VIN4RFVIN2RFVIN1RF
VIN3RF
VIN8
DVDMPDTEMPRFINP
CDMPD
LPCO2LPCO1
74
112111
999897
100
116105
ACD
B
FE1FE2
RF12296
103
106104
513
VINVOUT
ON/OFF
VCC5
VD8
543
VINVOUT
ON/OFF
A10
B
CD
FE1FE2
78MDCDMPD65MDDVDMPDTEMP
RF
ROUTLOUT
COMPOSITE
152146144138
STANDBY 191
CMDCOMN 53STSCOMN 54
IRQPWR 48
EXTRG1 75
D+
4
D-
AMUTE
2425
2326
F-F+
FOMFOP
TOPTOM
T+T-
TRCDATA1 78
IFCOUTD+D-
SCLSDA
RESET
COMPOSITSTANBYSLVSTS
HSTCMDSTSCOMNCMDCOMN
COMPOSITESTANDBY
ISC_SCLI2C_SDACP_Reset
IRQPWRAMUTE
VD8
XRESETNRES
X1950
ANALOG LOUT
CN1901
9
3
17
25
272829
23
1110
13
8
7
12
1
2219
VREF
70 NRES
IECOUT
I2C_SDACP_Reset
474661
I2C_SCL
121VDSENS
67127126
66
716463
FGCONT2CONT1
12EJ
08EJ
HOME
62
MDLDIN
CRGDRVFDTD
120VIN1
109VREFH
119VIN2
118VIN4
117VIN3
114VIN6
113VIN5
55
49
65
110 VHALF
VIN7 115
13VCC33 VDD5
VCC33
INOUT
28 VDD5VCC12 VINVDD
CE
LX5
VOUT
VDD5VD5
PU (DP10)
DEBUG
34
VIDEO+AUDIOIC1501
MN2DS0018MAUB
IC1951TC7SZU04FU
AUDIO 2CH ANALOG OUTIC1801
PCM1753DBQ
CN101A
VCC5 REG.IC1002
S-1133850-U5
AVCC5 REG.IC1003
S-1200B50-M5
3.3V REG.IC1004
NJM2885DL1-33
1.2V REG.IC1005
R1232D121B
.2
DVH-3200UB/XNUW526
1 2 3 4
1 2 3 4
C
D
F
A
B
E
- CAW1964
DVH-3200UB/XNUW5 27
5 6 7 8
5 6 7 8
C
D
F
A
B
E
DVH-3200UB/XNUW528
1 2 3 4
1 2 3 4
C
D
F
A
B
E
5. DIAGNOSIS5.1 OPERATIONAL FLOWCHART
VDD = 5 VPin 14, 60
BSENSPin 17
ASENSPin 18
DSENSPin 19
BSENS = L
DSENS = L
Startscommunication
with Grillemicrocomputer.
SWVDD <- HPin 5
Source keysoperative
Source ON
SYSPW <- HPin 50
Completes power-on operation.(After that, proceed to each source operation)
500 ms
500 ms
In case of the above signal, the communicationwith Grille microcomputer may fail.If the time interval is not 500 msec, the oscillatormay be defective.
Power ON
ASENS = L
DVH-3200UB/XNUW5 29
5 6 7 8
5 6 7 8
C
D
F
A
B
E
5.2 INSPECTION METHOD OF PICKUP UNIT
Disc to be used CD-DA: TCD-782
DVD-Video: TDV-582
Execution method
START
Is it OK?
Is it OK?
Ckeck partsother than PICK UP
PICK UPcleaned?
Perform lenscleaning
SKEW ADJ.
Is it OK?
LD current check
RF level check
RF level check
Yes
Error rate check
Finished
LD turned on? Check partsNo
Is it OK? PICK UPcleaned?
Perform lenscleaning
Error rate check
Is it OK?
Replace the PICK UP
Replace the PICK UP
Replace the PICK UP
Replace the PICK UP
Check point:AS MAX check
Check point:LD current check
Check point:Error rate check
YesNo
YesNo
YesNo
YesNo
YesNo
YesNo
YesNo
Check point:AS MAX check
Check point:Error rate check
DVH-3200UB/XNUW530
1 2 3 4
1 2 3 4
C
D
F
A
B
E
LD current check
CheckStatus: [Foucs closed] of TEST MODE
Notes: Please pay attention to the laser diode damage by static electricity.
Threshold
2 TCD-782 CDLD1-VCC5_3 60 - 360 (mV) 10 - 60 (mA)
NO. Disc Check Point
Check Point
DVDLD1-VCC5_3
NO.
1
Disc
GGV1025
Remarks: LD current
10 - 65 (mA)
Threshold
60 - 390 (mV)
Expansion
Expansion
Remarks: LD current
DVH-3200UB/XNUW5 31
5 6 7 8
5 6 7 8
C
D
F
A
B
E
ASMAX checkASMAX value shows the value of RF level.Status: [Foucs closed] of TEST MODE
No. Disc Check Point Threshold Remarks:8 digits value of
ASMAXmore than
on display 0000 0B008 digits value of
ASMAXmore than
on display 0000 0C00
Error rate checkStatus: [Tracking Closed] of TEST MODE
No. Disc Check Point Threshold Remarks:less than
1.000E-03less than
1.000E-03less than
2.500E-033 TCD-782 ID: HOME Position
2 GGV1025 ID: 200000
1 GGV1025 ID: 40000
1 GGV1025Only four last digits aredisplayed according to
the product.
2 TCD-782Only four last digits isdisplayed according to
the product.
In this case, the value is displayed for a split second.When you tried to perform [FOCS CLOSE],the display will charge automatically in the following order.[1FFF0000]->[FEMAX]->[FE MIN]->[AS MAX]->[ENV MAX]->[FE normal]->[Spindle gain]->[TEMAX]->[TEMIN] ->[20000000]Watch carefully the value of ASMAX.
DVH-3200UB/XNUW532
1 2 3 4
1 2 3 4
C
D
F
A
B
E
5.3 DIAGNOSIS FLOWCHARTB
AC
K E
ND
sec
tion
flow
Sta
ndby
OK
?E
xecu
tech
eck
1.
Can
the
play
back
sta
rt?
NO
YE
S
YE
S
YE
S
YE
S
YE
SY
ES
YE
SY
ES
YE
S
YE
S
YE
S
YE
S
NO
NO
NO
NO
NO
YE
S
YE
S
YE
S
NO
YE
SY
ES
NO
ST
AR
T
EN
D
EN
DY
ES
NO
NO
NO
NO
NO
YE
S
YE
S
NONO
NO
The
pro
duct
is
nor
mal
?(iP
od a
ttest
atio
n IC
)
YE
S
Pro
duct
rep
air
YE
S
NO
NO
NO
NO
YE
S
NO
YE
S
YE
S
YE
S
NO
NO
YE
S
Doe
s th
e op
erat
ion
take
tim
e?
Go
to F
E
sect
ion
chec
k.
Go
to F
E
sect
ion
chec
k.
Is th
e life
of f
lash
m
emor
y O
K?
Cond
uct c
heck
item
12.
Is th
e im
age
in e
rror
?
Is th
e vi
deo
circ
uit O
K?
Exe
cute
che
ck 1
1.
Is A
VC
C5
volta
ge O
K?
Exe
cute
che
ck 8
.
Rep
lace
the
unit.
Is V
DD
5(V
CC
33, V
CC
12)
pow
er s
uppl
y vo
ltage
OK
? E
xecu
te c
heck
2.
Res
et O
K?
Exe
cute
che
ck 3
.
Is V
SE
NS
O
K?
Exe
cute
che
ck 4
.
Is 2
7 M
Hz
OK
?E
xecu
te c
heck
5.
Is 4
8 M
Hz
OK
? E
xecu
te c
heck
13.
Rep
lace
the
unit.
Rep
lace
the
unit.
Rep
lace
the
unit.
Go
to F
E
sect
ion
chec
k.
Go
to th
e pr
oduc
t che
ck.
Go
to F
E
sect
ion
chec
k.
Is V
D8,
VC
C5
pow
er s
uppl
y vo
ltage
OK
? E
xecu
te c
heck
7.
Is S
DR
AM
IF
OK
? E
xecu
te c
heck
6.
Is th
e so
und
in e
rror
?Is
the
iPod
pla
y in
err
or?
Is th
e U
SB
pla
y in
err
or?
Is A
VC
C5
volta
ge O
K?
Exe
cute
che
ck 8
.
Is D
ACCL
K no
rmal
?Ex
ecut
e ch
eck
9.
Is th
e au
dio
circu
it O
K?
Exec
ute
chec
k 10
.
Rep
air
the
defe
ctiv
e pa
rt.
Nor
mal
?
Nor
mal
?
Is F
E s
ectio
n no
rmal
?
Go
to F
E r
elat
ed
repa
ir pr
oces
s.
Is th
e iP
od
circ
uit O
K?
Exe
cute
che
ck 1
4.
Is th
e U
SB
circ
uit O
K?
Exe
cute
che
ck 1
4.
DVH-3200UB/XNUW5 33
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Check 1: Standby OK?
<Check> Check the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference.
NO. Check point Module No. Specification value UnitSTANBY-DGND1 ALL VCC33 V-
0.6 V or moreV
Side A
1
Fig 1.1: STANBY check pointSTANBY
DGND1
DVH-3200UB/XNUW534
1 2 3 4
1 2 3 4
C
D
F
A
B
E
VCC33 (= 3.3 V)5DDV
VCC12 (= 1.2 V)
1 VDD5_1 - DGND12 VCC33_1 - DGND13 VCC12_1 - DGND1
VDD5_1
DGND1
VCC12_1
VCC33_1
Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK?
Fig 2.1: Power supply configuration
IC10043.3 V output regulator
IC1005DC/DC converter1.2 V output
IC1501 DV5U power supply
IC1401 FLASH power supply (Data)IC1402 FLASH power supply (Program)IC1481 SDRAM power supplyIC1501 DV5U power supply
<Check> Check the voltage at the “VDD5_1, VCC33_1 and VCC12_1” test point while the power is on. Use the “DGND1” test point at the reference.
Side A
NO. Check point Module No. Specification value Unit
Fig 2.2: VDD5, VCC33, VCC12 voltage check points
ALLALLALL
5.0 ± 0.43.3 ± 0.151.2 ± 0.12
VVV
DVH-3200UB/XNUW5 35
5 6 7 8
5 6 7 8
C
D
F
A
B
E
NRES
DGND1
Check 3: Reset OK?
NO. Check point Module No. Specification value Unit1 XRES-DGND1 ALL VCC33 ×
0.7 or moreV
Side A
<Check> Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference.
Fig 3.1: RESET check point
DVH-3200UB/XNUW536
1 2 3 4
1 2 3 4
C
D
F
A
B
E
CN1901HOST I/F
SNESV8DV
33CCV5DDV
VCC12
STANBYXRES
1 VSENS - DGND1 ALL 0.95 - 1.07 VVD8 = 8.0 ± 0.4 V
IC1501DV5U
IC1004Regulator
IC1005DC/DC converter
VSENS
DGND1
Check 4: Is VSENS OK?
Fig 4.1: Power supply configuration and VSENS
<Check> Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference.
NO. Check point
Side A
Module No. Specification value Unit
Fig 4.2: VSENS check point
R1004,R1007
DVH-3200UB/XNUW5 37
5 6 7 8
5 6 7 8
C
D
F
A
B
E
IC1501
DVD-LSIX150127 MHzcrystal
VCC33 VCC12
Check 5: 27 MHz Normal?
<Outline> Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501).
Fig 5.1: Clock configuration
<Check method> Turn the power on, and check with DGND being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components.
NO. Check point Module No. Specification value Unit
2 IC1501 169pin ALL 27 MHz± 50 ppm ppm
GNDFig 5.2: Clock specification value
Side A
Specificationvalue
Fig 5.3: 27 MHz check point
IC1501 158pin
DGND1
OSCO
OSCI
DVH-3200UB/XNUW538
1 2 3 4
1 2 3 4
C
D
F
A
B
E
MA0 - 11MDQ0 - 15MCKXWE(NWE)XCAS(NCAS)XRAS(NRAS)XCSM(NCSM)DQM0DQM1BA0BA1
IC1480SDRAM
IC1501DV5U
Fig 6.1: SDRAM I/F
Check 6: Is SDRAM I/F OK?
<Outline> In order to secure the MPEG stream data as the buffer, the capacity of communication I/F SDRAM between the LSI and the memory is 64Mbit. Be careful as XCSM, XWE, XCAS and XRAS of IC1480 are called differently in IC1501, namely NCSM, NWE, NCAS, NRAS.
DVH-3200UB/XNUW5 39
5 6 7 8
5 6 7 8
C
D
F
A
B
E
123456789
10111213141516171819202122232425262728293031323334353637
MA0MA1MA2MA3MA4MA5MA6MA7MA8MA9MA10MA11MDQ0MDQ1MDQ2MDQ3MDQ4MDQ5MDQ6MDQ7MDQ8MDQ9MDQ10MDQ11MDQ12MDQ13MDQ14MDQ15MCKXWEXCASXRASXCSMDQM0DQM1BA0BA1
56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %0.17 ohm or lower56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %56 ohm ± 5 %
IC1480 23pinIC1480 24pinIC1480 25pinIC1480 29pinIC1480 30pinIC1480 31pinIC1480 32pinIC1480 33pinIC1480 34pinIC1480 33pinIC1480 22pinIC1480 35pinIC1480 2pinIC1480 4pinIC1480 5pinIC1480 7pinIC1480 8pinIC1480 10pinIC1480 11pinIC1480 13pinIC1480 42pinIC1480 44pinIC1480 45pinIC1480 47pinIC1480 48pinIC1480 50pinIC1480 51pinIC1480 53pinIC1480 38pinIC1480 16pinIC1480 17pinIC1480 18pinIC1480 19pinIC1480 15pinIC1480 39pinIC1480 20pinIC1480 21pin
IC1501 201pinIC1501 203pinIC1501 207pinIC1501 209pinIC1501 208pinIC1501 206pinIC1501 202pinIC1501 200pinIC1501 198pinIC1501 194pinIC1501 199pinIC1501 192pinIC1501 160pinIC1501 162pinIC1501 164pinIC1501 168pinIC1501 170pinIC1501 172pinIC1501 176pinIC1501 178pinIC1501 177pinIC1501 175pinIC1501 171pinIC1501 169pinIC1501 167pinIC1501 163pinIC1501 161pinIC1501 159pinIC1501 183pinIC1501 181pinIC1501 188pinIC1501 189pinIC1501 190pinIC1501 179pinIC1501 180pinIC1501 193pinIC1501 197pin
<Check> Check the conductivity at “check point 1” and “check point 2” without power. In case of NG, check the soldering and defective components throughout the “output t input” of the applicable section.
NO. Signal name Check point 1 Check point 2 Specification value
DVH-3200UB/XNUW540
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Side B
Side A
Check point 1 (IC1480)
Check point 2 (IC1501)
Fig 6.2: SDRAM I/F check point
DVH-3200UB/XNUW5 41
5 6 7 8
5 6 7 8
C
D
F
A
B
E
VD8_1
PGND3VD
VD8_1
PGND1
VCC5_1
AGND3
Check 7: Is VD8, VCC5 power supply voltage OK?
F.E. driver system
IC1002REG IC for VCC 5 V.
Fig 7.1: Power supply configuration
Power supply for PU
NO. Check point Module No. Specification value Unit123
VD8_1 - PGND3VD - PGND3VCC5_1- AGND1
ALLALLALL
8.0 ± 0.48.0 ± 0.45.0 ± 0.1
VVV
Side A
<Check> Check the voltage at the “VD8_1, VD and VCC5_1” test point while the power is on. Use the “PGND3 and AGND1” test point at the reference.
Fig 7.2: VD8, VCC5 voltage check points
VD8_2 VCC5 (= 5.0 V)
DVH-3200UB/XNUW542
1 2 3 4
1 2 3 4
C
D
F
A
B
E
DV IC1801Audio-DAC
GNDAU1PGND3VD
AVCC5
Fig 8.2: VD8, AVCC5 voltage check points
Side A
Check 8: Is AVCC5 voltage OK?
Fig 8.1: Power supply configuration
IC1003REG IC for AVCC 5 V.
<Check> Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus. Check with PGND and GNDAU being the reference.
NO. Check pointVD - PGND_3AVCC5 - GNDAU1
Module No. Specification value Unit12
ALLALL
8.0 ± 0.45.0 ± 0.1
VV
AVCC5 (= 5.0 V)
DVH-3200UB/XNUW5 43
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Fig 9.1: Clock configuration
Check 9: Is DACCLK normal?<Outline> DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501).
DACCLK
<Check method> DVD: DVD-REF-A1 TITLE 1CD: Playback a normal CDDA.Common to all DVD-V compatible modules.Check with DGND being the reference.In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and defective components.
IC1501
DVD-LSIX150127 MHz crystal
IC1801Audio-DAC
VCC33 VCC12
GND
Fig 9.2: Clock specification value
Specificationvalue 1
Specificationvalue 2 Specification
value 3
NO. Check point 1 (stylus) Media Specification value 1 Specification value 2 Specification value 312
DACCKDACCK
DVDCD
2.0 V~VCC33 V2.0 V~VCC33 V
DGND~0.8 VDGND~0.8 V
36.864 0 MHz ± 300 ppm33.868 8 MHz ± 300 ppm
DVH-3200UB/XNUW544
1 2 3 4
1 2 3 4
C
D
F
A
B
E
DGND2
Side B
Side A
Fig 9.3: 27 MHz, DACCLK check point
Check point 1 (DACCK stylus)
Check point 2 (IC1501 148 pin)
DVH-3200UB/XNUW5 45
5 6 7 8
5 6 7 8
C
D
F
A
B
E
CN1901HOST I/F
IECOUT
OLKCRLADOUT
ORKCRS
GNDAU
IC1801Audio-DAC
IC1501DVD-LSI
Fig 10.1: Audio circuit
Check 10: Is the audio circuit OK?<Outline> The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1901). Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F. The digital audio signal (IECOUT), output from DVD-LSI (IC1501).
<Check method> Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB), and check with DGND being the reference. In case of NG, check the applicable line, periphery of major components as described in the above drawing, soldering of the peripheral components and defective components.
NO. Check point 1 (stylus)123
Specification value 1 Specification value 2 Reference waveformADOUT3SRCKLRCK
VCC33 V-0.6 V or higherVCC33 V-0.6 V or higherVCC33 V-0.6 V or higher
0.4 V or lower0.4 V or lower0.4 V or lower
Waveform 1Waveform 2Waveform 3
GND
Fig 10.2: Serial 3 lines specification value
Specificationvalue 1
Specificationvalue 2
DVH-3200UB/XNUW546
1 2 3 4
1 2 3 4
C
D
F
A
B
E
SRCK
LRCK
ADOUTDGND2
Fig 10.3: Serial 3 lines check points
Side A
Side B
DVH-3200UB/XNUW5 47
5 6 7 8
5 6 7 8
C
D
F
A
B
E
LORO GNDAU1
The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference.
NO.45
Fig 10.4: Analog audio out (LO, RO) specification value.
Side A
Specification value is the root-mean-square value (rms).
Check point 1 (stylus)1 400 ± 150 mV1 400 ± 150 mV
Specification value (rms) Reference waveformWaveform 4Waveform 4
LORO
LO GNDAU1 RO
47 kohm 47 kohm
Fig 10.5: Analog audio out check point
Check with DGND being the reference.
NO. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform6 IEC VCC33 V-0.6 V or higher 0.4 V or lower Waveform 5
DVH-3200UB/XNUW548
1 2 3 4
1 2 3 4
C
D
F
A
B
E
IEC DGND2
Fig 10.6: Digital audio signal (IECOUT) check point
Side A
DVH-3200UB/XNUW5 49
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Check 11: Is the video circuit OK?
<Outline> Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the HOST I/F (CN1901) via a buffer circuit.
CN1901HOST I/F
Composite COMPOSITE
Fig 11.1: Video circuit
<Checking method> Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPOSITE signal with an oscilloscope with GNDV1 (stylus) being the reference. Set the trigger mode to “TV trigger” and the trigger line to “150 line”.
IC1501DVD_LSI
VideoDACsection
NO.
Check point 1 (stylus)
Specification value Reference waveform1 COMPOSITE 1 000 mVpp ± 5 % Waveform 6
In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components.
PEAK
COMPOSITE signal Referencevalue
Color burstPedestal level
BOTTOMHorizontal sync signal
Fig 11.2: Waveform for the case of composite white 100% output
DVH-3200UB/XNUW550
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Side A
COMPOSITE GNDV
Fig 11.3: VIDEO signal check point
DVH-3200UB/XNUW5 51
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Check 12:How to judge whether the flash memory has reached its life or not.
If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory has reached its life.Make judgment regarding the flash memory life by looking at the display of the LD energizing time.
1.Let the LD energizing time displayed. (Refer to the FE test mode for the method of displaying the LD energizing time.) 2.If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life.
Example:
0E000BB8
DVH-3200UB/XNUW552
1 2 3 4
1 2 3 4
C
D
F
A
B
E
USB_CLOCK
IC1501
DVD-LSIX195048 MHz
VCC33 VCC12
Check 13: 48 MHz Normal?<Outline> Each clock is created inside the IC1501 using the 48 MHz master crystal oscillator (X1501).
Fig 13.1: Clock configuration
crystal
Fig 13.2: Clock specification value
<Check method> Turn the power on, and check with DGND1 being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components.
NO. Check point Module No. Specification value Unit
2 IC1501 50pin-DGND1 ALL 48 MHz± 50 ppm ppm
GND
Specificationvalue
DVH-3200UB/XNUW5 53
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Side A
DGND1
IC1501 50pin
Fig 13.3: 48 MHz check point
DVH-3200UB/XNUW554
1 2 3 4
1 2 3 4
C
D
F
A
B
E
CN1901HOST I/F
No.1 CP_RESET2 SDATA VCC33*0.7or more VCC33*0.2 or less
VCC33*0.7or more VCC33*0.2 or lessVCC33*0.7or more VCC33*0.3 or lessVCC33*0.7or more VCC33*0.3 or less
3 SCLOCK4 D+5 D-
Fig. 14.2: USB Circuit Communication Wave
VCC33*0.7or more
IC1501DVD-LSI
D-
D+
I2C_SCL
I2C_SDA
CP_RESE
Standard value 1
Standard value 1
Standard value 2
Standard value 2
DGND
Check 14: Is USB Circuit OK?<Outline>The data is transmitted through D+, D- and SDA of HOST I/F while playing USB/IPOD.USB memory uses only D+ and D-, but IPOD uses SDA (DATA) and SCL (CLOCK)in addition to D+ and D-.
Fig. 14-1: USB Circuit
<Check Method>1.USB Memory: Play a song from USB memory and check D+ and D- with the DGND standards.2.iPod: Connect iPod and check CP_RESET, SDA and SCL with the DGND standards until the pioneer log appears.Play a song from iPod and check D+/D- with the DGND standards.When it does not conform to the standards, check appropriate line, main parts shown in the above figure, soldering of peripheral parts and malfunctions in parts.
Checking spot (stylus)
*Until the pioneer log appears after connecting the iPod*Until the pioneer log appears after connecting the iPod
DVH-3200UB/XNUW5 55
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Side A
SCLOCK
SDATA
D-
CP_RESET
D+ DGND2
DVH-3200UB/XNUW556
1 2 3 4
1 2 3 4
C
D
F
A
B
E
AUDIO
Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: GNDAU2 1 V/div. 500 usec/div
Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: DGND2 1 V/div. 500 nsec/div
CH1:LRCK
CH1:SRCK
CH1:ADOUT3
CH1:LOCH2:RO
CH1:IECOUT
Reference voltage: DGND2 1 V/div. 5 usec/div
G->
G->
->G->G
G->
G->
Waveform 1 Waveform 4
Waveform 2
Waveform 3
Waveform 5
DVH-3200UB/XNUW5 57
5 6 7 8
5 6 7 8
C
D
F
A
B
E
VIDEO
USB memoryUSB memory USB memory
[WHITE 100IRE]
CH1:COMPO
Reference voltage: GNDV1 200 mV/div. 10 usec/div
-D-D
DNGDDNGD+D+D
Waveform 6
Waveform 7 Waveform 8
Reference voltage:DGND 1 ms/div 2 V/div Reference voltage:DGND 200 ns/div 2 V/div
DVH-3200UB/XNUW558
1 2 3 4
1 2 3 4
C
D
F
A
B
E
iPod
-D-D
DNGDDNGD+D+D
CP_RESET
DGND
SDA
NRES
iPod
SCL
iPod
iPodiPod
iPod
Waveform 9
Waveform 11
Waveform 13
Waveform 12
Waveform 10
Reference voltage:DGND 1 ms/div 2 V/div
Reference voltage:DGND 20 ms/div 1 V/div
Reference voltage:DGND 500 us/div 1 V/div
Reference voltage:DGND 2 ms/div 1 V/div
Reference voltage:DGND 200 ns/div 2 V/div
DVH-3200UB/XNUW5 59
5 6 7 8
5 6 7 8
C
D
F
A
B
E
5.4 ERROR CODE LIST
Error status OSD *1 DiscUSB
(MSC)USB
(iPod)ACC
Off/OnSourceOff/On
Eject Play Key
NON-PLAYABLE DISC
INCOMPATIBLE DEVICE
UNPLAYABLE FILE
Open 10h X - - * * * *Read Error 0h299-20-RORRE X - -Focus Error(Focus Errorin mechanism set u p) h1209-20-RORRE X - - X X X X
X X X X
Surface Error h22E9-20-RORRE X - - X X X X
Address no tfound(Invalid Track) ERROR-02-80 23h X - - X X X X
Spindle Lock ERROR-02-91 24h X - - X X X X
Carriage HOME ERROR-02-92 25h X - - X X X X
ID/SUBCODE Read Error ERROR-02-94 26h X - - X X X X
AV CHIP decode Error ERROR-02-9A 2Ah X X - X X X X
AV CHIP Recovery NG ERROR-02-9B 2Bh X X X X X X X
Error of PLAY BAC KMode Status ERROR-02-9C 2Ch X X - X X X X
Disc Data Error ERROR-02-9D 2Dh X - - X X X X
THERMALPROTECTION IN MOTION
No Disc( including Disc loadingand e jecting)
40h X - - * * * *
Loading_Mecha Error 50h X X X X - X -
Communication fault attesting iPod Communication fault attesting iPodh0606-20-RORRE X - Xh1616-20-RORRE X - X
iPod attestation retrying failure
iPod attestation time out
h2626-20-RORRE iPod attestation retrying failure X - X
h3636-20-RORRE X - X - - X -
- - X -- - X -- - X -
h4646-20-RORRE - - X - - X -
- - X -Error setting iPod h5656-20-RORRE - - X
h6666-20-RORRE - - X - - X -
h7676-20-RORRE - - X - - X -
h8686-20-RORRE - - X - - X -
No songs error h96 - - X - - X -
iPod control forwarding/Intarapta forwarding error hA6A6-20-RORRE - - X - - X -
Demand timeout iPod's reproducing hB6B6-20-RORRE - - X - - X -
- - X -ERROR-02-6C - - XRemote switch demand timeout ERROR-02-6D - - X - - X -
- - X -
- - X -
PROTECTED DISC
NO ACCESSIBLE DATA AVAILABL
DIFFERENT REGION DISC
NON-PLAYABLE DISC
ERROR-02-A0 X - - X X X X
h1A1A-20-RORRE X - -
ERROR-02-A2 A2h X - - X X X XERROR-02-A3 A3h X - - X X X XERROR-02-A4 A4h X - - X X X XERROR-02-A5 A5h X - - X X X XERROR-02-A6 A6h X - - X X X XERROR-02-A7 A7h X - - X X X XERROR-02-A8 A8h X - - X X X XERROR-02-A9 A9h X - - X X X XERROR-02-AA AAh X - - X X X X
Focus Error ERROR-02-AB ABh X - - X X X XError of PLAY BACKMode Status h0B0B-20-RORRE X - - X X X X
Error of PLAY BACKMode Status h1B
C0h
1B-20-RORRE X - - X X X X
Audio Property Timeou tError *9 ERROR-02-C0 Audio property timeout error X - - X X X -
ERROR-02-D0 - X - - - X -
CBW and CSW forwarding error ERROR-02-D1 - X - - - X -Audio class band securing failure ERROR-02-D8 - - X - - X -Audio class FS setting failure ERROR-02-D9 - - X - - X -Undefined Error ERROR-FF-FF X - - X X X X
- -
- -
00h USB device of format alone that cannot be reproduced X X
30h X
70h - -X --
90h --X
Method of reset
Temp Error(In Case of HighTem perature )
Region code Error NG
- -
- -
8*rorrEyeK7*MRPC Key Error for playback X --
X ---
- - - -
X -
Generation source
-
- -
X X
h00rorrEaideM X X X X -
00h USB device that doesn't correspond XX-
X -h07rorrEMRD X
(No display)
(No display)
(No display)
(No display)
A disc containing the unplayable Format only
Door open errorTransfer start error
Focus error
Focus error during set up (A focus has never been achieved with that disc.)
Address not found.
Spindle lock NG (the disc cannot rotate)Carriage home NG (The pick up tries to return to carriage home, but it cannot go back and stopped.)
ID/SUBCODE Read Error (ID/SUBCODE cannot be read due to scratch or stain.)
UART*2 Meaning
AV CHIP decode NG (AV chip cannot be decoded.)
AV CHIP recovery NG
Playback state error (An error due to software bug.)
Disc Data NG
Disc has not been inserted. (Including Load in process or Eject in process.)
High temperature (Playback is stopped because the pick up temperature is 89 C or higher.)
Loading mechanism error (The disc cannot be clamped.)
6Ch
6Dh
A0h
h39
D0h
FFhD9hD8hD1h
DRM error (All music cannot be played back due to DRM.)DRM error (All music cannot be played back due to DRM.)
Undefined error
iPod authentication data is abnormal iPod authentication data is abnormal
REQUEST errorFailure in issuing the read command
L0 adjustment is NG.L1 adjustment is NGLD system NGGain adjustment system NG.Gain determining system NG.Servo initial setting related items NG.Disc is not clamped yet.Tracking system NGMedia setting system NGJUMP over layers NG
Navigation command error
Retry over
REQUEST errorFailure in issuing read command (chip dependent)Adjustment of L0 is NG.Adjustment of L1 is NG.LD system NGGain adjustment system NG.Gain determining system NG.Servo initial setting related items NG.Disc is not clamped yet.Tracking system NG.Media setting system NG.
X X X X
Error when iPod is connected/It is generated STALL by the USB communication
Demand timeout when initial is communicatedProtocol version non-correspondenceTimeout when protocol version is judged
Remote switch error
iPod attestation time out
Error setting iPod
No songs error
iPod control forwarding/Intarapta forwarding errorDemand timeout iPod's reproducing
Remote switch demand timeout
Error when iPod is connected/It is generated STALL by the USB communication
Demand timeout when initial is communicatedProtocol version non-correspondenceTimeout when protocol version is judged
Remote switch error
Error when MCS is connected/It is generated STALL by the USB communication
CBW and CSW forwarding errorAudio class band securing failureAudio class FS setting failure
Error when MCS is connected/It is generated STALL by the USB communication
Region code NG (Unable to be played back due to incorrect mechanism region.)
DVH-3200UB/XNUW560
1 2 3 4
1 2 3 4
C
D
F
A
B
E
X: Cancel the error by operation. -: Error is not cancelled by operation. *: No setting*1 A content displayed on OSD. As for the items having multiple display patterns, the upper row is for the Japanese version Full GUI, and the lower row is for the Touch Panel model and Full GUI (English version).*2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits. *3 CPPM(Content Protection for Prerecorded Media) : A copyright protection technique used in DVD-A. The protection is realized by using the keys recorded on the media and the device key held by the player.*4 DVD-A compatible model only. When an error has occurred, only the audio output will be muted but playback operation will continue. Furthermore, acceptance of the user operation will be the same as usual.*5 AWM (Audio WaterMark): Electronic watermark. Information on the copyright owner or CCI (copy control information) are recorded so that illegally copied discs can be identified.*6 Notice as an error status will not be given*7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card. (DVD-VR model only)
DVH-3200UB/XNUW5 61
5 6 7 8
5 6 7 8
C
D
F
A
B
E
USB audio player/USB memory
Message Cause Action
NON-PLAY(UNPLAYABLEFILE)
This type of filecannot be playedon this unit.
Select the playablefile.
There are nosongs.
Transfer the audiofiles to the USBportable audioplayer/USB mem-ory and connect.
Security for theconnected USBmemory is en-abled.
Follow the USBmemory instruc-tions to disable se-curity.
SKIPPED (FILESKIPPED)
The connectedUSB portableaudio player/USB memorycontains WMAfiles that are pro-tected byWindows Med-ia™ DRM 9/10.
Play an audio filenot embedded withWindows MediaDRM 9/10.
PROTECT (NOACCESSIBLEDATA AVAIL-ABLE)
All the files onthe connectedUSB portableaudio player/USB memory areprotected byWindows MediaDRM 9/10.
Transfer audio filesnot protected byWindows MediaDRM 9/10 to theUSB portableaudio player/USBmemory and con-nect.
Message Cause Action
N/AUSB (IN-COMPATIBLEDEVICE)
The USB deviceconnected to isnot supported bythis unit.
Connect a USBportable audioplayer or USBmemory that isUSB Mass StorageClass compliant.
The USB deviceis not formattedwith FAT16 orFAT32.
The connectedUSB device shouldbe formatted withFAT16 or FAT32.
CHECK USB The USB connec-tor or USB cablehas short-circuited.
Check that theUSB connector orUSB cable is notcaught in some-thing or damaged.
The connectedUSB portableaudio player/USB memoryconsumes morethan 500 mA(maximum allow-able current).
Disconnect theUSB portableaudio player/USBmemory and donot useit.Turn theignition switch toOFF, then to ACCor ON and thenconnect a compli-ant USB portableaudio player/USBmemory.
ERROR-02-DX Communicationfailed.
Perform one of thefollowing opera-tions.–Turn the ignitionswitch OFF andback ON.–Disconnect theUSB portableaudio player/USBmemory.–Change to a dif-ferent source.Then, return to theUSB portableaudio player/USBmemory.
DVH-3200UB/XNUW562
1 2 3 4
1 2 3 4
C
D
F
A
B
E
5.5 CONNECTOR FUNCTION DESCRIPTION
(DVH-3250UB/XNRC)(DVH-3290UB/XNID)
AUDIO INPUT
ANTENNA REAROUTPUT
OPTICAL OUTPUT
1 3 5 7 9 11 13 15
2 4 6 8 10 12 14 16
1. B.UP2. GND3. NC4. B.REM5. ACC6. NC7. TELM8. VGND
9. RL-10. FL-11. RL+12. FL+13. RR-14. FR-15. RR+16. FR+
VIDEOOUTPUT
WIRED REMOTE CONTROL
(DVH-3200UB/XNUW5)(DVH-3220UB/XNUW5)
DVH-3200UB/XNUW5 63
5 6 7 8
5 6 7 8
C
D
F
A
B
E
6. SERVICE MODE6.1 DISPLAY TEST MODE
Turn BUP + ACC on while pushing the 1 + 3 key
Key21
Processing
Move to the next display test contents (B)
Contents (A) Contents (B)
Move to the next display test contents (A)
All lighting of displayPattern(1) lighting
Lighting of display
The same contents as the left
The same contents as the left
All lights out of displayCWW number is displayedPEG number is displayed
Pattern(2) lighting
The same contents as the left
System microcomputer version is displayed
LS1 mechanism version is displayed
System version display
Normal display
Display STOPROM Correction version display
DVH-3200UB/XNUW564
1 2 3 4
1 2 3 4
C
D
F
A
B
E
6.2 DVD TEST MODE
Image of the test mode.
[Note] Higher level 4 characters only. Lower level 4 characters are spaces.
)2()1(
Start of the test mode.
TEST
FE test selection EDC1 test selection
Hereafter, to FE test mode image.
Hereafter, to EDC1 test mode image.
[Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode.
(3)
EDC2 test selection
Hereafter, to EDC2 test mode image.
(4)
LD power on time mode selection
Hereafter, to LD power on time mode image.
(5)
Simple FE test mode
Hereafter, to simple FE test mode.
Legend: … Key operation
… Operation state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
Image of the front end test mode.
(2)
FE test mode
Disc type DVD1 layer
FE offset coefficientTE offset coefficientAS offset coefficientENV offset coefficientTG offset coefficientDBAL coefficientVIN1 offset cancel valueVIN2 offset cancel valueVIN3 offset cancel valueVIN4 offset cancel valueVIN5 offset cancel value
Power on
0000 00000FFF 0000
0 x 00 0000
Legend: … Key operation
… Operation state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
)5()4(
Disc type DVD2 layer
Disc type CD
0000002000000010
Disc type CD-RW
0300 0000
EJECT
EJECT
[Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically. If F close is selected during LD-OFF, it will become an error.During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds.In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again before F close.
FEMAX levelFEMIN levelASMAX levelENVMAX levelFE normalization coefficientSpindle gain coefficientTEMAX level indicationTEMIN level indication
(2)
Focus close state
)2()1(
S curve measurement
(2)
hcraesFesolcF
1A00 0000
F search
1100 0000
1FFF 0000
(3),(4)
CRG+/-
Activates while the key is being pressed.
1B00 0000 : CRG+1C00 0000 : CRG-
(5) (6)
LD-ON/OFF
When LO-ON: 1100 0000When LD-OFF: 1000 000
CRG_HOME
1D00 0000
(8)
Power_OFF
(1) (3)
a b
1 x 00 0000
(7)
CRG_OUTSIDER
1E00 0000
[4] + [6] + BUP & ACC ONSOURCE : DVD
DVH-3200UB/XNUW5 65
5 6 7 8
5 6 7 8
C
D
F
A
B
E
(2)
(1) (2)
Tracking balance
TBAL coefficient (layer 0)TBAL coefficient (layer 1)TE normalization coefficient (layer 0)TE normalization coefficient (layer 1)Off track adjustment result
Focus Jump
When L0 layer: 2000 0000When L1 layer: 2100 0000
2 x 00 0000
2FFF 0000
(3),(4)
CRG +/-
It operates while the key is being pressed.
2B00 0000 : CRG+2C00 0000 : CRG-
3000 0000
(8)
Power_OFF
(8)
Power_OFF
(5)
Performed including the tracking close processing.
FBAL coefficient (layer 0)FBAL coefficient (layer 1)Focus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)
RF level value
3FFF 0000
Tracking close state
)2()1(
(1)
Error rate measurement
Error rateFocus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)
RF level value indication start
5000 0000
RF level is informed every 500msec.
RF level value indication end
)8()7(
To (2)
T.OPEN Power_OFF
)4(,)3()1(
Tracking close CRG +/-
It operates while the key is being pressed.
3B00 0000 : CRG+3C00 0000 : CRG-
3FFF 0000
a b
)2()1(
Tracking close state
Error rate measurement
FBAL coefficient (layer 0)FBAL coefficient (layer 1)Focus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)
Playback speed switching
4000 0000
4 x 00 0000
(5)
Error rateFocus gain coefficient (layer 0)Focus gain coefficient (layer 1)Tracking gain coefficient (layer 0)Tracking gain coefficient (layer 1)AS normalization adjustment value (layer 0)
Focus Jump
DVDX1.3~1.6CAV
CDX4CLV:4x00 0000
When L0 layer: 4x00 0000When L1 layer: 4x00 0000
(8)
Error display
Power_OFF
Error occurrence
L0 layer DVD X 1.3~1.6CAV, CD X 4CLV :4000 0000L1 layer DVD X 1.3~1.6CAV :4100 0000
[Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again.
Error occurrence at Power_OFF
Error display
The number for designation of the track number shall be selected from the track numbers previously prepared.Switch to cyclic by (3). Fix by (4).For CD: Tracks 1, 4, 10, 11 and 32For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100
Change the method for ID address designation.Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5).
The higher 2 digits of the designated ID are the value showing the test state. The lower 6 digits show the ID.Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000.
)8()7(
To (2)
T.OPEN Power_OFF
)4(,)3()6(
)3()4(-)1(
)5()5(
ID Search T.Jump+/-
4A00 0000Jump+ : 4B00 0000Jump- : 4C00 0000
ID designation
ID display
Track number designation
Track number indication
Search start Jump start
DVH-3200UB/XNUW566
1 2 3 4
1 2 3 4
C
D
F
A
B
E
EDC. Image of the test mode
[Note] Image is the same for both EDC1 and EDC2.
(1) (2)
EDC1/2 test mode
0000 0000
Layer 0 selection Layer 1 selection
0000 0000 0100 0000
1003 0000 1103 0000
(5)
[Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected.
(1)-(4)
ID designation
EDC1/2 start
Layer 0: 10** ****Layer 1: 11** ****[Note] ** **** is the ID designation value
Layer 0: 20** ****Layer 1: 21** ****[Note] ** **** is the present ID designation value
**** ****[Note] **** **** is the present ID designation value
Legend:… Key operation
… Operational state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
[Note] Eject can be effected any time during the EDC test mode.
Eject
After completion of EJECT operation
EJECT operation
Test mode Eject
Image of the LD power on time mode.
LD power on time mode
0000 0000
CD LD power on time indication
DVD LD power on time indication
10** ****[Note] ** **** is the CD LD
power on time.
20** ****[Note] ** **** is the DVD LD
power on time.
(1) (2)CD LD power on
time setting
Setting time designation
30** ****[Note] ** **** is the setting time.
Setting time registration
DVD LD power on time setting
Setting time designation
40** ****[Note] ** **** is the setting time.
(5) (6)
(1)-(4) (1)-(4)
(5) (5)
(8)
10** ****[Note] ** **** is the CD LD
power on time.
Setting time registration
(8)
20** ****[Note] ** **** is the DVD LD
power on time.
[Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours.[Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory.
[Method of setting time designation]Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Cancel by command (8).
Legend: … Key operation
… Operational state
… The content displayed on the DVD mechanism (video only)8 characters data is sent to the product side (HOST) by UART communication.
Not for service use
DVH-3200UB/XNUW5 67
5 6 7 8
5 6 7 8
C
D
F
A
B
E
The selection of the figure of each screen can be selected by "Key command for the test".
TEST MODE
1: LD ON2: ASMAX3: Skew Adjustment4: Error Rate5: CRG Move Outer6: Eject
Please Input Number
NODLNODLNODL
1: DVD Single Layer 1: Power OFF2: DVD Dual Layer3: CD4: CD-RW5: Return
rebmuNtupnIesaelPgninnuRwoNrebmuNtupnIesaelP
XAMSAXAMSAXAMSA
1: DVD Single Layer 1: Power OFF2: DVD Dual Layer3: CD4: CD-RW5: Return ASMAX Level : 000000
rebmuNtupnIesaelPgninnuRwoNrebmuNtupnIesaelP
tnemtsujdAwekStnemtsujdAwekStnemtsujdAwekS
1: DVD Single Layer 1: Power OFF
5: Return RF Level : 000000
rebmuNtupnIesaelPgninnuRwoNrebmuNtupnIesaelP
rennI-etaRrorrErennI-etaRrorrEetaRrorrEetaRrorrE
tnemerusaeMrennI:1reyaLelgniSDVD:1 1: Power OFF2: Outer Measurement
tnemerusaeMelddiM:3DC:3
nruteR:5nruteR:5 Error Rate : 000000
NtupnIesaelPgninnuRwoNrebmuNtupnIesaelPrebmuNtupnIesaelP umber
*1 : The position in which select was done is displayed.
Error Rate -CD
DVD InnerDVD OuterDVD MiddleCD CD
Now Running
retuOevoMGRCretuOevoMGRCretuOevoMGRC
1: DVD Single Layer 1: Power OFF2: DVD Dual Layer3: CD4: CD-RW5: Return
rebmuNtupnIesaelPgninnuRwoNrebmuNtupnIesaelP
ERROR
1: Power OFF
Code : 00000000
Please Input Number
ERROR
Code : 00000000
Please Reset
1 select
2 select
3 select
4 select
select LD ONCompletion
selectASMAX
value set
value set selectRF Level
DVD select selectError Rate
set select
select
select
select
select
ASMAXLevel display
Error Ratedisplay
RF Leveldisplay
Update 500 msec.
*1
CD select
*1
*1
Search ID0x00100000
Search IDinner :
0x00040000outer :
Search CRGhome position
5 Return select
5 Return select
5 Return select
5 Return select
5 Return select
5 select
select select
CRG moves to the most outer
5 Return select
CRG MoveCompletion
0 00200000
Simple test mode
<Flow chart>
<Error>
<Error : Power OFF>
DVH-3200UB/XNUW568
1 2 3 4
1 2 3 4
C
D
F
A
B
E
7. DISASSEMBLY
2
1
2
3
4
Fig.1
Fig.2
- Removing the DVD Mechanism Module (Fig.1) DVD Mechanism Module
- Removing the Tuner Amp Unit (Fig.2)
1. Remove the Case.
Remove the screw.
Remove the screw.
Remove the two screws.
Straighten the tabs at three locationsindicated and then remove the TunerAmp Unit.
2
1
2
4
4
Disconnect the connector and then remove theDVD Mechanism Module.
Tuner Amp Unit
1 Release the three latches and then removethe Panel Assy.
Remove the four screws.
- Removing the Case (not shown)
Panel Assy
1 1
3
2
2
34
2
1
DVH-3200UB/XNUW5 69
5 6 7 8
5 6 7 8
C
D
F
A
B
E
1
2
1
* Don’t recycle the sheet removed, and exchange it for a new sheet.
- Removing the Sheet (Fig.3, 4)
Disconnect the FFC from the Connector. (Fig.3)
The two seals is removed, and then removed the Sheet. (Fig.4)
The Sheet is put on two places.
- How to put the Sheet (Fig.5)
1
2 2
1
1
Connector FFC
Sheet
Fig.3
Fig.4
Fig.5
DVH-3200UB/XNUW570
1 2 3 4
1 2 3 4
C
D
F
A
B
E
1.Have a specified part.
Handling OK
Handling NG
How to have it
DVH-3200UB/XNUW5 71
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Connector (relay FFC)Relay FFC
Fig. 1 Fig. 2
GND the brown line
4V to the gray line
Mecha Module_Bringing into the Clamp State with No Disc Loaded1. Remove the relay FFC from the connector on the module PCB side (Fig. 1). (Precaution) When it is difficult to apply 4V to the motor in procedure 2 below, remove the connector on the relay PCB side, then remove the FFC, and remove the solder of the CRG motor lead and apply voltage to the lead.2. Push the Disc detection arm while applying 4V to the CRG motor (Fig. 2) By this action, the mecha moves to the clamp state and the PU moves to the outer periphery.3. Stop the motor when the PU comes to the vicinity of the intermediate periphery. (Precaution) If the PU goes to the outer most periphery, it idles. It is not a problem, but please try not to let it idle as much as possible.
DVH-3200UB/XNUW572
1 2 3 4
1 2 3 4
C
D
F
A
B
E
T-case washer
Drive gear
Fig. 1
Fig. 2
b.Open-lock state
There is a space
There is no space
c.Clamp state with no disc loaded
A
CRG Mecha_Bringing into the Clamp State with No Disc Loaded1.Remove the T-case washer and then remove the drive gear. (Fig. 1)2.Lift the clamp arm assy until it is in the state shown in Fig. 2_b (open-lock state).3.Put your finger on the area A of Fig. 2_c and then slide it to the direction of the arrow (the direction of the playing state).4.Push down the clamp arm.(Precaution) When bringing the CRG mecha into the ejecting state again, install the drive gear after sliding the drive lever and bringing it to the ejecting state, in order to prevent the cog of the pinion in the drive gear from chipping at the time ofits installation.
a.Ejecting state
DVH-3200UB/XNUW5 73
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Connector (pick up FPC)
Connector(Relay FFC)
PCB clinch screw
Short-circuit
Fig.1Fig. 2
Fig.3
Pick up FPC
Relay FFC
Fig. 4
Solder on the lead
Relay PCB clinch screw
Hook A
Hook B
Fig. 5
Hook BFig. 6
OK NGFig. 7 Fig. 8
A
Removing the Module PCB1.Short-circuit two spots on the land of the pick up FPC. (Fig. 1)2.Remove the pick up FPC and the relay FFC from the connector. (Fig. 2)3.Temporarily attach the pick up FPC to the pick up rack. (Fig. 3)(in order to prevent the damage to the pick up FPC)4.Remove the two PCB clinch screws and then remove the module PCB. (Fig. 2)
Removing/Installing the Relay PCBRemoving)1.Remove the relay FFC from the connector (remove both sides so that the entire FFC will be removed). (Fig. 2)2.Remove the solder on the lead for the CRG motor. (Fig. 4)3.Remove the one relay PCB clinch screw. (Fig. 4)4.Slide the relay PCB to the direction of the arrow and then remove the relay PCB from the hook A and the hook B. (Fig. 4)5.Turn the relay PCB over and then remove the SPDL motor FFC from the connector.Installing)1.Check the mecha is in the ejecting state (disc-load suspended state).When it is not in the ejecting state, apply 4V to the lead (motor) and then bring it to the ejecting state (4V to the brown line and GND the gray line).2.Fit the SPDL motor FFC to the connector (back of the relay PCB).3.Hold the relay PCB so that it does not touch the SW knob as in Fig. 5.4.Insert it into the hook B as it is a little off to the clockwise direction.(Precaution) This is to prevent the SW knob from getting into the NG position as in Fig. 6.5.Push down the relay PCB lightly and then rotate it to the counterclockwise direction.It sets the relay PCB in the hook A and the positioning dowel. (Precaution) Pay attention so the SW knob will not get onto the PU rack. (Fig. 6)6.As in the Figures, while supporting the location A with your fingers, screw the relay PCB. (Fig. 7 / Fig. 8)7.Solder the lead for the CRG motor.8.Fit the relay FFC to the connector.
DVH-3200UB/XNUW574
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Fig. 2a
Permanently hooked position Temporary hooked positionFig. 2b
A
Slide to the direction of inner peripheryFig. 1
Fig. 3
B
Fig.4
Regularly installed position Install avoiding the area with blue broken line (the connected metal plate part)
The spring is installed under the resin flange and inside the bended metal plate.
Outside holderBack end of the feed screw
Removing the PU Unit1.Hook the feed screw biasing spring on the temporary hook (Fig. 2b). Be careful not to get injured by the tip of the spring.2.Hold the PU at the location A in Fig. 1 and slide and scoot it to the direction of the inner periphery.3.As in Fig. 3, shift the back end of the feed screw to the side and then to above and remove it from the outside holder.4.Remove the tucking joint for the chassis at the location B and the PU unit by lifting them up without changing their position and then remove the PU unit.(Precaution) When installing the PU again, make sure to tuck the chassis in B and the PU unit (Fig. 4) first.Moreover, do not forget to permanently hook the feed screw biasing spring (Fig. 2a).Adjustments to the PU after its installation should be made according to the service manual.
Sending the PU to the outer periphery1.Bring to the clamp state with no disc loaded according to the “Mecha Module_Bringing into the Clamp State with No Disc Loaded” manual.(Precaution) The relay FFC must be removed for certainty in order to prevent the IC damage.2.Apply 1.5V to the CRG motor and then transfer the PU to the outer periphery.(Precaution) Do not forget to reinstall the relay FFC after sending the PU to the outer periphery and take the necessary measures.
[Installation NG]The chassis is not tucked between the PU case and the PU rack.
DVH-3200UB/XNUW5 75
5 6 7 8
5 6 7 8
C
D
F
A
B
E
8. EACH SETTING AND ADJUSTMENT8.1 DVD ADJUSTMENT
1) PrecautionsThis product uses 5 V and 3.3 V as standard voltages.The electrical potential that is the reference for signals,is not GND, but VREF (approximately 2.2 V) and VHALF(approximately 1.65 V) .During product adjustments, if the reference voltage ismistakenly taken as GND, and a grounding contact ismade, not only would it be impossible to measure theaccurate electrical potential, but also the servo motorwould malfunction, resulting in the application of astrong impact on the pick up. The following precautionarymeasures should be strictly adhered to, in order toavoid such problems.The reference voltage and GND should not be confusedwhen using the minus probe of a measurement device.When an oscilloscope is being used special care shouldbe taken to make sure that the reference voltage is notconnected to the probe of ch1 (on the minus side),while the probe of ch2 (on the minus side), is connectedto GND. Further, since the body frame of most measurementdevices have the same electrical potential asthe minus side of the probe, the body frame of the measurement device should be set to floating ground.
If the reference voltage is connected to GND by mistake, turn the regulator OFF immediately, or turn the power OFF. Remove the filters and wires used for measurements only after the regulator has been turned OFF. After the power supply is turned on, regulator ON the following adjustment and measurement are promptly done. Whenever the product is in the test mode, the software will not take any protective action. For this reason, special care should be taken to make sure that no mechanical or electrical shock could be applied to the product when taking measurements in the test mode. Whenever the EJECT key is pressed to eject the disk, no other keys, other than the EJECT key, should be pressed until the disk eject action has been completed. Press the EJECT key only after the disk has stopped completely. If the product hangs up turn the power OFF immediately. Laser didoes may be damaged, if the volume switch for the laser power adjustment of the pick up unit, is turned.
DVH-3200UB/XNUW576
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Disc used:TDV-582
Measurement reference: AGND3Measurement point: RF
Expansion
Oscilloscope
RF
AGND3
- SKEW adjustmentWhen one of the following replacements has taken place, SKEW adjustment for the pick up will be required.(1) Replacement of the pick up unit(2) Replacement of the spindle motor(3) Replacement of the carriage chassis(4) Replacement of the main shaft of the pick up unit
Measurement equipment and tools/jigs: Oscilloscope Driver for SKEW adjustment -> Driver Bond for fixing the SKEW -> GEM1033 Bond for resonance -> 1530 (1530 : produced by THREE BOND) Bond for locking the screw -> 1401M (1401M : produced by THREE BOND)
Connection drawingDVD core unit
Symptom in case the adjustment is not adequate: Worsening of the error rate 10 (Normally 10 or less.) Large RF jitter RF waveform distortion Tracking drawing/Unstable servo* Caution: Do not look into the laser light during adjustment.
-3
-4
RF
AGND3
DVH-3200UB/XNUW5 77
5 6 7 8
5 6 7 8
C
D
F
A
B
E
TEST MODE
1: LD ON2: ASMAX3: Skew Adjustment4: Error Rate5: CRG Move Outer6: Eject
Please Input Number
7. Skew AdjustmentSelect “1: DVD Single Layer.”
Skew Adjustment
1: DVD Single Layer
5: Return
Please Input Number
There are two methods of making adjustment: a method of making adjustment through monitoring RF waves by the oscilloscope (method 1) and a method of making adjustment through checking the numerical value of the RF level by OSD (method 2).Adjusting procedure is shown below, but regarding how to start the test mode and the operating procedure, please refer to the clause on the service test mode.
Adjusting Procedure:1. Install the pickup(Refer to the removal of the pickup from the mecha unit.) When handling the pickup, refer to the precautions on how to handle the PU listed below.2. Method 1:Connect the oscilloscope according to the AGND3 standards with reference to the connection diagram so that the RF signals can be monitored.Method 2:The device does not need to be set. Proceed to the procedure 3.3. Turn ON the power of the product.4. Start the simplified FE test mode.(Regarding how to start the test mode and the operating procedure, refer to the clause on the service test mode.)5. Load the disc for adjustment (TDV582).6. TEST MODESelect “3: Skew Adjustment.”
8. Adjust the Skew using a driver while checking the RF value.Refer to the following pages concerning the locations to make SKEW adjustment. Method 1: Slightly turn the skew adjusting screw A while checking the RF wave level by the oscilloscope and make adjustment so the wave level would reach its maximum. Next, slightly turn the skew adjusting screw B so the wave level would reach its maximum. Slightly turn the skew adjusting screw A again so the wave level would reach its maximum. (Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw in the clockwise direction.)
Method 2:Slightly turn the skew adjusting screw A while checking the value of the RF level through the OSD display so the wave level would reach its maximum.Next, slightly turn the skew adjusting screw B so the level would reach its maximum. Slightly turn the skew adjusting screw A again so the level would reach its maximum. (Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw in the clockwise direction.)
DVH-3200UB/XNUW578
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Skew Adjustment
1: Power OFF
RF Level : 000000
Please Input Number
Skew Adjustment
1: Power OFF
RF Level : 000000
Please Input Number
TEST MODE
1: LD ON2: ASMAX3: Skew Adjustment4: Error Rate5: CRG Move Outer6: Eject
Please Input Number
TEST MODE
1: LD ON2: ASMAX3: Skew Adjustment4: Error Rate5: CRG Move Outer6: Eject
Please Input Number
Switch arms
9. Skew Adjustment Select “1: Power OFF.”
10. TEST MODE Select “6: Eject.”
11. TEST MODE Select “5: CRG Move Outer.”
12. In order to produce the clamping state with no disc loaded, slightly move the disc detection arm in the counterclockwise direction while moving the switch arms outward.
DVH-3200UB/XNUW5 79
5 6 7 8
5 6 7 8
C
D
F
A
B
E
CRG Move Outer
1: DVD Single Layer2: DVD Dual Layer3: CD4: CD-RW5: Return
Please Input Number
CRG Move Outer
1: Power OFF
Please Input Number
TEST MODE
1: LD ON2: ASMAX3: Skew Adjustment4: Error Rate5: CRG Move Outer6: Eject
Please Input Number
Disc Detection Arm
13. CRG Move Outer Select “1: DVD Single Layer.”
The pickup moves to the outer periphery. Apply the adhesive to fix the skew, the resonance adhesive and the screw lock. Refer to the next page regarding the locations of adhesive joining.
14. CRG Move Outer1: Power OFF
15. TEST MODE Select “6: Eject.”
DVH-3200UB/XNUW580
1 2 3 4
1 2 3 4
C
D
F
A
B
E
A
B
A
B
1
1 2 3
Locations to make SKEW adjustment
Locations to adhere the SKEW 1,2,3: BOND QUICK MENDER
23
DVH-3200UB/XNUW5 81
5 6 7 8
5 6 7 8
C
D
F
A
B
E
adhesive
Bond for resonance 4:Three Bond 1530
4
5
6
4
5 6
Bond for locking the screw 5,6 : Three Bond 1401M
Bond for locking the screw
DVH-3200UB/XNUW582
1 2 3 4
1 2 3 4
C
D
F
A
B
E
Hologram (Beware of the static)Do not touch the optical part
RF level adjusting part
Do not touch the spring
Precautions on handling the PU*Precaution: Do not touch those shaded areas in the following figures.
.
DVH-3200UB/XNUW5 83
5 6 7 8
5 6 7 8
C
D
F
A
B
E
8.2 PCL OUTPUT CONFIRMATION
- PCL outputIn the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby modecancelled), shift the TESTIN IC601(Pin 86) terminal to H.The clock signal is output from the PCL terminal IC601(Pin 37).The frequency of the clock signal is 468 750 Hz that is one 32th of the fundamental frequency.The clock signal should be 468 750 Hz (- 10 Hz, + 15 Hz)If the clock signal out of the range, the X’tal (X601) should be replaced with new one.
DVH-3200UB/XNUW584
1 2 3 4
1 2 3 4
C
D
F
A
B
E
9. EXPLODED VIEWS AND PARTS LIST
9.1 PACKING
NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)
""
(UW5)
(RC, RD, RI ,ID)
DVH-3200UB/XNUW5 85
5 6 7 8
5 6 7 8
C
D
F
A
B
E
PACKING SECTION PARTS LIST
(2) CONTRAST TABLEDVH-3200UB/XNUW5, DVH-3220UB/XNUW5, DVH-3250UB/XNRC, DVH-3250UB/XNRD, DVH-3250UB/XNRI and DVH-3290UB/XNID are constructed the same except for the following:
Owner's Manual, Installation Manual
Mark No. Description Part No.
1 Cord Assy See Contrast table (2)
2 Remote Control Unit CXE1474
3 Polyethylene Bag QEG3001
4 Unit Box See Contrast table (2)
5 Contain Box See Contrast table (2)
6 Protector QHP3006
7 Protector QHP3007
8 Case Assy QXA3129
9 Accessory Assy See Contrast table (2)
10 Screw See Contrast table (2)
11 Polyethylene Bag CEG1160
12 Handle CND3707
13 Screw Assy See Contrast table (2)
14 Screw See Contrast table (2)
* 15 Polyethylene Bag See Contrast table (2)
16-1 Operation Manual See Contrast table (2)
16-2 Operation Manual See Contrast table (2)
16-3 Operation Manual See Contrast table (2)
16-4 Owner's Manual See Contrast table (2)
16-5 Installation Manual See Contrast table (2)
* 16-6 Warranty Card See Contrast table (2)
* 16-7 Service Network See Contrast table (2)
Mark No. Description Part No.
Mark No. DescriptionDVH-3200UB/
XNUW5DVH-3220UB/
XNUW5DVH-3250UB/
XNRCDVH-3250UB/
XNRDDVH-3250UB/
XNRIDVH-3290UB/
XNID1 Cord Assy QDP3017 QDP3017 QDP3011 QDP3011 QDP3011 QDP3011
4 Unit Box QHG3064 QHG3065 QHG3066 QHG3067 QHG3068 QHG30695 Contain Box QHL3064 QHL3065 QHL3066 QHL3067 QHL3068 QHL30699 Accessory Assy YEA5083 YEA5083 YEA5084 YEA5084 YEA5084 YEA508410 Screw BPZ20P060FTC BPZ20P060FTC Not used Not used Not used Not used
13 Screw Assy Not used Not used YEA5082 YEA5082 YEA5082 YEA508214 Screw Not used Not used TRZ50P080FTC TRZ50P080FTC TRZ50P080FTC TRZ50P080FTC
* 15 Polyethylene Bag Not used Not used CEG-127 CEG-127 CEG-127 CEG-12716-1 Operation Manual QRB3064 QRB3064 QRB3066 QRB3066 QRB3066 Not used16-2 Operation Manual QRB3065 QRB3065 QRB3067 QRB3069 QRB3071 Not used
16-3 Operation Manual Not used Not used QRB3068 QRB3070 Not used Not used16-4 Owner's Manual Not used Not used Not used Not used Not used QRB307216-5 Installation Manual QRD3055 QRD3055 QRD3056 QRD3057 QRD3058 Not used
* 16-6 Warranty Card CRY1279 CRY1279 Not used Not used Not used CRY1304* 16-7 Service Network Not used Not used Not used Not used Not used CRY1305
Part No. Language
QRB3064 English
QRB3065 Russian
QRD3055 English, Russian
QRB3066 English
QRB3067 Traditional Chinese
QRB3068 Korean
QRD3056 English, Traditional Chinese, Korean
QRB3069 Spanish(Espanol)
QRB3070 Portuguese(B)
QRD3057 English, Spanish(Espanol), Portuguese(B)
QRB3071 Arabic
QRD3058 English, Arabic
QRB3072 English
DVH-3200UB/XNUW586
1 2 3 4
1 2 3 4
C
D
F
A
B
E
9.2 EXTERIOR (1)
B
(RC, RD, RI, ID)
(UW5)
DVH-3200UB/XNUW5 87
5 6 7 8
5 6 7 8
C
D
F
A
B
E
EXTERIOR (1) SECTION PARTS LIST
(2) CONTRAST TABLEDVH-3200UB/XNUW5, DVH-3220UB/XNUW5, DVH-3250UB/XNRC, DVH-3250UB/XNRD, DVH-3250UB/XNRI and DVH-3290UB/XNID are constructed the same except for the following:
Mark No. Description Part No.
1 Case CNB3542
2 Holder CND3598
3 Cord Assy See Contrast table (2)
> 4 Fuse(10 A) CEK1136
5 Cap CNS1472
6 Resistor RS1/2PMF102J
7 Remote Control Unit CXE1474
8 Cover CZN7062
9 Detachable Assy See Contrast table (2)
10 Screw BPZ20P100FTC
11 Spring CBH2210
12 LCD(LCD1801) CAW1964
13 Spacer CNN2527
14 Holder YNC5083
15 Rubber YNV5191
16 Connector YNV5192
17 Lighting Conductor YNV5193
18 Grille Unit See Contrast table (2)
19 Button(DISP, SRC, UP) YAC5384
20 Button(LEFT, DOWN, BAND) YAC5385
21 Button(1, RIGHT, 4, 5) YAC5386
22 Button(2, 3, 6, LIST) YAC5387
23 Button(EJECT, CLOCK) YAC5388
24 Button(DETACH) YAC5389
25 Cover YNS5536
26 GRIP(USB) YNV5194
27 Knob Unit YXC5123
28 Spring YBL5010
29 Panel YNS5537
Mark No. Description Part No.
Mark No. DescriptionDVH-3200UB/
XNUW5DVH-3220UB/
XNUW5DVH-3250UB/
XNRCDVH-3250UB/
XNRDDVH-3250UB/
XNRIDVH-3290UB/
XNID3 Cord Assy QDP3017 QDP3017 QDP3011 QDP3011 QDP3011 QDP3011
9 Detachable Assy QXA3204 QXA3205 QXA3206 QXA3207 QXA3208 QXA3209 18 Grille Unit QXA3191 QXA3192 QXA3193 QXA3193 QXA3193 QXA3194
DVH-3200UB/XNUW588
1 2 3 4
1 2 3 4
C
D
F
A
B
E
9.3 EXTERIOR (2)
A
601
A
B
B
A
(ID)
DVH-3200UB/XNUW5 89
5 6 7 8
5 6 7 8
C
D
F
A
B
E
EXTERIOR (2) SECTION PARTS LIST
(2) CONTRAST TABLEDVH-3200UB/XNUW5, DVH-3220UB/XNUW5, DVH-3250UB/XNRC, DVH-3250UB/XNRD, DVH-3250UB/XNRI and DVH-3290UB/XNID are constructed the same except for the following:
Mark No. Description Part No.
1 Screw ASZ26P050FTC
2 Screw BMZ25P040FTB
3 Screw BSZ26P060FTC
4 Screw BSZ26P160FTC
5 Cable CDE8742
6 Chassis CNA3099
7 Earth Plate CNC8915
8 Holder CND4748
9 Cushion CNM9126
10 Insulator CNN2593
11 Insulator CNN2764
12 Sheet CNN3039
13 DVD Mechanism Module(LS1) CXK6800
14 Tuner Amp Unit See Contrast table (2)
15 Screw BPZ26P080FTC
16 Screw BSZ26P060FTC
17 Screw BSZ26P160FTC
18 Holder See Contrast table (2)
19 Heat Sink CNR1976
20 FM/AM Tuner Unit See Contrast table (2)
21 Holder CND4324
22 Sheet See Contrast table (2)
23 Button CAC4836
24 Spring(Thin) CBH2961
25 Spring(Thick) CBH2962
26 Arm CNV9312
27 Arm CNW1439
28 Spring YBH5012
29 Cover YNN5030
30 Panel YNS5538
Mark No. Description Part No.
Mark No. DescriptionDVH-3200UB/
XNUW5DVH-3220UB/
XNUW5DVH-3250UB/
XNRCDVH-3250UB/
XNRDDVH-3250UB/
XNRIDVH-3290UB/
XNID14 Tuner Amp Unit QWM3138 QWM3138 QWM3139 QWM3140 QWM3141 QWM314218 Holder CND4760 CND4760 CND4761 CND4762 CND4762 CND476120 FM/AM Tuner Unit CWE2097 CWE2097 CWE2098 CWE2098 CWE2098 CWE209822 Sheet Not used Not used Not used Not used Not used CNN2525
DVH-3200UB/XNUW590
1 2 3 4
1 2 3 4
C
D
F
A
B
E
9.4 DVD MECHANISM MODULE
A
C
D
D
FE
C
B
A
B
E
G
F
G
C
D
(A) : GEM1045
(B) : GEM1038
(C) : GEM1024
(C)
(C)
(A)
(A)
(A)
(A)
(C)
(A)
(A)
(C)
(C)
(C)
(C)
(B)
(C)
(C)
DVH-3200UB/XNUW5 91
5 6 7 8
5 6 7 8
C
D
F
A
B
E
DVD MECHANISM MODULE SECTION PARTS LIST
Mark No. Description Part No.
1 Screw BMZ20P020FTC
2 Screw BSZ20P040FTC
3 Screw(M2 x 4) CBA1835
4 Washer CBF1038
5 Spring CBH2860
6 Spring CBH3010
7 Spring CBH3011
8 Spring CBH3012
9 Spring CBH3013
10 Spring CBH3014
11 Spring CBH3015
12 Spring CBH3016
13 Spring CBH3017
14 Spring CBH3018
15 Spring CBH3019
16 Spring CBH3020
17 Spring CBH3030
18 Plate Spring CBL1797
19 Cable CDE8631
20 Service PU Unit CXX2398
21 Bracket CND4553
22 Arm CND4555
23 Lever CND4556
24 Frame CND4557
25 Frame CND4558
26 Sheet CNN2280
27 Rack CNW1170
28 Guide CNW1171
29 Roller CNW1172
30 Arm CNW1173
31 Arm CNW1174
32 Roller CNW1175
33 Lever CNW1176
34 Arm CNW1177
35 Arm CNW1178
36 Gear CNW1180
37 Gear CNW1181
38 Gear CNW1182
39 Gear CNW1183
40 Rack CNW1184
41 Gear CNW1185
42 Gear CNW1186
43 Gear CNW1187
44 Gear CNW1188
45 Clamper CNW1190
46 Arm CNW1191
47 Arm CNW1192
48 Holder CNW1193
49 Holder CNW1194
50 Holder CNW1195
51 Damper CNW1197
52 Damper CNW1198
* 53 Connect PCB Unit CWX3618
54 Connector(CN701) CKS6003
55 Connector(CN101) CKS6063
56 Motor(M2)(SPINDLE) EXM1050
57 Screw Unit CXC8894
58 Chassis Unit CXC8895
59 Arm Assy CXC8896
60 Washer CBF1037
61 Washer CBF1038
62 Arm CND4554
63 Collar CNV6906
64 Roller CNW1196
65 Gear Unit CXC8893
66 Screw(M2 x 5) EBA1028
67 Motor Unit(M1)(LOAD/CRG) CXC4026
68 Screw JFZ20P025FTC
69 Screw JGZ17P022FTC
70 Washer YE15FTC
71 Screw IMS20P030FTC
72 DVD Core Unit YWX5007
73 Connector(CN1101) CKS5775
74 Connector(CN1201) CKS6003
75 Connector(CN1901) CKS6025
Mark No. Description Part No.
DVH-3200UB/XNUW592
1 2 3 4
1 2 3 4
C
D
F
A
B
E
(A) : GEM1045
(B) : GEM1038
(C) : GEM1024
(A)
(C)
(C)
(A)
(A)(C)
(C)(C)
(C)
(C)
(A)
(A)
DVH-3200UB/XNUW5 93
5 6 7 8
5 6 7 8
C
D
F
A
B
E
DVH-3200UB/XNUW594
1 2 3 4
1 2 3 4
C
D
F
A
B
E
10. SCHEMATIC DIAGRAM10.1 TUNER AMP UNIT (GUIDE PAGE)
A
A-aA-a A-b
A-a A-b
A-bA-a
Large sizeSCH diagram
Guide page
Detailed page
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".
VD8
RCK
HSLK
SL
CE2
CE1
TUNPCK
TUNPDO
LDET
TUNPDI
RDT
IPPW
IP_2_SYS
SYS_2_IP
ASENBO
RDSLK
AMUTELS_2_SYS
SYS_2_LSSTANDBY
XRST
IRQPW
LSL
LSR
LSV
VDCONT5
IPL-
IPL+
IPR-
IPR+
DPDT
SW
VD
D
SYSMUTEB
SE
NS
CE
1
AS
EN
S
LS_2_SYS
SYS_2_IP
ASENBO
CE
2
IPPW
ACCPW
TU
NP
DI
AMUTE
TU
NP
CK
AMPPW
STANDBY
ILM
CLR
2
ILM
CLR
1
RO
T0
ILM
PW
FLP
IL
RWCLK
RWBUSY
SYSPW
AN
TP
W
VS
T
VC
K
VD
T
V5C
ON
T
SYS_2_LS
VDCONT8
RW
CN
VS
S
RWBUSY
RWCLK
ACCPW
RWCNVSS
DPDT
RE
SE
T
RESET
ILM
CLR
1
ILM
CLR
2
KY
DT
DS
EN
S
RO
T1
D+D-
AU
XV
G
AUXL
AUXR
VD
CO
NT
5
DS
EN
S
VD
CO
NT
8
VD
CO
NT
5
TUNL
TUNR
KYDT
AU
XL
LSV
AUXG
VCRL
VCRG
VCRR
LDE
T
KYDT
SY
NC
IEC
AUXV
AUXVG
D+
D-
SY
NC
US
BC
TL
FLG
VD
CO
NT
5
DP
DT
IRQPW
RO
T0
AU
XV
RO
T1
AU
XR
AU
XG
TELIN
XRST
IP_2_SYS
AV
SC
L
AV
SD
A
VM
UT
E
RC
K
EJE
CT
47u/
16
C52
147
u/16
C53
1
22u/
16C
534
22u/
16C
523
100u
/16
C47
2
CC
H14
86-A
C11
95
C45
20.
01u/
25
C10
4
4.7u
/6.3
C64
1
NM
C60
4N
M
C47
3
33p/
50
C457
NM
C47
1
0.01
u/25
C131
0.1u/16
C15
1
0.1u
/16
C15
2
1000
p/50
C15
3
1000
p/50
C12
2
0.1u
/16
C11
01
1u/6
.3
C54
6N
M
C54
5N
M
C527 NM
C544 NM
C11
12
0.22
u/6.
3
C45
1
4.7u
/10
C53
2
0.1u
/16
C528 NM
C11
11
0.22
u/6.
3
C529 NM
C52
4
0.1u
/16
C51
0N
M
C530 NM
C50
51u
/10
C50
41u
/10
C51
1N
M
C45
4
1000
p/50
C52
2
0.1u
/16
C543 NM
C52
51u
/10
C1144 CCG1223-A
C11
92N
M
C11
51N
M
C11
31
10u/
35C
CG
1236
-A-T
C11
96
CC
G12
23-A
C11
52N
M
C11
94N
M
C11
62
NM
C11
93N
M
C1143 CCG1223-A
C11
86
NM
C52
61u
/10
C11
53N
M
C47
4
NM
C11
1
0.1u
/16
C10
2
0.1u
/10
C43
3
NM
C10
1
0.1u
/16
C45
5
NM
C53
30.
1u/1
6
D11
51N
M
D11
91
NM
D1141
RB551V-30
D1193RSX201L-30
D1192RSX201L-30
D52
1
S1G
-690
4G2P
D52
2
S1G
-690
4G2P
D1142
RB551V-30
D111NM
AGND
DGND
RFGND
LSDGND
ILMGND
USGND
AGND
USGND
AGND
US
GN
D
RFGND
DGND
DGND
ILMGND
RFGND
DGND
AGND
LSDGND
DGND
DGND
DGND
RFGND
GNDDDC
GNDDDC
DGND
GNDDDC
GNDDDC
GNDDDC
RFGND
IC1111
S-1200B33-M5
VIN1
VSS2
ON/OFF3
NC4
5VOUT
NMIC641
CS1
SK2
DI3
DO45
GND
6TEST
7NC
8VCC
HA12241FP
IC151
DIN11
ROUT2
DIN23
GND45
BUS-
6BUS+
7VCC
8STBY
IC122TC7MBL6126SFK
1OE1
A12
A23
A34
5 A46 4OE7 GND 8
3OE
9B4
10B3
11B2
12B1
132OE
14VCC
IC111TC74VHCT08AFTS1
1A1
1B2
1Y3
2A4
5 2B6 2Y7 GND 8
3Y
93A
103B
114Y
124A
134B
14VCC
IC112TC74VHC08FTS1
1A1
1B2
1Y3
2A4
5 2B6 2Y7 GND 8
3Y
93A
103B
114Y
124A
134B
14VCC
BD9013KV
IC1103
OU
TH
21
BO
OT
22
CL2
3N
.C.1
4V
CC
CL2
5N
.C.2
6V
CC
7V
CC
CL1
8N
.C.3
9C
L110
BO
OT
1
11O
UT
H1
12
SW1
13
DGND1
14
OUTL115
N.C.416
VREG5A17
N.C.518
N.C.619
N.C.720
FB121
COMP122
SS123N.C.8
24
N.C
.9
25
EN
1
26
EN
227
N.C
.10
28
N.C
.11
29
GN
D30
N.C
.12
31
N.C
.13
32
RT
33
SY
NC
34
N.C
.14
35N
.C.1
536
SS237
COMP2 38FB2
39N.C.16
40EXTVCC
41N.C.17
42N.C.18
43VREG5
44N.C.19
45OUTL2
46DGND2
47SW2
48 VCC1
1
BIAS1
2
GND13
L1-14
L1-25
R1-16
R1-27
L2-18
L2-29
VCC210
BIAS211GND2
12
R2-
1
13
R2-
2
14
L3-1
15 1645
V5-
246
V6-
1
47V
6-2
48
JA131CKS5271-A
1
2
3
4
5
6
7
8
9
10
11
L1108CTH1253-A
L452
10u
L641 NM
L1192CTH1253-AL1153
CTH1253-A
L451
2.2u
L1131NM
CTH1358-A-T
L472
22u
L1121
NM
CTH1358-A-T
L471
1u
L151CTF1473-A
LTC124EUB
Q132
UMD3NQ111
1
2
34
5
6
UM
H1N
Q40
1123
4 5 6
UM
H1N
Q40
2123
4 5 6
LSA1576UBQ131
R104 220
R52
210
0
R103 470
R105 220
R101 470
R1090
R106 470
R402
22k
R457 680
R403
22k
R108
470
R107
470
R122 0
R151
4.7k
R102 1k
R121 0
R123 0
R502 100
R503
NM
R454 680
R52
310
0
R501 100
R112
0
R11
01
100k
R455 680
R139
100
R13
7
15
R13
8
47
R141
2.2k
R14
2
22k
R143
4.7k
R62
1N
M
R152
1k
R11
3
1k
R452 680
R124
100k
R623 220
R12
510
0k
R11
720
R11
81
30k
R11
85
NM
R72
00
R131
180
R135
1k
R13
3
22k
R11
71 0
R453 680
R11
63 NM
R401
22k
R132
180
R13
4
22k
R140 1k
R64
2
NM
R608
100k
R404 22k
R60
5
47k
R63
210
0k
R643
NM
R625 NM
R630 1k
R451 680
R61
110
0k
R629 1k
R62
24.
7k
R65
468
0
R71
70
R63
347
k
R65
547
0
R71
60
R624 220
R607100k
R471 680
R136
100
R65
21k
R65
31k
R60
4 0
R626 1k
R63
447
k
R628 NM
R71
12.
2k
R71
42.
2k
R71
52.
2k
R71
82.
2k
R71
92.
2k
R60
9
100k
R71
32.
2k
R71
22.
2k
TUN5V2
VM
UT
E
ABO
BS+
TUN3V
PCL
GND
TSCK
RO
T0
ROMDATA
DGND
ROMLK
ROMCS
D+
CO
LOU
R1
D-
ILM
GN
D
CO
LOU
R2
DP
DT
2
SW
DV
DD
US
GN
D
ILM
+B
IPR-
RO
T1
IPR+
AU
XV
AU
XL
IRQPWR
AU
XG
ND
DS
EN
S
TUNR
US
B5V
KY
DT
2
STANBY
StoMS
AMUTE
FLG
DPDT1
RWCNVSS
ACCPW
KYDT1
PWCLK
RWBUSY
ACC3
USBCTL
BS-
XRES
LSL
LSV
IPL-
IPL+
LSR
MStoS
RFGND
VCC
MANT
ACC5V
TUNL
VD8_1 VD8_2
OUTH2
OUTH1
BU3
LSVD8
VD8
US
B5V
BUP
SYS+B
SYS+B
USB5VTU3.3
ILM+B
BUP
VD5
VD5
USB5VVDD
VD5VD3
VD5
VDD
SYS+B
VDD3
SYS+B
VD3
VD3
VDD
VD5
VDD
SWVDD
U40
1
1AM_ANT
2RF_GND
3FM_ANT
4VCC
5SL
6CE2
7WC
8CE1
9CK
10DI
11LDET
12OSCGND
13ROM_VDD
14DO
15DGND
16COMP
17VDD_3.3
18RDS_CK
19RDS_DATA
20RDS_LOCK
21RDS_HSLK
22BEGND
23Lch
24Rch
P47
1
IMS
A-6
802-
01Y
900
R111
0
C71
1N
M
AU
XR
R60
6
100k
DGND
RC
K
R11
84
82k
R11
83 0
R11
82
9.1k
R11
66
10k
CKS3844-ACN101
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
C431
NM
R437
0
R436
0
R43
5
NM
R43
4
NM
R43
3
NM
Q43
1N
M
R43
2
NM
R43
1
NM
Q43
0N
M
R43
0
NM
C432NM
RFGND
DGND
GNDDDC
R521 22k
R524 22k
VIGND
C606 C605
C12
10.
1u/1
0
C11
64
0.04
7u/1
6
C11
82
0.04
7u/1
6
R641 47k
C11
20.
1u/1
6
R72
50
R72
20
R72
322
k
R72
10
47u/
6.3
C45
3
47u/
6.3
C45
6
VGND
C1146 NM
C1147 NM
VD8
VDD5
D-2
D+2
SCK
SDA
CPRST
C65
2N
M
C65
1
NM
R651
NM
LSDGND
HA
T22
10R
JQ
1191
1 2 3 45678
HA
T22
10R
JQ
1151
12345 6 7 8
RFGND
RFGND
RFGND
VA703 EZJZ1V270RM
VA704 EZJZ1V270RM
R63
510
0k
IC601
12345B
YT
E6
CN
VS
S789
RE
SE
T10
XO
UT
11V
SS
112
XIN
13V
DD
114
NM
I1516171819202122232425
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75
V
A
R63
610
0k
NM
C43
4
R11
64
47k
R11
65
6.8k
C705 220p/50
C704 220p/50
C703 220p/50
C702 220p/50
C701 220p/50
R631 100k
R62
710
0k
VIGND
AGNDN
M
CN601
1
2
3
4
5
6
7
8
9
10
R63
710
0k
C11
971.
0u/3
5
C11
981.
0u/3
5
C1142 1.0u/35
C1184
1.0u/35
C11
220.
1u/1
0
C11
320.
1u/1
0
C11
021u
/6.3
R61
047
0
R11
74
470
C607100p/50
C11
99 NM
GNDDDC
RFGNDAGND
R1162
0 R11870
T0T1
CN701
1234567891011121314151617181920
L602 NM
C4751000p/50
C11
21
10u/
35C
CG
1236
-A-T
L101
CTF1389-A
RFGND
GNDDDC
R51075
L1152CTF1661-A
L115
1
CT
F16
61-A
L1141
CTF1661-A
L1191CTF1661-A
330u
/16
C11
91
330u
/16
C11
54
R116
NM
R114 NM
R115
NMDGND
X601CSS1774-A
R1188
2.2
R1161
2.2
JA471CKX1070-A 1
23
R60
3
4.7k
R11
67
22k
C11
63
220p
/50
C11
83
220p
/50
D701 DZ2S068C-T
D702 DZ2S068C-T
L121
NM
12
3 4
R126
0
R127
0
C107
NM
C10
6
4.7u
/10
IC121341S2162
NC1 1MODE1/SPI_nSS
2NC2
3nRESET
4
VCC
5NC
36
NC
47
NC
58
NC
69
NC
710
VSS11
I2C_SCL/SPI_SIMO12 I2C_SDA/SPI_SOMI
13 MODE0/SPI_CLK
14
NC8
15
NC
916
NC
1017
NC
1118
NC
12
19N
C13
20
C1161
P1131
CEK1286-A
R65
710
kR
656
10k
R68
539
k
R68
639
k
C1185
D715 DZ2S068C-T
D713 DZ2S068C-T
VDD1
R128
390
C71
2
NM
IC1101R5523N001B
EN1
GND2
FLG3
VIN4
5VOUT
R11
11N
M
R11
120
C12
30.
1u/1
0
P1191CEK1344-A1 2
P1121
CEK1286-A
R11
7382
k
C11
81
0.01
u/25
C11
65
0.01
u/25
C10
5
NM
R12
910
k
R1142
10
R1141 10
R1189
10k
R1190
10k
R1191
1k
C11450.033u/25
C11410.033u/25
C58
11u
/6.3
D712 DZ2S068C-T
D714 DZ2S068C-T
R72
422
k
R74
210
0k
VDD
Q112
1
2
3 4
5
6
FM
/AM
TU
NE
R U
NIT
X-2
026
FM/AM TUNER UNIT401 500
131 160
IP-BUS
DS
EN
S
AU
XL
701 750
KEYBOARD UNIT
SW
DV
DD
ILM
GN
D
DG
ND
Ver2.0B
AGND
AMUTE
XRES
S MS5TX
VD
VGND
SCK
AGND
DGND
VD
VDD5
ROUT
LOUT
DGND
DGND
IRQPWR
D+
COMPOSIT
8.0V
VD
PGND
PGND
D-
IECOUT
STANBY
AGND
MS5 SRX
CPRST
DGND
SDA
5.1V
DGND
101 130
LS1
5.1V
(D)
(D)
8.01V
(D)
(1/8W)
(1/8W)
(1/8W)
(D)
(F)
8.0V
(15uH)
MS VAUX V
AUX VGND
NC
NC
ILM
PW
SY
NC
VD
T
15.0MHz
IRQPW
NC
VC
K
AN
TP
W
CSEN
MOD
DS
EN
S
PCL
RC
K
LDE
T
NC
N
FLP
ILM
STANDBY
VD
D
NC
601 700
RO
T0
TSCK
V5C
ON
T
RO
MC
K
NC
MOD
RX
KEY
RWCLK
VD
CO
NT
5
TX
SYS u-COM
RDS-HS
VM
UT
E
VDCONT8
CE
2
NC
TUN
AV
SD
A
IPPW
DPDT
RX
2
USBF
USBC
CE
1
ILM
CLR
1
RDS-LOMOD
TXLS1
AV
RWEMP
NC
TEST
RWBUSY
TU
NP
CK
TU
NP
DI
NC
VS
S
KYDT
TELIN
RWCE
XRESET
NC
ACCPWRDS-DA
EJ
KE
MUTE
AV
SC
L
N
RO
MC
S
RXLS1
BS
EN
S
VS
T
AMPPW
AMUTE
MODEL
ASENBO
ILM
CLR
2
RO
MD
AT
A
AS
EN
S
NC
SYSPW
ROM CORRECTION
AV SELECTOR501 600
1101 1200DD CON
RO
T1
AU
XG
ND
RO
T0
CO
LOU
R2
CO
LOU
R1
AU
XR
AU
XV
ILM
+B
US
GN
D
D+
US
GN
D
D-
DP
DT
US
B5V
KY
DT
(15uH)
5.2VRaychem 4A
101~131~161~201~231~251~281~311~331~351~401~501~601~701~751~801~
1001~1
1101~1
NM
&KM386D/UW5
&KM386/RC
&KM386/RD
&KM386/RI
NM
NM
SW
VD
D
RDS A,B
&KM386/UW5
*A,B
*A,B
NM
NM
3.0A
NM
CWE2097-CWE2098-
A,B:C~F:
&KM386/ID
C605 C60618p/5020p/50A,B
C~F 20p/50 20p/50
PEG525A
PEG524A8 CWW1539-
SOFTWARE UNITFLASH
MASK
A,B
C~F-
NM
(330
0uF
)
3.3u/10 3.3u/10
3.0A
CKS6050-
A
B
C
D
E
DVH-3200UB/XNUW5
DVH-3220UB/XNUW5
DVH-3250UB/XNRC
DVH-3250UB/XNRD
DVH-3250UB/XNRI
DVH-3290UB/XNID
R
F
*only G
RT3N66M-T
(1/8W)
R671 R672 R673 R674 R675 R676
RD
RI
UW5
RC 47k 47k 47k47k 47k 47k
47k 47k 47k47k 47kID 47k
D
E
BA
C
UW5
FNM
>
>
>
TUNER(30%):-24.0 dBmTUNER(30%)(UW):-20.0 dBm
B CN1821
CCN1901
DVD/USB:+5.1 dBm
DVH-3200UB/XNUW5 95
5 6 7 8
5 6 7 8
C
D
F
A
B
E
A
A-b
VIDEO5
FR+
FR-
FL-
RR-
RL+
TELIN
RL-
FL-
FL+
FR+
RR+
FL+
FR-
ANTPW
AMPPW
IEC
ILMPW
ACCPWACCPW
SWVDD
V5CONT
AV
SD
A
AV
SC
L
NA
VIR
NA
VIL
SYSMUTE
KEYAD
AUXG
AUXL
LSL
TUNL
TUNR
LSR
AUXR
AUXG
VC
K
VD
T
HSLK
RDT
SW
VD
D
CE
1
TUNPDO
RDSLK
CE
2
TU
NP
DI
TU
NP
CK
ILM
CLR
2
ILM
CLR
1
RO
T0
ILM
PW
FLP
IL
SYSPW
FLPIL
VMUTE
RE
SE
T
RW
CN
VS
S
RE
SE
T
NAVIR
RO
T1
RR+
RR-
RL+
RL-
KEYAD
KEYD
AV
SIV
CR
LA
VS
IVC
RR
IPL+
IPR+
KEYD
AVSIVCRR
AVSIVCRL
IPR-
IPL-
VCRR
AV
SIV
CR
R
AV
SIV
CR
L
VC
RL
LDE
T
FLG
USBCTL
AMPPW
LSV
VC
RG
VC
RR
VS
T
VCRL
AV
SC
L
AV
SD
A
VM
UT
E
RC
K
SL
EJECT
VCRG
ASENS
BSENS
NAVIL
NMCN1001 12
CN821CKM1370-A
1
2
3
4
5
6
7
8
9
10
11
12
14
15
16
13
100u
/16
C10
23
C53
33u/
10C
184
100u/6.3C572
33u/
10
C26
1
NM
C16
1
NM
C10
72
330u/6.3C182
NM
C281
2.2u/50
C284
2.2u/50
C283
NM
C282
47u/16
C222
100u
/10
C10
14
CC
H14
86-A
C26
2
22u/10C181
100u
/16
C10
52
NM
C35
1
47u/6.3
C174
C37
2N
M
C371
NMC354
NM
C35
2
NM
C35
3N
M
NM
C60
1
C60
31u
/10
C60
4N
M
C60
2
0.01
u/25
C213 1u/10
C211 0.22u/16
C206 1u/10
C208 0.22u/16
C223
0.1u/16
C28
7
1000
p/50
C28
5
NM
C28
6
NM
C28
8
1000
p/50
C55
0N
M
C50
9N
M
C54
6N
M
C772
0.1u/16
C77
3
NM
C50
3N
M
C553
NM
C77
1
2.2u
/16
C10
02
0.22
u/6.
3
C50
8N
M
C54
5N
M
C527 NM
C580
NM
C544 NMC
1001
0.22
u/6.
3
C50
11u
/10
C54
7N
M
C18
3
0.1u
/16
C50
6N
M
C171
NM
C172
NM
C54
8N
M
C50
2N
M
C528 NM
C21
5
1u/1
0
C201 1u/10
C529 NM0.1u
/16
C16
2
NM
C54
9N
M
C51
0N
M
C202
1u/10
C50
7N
M
C530 NM
C50
51u
/10
CCG1182-A
C271
C26
3
0.1u
/16
C20
4
1u/1
0
C273
4.7u/16
C50
41u
/10
C2724.7u/16
C212 1u/10
C217 1u/10
C51
1N
M
C574 NM
C543 NM
C52
51u
/10
C573 NM
C255 0.47u/10
C256 0.47u/10
C251 0.47u/10
C252 0.47u/10
C32
1
NM
C52
61u
/10
C10
1310
u/10
C10
22
0.01
u/25
C10
112.
2u/1
0
C10
12N
M
C54
21u
/10
C10
31N
M
C576 NM
C575 NM
C10
71N
M
C33
1
0.1u
/16
C10
42
1000
p/50
C10
73N
M
C33
2
0.1u
/16
C10
510.
01u/
25
C10
53
0.01
u/25
D1011NM
D66
1
NM
D1012
NM
D8021SR154-400
D52
1
S1G
-690
4G2P
D52
2
S1G
-690
4G2P
D7711SR154-400
D82
1
1SR
154-
400
D1052
1SR154-400
D77
21S
R15
4-40
0
D1013NM
D82
21S
R15
4-40
0
D80
1
1SR
154-
400
D781
MC2848-11
D751
D10
71
NM
D752
VGND
ILMGND
AGND
VIGND
AGND
AGND
VGND
VGND
DGND
VGND
AGND
AGND
ILMGND
VGND
VGNDVIGNDVIGND
ILMGND
VGND
VIGND
AGND
AGND
AGND
AGND
DGND
AGND
GND
GND GND
GND
AGND
DGND
GND
DGND
GND
DGND
DGND
GND
GND
DGND
GND
GND
GND
NJM2885DL1-33IC1011
1IN
2G
ND
3O
UT
IC66
1
BD
4835
G
OU
T1
VD
D2
VS
S3
45
IC311
TC7SET08FUS1
INB1
INA2
GND3
OUTY4
5Vcc
IC1001
S-1200B33-M5
VIN1
VSS2
ON/OFF3
NC4
5VOUT
IC18
1
TK
1540
5BM
I
ST
BY
1O
UT
2S
AG
3IN
4 5G
ND
6V
CC
NMIC371
A_OUT1
A-IN2
A+IN3
V-45
B+IN
6B-IN
7B_OUT
8V+
IC77
1T
PD
1018
F
1O
UT
2G
ND
1
3G
ND
2
4G
ND
3
5V
DD
6IN
7G
ND
48
GN
D5
9G
ND
610
DIA
G
IC20
1
IN1_
L1
IN2_
L2
IN3_
L3
IN4+
_L4 5
IN4-
_L6
Fro
nt_L
7R
ear_
L8
Vcc
9V
ref
10G
ND
11D
AT
A
12C
LK
13S
TB
14R
ear_
R
15F
ront
_R
16IN
4-_R
17IN
4+_R
18IN
3_R
19IN
2_R
20IN
1_R
AN15887A
IC501
VCC1
1
BIAS1
2
GND13
L1-14
L1-25
R1-16
R1-27
L2-18
L2-29
VCC210
BIAS211GND2
12
R2-
1
13
R2-
2
14
L3-1
15
L3-2
16
R3-
117
R3-
218
L4-1
19
L4-2
20
R4-
121
R4-
222
L5-1
23L5
-224
R5-125
R5-2 26ROUT1
27LOUT1
28ROUT2
29LOUT2
30FB2
31VOUT2
32FB1
33VOUT1
34SDA
35SCL
36
V1-
137
V1-
238
V2-
139
V2-
240
V3-
141
V3-
242
V4-
143
V4-
244
V5-
145
V5-
246
V6-
1
47V
6-2
48
NJM
2388
F84
IC10
21
1V
IN
2V
OU
T
3G
ND
4C
ON
TR
OL
JA321CKS4124-A
231
JA33
1
CK
S41
24-A
2 3 1
L221
2.2u
L161
NM
L321
CTF1389-A
L351NM
L182
CT
F13
83-A
L781
CTF1379-A
L601 10u
L181
10u
L821
CTH1280
L371NM
min
iSM
DC
075F
/24
P29
11
2
LTC
114E
UB
Q10
62
NMQ1032
NMQ
1072
DTC323TUQ292
NM
Q10741
2
3 4
5
6
RT3T22M
Q1052
1
2
3 4
5
6
RT3T22MQ261
1
2
34
5
6
RT3T22M
Q2911
2
34
5
6
Q10512SD1858(QR)
Q1073 NM
NM
Q16
1
2SA1579(R)Q321
LSA1576UBQ781
Q16
2N
M
R22
11k
2 14 365 87
R571 220
R355
NM
R771
10k
R37
6
NM
R52
210
0
R375
NM
R504
NM
R508 NM
R16
2
NM
R356
NM
R374 NM
R172
NM
R171
NM
R373
NM
R185
68k
R542 NM
R18
1
47k
R360
NM
R16
6
NM
R16
1
NM
R26
2
10k
R57
310
0
R75
2
47k
R223
0
R541 NM
R251 1k
R206
0
R371
NM
R507 NMR
545
100
R16
7
NM
R751
100k
R572 220
R358
NM
R10
42
10k
R10
73
NM
R18
433
k
R502 100
R503
NM
R1071
NM
R10
62
4.7k
R357
NM
R35
9
NM
R782
15k
R52
310
0
R354
NM
R164
NM
R501 100
R57
410
0
R753
10k
R35
3
NM
R35
1
NM
R352
NMR
1052
2.2k
R10
51
22k
R17
40
R263
220
R781
4.7k
R75
5
4.7k
R75
4
47k
R10
31N
M
R10
32
NM
R10
43
22k
R10
75 NM
R1063
10k
R292 NM
R293 NM
R282
NM
R10
41
2.2k
R281
NM
R28
5
NM
R28
7
22k
R28
6
NM
R10
22
47k
R284
820
R311
0
R31
3
47k
R28
8
22k
R283
820
R304 NM
R303
R26
1
10k
R506
NM
R315
120
R301 NM
R302 NM
R294 NM
R296 NM
R297 NM
R299 NM
R300 NM
R1021
1k
R10
55
39
R10
53
39
R32
2
100k
R32
3
10k
R312
620
R321
NM
R314
0
R54
310
0
R10
56
39
R33
21k
R33
11k
R10
74
NM
R202 0
R212 0
R211 0
R10
54 39
R601
100k
R680 47k
R677680
R683
100k
R671 R672
R10
72
NM
R679 470
R65
468
0R
655
470
R1061
1
R65
21k
R675 R676
R16
3
NM
R65
31k
R682 10k
R673 R674
R681 100k
R678680
R60
4 0
R602
100k
R37
2
NM
ILM+
TESTIN
VM
UT
E
TP601
TEST2
VDD5V
FA
NG
DGND3
VDD1
VDD2
FA
NB
SWVDD1V5
VDD3
VIN
RESET
VOUT
VGNDIN
VGNDOUT
FR+
TELM
ACC
RL-
BSEN2
RL+
SYSB
FR-
BSEN1
AANT
FL+
ASEN
RR+
BREM
OPT2
GN
D1
BU2
GN
D2
BU1
FL-
KE
YA
D
KEYD
OPTG
RR-
OPT1
MUT
OPT3
BUP
BUP
BUP
SYS+B
ILM+B
SYS+B
TU3.3
SYS+B
VD5
FLPILM
VDD3
VDD
SYS+B
SWVDD
VDD
SYS+B
NM
VR
161
13
2
C55
11u
/10
C57
81u
/10
C55
21u
/10
GND
RC
K
C57
71u
/10
L1041
NM
C10
41
NM
C29
2
NM
CN291
NM
1
2
3
4
C54
11u
/10
R54
410
0
R23
9
10k
C231
2.2u/16
10u/
16
C23
4
R234
22k
NJM4558MDIC231
OUT11
IN-12
IN+13
GND45
IN+2
6IN-2
7OUT2
8VCC R236
22k
SYS+B
R237
22k
C232 2.2u/16
R235
22k
R24322k
C2412.2u/16
C2422.2u/16
SYS+B
NJM4558MDIC241
OUT11
IN-12
IN+13
GND45
IN+2
6IN-2
7OUT2
8VCC
R242
22k
R241
22k
VGND
C29
3
NM
min
iSM
DC
075F
/24
P29
21
2
C254 0.47u/16
C258 0.47u/16
C257 0.47u/16
C253 0.47u/16
C243
100p/50C233
100p/50
R245
22k
1000
u/16
C10
54
NMQ1031
LSA1576UBQ1041
2SA1576A(RS)Q1061
NMQ1071
C164
NM
C606 C605
C31
3
0.1u
/10
C274
0.047u/16
NMIC351
OUT11
IN-12
IN+13
GND45
IN+2
6IN-2
7OUT2
8VCC
C311
15p/50
R165
NM
C163
NM
R201 0
220u/6.3C571
100u
/10
C10
21
AGND
C51
21u
/10
R50
90
R50
50
R54
610
0
TP291
TP292
TP293
TP294TP295
TP296
TP297
TP298
TP299
TP300
C673 NM
C672 NM
C671 NM
C65
2N
M
VDD1
VDD1
VA
292
NM
VA
291
NM
VA
321
EZ
JZ1V
270R
M
RFGND
RFGND
GND
GND
RFGND RFGND
GND
GND
C601
12345B
YT
E6
CN
VS
S789
RE
SE
T10
XO
UT
11V
SS
112
XIN
13V
DD
163 64 65 66 67 68 69 70 71 72 73 74 75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95VREF
96AVCC
97
98
99
100
R684 100k
IC171
NM
Vout1
GND2
V+3
Vin4
5VGND
NM
C10
32
10u/16
C221
VGND
C801
0.1u/16
C10
61
0.1u
/16
C10
62
0.1u
/16
C75
1
0.1u
/16
C29
1N
M
C661
0.1u/10
R66
1
470k
R23
3
12kR
244
12k
R23
8
12k
R295
R298
R22
5
R22
7
R22
4
R22
6
VD5
R18
2R
183
IC271PA2030A
1
2
3
4
5
6
7
8
9
10
11
12
15
16
17
18
19
20
21
22
23
24
25
13
14
C78
1
0.1u
/16
RFGND GND
R51075
VD5
VD5
C16
5N
M
JA282
1
2
3
4
5
6
7
8
9
X601CSS1774-A
R60
3
4.7k
D1021
1SR154-400
R10
6410
0k
C374
NM
C373NM
VA
322
EZ
JZ1V
800A
M
R240
5.6k
R246
5.6k
C31
2
10u/
6.3
D753
NM
R75
6
NM
R757
NM
Q752NM
GND
BSEN3
D10
51U
DZ
S5R
6(B
)
R175
0
R173
0
R291
1k
R65
710
kR
656
10k
R68
539
k
R68
639
k
C224
1000p/50
C225
1000p/50C
275
10p/
50
C17
3
1000
p/16
C58
11u
/6.3
NM
Q28
11 2 3
456Q
282
1 2 3456
RT
3CLL
M(E
F)
Q75
11 2 3
456
B.U
AANT
ASENS&BSENS
251 280AMP
751 800
CONNECTOR
(330
0uF
)
GND
FL+
(104
)
RR-
TELM
5.FL+
POWER
RL+
801 1000
FR+
TELM
FL-
RL-
SENS
3.FL-
1.TAB
RR+
ACCBREM
FR-
VGND
MUTE
OPT-OUT330
OPT
OPT
311
(BLACK)
8.4V
VDD 5VREG
POWER SUPPLY
0.75A
SYS+B1001 1100
8.4V
TUNER 3V
1A
ILM+B
(321
6 1/
4W)
SWDVDDVIDEO5V
(3216 1/4W)
VCR VGND
MS V
VIDEO OUT ISO +0dB
6dB
75 DRIVER +6dBAMP
AUX V
VCR VAUX VGND
AV
SO
UT
L
AV
SO
UT
R
VGND(OUT)
VIDEO OUT
VIDEO IN
VGND(IN)
VoG
RC
VCRG
FL
FR
RL
RR
VCRR
VCRL
NA
VIG
R
NA
VIG
L
RR
FR
201 230
E-VOL MAESTRO2
REMOTE
* A,B
331 350
WIRED
INPUT
FL
RL
NC
ILM
PW
15.0MHz
NC
NC
CSENS
MODEL2
RC
K
LDE
T
NC
FLP
ILM
700
RO
T0
MODEL1
KEYAD
u-COM
RDS-HSLK
VM
UT
E
CE
2
TUNPDO
AV
SD
A
SL
USBFLG
USBCTL
CE
1
ILM
CLR
1
RDS-LOCKMODEL0
NC
AVss
NC
NC
TESTIN
TU
NP
CK
TU
NP
DI
NC
NC
RDS-DATA
EJECT
RO
T1
KEYD
AV
SC
L
NC
EL
ILM
CLR
2
RESET
NAVI MIXING351 400
OR
161 200
VIDEO OUT
VCR IN231 250
RCA281 310
101~130 LS1131~160 IP-BUS161~200 VIDEO OUT201~230 E-VOL MAESTRO2231~250 VCR IN251~280 AMP281~310 RCA311~330 OPT331~350 WIRED REMOTE INPUT351~400 NAVI MIXING401~500 FM/AM TUNER UNIT501~600 AV SELECTOR601~700 SYS u-COM 701~750 KEYBOARD UNIT751~800 SENS A.ANT TELM801~1000 POWER CONNECTOR
1001~1100 POWER SUPPLY
1101~1200 DD CON
*C,F
FLPILM
AANT
FAN
SW
VD
D
TUNL TUNRLSL LSR
AVSIVCRL AVSIVCRRIPL+ IPR+IPL- IPR-AUXLAUXG
AUXRAUXG
to IN1
A,B,DE C,F
NC
to IN2to IN3
to IN4+to IN4-
NM
*NM
*A,B,G
*A,B
NM
100
A,B,D
R295R298R303
C,F
10kNM10kNM
0NM
7.FR-
9.FR+
8.PW.GND1
20.VCC3/4
11.FRIN
12.FLIN
21.RL+
15.RRIN
23.RL-
25.B.REMOTE
24.PW.GND4
4.STBY
18.PW.GND3
14.RLIN
10.SVR
6.VCC1/2
16.ACGND
2.PW.GND2
22.MUTE
17.RR+
13.S-GND
19.RR-
NM
05 C60618p/5050
50 20p/50
Vo Vo
- -
RL RL
-
RR RR
-
VoG
AoG AoG
-
1 2
CKB1093-ACKB1095-A
12
*1
*1E
NM
NM
CWW1539-
OFTWARE UNIT
A,B
C~F-
NM
3933
NM
NM
NM
REFERENCE AREA MAP
NM
NM
HZU7R5(B3)
HZU6R8(B2)
NM
RT
3N66
M-T
*1
*1
PM
L014
*
R671 R672 R673 R674 R675 R676
D
W5
C 47k 47k 47k47k 47k 47k
47k 47k 47k47k 47k47k
W5
100
100
100
> >
A TUNER AMP UNIT
VCR(RC):+2.2 dBm
The > mark found on some component parts indicatesthe importance of the safety factor of the part.Therefore, when replacing, be sure to use parts ofidentical designation.
Symbol indicates a resistor.No differentiation is made between chip resistors anddiscrete resistors.
NOTE :
Symbol indicates a capacitor.No differentiation is made between chip capacitors anddiscrete capacitors.
NM : No Mount
: The power supply is shown with the marked box.
TUNER:-24.0 dBmTUNER(UW):-20.0 dBm
AUX:+2.2 dBmVCR(RC):+2.2 dBmDVD/USB:+5.1 dBm
TUNER:-5.9 dBmTUNER(UW):-1.9 dBm
AUX:+10.3 dBmVCR(RC):+10.5 dBmDVD/USB:+10.2 dBm
TUNER:+20.1 dBmTUNER(UW):+24.1 dBm
AUX:+36.3 dBmVCR(RC):+36.5 dBmDVD/USB:+36.2 dBm
DVH-3200UB/XNUW596
1 2 3 4
1 2 3 4
C
D
F
A
B
E
A-a
A-b
A-b
FR
+
FR
-
FL-
FL+
AM
PP
W
IEC
AVSDA
AVSCL
NAVIR
NAVIL
TU
NR
LSR
AU
XR
AU
XG
ROT0
ILMPW
FLPIL
VM
UT
E
NA
VIR
ROT1
KE
YD
AVSIVCRLAVSIVCRR
IPR
+
AV
SIV
CR
R
IPR
-
VC
RR
AVSIVCRR
AVSIVCRL
VCRL
LSV
VCRG
VCRR
VC
RL
SL
EJE
CT
VC
RG
33u/10C184
100u
/6.3
C57
2
NM
C161
330u
/6.3
C18
2
NM
C28
1
2.2u
/50
C28
4
2.2u
/50
C28
3
NM
C28
2
22u/
10C
181
NM
C351
47u/
6.3
C17
4
C372NM
C37
1 NM
C35
4
NM
C352
NM
C353NM
NM
C601
C6031u/10
C602
0.01u/25
C20
61u
/10
C20
80.
22u/
16
C287
1000p/50
C285
NM
C286
NM
C288
1000p/50
C550NM
C509NM
C546NM
C503NM
C55
3
NM
C508NM
C545NM
C58
0
NM
C5011u/10
C547NM
C183
0.1u/16
C506NM
C17
1
NM
C17
2
NM
C548NM
C502NM
C20
11u
/10
C162
NM
C549NM
C510NM
C20
2
1u/1
0
C507NM
C5051u/10
CC
G11
82-A
C27
1
C204
1u/10
C5041u/10
C511NM
C57
4N
M
C5251u/10
C57
3N
M
C25
10.
47u/
10
C25
20.
47u/
10
C321
NM
C5261u/10
C5421u/10
C57
6N
M
C57
5N
M
VG
ND
AG
ND
AG
ND
AG
ND
VG
ND
VG
ND
VG
ND
AG
ND
AG
ND
VG
ND
VG
ND
VIG
ND
VIG
ND
VIG
ND
AG
ND
AG
ND
AG
ND
AG
ND
DG
ND
DG
ND
GN
D
IC31
1
TC
7SE
T08
FU
S1
INB
1
INA
2
GN
D3
OU
TY
45V
cc
IC181
TK15405BMI
STBY1
OUT2
SAG3
IN4
5GND
6VCC
NM
IC37
1A_O
UT
1
A-I
N2
A+I
N3
V-
45
B+I
N
6B
-IN
7B
_OU
T
8V
+
AN
1588
7A
IC50
1
VC
C1
BIA
S1
GN
D1
L1-1
L1-2
R1-
1
R1-
2
L2-1
L2-2
VC
C2
BIA
S2
GN
D2
R2-1
13
R2-2
14
L3-115
L3-216
R3-117
R3-218
L4-119
L4-220
R4-121
R4-222
L5-1 23L5-2
24
R5-
125
R5-
226
RO
UT
127
LOU
T1
28R
OU
T2
29LO
UT
230
FB
231
VO
UT
232
FB
133
VO
UT
134
SD
A
35S
CL
36
V1-137
V1-238V2-1
39V2-2
40V3-1
41V3-2
42V4-1
43V4-2
44V5-1
45V5-2
46 V6-1
47V6-2
48
JA32
1C
KS
4124
-A2 3 1
L161
NM
L321
CT
F13
89-A
L351 N
M
L182
CTF1383-A
L601
10u
L181
10u
L371 N
M
miniSMDC075F/24
P29112
DT
C32
3TU
Q29
2
RT
3T22
M
Q29
1123
4 5 6
NMQ161
2SA
1579
(R)
Q32
1
Q162NM
R57
122
0
R35
5
NM
R376
NM
R522100
R37
5
NM
R50
4
NM
R50
8N
M
R162
NM
R35
6
NM
R37
4N
M
R17
2
NM
R17
1
NM
R37
3
NM
R18
5
68k
R54
2N
M
R181
47k
R36
0
NM
R166
NM
R161
NM
R573100
R54
1N
M
R25
11k
R20
6 0
R37
1
NM
R50
7N
M
R545100
R167
NM
R57
222
0
R35
8
NM
R18433k
100
R35
7
NM
R359
NM
R523100
R35
4
NM
R16
4
NM
100
R574100
R353
NM
R351
NMR35
2
NM
R1740
R29
2N
M
R29
3N
M
R28
2
NM
R28
1
NM
R285
NM
R287
22k
R286
NM
R28
4
820
R31
1
0
R313
47k
R288
22k
R28
3
820
R30
4N
M
R30
3
R50
6
NM
R31
5
120
R30
1N
M
R30
2N
M
R29
4N
M
R29
6N
M
R29
7N
M
R29
9N
M
R30
0N
M
R322
100k
R323
10k
R31
2
620
R32
1
NM
R31
4
0
R543100
R20
20
R60
1
100k
R68
3
100k
R163
NM
R68
110
0k
R60
2
100k
R372
NM
VD
D5V
VIN
VO
UT
VG
ND
IN
VG
ND
OU
T
OP
T2
OP
TG
OP
T1
OP
T3
BU
P
SY
S+B
VD
5
SY
S+B
VD
D
NM
VR1611 3
2
C5511u/10
C5781u/10
C5521u/10
C5771u/10
C292
NM
CN
291
NM
1 2 3 4
C5411u/10
R544100
R239
10k
C23
1
2.2u
/16
10u/16
C234
R23
4
22k
NJM
4558
MD
IC23
1OU
T1
1
IN-1
2
IN+1
3
GN
D4
5IN
+2
6IN
-2
7O
UT
2
8V
CC
R23
6
22k
SY
S+B
R23
7
22k
C23
22.
2u/1
6
R23
5
22k
R24
322
k
C24
12.
2u/1
6
C24
22.
2u/1
6
SY
S+BN
JM45
58M
DIC
241O
UT
11
IN-1
2
IN+1
3
GN
D4
5IN
+2
6IN
-2
7O
UT
2
8V
CC
R24
2
22k
R24
1
22k
VG
ND
C293
NM
miniSMDC075F/24
P29212
C25
40.
47u/
16
C25
30.
47u/
16
C24
3
100p
/50
C23
3
100p
/50
R24
5
22k
C16
4
NM
C313
0.1u/10
NM
IC35
1OU
T1
1
IN-1
2
IN+1
3
GN
D4
5IN
+2
6IN
-2
7O
UT
2
8V
CC
C31
1
15p/
50
R16
5
NM
C16
3
NM
R20
10
220u
/6.3
C57
1
AG
ND
C5121u/10R5090
R5050 R546100
TP
291
TP
292
TP
293
TP
294
TP
295
TP
296
TP
297
TP
298
TP
299
TP
300
VD
D1
VA292
NMVA291
NMVA321
EZJZ1V270RM
GN
D
GN
D
RF
GN
DR
FG
ND
1
2
3
4
909192939495V
RE
F96
AV
CC
979899100
IC17
1
NM V
out
1G
ND
2V
+3
Vin
4 5V
GN
D
C291NM
R233
12k
R244
12kR238
12k
R29
5
R29
8
R224
R226
VD
5
R182 R183
IC27
1P
A20
30A
1 2 3 4 5 6 7 8 9
10 11 12 13
VD
5
VD
5
C165NM
JA28
2
1 2 3 4 5 6 7 8 9
C37
4
NM
C37
3N
M
VA322
EZJZ1V800AM
R24
0
5.6k
R24
6
5.6k
C312
10u/6.3
R17
5
0
R17
3
0
R29
1
1k
750
C173
1000p/16
NM
Q2811
2
34
5
6Q282
1
2
34
5
6
5.F
L+
3.F
L-
1.T
AB
OP
T-O
UT
330
OP
T
OP
T
311
(BLA
CK
)
VC
R V
GN
D
VID
EO
OU
T IS
O +
0dB
6dB
75D
RIV
ER
+6d
BA
MP
VC
R V
AVSOUT L
AVSOUT R
VG
ND
(OU
T)
VID
EO
OU
T
VID
EO
IN
VG
ND
(IN
)
VoG
RC
VC
RG
FL
FR
RL
RR
VC
RR
VC
RL
NAVIG R
NAVIG L
RR
FR
201
230
E-V
OL
MA
ES
TR
O2
ILMPW CS
EN
S
NC
FLPILM
ROT0
SL
AV
ss
NC
NC
EJE
CTROT1
KE
YD
NC
NA
VI M
IXIN
G35
140
0
161
200
VID
EO
OU
T
VC
R IN
231
250
RC
A28
131
0
*C,F
TU
NL
TU
NR
LSL
LSR
AV
SIV
CR
LA
VS
IVC
RR
IPL+
IPR
+IP
L-IP
R-
AU
XL
AU
XG
AU
XR
AU
XG
to IN
1
A,B
,DE
C,F
to IN
2to
IN3
to IN
4+to
IN4-
NM
*NM
A,B
,D
R29
5R
298
R30
3
C,F
10k
NM
10k
NM
0N
M
7.F
R-
9.F
R+
8.P
W.G
ND
1
11.F
RIN
12.F
LIN
4.S
TB
Y
10.S
VR
6.V
CC
1/2
2.P
W.G
ND
2
13S
GN
D
NM
Vo
Vo
--
RL
RL
- RR
RR
-
VoG
AoG
AoG
-12
CK
B10
93-A
CK
B10
95-A
1 2
*1
*1E
NM
39 33
NM
NM
NM
RT3N66M-T
*1 *1
100
100
>>
AT
UN
ER
AM
P U
NIT
VC
R(R
C):
+2.2
dB
m
The
> m
ark
foun
d on
som
e co
mpo
nent
par
ts in
dica
tes
the
impo
rtan
ce o
f the
saf
ety
fact
or o
f the
par
t.T
here
fore
, whe
n re
plac
ing,
be
sure
to u
se p
arts
of
iden
tical
des
igna
tion.
NM
: N
o M
ount
DVH-3200UB/XNUW5 97
5 6 7 8
5 6 7 8
C
D
F
A
B
E
A-a
A-b
A-b
VID
EO
5
FR
+
FR
-
FL
RR
-
RL+
TE
LIN
RL-
FL-
FL+
FR
+
RR
+
FL+
FR
-
AN
TP
W
AM
PP
W
ILM
PW
AC
CP
WA
CC
PW
SW
VD
D
V5C
ON
T
SY
SM
UT
E
KE
YA
D
AU
XG
AU
XL
LSL
TU
NL
TU
NR
LSR
AU
XR
AU
XG
VCK
VDT
HS
LK RD
T
TU
NP
DO
RD
SLK
SY
SP
W
FLP
IL
RESET
RR
+
RR
-
RL+
RL-
KE
YA
D
KE
YD
IPL+
IPR
+
KE
YD
AV
SIV
CR
R
AV
SIV
CR
L
IPR
-
IPL-
LDET
FLG
US
BC
TL
AM
PP
W
VST
RCK
SL
EJE
CT
AS
EN
S
BS
EN
S
NA
VIL
NM
CN
1001
1
2C
N82
1C
KM
1370
-A
1 2 3 4 5 6 7 8 9 10 11 12 14 15 1613
100u/16
C1023
33u/10
C261
NM C1072
47u/
16
C22
2
100u/10
C1014
CCH1486-AC262
100u/16 C1052
C21
31u
/10
C21
10.
22u/
16
C20
61u
/10
C20
80.
22u/
16
C22
3
0.1u
/16
C77
2
0.1u
/16
C773
NM
C771
2.2u/16
C1002
0.22u/6.3
C10010.22u/6.3
C215
1u/10
C20
11u
/10
C20
2
1u/1
0
CC
G11
82-A
C27
1
C263
0.1u/16
C204
1u/10
C27
3
4.7u
/16
C27
24.
7u/1
6
C21
21u
/10
C21
71u
/10
C25
50.
47u/
10
C25
60.
47u/
10
C25
10.
47u/
10
C25
20.
47u/
10
C101310u/10
C1022
0.01u/25
C10112.2u/10
C1012NM
C1031NM
C1071NM
C331
0.1u/16
C1042
1000p/50
C1073NM
C332
0.1u/16
C10510.01u/25
C1053
0.01u/25
D10
11N
M
D661
NM
D10
12
NM
D80
21S
R15
4-40
0
D77
11S
R15
4-40
0
D821
1SR154-400
D10
52
1SR
154-
400
D7721SR154-400
D10
13N
M
D8221SR154-400
D801
1SR154-400
D78
1
MC
2848
-11
D75
1
D1071
NM
D75
2
ILM
GN
D
VIG
ND
DG
ND
ILM
GN
D
ILM
GN
D
VG
ND
AG
ND
DG
ND
AG
ND
GN
D
GN
DG
ND
GN
D
AG
ND
DG
ND
GN
D
GN
D
DG
ND
GN
D
GN
D
DG
ND
GN
D
GN
D
NJM
2885
DL1
-33
IC10
11
1IN
2GND
3OUT
IC661
BD4835G
OUT1
VDD2
VSS34
5
IC10
01
S-1
200B
33-M
5
VIN
1
VS
S2
ON
/OF
F3
NC
45V
OU
T
IC771TPD1018F
1OUT
2GND1
3GND2
4GND3
5VDD
6IN
7GND4
8GND5
9GND6
10DIAG
IC201
IN1_L1
IN2_L2
IN3_L3
IN4+_L4
5IN4-_L
6Front_L
7Rear_L
8Vcc
9Vref
10GND
11 DATA
12 CLK
13 STB
14 Rear_R
15 Front_R
16 IN4-_R
17 IN4+_R
18 IN3_R
19 IN2_R
20 IN1_R
NJM2388F84
IC1021
1VIN
2VOUT
3GND
4CONTROL
JA331
CKS4124-A
231
L221
2.2u
L781
CT
F13
79-A
L821
CT
H12
80
LTC114EUBQ1062N
MQ
1032
NMQ1072
NM
Q10
74123
4 5 6
RT
3T22
M
Q10
52
1234 5 6
RT
3T22
MQ
261
1234 5 6
Q10
512S
D18
58(Q
R)
Q10
73N
M
LSA
1576
UB
Q78
1
R2211k
2
1
4
3 6
5
8
7
R77
1
10k
R262
10k
R752
47k
R22
3 0
R25
11k
R20
6 0
R75
1
100k
R1042
10k
R1073
NM
R10
71
NM
R1062
4.7k
R78
2
15k
R75
3
10k
R1052
2.2k
R1051
22k
R26
3
220
R78
1
4.7k
R755
4.7k
R754
47k
R1031NM
R1032
NM
R1043
22k
R1075
NM
R10
63
10k
R1041
2.2k
R1022
47k
R261
10k
R10
21
1k
R1055
39
R1053
39
R1056
39
R3321k
R3311k
R1074
NM
R20
20
R21
20
R21
10
R1054
39
R68
047
k R67
768
0
R68
3
100k
R67
1R
672
R1072
NM
R67
947
0
R10
61 1
R67
5R
676
R68
210
k
R67
3R
674
R68
110
0k
R67
868
0
ILM
+
TE
ST
INTP
601
TE
ST
2
FANG
DG
ND
3
VD
D1
VD
D2
FANB
SW
VD
D1
V5
VD
D3
RE
SE
T
FR
+
TE
LM
AC
C
RL-
BS
EN
2
RL+
SY
SB
FR
-
BS
EN
1
AA
NT
FL+
AS
EN
RR
+
BR
EM
GND1
BU
2
GND2
BU
1
FL-
KEYAD
KE
YD
RR
-
MU
T
BU
P
BU
P
SY
S+B
ILM
+B
SY
S+B
TU
3.3 F
LPIL
M
VD
D3
VD
DS
WV
DD
SY
S+B
RCK
L104
1
NM
C1041
NM
C25
40.
47u/
16
C25
80.
47u/
16
C25
70.
47u/
16
C25
30.
47u/
16
1000u/16
C1054
NM
Q10
31LS
A15
76U
BQ
1041
2SA
1576
A(R
S)
Q10
61N
MQ
1071
C27
4
0.04
7u/1
6
R20
10
100u/10
C1021
C67
3N
M
C67
2N
M
C67
1N
M
VD
D1
RF
GN
D
RF
GN
D
GN
D
GN
D
72
73
74
75
7677787980818283848586878889909192939495V
RE
F96
AV
CC
979899
R68
410
0k
NM C1032
10u/
16
C22
1
VG
ND
C80
1
0.1u
/16
C1061
0.1u/16
C1062
0.1u/16
C751
0.1u/16
C66
1
0.1u
/10
R661
470k
R225
R227
R224
R226
3 4 5 6 7 8 9
10 11 12 15 16 17 18 19 20 21 22 23 24 2513 14
C781
0.1u/16
RF
GN
DG
ND
D10
21
1SR
154-
400
R1064100k
D75
3
NM
R756
NM
R75
7
NM
Q75
2 NM
GN
D
BS
EN
3
D1051UDZS5R6(B)
C22
4
1000
p/50
C22
5
1000
p/50
C27510p/50
RT3CLLM(EF)
Q7511
2
3 4
5
6
B.U
AA
NT
AS
EN
S&
BS
EN
S
251
280
AM
P
751
800
CO
NN
EC
TO
R
(3300uF)
GN
D
FL+
(104)
RR
-
TE
LM
5.F
L+
PO
WE
R
RL+
801
1000
FR
+
TE
LM
FL-
RL-
SE
NS
3.F
L- RR
+
AC
CB
RE
M
FR
-
VG
ND
MU
TE
8.4V
VD
D 5
VR
EG
PO
WE
R S
UP
PLY
0.75
A
SY
S+B
1001
1100
8.4V
TU
NE
R 3
V
1A
ILM
+B
(3216 1/4W)
SW
DV
DD
VID
EO
5V
(321
6 1/
4W)
RR
FR
201
230
RE
MO
TE
* A
,B
331
350
WIR
ED
INP
UT
FL
RL
NC
ILMP
NC
CS
EN
S
MO
DE
L2
RCK
LDET
NC
FLPIL
RO
MO
DE
L1
KE
YA
D
RD
S-H
SLK
TU
NP
DO
SL
US
BF
LG
US
BC
TL
RD
S-L
OC
KM
OD
EL0NC
AV
ss NC
NC
TE
ST
IN
NC
RD
S-D
AT
A
EJE
CTRO
KE
YD
NC
RE
SE
T
101~
130
LS
113
1~16
0 IP
-BU
S16
1~20
0 V
IDE
O O
UT
201~
230
E-V
OL
MA
ES
TR
O2
231~
250
VC
R IN
251~
280
AM
P28
1~31
0 R
CA
311~
330
OP
T33
1~35
0 W
IRE
D R
EM
OT
E IN
PU
T35
1~40
0 N
AV
I MIX
ING
401~
500
FM
/AM
TU
NE
R U
NIT
501~
600
AV
SE
LEC
TO
R60
1~70
0 S
YS
u-C
OM
70
1~75
0 K
EY
BO
AR
D U
NIT
751~
800
SE
NS
A.A
NT
TE
LM80
1~10
00 P
OW
ER
CO
NN
EC
TO
R
1001
~110
0 P
OW
ER
SU
PP
LY
1101
~120
0 D
D C
ON
FLP
ILM
AA
NT
FA
N
TU
NL
TU
NR
LSL
LSR
AV
SIV
CR
LA
VS
IVC
RR
IPL+
IPR
+IP
L-IP
R-
AU
XL
AU
XG
AU
XR
AU
XG
to IN
1
NC
to IN
2to
IN3
to IN
4+to
IN4-
*A,B
,G
*A,B
100
7.F
R-
9.F
R+
8.P
W.G
ND
1
20.V
CC
3/4
11.F
RIN
12.F
LIN
21.R
L+
15.R
RIN
23.R
L-
25.B
.RE
MO
TE
24.P
W.G
ND
4
4.S
TB
Y
18.P
W.G
ND
3
14.R
LIN
10.S
VR
6.V
CC
1/2
16.A
CG
ND
22.M
UT
E
17.R
R+
13.S
-GN
D
19.R
R-
NM
NM
NM
NM
RE
FE
RE
NC
E A
RE
A M
AP
NM
NM
HZ
U7R
5(B
3)
HZ
U6R
8(B
2)
NM
PML014*
100
100
100
Sym
bol i
ndic
ates
a r
esis
tor.
No
diffe
rent
iatio
n is
mad
e b
etw
een
chip
res
isto
rs a
nddi
scre
te r
esis
tors
.
NO
TE
: Sym
bol i
ndic
ates
a c
apac
itor.
No
diffe
rent
iatio
n is
mad
e b
etw
een
chip
cap
acito
rs a
nddi
scre
te c
apac
itors
.
: The
pow
er s
uppl
y is
sho
wn
with
the
mar
ked
box.
TU
NE
R:-
24.0
dB
mT
UN
ER
(UW
):-2
0.0
dBm
AU
X:+
2.2
dBm
VC
R(R
C):
+2.2
dB
mD
VD
/US
B:+
5.1
dBm
TU
NE
R:-
5.9
dBm
TU
NE
R(U
W):
-1.9
dB
mA
UX
:+10
.3 d
Bm
VC
R(R
C):
+10.
5 dB
mD
VD
/US
B:+
10.2
dB
m
TU
NE
R:+
20.1
dB
mT
UN
ER
(UW
):+2
4.1
dBm
AU
X:+
36.3
dB
mV
CR
(RC
):+3
6.5
dBm
DV
D/U
SB
:+36
.2 d
Bm
DVH-3200UB/XNUW598
1 2 3 4
1 2 3 4
C
D
F
A
B
E
A-b
A-a
A-a
A-b
VD
8
AM
UT
ELS
_2_S
YS
SY
S_2
_LS
ST
AN
DB
Y
XR
ST
IRQ
PW
LSL
LSR
LSV
VD
CO
NT
5
DP
DT
SWVDD
BSENS
ASENS
LS_2
_SY
S
SY
S_2
_IP
ILMCLR2
ILMCLR1
ROT0
ILMPW
FLPIL
RW
CLK
RW
BU
SY
SY
S_2
_LS
RWCNVSS
RESET
ROT1
AU
XL
AU
XR
DSENS
VDCONT8
VDCONT5
LSV
AU
XG
VC
RL
VC
RG
VC
RR
KY
DT
SYNC
IEC
AU
XV
AU
XV
G
D+
D-SYNC
USBCTLFLGVDCONT5
TE
LIN
IP_2
_SY
S
47u/16
C521 47u/16
C531
22u/16 C534
22u/16 C523
CCH1486-A
C1195
C104
4.7u/6.3
C604NM
22
16
C1101
1u/6.3
C509NM
C546NM
C508NM
C545NM
C52
7N
M
C54
4N
M
C5011u/10
C547NM
C1112
0.22u/6.3
C548NM
C502NM
C532
0.1u/16
C52
8N
M
C1111
0.22u/6.3
C52
9N
M
C524
0.1u/16
C549NM
C510NM
C53
0N
M
C5051u/10
C5041u/10
C511NM
C522
0.1u/16
C54
3N
M
C5251u/10
C11
44C
CG
1223
-A
C1192NM
C1151NM
C1131
10u/35CCG1236-A-T
C1196
CCG1223-A
C1152NM
C1194NM
C1162
NM
C1193NM
C11
43C
CG
1223
-A
C1186
NM
C5261u/10
C1153NM
C111
0.1u/16
C102
0.1u/10
C101
0.1u/16
C5421u/10
C5330.1u/16
D1151NM
D1191
NM
D11
41
RB
551V
-30
D11
93R
SX
201L
-30
D11
92R
SX
201L
-30
D521
S1G-6904G2P
D522
S1G-6904G2P
D11
42
RB
551V
-30
D11
1N
M AG
ND
US
GN
D
AG
ND
DG
ND
AG
ND
AG
ND
LSD
GN
D
DG
ND
GN
DD
DC
GN
DD
DC
GN
DD
DC
GN
DD
DC
GN
DD
DC
IC11
11
S-1
200B
33-M
5
VIN
1
VS
S2
ON
/OF
F3
NC
45V
OU
T
IC12
2T
C7M
BL6
126S
FK
1OE
1
A1
2
A2
3
A3
4 5A
46
4OE
7G
ND
83O
E
9B
4
10B
3
11B
2
12B
1
132O
E
14V
CC
IC11
1T
C74
VH
CT
08A
FT
S1
1A1
1B2
1Y3
2A4 5
2B6
2Y7
GN
D8
3Y
93A
103B
114Y
124A
134B
14V
CC
IC11
2T
C74
VH
C08
FT
S1
1A1
1B2
1Y3
2A4 5
2B6
2Y7
GN
D8
3Y
93A
103B
114Y
124A
134B
14V
CC
BD
9013
KV
IC11
03
OUTH21
BOOT22CL2
3N.C.1
4VCCCL2
5N.C.2
6VCC
7VCCCL1
8N.C.3
9CL1
10 BOOT1
11OUTH1
12
SW
1
13
DG
ND
1
14
OU
TL1
15
N.C
.416
VR
EG
5A17
N.C
.518
N.C
.619
N.C
.720
FB
121
CO
MP
122
SS
123
N.C
.824
N.C.9
25
EN1
26
EN227
N.C.1028
N.C.1129
GND30
N.C.1231
N.C.1332
RT33
SYNC34
N.C.14 35N.C.15
36SS
237
CO
MP
238
FB
239
N.C
.16
40E
XT
VC
C41
N.C
.17
42N
.C.1
843
VR
EG
544
N.C
.19
45O
UT
L246
DG
ND
2
47S
W2
48
AN
1588
7A
IC50
1
VC
C1
1
BIA
S1
2
GN
D1
3
L1-1
4
L1-2
5
R1-
16
R1-
27
L2-1
8
L2-2
9
VC
C2
10
BIA
S2
11G
ND
212
R2-1
13
R2-2
14
L3-115
L3-216
R3-117
R3-218
L4-119
L4-220
R4121
V2240
V3-141
V3-242
V4-143
V4-244
V5-145
V5-246 V6-1
47V6-2
48
L110
8C
TH
1253
-A
L119
2C
TH
1253
-AL1
153
CT
H12
53-A
L113
1N
M
CT
H13
58-A
-T
L112
1
NM
CT
H13
58-A
-T
UM
D3N
Q11
1
1234 5 6
R10
422
0
R522100
R10
347
0
R50
4
NM
R10
522
0
R10
147
0
R10
90
R10
647
0
R54
2
R10
8
470
R10
7
470
R54
1
R12
20R10
21k
R12
10
R12
30
R50
210
0
R50
3
NM
R523100
R50
110
0
R11
2
0
R1101
100k
R621NM
R113
1k
R12
4
100k
R62
322
0
R125100k
R11720
R1181
30k
R1185
NM
R11710
R1163
NM
R60
8
100k
R605
47k
R60
1
100k
R62
5N
M
R611100k
R6224.7k
R62
422
0
R60
710
0k
R6040
R62
61k
R60
2
100k
R609
100k
PC
L
VD
D5V
TS
CK
IRQ
PW
R
ST
AN
BY
Sto
MS
AM
UT
E
FLG
AC
C3
US
BC
TL
XR
ES LS
L
LSV
LSR
MS
toS
AC
C5V
VD
8_1
VD
8_2
OU
TH
2
OU
TH
1
BU
3
LSV
D8
VD
8
SY
S+B
BU
P
VD
5
VD
5US
B5V
VD
D
VD
5V
D3
VD
5
SY
S+B
VD
D3
VD
3
VD
3
VD
5
R11
1
0
R606
100k
DG
ND
R1184
82k
R1183
0
R1182
9.1k
R1166
10k
CK
S38
44-A
CN
101
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
C5411u/10
R544100
DG
ND
GN
DD
DC
R52
122
k
R52
422
k
VIG
ND
C60
6C
605
C1210.1u/10
C1164
0.047u/16
C1182
0.047u/16
C1120.1u/16
VG
ND
C11
46N
M
C11
47N
M
C5121u/10R5090
R5050 R546100
VD
8
VD
D5
D-2
D+2
SC
K
SD
A
CP
RS
T
LSD
GN
D
HAT2210RJQ1191
1
2
3
45
6
7
8
HAT2210RJQ1151
1
2
3
45
6
7
8
R635100k
IC60
1
1
2
3
4
5BYTE
6CNVSS
7
8
9RESET
10XOUT
11VSS1
12XIN
13VDD1
14NMI
15
16
17
18
19
20
21
22
23
24
25
26 27 28 29 30 31 32 33 34 35 36909192939495
VR
EF
96A
VC
C97989910
0
R1164
47k
R1165
6.8k
VIG
ND
AG
ND
C11971.0u/35
C11981.0u/35
C11
421.
0u/3
5
C11
84
1.0u
/35
C11220.1u/10
C11320.1u/10
C11021u/6.3
R610470
R1174
470
C60
710
0p/5
0C1199
NM
GN
DD
DC
R11
62 0R
1187 0
T0
T1
L602
NM
C1121
10u/35CCG1236-A-T
L101
CT
F13
89-A
GN
DD
DC
R51
075
L115
2C
TF
1661
-A
L1151
CTF1661-A
L114
1
CT
F16
61-A
L119
1C
TF
1661
-A
330u/16 C1191
330u/16 C1154
R11
6
NM
R11
4N
M
R11
5 NM DG
ND
X60
1C
SS
1774
-A
R11
88
2.2
R11
61
2.2
R603
4.7k
R1167
22k
C1163
220p/50
C1183
220p/50
L121 NM
12 3
4
R12
6
0
R12
7
C10
7
NM
C106
4.7u/10
IC12
134
1S21
62
NC
11
MO
DE
1/S
PI_
nSS
2N
C2
3nR
ES
ET
4
VC
C
5
NC36NC47NC58NC69NC7
10
VS
S
11 I2C
_SC
L/S
PI_
SIM
O
12 I2C
_SD
A/S
PI_
SO
MI
13MO
DE
0/S
PI_
CLK
14NC
8
15
NC9NC10 7NC11
8NC12
9NC13
0
C11
61
P11
31
CE
K12
86-A
C11
85
R12
8
390
IC11
01R
5523
N00
1B
EN
1
GN
D2
FLG
3V
IN45
VO
UT
R1111NM
R11120
C1230.1u/10
P11
91C
EK
1344
-A1
2
P11
21
CE
K12
86-A
R117382k
C1181
0.01u/25
C1165
0.01u/25
C105
NM
R12910k
R11
42 10
R11
4110
R11
89
10k
R11
90
10k
R11
91 1kC11
450.
033u
/25
C11
410.
033u
/25
C5811u/6.3
Q11
2
1 2 3456
AG
ND
AM
UT
E
XR
ES
SM
S5T
XVD
VG
ND
SC
K
AG
ND
DG
ND
VD
VD
D5
RO
UT
LOU
T
DG
ND
DG
ND
IRQ
PW
R
D+
CO
MP
OS
IT
8.0V
VD
PG
ND
PG
ND
D-
IEC
OU
T
ST
AN
BY
AG
ND
MS
5S
RX
CP
RS
T
DG
ND
SD
A
5.1V
DG
ND
101
130
LS1
5.1V
(D)
(D)
8.01
V
(D)
(1/8
W)
(1/8
W)
(1/8
W)
(D)
(F)
8.0V
(15u
H)
MS
VA
UX
V
AU
X V
GN
D
NC
ILMPW
SYNC
15.0
MH
z
CS
EN
S
DSENS
NC
NC
FLPILM
NC
601
700
ROT0
TS
CK
RX
RW
CLK
TX
SY
Su-
CO
M
NC
DP
DT
RX2
SL
ILMCLR1
TX
LS1
AV
ss
NC
RW
BU
SY
KY
DT
TE
LIN
NC
EJE
CTROT1
KE
YD
NC
RX
LS1
BSENS
ILMCLR2
ASENS
NC
AV
SE
LEC
TO
R50
160
0
1101
1200
DD
CO
N(1
5uH
)
5.2V
Ray
chem
4A
NM
NM
SWVDD
NM
3.0A
C60
5C
606
18p/
5020
p/50
A,B
C~F
20p/
5020
p/50
PE
G52
4A8
CW
W15
39-
SO
FT
WA
RE
UN
ITF
LAS
H
A,B
NM
(3300uF)
3.3u
/10
3.3u
/10
3.0A
RT
3N66
M-T
(1/8
W)
>
>
>
CC
N19
01D
VD
/US
B:+
5.1
dBm
DVH-3200UB/XNUW5 99
5 6 7 8
5 6 7 8
C
D
F
A
B
E
A-b
A-a
A-a
A-b
RC
K
HS
LK SL
CE
2
CE
1
TU
NP
CK
TU
NP
DO
LDE
T
TU
NP
DI
RD
T
IPP
W
IP_2
_SY
S
SY
S_2
_IP
AS
EN
BO
RD
SLK
VD
CO
NT
5
IPL-
IPL+
IPR
-
IPR
+
DP
DT
SY
SM
UT
E
CE1
LS_2
_SY
S
SY
S_2
_IP
AS
EN
BO
CE2
IPP
W
AC
CP
W
TUNPDI
AM
UT
E
TUNPCK
AM
PP
W
ST
AN
DB
Y
RW
CLK
RW
BU
SY
SY
SP
W
ANTPW
VST
VCK
VDT
V5CONT
SY
S_2
_LS
VD
CO
NT
8
RESET
RW
BU
SY
RW
CLK
AC
CP
W
RW
CN
VS
S
DP
DT
RE
SE
T
ILMCLR1
ILMCLR2
KYDT
DSENS
D+
D-
AUXVG
VDCONT5
TU
NL
TU
NR
KY
DT
AUXL
LDET
KY
DT
IEC
D+
D-
DPDT
IRQ
PW
ROT0
AUXV
ROT1
AUXR
AUXG
TE
LIN
XR
ST
IP_2
_SY
S
AVSCL
AVSDA
VMUTE
RCK
EJECT
100u/16
C472
C4520.01u/25
C641
NM
C473
33p/50
C45
7
NM
C471
0.01u/25C
131
0.1u
/16
C151
0.1u/16
C152
1000p/50C153
1000p/50
C122
0.1u/16
C451
4.7u/10
C454
1000p/50
C474
NM
C433
NM
C455
NM
D661
NM
AG
ND
DG
ND
RF
GN
D
LSD
GN
D
ILM
GN
D
US
GN
D
USGND
RF
GN
D
DG
ND
ILM
GN
D
RF
GN
D
DG
ND
LSD
GN
D
DG
ND
DG
ND
RF
GN
D
DG
ND
RF
GN
D
IC661
BD4835G
OUT1
VDD2
VSS34
5
NM
IC64
1
CS
1
SK
2
DI
3
DO
45
GN
D
6T
ES
T
7N
C
8V
CC
HA
1224
1FP
IC15
1
DIN
11
RO
UT
2
DIN
23
GN
D4
5B
US
-
6B
US
+
7V
CC
8S
TB
Y
IC12
2T
C7M
BL6
126S
FK
1OE
1
A1
2
A2
3
A3
4 5A
46
4OE
7G
ND
83O
E
9B
4
10B
3
11B
2
12B
1
132O
E
14V
CC
JA13
1C
KS
5271
-A
1 2 3 4 5 6 7 8 9 10 11
L452
10u
L641
NM
L451
2.2u
L472
22u
L471 1u
L151
CT
F14
73-A
LTC
124E
UB
Q13
2
UMH1N
Q4011
2
34
5
6
UMH1N
Q4021
2
34
5
6
LSA
1576
UB
Q13
1
R40
2
22k
R45
768
0
R40
3
22k
R12
20
R15
1
4.7k
R12
10
R12
30
R45
468
0
R45
568
0
R13
9
100
R137
15
R138
47
R14
1
2.2k
R142
22k
R14
3
4.7k
R15
2
1k
R45
268
0
R12
4
100k
R62
322
0
R125100k
R7200
R13
1
180
R13
5
1k
R133
22k
R45
368
0
R40
1
22k
R13
2
180
R134
22k
R14
01k
R642
NM
R40
422
k
R632100k
R64
3
NM
R62
5N
M
R63
01k
R45
168
0
R62
91k
R654680
R7170
R63347k
R655470
R7160
R62
422
0
R47
168
0
R13
6
100
R6521k R6531k
R62
61k
R63447k
R62
8N
M
R7112.2k
R7142.2k
R7152.2k
R7182.2k
R7192.2k
R7132.2k
R7122.2k
TE
S
TU
N5V
2
VMUTE
AB
O
BS
+
TU
N3V
PC
L
DG
ND
3
GN
D
TS
CK
ROT0RO
MD
AT
A
DG
ND
RO
MLK
RO
MC
S
D+
COLOUR1
D-
ILMGND
COLOUR2
DPDT2
SWDVDD
USGND
ILM+B
IPR
-
ROT1
IPR
+
AUXV
AUXL
AUXGND
DSENS
RE
SE
T
TU
NR
USB5V
KYDT2
DP
DT
1
RW
CN
VS
S
AC
CP
W
KY
DT
1
PW
CLK
RW
BU
SY
BS
-
IPL-
IPL+
RF
GN
D
VC
C
MA
NT
TU
NL
USB5V
BU
P
SY
S+B
US
B5V
TU
3.3
ILM
+B
VD
D
VD
D3
SY
S+B
VD
3
VD
D
VD
D
SW
VD
D
U401
1A
M_A
NT
2R
F_G
ND
3F
M_A
NT
4V
CC
5S
L
6C
E2
7W
C
8C
E1
9C
K
10D
I
11LD
ET
12O
SC
GN
D
13R
OM
_VD
D
14D
O
15D
GN
D
16C
OM
P
17V
DD
_3.3
18R
DS
_CK
19R
DS
_DA
TA
20R
DS
_LO
CK
21R
DS
_HS
LK
22B
EG
ND
23Lc
h
24R
ch
P471
IMSA-6802-01Y900
C711NM
AUXR
RCK
25 26 27 28 29 30
C43
1
NM
R43
7
0
R43
6
0R435
NM
R434
NM
R433
NM
Q431NM
R432
NM
R431
NM
Q430NM
R430
NM
C43
2N
M
RF
GN
D
C1210.1u/10
R64
147
k
R7250
R7220
R72322k
R7210
47u/6.3
C453
47u/6.3
C456
SC
K
SD
A
CP
RS
T
C67
C67
C652NM
C651
NM
R65
1
NM
RF
GN
D
RF
GN
D
RF
GN
D
VA
703
EZ
JZ1V
270R
M
VA
704
EZ
JZ1V
270R
M
IC60
1
BY
CNV
RES
XO
VS
X
VD
N
27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
7677787980818283848586878889909192939495V
RE
F96
AV
CC
979899
R636100k
NM
C434
C70
522
0p/5
0
C70
422
0p/5
0
C70
322
0p/5
0
C70
222
0p/5
0
C70
122
0p/5
0
R63
110
0k
R627100k
NM
CN
601
12345678910
R637100k
0
R661
470k
RF
GN
DA
GN
D
CN
701
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
C47
510
00p/
50
L101
CT
F13
89-A
RF
GN
D
JA47
1C
KX
1070
-A1
23
D70
1D
Z2S
068C
-T
D70
2D
Z2S
068C
-T
L121 NM
12 3
4
R12
6
0
R12
7
0
IC12
134
1S21
62
NC
11
MO
DE
1/S
PI_
nSS
2N
C2
3nR
ES
ET
4
VC
C
5
NC36NC47NC58NC69NC7
10
VS
S
11 I2C
_SC
L/S
PI_
SIM
O
12 I2C
_SD
A/S
PI_
SO
MI
13MO
DE
0/S
PI_
CLK
14NC
8
15
NC916
NC10 17NC1118NC12
19NC13
20
R65710kR65610k
R68539k
R68639k
D71
5D
Z2S
068C
-T
D71
3D
Z2S
068C
-T
VD
D1
R12
8
390
C712
NM
C1230.1u/10
R12910k
D71
2D
Z2S
068C
-T
D71
4D
Z2S
068C
-T
R72422k
R742100k
VD
D
FM/AM TUNER UNITX-2026
FM
/AM
TU
NE
R U
NIT
401
500
131
160
IP-B
US
DSENS
AUXL
701
750
KE
YB
OA
RD
UN
IT
SWDVDD
ILMGND
DGND
Ver
2.0B
SC
K
DG
ND
IEC
OU
T
CP
RS
T
SD
A
DG
ND
NC
ILMP
SY
VDT
IRQ
PW
NC
VCK
NC
ANTPW
CS
EN
S
MO
DE
L2
DSE
PC
L
RCK
LDET
NC
FLPIL
ST
AN
DB
Y
VDD
601
700
RO
TS
CK
V5CONT
ROMCK
NC
MO
DE
L1
RX
KE
YA
D
RW
CLK
VDCONT5
TX
SY
Su-
CO
M
RD
S-H
SLK
VMUTE
VD
CO
NT
8
CE2
TU
NP
DO
AVSDA
IPP
W
DP
DT
R
SL
US
BF
LG
US
BC
TL
CE1
ILMCL
RD
S-L
OC
KM
OD
EL0NC
TX
LS1
AV
ss NC
RW
EM
P
NC
TE
ST
IN
RW
BU
SY
TUNPCK
TUNPDI
NC
VSS
KY
DT
TE
LIN
RW
CE
XR
ES
ET
NC
AC
CP
WR
DS
-DA
TA
EJE
CTRO
KE
YD
MU
TE
AVSCL
NC
ROMCS
RX
LS1
BSE
VST
AM
PP
W
AM
UT
E
MO
DE
L
AS
EN
BO
ILMCL
ROMDATA
ASE
SY
SP
W
RO
M C
OR
RE
CT
ION
ROT1
AUXGND
ROT0
COLOUR2
COLOUR1
AUXR
AUXV
ILM+B
USGND
D+
USGND
D-
DPDT
USB5VKYDT
101~
130
LS
113
1~16
0 IP
-BU
S16
1~20
0 V
IDE
O O
201~
230
E-V
OL
M23
1~25
0 V
CR
IN25
1~28
0 A
MP
281~
310
RC
A31
1~33
0 O
PT
331~
350
WIR
ED
R35
1~40
0 N
AV
I MIX
401~
500
FM
/AM
T50
1~60
0 A
V S
ELE
601~
700
SY
S u
-C70
1~75
0 K
EY
BO
A75
1~80
0 S
EN
S A
.80
1~10
00 P
OW
ER
1001
~110
0 P
OW
ER
1101
~120
0 D
D C
ON
&K
M38
6D/U
W5
&K
M38
6/R
C
&K
M38
6/R
D
&K
M38
6/R
I
NM
NM
SWV
RD
S A
,B
&K
M38
6/U
W5
NC
*A,B *A,B
NM
NM
CW
E20
97-
CW
E20
98-
A,B
:C
~F:
&K
M38
6/ID
PE
G52
5A
PE
G52
4A8
CW
W15
39-
SO
FT
WA
RE
UN
ITF
LAS
H
MA
SK
A,B
C~F
-
CK
S60
50-
A B C D E
DV
H-3
200U
B/X
NU
W5
DV
H-3
220U
B/X
NU
W5
DV
H-3
250U
B/X
NR
C
DV
H-3
250U
B/X
NR
D
DV
H-3
250U
B/X
NR
I
DV
H-3
290U
B/X
NID
RE
FE
RE
F
*onl
y G
R67
1R
672
R67
3R
674
R67
5R
676
RD
RI
UW
5
RC
47k
47k
47k
47k
47k
47k
47k
47k
47k
47k
47k
ID47
k
D EBA C
UW
5
FN
M
TUN
ER
(30%
):-24
.0 d
Bm
TUN
ER
(30%
)(U
W):-
20.0
dB
m
BC
N18
21
DVH-3200UB/XNUW5100
1 2 3 4
1 2 3 4
C
D
F
A
B
E
10.2 KEYBOARD UNIT
B
CL195PGCD RS1/10SR0R0J
RS1/10SR0R0J
RS1/10SR102J
CL-197HB1-D
CL195SRCD
CL-197HB1-D
CL-197HB1-D
RS1/10SR***
RS1/4SA***
SYMBOL SIZE
REMOTE
BL
RS1/4SA681J
RS1/4SA821J RS1/4SA561J
RS1/10SR272J
RS1/10SR272J
RS1/10SR272J
COLOR 2
*1
5 MHz
R1852 1853R1873
R1867 R1870R1866
R. OF COLOR 2 ILMCLR
DEST. R1868R1872
PART
REF.
R1869R1859 1865
R. OF COLOR 1
R1877 1878
LED
D1871 1876
*1
CL-197HB1-D RS1/10SR272J
D1852 1870D1880 1889 R1875 1876
RS1/10SR821J
R1854 1856
RS1/4SA681J
R1857 R1858
RS1/4SA102J
RS1/4SA102J
RS1/4SA152J
RS1/4SA222J
RS1/10SR102JRS1/10SR821J
RS1/10SR102JRS1/10SR821J
RS1/10SR102JRS1/10SR821J
SE
G1
SE
G2
SE
G3
SE
G4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SE
G20
SE
G21
SE
G22
SE
G23
SE
G24
SE
G25
SE
G26
SE
G27
SE
G28
SE
G29
SE
G30
SE
G31
SE
G32
SE
G33
SE
G34
SE
G35
SEG36
SEG37
SEG38C
OM
0
CO
M1
CO
M2
CO
M3
KS
T0
KS
T2
KS
T3
KST4
KD
T0
KD
T1
KDT3
KDT2
KD
T1
KD
T2
SE
G1
SE
G7
SE
G11
SE
G12
SE
G13
SE
G14
SE
G15
SE
G19
SE
G20
SE
G22
SE
G24
SE
G30
AUXV/SOURCE
KD
T0
SE
G0
SEG39
SE
G0
SE
G2
SE
G3
SE
G4
SE
G5
SE
G6
SE
G8
SE
G9
SE
G16
SE
G10
SE
G18
SE
G17
SE
G25
SE
G23
SE
G21
CO
M3
CO
M2
CO
M1
CO
M0
SE
G39
SE
G38
SE
G37
SE
G36
SE
G35
SE
G34
SE
G33
SE
G32
SE
G31
SE
G29
SE
G28
SE
G27
SE
G26
KS
T1
KST0
KST1
KST2
KST3
KST4
X1801
IN1
GND2
OUT3
GP1UXC14RKIC1802
1R
EM
2G
ND
3V
CC
DGND
DGND
DGND R1802
2.2
S1824
1 2
S1826
1 2
S1
1
S1823
1 2
1
S18361 2
S18391 2
S1842
1 2
D18
83D
1884
D18
85
D18
88
D18
87
D18
89
D18
86
D18
76
NM
D18
78
D18
75
NM
D18
77
C18
51
NM
ILMGND
D18
73
D18
74
D18
71D
1872
DGND
S1841
1 2
S1825
1 2
S1828
1 2
S1827
1 2
R18
03 NM
R18
01
NM
C18
02
1u/1
6
D18
81D
1882
D18
80
NM
D18
79
S1
1
R18
60 NM
R18
61
NM
R18
63 NM
R18
64 NM
R18
65 NM
R18
62
NM
R18
51
820
R18
25 0
R1823 NM
R1826
0
R18
24 NM
R18
59 NM
C18
52
NM
C18
53
NM
C18
54
NM
C18
55
NM
C18
56
NM
C18
57
NM
C18
58
NM
C18
59
NM
C18
60
NM
C18
61
NM
C18
62
NM
C18
63
NM
C18
64
NM
C18
65
NM
C18
67
NM
C18
68
NM
C18
69
NM
C18
70
NM
C18
66
NM
S1
1
S18
1
S18321 2
S1831
1 2 1
S1
1
S1821
1 2S1822
1 2
S18381 2
S1
1
S18351 2
LCD1801
1S
EG
02
SE
G1
3S
EG
24
SE
G3
5S
EG
46
SE
G5
7S
EG
68
SE
G7
9S
EG
810
SE
G9
11S
EG
1012
SE
G11
13S
EG
1214
SE
G13
15S
EG
1416
SE
G15
17S
EG
1618
SE
G17
19S
EG
1820
SE
G19
21S
EG
2022
SE
G21
23S
EG
2224
SE
G23
25S
EG
2426
SE
G25
27S
EG
2628
SE
G27
29S
EG
2830
SE
G29
31S
EG
3032
SE
G31
33S
EG
3234
SE
G33
35S
EG
3436
SE
G35
37S
EG
3638
SE
G37
39S
EG
3840
SE
G39
41C
OM
042
CO
M1
43C
OM
244
CO
M3
IC1801
PD6497A
SE
G4
1
SE
G3
2
SE
G2
3
SE
G1
4
SE
G0
5
CO
M3
6
CO
M2
7
CO
M1
8
CO
M0
9
V3
10
V2/
P33
11
V1/
P32
12
P31
13
P30
14
P40
15P
WM
/P41
16
MODA21
X022
X123
VSS24
SCK/P4525
INT0/P4626
SEG41/P2527
SEG40/P2428
SEG39/P23 29
30
31
32
SE
G35
/P17
33
SE
G34
/P16
34S
EG
33/P
1535
SE
G32
/P14
36S
EG
31/P
1337
SE
G30
/P12
38S
EG
29/P
1139
SE
G28
/P10
40S
EG
27/P
0741
SE
G26
/P06
42S
EG
25/P
0543
SE
G24
/P04
44S
EG
23/P
0345
SE
G22
/P02
46S
EG
21/P
01
47S
EG
20/P
00
48
SEG1652
SEG1553
SEG1454
SEG1355
VDD56
SEG1257
SEG1158
SEG1059
SEG960
SEG861
SEG762 SEG6
63SEG5
64
SO/P4420
RST19
18
17
SEG1751
SEG1850
49SEG19
R1804
100C
1801
10u/
10
R18
72
R18
73
R18
74
NM
R18
75
R18
76
R18
78
R18
77
D18
51
SM
LXA
4WB
ET
W1(
Z1)
-TR
B
UCON&LCD 1801-1820
SWITCH&CONNENCTOR 1821-1850
LED 1851-1900
FRONT AUX 1901-1910
USB IN 1911-1920
DISP
SEG36/P20SEG37/P21SEG38/P22
SI/P43INT1/PWC/P42
LEFT RIGHT
2
5
1
LIST BAN
6
SRC
UP
EJECT
DO
4.9V
CAW1964-
CSS1731-
TA/AF:UW5CLOCK:OTHERS
A
B
C
D
E
DVH-3200UB/XNUW5
DVH-3220UB/XNUW5
DVH-3250UB/XNRC
DVH-3250UB/XNRD
DVH-3250UB/XNRI
DVH-3290UB/XNIDF
DVH-3200UB/XNUW5 101
5 6 7 8
5 6 7 8
C
D
F
A
B
E
B
CKN1082-
ROTARY
USB
FRONT_AUX
BL RE/GR
ILMCLR
COLOR 1COLOR 2
R1870 Q1851
ILMCLR
R1869 R1871
RS1/10SR0R0J
RS1/10SR0R0J
RS1/10SR0R0J
RS1/10SR0R0J
NM
*1
KD
T2
AU
XV
/SO
UR
CE
KD
T3 ILMGND
DGND
DGND
S1830
1 2
S18341 2
S1842
1 2
R18
68R
1867
R1870
ILMGND
D18
88D
1889
D18
70
D18
68
D18
69D18
64D
1866
D18
65
D18
60
D18
63D
1862
D18
56
D18
59D
1858
D18
57
R18
22
NM
Q1851
IMX1
1E6
1B5
2C42E
3
22B
11C
DGND
D18
52
D18
55
D18
54D
1853
R18
66
R1901
100
R1902
100
C19
01
4700
p/50
L191
11
12
2
33
44
D19
12
D19
11
R1805 2.2k
R1806 2.2k
R18
69
VA
1901
EZ
JZ1V
270R
MV
A19
02
EZ
JZ1V
270R
M
VA
1903
EZ
JZ1V
270R
M
C19
03
NM
C19
04
NM
C19
05
NM
S1828
1 2
S1827
1 2D
1802
MC
2846
-11
D18
01
MC
2848
-11
DGND
D18
67
S1837
1 2
R18
52
R18
54
R18
56
R18
57
R18
65 NM
R18
53
CN1821
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
R18
71
VA
1904
EZ
JZ1V
270R
M
D18
61
R18
58
R18
55
C18
69
NM
C18
70
NM
S1843
1 2
S1840
1 2
S18331 2
S1829
1 2
S1844
1 2
CN19011
2
3
4
S1845
11
22
33
44
55
R18
78
C19
02
4700
p/50
R18
21
10k
CN1911YKS5036-
1
2
3
4
5
R19
11 NM
R19
12 NM
DGND
ILMGND
AUXV/SOURCE
AUXR
AUXGND
AUXL
SWVDD
COLOR2
COLOR1
USGND
D+
D-
USB5V
ILM+B
ROT1
ROT0
KYDT
DPDT
DSEN
DISP/BACK
USGND
RIGHT
3
4
BAND/ESC
DOWN
4.9V
14.2V
14.2V
4.9V
DZ
2S06
8C-T
DZ
2S06
8C-T
CT
F17
13-
CSD1153-
TA/AF:UW5CLOCK:OTHERS
CKS6049-
ACN701
B KEYBOARD UNIT
AUX:+2.2dBm
DVH-3200UB/XNUW5102
1 2 3 4
1 2 3 4
C
D
F
A
B
E
10.3 DVD CORE UNIT (GUIDE PAGE)
C
C-a
A9
A4
A10
A5
A11
A6
A12
A7
A13
A8
A14
A15
D15
D7
D14
D6
D13
D5
D12
D4
D11
D3
D10
D2
D9
D1
D8
A3
A2
A1
XRD
A16
A5
A10
A4
A9
A1
A2
A3
A16A15
A14
A8
A13
A7
A12
A6
XRD
A11
A19
XWR1
A18
A17 A17
A19
A18
MDQ7
MDQ6
MDQ5
MDQ15
MDQ14
MA9
MA8
MA7
MA6
MA5
MA4
DQM0
XWE
XCAS
XRAS
XCSM
BA1
MA10
BA0
MA0
MA1
MA2
MA3
MCK
MA11
MD
Q15
MD
Q0
MD
Q14
MD
Q1
MDQ13
MDQ2
MDQ12
MDQ3
MDQ11
MDQ4
MDQ10
MDQ5
MDQ7
MDQ6
DQM1
DQM0
MDQ9
MDQ8
XWE
MA9
XRAS
BA0
XCAS
XCSM
MA7
MA0
MA1
MA10
MA8
BA1
MA6
MA3
MA5
MA4
MA2
A0
XC
SF
2
XR
D
A16
XW
R1
A19
A1
A17
A6
A3
A5
A2
A4
A7
FD
TD
XCSF1
D0
D8
D1
D9
D10
D2
D3
D4
D5
D11
D14
D13
D12
D7
D15
D4
D12
D5
D13
D6
D14
D7
D15
D10
D3
D11
D0
D8
D1
D9
D2
D6
A10
A8
A11
A9
LOUT
ROUT
SD
OD
AC
SC
KD
AC
LTD
AC
A12
IEC
OU
T
A0
MA11
TR
CD
AT
A3
SC
LOC
K
TR
CD
AT
A0
TR
CC
LK
TR
CD
AT
A1
TR
CS
T
TR
CD
AT
A2
SD
AT
A
A0
C
C
C
MCK
CO
MP
OS
ITE
XCSF2
FE
1
FE
2
EX
TR
G0
A15
A14
A13
A18
TE
MP
DQM1
COILU
COILV
COILW
MD
LDIN TOM
FOP
FOM
TOP
CONT1
CONT2
FG
CRGDRV
HWP
HVM
HVP
HUM
HUP
HWM
HBM
XWR1
NRESNRES
TD
FD
STANDBY
MDQ13
MDQ9
MDQ10
MDQ11
MDQ12
MDQ8
MDQ1
MDQ3
MDQ2
MDQ4
MDQ0
A20
A20
D+
D-
D0
DGND3
DGND2
IEC
GNDD
GNDD
GNDA
GNDA
GNDD
GNDD
GNDD
GNDD
GNDD
R14
05
100K
R1503
1M
R1406100K
R14
02
100K
C16
71
R1
C16
72
R1
C1487R1
C1481R1
C1674R1
C1480 R1
C16
03
100P
C1482R1
C1484 R1
C1509
R1
C1488R1
C16
02
100P
C1408R1
C1403R1
C1407
NMC1402
NM
C15
0210
C14044R7
C14094R7
C16
76
1
C1503 R1
VCC33
VCC12
VCC33
C1485
R1
C1504
R1
C1505
R1
C1506
R1
C1507
R1
C1508
R1
C15
18R
1
C15
19R
1
C15
14
R1
C15
11
R1
C15
13R
1
C15
16R
1
C15
17R
1
C15
15
R1
C18
05R
1
PC
M17
53D
BQ
IC18
01
BC
K1
DA
TA2
LRC
K3
DG
ND
45N
C
6V
CC
7V
OU
TL
8V
OU
TR9
AG
ND
10V
CO
M11
ZER
OR
/ZE
RO
A
12ZE
RO
L/N
A13
MD
14M
C15
ML
16S
CK
2081C
7R4
GNDAU1
R1804
820
R1803
820
C1801
4R7
R18
02
100K
C18
04
1800
P
R18
01
100K
C18
03
1800
P
GNDAU
C18
09
R1
GNDD
AV
CC
5
GNDAU
VCC33
C15
0110
GNDD
CN1951
1 2 3 4 5 6 7 8 9 1011
121314151617181920
GNDD
VCC33
TE
MP
PGND
GNDV
GNDD
R1954
15K
R195515K
C1601
R01
R1603
10K
R15
1710
K
R15
1810
K
C1673
R1
C1491 NM
C1492 NM
C1493 NM
C1494 NM
R15
2810
KR
1529
10K
R15
3010
K
R15
3110
K
C18
07
NM
R1217
1R1218
1
R12131
R1214
1R1215
1R1216
1
PGND
PGND1PGND2
VHALFVHALF
VD8
PGND
100/
16C
1201
FG
R1202 220
R1201 220
L190
1N
M
11
22
33
44
D1902NM
D1901NM
GNDD
C14
89
10
R1538
100K
R15
42
R1602
12K
R1601
12K
C16
04
68P
C16
05
68P
GNDD
VCC33
C1483 NM
C1486
NM
C14
05
NM
R1212
270
AD2
AD
OU
T
CONT2
CONT1
CRGDRV
DA
CC
K
FD1
LDIN
LRC
K
LTD
AC
MD1 MD2
SC
KD
AC
SD
OD
AC
SR
CK
TD1
XWR1
C1204
2200P
GN
DD
5
R1403
NM
R1203
10K
R1204
15K
FOM2
FOP2
TOM2
TOP2
R15
3910
0K
R15
01
1R2K
R1679
NM R1675
NM
R1673
NM
GNDD
R15
0510
0
R15
0610
0
R15
0710
0
L1904
C14
90
R00
1
C12
114R
7
R1401
220
C14
01
R01
R19
50
240
R19
51
240
C1512
10P
C1510
12P
C1203
NM
C1205R1
C1207R1
C12
10R
1
C1209
R1
R15
08 220
R1512
100
C1208R01
C15
25
R148356
2
1
4
36
5
8
7
R1487
56
2
1
4
36
5
8
7
R148656
2
1
4
36
5
8
7
R148856
2
1
4
36
5
8
7
R148156
2
1
4
36
5
8
7
R148056
2
1
4
36
5
8
7
R148456
2
1
4
36
5
8
7
R148256
2
1
4
36
5
8
7
R148556
2
1
4
36
5
8
7
R1490
56
R148956
C180610
R15
276R
8KR
1546
6R8K
R19
560R
0
R19
570R
0
R15
47
NM
R1409NM
IC1201BD8231EFV
1VC
2 TKIN
3 FCIN
4SLIN
5SLOPOUT
6LDIN
7SPIN
8CTL1
9CTL2
10 GND1
11 TEST
12 FG
13SPCNF
14HB
15HW-
16HW+
17HV-
18HV+
19HU-
20HU+
21VM_S
22BH
23SPRNF
24SPVM
25SPGND
26U
27V
28W
29SLVM
30PGND
31SL/LDO+
32SL/LDO-
33FCO+
34FCO-
35TKO+
36
TKO- 37AVM
38PREVcc
39PREGND
40SUBGND
41GND2
MN2DS0018MAUBIC1501
EX
DT
1
1
EX
DT
9
2
EX
DT
23
EX
DT
104
VS
S_1
5
VD
D33
_16
EX
DT
37
EX
DT
118
EX
DT
49
EX
DT
1210
EX
DT
511
EX
DT
1312
EX
DT
613
EX
DT
1414
VS
S_2
15
VD
D33
_216
EX
DT
717
EX
DT
1518
VS
S_3
19
VD
D12
_120
EX
AD
R16
21
EX
AD
T15
22
EX
AD
T14
23
EX
AD
T13
24
EX
AD
T12
25
EX
AD
T11
26
EX
AD
T10
27
EX
AD
T9
28
EX
AD
T8
29
EX
AD
R19
30
NE
XW
E31
VS
S_4
32
VD
D33
_333
EX
AD
R18
34
EX
AD
R17
35
EX
AD
T7
36
EX
AD
T6
37
EX
AD
T5
38
EX
AD
T4
39
EX
AD
T3
40
EX
AD
T2
41
EX
AD
T1
42
VS
S_5
43
VD
D12
_244 45 46 47
IRQ
PW
R48 49
VIN
611
4
115
116
VIN
311
7V
IN4
118
VIN
211
9V
IN1
120
VD
SE
NS
121
TE
MP
122
AD
212
3A
D4
124
AV
SS
H12
5T
D12
6F
D12
7A
VD
DH
128
DA
C3O
UT
129
DA
C2O
UT
130
DA
C1O
UT
131
AV
DD
F13
2C
OM
P1
133
VR
EF
134
IRE
F1
135
CO
MP
213
6A
VS
SF
137
CO
MP
OS
ITE
138
DA
C5O
UT
139
AV
SS
E14
0A
VD
DE
141
AV
DD
G14
2A
VS
SG
143
LOU
T14
4
145
AV
SS
I
146
RO
UT
147
AV
DD
I
148
DA
CC
K
149
SR
CK
150
LRC
K
151
AD
OU
T
152
IEC
OU
T
153
VS
S_9
154
VD
D33
_6
155
OS
CI
156
OS
CO
157
VS
S_1
0
158
VD
D12
_4
159
MD
Q15
160
MD
Q0
161
MD
Q14
162
MD
Q1163
MDQ13164
MDQ2165VSS_11166VDD33_7
167MDQ12
168MDQ3
169MDQ11
170MDQ4
171MDQ10
172MDQ5
173VSS_12
174VDD33_8
175MDQ9
176MDQ6
177MDQ8
178MDQ7
179DQM0
180DQM1
181NWE
182VSS_13
183MCK
184VDD33_9
185MCKI
186VSS_14
187VDD12_5
188NCAS
189NRAS
190NCSM
191
192DQM3
193BA0
194MA9
195VSS_15
196VDD33_10
197BA1
198MA8
199MA10
200MA7
201MA0
202MA6
203MA1
204VSS_16
205VDD33_11
206MA5
207MA2
208MA4
209MA3
210VSS_17
211VDD12_6
212EXADT0
213NEXCE
214 NEXOE215 EXDT0
216EXDT8
X1501CSS1768
X11
GND12
GND24 X2 3
L1512
IC1480
K4S641632N-LC75
VDD11
DQ02
VDDQ13
DQ14
5DQ2
6VSSQ1
7DQ3
8DQ4
9VDDQ2
10DQ5
11DQ6
12VSSQ2
13DQ7
14VDD2
15LDQM
16WE
17CAS
18RAS
19CS
20BA0
21BA1
22A10/AP
23A0
24A1
25A2
26A3
27VDD3
28VSS1
29A4
30A5
31A6
32A7
33A8
34A9
35A11
36N.C
37CKE
38CLK
39UDQM
40N.C/RFU
41VSS2
42DQ8
43VDDQ3
44DQ9
45DQ10
46VSSQ3
47DQ11
48DQ12
49VDDQ4
50DQ13
51DQ14
52VSSQ4
53DQ15
54VSS3
R15
04 12
C1808
NM
IC1401
CWW1753
A151
A142
A133
A124
5A11
6A10
7A9
8A8
9A19
10NC1
11/WE
12 /RESET13
NC214
NC315 RY_/BY16
A1817
A1718
A719
A620
A521
A422
A323
A224
A125
A0
26/CE
27Vss1
28/OE
29DQ0
30DQ8
31DQ1
32DQ9
33DQ2
34DQ10
35DQ3
36DQ11
37Vcc
38DQ4
39DQ12
40DQ5
41DQ13
42DQ6
43DQ14
44DQ7
45DQ15_A-1
46Vss2
47/BYTE
48A16
IC1402
CWW1754
A151
A142
A133
A124
5A11
6A10
7A9
8A8
9A19
10NC1
11/WE
12 /RESET13
NC214
NC315 RY_/BY16
A1817
A1718
A719
A620
A521
A422
A323
A224
A125
A0
26/CE
27Vss1
28/OE
29DQ0
30DQ8
31DQ1
32DQ9
33DQ2
34DQ10
35DQ3
36DQ11
37Vcc
38DQ4
39DQ12
40DQ5
41DQ13
42DQ6
43DQ14
44DQ7
45DQ15_A-1
46Vss2
47/BYTE
48A16
R15
110R
0
R1670
10K
R16
72
200
R1671
24K
R16
74
30K
FLASH 16M
(212
5)
(2125)(2125)
FLASH 16M
(IE
C/IP
FLG
)
SDRAM
(160
8)
(2125)
(2125)
AUDIO 2CH ANALOG OUT
ADAC
(212
5)
DEBUG
(212
5)
CP
_RE
AD
Y
I2C
_SD
A
I2C
_SC
L
08E
J
STANDBY
VIN
8
VIN
7
(321
6)
27.000MHz
24
T
T
F
F
F
T
T
F
TF
S
C
C
C
S
S
S
DVH-3200UB/XNUW5 103
5 6 7 8
5 6 7 8
C
D
F
A
B
E
C
C-b
DVDMPD
FE1
A1
A3
A5
A2
A4
SCLOCK
SDATA
TRCCLK
TRCDATA0
TRCDATA1
TRCDATA2
TRCDATA3
B
C
A
D
LPCO1
LPCO2
FD
TD
CDMPD
STANDBY
STSCOMN
SCKDAC
COILV
COILU
COILW
HVM
HVP
HWM
HUP
HUM
HBM
XCSF1
E+G_E+F
F+H_G+H
B
A
FE2
TEMP
RF
F+
H_G
+H
E+
G_E
+F
RF
CDMPD
CRGDRV
MD
FG
FE
1
FE
2
NRESNRES
LTDAC
SDODAC
TOP
EXTRG0
TE
MP
AMUTE
C
D
LDIN
CONT2
CONT1
CMDCOMN
VDSENS
VDSENS
HWP
FOM
FOP
U
V
W
HOME
NRES
IRQPWR
CMDCOMN
STSCOMN
ROUT
D-
D+
IECOUT
LOUT
AMUTE
08EJ
TRCST
TOM
I2C_SCL
I2C_SDA
CP_Reset
I2C_SCL
I2C_SDA
IRQPWR
COMPOSITE
HOME
08EJ
A20
CP_Reset
DVDMPD
DVDLD1
AGND3
VCC5_3
GNDAGNDD
GNDA
GNDA
GNDA
GNDA
R11
03
390
R11
04
510
R11
0110
0K
C11
06
R01
C16
03
100P
C16
06
R1C
1602
100P
VCC33
VCC5
Q11012SC4081
C15
19R
1
C15
20
R1
R1509 1K
R1510 1KSDATA
SCLOCK
C1521 R1
C1622 R033
GNDA
C1620 R22
GNDA
C1624
R1
C1625
R1
C1621 R22
ANAMONI1
ANAMONI2
C1619 5600P
C1618 100P
C1616 R1
C1617 R1
GNDA
C1612 R1
C1614 R1
C1615 R1
C1613 R1
C1611 R1
C1610 R1
GNDA
C1609 R1
VREF
VREF
C16231
C16081
VHALFR1232D121B
IC1005
PGND1
VIN2
VDD3
CE45
VOUT
6TEST
7AGND
8LX
L1004
FB12A
VCC12
C10
102R
2
C10
11 1
R10
02
100
VCC33-1
VCC33
VDD5VCC12-1
FB12B
DDF
VCC33
IC1001
NM
OUT1
VDD2
NC3
VSS4
VSENS
VD8
GNDA
DGND1
PGND
PGND4
GNDV
NRES
VDD5
VD8_1
C10
04
4R7
R1015
NM
AGND4
VCC5_1
EF1002
3
2
1
EF1001
3
2
1
PGND3
AGND1
VDD5_1
GNDAU GNDD
VDD5_2
GNDA
VCC5
GNDD
C10
011
DGND4
PGND5
GNDD
AVCC5
RO
LO
VD8
AVCC5
C1522 R1
DVDLD0
CDLD0
R1604 1M
TE
MP
PGND
GNDD
GNDD
VCC33
U-
HB+
HB-
W-
COM
COILU
V-
COP
U+
W+
V+
COILV
COILW
C1007
NM
C1006
NM
HOME
GNDD
R1017
NMGND_DD
C1110
R01
VREF
C11
08R
01
E+G_E+F
F+H_G+H
R11
0210
0K
GNDA
C11
05R
1
R11
06
560
Q11022SC4081
R11
05
390
C11
07
R01
CDLD1
DVDMPD
RF
C1601
R01
R1603
10K
CDMPD
C1523R1R1513
10K
08EJ
12EJ
IRQPWR
CMDCOMN
STSCOMN
STANBY
COMPOSITE
D+
D-
VD
C1526 R01R1523 220
R1522 100K
R1519 1K
IC1006
NM
G1
IN2
GND3
OUT4
5VCC
VD8
GNDAU
GNDAU3
GNDVGNDAU2
GNDD
C10
15
R00
1
PGND
R1536
100K
R1537
100K
R10
04
47K
R10
07
6R8K
GNDD
VD8_2
R1011
NM
GND_DD
GND_DD
GND_DCON
GND_DCON
B
A
C
D
FE1
FE2
R1217
1R1218
1
R12131
R1214
1R1215
1R1216
1
L1003
R1534
220
GNDD
C10
16
R00
1
R1540 220
AGND2
GNDA
C16
07 10
C10
03R
1
AMUTE
R1525 10K
GNDD
R19
52
1M
IC1951TC7SZU04FU
NC1
IN_A2
GND3
OUT_Y4
5VCC
C1950R1
R15
42
10K
R1524 4R7K
48M
Hz
C11
04 R1
R1602
12K
R1601
12K
C16
04
68P
C16
05
68P
R151418K
R1541 220
C10
17
NM
R1526 10K
C10
051
R1222
270
AD2
TRCST
R1026
NM
R151610K
R1300
0R0
VCC5
C1524R047
C13
02
NM
R10
21
0R0
TOP1
FOP1
R1535100KCP_RESET
RESET
SDA
SCL
R15
3910
0K
NJM
2885
DL1
-33
IC10
04
1IN
2G
ND
3O
UT
2SB1132Q1104
2SB1132Q1103
C16
26
NM
C16
27
NM
C10
18
R1
L1902
L1903
C12
114R
7
GNDDPGND
C1019
R1
R19
53
680
C12
10R
1
C1528470P
WAKEUP
R1019100
R1025100
R1027100
C15
29
NM
GNDAU
C19
5210
P
C19
51
10P
C15
25
NM
C1527
NM
R11
103R
3R
1109
3R3
C11
11
R22
C11
09R
22
R1008
NM
R10
01
NM
C1953
NM
C1954
47P
10C
1101
R15
276R
8KR
1546
6R8K
R1301
NM
R15
47
NM
CN19011
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
CN1201
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
EX
AD
T5
38
EX
AD
T4
39
EX
AD
T3
40
EX
AD
T2
41
EX
AD
T1
42
VS
S_5
43
VD
D12
_244 45 46 47
IRQ
PW
R48 49
US
B_C
LOC
K50
VS
S_6
51
VD
D33
_452
CM
DC
OM
N53
ST
SC
OM
N54
12EJ55
LTDAC 56SDODAC 57SCKDAC
58XCSSR
59P13
60
61
62CONT1
63CONT2
64
65MD
66CRGDRV
67VSS_7
68VDD33_5
69NRES
70FG
71SCLOCK
72SDATA
73EXTRG0
74EXTRG1
75TRCCLK
76TRCDATA0
77TRCDATA1
78TRCDATA2
79TRCDATA3
80TRCST
81VSS_8
82VDD12_3
83AVDDD
84PLFIL1
85VREFH7
86AVSSD
87VREFL7
88AVSSC
89CCAPA
90CDATA
91AVDDC
92ANAMONI1
93ANAMONI2
94RFINN
95RFINP
96VIN1RF
97VIN2RF
98VIN4RF
99VIN3RF
100VREFH5
101VREFL5
102DVDMPD
103LPCO1
104CDMPD
105LPCO2106AVDDB
107AVSSB
108
VR
EF
H10
9
VH
ALF
110
E+
G_E
+F
111
F+
H_G
+H
112
VIN
511
3V
IN6
114
115
116
VIN
311
7V
IN4
118
VIN
211
9V
IN1
120
VD
SE
NS
121
TE
MP
122
AD
212
3A
D4
124
AV
SS
H12
5
IC1003
S-1200B50-M5
VIN1
VSS2
ON/OFF3
NC4
5VOUT
X1950
CSS1760X1
1GND1
2
GND24 X2 3
C13
01
NM
CN11011
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
R1532100
C1014
10C10
0910
C1013
10
C10
0810
C10
12
NM
R1543 180
R1544 180R1533
NM
C11
12
22
C11
13
22
IC1002S-1133B50-U5
NC1
VSS2
ON/OFF3
VIN4
5VOUT
CP_READY
R1114
1R5
R1111
1R5
R1112
1R5
R1115
1R5
R1116
1R5
R1117
1R5
R1113
1R5
R1118
1R5
R16051M
GNDDGNDD
LPCO1
LPCO2
PU(DP10)
(160
8)
(160
8)
(1608*4)
(1608*4)
(1608)
DEBUG
MOTOR DRIVER
12cm(DSCSNS)
8cm
5.0-3.3&1.2 V DC/DC
VOLTAGE DETECT
(160
8)
VD5
HOST I/F
AMUTE
ANALOG ROUT
(212
5)
STANBY
(160
8)PGND
COMPOSIT
(3216)
HSTCMD
SLVSTS
PGND
XRESET
AGND
VD8
DGND
ANALOG LOUT
IRQPWR
VD8
AGND
VIDEO GND
AGND
D-
D+
DGND
COIL_U
HALL_V+
HALL_V-
HALL_U-
HALL_W+
GNDD
HALL_U+
COIL_V
HALL_W-
HALL_BIAS+
HALL_BIAS-
COIL_W
HOME
CRG/LE+
CRG/LE-
XL
H
LZ
G OUT
HL
<TC7SZ126FU>
H
IN
VD8
F+
T-
LD GND
F-
FE2
B
A
T+
78LD
C
RF
78MDG
SW
65LD
E+G/E+F
GND
D
F+H/G+H
VCC
65MDG
FE1
:PU1200->12991100->1199
:FLASH:SDRAM1480->1499
1850->1899
1670->1699 :DVN(BE)
:DVN(SYS)
:VIDEO
1900->1950
1500->1599
:AUDIO (DIGITAL)
1400->1449
1000->1049
1800->18491700->1749
:ACT+SPDL
:POWER SUPPLY
:OUTSIDE I/F
:AUDIO (ANALOG)
1600->1669 :DVN(FE)
1950->1999
(2125)
Vref
78MD
65MD
TEMP
TEMP GND
IECOUT
DGND
(1608)
(1608)
H
(1608)
LDIN
HOME
:USB
GNDD
(212
5)
CP_Reset
CP
_RE
AD
Y
I2C
_SD
A
I2C
_SC
L
08E
J
VIN
8
VIN
7
RESET
SDA
SCL
(321
6)
(1608)
(1005)
WAKEUP
DGND
USB
48.000MHz
X:Don’t CareZ:High Impedance
GNDD
C1021
680P
C1022680P
GNDV
C1934
68P
CD
DVD
C DVD CORE UNIT
ACN101
PIC
KU
P U
NIT
(SE
RV
ICE
)
DCN701
1
3
F FOCUS SERVO LINETRACKING SERVO LINECARRIAGE SERVO LINESPINDLE SERVO LINERF SIGNAL
T
C
S
F
F
T
T
T
F
C
C
C
S
S
S
S
DVH-3200UB/XNUW5104
1 2 3 4
1 2 3 4
C
D
F
A
B
E
C-a
C-b
C-b
SC
LOC
K
SD
AT
A
TR
CC
LK
TR
CD
AT
A0
TR
CD
AT
A1
TR
CD
AT
A2
TR
CD
AT
A3
B CA D
LPC
O1
LPC
O2
FD
TD
CD
MP
D
F+H_G+H
E+G_E+F
RF
CR
GD
RV
FG
FE1
FE2
NR
ES
NR
ES
EX
TR
G0
TEMP
AM
UT
E
VD
SE
NS
VD
SE
NS
NR
ES
AM
UT
E
TR
CS
T
DV
DM
PD
GN
DA
GN
DD
GN
DA
C1603
100P
C1606
R1
C1602
100P
VC
C33
R15
091K
R15
101K
SD
AT
A
SC
LOC
K
C15
21R
1
C16
22R
033 G
ND
A
C16
20R
22
GN
DA
C16
24
R1
C16
25
R1
C16
21R
22
AN
AM
ON
I1
AN
AM
ON
I2
C16
1956
00P
C16
1810
0P
C16
16R
1
C16
17R
1
GN
DA
C16
12R
1
C16
14R
1
C16
15R
1
C16
13R
1
C16
11R
1
C16
10R
1
GN
DA
C16
09R
1
VR
EF
VR
EF
C16
231
C16
081
VH
ALF
R12
32D
121B
IC10
05
PG
ND
1
VIN
2
VD
D3
CE
45
VO
UT
6T
ES
T
7A
GN
D
8LX
L100
4
FB
12A
VC
C12
C10102R2
C10111
R1002
100 VC
C33
-1
VC
C33
VD
D5
VC
C12
-1
FB
12B
DD
F
VC
C33
IC10
01
NM
OU
T1
VD
D2
NC
3VS
S4
VS
EN
S
VD
8
GN
DA
DG
ND
1
PG
ND
PG
ND
4
GN
DV
NR
ES
VD
D5
VD
8_1
C1004
4R7
R10
15
NM
AG
ND
4
VC
C5_
1
EF
1002
3
2
1
EF
1001
3
2
1
PG
ND
3
AG
ND
1
VD
D5_
1
GN
DA
UG
ND
D
VD
D5_
2
GN
DA
VC
C5
GN
DD
C1001
1
DG
ND
4
PG
ND
5
GN
DD
AV
CC
5
VD
8
AV
CC
5
C15
22R
1
R16
041M
C10
07
NM
C10
06
NM
GN
DD
R10
17
NM
GN
D_D
D
C16
01
R01
C15
23R
1R
1513
10K
VD
C15
26R
01R
1523
220
R15
2210
0K
VD
8
C1015
R001
PG
ND
R1004
47K
R1007
6R8K
GN
DD
VD
8_2
R10
11
NM
GN
D_D
D
GN
D_D
D
GN
D_D
CO
N
GN
D_D
CO
N
L100
3
GN
DD
C1016
R001
AG
ND
2
GN
DA
C1607
10
C1003R1
AM
UT
E
R15
244R
7K
R16
02
12K
R16
01
12K
C1604
68P
C1605
68P
C1017
NM
C1005
1
TR
CS
T
R15
1610
K
NJM2885DL1-33
IC1004
1IN
2GND
3OUT
C1626
NM
C1627
NM
C1018
R1
L190
2
L190
3
GN
DD
PG
ND
C10
19
R1
R10
1910
0
GN
DA
U
R10
08
NM
R1001
NM
C19
53
NM
C19
54
47P
CN
1901
1 2 3 4 5 6 7 8 9 10 1167
VS
S_7
68V
DD
33_5
69N
RE
S70
FG
71S
CLO
CK
72S
DA
TA
73E
XT
RG
074
EX
TR
G1
75T
RC
CLK
76T
RC
DA
TA
077
TR
CD
AT
A1
78T
RC
DA
TA
279
TR
CD
AT
A3
80T
RC
ST
81V
SS
_882
VD
D12
_383
AV
DD
D84
PLF
IL1
85V
RE
FH
786
AV
SS
D87
VR
EF
L788
AV
SS
C89
CC
AP
A90
CD
AT
A91
AV
DD
C92
AN
AM
ON
I193
AN
AM
ON
I294
RF
INN
95R
FIN
P96
VIN
1RF
97V
IN2R
F98
VIN
4RF
99V
IN3R
F10
0V
RE
FH
510
1V
RE
FL5
102
DV
DM
PD
103
LPC
O1
104
CD
MP
D10
5LP
CO
210
6A
VD
DB
107
AV
SS
B
108
VREFH109
VHALF110E+G_E+F111F+H_G+H
112VIN5
113VIN6
114
115
116VIN3
117VIN4
118VIN2
119VIN1
120VDSENS
121TEMP
122
IC10
03
S-1
200B
50-M
5
VIN
1
VS
S2
ON
/OF
F3
NC
45V
OU
T
C10
14
10
C100910
C10
13
10
C100810
C1012
NM
IC10
02S
-113
3B50
-U5
NC 1
VS
S 2
ON
/OF
F 3V
IN 4 5VO
UT
R16
051M
GN
DD
GN
DD
(160
8)
DE
BU
G
5.0-
3.3&
1.2
V D
C/D
C
VO
LTA
GE
DE
TE
CT (1608)
VD
5
HO
ST
I/F A
MU
TE
(2125)
(1608)
PG
ND
(321
6)
HS
TC
MD
PG
ND
XR
ES
ET
VD
8
DG
ND
IRQ
PW
R
VD
8
VD
8
:PU
1200
->12
9911
00->
1199
:FLA
SH
:SD
RA
M14
80->
1499
1850
->18
99
1670
->16
99
:DV
N(B
E)
:DV
N(S
YS
)
:VID
EO
1900
->19
50
1500
->15
99
:AU
DIO
(D
IGIT
AL)
1400
->14
49
1000
->10
49
1800
->18
4917
00->
1749
:AC
T+S
PD
L
:PO
WE
R S
UP
PLY
:OU
TS
IDE
I/F
:AU
DIO
(A
NA
LOG
)
1600
->16
69
:DV
N(F
E)
1950
->19
99
(212
5)
(160
8)
(160
8)
(160
8)
:US
B
(2125)
VIN8
VIN7
(160
8)
(100
5)
US
B
GN
DD
C10
21
680P
C10
2268
0PC
1934
68P
CD
VD
CO
RE
UN
IT
A
FF
OC
US
SE
RV
O L
INE
TR
AC
KIN
G S
ER
VO
LIN
EC
AR
RIA
GE
SE
RV
O L
INE
SP
IND
LE S
ER
VO
LIN
ER
F S
IGN
AL
T C S
T
C
DVH-3200UB/XNUW5 105
5 6 7 8
5 6 7 8
C
D
F
A
B
E
C-a
C-b
C-b
DV
DM
PD
FE
1
A1
A2
SC
LOC
K
SD
AT
A
TR
CC
LK
ST
AN
DB
Y
ST
SC
OM
N
SC
KD
AC
CO
ILV
CO
ILU
CO
ILW
HV
M
HV
P
HW
M
HU
P
HU
M
HB
M
XC
SF
1
E+G
_E+F
F+H
_G+H
B A FE
2
TE
MP
RF
CD
MP
D
CR
GD
RV
MD
FG
NR
ES
NR
ES
LTD
AC
SD
OD
AC
TO
P
EX
TR
G0
AM
UT
E
C D
LDIN
CO
NT
2
CO
NT
1
CM
DC
OM
N
HW
P
FO
M
FO
P
HO
ME
NR
ES
IRQ
PW
R
CM
DC
OM
N
ST
SC
OM
N
RO
UT
D- D+
IEC
OU
T
LOU
T
AM
UT
E
08E
J
TO
M
I2C
_SC
L
I2C
_SD
A
CP
_Res
et
I2C
_SC
L
I2C
_SD
A
IRQ
PW
R
CO
MP
OS
ITE
HO
ME
08E
J
A20
CP
_Res
et
DV
DLD
1
AG
ND
3
VC
C5_
3
GN
DA
GN
DD
GN
DA
GN
DA
GN
DA
R1103
390
R1104
510
R1101100K
C1106
R01
VC
C5
Q11
012S
C40
81
C1519R1
C1520
R1
R15
091K
R15
101K
SD
AT
A
SC
LOC
K
GN
DA
NR
ES
VD
D5
R10
15
NM
AG
ND
4
EF
1002
3
2
1
AG
ND
1
VD
D5_
1V
DD
5_2
GN
DD
DG
ND
4
GN
DD
RO
LO
C15
22R
1
DV
DLD
0
CD
LD0
PG
ND
GN
DD
GN
DD
VC
C33
U-
HB
+
HB
-W-
CO
M
CO
ILU V
-
CO
PU+
W+
V+
CO
ILV
CO
ILW
HO
ME
C11
10
R01
VR
EF
C1108R01
E+G
_E+F
F+H
_G+H
R1102100K
GN
DA
C1105R1
R1106
560
Q11
022S
C40
81
R1105
390
C1107
R01
CD
LD1
DV
DM
PD
RF
CD
MP
D
C15
23R
1R
1513
10K
08E
J
12E
J
IRQ
PW
R
CM
DC
OM
N
ST
SC
OM
N
ST
AN
BY
CO
MP
OS
ITE
D+
D-
C15
26R
01R
1523
220
R15
2210
0K
R15
191K
IC10
06
NM
G1
IN2
GN
D3
OU
T45
VC
C
GN
DA
U
GN
DA
U3
GN
DV
GN
DA
U2
GN
DD
PG
ND
R15
36
100K
R15
37
100K
B A C D
FE
1
FE
2
R12
17
1R
1218
1
R12
131
R12
14
1R
1215
1R
1216
1
R15
34
220
GN
DD
C1016
R001
R15
4022
0
AM
UT
E
R15
2510
K
GN
DD
R1952
1M
IC19
51T
C7S
ZU
04F
UNC
1
IN_A
2
GN
D3
OU
T_Y
45V
CC
C19
50 R1
R1542
10K
R15
244R
7K
48MHz
C1104
R1
R15
1418
K
R15
4122
0
R15
2610
K
R12
22
270
R10
26
NM
R15
1610
K
R13
00
0R0
VC
C5
C15
24R
047
C1302
NM
R1021
0R0
TO
P1
FO
P1
R15
3510
0KC
P_R
ES
ET
RE
SE
T
SD
A
SC
L
R1539100K
2SB
1132
Q11
04
2SB
1132
Q11
03
L190
3
C12114R7
R1953
680
C1210R1
C15
2847
0P
WA
KE
UP
R10
1910
0
R10
2510
0
R10
2710
0
C1529
NM
C195210P
C1951
10P
C1525
NM
C15
27
NM
R11103R3
R11093R3
C1111
R22
C1109R22
10C1101
R15276R8K
R15466R8K
R13
01
NM
R1547
NM
2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
CN
1201
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
EXADT241
EXADT142
VSS_543
VDD12_244
45
46
47
IRQPWR48
49
USB_CLOCK50
VSS_651
VDD33_4 52CMDCOMN 53STSCOMN
54
12E
J55
LTD
AC
56S
DO
DA
C57
SC
KD
AC
58X
CS
SR
59P
13606162
CO
NT
163
CO
NT
26465
MD
66C
RG
DR
V67
VS
S_7
68V
DD
33_5
69N
RE
S70
FG
71S
CLO
CK
72S
DA
TA
73E
XT
RG
074
EX
TR
G1
75T
RC
CLK
76T
RC
DA
TA
0
X19
50
CS
S17
60X
11
GN
D1
2
GN
D2
4X
23
C1301
NM
CN
1101
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
R15
3210
0
R15
4318
0
R15
4418
0R
1533
NM
C1112
22
C1113
22
CP
_RE
AD
Y
R11
14
1R5
R11
11
1R5
R11
12
1R5
R11
15
1R5
R11
16
1R5
R11
17
1R5
R11
13
1R5
R11
18
1R5
LPC
O1
LPC
O2
PU
(DP
10)
(1608)
(1608)
(160
8*4)
(160
8*4)
MO
TO
R D
RIV
ER
12cm
(DS
CS
NS
)
8cm
VD
5
AM
UT
E
AN
ALO
G R
OU
T
ST
AN
BY
PG
ND
CO
MP
OS
IT
(321
6)
HS
TC
MD
SLV
ST
S
PG
ND
XR
ES
ET
AG
ND
VD
8
DG
ND
AN
ALO
G L
OU
T
IRQ
PW
R
AG
ND
VID
EO
GN
D
AG
ND
D-
D+
DG
ND
CO
IL_U
HA
LL_V
+
HA
LL_V
-
HA
LL_U
-
HA
LL_W
+
GN
DD
HA
LL_U
+
CO
IL_V
HA
LL_W
-
HA
LL_B
IAS
+
HA
LL_B
IAS
-
CO
IL_W
HO
ME
CR
G/L
E+
CR
G/L
E-
XL
HLZ
GO
UT
HL
<TC
7SZ
126F
U>
H
IN
VD
8
F+
T-
LD G
ND
F-
FE
2
B A T+
78LD
C RF
78M
DG
SW
65LD
E+G
/E+F
GN
D
DF+H
/G+H
VC
C
65M
DG
FE
1
Vre
f
78M
D
65M
D
TE
MP
TE
MP
GN
D
IEC
OU
T
DG
ND
H
LDIN
HO
ME
GN
DD
CP
_Res
et
CP_READY
I2C_SDA
I2C_SCL
08EJ
RE
SE
T
SD
A
SC
L
(3216)
WA
KE
UP
DG
ND
48.0
00M
Hz
X:D
on’t
Car
eZ
:Hig
h Im
peda
nce
GN
DV
CD
DV
D
AC
N10
1
PICKUP UNIT (SERVICE)
DC
N70
11
3
F F
T TCC
C S
S S S
DVH-3200UB/XNUW5106
1 2 3 4
1 2 3 4
C
D
F
A
B
E
C-b
C-a
C-a
C-b
MD
Q7
MD
Q6
MD
Q5
MD
Q15
MD
Q14
MA
9
MA
8
MA
7
MA
6
MA
5
MA
4
DQ
M0
XW
E
XC
AS
XR
AS
XC
SM
BA
1
MA
10
BA
0
MA
0
MA
1
MA
2
MA
3
MC
K
MA
11
MDQ15
MDQ0
MDQ14
MDQ1
MD
Q13
MD
Q2
MD
Q12
MD
Q3
MD
Q11
MD
Q4
MD
Q10
MD
Q5
MD
Q7
MD
Q6
DQ
M1
DQ
M0
MD
Q9
MD
Q8
XW
E
MA
9
XR
AS
BA
0
XC
AS
XC
SM
MA
7
MA
0
MA
1
MA
10
MA
8
BA
1
MA
6
FD
TD
LOU
T
RO
UT
SDODAC
SCKDAC
LTDAC
IECOUT
MA
11
MC
K
COMPOSITE
FE1
FE2
TEMP
DQ
M1
ST
AN
DB
Y
MD
Q13
MD
Q9
MD
Q10
MD
Q11
MD
Q12
MD
Q8
MD
Q1
MD
Q3
MD
Q2
MD
Q4
MD
Q0
D+
D-
IEC
GN
DA
GN
DA
GN
DD
GN
DD
R15
03
1M
C1671
R1
C1672
R1
C14
87R
1
C14
81R
1
C16
74R
1
C14
80R
1
C1603
100P
C14
82R
1
C14
84R
1
C14
88R
1
C1602
100P
C150210
C1676
1
C15
03R
1
VC
C33
VC
C12
C14
85
R1
C15
04
R1
C15
05
R1
C15
06
R1
C15
07
R1
C1514
R1
C1511
R1
C1515
R1
C1805R1
PCM1753DBQIC1801
BCK 1DATA 2LRCK 3DGND 4
5NC
6VCC
7VOUTL
8VOUTR
9 AGND
10VCOM
11 ZEROR/ZEROA
12 ZEROL/NA13
MD14
MC15 ML16
SCK
20
81
C
7R
4
GN
DA
U1
R18
04
820
R18
03
820
C18
01
4R7
R1802
100K
C1804
1800P
R1801
100K
C1803
1800P
GN
DA
U
C1809
R1
GN
DD
AVCC5
GN
DA
U
VC
C33
C150110
GN
DD
TEMP
GN
DV
GN
DD
R19
54
15K
R19
5515
K
C16
01
R01
R16
03
10K
C16
73
R1
C14
91N
M
C14
92N
M
C14
93N
M
C14
94N
M
C1807
NM
L1901NM
11 2 2
3 344D19
02NM
D19
01 NM
GN
DD
C1489
10
R15
38
100K
R16
02
12K
R16
01
12K
C1604
68P
C1605
68P
C14
83N
M
AD
2
ADOUT
DACCK
LRCK
LTDAC
SCKDAC
SDODAC
SRCK
GNDD5
R1501
1R2K
R16
79
NM
R16
75 NM
R16
73
NM
GN
DD
R1505100
R1506100
R1507100
L190
4
C1490
R001
R1950
240R1951
240
C15
12
10P
C15
10
12P
R1508220
R15
12
100
R14
8356
2 14 365 87
R14
87
56
2 14 365 87
R14
8656
2 14 365 87
R14
8856
2 14 365 87
R14
8156
2 14 365 87
R14
8056
2 14 365 87
R14
8456
2 14 365 87
R14
8256
2 14 365 87
R14
8556
2 14 365 87
R14
90
56
R14
8956
C18
0610
R19560R0
R19570R0
MN
2DS
0018
MA
UB
IC15
01
VIN6114
115
116VIN3
117VIN4
118VIN2
119VIN1
120VDSENS
121TEMP
122AD2
123AD4
124AVSSH
125TD
126FD
127AVDDH
128DAC3OUT
129DAC2OUT
130DAC1OUT
131AVDDF
132COMP1
133VREF
134IREF1
135COMP2
136AVSSF
137COMPOSITE
138DAC5OUT
139AVSSE
140AVDDE
141AVDDG
142AVSSG
143LOUT
144
145AVSSI
146ROUT
147AVDDI
148DACCK
149SRCK
150LRCK
151ADOUT
152IECOUT
153VSS_9
154VDD33_6
155OSCI
156OSCO
157VSS_10
158VDD12_4
159MDQ15
160MDQ0
161
MDQ14
162
MDQ1
163
MD
Q13
164
MD
Q2
165
VS
S_1
116
6V
DD
33_7
167
MD
Q12
168
MD
Q3
169
MD
Q11
170
MD
Q4
171
MD
Q10
172
MD
Q5
173
VS
S_1
217
4V
DD
33_8
175
MD
Q9
176
MD
Q6
177
MD
Q8
178
MD
Q7
179
DQ
M0
180
DQ
M1
181
NW
E18
2V
SS
_13
183
MC
K18
4V
DD
33_9
185
MC
KI
186
VS
S_1
418
7V
DD
12_5
188
NC
AS
189
NR
AS
190
NC
SM
191
192
DQ
M3
193
BA
019
4M
A9
195
VS
S_1
519
6V
DD
33_1
019
7B
A1
198
MA
819
9M
A10
200
MA
720
1M
A0
202
MA
620
3M
A1
204
X15
01C
SS
1768
X1
1G
ND
12
GN
D2
4X
23
L151
2
IC14
80
VD
D1
1
DQ
02
VD
DQ
13
DQ
14 5
DQ
26
VS
SQ
17
DQ
38
DQ
49
VD
DQ
210
DQ
511
DQ
612
VS
SQ
213
DQ
714
VD
D2
15LD
QM
16W
E17
CA
S18
RA
S19
CS
20B
A0
21B
A1
22A
10/A
P23
A0
24A
125
A2
26A
327
VD
D3
28V
SS
1
29A
4
30A
5
31A
6
32A
7
33A
8
34A
9
35A
11
36N
.C
37C
KE
38C
LK
39U
DQ
M
40N
.C/R
FU
41V
SS
2
42D
Q8
43V
DD
Q3
44D
Q9
45D
Q10
46V
SS
Q3
47D
Q11
48D
Q12
49V
DD
Q4
50D
Q13
51D
Q14
52V
SS
Q4
53D
Q15
54V
SS
3
R150412
C18
08
NM
R15110R0
R16
70
10K
R1672
200
R16
71
24K
R1674
30K
(2125)
(IEC/IPFLG)
(1608)
(212
5)
(212
5)
AU
DIO
2C
H A
NA
LOG
OU
T
AD
AC
(2125)
(2125)
ST
AN
DB
Y
VIN8
VIN7
27.0
00M
Hz
T
F
T
F
DVH-3200UB/XNUW5 107
5 6 7 8
5 6 7 8
C
D
F
A
B
E
C-a
C-b
C-b
C-a
A9
A4
A10
A5
A11
A6
A12
A7
A13
A8
A14
A15
D15 D
7
D14 D
6
D13 D
5
D12 D
4
D11 D
3
D10 D
2
D9
D1
D8
A3
A2
A1
XR
D
A16
A5
A10
A4
A9
A1
A2
A3
A16
A15
A14
A8
A13
A7
A12
A6
XR
D
A11
A19
XW
R1
A18
A17
A17
A19
A18
MA
9
MA
8
MA
7
MA
6
MA
5
MA
4
XC
SM
BA
1
MA
10
BA
0
MA
0
MA
1
MA
2
MA
3
MA
11
MA
7
MA
0
MA
1
MA
10
MA
8
BA
1
MA
6
MA
3
MA
5
MA
4
MA
2
A0
XCSF2
XRD
A16
XWR1
A19
A1
A17
A6
A3
A5
A2
A4
A7
XC
SF
1
D0
D8
D1
D9
D10
D2
D3
D4
D5
D11
D14
D13
D12
D7
D15
D4
D12D
5
D13D
6
D14D
7
D15
D10D
3
D11 D
0
D8
D1
D9
D2
D6
A10
A8
A11
A9
A12
A0
TRCDATA3
SCLOCK
TRCDATA0
TRCCLK
TRCDATA1
TRCST
TRCDATA2
SDATA
A0
CCC
XC
SF
2
EXTRG0
A15
A14
A13
A18
DQ
M1
CO
ILU
CO
ILV
CO
ILW
MD
LDIN
TO
M
FO
P
FO
M
TO
P
CO
NT
1
CO
NT
2
FG
CR
GD
RV
HW
P
HV
M
HV
P
HU
M
HU
P
HW
M
HB
M
XW
R1
NR
ES
NR
ES
TD
FD
A20
A20
D0
DG
ND
3
DG
ND
2
GN
DD
GN
DD
GN
DD
GN
DD
GN
DD
R1405
100K
R14
0610
0K
R1402
100K
C15
09
R1
C14
08R
1C
1403
R1
C14
07 NM
C14
02 NM
C14
04 4R7
C14
094R
7
VC
C33
C14
85
R1
C15
07
R1
C15
08
R1
C1518R1
C1519R1
C1513R1
C1516R1
C1517R1
CN
1951
1
2
3
4
5
6
7
8
9
1011
12
13
14
15
16
17
18
19
20
GN
DD
VC
C33
PG
ND
R151710K
R151810K
R152810K
R152910K
R153010K
R153110K
R12
17
1R
1218
1
R12
131
R12
14
1R
1215
1R
1216
1
PG
ND
PG
ND
1P
GN
D2
VH
ALF
VH
ALF
VD
8
PG
ND
100/16C1201
FG
R12
0222
0
R12
0122
0
R1542
GN
DD
VC
C33
C14
86
NM
C1405
NM
R12
12
270
CO
NT
2
CO
NT
1
CR
GD
RV
FD
1
LDINMD
1M
D2
TD
1
XW
R1
C12
04
2200
P
R14
03
NM
R12
03
10K
R12
04
15K
FO
M2
FO
P2
TO
M2
TO
P2
R1539100K
C12114R7
R14
01
220
C1401
R01
C12
03 NM
C12
05R
1
C12
07R
1
C1210R1
C12
09
R1
C12
08R
01
C1525
R14
8356
2 14 365 87
R14
87
56
2 14 365 87
R14
8856
2 14 365 87
R14
8456
2 14 365 87
18
R15276R8K
R15466R8K
R1547
NM
R14
09N
M
IC12
01B
D82
31E
FV
1V
C
2T
KIN
3F
CIN
4S
LIN
5S
LOP
OU
T
6LD
IN
7S
PIN
8C
TL1
9C
TL2
10G
ND
1
11T
ES
T
12F
G
13S
PC
NF
14H
B
15H
W-
16H
W+
17H
V-
18H
V+
19H
U-
20H
U+
21V
M_S
22B
H23
SP
RN
F24
SP
VM
25S
PG
ND
26U
27V
28W
29S
LVM
30P
GN
D
31S
L/LD
O+
32S
L/LD
O-
33F
CO
+34
FC
O-
35T
KO
+36
TK
O-
37A
VM
38P
RE
Vcc
39P
RE
GN
D40
SU
BG
ND
41G
ND
2
EXDT1
1
EXDT9
2
EXDT23
EXDT104
VSS_15
VDD33_16
EXDT37
EXDT118
EXDT49
EXDT1210
EXDT511
EXDT1312
EXDT613
EXDT1414
VSS_215
VDD33_216
EXDT717
EXDT1518
VSS_319
VDD12_120
EXADR1621
EXADT1522
EXADT1423
EXADT1324
EXADT1225
EXADT1126
EXADT1027
EXADT928
EXADT829
EXADR1930
NEXWE31
VSS_432
VDD33_333
EXADR1834
EXADR1735
EXADT736
EXADT637
EXADT538
EXADT439
EXADT340
EXADT241
EXADT142
VSS_543
VDD12_244
45
46
47
IRQPWR48
49
MA
919
5V
SS
_15
196
VD
D33
_10
197
BA
119
8M
A8
199
MA
1020
0M
A7
201
MA
020
2M
A6
203
MA
120
4V
SS
_16
205
VD
D33
_11
206
MA
520
7M
A2
208
MA
420
9M
A3
210
VS
S_1
721
1V
DD
12_6
212
EX
AD
T0
213
NE
XC
E21
4N
EX
OE
215
EX
DT
0
216
EX
DT
8
K4S
6416
32N
-LC
75
19C
S20
BA
021
BA
122
A10
/AP
23A
024
A1
25A
226
A3
27V
DD
328
VS
S1
29A
4
30A
5
31A
6
32A
7
33A
8
34A
9
35A
11
36N
.C
IC14
01
CW
W17
53
A15
1
A14
2
A13
3
A12
4 5A
116
A10
7A
98
A8
9A
1910
NC
111
/WE
12/R
ES
ET
13N
C2
14N
C3
15R
Y_/
BY
16A
1817
A17
18A
719
A6
20A
521
A4
22A
323
A2
24A
125
A0
26/C
E
27V
ss1
28/O
E
29D
Q0
30D
Q8
31D
Q1
32D
Q9
33D
Q2
34D
Q10
35D
Q3
36D
Q11
37V
cc
38D
Q4
39D
Q12
40D
Q5
41D
Q13
42D
Q6
43D
Q14
44D
Q7
45D
Q15
_A-1
46V
ss2
47/B
YT
E
48A
16
IC14
02
CW
W17
54
A15
1
A14
2
A13
3
A12
4 5A
116
A10
7A
98
A8
9A
1910
NC
111
/WE
12/R
ES
ET
13N
C2
14N
C3
15R
Y_/
BY
16A
1817
A17
18A
719
A6
20A
521
A4
22A
323
A2
24A
125
A0
26/C
E
27V
ss1
28/O
E
29D
Q0
30D
Q8
31D
Q1
32D
Q9
33D
Q2
34D
Q10
35D
Q3
36D
Q11
37V
cc
38D
Q4
39D
Q12
40D
Q5
41D
Q13
42D
Q6
43D
Q14
44D
Q7
45D
Q15
_A-1
46V
ss2
47/B
YT
E
48A
16
FLA
SH
16M
(212
5)(2
125)
FLA
SH
16MSD
RA
M
DE
BU
G
CP_READY
I2C_SDA
I2C_SCL
08EJ
(3216)
24
T TFF
F TS
C C
C
S S S
DVH-3200UB/XNUW5108
1 2 3 4
1 2 3 4
C
D
F
A
B
E
10.4 CONNECT PCB
D
H+
,H-,
HU
+,H
U-,
HV
+,H
V-,
HW
+,H
W-,
U,V
,W
H+
W
U
V
HW+
HW-
HV+
HV-
HU+
HU-
H-
HV-
H+
HV+
HU-
HU+
HW-
HW+
H-
W
U
V
CN701
1 CRG-
2 CRG+
3 HALL BIAS-
4 HALL U-
5 HALL U+
6 HALL V-
7 HALL V+
8 HALL W-
9 HALL W+
10 COIL V
11 COIL U
12 COIL W
13 HALL BIAS+
14 DSCSNS
15 8SNS
16 HOME
17 GND
18 GND
CSN1068-A
S101
1
234
CSN1068-A
S102
1
2 34
1 2
11
HOME
8SNS0
DSCSNS0
GND3 GND2 GND1
CRGM
CRGP
HM
HUM
HUP
HVM
HVP
HWM
HWP
V
U
W
HP
BR
1
GY
1
DSCSNS0_B
8SNS0_B
HOME_B
C10
1
0.1u
/50
R101
100
R102
100
R103
100
GND_B
HOME1_BHOME1
8SNS1 8SNS1_B
DSCSNS1 DSCSNS1_B
CN101
1V
2U
3W
4H-
5HW+
6HW-
7HU+
8HU-
9HV+
10H+
11HV-
1
2
3
4
5
6
7
8
9
10
11
CSN1068-A
S103
1
234
H3
H1
H2
M2SPINDLE MOTOR
EXM1050
M1LOAD/CRG MOTOR
CXC4026
HOME
8SNS
DSCSNS
D CONNECT PCB
CCN1201
C
CC
C
S
S
S
SS
S
DVH-3200UB/XNUW5 109
5 6 7 8
5 6 7 8
C
D
F
A
B
E
10.5 WAVEFORMS
RF 0.2 V/div(AC) 100 ns/divCDRF(x4CLV)
RF 0.2 V/div(AC) 50 ns/divDVDRF(x1.3ZCAV)
RF 0.5 V/div 100 us/divDVDRF(BD1mm)
TD1 0.2 V/div 100 us/divInterval FWD(DVD)
TD1 0.2 V/div 100 us/divInterval REV(DVD)
VHALF VHALF
2.2 V->
Traverse 1001FWD(short)(DVD)
VHALF
VHALF VHALF
0->
TD1 0.2 V/div 500 us/divMulti 32FWD(DVD)
TD1 0.2 V/div 500 us/divMulti 32REV(DVD)
CH1:TD1 0.5 V/div 10 ms/divCH2:COP-COM 2.0 V/div 10 ms/div
- Waveforms Note:1. The encircled number denote measuring points in the circuit diagram. 2. Reference voltage: 1.65 V(TD1,FD1)(=VHALF) 2.2 V(RF)(=VREF)
In the waveform, it is seeing on the GND standard.Offset of 1.65 V or 2.2 V is put in.
DVH-3200UB/XNUW5110
1 2 3 4
1 2 3 4
C
D
F
A
B
E
VHALF VHALFVHALF
VHALFVHALF VHALF
VHALFVHALF
0->
0->
0->
0->
CH1:TD1 0.5 V/div 10 ms/divCH2:COP-COM 2.0 V/div 10 ms/div
Traverse 1001REV(short)(DVD)
CH2:COP-COM 2.0 V/div 100 ms/divID search Inside -> Outside(DVD)
FD1 0.5 V/div 20 ms/divPlay FD(DVD)
FD1 0.5 V/div 500 us/divFocus Jump L0 -> L1
FD1 0.5 V/div 500 us/divFocus Jump L1 -> L0
TD1 0.5 V/div 100 ms/divPlay TD (DVD)
FD1 0.5 V/div 1 ms/divFocus Close (DVD)
CH1:TD1 0.5 V/div 20 ms/divCH2:COP-COM 2.0 V/div 20 ms/div
Traverse 5001FWD(long)(DVD)
CH1:TD1 0.5 V/div 20 ms/divCH2:COP-COM 2.0 V/div 20 ms/div
Traverse 5001REV(long)(DVD)
DVH-3200UB/XNUW5 111
5 6 7 8
5 6 7 8
C
D
F
A
B
E
DVH-3200UB/XNUW5112
1 2 3 4
1 2 3 4
C
D
F
A
B
E
11. PCB CONNECTION DIAGRAM11.1 TUNER AMP UNIT
A
A TUNER AMP UNIT
CapacitorConnector
P.C.Board Chip PartSIDE B
SIDE A
NOTE FOR PCB DIAGRAMS1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- gram.2.Viewpoint of PCB diagrams
5
1 1
1 5 10
15 20
30
35
40 45
25
15
1
E
1
1
1
5
1
1
1
1
1
5
1
1
5
1
1
1
1
E
1
5
E
E
1
5
5251
51
0302
10
51
1
1
1 5 10
15 20
25
30
3
5
40 45
15
1 5
10
15
20
1
1
1
C1121
C1122
IC351
Q281
C1131
IC
C1132
IC1103
IC171
Q291
Q292
R23
3
R234
C11
41
IC1
R23
5
C1142
R23
6
C1143
R237
C1144
R238
IC371
C11
45
R239
C1146
C1147
IC181
R240
R24
1R
242
R24
3
R24
4
C1151
R245
C1152
R24
6
C1153
C1154
Q1151
R251
C1161
C1162C11
63
C1164
D1141
C1165
D1142
R11
41
R11
42
R26
1
R262
R263
P1191
D1151
C231
VA291
VA292
C232
C23
3
C234
C1181 C1182
C11
83
C1184C1185C
1186
R1161
C241
R1162
C242
R1163
C243
R11
64
R1165
R28
1
R11
66
R28
2
R11
67
R28
3
R28
4
C1191
R285
C1192
R286
C1193
R287
C1194
R288
Q1191
C1195
C1196
C1197
C1198
R1171
C1199
R1172
R1173R1174
C
R291
R29
2R
293
R29
4
R29
5R
296
R29
7R
298
R29
9
R1181
C261
R1182
R11
83
C263
R1184
R11
85
JA282
R11
87
R1188
R11
89
Q112
D1191
L101
D1192
D1193
R11
90
R1191
CN291
C271 C
C281 C282
C283 C284
Q321
C285
C286
C287
C288
C291
C292
C293
L321
IC231
Q161Q162
R
R109
VA321
IC241
VA322
R30
0
R30
1R
302
R30
3R
304
L351
L161
C1021
C1022
C1023
R50
1R
502
R50
3
R504
R50
5
CN101
R31
1
R506
R312
R50
7
R313
R50
8
R314
R50
9
R121
R31
5
R122
R12
3
R124
R125
R128
R510
R12
9
R321R322
R32
3
L371
L181
L182R52
1
D1021
R52
2R
523
R52
4
C101
R1021
C102
R1022
C104
C105
C106
C107
R720
IC1021
L1108
JA321
C50
1
C50
2C
503
C50
4
C50
5
R54
1
C31
1
C50
6
C312
R543
C50
7
C313
R54
4
C50
8
R351
R545
C50
9
C12
1R
546
R352
C12
3
R353
R354
R161R162
R356
R163
R358
R164
C510 C511
R16
5
L1121
C51
2
R166
R167
C321
R360
R17
1R
172 R
173
R174
L1131
C521
R175
C522
C523
C524
C52
5C
526
C527C528C529
R372
R374
R181
R18
2
R37
R18
3
C530
R18
4
C531
R18
5
L1141
C532C533
C534
R57R5
C54
1
L1151
C54
2
L115
2
C543
L1153
C544
C545
C352
C546
C54
7
C353
C354
C54
8C
549
C161
C162
C16
3
C164
C165
C55
0
C
C
C17
1
C17
2
C17
3
C174
C372
C374
C181
C182
C183
C184
VR161
P291
P292
C581
IC501
D521
L1191
D522
L1192
IC311
IC121
P1121C1101
C1102
Q261
P1131
C1111
C11
Q282
10 20 30 40 50 60 70X
150
140
130
120
110
100
90
80
70
60
50
40
30
20
10
0
Y
538
26497
F
RCA
LS1
RCAOPT-OUT
CCN1901
DVH-3200UB/XNUW5 113
5 6 7 8
5 6 7 8
C
D
F
A
B
E
A
SIDE A
1
5
1
5
1
1
1
1
1
0
1
5
1
1 5
10
1
11
1
15
10
1520
E
E
1
1 510 15 20 25
30 35 40 45 50
55 60 65 70 75
80
85
9
0
95
10
0
1
E
5251
51
0302
10
1
5
1
E
E
1
525151
2010
E
15
1015
20
1 515
0201
1
E
E
1
E
E
E
E
E
1
1
1
1
1 5
10
1 5
10
1 5 10
15 20
25
30
3
5
40 45
E
E
5
20
1 5 10
1
1
L641
IC151
R401
R402
R403
R404
R211
L451
D751
R212
L452
D752
D753
C1121
C1122
R601
IC351
R602R603
R604
R605
R1101
R606
R607
R608
R221
R609
R22
3
R224
IC1101
R225
R226
R227
R610
R611
R1111
R11
12
L471
D771
L472
D772
CN601
IC1111
R621
IC371
R622
R623R624
R430
C201
R625
R431
C202
R626
R43
2
R627
R433
C204
R628
R434
R629
R43
5
D781
C206
R436
R437
C208
R630R631
R632
R633
R634
C211
R635
C212
R636
C213
R637
C215
R251 IC771
C217
C601
C60
2 C603
C604
C60
5
R641
C60
6
R642
C607
R64
3
C221
R451
C222
R452
C22
3
R453
C22
4
R454C22
5 R455
CN821
C801
R457
X601
R65
1
R65
2R
653 R654
R655
VA291
R656
VA292
R657
C431
R661
L1041
C432
C433
C434
R471
R67
1R
672
R67
3R
674
R67
5
C251
R67
6
C252
R67
7
C253
R67
8
C254
R679
C255
C256
C257
C258
C641
R680
C451
R68
1
C452
R68
2
C453
R683
C454
R684
R685
C455
JA471
C261
R68
6
C262
C456
C457
C263
C65
1
Q111
C65
2
Q112
192
193
91
C271
C272
C273
C274
C275
C661
C471
C472
C473
C474
IC201
C475
D801 D802
C671
Q131
C672
Q132
C673
L121
C291
IC601
CN1001
D821
D822
C1001
C1002
R101
R102R103
VA
703
R104
VA
704
L151
C1011
R105
C1012
R106
R107
C1013
R108
C1014
R109
R111
L351
R112
R113
R114
Q751
R115
R116
Q752
R50
1R
502
R50
3
R50
5
CN101
IC641
R50
9
121
D661
122
R12
3
R124
C1031R125
IC1001
C1032
R126
R127
128
R510
R12
9
Q1031
D1011
Q1032
D1012
D1013
L371
R13
1
R13
2
R13
3
R13
4
R13
5
IC1011
R71
1
C1041
R13
6
R71
2
C10
42
R137
R71
3
R138
R71
4
R139
U401
R71
5
Q1041
IC271
R52
2
R71
6
R52
3
R71
7
R71
8
R71
9
R331
C102
R332
R14
0
C104
IC661
CN701
R141
C105
R142
106
R143
07
R720
C1051
R72
1
Q781
C1052
R72
2
C1053R723
C1054
R724
Q1051
R72
5
Q1052
R1031
C111
R1032
C112
R151
JA131
R152
C50
1
C1061
C50
2
C1062
C50
3
C50
4
C50
5
Q1061
L781
R542
C50
6
Q1062
R543
C50
7
R54
4
C50
8
R351
R545
C50
9
C12
1
R10
41
JA331
R54
6
R1042
C122
R352
C12
3
R353
R1043
R354 R355
C70
1
R356
C70
2
R357
C70
3
R358
C70
4
C70
5
C1071
511
L1121
R359
C1072
C51
2
R742
C1073
Q1071
D1051
Q1072
D1052
Q1073
R360
Q1074
R1051
C131
R1052
R1053R1054
C71
1
R1055
C712
R1056
R751R752R753R754
C331
R755
C332
R756R757
R371
R1061
R1062
R372R373
R10
63
R374
R1064
R375
R376
D1071
R571R572
R573R574
C15
1
R1071
C152
R1072
C153
R1073
R1074
R1075
R771
C351
C352
C54
7
C353
C354
C54
8C
549
C55
0
C551
R781
C552
R782
C553
D111
Q401
Q402
C751
C371
C372C373
C374
P471
D701
D702
C571
C572
C573C574
C575C576
C577
C578
IC111
L601
IC112
L602
C771
C772
D71
2
C773
D71
3
C580
D71
4
IC501
L221
D71
5
Q430
1
Q431
IC122
C781
P1121C1101
C1102
L821
R201
R202
C1111
R20
6
C1112
0 70 80 90 100 110 120 130 140 150 160 170
15 13 11 9 7 5 3 1
16 14 12 10 8 6 4 2
14
57
811
B CN1821
FRONT
A
LS1
POWERCONNECTOR
WIRED REMOTE
ANTENNA
FM
/AM
TU
NE
R U
NIT
DVH-3200UB/XNUW5114
1 2 3 4
1 2 3 4
C
D
F
A
B
E
A
A TUNER AMP UNIT
90100110120130140150160170
1
1
1
1
PCL
TESTIN
DVH-3200UB/XNUW5 115
5 6 7 8
5 6 7 8
C
D
F
A
B
E
A
SIDE B
10203040506070809000 X
150
140
130
120
110
100
90
80
70
60
50
40
30
20
10
0
Y
1
1
1
DVH-3200UB/XNUW5116
1 2 3 4
1 2 3 4
C
D
F
A
B
E
11.2 KEYBOARD UNIT
B
SIDE AB KEYBOARD UNIT
1
5
1
1 5 10 15 20 25 30 35 40
1
1
5
CN
1901
CN
1911
LCD
1801
IC18
02
C18
52
C1853
C1854
C1855
C18
56
C18
58
C18
59
C1860
C18
61
C18
62
C18
63
C18
64
C18
65
C18
66
C18
68
S18
21S
1822
S18
23
S18
24
S18
25S
1826
S18
27S
1828
D18
51
S18
29
D1852
D1853
D1854
D1855
D1856
D1857
D18
58
S18
30
D18
59
S18
31S
1833
S18
34
S18
35
S18
36S
1837
D1860
S18
38
D1861
S18
39
D1862
D1863
D18
64
D18
65
D1866
D1867
S18
40
D1868
S18
41
D18
69
S18
42
S18
43S
1844
S18
45
D18
70
D1871 D1872
D1873
D1874
D1875
D1876
D18
77
D18
78
D1879
D1880D1881 D1882
D18
83
D18
84
D1885
D1886
D1887
D18
88D
1889
S18
32
1020
3040
5060
7080
9010
011
012
013
014
015
0X
40 30 20 10
0
Y
160
170
EJE
CT
LIS
T
6
54
32
1
RIG
HT
RO
TAR
Y
UP
SR
C
LEF
T DO
WN
BA
ND
/ES
C
DIS
P/B
AC
K
FR
ON
T_A
UX
US
B
TA
/AF
:UW
5C
LOC
K:O
TH
ER
S
DVH-3200UB/XNUW5 117
5 6 7 8
5 6 7 8
C
D
F
A
B
E
B
SIDE BB KEYBOARD UNIT 170160
150140
130120
110100
9080
7060
5040
30
X
40302010
0
Y
2010
1
515
1
2010
1
1
1 5 10 15
20 25 30
35
4
0
4
5
50 55 60
5
1
1C
1901
X1801
C1902
C1903
C1904C1905
R1901R1902
D1911
D1912
R1911
R1912
C1801
C1802
CN
1821
D1801
D1802
R1801R1802
R1803
R1804
R1805
R1806
IC1801
R1821
R1822
R1823
R1824
R1825
R1826
C1851
Q1851
C1857
L1911
C1867
C1869
C1870
R1851
R1852
R1853
R1854
R1855
R1856
R1857
R1858
R1859
R1860
R1861
R1862
R1863
R1864
R1865
R1866
R1867
R1868R1869
R1870
R1871
R1872
R1873
R1874
R1875
R1876
R1877
R1878
VA1901 VA
1902V
A1903
VA1904
AC
N701
1
1
DVH-3200UB/XNUW5118
1 2 3 4
1 2 3 4
C
D
F
A
B
E
11.3 DVD CORE UNIT
C
SIDE AC DVD CORE UNIT
1
5
1
0
1
520
25
30
1 5 10 15 20 25 30 35 40 4550
65 70 75 80 85 90 95 100 105
130 135 140 145 150 155 160
195
2
00
20
5
210
215
6055
125120115110
190
185
180
175
170
165
1 5 10
1520
1 5 10 15
1
1 5 10 15 20
2530
3540
1
1 5 10 15 20 25
E
E
E
E
C15
02
C1503
C15
04
C15
05
C15
06C
1507
C15
09
CN
1901
R1101
C15
11
R1102
R11
03
C15
14
R1104
C15
15
R11
05
C15
16
R11
06
C1517
C15
18
C15
19
R11
09
C15
20
R1110
C15
21
R11
11
C1522
R11
12
C1523
R11
13
C1524
R11
14
R11
15C1526
R11
16
R11
17
C1528
R11
18
C15
29
R15
05
R15
06R
1507
R15
08
R1509
IC15
01
R15
10
R15
12
R1513R
1514
D19
01
D19
02
R1516
R15
17
R15
18
R1519
R15
22
R1523
R1524
R1525
R15
26
R1528
R15
29
R1530R1531
R15
33
R15
34
CN
1951 R15
36
R15
37
R1538
R15
39
R15
40
R1541
R15
42
C1953
R15
47
R19
50
R19
51R
1954
R19
55
R19
56
R19
57
CN
1201
C12
03
C12
04C
1205
C12
07
C1208
C1018
C10
19
C10
22
C1601
C16
02
C1603
C1604
R10
01
C16
05
C16
06
C1607
R10
04
C1608
C16
09
R10
07
R1008
IC10
01
C1610
R1201
C1611
R1202
C1612
R12
03
C16
13
R1204
C1614
C1615C1616
C16
17
C1618
IC12
01
C1619
C1620
C1621
C1622
R12
12
C1623
C1624
R10
21
C1625
C16
26C
1627
R16
01
R10
26
R16
02
R16
03
R10
27
R16
04
R1605
L1512
L190
1C
1671
C16
72
C16
73
C16
74
C16
76
R16
70R
1671
R16
72
R1673
R16
74
R1675
R1679
CN
1101
C11
04
C11
05
Q11
01
Q11
02
C11
06
Q11
03
C11
07
C11
08
Q11
04
C11
09C
1110
C11
11
C15
08
1020
3040
5060
7080
X
50 40 30 20 10
0
Y
PIC
KU
P U
NIT
(S
ER
VIC
E)
AC
N10
1
DC
N70
1
DVH-3200UB/XNUW5 119
5 6 7 8
5 6 7 8
C
D
F
A
B
E
C
SIDE BC DVD CORE UNIT
8070
6050
4030
2010
X
50403020100Y
1
1
1
5
1
1
1
1
1
5
1
5
10
15
20
25
30
35
40
45
1
5
10
15
20
25
30
35
40
45
1 5
1015
1
1
5
10
1
5
2
0
2
53035
4045
50
C1501
C1510
C1512
C1513
R1300
R1301
C1525
C1527
R1501
R1503
R1504
L1003
L1004
R1511
EF
1001
EF
1002
C1934
R1527
R1532
R1535
C1950
C1951
C1952
R1543
R1544
C1954
R1546
R1952
R1953
IC1951
C1001
C1003
C1004
C1005C
1006
C1007
C1008
C1009
C1201
C1010
C1011 C
1012
C1013
C1014
C1209
C1015
C1016
C1017
C1401
C1402
C1403
C1404
C1210
C1405
C1211
C1407
C1408
C1409
C1021
X1501
R1002
C1802
IC1002
C1803 IC
1003
C1804
IC1004
IC1005
C1805
C1806
IC1006
C1807
C1808
R1011
C1809
R1015
R1017
R1019
R1401
R1402
R1403
R1405 R
1406
R1213
R1214
R1215
IC1401
R1409
R1216
IC1402
R1217
R1218
R1025
R1222
R1801
R1802
R1803
R1804
IC1801
L1902
L1903
L1904
X1950
C1480
C1481
C1482
C1483
C1484
C1485
C1486
C1487
C1488
C1489
C1490
C1491
C1492
C1493C
1494
R1480
R1481
R1482
R1483
R1484
R1485
R1486
R1487
R1488
IC1480
R1489
R1490
C1101
C1301
C1302
C1112
C1113C
1801
1
DVH-3200UB/XNUW5120
1 2 3 4
1 2 3 4
C
D
F
A
B
E
11.4 CONNECT PCB
D
SIDE AD CONNECT PCB
1
5
10
15
CN701
10 20 30 40 50X
40
30
20
10
0
Y
M
M1LOAD/CRG
MOTOR
C CN1201
DVH-3200UB/XNUW5 121
5 6 7 8
5 6 7 8
C
D
F
A
B
E
D
SIDE BD CONNECT PCB
50 40 30 20 10X
40
30
20
10
0
Y
1
1
1
1 5 10R101
R102
R103
CN101
C101
S101
S102
S103
M2SPINDLE MOTOR
HOME
8SNS
DSCSNS
DVH-3200UB/XNUW5122
1 2 3 4
1 2 3 4
C
D
F
A
B
E
12. ELECTRICAL PARTS LISTNOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V
Circuit Symbol and No. Part No.
A:DVH-3200UB/XNUW5
B:DVH-3220UB/XNUW5
C:DVH-3250UB/XNRC
D:DVH-3250UB/XNRD
E:DVH-3250UB/XNRI
F:DVH-3290UB/XNID
Unit Number : QWM3138(A,B)
Unit Number : QWM3139(C)
Unit Number : QWM3140(D)
Unit Number : QWM3141(E)
Unit Number : QWM3142(F)
Unit Name : Tuner Amp Unit
Unit Number :
Unit Name : Keyboard Unit
Unit Number : YWX5007
Unit Name : DVD Core Unit
Unit Number :
Unit Name : Connect PCB
A:DVH-3200UB/XNUW5B:DVH-3220UB/XNUW5C:DVH-3250UB/XNRCD:DVH-3250UB/XNRDE:DVH-3250UB/XNRIF:DVH-3290UB/XNID
AUnit Number : QWM3138(A,B)Unit Number : QWM3139(C)
Unit Number : QWM3140(D)Unit Number : QWM3141(E)Unit Number : QWM3142(F)Unit Name : Tuner Amp Unit
MISCELLANEOUS
IC 111 (A,90,58) IC TC74VHCT08AFTS1IC 112 (A,90,47) IC TC74VHC08FTS1IC 122 (A,80,34) IC TC7MBL6126SFKIC 181 (A,27,91) IC TK15405BMIIC 201 (A,102,89) IC PML014A
IC 231 (A,32,111) IC(C,F) NJM4558MDIC 241 (A,32,117) IC(C,F) NJM4558MDIC 271 (A,78,141) IC PA2030AIC 311 (A,20,128) L-MOS And Gate TC7SET08FUS1
IC 601 (A,123,55) (A,B) PEG524A8(A,123,55) IC(C,D,E,F) PEG525A
IC 661 (A,104,61) IC BD4835GIC 1001 (A,81,30) IC S-1200B33-M5
IC 1011 (A,143,48) IC NJM2885DL1-33IC 1021 (A,8,122) IC NJM2388F84IC 1101 (A,74,26) IC R5523N001BIC 1103 (A,33,58) IC BD9013KVIC 1111 (A,74,33) IC S-1200B33-M5
Q 111 (A,78,75) Transistor UMD3NQ 112 (A,71,75) Transistor RT3N66MQ 261 (A,52,126) Transistor RT3T22MQ 282 (A,35,126) Transistor RT3N66MQ 291 (A,48,127) Transistor RT3T22M
Q 292 (A,48,131) Transistor DTC323TUQ 321 (A,13,127) Transistor 2SA1579Q 401 (A,158,52) Transistor(A,B) UMH1NQ 402 (A,158,56) Transistor(A,B) UMH1NQ 751 (A,105,121) Transistor RT3CLLM
Q 781 (A,114,119) Transistor(A,B) LSA1576UBQ 1041 (A,141,19) Transistor LSA1576UBQ 1051 (A,143,23) Transistor 2SD1858Q 1052 (A,166,31) Transistor RT3T22MQ 1061 (A,139,15) Chip Transistor 2SA1576A
Circuit Symbol and No. Part No.
DVH-3200UB/XNUW5 123
5 6 7 8
5 6 7 8
C
D
F
A
B
E
Q 1062 (A,145,14) Transistor LTC114EUBQ 1151 (A,35,45) FET HAT2210RJQ 1191 (A,35,71) FET HAT2210RJD 701 (A,100,10) Diode DZ2S068CD 702 (A,99,11) Diode DZ2S068C
D 712 (A,112,14) Diode DZ2S068CD 713 (A,110,14) Diode DZ2S068CD 714 (A,114,14) Diode DZ2S068CD 751 (A,98,118) Diode HZU7R5(B3)D 752 (A,100,120) Diode HZU6R8(B2)
D 781 (A,110,119) Diode(A,B) MC2848-11D 801 (A,118,128) Diode 1SR154-400D 802 (A,122,127) Diode 1SR154-400D 821 (A,126,126) Diode 1SR154-400D 822 (A,126,129) Diode 1SR154-400
D 1021 (A,17,113) Diode 1SR154-400D 1051 (A,163,26) Diode UDZS5R6(B)D 1052 (A,164,39) Diode 1SR154-400D 1141 (A,46,63) Diode RB551V-30D 1142 (A,43,51) Diode RB551V-30
D 1192 (A,62,23) Diode RSX201L-30D 1193 (A,62,26) Diode RSX201L-30L 101 (A,59,66) Inductor CTF1389L 181 (A,29,96) Inductor LCYC100K2125L 182 (A,49,110) Inductor CTF1383
L 221 (A,84,85) Inductor LCTAW2R2J2520L 321 (A,17,128) Inductor CTF1389L 451 (A,146,63) Inductor LCTAW2R2J3225L 452 (A,147,71) Chip Coil LCTAW100J2520L 471 (A,149,85) Chip Coil LCTAW1R0J2520
L 472 (A,159,107) Inductor LCTAW220J2520L 601 (A,139,67) Chip Coil LCTAW100J2520L 781 (A,108,122) Inductor(A,B) CTF1379L 821 (A,137,98) 600 uH CTH1280L 1108 (A,48,71) Inductor CTH1253
L 1141 (A,30,67) Inductor CTF1661L 1151 (A,32,51) Inductor CTF1661L 1152 (A,31,48) Inductor CTF1661L 1153 (A,48,45) Inductor CTH1253L 1191 (A,30,69) Inductor CTF1661
L 1192 (A,20,49) Inductor CTH1253X 601 (A,123,70) 15.000 MHz CSS1774P 291 (A,39,130) Poly Switch MINISMDC075F/24P 292 (A,55,133) Poly Switch MINISMDC075F/24P 471 (A,165,115) Surge Protector IMSA-6802-01Y900
P 1121 (A,70,29) Fuse 3 A CEK1286P 1131 (A,56,51) Fuse 3 A CEK1286P 1191 (A,32,31) Fuse 4 A CEK1344VA321 (A,13,129) Varistor EZJZ1V270RMVA322 (A,17,125) Varistor EZJZ1V800AM
VA703 (A,122,14) Varistor EZJZ1V270RMVA704 (A,124,14) Varistor EZJZ1V270RMCN101 (A,67,55) Connector CKS3844CN701 (A,116,5) Connector CKS6050CN821 (A,114,136) Plug CKM1370
JA282 (A,37,138) Pin Jack(A,B,D,E) CKB1093(A,37,138) Pin Jack(C,F) CKB1095
JA321 (A,15,137) Connector CKS4124JA331 (A,135,137) Connector(A,B) CKS4124JA471 (A,171,131) Antenna Jack CKX1070
Circuit Symbol and No. Part No.RESISTORS
R 101 (A,87,53) RS1/16SS471JR 102 (A,91,41) RS1/16SS102JR 103 (A,89,42) RS1/16SS471JR 104 (A,89,52) RS1/16SS221JR 105 (A,87,52) RS1/16SS221J
R 106 (A,87,63) RS1/16SS471JR 107 (A,75,72) RS1/16SS471JR 108 (A,77,73) RS1/16SS471JR 109 (A,68,75) RS1/16SS0R0JR 111 (A,87,57) RS1/10SR0R0J
R 112 (A,87,45) RS1/10SR0R0JR 113 (A,78,77) RS1/16SS102JR 126 (A,84,35) RS1/16SS0R0JR 127 (A,85,31) RS1/16SS0R0JR 128 (A,61,64) RS1/16SS391J
R 173 (A,16,75) RS1/16SS0R0JR 174 (A,17,83) RS1/16SS0R0JR 175 (A,16,72) RS1/16SS0R0JR 181 (A,30,93) RS1/16SS473JR 182 (A,51,109) RS1/16SS390J
R 183 (A,50,109) RS1/16SS330JR 184 (A,30,90) RS1/16SS3302DR 185 (A,31,90) RS1/16SS6802DR 201 (A,115,88) RS1/16SS0R0JR 202 (A,115,90) RS1/16SS0R0J
R 206 (A,83,106) RS1/16SS0R0JR 211 (A,89,77) RS1/16SS0R0JR 212 (A,89,76) RS1/16SS0R0JR 221 (A,110,85) RAB4C102JR 223 (A,84,106) RS1/16SS0R0J
R 224 (A,110,89) RS1/16SS101JR 225 (A,95,92) RS1/16SS101JR 226 (A,110,88) RS1/16SS101JR 227 (A,95,90) RS1/16SS101JR 233 (A,24,124) (C,F) RS1/16SS123J
R 234 (A,24,115) (C,F) RS1/16SS223JR 235 (A,24,123) (C,F) RS1/16SS223JR 236 (A,28,113) (C,F) RS1/16SS223JR 237 (A,27,107) (C,F) RS1/16SS223JR 238 (A,38,109) (C,F) RS1/16SS123J
R 239 (A,38,110) (C,F) RS1/16SS103JR 240 (A,23,116) (C,F) RS1/16SS562JR 241 (A,26,123) (C,F) RS1/16SS223JR 242 (A,25,123) (C,F) RS1/16SS223JR 243 (A,29,121) (C,F) RS1/16SS223J
R 244 (A,26,124) (C,F) RS1/16SS123JR 245 (A,27,116) (C,F) RS1/16SS223JR 246 (A,27,123) (C,F) RS1/16SS562JR 251 (A,69,130) RS1/16SS102J
R 261 (A,50,129) RS1/16SS103JR 262 (A,52,128) RS1/16SS103JR 263 (A,53,129) RS1/16SS221JR 283 (A,33,123) RS1/16SS821JR 284 (A,38,124) RS1/16SS821J
R 287 (A,33,128) RS1/16SS223JR 288 (A,35,129) RS1/16SS223JR 291 (A,50,125) RS1/10SR102JR 295 (A,31,132) (C,F) RS1/16SS103J
Circuit Symbol and No. Part No.
DVH-3200UB/XNUW5124
1 2 3 4
1 2 3 4
C
D
F
A
B
E
R 298 (A,26,132) (C,F) RS1/16SS103J
R 303 (A,23,132) (C,F) RS1/16SS0R0JR 311 (A,22,125) RS1/16SS0R0JR 312 (A,22,127) RS1/16SS621J
R 313 (A,22,129) RS1/16SS473JR 314 (A,19,125) RS1/16SS0R0JR 315 (A,17,129) RS1/16SS121JR 322 (A,11,127) RS1/16SS104JR 323 (A,15,129) RS1/16SS103J
R 331 (A,142,135) (A,B) RS1/16SS102JR 332 (A,142,132) (A,B) RS1/16SS102JR 401 (A,156,57) (A,B) RS1/16SS223JR 402 (A,156,50) (A,B) RS1/16SS223JR 403 (A,156,58) (A,B) RS1/16SS223J
R 404 (A,156,51) (A,B) RS1/16SS223JR 436 (A,159,79) RS1/16SS0R0JR 437 (A,159,75) RS1/16SS0R0JR 451 (A,159,68) RS1/16SS681JR 452 (A,159,81) RS1/16SS681J
R 453 (A,159,82) RS1/16SS681JR 454 (A,159,83) RS1/16SS681JR 455 (A,159,84) RS1/16SS681JR 457 (A,159,85) RS1/16SS681JR 471 (A,159,86) RS1/16SS681J
R 601 (A,133,64) RS1/16SS104JR 602 (A,131,64) RS1/16SS104JR 603 (A,131,66) RS1/16SS472JR 604 (A,125,65) RS1/16SS0R0JR 605 (A,116,67) RS1/16SS473J
R 606 (A,117,66) RS1/16SS104JR 607 (A,116,70) RS1/16SS104JR 608 (A,115,68) RS1/16SS104JR 609 (A,116,71) RS1/16SS104JR 610 (A,110,64) RS1/16SS471J
R 611 (A,110,57) RS1/16SS104JR 623 (A,112,58) RS1/16SS221JR 624 (A,110,58) RS1/16SS221JR 626 (A,112,56) (A,B) RS1/16SS102JR 627 (A,110,55) RS1/16SS104J
R 629 (A,112,53) RS1/16SS102JR 630 (A,110,52) RS1/16SS102JR 631 (A,111,51) RS1/16SS104JR 632 (A,109,54) RS1/16SS104JR 633 (A,117,45) RS1/16SS473J
R 634 (A,110,56) (A,B) RS1/16SS473JR 635 (A,112,59) RS1/16SS104JR 636 (A,110,51) RS1/16SS104JR 637 (A,112,44) RS1/16SS104JR 641 (A,110,32) RS1/16SS473J
R 652 (A,122,45) RS1/16SS102JR 653 (A,123,45) RS1/16SS102JR 654 (A,127,43) RS1/16SS681JR 655 (A,129,44) RS1/16SS471JR 661 (A,109,61) RS1/16SS474J
R 671 (A,131,40) (C,D,E,F) RS1/16SS473JR 673 (A,132,40) (C,D) RS1/16SS473JR 674 (A,132,43) (E,F) RS1/16SS473JR 675 (A,133,40) (C,E) RS1/16SS473JR 676 (A,133,43) (D,F) RS1/16SS473J
Circuit Symbol and No. Part No.R 677 (A,133,49) (A,B) RS1/16SS681JR 678 (A,133,53) (A,B) RS1/16SS681JR 679 (A,134,57) RS1/16SS471JR 680 (A,132,39) RS1/16SS473JR 681 (A,137,58) RS1/16SS104J
R 682 (A,136,58) RS1/16SS103JR 684 (A,130,41) RS1/16SS104JR 711 (A,127,23) RS1/16SS222JR 712 (A,125,23) RS1/16SS222JR 713 (A,123,23) RS1/16SS222J
R 714 (A,109,23) RS1/16SS222JR 715 (A,107,23) RS1/16SS222JR 716 (A,85,30) RS1/16SS0R0JR 717 (A,86,30) RS1/16SS0R0JR 718 (A,121,23) RS1/16SS222J
R 719 (A,117,23) RS1/16SS222JR 720 (A,63,105) RS1/16SS0R0JR 721 (A,88,31) RS1/16SS0R0JR 722 (A,89,31) RS1/16SS0R0JR 723 (A,87,27) RS1/16SS223J
R 724 (A,89,30) RS1/16SS223JR 751 (A,102,118) RS1/16SS104JR 752 (A,102,119) RS1/16SS473JR 753 (A,102,120) RS1/16SS103JR 754 (A,102,121) RS1/16SS473J
R 755 (A,102,122) RS1/16SS472JR 781 (A,116,119) (A,B) RS1/16SS472JR 782 (A,108,119) (A,B) RS1/16SS153JR 1021 (A,16,103) RS1/16SS102JR 1022 (A,21,103) RS1/16SS473J
R 1041 (A,136,21) RS1/16SS222JR 1042 (A,139,17) RS1/16SS103JR 1043 (A,141,16) RS1/16SS223JR 1051 (A,164,25) RS1/16SS223JR 1052 (A,167,26) RS1/4SA222J
R 1053 (A,167,33) RS1/16SS390JR 1054 (A,166,33) RS1/16SS390JR 1055 (A,167,34) RS1/16SS390JR 1056 (A,166,34) RS1/16SS390JR 1061 (A,136,13) RS1/16SS1R0J
R 1062 (A,142,13) RS1/16SS472JR 1063 (A,141,14) RS1/16SS103JR 1064 (A,136,11) RS1/10SR104JR 1101 (A,82,25) RS1/16SS104JR 1112 (A,76,36) RS1/16SS0R0J
R 1141 (A,27,65) RS1/8SQ100JR 1142 (A,28,48) RS1/8SQ100JR 1161 (A,39,51) RS1/8SQ2R2JR 1162 (A,47,52) RS1/10SR0R0JR 1164 (A,47,55) RS1/16SS4702D
R 1165 (A,45,55) RS1/16SS6801DR 1166 (A,44,57) RS1/16SS1002FR 1167 (A,44,53) RS1/16SS223JR 1171 (A,41,56) RS1/16SS0R0JR 1172 (A,41,57) RS1/16SS0R0J
R 1173 (A,40,58) RS1/16SS823JR 1174 (A,41,60) RS1/16SS471JR 1181 (A,43,61) RS1/16SS303JR 1182 (A,44,60) RS1/16SS9101DR 1183 (A,45,58) RS1/16SS0R0J
Circuit Symbol and No. Part No.
DVH-3200UB/XNUW5 125
5 6 7 8
5 6 7 8
C
D
F
A
B
E
R 1184 (A,45,57) RS1/16SS8202DR 1187 (A,48,57) RS1/10SR0R0JR 1188 (A,40,68) RS1/8SQ2R2JR 1189 (A,28,51) RS1/10SR103JR 1190 (A,28,65) RS1/10SR103J
R 1191 (A,47,61) RS1/10SR102J
CAPACITORS
C 101 (A,60,44) CKSSYB104K16C 102 (A,71,36) CKSSYB104K10C 104 (A,70,35) CKSQYB475K6R3C 111 (A,87,60) CKSSYB104K16C 112 (A,87,48) CKSSYB104K16
C 122 (A,78,29) CKSSYB104K16C 173 (A,15,82) CKSSYB102K16C 174 (A,19,94) CEJQ470M6R3C 181 (A,19,100) CEJQ220M10C 182 (A,16,87) CEJQ331M6R3
C 183 (A,30,92) CKSSYB104K16C 184 (A,21,82) CEJQ330M10C 201 (A,113,88) CKSRYB105K10C 202 (A,113,89) CKSRYB105K10C 204 (A,110,90) CKSRYB105K10
C 206 (A,110,91) CKSRYB105K10C 208 (A,110,93) CKSRYB224K16C 211 (A,94,96) CKSRYB224K16C 212 (A,92,92) CKSRYB105K10C 213 (A,94,95) CKSRYB105K10
C 215 (A,94,94) CKSRYB105K10C 217 (A,89,93) CKSRYB105K10C 221 (A,89,83) CEJQ100M16C 222 (A,89,89) CEJQ470M16C 223 (A,94,86) CKSSYB104K16
C 231 (A,27,110) (C,F) CKSYB225K16C 232 (A,25,112) (C,F) CKSYB225K16C 233 (A,27,113) (C,F) CCSSCH101J50C 234 (A,31,103) (C,F) CEJQ100M16C 241 (A,27,119) (C,F) CKSYB225K16
C 242 (A,25,119) (C,F) CKSYB225K16C 243 (A,30,121) (C,F) CCSSCH101J50C 251 (A,77,126) CKSRYB474K10C 252 (A,75,126) CKSRYB474K10
C 253 (A,77,129) CKSQYB474K16C 254 (A,75,129) CKSQYB474K16C 255 (A,87,124) CKSRYB474K10
C 256 (A,88,119) CKSRYB474K10C 257 (A,90,124) CKSQYB474K16C 258 (A,86,122) CKSQYB474K16C 261 (A,68,127) CEJQ330M10C 262 (A,120,118) 3 300 uF/16 V CCH1486
C 263 (A,65,131) CKSSYB104K16C 271 (A,71,132) 10 uF CCG1182C 272 (A,80,127) CKSYB475K16C 273 (A,83,125) CKSYB475K16C 274 (A,119,124) CKSSYB473K16
C 283 (A,37,99) CEJQ2R2M50C 284 (A,42,99) CEJQ2R2M50C 287 (A,33,129) CKSSYB102K50
Circuit Symbol and No. Part No.C 288 (A,35,128) CKSSYB102K50C 311 (A,23,127) CCSSCH150J50
C 312 (A,20,126) CKSQYB106K6R3C 313 (A,21,125) CKSSYB104K10C 331 (A,142,136) (A,B) CKSRYB104K16C 332 (A,142,133) (A,B) CKSRYB104K16C 451 (A,157,61) CKSYB475K10
C 452 (A,159,62) CKSSYB103K25C 453 (A,152,64) CEJQ470M6R3C 454 (A,159,70) CKSSYB102K50C 456 (A,151,70) CEJQ470M6R3C 471 (A,156,94) CKSSYB103K25
C 472 (A,153,89) CEJQ101M16C 473 (A,159,87) CCSSCH330J50C 475 (A,157,72) CKSSYB102K50C 602 (A,137,65) CKSSYB103K25C 603 (A,138,64) CKSRYB105K10
C 605 (A,124,66) CCSSCH200J50C 606 (A,123,66) (A,B) CCSSCH180J50
(A,123,66) (C,D,E,F) CCSSCH200J50C 607 (A,111,66) CCSSCH101J50C 661 (A,107,62) CKSSYB104K10C 701 (A,115,14) CCSRCH221J50
C 702 (A,119,14) CCSRCH221J50C 703 (A,106,14) CCSRCH221J50C 704 (A,107,14) CCSRCH221J50C 705 (A,126,14) CCSRCH221J50C 751 (A,102,123) CKSRYB104K16
C 781 (A,109,122) (A,B) CKSRYB104K16C 801 (A,123,131) CKSRYB104K16C 1001 (A,83,28) CKSSYB224K6R3C 1002 (A,84,30) CKSSYB224K6R3C 1011 (A,146,60) CKSQYB225K10
C 1013 (A,148,44) CKSYB106K10C 1014 (A,156,44) CEJQ101M10C 1021 (A,19,107) CEJQ101M10C 1022 (A,22,103) CKSSYB103K25C 1023 (A,17,119) CEJQ101M16
C 1042 (A,137,21) CKSSYB102K50C 1051 (A,153,19) CKSSYB103K25C 1052 (A,152,24) CEJQ101M16C 1053 (A,164,27) CKSSYB103K25C 1054 (A,154,33) CEAT102M16
C 1061 (A,134,11) CKSRYB104K16C 1062 (A,138,11) CKSRYB104K16C 1101 (A,71,27) CKSSYB105K6R3C 1102 (A,71,24) CKSRYB105K6R3C 1111 (A,74,31) CKSSYB224K6R3
C 1112 (A,75,37) CKSSYB224K6R3C 1121 (A,67,33) 10 uF CCG1236C 1122 (A,69,33) CKSSYB104K10C 1131 (A,57,59) 10 uF CCG1236C 1132 (A,58,55) CKSSYB104K10
C 1141 (A,29,65) CKSRYB333K25C 1142 (A,22,64) CKSYB105K35C 1143 (A,32,38) 10 uF CCG1223C 1144 (A,29,73) 10 uF CCG1223C 1145 (A,29,51) CKSRYB333K25
C 1154 (A,54,33) CEHAZL331M16C 1161 (A,41,48) CKSQYB335K10
Circuit Symbol and No. Part No.
DVH-3200UB/XNUW5126
1 2 3 4
1 2 3 4
C
D
F
A
B
E
C 1163 (A,43,53) CCSSCH221J50C 1164 (A,43,55) CKSSYB473K16C 1165 (A,39,54) CKSSYB103K25
C 1181 (A,40,63) CKSSYB103K25C 1182 (A,43,63) CKSSYB473K16C 1183 (A,44,61) CCSSCH221J50C 1184 (A,40,65) CKSYB105K35C 1185 (A,33,65) CKSQYB335K10
C 1191 (A,42,81) CEHAZL331M16C 1195 (A,56,22) 3 300 uF/16 V CCH1486C 1196 (A,22,57) 10 uF CCG1223C 1197 (A,22,61) CKSYB105K35C 1198 (A,21,38) CKSYB105K35
BUnit Number :Unit Name : Keyboard Unit
MISCELLANEOUS
IC 1801 (B,125,27) IC PD6497AIC 1802 (A,123,11) Remote IC GP1UXC14RKD 1801 (B,98,28) Diode MC2848-11D 1802 (B,102,28) Diode MC2846-11D 1851 (A,166,25) White LED SMLXA4WBETW1(Z1)
D 1852 (A,64,23) LED(A) CL-195SR-CD(A,64,23) LED(B) CL-195PG-CD
D 1853 (A,63,14) LED(A) CL-195SR-CD(A,63,14) LED(B) CL-195PG-CD
D 1854 (A,71,13) LED(A) CL-195SR-CD(A,71,13) LED(B) CL-195PG-CD
D 1855 (A,79,35) LED(A) CL-195SR-CD(A,79,35) LED(B) CL-195PG-CD
D 1856 (A,71,30) LED(A) CL-195SR-CD(A,71,30) LED(B) CL-195PG-CD
D 1857 (A,63,29) LED(A) CL-195SR-CD(A,63,29) LED(B) CL-195PG-CD
D 1858 (A,55,28) LED(A) CL-195SR-CD(A,55,28) LED(B) CL-195PG-CD
D 1859 (A,37,26) LED(A) CL-195SR-CD(A,37,26) LED(B) CL-195PG-CD
D 1860 (A,45,11) LED(A) CL-195SR-CD(A,45,11) LED(B) CL-195PG-CD
D 1861 (A,28,30) LED(A) CL-195SR-CD(A,28,30) LED(B) CL-195PG-CD
D 1862 (A,26,23) LED(A) CL-195SR-CD(A,26,23) LED(B) CL-195PG-CD
D 1863 (A,28,13) LED(A) CL-195SR-CD(A,28,13) LED(B) CL-195PG-CD
D 1864 (A,15,32) LED(A) CL-195SR-CD(A,15,32) LED(B) CL-195PG-CD
D 1865 (A,10,39) LED(A) CL-195SR-CD(A,10,39) LED(B) CL-195PG-CD
D 1866 (A,15,9) LED(A) CL-195SR-CD(A,15,9) LED(B) CL-195PG-CD
D 1867 (A,91,10) LED(A) CL-195SR-CD(A,91,10) LED(B) CL-195PG-CD
D 1868 (A,79,8) LED(A) CL-195SR-CD(A,79,8) LED(B) CL-195PG-CD
D 1869 (A,150,44) LED(A) CL-195SR-CD
Circuit Symbol and No. Part No.(A,150,44) LED(B) CL-195PG-CD
D 1870 (A,166,43) LED(A) CL-195SR-CD(A,166,43) LED(B) CL-195PG-CD
D 1871 (A,65,23) LED(C,D,E,F) CL-197HB1-D(CDE)
D 1872 (A,64,14) LED(C,D,E,F) CL-197HB1-D(CDE)D 1873 (A,72,13) LED(C,D,E,F) CL-197HB1-D(CDE)D 1874 (A,81,35) LED(C,D,E,F) CL-197HB1-D(CDE)D 1875 (A,72,30) LED(C,D,E,F) CL-197HB1-D(CDE)D 1876 (A,64,29) LED(C,D,E,F) CL-197HB1-D(CDE)
D 1880 (A,30,30) LED(C,D,E,F) CL-197HB1-D(CDE)D 1881 (A,28,23) LED(C,D,E,F) CL-197HB1-D(CDE)D 1882 (A,30,13) LED(C,D,E,F) CL-197HB1-D(CDE)D 1883 (A,16,32) LED(C,D,E,F) CL-197HB1-D(CDE)D 1884 (A,11,39) LED(C,D,E,F) CL-197HB1-D(CDE)
D 1885 (A,16,9) LED(C,D,E,F) CL-197HB1-D(CDE)D 1886 (A,93,10) LED(C,D,E,F) CL-197HB1-D(CDE)D 1887 (A,81,8) LED(C,D,E,F) CL-197HB1-D(CDE)D 1888 (A,150,42) LED(C,D,E,F) CL-197HB1-D(CDE)D 1889 (A,166,42) LED(C,D,E,F) CL-197HB1-D(CDE)
D 1911 (B,152,19) Diode DZ2S068CD 1912 (B,150,25) Diode DZ2S068CL 1911 (B,150,24) Inductor CTF1713X 1801 (B,115,26) 5.00 MHz CSS1731S 1845 (A,46,22) Rotary Switch CSD1153
VA1901 (B,161,21) Varistor EZJZ1V270RMVA1902 (B,160,23) Varistor EZJZ1V270RMVA1903 (B,157,23) Varistor EZJZ1V270RMLCD1801 (A,160,35) LCD CAW1964CN1821 (B,111,12) Connector CKS6049
CN1901 (A,156,11) Jack CKN1082CN1911 (A,140,11) Connector YKS5036
RESISTORS
R 1802 (B,105,26) RS1/10SR2R2JR 1804 (B,147,22) RS1/10SR101JR 1805 (B,102,25) RS1/10SR222JR 1806 (B,103,23) RS1/10SR222JR 1821 (B,60,10) RS1/10SR103J
R 1825 (B,12,23) RS1/10SR0R0JR 1826 (B,18,23) RS1/10SR0R0JR 1851 (B,159,27) RS1/4SA821JR 1852 (B,71,30) (A) RS1/4SA681J
(B,71,30) (B) RS1/4SA821J
R 1853 (B,76,30) (A) RS1/4SA681J(B,76,30) (B) RS1/4SA821J
R 1854 (B,64,12) (A) RS1/4SA681J(B,64,12) (B) RS1/4SA561J
R 1855 (B,26,24) (A) RS1/4SA681J(B,26,24) (B) RS1/4SA561J
R 1856 (B,28,19) (A) RS1/4SA681J(B,28,19) (B) RS1/4SA561J
R 1857 (B,83,17) (A,B) RS1/4SA102JR 1858 (B,157,26) (A) RS1/4SA152J
(B,157,26) (B) RS1/4SA222J
R 1866 (B,70,20) (A,B) RS1/10SR0R0JR 1871 (B,69,20) (C,D,E,F) RS1/10SR0R0JR 1872 (B,69,32) (C,D,E,F) RS1/10SR821JR 1873 (B,77,32) (C,D,E,F) RS1/10SR102JR 1875 (B,31,20) (C,D,E,F) RS1/10SR102J
Circuit Symbol and No. Part No.
DVH-3200UB/XNUW5 127
5 6 7 8
5 6 7 8
C
D
F
A
B
E
R 1876 (B,23,20) (C,D,E,F) RS1/10SR102JR 1877 (B,88,11) (C,D,E,F) RS1/10SR272JR 1878 (B,157,32) (C,D,E,F) RS1/10SR272JR 1901 (B,160,21) RS1/10SR101JR 1902 (B,159,21) RS1/10SR101J
CAPACITORS
C 1801 (B,148,20) CKSYF106Z10C 1802 (B,88,18) CKSRYB105K16C 1901 (B,157,22) CKSRYB472K50C 1902 (B,157,20) CKSRYB472K50
CUnit Number : YWX5007Unit Name : DVD Core Unit
MISCELLANEOUS
IC 1002 (B,21,41) Regulator IC S-1133B50-U5IC 1003 (B,35,23) IC S-1200B50-M5IC 1004 (B,25,11) IC NJM2885DL1-33IC 1005 (B,19,21) IC R1232D121BIC 1201 (A,15,29) IC BD8231EFV
*IC1401 (B,63,36) Flash ROM Unit CWW1753*IC1402 (B,50,36) Flash ROM Unit CWW1754IC 1480 (B,59,13) SDRAM(64M) K4S641632N-LC75IC 1501 (A,60,20) IC MN2DS0018MAUBIC 1801 (B,37,16) D/A Converter PCM1753DBQ
IC 1951 (B,76,32) Logic IC TC7SZU04FUQ 1101 (A,35,39) Transistor 2SC4081Q 1102 (A,46,42) Transistor 2SC4081Q 1103 (A,38,45) Transistor 2SB1132Q 1104 (A,45,49) Transistor 2SB1132
L 1003 (B,22,26) Inductor CTF1677L 1004 (B,14,17) Inductor CTF1678L 1512 (A,57,5) Inductor CTF1743L 1902 (B,5,8) Inductor CTF1487L 1903 (B,12,11) Inductor CTF1558
L 1904 (B,46,19) Inductor CTF1473X 1501 (B,43,7) Oscillator 27.000 MHz CSS1768X 1950 (B,76,35) Oscillator 48.000 MHz CSS1760EF1001 (B,5,12) Chip EMI Filter DTF1106EF1002 (B,11,13) Chip EMI Filter DTL1106
RESISTORS
R 1002 (B,18,27) RS1/16SS101JR 1004 (A,29,27) RS1/16SS4702DR 1007 (A,29,26) RS1/16SS6801DR 1019 (B,15,9) RS1/16SS101JR 1021 (A,27,15) RS1/16SS0R0J
R 1025 (B,19,11) RS1/16SS101JR 1027 (A,27,19) RS1/16SS101JR 1101 (A,35,36) RS1/16SS104JR 1102 (A,43,42) RS1/16SS104JR 1103 (A,34,41) RS1/16SS391J
R 1104 (A,36,36) RS1/16SS511JR 1105 (A,42,44) RS1/16SS391JR 1106 (A,45,39) RS1/16SS561JR 1109 (A,34,43) RS1/16SS3R3JR 1110 (A,41,43) RS1/16SS3R3J
Circuit Symbol and No. Part No.
R 1111 (A,38,39) RS1/10SR1R5JR 1112 (A,38,38) RS1/10SR1R5JR 1113 (A,49,46) RS1/10SR1R5JR 1114 (A,48,46) RS1/10SR1R5JR 1115 (A,41,38) RS1/10SR1R5J
R 1116 (A,41,39) RS1/10SR1R5JR 1117 (A,48,43) RS1/10SR1R5JR 1118 (A,49,43) RS1/10SR1R5JR 1201 (A,16,36) RS1/16SS221JR 1202 (A,17,35) RS1/16SS221J
R 1203 (A,22,35) RS1/16SS103JR 1204 (A,19,35) RS1/16SS153JR 1212 (A,7,36) RS1/16SS271JR 1213 (B,8,29) RS1/16SS1R0JR 1214 (B,8,27) RS1/16SS1R0J
R 1215 (B,8,28) RS1/16SS1R0JR 1216 (B,8,24) RS1/16SS1R0JR 1217 (B,8,25) RS1/16SS1R0JR 1218 (B,8,26) RS1/16SS1R0JR 1222 (B,26,39) RS1/16SS271J
R 1300 (B,39,24) RS1/16SS0R0JR 1401 (B,63,49) RS1/16SS221JR 1402 (B,70,27) RS1/16SS104JR 1405 (B,56,24) RS1/16SS104JR 1406 (B,54,25) RS1/16SS104J
R 1480 (B,52,21) RAB4CQ560JR 1481 (B,56,21) RAB4CQ560JR 1482 (B,61,21) RAB4CQ560JR 1483 (B,64,21) RAB4CQ560JR 1484 (B,67,21) RAB4CQ560J
R 1485 (B,50,5) RAB4CQ560JR 1486 (B,55,5) RAB4CQ560JR 1487 (B,64,5) RAB4CQ560JR 1488 (B,68,5) RAB4CQ560JR 1489 (B,59,5) RS1/16SS560J
R 1490 (B,50,21) RS1/16SS560JR 1501 (B,46,7) RS1/16SS122JR 1503 (B,45,8) RS1/16SS105JR 1504 (B,45,13) RS1/16SS120JR 1505 (A,43,13) RS1/16SS101J
R 1506 (A,37,14) RS1/16SS101JR 1507 (A,44,14) RS1/16SS101JR 1508 (A,43,15) RS1/16SS221JR 1509 (A,63,35) RS1/16SS102JR 1510 (A,64,35) RS1/16SS102J
R 1511 (B,46,13) RS1/16S0R0JR 1512 (A,58,5) RS1/16SS101JR 1513 (A,66,35) RS1/16SS103JR 1514 (A,68,35) RS1/16SS183JR 1516 (A,65,36) RS1/16SS103J
R 1517 (A,76,16) RS1/16SS103JR 1518 (A,74,24) RS1/16SS103JR 1519 (A,70,34) RS1/16SS102JR 1522 (A,65,38) RS1/16SS104JR 1523 (A,66,37) RS1/16SS221J
R 1524 (A,64,37) RS1/16SS472JR 1525 (A,71,34) RS1/16SS103JR 1526 (A,67,34) RS1/16SS103JR 1527 (B,77,29) RS1/16SS682JR 1528 (A,78,20) RS1/16SS103J
Circuit Symbol and No. Part No.
DVH-3200UB/XNUW5128
1 2 3 4
1 2 3 4
C
D
F
A
B
E
R 1529 (A,76,18) RS1/16SS103JR 1530 (A,77,20) RS1/16SS103JR 1531 (A,75,24) RS1/16SS103JR 1532 (B,70,33) RS1/16SS101JR 1534 (A,78,30) RS1/16SS221J
R 1535 (B,70,34) RS1/16SS104JR 1536 (A,78,31) RS1/16SS104JR 1537 (A,73,35) RS1/16SS104JR 1538 (A,61,4) RS1/16SS104JR 1539 (A,77,23) RS1/16SS104J
R 1540 (A,73,32) RS1/16SS221JR 1541 (A,75,32) RS1/16SS221JR 1542 (A,77,29) RS1/16SS103JR 1543 (B,75,28) RS1/16SS181JR 1544 (B,77,28) RS1/16SS181J
R 1546 (B,75,29) RS1/16SS682JR 1601 (A,42,25) RS1/16SS123JR 1602 (A,44,25) RS1/16SS123JR 1603 (A,43,30) RN1/16SE1002DR 1604 (A,50,35) RS1/16SS105J
R 1605 (A,49,37) RS1/16SS105JR 1670 (A,34,21) RS1/16SS1002DR 1671 (A,36,21) RS1/16SS2402DR 1672 (A,45,19) RS1/16SS2000DR 1674 (A,45,20) RS1/16SS3002D
R 1801 (B,35,6) RS1/16SS104JR 1802 (B,33,6) RS1/16SS104JR 1803 (B,35,11) RS1/16SS821JR 1804 (B,34,11) RS1/16SS821JR 1950 (A,42,16) RS1/16S24R0F
R 1951 (A,42,18) RS1/16S24R0FR 1952 (B,78,34) RS1/16SS105JR 1953 (B,74,34) RS1/16SS681JR 1954 (A,35,17) RS1/16SS153JR 1955 (A,40,14) RS1/16SS153J
R 1956 (A,40,18) RS1/16SS0R0JR 1957 (A,40,15) RS1/16SS0R0J
CAPACITORS
C 1001 (B,36,21) CKSRYB105K10C 1003 (B,18,44) CKSSYB104K16C 1004 (B,24,40) CKSQYB475K10C 1005 (B,32,23) CKSRYB105K16C 1008 (B,20,31) 10 uF DCH1201
C 1009 (B,18,31) 10 uF DCH1201C 1010 (B,26,18) CKSQYB225K10C 1011 (B,22,18) CKSRYB105K10C 1013 (B,15,25) 10 uF DCH1201C 1014 (B,13,25) 10 uF DCH1201
C 1015 (B,7,8) CKSSYB102K50C 1016 (B,12,10) CKSSYB102K50C 1018 (A,28,28) CKSSYB104K10C 1019 (A,10,17) CKSSYB104K10C 1021 (B,34,4) CCSRCH681J50
C 1022 (A,23,21) CCSRCH681J50C 1101 (B,31,40) 10 uF DCH1201C 1104 (A,34,42) CKSSYB104K10C 1105 (A,42,45) CKSSYB104K10C 1106 (A,37,48) CKSSYB103K16
Circuit Symbol and No. Part No.
C 1107 (A,41,49) CKSSYB103K16C 1108 (A,74,42) CKSSYB103K16C 1109 (A,56,41) CKSRYB224K10C 1110 (A,71,42) CKSSYB103K16C 1111 (A,61,39) CKSRYB224K10
C 1112 (B,40,39) 22 uF CCG1178C 1113 (B,36,38) 22 uF CCG1178C 1201 (B,12,34) CEVW101M16C 1204 (A,8,24) CKSSYB222K50C 1205 (A,13,23) CKSSYB104K16
C 1207 (A,22,25) CKSSYB104K16C 1208 (A,15,36) CKSSYB103K16C 1209 (B,10,25) CKSSYB104K16C 1210 (B,6,23) CKSSYB104K16C 1211 (B,9,22) CKSYB475K16
C 1401 (B,63,48) CKSSYB103K16C 1403 (B,69,23) CKSSYB104K10C 1404 (B,58,25) CKSQYB475K6R3C 1408 (B,47,25) CKSSYB104K10C 1409 (B,47,23) CKSQYB475K6R3
C 1480 (B,47,21) CKSSYB104K10C 1481 (B,49,23) CKSSYB104K10C 1482 (B,54,21) CKSSYB104K10C 1484 (B,59,20) CKSSYB104K10C 1485 (B,69,21) CKSSYB104K10
C 1487 (B,58,4) CKSSYB104K10C 1488 (B,52,5) CKSSYB104K10C 1489 (B,45,20) CKSQYB106K6R3C 1490 (B,45,23) CKSSYB102K50C 1501 (B,72,9) CKSQYB106K6R3
C 1502 (A,35,32) CKSQYB106K6R3C 1503 (A,60,4) CKSSYB104K10C 1504 (A,51,5) CKSSYB104K10C 1505 (A,53,5) CKSSYB104K10C 1506 (A,55,5) CKSSYB104K10
C 1507 (A,62,5) CKSSYB104K10C 1508 (A,66,5) CKSSYB104K10C 1509 (A,69,5) CKSSYB104K10C 1510 (B,46,5) CCSSCH120J50C 1511 (A,46,9) CKSSYB104K10
C 1512 (B,43,10) CCSSCH100D50C 1513 (B,74,12) CKSSYB104K10C 1514 (A,46,13) CKSSYB104K10C 1515 (A,45,15) CKSSYB104K10C 1516 (A,75,15) CKSSYB104K10
C 1517 (A,74,16) CKSSYB104K10C 1518 (A,75,22) CKSSYB104K10C 1519 (A,74,26) CKSSYB104K10C 1520 (A,75,30) CKSSYB104K10C 1521 (A,60,37) CKSSYB104K10
C 1522 (A,65,34) CKSSYB104K10C 1523 (A,68,37) CKSSYB104K10C 1524 (A,69,37) CKSSYB473K10C 1526 (A,68,37) CKSSYB103K16C 1528 (A,78,29) CCSSCH471J16
C 1601 (A,44,29) CKSSYB103K16C 1602 (A,42,24) CCSSCH101J50C 1603 (A,44,27) CCSSCH101J50C 1604 (A,41,27) CCSSCH680J50C 1605 (A,43,27) CCSSCH680J50
Circuit Symbol and No. Part No.
DVH-3200UB/XNUW5 129
5 6 7 8
5 6 7 8
C
D
F
A
B
E
C 1606 (A,41,23) CKSSYB104K10C 1607 (A,41,35) CKSQYB106K6R3C 1608 (A,43,36) CKSRYB105K10C 1609 (A,48,35) CKSSYB104K10C 1610 (A,50,37) CKSSYB104K10
C 1611 (A,51,37) CKSSYB104K10C 1612 (A,52,34) CKSSYB104K10C 1613 (A,52,37) CKSSYB104K10C 1614 (A,53,34) CKSSYB104K10C 1615 (A,54,34) CKSSYB104K10
C 1616 (A,54,37) CKSSYB104K10C 1617 (A,54,38) CKSSYB104K10C 1618 (A,56,34) CCSSCH101J50C 1619 (A,57,34) CKSSYB562K25C 1620 (A,58,34) CKSSYB224K6R3
C 1621 (A,57,37) CKSSYB224K6R3C 1622 (A,59,35) CKSSYB333K16C 1623 (A,45,35) CKSRYB105K10C 1624 (A,58,37) CKSSYB104K10C 1625 (A,56,37) CKSSYB104K10
C 1671 (A,44,17) CKSSYB104K10C 1672 (A,45,18) CKSSYB104K10C 1673 (A,45,22) CKSSYB104K10C 1674 (A,43,21) CKSSYB104K10C 1676 (A,38,22) CKSRYB105K10
C 1801 (B,34,8) CKSQYB475K6R3C 1802 (B,32,8) CKSQYB475K6R3C 1803 (B,36,8) CCSRCH182J50C 1804 (B,31,7) CCSRCH182J50C 1805 (B,32,19) CKSSYB104K10
C 1806 (B,39,9) 10 uF DCH1201C 1809 (B,43,16) CKSSYB104K10C 1934 (B,42,29) CCSRCH680J50C 1950 (B,73,33) CKSSYB104K10C 1951 (B,74,36) CCSSCH100D50
C 1952 (B,78,36) CCSSCH100D50C 1954 (B,43,49) CCSRCH470J50
DUnit Number :Unit Name : Connect PCB
MISCELLANEOUS
S 101 (B,51,37) Switch(HOME) CSN1068S 102 (B,12,23) Switch(DSCSNS) CSN1068S 103 (B,22,10) Switch(8SNS) CSN1068R 101 (B,52,27) RS1/16S101JR 102 (B,15,29) RS1/16S101J
R 103 (B,16,11) RS1/16S101JC 101 (B,51,23) CKSRYB104K50
Miscellaneous Parts List
Pickup Unit(Service) CXX2398M 1 Motor Unit(LOAD/CRG) CXC4026M 2 Motor(SPINDLE) EXM1050
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.