Philips HTS3455

DVD Receiver

HTS3455/51/96/98

CLASS 1 LASER PRODUCT

Contents1 2 3 4 5 6 7 Technical Specications and Connection Facilities Measurements Setup, Service Aid & Lead Free Requirements Directions For Use Dismantling Instructions & Service Positions Service Test Program Block Diagram, Wiring Diagram Wiring Diagram Circuit Diagram and PWB Layout AV Board: Circuit Diagram Layout: AV Board (Top view) Layout: AV Board (Bottom view) Display Board Layout: Display Board (Top view) Layout: Display Board (Bottom view) AV Interface Board: Circuit Diagram Layout: AV Interface Board (Top view) Layout: AV Interface Board (Bottom view) PCBA 9.1 Board: Circuit Diagram Layout: PCBA 9.1 Board (Top view) Layout: PCBA 9.1 Board (Bottom view) Standby Board Layout: Standby Board (Top view) Layout: Standby Board (Bottom view)

Page2 4 9 11 14 17 17 18 18 22 23 24 25 25 26 28 28 29 32 33 34 34 34

Contents8 9 Exploded View & Spare Parts List Exploded View of the set Spare Part List Active Subwoofer SW3455

Page35 35 36 37

Copyright 2006 Philips Consumer Electronics B.V. Eindhoven, The Netherlands. All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by KC-TE 0624 AV Systems Printed in the Netherlands

Subject to modication

EN 3139 785 31590

Version 1.0

EN 2

1.

3139 785 31590

Technical Specications and Connection Facilities

LOCATION OF PC BOARDS

AV Board

AV Interface Board PCBAS 9.1

Tuner

PSU

Loader

PCBAS Front Panel

HTS3455

VERSION VARIATIONS: Type /Versions: Features & Progressive Scan Digital-In (Coax) TV-In Aux-In Y/Pb/Pr (YUV) Component Video Output CVBS S-Video Output SCART VGA /96 x x x x x x x x HTS3445 /98 x x x x x x x x /51 x x x x x x x x

Technical Specications and Connection Facilities

3139 785 31590

1.

EN 3

1. Specications1.1 General:Mains voltage Mains frequency Power consumption : 120V/230V : 50/60Hz : 12W < 0.5W Eco standby power < 70W at 1/8 P rated (For main unit) : 340 x 70 x 330mm

1.3

AMPLIFIER:Output power Front Rear Center Subwoofer : : : : 125W RMS / channel 125W RMS / channel 250W RMS 250W RMS

Dimension main unit

Frequency response 0.5dB : 20Hz-20kHz Hum (Volume Minimum) : 200nW Residual noise (Volume Minimum) : 40nW Input sensitivity Aux In Scart In Output sensitivity Line Out (Left/Right) Scart Out (Left/Right)

1.2

Tuner FMTuning range : Grid : IF frequency : Aerial input : Sensitivity at 26dB S/N : Selectivity at 600kHz bandwidth : IF rejection : Image rejection : Distortion at RF=1mV, dev. 75kHz : -3dB Limiting point : Crosstalk at RF=1mV, dev. 67.5kHz : Crosstalk at RF=1mV, dev. 40kHz : 87.5-108MHz 100kHz 10.7MHz 25kHz 75 coaxial < 7V > 25dB > 60dB > 25dB < 3% 8V > 28dB > 18dB

: 1V 3dB at 22k : 0.5V 3dB at 22k : 1V 2dB at 10k : 1V 2dB at 10k

1.4

COMPACT DISC/VCD/DVD:Video Decoding Video DAC Signal System Video Format : MPEG-1/MPEG-2/ DivX 3/4/5/6, Ultra : 12 Bits : PAL / NTSC : 4:3 / 16:9

MWTuning range Grid IF frequency Aerial input Sensitivity at 26dB S/N Selectivity at 18kHz bandwidth IF rejection Image rejection Distortion at RF=50mV, m=80% : 531-1602kHz 530-1700kHz : 9kHz 10kHz : 450kHz 1kHz : Frame aerial : < 4.0mV/M : > 20dB : > 45dB : > 28dB : < 5%

CVBS Out 1) CVBS level Luminance S/N

: 1.0 0.1V p-p : >= 55dB

S-Video Out 1) Y level Y S/N C level (burst)

: 1.0 0.1V p-p : >= 55dB : 286mV pp +1/-4 dB (NTSC)

RGB/YUV Out 1) Amplitude S/N

: 0.7 0.1Vp-p : >= 60dB

1)

Output terminals to be terminated with 75

EN 4

2.

3139 785 31590

Measurements Setup, Service Aid & Lead Free Requirements

2. Measurements Setup, Service Aid & Lead Free RequirementsMEASUREMENT SETUPTuner FMDUT RF Generatore.g. PM5326

Bandpass 250Hz-15kHze.g. 7122 707 48001

LF Voltmetere.g. PM2534

Ri=50

S/N and distortion metere.g. Sound Technology ST1700B

Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).

Tuner AM (MW,LW)DUTBandpass 250Hz-15kHze.g. 7122 707 48001

LF Voltmetere.g. PM2534

RF Generatore.g. PM5326


Ri=50

Frame aeriale.g. 7122 707 89001

To avoid atmospheric interference all AM-measurements have to be carried out in a Faradays cage. Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).

CDUse Audio Signal Disc (replaces test disc 3) SBC429 4822 397 30184

RecorderUse Universal Test Cassette CrO2 SBC419 4822 397 30069 or Universal Test Cassette Fe SBC420 4822 397 30071DUTL R R

DUTL

LF Generatore.g. PM5110



LEVEL METERe.g. Sennheiser UPM550 with FF-filter

LEVEL METERe.g. Sennheiser UPM550 with FF-filter


3139 785 31590

2.

EN 5

SERVICE AIDSService Tools: Universal Torx driver holder .................................. 4822 395 91019 Torx bit T10 150mm ............................................. 4822 395 50456 Torx driver set T6 - T20 ......................................... 4822 395 50145 Torx driver T10 extended ...................................... 4822 395 50423 Compact Disc: SBC426/426A Test disc 5 + 5A ............................ 4822 397 30096 SBC442 Audio Burn-in Test disc 1kHz ................. 4822 397 30155 SBC429 Audio Signals disc .................................. 4822 397 30184 Dolby Pro-logic Test Disc ...................................... 4822 395 10216

HANDLING CHIP COMPONENTS

EN 6

2.

3139 785 31590


GB

WARNING

ESD

NL

WAARSCHUWING

All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential.

Alle ICs en vele andere halfgeleiders zijn gevoelig voor electrostatische ontladingen (ESD). Onzorgvuldig behandelen tijdens reparatie kan de levensduur drastisch doen verminderen. Zorg ervoor dat u tijdens reparatie via een polsband met weerstand verbonden bent met hetzelfde potentiaal als de massa van het apparaat. Houd componenten en hulpmiddelen ook op ditzelfde potentiaal.

F

ATTENTION

D

WARNUNG

Tous les IC et beaucoup dautres semi-conducteurs sont sensibles aux dcharges statiques (ESD). Leur longvit pourrait tre considrablement courte par le fait quaucune prcaution nest prise leur manipulation. Lors de rparations, sassurer de bien tre reli au mme potentiel que la masse de lappareil et enfiler le bracelet serti dune rsistance de scurit. Veiller ce que les composants ainsi que les outils que lon utilise soient galement ce potentiel.

Alle ICs und viele andere Halbleiter sind empfindlich gegenber elektrostatischen Entladungen (ESD). Unsorgfltige Behandlung im Reparaturfall kan die Lebensdauer drastisch reduzieren. Veranlassen Sie, dass Sie im Reparaturfall ber ein Pulsarmband mit Widerstand verbunden sind mit dem gleichen Potential wie die Masse des Gertes. Bauteile und Hilfsmittel auch auf dieses gleiche Potential halten.

I

AVVERTIMENTO

Tutti IC e parecchi semi-conduttori sono sensibili alle scariche statiche (ESD). La loro longevit potrebbe essere fortemente ridatta in caso di non osservazione della pi grande cauzione alla loro manipolazione. Durante le riparazioni occorre quindi essere collegato allo stesso potenziale che quello della massa dellapparecchio tramite un braccialetto a resistenza. Assicurarsi che i componenti e anche gli utensili con quali si lavora siano anche a questo potenziale.

GB

ESD PROTECTION EQUIPMENT:

Complete Kit ESD3 (small tablemat, wristband, connection box, extention cable and earth cable) ........... 4822 310 10671 Wristband tester .................................................................... 4822 344 13999

GBSafety regulations require that the set be restored to its original condition and that parts which are identical with those specified, be used Safety components are marked by the symbol!

.

CLASS 1 LASER PRODUCT

NLVeiligheidsbepalingen vereisen, dat het apparaat bij reparatie in zijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen, identiek aan de gespecificeerde, worden toegepast. De Veiligheidsonderdelen zijn aangeduid met het symbool!

GB

Warning !

Invisible laser radiation when open. Avoid direct exposure to beam.

FLes normes de scurit exigent que lappareil soit remis ltat dorigine et que soient utiliss les pices de rechange identiques celles spcifies. Less composants de scurit sont marqus!

S

Varning !

Osynlig laserstrlning nr apparaten r ppnad och sprren r urkopplad. Betrakta ej strlen.

DBei jeder Reparatur sind die geltenden Sicherheitsvorschriften zu beachten. Der Original zustand des Gerts darf nicht verndert werden; fr Reparaturen sind Original-Ersatzteile zu verwenden. Sicherheitsbauteile sind durch das Symbol!

SF

Varoitus !

Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina nkymttmlle laseristeilylle. l katso steeseen!

markiert.

DK ILe norme di sicurezza esigono che lapparecchio venga rimesso nelle condizioni originali e che siano utilizzati i pezzi di ricambio identici a quelli specificati. Componenty di sicurezza sono marcati con!

Advarse !

Usynlig laserstrling ved bning nr sikkerhedsafbrydere er ude af funktion. Undg udsaettelse for strling.

GBAfter servicing and before returning set to customer perform a leakage current measurement test from all exposed metal parts to earth ground to assure no shock hazard exist. The leakage current must not exceed 0.5mA.

F"Pour votre scurit, ces documents doivent tre utiliss par des spcialistes agrs, seuls habilits rparer votre appareil en panne".


3139 785 31590

2.

EN 7

2.1 Lead Free Requirements Pb(Lead) Free SolderWhen soldering , be sure to use the pb free solder. For sets produced before 1.1.2005 (except products of 2004), containing leaded solder-alloy and components, all needed spare-parts will be available till the end of the service-period. For repair of such sets nothing changes. On our website www.atyourservice.ce.Philips.com you nd more information to: BGA-de-/soldering (+ baking instructions) Heating-proles of BGAs and other ICs used in Philips-sets You will nd this and more technical information within the magazine, chapter workshop news. For additional questions please contact your local repair-helpdesk.

INDENTIFICATION:

Regardless of special logo (not always indicated) one must treat all sets from 1 Jan 2005 onwards, according next rules: Important note: In fact also products of year 2004 must be treated in this way as long as you avoid mixing solder-alloys (leaded/ lead-free). So best to always use SAC305 and the higher temperatures belong to this. Due to lead-free technology some rules have to be respected by the workshop during a repair: Use only lead-free solder alloy Philips SAC305 with order code 0622 149 00106. If lead-free solder-paste is required, please contact the manufacturer of your solder-equipment. In general use of solder-paste within workshops should be avoided because paste is not easy to store and to handle. Use only adequate solder tools applicable for lead-free solder alloy. The solder tool must be able o To reach at least a solder-temperature of 400C, o To stabilize the adjusted temperature at the solder-tip o To exchange solder-tips for different applications. Adjust your solder tool so that a temperature around 360C 380C is reached and stabilized at the solder joint. Heatingtime of the solder-joint should not exceed ~ 4 sec. Avoid temperatures above 400C otherwise wear-out of tips will rise drastically and ux-uid will be destroyed. To avoid wear-out of tips switch off un-used equipment, or reduce heat. Mix of lead-free solder alloy / parts with leaded solder alloy / parts is possible but PHILIPS recommends strongly to avoid mixed solder alloy types (leaded and lead-free). If one cannot avoid or does not know whether product is leadfree, clean carefully the solder-joint from old solder alloy and re-solder with new solder alloy (SAC305). Use only original spare-parts listed in the Service-Manuals. Not listed standard-material (commodities) has to be purchased at external companies. Special information for BGA-ICs: - always use the 12nc-recognizable soldering temperature prole of the specic BGA (for de-soldering always use the lead-free temperature prole, in case of doubt) - lead free BGA-ICs will be delivered in so-called drypackaging (sealed pack including a silica gel pack) to protect the IC against moisture. After opening, dependent of MSLlevel seen on indicator-label in the bag, the BGA-IC possibly still has to be baked dry. (MSL=Moisture Sensitivity Level). This will be communicated via AYS-website. Do not re-use BGAs at all.

EN 8

2.

3139 785 31590


2.2 Service Hints CAUTIONCHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE DRIVE ELECTRONICS WHEN CONNECTING A NEW DRIVE.THATS WHY, BESIDES THE SAFETY MEASURES LIKE SWITCH OFF POWER SUPPLY ESD PROTECTION ADDITIONAL ACTIONS MUST BE TAKEN BY THE REPAIR TECHNICIAN. The following steps have to be done when replacing the defective loader :1. 2. 3. 4. 5. 6. 7. Dismantling of the loader to access the ESD protection point if necessary. Solder the ESD protection point*. Disconnect exfoil cable from the defective loader. Put a paper clip on the exfoil to short-circuit the contacts (g.1) Replace the defective loader with a new loader. Remove paperclip from the exfoil and connect it to the new loader. Remove solder joint on the ESD protection point.

ATTENTION: The laser diode of this loader is protected against ESD by a solder joint which shortcircuits the laserdiode to ground. For proper functionality of the loader this solder joint must be remove after connection loader to the set.

Type 1

Type 2

(ESD protection point is accessible from top of loader)

(ESD protection point is accessible from bottom of the loader)

*Only applicable for defective loader needed to be sent back to supplier for failure analysis and to support backcharging evidence. This is also applicable for all partnership workshops.

DVD HOME THEATRE SYSTEM

HTS3455

1APlacementProper speakers system placement is important to ensure optimum sound performance.

ConnectCConnect the speakers to AV subwoofer

Quick Start GuideConnect the various coloured plugs from the speakers to the same coloured sockets at the rear of the AV subwoofer.REAR RIGHT REAR LEFT FRONT RIGHT CENTER FRONT LEFT

D C C A B

3. Directions For Use

ConnectDA Place the centre speaker above or close to the TV. B Place the subwoofer on the floor, at least one metreaway from the TV.

Set up EnjoyC Place the front speakers at equal disctances from theTV.

1 2 3D Place the rear speakers at normal listening ear level.

Directions for Use

Whats in the box?Composite video cable Remote Control and 2 batteries

B

Connect the radio antennas

Keep the antennas away from the electronic devices to prevent unwanted interference.

DVD system

AV subwoofer (rear)12 mm

BL

C

DR

Connect the AV subwoofer to DVD systemAUse the supplied inter-connect cable to connect TO AV SUBWOOFER socket and TO DVD SYSTEM socket. Tighten the screws at the sides to secure the connection.

2 Power cables Inter-connect cable

DVD System (rear)

3139 785 31590

AV subwoofer (rear)

A Connect the FM antenna to the FM socket. Extendthe wire and fix its end to the wall.AM/MW loop antenna User Manual

3.

1 centre, 2 front, 2 rear speakers and AV subwoofer

FM wire antenna

B Unfold the AM/MW loop antenna and fix the clawinto the slot.

The following except of the Quick Use Guide serves as an introduction to the set. The Complete Direction for the Use can be downloaded in different languages from the internet site of Philips Customer care Center: www.p4c.philips.com

C Push the tabs and insert the wires into the AM/MWsockets.HDMI OUT

L

MWR

EN 9

DVD System (rear)

EN 10

23.Finding the viewing channelA Press OPEN CLOSE to open the disc tray.Load a disc and close the disc tray. The display panel will show AUTO INSTALL PRESS PLAY.

Set up

3Start disc playbackA Press TUNER.

EnjoyListen to radio

EB Press PLAY

Connect the DVD system to TV

A

Television ( rear)

VIDEO IN (CVBS)

A Press STANDBY ON on the DVD system. B Press SOURCE on the DVD system until DISC

appears on the display panel.

VIDEO IN (CVBS)

To off-air antenna or set-top box

until START ... appears on the display panel. All the available radio stations with strong reception signal will be stored automatically.

L

MAINS

~

MW

Pb

Note This feature is only available for the first time setup. If you wish to reinstall all the radio stations, hold down the PROGRAM button on the remote control.

MW

R

HDMI OUT

B Playback will start automatically. C If the disc menu appears, usekeys to select an option in the menu and press PLAY to start playback. preset radio station.

3139 785 31590

r DVD System (rear)

Y

C Turn on the TV. Use the TVs remote control to D Press STOP x to stop playback.

C Once complete, use . > keys to select a D To delete a preset radio station, hold down STOPx until FM/MW X DELETED appears.

Pb

select the correct viewing channel for the DVD system. You should see the blue DVD background on the TV.Note When you press PLAY button again, the playback will resume from its last stopped point. To start playback from the beginning, you have to press STOP button two times to cancel the resume mode, then press PLAY button.

A Use the supplied composite video cable to connect

the CVBS socket on this DVD system to the VIDEO IN socket on your TV.

B Plug in the power cables from the DVD system, AV

Note To search for the correct viewing channel, press the Channel Down button on the TVs remote control repeatedly (or AV, SELECT, button) until you see the blue DVD background.

Experience surround soundA Press SURR to switch between stereo and multichannel.

subwoofer and TV to the AC power outlets.

Directions for Use

Note It is important to connect the DVD system directly to your TV.

BSelect the display language on the screen

B Press SOUND to select either CONCERT,DRAMA, ACTION or SCI-FI preset digital sound effects.

F TroubleshootingGeneral Setup Page

Connect the audio from TV to DVD system (optional)No picture.

A Press SETUP.For more troubleshooting tips, see the user manual.

The { General Setup Page } appears.

To hear the TV audio through this home theatre system, use the red and white audio cables (not supplied) to connect the TV IN (R/L) sockets on this DVD system to the AUDIO output sockets on your TV.Disc Lock Display Dim Program OSD Language Screen Saver DivX(R) VOD Code English Espanl Brazil Por

Television ( rear)

Press DISC button on the remote control. Check the connection to the TV and ensure the plugs are firmly in place.

AUDIO OUT

No sound.

AUDIO OUT

AUDIO OUT

to select { OSD Language } and press .

AUDIO IN

B Press C Use

Check the speaker connections and settings. Check the audio connections and press SOURCE button to select the correct input source. The centre and rear speakers operate only in multi-channel surround mode. Press SURR button to select multi-channel surround output.

keys to select a language in the menu and press OK to confirm.

The DVD system does not work. Disconnect the power cord from the power outlet for a few minutes. Reconnect the power cord and try again.

b

D Press SETUP to exit.

L

MW

MW

R

DVD System (rear)

Note The language set here is only for the menus that are shown on the TV while operating this DVD system, not for the DVD disc menu.

Need help?User ManualSee the user manual that cames with your Philips DVD System

OnlineGo to www.philips.com/support 2005 C Koninklijke Philips N.V. All rights reserved. 12 NC 3139 246 18981 www.philips.com

Note Press TV on the remote control to get the sound output from the speakers system when watching the TV programme.

There are various setup options (Audio Setup, Video Setup, Preference Setup) available on this DVD system. Refer to the user manual for more information.

Dismantling Instructions & Service Positions

3139 785 31590

4.

EN 11

4.4.1

Dismantling InstructionsDismantling of the DVD Loader Tray Cover1) Insert a minus screwdriver and push the lever in the direction as shown in Figure 4-1 to unlock the tray before sliding it out.

4.2

Dismantling of the Front Board, PSU Module & DVD Loader.1) Release 4 snap hooks to remove the Front Board. 1 snap hook each on the left & right side 2 snap hooks on the bottom side 2) Loosen 2 screws (See Figure 4-3) to remove the PSU Module.

1 Figure 4-1 2) Remove the Tray Cover as shown in Figure 4-2

Figure 4-3 3) Loosen 4 screws (See Figure 4-4) to remove the DVD Loader.

2 Figure 4-2

2

Figure 4-4

EN 12 4.3

4.

3139 785 31590

Dismantling Instructions & Service Positions 4.4 Dismantling of the AV Interface Board & PCBAS 9.1 Board1) Loosen 2 screws (See Figure 4-8) & 2 screws (Figure 4-9) to remove AV Interface Board & PBCAS 9.1 Board.

Dismantling of the Tuner Module & AV Board.1) Loosen 1 screw (See Figure 4-5) to remove the Tuner Module.

3 6 7

Figure 4-8

Figure 4-9

Figure 4-5 2) Loosen 2 screws (See Figure 4-6 & Figure 4-7) to remove the AV Board.

4 Figure 4-6

5 Figure 4-7

Dismantling Instructions & Service Positions 4.5 Service PositionsInsulation Sheet

3139 785 31590

4.

EN 13

PCBA 9.1

AV Board Insulation Sheet

Insulation Sheet

Service Position - AV Board

Service Position - PCBAS 9.1

Front Board

Service Position - Front Board

EN 14

5.

3139 785 31590

Service Test Program

5.

Service Test ProgramTo start service test program open the tray with remote control or front panel key, while plugging in the mains cord press 2, 5 8 on remote control, the tray will close by itself and the set will display shown S-Vxx-yy S refers to Service Mode V refers to Version xx refers to Software version number of BEA (counting up from 01 to 99) yy refers to Software version number of Front uP (counting up from 01 to 99)

Display shows SERVICE followed by ROM version S-Vxx-yy

4.1

Display Test

Purpose: This test is used to check the driving circuits, the display and whether there are any short-circuits, open-circuits or any other defects. Player:

Main Menu Display Test key "DisplayTest" triggered? y

Following display patterns are used to test the display and its connections to P. Pattern 1: Default: All display control pins are ON - to check the open-circuitsn

Pattern 2: Alternate display control pins are on (Test Pattern: 0x55) - to check the short-circuits on Data portActivate and display "Pattern1"

key "DisplayTest" triggered? y

n

Receiver: Following display patterns are used to test the display and its Pattern 1: Default: All display control pins are ON - to check the open-circuits connections to P.

Activate and display "Pattern2"

key " " triggered? y

n

Pattern 2: Alternate display control pins are on (Test Pattern: 0x55) - to check the short-circuits on Data port

Service Test Program5.1.1 Reprogramming of DVD version Matrix 5.1.4

3139 785 31590

5.

EN 15

Procedure to upgrade the rmware

After repair, the customer setting and region code may be lost. Reprogramming will put the set back in the state in which it has left the factory, ie. with the default setting and the allowed region code. Model HTS 3455/51 HTS 3455/96 HTS 3455/98 Region Russia Taiwan APAC Region Code 5 3 3 TV Type PAL NTSC PAL

1. Power up the set and open tray. 2. Insert the prepared Upgrade CDROM and close the tray. 3. The set will display: 1. LOAD 2. Display software version number for 2 sec on the FTD display. 3. ERASE 4. WRITE 5. ERROR (if unsuccessful) 6. UPG END (if successful) 7. DISC -> CLOSE -> LOAD. (Meanwhile tray will be pulled in) Note: Do not press any button or interrupt the main supply upgrading process,Otherwise the set may become defective. 4. When the upgrade is completed, the tray will close automatic. 5. The tray will close and the set will go to Standby mode automatically when the upgrade process is completed. 5.1.5 Procedure to check the rmware version to conrm upgrading

To reprogram do as follows: 1) Power up the set and select DISC source. 2) Open tray by press OPEN/CLOSE button on the set or press and hold STOP button on the RC. 3) Press the following buttons on the Remote Control: ...........for HTS 3455/51 ...........for HTS 3455/96 ...........for HTS 3455/98 4) The display shows YYYY-ZZ and the tray will close. YYYY = model number (eg. 8300, 8500, etc.) ZZ = slash stroke version (eg. 01, 69, etc.) 5.1.2 Procedure for check Software version

1) Power up the set and select DISC source. 2) Open tray by press OPEN/CLOSE button on the set or press and hold STOP button on the RC. 3) Press DISPLAY button on the Remote control. 4) The TV screen will shows: PPPP-Vxx YYYYY-ZZ SERVO: GGGGGGGG REG:DD PPPP = xx = YYYYY = ZZ = GGGGGGGG = 5.1.3 HTS 3300MKII version number model # - 3300D stroke version (12, 51, 05, 98, 55, 51K) version for servo code

1. Power up the set and open tray. 2. Press the button on the Remote Control. 3. The rmware version will be displayed on the top left hand corner of the OSD. 5.1.6 Trade Mode

Trade mode is a feature that will block all set keys when enabled. It is for dealers to prevent customers fromremoving disc, changing source etc using the set keys.Rotary and Remote Control (RC) keys are still allowed inTrade mode. To activate Trade Mode: 1) Power up the set and select DISC source. 2) Open tray by press OPEN/CLOSE button on the set or press and hold STOP button on the RC. 3) Then press buttons on the RC. 4) The display shows TRA ON and the tray will close. Trade Mode is now enabled. To deactivate Trade Mode: 1) Power up the set and select DISC source. 2) Open tray by press and hold STOPbutton on the RC. 3) Then press buttons on the RC. 4) The display shows TRA OFF and the tray will close. Trade Mode is now disabled.

Burning of rmware

1. Unzip the zip-archive attached with this service information. 2. Start the CD burning software and create a new CD Project (Data disc) with the following settings: a. File System: ISO9660 b. Format: MODE 2/XA c. Recording format: Single Session (Track at once), Finalized CD 3. Place the content of the zip-archive into the root directory of the new CD project. 4. Burn the data onto a blank CDR or CDRW. Note: ISO9660 is mandatory, UDF discs are not supported! The nal CDROM must not contain any other data except the le from the zip-archive.

EN 16

5.

3139 785 31590

Service Test Program

Notes:

Block Diagram, Wiring Diagram

3139 785 31590

6.

EN 17

Wiring Diagram1 2

3

4

5

6

7

8

1103

9

10

11

12

13

14

15

16

17

18

19

20 A

A1600 1 2 3 4 5 6

1404

B1 GND 2 VCC NC/RDS 3 TU_R 4 TU_Stereo 5 TU_L 6 TU_SD 7 TU_SDA 8 TU_SCL 9 10 Port_S

C

1 2 3 4 5 6 7 8 9 10

1 2 3 4 5 6GND VCC NC/RDS TU_R TU_Stereo TU_L TU_SD TU_SDA TU_SCL Port_S

B

1601

D

E1 GN D 2 RDS_CLK 3 RDS_CLK 4 G ND 5 SP I D F _ I N 6 I2C_CLK 7 I2C_DATA 8 RESET-MCU-DAC 9 G ND 10 TU_SD 1 1 G ND 12 +3V3

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

C

D

E

1 2 3 4 5 6 7 8 9

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

F

1 2 3 4 5 6 7 8

1 2 3 4 5 6 7 8

1 2 3 4

F

G

1 2 3 4 5 6 7 8

G

1 GN D RDS_CLK 2 3 RDS_CLK 4 GN D 5 SPIDF_IN I2C_CLK 6 7 I2C_DATA RESET-MCU-DAC 8 GND 9 10 TU_SD 11 G ND 12 +3V3

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

H

H1 2 3 4

I15041 2 3 4 51 2 3 4 5 6 7 8 9

1 2 3 4 5 6 7 8

I1 2 3 4 5

J11051 2 3 4

J

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

K

K

L

L

1522

1 2 3 4

15011 2 3 4

15001 2 3 4

M

M

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

1521

N

N

O

O

P

PWiring Diagram.pdf 2006-04-06

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

Circuit Diagram and PWB Layout

3139 785 31590

7

EN 18

7.

AV Board: Circuit Diagram (Part 1)1 2

3

4

5

6

7

8

9

10

11

12

13

F100 F101

SCL +5VD TU_DO_STEREO

3141 4K7 TU_SD

+12VM

3160 10R

A

100u

2151

10 9 8 7 6 5 4 3 2 1 1100

+12Va

+12Va_AM

5102 2u2

F102 SDA F103 3100 1K2 F105 F106 TU_RDS_IN F107 F108 3101 1K2

+12Va

3142 4K7

TU_DO_STEREO

A

GND 3102 3103 47K 47K100n 2153

2125

B

TU_SD

-12VM GND 7100 BC547B3104

3161 10R

100u

GND

-12Va

GND

-12Va_AM

5103 2u2

-12Va

B

+12Va4R7 Source_sel_A0 Source_sel_A1

GND3105

3106 5K6 3107 6K8 Source_sel_A0 Source_sel_A1

2100

100u

+12Va

C

1N4148

1K5

6101 Chip_sel_A2 4102

3150 F136 5K6 3151 6K8

F135 An_Right

+12Va

C

BZX384-C9V1

XM_R

3155 4K7 2147 2143 100p

3156 5K6 3157 27K

3109

MIC_L

2105

220p

3110

56K

Right_In

68p

4K7 F130

100K

3121

D

1104 1 2 3 4 B4B-EH-A F110

F109

+12VM3111

7102 HEF4052B VDD 10 0 0 9 4X 1 3 16 6 12 14 15 11 1 5 2 4G4 0 1 2 3 0 1 2 3

2106 2u2

3120

F132

6 12 14 15 11 1 5 2 4

16

GND

GND

GND

GND

7103 HEF4052B VDD 10 0 0 9 4X 1 3G4 0 1 2 3 0 1 2 3

GND

GND

GND

MDX

13 An_Right

MDX

GND13

GND3153 5K6 2142 3154 100p 27K

GND

D

GND

2110

220p

GND -12VMF131 F111 3116 4K7 2113 68p 3117 4K7 2115

XM_L

3112

56K

4K7

3152 4K7 2146

3 An_LeftVEE VSS

7

SCART_TV_Left_In

2u2VEE VSS

100K

3114

7

8

GNDHDD_R 3170 4K7 2160 2161 100p 6 8p

GND3171 5K6 3174 27K

GNDF137

3118 -12Va 3125 5K6 6K8 F134

2116

100p

3119

4 1 LPR6520-J920G

F112 F113 F114 2119 68p 3122 4K7 3124 100p 2120 56K 3123

GNDHDD_L 3172 4K7 2162 2 1 63 100p 68p

GND3173

GND+3V3

2 1 1102 3

3175

FSCART_TV_Right_In

27K

3162

4K7

GND

5K6

2148

6

50V 1u0

Aux_L

GND

GND

GND

3128

Aux_R

An_Left

3

Aux_R

5

Aux_L

56K

68p

E

GND3158 5K6 -12Va

8

GND

GND

3

2107

3108

F133

Left_In

LPR6520-J440G 1106 2

GND

GND

GND

E

GND GNDF115 3129 4K7 2127 68p F128 3130 4K7 2129 2130 100p 68p 3131 5K6 3132 12 K

GND GND GND GND GND GND7104 BC847B 3163 10K Chip_sel_A2

F

Aux_L GND

G

GNDF129 3136 4K7 2137 2138

GND3137 5K6 100p 3140

GND

GND

GND

G

7105 M62320FP 12K

CS1

CS0

68p

CHIP SELECTGND GND GNDSCL SDA 2 3 13 8 2154 100n SCL SDA VDD GND

H

I2C BUS TRANSCEIVER PWR RES8 8

CS2

Aux_R

SHIFT REG8

SO

1

3K3 3182

1K5 3181

22K 3184

3180

8K2 3183

8

8

8HDD_L 33R 3 1 67 1K0 3165 1K0 3166 33 R 3168 3164 22K D1 D0 HDD_R F138 F139 F140 F141 3K3 3113

4M7

+5VD

H1105 1 2 3 4 5 B5B-EH-A

IN OUT I/O DATA LATCHES I/O PORT

GND

I

+5VD

3185

GND

I

Reset_DSP

DSP_INT

3K3

GND

3139_243_33617__a2_sh130_sh1.pdf

2006-03-10

1100 B1 1102 F1 1104 D1 1105 H12 1106 E1 2100 C2 2105 D4 2106 D8 2107 E8 2110 D4 2113 E2 2115 E2 2116 E3 2119 F2 2120 F3 2122 A11 2125 B11 2127 G2 2129 G4 2130 G5 2137 H4 2138 H5 2142 D10 2143 D10 2146 D9 2147 D9 2148 E12 2150 A8 2151 B8 2152 A7 2153 B7 2154 H7 2160 E9 2161 E10 2162 F9 2163 F10 3100 A3 3101 A3 3102 B3 3103 B4 3104 B4 3105 C3 3106 C8 3107 C8 3108 E8 3109 D3 3110 D4 3111 D3 3112 D4 3113 I10 3114 E8 3116 E3 3117 E3 3118 E4 3119 E4 3120 D8 3121 D8 3122 F3 3123 F4 3124 F4 3125 E7 3128 E7 3129 F3 3130 G5 3131 G5 3132 G5 3136 G5 3137 G5 3140 H6 3141 A3 3142 A3 3150 C13 3151 C13 3152 D10 3153 D10 3154 D11 3155 D10 3156 D10 3157 D11 3158 E12 3160 A8 3161 B8 3162 F11 3163 F12 3164 I10 3165 I10 3166 I10 3167 I10 3168 I11 3170 E10 3171 E10 3172 F10 3173 F10 3174 E10 3175 F10 3180 H10 3181 H10 3182 H10 3183 H10 3184 H11 3185 I8 4102 C6 5102 A12 5103 B12 6100 C3 6101 C3 7100 B3 7102 D7 7103 C12 7104 F11 7105 G7

F100 A2 F101 A2 F102 A2 F103 A2 F105 A2 F106 B2 F107 B2 F108 B2 F109 D2 F110 D2 F111 E2 F112 E2 F113 F2 F114 F2 F115 F2 F128 F4 F129 G4 F130 D2 F131 D2 F132 D9 F133 D9 F134 E7 F135 C7 F136 C12 F137 E12 F138 H11 F139 I11 F140 I11 F141 I11

100u

2150

100n

2152

6100

15

D7

14

16

D3

D6

D5

12

11

10

D4

D2

5

9

7

1

2

3

4

5

6

7

8

6

4

9

68p

10

11

2122

100u

12

13


3139 785 31590

7.

EN 19

AV Board: Circuit Diagram (Part 2)1 2+3V3

33V3D 5203 2214 100n 5104

4

51204 1 2 3 4 5 6 7 8 9 B9B-EH-A

6F240 F241 F242 F243 F244 F245 F267 F247

7S_CS S_DATA S_CLK GND PCM_LRCLK RC Stby Erro_Det

8

93V3_DSP1

10

11

12

+5VA 2101 100n

GND

GND3214 3V3D Left_In 2218 2u2 10V 10K PCM_MCLK

1 16 9 2 10 12

2257

6200

0 M 1 RST

ADC

VQ FILT+ SCLK

15 7 4 8

10V 2u2 2217 2256 3215 100n 10K AUX_Data PCM_LRCLK PCM_SCLK 3V3D

2203

2259

MCLK SDOUT AINL LRCK AINR GND REF_GND

1205 1 2 3 4 5 6 7 8 B8B-PH-K-S

100n

GND

GND

3V3_DSP 100n 100n 2207 2206 2205 2209 5105 VPIId VCore 2201 2202 2204 3 17 25 64 75 41 39 8 29 52 71 44

Right_In 2219

2u2 10V 2265 2264 2n2 2n2

B

5

14

GNDF268 +5VD

100n 100n 100n 100n 100nGND

100n

11

220u 16V 2258

10V 2u2 2215

22u 6.3V 2240

2216

1u0

VA

VD

VL

120R

100n BZX384-C3V3

A

3211 4K7

4K7 3210

7201 CS5340

13

6

3

2255 100n

GND

5215 +3V3

5207 120R

F252

3V3_DSP

A

GND GND

GND

B

BUF_MCLK

4210

3263 10K F215 3264 2208 22p 30FE-ST-VK-NA 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 1201 10K

7203 DSPA56371AF180

C

GND

2261 22p 3247 3223 33R 45 10K 2262 46 69 70

IO_VDD

A P D PLL_VDD

CORE_VDD MOSI HA0 SS HA2 MISO SDA SCK SCL HREQ PC SCKR FSR HCKR SCKT FST HCKT SDO5 SDO4 SDO3 SDO2 SDO1 SDO0

DSP_MCLK

GND4202 4203 PCM_SCLK PCM_MCLK PCM_LRCLK Data_FL_FR Data_SL_SR Data_Cen_Sub 4208 3115 33R

1200 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 20FE-BT-VK-N 4216 4219 100n 3V3_DSP1

EXTAL NMI_PINIT ADO ACI PD

DSPCLOCK

34 37 35 36 38

3221 3222

10K 10K DSP_SDA DSP_SCL 3243 3244 4K7 4K7 3242 33R DSP_INTGND

C

DSP_PCM_LRCLK DSP_Data_FL_FR DSP_Data_SL_SR DSP_Data_Cen_Sub

4204 4205 4206 4207

100n

F216 F217 F218 F219 F220 F221 F222 F223 F224 F225 F226 F227 F228 F229 F230 F231 F232 F233 F234 F235

DSP_PCM_SCLK

GND

3126 33R

AUX_Data

RESET_TI

SPDIF SHI

3224 3225 3226 3227GND

10K 10K 10K 10K

51 50 49 48

D

A B MOD C D IRQ

Data_Lo CVBS_DVD G_Y B_U R_V SCART0 SCART1 Source_sel_A0 Source_sel_A1 Mute_Ctrl1 Mute_Ctrl2 SY SC RESET Erro_Det TD Mute P_Down RESET_TI SCL

SDA

47 2250 F251 3V3_DSP1 Reset_DSP 10K 3251 2260 7206 BC847BGND

470n 31 32 30 33 26 27

RESET TDI TCLK TDO TMS

INTERRUPTS

4218 F250 4215

10K 3250 3229 3230 10K 10K

JTAG 0 1 TIO TIMER ESAI

76 78 72 77 79 73 80 1 4 5 6 7

3256 3257 3258 3259

33R 33R 33R 33R

PCM_SCLK PCM_LRCLK PCM_SCLK PCM_LRCLK

D

3260 3261 3262

33R 33R 33R

Data_Cen_Sub Data_SL_SR Data_FL_FR

SDI PE SCKR FSR HCKR SCKT FST HCKT SDO5 SDO4 SDO3 SDO2 SDO1 SDO0

GND

E

GND

GND

GND

19 18 13 14 15 16 10 11 9 21 23 3236 22 2263

0 1 2 3 4 5 6 7 8 9 10

PF

63 61 67 62 60 66 59 58 57 56 55 54

3231 3232

33R 33R

PCM_SCLK PCM_LRCLK

E

3233 3234 3235

33R 33R 33R

DSP_Data_FL_FR DSP_Data_SL_SR DSP_Data_Cen_Sub

100n

2 20 24 65 74

40

GND GND

SCL

SD A

5204 3237 1K5 3238 1K5 2220 220p

1202 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 F202 F203 F204 F205 F206 F207 F208 F236 F213

G

12FE-BT-VK-N 1203 1 2 3 4 5 6 7 8 9 10 11 12 DSP_SDA DSP_SCL

+5VD

2u2 F258

+5VD

2230 1n0

TU_RDS_IN

3V3_DSP1

2241 3V3_DSP1 3216 10K 560p 2233 2232 47p 100n 5208GND

GND12 DIG_IN RESET TU_SD F214 1K0 3217VDDD

1 2 3 8 16 560p 2231 14

GND GND GND

RDDA VREF SCOUT RDSCL OSCO VSSD

CIN MODE SYNC TCON OSCI VSSA

2221 2u2

9 10 15 13GND

5212

600R

PCM_MCLK DSP_MCLK

5

1K0 3218

QUAL

7202 SAA6581T 4 7

12 28 53 68

42

43

F

GND

10K

SCAN IO_GND

GPIO SDI SCAN ESAI_1 PLL_GND CORE_GND A P D

F

VDDA MPX

GND

GND

G4 3246 33R 2234 56p BUF_MCLK VCore

7204 74LVC1G125GW 2 1

GND

2251 100n 3253 7207-1 74HCU04PW 1 4K7 14

EN

+3V3

GND

5209 600R

GNDRXD TXD XM_IRQ

1

F253

2

100n 2243

100n 2245

2242

100n 2246

H

GND

100n

F210 F211 F209

4213 4201

11

GND3219 220K 3220 2K2 4M332 5205 LA-8481 2226

GND

GND

Chip_sel_A2

3252 U2 1M0 1206

7207-2 74HCU04PW 3

7207-3 74HCU04PW 1 4 5

GND

H

1

6 5211GND

7205 LD1117 3IN OUT ADJ

21FE-BT-VK-N

120R

22u 6.3V

3245

47p

2252

18p

1

2

2212 2253

2211

22u 6.3V

24M576

1

GND GND GND GND GND

100n

2244

GND

GND

2

7

7

5210 600R

F254

VPIId

600R

I

I

3248

GND

GNDGND

2210

GND

3139_243_33617__a2_sh130_sh2.pdf

2006-03-10

U2 H6 1200 C5 1201 E1 1202 G1 1203 G2 1204 A6 1205 A6 1206 H8 2101 A4 2201 B9 2202 B9 2203 A10 2204 B9 2205 B9 2206 B9 2207 B9 2208 C2 2209 B9 2210 I10 2211 I11 2212 I9 2214 A4 2215 A4 2216 A2 2217 A4 2218 B1 2219 B1 2220 G5 2221 G4 2226 I4 2227 I5 2230 F6 2231 H4 2232 G6 2233 G6 2234 H10 2240 A10 2241 G10 2242 H12 2243 H12 2244 I12 2245 H12 2246 H12 2250 D8 2251 G7 2252 I7 2253 I8 2255 A4 2256 A4 2257 A9 2258 A9 2259 A7 2260 E7 2261 C9 2262 C9 2263 F9 2264 B2 2265 B1 3115 C5 3126 C5 3210 A2 3211 A2 3214 A2 3215 B4 3216 G7 3217 G4 3218 G4 3219 H5 3220 I4 3221 C11 3222 C11 3223 C9 3224 D8 3225 D8 3226 D8 3227 D8 3229 E8 3230 E8 3231 E11 3232 E11 3233 E11 3234 E11 3235 E11 3236 F9 3237 F3 3238 G3 3242 D12 3243 C12 3244 D12 3245 I10 3246 G10 3247 C9 3248 I10 3250 D9 3251 E7 3252 H8 3253 H8 3256 D11 3257 D11 3258 D11 3259 D11 3260 D11 3261 D11 3262 E11 4201 H2 4202 C3 4203 C3 4204 D3 4205 D3 4206 D3 4207 D3 4208 C4 4210 C4 4213 H2

4215 E4 4216 E4 4218 D4 4219 E4 5104 A4 5105 B10 5203 A3 5204 F5 5205 I5 5207 A9 5208 G10 5209 H11 5210 H11 5211 H9 5212 G7 5215 A9 6200 A9 7201 A3 7202 G5 7203 C9 7204 G9 7205 H10 7206 D8 7207-1 H7 7207-2 H8 7207-3 H9 F202 G2 F203 G2 F204 G2 F205 G2 F206 G2 F207 G2 F208 G2 F209 H1 F210 H1 F211 H1 F213 H1 F214 G4 F215 C2 F216 C2 F217 C2 F218 C2 F219 D2 F220 D2 F221 D2 F222 D2 F223 D2 F224 D2 F225 D2 F226 D2 F227 E2 F228 E2 F229 E2 F230 E2 F231 E2 F232 E2 F233 E2 F234 E2 F235 E2 F236 G2 F240 A6 F241 A6 F242 A6 F243 A6 F244 A6 F245 A6 F247 A6 F250 D4 F251 D8 F252 A10 F253 H12 F254 H12 F258 G5 F267 A6 F268 B6

5

14

47p

2227

82p

14

3V3_DSP1

6

7

3

1

2

3

4

5

6

7

8

9

10

22u 6.3V

10R

11

12

3V3_DSP1


3139 785 31590

7

EN 20

AV Board: Circuit Diagram (Part 3)1 2 3 4 5 6 7 8 9 10 11 12 131300-1 A11 1301-A E12 1301-B F11 1301-C F11 1302 F1 2300 G4 2301 G4 2302 G4 2340 F11 2341 D6 2342 E3 2343 E5 2344 D5 2351 H9 2352 H7 2353 H7 2354 H8 2355 H9 2356 H5 2357 H9 2358 I5 2359 I11 2360 I11 2361 I11 2362 I11 2363 I8 2364 I7 2365 I7 2366 I8 2367 B5 2368 A5 2369 A7 2371 B10 2372 B10 2373 B7 2374 B10 2375 B7 2376 B10 2379 B7 2380 B5 2381 C10 2382 C12 2383 C12 2384 D11 2385 D12 2386 D11 2387 E7 2388 F10 2389 F10 2390 F11 2391 F11 2392 G3 2393 G2 2394 G5 2395 H2 2396 G2 2397 H2 2398 H5 2399 H8 3301 A6 3302 A7 3305 A6 3306 A11 3308 B9 3309 B5 3310 B5 3311 C6 3312 C6 3346 B11 3348 B9 3349 B6 3351 B7 3353 B6 3354 C4 3355 C4 3357 C10 3358 C8 3359 C9 3367 I8 3369 C10 3370 C4 3371 D5 3372 D5 3373 D9 3374 D3 3375 D3 3376 D6 3377 E3 3378 E3 3379 E4 3380 G2 3381 G2 3382 G5 3383 H6 3384 H7 3385 H7 3386 H8 3387 C9 3391 H5 3392 B5 3397 I6 3398 I7 3399 I7 4300 F7 4301 F7 4302 F7 4312 F2 4315 F4 4316 D6 4317 E5 5300 F3 5301 F4 5302 F4 5305 E7 5306 H11 6324 A12 6325 B12 6326 B12 6327 B12 6328 B12 6329 C10 6330 C12 6331 C12 6332 D12 6333 B4 6334 B4 7342 A6 7344 B7 7345 C4 7346 D10 7347 D4 7348 D6 7349 E4 7350 E6 7351-1 H6 7351-2 I6 7352 H10 7353 A5 7354 C9 F300 A11 F301 B11 F302 B11 F303 B11 F304 B11 F305 B11 F306 B11 F307 C11 F308 C11 F309 C11 F310 D11 F311 D11 F312 D11 F316 F11 F317 G10 F320 F1 F321 G1 F322 G1 F323 G1 F325 H10 F327 E7 T301 H8 T302 I8 T439 G2

For Scart version only

A+5VDBAS316 6333 SCART0 BAS316 6334

SCART_LO_L1

2368 2u2 BC857B 7353

3301 SCART_LO_L 680R 3305 2K2 2373 3302 2369 47K 1n0 7342 BC847B SCART_TV_Right_In SCART_LO_R 3308 22K 2371 4n7 2372 1n0 3306 470R 3346 1n0 470R

SCART 1 For Europe only1300-1 F300 1 F301 2 F3023 F303 4 5 F304 6 B BZX384-C15 2381 220p 6329 F305 7 F306 8 9 6327 BZX384-C15 6328 BZX384-C22 2382 220p 6330 BZX384-C15 6324 BZX384-C15 6326 BZX384-C15 6325 BZX384-C15

APin 8 0 - 2V :

TV BCAST

3392 10K 3309 1n0 3348 2376 22K 4n7 2367 1u0 3349 1n0

SCART_LO_L 2374

4.5 - 7V : 16 : 9 DVD 9.5-12V : 4: 3 DVD

B+5VD100R 3354

Mute

1K0 TV_Mute 3310 1K0

GND2375 7344 BC847B SCART_TV_Left_In 2379 47K 1n0

GND

B

GNDG_Y B_U 3355 4K7 SCART_LO_R1 2380 2u2 3353 680R

2K2

3351

SCART_LO_R 3311 10K 3312 10K

-12Va

+5VD +12VL3357 2K7

GND

10

R_V

GND3358 10K 3359 10K BC847B

F30711

7 345

C

GND3387 10K 7354 BC847B 3369 2K7 R FBOUT 2384

G

12 F30813

C

+5VDFBOUT

SCART0

2383 14

GND

3370

1K0

F30915 F31016

220p 6331 BZX384-C15

3371

15K

GND3373 SCART1 10K 7346 BC847B

Pin 16 0 - 0.4V : CVBS 1 - 3.0V : EXT RGB

22n

F31117 2385 18 F312 19 20 21 220p 6332 BZX384-C15

3374

7347 BC847B

GND2344 220u 4V 3372 10K 7348 BC847B 4316

D3375 82R

10K

CVBS 330p 2341

GND2386

DGND

GND +5VD GND3377 15K

GND

3K3

4V 220u 3376

GND

GND

4317

MSP-801V1-02-01-B NI FE LF2343 1 F327 7350 TS5V330PW 16 2 5305 1 600R 2387 100n 2 3 5 6 11 10 14 13 4300 4301 4302 R V G Y 2388 220p 2389 220p 2391 68p 2390 B U 68p

EGND

1301-A

2342 220u 4V 3378 10K

7349 BC847B

4V 220u

E

+5VDSY

GND

3 4 2

3379 3K3 4315 SCART0

GND1 4

15

VIDEO SWEN IN A B D C D GND S 1C 2C 1D 2D 1A S 2A S 1B 2B

VCC

GND

F316 5 SC 1301-C MSP-801V1-02-01-B NI FE LF GND 8

S-VIDEOGND

5300

F1302 3 F320 T439 F321 4312

1u8

5301 1u8 5302 1u8

7 9 12

FCVBS

*

*1301-B 7 6 MSP-801V1-02-01-B NI FE LF 2340 330p

CVBS_DVD

S

GNDF317

2300 47p

2301 47p

2302

47p

8 3382 10K 2394

YUV/ PROG SCAN

1 2 6 4 5 LPR6520-E610F 2395 100p F322 F323

3380 68R

2392 DIG_IN 10n 150R 2393

GND

3381

V U Y

180p

*

G

GND

COAXIAL IN

G-12Va_AM

2397 100p

GND

56p 100n 2398 GND

100p

2396

3383 4 2 1 LM833D 7351-1 8 3 4K7 2352 100p

3384 5K1 220p 2353

3385 3K3 2354

T301

3386 2K2

2399 22u 16V GND

2351 47u 25V 2355 100n 2357 47u 25V 7352 CS4344SDIN DEM SCLK LRCK MCLK VA GND

220p

GND

GNDSCART_LO_L1

F325 5 6 7 10VQ FILT+ AOUTL AOUTR

1 2 3 4 9 100n 2359 22p 22p 22p 5306 600R

H

100n 2356 GND 3391 10K 2358 56p GND

Data_Lo PCM_SCLK PCM_LRCLK PCM_MCLK

H

+12Va_AM

GND

GND

GND

+5VA

8

2361

-12Va_AMSCART_LO_R1

GND 3397 3398 5K1 2364 100p 2365 220p 3399 3K3 2366 220p T302 3367 2K2 2363 GND 22u 16V

2360

2362

I7 LM833D 7351-2

6 8 5

4K7

GND

I

4

+12Va_AM

GND GND GND GND

3139_243_33617__a2_sh130_sh3.pdf

2006-03-10

1

2

3

4

5

6

7

8

9

10

11

12

13


3139 785 31590

7

EN 21

AV Board: Circuit Diagram (Part 4)1 2 3 4 5 6 7

8

9

10

11

12+5VD

13

A+12V_Stb

6416 BAS316

10K 3450

220u 16V

2414

3448

4K7

6411 3449 10K

3447

4K7

+5VD

4409

PO_Mute

+5VD

4410

BAS316

PD_Mute

APO_Mute1 PD_Mute1

+12Va

4411

+12Va3451 4K7

4412

GND

PO_Mute PD_Mute 3453 10K 7421 BC847B

3452 10K

7420 BC847B

100u 25V

2415

BStby 3406 10K 3407 56K 7400 BC847B

switch

GND

GND

B

GNDPD_Mute1 6415 BAS316 6410 PO_Mute1 BAS316 6413 BAS316 F420 Mute

GND

Mute_Ctrl1

Mute_Ctrl2

6412 BAS316

TV_Mute

GND

GND +5VL

C

5403 100n 220R

C+12VL

+5VA2400 4415

-12V_Stb

7402

5406 10u

F422

F423

-12VaBC327-25 7403 5405 2402 10u 22u 25V

GND +5V_Stb7401 F400 1407 100u 10V 2 2401 2000mA 5404 390R F421 switch 3401 10K 7405 3412 10K 3416 1K0 BC857B BC337-40

25V 22u

1

D1 2 3 4 5 6 7 8 B8B-EH-A 1402

F401

+5V_Stb GND +5V_Stb

3 SI2312DS switch 3410 10K 100K

+5VD

2404

+12V_Stb

1408 2000mA

+12Va

3418

F426 F403

5K6

GNDF405

E

NC

+5V_Stb -12V_Stbswitch

3422

GND +12V_Stb

GND

GND

GND

GND

D

3424 10K

7406 BC847B

E

GND

1405

F406 F404 2422 100u 25V

6424 BAS316

6423 BAS316

6422 BAS316 7423 BC857B

6421 BAS316

6420

+1 2 V L

F

1 2 B2B-EH-A

+1 2 V L

3462

BAS316

F3467 4K7 FAN

3463 10K 3464 2421 1u0

3466 FAN 3460 10K 100n 2420 10K

7424 BC847B

GND

2K7

G+5VL

GND

7422 BC847B

3465

10K

TD

G

GND GND4400 4401

GND

H

1403 1 2 3 4 5 6 7 8 9 10 11 12

F407 F413 1404 1 2 3 4 5 6 B6B-EH-A 4417 4416 4402 4403 4419 4404 4418

H+5VA +5V_Stb GND +12Va_AM GND -12Va_AM

F408 F409 F410 F411

GND

+12VL

P_Down Stby

I

F412 B12B-EH-A

GND

1402 E1 1403 H2 1404 H3 1405 F3 1407 D4 1408 D9 2400 C5 2401 D4 2402 D10 2404 D8 2414 A8 2415 B5 2420 G6 2421 G4 2422 F3 2423 C2 3400 B2 3401 D6 3406 B1 3407 C2 3410 D4 3412 D7 3416 D6 3418 D4 3422 E10 3424 E9 3447 A12 3448 A10 3449 A7 3450 A4 3451 B5 3452 B12 3453 B9 3460 G6 3461 F7 3462 F6 3463 F4 3464 G4 3465 G8 3466 G7 3467 F8 4400 H3 4401 H3 4402 H4 4403 H4 4404 I3 4409 A4 4410 A7 4411 A4 4412 A7 4415 C11 4416 I3 4417 I3 4418 I4 4419 H4 5403 C4 5404 D4 5405 D10 5406 C7 6410 C11 6411 A8 6412 C13 6413 C11 6415 B11 6416 A4 6420 F5 6421 F4 6422 F4 6423 F4 6424 F3 7400 B2 7401 D4 7402 C7 7403 D10 7405 D6 7406 E10 7418 A5 7419 A8 7420 B12 7421 B10 7422 G7 7423 F4 7424 G8 F400 D2 F401 D2 F403 D2 F404 F3 F405 E2 F406 F3 F407 H2 F408 H2 F409 I2 F410 I2 F411 I2 F412 I2 F413 H2 F420 C5 F421 D5 F422 C8 F423 C11 F426 D2

100n

2423

3400

2K2

BC857B 7418

22R

+12VL

3461

4K7

BC857B 7419

+5VD

I

+12Va

-12Va

3139_243_33617__a2_sh130_sh4.pdf

2006-03-10

1

2

3

4

5

6

7

8

9

10

11

12

13


3139 785 31590

7.

EN 22

Layout: AV Board (Top view)

AVBd_Topview_33617.pdf_2006-05-05


3139 785 31590

7

EN 23

Layout: AV Board (Bottom view)

AVBd_Bottomview_33617.pdf_2006-05-05


3139 785 31590

7

EN 24

Display Board1 2 3 4 5 6 7 8 9 10 11 12 13 141501 A13 1502 F2 1503 D1 1504 E1 1505 B2 1507 H6 1508 H6 1509 H7 1510 H7 1511 H7 1512 H7 1513 H8 1514 G4 1520 C9 1530 E9 1540 C13 2500 A12 2501 A10 2502 B5 2503 B6 2504 B5 2505 C3 2506 C4 2507 C5 2508 C5 2509 C6 2510 B12 2511 C6 2512 C4 2513 D10 2514 E11 2515 E9 2516 E11 2517 E9 2518 E9 2519 E8 2520 E8 2521 E9 2522 E3 2523 F6 2524 H3 2525 H12 2526 I13 2527 I8 2528 I12 2529 I11 2530 F4 2531 E8 2532 I8 2533 I9 3500 A12 3501 A10 3502 A11 3503 B8 3504 B9 3505 B11 3506 B6 3507 B2 3508 B3 3509 B7 3510 C5 3511 B13 3512 C7 3513 B12 3514 C2 3515 C6 3516 C2 3517 B12 3518 B13 3519 B13 3520 C6 3521 C5 3522 C9 3523 C11 3524 C9 3525 C11 3526 D4 3527 D4 3528 D9 3529 D8 3530 E10 3531 E9 3532 E6 3533 E6 3534 F6 3535 F7 3536 E8 3537 E8 3538 G5 3539 G5 3540 H3 3541 H10 3542 I3 3543 I13 3544 I4 3545 I13 3546 I13 3547 I6 3548 I6 3549 I7 3550 I8 3551 I4 3552 I11 3553 I11 3554 I13 3555 E5 3556 E4 3560 F9 3561 F9 3562 F9 5500 A12 5501 A10 5502 B3 6500 C4 6501 D10

+12VStyBC847B 7501 MGND 5501 600R 35V 10u 2501 3501 10K 3500 10K

BC857B 7500

DISPLAY BOARDA-24V -24VDswitch +12VM 2502 BC857B 7503 switch

5500 10u 16V 600R 2500

+12VD1 2 3 4 +5VDSTBY

1501 F725 F736 F737 F738 LED Stby-k1 Stby-k2

A

3502 1K0

WH04D-1

3503 10K

3504 1K0

3505 10K

BC847B 7502 3513 4K7 470R 3511

MGND

2 4 5 MSJ-035-11C B AG SR

F718

1K2 3507 F719

3508 2K2 100p 2505

5502 MGND 22u 2506 100p

3506 2503 100p 2K7

+12VM

stdby_1

2 2504 3510 2507 68K 47p 470n MGND -12VM 4

4K7 2510 7504-2 LM833D 7 1u0

4K7

7506 BC847B

470R

3519

B

1505 1

3

470n MGND 7504-1 LM833D 1

3517

3518

BLED

5 6

3509 1K0

F720

MIC

MGND MIC_DET

2508

4

1520 HUV-08SS57T

3514

3515

6K8

3516

3K9

MGND

MGND

-12VM 3520 6K8

1K0

1u0

DSP

C

C3523 F717 33R 3525 33R 1 1540 VGL-1

1u0

+12VM MGND

7507 BC847B

F734 2512

6500 1u0 BAS316

3521 1K0

MGND 2511 47p

3522 33R 3524 VGL+1 33R F716

MGND

FROM AV Board150R 3527 1503

MGND

3526 PDZ6.2-B 8K2 6501 +5VDSTBY

D

1 2 3 4 WH04D-1

F721 F735 F723 F724

+12VM MIC GND -12VM

D

F729 RESET 2531

3529 10K 2515 2u2

3528

22K

MGND

-V_FIL F715 +5VDSTBY 3530 10K 2514 6502 BAS316 F730 2516 100n 10u 3531 1M0 1530 BAS316 6504 BAS316 6505 BAS316 6506 7509 V63111 1 52 3560 100R 3561 100R 3562 100R 5 8 9 10 11 12 13 +5VDSTBY RESET 2 3 3538 4K7 3539 4K7 BAS316 BAS316 REMOTE 4 6 7 50 49 48 47 BAS316 6507 BAS316 6508 BAS316 6503 455K 2517 3537 100p 2518 100p 4K7

+5VDSTBY F702 F703 F704 +5VDSTBY F705 100n 2522 stdby_1 3556 10K 1u 0 2530

+12VSty

3555

3532

4K7

2519

100p 2521

100p 2520

3534

100n

2523

56K

4K7

WH05D-1

3536

-24V

10K

100p

NC +12VSty GND_D +5V_Ever -24V

1 2 3 4 5

2K2

E

1504

2u2

FROM PSU

+12VSty

+5VDSTBY switch

E14 33 45 VDD OSC1 OSC2 D_IO CLK STB 1 2 K 3 4 RESET MODE REMOTE SDA SCL 1 2 3 4 GRID KS

stdby_2 7505 BC847B stdby_2 3533 7508 BC847B

F

TO/FROM 1105 OF MONOBOARD

1502

6512 BAS316

LR-CLK Erro_Det stdby_2

WH09D-1

G

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

44 43 42 41 40 39 38 37 36 35 32 31 30 29 28 27

6514

6515

6513 BAS316

S-CS S_DAT S-CLK GND_MTK 40kHZ IR ioSTBY

1 2 3 4 5 6 7 8 9

F706 F707 F708 F709 F710 F711 F712 F713

6509 BAS316

6510 BAS316

1 2 3 4 5 6 7 8 9 10 11 12

15 16 17 18 19 20 21 22 23 24 25 26

P(1) P(2) P(3) P(4) P(5) P(6) P(7) P(8) P(9) P(10) P(11) P(12)

G(1) G(2) G(3) G(4) G(5) G(6) G(7) G(8)

P(1) P(3)

P(2)

6502 E10 6503 E12 6504 E12 6505 E12 6506 E12 6507 E12 6508 E13 6509 F13 6510 F13 6511 G13 6512 G13 6513 G13 6514 G6 6515 G7 6516 H9 6517 H9 6518 I9 6521 I7 6522 I7 6523 I8 6524 I6 7500 A12 7501 A10 7502 B11 7503 B9 7504-1 B5 7504-2 B6 7505 E5 7506 B13 7507 C4 7508 E6 7509 E10 7510 I2 7511 I12 7512 I12 7513 I13 F702 E2 F703 E2 F704 E2 F705 E2 F706 F3 F707 F3 F708 F3 F709 F3 F710 F3 F711 G3 F712 G3 F713 G3 F715 D10 F716 C9 F717 C11 F718 B2 F719 B2 F720 C2 F721 D2 F723 D2 F724 D2 F725 A14 F726 H3 F727 I3 F728 I4 F729 D8 F730 E10 F733 H12 F734 C4 F735 D2 F736 A14 F737 A14 F738 A14

8

8

4K7

3512

P17 P16 P15 P14 P13 P12 P11 P10 P9 P8 P7 P6 P5 P4 P3 P2 P1

1G 2G 3G 4G 5G 6G 7G 8G

4 5 6 7 8 9 10 11

13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

2509

G(1) G(2) G(3) G(4) G(5) G(6) G(7) G(8)

2513

3535

4K7

100n

-24VD

P(17) P(16) P(15) P(14) P(13) P(12) P(11) P(10) P(9) P(8) P(7) P(6) P(5) P(4) P(3) P(2) P(1)

32

1

F2

F1

F6511 BAS316

SEG

VOLA VOLB1514 EVE 1 3

VOLA Erro_Det VOLB VOLA

GP(17) P(16) P(15) P(14) P(13)

VOLB Stby-k1

GPIO GRID

A

B

1507 SKQNAB

1509 SKQNAB

1511 SKQNAB Stby-k2

6516 VSS BAS316

SEG VEE PSW 46 F733 P(2) +12VD stdby_1

C 4 5 2

H

+5VDSTBY

3540 100R 100n 2524

F726

6517 BAS316 3541 4K7

H2525 33n

51

34 -24VD

1508 3542 10K SKQNAB

1510 SKQNAB

1512 SKQNAB

1513 SKQNAB 6518

+5VDSTBY 7510 TSOP4836ZC1 VS OUT 3 1 2 F727 3544 PDZ5.6-B PDZ5.6-B 4K7 PDZ5.6-B 4K7 PDZ5.6-B 1K0 3547 4K7 3551 1K2 F728 REMOTE

3543 330R 330R 3545 3546 LR-CLK

VGL-1 7511 BC817-25 VGL+1 3552 2K2 35V 10u 25 2 9 -V_FIL 3553 2K2 2528 10u 35V

4K7 2526

22p

BAS316 2527 3549 6522 100p 2532 3550 2533 6524 3548 6521 6523 100p 100p 4K7

4

5

I

GND

I

3554

BC857B 7512

7513 BC847B

3139_243_34144__a2_sh130_sh1.pdf

10K

2006-03-10

1

2

3

4

5

6

7

8

9

10

11

12

13

14


3139 785 31590

7

EN 25

Layout: Display Board (Top view)

DisplayBd_topview_34144.pdf_2006-05-05

Layout: Display Board (Bottom view)

DisplayBd_Bottomview_34144.pdf_2006-05-05


3139 785 31590

7

EN 26

AV Interface Board: Circuit Diagram (Part 1)1 2 3 4 5 6+5VA

7

86K8 3100 3101 10K 3166 7102 BC847B

9

10

11

12

13

BAS316

+12V_A

3102 4R7 3104 1K5

7100 BC847B

6104 +9V 6105 BAS316

3103

B

3165

20FE-BT-VK-N GND GND

3109

39K

3108

12K

Mute

2K2

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

F100 F101 F102

PCM_SCLK PCM_LRCLK PCM_MCLK

BC857B 7101

3K9 BAS316 6108 +5VA GND

BAS316

6106

3161

3105

10K

5K6

F104

F103 1N4148 6100 Data_FL_FR F105 Data_SL_SR F106 Data_Cen_Sub F107 SDA SCL F109 RESET Err_Det F111 BZX384-C9V1 Mute GND 3107 2K2 3164 4K7

LM393D 3106 2156 3 100n +5V_D 2 4 3162 10K 10K 7104-1 1 8 Err_Det

6101

3163

4K7

+5VA

1K0

A

P_control

1601

A

Mute1

7103 BC847B

6107 3 5 BAS316 MuteAV

F108

7111 BC847B

7112-2 BC847BS 4

B

6 GND GND Mute1 2 7112-1 BC847BS 1

F110

C1600 1 2 3 4 5 6 F112 F113 F115 F116 +5VA +5V_Stb +12V_A -12V_A DAC_FL 3110 -12V_A 5K6 2101 2102 4 2 1 3 8 2110 LM833 7108-1 100n 220p F114

GND

C

GND 3111 -12V_A 5K6 3112 2103 2105 4 2 1 3 8 2117 LM833 7109-1 100n 220p -12V_A 5K6 2104 2109 4 2 1 3 8 2118 +12V_A 3130 D_FR DAC_SR 3134 5K6 2127 1n0 3135 8K2 6 7 5 LM833 8 7109-2 +12V_A 5K6 2120 4 220p -12V_A LM833 7110-1 100n 220p

S6B-EH

3115 5K6 2108

3116 8K2 1n0

GND

D_FL DAC_SL 3119 5K6 2113 1n0 3120 8K2

D

GND

GND

D_SL

DAC_CEN

DD_CEN

3123 5K6 21 16 1n0

3124 8K2

GND

GND

100n

GND

+12V_A 3125 5K6 2119 4 220p -12V_A

GND

100n

DAC_FR

GND

GND GND

100n +12V_A 3131 5K6 2124 4 220p -12V_A 6 7 5 LM833 8 7110-2 +12V_A

E

3128 5K6 2123 1n0

3129 8K2 6

ED_SUB

7 5 LM833 8 7108-2 +12V_A

D_SR

DAC_SUB

3138 5K6 2130 1n0

3139 8K2

GND

GND

GND

GND

F

+5VA BAS316 3140 10K 6102 2133 1u0 RESET 10K 3143 7105 BC847B 4100 BAS316 6103

5100 +9V 5101 600R 600R +5V_D +5V_D 10u 2131 2132 10u 2135

GND

GND

F

7106 CS4360-KZ

GNDAOUTA1 27 DAC_FL 7107 PT2258-S 16

2136 2137 100n

8 22

3141

GND

100n 2134

100n

600R

5102

GND

50V 10u

GND+5V_D 3147 33R

10

RST_

INTERPOL FILTER INTERPOL FILTER SERIAL PORT INTERPOL FILTER INTERPOL FILTER INTERPOL FILTER 1 :2 INTERPOL FILTER

VOLUME CONTROL MIXER VOLUME CONTROL VOLUME CONTROL MIXER VOLUME CONTROL VOLUME CONTROL MIXER VOLUME CONTROL

DAC DAC DAC DAC DAC DAC

ANAL FILTER ANAL FILTER ANAL FILTER ANAL FILTER ANAL FILTER ANAL FILTER

GNDAOUTB1 26 DAC_FR D_FL AOUTA2 24 DAC_SL D_FR AOUTB2 23 DAC_SR D_SL AOUTA3 20DAC_CEN D_SR AOUTB3 19 DAC_SUB D_CEN

3146 100K 3148 100K 2138 2u2 2139 2u2 2141 2u2 2143 2u2 2146 2u2 2148 2u2

VCC SCL SDA 6 7 1 2 3 8 9 10 SCL SDA 1 2 3 IN 4 5 6

1 CODE 2 1 2 3 OUT 4 5 6 REF

17 4 20 19 18 13 12 11 15

PCM_SCLK PCM_LRCLK Data_FL_FR Data_SL_SR Data_Cen_Sub

3150 33R

1 5 6 2 3 4

VLS SCLK LRCK SDIN1 SDIN2 SDIN3

GND2140 2u2 2142 2u2 2144 2u2 2147 2u2 2149 2u2 2150

3145 10K

3144 10K

G

GND

G3149 100K 100K 3152 FR 100K 3154 SurL 100K 3157 SurR 100K 3159 Cen 100K 3160 Sub

GNDFL

3151 100K

3153 100K

H

PCM_MCLK

3155 33R 15p 2145

7

MCLK

3156 100K

H

3158 100K

14

GNDSCL SDA 11 12 13 15 14 DIF1|SCL|CCLK DIF0|SDA|CDIN M1|AD0|CS_ M2 VLC

MUTE CONTROL CONTROL PORT/ MODE SELECT

MUTEC1 MUTEC2 MUTEC3

28 25 18

Mute_FRL Mute_SRL Mute_Sub_Cen

D_SUB

GND DGND 5

GND2151 VQ FILT+ 10u 50V 17 16

4u7

2152

2153

100n

100n

10u

10u

+5V_D

2154

2 1 55

I

GND GND9 21

I

GND

GND

GND

3139_243_33675__a2_sh130_sh1.pdf

2006-04-10

1600 C1 1601 A1 2101 C5 2102 D5 2103 D9 2104 D12 2105 D9 2108 D4 2109 D12 2110 D4 2113 D8 2116 D12 2117 D8 2118 E12 2119 E5 2120 E8 2123 E4 2124 E12 2127 E8 2130 F11 2131 F5 2132 F5 2133 F2 2134 G5 2135 G5 2136 G11 2137 G11 2138 G10 2139 G10 2140 H12 2141 H10 2142 H12 2143 H10 2144 H12 2145 H2 2146 H10 2147 H12 2148 H10 2149 H12 2150 I12 2151 I11 2152 I6 2153 I7 2154 I7 2155 I7 2156 B8 3100 A9 3101 A8 3102 A4 3103 A7 3104 A4 3105 A7 3106 B7 3107 B6 3108 C8 3109 C8 3110 C4 3111 D8 3112 D12 3115 D4 3116 D4 3119 D7 3120 D8 3123 D11 3124 D12 3125 E4 3128 E4 3129 E4 3130 E8 3131 E12 3134 E7 3135 E8 3138 E11 3139 E12 3140 F2 3141 G12 3142 G12 3143 G1 3144 G12 3145 G12 3146 G9 3147 G2 3148 G9 3149 G13 3150 G2 3151 H9 3152 H13 3153 H9 3154 H13 3155 H2 3156 H9 3157 H13 3158 H9 3159 H13 3160 I13 3161 A6 3162 B12 3163 B12 3164 B6 3165 B6 3166 A8 4100 F3 5100 F4 5101 F4 5102 G11 6100 B4 6101 B5 6102 F3 6103 F3 6104 A6 6105 A6

6106 A6 6107 B13 6108 A8 7100 A4 7101 A7 7102 A8 7103 B7 7104-1 B10 7105 G1 7106 G3 7107 G11 7108-1 D5 7108-2 E5 7109-1 D8 7109-2 F8 7110-1 E12 7110-2 F12 7111 B6 7112-1 B12 7112-2 B12 F100 A2 F101 A2 F102 A2 F103 B2 F104 B1 F105 B2 F106 B2 F107 B2 F108 B1 F109 B2 F110 B1 F111 B2 F112 C1 F113 C1 F114 C1 F115 D1 F116 D1

10K

1

2

3

4

VD VA

5

6

7

8

9

10

11

12

3142 10K

13


3139 785 31590

7

EN 27

AV Interface Board: Circuit Diagram (Part 2)1 2 3 4 5 6 7 8 9 10 11 121602 D12 2200 A8 2201 B3 2202 B5 2203 A5 2204 B7 2205 B3 2206 B8 2207 B1 2213 B2 2214 B2 2215 B3 2216 C3 2217 C1 2218 C7 2219 F7 2220 I6 2221 C2 2222 C2 2223 D3 2224 D5 2225 D3 2228 D8 2229 E1 2230 E2 2235 E2 2236 E7 2237 E3 2238 E8 2240 E5 2241 F3 2242 F1 2243 F2 2247 F2 2248 G3 2249 G3 2250 G6 2251 H6 2252 G1 2254 G2 2255 G2 2256 G8 2262 H3 2263 H7 2267 H8 2268 H3 2271 I2 2275 D12 2276 E12 2278 E12 3113 H2 3200 A7 3203 A7 3204 A3 3205 B9 3206 B9 3207 B7 3208 B1 3209 B2 3210 B2 3211 B2 3213 B7 3218 C7 3219 C7 3220 C3 3221 C1 3222 C1 3223 C2 3224 C6 3225 C6 3229 C2 3230 D3 3231 D7 3234 E1 3235 E2 3236 E2 3237 E2 3238 D7 3240 E9 3241 E9 3242 E7 3243 E3 3244 E7 3249 F1 3250 F1 3251 F2 3252 F2 3253 F7 3254 F7 3255 G3 3256 G1 3257 F6 3258 F6 3262 G2 3263 G2 3264 G2 3265 G7 3273 G7 3274 H9 3280 H9 3281 H3 3282 H7 3283 I6 3284 I6 3286 H2 3287 H7 3288 I7 3289 I7 3290 C8 3291 C9 3292 C6 3293 F6 3294 F9 3295 F10 3296 I6 3297 I9 3298 I10 6202 C9 6203 F10 6204 I10 6210 D12 7200-1 B3 7200-2 D3 7201-1 E3 7201-2 F3 7202-1 H3 7202-2 I3 7203-1 A8 7203-2 B8 7204-1 C9 7204-2 C6 7205-1 D8 7205-2 E8 7206-1 F10 7206-2 F6 7207-1 G8 7207-2 H8 7208-1 I10 7208-2 I6

A3204 -12V_A 82K 2201 2205 56p

2203 L 1u0

3200 Lf 680R 6 7203-1 BC847BS 1

A

2K2 2204 100n

2200

100p

3203 2

Rf

3205

3206

1K8

2206

100p

B

FL

3207 3208 1K0 560p 2207 3209 2K2 2213 1n0 3210 3K3 2214 2n2 3211 2K2 2 1 3 8 2215 LM833 7200-1 R 1u0 +5VA +12V_A 3292 3218 3219 10K 10K 10K 3220 82K 2216 4 56p -12V_A 6 7 5 LM833 8 7200-2 +12V_A MuteAV R Mute_FRL1 3224 2K2 3225 2K2 5 2218 4 4 100n

GND

L 2202 BC847BPN 7204-2

2K2

5

4 BC847BS 7203-2 3

1K8

GND

GND

B

680R 4K7 3

3291

+5VA

3213

GND

GND

GND GND

100n

Mute_FRL1 6202

6 Mute_FRL 3290 10K 1u0 2

CFR 3221 1K0 2217 560p 3222 2K2 2221 1n0 3223 3K3 2222 2n2 3229 2K2

BAS316 7204-1 BC847BPN 1

-12V_A GND

GND GND

C

100n

GND2224 3231 680R 6 7205-1 BC847BS 1 Rs Cent GND GND Subw GND GND Lf Rf GND Rs Ls SL 1u0 2223 2225 56p Ls P_control

2275

GND

GND

GND

GND3230 82K -12V_A

BAS316 1602 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

6210

D

D

2228

SurL

2K2 4 100n

3241

3240

1K0 560p 2229

2K2 2230 1n0

3K3 2235 2n2

2K2

2 1 3 8 2237 LM833 7201-1

GND

SL

2236 100n 22 38 100p 3242 2K2 5 4 BC847BS 7205-2 3 BC847BPN 7206-2

1K8

1K8

3234

3235

3236

3237

100p

3238 2

EGND GND GND GND

GND

GND

2276 22n 2278 +5VA 22n

16 17

E

100n +12V_A 3243 82K 2241 4 56p 6 7 5 2219 1u0 LM833 8 7201-2 +12V_A MuteAV 3257 2K2 3258 2K2 -12V_A +5VA 3293 4 SR 2240 1u0 3244 680R 3

1216-014-15S-AAF

3253

3254

560p

2242

2243

2247

F

1K0

2K2 1n0

3K3 2n2

2K2

SR

10 K

5

1 0K

10 K

3249

3250

3251

3252

3295

4K7

SurR

Mute_SRL1 6203

6

-12V_A

GND

Mute_SRL

3294 10K

2

BAS316 7206-1 BC847BPN 1

F

GND

GND

GND

GND

Mute_SRL1

GND GND

3255 82K -12V_A

GCen 3256 1K0 560p 2252 3262 2K2 2254 1n0 3263 3K3 2255 2n2 3264 2K2 2

2248 2249 4 100n

56p C

2250 1u0

3265 Cent 680R 6 7207-1 BC847BS 1

G

GND1 LM833 7202-1

C

3 8 2262

2K2 2263 100n

2256

100p

3273 2

Subw

3274

3280

1K8

GND

GND

GND GND

100n

+12V_A

2 26 7

100p

HSub 3113 4K7 2271 1n0 3286 4K7

3282 2K2 5

4 BC847BS 7207-2 3

1K8

GND

GND

3281 180K 2268 Lfe 4 270p -12V_A 6 7 5 3296 3288 1 0K 10K LM833 8 7202-2 +12V_A 1u0 Lfe +5VA 4 2251 BC847BPN 7208-2 3287 680R

H+5VA 3298 4K7

3

Mute_Sub_Cen1 6204

6 Mute_Sub_Cen 3297 10K 2

3289

10K

I

5 MuteAV 3283 2K2 3284 2K2

GND

GND

Mute_Sub_Cen1

2220

1u0

-12V_A GND

GND

BAS316 7208-1 BC847BPN 1

I

GND

3139_243_33675__a2_sh130_sh2.pdf

2006-04-10

1

2

3

4

5

6

7

8

9

10

11

12


3139 785 31590

7.

EN 28

Layout: AV Interface Board (Top view)

Layout: AV Interface Board (Bottom view)

AVInterfaceBd_Bottomview_33675.pdf_2006-05-05

AVInterfaceBd_Topview_33675.pdf_2006-05-05


3139 785 31590

7

EN 29

PCBA 9.1 Board: Circuit Diagram (Part 1)1 2 3 4 5 6

7

8

9

1033R 3102

11CENTRE_CH USB_OVERCURRENT SurrL GPIO_1 Lo GPIO_2 Ro GPIO_3 SurrR SEL_0 SubW SEL_1 MUTE_CTRL2

12DV33

13

14

4K7

DV33

DV33

33R

3106

4K7

33R

3103

3167

1K0

A5140 BLM18P

2101 100n7115 74HC1G04GW 2 1 5NC

RFVDD

33R

3107

I2C_DAT I2C_CLK

2152 100n

DV33

33R

3101

7116 74HC1G04GW 2 4 1 5NC

7117 74HC1G04GW 2 4 1 5NC

33R

3110

4

3168 33R

33R 33R 33R 33R

3109 3111 3113 3115

RDS_DATA USB_OVERCURRENT RDS_CLK GPIO_1

A

27M

2154

22p

+V_V33

3166

220u

33R

+1V8

+V18

100n

2166 1n0

+V18

2158

2161

100n 560R

10R

10R

DV33

XTALI

XO

XTALI

100K

+V_V33

2164 33p

2165 22p

SPMCLK PCM_DATA2 PCM_DATA1

5141 16M

2177 3119

2192

B+RF_V5 DV33 FOSO +5VL

RFVDD5160 BLM18P

PCM_DATA0

5147 BLM18P

+V_V33

3173

3116

100K

3156

V1P4

3117

2169 100n

2184 100n

B

FOO

5145 BLM18P

100n

27K3125 15K3126 10KDMO C_ B_ A_ D_ FMO

AVDD3 IREF RFGC OSN OSP CEQN CEQP RFGND CRTPLP HRFZC RFRPAC RFRPDC RFVDD3 S_VREFN S_VREFP ADCVSS S_VCM ADCVDD3 LPFOP LPFIN LPFIP LPFON PLLVDD3 IDACEXLP PLLVSS JITFN JITFO XTALI XTALO RFVDD18 RFGND18 SPDIF MC_DATA DVSS_13 ASDATA4 DVDD18_6 ASDATA3 ASDATA2 ASDATA1 ASDATA0 DVSS_12 ACLK ABCK ALRCK DVDD3_10 SPBCK SPLRCK SPDATA SPMCLK HSYN YUV7 VSYN DVDD3_9 YUV6 YUV5 DACVSSA YUV4 DACVDDA YUV3 DACVSSB YUV2 DACVDDB YUV1 DACVSSC

TRSO

27K 3124

TRO

203 202 201 2 00 199 198 197 196 195 194 1 93

2193 100n

2194 2n2

100n

3123

2001 100u

2190

2191

RFVDD

+V_V33

FMSO

C

DMSO

2196 2197 2102 2103 2104 4122 4123 4124 4125

1u0 1u0 1u0 1u0 1u0 T143

V1P4

2111 220u

2112 100n

D1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 rf 17 18 19 20 21 22 23 24 26

3

2

5151 10u

3131 4R7

3130 4R7 +L_V33+L_V33

5148 BLM18P

DV33 E F

47u 16V

+RF_V5

47u 16V

2114

T101 T102T103 T104 T105 T106 T107

7105 BC807-25

2115

1101 SFV24R-1ST

5152 BLM18P

5153 10u

1

7104 BC807-25

4126

V2P8

V1P4

V20

3132 390R

DV33

5154

BLM18P

3133 100R

3134 100RADIN

2117 100n100n

100nV2P8 V20 V1P4

T141 T142 T112 T139 T140 T136 T138

2121

2119

2120

2123

2122

2124

E

2118 21253135OPOP+ V1P4

100n 2n2

T109 T110 T111 T113 T114 T115 T116 T117 T118 T119 T120 T121 T122 T123

E +RF_V5 V20 F B_ A_ BC847B 7106 BC847B 7107

2126 680K

100n

3140 10K D_ C_

3 1 2IOA

2132

+5VL

+5M

F

TT+ F+ F-

2002 2133 22p 100n

USB_LIMITER_OE

2 3

1 2 IN

OUT 2 3GND OC_

7 8 5USB_OVERCURRENT

31841105 1 2 3 4 B4B-EH-APSS8550 7118

2131 100n 1106 3 4 100n ACM 2135

6n8

5156

3139 10K 7109 BC817-25W

7110 TPS2051D 4DISABLE_USB

3138 2129DV33

680K 2n2

EN

1

6

3169 3170

15K 15K

5155 BLM18P

DMO FMO TROPEN T137 TRO FOO

+5VL

4143

470R

25

3171 4K7

2 1

100R 100RADIN TROUT TRIN STBY TRCLOSEA(2) A(3) A(4) A(5) A(6) A(7) A(8) A(18) A(19)

5149 BLM31

3182 3183

SL+ SLSP+ SP-

+5V_STBY 50R5159 BLM31

100n

1102 B6B-PH-K 6 5 4 3 2 1 T125 T126 T127 T128 T129 T130

2199

4127 4128 4129 4130

USB_OVERCURRENT

+5M

2138D

50R

+V18

5157 BLM18P

47u 16V7111 AM5888S 19 8

GLIMIT

3143

1R0

2140 100n

2141 100n

5158100n 21422185 22p

31443146 3145

1R0 3147FOSO 3148

150K

150K

23 26 21

+5M

VINLD VOSL VINTK VTCL VOLD FWD REV VOTK 1 TRB 2 VOTR BIAS MUTE REGO NC GND22

+

11 12

SP+ SPSL+ SLTT+ LOAD+ LOADREGO1 REGO2 +1V8 TRB1 +5VL

4135

+5D

DV33

OP+

TRSO OP-

2143

10K FMSO

APLLVDD3 IOWR# A16 HIGHA7 HIGHA6 HIGHA5 HIGHA4 HIGHA3 DVDD3_1 HIGHA2 HIGHA1 IOA20 IOCS# IOA1 IOOE# DVDD3_2 AD0 AD1 AD2 AD3 DVSS_2 AD4 AD5 AD6 IOA21 ALE AD7 A17 IOA0 DVSS_3 UWR# URD# DVDD18_2 UP1_2 UP1_3 UP1_4 UP1_5 UP1_6 UP1_7 UP3_0 UP3_1 UP3_4 UP3_5 DVDD3_3 ICE PRST# IR INT0# DQM0 DQS0 RD7 DVSS_4 RD6 RD5 DVSS_5 RD4 RD3 DVDD18_3 RD2 RD1 RD0 RD15 DVDD3_4 RD14

DMSO

4

VOFC VINSL+ -

13

F-

LIMIT DQ8

10K

100n

VINFC

+

F+

DV33

1

MOTOR DRIVER

VCC14

3172 470R D

D

D

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64

AGND DVDA DVDB DVDC DVDD DVDRFIP DVDRFIN MA MB MC MD SA SB SC SD CDFON CDFOP TNI TPI MDI1 MDI2 LDO2 LDO1 SVDD3 CSO RFLVL SGND V2REFO V20 VREFO FEO TEO TEZISLV OP_OUT OP_INN OP_INP DMO FMO TROPENPWM PWMOUT1 TRO FOO USB_VSS USBP USBM USB_VDD3 FG TDI TMS TCK TDO DVDD18_1 IOA2 IOA3 IOA4 IOA5 IOA6 IOA7 HIGHA0 IOA18 IOA19 DVSS_1 APLLCAP APLLVSS

7108 MT1389

YUV0 FS VREF DACVDDC RD16 RD17 RD18 RD19 RD20 RD21 DVDD3_8 RD22 RD23 DQM2 DQM3 RD24 RD25 DVSS_11 RD26 DVDD18_5 RD27 RD28 RD29 RD30 RD31 DVDD3_7 RA4 RA5 RA6 DVSS_10 RA7 DVSS_9 RA8 RA9 RA11 CKE RCLK DVDD3_6 RCLKB RVREF DVDD18_4 RA3 RA2 RA1 DVSS_8 RA0 RA10 BA1 DVSS_7 BA0 RCS# DVDD3_5 RAS# CAS# RWE# DQM1 DQS1 RD8 DVSS_6 RD9 RD10 RD11 RD12 RD13

192 191 190 189 188 187 186 185 184 183 182 181 180 3128 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129

2186

#Y #C

2195 100n

C+V_V33

2105

330p

2106

330p

100n

2107

2108

#CVBS #Y_G #B_Cb_Pb #R_Cr_Pr

2110 120p

2109 100n

47R

3127

47R

HDMI_VSYN HDMI_HSYN S0 S1

AUX_DATA_IN

31293179 3180

47R47R 47R

HDMI_RST HDMI_C0 HDMI_C1 HDMI_C2 HDMI_C3 HDMI_C4 HDMI_C5 HDMI_C6 HDMI_C7 HDMI_VCK HDMI_Y0 HDMI_Y1 HDMI_Y2 HDMI_Y3 HDMI_Y4 HDMI_Y5 HDMI_Y6 HDMI_Y7 MA4 MA5 MA6 MA7 MA8 MA9 MA11 DCKE DCLK MA3 MA2 MA1 MA0 MA10 BA1 BA0 CS RAS CAS WE DQM1

2113 100n+V18

D

DV33

2116 100n

E+V18

3136 100K

3137 100K

2128 100nDV33

2130 100n

D

2134 100nDV33 +V18

F

2137 100n

D

GDV33

65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 1 09 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128

3149 10KTRCLOSE TROPEN TRB1

+ + + 1 2 PGND29 30

17 18 15 16 10 9 5 3

+5V_STBY

4136 1N4001 2145 6104

UP3_1 UP3_0

22R 22R 4142 4137

3162 3164

STBY_PSU STBY_FRONT UART_TX UART_RX

100n

DV33

4144

D

D

4146

H1103 B5B-PH-K 1 2 3 4 5T131 T132 T133 T134 T135 4131 60R 60R 4134 60R 60R 60R 60R 4138 4139 4145 4147 4132 4133

2144

100n

10K 3150

4K7

6 7 2 25 27 28 20

61051N4001 TRB2 PSS8550 7112

H

D

DTRB2

DMUTE_CTRL1 PWR A(16) A(15) A(14) A(13) A(12) A(11) A(10) A(9) A(20) PCE A(1) PRD AD(0) AD(1) AD(2) AD(3) AD(4) AD(5) AD(6) A21 AD(7) A(17) A(0)

DISABLE_USB

100n

LOAD+ LOAD-

V1P4 STBY

PSS8550 7113

RC6

DV33

3177 22K

D2146

7119 BC817-25W

DV33

+V18

TROUT

220u

100n

2187

2188

DDV33

D

D

2136 2139 2160 2162 2163

4K7 4K7

3157 3158

3159

TRIN

I2C_CLK1 I2C_DAT1

3161 3163

22R 22R1 2 3 4 1104 B4B-PH-K

D

D

3

4

2159 100n

DV33

3152

1 0K 6106

TROUT

D

10K

9K1 3160

GND NC

CD

5

S1D

1

INP OUTP

+5D

3139_243_33576__a2_sh130_sh1.pdf

2147

100 n

2003

22p 22p 22p 22p 2 2p

REGO1

REGO2

VSCK VSDA VSTB

2

10u 16V

T155 T156 T157 T158

I

2148

TRIN

10K 3155

100n 2155 3174 3175 3176

DV33

100n

24

D

5K6 3153

15K 3154

DV33

100n 2151

DV33

D

100R 100R 100R

7114 NCP303LSN30

I

2006-02-28

1101 D1 1102 F1 1103 H1 1104 I10 1105 F5 1106 F6 2001 B6 2002 F2 2003 I13 2101 A4 2102 C6 2103 C6 2104 C6 2105 C3 2106 C4 2107 C4 2108 C4 2109 C14 2110 C6 2111 D2 2112 D2 2113 D13 2114 D5 2115 D3 2116 E13 2117 E5 2118 E5 2119 E4 2120 E4 2121 E4 2122 E4 2123 E4 2124 E5 2125 E5 2126 E6 2127 E2 2128 E13 2129 E5 2130 F13 2131 F6 2132 F6 2133 F3 2134 F13 2135 F6 2136 I1 2137 G13 2138 G4 2139 I1 2140 G6 2141 G6 2142 G1 2143 G13 2144 H3 2145 H7 2146 I11 2147 I13 2148 I4 2149 A9 2150 A9 2151 I9 2152 A8 2153 A9 2154 A8 2155 I9 2156 B10 2157 B11 2158 B2 2159 I12 2160 I1 2161 B2 2162 I1 2163 I1 2164 B4 2165 B5 2166 A8 2167 B8 2168 B8 2169 A13 2170 B9 2171 B9 2172 A9 2173 B10 2174 B10 2175 B10 2176 B8 2177 B12 2178 B8 2179 B8 2180 B8 2181 B8 2182 B8 2183 B8 2184 B12 2185 G1 2186 C2 2187 I8 2188 I8 2189 B10 2190 B13 2191 B13 2192 B7 2193 B6 2194 B6 2195 C13 2196 C6 2197 C6 2199 G3 3101 A10 3102 A10 3103 A10 3104 A12 3105 A12 3106 A10 3107 A10 3109 A12 3110 A10

3111 A12 3112 A9 3113 A12 3115 A12 3116 B4 3117 B8 3118 B9 3119 B12 3120 B7 3121 B10 3122 B10 3123 B4 3124 C4 3125 C4 3126 C4 3127 D14 3128 D12 3129 D14 3130 D5 3131 D3 3132 D2 3133 E3 3134 E3 3135 E5 3136 E2 3137 E3 3138 E5 3139 F3 3140 F3 3143 G2 3144 G2 3145 G2 3146 G2 3147 G2 3148 G3 3149 H3 3150 H3 3151 H10 3152 I12 3153 I6 3154 I7 3155 I3 3156 B5 3157 I3 3158 I3 3159 I6 3160 I7 3161 I9 3162 H13 3163 I9 3164 H13 3165 B10 3166 A5 3167 A6 3168 A6 3169 F5 3170 F5 3171 F4 3172 G5 3173 B4 3174 I9 3175 I9 3176 I9 3177 H13 3178 B11 3179 D14 3180 D14 3181 B11 3182 F7 3183 F7 3184 F5 4122 C7 4123 C7 4124 C7 4125 D7 4126 D7 4127 F2 4128 F2 4129 G2 4130 G2 4131 H2 4132 H2 4133 I2 4134 I2 4135 H7 4136 H7 4137 H13 4138 I2 4139 I2 4142 H13 4143 F4 4144 H10 4145 I2 4146 H11 4147 I2 5139 A9 5140 A2 5141 B4 5142 A9 5143 B10 5144 A9 5145 B2 5147 B13 5148 D5 5149 F3 5151 D3 5152 D2 5153 D3 5154 E5 5155 F6 5156 F3 5157 G6 5158 G1 5159 G3 5160 B6 6104 H7

2127 100n

6105 H6 6106 I12 7104 D4 7105 D3 7106 E2 7107 E3 7108 E10 7109 F3 7110 E4 7111 G4 7112 H6 7113 H7 7114 I11 7115 A4 7116 A5 7117 A5 7118 G5 7119 H14 T101 D2 T102 D2 T103 E2 T104 E2 T105 E2 T106 E2 T107 E2 T109 E2 T110 E2 T111 E2 T112 E7 T113 E2 T114 E2 T115 E2 T116 E2 T117 F2 T118 F2 T119 F2 T120 F2 T121 F2 T122 F2 T123 F2 T125 G1 T126 G1 T127 G1 T128 G1 T129 G1 T130 G1 T131 I1 T132 I1 T133 I1 T134 I1 T135 I1 T136 E7 T137 F7 T138 E7 T139 E7 T140 E7 T141 E7 T142 E7 T143 C7 T155 I10 T156 I10 T157 I10 T158 I10

256 255 3120 15K 2178 100n 254 2179 100n 253 2 52 251 2180 33 n 250 249 2181 100n 248 247 246 2176 100n 245 RFVDD 2 44 10V 2167 100u 2182 47n 243 242 2168 100n 2183 47n 241 240 5142 2 39 3112 6R8 238 2149 470n BLM18P 2 37 236 2170 1n0 2150 10u 235 3118 750K 234 XTALI 233 5144 BLM18P +V18 XO 2171 100n 232 2 31 5139 60R DV33 10V 100u 2153 230 6.3V 4u7 2172 229 228 227 2 26 2189 6.3V 10u 225 224 223 222 221 2174 6.3V 10u 220 2 19 5143 60R DV33 10V 100u 2173 218 2175 100n 217 216 33R 3121 SPDIF_OUT 215 33R 3122 AUX_DATA_IN 214 33R 3165 PCM_DATA4 21 3 2156 100n 212 PCM_DATA3 211 PCM_MCLK 210 PCM_BCLK 209 2157 100n PCM_LRCLK 208 DV33 207 SPBCLK MUTE_CTRL1 22R 3178 2 06 SPLRCLK 205 SPDATA 22R 3181 204

3104

1

3

1

3

1

3

3105

15n

3

2

1

1

100n

47u

47u

47u

UP3_0 UP3_1

D

3151

DQM0 I OA DQ7 DQ6 DQ5 DQ4 DQ3

DQ2 DQ1 DQ0 DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ9

D

100n

10u

1

2

3

4

5

6

7

8

9

10

11

12

13

14


3139 785 31590

7.

EN 30

PCBA 9.1 Board: Circuit Diagram (Part 2)1#R_Cr_Pr 2201 47p 2202 47p 3201 150R 5201 1u8 R_Cr_Pr 3202 150R32 03 1 5 0R

2#C2 20 3 47 p

3C 3 20 4 1 5 0R 2 20 4 4 7p 5202 1u8

4

5

6

7

8

9

10

11

12

13

+5V_STBY D B8B-PH-K-S 1205 F249 F222 1 F223 2 F224 3 F225 4 F226 5 F227 6 F228 7 F229 8 B9B-PH-K 1206 1 2 3 4 5 6 7 8 9 10p 10p 10p 22p 22p 22p 22p 2227 2228 2229 2230 2231 2232 2234 I2C_CLK 7208 BSH103 2 3 RDS_CLK RDS_DATA SPDIF_IN 1

D

D

#B_Cb_Pb 3206 150R 2205 47p 5203 1u8

B_Cb_Pb 3207 150R3208 150R

#Y2207 47p 2208 47p 5204 1u8

Y 3209 150R

2206 47p

PCM_LRCLK

4203 RC6

VSDA VSCK VSTB 1K0 3205

DV33 D

3271

1K0

4206

1

2257

100n

1 2 3 4 5 6 7 8 GPIO_1 DV33

B3210 150R

+5VLD D

DV33

1 2 3 4 5 6 7 8 9 10

F230 F231 F232 F234 F233 F235 F236 F237 F245 F240 F241

D 30FE-BT-VK-N +5VL STBY_FRONT

4208 4209 1207 +5VL F246 1 2 3 4 5 B5B-EH-A D D

I2C_DAT

2 7209 BSH103

3 3265 4K7

#Y_G 2209 47p 2210 47p 5205 1u8

Y_G VSDA VSCK I2C_DAT I2C_CLK SEL_1 SEL_0 3277 3278 3279 3280 22R 22R 22R 22R F201 MUTE_CTRL2 MUTE_CTRL1 26FE-BT-VK-NA 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 1202 D D F202 F203 F204 F205 F206 F207 F208 F209 F210 F211 F212 F213 F214 F215 F216 F217 F218 F219 F221 F220 3211 150R

D #CVBS

CVBS3213 150R 2212 47p 5206 1u8

C

3212 150R

2211 47p

S1 S0 33R PCM_DATA3 33R 3276 3275

#PCM_DATA3

D

PCM_DATA4 PCM_DATA2 PCM_DATA1 PCM_DATA0

33R 33R 33R 33R 33R 33R

3214 3215 3216 3217 3218 3221 AUX_DATA_IN 3281

DPCM_BCLK 3267 150R 2 1

PCM_LRCLK 4216 DV33 100n 5 2268

30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 1201

4212

22p 22p 22p 22p 22p 22p

2221 2222 2223 2224 2225 2226

+5V_STBY STBY_PSU

F247 F248

22p 22p

2235 2236 D

UART_RX UART_TX GPIO_3 GPIO_2 7207 BC817-25W GPO_1 D

F242 F243 F239 F238

HDMI_RST

3266 22K

1 2 3 4 5 6 7 8 9 10 22p 11 100n 12 13 14 15 16 22p 17 22p 18 19 22p 22p 20 21

22p 22 p 22p 22p

A

08FE-BT-VK-N 1204

10FE-BT-VK-N 1208

21FE-BT-VK-N 1203

D

A4201 4202 4204 4205 4207 4211 SubW CENTRE_CH Ro Lo SurrL SurrR

2260 2265

B

2266 2267 2261 2262

D

D

I2C_CLK1

7210 BSH103 2 3

D

F244

C2264 DV33 100n D

DV335207 BLM18P

3108 1

HDMI_SWITCH DV33 D 2256 100n 2 7211 BSH103 3

7201 74HC1G125GW

3219 1K0SPDIF_OUT HDMI_AUDIO_MUTE

5 2 4 1

2213 3220

100n D 22R #SPDIF_OUT

I2C_DAT1

1

1K0

EN3

D

22R 1K0 1K0 1K0

2214 22p

2215 22p

2216 22p

2217 22p

2219 22p

2218 22p

2220 22p

4 120R

3222

EN3

3223

3224

3225

7214 74AHC1G125GW

7202 74HC1G125GW 3226 1K0 SPDIF_OUT 5 2 4 1

DV332233 3227 100n D 22R SPDIF_MT1392

DV33

PCM_MCLK

5208 BLM18P

3258 7212 M24C16-RDW6 100n 8

ED

EN3

4214 5211 BLM18P DV332241 47u 16V

1 2 3

(2Kx8) EEPROM0 1 2 ADR

D 7 6 5

ED I2C_CLK I2C_DAT

WC SCL

SDA4

37

F

A(0:21)

G

220p

330R

MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11

3233 3235 3237 3239 3240 3241 3242 3244 3246 3248 3249 3250

150R 150R 150R 150R 150R 150R 150R 150R 150R 150R 150R 150R

23 24 25 26 29 30 31 32 33 34 22 35

VDD 0 1 2 3 4 5 A 0 1M-1 6 7 8 9 10 11

DRAM

VDDQ NC36 40

1M X 16 X 4

7206 IS42S16400A

DBA0 BA1 DCLK DCKE CS RAS CAS WE

2263

3238

3251 3252 3253 3254 3256 3270 3259 3261

150R 150R 47R 150R 150R 150R 150R 150R

20 21 38 37 19 18 17 16

0 BA 1 CLK CKE CS RAS CAS WE VSS54 6 28 41

H

0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

2 4 5 7 8 10 11 13 42 44 45 47 48 50 51 53

DQ7 DQ6 DQ5 DQ4 DQ3 DQ2 DQ1 DQ0 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15

A(1) A(2) A(3) A(4) A(5) A(6) A(7) A(8) A(9) A(10) A(11) A(12) A(13) A(14) A(15) A(16) A(17) A(18) A(19) A(20) 4210

25 24 23 22 21 20 19 18 8 7 6 5 4 3 2 1 48 17 16 9

0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

[FLASH] 2Mx8/1Mx16

A

0 2M-1 / 1M-1

0 1 2 3 4 5 6 7 D 8 9 10 11 12 13 14 15 A-1

3273

A(0)

DV33 HDMI_RST2252 100n

3230 3269 3268

I2C_DAT 4217

NC+3V3_FL PWR PRD PCE +3V3_FL 3257 10K

VSSQ12 46

VSS27 46

22

DQM52

H L

39 15

3263 3264

150R 150R

DQM1 DQM0

RB RP WE OE CE BYTE

13 14 10

3255 22R

+3V3_FL A21

I2C_CLK

3232

22R

14 15 18 19 20

4K7 4K7

47K

29 31 33 35 38 40 42 44 30 32 34 36 39 41 43 45

23

6

21

AD(0) AD(1) AD(2) AD(3) AD(4) AD(5) AD(6) AD(7)

AD(0:7)

2240 2242 2243 2245 2246 2248 2249 43 49 14 27 1 3 9

100n 100n 100n 100n 100n 100n 100n

+3V3_FL 7205 M29W160ET70

5212 BLM18P DV332244 47u 100n 16V 5210 BLM18P 2239 100n

D

FDV33

VDD

2247

5209 BLM18P

100n 2238 47n 2255 100n 2 254 100n 2250

DV33 7203 CS8416-CZ 3274SPDIF_IN

47K 322822R 3229 SPDATA

VA2251 100n

220R3260 10K

4 3 2 1 10 11 12 13 9 5 25 16

0 1 2 3 RXP 4 5 6 7 RST RXN OMCK SCL CCLK

DIG. AUDIO IF RECEIVER FILTRMCK OSCLK OLRCK SDOUT SDA CDOUT AD CS CDIN 2 GPO 1 0 DGND

VD

VL8 24 3231 27 3247 28 3243 26 17 22R

1K2 3262 22R 22R 22R SPMCLK SPBCLK SPLRCLK

GDV33

MUTE_CTRL2

DV33

3272 3236 47K

7213 BC817-25W

4215USB_LIMITER_OE

H

AGND7

DV33

3234 10KMUTE_CTRL1

3245 100K

7204 BC817-25W

I

I3139_243_33576__a2_sh130_sh2.pdf 2006-02-28

1201 D6 1202 D5 1203 A12 1204 A11 1205 A8 1206 A8 1207 B8 1208 A12 2201 A1 2202 A1 2203 A3 2204 A3 2205 B1 2206 B1 2207 B3 2208 B3 2209 B1 2210 B1 2211 C1 2212 C1 2213 D8 2214 E3 2215 E3 2216 E3 2217 E3 2218 E3 2219 E4 2220 E4 2221 C6 2222 C6 2223 C6 2224 C6 2225 C6 2226 C6 2227 A9 2228 A9 2229 B9 2230 B9 2231 B9 2232 B9 2233 E8 2234 B9 2235 C9 2236 C9 2237 A13 2238 G9 2239 F10 2240 F3 2241 F2 2242 F3 2243 F3 2244 F7 2245 F3 2246 F3 2247 F7 2248 F3 2249 F3 2250 G10 2251 G8 2252 H8 2253 I11 2254 G11 2255 G11 2256 D10 2257 B9 2258 A13 2259 A13 2260 B13 2261 B13 2262 C13 2263 H8 2264 C13 2265 B13 2266 B13 2267 B13 2268 D2 2269 A13 3108 C10 3201 A1 3202 A2 3203 A3 3204 A4 3205 B7 3206 B1 3207 B2 3208 B3 3209 B4 3210 B1 3211 B2 3212 C1 3213 C2 3214 C2 3215 D2 3216 D2 3217 D2 3218 D2 3219 D7 3220 D8 3221 D2 3222 E2 3223 E4 3224 E4 3225 E4 3226 E7 3227 E8 3228 G12 3229 G12 3230 H11

3231 G10 3232 H9 3233 G2 3234 H11 3235 G2 3236 H12 3237 G2 3238 H8 3239 G2 3240 G2 3241 G2 3242 G2 3243 G10 3244 G2 3245 I11 3246 G2 3247 G10 3248 G2 3249 G2 3250 G2 3251 H2 3252 H2 3253 H2 3254 H2 3255 H7 3256 H2 3257 H5 3258 E12 3259 H2 3260 G9 3261 H2 3262 G11 3263 H4 3264 H4 3265 B10 3266 C10 3267 D1 3268 H11 3269 H11 3270 H2 3271 A9 3272 H12 3273 G13 3274 G8 3275 C3 3276 C3 3277 B3 3278 B3 3279 B3 3280 B3 3281 D4 4201 A13 4202 A13 4203 B7 4204 A13 4205 B13 4206 B7 4207 B13 4208 B7 4209 B7 4210 H5 4211 B13 4212 B10 4213 D7 4214 F7 4215 H11 4216 D1 4217 H12 5201 A1 5202 A3 5203 B1 5204 B3 5205 B1 5206 C1 5207 D8 5208 E8 5209 G9 5210 F10 5211 F2 5212 F7 7201 D7 7202 E7 7203 G9 7204 I12 7205 F5 7206 G3 7207 C10 7208 A10 7209 B10 7210 C10 7211 D10 7212 E11 7213 H13 7214 E2 F201 B5 F202 B5 F203 C5 F204 C5 F205 C5 F206 C5 F207 C5 F208 C5 F209 C5 F210 C5 F211 C5 F212 C5 F213 D5 F214 D5

F215 D5 F216 D5 F217 D5 F218 D5 F219 D5 F220 D5 F221 D5 F222 A8 F223 A8 F224 B8 F225 B8 F226 B8 F227 B8 F228 B8 F229 B8 F230 A12 F231 A12 F232 A12 F233 B12 F234 B12 F235 B12 F236 B12 F237 B12 F238 C12 F239 B12 F240 B12

Philips HTS3455

Documents

Transcript of Philips HTS3455