Philips Chassis LC4.31E AB
Transcript of Philips Chassis LC4.31E AB
Published by WS 0662 TV Service Printed in the Netherlands Subject to modification EN 3122 785 16220
©Copyright 2006 Philips Consumer Electronics B.V. Eindhoven, The Netherlands.All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.
Colour Television Chassis
LC4.31EAB
Supplement to manual LC4.31E AA 3122 785 16210
G_16210_000.eps090206
ME6 ME5
Contents Page1. Technical Specifications, Connections, and Chassis
Overview 22. Safety Instructions, Warnings, and Notes 43. Directions for Use 44. Mechanical Instructions 55. Service Modes, Error Codes, and Fault Finding 76. Block Diagrams, Test Point Overviews, and
WaveformsWiring Diagram 26” & 32” 9Wiring Diagram 37” 10Wiring Diagram 42” 11Block Diagram Supply 37” 12Block Diagram Supply 42” 13Block Diagram Video 14Block Diagram Audio & Control 15Block Diagram IBO Zapper 16I2C Overview 17Supply Voltage Overview 18
7. Circuit Diagrams and PWB Layouts Diagram PWBIBO Zapper Panel: MOJO (K1) 19 26-31IBO Zapper Panel: Flash Memory (K2) 20 26-31IBO Zapper Panel: Power Supply (K3) 21 26-31IBO Zapper Panel: Interface (K4) 22 26-31IBO Zapper Panel: Analog Back End (K5) 23 26-31IBO Zapper Panel: Front End (K6) 24 26-31IBO Zapper Panel: Common Interface (K7) 25 26-31
8. Alignments 379. Circuit Descriptions, Abbreviation List, and IC Data
Sheets 40Abbreviation List 42IC Data Sheets 44
10. Spare Parts List 4611. Revision List 48
Technical Specifications, Connections, and Chassis OverviewEN 2 LC4.31E AB1.
1. Technical Specifications, Connections, and Chassis Overview
Index of this chapter:1.1 Technical Specifications1.2 Connection Overview1.3 Chassis Overview
Notes: • Only information that is related to the IBO Zapper module
is published in this manual. For the other information, see the relevant chassis manual (order code on front page).
• Some models in this chassis range have a different mechanical construction. The information given here is therefore model specific.
• Figures below can deviate slightly from the actual situation, due to the different set executions.
• Specifications are indicative (subject to change).
1.1 Technical Specifications
1.1.1 Vision
Display type : LCD, IPS
Screen size :- 26PF5521D/10/12 : 26” (66 cm), 16:9- 32PF5521D/10/12 : 32” (82 cm), 16:9- 37PF5521D/10 : 37” (94 cm), 16:9- 26PF7521D/10 : 26” (66 cm), 16:9- 32PF7521D/10 : 32” (82 cm), 16:9- 37PF7521D/10 : 37” (94 cm), 16:9- 42PF7421D/10 : 42” (107 cm), 16:9
Resolution (HxV pixels) : 1366 x 768
Contrast ratio :- 26PF5521D/10/12 : 600:1- 32PF5521D/10/12 : 800:1- 37PF5521D/10 : 800:1- 26PF7521D/10 : 600:1- 32PF7521D/10 : 800:1- 37PF7521D/10 : 800:1- 42PF7421D/10 : 550:1
Light output (cd/m2) : 500
Response time (ms) : 8
Viewing angle (HxV degrees) :- 26PF5521D/10/12 : 178x178- 32PF5521D/10/12 : 178x178- 37PF5521D/10 : 176x176- 26PF7521D/10 : 178x178- 32PF7521D/10 : 178x178- 37PF7521D/10 : 176x176- 42PF7421D/10 : 176x176
Tuning system : PLL
TV Colour systems : PAL B/G, D/K, I: SECAM B/G, D/K, L/L’
Video playback : NTSC M/N 3.58, 4.43: PAL B/G: SECAM L/L’
Supported computer formats : VGA (640x480): MAC (640x480): SVGA (800x600): XVGA (1024x768)
: VGA (720x400)
Supported video formats : 640x480p - 2fH: 720x576p - 2fH: 1280x720p - 3fH: 1920x1080i - 2fH
Presets/channels : 100 presets
Tuner bands : VHF: UHF: S-band: Hyper-band
1.1.2 Sound
Sound systems : NICAM B/G, D/K, I, L: AV Stereo
Maximum power (WRMS) :- 26PF5521D/10/12 : 2 x 5- 32PF5521D/10/12 : 2 x 15- 37PF5521D/10 : 2 x 15- 26PF7521D/10 : 2 x 5- 32PF7521D/10 : 2 x 15- 37PF7521D/10 : 2 x 15- 42PF7421D/10 : 2 x 15
1.1.3 Miscellaneous
Power supply:Mains voltage (VAC) :- 26PF5521D/10/12 : 110 - 240- 32PF5521D/10/12 : 110 - 240- 37PF5521D/10 : 220 - 240- 26PF7521D/10 : 110 - 240- 32PF7521D/10 : 110 - 240- 37PF7521D/10 : 220 - 240- 42PF7421D/10 : 220 - 240
Mains frequency (Hz) : 50 / 60
Ambient conditions:- Temperature range (°C) : +5 to +40- Maximum humidity : 90% R.H.
Power consumption:Normal operation (W) :- 26PF5521D/10/12 : 100- 32PF5521D/10/12 : 120- 37PF5521D/10 : 180- 26PF7521D/10 : 100- 32PF7521D/10 : 120- 37PF7521D/10 : 180Stand-by (W) :- 26PF5521D/10/12 : < 1- 32PF5521D/10/12 : < 1- 37PF5521D/10 : < 2- 26PF7521D/10 : < 1- 32PF7521D/10 : < 1- 37PF7521D/10 : < 2- 42PF7421D/10 : < 2
Dimensions (WxHxD cm):- 26PF5521D/10/12 : 80.45 x 43.8 x 11.4- 32PF5521D/10/12 : 92.4 x 50.7 x 11.9- 37PF5521D/10 : 110.0 x 60.9 x 10.25- 26PF7521D/10 : 69.75 x 49.48 x 9.97- 32PF7521D/10 : 93.5 x 51.65 x 12.0
Technical Specifications, Connections, and Chassis Overview EN 3LC4.31E AB 1.
- 37PF7521D/10 : 111.4 x 61.8 x 10.3- 42PF7421D/10 : 124.9 x 69.7 x 12.8
Weight (kg):- 26PF5521D/10/12 : 13.3- 32PF5521D/10/12 : 18.9- 37PF5521D/10 : 25.1- 26PF7521D/10 : 13.0- 32PF7521D/10 : 19.2- 37PF7521D/10 : 25.9- 42PF7421D/10 : 32
1.2 Connection Overview
Note: The following connector colour abbreviations are used (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, and Ye= Yellow.
1.2.1 Rear Connections
Figure 1-1 Rear I/O (26” and 32”)
Figure 1-2 Rear I/O (37” and 42”)
CI Common Interface: PCMCIA68p- See diagram K7
S/PDIF Cinch: OutBk - Coaxial 0.2 - 0.6 VPP / 75 ohm
Service connector (UART)1 - UART_TX Transmit
2 - Ground Gnd
3 - UART_RX Receive
G_16220_020.eps090206
G_16220_021.eps090206
Safety Instructions, Warnings, and NotesEN 4 LC4.31E AB2.
1.3 Chassis Overview
Figure 1-3 Chassis overview
2. Safety Instructions, Warnings, and Notes
See the relevant chassis manual (order code on front page).
3. Directions for Use
You can download this information from the following websites:http://www.philips.com/supporthttp://www.p4c.philips.com
G_16220_025.eps090206
SMALL SIGNAL BOARD B
CLASS D AUDIOAMPLIFIER PANEL C
KEYBOARD CONTROLPANEL E
IBO ZAPPER 2 PANEL K
LCD PANEL
POWER SUPPLYPANEL
LED & IR PANEL J
SIDE I/O PANEL D
POWER SUPPLYUNIT A
A
OTC TXT PANEL T
OTC TXT PANEL TIBO ZAPPER 2 PANEL K
CONTROL BOARDE
LCD PANEL
Chassis Overview 37” + 42” Models
SMALL SIGNALBOARDB
STANDBY & AUDIOPANELSA
LED & IR PANEL J
SIDE I/O PANEL D
Chassis Overview 26” & 32” Models
Mechanical Instructions EN 5LC4.31E AB 4.
4. Mechanical Instructions
Index of this chapter:4.1 Assy/Panel Removal4.2 Set Re-assembly
Notes: • Figures below can deviate slightly from the actual situation,
due to the different set executions.• Follow the disassembling instructions in described order.• Only information that is related to the IBO Zapper module
is published in this manual. For the other information, see the relevant chassis manual (order code on front page).
4.1 Assy/Panel Removal
4.1.1 IBO Zapper Module (26” and 32”)
Figure 4-1 IBO zapper module (26” and 32”)
1. Disconnect the cable [1] from connector 1301 on the IBO zapper module.
2. Disconnect the flatcable [2] from connector 1500 on the IBO zapper module and remove the tape which secures it to the IBO zapper module.
3. Disconnect the antenna cable [3] from the tuner on the IBO zapper module.
4. Remove the torx screws [4] and remove the IBO zapper module from the TV set.
4.1.2 IBO Zapper Module Front Panel (26” and 32”)
Figure 4-2 IBO zapper module front panel
1. Remove the two screws [1].2. Remove the front panel by shifting it sideways to unlock it.
4.1.3 Unlocking the metal cover of the IBO zapper module (26” and 32”)
Figure 4-3 Unlocking the metal cover of the IBO zapper module (26” and 32”)
Figure 4-4 Opening the IBO zapper module (26” and 32”)
1. Unlock the metal cover with a screwdriver (see Figure “Unlocking the metal cover of the IBO zapper module (26” and 32”)”).
2. Unhook the metal cover from its hinges (see Figure “Opening the IBO zapper module (26” and 32”)”) and remove the cover (this is possible only if the front panel has been removed first).
F_15270_087.eps310505
1
4
2
3
F_15270_088.eps300505
1
F_15270_089.eps300505
F_15270_090.eps300505
Mechanical InstructionsEN 6 LC4.31E AB4.
4.1.4 Cover Shield for IBO-zapper & SSB (37” and 42”)
Figure 4-5 Cover shield (37” and 42”)
Figure 4-6 Connector screws (37” and 42”)
1. Remove the rear cover from the set.2. Very cautiously disconnect the LVDS cable [1] from the
SSB panel (see Figure “Cover shield (37” and 42”)”). Notice that this connector is very fragile.
3. Unplug the black cable [2] going from the IBO zapper/SSB to the Audio/STBY board.
4. Remove all other cables [3] from the IBO zapper/SSB.5. Remove the fixation screws [4] that connect the top
shielding with the bottom shielding.6. Remove the fixation screws [5] that connect the connector
plate to the frame.7. Remove the fixation screws [6] that connect the shield to
the rear connector plate, see Figure “Connector screws (37” and 42”)”.
8. Remove the fixation screws [7] from the connectors.9. Remove the connector plate from the shielding.10. Remove the upper part of the shield (with the IBO zapper
attached to it) from the lower part of the shield (on which the SSB is located), by unhooking it from its brackets.
11. Disconnect the antenna connector [8] from the tuner, see Figure “IBO zapper & SSB (37” and 42”)”.
12. Carefully unlock the locking mechanism of the FFC connector [9] and remove the flatfoil cable (see Figure “How to unlock an FFC connector”).
13. Finally, loosen four screws [10], and remove the IBO zapper from the top shielding.
Figure 4-7 IBO-zapper & SSB (37” and 42”)
Figure 4-8 How to unlock an FFC connector
4.2 Set Re-assembly
To re-assemble the whole set, execute all processes in reverse order.
Notes:• While re-assembling, make sure that all cables are placed
and connected in their original positions. Be careful with the fragile LVDS cable.
G_16220_022.eps090206
1 3
5
4
3
32
G_16220_023.eps090206
7 7
66
G_16220_024.eps090206
108
9
F_16040_038.eps021105
Service Modes, Error Codes, and Fault Finding EN 7LC4.31E AB 5.
5. Service Modes, Error Codes, and Fault Finding
Index of this chapter:5.1 Service Modes5.2 Error Codes
Notes: • Only information that is related to the IBO Zapper module
is published in this manual. For the other information, see the relevant chassis manual (order code on front page).
5.1 Service Modes
5.1.1 Digital Customer Service Mode (DCSM)
PurposeThe Digital Customer Service Mode shows error codes and information on the IBO Zapper module operation settings. The call centre can instruct the customer to activate DCSM by telephone and read off the information displayed. This helps the call centre to diagnose problems and failures in the IBO Zapper module before making a service call.
The DCSM is a read-only mode; therefore, modifications are not possible in this mode.
How to ActivateTo activate the DCSM, put the television in its digital mode (via the A/D button on the remote control).1. Press the “Digital” Menu button on the remote control to
activate the digital user menu (“Setup”).2. Activate the “Information” sub menu (via the “down” and
“right” cursor buttons).3. In the “Information” sub menu, press the following buttons
on the remote control to activate the DCSM:“GREEN RED YELLOW 9 7 5 9”. Then, the “Service menu” will appear (see figures below).
Menu explanation
Figure 5-1 DCSM menu - 1
Figure 5-2 DCSM menu - 2
Figure 5-3 DCSM menu - 3
1. Hardware version: This indicates the version of the IBO Zapper module hardware.
2. Application SW: The application software version.3. NOR Version: The NOR Flash image software version4. Digital Frequency: The digital frequency that the set is
tuned to.5. Bit Error Rate: The error rate measured before the error
correction algorithm circuitry. (this value gives an impression of the received signal)
6. Tuner AGC: Tuner AGC value. 7. COFDM Lock: Indication if COFDM decoder is locked.8. AFD Status: Status of the Active Picture Format
Descriptor. 9. Terrestrial Delivery System Parameters:
– Bandwidth: Bandwidth of the received signal.– Constellation Pattern: Displays the signal
constellation.– Alpha Value: Displays the Alpha Value.– FEC Scheme: Displays the Forward Error Correcting
Scheme– Guard Interval: Displays the value for the Guard
Interval.– Transmission Mode: Displays the Transmission
Mode.10. Audio Comp Type: Type of detected audio stream.11. MHEG Present: Indicates if MHEG is present or not.12. CIM Card Present: Indicates if CIM card is present or not.
How to exitPress the BLUE button on the Remote Control to exit DCSM.
E_14970_040.eps090904
E_14970_041.eps100904
E_14970_042.eps090904
Service Modes, Error Codes, and Fault FindingEN 8 LC4.31E AB5.
5.2 Error Codes
The error code buffer contains all errors detected since the last time the buffer was erased. The buffer is written from left to right. When an error occurs that is not yet in the error code buffer, it is displayed at the left side and all other errors shift one position to the right.
5.2.1 How to Read the Error Buffer
You can read the error buffer in 3 ways:• On screen via the SAM (if you have a picture).
Examples:– ERROR: 0 0 0 0 0 : No errors detected– ERROR: 6 0 0 0 0 : Error code 6 is the last and only
detected error– ERROR: 9 6 0 0 0 : Error code 6 was detected first and
error code 9 is the last detected (newest) error• Via the blinking LED procedure (when you have no
picture). See “The Blinking LED Procedure”.• Via ComPair.
5.2.2 How to Clear the Error Buffer
The error code buffer is cleared in the following cases:• By using the CLEAR command in the SAM menu:
– To enter SAM, press the following key sequence on the remote control transmitter: “062596” directly followed by the OSD/i+ button (do not allow the display to time out between entries while keying the sequence).
– Make sure the menu item CLEAR is selected. Use the MENU UP/DOWN buttons, if necessary.
– Press the MENU RIGHT button to clear the error buffer. The text on the right side of the “CLEAR” line will change from “CLEAR?” to “CLEARED”
• If the contents of the error buffer have not changed for 50 hours, the error buffer resets automatically.
Note: If you exit SAM by disconnecting the mains from the television set, the error buffer is not reset.
5.2.3 Error Codes
In case of non-intermittent faults, write down the errors present in the error buffer and clear the error buffer before you begin the repair. This ensures that old error codes are no longer present.If possible, check the entire contents of the error buffer. In some situations, an error code is only the result of another error and not the actual cause of the problem (for example, a fault in the protection detection circuitry can also lead to a protection).
Table 5-1 Error code overview
Error Error Description Check Item Diagram
0 No Error
1 Mis-match of TV (Hercules) SW and Scaler SW
Software versions
N.A.
2 +12V from PSU error PSU A
3 Plasma I2C error (only for plasma sets) N.A. N.A.
4 I2C error while communicating with the Genesis Scaler
7801 B7 + B8
5 +5V protection 7752 B6
6 General I2C error; communication between ADC, analogue tuner, and/or Columbus I2C failed
1102, 7L01, 7M00
B1 + B18 + B19
7 I2C error while communicating with ADC
7L01 B18
8 I2C error while communicating with the Scaler EEPROM
7C01 B11
9 I2C error while communicating with the Hercules EEPROM (NVM for TV). Remark: when the Hercules EEPROM is defective, the Hercules should operate with its default values.
7207 B2
10 I2C error while communicating with the PLL tuner
1102 B1
11 I2C error while communicating with the 3D combfilter IC-7M00 (Columbus)
7M00 B19
12 I2C error while communicating with iBoard uP (only iTV sets)
N.A. N.A.
13 I2C error while communicating with the HDMI decoder IC-7D03 (only for NAFTA and AP)
N.A. N.A.
14 Read-write error with the Scaler SDRAM
7B01 B10
15 I2C error while communicating with the OTC
7001 T
16 I2C error while communicating with EPLD or Pacific III
7N00 B20 + B21
17 I2C error while communicating with the Digital Module (only for digital sets)
7100 K1
Block Diagrams, Test Point Overviews, and Waveforms 9LC4.31E AB 6.
6. Block Diagrams, Test Point Overviews, and Waveforms
Wiring Diagram 26” & 32”
LEFTSPEAKER
RIGHTSPEAKER
12P31P
G_16220_001.eps070206
30P
12P
X200
12P
X530
1P06 1J02
POWERIN
X002
B SSB
D SIDE AV
LVDS CONNECTIONTO SCREEN
INVERTER
6P
1870
1304
(1M
06)
POWERSUPPLY
HP
1303
1302
1301
10011003
9P1JO4(1M52)
3P1J03
1002
30P
3P 16846P
1K00
(1M
21)
12P
1K01
(1M
06)
3P1K02
32P1J03
1500
1301
X220
14P
14P
X520
INVERTER
12P
INVERTER
2P3
3P
9P
3P 4P
32P
3P
12P
AC POWERINLET
L
R
Y
SVHS
CCLASS DAUDIOAMPLIFIER
EK
EY
BO
AR
D C
ON
TR
OL
J IR/LED/LIGHTSENSOR
8520
8J02
8P06
8002
8684
8600
8K01
8870
8J03
8J04
89038903
8500
8301
K IBO ZAPPER
TUNER
TUNER(IBO ZAPPER2)
WIRING 26”- 32”
8520
10LC4.31E AB 6.Block Diagrams, Test Point Overviews, and Waveforms
Wiring Diagram 37”
INVERTER
03456PJ LED PANEL
LCD PANEL
RIGHTSPEAKER
LEFTSPEAKER
G_16220_002.eps070206
WIRING 37”
INVERTER
14P
12P
13044P
1305
3P13
062P
3
A LCD SUPPLY
1M027P
13082P3
13093P
D SIDE AV
1M36
11P
TUNER
B SSB1J049P
1N1730P
1J033P
1K02
3P1K
0411
P1K
006P
1J0111P
1442
14P
1J0010P
1N20
3P
SA STANDBY
1316
12P
1739
9P
1317
12P 13
09
3P13
04
4P
1306
2P3
1307
4P
1305
3P
1M03
10P1M
46
11P
1736
3P17
353P
1M02
7P
1319
14P
LVDS
TO DISPLAY
8002
AC INLET
8187
(818
8UK
)
1M013P
EK
EY
BO
AR
D C
ON
TR
OL
8902 8903
8305
8306
8520
83048309
8302
8J04
8337
8P068322
8870
8K01
8101
8521
T OTC-FLASH
1000
14P
8000
1G0332P
TUNER
1301 3P
1500
32P
K IBO ZAPPER
14023P
1M10
4P
8500
8600
8301
Block Diagrams, Test Point Overviews, and Waveforms 11LC4.31E AB 6.
Wiring Diagram 42”
INVERTER
03456PJ LED PANEL
LCD PANEL
RIGHTSPEAKER
LEFTSPEAKER
G_16220_003.eps070206
WIRING 42”
INVERTER
14P
12P
1309
3P
1B06
3P13
062P
3
A LCD SUPPLY
1M027P
13082P3
1304
4P
D SIDE AV
1M36
11P
TUNER
B SSB1J049P
1N1730P
1J033P
1K02
3P1K
0411
P1K
006P
1J0111P
1442
14P
1J0010P
1N20
3P
SA STANDBY
1316
12P
1739
9P
1317
12P 13
09
3P13
04
4P
1306
2P3
1307
4P
1305
3P
1M03
10P1M
46
11P
1736
3P17
353P
1M02
7P
1319
14P
LVDS
TO DISPLAY
8002
AC INLET
8187
(818
8UK
)
1M013P
EK
EY
BO
AR
D C
ON
TR
OL
8902 8903
8305
8306
8520
83048309
8302
8J04
8337
8P068322
8870
8K01
8101
8521
T OTC-FLASH
1000
14P
8000
1G0332P
TUNER
1301 3P
1500
32P
K IBO ZAPPER
14023P
1M10
4P
8500
8600
8301
1305
3P
1C05
3P
1307
4P
1320
3P13
034P
1320
3P
1303
4P
1420
83208303
8307
12LC4.31E AB 6.Block Diagrams, Test Point Overviews, and Waveforms
Block Diagram Supply 37”
CONNECTIONSSA1
STANDBYSA2
MAINS FILTER + STANDBYA1 SUPPLYA2
6307GBJ6J
- +
6306DF06M
- +
7001MC34067P 15
70117012
7007HIGHSIDE
DRIVE
70047009
5001
BIAS SUPPLY
SOFTSTART
+CURRENT
PROTECTION
CONTROL
VCCOSCC
ERROR
SOSTOB
OA
FI
2
4
11
7
11
14
12
10
6
7
5011
7008LOWSIDE
DRIVE
10
9
2003
60246025
3007
7010TS2431
3030
1314
T5AH
1308 53055306
MAINSFILTER
2
1
OVERVOLTAGE
PROTECTION
400V_HOT
25V_HOT
HOT COLD
HOT
COLD
SUPPLY 37"
399V_HOT
5002
1007
T5A
VSND_POS
VSND_NEG
GND_SND
+24Vb
+24Va
+12V
400V_HOT
2303
2020
2022
2060
PRINTEDCOMPONENT
HOT COLD
VREF5
N.C.
50085007
25V_HOT
399V_HOT
6315
6316
6318
6317
RE
S
6314
630423193318 3000
2029
2045
6021
6041
5025
5026
+12V_A
+12V_+24V
HOT
COLD
CONTROL
3
STANDBY
710071017105
VTUN
+11V
+8V6
+5V2
+5V_SW
5500
+12V
6
7
10
STANDBY
750775067512
STANDBY
OVERVOLTAGEPROTECTION
8
B01BTO 1M46
SSB
5
2
1
+5V2
STANDBY: LOW = ON HIGH = STBY
CONTROL7505/7509/7560
Prot-OVV
+12
V_A
PROT-OVV
G_16210_060.eps010206
TODISPLAY
13051 1
1305
2 2
3 3
13061 1
1306
2 2
1 1307
2
3
4
13044 4
1304
3 3
2 2
1 1
6504
6140
35095110
5507
5103
6107
6122
3158
PROT_AUDIOSUPPLY
2512
55062513
3128 31133124
2141
5504 5505
5104
5105
3108
3127
3104
3150
3101
315561516150 3156
6153 31
57
6156
1
2
3
4
5
1316
1
2
1M10
1M03
7
1M46
4
7
3100
11
2
1
2
3
4
5
1317
1M02
7
6
4
5
3
2
1
TO 1M02
AUDIO
TODISPLAY
SA1SA2
2009
6029
2021
6030
5020
5018
5019
2042
2049
6031
6040
5021
5022
DC_PROT7003
3031
3052
3057
VS VoltageAdj.30
26
3025
5017
5012
5009
2059
5010
DC_PROT
3V MAX1V MAX STBY
7150TCET1102
2
1 4
3
7501TCET1102
2
14
3
7002TCET1102
2
14
3
7307TCET1102
2
1 4
3
B16
B01BTO 1M03
SSB
B16
SA3
HOT COLD
6019STPS20L40CFP
6019STPS20L40CFP
7005STP15NK50
7006STP15NK50
7102STP15NK50
7531
7131
7511
2 3
1 4
1350
9311
RES
RES
1
4
1315
T1A
9
SA2
1
2
3
4
5
1319
TODISPLAY
B01BTO 1301
IBO ZAPPER(ONLY DVB SETS)
K3
Block Diagrams, Test Point Overviews, and Waveforms 13LC4.31E AB 6.
Block Diagram Supply 42”
G_16220_004.eps070206
SUPPLY PART AA2
STANDBYSA2
SUPPLY PART BA4
CONNECTIONSSA1
MAINS FILTER + STANDBY PART B
A3
MAINS FILTER + STANDBY PART AA1
SUPPLY 42"
6807GBJ6J
- +
7001MC34067P 15
70177018
7007
70047009
5001
BIAS SUPPLY
SOFTSTART
+CURRENT
PROTECTION
CONTROL
VCCOSCC
ERROR
SOST
OB
OA
FI
2
4
11
7
11
14
12
10
6
7
5
3
7
8
9
10
11
3
1
2
12
13
5002
7008
10
9
3007
7010TL431ACD
VS VoltageAdj.
+12V_A
+12V_+24V
540054015403
2 3MAINSFILTER
1 4
6506DF06M
- +
1450
OVERVOLTAGE
PROTECTION
400V_HOT_A
25V_HOT_A
14
15
16
6021STTH2003CFP
6H07GBJ6J
- +
7U01MC34067P 15
7U177U18
7U07HIGHSIDE
DRIVE
7U047U09
5U01
BIAS SUPPLY
SOFTSTART
+CURRENT
PROTECTION
CONTROL
VCCOSCC
ERROR
SOST
OB
OA
FI
2
4
11
7
11
14
12
10
6
7
5
3
7
8
9
10
11
12
13
5U02
7U08
LOWSIDE
DRIVE
10
97U10TL431ACD
VS VoltageAdj.
+24V
HOT COLD
5D005D015D03
2 3MAINSFILTER
1 41D50
OVERVOLTAGE
PROTECTION
400V_HOT_B
25V_HOT_B
14
15
16
400V
_HO
T_B
HOT COLD
HOT COLD
HOT
COLD
HOT
COLD
HOT COLD
VSND_POS
VSND_NEG
MAINS INPUT
HOT
COLD
CONTROL
3710071017105
VTUN
+11V
+8V6
+5V2
+5V_SW
+12V
6
7
10
STANDBY
750775067512
STANDBY
OVERVOLTAGEPROTECTION
8
5
2
1
+5V2
STANDBY: LOW = ON HIGH = STBY
3V MAX1V MAX STBY
2020
2022
CONTROL7505/7509/7560/
Prot-OVV
+12
V_A
DC_PROTDC_PROT
DC_PROT
DC_PROT
PROT-OVV
VREF5
TODISPLAY
TODISPLAY
+24V_2
VREF55B92
2
1308
1 1400
3A15
1401
T1A2503
6156
3810
2815China
2816
6157
3406
2H15China
2H16
13051 1
1305
2 2
3 3
13061 1
1306
2 2
13071 1
1307
2 2
3 3
4 4
1C05 1
11B
06
22
33
3000 6080 6078
2003
3022
3052
3026
3030
13044 4
1304
3 3
2 2
1 1
3057
+12V
+24Va
7030
6014
3025
6504
6140
35095110
5507
5103
6107
6122
3158
PROT_AUDIOSUPPLY
2512
55062513
3128 31133124
2141
5504 5505
5104
5105
3108
3127
3150
3101
315561516150 3156
6153 31
57
6156
3U07
3U57
6U786U79
2003
2B91
2B93
6B91
6B93
5B93
5B91
13031 1
1303
2 2
3 3
4 4
3U30
3U26
3U24
3U22
2U22
13161
2
3
4
5
1M10
1
2
1M46
9
1
7
13171
2
3
4
5
1M02
6
5
3
2
1
4
3U28
3U00 6U77
5U40
5U105U17
5U085U07
7DC_PROT
3U25
6077 50105017
3028
5007 5008
5U09
5009
3U52
3U39
MA
INS
_L
MA
INS
_N
3H10
3100
11
2
1M03
7
4
SA3
3
4
1400
3A15
6019STPS20L40CFP5027
5028
1
3
2
6021STPS20L40CFP5025
5026
7002TCET1102
2
14
3
7005STP15NK50
7006STP15NK50
HIGHSIDE
DRIVE5040
LOWSIDE
DRIVE
1
3
2
6021STPS20L40CFP5U25
5U26
1U07
T5A
7U05STP15NK50
7U06STP15NK50
7U02TCET1102
2
14
3
7501TCET1102
2
14
3
7150TCET1102
2
1 4
3
7102
3104
5500
7531
7131
7511
B01BTO 1M46
SSB
KTO 1301
IBO ZAPPER(ONLY DVB SETS)
TO 1M02
AUDIO
B16
B01BTO 1M03
SSB
B16
SA3
RES
RES
STANDBY
RES
14LC4.31E AB 6.Block Diagrams, Test Point Overviews, and Waveforms
Block Diagram Video
B1 TUNER & VIF
B15A SCART ANALOG IO
B2 HERCULES
B14 DIGITAL IO
B13 MUX-SYNC INTERFACE B7 SCALER
B11 FLASH/CONTROL
B10 SDRAM
B3 SYNC INTERFACE
VIDEO
B18 ADC
B17 SIDECONNECTIONS
D SIDE AV
B19 COLUMBUS (Dig. PAL/NTC Comb)
B20 PACIFIC3
HERCULES
B15A SCART ANALOG IOT OTC-FLASH (FOR 1000pg TXT) B3 SYNC INTERFACE(TO OTC-FLASH)
B15B DMMI
K5
B12 HDMI
DD(0-15)
1152UV1318S RF
IN
MAINTUNER
215611
1154 VIF1
VIF25
41
4 5 1 3154 RF_AGC
SC
L
SD
A
DC
AC AGCDetect
21
1
1G02
20
15
SC2_Y_IN
SC2_Y_IN_1
SC2_C_IN
1G01
20
7
8
16
15
11
SC1_CVBS_IN
21
1
24
25
31
51
52
55
SC2_CVBS_MON_OUT
19 SC1_CVBS_RF_OUT
43
EF7G03
77 78 79 80
EF7208
R_OTC_SDTV
EF7209
G_OTC_SDTV
EF7210
B_OTC_SDTV
85
86
87
74 75 76 70 71 72
22
67
7E01
SC1_R_CVI_Pr_IN
SC1_G_CVI_Y_IN
SC1_B_CVI_Pb_IN
27
3
7
25
1
5
R_PR+
G_Y+
B_PB+
17
14
11
Vsync_SDTV
Hsync_SDTV
AVSYNC
AHSYNC
7604
5
1
8
4 L4
L3
ANALOGINPUTPORT
DVI/HDMIINPUTPORT
7B01K4D263238F
SDRAM1Mx32x4
FSDATA
FSADDR
7801GM1501
GRAPHICZOOM
DISPLAYTIMINGGEN.
VIDEOZOOM
OS
D C
ON
TR
OLL
ER
OU
T B
LEN
DE
R
BR
IGH
TN
ES
S/C
ON
TR
AS
T/H
UE
/SAT
EXTERNALROM
INTERFACE
7C03M29W400DT55N6E
FLASHROM
512Kx8
OCMDATA
OCMADDR
1N171
11
10
12
1413
15
19
18
20
27
26
28
22
21
23
LVDS_VCC
TXB0-
TXB3+
TXB0+
TXB1-
TXB1+
TXBC+
TXBC-
TXB2-
TXB2+
TXB3-
RGB/Pr Pb InsertYUV Interface
RGB MatrixBlue & Black
StrechGamma Corr.
PAL/NTSC/SECAM
Decoder &Baseband
Delay
Sync SepH-OSCH-ShiftH-Drive
Vertical &East-WestGeometry
CV
BS
/Y
VDRB
H/V HOUT
RO
GO
BO
INS
SW
3
Chroma
Yint
R/P
r-3
G/Y
3
B/P
b-3
YO
UT
VO
UT
UO
UT
VIN
UIN
YIN
B_O
SD
G_O
SD
R_O
SD
Fast
Bla
nkin
g
PeakingSCAVEMU/V Delay
Skin ToneU/V Tint
Saturation
YUV
YUV in/out
SAT
SCAVEMon text
Dig. 2H/4HCombfilter
Y Delay Adj.
c
cvbs/y
SoundTraps
VideoSwitch
+Control
Uint
Vint
CVBS1
BINA|Pb
GINA|YINA
RINA|Pr
FRAMESTORE
CONTROL
MICROCONTROLLER
UARTINTERFACE
INTERNALRAM
QSS MixerAM Demod. AM
QSS/FM1156 4
51
SIF1
SIF2
29
30
FE00
FE01
FE02
IF-TER
AE16
AF11
AF16
AF12
AE15
AF15
AE12
AF13
AE14
AF14
D2
C2
B2
7217TDA15021H
RO
GO
BO
Vsync_SDTV
Hsync_SDTV
INTF_Y_OUT
INTF_U_OUT
INTF_V_OUT
SC
1_C
V1_
DM
MI_
B_P
b_IN
SC
1_F
BL_
IN_1
SC
1_C
V1_
DM
MI_
R_P
r_IN
SC
1_C
V1_
DM
MI_
G_Y
_IN
19
STATUS_2_IN|OUT
8 STATUS_1
6 7
+5SW_a+VTUN
7436-2
43
7436-1
21
N.C.
EF7L61/7L62
EF7L51/7L52
EF7L71
7L01P3563M-LF
A/DCONV.
COL_Di(1-9)
COL_YA(1-9)
CO
L_A
CO
L_D
Q
7M00T6TU5XBG
COLUMBUSDIGITAL COMB
FILTER
DRAM512Kx16x2
7M01MSM56V16
+2V5_DDR
95
G_16220_005.eps070206
9
6
11
2
3
37
38SCL
SDA
COL_Do(1-8)
COL_YB(1-8)
7E00
1
13
3
5
2
12
15
14
4
C3SOG
2
1304(1M36)
1K01(1K04)
2
4 4
1
5
SVHS
24
3
1301(1001)
1302(1002)
EF7206
64
58
7G112
9
1215
14FRONT_Y_CVBS_IN 1
FRONT_C_IN 13
59SC2_AV3_C_IN
SC1_FBL_IN
CVI_Pr_IN
CVI_Y_IN
CVI_Pb_IN
B2
B2,B13
B2,B13
B2,B13
B15
b
B15
b
B15
b
B15
b
SC1_CV1_DMMI_R_Pr_IN
SC1_CV1_DMMI_G_Y_IN
SC1_CV1_DMMI_B_Pb_IN
B15b
B15b
B15b SC1_R_CVI_Pr_IN
SC1_G_CVI_Y_IN
SC1_B_CVI_Pb_IN
B13
B13
B13
B13
B13
B13
B3
B3
7219
48
13
1214
B2
B2
FRONT_YCVBS_IN
FRONT_C_IN
CVBS_COMB B9 SCALER
LVDSPACIFIC3
7N00T6TF4AFG
TXB0-
TXB3+
TXB0+
TXB1-
TXB1+
TXBC+TXBC-
TXB2-
TXB2+
TXB3-
OR
4N02
4N09
4N01
4N10
4N044N03
4N07
4N08
4N06
4N05
TXO0+
TXO0-
TXO1+
TXO1-
TXO2+
TXO2-
TXO3+
TXO3-
TXOC+
TXOC-
OR
LVDSA+
LVDSA-
LVDSB+
LVDSB-
LVDSC+
LVDSC-
LVDSD+
LVDSD-
LVDSCLK+
LVDSCLK-
1N161
11
12
13
1415
16
17
18
19
20
24
25
26
21
22
LVDS_VCC
LVDSA+
LVDSA-
LVDSB+
LVDSB-
LVDSC+
LVDSC-
LVDSD+
LVDSD-
LVDSCLK+
LVDSCLK-
TO D
ISP
LAY
(26
” & 3
2”)
TO D
ISP
LAY
(LC
D 3
7” &
42”
, PD
P 4
2” &
50”
)
SC2_AV3_Y_IN
9
9 RGB|CVI_HDA_SEL
SCALER
B7
9
AV2_DMMI_SW
B7 SC2_OUT_SW
I_PC_HD_SEL
R-PR-ADC
G-Y-ADC
B-PB-ADC
EXT 2SCART 2
EXT 1SCART 1
VIDEOIN
S-VHS
B2
VSYNC
HOUT
RGB-R|YC-C_IN
For sets withoutOTC-Flash (26”, 32”)
1F03
1210
7
9
64
3
RX0-B
RX0+B
RXC+B
RXC-B
RX1-BRX1+B
RX2+B
RX2-B
HDMI-2
1
191
182
7D03SII9993CTG100
HDMIPANELLINKRECEIVER
HDMI_Y(0-7)
HDMI_CbCr(1-7)C10
C9
C13C12
C16
C15
G14F14
H_HDMI
V_HDMI
A2
A1 B14
C141F02
1210
7
9
64
3
RX0-A
RX0+A
RXC+A
RXC-A
RX1-ARX1+A
RX2+A
RX2-A
HDMI-1
1
191
182
A9
A10
A12A13
A15
A16
F16G16
1G01
HDMI_VCLKD1 D16
1N12
1N13
1N14
1N15
1N11
(RES For PIXEL+)
7006M29W160ET70N6E
FLASHROM
512Kx8
7007MSM51V18165F
FLASHROM
512Kx8 AA(1-20)
7001SAA5801H/015
TVCONTROL
1000 1442
2 2
4 4
5 5
9 9
7 7
11 11
12 12
13 13
14 14
83 H
84 V
77 R_OTC
78 G_OTC
79 B_OTC
78 SCL
79 SDA
5 CVBS_COMB
96 INT_OTC
74 RESET_FLASH
Hsync_SDTV
Vsync_SDTV
R_OTC_SDTV
G_OTC_SDTV
B_OTC_SDTV
SCL
SDA
CVBS_COMB
INT_OTC
RESET_FLASH
1 1
B2
B2
B7
B13
B13
B13
B13
B13
CV
BS
_CO
MB
B3
(OT
C)
7L72
VIN VOUTCOM
FRONT_YCVBS_IN
FRONT_C_IN
(Only For 37” - 50” Sets)( ) 37” - 42” only
TXO0+
TXO0-
TXO1+
TXO1-
TXO2+
TXO2-
TXO3+
TXO3-
TXOC+
TXOC-
28
29
31
32
34
35
40
41
38
37
102
103
100
101
98
99
92
93
95
96
SC1_FBL_IN
CVI_Pr_IN
CVI_Y_IN
7G09
4
7
14
17CVI_Pb_IN
2
9
12
19
SC1_FBL_IN_13
8
13
18
DMMI_RGB_SW
1G03
12
10
8
14
FBL_HSYNC_PIN16_IN
DMMI_R_Pr_IN
DMMI_G_Y_IN
DMMI_B_Pb_IN
DMMI_R_Pr_IN
DMMI_G_Y_IN
DMMI_B_Pb_IN
DMMI_CVBS_IN|Y_IN
For DVBSets Only
FROM 1500
See alsoBlock giagramIBO-ZAPPER
B2
7G075
34
SC2_AV3_Y_INEF
7G08
SC2_Y_IN_1
10,11
1,10,11,20
SC1_CV1_DMMI_R_Pr_IN
SC1_CV1_DMMI_G_Y_IN
SC1_CV1_DMMI_B_Pb_IN
EF7G02
4DMMI_CVBS_IN|Y_IN 3
SC2_CVBS_MON_OUT 5
DMMI_CVBS_IN
SC2_Y_IN_1
7G06
12
9
18
10,11
EF7G04
EF7G10
EF7G05
2
RGB-R|YC-C_INRGB-G_IN
RGB-B_IN
FBL_HSYNC_OUT
3
8
13
11 RGB-G_IN
7 RGB-B_IN
16 FBL_HSYNC_OUT
15 FBL_HSYNC_PIN16_IN 19
DMMI_RGB_SWB2
FROM IBO-TUNER
See alsoBlock DiagramIBO-ZAPPER
K6
Block Diagrams, Test Point Overviews, and Waveforms 15LC4.31E AB 6.
Block Diagram Audio & Control
13
B5 AUDIO PROCESSING
B17 SIDECONNECTORS
D SIDE AV
B2 HERCULESB1 TUNER & IF
AUDIO
CONTROL
J IR/LED/LIGHT-SENSOR
B2 HERCULES
C AUDIO AMPLIFIER (CLASS-D)
B16
B14 DIGITAL IOB15A SCART ANALOG-IO
D SIDE AV B17 SIDE CONNECTORS
E KEYBOARD CONTROL B17 SIDE CONNECTORS
B3 SYNC INTERFACE
B6 DC-DC CONVERTER
B14 DIGITAL IO
SA3 AUDIO
B15B DMMI (IBO-ZAPPER2)
B15A SCART ANALOG-IO
B12 HDMI
K5
1001
4
3
2
1
LEFTSPEAKER
RIGHTSPEAKER
60
61 AUDOUTLSR
AUDOUTLSL
1K0110 10
1304(1M06)
12 12
HP_LOUT
HP_ROUT
HEADPHONE
HEAD_PH_L
HEAD_PH_R
7217TDA15021H
1152UV1318S
RF IN
TUNER
215611
4 5
SC
L
SD
A
QSS MixerAM Demod.
AM1156 4
5
1 SIF1
SIF2
AD Conv.Std StereoDecoder
21
11G02-1
21
11G01-1
21
1
SC1_L_RF_OUT
SC1_R_RF_OUT
AV1_Audio_INL
AV1_Audio_INR
34
35
SC2_L_MON_OUT
SC2_R_MON_OUT
AV2_Audio_INL
AV2_Audio_INR
21
1
SCART 1
SCART 2
62
63
36
37
29
30
33
IF-TERIFOUT
F158
AUDIOSELECT
ADC/DAC
AUDIOCONTROLVol/Treb/
BassFeatures
DACs
I2SProcessor
QSS/FM
1310
3324
1311
1312
1313
Channel+Channel-
Volume+
Volume-Power
3 3
5 5
1870(0345) 1K00
2 2
4 4
6 6PC-TV-LED
LED_SEL
RC
+3V3STBY
PC-TV-LED
LED_SEL
RC_OUT
KEYBOARD
97
7217TDA15021H
115
107
120
7430+3v3STBY
+5VSW
3431
6430
114 SEL_IF_SDM
4204
SERVICESDM
116 STATUS_1 B15A119 STATUS_2
MUTE
OUT_MUTE
102 EXT_MUTE B5
POWER_DOWN
SOUND_ENABLE
111 SOUND-ENABLE B5122 SC_STANDBY
B6
B1
HERCULES
6154
7151
3
SEL_IF_SDMB2
MUTEOUT_MUTE
MUTE
4211
4212
1J04
3 3
1002
1 1
POWERCOMPARATOR
7001TDA8931T
OUT
HVPI
16
13IN+4
POWERCOMPARATOR
7000TDA8931T
OUT
HVPI
16
13IN+4
8 8
7
AUDIO-R
SOUND-ENABLE
AUDIO-L
PHASEINVERTER
SOUND-ENABLE
7606
7202
7201
1G01-16
2
1G02-16
2
1G02-2
6 6
8 8
L_FRONT_IN
R_FRONT_IN
FRONT_L_IN
FRONT_R_IN
53
54
1304(1M06)
1K01(1M06)
1 1LIGHT-SENSOR LSIPDP_DVB_SEMISTANDBY
1309
Menu1684
(1M01)
2 2
1K02(1M01)
KEYBOARD
+3V3STBY
P50_LIN2_ITV_IR_SW_RST 123
120224M576
127 AV2_DMMI_SW
7601TS482ID
1
7
2
6
SC1_L
SC1_R
SC2_L
SC2_R
7
7004
11
10
13037
1
211 11 HP_DET_R_DC1HP_DET_R_DC_1HP_DET_R_DC_1
EXT_MUTE
2
1
9
10
760274HC08PW
B16
B2
B2
6
8
SC1_L_RF_OUT
SC1_R_RF_OUT
SC2_L_MON_OUT
SC2_R_MON_OUT
OUT_MUTE
&
&
&
3
5
3432
RES
7756
3759 3750
+3V3STBY+3V3SW
SC_STANDBY
7755
PANEL-PWR-CTL
3758 3755
LVDS_VCC
5756 5757 PAN_VCC+12VSW
B8
B2
EXT 1
EXT 2
AUDIOL/R IN
EXT 2SCART 2
EXT 1SCART 1
3
1
3
1
7758
7754
2
HD_AudioINL
HD_AudioINR
HD_AudioINL
HD_AudioINR
49
50
1302
7F03
1
12
4
11
2
15
3
13
9 Analog_AudioSEL1
1F01
AUDIOL/R IN
DVI_D_AudioINL
DVI_D_AudioINR
DVI_D_AudioINL
DVI_D_AudioINR
56
57
SIDE_AudioINL
SIDE_AudioINRAnalog_AudioINL
Analog_AudioINR
10
Analog_AudioSEL2 B7
7D03TDA9975
7D04UDA1334ATS
DAC
14
16
HDMI_AudioINL
HDMI_AudioINR
1
3
2
A5
A7
B7
HDMI
10-BITVIDEO
CONVERTER
HDMI_A
HDMI_B
1F02
1F03
191
182
191
182
FOR 26” & 32” ONLY
FOR 37”ONLY
7
9
8
3
1
1739
PWM
PWM
OSC
7700TDA7490
5731 17361
2
3
5730 17351
2
3
1M02
7
TO 1002
SUPPLYSA
SOUNDENABLE
SOUND-ENABLE
AUDIO SUPPLYPROT, CIRCUIT
PROT_AUDIOSUPPLY
7701÷7707
POR-CLASSD
PROT1
stby-mute
10
6
18
3
23
AUDIO-L
AUDIO-R
37646703
37616702
-16 V-19V
+16 V+19V
7708÷7711
3717
3718
DCPROT
7 7PROTECT_AUD
AUDIO-R
AUDIO-L
9 9POR_AUDIO
OR
1
5
5702
5701
LEDSELECT
LEDGREEN
LEDRED
LIGHTSENSOR
REMOTECONTROL
5700
LEFTSPEAKER
RIGHTSPEAKER
4205
B15A
B15B
B15AB15B
1G03
6
4 DMMI_AudioINR
DMMI_AudioINLFROM 1500
See alsoBlock giagramIBO-ZAPPER
5
14
DMMI_AudioINL
DMMI_AudioINR
SIDE_AudioINL
SIDE_AudioINR
7G07
2
115
14
10 DMMI_SC2_REC_SEL
12
G_16220_006.eps070206
HER_SC2_AudioOutL
HER_SC2_AudioOutR
DMMI_AudioINR
DMMI_AudioINL
FROM IBO-TUNER
See alsoBlock DiagramIBO-ZAPPER
K6
16LC4.31E AB 6.Block Diagrams, Test Point Overviews, and Waveforms
Block Diagram IBO Zapper
K6 FRONT END
IBO - ZAPPER 2 PANEL (DVB)
K2 FLASH MEMORY
K3 POWER SUPPLY
K5 ANALOG BACK ENDK1 MOJOK7 COMMON INTERFACE
K4 INTERFACE
11
9
1600TD1316L
7600TDA10046HT
TUNERCOFDM
CHANNELDECODER
15
2
31
14
61
62IF1
9RESET_FE-N
IF2
2IF-AGC1
21
4
3
AGC-TUN
COMB-OUT
RF-IN
I2C_TDA_SDA
I2C_TDA_SCL
I2C_LOCAL_SDA
I2C_LOCAL_SCL
dsp_EEPROM_WP
+5VClean
K7
B1
K1
K1
K1
K1
K7
K7
EF7402
55117512 75117507
SPDIFOUT
R1
L1
CVBS_VCR
GREEN/Y
BLUE/U
RED/V
I2C_TV_SDA
I2C_TV_SCL
AUDIODAC
FILTER
OSC27MHz
7502UDA1334ATS7100
PNX8316HS7700STV0700
16
14
TV_IRQ
+12V
+12V
+5VCLEAN
1301
1
2TO X220OR 1M10
PSU
SPDIF
MOJO_I2S_OUT_SD
C_CVBS
G/Y
B/Pb
R/Pr
7704FXO-31FT
MOJO_I2S_OUT_SCK
MOJO_I2S_OUT_WS
3
1
2
MOJO
AV
GPIOUCSG
MIU
SDRAM
I2C
PCMCIACONTROLLER
TSINTERFACE
COFMD
TSIN
TSIN
TSOUT
RXDO
TXDO
TS_DATA (0-7)
TS_CLK
TS_SYNC
TS_VALID
I2C_LOCAL_SDA
user_EEPROM_WP
I2C_LOCAL_SCL
TDA_CLK
TDA_VALID
TDA_SYNC
UNCOR
INTERRUPTMANAGEMENT
ICCINTERFACE
I2C_LOCAL_SCL 31
35
CURRENTSWITCH
7705ST890C
12
I2C_LOCAL_SDA 30
PCMCIA_5V
FAULTVCCEN
3
SYNCDRAM
4x2Mx16
7202K4S281632F
7203M24C64
EEPROM8KX8
NORFLASH
(optional)
7201M58LWO32A
EPROMNOR
FLASH
7200M29W320DT
+5V
5 6
7
MIU BUS
MIU_ADDR (15-24)
MIU_ADDR (0-7)PCMCIA-A (0-7)
CONTROL
CONTROL LINES
A_MD (0-7) + A_MDO (0-7)
LATCH
770174LVC573ADB
68P
PC
MC
IA C
ON
N
MIU_ADDR (8-14)PCMCIA-A (8-14)
CONTROL
LATCH
770274LVC573ADB
CONTROL
BUSTRANSCEIVER
770374LVC245A
1
34
35
68
FROMMAIN TUNER
SSB
38
37
36
35
33
FE_LOCK25
8 10 5 13
AG
C
XTA
L
8
6
8
6
4 54X-IN
+5V+5V
+5V
5 6
77602
M24C256
EEPROMINVERTER
4
2
2 4MHz_MOJOINVERTER
760674AHC1GU04GW
760574AHC1GU04GW
K1 K2
+5V
+3V3
+12V_A
+1V8FE
+1V2_MOJO
6304
7305MC34063AP1
SUPPLY
CONTROL
7306NCP303LSN30
POWERON
RESET
12
6303
7303MC34063AP1
SUPPLY 26
180
+3V3
5302
6300
2311
73097310
+3V3CLEAN
G_16220_007.eps070206
RESET_n
MPEG
K7
K7
53093
5511
FILTER
5513
FILTER
5514
FILTER
5512
FILTER
7521÷7523
75007501
75037504
1500
14021
2
3
UARTCONN.FOR
COMPAIRONLY
1403
1
2
3
4
USB_D+
USB_D-
VBUS
USBCONNECTOR
(Reserved)
7403LM3525
USB_OVRCUR
USB_PWR 6,8
2
1
7+5V_USB
Power Switch and Over-current
Protection
3420
3421USB_DP
USB_DM
5301
7300MC34063AP1
SUPPLY 26 7311
7308LD1117V50
IN OUTCOM
7301LD1117V18
IN OUTCOM
53035304
5300
7307LD1117V50
IN OUTCOM
5306 5305
TO 1G03
LC4.x (EUR)B15B
3207
3206
3211
3209
3210
3700
3701
3607
3606
3626
3627
3612
3633
3634
5602
3630
3631
3625
3629
7601-1LM393D
3
2
1
14
10
12
8
6
4
SDRAM_ADDR
SDRAM_DATA
200
201
199
198
6
7
202
203
204
172
165
163
167
I2C
AV
9
8
GPIO
206
15
14
293028
3135
3134
3133
185 GPIO
5048
49
63
62
61
1401
1304
F500mA
26
MOJO_SYSCLK 6205 3164TDA_DAT (0-7)
FE_LOCK 34K6
1700
MIU_ADDR
MIU_DATA
PCMCIA-D (0-7) MIU_DATA (0-7)
TV_IRQ181 25
7524÷7526
182
7527÷7529
AR1
AR2
7302LD1117V18
IN OUTCOM
7520
7518÷7819
Block Diagrams, Test Point Overviews, and Waveforms 17LC4.31E AB 6.
I2C OverviewI²C
HERCULESB2 SCALERB8 TUNER & IFB1 COLUMBUSB19 SYNC INTERFACEB3 OTC-FLASHT
ADCB18
ANALOGBACKENDK5
SDRAMB10 SCALER INTERFACEB9
FLASH / CONTROLB11 HDMIB12 DIGITAL I/OB14 PACIFIC3B20
SCALERB7
IBO ZAPPER2 (Only For DVB Sets)
FRONT ENDK6 MOJOK1 FLASHMEMORY
K2 COMMON INTERFACE
K7
DMMIB15B
INTERFACEK4
SDA
SCL
109
HERCULESSET
PROCESSOR
108
5 4
1102UV1318S
TUNER
ERR10
N1 N2
7801GM1501H
SCALER
ERR4
ERR6
G_16220_008.eps090206
+3V3STBY
3233
3232
5 6
7207M24C16
EEPROMNVM
ERR9
NVM_WP_HERC
+3V3STBY
3249
104
11511
2
3
SERVICE CONNECTOR
COMPAIR
5 6
7D01M24C02
EEPROM256x8
2x HDMICONNECTOR
3102
3101
SDA_IO
SCL_IO
5 6
7C01M24C32
EEPROM
P3
P4
+3V3SW
3818
3817
ERR8
NVM_WP_SCALER
7C03M29W400D
ERROM
7B01K4D263238F
SDRAM
ERR14
ADDRESS
DATA
ADDRESS
DATA
AF5
SDA
SCL7
11771
2
3
SERVICE CONNECTOR
UART
UART_TX
UART_RX
3172
3173
M1
M2
21802
1
JTAG_TDI_SDA
JTAG_CLK_SCL
AF7
AD6
+3V3_IO
3838
3837
JTAGI2C
FSDATA
FSADDR
OCMDATA
OCMADDR
7
SWHW_I2C_SDA
SWHW_I2C_SCL
1500
For DMMI
38 37
7L01P3563M
ADC
ERR7
3L19
3L18
A15 B15
7M00T6TU5XBG
COLUMBUSCTRL
ERR11
3M14
3M15
ERR17
198 200
7N00T6TF4AFG
PACIFIC3MISC
ERR16
1N04
2
3
4
FORDEVELOPMENTUSE ONLY (N.S.)
SDA
SCL
1
+3V3SW
3N20
3N21
7A00PCA9515ADP 1N17
(1G50)
31
30
3
2
6
7
TODISPLAY
3152
3151
112
113
191
182
75 74
7D03SII9993CT
HDMIPANELLINKRECEIVER
ERR13
3D05
3D06
1F03
16
15
+5VHDMI_A
3D09
3D01
J16
J15 DOC_SCLB
DOC_SDAB
+3V3STBY
3170
3171
SDA_DMA_BUS1_DISP
SDA_DMA_BUS1_DISP
FOR PDP ONLY(Depending on screen manufacturer)
4A01
4A00
RES
7221
7220
+3V3SW
3298
3297
+3V3SW
144214 14
1000
13 13
86 85
7001SAA5801H/
TVCONTROL
ERR15
3016
3015
+3V3STBY
3902
3901
5 6
7D00M24C02
EEPROM256x8
1F02
16
15
K16
K15 DOC_SCLA
DOC_SDAA
+5VHDMI_B
3D10
3D03
4N30
4N31
(OPTIONAL PIXEL+)
SDA_PF3
SCL_PF3
1N03
2
3
4
FOR PACIFIC3PROGRAMMING (N.S.)
SSDA
SSCL
1
+3V3SW
202
204
7N02M25P05
Flash512k
SPI_SOSPI_SCK
192191
SPI_CSSPI_WP
194188
SPI_RSTSPI_SI
187193
56
1372
(Only For 27” - 42” Sets)
1G03
I2C_TDA_SDA
I2C_TDA_SCL
+5V
3626
3627
9 8
1600TD1316L
TUNERDIGITAL
3513
3512
5 6
7602M24C256
EEPROM
3607
3606
3632
3633
4 3
7600TDA10046
COFDMCHANNEL DECODER
3630
3631
8 6
3625
3629
9 8
7100-6PNX8316HS
MOJO(I2C-USB-SCO)
3147
3146
7 6
3144
3143
5 6
7203M24C64
EEPROM8kx8
3209
3210
+5V
3207
3206
30 31
7700STV0700
PCMCIACONTROLLER
3701
3700
I2C_local_SDA
I2C_local_SCL
1 1
2 2
7217TDA15021H
14021
2
3
UARTCONNECTOR
FOR COMPAIR
7100-7PNX8316HS
MOJO(GPIO)
TXD0
RXD0
15
14
I2C_TV_SDA
I2C_TV_SCL
RES
18LC4.31E AB 6.Block Diagrams, Test Point Overviews, and Waveforms
Supply Voltage Overview
B12
B18
B6
B6
B16 TOP CONNECTORS B1 TUNER & IF
B2 HERCULES
B3 SYNC INTERFACE
B4 AUDIO DELAY LINE (FOR PDP SETS ONLY)
B5 AUDIO PROCESSING
B7 SCALER
B8 SCALER
B10 SDRAM
B11 FLASH / CONTROL
B12 HDMI
B13 MUX-SYNC INTERFACE
B14 DIGITAL IO
B15A SCART ANALOG IO
B18 ADC
B19 COLUMBUS
B20 PACIFIC3
B6 DC-DC CONVERTER
B15B DMMI
C CLASS D AUDIO AMPLIFIER
D SIDE-AV
J IR / LED / LIGHT-SENSOR
T OTC-FLASH (FOR 1000pg TXT)
B17 SIDE CONNECTORS
B9 SCALER INTERFACE
K2 FLASH MEMORY
K4 INTERFACE
K6 FRONT END
K7 COMMON INTERFACE
K5 ANALOG BACK END
K3 POWER SUPPLY
K1 MOJO
SA3 AUDIO
SUPPLYPANEL 26”- 32”
(PSU)
SUPPLY LINE OVERVIEW
1 1J02
2
3
4
5
6
7
8
9
10
11
12 LAMP_ON_OFF
BACKLIGHT_CTRL
STANDBY
POWER_DOWN
+3V3STBY
VP
+12VSW
+5VSW+5VSW
+5VSW_b
+5VSW_a5152
5153
+3V3STBY+3V3STBY
+1V8_A
+3V3STBY+3V3STBY
+5VSW+5VSW
+8VSW_TV+8VSW_TV
72153265
7216-13264
+1V8_B72173263
7216-23262
+5VSW+5VSW
+3V3STBY+3V3STBY
+3V3SW+3V3SW
+5VSWI+5VSWI
+5VD5501
+3V3SW+3V3SW
+3V3STBY+3V3STBY
+5VSW+5VSW
+5V+5V
+1V8_CORE+1V8_CORE
+2V5_DDR+2V5_DDR
+3V3SW+3V3SW
+3V3_IO+3V3_IO
+3V3_PLL+3V3_PLL
+3V3SW+3V3SW
+1V8
3V3_PLL5900
3V3_ADC5901
3V3_DVI5902
3V3_IO5903
3V3_LBADC5904
3V3_LVDSA5905
3V3_LVDSB5906
3V3_LVDS5907
+2V5_DDR59087900
IN OUTCOM
7901
IN OUTCOM
5909
5910
5911
+1V8_ADC
+1V8_DV1
+1V8_CORE
+2V5_DDR+2V5_DDR
FSVREF3B01
+3V3_IO+3V3_IO
+3V3SW+3V3SW
+3V3SW+3V3SW
+3V3SW+3V3SW
+5VSWI+5VSWI
+5VSWI+5VSWI
181F03
+5VHDMI_B
+5VSW+5VSW
+5VSWIA+5VSWIA
+3V3SWB7L02
IN OUTCOM
+3V3SW+3V3SW
+3V3SWA5M03
+5VSWI+5VSWI
+5VSWIA5M04
+3V3SW+3V3SW
+1V5
LVDS_VCCLVDS_VCC
+2V5PLL7N03
IN OUTCOM
5N03 +2V5VDD
1
1J01(1M46)
2
3
4
5
6
7
8
9
10
11
+12VUFD
+5V_UFD
5J03
1J07
1J08
N.C.
N.C.
N.C.
N.C.
4J01
+5V
37” SETS
1J031
1
1J00(1M03)
2
3
4
5
6
7
8
9
10
STANDBY
FAN_SPEED
BACKLIGHT_CTRL
N.C.LAMP_ON_OFF
POWER_UP_OKN.C.
N.C.
PROTECT_AUD
UFD CONTROL
C1003
B1,B2,B3,B5,B8,B9,B15b
B3,B6
B5,B6,B9
B6
B6,B16
B16
B6
B6
B6
B6
B16
B6
B6
B8
B6
B15b
B4,B9,B19
B19
B6
B6
B20
B6
B6
26” SETS +12VSW
+3V3STBY7708
IN OUTCOM
+5V+5V
5704
+8VSW_TV7738
IN OUTCOM
5738
7754
LVDS_VCC
7758
+3V3SW
PANEL-PWR-CTL
5752 DC/DCConverter
7752 57535754 +5VSWI
5730 PWRREG
77305733 +VTUN
+5VSW5737
5757
6735
B16
B16
5709
(For 37”-50” Large Screen)
DVI
5J04
B7,B10
B8
B8
B8
B6
B6
B6,B16
B6
B6
B8
B6
B6
B6
B6
B7,B11
B13,B19,B20
B8
5700
B6
PAN_VCC
(For 26”-42” Screen)
HERCULES
RES
X20
0
1308
+3V3SW+3V3SW
+12VSW+12VSW
+5V+5V
+12VSW
77585717 5713
STEPDOWNCONTR
3718
7754
SC_STANDBY
(Supply to Tuner & Hercules)
+3V3STBY+3V3STBY
B16
VDDA_3V3PLL5D06
VDDA_3V35D00
VDDD_3V35D01
VDDI_3V35D02
VDDC_1V85D057D02
IN OUTCOM
5D03
5D04
VDDA_1V8
VDDD_1V8
181F02
+5VHDMI_ADVI
+3V3STBY+3V3STBY
+5VSW+5VSW
+8VSW_TV+8VSW_TV
5L01
5L11
VDDP
VADC
VMPLL
5L17 VPLL
+2V5_DDR+2V5_DDR
VDDC5L21
B8
7N04
IN OUTCOM
5N04 1V5CORE
5N05
+1V5PLL5N06
3001
50013
B16
7
B17
5
1J03VP
VP_SGN
1K01+5VSW
+3V3STBY1870
1304
1003
5001
6B3
1442 +3V3SW
+3V3_INTOTC
1000
(OPTIONAL)
+3V3STBY+3V3STBY
+5VSW+5VSW
1K005
1K017
+3V3STBY_1
+5VSW_1
B6,B16
B6
D1304
+5VHDMI_A+5VHDMI_A
+5VHDMI_B+5VHDMI_BB14
B14
5L19
B18
+3V3SW+3V3SW
+3V3STBY+3V3STBY
+5VSWI+5VSWI
+5V+5V
B16
B6
B2,B3,B5,B7,B8,B9,B11,B12
B12
B13
B15a,B15b,B17
B1,B2,B3,B5,B8,B9,B15b
B1,B2,B3,B5
B6
B16
B6
B2
B6B16
B6
B6
B6
B6
B6
B7
B7
1M46
B6
G_16220_009.eps070206
B1
+VTUN+VTUN
1M02
2
6 +16V+19V
-16V-19V
-Vf21
-Vf11
-Vf1
+16V+19V
-16V-19V
Vp
Vm
A2
1M02
TO 1M02
SUPPLY 37”
1
5
5723
5707
5711
3760
3759
7712
7713
2797
2798
6710
6711
SA1TO 1M02
STBY-SUPPLY
SA1TO 1M02
STBY-SUPPLY
SUPPLYPANEL 37”
(PSU)
1M03
5K00
5K01
(Only For 26” - 32” Sets)
(Only For 37” Sets)
(Only For 26” - 32” Sets)
+3V3+3V3
+3V3_NOR485201
5200
+5V+5V
K3
K3
+3V3+3V3K3
+5V_USB+5V_USBN.C.
+1V8FE+1V8FE
+3V3+3V3
K3
K3
+5V+5V
K3
+3V3_FE5801
+5Vclean+5Vclean
K3
+3V3+3V3
K3
+3V3_BUF5702
+5V+5V
K3
+3V3_STV5703
+3V3_CORE5704
CURRENTSWITCH
77051 7 PCMCIA_5V
PCMCIA_AVCC5701
PCMCIA_VPP5700
+3V3+3V3
+5Vclean+5Vclean
K3
K3
+3V3clean+3V3cleanK3
1 +12V1301
5309 +12V_A
SUPPLY
7300MC34063AP1
6 2 5300 7311
5302
+3V3
3V3clean
7301
IN OUTCOM
+1V8FE
SUPPLY
7305MC34063AP1
6 25306 53087307
IN OUTCOM
7308
IN OUTCOM
+5V
+5Vclean
SUPPLY
7303MC34063AP1
5304 5303 +1V2_MOJO6 2
K6
K2,K5,K6,K7
K1
K6
K1,K5
K1,K2,K4,K5,K6,K7
(ONLY FOR DVB SET)
(ONLY FOR DVB SET)
(ONLY FOR DVB SET)
(ONLY FOR DVB SET)
(ONLY FOR DVB SET)
(ONLY FOR DVB SET)
X220(26”)1M10(37”-42”)
PSU
+1V2_MOJO+1V2_MOJO
+3V3+3V3
+3V3_MOJO5100
K3
K3
3V3clean3V3cleanK3
(ONLY FOR DVB SET)
1M10 K3
1301
IBO ZAPPER2(DVB)
X22
0 K3TO 1301
IBO ZAPPER2(DVB)
1304
7302
IN OUTCOM
+5V_amp5515
K5
+12V_A+12V_AK3
A4OR 1M02
SUPPLY 42”
Circuit Diagrams and PWB Layouts 19LC4.31E AB 7.
7. Circuit Diagrams and PWB Layouts
IBO Zapper Panel: MOJO
2
AVDD
1
2IDUMP
(PWR)
VDDC
VDDP
VSSC
VSSP
0
1
TS_DATA
(TS)01234567
TS_VAL
TS_STROBE
TS_SYNC
Y
C
CVBS
G
R
SD_OUT
SCK_OUT
WS_OUT
SPDIF
FSCLK
Y
CVBS
CVBS
Y
C
(AV)
B
DQM0
14
13
12
11
10
9
8
7
6
5
4
3
2
1
0
8
9
10
11
12
13
(SDRAM)
14
15
0
1
2
3
4
5
6
7
SDRAM_DATA
SDRAM_ADDR
HSCKB
CKE
WE
RAS
CAS
DQM1
0
456789
MIU_CS_N3
MIU_OE_N
MIU_WEN
MIU_MASK0
0123456789
1011121314151617
MIU_DATA
MIU_LBA
MIU_BAA
MIU_CLK
24
MIU_ADDR
(MIU)
321
181920212223
MIU_MASK1
101112131415
MIU_RDY
MIU_CS_N0
MIU_CS_N1
MIU_CS_N2
SC0_CCK
USB_DM
USB_DP
USB_PWR
SC0_CMDVCC
(I2C-USB-SCO)
SCL1
SDA0
SCL0
SDA1
SC0_DA
USB_OVRCUR
SC0_OFFSC0_RST
PIO <0:15>
VS
SC1_DA
SC1_CMDVCC
SC1_RST
SC1_OFF
SC1_CCK
CTS0
RTS0
RX0
TX0
DCD0
PLL_OUTX0
VCXO_CLOCK
BOOT <0:3>
PIO <16:27>
ITU_OUT
(GPIO)
TX1
DTR0
RX1
ITU_CLOCK
7
6
5
4
3
2
1
0
IR_IN
IR_OUT
PWM
VPP
C4
C8
DS
U_T
PC
0
12012 SY
S_R
ES
ET
N
TD
I
TD
O
PC
ST
0
PC
ST
1
TM
S
TR
ST
TC
K
RE
SE
TN
XT
AL_
IN
XT
AL_
OU
T
AV
DD
_PLL
AV
SS
_PLL
(JT
AG
-ET
AG
-SY
S)
DS
U_C
LK
DS
U_T
PC
1
0
MOJO
100MHz
100MHz
100MHz
1%
K7K7K7K7K7K7K7K7
K5
K5
K5
K2, K6, K7
K2, K6, K7
K5
K5
K5
K5
K5
K5
K7
K7
K7
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K2
K5
K6
K7
K2
K6
K6
K2
K2
K7
K7
K4
K4
K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2K2K2K2K2K2K2K2
K2
K7
K7
K2, K7K1, K2, K7
K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7K2, K7
2V22V22V22V22V22V22V22V2
0V
1V6
1V3
0V
1V
1V6
0V
0V
0V
0V
4V6
4V6
3V3
3V3
3V2
3V2
3V3
3V3
0V
3V3
0V
1V2
0V0V0V
0V
0V
0V
1V2
3V3
1V2
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
2V1
3V1
3V
3V
2V9
3V3
1V5
2V3
2V3
2V3
0V
2V5
0V
2V5
2V9
2V3
3V3
0V
4V6
3V3
3V3
0V
0V
0V
3V3
0V
0V
0V
0V
0V
0V
0V
0V
3V3
0V
3V3
3V3
3V2
0V
0V0V0V0V0V0V0V0V0V0V0V0V0V0V0V0V
3V3
3V3
3V3
3V3
3V3
3V3
3V33V33V33V3
3V3
3V3
3V33V33V33V33V3
0V0V0V
0V0V
3V30V
0V0V
0V0V
0V
0V
2V6
2V6
2V6
2V6
2V6
FOR DEV. ONLY
CONFIGURABLE
RES RES
RES
RES
K4
FOR DEV.ONLY
0V
K4
K4
K4
K4
K6
K3
K2
K1
K5
RES
RES
K5K5
1 2 3 4 5 6 7 8 9 10 11 12 13 14
1 2 3 4 5 6 7 8 9 10 11 12 13 14
A
B
C
D
E
F
G
H
I
A
B
C
D
E
F
G
H
I
1100-1 E81100-2 E81101 B91106 E142100 F62101 G62102 G62103 G62104 G62105 G62106 G62107 H62108 H62109 H62110 H62111 H62112 F62113 F62114 G62115 G62116 G62119 H92120 H92121 I92122 C82130 I72131 I72132 H72133 C53100 A43101 E63112 E93113 C73114 A33115 A43116 A43117 A43119 A43120 E53121 E53122 E63123 E63124 E63125 E63126 E63127 E63128 E143129 F143130 E143131 E143132 F143133 G13134 G13135 F13136 E143137 F143138 A33139 C63140 I93141 D143142 G13143 H43144 H43145 H23146 H43147 H43148 I23149 I33150 I33151 G133154 G133155 G143156-1 G113156-2 H113156-3 G113156-4 H113157-1 G113157-2 H113157-3 G113157-4 H113158-1 G113158-2 H113158-3 G113158-4 H113159-1 H113159-2 H113159-3 H113159-4 H113160 I113161 I113162 I113163 G113164 G14100 H34101 H24102 A44104 A44105 B74106 B74107 B74108 F144109 C74110 B75100 I75101 F55102 F55103 C57100-1 F87100-2 E27100-3 F27100-4 A127100-5 G127100-6 H57100-7 D127100-8 D77103 H37104 I2
7105 F13F105 A7F106 A7F107 A7F108 A7F109 A7F110 A7F111 A7F112 A7F113 B7F114 A7F122 E9F125 B6F129 E13F131 E13F132 F13F133 H3F134 H3F135 H2F136 H2F137 F14F138 A10I100 H4I101 H4I103 F13I104 E6I105 I9
N.C
.
N.C.
N.C.
22R
3164
F138
15 16
17 18
19
2
20
3 4
5 6
7 8
9
1101FTR
1
10
11 12
13 14
10K
3163
468
1012141618
2
2022242628
FTSH-114-01-L-DV
ROW_21100-2
33R3162
33R
3161
45
33R
3160
7 33R3159-433R3159-2
2
33R3156-445
33R3156-2
27
3158-4
45
4533R27
33R3157-4 2733R3158-2
36 33R3157-2
3633R3159-3
33R3156-333R3159-1
18
33R3156-1
18
3158-3
3618 33R36 33R3158-118 33R3157-3
+1V2_MOJO
33R3157-1
+3V3_MOJO
+1V2_MOJO
10K3132
2
4108
BSN207105
3
1
F137
100R3142
2122
57
911131517
3113
1
1921232527
3
+3V
3
ROW_11100-1
FTSH-114-01-L-DV
10K3115
+3V
3
4104
4102
F113
F112
F107
F110
F106
F111
F114
F109
F108
F105
4109
4107
4106
4105
4110
F12
2
10K
3154
+3V3
10K
3155+3V3
5100
+3V3
+3V3
+3V3_MOJO
+3V3_MOJO
+3V
3_M
OJO
3140+3V3_MOJO
+3V
3
10K
1K2
3151
F134
F133
10u
2133
I105
F132
I104
I103
+3V3_MOJO
10K
3112
33R
3139
10K
+3V
3 3100
10K3138
10K3136
+3V
3
10K3137
10K3119
5103
F125
2111 100n
100n2110
2109 100n
100n2106
2108 100n
100n2107
100n2103
2105
2104 100n
100n
100n2114
100n2115
2112 100n
2116 100n
2113 100n
10u
2101
5102
5101
2100
10u
2102
10u
2121100n
+3V3clean
100n2120
2119100n
10K
3114
3131
3101
10K
10K
208
20712
158
159
187
194
189
188
197
196
195
4
5
3
PN
X83
16H
S71
00-8
157
160
186
183
184
185
33
34
35
45
46
47
48
18
19
176
32
177
178
179
180
181
182
PNX8316HS7100-7
31
49
12
13
14
15
16
17
7
9201
200
198
199
PNX8316HS7100-6
40
37
36
3938
6
8
110
106
10770
109
108
52
6563595755536866
74
73
72
71
6967
6462585654
105
82838485868788
50
51
96979899
100
81
101102103104
7580
8990919293
117
118
121
122
132
129
139
7100-5PNX8316HS
144
113
114
128
127
126
125
124
123
115
116
142
150
151
155
156
149
148
147
146
145
140
137
138
133
136
141
153
154
152
143
206
204170
PNX8316HS7100-4
7100-3PNX8316HS
163
168
172
205 165
167
203
202
27
29
30
28
20212223242526
61
77
95
112
131
162
193
7100-2PNX8316HS
130
161
190
173
42
79
120
135
192
11
44
78
119
134
191
10
43
60
76
94
111
7100-1PNX8314HS
175
169
164
171
166
174
41
+3V310K3128
10K3129
3130 10K
+3V
3 10K3116
3117 10K
33R
3127
3126
33R
33R
3125
3124
33R
3123
33R
3122
33R
3121
33R
3120
33R
3135 22R
3133 22R
3141
10K
F129
2130
+3V3
16V10u
10u 16V
2132
F131
16V10u
2131
10K
3149
3150
10K
10K
10K
3145
3148
1
2
4101
+3V3_MOJO
7104BSN20
3
4100
BSN20
3
1
2
12
7103
1106B2B-PH-K
F136
F135
3134 22R
I101
I100
100R3144
100R3143
+3V3_MOJO
100R3147
3146 100R
JTAG_TCK
STV_TDI
NOR_RYBY
MIU_WEN
SPDIF
TV_IRQ
MOJO_SYSCLK
MOJO_TDI
MO
JO_T
DI
MOJO_TDI
10046_TDO
10046_TDO
10046_TDO
JTAG_TRST
JTAG_TMS
TS_CLK
TS_SYNC
TS_VALIDDSW_n
NOR_CS
CTSN0
RTSN0
RXD0
TXD0
DCD0
MIU_DATA(13)MIU_DATA(12)MIU_DATA(11)MIU_DATA(10)MIU_DATA(9)MIU_DATA(8)MIU_DATA(7)MIU_DATA(6)MIU_DATA(5)MIU_DATA(4)MIU_DATA(3)MIU_DATA(2)MIU_DATA(1)MIU_DATA(0)
MIU_OEN
STV_CS
MOJO_TMS
MOJO_TRST
MOJO_TRST
MO
JO_T
RS
T
4MHz_MOJO
RESET_n
RE
SE
T_n
RESET_n
RESET_n
MO
JO_T
DO
DSU_CLK
DSU_CLK DSU_CLK
MIU_DATA(15)MIU_DATA(14)
MIU_ADDR(9)
USB_DM
USB_DP
USB_OVRCUR
USB_PWR
DT
R0
MOJO_TCK
MOJO_TCK
MO
JO_T
CK
MOJO_TMS
MO
JO_T
MS
1V2_CORE
MIU_ADDR(0)MIU_ADDR(1)
MIU_ADDR(10)MIU_ADDR(11)MIU_ADDR(12)MIU_ADDR(13)MIU_ADDR(14)MIU_ADDR(15)MIU_ADDR(16)MIU_ADDR(17)MIU_ADDR(18)MIU_ADDR(19)
MIU_ADDR(2)
MIU_ADDR(20)MIU_ADDR(21)MIU_ADDR(22)MIU_ADDR(23)MIU_ADDR(24)
MIU_ADDR(3)MIU_ADDR(4)MIU_ADDR(5)MIU_ADDR(6)MIU_ADDR(7)MIU_ADDR(8)
PCST0_1PCST0_1
TPCI
PCST1_0
PCST1_1
PCST1_2
PCST0_0PCST0_0
PCST0_0
PCST0_2
PCST0_2
PCST0_2
AR2
DSW_I2C_enable
SDRAM_ADDR(12)
SDRAM_ADDR(13)
MIU_WEN
MOJO_I2S_OUT_WS
MOJO_I2S_OUT_SD
MIU_RDY
NOR_RYBY
PCST0_1
NOR_WPPIO19|ITU_OUT0|BOOT0
PIO20|ITU_OUT1|BOOT1
PIO22|ITU_OUT3|BOOT3
C_CVBS
B|Pb
G|Y
R|Pr
SDRAM_DQM1
SDRAM_RAS
SDRAM_CLK
SDRAM_CKE
SDRAM_DQM0
SDRAM_CAS
SDRAM_WE
1V2clean
PIO21|ITU_OUT2|BOOT2
AR1
SDRAM_DATA(7)
SDRAM_DATA(8)
SDRAM_DATA(9)
SDRAM_DATA(10)
SDRAM_DATA(11)
SDRAM_DATA(12)
SDRAM_DATA(13)
SDRAM_DATA(14)
SDRAM_DATA(15)
FE_LOCK
dsp_EEPROM_WP
RS232_DSR
STV_A25
STV_INT
SDRAM_ADDR(5)
SDRAM_ADDR(6)
SDRAM_ADDR(7)
SDRAM_ADDR(8)
SDRAM_ADDR(9)
SDRAM_ADDR(10)
SDRAM_ADDR(11)
SDRAM_ADDR(14)
SDRAM_DATA(0)
SDRAM_DATA(1)
SDRAM_DATA(2)
SDRAM_DATA(3)
SDRAM_DATA(4)
SDRAM_DATA(5)
SDRAM_DATA(6)
user_EEPROM_WP
SDRAM_ADDR(0)
SDRAM_ADDR(1)
SDRAM_ADDR(2)
SDRAM_ADDR(3)
SDRAM_ADDR(4)
TS_DATA(3)TS_DATA(4)TS_DATA(5)TS_DATA(6)TS_DATA(7)
RESET_STV
UART1_RX
UART1_TX
I2C_LOCAL_SCL
I2C_LOCAL_SDA
I2C_TV_SCL
I2C_TV_SDA
RES
RES
RES
RES
RES
RE
S
RES
RES
RES
RESET_FE_n
MOJO_I2S_OUT_SCK
TS_DATA(0)TS_DATA(1)TS_DATA(2)
K1
3139 123 6147.1 G_16220_011.eps070206
20LC4.31E AB 7.Circuit Diagrams and PWB Layouts
IBO Zapper Panel: Flash Memory
VDD VDDQ
1314
CKE
10
D
A
DQMLU
11
456
123
7
378910
CLK
4
BA
CS
5
VSS
2
CASWE
15
RAS
VSSQ
0
9
NC
10
0
6
12
8
1
11
SCLADR
012 SDA
WC
10
4
9876
0
32M-1
0A
D
5
11
21
17
OE
12131415
VPP/WP_
201918
16
RB
432
CE
76
WERP
10
BYTE
3
NC
5
89
101112131415
A-1
W
VPP
VD
DQ
VS
SQ
VD
D
R
RB
VS
S
1918
15
12345678D
0
91011121314
34
1
E
G
RP
0
2
1716151413
2048k-1121110987
5
A
6
L
K
2021
2/4/8MBNOR
FLASH
2/4/8MBNOR
FLASH
SYSTEMEEPROM
I2C ADDRESS=A8
FLASH MEMORY
100MHz
100MHz
100MHz
100MHz
K1
K1
K1
K1K1K1K1K1K1K1K1K1
K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7
K1, K7
K1, K7K1, K7
K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7
K1, K7
K1
K1, K7
K1, K3
K1
K1K1K1K1K1K1K1K1
K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7
K1, K7
K1, K7K1, K7
K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7K1, K7
K1
K1, K7
K1K1, K7
K1
K1
K1K1K1K1K1K1K1K1K1K1K1K1K1K1K1K1
K1K1
K1K1K1K1K1K1K1K1K1K1K1K1
K1K1
K1K1
K1K1K1
K3K1
0V0V0V0V0V0V0V0V0V0V0V0V
0V0V
1V53V3
3V3V3V
0V
1V31V31V1V31V31V20V
1V41V31V31V1V41V41V3
1V20V7
3V32V2
5V
5V
4V6
4V6
4V6
0V0V
0V0V0V0V
0V0V0V0V
0V0V0V0V
0V0V
0V
3V2
3V2
3V23V23V23V2
3V2
3V2
3V2
3V2
3V23V23V2
3V23V23V23V23V23V2
0V
0V0V
0V
0V0V
0V0V
0V
MECHANICAL 3.5MM HOLE
1 2 3 4 5 6 7 8 9 10 11 12 13 14
1 2 3 4 5 6 7 8 9 10 11 12 13 14
A
B
C
D
E
F
G
H
I
A
B
C
D
E
F
G
H
I
0001 H10002 H20003 H20004 H20005 H30006 H40007 H40008 H50009 H50010 H60011 H60012 H70013 H80014 H90015 H90016 H100017 H100018 H112200 B132201 B122202 B132203 B82204 B92205 B132206 E52207 E42208 E42209 E42210 E42211 E42212 E42213 E42214 F113200 D63201 D143202 E133203 E113204 E123205 D93206 F123207 F133209 G133210 G133211 F123212 D114200 D74201 D74202 D74203 D74204 D74205 D94212 F134213 E134214 D114215 D95200 B125201 B85202 D35203 F127200 B87201 B127202 E37203 G11F200 F12F201 E7I200 B12I201 B8I202 D4I203 D12I204 D7I205 E7I206 D9I207 F12I208 G13I209 E12I210 E12I211 E13
I202
HEATSINK
0017 0018
HEATSINKHEATSINK
0015 0016
HEATSINK
0014
HEATSINKHEATSINK
00130011
HEATSINKHEATSINK
00100009
HEATSINKHEATSINK
00080007
HEATSINKHEATSINK
0006 0012
HEATSINK0005
HEATSINKTYPE0004
TYPE0003
TYPE0002
+3V3_NOR48
+3V3_NOR48
TYPE0001
+3V3_NOR48
+3V3_NOR48
I210 I211
+3V3
+5V
I209
+3V3_NOR48
+3V3
+3V3_NOR48
+5V
+3V3
+3V3_NOR48
+3V3_NOR48
+5V+5V
+5V
F201
3212
470R
4204
I2043K33200
4201
13
28
1512
37
14
27 46
114200
4345
3335384042443032
1887
4726
2931
34363941
14817169
23
10
22212019
4Mx8/2Mx16EPROM25
24
65432
M29W320ET70N7200
4214
I203
I208
3201
470R
4213
F200 4212
10K
3211
100R
3209
WC_
100R
3210
E01
E12
E23
6
SCL5
SDA
8
4
VSS
7(8Kx8)Φ
EEPROM
M24C64-WMN67203
3K3
I207
3207
3206
3K3
100n
2214
5203
I200 2200
100n
5200
10u
2201
16V
I201
2203
10u
5201
100n
2202
2205
100n
470R
3202
3203
470R
3204
470R
37 43
15
21 48 42
55
31
29
1303256
2
53
16
9
3840444649513436
14
54
222019
3335
394145475052
8765
27
43
26252423
28
181713121110
Φ
M58LW032C90N17201
4203
4202
I205
4205
I206
4215
10K
3205
2204
100n
49
28 41 54 6 12 46 52
16
3640
18
39
1 14 27 3 9 43
5153
5781011134244
1517
3738
19
24
45474850
35
2526293031323334
2021
SYNCΦ
4x2Mx16DRAM
7202
2324
22
K4S281632F
5202
10u
2206
100n
2211
2212
100n
100n
2207
100n
2208
2209
100n
100n
2210
2213
100n
user_EEPROM_WP
MIU_DATA(1)
NOR_RYBY
MIU_ADDR(20)
MIU_ADDR(21)
I2C_LOCAL_SCL
I2C_LOCAL_SDA
MIU_ADDR(22)MIU_ADDR(23)
MIU_ADDR(24)
NOR_WP
MIU_WEN
NOR_RYBYRESET_n
MIU_DATA(5)MIU_DATA(6)MIU_DATA(7)
MIU_ADDR(1)
MIU_ADDR(10)MIU_ADDR(11)MIU_ADDR(12)
MIU_ADDR(2)MIU_ADDR(3)MIU_ADDR(4)MIU_ADDR(5)MIU_ADDR(6)MIU_ADDR(7)MIU_ADDR(8)MIU_ADDR(9)
MIU_DATA(10)MIU_DATA(11)MIU_DATA(12)MIU_DATA(13)MIU_DATA(14)MIU_DATA(15)
MIU_DATA(8)MIU_DATA(9)
NOR_CS
MIU_OENNOR_WP
MIU_DATA(8)MIU_DATA(9)
MIU_DATA(10)MIU_DATA(11)MIU_DATA(12)MIU_DATA(13)MIU_DATA(14)
MIU_WEN
MIU_ADDR(13)MIU_ADDR(14)MIU_ADDR(15)MIU_ADDR(16)MIU_ADDR(17)MIU_ADDR(18)MIU_ADDR(19)MIU_ADDR(20)MIU_ADDR(21)
MIU_DATA(0)MIU_DATA(1)MIU_DATA(2)MIU_DATA(3)MIU_DATA(4)
MIU_DATA(0)
MIU_DATA(2)MIU_DATA(3)MIU_DATA(4)MIU_DATA(5)MIU_DATA(6)MIU_DATA(7)
MIU_ADDR(18)
MIU_ADDR(19)MIU_ADDR(20)
MIU_ADDR(22)MIU_ADDR(22)
MIU_OEN
RESET_n
NOR_CS
SDRAM_ADDR(3)SDRAM_ADDR(2)SDRAM_ADDR(1)SDRAM_ADDR(0)
SDRAM_ADDR(14)SDRAM_ADDR(13)
MIU_ADDR(1)MIU_ADDR(2)MIU_ADDR(3)MIU_ADDR(4)MIU_ADDR(5)MIU_ADDR(6)MIU_ADDR(7)MIU_ADDR(8)MIU_ADDR(9)MIU_ADDR(10)MIU_ADDR(11)MIU_ADDR(12)MIU_ADDR(13)MIU_ADDR(14)MIU_ADDR(15)MIU_ADDR(16)MIU_ADDR(17)
MIU_DATA(15)
SDRAM_DATA(8)SDRAM_DATA(9)
SDRAM_DATA(10)SDRAM_DATA(11)SDRAM_DATA(12)SDRAM_DATA(13)SDRAM_DATA(14)SDRAM_DATA(15)
SDRAM_ADDR(11)SDRAM_ADDR(10)SDRAM_ADDR(9)SDRAM_ADDR(8)SDRAM_ADDR(7)SDRAM_ADDR(6)SDRAM_ADDR(5)SDRAM_ADDR(4)
SDRAM_ADDR(12)
SDRAM_DQM1SDRAM_DQM0
SDRAM_WESDRAM_CASSDRAM_RAS
SDRAM_CKESDRAM_CLK
SDRAM_DATA(0)SDRAM_DATA(1)SDRAM_DATA(2)SDRAM_DATA(3)SDRAM_DATA(4)SDRAM_DATA(5)SDRAM_DATA(6)SDRAM_DATA(7)
RES
RES
RES
RES
RE
S
K2 K2
3139 123 6147.1 G_16220_012.eps070206
Circuit Diagrams and PWB Layouts 21LC4.31E AB 7.
IBO Zapper Panel: Power Supply
COM
OUTIN
COM
OUTIN
COM
OUTIN
COM
OUTIN
POWER ON RESET
FOR DEV. ONLY
POWER SUPPLY
(446mA)
(193mA)
(197mA)
(400mA)
(380mA)
RES
LD1117V18
1%1%
1%
1% 1%
1%
K1, K2
11V2
3V23V2
3V3
3V3
2V9
11V3
11V3
1V2
3V3
0V7
2V6
1V9 10V6
11V3
11V3
11V3
1V3
0V7
3V2 1V8
11V9
1V2
6V5
0V7
6V5
6V5 5V
5V
FR
OM
PO
WE
R S
UP
PLY
BO
AR
D
(500mA)
RES
(230mA)
LD1117V
RE
SR
ES
RES
RE
S
5V1
RE
S
RES
RES
RE
S
PD
Z3.
6-B
1 2 3 4 5 6 7 8 9 10 11 12 13
1 2 3 4 5 6 7 8 9 10 11 12 13
A
B
C
D
E
F
G
H
I
A
B
C
D
E
F
G
H
I
1301 B11303 H31304 B62300 B102301 B72302 C132303 C82304 C112305 F112306 C122308 D102309 E72310 E82311 E112312 A112313 G102314 H22315 H72316 H82317 H122318 H112319 I132320 C122321 D112322 G112323 A112324 B102325 D102326 H112327 H112328 I112329 C92330 E122331 H92332 F132333 B22334 B32335 B32336 E92337 B113300 A73301 A73302 A83303 A73304 B93306 C83307 C93311 D83312 D73313 D73314 D73315 E93316 G33317 E93318 G73319 G73320 G73321 G83322 H93323 H83324 A123325 A133326 A113327 A133328 B133329 A123330 A113331 I83332 F93333 B113334 B124302 F114303 E125300 B115301 B75302 C125303 D115304 D65306 H65307 E125308 H115309 B36300 A106303 D116304 G116305 F116306 E116307 B126308 C127300 A97301 C127302 F127303 C97305 G97306 G27307 H127308 I127309 A137310 A127311 B117312 B12F300 A7F301 B5F302 B5F303 B13F304 C13F305 C1F306 C1F307 C12F308 D7F309 B2
F310 E12F312 H2F313 H13F314 I13F315 G7F316 H11F317 F13I301 D2I302 D1I306 D1I310 A11I312 A13I313 B13I314 B10I316 B7I317 B11I318 B8I321 D11I322 D7I323 E8I324 G11I325 H7I326 H8I327 E11I328 B2I330 F11I331 F11
11V9
I302
33K
3334
1304
500mA
6308
7312BC847B
1N4148
6307
50V
2u223
37
27K
3333
43036306
S1D
1
3 2
2336
7302
4n7
I331
4302
2305100n
I330
+1V2_MOJOF317
25V100u2332
+5V_USB
S1D6305
I328
16V100u2335
+12V_A
3
100n2334
1301
B3B-PH-K
12
5309
233310n
F309
+12V
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
I327
SUPPLY_GND
SUPPLY_GNDSUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
4n7
2331
2330
16V
470u
10u
5307SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
SUPPLY_GND
2329
4n7
SUPPLY_GND SUPPLY_GND
SUPPLY_GND
2327
100n
470n
2326
100n
2328
470n
2325
470n
2324
2323
+1V8FE
F316
+12V
+3V3
+3V3clean
+12V
+3V3
+5V
+12V
+5V
+5Vclean
+3V3
2322
100n
2321
100n
3326
10K
2312
100n
I313
I312
I321
I324
I317
I310
I314
I326
I318
I323
I322
I325
I316
F313
F303
F305
2320
100n
3
1
2
7311SI2314EDS
3329
47K
100K
3328
3327
33R
100K
BC857B7309
3325
2 A 1K
R
3
1K0
3324
TL431CZ
7310
3330
1K8
2304
1m0
16V
3331
10u
5306
100R
10u
5301
10u
5304
F314
F310
F307
F304
F315
F300
F308
3316
1K0
100u
2319
2317
100u
3K9
3322
16V
470u23
18
820R23
16
3323
4n7
2313
470p
100u
5308
6304
SS14
330u
2315
1R0
3321
1R0
3320
3319
3318
1R0
IS
1SWC
2SWE
3TIMC
6VCC
1R0
5 CIN_NEG
8 DCOL
4GND
7
3332
MC34063AP17305
S
R
Q
IPKOSC
REFERENCEREGULATOR
75R
3K3
3317
F312
33n
2314
5 CD
3
GND
2INP
NC
4
1OUTP
7306NCP303LSN30
4
12
1303
SK
QT
LB
3
470u
16V
2311
1K0
3315
2310
470p
4n7
100u
5303
2308
6303
SS14
2309
330u
3311
1R0
3312
1R0
3313
6 VCC
3314
1R0
5 CIN_NEG
8 DCOL
4GND
7 IS
1SWC
2SWE
3TIMC
7303
S
R
Q
IPKOSC
REFERENCEREGULATOR
MC34063AP1
3 2
100u
2306
7301
1
10u
5302
100R
3307
3304
1K8
2303
3306
1K0
4n7
2300
470p
47u
5300
SS
14
6300
2301
SUPPLY_GND
3302
330u
3303
1R0
1R0
3300
6VCC
1R0
3301
8 DCOL
4GND
7 IS
1SWC
2SWE
3TIMC
S
R
Q
IPKOSC
REFERENCEREGULATOR
7300
5 CIN_NEG
LD1117V50
1
3 2
MC34063AP1
GND
IN OUT
7308
25V 100u
7307LD1117V50
2302
F302
I301
F306
F301
I306
RESET_n
RES
RES
RE
SR
ES
RE
S
RE
S
K3 K3
3139 123 6147.1 G_16220_013.eps070206
22LC4.31E AB 7.Circuit Diagrams and PWB Layouts
IBO Zapper Panel: Interface
NC
OUTIN
EN
FLG
COM
INTERFACE
ES
D P
rote
ctio
n
K1
K1UART CON
FORCOMPAIR ONLY
USB
LM3525MY
SPDIF OUTPUT
100MHz
RES
K1
RES
RES
RE
S
3V3
1V6
1V
K1
K1
5V1
3V3
0V
4V5
K1K1
RES
RES
RES RES
RES
RES
FOR BOARD WITH USB FEATURE ONLY
1 2 3 4 5 6 7 8 9 10 11
1 2 3 4 5 6 7 8 9 10 11
A
B
C
D
E
F
G
A
B
C
D
E
F
G
1400 B101401 B111402 C31403 F112403 E72405 F72406 F82411 B62412 B82413 C92414 C42415 C42416 F53403 E63404 B63405 B73406 B73407 B83408 C93409 E63411 B73414 C43415 C43420 F93421 F93422 F93423 F93424 F54402 F54414 B44415 C44416 F114417 F104418 F105401 B95420 F75421 F105422 F105423 F116400 C96401 C36403 C37402 B77403 E6F407 B10F408 B10F409 F5F410 F5F414 C4F415 C4F420 F11F421 F11F422 F11F423 F10F424 F9I402 F6I403 F6I404 F7I405 F9I406 F9I416 B7I417 B8I418 B6I419 B7I420 B6I421 B9
I404
47R
5422
4418
5421
47R
5423
60R
4417
1400
4416
4414
4415
2416
3424
F414
F415
3411
+3V3
180R6400
BZ
X38
4-C
5V1
2413100n
BC847B7402
100n
2411
3407
68R 100n
2412
3408
I417
3404
560R I421I419
I416I420 I418
34051K0
1K03406
F4075401
F408
1
3
2
I403
YKC21-3416
1401
I402F409
10K3409
F410
F424
F422F423
F421
3423
F420
15K342215K
342133R
33R3420
+3V3
10K3403
2403100n
+5V_USB
6.3V100u2406
100n2405
54201234
5 6
5401-032-100-70
1403
2414330p
100R3415
2415330p
3414 100R
6403
BZ
X38
4-C
8V2
123
BZ
X38
4-C
8V2
6401
1402
S3B-PH-K
1
2
3
7
45
68
4402
7403LM3525MX-H
I406
I405
SPDIF
USB_PWR
USB_OVRCUR
TXD0
RXD0
USB_DMUSB_DP
VBUSUSB_D-USB_D+
K4 K4
3139 123 6147.1 G_16220_014.eps070206
Circuit Diagrams and PWB Layouts 23LC4.31E AB 7.
IBO Zapper Panel: Analog Back End
DIGITAL
DE-EMPHASIS
INTERPOLATION
DA
C
NOISE SHAPER
FILTER
INTERFACE
DA
C
ANALOG BACK END
K1
K1
K1
K1
K1
K1
K1
K1
K1
K1
8V8
8V2
3V82V7
2V1
8V8
8V2
3V82V7
2V1
1V8
4V
4V7
2V5
3V1
11V6
1V5
2V1
7V
7V7
0V
0V6
0V6
1V
1V6
3V3 3V3
1V6
1V61V6
K1
RES
RES
RE
S
RES
K1
K1
1V8
4V
4V7
0V
0V6
RES 1V8
4V
4V7
0V
0V6
7V7
RESR
ES
RE
S
RE
SR
ES
1 2 3 4 5 6 7 8 9 10 11 12 13
1 2 3 4 5 6 7 8 9 10 11 12 13
A
B
C
D
E
F
G
H
I
A
B
C
D
E
F
G
H
I
1500 C132500 A72501 A62502 A32503 C72504 A32505 B72506 B52507 C52508 C82509 A122510 A122511 D32512 D42513 D82514 D62515 D62516 A82517 A92520 E32521 F42522 F32523 F32524 G32525 G32526 G32527 H32528 A112529 G52530 H32531 H22532 I32533 D92534 B92535 H42536 I42537 I22538 I32543 A52544 A42550 E52551 E52557 E82558 E82559 E102560 F103500 A63501 A63502 A53503 B63504 A33505 B63506 B53507 C53508 A33509 C73510 C63511 C73512 A113513 A113514 D73515 D63516 D73517 D63519 F23520 G23521 H23522 I23523 A113526 D83527 B83528 A53530 G43533 H33539 I33543 G73544 H93545 I113547 F33548 E73557 E53558 E53559 E63560 E43561 E63562 F53569 E83572 D73573 D123574 D123575 E113576 E123577 E123578 E103579 E113580 E123581 F103582 F113583 F63584 F73585 F83586 G73587 G73588 G83589 G83590 G93591 H93592 H93593 H103594 H113595 H123596 I113597 I123598 E124503 F64505 E8
4506 D74507 B24508 H64509 I84510 I114511 E74512 E135502 A45504 E45505 G45507 H45508 I45511 E35512 G35513 H35514 I35515 A85528 A56503 E56507 D136508 E136509 G66510 H86511 I106512 G66513 H86514 I106515 E137500 A77501 B67502 A37503 C77504 C77507 E77511 E67512 E57518 D127519 E117520 F127521 G57522 G77523 F77524 H77525 H97526 G97527 I97528 I117529 H12F500 B2F501 C4F502 B2F503 B2F505 A12F506 A12F507 A12F509 E13F512 D5F514 E9F516 D13F517 B13F518 G10F519 G12F521 H12I500 A6I501 A3I502 A6I503 B5I504 B7I505 B7I506 B6I507 B4I508 B5I509 B4I510 C2I511 C7I512 C7I513 C6I514 D7I515 C4I516 D8I517 D7I518 D6I520 G2I521 G2I522 G2I523 G2I524 A3I526 H7I528 H4I529 H9I531 I4I532 E3I533 G4I534 H3I535 I3I537 E8I538 E4I539 F7I540 H11I541 G5I542 G6I543 D5I544 E5I545 E5I546 E6I547 F6I548 E5I549 F5I550 H8I551 G5I552 I11I553 G7I554 F8I557 I9I558 G9I559 H11
I560 G9I561 H12I562 D12I563 D13I564 D11I565 E12I566 E12I567 E13I568 E10I569 E11I570 E11I571 F12I572 F10I573 F11I574 F12
RES
RES
RES
RES
TO SSB
11V2
0V
0V
0V
9V6
1V8
1V2
1V81V2
1V8
1V2
VOLTAGE MEASURED IN SDM MODE
RES
RES
I520
4512
BZ
X38
4-C
12
6515
6514
BAS316
1K0
3598
6513
BAS316
6512
BAS316
4511
3545
390R
3544
390R
3543
390R
3595
68R
I552
+5V_amp
I561
I559
I557
7529BC857B
BAS316BC857B7527
6511
3596
220R
4510
3593
2K2
3594
270R
I540 7528BC847B
3597
68R
3590
I560
+5V_amp
I558 BC857B7526
7524BC857B
BAS316
6510
220R
3591
4509
270R
3589
2K2
3588
3592
BC847B7525
I568
I572
I569
I573
I570
I574
I566
I571
I565I564
I567
I562 I563
+12V_A
22p
2560
2559
22p
7518BC857B
7520
BC847B7519
BC847B
6508
BAS316
3576
820R
3577
820R
1K0
3580
10K
100K
3575
3579
10K
3582
3578
75R
75R
3581
+5Vclean +5V_amp
2517
100n16
V10
0u2516
1K0
5515
3574
150R
+5V_amp
3573
6507
BAS316
150R
4507
4506
560R
3572
2558
100n16
V10
u2557
3585
68R
4505
5528
2544100n
+12V_A
+5V_amp
+3V3clean
+12V_A
+12V_A
I553
I537
+3V3
I554
I547
I551
I550
I539
3569
68R
I546
I549
I543
I545
I548
7523BC857B
I544
BAS316BC857B7521
650935
86
220R
4508
3583
2K2
3584
270R
BC857B7511
7512BC847B
BA
S31
6
6503
220n
2550
1u0
2551
4503
270R
356115
0R
3562
680R
3559
1K0
3558
100K
3557
27K
3560
32
456789
33 34
2223242526272829
3
3031
13141516171819
2
2021
1500
AF732L-N2G1A
1
101112
I542
I541
I538
7522BC847B
3587
3547
47R
BC847B
3548
560R
7507
I535
I534
I533
I529
I532
I526
I531
I528
3539
47R
47R
3533
47R
3530
I5242543
47u 16V
3528
10R
2503
100p
2501
100p
3504
2R2
3508
2R2
F509
75R3527
3526 75R
3523 75R
BC857B7503
7500BC857B
3509
1K0
3500
1K0
2528
22p
22p
2533
2534
22p
I509
I510
I507
I51525
11
2512
47u
16V
100n
F502
F503
F500
13
VDDA
4
VDDD
14 VOL 16VOR
12
VREF-DAC
15
VSSA
5
VSSD
2 WS
1 BCK
3 DATAI
9 DEEM
8 MUTE
10 PCS
11SFOR0
7SFOR16 SYSCLK
UDA1334BTS7502
F507
I518
I508
I512
I503
I502
F501
I500
I506
I505
I504
68K
3502
820R
2500
3501
1u0
1u0
25053503
1K0
820R
33K
3505
1u0
3506
2506
4n7
2507
1K5
3507
BC847B7501
F512
I513
I517
I511
I516I514
3511
3510
68K
2508
1u0
820R
1u0
2513
1K0
3516
3514
3515
820R
2514
33K
1u0
2515
4n7
1K5
3517
7504BC847B
I501 5502
100n
2502
100n
2504
22p2529
253622p
22p2535
252122p
2509100p
2510100p
22p
2532
2527
22p
22p
2524
22p
2520
F519
F521
F518
F514
F506
F505
F516
F517
5508
5507
5505
5504
2538
68p
2537
180p
2530
68p
180p
2531
68p
2526
2525
68p
180p
2522
180p
2523
3512 100R
100R3513
3520
180R
3u3
5512
3u3
5514
180R
3522
3519
180R
5511
180R
3521
3u3
5513
3u3
I522
I523
I521
AR1
AR2
BLUE|U
RED|V
CVBS_VCR
TV_IRQ
MOJO_SYSCLK
IRQ
R1
L1
SDA
I2C_TV_SDA
I2C_TV_SCL
SCL
MOJO_I2S_OUT_SCK
MOJO_I2S_OUT_WS
MOJO_I2S_OUT_SD
C_CVBS
G|Y
B|Pb
R|Pr
K5 K5
3139 123 6147.1 G_16220_015.eps070206
24LC4.31E AB 7.Circuit Diagrams and PWB Layouts
IBO Zapper Panel: Front End
NC
1
NC
1
012
E
SCL
WC
SDA
NC
RFIN
MT
LB
MT
MB
HB
OSC
OSC
OSC
PLL5
33
MP
EG
-TS
(P
AR
ALL
EL)
I2C
MP
EG
-TS
(S
ER
IAL)
MP
EG
-TS
(S
ER
IAL)
JTA
G
4MH
z
TUNER
EEPROM
COFDMCHANNEL DECODER
4MHz
K7
K1
K1
K1
K1
K7K7K7K7K7K7K7K7
K7
K7
K7
K1
K1
K1
K1
K1
K1
3V2 5V5V 5V
1V3 1V3
3V2
1V3 1V6
3V2
1V3 1V6
2V8
1V3
1V5
1V5
0V7
0V6
2V3
3V2
4V6
4V6
5V
5V
0V
0V
0V
2V4
2V4
2V22V22V22V22V22V22V22V2
1V7
1V3
0V
0V
2V2
3V3
3V3
K7K7K7K7K7K7K7K7
K7
K7
K7
RES
3V2
1 2 3 4 5 6 7 8 9 10 11 12 13
1 2 3 4 5 6 7 8 9 10 11 12 13
A
B
C
D
E
F
G
H
I
A
B
C
D
E
F
G
H
I
1600 A21601 F61603-1 H131603-2 H122607 D102608 D92609 D92610 D102611 D102612 D102613 D112614 D112615 D82617 D82618 D102619 D112620 D112621 D112622 D32623 D42624 E132625 D72626 E22627 E52628 F62629 F72630 F12631 F62632 F52633 G52634 G62635 H42636 D22637 D23606 C43607 C43608 E83609 E63610 E63611 E43612 E13613 E23614 E63615 E63616 F43617 F63618 F53619 F53620 G33621 G83622-1 G113622-2 G113622-3 G113622-4 G113623 G33624-1 G113624-2 G113624-3 G113624-4 G113625 G83626 G53627 G53629 G83630 H83631 H83632 H53633 H53634 I33635 E113636 C63637 C63638 C73639 C73640 D63641 D63642 D73643 D73644-1 G113644-2 H113644-3 H113644-4 H113645 G84605 E74606 E34607 E54610 I34611 C35600 C105601 D135602 D35603 H45604 C27600 E87601-1 E27601-2 F27602 H47605 C67606 D6F600 C2F603 D3F604 F5F605 F5F606 F5F607 F7F608 F7F609 F8F610 G7F611 H5F612 H5F613 I3I601 D4I602 C5I603 H12
I604 E8I605 E4I606 E5I607 E6I614 G8I615 G12I616 G4I618 G12I619 G12I620 G12I621 G12I622 G12I623 G12I624 G12I625 G12I626 H12I627 H12I628 H11I629 H11I631 E7I632 E2I633 C7I634 D7I635 C3
N.C.
N.C.
I6355604
+5Vclean60R
10u26
36
4611
2637
100n
18
2
20
468
10121416 15
17
1603-2ROW_2
FTSH
1
19
35791113
84
7
1603-1ROW_1
FTSH
(32Kx8)Φ
EEPROM
7602M24256-BWMN6
123
6 5
+5V
+3V3FE
+3V3FE
+5Vclean
+3V3
3645
10K
I634
315
474AHC1GU04GW
7606
2
330R
3643
220K
3641
330R
3642
3640
I633
680K
+3V3
74AHC1GU04GW2
315
4
7605
3639
390R3637
220K
3638
330R
3636
680K
+3V3 +3V3FE
F613
+3V3FE
+3V3FE
+1V8FE
+5Vclean +5Vclean
+1V8FE
+5Vclean+5V +5Vclean
+5Vclean
+5V
+5V+5V
+5Vclean
I60333R4 5
I632
3644-4
I631
4610
I628
100n
2607
33R
3635
F604
F606
F610
F605
F607
F600
F603
33R
3621
3607
100R
I627
I626
3 6
I625
3644-2 2 7
3644-3 33R
1 8
33R
1 8
3644-1 33R
2 73624-1 33R
633R3624-2
3624-3 33R333R3624-4 4 533R3622-1 1 8
2 73622-3 3 63622-2 33R
4 533R
3622-4 33R
2632
10p
2630
100n
3612
4K7
I629
2626
46063613
100n
100K
7
8
4
7601-2
LM393D5
6
3
21
8
4
7601-1
LM393D
I624
5600
I623I622
I620I621
I618I619
I615
F611
F612
F608
I602
I604
I607I605 I606
I616
4607
I601
3610
4K7
3615
1K02628100n
3617
220R
100R
3633
3632
100R
100R3631
3630100R
2624
100n
5601
16V
47u26
14
2621
47u
16V
3606
100R
100R3629
100R3625
4605
100n2625
2627
100n
3611
680K
3616
100K
3609
4K7
3614
100K
3623
4K7
VT
UN
11
XT
AL
10
3620
4K7
1719
18
2 3 4 6
PLL
7
SC
L8
SD
A9
AG
C5
DC
-PW
R1
IF-1
14
IF-2
15
IF-A
GC
13
IF-O
UT
12
16
1600TD1316/SPHP
5603
3618
100K
100K
3619
3634
470R
2622
47u
16V
2623
100n
5602
F609
I614
2629
100n
100n
2631
100n
2635
3626
2K7
2K7
3627
33p
2633
2634
33p
AT-49
1601
100n
2609
2608
100n
100n
2615
2613
100n
2612
100n
100n
2611
2610
100n
100n
2620
2619
100n
100n
2618
2617
100n
3608
10K
XIN
XOUT55
XOUT
VS
S3
VS
S4
29
VS
S4
VS
S5
40
VS
S5
VS
S6
45
VS
S6
VS
S7
52
VS
S7
VS
SA
_AD
CV
SS
A_A
DC
63
VS
SA
_OS
CV
SS
A_O
SC
56
VS
S_P
LL_A
DC
VS
S_P
LL_A
DC
58
54XIN
VD
DI1
8_1
VD
DI1
8_2
VD
DI1
8_2
22
VD
DI1
8_3
VD
DI1
8_3
42
VD
DI1
8_4
VD
DI1
8_4
50
VIM61
VIM
VIP62
VIP
VS
S1
7
VS
S1
VS
S2
15
VS
S2
24
VS
S3
VD
D18
_PLL
_AD
C
VD
D33
_AD
CV
DD
33_A
DC
64
VD
DA
18_O
SC
VD
DA
18_O
SC
53
VD
DA
18_P
LL
57
VD
DA
18_P
LL
VD
DA
33_A
DC
VD
DA
33_A
DC
60
VD
DE
33_1
VD
DE
33_1
19
VD
DE
33_2
VD
DE
33_2
34
VD
DE
33_3
VD
DE
33_3
47
VD
DI1
8_1
5
TCK
TDI17
TDI
TDO20
TDO
TESTTEST12
TMS16
TMS
TRST14
TRST
UNCOR33
UNCOR
59
VD
D18
_PLL
_AD
C
3
SDA8
SDA
SDA_TUNSDA_TUN4
S_DENS_DEN30
S_DOS_DO32
S_OCLKS_OCLK31
S_PSYNCS_PSYNC28
S_UNCORS_UNCOR27
18TCK
25
GPIO3GPIO326
OCLK37
OCLK
PSYNC35
PSYNC
SACLK51
SACLK
SADDR011
SADDR0
SADDR110
SADDR1
SCL6
SCL
SCL_TUNSCL_TUN
44DO4DO4DO5
46DO5DO6
48DO6DO7
49DO7
ENSERI13
ENSERI
GPIO021
GPIO0
GPIO1GPIO123
GPIO2GPIO2
AGC_IF
AGC_TUN1
AGC_TUN
CLR_CLR_9
DEN36
DEN
DO0 38DO0DO1
39DO1DO2
41DO2DO3
43DO3
TDA10046AHT7600
AGC_IF2
UNCOR
TDA_VALID
TDA_SYNC
TDA_CLK
TDA_DAT(0)TDA_DAT(1)TDA_DAT(2)TDA_DAT(3)TDA_DAT(4)TDA_DAT(5)TDA_DAT(6)TDA_DAT(7)
dsp_EEPROM_WP
UNCOR
4MHz_MOJO
TDA_CLK
TDA_VALID
TDA_SYNC
FE_LOCK
TDA_DAT(0)TDA_DAT(1)TDA_DAT(2)TDA_DAT(3)TDA_DAT(4)TDA_DAT(5)TDA_DAT(6)TDA_DAT(7)
COMP_OUT
I2C_LOCAL_SCL
I2C_TDA_SCL
I2C_TDA_SDA
STV_TDO
10046_TDO
JTAG_TMS
JTAG_TRST
I2C_LOCAL_SDA
RES
RES
RES
OPTION
RE
S
RESET_FE_n
COMP_OUT
JTAG_TCK
FRONT ENDK6 K6
3139 123 6147.1 G_16220_016.eps070206
Circuit Diagrams and PWB Layouts 25LC4.31E AB 7.
IBO Zapper Panel: Common Interface
INTERRUPTS
UCSG
INTERFACE
TS INTERFACE
I C2
MANAGEMENT
G3
12
3EN23EN1
ENC1
1D
ENC1
1D
PCMCIA
CONTROLLER
68p PCMCIA
CONNECTOR
LATCH
LATCH
BUS TRANSCEIVER
CURRENT
SWITCH
COMMON INTERFACEK7 K7
3139 123 6147.1 G_16220_017.eps070206
K2, K7
K2
K1
K2
K1, K2
K1, K2
K1, K2
K1, K2
K1, K2
K1, K2
K1, K2
K1, K2
K1, K2
K1, K2
K1
K1
K1
K6
K6
K6
K6
K6
K6
K6
K6
K6
K6
K6
K7
K7
K7
K1
K1
K1
K1
K1
K1
K1
K1K
1, K
6
K1,
K6
K1
K1,
K6
K6
K1, K2
K1, K2K1, K2K1, K2K1, K2K1, K2K1, K2K1, K2
K1
K1
0V3V23V23V23V20V3V23V2
3V20V
0V3V23V23V23V20V
3V23V2
0V3V2
3V2
3V2
0V0V
0V
0V
0V3V20V0V3V20V3V2
3V2
0V
0V0V0V0V0V0V0V
0V0V0V0V0V0V0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V
2V8
0V
0V
0V
0V
0V
0V
0V
0V
0V
4V6
4V6
1V6
0V
2V2
2V2
2V2
2V2
2V2
2V2
2V2
1V3
2V2
1V5
0V
1V3
2V2
2V2
2V2
2V2
2V2
2V2
2V2
2V2
2V3
2V5
0V
3V2
3V2
3V2
0V
0V
3V2
3V2
3V2
3V2
3V2
3V2
0V
0V
3V2
3V2
3V2
0V
0V
0V
0V
0V
0V
0V
0V
0V
3V2
3V2
3V2
3V2
3V2
3V2
3V2
5V
5V
0V
5V
5V
3V2
3V2
3V2
3V2
5V 5V
K1, K2K1, K2K1, K2K1, K2K1, K2K1, K2K1, K2
K1, K2K1, K2K1, K2K1, K2K1, K2K1, K2K1, K2
K1, K2
1%
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
A
B
C
D
E
F
G
H
I
J
K
L
M
N
A
B
C
D
E
F
G
H
I
J
K
L
M
N
1700-A D181700-B D182700 C142701 E142702 G182703 G182704 H122705 H182706 K132707 J32708 M22709 M22710 M22711 M22712 M22713 M22714 I32715 J143700 B43701 B43702-1 D43702-2 D43702-3 D43703-1 E43703-2 E43703-3 E43703-4 E43704 D203705-1 E43705-2 E43705-3 F43705-4 F43706 G193707 G193708 G173709 I33710 J33711 J13712 J43713 J23715 I93716 I93717 I93718 I103719 I103720 I103721 I103722 I93723-1 I143723-2 I143723-3 I143723-4 I143724-1 I143724-2 I143724-3 I143724-4 I143725 I143726 I143727 B83728 C83729 C83730 C83731 C83732 C83733 C83734-1 D83734-2 D83734-3 D83734-4 D83738 D83739 D83740 D83741 E83742 E83743 E83744 E83745 E83746 E83747 F83748 F83749 C123750 D123751 G173752 F83999 K194700 I55700 G185701 H185702 J135703 L15704 M17700 A57701 C137702 E137703 H137704 H47705 J2F700 I4F701 I5F702 J5F703 K18F704 K19I700 D17I701 D19I702 D17I703 D19I704 D17I705 D19I706 D17I707 D19I708 D17I709 D19I710 E17I711 E19I712 E17I713 E19I714 E17I715 E19I716 E17I717 E19I718 E17I719 E19I720 E17I721 E19I722 E17I723 E19I724 E17I725 E19I726 E17I727 E19I728 E17I729 E19I730 E17I731 E17I732 E17I733 E19I734 E17I735 E19I736 F17I737 F19I738 F17I739 F19I740 F17I741 F19I742 F17I743 F19I744 F17I745 F19I746 F17I747 F19I748 F17I749 F19I750 F17I751 F19I752 F17I753 F19I754 F17I755 F19I756 F17I757 F19I758 F17I759 F19I760 F17I761 F19I762 F19I763 G17I764 I5I766 J2I767 J3I768 J9I769 J9
I770 J2I772 J1I773 J9I775 K5I776 K9I777 L2I778 M2I779 J13
7700
STV0700
3750 33R
3749 33R
3751
4K7
45
3752
4K7
63734-4 47R
3734-3 47R
3
3734-2 47R
27
3748 47R
3747
3746 47R
47R
47R3745
3744 47R
47R3743
3742 47R
47R3741
3740 47R
47R3739
3738 47R
18
3734-1 47R
47R
47R3733
3732
47R3731
3730 47R
47R3729
3728 47R
47R3727
2715
33R
100p
3726
4 5
3725 33R
3 63724-4 33R
2 73724-3 33R
83724-2 33R3724-1 33R1
3723-4 33R4 5
3723-3 33R3 63723-2 33R2 7
1 8
PCMCIA_VPPPCMCIA_AVCC
3723-1 33R
+3V3_STV
PCMCIA_5V
PCMCIA_VPPPCMCIA_AVCC
F703
I779
F704
+3V3_BUF
+3V3_BUF
+3V3_BUF
19
20
VCC
+3V3 +3V3_BUF
18
17161514131211
1
10
GND
74LVC245A7703
2
3456789
PCMCIA_5V
+3V3
+3V
3_S
TV
+3V
3_S
TV
+5V
+3V3_STV
+3V3_STV
1n0
2714
F702
F700
F701
PROCESS CHIP
3999
68R
100n
2710
10K
+3V3_STV
WE|P 15
33WP|IOIS16
3709
GND1 1
34GND2
7172
OE 9
RDY|BSY16VCC117
VPP1 18
30D1
31D232
2D3D4 3D5
4D65
D7 6
26
A425
A5 2423
A6A7
22
A8 12
A911
CE17
D0
8
A1110
A12 21
A1313A1414
A1520
A1619
A2 27
A3
ICME68H-D1121NS
ROW_A1700-A
A029
A128
A10
61 REG
58 RESET
51VCC2
52 VPP2
43 VS1
VS257
59WAIT
D15
64 D8
65D9
35 GND3
68GND4
INPACK60
44IORD
45IOWR
67 CD2
42CE2
66D10
37 D11
38D12D13
3940 D14
41
50A21
53A22
54A23
55 A24
56A25
BVD1|STSCHG6362
BVD2|SPKR
36CD1
ROW_B
ICME68H-D1121NS
1700-B
46 A17A18
4748
A19
49 A20
I763I762
I700 I701I702 I703
I705I707
I704
I709I706I708
I711I713
I710
I715I712I714I716 I717
I719I718
I723I720 I721I722
I725I724
I729I726 I727I728
I731I730
I733I735
I732I734
I737I739
I736
I741I738
I743I740I742I744 I745
I747I749
I746I748
I751I753
I750
I755I752I754
I757I758 I759I756
I761I760
I769
I768
I776
I773
I778
I764
I777
I766
I775
I767
I772
I770
14
VDD
3
+5V
4700
FXO-31FT7704
27M0 2
GND
33R
10K
3712
3705-3
3705-4 33R
3705-2
33R
33R
3705-1 33R
3703-4 33R
3703-3
3703-2
33R
33R
3703-1
3702-1
33R
33R
3702-2
3702-3
33R
2703
100n
2705
100n
100n
2702
PCMCIA_AVCC
PCMCIA_VPP
5701
5700PCMCIA_5V
3706
10K
5702
10u
2706
GN
D
1IN1
2IN2
3ON_
7OUT1
6OUT2
5SET
7705ST890C
8FAULT_
4
3713
2K0 27
07
10u
+3V3_STV
+3V3_CORE
PCMCIA_5V
5704
5703
3701
100R
3700
100R
10K
3707
+3V3_STV
3704
10K
+3V3_STV
10K
3708
2700
100n
100n
2701
2704
100n
Q5 14Q6 13Q7 12
VCC
20
89 D7
GND10
111 OE_
Q0 19Q1 18Q2 17Q3 16Q4 15
D02D13D24D35D46
7 D5D6
Q3 16Q4 15Q5 14Q6 13Q7 12
VCC
20
74LVC573ADB
7701
6D57D68D79 GND
10
11OE_1
19Q0Q1 18Q2 17
74LVC573ADB
D02D13D24D35D4
7702
10u
2713
100n
2712
+3V3
2709
10u
100n
2708
2711
100n
3711
10K
3716
10K
3715
10K
3722
10K
10K
3717
3718
10K
10K
3720
10K
3721
3719
10K
3710
10K
+3V3_CORE
VC
C-T
SO
70VCCEN
122WAITA_
121WAITB_15 WAIT|ACK
97WE_
16 WR|STR
+3V3_STV
38
TD
I
10
TD
O
65
TM
S
8
TR
ST
_
36
VC
C-C
OR
E
109
VC
C-P
RO
C
51
VC
C-T
SI
64
34 RESET
120RSTA
119RSTB
32 SA0
33 SA1
31 SCL
30 SDA
11
TC
K
61 MOVAL 125MOVALA
124MOVALB
88OE_
101RDY|IRQA_
100RDY|IRQB_
17 RD|DIR
123REG_
105MIVALA
104MIVALB
63 MOCLK 118MOCLKA
117MOCLKB
62 MOSTRT 127MOSTRTA
126MOSTRTB
83MDOB7
50 MICLK 110MICLKA
108MICLKB
49 MISTRT 92MISTRTA
91MISTRTB
48 MIVAL
MDOA7
128MDOB0
2MDOB1
4MDOB2
73MDOB3
75MDOB4
77MDOB5
79MDOB6
MDO7
1MDOA0
3MDOA1
5MDOA2
74MDOA3
76MDOA4
78MDOA5
80MDOA6
84
MDIB7
53 MDO0
54 MDO1
55 MDO2
56 MDO3
57 MDO4
58 MDO5
59 MDO6
60
MDIA7
93MDIB0
95MDIB1
98MDIB2
102MDIB3
106MDIB4
111MDIB5
113MDIB6
115
94MDIA0
96MDIA1
99MDIA2
103MDIA3
107MDIA4
112MDIA5
114MDIA6
116
40 MDI0
41 MDI1
42 MDI2
43 MDI3
44 MDI4
45 MDI5
46 MDI6
47 MDI7
37
GN
D-C
OR
E
86
GN
D-D
VB
2
9
GN
D-P
RO
C
39
GN
D-T
SI
52
GN
D-T
SO
14 INT
89IORD_
90IOW_R
CE2A_
85CE2B_
35 CLK
18 CS
68DATDIR
69DATOE_
13 EXTCS
12 EXTINT
ADLE
67ADOE_
72CD1A_
71CD1B_
7CD2A_
6CD2B_
82CE1A_
81CE1B_
87
A18
23 A19
24 A20
25 A21
26 A22
27 A23
28 A24
29 A25
66
19 A15
20 A16
21 A17
22
TS_VALID
TS_DATA(0)
TS_DATA(1)
TS_DATA(2)
TS_DATA(3)
TS_DATA(4)
TS_DATA(5)
TS_DATA(6)
TS_DATA(7)
MIU_WEN
TDA_DAT(0)
TDA_DAT(1)
TDA_DAT(2)
TDA_DAT(3)
TDA_DAT(4)
TDA_DAT(5)
TDA_DAT(6)
TDA_DAT(7)
TDA_CLK
TDA_VALID
TDA_SYNC
TS_SYNC
TS_CLK
|DATOE
DATDIR
A_MOVALA_MOSTRT
A_|CD2
A_|CE2A_|VS1
PCMCIA_|IORDPCMCIA_|IOWR
A_MISTRT
A_MOCLK
A_RESETA_|WAITA_|INPACK
PCMCIA_|REG
PCMCIA_|OE
PCMCIA_|WEA_|RDY|IRQ
A_MIVALA_MICLK
A_|IOIS16
A_|CD1
ADLE|ADOE
A_|CE1
I2C_LOCAL_SCL
I2C_LOCAL_SDA
VCCEN
A_MICLK
A_MISTRT
A_MIVAL
A_MOCLK
A_MOSTRT
A_MOVAL
PCMCIA_|OE
A_|RDY|IRQ
PCMCIA_|REG
RESET_STV
A_RESET
VCCEN
A_|WAIT
PCMCIA_|WE
ADLE
|ADOE
A_|CD1
A_|CD2
A_|CE1
A_|CE2
STV_CS
DATDIR
|DATOE
STV_INT
PCMCIA_|IORD
PCMCIA_|IOWR
MIU_ADDR(1)MIU_ADDR(0)
PCMCIA_A(10)PCMCIA_A(11)
PCMCIA_A(9)PCMCIA_A(8)
PCMCIA_A(13)PCMCIA_A(14)
PCMCIA_A(12)
MIU_ADDR(10)MIU_ADDR(11)
MIU_ADDR(9)MIU_ADDR(8)
MIU_ADDR(13)MIU_ADDR(14)
MIU_ADDR(12)
MIU_OEN
ST
V_T
DI
PCMCIA_A(7)PCMCIA_A(6)PCMCIA_A(5)PCMCIA_A(4)PCMCIA_A(3)PCMCIA_A(2)PCMCIA_A(1)PCMCIA_A(0)
MIU_ADDR(7)MIU_ADDR(6)MIU_ADDR(5)MIU_ADDR(4)MIU_ADDR(3)MIU_ADDR(2)
A_MDI(2)A_MDI(3)
A_MDI(4)A_MDI(5)A_MDI(6)A_MDI(7)
JTA
G_T
CK
JTA
G_T
MS
JTA
G_T
RS
T
ST
V_T
DO
MIU_RDY
A_MDO(3)A_MDO(4)A_MDO(5)A_MDO(6)A_MDO(7)
A_MDO(0)A_MDO(1)A_MDO(2)
A_MDI(0)A_MDI(1)
PCMCIA_A(9)PCMCIA_A(8)PCMCIA_A(13)PCMCIA_A(14)
PCMCIA_A(12)PCMCIA_A(7)PCMCIA_A(6)PCMCIA_A(5)PCMCIA_A(4)PCMCIA_A(3)PCMCIA_A(2)PCMCIA_A(1)PCMCIA_A(0)
PCMCIA_D(0)PCMCIA_D(1)PCMCIA_D(2)
MIU_DATA(5)MIU_DATA(4)MIU_DATA(3)
PC
MC
IA_D
(0:7
)
PCMCIA_D(0)PCMCIA_D(1)PCMCIA_D(2)
PCMCIA_D(7)
PCMCIA_D(6)PCMCIA_D(5)PCMCIA_D(4)PCMCIA_D(3)
PCMCIA_D(3)PCMCIA_D(4)PCMCIA_D(5)PCMCIA_D(6)PCMCIA_D(7)
PCMCIA_A(0:14)
PCMCIA_A(10)
PCMCIA_A(11)
A_MDI(0)
A_MDI(1)
A_MDI(2)
A_MDI(3)
A_MDI(4)
A_MDI(5)
A_MDI(6)
A_MDI(7)
A_MDO(0:7)
A_MDO(0)
A_MDO(1)
A_MDO(2)
A_MDO(3)
A_MDO(4)
A_MDO(5)
A_MDO(6)
A_MDO(7)
MIU_DATA(0)MIU_DATA(1)MIU_DATA(2)
MIU_DATA(7)
MIU_DATA(6)
MIU_ADDR(0:24)
MIU_ADDR(15)
MIU_ADDR(16)
MIU_ADDR(17)
MIU_ADDR(18)
MIU_ADDR(19)
MIU_ADDR(20)
MIU_ADDR(21)
MIU_ADDR(22)
MIU_ADDR(23)
MIU_ADDR(24)
STV_A25
A_MDI(0:7)
26LC4.31E AB 7.Circuit Diagrams and PWB Layouts
Layout IBO Zapper Panel (Overview Top Side)
3139 123 6147.1 G_16220_018.eps090206
Part 1G_16220_018a.eps
Part 2G_16220_018b.eps
Part 4G_16220_018d.eps
Part 3G_16220_018c.eps
0005 E30006 D30007 C30008 C30009 B30010 B30011 A31100 B91101 B91106 C91301 E11303 A91304 E21401 A91402 A71403 A8
1500 D11600 B21601 A41603 B51700 A62100 C92101 D82102 C82122 B92130 C92131 D82132 C82133 D92201 C72203 C72204 C7
2206 E82214 A52301 D32302 D62303 D32304 E42306 D42308 E52309 D42310 E52311 E52314 A92315 D32316 C32317 C42318 C4
2319 C42320 D52323 D42325 E52328 C42329 D32330 E62331 C32332 E72333 E12334 E12335 E22336 E52337 E52403 B92405 B9
2406 B92411 A92412 A92414 A72415 A72416 B92500 B72501 B72502 B82503 B72504 B82505 B72506 B72507 B82508 B72509 A3
2510 A32511 B82512 B82513 B72514 B72515 B82516 D32517 D12520 E82521 E32522 E82523 E82524 E82525 E82526 E82527 E8
2529 E32530 E82531 E82532 E82533 A32534 A32535 E32536 E32537 E82538 E82543 B72550 E22551 E22557 E12558 E12614 A4
2621 B42622 C32623 B32624 B42625 A42626 C32627 B32628 B32629 A32630 C32631 A32632 A32633 A42634 A42635 B32636 D2
2700 E72701 E62704 E62706 D62707 B72709 C42713 C43100 B93113 B93114 B83115 B83116 B93117 B93119 B83120 B93121 B9
3122 B93123 B93124 B93125 B93126 B93127 B93128 D93131 D93133 B83134 B83135 B83136 D93138 B83139 B93141 C93143 C9
3144 C93145 A63146 A63147 A63148 A63149 A63150 A63156 C83157 C83158 C83159 C73206 A53207 A53209 A53210 A53211 A5
3300 E33301 E33302 D33303 D33304 D33315 E53316 B93317 E53318 D33319 D33320 D33321 D33322 C33323 C33324 D53325 D5
3326 D53327 D53328 D53329 D53330 D43331 C33332 E53333 D53403 B93404 A93405 A93406 A93407 A93408 A93409 B93411 A9
3414 A73415 A73420 B93421 B93422 B93423 B93424 B93500 B83501 B73502 B83503 B73504 B83505 B73506 B83507 B83508 B8
3509 B73510 B73511 B73512 A33513 A33514 B73515 B83516 B73517 B83519 E83520 E83521 E83522 E83526 A33527 A33528 B7
3530 E33533 E33539 E33543 D23544 E23545 E13547 E33548 E13557 E23558 E23559 E23560 E23561 E23562 E23569 E13572 E2
3583 D13584 D13585 D13586 D23587 D23588 D23589 D13590 D13591 D23592 D13593 E13594 E13595 D13596 E13597 D13608 B4
3609 B33610 B33611 B33612 C33613 C33614 B33615 B33616 B33617 A43618 A33619 A33620 B33621 B43622 B43623 B33624 B4
3625 A53626 A33627 A33629 A53630 B33631 B33632 A33633 A33634 B33635 B43636 A43637 A43638 A43639 A43640 D93641 D9
3642 D93643 D93644 B43700 A53701 A53702 B53703 B53705 B53711 B73715 C63716 C63719 C53720 C53723 D63724 D63725 C5
3734 C63749 C53750 C54100 A64101 A64102 B94104 B94105 A84106 B84107 B84109 B84110 B84200 E74201 E74202 E74203 E7
4205 E74212 A54402 B94414 A74415 A74417 A84418 A84503 E14505 E14506 E14508 D24509 E24510 D14511 E14605 A44606 B3
4607 B34610 A34700 B55100 D95101 E85102 E85103 D95200 C75201 C75202 E85203 A55300 E45301 D25302 D55303 E55304 E4
5306 D25307 E65308 D45309 E15401 A95420 B95421 A85422 A85502 B85504 E35505 E35507 E35508 E35511 E85512 E85513 E8
5514 E85600 A45601 C45602 B35603 B35702 D65703 C45704 C46401 A76403 A76503 E26509 D26510 D26511 E16512 D26513 D2
6514 E17100 D97103 A67104 A67200 D77201 D87202 E97203 A57300 D37301 D47302 E67303 E57305 D37306 A97307 C47308 C4
7309 D57310 D57311 D57402 A97403 B97500 B77501 B77502 B87503 B77504 B77507 E17511 E27512 E27521 D27522 D17523 D2
7524 D27525 D27526 D17527 D17528 E17529 D17600 B47601 C37602 B37605 A47606 D97700 B67701 E77702 D77703 D77704 A5
7705 B7
Circuit Diagrams and PWB Layouts 27LC4.31E AB 7.
Layout IBO Zapper Panel (Part 1 Top Side)
Part 1
G_16220_018a.eps090206
28LC4.31E AB 7.Circuit Diagrams and PWB Layouts
Layout IBO Zapper Panel (Part 2 Top Side)
Part 2
G_16220_018b.eps090206
Circuit Diagrams and PWB Layouts 29LC4.31E AB 7.
Layout IBO Zapper Panel (Part 3 Top Side)
Part 3
G_16220_018c.eps090206
30LC4.31E AB 7.Circuit Diagrams and PWB Layouts
Layout IBO Zapper Panel (Part 4 Top Side)
Part 4
G_16220_018d.eps090206
Circuit Diagrams and PWB Layouts 31LC4.31E AB 7.
Layout IBO Zapper Panel (Overview Bottom Side)
3139 123 6147.1 G_16220_019.eps070206
Part 1G_16220_019a.eps
Part 2G_16220_019b.eps
Part 4G_16220_019d.eps
Part 3G_16220_019c.eps
2103 C12104 C22105 C22106 C22107 D22108 D22109 D1
2110 D12111 C12112 C22113 D22114 D22115 D12116 C1
2119 D12120 D12121 D12200 D22202 C22205 C22207 E1
2208 E22209 E22210 E12211 D22212 D12213 E12300 D6
2305 E42312 D72313 D72321 E52322 D62324 D62326 D7
2327 C62413 A12528 E72544 A72559 E72560 E72607 B6
2608 B62609 B62610 B62611 B62612 B62613 B62615 B6
2617 B62618 B62619 B62620 B62637 C82702 C52703 C5
2705 C52708 B52710 B52711 B42712 B52714 B52715 D3
3101 C13112 C23129 D13130 D13132 D13137 D13140 D1
3142 C13151 D13154 C13155 C13160 C23161 D33162 D2
3163 C13164 C13200 D33201 C33202 D33203 C23204 C2
3205 D33212 D23306 D73307 D63311 E53312 E53313 E5
3314 E63334 E53523 E73573 E93574 E93575 C93576 D9
3577 D93578 E73579 C83580 D93581 E73582 D83598 D9
3606 B73607 B73645 B63704 C43706 C53707 C53708 C5
3709 B53710 B43712 B43713 B33717 B43718 B43721 B4
3722 B43726 C33727 B43728 C43729 C53730 C43731 C4
3732 C43733 C43738 C53739 C53740 C53741 C53742 C5
3743 C53744 C43745 C43746 C43747 C43748 C43751 C5
3752 B43999 A54108 D14204 D34213 C34214 D24215 D3
4302 E44303 E44416 A24507 B24512 D94611 A85423 A2
5515 C85528 A75604 C85700 C55701 C56300 E66303 E5
6304 D66305 E46306 E46307 E56308 E56400 A16507 E9
6508 D96515 D97105 D17312 D57518 C97519 C97520 D9
32LC4.31E AB 7.Circuit Diagrams and PWB Layouts
Layout IBO Zapper Panel (Part 1 Bottom Side)
Part 1G_16220_019a.eps
G_16220_019a.eps100206
Circuit Diagrams and PWB Layouts 33LC4.31E AB 7.
Layout IBO Zapper Panel (Part 2 Bottom Side)
Part 2G_16220_019b.eps
G_16220_019b.eps090206
34LC4.31E AB 7.Circuit Diagrams and PWB Layouts
Layout IBO Zapper Panel (Part 3 Bottom Side)
Part 3G_16220_019c.eps
G_16220_019c.eps090206
Circuit Diagrams and PWB Layouts 35LC4.31E AB 7.
Layout IBO Zapper Panel (Part 4 Bottom Side)
Part 4G_16220_019d.eps
G_16220_019d.eps090206
36LC4.31E AB 7.Circuit Diagrams and PWB Layouts
Personal Notes:
E_06532_013.eps131004
Alignments EN 37LC4.31E AB 8.
8. Alignments
Index of this chapter:8.1 General Alignment Conditions8.2 Hardware Alignments8.3 Software Alignments Note: Figures below can deviate slightly from the actual situation, due to the different set executions.
8.1 General Alignment Conditions
Perform all electrical adjustments under the following conditions:Mains voltage and frequency: 110-240 V / 50/60 Hz (26 and 32”), 220-240 V / 50/60 Hz (37” and 42”).Allow the set to warm up for approximately 10 minutes.Test probe: Ri > 10 MΩ; Ci < 2.5 pF.
8.2 Hardware Alignments
There are no hardware alignments foreseen for the IBO Zapper module.
8.3 Software Alignments
With the software alignments of the Service Alignment Mode (SAM) the geometry, white tone and tuner (IF) can be aligned.To store the data: Use the RC button Menu to switch to the main menu and next, switch to ‘Stand-by’ mode.
8.3.1 ADC Gain and Grey Scale Alignment
The table below shows a number of NVM settings used for each model of TV set. Be sure to use the correct editor in the SAM menu (NVM Editor or SC NVM Editor), because the first one is used for the Hercules NVM, and the second one for the SCALER (SC) part of the TV set.
Caution: • Do not change the NVM settings without
understanding the function of each setting, because incorrect NVM settings may seriously hamper the correct functioning of the TV set!
• Do not change the Scaler NVM settings, as this will hamper the DVI / HDMI functionality of the TV set!
• Always note down the existing NVM settings, before changing the settings. This will enable you to return to the original settings, if the new settings turn out to be incorrect.
Table 8-1 ADC gain and grey scale alignment
SDTV ADC Gain settings: Use the NVM Editor in SAM to set these values in the Hercules NVM
Setting Hercules NVM Address (decimal value)
26PF5521D/10/1232PF5521D/10/12
37PF5521D/1026PF7521D/1032PF7521D/1037PF7521D/10 42PF7421D/10
NVM_ADC_GAIN_R 006 135NVM_ADC_GAIN_G 007 185NVM_ADC_GAIN_B 008 165
SDTV Greyscale settings: Use the SC NVM Editor in SAM to set these values in the Scaler NVM
Setting Scaler NVM Address (decimal value)
26PF5521D/10/1232PF5521D/10/12
37PF5521D/1026PF7521D/1032PF7521D/1037PF7521D/10 42PF7421D/10
ADC_RED_OFFSET2 338 070ADC_GRN_OFFSET2 339 070ADC_BLU_OFFSET2 340 070ADC_RED_GAIN 341 150ADC_GRN_GAIN 343 150ADC_BLU_GAIN 345 150
PC Greyscale settings
Setting Scaler NVM Address (decimal value)
26PF5521D/10/1232PF5521D/10/12
37PF5521D/1026PF7521D/1032PF7521D/1037PF7521D/10 42PF7421D/10
ADC_RED_OFFSET2 325 070ADC_GRN_OFFSET2 326 070ADC_BLU_OFFSET2 327 070ADC_RED_GAIN 328 240ADC_GRN_GAIN 330 240ADC_BLU_GAIN 332 240
HD Greyscale settings
Setting Scaler NVM Address (decimal value)
26PF5521D/10/1232PF5521D/10/12
37PF5521D/1026PF7521D/1032PF7521D/1037PF7521D/10 42PF7421D/10
ADC_RED_OFFSET2 351 064ADC_GRN_OFFSET2 352 075ADC_BLU_OFFSET2 353 064ADC_RED_GAIN 354 180ADC_GRN_GAIN 356 180ADC_BLU_GAIN 358 180
AlignmentsEN 38 LC4.31E AB8.
8.3.2 Panel Size Settings
The table below shows the NVM settings for panel selection, based on panel size and manufacturer. Use the SC NVM editor in the SAM menu to change the panel code at decimal address 320.Caution: • Make sure to choose the right panel, because incorrect
NVM settings may seriously hamper the correct functioning of the TV set!
• Always note down the existing NVM settings, before changing the settings. This will enable you to return to the original settings, if the new settings turn out to be incorrect.
Table 8-2 Panel size settings
8.3.3 Options
Options OP1...OP7 in the SAM menu can be used for quickly restoring 64 features or settings of the HERCULES part of the TV set to their original default factory values (8 groups of 8 features/settings each). When the decimal value of one option byte OP1...OP7 is changed (see the first table below) then a group of 8 bits, representing 8 HERCULES options or features, is changed as well (see the second table below for a detailed description of the features or settings that are changed).The second table shows which option byte (OP1...OP7) represents which group of 8 option bits. Each bit (0...7) switches a particular HERCULES feature or setting ON or OFF, depending on its value (1 or 0).It is also possible to change the features or settings mentioned in the second table directly at bit level, by means of the NVM Editor in the SAM menu. In the NVM Editor, first the correct NVM address (ADR) has to be entered, then the correct value (VAL, 1 or 0) for each bit (see second table), and finally the settings have to be stored (STORE). For quickly restoring the HERCULES part of the TV set to its original factory settings, however, it is more convenient to simply enter the default factory settings OP1...OP7 that are given in the first table below. How to do this, is described in the next paragraph.
How to Change an Option ByteAs has been explained above, an Option byte (OP) represents a number of different HERCULES options. Changing these bytes directly makes it possible to set all HERCULES options very fast. All options are controlled via seven option bytes. Select the option byte (OP1.. OP7) with the Menu Up/ Down keys, and enter the new (decimal) value. For the correct Factory Default settings, see the first table below. For more detailed information, see the second table. Leaving the Option submenu saves the changes in the Option Byte settings. Some changes will only take effect after the set has been switched “off” and “on” with the AC power switch (cold start).
Table 8-3 Option codes OP1...OP7
How to Change Options at Bit LevelIf you wish to know which features or settings of the HERCULES are changed via OP1...OP7, or if you want to change each option or feature bit by bit, use the more detailed table below.Note: the table below contains only part of the NVM settings that can be changed. A second range of settings and features can be found in Chapter 5 of this manual, in table NVM Default values. The settings mentioned there can only be changed via the NVM editor. For further settings, see also the table “ADC Gain and Grey scale alignment” elsewhere in this manual.
Option table for panel size settings
Manufacturer Size (inch) Panel code (hex)
LPL 26 1A
LPL 32 0F
LPL 37 0E
LPL 42 22
Sharp 26 11
Sharp 32 10
AUO 26 08
AUO 32 09
AUO 37 0A
Option table for quickly restoring the HERCULES to its Factory Default settings
Model number 26PF5521D/10/1232PF5521D/10/12 37PF5521D/10
26PF7521D/1032PF7521D/1037PF7521D/1042PF7421D/10
OP1 156 156 156
OP2 231 231 231
OP3 47 47 111
OP4 81 113 113
OP5 252 252 252
OP6 27 27 27
OP7 19 19 19
Options (can be changed only via the
SAM menu)
Total decimal value for each option per model number
Alignments EN 39LC4.31E AB 8.
Table 8-4 Option codes in detail, at bit level
Option byte & bit table for restoring the TV set to its original Factory Default settings via the NVM Editor in the SAM menu
Model number 26PF5521D/10/1232PF5521D/10/12 37PF5521D/10
26PF7521D/1032PF7521D/1037PF7521D/1042PF7421D/10
OP1 Description of feature/option to be switched ON or OFFbit 7 (msb) OP_PHILIPS_TUNER 1 1 1
bit 6 OP_FM_RADIO 0 0 0
bit 5 OP_LNA 0 0 0
bit 4 OP_ATS // for EU 1 1 1
bit 3 OP_ACI 1 1 1
bit 2 OP_UK_PNP 1 1 1
bit 1 OP_VIRGIN_MODE 0 0 0
bit 0 (lsb) OP_CHINA 0 0 0
Total DEC Value 156 156 156
Total HEX Value 9C 9C 9C
OP2bit 7 (msb) OP_HDMI-2X 1 1 1
bit 6 OP_IBEX (for DVB) 1 1 1
bit 5 OP_CHANNEL_NAMING 1 1 1
bit 4 OP_LTI (Lum Transcient Improvmt) 0 0 0
bit 3 OP_TILT 0 0 0
bit 2 OP_FINE_TUNING 1 1 1
bit 1 OP_BACKLIGHT_DIMMING (for Malibu only) 1 1 1
bit 0 (lsb) OP_HUE 1 1 1
Total DEC Value 231 231 231
Total HEX Value E7 E7 E7
OP3bit 7 (msb) OP_EW_FUNCTION 0 0 0
bit 6 OP_PIXEL_PLUS (for Option A) 0 0 1
bit 5 OP_SCL_RECOVERY 1 1 1
bit 4 OP_SPLITTER // temp 0 0 0
bit 3 OP_VIRTUAL_DOLBY 1 1 1
bit 2 OP_WIDE_SCREEN 1 1 1
bit 1 OP_WSSB 1 1 1
bit 0 (lsb) OP_OP_ME5 // OP_ME5 - 5/6 local buttons implementation 1 1 1
Total DEC Value 47 47 111
Total HEX Value 2F 2F 6F
OP4bit 7 (msb) OP_LIP_SYNC (for PDP only) 0 0 0
bit 6 OP_HD 1 1 1
bit 5 OP_1000P_TEXT 0 1 1
bit 4 OP_DELTA_VOLUME 1 1 1
bit 3 OP_TAIWAN_KOREA 0 0 0
bit 2 OP_VOLUME_LIMITER 0 0 0
bit 1 OP_STEREO_DBX 0 0 0
bit 0 (lsb) OP_STEREO_NICAM_2CS 1 1 1
Total DEC Value 81 113 113
Total HEX Value 51 71 71
OP5bit 7 (msb) OP_AV1 1 1 1
bit 6 OP_AV2 1 1 1
bit 5 OP_AV3 1 1 1
bit 4 OP_CVI 1 1 1
bit 3 OP_SVHS2 1 1 1
bit 2 OP_SVHS3 1 1 1
bit 1 OP_HOTEL_MODE 0 0 0
bit 0 (lsb) OP_SIMPLY_FACTORY=OP_BTSC_AVSTEREO 0 0 0
Total DEC Value 252 252 252
Total HEX Value FC FC FC
OP6bit 7 (msb) OP_PERSONAL_ZAPPING 0 0 0
bit 6 OP_SMART_SURF 0 0 0
bit 5 OP_FMTRAP 0 0 0
bit 4 OP_COMBFILTER 1 1 1
bit 3 OP_ACTIVE_CONTROL 1 1 1
bit 2 OP_VIDEO_TEXT 0 0 0
bit 1 OP_LIGHT_SENSOR 1 1 1
bit 0 (lsb) OP_TWIN_TEXT 1 1 1
Total DEC Value 27 27 27
Total HEX Value 1B 1B 1B
OP7bit 7 (msb) OP_TIME_WIN1 0 0 0
bit 6 OP_DVB_USB = OP_MALAY 0 0 0
bit 5 OP_AMBILIGHT 0 0 0
bit 4 OP_COLUMBUS 1 1 1
bit 3 OP_DUMMY6 0 0 0
bit 2 OP_DUMMY7 0 0 0
bit 1 OP_WEST_EU 1 1 1
bit 0 (lsb) OP_MULTI_STANDARD_EUR 1 1 1
Total DEC Value 19 19 19
Total HEX Value 13 13 13
Circuit Descriptions, Abbreviation List, and IC Data SheetsEN 40 LC4.31E AB9.
9. Circuit Descriptions, Abbreviation List, and IC Data Sheets
Index of this chapter:9.1 Introduction9.2 IBO Zapper 2 Module9.3 Block diagram IBO Zapper 2 Module9.11 Abbreviation List9.12 IC Data Sheets
9.1 Introduction
The LC4.31 chassis is a global chassis for the year 2006. It is the successor of the LC4.3 chassis and covers screen sizes of 26, 32, 37 and 42 inch (in 16:9 ratio). It has two new stylings, called ME5FL and ME6 (see front page). There are two different picture qualities available, depending on the model: Pixel Plus in the xxPF7x21/10 models, and Digital Crystal Clear in the xxPF5321/10 and /12 models.
The Digital Video Broadcasting (DVB) TV sets/models discussed in this manual are a combination of a standard TV set and an IBO Zapper 2 module.
Note: • Only information that is related ito the IBO Zapper 2
module is published in this manual. For the other information, see the relevant chassis manual (order code on front page).
9.2 IBO Zapper 2 Module
The “IBO Zapper 2” module is meant to receive, process, and transfer Digital Video Broadcasting-Terrestrial (DVB-T) signals to the internal TV interface for audio, video, and control. The “IBO Zapper 2” is intended for use in combination with an analogue TV chassis.Differences with respect to the earlier version of the IBO zapper module are:• The PCMCIA connector is different.• The USB connector has been removed.
9.3 Block diagram IBO Zapper 2 Module
Figure 9-1 Block Diagram IBO zapper 2 module
GATJE UIM LATX MARDS
RI BSU 1C2I TESER 232SR
XUMED RCSED
oiduA-1GEPMredoced
oediV-2GEPMredoced
UPC
OJOMxx38xnp
TS
inI2
C0
Sm
Car
d1S
mC
ard0
SP
DIF
I2SA
nalog Video O
ut
MARDSBM 61
HSALFBM 4
ni FH
FI golana C2I CGA
RENUT dirbyh6131DT
FI latigid ni FI
renut C2I CGA
MDFOC64001
tuo ST
C2I
ni ST
C2I tuo ST
LORTNOC
F/I UPC+hctaL
reviecsnarT
:)VT( yramirp
cnysSBVC+ )4:4:4( BGR
ro )4:4:4( rPbPY
:)RCV( yradnucesSBVC
oidua latigid
oiduaCAD
R,L oidua golana
232SR/LTT 232SR
CGA
C2IMORPEE
)sgnittes resu(
USPV21
hctiws A/D
GATJGATJ
.I.CA0070VTS
DSO
-AICMCProtcennoc
FEH+XUM
C2I
V5
QRI
FI golana
ni FH
eludom reppaZOBI
ffO/nO rewoP
E_14970_036.eps011105
Circuit Descriptions, Abbreviation List, and IC Data Sheets EN 41LC4.31E AB 9.
9.4 PNx83xx MOJO
The MOJO is a source decoder chip targeted for very low cost application in integrated digital televisions.The device contains all hardware and software to be able to decode and display MPEG2 transport streams, including: • Descrambling• Demultiplexing• Audio / video decompression • Video encoding.• Overlay graphics provisions
Some features of the MOJO are:• 32-bit PR1910 core operating at 120 MHz.• 16-bit memory and peripheral interface to connect ROM,
NOR Flash and various peripherals.• Sixteen external interrupt inputs shared with PIO lines.• Several embedded peripheral units with physical interfaces
to:– Two UART (RS-232) data ports– Two I2C master / slave transceivers– Two smart-card reader interfaces– One Integrated Conditional Access Module interface
• Supports parallel and serial transport stream input interfaces
9.5 Front End
The front end of the “IBO Zapper” module is almost identical to the “IBO+” module as used in the A10E with the exception that the Transport Streams that come from the COFDM demodulator are now fed through the PCMCIA controller first. The PCMCIA controller receives encrypted Transport Streams from the COFDM demodulator. Via the PCMCIA card, these encrypted Transport Streams are decrypted, and transported to the MOJO.
9.6 Back End
The MOJO is the main building block of the back-end of the “IBO Zapper” module. The IC decodes the MPEG-2 stream into analogue video and digital audio.
9.6.1 Transport Stream Input
The Transport Stream input is according to MPEG2 standard. In the “IBO Zapper 2”, only 8-bit parallel is supported. The used TS names are TDA_DATA.
9.6.2 Video Outputs
The MOJO has two analogue video outputs:• Primary (TV): YUV + RGB• Secundary (VCR): CVBS
The primary MOJO output is used as input for the TV display and is fed either to the Hercules YUV/RGB input (pins 78/79/80), for teletext insertion purposes, or directly to the analogue Scaler input D2/C2/B2. The signal path is as follows:switch 7G09 chooses between the SCART1 input signal and the YUV/RGB output of the MOJO. The signal selected by switch 7G09 is passed on to one group of the inputs of switch 7E00. The other group of inputs of this switch is connected to the three analogue input pins of the DVI-D connector. The output signal of switch 7E00 is passed on to the Hercules input, pins 78/79/80 and to the Scaler input D2/C2/B2 via switch 7E01 in the MUX-SYNC interface. This switch chooses between the MOJO output signal and the Hercules output signal, which is used for SDTV signals (analogue terrestrial TV reception via the analogue receiving part). The Hercules output is not only used for SDTV signals, but also for MOJO output signals that
were first sent to the Hercules input for e.g. teletext reinsertion purposes before they are passed on to the Scaler. The secundary MOJO output, which delivers CVBS signals, is used for monitoring purposes or for recording via the SCART 2 output of the TV set. The signal path of the secundary MOJO output is as follows:the CVBS/VCR signal coming from the MOJO is sent to the Hercules video switch input, pin 58, via switch 7G07. The signal then appears on one of the outputs of the Hercules video switch, pin 48, and is passed on via switches 7219 and 7G10 to pin 19 of SCART 2, which is the CVBS/monitor output.For further details, see the manuals of the original TV sets on which the various models of IBO zappers are based.
9.6.3 Audio Outputs
The MOJO has two audio output interfaces:• SPDIF Out: The SPDIF sound output goes directly to a
connector on the back of the module.• I2S Out: This digital sound output is fed through a DAC and
the analogue L/R signals are directely fed into the Hercules.
9.7 IBOLink Interface
The IBOLink™ approach is such that the conventional TV microcontroller is re-used when digital functionality is added. In principle, the TV can still operate without the bolt-on module. The IBOLink™ software is added to the TV-set software, and is operating as a software bridge.
9.8 Control Interface
The “IBO Zapper” is connected as a slave I2C device, The I2C bus should be +5V tolerable and operating at 100kHz(MAX). The “IBO Zapper” module slave address is 0xE4 (similar to IBO+) but is configurable via IBOLink.
All communication from digital module to Television chassis has to be initiated via an active low hardware interrupt line from the digital module.
9.9 UART Interface
The UART interfaces (Universal Asynchronous Receiver And Transmitter) are serial interfaces, which are used to transfer data and commands between two devices.
The “IBO Zapper” system uses an UART interface for serial communication with a PC for: • Diagnostic SW for Service or Production• SW uploading for Service or Development
9.10 Power Supply IBO Zapper Module
The “IBO Zapper” module operates from a single 12V supply provided by the TV chassis. All other voltages that the module needs are derived from the +12V. The module has four different physical power states: • “Off” State. • “Passive Standby”.• “Active Standby”. • “On” State.
Please refer to the LC4.31E AA manual for more information.
Circuit Descriptions, Abbreviation List, and IC Data SheetsEN 42 LC4.31E AB9.
9.11 Abbreviation List
0/6/12 SCART switch control signal on A/V board. 0 = loop through (AUX to TV), 6 = play 16:9 format, 12 = play 4:3 format
1080i 1080 visible lines, interlaced1080p 1080 visible lines, progressive scan2CS 2 Carrier Sound (or 2 Channel Stereo)480i 480 visible lines, interlaced480p 480 visible lines, progressive scanACI Automatic Channel Installation:
algorithm that installs TV channels directly from a cable network by means of a predefined TXT page
ADC Analogue to Digital ConverterAFC Automatic Frequency Control; Control
signal used to tune and lock to the correct frequency
AGC Automatic gain control (feedback) signal to the tuner. This circuit ensures a constant output amplitude regardless of the input amplitude
AM Amplitude Modulation; A "data encoding to a carrier" method, such that the carrier amplitude is proportional to the data value
AP or A/P Asia PacificAR Aspect Ratio: 4 by 3 or 16 by 9ASD Automatic Standard DetectionAV External Audio VideoB-SC1-IN Blue SCART1/EXT1 inB-SC2-IN Blue SCART2/EXT2 inB-TXT Blue TeleteXTB/G Monochrome TV system. Sound
carrier distance is 5.5 MHz. B= VHF-band, G= UHF-band
C-FRONT Chrominance front inputCBA Circuit Board Assembly (also called
PCB or PWB)CL Constant Level: audio output to
connect with an external amplifierCLUT Colour Look-Up TableCOFDM COLour LUMinance Baseband
Universal Subsystem. IC performing noise reduction and 2D/3D comb filtering
ComPair Computer aided rePair. A tool for diagnosing a TV through a PC controlled interface
CSM Customer Service ModeCVBS Composite Video and Blanking Signal;
A single video signal that contains luminance, colour, and timing information
CVBS-EXT CVBS signal from external source (VCR, VCD, etc.)
CVBS-INT CVBS signal from internal TunerCVBS-MON CVBS monitor signalCVBS-TER-OUT CVBS TERrestrial OUTput signalDAC Digital to Analogue ConverterDBE Dynamic Bass Enhancement: extra
low frequency amplificationDFU Directions For Use: Owner's manualDNR Dynamic Noise Reduction / Digital
Noise Reduction; Noise reduction feature of the set
DRAM Dynamic RAM; dynamically refreshed RAM
DSP Digital Signal ProcessingDST Dealer Service Tool; Special remote
control designed for dealers to enter e.g. service mode (a DST-emulator is available in ComPair)
DTS Digital Theatre System; A multi-channel surround sound format, similar to Dolby Digital
DVB Digital Video Broadcast; A method of transmitting digital audio and video, based on MPEG2
DVB-T DVB-Terrestrial; HDTV standard for the EU
DVD Digital Versatile DiscEEPROM Electrically Erasable and
Programmable Read Only MemoryEPG Electronic Program Guide: system
used by broadcasters to transmit TV guide information (= NexTView)
EU EuropeEXT EXTernal (source), entering the set by
SCART or by cinches (jacks)FBL Fast BLanking; DC signal
accompanying RGB signals. To blank the video signal when it is returning from the right side of the screen to the left side. The video level is brought down below the black video level
FM Field Memory; A memory chip that is capable of storing one or more TV picture fields / Frequency Modulation; A technique that sends data as frequency variations of a carrier signal
FRC Frame Rate ConverterH H_sync to the module HA Horizontal Acquisition; horizontal sync
pulseHD High DefinitionHP HeadPhoneI Monochrome TV system. Sound
carrier distance is 6.0 MHz. VHF- and UHF-band
IBO Intelligent Bolt OnI2C Integrated IC busI2S Integrated IC Sound busIC Integrated CircuitIF Intermediate FrequencyInterlaced Scan mode where two fields are used
to form one frame. Each field contains half the number of the total amount of lines. The fields are written in "pairs", causing line flicker.
IR Infra RedIRQ Interrupt ReQuestLast Status The settings last chosen by the
customer and read and stored in RAM or in the NVM. They are called at start-up of the set to configure it according to the customer's preferences
LATAM LATin AMericaLC04 Philips chassis name for LCD TV 2004
projectLCD Liquid Crystal DisplayLED Light Emitting Diode; A semiconductor
diode that emits light when a current is passed through it
L/L' Monochrome TV system. Sound carrier distance is 6.5 MHz. L' is Band I, L is all bands except for Band I
LS LoudSpeakerLVDS Low Voltage Differential Signalling,
data transmission system for high speed and low EMI communication.
M/N Monochrome TV system. Sound carrier distance is 4.5 MHz. M= 525 lines @ 60 Hz, N= 625 lines @ 50 Hz
MOSFET Metal Oxide Semiconductor Field Effect Transistor
MPEG Motion Pictures Experts Group. An ISO/IEC body that has given its name
Circuit Descriptions, Abbreviation List, and IC Data Sheets EN 43LC4.31E AB 9.
to an image compressing scheme for moving video
MSP Multi-standard Sound Processor: ITT sound decoder
MUTE MUTE LineNC Not ConnectedNICAM Near Instantaneously Companded
Audio Multiplexing; This is a digital sound system, mainly used in Europe
NORNTSC National Television Standard
Committee. Colour system used mainly in North America and Japan. Colour carrier NTSC M/N = 3.579545 MHz, NTSC 4.43 = 4.433619 MHz (this is a VCR norm, it is not transmitted off-air)
NVM Non Volatile Memory; IC containing data such as alignment values, preset stations
O/C Open CircuitON/OFF LED On/Off control signal for the LEDOSD On Screen DisplayPAL Phase Alternating Line. Colour system
used mainly in Western Europe (colour carrier = 4.433619 MHz) and South America (colour carrier PAL M = 3.575612 MHz and PAL N = 3.582056 MHz)
PC Personal ComputerPCB Printed Circuit Board (or PWB)PCMCIA Personal Computer Memory Card
International AssociationPIG Picture In GraphicPIP Picture In PicturePLL Phase Locked Loop. Used, for
example, in FST tuning systems. The customer can directly provide the desired frequency
Progressive Scan Scan mode where all scan lines are displayed in one frame at the same time, creating a double vertical resolution.
PWB Printed Wiring Board (also called PCB or CBA)
RAM Random Access MemoryRC Remote Control transmitterRC5 or 6 Remote Control system 5 or 6, the
signal from the remote control receiver RGB Red, Green, and Blue colour space;
The primary colour signals for TV. By mixing levels of R, G, and B, all colours (Y/C) are reproduced
RGBHV Red, Green, Blue, Horizontal sync, and Vertical sync
ROM Read Only MemorySAM Service Alignment ModeS/C Short CircuitSCART Syndicat des Constructeurs
d'Appareils Radiorécepteurs et Téléviseurs; This is a 21-pin connector used in EU, that carries various audio, video, and control signals (it is also called Péritel connector)
SCL Serial CLock Signal on I2C busSD Standard DefinitionSDA Serial DAta Signal on I2C busSDRAM Synchronous DRAMSECAM SÉquence Couleur Avec Mémoire;
Colour system mainly used in France and East Europe. The chroma is FM modulated and the R-Y and B-Y signals are transmitted line sequentially. Colour carriers= 4.406250 MHz and 4.250000 MHz
SIF Sound Intermediate FrequencySMPS Switched Mode Power SupplySND SouNDSOPS Self Oscillating Power SupplySPDIF Sony Philips Digital Interface; a
consumer interface, used to transfer digital audio
SRAM Static RAMSTBY STandBYSVHS Super Video Home SystemSW Software or Subwoofer or SwitchTHD Total Harmonic DistortionTS Transport StreamTXT Teletext; TXT is a digital addition to
analogue TV signals that contain textual and graphical information (25 rows x 40 columns). The information is transmitted within the first 25 lines during the Vertical Blank Interval (VBI)
uP MicroprocessorUSB Universal Serial BusVA Vertical AcquisitionVL Variable Level out: processed audio
output towards external amplifierVCR Video Cassette RecorderVGA Video Graphics Array; 640x480 (4:3)WD Watch DogWYSIWYR What You See Is What You Record:
record selection that follows main picture and sound
XTAL Quartz crystalY Luminance signalY/C Y consists of luminance signal,
blanking level and sync; C consists of chroma (colour) signal
YPbPr This is a scaled version of the YUV colour space. Y= Luminance, Pb/Pr= Colour difference signals B-Y and R-Y, other amplitudes w.r.t. to YUV
YUV Colour space used by the NTSC and PAL video systems. Y is the luminance and U/V are the colour difference signals
Circuit Descriptions, Abbreviation List, and IC Data SheetsEN 44 LC4.31E AB9.
9.12 IC Data Sheets
This section shows the internal block diagrams and pin layouts of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs).
9.12.1 Diagram K1, PNx83xx (IC7100)
Figure 9-2 PNx831x architecture and data paths
Block Diagram
Video decoder
Audio decoder
MPEG system processor
Background color
Display
Graphics (OSD)
Cursor
Mixer unit
DENC
Priority int ctrl
USB host
GPIO
Infrared
RS232-UART0
Boot
I2C-unit1
RS232-UART1
ISO7816-UART
Analog video CCIR-656
CPU PR1910
PI Bridge DMA
SDRAM interface
Central Data Unit
MIU
3L
PV
Ds
uB2
L P
VD
Slow PI-Bus (60 MHz)
Fast PI-Bus@120 MHz
Clock, ResetPower down
su
B
CCIR
EJTAG, DSU
16 bit@133 MHz
I2C-unit2
RGB, Y,C,CVBS
E_14970_043.eps020605
Circuit Descriptions, Abbreviation List, and IC Data Sheets EN 45LC4.31E AB 9.
9.12.2 Diagram K6, TDA10046 (IC7600)
Figure 9-3 Internal blockdiagram TDA10046
Block Diagram
SADDR(1:0)
spare inputs
10
SCLSDA
Fsamp
∆Σ
SACLK
I2CInterface
XIN
SCL_TUNSDA_TUN
AGC_TUN
VIM
DIGITAL FRONT-ENDAND OFDM
DEMODULATION
GPIO(3:0)
DSP CORE
SYNCHRONISATION
Frequency, Time, Frame RecoveryFFT Window positioning
TPS decoding
CHANNEL DECODER
VBER CBERCPT_UNCOR
MPEG-TS(parallel)
CHANNEL ESTIMATIONAND CORRECTION
OFDM Spectrum
Confidence (I,Q)
CarrierRecovery
VIP
XOUT
TimeRecovery
ACIFiltering
DigitalAGC
DynamicTimeShift
FFT2K/8K
CoarseTime
Estimator
Dual AGC
∆Σ
AGC_IF
ANALOG
TimeInterpolation
FrequencyInterpolation
PartialChannel
Estimation
CPEcalculation
ChannelCorrection
ConfidenceCalculation
OuterForney
Deinterleaver
InnerFrequency
Deinterleaver
BitDeinterleaverDescrambler RS decoder Demapper
MPEG2Output
Interface
ViterbiDecoder
ADC
PLL
OSC
MPEG-TS(serial)
∆Σ∆Σ
∆Σ∆Σ
E_14970_044.eps020605
Spare Parts ListEN 46 LC4.31E AB10.
10. Spare Parts List
Sets included in this parts list:
26PF5521D/1026PF5521D/1232PF5521D/1032PF5521D/12
Set Level
Various
8301 3139 110 27701 Cable 3p/480/3p Bk8500 3139 131 06221 FFC 32p/400/32p8600 3139 131 05451 Wire Phono/340/Phono8870 3104 311 09151 Cable 6p/400/6p
IBO Zapper Panel [K]
Software
0601 3139 127 04472 IBO Z2 SW R2C49
Various
1028 3139 267 20961 IBO Zap.2.1 Panel ASDM1301 2422 025 10768 Connector 3p m1303 2422 128 02863 Switch tact 1p1304 4822 252 51187 19398E1(0,500A)1401 4822 267 31729 Connector cinch 1p1402 4822 267 10459 Connector 3p1403 2422 025 18799 Socket USB 4p f1500 2422 025 18872 Connector 32p f1600 3112 297 13771 TUNER TD1316A/SPHP1700 2422 033 00364 Connector smartcard8301 3104 311 02141 Cable 3p/480/3p8500 3139 131 06221 Cable 32p/400/32P
2100 4822 124 23002 10µF 16V2101 4822 124 23002 10µF 16V2102 4822 124 23002 10µF 16V2103 2238 586 59812 100nF 20% 50V 06032104 2238 586 59812 100nF 20% 50V 06032105 2238 586 59812 100nF 20% 50V 06032106 2238 586 59812 100nF 20% 50V 06032107 2238 586 59812 100nF 20% 50V 06032108 2238 586 59812 100nF 20% 50V 06032109 2238 586 59812 100nF 20% 50V 06032110 2238 586 59812 100nF 20% 50V 06032111 2238 586 59812 100nF 20% 50V 06032112 2238 586 59812 100nF 20% 50V 06032113 2238 586 59812 100nF 20% 50V 06032114 2238 586 59812 100nF 20% 50V 06032115 2238 586 59812 100nF 20% 50V 06032116 2238 586 59812 100nF 20% 50V 06032119 2238 586 59812 100nF 20% 50V 06032120 2238 586 59812 100nF 20% 50V 06032121 2238 586 59812 100nF 20% 50V 06032130 4822 124 23002 10µF 16V2131 4822 124 23002 10µF 16V2132 4822 124 23002 10µF 16V2133 4822 124 23002 10µF 16V2203 4822 124 23002 10µF 16V2204 2238 586 59812 100nF 20% 50V 06032206 4822 124 23002 10µF 16V2207 2238 586 59812 100nF 20% 50V 06032208 2238 586 59812 100nF 20% 50V 06032209 2238 586 59812 100nF 20% 50V 06032210 2238 586 59812 100nF 20% 50V 06032211 2238 586 59812 100nF 20% 50V 06032212 2238 586 59812 100nF 20% 50V 06032213 2238 586 59812 100nF 20% 50V 06032214 2238 586 59812 100nF 20% 50V 06032300 4822 126 13881 470pF 5% 50V2301 4822 124 40849 330UF 20% 16V2302 4822 124 40207 100µF 20% 25V2304 2020 021 91506 1000µF 20% 16V2305 2238 586 59812 100nF 20% 50V 06032306 4822 124 40207 100µF 20% 25V2308 4822 126 13881 470pF 5% 50V2309 4822 124 40849 330UF 20% 16V2311 2020 021 91687 470µF 20% 16V2313 4822 126 13881 470pF 5% 50V2314 3198 017 33330 33nF 20% 16V 0603
2315 4822 124 40849 330UF 20% 16V2317 4822 124 40207 100µF 20% 25V2318 2020 021 91687 470µF 20% 16V2319 2020 021 91634 100µF 25V2320 2238 586 59812 100nF 20% 50V 06032324 3198 017 44740 470nF 10V 06032325 3198 017 44740 470nF 10V 06032326 3198 017 44740 470nF 10V 06032327 2238 586 59812 100nF 20% 50V 06032328 2238 586 59812 100nF 20% 50V 06032329 4822 126 13193 4.7nF 10% 63V2330 2020 021 91687 470µF 20% 16V2331 4822 126 13193 4.7nF 10% 63V2332 4822 124 40207 100µF 20% 25V2333 5322 126 11583 10nF 10% 50V 06032334 2238 586 59812 100nF 20% 50V 06032335 4822 124 12095 100µF 20% 16V2336 4822 126 13193 4.7nF 10% 63V2337 4822 124 22652 2.2µF 20% 50V2403 2238 586 59812 100nF 20% 50V 06032405 2238 586 59812 100nF 20% 50V 06032406 3198 032 27190 100µF 6.3V2411 2238 586 59812 100nF 20% 50V 06032412 2238 586 59812 100nF 20% 50V 06032413 2238 586 59812 100nF 20% 50V 06032500 3198 017 41050 1µF 10V 06032501 2020 552 94427 100pF 5% 50V2502 2238 586 59812 100nF 20% 50V 06032503 2020 552 94427 100pF 5% 50V2504 2238 586 59812 100nF 20% 50V 06032505 3198 017 41050 1µF 10V 06032506 4822 124 12084 1µF 20% 50V2507 4822 126 13193 4.7nF 10% 63V2508 3198 017 41050 1µF 10V 06032509 2020 552 94427 100pF 5% 50V2510 2020 552 94427 100pF 5% 50V2511 2238 586 59812 100nF 20% 50V 06032512 4822 124 80151 47µF 16V2513 3198 017 41050 1µF 10V 06032514 4822 124 12084 1µF 20% 50V2515 4822 126 13193 4.7nF 10% 63V2516 4822 124 41643 100µF 20% 16V2517 2238 586 59812 100nF 20% 50V 06032521 4822 122 33761 22pF 5% 50V2522 4822 126 14221 68pF 5% 50V NP0 06032523 4822 126 14508 180pF 5% 50V 06032525 4822 126 14508 180pF 5% 50V 06032526 4822 126 14221 68pF 5% 50V NP0 06032528 4822 122 33761 22pF 5% 50V2529 4822 122 33761 22pF 5% 50V2530 4822 126 14221 68pF 5% 50V NP0 06032531 4822 126 14508 180pF 5% 50V 06032533 4822 122 33761 22pF 5% 50V2534 4822 122 33761 22pF 5% 50V2535 4822 122 33761 22pF 5% 50V2536 4822 122 33761 22pF 5% 50V2537 4822 126 14508 180pF 5% 50V 06032538 4822 126 14221 68pF 5% 50V NP0 06032543 4822 124 80151 47µF 16V2544 2238 586 59812 100nF 20% 50V 06032550 3198 017 42240 220nF 16V Y5V 06032551 3198 017 41050 1µF 10V 06032557 4822 124 23002 10µF 16V2558 2238 586 59812 100nF 20% 50V 06032559 4822 122 33761 22pF 5% 50V2560 4822 122 33761 22pF 5% 50V2607 2238 586 59812 100nF 20% 50V 06032608 2238 586 59812 100nF 20% 50V 06032609 2238 586 59812 100nF 20% 50V 06032610 2238 586 59812 100nF 20% 50V 06032611 2238 586 59812 100nF 20% 50V 06032612 2238 586 59812 100nF 20% 50V 06032613 2238 586 59812 100nF 20% 50V 06032614 4822 124 80151 47µF 16V2615 2238 586 59812 100nF 20% 50V 06032617 2238 586 59812 100nF 20% 50V 06032618 2238 586 59812 100nF 20% 50V 06032619 2238 586 59812 100nF 20% 50V 06032620 2238 586 59812 100nF 20% 50V 06032621 4822 124 80151 47µF 16V2622 4822 124 80151 47µF 16V2623 2238 586 59812 100nF 20% 50V 06032624 2238 586 59812 100nF 20% 50V 06032625 2238 586 59812 100nF 20% 50V 06032626 2238 586 59812 100nF 20% 50V 06032627 2238 586 59812 100nF 20% 50V 06032628 2238 586 59812 100nF 20% 50V 06032629 2238 586 59812 100nF 20% 50V 06032630 2238 586 59812 100nF 20% 50V 0603
2631 2238 586 59812 100nF 20% 50V 06032632 4822 122 33741 10pF 10% 50V2636 4822 124 11947 10µF 20% 16V2637 2238 586 59812 100nF 20% 50V 06032700 2238 586 59812 100nF 20% 50V 06032701 2238 586 59812 100nF 20% 50V 06032702 2238 586 59812 100nF 20% 50V 06032703 2238 586 59812 100nF 20% 50V 06032704 2238 586 59812 100nF 20% 50V 06032705 2238 586 59812 100nF 20% 50V 06032706 4822 124 23002 10µF 16V2707 4822 124 23002 10µF 16V2708 2238 586 59812 100nF 20% 50V 06032709 4822 124 23002 10µF 16V2710 2238 586 59812 100nF 20% 50V 06032711 2238 586 59812 100nF 20% 50V 06032712 2238 586 59812 100nF 20% 50V 06032713 4822 124 23002 10µF 16V2714 5322 126 11578 1nF 10% 50V 06032715 2020 552 94427 100pF 5% 50V
3100 4822 051 30103 10kΩ 5% 0.062W3101 4822 051 30103 10kΩ 5% 0.062W3112 4822 051 30103 10kΩ 5% 0.062W3116 4822 051 30103 10kΩ 5% 0.062W3117 4822 051 30103 10kΩ 5% 0.062W3119 4822 051 30103 10kΩ 5% 0.062W3128 4822 051 30103 10kΩ 5% 0.062W3130 4822 051 30103 10kΩ 5% 0.062W3131 4822 051 30103 10kΩ 5% 0.062W3133 3198 021 32290 22Ω 5% 06033134 3198 021 32290 22Ω 5% 06033135 3198 021 32290 22Ω 5% 06033137 4822 051 30103 10kΩ 5% 0.062W3138 4822 051 30103 10kΩ 5% 0.062W3139 4822 051 30339 33Ω 5% 0.062W3140 5322 117 13036 1.2kΩ 1% 0.063W 06033141 4822 051 30103 10kΩ 5% 0.062W3142 4822 051 30101 100Ω 5% 0.062W3143 4822 051 30101 100Ω 5% 0.062W3144 4822 051 30101 100Ω 5% 0.062W3146 4822 051 30101 100Ω 5% 0.062W3147 4822 051 30101 100Ω 5% 0.062W3151 4822 051 30103 10kΩ 5% 0.062W3154 4822 051 30103 10kΩ 5% 0.062W3156 3198 031 13390 4 x 33Ω 5% 12063157 3198 031 13390 4 x 33Ω 5% 12063158 3198 031 13390 4 x 33Ω 5% 12063159 3198 031 13390 4 x 33Ω 5% 12063160 4822 051 30339 33Ω 5% 0.062W3161 4822 051 30339 33Ω 5% 0.062W3162 4822 051 30339 33Ω 5% 0.062W3163 4822 051 30103 10kΩ 5% 0.062W3164 3198 021 32290 22Ω 5% 06033200 4822 051 30332 3.3Ω 5% 0.062W3205 4822 051 30103 10kΩ 5% 0.062W3206 4822 051 30332 3.3Ω 5% 0.062W3207 4822 051 30332 3.3Ω 5% 0.062W3209 4822 051 30101 100Ω 5% 0.062W3210 4822 051 30101 100Ω 5% 0.062W3211 4822 051 30103 10kΩ 5% 0.062W3300 3198 021 31080 1Ω 5% 06033301 3198 021 31080 1Ω 5% 06033303 3198 021 31080 1Ω 5% 06033304 5322 117 13046 1.8kΩ 1% 0.063W 06033306 2322 704 61002 1kΩ 1%3307 2322 704 61001 100Ω 1% 06033312 3198 021 31080 1Ω 5% 06033313 3198 021 31080 1Ω 5% 06033314 3198 021 31080 1Ω 5% 06033315 4822 051 30102 1kΩ 5% 0.062W3316 4822 051 30102 1kΩ 5% 0.062W3317 2322 704 63302 3.3kΩ 1% 06033318 3198 021 31080 1Ω 5% 06033319 3198 021 31080 1Ω 5% 06033320 3198 021 31080 1Ω 5% 06033321 3198 021 31080 1Ω 5% 06033322 5322 117 13042 3.9kΩ 1% 0.063W 06033323 5322 117 13057 820Ω 1% 0.063W 06033324 4822 051 30102 1kΩ 5% 0.062W3325 4822 117 13632 100kΩ 1% 0603 0.62W3326 4822 051 30103 10kΩ 5% 0.062W3327 4822 051 30339 33Ω 5% 0.062W3328 4822 117 13632 100kΩ 1% 0603 0.62W3330 3198 021 31820 1.8kΩ 5% 0.062W 06033331 2322 704 61001 100Ω 1% 06033332 5322 117 13055 75Ω 1% 0.063W 0603
Spare Parts List EN 47LC4.31E AB 10.
3333 4822 051 30273 27kΩ 5% 0.062W3334 4822 051 30333 33kΩ 5% 0.062W3403 4822 051 30103 10kΩ 5% 0.062W3404 4822 051 30561 560Ω 5% 0.062W3405 4822 051 30102 1kΩ 5% 0.062W3406 4822 051 30102 1kΩ 5% 0.062W3407 4822 051 30689 68Ω 5% 0.063W 06033411 4822 051 30181 180Ω 5% 0.062W3420 4822 051 30339 33Ω 5% 0.062W3421 4822 051 30339 33Ω 5% 0.062W3422 4822 051 30153 15kΩ 5% 0.062W3423 4822 051 30153 15kΩ 5% 0.062W3500 4822 051 30102 1kΩ 5% 0.062W3501 4822 117 12968 820Ω 5% 0.62W3502 4822 051 30683 68kΩ 5% 0.062W3503 4822 051 30102 1kΩ 5% 0.062W3504 4822 117 13613 2.2Ω 5% 06033505 4822 117 12968 820Ω 5% 0.62W3506 4822 051 30333 33kΩ 5% 0.062W3507 4822 051 30152 1.5Ω 5% 0.062W3508 4822 117 13613 2.2Ω 5% 06033509 4822 051 30102 1kΩ 5% 0.062W3510 4822 051 30683 68kΩ 5% 0.062W3511 4822 117 12968 820Ω 5% 0.62W3512 4822 051 30101 100Ω 5% 0.062W3513 4822 051 30101 100Ω 5% 0.062W3514 4822 051 30102 1kΩ 5% 0.062W3515 4822 051 30333 33kΩ 5% 0.062W3516 4822 117 12968 820Ω 5% 0.62W3517 4822 051 30152 1.5Ω 5% 0.062W3519 4822 051 30181 180Ω 5% 0.062W3520 4822 051 30181 180Ω 5% 0.062W3521 4822 051 30181 180Ω 5% 0.062W3522 4822 051 30181 180Ω 5% 0.062W3523 4822 051 30759 75Ω 5% 0.062W3526 4822 051 30759 75Ω 5% 0.062W3527 4822 051 30759 75Ω 5% 0.062W3528 5322 117 11726 10Ω 5%3530 4822 051 30479 47Ω 5% 0.062W3533 4822 051 30479 47Ω 5% 0.062W3539 4822 051 30479 47Ω 5% 0.062W3543 4822 051 30391 390Ω 5% 0.062W3544 4822 051 30391 390Ω 5% 0.062W3545 4822 051 30391 390Ω 5% 0.062W3547 4822 051 30479 47Ω 5% 0.062W3557 4822 117 13632 100kΩ 1% 0603 0.62W3558 4822 051 30102 1kΩ 5% 0.062W3559 4822 051 30681 680Ω 5% 0.062W3560 4822 051 30273 27kΩ 5% 0.062W3561 4822 051 30271 270Ω 5% 0.062W3562 4822 051 30151 150Ω 5% 0.062W3572 4822 051 30561 560Ω 5% 0.062W3573 4822 051 30151 150Ω 5% 0.062W3574 4822 051 30151 150Ω 5% 0.062W3575 4822 117 13632 100kΩ 1% 0603 0.62W3576 4822 117 12968 820Ω 5% 0.62W3577 4822 117 12968 820Ω 5% 0.62W3578 4822 051 30759 75Ω 5% 0.062W3579 4822 051 30103 10kΩ 5% 0.062W3580 4822 051 30102 1kΩ 5% 0.062W3581 4822 051 30759 75Ω 5% 0.062W3582 4822 051 30103 10kΩ 5% 0.062W3583 4822 051 30222 2.2kΩ 5% 0.062W3584 4822 051 30271 270Ω 5% 0.062W3585 4822 051 30121 120Ω 5% 0.062W3586 4822 051 30221 220Ω 5% 0.062W3588 4822 051 30222 2.2kΩ 5% 0.062W3589 4822 051 30271 270Ω 5% 0.062W3590 4822 051 30121 120Ω 5% 0.062W3591 4822 051 30221 220Ω 5% 0.062W3593 4822 051 30222 2.2kΩ 5% 0.062W3594 4822 051 30271 270Ω 5% 0.062W3595 4822 051 30121 120Ω 5% 0.062W3596 4822 051 30221 220Ω 5% 0.062W3598 4822 051 30102 1kΩ 5% 0.062W3606 4822 051 30101 100Ω 5% 0.062W3607 4822 051 30101 100Ω 5% 0.062W3608 4822 051 30103 10kΩ 5% 0.062W3609 4822 051 30472 4.7Ω 5% 0.062W3610 4822 051 30472 4.7Ω 5% 0.062W3612 4822 051 30472 4.7Ω 5% 0.062W3613 4822 117 13632 100kΩ 1% 0603 0.62W3614 4822 117 13632 100kΩ 1% 0603 0.62W3615 4822 051 30102 1kΩ 5% 0.062W3618 4822 117 13632 100kΩ 1% 0603 0.62W3619 4822 117 13632 100kΩ 1% 0603 0.62W3621 4822 051 30339 33Ω 5% 0.062W3622 3198 031 13390 4 x 33Ω 5% 12063623 4822 051 30472 4.7Ω 5% 0.062W3624 3198 031 13390 4 x 33Ω 5% 12063625 4822 051 30101 100Ω 5% 0.062W3626 4822 051 30272 2.7kΩ 5% 0.062W3627 4822 051 30272 2.7kΩ 5% 0.062W3629 4822 051 30101 100Ω 5% 0.062W
3630 4822 051 30101 100Ω 5% 0.062W3631 4822 051 30101 100Ω 5% 0.062W3636 4822 051 30684 680kΩ 5% 0.062W3637 4822 117 12891 220kΩ 1%3638 4822 051 30331 330Ω 5% 0.062W3639 4822 051 30391 390Ω 5% 0.062W3640 4822 051 30684 680kΩ 5% 0.062W3641 4822 117 12891 220kΩ 1%3642 4822 051 30331 330Ω 5% 0.062W3643 4822 051 30331 330Ω 5% 0.062W3644 3198 031 13390 4 x 33Ω 5% 12063645 4822 051 30103 10kΩ 5% 0.062W3700 4822 051 30101 100Ω 5% 0.062W3701 4822 051 30101 100Ω 5% 0.062W3702 3198 031 13390 4 x 33Ω 5% 12063703 3198 031 13390 4 x 33Ω 5% 12063704 4822 051 30103 10kΩ 5% 0.062W3705 3198 031 13390 4 x 33Ω 5% 12063707 4822 051 30103 10kΩ 5% 0.062W3708 4822 051 30103 10kΩ 5% 0.062W3709 4822 051 30103 10kΩ 5% 0.062W3710 4822 051 30103 10kΩ 5% 0.062W3711 4822 051 30103 10kΩ 5% 0.062W3712 4822 051 30103 10kΩ 5% 0.062W3713 2322 704 62002 2kΩ 1%3715 4822 051 30103 10kΩ 5% 0.062W3716 4822 051 30103 10kΩ 5% 0.062W3717 4822 051 30103 10kΩ 5% 0.062W3718 4822 051 30103 10kΩ 5% 0.062W3719 4822 051 30103 10kΩ 5% 0.062W3720 4822 051 30103 10kΩ 5% 0.062W3721 4822 051 30103 10kΩ 5% 0.062W3722 4822 051 30103 10kΩ 5% 0.062W3723 3198 031 13390 4 x 33Ω 5% 12063724 3198 031 13390 4 x 33Ω 5% 12063725 4822 051 30339 33Ω 5% 0.062W3726 4822 051 30339 33Ω 5% 0.062W3727 4822 051 30479 47Ω 5% 0.062W3728 4822 051 30479 47Ω 5% 0.062W3729 4822 051 30479 47Ω 5% 0.062W3730 4822 051 30479 47Ω 5% 0.062W3731 4822 051 30479 47Ω 5% 0.062W3732 4822 051 30479 47Ω 5% 0.062W3733 4822 051 30479 47Ω 5% 0.062W3734 4822 117 13573 4 x 47Ω 5%3738 4822 051 30479 47Ω 5% 0.062W3739 4822 051 30479 47Ω 5% 0.062W3740 4822 051 30479 47Ω 5% 0.062W3741 4822 051 30479 47Ω 5% 0.062W3742 4822 051 30479 47Ω 5% 0.062W3743 4822 051 30479 47Ω 5% 0.062W3744 4822 051 30479 47Ω 5% 0.062W3745 4822 051 30479 47Ω 5% 0.062W3746 4822 051 30479 47Ω 5% 0.062W3747 4822 051 30479 47Ω 5% 0.062W3748 4822 051 30479 47Ω 5% 0.062W3749 4822 051 30339 33Ω 5% 0.062W3750 4822 051 30339 33Ω 5% 0.062W3751 4822 051 30472 4.7Ω 5% 0.062W3752 4822 051 30472 4.7Ω 5% 0.062W
5100 4822 157 11499 Bead 60Ω at 100MHz5101 4822 157 11717 Bead 50Ω at 100MHz5102 4822 157 11717 Bead 50Ω at 100MHz5103 4822 157 11717 Bead 50Ω at 100MHz5201 4822 157 11499 Bead 60Ω at 100MHz5202 4822 157 11499 Bead 60Ω at 100MHz5203 4822 157 11499 Bead 60Ω at 100MHz5300 2422 536 00491 47µH5301 4822 157 10452 10µH 10%5302 2422 535 94639 10µH 20%5303 2422 536 00548 100µ5304 4822 157 10452 10µH 10%5306 4822 157 10452 10µH 10%5307 2422 535 94639 10µH 20%5309 3198 018 90050 Bead 1kΩ at 100MHz5401 4822 157 11499 Bead 60Ω at 100MHz5420 2422 549 44197 Bead 220Ω at 100MHz5502 4822 157 11499 Bead 60Ω at 100MHz5504 4822 157 11499 Bead 60Ω at 100MHz5505 4822 157 11499 Bead 60Ω at 100MHz5507 4822 157 11499 Bead 60Ω at 100MHz5508 4822 157 11499 Bead 60Ω at 100MHz5511 3198 018 53380 3.3µH 10% 06035512 3198 018 53380 3.3µH 10% 06035513 3198 018 53380 3.3µH 10% 06035514 3198 018 53380 3.3µH 10% 06035515 4822 156 21729 Bead 1kΩ 100MHz 08055528 4822 157 11499 Bead 60Ω at 100MHz5600 4822 157 11499 Bead 60Ω at 100MHz5601 4822 157 11499 Bead 60Ω at 100MHz
5602 4822 157 11499 Bead 60Ω at 100MHz5604 4822 157 11499 Bead 60Ω at 100MHz5700 4822 157 11499 Bead 60Ω at 100MHz5701 4822 157 11499 Bead 60Ω at 100MHz5702 4822 157 11499 Bead 60Ω at 100MHz5703 4822 157 11499 Bead 60Ω at 100MHz5704 4822 157 11499 Bead 60Ω at 100MHz
6300 9322 128 70685 SMSS146303 9322 128 70685 SMSS146304 9322 128 70685 SMSS146307 9965 000 20150 1N4148WS SOD-3236308 9340 548 48115 PDZ3.6B6400 9340 548 52115 PDZ5.1B6401 4822 130 10837 UDZS8.2B6403 4822 130 10837 UDZS8.2B6503 4822 130 11397 BAS3166507 4822 130 11397 BAS3166508 4822 130 11397 BAS3166509 4822 130 11397 BAS3166510 4822 130 11397 BAS3166511 4822 130 11397 BAS3166512 4822 130 11397 BAS3166513 4822 130 11397 BAS3166514 4822 130 11397 BAS3166515 9322 129 41685 BZM55-C12
7100 9352 773 55557 PNX8314HS/C1027200 For SW see item 06017202 9322 217 26668 MT48LC8M16A2P-6A7203 9322 130 41668 M24C64-WMN67300 4822 209 60059 MC34063AP17301 9322 184 19687 LD1117V187302 9322 216 98687 LD1117V7303 4822 209 60059 MC34063AP17305 4822 209 60059 MC34063AP17306 9322 165 15685 NCP303LSN307307 9322 202 15687 LD1117V507308 9322 202 15687 LD1117V507309 4822 130 60373 BC856B7310 3198 010 70510 TL431CZ7311 9322 231 51685 FET NTR4501NG7312 5322 130 60159 BC846B7402 5322 130 60159 BC846B7403 9322 150 49668 LM3525M-H7500 4822 130 60373 BC856B7501 5322 130 60159 BC846B7502 9352 668 47118 UDA1334BTS/N27503 4822 130 60373 BC856B7504 5322 130 60159 BC846B7507 5322 130 60159 BC846B7511 4822 130 60373 BC856B7512 5322 130 60159 BC846B7518 4822 130 60373 BC856B7519 5322 130 60159 BC846B7520 5322 130 60159 BC846B7521 4822 130 60373 BC856B7522 5322 130 60159 BC846B7523 4822 130 60373 BC856B7524 4822 130 60373 BC856B7525 5322 130 60159 BC846B7526 4822 130 60373 BC856B7527 4822 130 60373 BC856B7528 5322 130 60159 BC846B7529 4822 130 60373 BC856B7600 9352 732 45557 TDA10046AHT/C17601 5322 209 70225 LM393D7605 9352 630 16165 74AHC1GU04GW7606 9352 630 16165 74AHC1GU04GW7700 9322 227 91671 STV0700L7701 9352 190 10118 74LVC573ADB7702 9352 190 10118 74LVC573ADB7703 9352 115 40118 74LVC245APW7704 2722 171 00207 Xtal 27MHZ 50P7705 9322 175 13668 ST890CD
Revision ListEN 48 LC4.31E AB11.
11. Revision ListManual xxxx xxx xxxx.0• First release.