OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the...

118
OVID OVID Refresher Inspector Course A Guide to the uniform inspection procedure Presentation E, New Edition 2013

Transcript of OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the...

Page 1: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

OVID

OVID Refresher Inspector Course

A Guide to the uniform inspection procedure

Presentation E, New Edition 2013

Page 2: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Introduction to the inspection

• Introductory Chapter to the OVIQ

• The inspection sections as set out in the Manual

• Recording Observations

• Recording Other Comments

• Recording Additional Comments

• Using the Inspector Guidance that accompanies many VIQ

questions

Page 3: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Introductory Chapter to the VIQ

Follow the Inspection Requirements!

Respond to the questions accurately

Use only verified information

Page 4: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

The inspection work flow

Prior to boarding

Inspector Access OVPQ

Master list of Documents

Officer Matrix

The OVID

Pocketbook,

Report Editor on

iPad, Android,

etc

Use Report Editor to produce

and print a fresh, new Report

Pocketbook template for

each inspection

Use Pocketbook/iphone/Andriod

etc during inspection

Input inspection findings

from Pocketbook into OVIQ

computer programme or

use iPad or Android etc.

Transmit OVIQ to OVID

or OCIMF Member

Page 5: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Introduction to the inspection

Remember when writing comments in:

a) The Comments box, and/or

b) The Other Comments box, and/or

c) The Additional Comments box

Do not include partial or overall summaries or any suggestions to

rectify situations

Page 6: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Summaries and Guidance

A summary will present the reader with your impressions and

conclusions

Do not summarise at the end of a Chapter

Facts that cannot be refuted are all that should be presented -

nothing more

DO NOT OFFER GUIDANCE

Page 7: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

The Inspection.

The Inspection begins...

• Prior to boarding

• Approaching the vessel

• During boarding

Page 8: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Prior to boarding

The condition of the hull and superstructure

• The overall physical appearance

• Air pollution

• Oil, Rust or other staining

• Mechanical damage from Berths or fenders

• Mooring arrangement

• Legible draught and hull markings

Page 9: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

The outside…..a minor indent?

Page 10: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

The inside story….and a significant problem.

Page 11: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Contact damage on

port quarter

Contact damage on port quarter at

fr 15; 0.5 m below load waterline.

Damage area 3000 mm x 500 mm

max set-in 50 mm.

Contact damage on port quarter

Page 12: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Suspected crack

Suspected crack up to 150 mm in

length on the port side hull plating

at fr 25, below rubbing bar.

Suspected crack

Page 13: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Mooring

Page 14: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Before boarding

Access to the vessel – be careful!

• What does it comprise?

• Is it safe enough to permit you to proceed?

• Rule of thumb – if you will write an observation relating to the

access, then you shouldn’t use it

• Are a heaving line, lifebuoy and light available?

• Is a “No Visitors” notice posted?

Page 15: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this vessel provided with a safe means of access?

Page 16: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this vessel provided with a safe means of access?

Page 17: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this Access Safe?

Page 18: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this Access Safe?

Page 19: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this access safe?

Page 20: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this Access Safe?

Page 21: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage
Page 22: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Notches cut into gangway-reduced strength

Page 23: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Transfer by Crane.

Prototype Billy Pugh??

Page 24: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this means of access safe??

Page 25: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage
Page 26: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Frog Transfer Basket.

Page 27: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Frog Transfer Basket

Page 28: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Pilot Ladder.

Page 29: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Coming on board

Security

• Is the gangway manned?

• Does the deck watchman ask your business?

• Does he ask for your photo ID?

• Are you asked to sign a Visitor’s Book?

• Are you provided with an Emergency Stations

Card

• Don’t be upset if he asks to see inside your bag

Page 30: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

On boarding

• The inspector has been on board for only a few

minutes

• He has not yet met the Master, but…

• What he has already seen is important and

• an initial impression has been gained

Page 31: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Entering the Accommodation

• Are all accommodation doors shut?

• Is the watertight door seal packing sound?

• Are the alleyways brightly lit, free of clutter and

clean?

• Are the posted fire and safety signs clearly

legible?

Page 32: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

The pre-inspection meeting

You will meet the master prior to commencing the

inspection.

• Topics for discussion

• The order of the inspection

• The equipment you want to see operating.

• Confirmation that the access hatches any tanks/voids

you want to sight are ready to open

• Any unusual conditions on board that you need to be

aware of

• The timing of the inspection.

• Be conscious of work demands on ship’s staff

Page 33: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Certification and documentation (1)

• Use the actual certificates – do not use data from the

VPQ

• General information for Chapter 1 of the OVIQ

• Certificates as listed in OVIQ Chapter 2

• Operator’s Operating Procedures Manuals

• Class Condition Survey files

• IOPPC

• Oil Record Book

• Hours of Rest

Page 34: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Certification and documentation (2)

• Publications

• Crew management

• Crew licences and records of sea service

• Drug and alcohol policy

• Safety management

• Minutes of meetings,

• Records of drills, training and familiarisation

• Record of Visits by Operator’s Superintendent

Page 35: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Certification and Documentation (3)

• Ship security

• Enclosed space, entry procedures

• Hot work procedures and certificates

• Life-saving equipment from the LSC and Form E

• Garbage management plans and logs

• Cargo lifting equipment records

• Mooring equipment records

Page 36: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hours of Rest – what to check

Page 37: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

ISF Watchkeeper 3

Page 38: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

ISF Watchkeeper 3

Page 39: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

ISF Watchkeeper 3

Page 40: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hours of Rest – what to check

The actual Manning level aboard and trading pattern of the

vessel is key

Accuracy in the completion of the hours of RestLog

Documents to review ( Past 6 to 12 months)

• Oil Record Book

• Enclosed Space Permits & Entry Logs

• Records of Drills – if outside normal work hours, are they

logged?

Page 41: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hours of Rest – what to check

Manning Levels

• Two, Three, or Four Mates?

• Three AB’s

• Chief Engineer and two additional engineer officers

• One Oiler

Work Schedules in port

• Both deck and Engineering officers, Chief Officer and Chief

Engineer are key

Page 42: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hours of Rest – what to check

Is the log completed in accordance with Operator’s instructions

• Many SMS do not have instructions

• Comments section is not completed

• Are the total daily and weekly hours recorded

• Inconsistencies between the recorded hours versus evidence that is

uncovered by reference to previously discussed records

Page 43: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hours of Rest – what to check

Oil Record Book

Part 1

• Bunkering

• OWS operations

• Transfer of residues

• Incineration of waste

Page 44: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hours of Rest – what to check

Enclosed Space Permits & Enclosed Space Entry Logs

• Time when permits were opened and closed

• Who was in the spaces

Page 45: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Some examples of inspector observations

The engine oil record book showed that the vessel conducted bunkering

operations on 2 of Jan between 0100 and 1000.

The Chief Engineer and 2nd Engineer’s Hours of Rest logs were

reviewed and both were shown to have been working a normal day (

0800-1700) on 2 Jan.

Page 46: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hours of Rest – conclusions

• Logs are being completed by a single person – not by individuals

• Logs are not completed on a daily basis

• Compare the key documents at the same time as the Hours of Rest

Logs

Page 47: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Tank conditions• OCIMF does not endorse any tank entry.

• Recognise that some members may require inspectors to

enter tanks.

Concerns relating to tank entry.

• Owner’s permission

• Master’s permission (Letter of indemnity)

• Terminal Regulations

• Port requirements for shore chemist

• Vessel crew’s ability to undertake tank entry, specifically with work

load etc.

What Practical alternatives are there to actual tank entry?

Page 48: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Tank sighting from hatch opening – Practical aspects

What can be achieved - 1?

• Observations from the tank access hatch

• Steel wastage of hand rails and ladder rungs (if fitted)

• Visible breakdown of transverse and longitudinal girders

• Sound of liquid falling into the tank

• Odour of Gas

• Oil sheen on the surface of ballast

Page 49: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Tank sighting from the deck – Practical aspects

What can be achieved - 2?

• Colour of the sounding rod gives a good indication of the nature of

the bottom.

• Steel wastage of the deck longitudinals

• Inspection of sounding book, for any drop in sounding during

passage

Page 50: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hot work certificates

• General – The bigger the file, the more concerned you need to be.

• ISGOTT Guidance or other industry guidance must be followed.

• Consideration of alternatives,(such as cold work).

• Planning.

• Execution.

• Notification process

between vessel and shore management.

Page 51: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hot work certificates

Page 52: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hot Work is not only welding!

Page 53: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Common documentation Observations

• Certificates folder disorganised

• Ship’s management manuals not updated

• Ship’s manuals not signed by personnel

• Unsatisfactory winch testing records

• Certificates for mooring lines do not indicate the winch on which

they are stored

• Inadequate Hot Work and Enclosed Space Entry Permits

• Physical evidence not in conformity with records

• Fire plans do not reflect actual equipment

• Unfamiliarity with contents of management manuals

Page 54: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

15. Inspection of the Wheelhouse and Navigation

Page 55: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

15. Inspection of the Wheelhouse and Navigation

Page 56: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

15. Inspection of the Wheelhouse and Navigation

Page 57: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Supply Boat Control Position.

Page 58: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Equipment checks and verification techniques.

• Clearly visible from the steering position? Good illumination?

• Compass error observations agree with posted deviation card and carried out as per STCW 95?

• Caution: Deviation alongside berth may be affected by proximity of steel structures and is an unreliable basis for observations.

Magnetic Compass

• Note gyro heading for later comparison with repeaters.

• Compare with berth direction on chart.

Gyro

• Switched off or standby during transfer of flammable products?

• Performance monitor readings (values) recorded in accordance with OVID guidance?

• Crew familiar with speed input when used for collision avoidance?

Radars

Page 59: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

• Extract from Furuno Radar

Manual.

• In this example, PM readings

should include the number of

visible arcs and distance to the

innermost arc as a measure of

performance

Equipment checks and verification techniques.

Page 60: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Equipment checks and verification techniques.

• Correctly aligned with gyro heading? Correct quadrant alignment?

• If misaligned – does pre-arrival checklist confirm alignment was carried out? Trace back misalignment – heading at last berth from chart verses course recorder heading.

Course Recorder

• Correct date & time.

• Verify pre-port entry propulsion checks carried out.

• If no stern movement recorded – did pre-arrival checklist indicate this was done?

Engine Order Printer

• Set to correct datum for the chart used.

• Do crew understand the significance of chart datum and know how to change it?

GPS Receivers

Page 61: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Equipment checks and verification techniques.

• Power setting as per ISGOTT 4.8.4.

AIS

• Check printer data or internal memory for continuous operation during entry.

• Scale appropriate for the depths – evidence of monitoring, egchanging scale as depths change.

• Test run – displayed depths comparable with charted depth? Clear legible trace?

• Depth alarm set to provide warning of unexpected UKC reduction?

• Where no printer connected – is VDR or SVDR installed?

Echo Sounder

• Is there evidence of use (weather maps)? Maps legible?

Weather fax

Page 62: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Any observation?

Page 63: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Equipment checks and verification techniques.

• Data clearly legible on screen/printer.

• Correct message types and receiving stations for the area selected.

• If unit switched off – ask crew to demonstrate recovery

of messages received since power off.

Navtex

Page 64: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Equipment checks and verification techniques.

• Rudder angle & rate of turn indicators, speed log, wind speed & direction indicators, etc.

• Visualise what you expect to see before looking at any equipment – if the display does not meet with expectations….ask questions to establish why?

Other Equipment

Page 65: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Procedures & Teamwork

• Document Company UKC Policy in the report.

• Does the UKC calculation(s) clearly establish the controlling depth(s) and was the correct controlling depth used?

• Was the calculation valid for the actual time and speed of transit over the controlling depth (use plotted positions to verify actual speed over the ground).

• Any limitations imposed – time of transit, speed of transit – effectively brought to the attention of bridge team members including the pilot.

• Common observations: Wrong controlling depth used; calculations only use high water when passage not at high water; speed used for squat too low.

Under Keel Clearance (Under Thruster Clearance).

Page 66: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Procedures & Teamwork

• Refer to Guidance Notes in OVIQ. Be practical when assessing – if a deficiency is raised, clearly document the error or omission, preferably with industry guidance reference.

• Review the plan & voyage charts – particular attention to transit of areas where high traffic density, close to hazards, etc.

• Position fixing frequency and methods established? Is position fixing increased on approach to navigational hazard? General rule: distance between charted fixes should not exceed the distance to the nearest danger.

Passage Planning

Page 67: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Procedures & Teamwork

• Parallel indexing used where beneficial to navigation. Floating marks avoided but if used positions verified.

• No go areas established. Company policy stipulates minimum UKC –highlight isolated areas close to the track where this cannot be met. Were highlighted areas relevant for the draft, state of tide, etc. and not falsely indicating a restriction in manoeuvring room.

• Charts used largest scale? Berth to berth planning?

• Contingency planning – emergency anchorages; abort points.

• Publications updated (Radio Signals, Light Lists, Pilot Books).

• Charts corrected.

• Plan signed by Bridge Team members verifying cross checks.

Passage Planning

Page 68: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Procedures and verification techniques.

Page 69: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Procedures and verification techniques.

• Establish latest NTM applied to all charts.

• Request a list of charts used last passage, latest cumulative list of NTM, chart correction log/cards & latest corrected weekly NTM.

• Use chart correction records and weekly NTM to identify voyage charts affected by the notice.

• Use cumulative list to check all small correction numbers marked on charts (historical check).

• Use latest NTM to verify last correction actually plotted on chart & quality of correction (contemporary check).

• Two or more charts checked this way for random verification; any deficiencies recorded.

Chart Corrections – paper charts & NTM

Page 70: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Procedures and verification techniques.

• ChartCo, Digitrace, ChartTrack, etc.

• Request officer to select paper chart management on software to view the list of charts on board.

• Randomly select two or more paper charts.

• Software provides a historical record of corrections affecting each chart. Check all small corrections marked and randomly select tracings for display (or print) to verify these marked on charts. Assess quality of corrections.

• Any deficiencies noted.

Chart Corrections – paper charts; electronic NTM

Page 71: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Procedures and verification techniques.

• Summary of in-force T & P Notices updated monthly in NTM – use in conjunction with list of voyage charts to identify affected charts. Notices issued since last summary update checked for recent corrections.

• Electronic NTM may store in-force T & P notices under individual chart number.

• Navigation Warning file checked to verify all in-force notices available and segregated according to Navarea.

• Check any affected voyage charts to ensure content of the notice is plotted (or otherwise effectively brought to the attention of the watch officer).

• Any deficiencies noted.

Chart Corrections – T & P notices and Navigation Warnings.

Page 72: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Fire Detection Panel

• Any malfunction or

disconnection?

• If sensors in machinery spaces

not connected…… is the ER

operated UMS?

Bridge Equipment - Other

Page 73: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Emergency Radios

• Battery expiry.

SARTS

Tested.

EPIRB’s

• Battery expiry

• Float free

• Tested

Pyrotechnics

• Expiry date

Bridge Equipment - Other

Page 74: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Bridge Equipment - Other

• Pyrotechnics

– Expiry date

– Ready for use

Page 75: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

• Daily, Weekly & Monthly tests

carried out & recorded.

• GMDSS log entries.

• Call sign & equipment specific

instructions posted.

• Responsible officer familiar with

equipment?

• Security alert visible?

Communications Equipment

Page 76: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

VDR

Page 77: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

VDR

Page 78: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Practice Observations

In the next few pictures try to describe

what you are seeing using what you have

learned so far about OVID.

Page 79: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Practice Observations

Page 80: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Practice Observations

Page 81: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Practice Observations

Page 82: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Housekeeping issue, cluttered paint locker

Page 83: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Practice Observations

Page 84: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Practice Observations

Page 85: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Leaking fire hydrant when tested

Page 86: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Garbage Management

Page 87: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Condition of the deck area

• Are deck fittings well maintained?

• Are protective rails fitted around back decks

etc.

• Are sounding pipes and filling pipes properly

identified and closed/capped?

• Are air vents properly identified and provided

with save-alls? Where drain plugs are fitted are

these in place?

Page 88: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Condition of the deck area

Page 89: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Condition of deck area

Page 90: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Condition of the deck area

Page 91: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Condition of the deck area

Page 92: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

ER Em emergency escape to deck

Page 93: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

ER Emergency escape to deck.

Page 94: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Condition of the deck area

Page 95: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Condition of the deck area

Page 96: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Lifeboats on OSV’s

Page 97: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Lifeboats on OSV’s

Page 98: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Lifeboats on OSV’s

Page 99: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Lifeboat disasters

Page 100: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Where more than

one life raft is fitted

to a single HRU,

each life raft must

be fitted with its

own weak link.

Are Hydrostatic Releases, where fitted, correctly attached and in

good order?

Page 101: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hydrostatic Release arrangements

Page 102: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Beware of Pirated Hammar Hydrostatic Release

Page 103: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hydrostatic Release arrangements

Page 104: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hydrostatic Release arrangements

• Three liferafts

attached to one

HRU.

• HRU is two decks

below the liferaft

deck.

Page 105: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hydrostatic Release arrangements – Series of 3 Photos. (No 1)

No 1 shows 3 yellow

extension lines attached

on main deck, coming

from 3 life rafts placed

on deck above. These 3

lines are shackled

directly the ship side.

Page 106: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hydrostatic Release arrangements – Series of 3 Photos. (No 2)

No 2 shows the

other end of the

yellow line

(illustrated to one

life raft) connected

to the red release

line from the raft.

Page 107: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Hydrostatic Release arrangements – Series of 3 Photos. (No 3)

No 3 shows the

shackle in picture No.

2 moved into the

eyelet in red line

coming from raft and

which is again

connected the HRU

(Hydrostatic Release

Unit).

Page 108: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Common external accommodation inspector observations

• Man overboard lights

• Lifeboats – condition, equipment and hook release arrangements

• Life rafts – hydro release arrangements

• Fire fighting equipment

• Hose boxes

• Accommodation doors

• Ventilators

• Fire flaps

• ID. Stencilling and Warning signs

• External lighting

• Loose pipes, or other equipment

• Tripping hazards

• Slippery decks

Page 109: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

The Working Deck and what to look for!

Check the tugger ..Wire?

Condition? Guard? Base of

tugger; wastage?

Do the tow pins work?

Mooring rope condition……Hose condition?

Storage?

Is cargo secured properly?

Page 110: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Back Deck Sheathing.

Page 111: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Back Deck Sheathing

Page 112: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Is this proper storage for Gas/Acetylene?

Page 113: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Housekeeping Issues

Page 114: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Take a look at wires/sockets; note condition, greased? Wire

damaged, kinked?

Page 115: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Emergency Tow Wire...

Page 116: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

Engine room escape hatches: What are some of the issues in this

picture?

Page 117: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

What are some other hazards that can be found on the back deck?

• Trip Hazards

• Blocked scuppers

• Fuel/Liquid Mud vents (No Savealls)

• Engine room fire flaps not closing (Aft Stack Vessels)

What are some that you may have seen in your experience?

Page 118: OVID Refresher Inspector Course ·  · 2018-01-02OVID Refresher Inspector Course A Guide to the uniform inspection procedure ... Entering the Accommodation ... • Steel wastage

www.ocimf.com