Orthopedic Foot Instruments. Dedicated instruments for ... Foot Instruments.pdf · Orthopedic Foot...

Orthopedic Foot Instruments.Dedicated instruments for reconstructivefoot surgery.

Handling Technique

0X6.001.030_AA 14.09.09 12:05 Seite Cvr1

0X6.001.030_AA 14.09.09 12:05 Seite Cvr2

Synthes 1

Table of Contents

Introduction

Handling Techniques

Product Information

Orthopedic Foot Instruments 2

Indications 4

Compression/Distraction Device Set 5

Bone Harvesting Set 12

Chisel Set 19

Instruments 22

Sets 25

Replacement Articles 28

Image intensifier control

WarningThis description alone does not provide sufficient background for direct use ofthe instrument set. Instruction by a surgeon experienced in handling theseinstruments is highly recommended.

Reprocessing, Care and Maintenance of Synthes InstrumentsFor general guidelines, function control and dismantling of multi-part instruments,please refer to: www.synthes.com/reprocessing

0X6.001.030_AA 14.09.09 12:05 Seite 1

2 Synthes Orthopedic Foot Instruments Handling Technique

Compression/Distraction Device Set,in modular trayFields of application– Compression and distraction of joints

or bones– Fracture treatment– Arthrodeses (e.g. subtalar arthrodesis)– Osteotomies (e.g. lateral calcaneal

lengthening osteotomy)

Bone Harvesting Set, in modular trayFields of application– Bone harvesting

(e.g. from the calcaneus, proximaltibia or iliac crest)

– Bone biopsies

Orthopedic Foot Instruments. Dedicated instruments for reconstructivefoot surgery.

System Overview

The Orthopedic Foot Instruments havebeen designed to perform specific procedures on the foot more efficiently. The system consists of three modularsets: Compression/Distraction DeviceSet, Bone Harvesting Set and Chisel Set.

0X6.001.030_AA 14.09.09 12:05 Seite 2

Synthes 3

Chisel Set, in modular trayFields of application– Preparation of joints for arthrodeses– Removal of joint cartilage and bone– Removal of exostoses– Removal of osteophytes

Features and Benefits

Bone Harvesting Set– Different trephine diameters enable accurate

local bone grafting– Corresponding extraction attachments enable

the safe removal of bone graft

Chisel Set– Different shapes of chisels and a cartilage

remover facilitate proper joint preparation– Silicon handles for optimal grip

Compression/Distraction Device Set– Placement of 2.0, 2.5 and 3.0 mm K-wires at

various angles– Precise compression/distraction mechanism– Two extra K-wire holes for more stability

0X6.001.030_AA 14.09.09 12:05 Seite 3

Indications

− Fractures in the foot and ankle− Skeletal deformities and/or skeletal defects in the foot

and ankle− Instability of the foot and ankle − Tumors in bones and cartilage in the foot and ankle− Non-unions of small and large bones in the foot and ankle − Pseudoarthrosis in the foot and ankle− Osteoarthritis in the foot and ankle− Rheumatoid arthritis in the foot and ankle− Exostoses in the foot and ankle


0X6.001.030_AA 14.09.09 12:05 Seite 4

Handling TechniquesCompression/Distraction Device Set

Set

01.111.476 Compression/Distraction Device Set for Orthopedic Foot Instruments, with Lid, with Contents

Set content

03.111.021 Compression/Distraction Device for Foot and Ankle

03.111.022 Holding Sleeve � 2.0 mm for Compression/Distraction Device for Foot and Ankle



292.250 Kirschner Wire � 2.5 mm with trocar tip, length 150 mm, Stainless Steel

292.750 Kirschner Wire � 2.5 mm with threaded tip, length 150/15 mm, Stainless Steel



Synthes 5

0X6.001.030_AA 14.09.09 12:05 Seite 5

1Preparation

Expose the indicated area. The approach will depend on thesurgical procedure.


2Prepare Compression/Distraction Device

Instruments

03.111.021 Compression/Distraction Device for Foot and Ankle




Thread the corresponding holding sleeves into the threadedfixation holes of the fixation arms.

For 2.0 mm K-wires use 2.0 mm holding sleeves.For 2.5 mm K-wires use 2.5 mm holding sleeves.For 3.0 mm K-wires use 3.0 mm holding sleeves.

Note: Do not tighten holding sleeves at this point.


0X6.001.030_AA 14.09.09 12:05 Seite 6

Open all locking-clamps of the compression/distraction device.

Synthes 7

Adjust the rotation and distance of the arms until initialalignment for the surgical procedure is defined.

Tips– lock the rotational mechanism first– lock both arms – adjust space between the arms

Note: A range of different adjustment approaches may beused.

0X6.001.030_AA 14.09.09 12:05 Seite 7

3Insert K-wires

Instruments

292.250 Kirschner Wire � 2.5 mm with trocar tip, length 150 mm, Stainless Steel




Position the device in such a way that the ends of the holding sleeves are as close to the bone as possible.

Drill two K-wires through the corresponding holding sleevesinto the bone.



0X6.001.030_AA 14.09.09 12:05 Seite 8

If more stability is desired, additional 2.0 mm K-wires can bedrilled through the extra K-wire holes of the arms.

Finger-tighten the holding sleeves. This will fix the device tothe K-wires.

Synthes 9

0X6.001.030_AA 14.09.09 12:05 Seite 9

4Compress or distract

Perform the surgical procedure once the K-wires have beeninserted.

Choose whether compression or distraction is desired by adjusting the switch mechanism.

Turn the wing bolt to compress or distract.

Warning: Avoid excessive distraction. Too much distractioncan damage the surrounding soft tissue.


5Remove compression/distraction device

Loosen the holding sleeves first, then open the lockingclamps.

Carefully remove the device.

Remove K-wires.


0X6.001.030_AA 14.09.09 12:05 Seite 10

Synthes 11

0X6.001.030_AA 14.09.09 12:05 Seite 11

Set

01.111.477 Bone Harvesting Set for Orthopedic Foot Instruments, with Lid, with Contents

Set content

03.111.012 Handle, long, with Quick Couplingor03.111.013 Handle, short, with Quick Coupling

02.111.001 Guide Wire � 3.2 mm with Stop, tip 1.2 mm, Stainless Steel

03.111.030 Shaft for Trephine and Extraction Attachment

03.111.031 Stylet for Trephine and Extraction Attachment

03.111.025 Trephine Attachment � 5.5 mm


387.659 Trephine Attachment � 8.5 mm





03.111.027 Extraction Attachment � 5.5 mm


387.669 Extraction Attachment � 8.5 mm

Handling TechniquesBone Harvesting Set


0X6.001.030_AA 14.09.09 12:05 Seite 12





Important– Trephines have sharp cutting edges that may cause injury.– Handle the attachments with care. Damage to the cutting

edges may cause failure and will alter the precision of theinstrument.

– Only use instruments with sharp edges.

Synthes 13

0X6.001.030_AA 14.09.09 12:05 Seite 13


1Preparation


2Place guide wire

Instrument

02.111.001 Guide Wire � 3.2 mm with Stop, tip 1.2 mm, Stainless Steel

Drill the guide wire into the location where bone removal isrequired.

Technique Tip: In case that insertion of the guide wire byhand is not possible, use a power tool to drill the guide wireinto the bone.


0X6.001.030_AA 14.09.09 12:05 Seite 14

3Cut bone graft

Instruments










Attach the shaft for trephine and extraction attachments to ahandle.

Select the preferred trephine size and attach it to the shaft.

Slide the trephine over the guide wire to the bone.

Note: The trephine cannot be disengaged from the shaftwhen it is inserted over the guide wire.

Synthes 15

0X6.001.030_AA 14.09.09 12:05 Seite 15

Use gentle rotational movements to cut into the bone.

Use the guide wire to read the length of the bone graft.

Cut to the desired depth.


The extracted bone graft should remain in the trephine.

Important: If the bone graft cannot be removed with thetrephine, use the bone extraction attachment to remove thebone graft from the bone. This technique is described onpage 18.


0X6.001.030_AA 14.09.09 12:05 Seite 16

1

2

4Remove bone graft from trephine

Instrument

03.111.031 Stylet for Trephine and Extraction Attachment

Remove the handle and insert the stylet into the back of thetrephine shaft (1).

Push the bone graft carefully out from the front of thetrephine along with the guide wire (2).

Synthes 17

0X6.001.030_AA 14.09.09 12:05 Seite 17

Removal of bone graft with the bone extractionattachment

Instruments










Note: All trephines have a corresponding size extraction attachment.

Slide the extraction attachment over the guide wire and insert it until you reach the limited depth (the handle shouldnot rotate).

To break the graft dowel free, turn the holder slowly untilyou hear a cracking noise or feel no more resistance in turning. Remove the holder. Both the bone dowel and the guide wire remain in the extraction attachment.

The technique to remove the bone graft is the same as whenusing a trephine.

Tips– It is possible to use a hammer in combination with

the handles.– Use light, controlled hammer blows.



0X6.001.030_AA 14.09.09 12:05 Seite 18

Handling TechniquesChisel Set

Set

01.111.475 Chisel Set for Orthopedic Foot Instruments, with Lid, with Contents

Set content


03.111.014 Cartilage Remover, for Foot

03.111.015 Chisel, for Foot, straight, narrow, width 10 mm, length 124 mm

03.111.016 Chisel, for Foot, straight, wide, width 15 mm, length 124 mm

03.111.017 Chisel, for Foot, 20° bend, narrow, width 10 mm, length 124 mm

03.111.018 Chisel, for Foot, 20° bend, wide, width 15 mm, length 124 mm

03.111.019 Chisel, for Foot, curved, narrow, width 10 mm, length 124 mm

03.111.020 Chisel, for Foot, curved, wide, width 15 mm, length 124 mm

Important– Chisels and cartilage remover have sharp cutting edges

that may cause injury.– Handle the instruments with care. Damage to the cutting

edges may cause failure and will alter the precision of theinstrument.

– Only use instruments with sharp edges.

Synthes 19

0X6.001.030_AA 14.09.09 12:05 Seite 19

Handling TechniquesChisel Set

1Preparation


2Choose instrument

Instruments









Attach the desired chisel or the cartilage remover to a handle.


0X6.001.030_AA 14.09.09 12:05 Seite 20

3Prepare joints and/or bones

Tips– It is possible to use a hammer in combination with

the handles.– Use light, controlled hammer blows.

Synthes 21

0X6.001.030_AA 14.09.09 12:05 Seite 21

03.111.021 Compression/Distraction Device for Footand Ankle

03.111.022 Holding Sleeve � 2.0 mm forCompression/Distraction Device for Footand Ankle



292.250* Kirschner Wire � 2.5 mm with trocar tip,length 150 mm, Stainless Steel

292.750* Kirschner Wire � 2.5 mm with threadedtip, length 150/15 mm, Stainless Steel



03.111.012 Handle, long, with Quick Coupling

*Add suffix "S" to article number to order sterile product.

Instruments


0X6.001.030_AA 14.09.09 12:05 Seite 22








03.111.030 Shaft for trephine and extractionattachment

02.111.001* Guide Wire � 3.2 mm with Stop, tip 1.2 mm, Stainless Steel

03.111.031 Stylet for trephine and extractionattachment

03.111.013 Handle, short, with Quick Coupling

*Add suffix ”S“ to article to order sterile product.

Synthes 23

0X6.001.030_AA 14.09.09 12:05 Seite 23

Trephine Attachments








Extraction Attachments








Instruments


0X6.001.030_AA 14.09.09 12:05 Seite 24

01.111.476 Compression/Distraction Device Set for Orthopedic Foot Instruments, with Lid, with Contents

Sets

Synthes 25

Art. no. Description Quantity

03.111.021 Compression/Distraction Device for Foot and Ankle 1

03.111.022 Holding Sleeve � 2.0 mm for Compression/Distraction Device for Foot and Ankle 2



292.250.10 Kirschner Wire � 2.5 mm with trocar tip, length 150 mm, Stainless Steel, pack of 10 units 1

292.750.10 Kirschner Wire � 2.5 mm with threaded tip, length 150/15 mm, Stainless Steel, pack of 10 units 1



68.000.102 Lid for Instrument Tray, size ¼ 1

68.111.466 Tray for Compression/Distraction Device, for Orthopedic Foot Instruments, without Lid, without Contents 1

0X6.001.030_AA 14.09.09 12:05 Seite 25

01.111.475 Chisel Set for Orthopedic Foot Instruments, with Lid, with Contents

Sets


03.111.013 Handle, short, with Quick Coupling 1

03.111.014 Cartilage Remover, for Foot 1

03.111.015 Chisel, for Foot, straight, narrow, width 10 mm, length 124 mm 1

03.111.016 Chisel, for Foot, straight, wide, width 15 mm, length 124 mm 1

03.111.017 Chisel, for Foot, 20° bend, narrow, width 10 mm, length 124 mm 1

03.111.018 Chisel, for Foot, 20° bend, wide, width 15 mm, length 124 mm 1

03.111.019 Chisel, for Foot, curved, narrow, width 10 mm, length 124 mm 1

03.111.020 Chisel, for Foot, curved, wide, width 15 mm, length 124 mm 1


68.111.465 Tray for Chisel, for Orthopedic Foot Instruments, without Lid, without Contents 1

68.111.475 Module for Chisels, for Orthopedic Foot Instruments, without Lid, without Contents 2


0X6.001.030_AA 14.09.09 12:05 Seite 26

01.111.477 Bone Harvesting Set for Orthopedic Foot Instruments, with Lid, with Contents

Synthes 27


03.111.012 Handle, long, with Quick Coupling 1

03.111.030 Shaft for Trephine and Extraction Attachment 1

02.111.001 Guide Wire � 3.2 mm with Stop, tip 1.2 mm, Stainless Steel 1

03.111.031 Stylet for Trephine and Extraction Attachment 1

03.111.025 Trephine Attachment � 5.5 mm 1

03.111.026 Trephine Attachment � 7.0 mm 1

387.659 Trephine Attachment � 8.5 mm 1

387.660 Trephine Attachment � 9.5 mm 1

387.661 Trephine Attachment � 10.5 mm Optional



03.111.027 Extraction Attachment � 5.5 mm 1

03.111.028 Extraction Attachment � 7.0 mm 1

387.669 Extraction Attachment � 8.5 mm 1

387.670 Extraction Attachment � 9.5 mm 1

387.671 Extraction Attachment � 10.5 mm Optional



68.111.467 Tray for Hollow Reamer and Instruments for Bone Graft Harvesting, for Orthopedic Foot Instruments, without Lid, without Contents 1


68.111.476 Module for Bone Harvesting Trephines, for Orthopedic Foot Instruments, without Lid, without Contents 2

68.111.477 Module for Bone Harvesting Instruments, for Orthopedic Foot Instruments, without Lid, without Contents 1

0X6.001.030_AA 14.09.09 12:05 Seite 27

60043900 Spring for Handles

Replacement Articles

60030145 Spring for Compression/DistractionDevice

For detailed information ask your Synthes sales representative.


0X6.001.030_AA 14.09.09 12:05 Seite 28

0X6.001.030_AA 14.09.09 12:05 Seite Cvr3

0123 036.

001.

030

SE_2

3951

5 A

A

3009

0038

©

09/

2009

Syn

thes

, Inc

. or

its a

ffili

ates

A

ll rig

hts

rese

rved

Sy

nthe

s is

a t

rade

mar

k of

Syn

thes

, Inc

. or

its a

ffili

ates

All technique guides are available as PDF files at www.synthes.com/lit

Ö036.001.030öAA<ä

0X6.001.030_AA 14.09.09 12:05 Seite Cvr4

Orthopedic Foot Instruments. Dedicated instruments for ... Foot Instruments.pdf · Orthopedic Foot...

Documents

Transcript of Orthopedic Foot Instruments. Dedicated instruments for ... Foot Instruments.pdf · Orthopedic Foot...