Orion Manual

84
ORION XT High-Sensitivity Smoke Detector Installation, Operation and Maintenance Manual Part Number 06-236005-401 Document Number 77.100 February 2006 FM APPROVED R LISTED LISTED O F FIC E O F STATE FIRE MARSHAL CSFM Listed MEA Listed

Transcript of Orion Manual

Page 1: Orion Manual

����������� ����������������������

�������������� �������������� ���� ������

������������ ������ ���������������������������������

FM

APPROVED

R

LISTED LISTED

OFFICE OF

STATE FIRE MARSHAL

��������

�������

Page 2: Orion Manual
Page 3: Orion Manual

����������� ����������������������

�������������� �������������� ���� ������

������������� ������ ���������������������������������

Page 4: Orion Manual

����������������� ����������

Page 5: Orion Manual

��������

��������������������������������� �������������� ���!����������"��#�$����%�&�������'�� ����(��)���������� �����������������������*�������* ���������������*��������� �������+�*���������������*��������+�������,������������������������������!�������"���$����%�&�������'�� ����(��)���������� �����

����������������� ����

AC Alternating Current ISOL Isolate

AH Ampere Hour LED Light Emitting Diode

CPU Central Processing Unit MEA

Materials and EquipmentAcceptance Division of theDepartment of Buildings. City ofNew York

CSFM California State Fire Marshal mA Milliamperes

DC Direct Current NFPS National Fire ProtectionAssociation

DIA Diameter OCS ORION Configuration Software

DIP Dual In-line Position PALM PEGAsys Addressable LoopModule

ESC Escape PC Personal Computer

EOL End-of-Line P/N Part Number

ESP Extended Sampling Point PSU Power Supply Unit

FM Factory Mutual RAM Random Access Memory

ft. Feet or Foot RH Relative Humidity

ft./sec Feet per Second sq. ft. Square Feet

GND Ground UL Underwriters Laboratories

HSSD® High Sensitivity Smoke Detection VAC Voltage Alternating Current

HVAC Heat, Ventilation and Air-Conditioning VDC Voltage Direct Current

IIM Intelligent Interface Module vs. Versus

Page 6: Orion Manual

��

���� �� ���������� ������ � ���� ��� ��� ���������� ���!������"�� � ����������#�#$� �!�� �"#%!&&'()&**+',,(

���������������� ���!�����"��

-� ������.��+��������+�����/���������01��!�������������2�������������2����������3�224������������������*���������*��/�������������������22���%�������������*����������%����.��'����������*���3"4���!���.������,��������!�������������*��+��'����������������+��������+�� �

5� ������.��+������������������22����+��������������6��(������������%�������*�����������������������+��������/��(���+��������/����%�����%����+���*�����������+��%��������*���%�/��������+� �/����������.�����������!��22������01�������

7� ����"��%���.��'���������*��,����",�����������������������������*����!���'�����/������� �*����������������������+���������������8�����'��"��� ������������.��+���������������%�������+������������������%��������������������,���������!�����"���!������.��+���������������������������8�����!�'��39�:4�;

<� �����������(�� ��'���������������.��+����������������������������+��������/��(,���������+��������+�� ��������+�&����� ������������ �������'�������������+��������+�� �/������ ����/���� ��������'������!��� �������������������,�*���!���'���������������=��+��������,������ �������������������'����!�������������! � ��������������+����*����!���/�������������'������������������������������������������� ,� ���/����*����'������!� ������%������!���������+������/���������22�

9� �����������������,���������+��������+�� ��� ���(������%����������!���������,��.��+����,�����+���������/�����������!!���������+���������!�������.��+�������!������������,���������+��������+�� ������.���������+��'���� ���/������'�������������� ���������(����������!����������������� ����������������������+�������'����

"�+��������/������ ���!�������������*���*��������������>����!���������&���/���39:14�11-&5:::

��#�$��������#����!�����"��-�� ���������������� �2��������*���������!���������!�����.��+����������������!������������������������.��+��������������������������������/��(�+�������'�,��+����������������!�� ���.�������������+������*�����������++��+��������������.��+���������������"�.������������������3�4��������+�����������������%��������������.��+�����/�����+����������������=�������!�������

��!�������������%�������.��+����,��������������������������������+�������*������*�������������������!�����������!��������������������������������+�� �������.��+���������������*�� ��������������%��������+��*�����������!��������������������������������*���/������������+�������/���������*�'��������������� �����+��'������%����������!����'�����������������������"�+�������������!�����.��+������������*��������������* �����+���������'������%������* �������++�������� ���&+�������������������������* �������������������.��+����,�����.��+��������!��������,��� �%�'���������������������������+�� ������������.���������������������������������.��+�����

>�������������������!����������/��+������������������������������%�������������������!�����+�/��������� ,�����+��������������������������������/�����+�+��� ����,��!�+������,�����������������%������������+������������ �*��+���������� ���+����������������������2������?�>���������������������+�������(��������������������������'��,�*�����������������������++��+�����������������+��������������� ,���������������,�����++��+������@

-�� ���������"��%���.��'���������*���3"4�����%�����������������������'����+��'��������������������!�������8�&�������*����!���������������/������*���������������������+����������!��������������������������������!������ ���������!��� ����*���������!���'�������*6������� ����������.�����������������������!��������%����.��'���������*�����!����������'���������������8�����9�@

"�'�����A�����5B,�5::-

Page 7: Orion Manual

���

��������� �� ��

����/��� �������������������������������������������������������������������������������������������������������������������������������������������������� ��������22������01������������ �2��������!������������������������������������������������������������������������������������������ ��������!�������������� ����������������������������������������������������������������������������������������������������������������������������������������� '��������!���*��� ������������������������������������������������������������������������������������������������������������������������������������������������� �8��!�� ������� ������������������������������������������������������������������������������������������������������������������������������������������� 8

.���/��.0 � �� ����.�/�

* /�������������� ��� 1111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 *'*-&- ������������ �������������������������������������������������������������������������������������������������������������������������������� -&--&5 �������� ������������������������������������������������������������������������������������������������������������������������������������ -&-

( �2� ����3�� ������������. ��� 1111111111111111111111111111111111111111111111111111111111111111111111111111111111 ('*5&- ������� �������������������������������������������������������������������������������������������������������������������������������������� 5&-5&5 �'�����������������)�����+���� ��������������������������������������������������������������������������������������������������� 5&-5&7 )������� ������������������������������������������������������������������������������������������������������������������������������������� 5&55&7�- )������������ ��������������������������������������������������������������������������������������������������������������������������� 5&55&7�5 ����������������� ��������������������������������������������������������������������������������������������������������������������� 5&75&7�7 ����A����������8�������+����� ��������������������������������������������������������������������������������������������� 5&<5&7�< ��������)�����+���� ���������������������������������������������������������������������������������������������������������������� 5&<5&7�9 "�&575����� ������������������������������������������������������������������������������������������������������������������������������� 5&95&< )��+�� �A����� �������������������������������������������������������������������������������������������������������������������������� 5&95&9 �������%���������!����A������3��A4 ����������������������������������������������������������������������������������������������� 5&05&9�- "�&<19���/��( ������������������������������������������������������������������������������������������������������������������������ 5&05&9�5 ����������������������!��� ��������������������������������������������������������������������������������������������������������� 5&05&9�7 ����+����������3/�����+������������4 �������������������������������������������������������������������������������������� 5&B5&0 ���� ����������*������+�A������3���A4 ���������������������������������������������������������������������������� 5&B5&0�- �����������������������!����2���������� ��������������������������������������������������������������������������������� 5&B5&B ��/�����++���� �������������������������������������������������������������������������������������������������������������������������� 5&15&B�- ���!&2�����������/�����++� ���������������������������������������������������������������������������������������������������� 5&15&B�5 A����&C������/�����++� ����������������������������������������������������������������������������������������������������������� 5&15&B�5�- ������ ���������� ����������������������������������������������������������������������������������������������������������������������� 5&D5&1 ��������� ������������������������������������������������������������������������������������������������������������������������������������ 5&-:

4 �.��� ���� 111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 4'*7&- )��+�� �A����� �������������������������������������������������������������������������������������������������������������������������� 7&-7&-�- �2)��������)��+�� ������������������������������������������������������������������������������������������������������������������ 7&-7&-�5 �)����������������� ������������������������������������������������������������������������������������������������������������������ 7&-7&5 A����� ��������������������������������������������������������������������������������������������������������������������������������� 7&-7&7 2��������� � ������������������������������������������������������������������������������������������������������������������������������ 7&57&< �������������������% ����������������������������������������������������������������������������������������������������������������� 7&57&<�- ��������%�������EE�� ������������������������������������������������������������������������������������������������������������������ 7&57&<�5 ������%���������/��� �������������������������������������������������������������������������������������������������������������� 7&57&9 "���� ����������������������������������������������������������������������������������������������������������������������������������������� 7&77&0 )��+�� ��%�� ����������� ���������������������������������������������������������������������������������������������������������� 7&77&B ���(��)��+�� ��������������������������������������������������������������������������������������������������������������������������� 7&77&1 )��+�� ��%����!��/ ���������������������������������������������������������������������������������������������������������������������� 7&<7&D ������� ���������������������������������������������������������������������������������������������������������������������������������������� 7&<7&-: �����A��� ���������������������������������������������������������������������������������������������������������������������������������� 7&<7&-:�- )������������ ����������������������������������������������������������������������������������������������������������������������������� 7&97&-:�5 ���!��/����� �������������������������������������������������������������������������������������������������������������������������������� 7&97&-:�7 ����*������� ������������������������������������������������������������������������������������������������������������������������������� 7&9

Page 8: Orion Manual

��

��������� �� ����������

.���/��.0 � �� ����.�/�

7&-:�< ����������� ��������������������������������������������������������������������������������������������������������������������������������� 7&97&-- ���%��%����������� ������������������������������������������������������������������������������������������������������������������� 7&97&-5 �2����!�/��� ���������������������������������������������������������������������������������������������������������������������������� 7&9

+ ��� ���� ��� 1111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 +'*<&- ������������ �������������������������������������������������������������������������������������������������������������������������������� <&-<&5 ���������%�����)������� ���������������������������������������������������������������������������������������������������������������� <&5<&5�- >�+��(��%�����)������� ������������������������������������������������������������������������������������������������������������� <&5<&5�5 "���'��%�����)��������2�'�� ��������������������������������������������������������������������������������������������������� <&5<&5�7 )��������A������%��������� ������������������������������������������������������������������������������������������������������� <&5<&5�< )��������A������%��+����� �������������������������������������������������������������������������������������������������������� <&5<&5�<�- )������������������� ������������������������������������������������������������������������������������������������������������������ <&5<&5�<�5 ���!����A������%��+���� ����������������������������������������������������������������������������������������������������������� <&5<&5�<�7 ������A������%��+���� �������������������������������������������������������������������������������������������������������������� <&5<&5�<�< )��������A�������)��+�� �A�������+���� ��������������������������������������������������������������������������������� <&7<&5�<�9 ���!&2�����������/�����++� ��+���� ���������������������������������������������������������������������������������������� <&7<&5�<�0 8������������+����� ����������������������������������������������������������������������������������������������������������������� <&7<&5�<�B �����������+���� ������������������������������������������������������������������������������������������������������������������������� <&7<&5�9 ����(�����!�������������2���������� ���������������������������������������������������������������������������������������� <&7<&5�0 8��������������+�����������������3�+������4 ������������������������������������������������������������������������������ <&7<&5�0�- �����8������������������ ����������������������������������������������������������������������������������������������������������� <&7<&5�0�5 "����8������������������ ����������������������������������������������������������������������������������������������������������� <&7<&5�B A������%�����)������� ��������������������������������������������������������������������������������������������������������������� <&7<&5�B�- ���!����A������%������������� ���������������������������������������������������������������������������������������������������� <&7<&5�B�5 ������A������%������������� �������������������������������������������������������������������������������������������������������� <&<<&5�1 2��������%�����������+���%���+����/��( �������������������������������������������������������������������������������� <&<<&5�D ������������������������F����% ������������������������������������������������������������������������������������������������� <&<<&5�-: )����������!�/����2��!�%������� ����������������������������������������������������������������������������������������������� <&<<&5�-:�- )��������A���� ������� ����(�G��+�� �������������������������������������������������������������������������������������� <&<<&5�-- ��������%�����)��������2�'�� ����������������������������������������������������������������������������������������������������� <&B<&7 ���������%���������������3�+������4 ���������������������������������������������������������������������������������������������� <&B<&7�- )�������������������������� ����������������������������������������������������������������������������������������������������������� <&B<&7�5 ��+����/��(������������� ����������������������������������������������������������������������������������������������������������� <&B<&< ���������%��������� ����������*������+�A������3�+������4 ��������������������������������������������������� <&B<&<�- ���A�����/���������������� ������������������������������������������������������������������������������������������������������ <&B<&<�5 ���������%�����"�%�������%��������A �������������������������������������������������������������������������������������� <&D<&<�5�- ���������%��������A�/������������ �H�"�������� ������������������������������������������������������������� <&D<&<�5�5 "�%�������%��������A�/������������ �H�"�������� ������������������������������������������������������������� <&D<&9 ���������%�����)��+�� �A������3�+������4 ������������������������������������������������������������������������������������ <&D<&9�- )��������A�������)��+�� �A������������������ ��������������������������������������������������������������������������� <&D<&9�5 ���������%�����"������)��+�� �A����� ��������������������������������������������������������������������������������������� <&D<&9�7 )��+�� �A��������!�/��������+�3"�%�������%������2)4 ������������������������������������������������������������� <&--<&0 ���������%����!&2�����������/�����++� �3�+������4 �������������������������������������������������������������������� <&--<&B ���������%�����A����&C������/�����++� �3�+������4 ��������������������������������������������������������������������� <&-5<&B�- A�����������/�����++� ���������� ����������������������������������������������������������������������������������������� <&-5<&B�5 2��!�%����%�������/�����++� �!������������������ ����( �������������������������������������������������������� <&-7<&B�7 2��!�%����%���������*���"��� ��������������������������������������������������������������������������������������������������� <&-<<&B�< ���������%�����F����%�����A����&C������/�����++� �A������������������� ��������������������������������� <&-<<&1 ���������%������������%���������!����A������3�+������4 ������������������������������������������������������������������ <&-0<&1�- F����%�����"�&<19���/��( ������������������������������������������������������������������������������������������������������� <&-0<&1�5 ���������%����������&�������������%���������!����A������3��A4 ������������������������������������������������������ <&-0<&1�7 ������%�)��������������� ����������������������������������������������������������������������������������������������������������� <&5-<&1�< �������������2���(� �������������������������������������������������������������������������������������������������������������������� <&5-

Page 9: Orion Manual

��������� �� ����������

.���/��.0 � �� ����.�/�

<&1�9 2��������%�������+������������������������%���������!����A������3�+������4 ������������������������������ <&5-<&1�0 ��!�/����2��!�%������� �������������������������������������������������������������������������������������������������������������� <&5-<&D ����������/��&>+ ������������������������������������������������������������������������������������������������������������������������� <&5-

5 �2� �������/� 111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 5'*9&- ������������ �������������������������������������������������������������������������������������������������������������������������������� 9&-9&5 )������� ������������������������������������������������������������������������������������������������������������������������������������� 9&-9&7 ��+����/��(�)���%������������)������ ����������������������������������������������������������������������������������� 9&-9&7�- �������+���%���+����/��( �������������������������������������������������������������������������������������������������������� 9&-9&7�5 ����I������ ��������������������������������������������������������������������������������������������������������������������������������� 9&-9&7�7 ������������ ������������������������������������������������������������������������������������������������������������������������������ 9&59&7�< ��������� ������������������������������������������������������������������������������������������������������������������������������������ 9&59&7�9 �*�/,����������<9�)�%��� ������������������������������������������������������������������������������������������������������� 9&59&7�0 �*�/,����������D:�)�%��� ������������������������������������������������������������������������������������������������������� 9&59&7�B �/��+��*�/ ����������������������������������������������������������������������������������������������������������������������������� 9&59&7�1 .��'���������� �������������������������������������������������������������������������������������������������������������������������� 9&59&7�D 8����������+���%�������3��4 ������������������������������������������������������������������������������������������������ 9&59&7�-: ���+���%�������3��4 ������������������������������������������������������������������������������������������������������������������ 9&59&7�-- G����������8�� �������������������������������������������������������������������������������������������������������������������������� 9&59&7�-5 ��+����%���� ���������������������������������������������������������������������������������������������������������������������������� 9&79&7�-7 ���+���%����� ��������������������������������������������������������������������������������������������������������������������������� 9&79&7�-< � ����������+�������� ������������������������������������������������������������������������������������������������������������� 9&79&7�-9 >��������%�!����+������������������ ������������������������������������������������������������������������������������������ 9&79&7�-0 ���������������� ����������������������������������������������������������������������������������������������������������������������� 9&79&< C������!�I�� ��%���������������� ����������������������������������������������������������������������������������������������� 9&79&<�- A�������%�����������������)�!!�������� �������������������������������������������������������������������������������������� 9&79&9 ��+����/��(����+���%�� +�� ��������������������������������������������������������������������������������������������������� 9&<9&9�- )�����*�������+����/��(����+���% ������������������������������������������������������������������������������������������� 9&<9&9�5 "�������������������+���% ����������������������������������������������������������������������������������������������������������� 9&<9&9�7 "����������)�������+���% ���������������������������������������������������������������������������������������������������������� 9&<9&0 ��������%������+���%�A����� ���������������������������������������������������������������������������������������������������� 9&<9&0�- ����+�����2��������!!���� ��������������������������������������������������������������������������������������������������������� 9&<9&0�5 2��+�����"���� ���������������������������������������������������������������������������������������������������������������������� 9&<9&0�7 2��������� ������������������������������������������������������������������������������������������������������������������������������� 9&<9&0�< ������� �������������������������������������������������������������������������������������������������������������������������������������� 9&<9&0�9 �!!��������� ������������������������������������������������������������������������������������������������������������������������������� 9&99&0�0 F��������������%� ������������������������������������������������������������������������������������������������������������������� 9&99&B ���+���%���+����/��(�)���%� ������������������������������������������������������������������������������������������������� 9&99&B�- >���%�J����@�I�������7���!�/��� �������������������������������������������������������������������������������������������� 9&99&B�5 )�����*�������+����/��(����+���%�)���%� ������������������������������������������������������������������������������� 9&99&B�7 "�������������������+���%�)���%� ����������������������������������������������������������������������������������������������� 9&99&B�< "����������)�������+���%�)���%� ���������������������������������������������������������������������������������������������� 9&09&B�<�- )�������+���%���+��"�.��������� �������������������������������������������������������������������������������������������� 9&09&1 ��+����/��(������������� ����������������������������������������������������������������������������������������������������������� 9&09&1�- ���+���%������������������� �������������������������������������������������������������������������������������������������������� 9&B9&1�-�- 8����������+���%������ ���������������������������������������������������������������������������������������������������������� 9&B9&1�-�5 ���+���%������ �������������������������������������������������������������������������������������������������������������������������� 9&B9&1�5 ��+����/��(���*��� ������������������������������������������������������������������������������������������������������������������ 9&19&1�5�- ���+���%���+����*��� ���������������������������������������������������������������������������������������������������������������� 9&19&1�5�5 ���+���%��������*��� ���������������������������������������������������������������������������������������������������������������� 9&19&1�5�7 8����������+���%���������*��� ����������������������������������������������������������������������������������������������� 9&19&1�5�< ���+���%���������*��� ��������������������������������������������������������������������������������������������������������������� 9&1

Page 10: Orion Manual

��

��������� �� ����������

.���/��.0 � �� ����.�/�

6 �2� ���������������/11111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 6'*0&- ������������ �������������������������������������������������������������������������������������������������������������������������������� 0&-0&-�- 2�����������%�2���(������ ���������������������������������������������������������������������������������������������������� 0&-0&5 ���&2�����������%����+������� ������������������������������������������������������������������������������������������������ 0&-0&7 ��*�����A��������% �������������������������������������������������������������������������������������������������������������������� 0&-0&< ���!��/����� �������������������������������������������������������������������������������������������������������������������������������� 0&-0&<�- ��/����!��/����� ������������������������������������������������������������������������������������������������������������������������� 0&-0&<�5 ��%�����!��/����� ������������������������������������������������������������������������������������������������������������������������ 0&-0&9 �����������������I���!������� ����������������������������������������������������������������������������������������������������� 0&50&0 �����+���������I���!������� �������������������������������������������������������������������������������������������������������� 0&50&B ���������(��������% ���������������������������������������������������������������������������������������������������������������� 0&50&B�- �����������(���+�� ���������������������������������������������������������������������������������������������������������������� 0&50&B�5 F��������������� ������������������������������������������������������������������������������������������������������������������������ 0&50&B�5�- F����������������-�3�+������4 ���������������������������������������������������������������������������������������������������� 0&50&B�5�5 F����������������5�3�+������4 ���������������������������������������������������������������������������������������������������� 0&7

& ��3 �������� ������ 1111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 &'*B&- ������������ �������������������������������������������������������������������������������������������������������������������������������� B&-B&5 ����������A���������� ������������������������������������������������������������������������������������������������������������ B&-B&7 A��������������������� ����������������������������������������������������������������������������������������������������������� B&-B&7�- I������2���( ������������������������������������������������������������������������������������������������������������������������������ B&-B&7�5 ������ ��������2���( ����������������������������������������������������������������������������������������������������������������� B&-B&7�7 ���������(������ ��������������������������������������������������������������������������������������������������������������������� B&-B&7�< �����������������I���!������������ ��������������������������������������������������������������������������������������������� B&-B&7�9 �����+���������I���!������������ ������������������������������������������������������������������������������������������������ B&-B&7�0 )���������������'�� ����� ������������������������������������������������������������������������������������������������������������ B&-B&7�B 2�����)������� ��������������������������������������������������������������������������������������������������������������������������� B&5B&7�1 2�������������� �������������������������������������������������������������������������������������������������������������������������� B&5

7 ��3����0�� ��/����������� �������� ������ 1111111111111111111111111111111111111111111111111 7'*1&- ������������ �������������������������������������������������������������������������������������������������������������������������������� 1&-1&5 �������������������������������.��� ������������������������������������������������������������������������������������������ 1&-1&5�- I���������+������ ����������������������������������������������������������������������������������������������������������������������� 1&-1&5�5 ��/���2���(� ��������������������������������������������������������������������������������������������������������������������������� 1&-1&7 ����*���������% ������������������������������������������������������������������������������������������������������������������������� 1&-1&< "�+�������� ����������������������������������������������������������������������������������������������������������������������������� 1&91&<�- "�+�����%�����)������� �������������������������������������������������������������������������������������������������������������� 1&91&<�5 "�+�����%�����)������������ ���������������������������������������������������������������������������������������������������� 1&91&<�7 "�+�����%��������������������������������������������������������������������������������������������������������������������� 1&01&<�< "�+�����%���������A����� ��������������������������������������������������������������������������������������������������������� 1&B1&<�9 "�+�����%�����)��+�� �A�������������)��������2�'�� ���������������������������������������������������������������� 1&B1&<�0 "�+�����%�����"������)��+�� �A����� �������������������������������������������������������������������������������������� 1&11&<�B "�+�����%������������%���������!����A����� ��������������������������������������������������������������������������������� 1&11&<�B�- "�+�����%������������������������%���������!����A����� ������������������������������������������������������������� 1&11&<�1 "�+�����%��������� ����������*������+�A����� ������������������������������������������������������������������ 1&11&<�D "�+�����%��������!&2�����������/�����++� ����������������������������������������������������������������������������� 1&D1&<�-: "�+�����%�����A����&C������/�����++� ������������������������������������������������������������������������������������ 1&D

) .�� ����� 111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 )'*D&- ������������ �������������������������������������������������������������������������������������������������������������������������������� D&-

Page 11: Orion Manual

���

���������������� �

��/3�� � �� ����.�/�

-&- )������� ������������������������������������������������������������������������������������������������������������������������������������� -&-

5&- � +����������&������� ���� ������������������������������������������������������������������������������������������������������ 5&-5&5 � +������ �����/���������&�������������%���������!����A����� ��������������������������������������������������� 5&-5&7 � +������ �����/���������A�2����������������"���2������������ ������������������������������������������� 5&55&< � +������ �����/�������� ����������*������+�A����������2������������ ��������������������������� 5&55&9 )������������ ��������������������������������������������������������������������������������������������������������������������������� 5&75&0 )������������(�)��%��� ������������������������������������������������������������������������������������������������������������ 5&75&B ���������������������������F����%�)��%��� ������������������������������������������������������������������������������ 5&<5&1 ���� ����������*������+�A�������� ��� ����������������������������������������������������������������������������� 5&B5&D ���!&2�����������/�����++� �)��%��� ������������������������������������������������������������������������������������� 5&15&-: ����������2��&�/� �I��/ ����������������������������������������������������������������������������������������������������������� 5&-:

7&- ������)��+�� �������������������������������������������������������������������������������������������������������������������������� 7&-7&5 A����)��+�� ����������������������������������������������������������������������������������������������������������������������������� 7&-7&7 2��������� � ������������������������������������������������������������������������������������������������������������������������������ 7&57&< ������)��+�� ���������������������������������������������������������������������������������������������������������������������������� 7&57&9 ����/����)��+�� ���������������������������������������������������������������������������������������������������������������������� 7&57&0 �������)��+�� ���������������������������������������������������������������������������������������������������������������������������� 7&77&B ���(��)��+�� ��������������������������������������������������������������������������������������������������������������������������� 7&77&1 ���!��/�)��+�� ��������������������������������������������������������������������������������������������������������������������������� 7&<7&D ������� ���������������������������������������������������������������������������������������������������������������������

Page 12: Orion Manual

����

���������������� ���������

��/3�� � �� ����.�/�

9&- ���������� ������������������������������������������������������������������������������������������������������������������������������ 9&-9&5 G����������8���!�����+����%����� �������������������������������������������������������������������������������������������� 9&59&7 A�%�����������%� �������������������������������������������������������������������������������������������������������������������� 9&79&< "�������������������+���%�A����� ���������������������������������������������������������������������������������������������� 9&99&9 "����������)�������+���%�A����� ��������������������������������������������������������������������������������������������� 9&09&0 8����������+���%������ ���������������������������������������������������������������������������������������������������������� 9&B9&B ���+������������ ������������������������������������������������������������������������������������������������������������������������ 9&B9&1 ���+���%���+����*�� ������������������������������������������������������������������������������������������������������������������ 9&19&D ���+���%��������*�� ������������������������������������������������������������������������������������������������������������������ 9&19&-: 8����������+���%���������*�� ������������������������������������������������������������������������������������������������� 9&19&-- ���+���%���������*�� ����������������������������������������������������������������������������������������������������������������� 9&1

0&- A�%����������������&>+ ������������������������������������������������������������������������������������������������������������ 0&5

1&- "�+�����%�����)������������ ���������������������������������������������������������������������������������������������������� 1&91&5 ���������������������������F����%�)��%��� ������������������������������������������������������������������������������ 1&01&7 "�+�����%��������������������������������������������������������������������������������������������������������������������� 1&B1&< "�+�����%���������A����� ��������������������������������������������������������������������������������������������������������� 1&B1&9 "�+�����%�����)��+�� �A����� ��������������������������������������������������������������������������������������������������� 1&11&0 "�+�����%��������� ����������*������+�A����� ������������������������������������������������������������������ 1&D1&B "�+�����%��������!&2�����������/�����++� ����������������������������������������������������������������������������� 1&D1&1 "�+�����%�����A����&C������/�����++� ������������������������������������������������������������������������������������ 1&-:

Page 13: Orion Manual

��

�����������

���� � �� ����.�/�

-&- )�������������������+���!������� ������������������������������������������������������������������������������������������������ -&5

5&- )��+�� �A�������+���!�������� ��������������������������������������������������������������������������������������������������� 5&95&5 ��A��+���!�������� ���������������������������������������������������������������������������������������������������������������������� 5&05&7 ���� ����������*������+�A�������+���!�������� ������������������������������������������������������������������ 5&B5&< ���AH�����������������������!����2���������� ����������������������������������������������������������������������� 5&B5&9 ���!&2�����������/�����++� ��+���!�������� ����������������������������������������������������������������������������� 5&15&0 ���!&2�����������/�����++� ������� ��+���!�������� ����������������������������������������������������������������� 5&15&B A����&C������/�����++� ��+���!�������� ������������������������������������������������������������������������������������ 5&D5&1 A����&C������/�����++� ������� ��+���!�������� ����������������������������������������������������������������������� 5&D5&D A����&C������/�����++� �����������+���!�������� ������������������������������������������������������������������� 5&D5&-: ���(&�+������� ��+���!�������� �������������������������������������������������������������������������������������������������� 5&D5&-- ������ ������"�.����������������� ����������������������������������������������������������������������������������������� 5&D

7&- �)������� ��������������������������������������������������������������������������������������������������������������������������������� 7&-7&5 A����)�����+���� ����������������������������������������������������������������������������������������������������������������������� 7&-7&7 ����/�������������'��� ����������������������������������������������������������������������������������������������������������� 7&57&< �����A����)�����+���� ��������������������������������������������������������������������������������������������������������������� 7&<

9&- �������'�� �"��%�� ��������������������������������������������������������������������������������������������������������������������� 9&-9&5 �*�/�.��'���������� ��������������������������������������������������������������������������������������������������������������� 9&59&7 A�������)���������������'�� �������%�!���>���+��������������% ������������������������������������������������ 9&7

1&- ����*���������%������ �������������������������������������������������������������������������������������������������������������� 1&51&5 �������%���������!����A���������2��+�����2������������������ ������������������������������������������������ 1&51&7 ��������� ����������� �������������������������������������������������������������������������������������������������������������� 1&71&< �������%���������!�������)��������2����������������*���� ������������������������������������������������������� 1&71&9 ������������������������)��+�� �A����������2�����+����)��+�� ���������������������������������������������� 1&<1&0 )�����������2��+�����2����������������*���� ���������������������������������������������������������������������� 1&9

D&- ���������� ������������������������������������������������������������������������������������������������������������������������������������ D&-

Page 14: Orion Manual

��������������

��� ���� ����.����3 ����

���� �����������������!����/��%�/�����������+��*���&!�����������������/�������%&����������*���� ?

WARNING!

�8!������!�����"!������ ��!�����%���������������������9�: �0���'������8��;��#�<������!1����������������"!������ ��!�%��!��!8�����1� ��������: ��;��#�������������="� #���#�;%��#���%;�!#�8������>�!����!�������!�$�#�"��$��!����!������������%�����������"�������!��?1�����������# ������������$��!8��$��!�� !��������"����"����������#��"������!�����"�!����1

CAUTION!

� ����������������;��#�� ��!"����� ����%����;�������8!�������!#����"��%;�-��!#��@��#%������������$����������: ��;��#�#"���%�#�����!�%��!���������##���������1�� �����������������"�%� ��8�� ��� �;��#�� ����������!� �8��� �8��� ��� %��<�!�"�� �#%���� �#�<� �!� �!���"���������!��������!� !�������������� !������!�1��A�# �������"���� ������������"��%��<������$%���!�!��#�$�#��"����"!�����!����!� !��������!�� �����#���!�"� !�������������"!������! !���1

����#�����!����#"���%����"�����!���#���#"#���������<�����%����"���"!����������!#�����"�������������#�;���"������8����8������#�<��!� �!���"����������"!������� !������!�1� ���#�����!���� !�����������!#������#����� !� !��������!�������8��;$����!#���!����������;����������!����� ��������1

CAUTION!

3���������!��" !�������;��#���3�!������!�"#����������"�����������: ������!�%�"�����!���;������������!�����������!��" !�������;��#1�B���"��������������!�����!��" !������;��#$����������: ������!����"�� !�8�����������������������������!���'?�����������;��#1

CAUTION!

�����������!����;�� ����!����� ��# ������ ���#�"��� ����%��#���%;� �#���� �#�"������� ���������!����;1�B�����������������# �������!�#�"��$���!����������������!������!� ��!��!�"����8��1

/����������� 2��� ����

���� ����!����/��%������*���*���'���������������+�����������!�� �

���������������� ��� ����������������������������� ���� ��� ����� ��� ��������� � �������� ��������� ��������������������������������� �� ��������������� ��� ��� �� ���������������� ������� �������������������������� ��������������������������������������������������������������������������� � ����� ������� ����� ������ ��� �� ����� ������� ������� ��� ��� ��������� ������ ������� ������� ��� ��� ����� ���� � ���� ��������������� ����� ���!���� ��������������!����������������� ����������� ������ ������ ��������� �� ���������� ��������� ������ ��������������������� ��� ��������� ����� ������������������ �� �������"#� ����������� ����������� ���� ������������������ �������� ����� ����������� ����� �������$%&!�$'(�)*+� �

��� ������� ��������������

+� ���� ������ ��� ����� ������ �������� ������������ ����������������������� �� ����������� �� �������������������

,� -��������������������� ���������!����� ���������������������� ������������������.���

/� 0��� ������ � �� ���������!� ��� ��� ���� ��� �� �����!� �� �������!� ��� ���� �����!� ��� �� ������ �� ����� � ��� �1��������������� ��� ��

2� 0���������� �������������� ��������� �������!������ ����������� ��1����������� ���

Page 15: Orion Manual

�������� ���� �������������

������������� �������������������������������

����������� ����� ��������

*'* �� ���3� ���

����������������������+�������,�������������,������������,����*���������%�����+������������!���������!��������"��#$����%���������'�� ����(��)���������� �����

�����"���$��)����������������(�����������/������������&�������!�������������������'������������������+��������&����� �+��� ����������F���� ���������� ��'���� ��� ��/� ��:�:::B9KH!��,������"���$��)������������������'������%�������������'���*���+���������!����*����������������������&%�����%��!�+�������E����!�����'��������%��I2�/����������&�������������������� ���+������,���� ������ ����%��� ��� �����*�������'����!��*���������������%���������+��������%���!��!�����)��������������%� ���� ����+����� ���%������/�� ����� !����������'��������,�+����*� �+��'�����%����������������!����!�������������,����������������E��%�!��������%���� +��������� /�����%����(�������������++����������!��������"���$�)�������������������������������!���������,������+������&��%�!���������,�������������/����������

����������!������"���$�����)�� ���������������!����������+���%�+�+�����/��(,���������*�������%���������'�� ���&��������������������%�&�!!������ �������!�%��� !�������(�������������������+�������* �����%�����!���������/�����!�������+�������������������%���������+���%�+�+�����/��(,�*��(��������������������,�/�������������������� E���!�������+���&������!����(��

*'( ��� 3���

����!����/��%������������!���6���!���������!������"���$�� �����

L ���%�����*��� �������'�� � ���%�� �!� :�:::B9KH!��� ��:�7KH!���3:�::59KH�����-KH�4��*���������

L ������+���������������%���������%

L �����������E����������������M���!�����

L >+����5:,:::��.��!����!���'���%�

L �/��+��%�����*�����������'���������/��+��%�����*��+��&��������'���

L 2��!�%������������������ ������������� ������&'������������

L ������ � *�!!��� �����%�� �!� �+� ��� 51� �� �� �!� ���(�������

L ��'��������%����+��������%�!�������

L ��������!�%������������%��"���2��!�%����������!�/���

L A�����������%��!���!����������� ����'����%

L ��/��(���� �������!��+����-5B����������������%�����������%���������!����A�����

L �������������+���*���/���������/������������ ���������*������+�A�����

��%����-&-��)�������

Page 16: Orion Manual

������������� ����� ����

������������� ������������������������������

���

��*���-&-��)�������������������+���!�������

DESCRIPTION SPECIFICATION

Detector Sensitivity Range 0.00075%/ft. to 0.3%/ft. (0.0025%/m to 1%/m)

Maximum Coverage 20,000 sq. ft. (2000 sq. m)

Input Voltage 24 Vdc nominal (18 to 30 Vdc)

Input Current 310 mA standby, 342 mA alarm

Operating Temperature 32º to 120ºF (0º to 49º C)

Operating Humidity 10 to 93% RH non-condensing

Enclosure Rating NEMA-1 (IP-31)

Finish Light Grey Polycarbonate with Painted Steel Backbox

Dimensions 12.6" W x 8.98" H x 4.25" D (32.0 cm W x 22.8 cm H x 10.8 cm D)

Alarm & Pre-Alarm Relays Four relays; each has normally open contacts, 2 Amp @ 28 Vdc, resistive

Trouble Relay Form C, 2 Amp @ 28 Vdc, resistive (energized on power-up)

Isolate Relay Optional: Form C, 2 Amp @ 28 Vdc, resistive

Electrical Connections 18 to 12 AWG (0.75 to 2.5mm 2 ) wiring to removable terminal blocks

Service Port Connection RS232 communications with modular RJ12 jack. Requires Orion Configuration Software

Remote Display Connection Optional: 1 pair RS485 communications, 1 pair power

Power Supply Supervision Input Optional: Monitors normally closed contact on power supply

Air Inlet Port 3/4" NPT threaded

Exhaust PortSide exhaust, optional rear exhaust with supplied adapter, optional 1" NPT threaded exhaust pipeconnection with supplied adapter

Weight 8.0 lb. (3.6 kg)

Page 17: Orion Manual

����� ���� ����������������

������������� �������������������������������

������������������ ���� ������������

('* /������

��������+����+��'�������!����������������+����������'������+���������!������ ����,����/�������!����������������+������!� ������6��� ���+������� ����� ��%��������(�� �+� ����"��#�$��� �����

('( ���������3�� ������������. ���

�����"���$��)��������/�������%����/��������!��8�*���� ��������!����/������ �!������������������+��������%�����5&-����5&5����/����� �/����!!���������!�%��������� ���������!������+�����%��������� +���!���������+������������� �����

����� +����������&������� ������������"���$��)������������!����%������!������������������+�����* �����%��������� ��������������������)��������3������%����5&-4�������"��$��)������������.��++���/������8����� �?����&������-,����&������5,�������-,�������5,�����*������������������%����5&-���/������)�������������'��%�+�/���!���������!&2����������/�����++� ,�*�����5<�I���+�/�����++�����* �����!�����������������+��������A����&C������/�����++� ��� ������*�������

FIRE ALARMCONTROL PANEL

LOCAL COMPUTER

RELAY OUTPUTS

BOARD

TERMINATION

RS232

PORTFAN

DETECTOR

HEAD

DETECTOR

TROUBLE INPUT

PRE-ALARM INPUT

ALARM INPUT

NETWORK

PIPING

(OPTIONAL)

SELF CONTAINED

POWER SUPPLY

��%����5&-��� +����������&������� ����

��%����5&5���������������� +������ �����/�����������&������������%���������!����A������3��A4�������������!�%�������,�����"���$��)���������/��������������!����������!�����������������+�����/�������� �����������*�����/��(�����%�����/�����������&��������A�����������/���+����-5B��"���$�)������������*�������������������!�%�����!�����������������������������A�����'����*�������/��������?

L �H�BB&5DB--<&::-�3/������������4

L �H�BB&5DB--<&::5�3/���������4

UP TO 127 DETECTORS

REMOTE COMPUTER

TEL PORT

TERMINATION

HEADDETECTOR

DETECTOR

PC PORTRS-232

INTELLIGENT INTERFACE MODULE(IIM)

STANDALONE ENCLOSURE

PORTRS-485

FIRE ALARM CONTROL PANEL

TROUBLE

ALARMCONTACT

CONTACTTROUBLE

INPUT

TROUBLERELAY

AUX. TROUBLE INPUT

AUX. ALARM INPUT

PIPINGNETWORK

FAN

BOARD

RELAY OUTPUTS

RELAY OUTPUTS

BOARDTERMINATION

DETECTOR NETWORK

DETECTOR

FAN

HEAD

PIPING

WITH MODEM AND OCSLOCAL COMPUTER

WITH OCS

ALARM ANDTROUBLE

INPUTS

��%����5&5�� +������ �����/���������&������������%���������!����A�����

���������'�� ,������������A�����*�������������������������"���2�������������������/�������%����5&7������������,+��&������� ���� ����*��� ����������� ���� ��+������ ��� ����"���+����������%��������A����������!�������������.���������������/����%��������)������������ ����������

Page 18: Orion Manual

������������� ����� ����

������������� ������������������������������

���

�����"���$��)������������*��������������������������&�*������+��!��������� ������"�������������%������� ���������*������+�A������3���A4�3������%����5&<4��F����������A,������"���$��)���������+���������������!��+���599�������������'��������������������*������+�

PEGAsys/ARIESControl Panel

DETECTORTERMINATION

PORT

RS-232

BOARD

FAN

HEAD

PIPING

NETWORK

PALM

LOCAL COMPUTERWITH ORION CONFIGURATION SOFTWARE (OCS)

DETECTOR

PIPING

NETWORK

DETECTOR

FAN

HEAD

DETECTOR

TERMINATION

PORT

RS-232

BOARD

PALM

UP TO 255 LOOP DEVICES

PEGAsysRX/TXMODULE

SLCLOOP

OR

ARIES

��%����5&<�� +������ �����/�������� ����������*�����+�A����������2������������

�+����������+�� �����+�/�����++� ����!�%������������������'����*��� �������"���$��� ����������������������+�� ���!�%���������!�����"���$��)��������������� �����������������)�!���+�����������++����������/������������������'������������������!��������������������������.�����,�����+&�������)��+�� �A������/������*��(�����2)������������*�����&��������������)�������������)��+�� �A����������/����������������������!�������������������������(����'���,����+���%+�+�����!��/����������������������!�%��������������%��������+��!���������������������!����������������������,�����,���&������������������

�����"���$��)������������!������!!������+�/�����++� ���!�%�����������������!&2�����������/�����++� � ��� ��&��%�������+��'����5<�I���+�/��������)��������!����-5:���5<:�I��������� ������/���������+����"���$��)��������,��A����&C������/�����++� �����+��'����5<�I���+�/���!����+�����%���)���������!����-5:����5<:�I����)�������������������'��5<�I���+�/�����++�����* �����!������������������+��������� ������������++��'���+�/�����++� �

('4 �� �� ��

�����"���$����%�&�������'�� ����(��)�������,�3�H�BB&5DB-:-&:::4�����������!���������+����������������������������,�����%�&�!!������ �!����������������������������*����3������%����5&94������������������+�����������*����+�����/������� ����'��%� ���� ��������� !���� ���� ������������������"���$��)�������,�/�������������� �����+�+�����/��(����%��������%�J����@�I�������7���!�/���,�+��'�������'&���%��!������������+����5:,:::��.��!��

5&7�- )������������

���������������������������+����������!����*�������������+��������������/������������+���������������������������*����'���������/����:�::-9KH!��,�����������+�������������������������'������%��������������'���*���+���������!����*���������������������%�����%��!�+�������E����!�����'��������%��I2/���������������������������������+������,��������������%�����������*�������'����!��*���������������%���������+��������%��!�!���������)�������������������� �������������'�� ����%��!�:�:::B9KH!������:�7KH!���3:�::59KH�����-KH�4���/������������/��+��&��������'��������+��%�����*���/��������������%������%���"���2��!�%����������!�/����3�2�4�

���(������������������������������* ��������%��������&*����!����������+����������!����+���!�����E�������%�'�������+��������������!��������+��������������������/�������%������������������,�+�������������������/������+���������%����-::&���������!������������*���������*���������!��������!!��!����+���������������������'����������������������������� ��!������!��������������������� ��!�������!�������������������������E��!�����+��������������������������=��+����������E������������&����� !�����������/����� ����+���!��� ���%���!�+���������3*�&�/����:�:-�����-:��������4����*�������������������������+���������!����*���������� ����%��*�'�����*���/��������%�����%������� ��%�������������������������*����������(���%��������������������������������������*����������+����

UP TO 127 DETECTORS

REMOTE COMPUTER

TERMINATION

HEADDETECTOR

DETECTORPIPINGNETWORK

FAN

BOARD

BOARDTERMINATION

DETECTOR NETWORK

DETECTOR

FAN

HEAD

PIPING

WITH MODEM AND OCSLOCAL COMPUTER

WITH OCS

ARIES PANEL

IIM

RS-232CONNECTION

��%����5&7�� +������ �����/���������A�2���������������"���2������������

Page 19: Orion Manual

����� ���� ����������������

������������� �������������������������������

��� ������������!� ����+����������!����*������� ���%���)���+��������,�/���������� +����� � ���%��������-:��������,�����%���������������������!��/������%��������������������/���&����!�������������!��/������������,�!���������������������������!��������'�� ��������!���������%%��%���������������

����)����������������������������!��/����������%����������������������������������!�����!��/��%������%�����������&���������/������!!���������E�������������������!��/�����*�����%����������!�����!��/��!����������%����������������8���������%�&���!��/��������������!�����*���/�����/&���!��/�������&������������������������+��%�����*��������%���2��

DIRECTION OFAIRFLOW

LASER BEAM (–)

LASER DIODE

VIEW FROM UNDERSIDE OF DETECTOR HEAD

RECIEVE OPTICS

BEAM DUMP

OPTICSTEST LED

AIRFLOW MONITOR

SIGPROC

CARD

5&7�5 �����������������

����������������*����������������������������������!�����)�&���������� �!���������!� ����������������*����� �����������!����/��%?

L ��/��(&���� ������������������������/����

L ���� ����������*������+�A���������������

L �����,����&�����,�����*���������������"��� �

L �������������8����������+����������������

L ��&*���������� ������%�

����)�������������������+������!������������%������!�����������������+�����

�!�����)����������������������������"�����������+����,������������!�����������+����������%������������%���������!���A������3��A4������������������*�����������/��(����� �!���������������������A�/������+��&����������"�&<19�����������������/��(���������)����/������3��������%��+��5&9�!����A��������4�

����)�����������������*��������������������� ������"&�����������+�����/���������� ����������*������+�A��&����3���A4������������������*�����������+��%&������������!����������A�3��������%��+��5&0�!������A��������4�

INTEFACE CARDS(optional)

PEGASYS ADDRESSABLELOOP MODULE (PALM)

TERMINATION BOARD

DETECTORHEAD

REMOTE LCDDISPLAY(optional)

LCDDISPLAY(optional)

STATUS LEDFACEPLATE

FAN

SERVICEPORT

RS232 TO COMPUTER

TE

RM

INA

TIO

NB

OA

RD

LASERRADIATION

ATTEN

TB

2

F1

P2

P7

P8

STATUS POWER OUT0V

POWER IN

PRE 2PRE ALARM 2ALARM1ALARMCM

1

M/TERM

1

PC

INT

ER

FA

CE

L/T

ER

M

NO CM NOALARM 1

CM NO CM NOTROUBLE

CM NC NOISOLATE

CM NC NO

MAIN LOOP- + +-

EXTERNAL DISPLAY+24V - + - + + + +---

PSU

1

1

1

1

1

��%����5&0��)������������(�)��%���

��%����5&9��)������������

Page 20: Orion Manual

������������� ����� ����

������������� ������������������������������

���

CABLE ASSEMBLYTERMINATION BOARD/TRI-COLOR LED

CABLE ASSEMBLYTERMINATION BOARD/PORT RS-232

PROGRAMMINGPORT

CHASSISGROUND

CABLE ASSEMBLYTERMINATION

BOARD/DETECTOR

DETECTORHEAD

FAN

CABLE SUPPLIEDWITH FAN ASSEMBLY

CABLE ASSEMBLYTERMINATION BOARD/LCD DISPLAY

PEGASYSADDRESSABLELOOP MODULE

DISPLAY

FRONT PANEL OPTIONS(LCD DISPLAY OR STATUS LED)

STATUS LEDFACEPLATE

MAIN LOOP EXTERNAL DISPLAY

0V +24v– – – – – – –+ + + + + + +

TB1

PSUSTATUS

POWEROUT

POWERIN

SW

2

M/TERM

ON

1P

9

INT

ER

NA

LD

ISP

LA

YIN

TE

RF

AC

E

P4R

EL

AY

EX

P/L

OC

AL

AS

ER

STA

TU

SL

ED

P6

P1 LK

1

RL2RL1

PRE ALARM1 PRE ALARM2

RL3 RL4 RL5 RL6

CM CM CM CM CM CMNO NO NO NO NO NONC NC

ALARM 1 ALARM2 TROUBLE ISOLATE

TB

2

POWER ONLED

PC

MA

INL

OO

PA

DD

RE

SS

SW

1R

ES

ET

P5

LK4BAT1

LK

3

DE

T.

HE

AD

FA

NA

DJ

P7

FA

N

LK2

PR

OG

RA

M

TE

RM

INA

TIO

NB

OA

RD

1

1

+

1

FUSE F2LITTLE FUSE 1541AT

��%����5&B�����������������������������F����%�)��%���

��������������+����������������������� ������"��,����)�����������������!�����������+����������%�����������������*��������� �������������������*�����������8����� ����������*�������!��������!����%������!������������������+����?���/������,��/��+��&�����,���������*��������������������������&�� ������������� ��+����8��+�� !��� ���� ����*��� ���� ���������*������� ����������� ��������������/���������!������������&��'���������!�����)��������������+�/���

���� -��"��� ������������'�����/��������%������� ���������*������+�A������3���A4�

5��������A������������ �����+���*��

����������!�����������������������������,������������������8����������+����������������������������)�������������%�����������������*����������������������*�������������'&�*�������������!���!�����/����%���������8����������+�������������������8����������+�� ������������+�/�����++� ����&����������+��������������������������������,�!��,��������)��������%���������+�� ��������������������������������&���������*����������%��+��%&��������������3��%����5&94�

����������������*�������&*���������� ������������)����&�������!�%��������������%�,����(�������� ������'������%���������'�����!���+�/���!������,���*����� �*��(���+���������� !����++��8������ �����������

���� ����*����� �*��(&�+� 6��+��� 3��74������*�����&�������!������������ �*��(&�+����!��������+��+&��� �3������%����<&74���!�����6��+�������������������,���� ���!�%�������� ������%�� ���� ������ ��&*��������� �/����*��������!�����)��������������+�/���

5&7�7 ����A����������8�������+�����

�����"���$��)�����������������%�&�!!������ �������!�%��!���������/���������������� �!��������+�������������,�������+�+��%����/��(����������%�������������������������%������'����%�������++������������!����������!�������������������*������������������������������������+�������+���������������+��!�������������������* �J����@���!�/����

����)������������*�����!�%�����!�����������������8�����+����������)��������������++���!������������!��������/����� ������8������ +���� ���!�%����������/���+������� �8��������+����� ���� ��++����� /���� ���� )�������N����� �8��������+��������-@��������������8������+�+�����+����3�������%��+��<&5�0�!����8������+�����������4�

5&7�< ��������)�����+����

����������������!�%���������!�����"���$��)�������� ���.��++���/��������������)�!���+������������������)�!���&

Page 21: Orion Manual

����� ���� ����������������

������������� �������������������������������

+����������+���������������������/���������&�������)����������&����������!����/��%�����������?

2��������������� ������������%������ ����&����+#2���������� ����/ ����*��H���������������%�"�� ���&�����2����������"�� �����

5&7�9 "�&575�����

�����"���$��)���������������"�&575�+��%������%�+��������������������!��������!�����)��������������+�����������%�2���������������'�����+��%������%���*����������"�&575+������2��+��'����� �����*���� � ����������,� ���!�%���������/������������ �!��������)��������

('+ ���.��2����3��

����)��+�� �A�������������+�����������������!���������+��&'�����'������ ������������!� ����)����������������������*���������������2)����������������������!���*��(���������������2)� ������,� ��������������� ������� �)����� ��� ���������������������)�����������������������'������"�&<19����&���������������(�������++�����5<�I���+�/����������)��+�� A������3������*���5&-4�

�� �!���������!�����)��+�� �A������������������!����/��%?

L ���(�����2)�)��+��

L A�����'�%�����������%��!�����������(� ���������������(�

L �2)� ������� ����������� �!� )�������������� �������*���������

L "����,�����,������������������������������

L A����&���������)�������������!������,�����*��,���&����������������2���������

L ���%�����*����������������!������,����&�������������*���2���������

L ����/��������������

L A������������������5&���%���8����<@����(*�8

L �'����*��� ��� �%����,� �+�����,� ������� ��������%����

��������2)�������,�����&�������������������������+�� ����������� &��&���,�������������!�����,�/�������� ���������'�������������������+�� ����>���%�����������=����������(� �,���������������'�%���������%�����������'��/������������&!�������������+��!���������������������!����������A������&�����*�������� �������������&��������(�� ��'����������!��/

��'��,������,�+��&�������������!��/��������������������*������������������ �'����*��� ��������� �������� !��������� ������������ ����,� �������,� ������������������������������� !���&����������+���/����+���������

�������������������������*��+��%������������%���2����+��'�����������*��������������/������������,�+��&������������*���������������������������� ��������������*�������&�������/���������������������������������������������������&��%�������������(� ���������������������������*�����������������'�������������������?

L ������2��������?�2��������������

L ���&������2��������?������������������

L ����*���2��������?������������������

����������������)�+��'�������'������������������!��������&���������������������������)���+���������!����/��%������&�����?

2��������������� ������������%������ ����&����+#2���������� ����/ ����*��H���������������%�"�� ���&�����2����������"�� �����

����)��+�� �A�����������/����������������+��������������&���������������*������%���������������"���$��)������������������������� ,��+����-:::�!����/� �!����������������,��������������5&%��%����<@�*��(*�8�

����)��+�� �A����������'����*�������%����,��+�����,����������������%������ �H� BB&5DB-:5&:::� ��������� �%����,�+����������������O��H�BB&5DB-:5&5::�����������%����,�+���������������%�����

��*���5&-��)��+�� �A�������+���!��������

DESCRIPTION SPECIFICATION

Input Voltage: 24 Vdc nominal (powered from Detector)

Maximum Input Current:30 mA (normal) 104 mA(with backlight ON)

Operating Temperature: 32° to 120°F (0° to 49°C)

Operating Humidity: 10 to 93% RH, non-condensing

Electrical Connections:

Detector Mounting: Via supplied plug-in harness

Remote Mounting: 18 to 16 AWG (0.75 to 1.32 mm 2) wiringto terminal block, mounted up to 1000 ft.(300 m) from Detector

Shipping Weight: 1.6 lb. (0.7 kg)

Dimensions:4.76" W x 5.74" H x 1.56" D(12.1 cm W x 14.6 cm H x 4.0 cm D)

Page 22: Orion Manual

������������� ����� ����

������������� ������������������������������

���

('5 �� ����/�� ��� ����������3���C���D

�����������%���������!����A������3��A4�+��'��������������&����������(�������/��(��+����-5B��"���$��)��������������+�����������%��2����!�/��������������������/���������A,�������������%�������������+��������������������+����'���������������������/�������"���$��)������������*����+����� ����!�%�������������������!������������������&������2�����������!�����+�����������+��������������/�������&��%�������!������ �����/����������������+���������������������&���� ����� ����������+�������� ����������������!��� �"���$��)���������������������*�������������

��������������*�������������,�������������!�%�������,�����&��������(���������!��/���'�����������(�������� ���������&�������!���������)���������'�������"�&<19����/��(���������A���������/��(����������*��������������������������!��������������������������%��2����!�/�������������������������&+��������������������+�����'�����������

��A�+���������������������������&'������������� ������&�������������+��%������%�/����*������������%������+����+�/���!������������!����/��%�!����&+��%�����*���+����������������!�%����������%�������2����!�/����

L ����������+��������*����!�������&�������.�����

L �/��� ������������/������������������%�

L ����������+���/���

L �/����+���/���

L )�����������+��'���������*��H����*��

L ����������!�����������*��H����*��

L 2��!�%�������� �!� "�&<19� ���/��(� !��� �� ��� <����� ���0

L ����*�����+��������

L ������� ������*��(�����������*��H����*��

L 2����*��(�+��������*��

5&9�- "�&<19���/��(

���"�&<19����/��(�����������+����-5B��"���$��)����&��������������A������)���������������%���������������������"�&<19����+�'�����)����/������������������������)����&���������"�&<19����/��(�����*��/����� !������������ ���<32������4������ ���0�32������4�/��������8��������+����%���!�<,:::�!���������"�&<19����/��(�/����%����������������� ����������/��(��������������������������)��������/���������������!������������������/���������!�/����

5&9�5 ����������������������!���

������A�����'����*�������������&�����H�"������+���*�����!�%�������������������������������������������������%���!��� ���+��'����,�*�&������������"�&575���������+������+��&'����������(�����/��%������/����������'���,��/��+��&�������'�������������+�������*�����������������*��������������!���������"���$��)���������������+�� ������������������+�������+�� ��F���������������� ����*������������� ��� �����'��,����+�����/��������'����+��&+��%����������+��������������/���������������������*�����+�����"�!�����������"���2��&!�%����������!�/����3�2�4�A�����,��H�:0&570:-5&<:-�����"��� 2��!�%�������� ����� 3�2�4� >���P�� �����,�H�:0&57097:&::5�

F�������������/��������"���2�����������������������������&����������,� ������A������������+��������������������������*���������������������!����������+��������������!���,������"���$��)�������� ���������� ����*��� ������������� *�/������������!����������+��������������%�E�����������*������� ���������A�����/������!����������+������������������ �!�������������A��������"�&<19����/��(����������*������� �/������������'���� �!� ���� ��A� ������+�/����������+��'�������8����� ��������������*�������������+�������������A�����*������������������������� ��������������� �!����������+�����!��������&��� ���������������!����������������������*����������������������+��������*�����+�� �����������������+����������������������+�����������%��2����!�/�����3������*����5&7�4

��*���5&5����A��+���!��������

DESCRIPTION SPECIFICATION

Input Voltage: 24 Vdc nominal (20.4 to 28 Vdc)

Maximum Input Current: 70 mA (normal) 80 mA (alarm)

200 mA (with modem active)

Operating Temperature: 32° to 120°F (0° to 49°C)

Operating Humidity: 10 to 93% RH, non-condensing

Enclosure Finish: Painted steel enclosure with keylock,Red

Trouble Relay: Form C, 2 A at 30 Vdc

Auxiliary Inputs: Auxiliary alarm and trouble inputs, Class B

Electrical Connections: 18 to 12 AWG (0.75 to 2.5 mm 2) wiring toremovable terminal block. PC and TELconnections via RJ-12 jack.

Shipping Weight: 3.9 lb. (1.8 kg)

Dimensions: 8.4" W x 8.25" H x 2.5" D(213 mm W x 210 mm H x 64 mm D)

Page 23: Orion Manual

����� ���� ����������������

������������� �������������������������������

5&9�7 ����+����������3/�����+������������4

������A�����'����*���/��������+��������22��++��'�����&���� !��� ����������������%������������� '����� ����+���������������!�������+��'����������*���� ��������� �����������A!����������������+����,����'��/�����&��������(���������&!��/���'���,�����(�������������!�%���������������/����������� � !����������"���$��)������������� ��A�����*�+��%���������������������� ������������������+�������&��%��+����������+����������+��������*����������������&�������!��� ��"���$��)���������������������*������������,����� !������������������+�������������� ����*��� ��+���� �!���������!�������������������������*��������������!��������&*��,����������������������������������+��������*���/����*�������!�+��%�������

('6 .�/��2�����������������.���3���C.���D

�������� ����������*������+�A�������������������%������+� ��'���� ����� ����/�� ����"���$����%�&�������'�� ���(��)�����������*��������� �������������������� �H�"�����2� ��������*��� ���+���������A�+��'����� ��&��������!��8�*���� �������������%���%�&�������'�� ����(����&�������,�* �+��'����%������!��������)��������*��(����������� �H�"���!������������������+�����

���� �������� ��+������������������/����I������1:�:������%����

�������A���������������������*�����2����+,�����%�����������������������������������>+� ���599���������*����'������!��� ����*�������,���������%��������A,��� �*��������������������2����+���������A������.������!��������"��� $�� )�������� ����� ��� ��� *�� ���������� ��� ������� �H�"�����2����+�

�������A�����������+��&�����,������������+������8�����*�������%�������������� �H�"�����������A����!��� ���&+��'�������������������� ����������������+������!��������A�����"���$��)���������>���%����������!����������!�������� �H�"���+����,�����&��������(���������!��/���'&��������*��������������!�����������A��������+�� ���������+�����������������,�����������������'�� �����������*��+��&!������!��������������������+�����

�������A���������%�����������*����������+��%������������(���������������������*����������������"���$��)��������������� &��&�����������A�J���+�@��!!�������� ���������������&��%�����/����������.����������8��������/���� ��� ���������!�����������%� �������A,���� � !�'�� !�����/����%�������&�����������������!���������2����+�����%���������/�����+��'���������������A�'�������������������*������������&������������!��������A�����*�����+������/�������������3������%����5&0�������*���5&74�

���%������%��!��������A�3��������%���!����%������"���������4����������� ���/�������%����������/���������&+�����������%��2��I�������5�7�������������������������� �������)��������"�&575�+����

��%����5&1������ ����������*������+�A�����

��*���5&7������ ����������*������+�A������+���!��������

DESCRIPTION SPECIFICATIONS

Input Voltage: 5 Vdc (supplied by termination board)

Maximum Input Current:125 mA at 5 Vdc (supplied by terminationboard). Adds 20 mA at 24 Vdc toDetector current

Operating Temperature: 32° to 120°F (0° to 49°C)

Operating Humidity: 10 to 93% RH, non-condensing

Electrical Connections:18 to 12 AWG (0.75 to 2.5 mm 2) wiring toremovable terminal block

Shipping Weight: 0.3 lb. (0.2 kg)

Dimensions:3.94" W x 2.17" H x 1.56" D(10 cm W x 5.5 cm H x 4.0 cm D)

5&0�- �����������������������!����2����������

����������������A������������<����������������� �9�I��+�/���������%������������!��������������������*��������*��5&<�������*�����������������������

��*���5&<�����AH�����������������������!���2����������

Terminal Number Signal Name Function

1 I/O Port RX Communications

2 I/O Port TX Communications

3 Loopback PALM Connected

4 PCI-RST Reset

11 5 Vdc (-) Power

13 5 Vdc (+) Power

Page 24: Orion Manual

������������� ����� ����

������������� ������������������������������

���

('& .�B����3..����

�����"���$��)������������!������!!������+�/�����++� ���!�%�����������������!&2�����������/�����++� � ��� ��&��%�������+��'����5<�I���+�/��������)��������!����-5:���5<:�I��������� ������/���������+����"���$��)��������,��A����&C������/�����++� �����+��'����5<�I���+�/���!���+������%���)���������!����-5:����5<:�I����)�������������������'��5<�I���+�/�����++�����* �����!�����������������+���������� ������������++��'���+�/�����++� �

5&B�- ���!&2�����������/�����++�

�������!&2���������-5:H5<:�I�����/�����++� ������*� +��'�������+��'�����5<�I���+�/���/����<&�����*��(�+�!�������%����"���$��)����������������'��������+�������+���������-5:�I������5<:�I�����+���'����%�����������������&.������������'����%����������������+�������������������%�3������%����5&D�������*���5&94�

������������������������+�/�����++� H*����� �����%�������/�������������&�����*���������������/����+��'����+�/���/���<�������*����� �*��(&�+�!�������"���$��)�������,���(&��%����������!������%���E���������������++���������������!������ /��������%��� �+�/���� ������

����+�/�����++� H*����� �����%�����+��'�����������+����2+�/��,�����*�����������������*����� �����%����������*�����%&����+��'�����+�/�����++� ���+��'��������������"���$�)��������������������������������������+�/�����++� �

�������!&2����������"���$��)�������������*� ������&��%����!������!�����������%�/������+�������������*��(*�8������ ��%���%�� �+�� ���*��������'��������/����%�!�������+�/�����++� ��������)�����������������������%���������%(���(��������������+��!�����+�/�����++� ������������*��&�����!������"���$��)��������

��%����5&D�����!&2�����������/�����++� �)��%���

������+� �/�������&B5���.���������,��������!&2����������/�����++� ������*��+�/�����!�����������%��� �+�/������������������*��(����+�* ���������������������%,���%���&���'���%���������

��*���5&9�����!&2�����������/�����++� ��+���!��������

DESCRIPTION SPECIFICATION

Input Voltage:120 or 240 Vac 50/60 Hz. Must be fedfrom an emergency power circuit.

Maximum Input Current: 333 mA at 120 Vac, 200 mA at 240 Vac

Operating Temperature: 32º to 120º F (0º to 49ºC)

Operating Humidity: 10 to 93% RH, non-condensing

Output Voltage: 28.75 Vdc

Output Current: 1 A maximum

Battery Charge Voltage: 27.3 Vdc

Battery Charging Circuit: 500 mA

Trouble Output: Normally closed TTL logic

Electrical Connections:18 to 14 AWG (0.75 to 2.08 mm 2) wiringto terminal block

Shipping Weight: 7.4 lb. (3.4 kg)

Dimensions:12.6" W x 4.55" H x 4.25" D(32 cm W x 11.5 cm H x 10.8 cm D)

��*���5&0�����!&2�����������/�����++� ������ ��+���!��������

DESCRIPTION SPECIFICATION

Nominal Voltage: 12 Vdc

Capacity: 2 AH

Construction: Sealed Lead-Acid

Termination: 0.187 quick disconnect terminals

Dimensions:5.91" W x 3.50" H x 0.79" D(15 cm W x 8.9 cm H x 2 cm D)

Shipping Weight: 1.54 lb. (0.7 kg)

5&B�5 A����&C������/�����++�

����A����&C������/�����++� � ������/������%���++� �/���*����� �*��(�+����������'�����+����<�:���+��������������5<�I���!������-5:����5<:�I�����+�����������������!���������+������?� ����+�/�����++� H*����� �����%��%�������,-5�I��,�77���+&�����*��������,���������������������������������+�/�����++� ������/��*�������������������8��������&!�%�������,��/�������������*������������������������������������*������,�!������������!�00���+&������

Page 25: Orion Manual

����� ���� ����������������

������������� �������������������������������

����A����&C������/�����++� �+��'�����*����� �+�����������'����%����+��'�����,�*����� �����%������+�����+��'���������%������!�������+��'�������������������������/������%��'�&*������,������+������������� �����+������������������������A����&C������/�����++� ����>�-<1-�������,��A��++��'��,����>�2�������������+�/�����++� �!���!����+�������'����%���&��%�����3������*����5&B,�5&1�����5&D4�

��*���5&B��A����&C������/�����++� ��+���!��������

DESCRIPTION SPECIFICATION

Input Voltage: 120 or 240 Vac 50/60 Hz

Maximum Input Current:2.4 A at 120 Vac1.4 A at 240 Vac

Operating Temperature: 32º to 120º F (0º to 49ºC)

Operating Humidity: 10 to 93% RH, non-condensing

Output Voltage: 27.3 Vdc with 0.28 Vpp ripple

Output Current:Up to 4 A. Actual current depends onconfiguration. (See Table 2-10).

Battery Charge Voltage: 27.3 Vdc

Battery Charging Circuit:Two, each protected by a 6.0 A PTC and1.5 A current limit.

Trouble Relay:Normally closed contacts (selectable fornormally open) 1 A @ 28 Vdc, resistive

Electrical Connections:18 to 12 AWG (0.75 to 2.5 mm 2)terminal wiring

Shipping Weight: 3.5 lb. (1.6 kg)

��*���5&1��A����&C������/�����++� ������� �+���!��������

DESCRIPTION SPECIFICATION

Nominal Voltage: 12 Vdc

Capacity: 33 AH

Construction: Sealed Lead-Acid

Termination: 1/4” ring lugs

Dimensions:7.75” W x 6.4" H x 5.2” D(19.7 cm W x 16.3 cm H x 11.7 cm D)

Shipping Weight: 26 lb. (11.8 kg)

��*���5&D��A����&C������/�����++� ����������+���!��������

DESCRIPTION SPECIFICATIONS

Dimensions:17.25” W x 14” H x 6.25” D(43.8 cm W x 35.6 cm H x 15.9 cm D)

Shipping Weight: 12.1 lb. (5.5 kg)

5&B�5�- ������ ����������

������ ���E�����*���������������*����!�*��(&�+���������&.��������������� ����������������/��� +�����*��(&�+���&.��������������!����������/�����������%��� �%��������,���5<�����������������������������,�0:����D:������������*����.����������������������������/����� +����� �!�'�����&����,��8��+��/����D:��������!�*��(&�+������.������������������,� -:� �������� �!� ������ �������� ��� �������� �����*���5&-:�����5&--��������������*����� ���E���������8�&���������* ���������

���� �����������/�����+�������������������+�/�����++� ��������������*������������������8�����<�:���+��������8����������!������������'�����������������5�9��+��

��*���5&-:�����(&�+������� ��+���!��������

Backup Hoursand Battery Size

(Two 12Vconnected in

series)

UL and FM(48 Hour

Battery Recharge)

ULC (24 Hour

Battery Recharge)

Standby(Normal

Operation)Alarm

Standby(Normal

Operation)Alarm

2466 AH

(2 x 33AH)2.5 A 4.0 A 2.0 A 4.0 A

24 33 AH 1.2 A 4.0 A 1.2 A 4.0 A

4 33AH 3.6 A 4.0 A 3.4 A 4.0 A

���� ������ �������� ��� ���� ������ �������� ���/O� ����� �������* ���������+����������������������������%�������������������

��*���5&--�������� ������"�.�����������������

TotalStandby

Load( )

x Required Standby Time ____ hr. =

Total AlarmLoad

( )x

Required Alarm Time(for 5 minutes or for 10 minutes)

0.084 or 0.167=

Basic Amp Hours(Add the results)

=

X 0.1(Basic AH x Derating)*

=

Minimum Amp Hours Required(more is OK) Add the Basic AH

+ Derated AH=

* This is based on an average battery temperature of 68oF. The batterymanufactuer should be consulted for further derating information. Inorder to have batteries meet the full backup period after two years ofoperation, a minimum of a 10% derating has been included.

Page 26: Orion Manual

������������� ����� ����

������������� ������������������������������

����

('7 ��3 ��� ��

�����+���������������������������������+����������+���������������/����������������+����������������������(�����!��/�!���� �����%�,�/�������+������%��������%��+�����������������������������������������!����������������/��������' ����������!���&���*������� +����������� ��� �8+�����,� ����� ���/���&�������

ENCLOSURE

O-RING

IMPACT PLATEAND SCREEN HOUSING

IMPACT PLATE

SCREENS

ENCLOSURE

(EXHAUST)

(INPUT)

��%����5&-:������������2��&�/� �I��/

Page 27: Orion Manual

�������� ���� �������������

������������� ��������������������������

����������������� �

4'* ���.��2����3��

�����"��#�$��)��+�� �A�������������+�����������������&!���������+��'�����'������������������!�����)���������������������*����������������2)���������������������!����++����&������/�������������������������������������������������&������!�������������+��!����*����������������������!��������/����������������!������+�����

7&-�- �2)��������)��+��

����)��+�� �A�����������������*��(����������������2)����������+�� �������2)�����������+�� ������&����������&������������������ &��&���,�������������!�����,�/�������� ��������'��������������������+�� ���

����)��+�� �A������*��(��%������ ��++����������%�����'�����������,� ����� ����������������*��,� ���/���� �� (� � ��+������������*��(��%���/����������!!��!�����������+�� ����(� �����������'��!��������������

����!����/��%�����������+�� ��/��������� �����+�/�����+����/���������������������*�����������������

��%����7&-��������)��+��

7&-�5 �)�����������������

�������&�������),����������������!������!�����)�����������������*��������!����������!�����)��+�� �A�����,���������������������������������������������*���7&-�

��*���7&-���)�������

LED INDICATION SYSTEM STATUS

Continuous Green Normal

Flashing Green Auto-Setup™

Continuous Yellow Isolate/Trouble

Flashing Red Pre-Alarm

Continuous Red Alarm

4'( ���3��2� ��

)��+�� ����������* �+������%��� �(� ������!����/��%��������������+�� ?

��*���7&5��A����)�����+����

MENU DESCRIPTION

SilenceSilences the internal sounder. (Displays only when anAlarm or Trouble condition is detected.)

ResetResets the Detector after latching alarms or latchingtroubles have been cleared. (Displays only when anAlarm or Trouble condition is detected.)

Status Displays the current detector status.

SmokeDisplays alarm sensitivity settings, pre-alarm settings,and current smoke level.

Airflow Displays airflow thresholds and settings.

Isolate Allows the user to isolate and de-isolate the detector.

Test Menu Options for detector test.

Exit Returns to Normal Display

�����(��������������!������������,��������!����/��%?

-� >��������+�3 4�������/��3 4�����/�(� �������%���%�� �����������

5� ������������3 4�

��%����7&5��A����)��+��

Page 28: Orion Manual

������������� ����� ����

������������� �������������������������

���

4'4 ��� ����E�2�

����)��+�� �A�����=����������(� ������/���������������'�&%���������%�����������'��/������������!�������������+��&!���������������������!����������������������(� ��������!�������!����/�?

UP DOWNLEFT RIGHT ENTER

��%����7&7��2��������� �

>���������%���3 4������/��3 4�(� ��������������/�����������>�����!��3 4�����+�3 4������������+����������

������������3 4�����������������%���%���������������

4'+ �������������������/

F��������������������*������������������������,�����!����/&��%��������������+�� ����������������������������/��������&'���,� �!�+��'����� ����*���������%���"���2��!�%���������!�/����3�2�4�I�������7�:�

��%����7&<��������)��+��

7&<�- ��������%�������EE��

���� ��������� �������� ����*��+��%������� ���+��'����������*��������������/������������,�+��&�������������*������&���������������������� ��������������*��������������/�������&����������������������������������������������%������������(� ��

����������������������������*������!����/�?

L ������2��������?�2��������������

L ���&������2��������?������������������

L ����*���2��������?������������������

����������������������,��������!����/��%?

-� �������� �(� �������+�� ����������

5� ��%���%���Q�������Q�����+�����������3 4������+���/������+�� ��++�������������%����7&9�

��%����7&9������/����)��+��

7&<�5 ������%���������/���

���������������������!�������������+���/����+�����������/���'�����!�+���/����������'����*����������)��+�� �A�����,�/�������� �����������������!�����+���/���������!���������������������!����/�?

��*���7&7������/�������������'���

ACCESSLEVEL

MENU ACCESSDEFAULT

PASSWORD

Monitoring Status, Smoke, AirflowNo password

required

OwnerAll monitoring menu access plusSilence, Isolate and Reset

1234

Installer All owner menu access plus Test 5678

���������������!������/����+���/���,��������!����/��%?

-� F������������/����)��+�� �3��%����7&94��������� ��+&+����,�����-���������� ���%���%������������������3 4�����������%�������������,�����������(�3R4����+�� ���������*��&�����!�������������>���*��(�+����3��������/�� �*��*���/�����B4�������������+��'��������� �

5� >�����������/�(� �������%���%����������������%����!����+���/�����������������3 4�

7� "�+�������+�5������������������������!��������%�����!����+���/����

<� F���� ������� !���������������%� ����+���/���,���%�&��%�����������(����(�����+�����������3 4�

���������%��Q����/����I����Q����+�� ������ ������������������������������

�!� ���������������+���/�������������� ,����������%��Q����&/������'����Q����+�� �������������������������������������

�!���(� ��������+�������!���7:��������,�����+���/����/���*��������'������������������/������'�������&����������+���&/�����������'������+���/����+���������!��������

�������+�� ��������+���/���������*������%��������%��2��

Page 29: Orion Manual

�������� ���� �������������

������������� ��������������������������

4'5 ����

����J"����@����������������������)���������!�����������%�����������������%�����*������'��*���������������������������������++����������%��������������*����������������� ���+���/���������.�������������������)��������

���������������,��������!����/��%?

-� �������� �(� �������+�� ����������

5� ��%���%���Q"����Q�����+�����������3 4�

7� ����� ���� +���/���� ��� ������*��� ��� ����%��+�7&<�5��F�������������%��Q����/����I����Q����+�� �,����)����������������������������������������������������

4'6 ���.��2��/��2� ���� � 3�

������+�� �� �����������,��������!����/��%?

-� �������� �(� �������+�� ����������

5� ��%���%���Q������Q�����+�����������3 4������!����/��%����������+�� �?

��%����7&0���������)��+��

7� F���� �������!��������/������������������+�� ,�+������ �(� �����������������������

��������������+�� �����������������!��/,�+�/�����++� �����3��>4,���������+��������%������32�>4,����A����������&���������������� ��3�2�����4,�)������������)��+�� �A��&���� !��� ����*��� ������������ ������� ���+�� � ����� ���������/�����������)������������*������������������!���%�����'��&�%��%�����*�������*����

��%�����'���%��%����������� �����*������������*�����*���'����2�������)������������*����������������%������)��+�� A����������2��

4'& ���E�����.��2

�������(�����+�� ���������������� ����+�� ���/����'������������������*������������������/������������������������%�������+������

�������'�����������(�����+�� ,��������!����/��%?

-� �������� �(� �������+�� ����������

5� ��%���%���Q���(�Q�����+�����������3 4������!����/��%����������+�� �?

��%����7&B�����(��)��+��

7� F����!��������/�����������(�����+�� ,�+������� �(� ����������������������

�������(�����+�� �����������+�� �� �������(�� ��'���*��%��+�,�����������������������������������������+��&���������������������%����������(����'���*���%��+�,�����������������!��������!�����������,��������������������������(����'����� �� +�������%�� 3:K� ��� -::K4� �!� ���� )�������=�� +��&%��������������'�� ����%����������*��������������+��&�����������������������+�� ������������%����!�����*���%��+��

>����� ������� �+������%� ����������,� ����/�����"A���++������*�'����������������������������������������������������+�� ���������������"A,��"&���"A,��"�>��,����������������F��������)�������� ��� ��������,��� �����,�+��&�������������*��������������/��������*�����+�� ���������)��+�� �A������

Page 30: Orion Manual

������������� ����� ����

������������� �������������������������

���

4'7 ���.��2��/�������B

������+�� ����!��/����������������������%�,��������!����/��%?

-� �������� �(� �������+�� ����������

5� ��%���%������!��/�����+����������� 3 4������ !����/��%����������+�� �?

��%����7&1�����!��/�)��+��

7� F���� �������!��������/�����������!��/����+�� ,�+������ �(� �����������������������

����!�������������+�� ������&��������!��/���'��������������5����7����/�����+��%���������%��������/����!��/�������&������)�!�������%���������������5:K�������!�������/�������&�������N5:K�������<����/�����������������!��/��!!����������/�������%�����!��/�������������������!��/��������E���������*��+��%�������'����2��

4') ����� �

��������%�����)������������*�����������������+���,�����/��%����)�����������*���������/�������%��������%��������������!����������+��������������*������+���/����*������'�����/��������!�������������*����

��������������)�&������������)�������,��������!����/��%?

-� �������� �(� �������+�� ����������

5� ��%���%���������������+�����������3 4�

7� ����� ���� +���/���� ��� ������*��� ��� ����%��+�7&<�5������!����/��%�����������+�� �?

��%����7&D���������

<� �������)�&��������������������������������������������������

4'*, �� ����3

��������%������A����!������������������+��'���������!��&��/��%��+������!���+��!�����%����%��������������������)�&������?

��*���7&<�������A����)�����+����

MENU DESCRIPTION

Detector Performs a detector sensitivity test.

Airflow Disables the fan to perform a low airflow test.

Trouble De-energizes the trouble relay to test trouble reporting.

Status Performs a test to verify all inputs are working.

Exit Returns to normal display.

���+��!����������,��������!����/��%?

-� �������� �(� �������+�� ���������������

5� ��%���%��������A���,�����+�����������3 4�

7� ����� ���� +���/���� ��� ������*��� ��� ����%��+�7&<�5������!����/��%�����������+�� �?

��%����7&-:�������A���

�����(��������������!�������������A���,��������!����/��%?

-� >��������+�3 4�������/��3 4�(� ��������������/������%���%�����������������

5� ������������3 4�

Page 31: Orion Manual

�������� ���� �������������

������������� ��������������������������

7&-:�- )������������

���+��!����������������������'�� �����,��������!����/��%?

-� ��%���%���)������������+�����������3 4�

5� ����!����/��%�����������+�� �?

��%����7&--������

7� ����*���%��+���������������B:K��!�!������������������&+�� �/�������/���������)��!��������������+����������������'�� ��������!��������������!�������������,��������&+�� �/�������/���������)�

7&-:�5 ���!��/�����

�������*�������!������+��!��������/����!��/�����,��������!��&��/��%?

-� ��%���%������!��/�����+�����������3 4�

5� ��������������/�������+�� �Q)���*��Q��!����Q���!��/Q�

7� ��/���/����*������'���!��������!����������!��/����������+����&9:������/����!��/�����*���/����*��%��������/�����������!��/����+��*���/���������������

<� ����Q���(�Q��������/�������+�� �Q����Q�

9� ����Q������Q��������/�������+�� �Q���!��/���/Q�

0� "������������������A�������%���%������!��/�)���*������+�����������3 4������!���/�����������,��������!��/�����*��/������������������)��������/���������������������

7&-:�7 ����*�������

�����&����%�E����������*������� �������������*�����+�����%�������������+����,��������!����/��%?

-� ��%���%�������*�������+�����������3 4�

5� ��������������/�������+�� �Q����Q��!����Q����*��Q,������������*������� �/���������!���!���-:���������

7� ������������!�-:��������,�����)��������/������������&���� ������������������

7&-:�< �����������

���+��!������A�����������+�����������'���! ����������)����&���� ����� ��+���� ��� ���� ������������*��������� !���������%�������� ,��������!����/��%?

-� ��%���%��������������+�����������3 4�

5� ���������/�������������!������'������������,��������+�� /�������/�Q������Q��!����Q������Q�

7� ����)��������/���������������� ������������������

4'** ���/3�/������� ���

����)��+�� �A����������'����*�������%����,�������,��+��&����3�H�BB&5DB-:5&:::4�����%����,��+�����,������%����3�H�BB&5DB-:5&5::4��F�����������+�� ���������������������������%��%��������������������++�������������%��%������������������ ���� ����� *�� ��������� ��� �� � ����� * +������%�������!��3 4�������%���3 4�(� ������������������/�������������������������

���������������%��%�,��������!����/��%?

-� >��������������(� �������%���%����������%��%���!� ����������

5� ������������3 4�

��%����7&-5�����%��%������������������

���� ���� ��!�/���� '������� �!� ���� ���+�� �������� �����/�����������/�����%�����������!��������%��%������������������

4'*( ������� B���

�2�� I������� 7�:� ��� �8+������� ��� ���� �"��� $�2��!�%����������!�/����>���P�������,�3�H�:0&570:-5&<:-4�

Page 32: Orion Manual

������������� ����� ����

������������� �������������������������

���

THIS PAGE INTENTIONALLY LEFT BLANK.

Page 33: Orion Manual

�������� ���� �������������

������������� �������������������������������

�������� � �������

+'* �� ���3� ���

��������+����+��'�������!����������������� ����������������"��#�$��� �����������������������������!�����!����/��%���+�?

-� >�+��(�!�������++��%��������

5� )����������+���������������!���)��������

7� �������������8������+�������+����3�+������4�

<� A�(������(���(�����!���!�����/����%�����*����� ����&���������

9� A���������)��������

0� ����������������������3�+������4

B� 2�����������)������������������+���%�+�+�����/��(�

���� ������������������+����������A��� �*�����������,��!�����

1� 2�������!�����/����%��������)�������

������������� ����� ��������������+���������A,��!��������*���%�����������/����������*�������������������������������������!&2������������A����&C���������� �� ������!�������+��������*���%�����

D� ���������������!&2������������A����&C���������� �� �����!�������+��������*���%������

-:� ��/��&�+�����+��%��������)�������

���� �!��������A����*���%�����,�����������*��+��%�����!�����

�����+�������)��+�� �A�������������*�������������������)�&���������'���*�!���������������%�������'��������,������+������"������)��+�� �>������ ���/�*������������

����������������������� �*�������* �!����� ���������������&������ ��� �����������/���� �++����*��� ������������� ��.����&��������������������?

L 2�B0:�3������������������2���4

L ���&B5�3�����������������������������������4�

L �� ����������������������������.����������

���� ��/����������*����������!!������%��������������

ATTENTION

OBSERVE PRECAUTIONSFOR HANDLING

ELECTROSTATICSENSITIVEDEVICES

CAUTION!

�� �� � ���.����3 ����

B��� �������� ��;� ���!��� ��# ������ �!��!�"���%��!�$������������ !��"������#"���%��!!�� �"�1� ����"!� ��� �� ���#�;� !�"��� ����# ������#��1

��������������%������*����������* ��������%��������!����/&��%�%���������?

-� ��/� ��������������'���������������������������!��������&+������������������%�,��!���������%��� ������

5� F������/���������+�/������������%���'�����������������%����%�������������������������%�����

7� �'�����*6��������������������'����'�������������%���'�&������'��������%�����������!���������'������ ���������������/��������+�������������������

<� �'���� +�����%� �������'�� ��'����� ����� +������� ��� '�� ����!�����

9� A�����E�������������%��!��������'����'����������������2��������������3�2��4�

���� ���� !����/��%� �������� ����/�����%������ *�� �*&���'��������%�������������+����

CAUTION!

������0�F���

������!������������"!�����������!;'���"����������������������'4�����!� !�"���������8���%��!�������1

WARNING!

�������:.��3��� �������

�A���A ��"!�����������'4�����!��!���;�!����!���;�#�;���"���8!��#���������"#���;1

Page 34: Orion Manual

���������������� ����� ����

������������� ������������������������������

+'( ��� �����/� 0���� �� ��

<&5�- >�+��(��%�����)�������

�����/�����+���������*���/������+��(�����)��������!����������++��%��������

-� 2���(�������������++��%���������������������!����/��%?

L �"���$��)�������

L 8���������� ��*��� !��� ����/�����������%� ��� ��J�+����&��/�@������������

L ������(������������%������8������+�������+�������������8������+���

L 2�����������%�2���(������

5� "���'������)��������!���������������

7� ���+��������)������������������������������%���������������%����++��%�

<� ��������)����������������*������!����

<&5�5 "���'��%�����)��������2�'��

�����/�����+���������*���/��������'�����������������'��?

-� ���������������'��� ��������������������������������&�����* ��/����'������(��%�����/���������*�������!����)�������������/������������*�����������+��!�����)����&����������������'������(��%�����/����.�����������,������+��+�������������������'���!���,���������(���������������'���

5� ��!������*�����������!����������������'��������������/���*�������(�!�������������������������+��!������������������������������'����������������������)��������* ��/�����+����������������������*������������������)�����������������������+�� ��������

7� �������������������!��������)�������,�������+������+���������!��������������������/���������������������(� �������� �!� ������������������������!!������ ,����������������������������������*��+�������!!�

<� >�+��%�������������)���*�������������+�� ����������*��!��������������������*������������'��������/���������!��������)�������������������'���������

<&5�7 )��������A������%���������

2�������� ����!����/��%�%����������/�����������%�����+&+��+���������������!����������%�����)�������?

L ����)���������������*����������������������+����*���������+������������������������E�������+�����������������������������������������+���%�+�+�����/��(�

L ����)���������������*�������������������E���������&*����!�D:���%����*���������������������������)����&�����������+�+��%����/��(������� ��������/��%����������������� ���+��������)�������������������������+�+��%��������������*�������.������!��������������������������

L ����)�������������*���������������������/������������+������������������%���������������������,������/����������������+������+��������������������������+���%�+��������������+���%�+�+�����/��(����*������%=���I�2�!����� �+�����'�� �+�������E�����+����/����������*������%���!����)������������������������������/���������+����������%�������������������+���%�+�+�,������������������������������!��/������%������+�+��/����������

L ����)���������������*���������������������/�����������*�����������!�����������������������

L ����)���������������*��������������������������*��!������������������������������%��+����������������&������������������,�!������������%��+����,����+�� ����&���� '���*���� ,� ���!&���������� +�/��� ��++� � �+����,�8������+������������������

<&5�< )��������A������%��+�����

)���������������%� �+����������� *�� ����������� +����� ���������%�������������������%���������������!����/��%�+���&%��+����8+�������/����������������������%��+����������!&!������������������������%����������

<&5�<�- )�2��"��"������

����)���������� �*��������������/����������������������*������������%��&������+�/��������������+�+�����������+��!������������J�+����&��/�@�/��������������+�+���������*�������!��������������J�+����&��/�@������������� ������'������� !����*&!������++����������

�������J�+����&��/�@������������,������8���������������� �&�������*����������*���++������������)�������,��'��������8&�����%���*��������,��!������+�� ��������������������,��������+�� ��������������*������������J�+����&��/�@����/����3��!���������%��+��<&9�-4�

<&5�<�5 �>"��2�A�>���������

����)���������� �*��������������� ����!����/����!����S-:����/����!�����)�������������������������� �/���,�����!����� �/������������!��������������%�����/�������������������++���,����%���%�����������/���������%�����/��/������/������������������������F�����������%������/��������,���(������ �!� �� � (���(����� ��� �8������ �+������ ������� � *�*���(���* ��������������+�����������%��������������(���(&��������8�������+�����

<&5�<�7 ��>���A�>���������

����)���������� �*��!�������������/������/����* �����%��!���������������&���%�3�H�BB&5DB---&:::4������������������++���,����%���%�����������!���������&���%�/������/�������������������������!�����)�����������!������������,�����!����/&��%��������%��������������++� ?

L ����)��������������� �*���8�������������%�����������8������+����

L ����8������� /��������(������!�9H1&�����

L ���!&2�����������/�����++� ��������*�������/�����!�������������)��������

Page 35: Orion Manual

�������� ���� �������������

������������� �������������������������������

L ����/���������*���������*���!�����������������������������+���%� +�+�� ���/��(� ���� ����������� �������� ��� ���)��������

L ���������������������*������������������� �����������&+���%�+�+���������!�����)��������

<&5�<�< )�2��"�A�>�)�)����� �A�)>������

�!������+�� ��������������������������)�������,�����������*���������������������������%���/������������+�� ��������������� �'��/��������������*�����!�������������+����*��,��������������%��!��������+�� �����������������������3��!���������%��+��<&9�54�

<&5�<�9 ���&2����)���F"��>��� �����

���� ���!&2��������� ��/��� ��++� � ��� ����%���� ��� *�����������6�������������*�������!�����)������������������*��!���������������������)���������������*����������J�+&����&��/�@�/���������������������!&2�����������/�����+&+� �

����������������A�"�&<19���/��(������������������������+�� ��������������������������������������%���������������+�(���(�����*�����������*������(���(�������������!����������!&2�����������/�����++� ������������

<&5�<�0 $��>�����"��������

����)������������*���8�������������%��������������������!����)����������!�����)������������������������/���������������'���� ���� ����� �8������ +���,� ����)������������� *�� �8&�������������%������������8��������!�����)�����������!�����������,�����)�������������*���8�������������%�����������8������+����

<&5�<�B �>�"����"������

�!����������%���������������������� �������������+���%�+�+��������!�����)�������,�����)���������������*��!�����������������)��������������������*���������� ����������� ���������/�����%������������!������������������

<&5�9 ����(�����!�������������2����������

����)��������������%�����������(���(������������!�����/��&��%������%�������(���(���� ����������������T&�����3-5�B��4�����U&�����3-D�9���4���E����!���������%������!&2��&���������/�����++� ��������)�������,�����������!��(���(������ ���� *�������!� ����)�������� !������!&2�����������/����++� �/����%�

<&5�0 8��������������+�����������������3�+������4

����)�������������/���8�������+�����,�������8��������������8�������2�����������8�������+�����/�����*�������������+�����������++���������

<&5�0�- ��)�$��>�������������

����)��������������++���!��������!����� �/��������������8&������+����+��&������������!��������������������,�!����/�����+��&�������*���/����������������������8������+�������+����

-� "���'������������8������+�������+���,� �!��������� ������ ����������8������+�������+���� ��� ����������!� ���)�����������������������������!��������!��������������+�����*���������������!����������������%����+�����������������8������+�������+�����/� �!��������)���������������'��

5� ����������������8������+�������+�����������+����,����%�&��%��������+������*�����������%����!�������������%����+��

7� �����������������8������+�������+�����������!���/������(��%���������������������+������*������������%������������������%����+��

<� >�������-&���������8������+����!�����%,���++�����/��������)�������,� ���������� �����8������+���� ��� �����8&������+�+�����/��(�

<&5�0�5 "�"�$��>�������������

�����/�����+���������*����/����������������������8������+������+����

-� "���'������������8������+�������+���������� ���������8������+�������+�����������������!�����)����������������������������!��������!��������������+������*��������&�������!����������������%����+������������������8�����+�������+�����/� �!��������)���������������'��

5� ����������������8������+�������+�����������+����,����%�&��%��������+������*�����������%����!�������������%����+��

7� �����������������8������+�������+�����������!���/������(��%���������������������+������*������������%������������������%����+��

<� >�������-&���������8������+����!�����%,���++�����/��������)�������,� ���������� �����8������+���� ��� �����8&������+�+�����/��(�

<&5�B A������%�����)�������

����)�������������/���������%��+�����,����!�����������%����!������������%�

<&5�B�- �>"��2�A�>��������������

�����/�����!����/��%�+���������������!��������������)�&�������

-� "���'�����������������'���

5� ���+��������)��������!���������������,�����'��%�(���(&��������� ���������%� ������8������+�������+���,���� ��&.������

Page 36: Orion Manual

���������������� ����� ����

������������� ������������������������������

7� ���������)����������������������%���������,��������%�������������������,��������(�����!�����������%����������������8������+�������(���(����,������.������

<� )�����!�����������%���������E���!���S-:�39���4�����/�������������� �/�����������,������.������

9� )�����������!������������(���(��������,��!��������� ,����������8������+����

0� �������S-:�39���4�����/������������������%�����/����������/������������������/������+��������%�!��������/������������T&�������!�����������������������������������)�&������,�����������!����� ����/��������'���������!����!��������/����������/���������/�����+��������!�������/�������������7H<&�����

B� �!��������� ,������������������ �����������������(���(&����������8������+�+�����������8������+����

1� ����������)���������%����������/���,������%��+���������/�/���� �����������%��������F����!�����/����/���,������)����������/�������������������������������%�������

D� �����������)�����������+��������* ���%������%�����!�������/��

<&5�B�5 ��>���A�>��������������

�������������%�����)����������.����������!���������������&���%�3�H�BB&5DB---&:::4�������/�����!����/��%�+�����������!���������������)��������

-� 2�����-5�7H<&�����8�D�-H1&������.�����������������/���!�����������&���%�

5� ���������������&���%�����+�����/�,�������������������&���%�����+���������*��(��!���������&���%���!��������%��������&���%��%��������/��������,�����'����������&���%�����+�����/����*����������������������

7� ����������&���%����/������!��������%�J�+����&��/�@,���(��������������/���������������������������+��!���������&���%�

<� 2���/����/����(��!���������/��������������������������������%���+����!������������������'������(�����/�����*����������/����������/���'���

9� �!��������%���������&���%��%��������/��������,������������!&��++��%�����/����������/��������������%����������&���%����+������

0� ����������/����* �������%���������&���%�����+���%���������*��(��!�����/�������%�������������+�����/��

B� ���+��������)��������!���������������,�����'��%�(���(&������������������%�������8������+�������+����

1� F�������������������'�������'��,�+���������)������������������&���%�

D� �����������)�������������������&���%�/�����/��S-:&75�8T&������������%�����/��

<&5�1 2��������%�����������+���%���+����/��(

�!����������%������8�������+����,��������������8������+�+����/��(��������-&���������8������+����!�����%�

���� �������������/�����������������!�����%����������'����*��,�����7H<&������������������+�+��/�����*��(���� 3�H� :0&--BD--&::-4� ����/������ 3�H:0&--BD-5&::-4�

<&5�D ������������������������F����%

����������������*����������/����/���!����������*���(��!��������������� ,�����������+�� ������������+�/�����++� ������������3������%����<&<4������!�����/����%������*��*���%�����������)�������������%�����������������(���(����������/��&��%�����������,���!����������'���������+���������������

CAUTION!

��!��;��#��" !8������������!#��!#�����$������"�����������"�"����� ������!�"�!����!#�����1�� �!��$����������������������!#"���%�!"��%��������������1

�!� ��.�����,���������������%������ ��� ����%������+���� ��&�������������*��������!���������������!�����)����������!������%������������������ ��������*��,�������/����!��������+�/����++� �����������������%������+����

<&5�-: )����������!�/����2��!�%�������

������!�%��������)�������,��������������+���������������2�I�������7�:���������������������+�����+������������������������!�����)���������>�������"�&575�+��%������%���*��3�H�B<&-:::-0&::74�������������������+������������)�&������������)�����������!�%���������������,���!�����������"��$��2��!�%����������!�/����3�2�4�>���P��������3�H�:0&570:-5&<:-4�

<&5�-:�- )�2��"�AA�" �����" ����G>A�"

����)��������������&*���������� ����������������������������!�%��������������%�,����(�������� ������'���������� ��������������������������%������������������� �/�������������������+�/�������/�,�����*����� ����(�6��+���3������������/������%����<&<4������*������������������/�������%����<&-�

1 2

1 2

BACK-UPBATTERY CONNECTED

BACK-UPBATTERY DISCONNECTED

��%����<&-��A���� ����(&>+�G��+���������������

Page 37: Orion Manual

�������� ���� �������������

������������� �������������������������������

��%����<&5��)��������A������%�)��%���

��%����<&7��������A���������&"��%

TOPVIEW

Note: All dimensions are ininches unless otherwisestated.

FRONTVIEW

BOTTOMVIEW

12.04(305.82 mm)

0.9

7

Air Inlet

9.50(241.30 mm)

1.0

8(2

7.4

3m

m)

Rear ExhaustPort

ElectricalKnockouts (8 PL)

MountingHole (4PL)

11.43(290.3 mm)3.89

0.8

7(2

2.1

0m

m)

2.320.78 1

.12

0.3

9

0.61 (15.49 mm)

2.5

0 3.2

4

1.11(28.19 mm)

1.1

2

0.8

70.780

.44

(11

.18

mm

)1

.17

(28

.45

mm

)

9.9

1m

m)

(98.81 mm)

( )58.93 mm(19.81 mm)

(29.7

2m

m)

(19.81 mm)

(22.1

0m

m)

(28.4

5m

m)

(63.5

0m

m)

(82

.30

mm

)

(26

.64

mm

)

277.3

368.3

36.2

43.3

70.2

Clamp Slot(2 PL)

Mounting Holes(4 PL)

Screw AccessSlots (2 PL)

Rear KnockoutHoles (2 PL)

Inlet Hole

BottomKnockoutHole

218.2

79.9

TopKnockoutHole

TOP VIEW

FRONT VIEW

BOTTOM VIEW

Bezel

Rear ExhaustPort Hole

Page 38: Orion Manual

���������������� ����� ����

������������� ������������������������������

TB1

TB2

AL

AR

M2

RE

LA

Y

PR

E-A

LA

RM

2R

EL

AY

PR

E-A

LA

RM

1R

EL

AY

CM

BO

AR

D

TE

RM

INA

TIO

N

NO

CM

NO

AL

AR

Mi

RE

LA

Y

CM

NO

CM

NO

TR

OU

BL

E‘R

EL

AY

CM

NC

NO

ISO

LA

TE

RE

LA

Y

CM

NC

NO

REMOTE DISPLAY

- + + +- - - + - + + + +---

DETECTORPROGRAMMINGPORTEXTENDER

MEMORYBACK-UPBATTERYJUMPER

FANCONNECTOR

1 2 3 4 5 6 7 98 10 11 12 13 14

12345678910111213141516

DETECTORHEADCONNECTOR

HARD RESETBUTTON

DETECTORSTATUS LEDCONNECTOR

FACTORYPROGRAMMINGJUMPERS(DO NOT MOVEFROM DEFAULTLOCATION)

DETECTORMOUNTEDDISPLAYMODULECONNECTOR

POWER ONINDICATOR

OPTIONAL

TO CONTROL PANEL INPUTALARM CIRCUITS(NOT FOR USE WITH PALM WHENCONNECTED TO ARIES PANEL ASSHOWN IN FIGURE 2-3)

TO CONTROL PANEL INPUTALARM CIRCUITS(NOT FOR USE WITH PALM OR IIMWHEN CONNECTED TO ARIESPANEL AS SHOWN IN FIGURE 2-3)

E.O.L.RESISTOR TOMATCH CONTROLPANEL (TYP)

OPTIONAL

OPTIONAL

O

OO

O

OO

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

POWER SUPPLY

DIS

PL

AY

PO

WE

R

DIS

PL

AY

SIG

NA

L

SP

AR

ED

ISP

LA

YS

IGN

AL

PS

US

TA

TU

S

PO

WE

RO

UT

PO

WE

RIN

{

{

{

{

{

{

{

{

Note: Trouble relay is normally energized,and will transfer on loss of power.

See Figure 4-10 See Figures 4-13 or 4-17OR

Wire as below:= POWER LIMITED CIRCUITS

S

S

= SUPERVISED CIRCUITS

L L

6 5 4 3 2 1- + - +

JUMPER

Note: In and out terminals are internally connected.

TO NEXT DETECTORBLK

BLKRED

RED

+

+

– –

FROM 24 VDCUL LISTED, FMAPPROVED, OR

ULC LISTEDPOWER SUPPLY

LITTLE FUSE1541AT

F2

��%����<&<��������������������8�������F����%�)��%���

Page 39: Orion Manual

�������� ���� �������������

������������� �������������������������������

<&5�-- ��������%�����)��������2�'��

��!����������%��+�����)�������,���������!����/��%�����(�������*������������������������ �����������������+����'��*������+������

L ��'�� �������������������������������������+�� ����&���V�3�+������4

L ��'�� ��������������������AV�3�+������4

L ���������������������������(���+�������V

L ��'�� ��� ���������� ������������������ �*��(&�+*����� ����(�6��+��V

L ��������!� ����!�����/����%��������������������*�������&����V

L ���������������)�����������3�+������4,����+�� ����&����3�+������4,����+�����+���,�������������������!��������������*���������������������������������*����V

L �������+��+����8���������+����!��� �����++�����������&�������V

L ���������!�����6��+�����������+��+���+�������V

L ��'�� �������������A����/��(��������������������������+��/������V�3�+������4

L ������������������'�����!�� �����������������������)�&������V

>�������!����/��%�+����������������������������������'���������������������������?

-� ������������+���%���!�����)����������'������������+��%���!�����)������������������

5� �!����������������)��+�� �A���������������'��,�+��%����)��+�� �A�����������������������0&+�������������������������������*��������(������������)��+�� �3������%&����5&B�!�����������4���!������������������*���(�+���������)��������)����������'��,�+��%���������������������7&+��������������������������������*��������(������&�����)�3������%����5&B�!�����������4�

7� "������������/�����+������������!��������)����������'���������)��������3����+��%��������*�����������������!����)�������4�����������������������������+��%,��������������������������������%������/�������������+�������������������������D:���%�����������(���������������+������

<� 2���!��� ����(�����/�����������������������������������

9� ������������(��%�����/���������*�������!�����)�������D:���%�����������������(��%�+��������

+'4 ��� �����/� 0����3 ��� ��C�. �����D

���������������������������������� ������������������������������+�����!�����+�+�����/��(����������������������*���������'�������� �/����������������(���J��"���F@�����������������+�+�����/��(������������!������������,�����������������&��������������+�+�����/��(������!����������������

<&7�- )��������������������������

�������������������*������������������� ����������U&�������������������������������!������!���������������������������&������3������%����<&94��>�������!����� ����/������,���++����/���� ��������������,���� ��������������������%�����/�������/�����+��������)���������/� �!��������/�����������/�����%��������������������������������

��� ������� ���� ����������� ��� ���� ��������� �����,� ������� �������������� ����(/���� * � ����� ������ ��� ��� �������� >���%� �-&-H1&������+����������+�����,���%���������*�������!�����������������������.������&������)�������'����%�����

<&7�5 ��+����/��(�������������

����������������� �*���������������+�����!�����+�+�����/��(3������%����<&04������������������� �*�������������� /����*��/��������)����������������!�����*������+�����������������&��������+��������������������!���������!����'������������&��������

+'+ ��� �����/� 0��.�/��2����������������.����3��C�. �����D

<&<�- ���A�����/����������������

�����������������*���/��������������������������+��������&��� ����������*������+�A������3���A4������������������&�������!��������%�������������������������������*�����������)�������� ���� /����%� ���� ������� ��� ���� � ����� 3�����%����<&B4�

���� �������� �� +���������� ��������/����I������1:�:������%����

���� ��������A��������*�������/������A��+�����

-� "���'���������A�!��������+��(�%��%�

5� ���+�����������������������������������%��������������&��%���������

7� ��������� ��� �������A����� !����� �����������%�+����/�����������������+�����* �!���������������������������������+�����3������%����<&B4������������������������������ �!��%�����%���

Page 40: Orion Manual

���������������� ����� ����

������������� ������������������������������

<� "���'�����������������'������������*����������%��+�<&5�5

9� �������������A��'�������������������*������������)�&�����������%�� �����������%�+�����/���� ���� !�������A�������%��������������������������*�����������/�����������%����������+������������������������!��������A�/������������������<��������������������*�����3������%���<&B�!�������������!��������%������4�

0� �������������A���/��!���� ��������!���������������������+��������+��������(����������������������*���������-<&+�������������������������������!��������A�*�������������/�*�������������������+�������<��������)�&�������������������*�����

B� �����������2�/����%������%���������������������(���(&����������0����1���������!�/����%���������������)��������

1� ����+��!!�-H1&�����37���4��!������������!�������������!����/�����

D� 2������� ���������� -� ���� 5� ��� ���� ���A� +��%� ��������2�/����%�!��������+�������%������������'�������"��H���� ����2�������,��!�!�������'������������2����+�3������%����<&14�

-:� 2������� ���������� 7� ���� <� ��� ���� ���A� +��%� ������ ��2� /����%� ��� ���� ��8�� ��������� ��'���� ������ �H�"��� �������,� �!� �������'������� ������2���+�

--� 2����������������9�����������A�+��%����������%���������������������%������+������������/���������++����/�������A���!�������%������������������ ��������*��,������/���� !���� ���� +�/��� ��++� � 3�����&E���,� ���!&���&������,����� �����������>���������+�/�����++� 4����������������%������+����

-5� �������9&+������A�+��%�������������A�/����%�������&����

��%����<&0��� +�����2����������/��������������������������������!���+����/��(

3/4" NIPPLE

1” x 3/4”REDUCERCOUPLING

1” PIPE TOSAMPLINGNETWORK

UNION

3/4" NIPPLE

3/4" COUPLING

ELUTRIATOR

DETECTOR

3/4" NIPPLE

3/4" NIPPLE

1” x 3/4”REDUCERCOUPLING

1” PIPE TOSAMPLINGNETWORK

UNION

3/4" THREADED PIPE

3/4" COUPLING

ELUTRIATOR

DETECTOR

��%����<&9��� +�����2����������/�����������������������)������ ������)�������

Page 41: Orion Manual

�������� ���� �������������

������������� �������������������������������

ON TERMINATION BOARD

PALM RECEPTACLE

PALM

TERMINATIONBOARD

��%����<&B������ ����������*������+�A������������������)��%���

<&<�5 ���������%�����"�%�������%��������A

���������%��������A�������/�����+�+������?

<&<�5�- �))"�����������A�F���������� �H�"������

������������������A,���!�����������"���2��!�%���������!�/���� >���P�� ������ 3�H� :0&570:-5&<:-4� ���� ������� ��A������ 3�H� B0&-:::-0&::-4� ��� �����"��A������3:0&57097:&::-4������"���2��!�%����������!�/���>���P��������3:0&57097:&::54�

F����� ��������������� �������A��������/����+�����������(���

<&<�5�5 "����"���������A�F���������� �H�"������

�������A������*����%��������/������������ �H�"��+���������+������+��+��� �������������/��/� �������%������������A?

-� "�%����������%�����+�������������������"�!������2��+&���� 5� �!� ���� ���� ��A������ ��� 2��+���� 5� �!� ����"���A������

5� "�%������* ��������%��������A�������������%����&� ��2��!�%����������!�/����3�2�4�����������*����������������3�H�:0&579B00&::-4������������"���2��!�%�&���������!/����3�2�4����������*�����������������3�H:0&57097:&::54�

(MOUNTED INSIDEORION XT ENCLOSURE)

= POWER LIMITED CIRCUITSL

= SUPERVISED CIRCUITSS

S

S

L

L

RX/TX OUT

NOTE: GROUNDWIRE SUPPLIEDWITH PALM

RX/TX IN

PALM

GROUND

PALM PLUG

1

2

3

4

5

��%����<&1������ ����������*������+�A�����F����%�)��%���

+'5 ��� �����/� 0�����.��2����3��C�. �����D

����)��+�� �A����������*������%���������������"���$�)�������������������������� �

<&9�- )��������A�������)��+�� �A������������������

-� "���'������)��+�� �A������!���������������

5� ���+�����������������������������������%��������������&��%���������

7� �!�������'�������������)�������,�����'�������/���������%������������������������%��+��<&5�5�

<� "���'��������������)�+������������)����������'���* +�����%������/����������%����+�,��������������,���/�������+�����%�����+������������!�����

9� ��������)��+�� �A����������������+����%���!��������%����)���������+����&��/�,�����*��������!��������+�� ����&����/��������������+�/��������)����������*���

0� ���������)��+�� �A�����������+�������������������%�%��/���������/����������%����+��

��������%��+��<&5�--�*�!���� ��+�����%� ������'������ ���)��������

<&9�5 ���������%�����"������)��+�� �A�����

����)��+�� �A����������*����������������� ��������������5&%��%����<Q�*��(*�8,��+����-:::�!����/� �����%�5&+������*��������������%�+������!�������������������������������������&����*�8�* ��������%�����/��3������++����4����!��������������������������������+�/�����*����������*��/�������������&�������*����� ��� ����)������������ ���� ����������/������ ���)��+�� �A������3������%����<&-:4�

Page 42: Orion Manual

����������������� ����� ����

������������� ������������������������������

�����/�����+���������*���/��������������)��+�� �A�����?

-� A�������<Q����5&%��%������������*�8��������������������&�����

5� ������������/���������!������������%��������!������������&����*�8,����'��%���������/������(��%�����-H<&�����30���4��/������/��������.������!���<&�����*�8���������%����!����������.������!���5&%��%�*�8��������%�

7� "����/��+������!�/�����!����+���������D&-5,� �:&5<�I,����8��)��+�WH&����������������*������������)�������������������������*�8�3������%����<&7�!��� ����������������������������*����4�

<� �����/�����!��������)�������������%�������������������������������*�8����'��%���8���������������!�����!�/������&���������*�8�

9� "���'������)��+�� �A������!���������������

0� ���+���� ��������� ���������� ������������%���������������%���������

B� "���'����������/��������*�������!�����)��+�� �A��&���,�������+������������'���!��������*��(������/�����������������������������������!�����*��(*�8����������������)��+�� �A��������������/�

1� ���������/�����!��������������������������*�8������%�������**���%��������!� ����*��(*�8���������� ���+���� ���/�����!��������*��(�������!�����*��(*�8���������������

D� ��(������*��(*�8�����+���������*��(��!�����*�8��'�����������������*�8,��������%������������%�������������*��(*�8�/���� ���� ����/�� ��� ���� ����������� *�8�����*��(*�8��������*���������������������������**���%���&�������������������%������!�������)��+�� �A��������'��

�������������������*���������%�������������/���������������*��(*�8�������������������*�8�

-:� "���'������������������/����%�����������++�����/�������)��+�� �A������������������������� ��������/�������)��+�� �A��������������������������)����������'���

--� 2������� ����/����� !���� ����)�������� ��� ���� ��������*���(��������)��+�� �A�������������!����/��%�������3������%����<&-:4?

2���������-&-5�:I,�)��+�� �+�/���3&4,����+��������-,��*�����:I��������)��+�� �A�������3�����/����������������������*���(�������%���������/��4

2���������-&--�W5<�I,�)��+�� �+�/���3W4,����+�������5,���*�����5<�I����������)��+�� �A������

2���������-&D�)��+�� ���%����3W4����+��������7,���*����3W4��������)��+�� �A������

2���������-&-:�)��+�� ���%����3&4����+��������<,���*����3&4��������)��+�� �A������

REMOTEDISPLAYMODULE

--

- +++

24v 0v

BOARD

TERMINATION

10 9

TB1

12 11

+-FAN

DETECTORHEAD

= POWER LIMITED CIRCUITS

S

S

= SUPERVISED CIRCUITS

RS-485

24 Vdc

LL

��%����<&-:��"������)��+�� �F����%�)��%���

-5� A����� ����)��+�� �A��������� ��� ����*��(*�8��A�(���������������+��!�����*��(*�8�����������������������%��*��������)��+�� �A����������������/�����*��(������%�����%����������������������(��������������)��+�� A������3������%����<&--4�

-7� "����������������/��������*�������!�����)��+�� �A�������'���������%�������!���������/����������������+������ /����������������������'��,����������)��+�� �A������/�����������������������*��(*�8��������� �

LCD Module

LID

��%����<&D�����������%�����)��+�� �A�����

Page 43: Orion Manual

��������� ���� �������������

������������� �������������������������������

1.8246.23 mm

1.5639.5 mm

4.76120.90 mm

Note: All dimensions are ininches unless otherwise stated.

5.7

4

145.8

0m

m

Grommet

FRONT

2-gang mountingholes (4 places)

BACK

4” Backboxmounting holes(2 places)

SIDE

BOTTOM

��%����<&--��"������)��+�� �A�����,�A������%�)������

<&9�7 )��+�� �A��������!�/��������+�3"�%�������%�����2)4

����)��+�� �A�����������*����%��������/��������)������������%�������2��I�������7�:���!�����)��+�� �A��������������%�������,����J>���%��2)@�����*���/�����++�����������)��&+�� �A�������"�!�����������"���2��!�%����������!�/���>���P��������3�H�:0&570:-5&<:-4,�!����������������%�����&��%������2)�

+'6 ��� �����/�����'��� ������.�B���3..�2�C�. �����D

���� "���'������+�/�����++� ��������������+�!�������)���������*�!�������������%�����+�/�����++� �

�������!&2�����������/�����++� ������*����������������� *���/�����)�����������!����/�?

-� "���'�� �������!&2�����������/��� ��++� � !���� ���+��(�%��%�

5� ���+���� ��������� ���������� ������������%���������������%���������

7� "���'��������������������/����������������!�������'���"���'��������'��������������������

<� "���'��������� �/��(���(�������� ����*�������!� ���)��������!��������2�'����%��/����%,�����������

9� ����������T&�����3-D���4����X&�����30���4���++���������(���(�����!�����)��������

0� "���'���������%�(���(��������������+��!�����+�/����++� �3������+�������������/��������'����������������4�����++��+������(���(�����!����2���+���/����%�

B� ����������+�/�����++� �����������)�����������������������++�������������������+�<����������(���(�����!����+�/��� ��++� ������ +�/��� ��++� ,�/������� ���� ��'��,�������������������������������������(��%�����/��������*�������!�����)�������������+�/�����++� ��������!���*�&�/�����������/������/���������/����������������'�����*�������������� ����'����2���(� ����+���������!� ����/��������+��������������+��!�����+�/�����++� ��������������!�����'������������������F��������+�/�����++� ��������������������������������!��������)�������,�������/��+������������6��������������)��������

1� A��(� ���� ����������!� �����������%���������� ����/���3������%����<&-5�!����������%��������4�

D� )�������������������/�����+�/�����++� ��������/�����������������%��������3����/������������++�����4

-:� ����/�������������!�����%��������������++������������������!�����+�/�����++� �

--� �������+�/�����++� ����������������%�����/��������!�����+�/�����++� ��������������������2�/����%�3��!�������%����<&-7�!���/����%����%���4�

-5� F���������2�+�/����/��������!!,�*���%��2���+���/����%�����%���++��+������(���(�����������������2�/����%�����������34����������3�4�������2�+�/��������*��������%��� �+�/�������������������*��(����+�* ��������&�������������%,���%���&���'���%���������

-7� "�+���������������������+�������������%�����/��

-<� ��(������/����%���������/�����������H*���(H*����/������������%����H ����/�/��������!��������������%������������,����������)��������

-9� 2������� ���� ����/���� ������&-����� ����*���(�/���� ����-&5��������������������*�����

-0� 2�����������*����/���������-&9����(�����>��������W�3�!� ����������������%���+�/�����++� �������������������!&2������������A����&C����+�/�����++� ,���������+�/����++� ����������+��'������������� ���/���+��'���� ���%&���,���6��+��������*��+���������������>��������WH&�4

-B� ����������%��������%��'������������3��/�����!����������&�����!�����)�������4���������������/����������3+��'����4�

WARNING!

3��A�!#���!����������������%���!��1� ��!#�������!�A ��$�����������������#���#�;����������������!�>!���������������"���"���8!�%���;���G"!;1

Page 44: Orion Manual

����������������� ����� ����

������������� ������������������������������

-1� >�/��+������/��5����*�������������+��������������������+�/�����++� �/������������������!����%�����/����%������������

-D� 2�����������*����/�����������������������*����� ������&����,�����,����������!�����*����/����������������������%�&��'��3&4�����������!�������+������*����� ����������������������������������+�����'��3W4�����������!�����*�����*����� �

5:� 2���������������/�����������+�����'��3W4������������������+�*����� �

5-� 2�����������*���(�/�������������%���'��3&4�����������!����*������*����� �

55� 2���(�����/����%������������������/��������+�/���

57� "�+�����������'���*��(��������+�/�����++� �����������/����������������������/� �����/

SELF-CONTAINEDPOWER SUPPLY/

BATTERY CHARGER

SELF-CONTAINEDPOWER SUPPLYP/N 297104

BATTERIES

WIRE HARNESS

BATT –

L

N

N/C

E

C/S

0V

0V

BATT +

+28V

+28V

RE

D

WH

T

RED

GR

N

BLU

GR

N

BL

U

BL

K

BL

K

BLK

BOARDTERMINATION

DETECTOR

FAN

2 X P/N 297105

TO DEDICATED120 or 240 VAC EMERGENCY POWER CIRCUIT

DETECTORHEAD

2 1

TB1

45 3

+ +

RED

BLK

BLKBLKBLKBLKBLKBLKBLKBLKBLKBLKBLKBLKBLKBLKBLKBLKBLK

= POWER LIMITED CIRCUITS.WIRES MUST BE ROUTEDSEPARATELY FROM NON-POWER LIMITED CIRCUITSBY MORE THAN 1/4 IN.

S = SUPERVISED CIRCUITS

L

L

L

S

S

S

12 V2 AH

12 V2 AH

FAULT

��%����<&-7�����!&2�����������/�����++� F����%�)��%���

+'& ��� �����/� 0���3� �'F����.�B���3..�2�C�. �����D

ATTENTION

OBSERVE PRECAUTIONSFOR HANDLING

ELECTROSTATICSENSITIVEDEVICES

��������2��"2�>����

B��� �������� ��;� ���!��� ��# ������ �!��!�"���%��!�$������������ !��"������#"���%��!!�� �"�1� ����"!� ��� �� ���#�;� !�"��� ����# ������#��1

<&B�- A�����������/�����++� ����������

��������������3�H�BB&5DB-:B&:::4��������%����!������&!�����������%���������!�����������%������,�������/������%����<&-<��A�������������������*�!�������������%�����+�/����++� ���������������*�������������������!�����/��%����!���� +�/��� ��++� ,�X&������������%� ����/���� ��� �����&�������� �!� ����%� �� �������� � ���������,� ��� ������� *������������������� ���6�������������+����� ������������!����������������������������,������������������������+�����������!�����/����%�

���� ����>�2���������������������,������������+�/�����+&+� �������������6�����������������������������/�������/+�/��&���/������%���������������

��%����<&-5�����!&2�����������/�����++� ���(&��8�A������%�)������

2.1

5

0.94

9.35(237.49 mm)

2.63(66.80 mm)

0.94

1.0

0

10.10

10.85(275.59 mm)

Note: All dimension in inchesunless otherwise stated.

2.0

9

4.1

5

4.5

5

MOUNTINGHOLES (2)

(54

.61

mm

)

(23.8 mm)

(23.8 mm)

(25

.4m

m)

2.1

52

.15

(256.54 mm)

(11

5.5

7m

m)

10.10

(10

5.4

1m

m)

10.1010.10

(53

.09

mm

)

Page 45: Orion Manual

��������� ���� �������������

������������� �������������������������������

CAUTION!

�� ��!� �" �;� �����"!� ��� ����� ��!�"!����#�"������ ��� ���"�� %�#�"��%��!����#%�;1� �����������������#%�;�����%���!�������"%��������1����"!������������'������� ��#��� ��� ���� A�� ��� ������������%��" �!�����������# �����#%�;����#�"��1

<&B�5 2��!�%����%�������/�����++� �!����������������� ����(

��� ������� ����������/�������������*�����������������������������������+�/�����++� ��������������++���!�������!����� ����!�%�����!�����+��'����%������/��*��������������������������������!�����%������������+�����!�*��������,�6��+&����F-�����F5������*����'���!����+���������2����+���&���������������������������%����<&-9�

���� �������� ���+�����F-�����F5� ��� ������������+���&������/��������*���*����� ���+��'���������%�'����!����*����� �����*��������������

14.0 (355.6 mm)

17.25(438.15 mm)

(2) BOTH SIDES

15.5(393.7 mm)

13.5(342.9 mm)

3.5(88.9 mm)

1.5(38.1 mm)

1.25(31.75 mm)

3/4” (1.125 DIA.[28.57 mm])1/2” (.875 DIA.[22.23 mm]) &

TYP. (4) TOP &KNOCKOUT SET

.5 DIA. (12.7 mm)

.437 (11.10 mm)

1.0 (25.4 mm)1.25(31.75 mm)

14.5(368.3 mm)

17.0(431.8 mm)

2.0

(50

.8m

m)

1.25(31.75 mm)

5.5(139.7 mm)

6.25(158.75 mm)

4.0(101.6 mm)

12.0 (304.8 mm)

.281 DIA(7.14 mm).

.281 HOLE DIA.(7.14 mm)

��%����<&-<��A����&C�������������A������%�)������

Page 46: Orion Manual

����������������� ����� ����

������������� ������������������������������

<&B�7 2��!�%����%���������*���"���

����+�/�����++� ����!����� �����!��������� �2����������*������ �������������������������������.������!�������������9����0��������)����������������+�/�����++� �/����*������������* ���������������/���������� ��+�����������,����+���!�����3��&�!&����4�����������������������������������������*����&������������������� ��+�������*������� ���������,���'�6��+���F7�!�����2���������������������������%����<&-9�

W1 BATTERY JUMPER

W3 TROUBLERELAYCONNECTION

W2 BATTERY JUMPER

BATTERY TROUBLE LED

BATTERY OPERATION LED

GROUND FAULT LED

AC ON LED

TB

2

TB

3

TR

OU

BL

E

N.O

.

N.C

.

(+) (-)

(-)(+

)(-)

(+)

(-)(+

)

LOAD1

LO

AD

2C

OM

NO

/NC

BA

TT

2B

AT

T1

A

A

B

B

C

C

��%����<&-9��A����&C������/�����++� 2��!�%��������G��+���

<&B�< ���������%�����F����%�����A����&C������/����++� �A�������������������

)������+�������/������������+��������!��������+�/�����++� ��������������*�����������������������!�%��������6��+&������'��*������������ ������"�!�����%�����<&-0�����<&-B�

���� "���'������+�/�����++� ��������������+�!�������)��������*�!�������������%�����+�/�����++� �

-� A����������H�BB&5DB-:0&:::�+�/�����++� ����������������������������%�����!����S0&75�����/��+��'�����/�����������������

5� ������� �!����������%�����%������/�����������+�/����++� ���������������%��������%��������������������&��%� ����S1&75�����/���������� �/��/�������+��'����/������������������

7� "���'��������'�����������2����������*���(�

<� F���� ������� ��!�����������,��������� �����2/����%�����������������*���(����,�>�������)������/���������/����%����%����

9� "�+�����������'�����������2����������*���(�

0� 2�����������-���������5�/����%��������������������/��������/����%����%����

B� 2���������������*���"��� �/����%�����������������������������������/���������/����%����%����

1� �!����������� �����+�����3�H�BB&5DB--7&:::4����*���%����,�����������������������������F��������I�������������!��������+�!����%� ��,�����������������+���/�������%�����!��������������������+������%����������������������*�������!���������������

D� �����������/��*��������3�H�BB&5DB-:1&:::4����������*�&���,�*���������#�<���;����������������������#1

���� )����������������*����� �����/��������+��&��������'���&�%������������55�I���

-:� �!����������� �����+�����3�H�BB&5DB--7&:::4����*���%����,�/��+�������+������������*����� �������������+���&����*��(���������!������!�����*����� ���A�(��%��������������������������(��(������/����������������+,��������������������%������+�������*��(��,�������%������������������������!���������+�* ������%������/��I�������������"�&+����!�������������*����� �

--� ������� �!����������"�����������(�*����� ���*����!�������*����������������+�/�����++� ��������������/��������/����%����%����������� ���*����/����*������������(&�����������++�����/������������������

���� 8������������������������������������*����� ����&���������*���������!���������������*����� ���*������� ����������!����

-5� ������� �!��������������������(�*��/��������*��������������/���������/����%����%�������������������(�/���*������������(����������++�����/������������������

���� 8������������������������������������*����� ����&���������*����������!�������������������������(����� ����������!����

-7� 2���(�����/����%�������������

-<� �/���������2�+�/��������%������2����)�/������%����������������*����� �/��������+�/�������� ������������2+�/��������++�����

POWER SUPPLYENCLOSURE

POWER SUPPLY MODULE

CENTER LINK

POWER SUPPLYMOUNTING SCREWS

(12 VDC, 33 AMP HR.)BATTERY

(12 VDC, 33 AMP HR.)BATTERY

R19

C102

C101

R108

R42

BATT

OPR

Q15

D

R45

GND

FLT

DS3DS1

Q16

U2

C11 +

R49

C8

CR10

C B A

W2C2

R23

CR4

CR3

R11

Q4

Q3

R10

BATT

TBL

R8

DS2

U3

R13

R9

R21

Q2

R14

R12

R7

R35

R34

C5

CR9

R6

R50

Q6 Q7

Q1

R15

R22

R107

C13U101

R46

Q9

CR102

C

U1

R4

+

CR14

R44R43

R40

R39

C10

CR13

R41

R38

R48

R31

R27

R32

R30

C12

R28

R29 C3

Q8

R1

C9

CR12

R36Q13

Q11C4

Q14

R16

R37

CR11

Q12

R18

C1

CR1

C6C7

R26

+ R208

R207

C201

CR5

R25

R33

R5

R20

CR202

Q203

Q5

R3

R2

W1

B A

R24R17

C14

R51

Q10

BATT1

CR6

C104

TB3

CR19

(+)28VDC

TB1

R47

(-)

LOAD1

(+)(-)

RT4

CR2

CR16

C103

(-) (+)

R101

R104

R102R105

RV101

Q102

R103CR101

Q101

R106

R109

CR17

RT3

TB2

K1

CR18

RT1

(-)(+

)LO

AD

2(+

)

K2

Q202

CR201

R202

R205

R203

Q103

C202

C203

U201

R206

R204

R201

C204

Q201

R209

RV201

RT2

CR8

N.C

.

N.O

.

W3

06-129857-001

CR7

CR15

(+)

(-)(-)

BATT2

CO

MTR

OUBLE

NO

/NC

RED LEAD TOPOWER SUPPLYMODULE

OPTIONALBATTERY STRAP

BLACK LEAD TOPOWER SUPPLYMODULE

GROUNDLUG

+

+–

��%����<&-0��A����&C������/�����++� H������ �A������%

Page 47: Orion Manual

��������� ���� �������������

������������� �������������������������������

��%����<&&-B��A

����&C

������/�����++� �F

����%�)

��%���

=S

UP

ER

VIS

ED

CIR

CU

ITS

.SL

=P

OW

ER

LIM

ITE

DC

IRC

UIT

S.

WIR

ES

MU

ST

BE

RO

UT

ED

SE

PA

RA

TE

LY

FR

OM

NO

N-P

OW

ER

LIM

ITE

DW

IRE

SB

YM

OR

ET

HA

N1/4

INC

H

HO

TN

EU

TG

ND

GR

N

WH

T

BL

K

CO

M

N.C

.

-+-+-+

+-

LO

AD

2

BA

TT

1

BA

TT

2

LO

AD

1

TR

OU

BL

E

RE

LA

Y

PO

WE

R

SU

PP

LY

MO

DU

LE

(P/N

77-2

97106-0

00)

++

--

BA

TT

ER

Y

12V

33

AH

(P/N

77-2

97108-0

00

12V

33

AH

(P/N

77-2

97108-0

00

BA

TT

ER

Y

EN

CL

OS

UR

E(P

/N77-2

97107-0

00)

RE

DB

LK

12V

33

AH

(P/N

77-2

97108-0

00

BA

TT

ER

Y

EN

CL

OS

UR

E(P

/N297107-0

00)

(P/N

77-2

97108-0

00

12V

33

AH

RE

D

+-

+ BA

TT

ER

Y

-BL

K

LS

S S

NO

TE

2

NO

TE

2

LS

RE

D

BL

K

TO

NE

XT

DE

TE

CT

OR

IFU

SE

D

TO

NE

XT

DE

TE

CT

OR

IFU

SE

D

RE

D

BL

K

NO

TE

1

GR

OU

ND

LU

G

TE

RM

INA

LC

UP

WA

SH

ER

GR

OU

ND

WIR

E

LO

CK

WA

SH

ER

GR

OU

ND

SC

RE

W

TO

DE

DIC

AT

ED

120/2

40

Vac

CIR

CU

IT

GR

OU

ND

WIR

EO

N

GR

OU

ND

LU

GO

NE

NC

LO

SU

RE

(SE

ED

ETA

IL)

PO

WE

RS

UP

PLY

GR

OU

ND

LU

GO

NE

NC

LO

SU

RE

(SE

ED

ETA

IL)

NO

TE

S:

1.T

OD

ET

ER

MIN

EM

AX

IMU

ML

EN

GT

H,P

ER

FO

RM

VO

LTA

GE

-DR

OP

CA

LC

UL

AT

ION

US

ING

WIR

ER

ES

ISTA

NC

EA

ND

TO

TA

LC

IRC

UIT

CU

RR

EN

T.

2.B

AT

TE

RY

CA

BL

ES

AR

ES

UP

PL

IED

WIT

HT

HE

EN

CL

OS

UR

E.

3.IF

FIV

ET

OE

IGH

TD

ET

EC

TO

RS

(297101)

AR

EIN

STA

LL

ED

,T

HE

SE

CO

ND

BA

TT

ER

YE

NC

LO

SU

RE

WIL

LB

EN

EC

ES

SA

RY

TO

SU

PP

LY

PR

OP

ER

24-H

OU

RB

AT

TE

RY

BA

CK

-UP.

4.D

ET

EC

TO

RT

ER

MIN

AT

ION

BO

AR

DT

ER

MIN

AL

ST

B1-5

AN

DT

B1-6

(PS

US

TA

TU

S)

SH

OU

LD

BE

JU

MP

ER

ED

TO

GE

TH

ER

ON

AL

LD

ET

EC

TO

RS

,E

XC

EP

TT

HE

FIR

ST

ZO

NE

INA

SY

ST

EM

.T

HE

FIR

ST

ZO

NE

SH

OU

LD

BE

WIR

ED

TO

TH

ET

RO

UB

LE

RE

LA

YA

SS

HO

WN

.

NO

TE

4

NO

TE

3

BO

ARD

TERM

INATI

ON

DETE

CTO

R

FAN

DETE

CTO

RH

EA

D

TERM

INATI

ON

TB1

BO

ARD

DETE

CTO

R

FAN

HEA

D

DETE

CTO

R

2

2

6

6

STA

TUS

-+

-+

STA

TUS

-+

-+ 1

1

5

5

TB1

4

4

3

3

Page 48: Orion Manual

����������������� ����� ����

������������� ������������������������������

+'7 ��� �����/� 0���� ����/�� �� ����������3���C�. �����D

���� �������%���� �����!����A������ 3��A4�����*������������������ ���������"���������'�������"�&575�������������������������������������'����������� ��������������������A��������"��������,���������%��+��<&1�5�-,���%�����<&-D�����<&5:,������������������������������"���������������,��+���&����,�����A�����������A������ 3�H�:0&57097:&::-4������������������A�'������� �,���������%��+��<&1�5�5�

���� ���� �������������/��(��������*��+��!������* �!��&��� ������������������������������������������������/�����++����*������������������.����������

<&1�- A������%������������%���������!����A�����

�����/����������+�������������������A�

-� "���'�� ���� ��A�/���� ���������� !���� ���� ���++��%�������

5� ���+������������/��������������������������%���������������%���������

7� ���������������(����������������!����/��%������?

5�&������"���������39�0(�����:�9�F4

-�N����������%�F�����

5�N����������%���

-�N����A������(� ����(������������,�/����5���%�

CAUTION!

���� !������ ����������� �!� �!8������ ��� ���="� #���#"�����!����!�"�������!� ������!<������������#�"������8�����!���������������!����;�������������!�;�����!����!�"���1

WARNING!

���������������!������������;���!��������������������� ��!��" �;�������1

<� A�����������������������%���-:�39���4�����/���������������+����*�������������������������*�������������&���������������%�������*�����!������������

9� 2���������������������������������-H5Q�3-D���4����7H<Q359���4�(���(���������������������,����������,����+�������!�����/����%�

0� 2�����������5<�I���+�/�����++� ���*������������A�

B� ��/��������*����++�����!������>��������,��A��++��'�����>�2��������+�/�����++� �!���!����+������������%���&���%�������������"���2�������>������8����� ����+���

1� 2�������%������/�������%�������%���%�����!������/�������%��������%�����

D� ����������%�������%�����������������A�����������%�������%�

<&1�5 2��������%�������A������2�������>���

<&1�5�- "�&575�2�2��������"��2��"���>��

2�����������"�&575���*���!����G-�22A����������A�������"�&575��2�+������� �����"���2�������>����������/�� ����%����<&-D�������%����<&5:�

<&1�5�5 "�� �2���2��F�"���������"��"����"A�>���

2��������������� �/����%����������*����������+���������*�&��/�����<&5-�������%����<&55�

-� 2�����������/����%�!��������*������� ����������*�������&�����%���������

5� �!�����,���������������/����%����������A�����������������������������������'������������������������8����� ���&+���,� ��� ���/�� ��� ��%���� <&5-�� �������9�0(�����3:�9�F4������������������Q��8����� ���������Q����Q��8����� �����*�����Q����������,��!���������+����������������

<&1�7 F����%�����"�&<19���/��(����)��������

���� !����/��%� ��� �� � ���� �!� "�&<19� ���/��(� ����%�+����������

-� �� ��� 0�/����%,� ��� ���/�� ��� ��%���� <&-D� ������%���<&5-,� ��� ����+��!������/����%�*������� ���+��'����� ���%�������������*���� �������� ���0������+�����!�/���������*�������+��������������

5� �!�������A��������������������� ���<����!�%������������������������3������%����<&5:�������%����<&554,�����"�&<19������������������������������)���������������*�����&�������� ����� ��� ����� * � ������%� *���� ������ �!� ���AH�"A��/�������� ���� ������������*����� ��� �����+��������

7� �������/��(���*��������*���/�����,����������+����/�������������%��%���!�-1��F��3:�B9���Y4���������8�&�����!�-5��F��35�9���Y4�/����

<� A�8����� ��������� !��� ������� '�������� ���+� ��<:::�!���3-5::��4�

9� >+����-5B������������� �*����������������������/��(���������������������'���������.���������������������)����/��������3������%����<&-1�4

1234567

ONADDRESS 1

37 56 4

ADDRESS 20ON

2 1

37 56 4

ADDRESS 32ON

2 1

��%����<&-1��"�&<19���/��(���������8��+���

Page 49: Orion Manual

��������� ���� �������������

������������� �������������������������������

3. CABLE IS TO BE 2 CONDUCTOR, TWISTED SHIELDED PAIR. 18 AWG. MIN. MAX DISTANCE FOR ENTIRE LOOP IS 4000 FT.

4. THESE INPUTS ARE NOT USED WHEN CONNECTING TO THE KIDDE ARIES PANEL.

2. ONE END OF SHIELD IS TO BE CONNECTED TO EARTH GROUND AT ARIES PANEL.

= POWER LIMITED CIRCUITS

127 MAXIMUM DETECTORS

S = SUPERVISED CIRCUITS

NOTES:

L

LS

MODULAR RS-232 CABLE

SEE NOTE 2L

SEE NOTE 4

SHIELD

BLK

RED

PC

PORT

TB1

RED

BLK

RED

BLK

1. TERMINATION BOARD M/TERM SWITCHES 1 AND 2 TO OFF FOR ALL DETECTORS.

SEE NOTE 3

11

AUX TROUBLE IN

12

+24VDC1

AUX ALARM IN

DC GND

10

8

9

+

7

5

6

-

-

+

3

4

2

CHANNEL 2

J1

RS485

RS485CHANNEL 1

IIM (SEE NOTE 5)

ARIES(SEE NOTE 6)

SEE NOTE 4{

TEL

PC

CCM

TERMINATION TERMINATION

TB1 TB1

BOARD BOARD

DETECTOR DETECTOR

FAN FAN

HEAD HEAD

DETECTOR DETECTOR

16 15 14 13

- + - +

16 15 14 13

- + - +

INBOUND (RETURN) WIRING MUST BEROUTED SEPARATELY FROM OUTBOUND WIRING

POWER CABLE

OFF POSITION

M/TERM SWITCH

ON POSITION

DETAIL 1

5. IIM PART NUMBERS: 77-297114-001 OR 77-297114-002.6. FOR MORE INFORMATION ON THE ARIES FACP, REFER TO THE ARIES MANUAL (P/N 06-236530-001).

24 VDCAUX OUT

��%����<&-D���������%���������!����A�����,�2�������������"�����2��/����)������������2������,��� ���0�F����%

Page 50: Orion Manual

����������������� ����� ����

������������� ������������������������������

3. CABLE IS TO BE 2 CONDUCTOR, TWISTED SHIELDED PAIR. 18 AWG. MIN. MAX DISTANCE FOR ENTIRE LOOP IS 4000 FT.

4. THESE INPUTS ARE NOT USED WHEN CONNECTING TO THE ARIES FACP.

2. ONE END OF SHIELD IS TO BE CONNECTED TO EARTH GROUND AT ARIES PANEL.

= POWER LIMITED CIRCUITS

127 MAXIMUM DETECTORS

S = SUPERVISED CIRCUITS

NOTES:

L

LS

MODULAR RS-232 CABLE

SEE NOTE 2L

SEE NOTE 4

SHIELDBLK

RED

PC

PORT

TB1

RED

BLK

1. EOL RESISTORS TO BE SET ON LAST DETECTOR BY SETTING TERMINATION BOARD M/TERM SWITCHES 1 AND 2 TO ON, AND OFF FOR ALL OTHER DETECTORS(SEE DETAIL 1).

SEE NOTE 3

11

AUX TROUBLE IN

12

+24VDC1

AUX ALARM IN

DC GND

10

8

9

+

7

5

6

-

-

+

3

4

2

CHANNEL 2

J1

RS485

RS485CHANNEL 1

ARIES

(SEE NOTE 6)

SEE NOTE 4{

TEL

PC

CCM

TERMINATION TERMINATION

TB1 TB1

BOARD BOARD

DETECTOR DETECTOR

FAN FAN

HEAD HEAD

DETECTOR LAST DETECTOR (SEE NOTE 1)

16 15 14 13

- + - +

16 15 14 13

- + - +

POWER CABLE

RS 485 CONNECTION CABLE

OFF POSITION

M/TERM SWITCH

ON POSITION

DETAIL 1

IIM (SEE NOTE 5)

5. IIM PART NUMBERS: 77-297114-001 OR 77-297114-002.6. FOR MORE INFORMATION ON THE ARIES FACP, REFER TO THE ARIES MANUAL (P/N 06-236530-001).

RED

BLK24 VDCAUX OUT

��%����<&5:���������%���������!����A�����,�2�������������"�����2�,�2������,��� ���<�F����%

Page 51: Orion Manual

��������� ���� �������������

������������� �������������������������������

3. CABLE IS TO BE 2 CONDUCTOR, TWISTED SHIELDED PAIR. 18 AWG. MIN. MAX DISTANCE FOR ENTIRE LOOP IS 4000 FT.

4. EOL RESISTOR AS REQUIRED BY CONTROL PANEL FOR SUPERVISION.5. IN THIS CONFIGURATION, THE TB2 OUTPUT RELAYS ON THE DETECTOR MUST BE WIRED TO THE

CONTROL PANEL (SEE FIGURE 4-3).

2. ONE END OF SHIELD IS TO BE CONNECTED TO EARTH GROUND AT IIM.

= POWER LIMITED CIRCUITS

127 MAXIMUM DETECTORS

S = SUPERVISED CIRCUITS

NOTES:

L

LS

SEE NOTE 2L

BLK

RED

TB1

24

VD

C

DC

GN

D

RED

BLK

1. TERMINATION BOARD M/TERM SWITCHES 1 AND 2 TO OFF FOR ALL DETECTORS.

SEE NOTE 3

11

AUX TROUBLE IN

12

+24VDC1

AUX ALARM IN

DC GND

10

8

9

+

7

5

6

-

-

+

3

4

2

CHANNEL 2RS485

RS485CHANNEL 1

POWER SUPPLYWITH BATTERY BACKUP

UL LISTED OR FM APPROVEDFOR FIRE PROTECTION

SIGNALING USE

SEE NOTE 4

TERMINATION TERMINATION

TB1 TB1

BOARD BOARD

DETECTOR DETECTOR

FAN FAN

HEAD HEAD

DETECTOR DETECTOR

16 15 14 13

- + - +

16 15 14 13

- + - +

POWER CABLE

LISTED

(06-129611-005)

5.6K

EOL

RESISTOR

OPTIONAL CONNECTIONS

COMMON

TROUBLESL

ALARM

COMMONSL

TROUBLE

INPUT

CONTROL PANEL

TBL OUT

TBL OUT

SL

TO EARTH GND

CONNECT GND STUD

NOTE 5NOTE 5

OFF POSITION

M/TERM SWITCH

ON POSITION

DETAIL 1

IIM (SEE NOTE 6)

6. IIM PART NUMBERS: 77-297114-001OR 77-297114-002.

��%�����<&5-���������%���������!����A������2��������������2�����������������A����/����)������������2������,��� ���0F����%

Page 52: Orion Manual

����������������� ����� ����

������������� ������������������������������

3. CABLE IS TO BE 2 CONDUCTOR, TWISTED SHIELDED PAIR. 18 AWG. MIN. MAX DISTANCE FOR ENTIRE LOOP IS 4000 FT.

4. EOL RESISTOR AS REQUIRED BY CONTROL PANEL FOR SUPERVISION.5. IN THIS CONFIGURATION, THE TB2 OUTPUT RELAYS ON THE DETECTOR MUST BE WIRED TO THE CONTROL PANEL (SEE FIGURE 4-3.)

2. ONE END OF SHIELD IS TO BE CONNECTED TO EARTH GROUND AT IIM.

= POWER LIMITED CIRCUITS

127 MAXIMUM DETECTORS

S = SUPERVISED CIRCUITS

NOTES:

L

LS

SEE NOTE 2L

BLK

RED

TB1

24

VD

C

DC

GN

D

RED

BLK

1. EOL RESISTORS TO BE SET ON LAST DETECTOR BY SETTING TERMINATION BOARD M/TERM SWITCHES 1 AND 2 TO ON, AND OFF FOR ALL OTHER DETECTORS.

SEE NOTE 3

11

AUX TROUBLE IN

12

+24VDC1

AUX ALARM IN

DC GND

10

8

9

+

7

5

6

-

-

+

3

4

2

CHANNEL 2RS485

RS485CHANNEL 1

POWER SUPPLYWITH BATTERY BACKUP

UL LISTED OR FM APPROVEDFOR FIRE PROTECTION

SIGNALING USE

SEE NOTE 4

TERMINATION TERMINATION

TB1 TB1

BOARD BOARD

DETECTOR DETECTOR

FAN FAN

HEAD HEAD

DETECTOR LAST DETECTOR (SEE NOTE 1)

16 15 14 13

- + - +

16 15 14 13

- + - +

POWER CABLE

LISTED

(06-129611-005)

5.6K

EOL

RESISTOR

OPTIONAL CONNECTIONS

COMMON

TROUBLESL

ALARM

COMMONSL

TROUBLE

INPUT

CONTROL PANEL

TBL OUT

TBL OUT

SL

TO EARTH GND

CONNECT GND STUD

OFF POSITION

M/TERM SWITCH

ON POSITION

DETAIL 1

NOTE 5NOTE 5

IIM (SEE NOTE 6)

6. IIM PART NUMBERS: 77-297114-001 OR 77-297114-002.

��%����<&55��������%���������!����A������2��������������2�����������������A����/����)������������2������,��� ���<F����%

Page 53: Orion Manual

��������� ���� �������������

������������� �������������������������������

<&1�7 ������%�)���������������

F��������)�����������/��(���������)����/������,����������������������������/��(�/���������.�����������������+&+����8���!�������)������������������

<&1�< �������������2���(�

��!����+�/����%��+�������A�!�������!�������������������������!����/��%�����(����'��*�������+�����?

-� ������A�������������������� �

5� ������A�/����%���������������������� �

7� ����)����/�������������������������*������������)�&�������������������������������������

<&1�9 2��������%�������+�����������������������%���������!����A������3�+������4

�!� ���� ��A���������+������������,� !����/� ���������+�� ����������������+�������������������A�

-� ���������������+��������������������%�������"G&--�6��(�������*��������������6���������������A�

5� 2����������"G&--���*���!��������Q��Q�������������������A������������+�����6��(�

<&1�0 ��!�/����2��!�%�������

������!�%����������A,���!�����������2��I�������7�:���!�/���A������

+') ��� ����.�B��'3.

�!��������/����%�������+��������������(��,������ ��������*��+�/����&�+����������*���*���/���!������+�����������%�2������*�������������������)�������,����/����*����������������������������%���������*���������������!��� �

���� �2������������%����+�����!������"���$�����!�%�&�����������+�/��&�+�������� ����� ������������ +��%������%� +���������� !����2�� ���� !����/��3����2��+����<4�

-� 2���(����������+�+��%�����*����������������������%�����������%�����/��%����������6��������������������������������

5� "���'�����������������'�����������������/��������&%��+��<&5�5����������6��+��������7�������������������&���������*�����������/��������������������� �*��(�+*����� �

7� 2�������������>��������������+��������������������*�������+�/��&�+�

<� ����J��F"����)@��������������������*�������������/�*������

9� ����)��������/����*���������*����������� ����/��)�/���*������

0� �!�����)��+�� �A�����������������,����/�����������������*���������������������������/�����+������������������� �

B� ����*�������������������*��'��/���* �����%������2���!�/�����"�!�����������"���2��!�%����������!�/���>���P��������3�H�:0&570:-5&<:-4�

1� ��"�A����!�%������������*���/����������*��+����������������� �*����������* ��+������%�"�����!�����2��

D� �!���)��+�� �A��������������,���������*����%����������&��%��2��

-:� 2��������� �����������*�������������������*��������������������&�������%�����/���������������������� ��"�!������������+���������������*����������%�����2�������'��A���&��������!���!���������!��������

--� ����������)�������������/�����������������

Page 54: Orion Manual

����������������� ����� ����

������������� ������������������������������

����������������� ����������

Page 55: Orion Manual

�������� ���� �������������

������������� �������������������������������

��������!������������

5'* �� ���3� ���

����� ���+���� ��������� ������������� ��.������ !��� �� +��+��� ���������%���A�����!���������+������'��������+�+�����&/��(�����%�,�/����������*�������+�������+����������������&������!��� ����+��������!������"��#�$����%�&�������'�� ���(��)��������� �����

5'( �� �� ��

�����"���$��)��������������� �������������'�� ����%��!�:�:::B9� ���:�7:KH!��� 3:�::59� ���-�:KH�4��*����������������8�����+��������������!��������"���$��� �������5:,:::��.�����!����35:::��.�����������4��� +������++��&��������!����������������'�� ����%��������������*���/�

��*���9&-���������'�� �"��%��

SENSITIVITY RANGES

%/ft. %/m

0.30000 - 0.07500 1.00000 - 0.25000

0.24000 - 0.04800 0.80000 - 0.16000

0.18000 - 0.04000 0.60000 - 0.13000

0.16000 - 0.03000 0.55000 - 0.10000

0.15000 - 0.02400 0.50000 - 0.08000

0.13000 - 0.02000 0.45000 - 0.06500

0.12000 - 0.01600 0.40000 - 0.05500

0.11000 - 0.01500 0.35000 - 0.05000

0.10000 - 0.01500 0.32500 - 0.04500

0.09000 - 0.01200 0.30000 - 0.04000

0.08250 - 0.01000 0.27500 - 0.03500

0.75000 - 0.00900 0.25000 - 0.03000

0.06750 - 0.00750 0.22500 - 0.02500

0.06000 - 0.00600 0.20000 - 0.02000

0.05250 - 0.00450 0.17500 - 0.01500

0.04500 - 0.00300 0.15000 - 0.01000

0.03750 - 0.00225 0.12500 - 0.00750

0.03000 - 0.00150 0.10000 - 0.00500

0.02250 - 0.00110 0.07500 - 0.00375

0.01500 - 0.00075 0.05000 - 0.00250

5'4 .�.���� B��E�����/�� ���������� ����

�����������������!����/��%�+���%��+���������������������&��%���!���+�+�����/��(�!��������"���$��� ��������������&+������� ��� *������ !�������� /���� ������ ������ ���� �����������%��+������������%���%�����+�+�����/��(�

9&7�- �������+���%���+����/��(

����������+���%�+�+�����/��(������������%�������!�+�+����������/����������+�������������������%��/���������������/�*��(��������������������*������ E������+��%��� �*����������������&������������������*���������*����

���� ��������+��������������������������6����������������&+���%�+�+�����/��(����������%����������������� ����������.����� ���++���������+��'�����������(�%�,���������������!!����� �����+��!��������

2����� +�+�� ������� ���� *�� ����� /������ -:� !���37�������4��!�����)����������+���������������+��'�����%���!����+���������%�����+�+��/���������������%��!������*����������������%�

9&7�5 ����I������

����'������ ��������'������ ��!����������+�����������+����������������'������ �����*�����������/����������������������&�����3������%����9&-4��������������������������+��+����+���������!��������+���%�+������������������������������*&�����������8�����������%��������������*������%�� ������������ ���'������!!��������������!��/�+��������!�����+������������,����������I�2�� �����,��������*���+������%�/��������������������������(���������������������������*�����������!�������/��������%���%�����+�+�����/��(���J����@�I�������7�

��%����9&-������������

Page 56: Orion Manual

���������������� ����� ����

������������� ������������������������������

9&7�7 ������������

��*������+������������+�����/�������+�+����%���������*�����'�����������/����������+�+����%������* ���������������������6��������*�8�

9&7�< ���������

��������������3�H�BB&5DB--5&:::4����������������+����������+�&������������� �*��������������+�+������(���!�����"���$�)������������/��������'�����'����+�����������!�����������+�������*�!������������������)��������

9&7�9 �*�/,����������<9�)�%���

�����������<9���%������*�/�������������������������������+���*��%�������� ���/��<9���%������*�/������*�������������*��������!�������D:���%������*�/��������������������������!������ ����������������������� ����������+���������

9&7�0 �*�/,����������D:�)�%���

�����������D:���%������*�/�������������������������������+���*��%�������� ��������*�/���������������������������!����� ������� �������������*������%�������������E��������*����!���*�/��

9&7�B �/��+��*�/

���/��+���*�/��������� +������������(��%���������������&�����*�������/��+���*�/����'�������%�������������������&�������*�/������/��+���*�/�/����������E������!������������/������(��%���D:���%����*������������%����.���(��������&+����������������/��+���*�/����+��!������!����������+���%� ������3�'����*�������������������������!�����%�4�

9&7�1 .��'����������

���������������������������������'���!!�����������!���!!��&���� � +����!�+���*��%��-� !���� 37�������4��!������%���+�+��.�����-��.��'������!����37��.��'������������4������!����/&��%� ��*���%�'��� �����.��'������������������ !�����!!�������E������� +����!���*�/�������������*����������������/���������8���������/���+�+�����%��������*���%��++�������3������*���9&54�

��*���9&5���*�/�.��'����������

Elbow ID1 in.

(32 mm )0.75 in.(25 mm)

0.5 in.(20 mm)

Standard 90° Elbow2.25 ft.

(0.69 meters)2.00 ft.

(0.61 meters)1.50 ft.

(0.46 meters)

Standard 45°/Sweep Elbow

1.40 ft.(0.43 meters)

1.00 ft.(0.31 meters)

0.75 ft.(0.23 meters)

9&7�D 8����������+���%�������3��4

8����������+���%�+�����������8����������!�+�+��!�������+�+����%�����������������*���%�+������������� +����������!����8����������+���%�+�����/�����*��������+������+���%+�������/��!�������������+�+����%��������������+�������������

9&7�-: ���+���%�������3��4

���+���%������������+�������+�+�����/��(�!�����%������%���!������+�������%� ������������������!����������������������>��501�!�������������������+���+������������������������+�+�����/��(�* �7H1&�����3D�9���4���+����� ���*��%�������+��&��������/������-H75&��������+��������������������������&��������������J����@�I�������7���������+�+�����/��(������&��������

�������+���%�����������3�H�BB&5DB-:D&:::4����������59������!����+���+�����,�!���������������-H5&����������+&����� ���*�����+������������+���+�������*�����2�+����� ���*&��%�����'����*��������59:�!��������3�H�BB&5DB--:&:::4�������>��-15:�������!����������+�������++����������

9&7�-- G����������8��

�������+���%�� ������/��������������������+�+����%�����,�������������������������6��������*�8�*����������+������!������������������.������ +�������������6��������*�8�������&��������������������*��������������'����� �/������%��&(���*��/����������'�����������*�8������*�8��������'���������'�������������!�-<<���*����������357B-���*����������&����4����������*�����+����� �����������+��'�������� ���(&�%���>+������'���+�+�������*�������������������6�������*�8������+�+����������*����������������� ���������������%�&�����/�������+�+����������������������������+����*�������!����6��������*�8�3������%����9&54�

JUNCTIONBOX

TOSAMPLING

PIPE

TODETECTOR

TOSAMPLING

PIPE

TOSAMPLING

PIPE

ACCEPTABLE

JUNCTIONBOX

TOSAMPLING

PIPE

TODETECTOR

TOSAMPLING

PIPES

TOSAMPLING

PIPE

ACCEPTABLE

JUNCTIONBOX

TODETECTOR

TOSAMPLING

PIPES

ACCEPTABLE

TOSAMPLING

PIPES

TOSAMPLING

PIPES

JUNCTIONBOX

TODETECTOR

UNACCEPTABLE

TOSAMPLING PIPES

��%����9&5��G����������8���!�����+����%�����

Page 57: Orion Manual

�������� ���� �������������

������������� �������������������������������

9&7�-5 ��+����%����

�����%����!�+�+��/�������/����������+���%�������/��������&���� ��������������������!�-&����,�7H<&��������-H5&�����375��,�59�������5:���4����+�+����%����������!��������������������%����!�+�+������� ��!�����!����/��%?

-� �����)�����������+�+������

5� �����)�����������*������+�����

7� �����*������+����������������*������+�����

<� �����*������+��������+�+������

9&7�-7 ���+���%�����

���+���%�����������������%����� ���������+������������������+�+����%����������%��/���������������/��������������&+���%�� ������"�!���������&B5���������������������������!������+���������+����%���.������������������+���%�������E��������������������%�Q����Q�I�������7���!�/����

9&7�-< � ����������+��������

� ����������+�����������������������.������!������(�������'���!��������!�����������+���%�������������� �����������)��������

���� ���&B5���.������-5:����������8����������+����������� �>��������,�>�2������������A��++��'��� ������������'���������+����������!�-5:���������

9&7�-9 >��������%�!����+������������������

�������������������������.������+���������������������>���+������������������������%,�����"���$��� ������� �*�������������*��������!����+�������������/�����������+����������������+������/��������"���$�����+���%���������������>���.����������!����+������������������,�������������������&��'�� �������%������*����������������/������*���9&7�

��*���9&7��A�������)���������������'�� �������%�!��>���+��������������%

PROTECTED AREA MINIMUMSENSITIVITY SETTING

Square feet Square meters %/ft. %/m

< 3500 < 350 0.2400 - 0.0480 0.8000- 0.1600

3500 - 8999 350 - 849 0.1800 - 0.0400 0.6000 - 0.1300

9000 - 10999 850 - 999 0.1600 - 0.0300 0.5500 - 0.1000

11000 - 11499 1000 - 1099 0.1500 - 0.0240 0.5000 - 0.0800

11500 - 13999 1100 - 1299 0.1300 - 0.0200 0.4500 - 0.0650

14000 - 14999 1300 - 1399 0.1200 - 0.0160 0.4000 - 0.0550

15000 - 16499 1400 - 1499 0.1100 - 0.0150 0.3500 - 0.0500

16500 - 17499 1500 - 1599 0.1000 - 0.0150 0.3250 - 0.0450

17500 - 18499 1600 - 1699 0.0900 - 0.0120 0.3000 - 0.0400

18500 - 19499 1700 - 1799 0.0825 - 0.0100 0.2750 - 0.0350

19500 - 20000 1800 - 2000 0.0750 - 0.0090 0.2500 - 0.0300

9&7�-0 ����������������

����������������� ��� ������������!��������,���������� ����������!�/����� ������,� �'����*��� ��� ����� ���+��� �������������+������������*�����������/��������%��������+���&�����%��%�,��H�BB&5DB-55&:::�3������%����9&74�

��������+���������!���������+���%�������������*�����&����������������������������������%��������������+���&������!�������������+����������������+�+��*�������������*���������������%�+��������!����/&�+�������������'������������+������������������������%��������!�������������+���&�����������%��!������ �����%���������������������%,�����(����+�+�����/��(�!����� �*���(�%������*���(����������(����!����������� ��!�����!������������+��������������������������������������'������������%��+��9&<�

INCHES OF WATER

0.20

.40 .60 .801.0

MAGNEHELIC

��%����9&7��A�%�����������%�

5'+ F�����������2��/�� � ���.����3��

�"���$��)��������������������*���������������������/����������*�����+�����������+�����'��������'�����������*�����+���&���������������%�����+�+��%����/�'��,�����)����������� *������������������������������%��������+�������������������%���'��/�������+�������/���������+�+��%�������������������"���$��)������������+������������+����������!���!!����%�������+����������J����@�I�������7���!�/����������E��������+���%�������������+�������!���+���������������/������!&!�������������+���������

9&<�- A�������%�����������������)�!!��������

�������+����������!!�������������*�����������/��������%&��������+��������%��%�,��H�BB&5DB-55&:::��������������!!���������+�������,�����������*��%�!��������%��������!��/�+����������������������������%��+��������+��������������/��������������/�+��������+��������%�*�����������+������"��������������+����������!!����������������%��%�,���(��%����&����������������%��������%��%����������+���������������!�����

Page 58: Orion Manual

���������������� ����� ����

������������� ������������������������������

5'5 .�.���� B��E����.���/� 2.��

�����"���$��)������������*������%����/����������*����+�+�����/��(����+���%�� +��?�������*�����+�+�����/��(����&+���%,������������%��������+���%�����������������������+���%�

9&9�- )�����*�������+����/��(����+���%

)�����*�����+�+�����/��(����+���%��������������������� +��!����+���%�� ��������������*�����+�+�����/��(� ��������&/��(��!�+�+���������8��������������+��������������/��������&��%����� � �������� ���+���%������� !��� ���/��%����� ����� ���� �����

�����"���$��������*�����+�+�����/��(����������%����/���J����@�I�������7������+�+��%����/��(�����*��� ���������������&� ����������/�����+�������������+�+��������J����@�����������������8����������+����������!������ ����������������+���������������������E���!����������+���������������+�+�����/��(�������������E������������������������+�&��!�����E������������*���������������'�� �!����������+���������������� �����

9&9�5 "�������������������+���%

"�������������������+���%� ����������+���%� �����%����+�+����/��(����!������!,������������������������%���������������������*������%����/����J����@�I�������7�������"���$�)������������*������%����/����*����������*�����+�+�����&/��(����+���%����������������%��������+���%�������������+�+����/��(�

9&9�7 "����������)�������+���%

"����������)�������+���%�����������+���%������%����+�+�������� ���� ���������������������������������*������%���/����J����@�I�������7�������"���$��� ��������/����������!������������������*����������+��'������8���������������������������E����������������������

����)�������������*�����������������������711��.��'�����!����3--1�������4�!�����������+���%�+�����������)����������>������>�2��������!���������++�����������!�7::����<:::!��H�����3-�9����5:�7�������H����4

���� "����������)�������+���%�+�+�������*��>��-15:������!���������������������+�������

5'6 ����� ��/������.���/��� 0��

�����++����������!��������������������+���%��������!�������"���$��� ����������!����/��%�������!�� +������++�������������*������������%���������!������+���%������������������

9&0�- ����+�����2��������!!����

)�����*�����+�+�����/��(����+���%����*�����/��������������%��������+���%����������������!�������+��������������!!������!������!!�������'����*������ ���*�'�������.��+��������(�,�/����'�����!�������*�����+�+�����/��(����+���%���������&��������������'����!��8����������+���%�+������/�����*����������%���'������������������'���/�����*��*���/�������*����� ��6�����*�'�������.��+��������(��������/����'�������*������%�����/��/� ��������+����������������������+�+��*�'������������%�/���������������+������������������+�+��!������!�������'��������8����������+���%�+���������++�����/�*���/�������*������ �!����������������'�������������+�����������������������������'����!�+�+��%�*���/�������*������ ����������������,����������������������������.�����������������.����� !����%�� �!� ���� +��������� ����� �8������ 5:,:::�.�����!����35:::��.�����������4�

9&0�5 2��+�����"����

)�����*�����+�+�����/��(����+���%���������������%��������&+���%����������������!������+�����������++������������������*�����+�+�����/��(�����*�������������*�'���������++��������%�/������+����� ���*�����+���%�+�������������������������+�������%���������!�����%������������%��������+���%,�������&������������������ ��������������������+��!����������������%�����,� *�!���� �������� ������� ����������������������������.���� ��!!����'�,���/�'����!����������������%����������������!!,� �����'���������(�������������!!����'������/����*���!&!������������*���������!�*������������/����+��'����� ���.���(�������+��������+����������!����*�������

�!���*&!��������������������.�����,���������*�����+�+�����/��(���������������/�����������+���%�������!����%���/����+��+��������������������!��/�

9&0�7 2���������

"����������%��������+���%�����������������������+���%�������&���������!��������������++���������������*�������+���%����%��/������+����������������������%��.��+�������������&������!�����!�������

9&0�< �������

)�����*�����+�+�����/��(����+���%����������������!���+��&������%����������A����+��� ��'������+���%��� �*����.�������+�����%�����������%����!������������������%��A��������%���� ����������� %����� ��� ���*��������/������������*�����+�+����/��(��� ���%��!������ ��������������������+����������

Page 59: Orion Manual

�������� ���� �������������

������������� �������������������������������

9&0�9 �!!���������

)�����*�����+�+�����/��(����+���%�/������+����� ���*�����&+���%�+������ ��� ������������ !���+��������%��!!����������"�!������������������!���+�+��� +����.�����������A�� ��!&!�����������������������'�������*�'������������%����������������������+������

9&0�0 F��������������%�

)�����*����� +�+�� ���/��(� ���+���%� ��� ������������ !��/����������++���������������'����������(��������!�������,�/������������'�����!����+���%��� �*����.��������+�����%�������������%����%����!�����/�����������"���$��)����&���������*����������!���E���/����������++��������������%������ �*���������� ����������������������*�!�����������������)�������������� ����)�������������*�������������������!������/����+��������������"�!������2��+����-�!�������)�&���������'������������+���!���������

5'& ���.���/�.�.���� B��E�����/�

�!�����������%������+���%�������,�����+�+�����/��(���������*������%����������������������������������+����%����������������������+���������!������+���%�+�+�����/��(����%�����������������������!����/��%�+���%��+�����������&+���%�+�+�����/��(�� ������3������*�����+�+�����/��(����&+���%,������������%��������+���%������������������������+���%4����*������%����/����J����@�I�������7���!�/����

9&B�- >���%�J����@�I�������7���!�/���

J����@�I�������7���!�/���������F����/���++���������������� ����� !��� ����%���%� ���� ���+���%� +�+�� ���/��(�� !��� ����"�����%�&�������'�� ����(��)����������J����@�����%���� � �������� � *�������� +�+�� ���/��(� * � ����������%� �����������+���������!���������+���������������+�+�����/��(�����,� J����@��������������������+����������������� ������������.����E��������������+��������!�����������������&/��(��������������������������������� ���.���������,���&�����+�+���� ��������������+����%������*�����������������������������J����@�* ���������%����

"�!������J����@�I�������7�>���=�������,�:0&579D1<&<:-,!��������������J����@�

9&B�5 )�����*�������+����/��(����+���%�)���%�

��������*�����+�+�����/��(���������/��(��!�+�+���������8�������������+��������������/����������%����� ������������+���%������ !������/��%����� ����� ����� ����������+�+�����/��(�������*������%�����������������������!����+���!���������&�������������������+��'�����+��������'���%��!�������+�������������

���� !����/��%� ����� ������!�������*�����+�+�����/��(�����%�+���������?

-� A�8��������*����!����+���%����������-::�

5� A�8��������*����!�+�+����%���������<:�

7� A�8��������+���������+����%����7:�!����3D�-�������4�5:�!����30������4��+����%���������������������%��'����������

<� ���������&������� �����,�����������+�������*��������������0��������3-9:���4�!����������������+��������������+�+��*������

9� 8����������+���+�����3��4����+�������*��-&����,�7H<&��������-H5&�����375���,�59�������5:���4�����������������������59�!����3B�0�������4����%�

0� 2�+����� ���*�����+���+������3��4������*��7H1&����3-:��4���+����� ���*����������������-5�!����37�B�������4���%�

B� A�8������������+����������!!��������� ���:�5� ��������!/�����

���� �������+����������!!���������#"���%����������!������ /���� Q����Q� ��!�/����� "�!��� ��� Q����Q������,��H�:0&579D1<&<:-,�2��+����5,�!��������������������+��������������������

1� 8������+�����������'�����������0���������!�����������

9&B�7 "�������������������+���%�)���%�

"�������������������+���%�� ��������������%����/�������Q����Q�I�������7���!�/��������������*������������++� /���������8��+������!�����������+����%���.�������������������������%����� ���+���%������������ ����������*�����+�+����+���%������������*�����������������������������E����

���+���%�+�+����������*������������������!������!�������&���������%���������+���%��������������*���+�����������������������!���������������������!��������%���������%���%�����/������.�������������+���%���������������+���%�������������*�� ��� D:� ��%����� ��� ���� ���!��/�/���� �� ������� ���� +�+�3��++��4�3������%����9&<4�

END CAP

AIR FLOW

SAMPLING PIPECENTERED ON GRILL

RETURN AIRGRILL

SAMPLING HOLES POSITIONED90 TO AIR FLOW

o

*

��%����9&<��"�������������������+���%�A�����

Page 60: Orion Manual

���������������� ����� ����

������������� ������������������������������

9&B�< "����������)�������+���%�)���%�

)�������+���%�����������������&�!!����'����������!��������&+���%�����������+�+����������������������������%���)��������� �*������������'��������%�������������+�����!����+�����!�����)��������������(��/����*��%�'���* ������8����%�������������������'����������* ����������'������������ �������������������*����+��,�%�'��%����� �/�����%��!��� ����(��+������������� +���!����+���%����+���������� �������������%�&�������'&�� ���'������������������(���������������������/������������*����������������'���*���/�������!�+������ +�����������������,����������'�� ���%�����!��/�������������/�����������������!&!����'�������!�+����&������������'�����

������������+���%���������������'��������6��������&'����%����!�����'�����������*����������+�����'�,��������!��/�����%������������ �����������������������(�&���������� �����*����������!!����'��

����)�����������>��501������>�2��������!���������++����&������/��������+������%�����'������ ����%���!�7::����<:::!���H�����3-�95&5:�75�������H����4�

J����@�I�������7���!�/�������������������%������������&�����!����"���$��� ���������������������������E�����������+�����������������%��������!����/��%�%���������?

-� ��� ��������������*������������+������������

5� �!������"���$��� ��������������������+����� ����(�&����������� ����,����������������*����+�� ��������&������������++�%���!����!��/������������3�4�

7� �����8����������!��������)��������#"���%���������*��(� ��� �������������%�����8�����&+�������+������������������+�+��%���������.�����������������+�����'����!��/������%������)��������

<� ����������+���%�+�+�� ��������������++� ����������������,���/����������!�����!������������������!���8�����/������!������ ���������!����*�������3*����,������������!��������+�����4����������������!!������!�������!�������������������������/���������!�����������+�*����!�����'��%���(�,����������������+���%���*���+��������!�����!������

���� F�����������+� ������ ���+����*��������������������&+���%�+�+����������������/����%���������<,��������&+���%�+�+���� �*��+������������������������8�����/�����,�*������!������+����*���!����������,�*���������!��������+������

9� ������� �������+���%�+�+������� ��������+����������������������!��/�����������+���%�+�+��

0� ���� ���+���%� +�+�� ������� *�� ��������*�!���� ���� �8&������� !���� ����*������%����*�!�����������%� ����������/����������������

B� ����������+���%�+�+���!�������������!���������!������������!������������.������

1� ����������+���%�+�+�����������/��������������!����!���������������!�����������!�������

���� �!�!�����������*���(��,���!!����������!��/��� �������%��*��+�������!���+��+����+��������

D� )����������������+���%�+�+���������������������������8&��+����������������(������ ���������������%�� �����!����6������������

-:� F����'���+����*��,�����������+���%�+�+���+��������!����������!�����������/���������!���������!�����

9&B�<�- )>2����A���������"Z>�"A��

-� ��������(�����+���%���*�������!����������������!��/�

5� ��������(�����+���%���*�������%�������%��������������*��������&������3��++��4�

7� ����������������+���%���*�������*���+������++��8�&����� ��'�� �<��������3-::���4�

<� �����8��������*��������8����������������!�5�������30:���4���������������

9� ����������+�+�����/��(,���������%�����������,����������8�����711��.��'������!����3-11�������4�

0� ����(�������8��������*����������*��>��-15:�������!�������������+�������

AIR FLOW

“ SNIFF” VER 3 CALCULATED SAMPLING HOLESFACING AIR FLOW SPACED EVERY 4“ (10.2 cm)

X

EXHAUST TUBEAIR TIGHT RUBBERGROMMET OR EQIV.

NOTE: DIMENSION X MUSTEXTEND 2” (5.1 cm) MIN. INTOTHE DUCT

CLOSED END CAP

��%����9&9��"����������)�������+���%�A�����

5'7 .�.���� B��E���� ���� ���

CAUTION!

�������!������# �������"�����8!��;������������������� � � ����!<�#������ ��� H�����H����� � �����!<�"����!�����"�������1�8���������������������� � �����!<��!�#���H�����H����������!<�#�;�����!�"����� H�����H� ����"���� �!��� �!�� ��#$� ��!��������"������ !��"!�#��"!#���1

�����+���%�+�+�����/��(������������%�������!�+�+���/���������+�������������������%��/���������������/��*��(�������)�������� ���*�����+�������+��%��� �*�����������������&��������������+�+�������*���������*����/�����������������&�������!�-H5&����,�7H<&��������-&�����35:���,�59���,����75��4���+�����%��+�����������%�����������

�������+���+�+�������*��������������������%��������� �������/��%����'���+���!���������������������������������Q����QI�������7�>���P��A������

���� �� ���6�����'���������!� ���� ������������� !�����������%�����/��%���������Q����Q�����%����+�+�����&/��(������*��*���%���������������������!������ �&��������%����

Page 61: Orion Manual

�������� ���� �������������

������������� �������������������������������

�������+���+�+�������*�����+����������%����������+�+����%������������6��������������/�����������������������&������%�������������+���*��%�+������������������+�������������������������6���������������%����������������� ����������&�.����� ���++���������+��'������ ����(�%�,���������/�����!!����� �����+��!��������

9&1�- ���+���%�������������������

���������� �/�� � +����!� ���+���%�+�����?��8����������&+���%�+������������+����� ���*�����+���%�+������

9&1�-�- $�))���A���������

8����������+���%��������3��4�����������������!��������&�����+���*��%���++����������������������!��� ���,����++�+������������+�3������%����9&04���������+���%����������*�������������������������+�������*�����/��������8���������+���%�+����� ��*��� 3��������%��+��9&1�5�74��A�8����������%������59�!����31�������4�

1” (25 mm) MIN.

SAMPLING HOLEDRILLED IN END CAP

ESCUTCHEON PLATE

CEILING TILE

3/4” 1/2”OR

1/2”

(25 mm) x (20 mm)

(20 mm) x (20 mm)1/2”‘T’ FITTING

1” ” OR1/2”

(32 mm) 3/4 (25 mm)

(20 mm)PIPE

1” (32 mm) 3/4 (25 mm)

(20 mm)

”OR 1/2” PIPE

1” (32 mm) 3/4 (25 mm)

(20 mm)

”OR 1/2”PIPE and END CAP

25 FEET

MAX.(8 METERS)

1” (32 mm) x1/2”(20 mm)OR

��%����9&0��8����������+���%������

0&1�-�5 ��A���������

�����+���%�������3��4�����������!������,������-H5&���������+����� ���*�����+���,�!������T&����������+����� ���*����+���,�7H1&�������+����� � ��*���������+���%�+������������+���%�����������*���������� ����� �������+���%�+����������+���%�+�����(���3�H�BB&5DB-:D&:::4�����'����*���/����59������!�����/����3������%����0&B4��������+����� ���*�����������+������ �����������!�59:�!����3�H�BB&5DB--:&:::4�

�������+���%�+��������������!���!��������������,����!&�8&���%������%�+������,���������������>��9I��!�����*���� ����&��%�������������>I����*���E����������*��� ����/��%��'��������������+����� ���*�����>��-15:��������!����������+��������&����������������!���������������/������>��D<I&5�������%�

���������������,���������!����/��%����+&* &���+�+���������

-� )��������+�������BH1&���������������������%�����������������+���%�+��������!����

5� ��������������+���+����,������������!����,�����������������������+���+��������!�����/�������!����

7� �������� ����*����/� ����� ���+��� +����� �������� �����%��������������%�

<� ��������������%������������+����� ���*�����+����������!�����%�

9� ��������+����� ���*����������������+����� ���*�����+����2�����*��%������E��

0� ��������E�����*��%���������������������������%��������&+������������

B� ��������*��%������!��������+����� ���*�����+�����������!��������+����� ���*�����+������������+���%�+�����������������%�����/���������%���/���������+��'�����������&+���%�+�����!�����������%�

1� F���������%�����/�����,���%�����!��������+����� ���*����+�����������

PIPE NETWORKPIPE NETWORK

3/4" X 1/2" T FITTINGOR

1/2" X 1/2" T FITTING

MALE CAPILLARY TUBE ADAPTER

(1/2" OD COMPRESSION X 1/2" NPT)

CAPILLARY TUBE

(1/2" OD COMPRESSION X 3/8" NPT)FEMALE CAPILLARY TUBE ADAPTER

SAMPLE POINTTHUMB SCREW NUTCEILING TILE OR

MOUNTING SURFACE

SAMPLE POINT

12' MAX.3.66 METERS

7/8” HOLE

��%����9&B�����+������������

Page 62: Orion Manual

���������������� ����� ����

������������� ������������������������������

9&1�5 ��+����/��(���*���

����!����/��%���*�����������*���++�����!�����!����������/�����%�

9&1�5�- ��A��������������

�������&���+���%�+�+�����/��(������*�����(���/����������&!����������*�������������*�����������*���++������������+�+����/��(���� �������'�� � ���� !���� 37�������4�����+���+�+���*���� ����� ��� �� ����� �!� -::� 3�H� BB&5DB:57&:::,� �����%����9&14�

Fire SystemsFire Systems

6.0

1.000

RED BORDER

SMOKE DETECTION SAMPLE PIPE

DO NOT DISTURB OR ALTER

��%����9&1�����+���%���+����*��

0&1�5�5 ��A�������"�������

�������*������+��������6������������+������������������������ ������������+���%�+�+�����/��(���������+���%�+��������*����*����������+���%�+������*�������������������!�-::�3�HBB&5DB:55&:::,�������%����9&D4�

Fire Systems

SMOKE DETECTION SAMPLE PORT

DO NOT PAINT OR BLOCK

3.0

0.75

��%����0&D�����+���%��������*��

9&1�5�7 $�))���A���������������

�������*��������������������! ����+�������������������������������+��!�����8����������+���+�����������8����������&+���%�+����������*����*����������+���%�+�������*������������������!�-::�3�H�BB&5DB:5-&:::,�������%����9&-:4�

0.875 DIA.0.875 DIA.

0.375 ± 0.0100.375 ± 0.010

DIA. HOLEDIA. HOLE

OR I O N

SA

M

PLEPO

IN

T

TM

D

O

NO

TP

AI N T

O

RB

LO

C

K

��%����9&-:��8����������+���%���������*��

9&1�5�< ��A���������������

�������*��������������������! ������+���%�������������������������+���%�+�������������+���%�+����������*����*����������&+���%�+�������*������������+�����!��������+���%�+�����(������������!�59,�3�H�BB&5DB-:D&:::,�������%����9&--4�

OR

ION

™X

TS

A

MPLE POINT-DO

NO

TP

AIN

TO

RB

LOCK.

1.925 DIA.1.925 DIA.

1.015 DIA. HOLE1.015 DIA. HOLE

��%����9&--�����+���%���������*��

Page 63: Orion Manual

�������� ���� �������������

������������� �������������������������������

��������"���������������� � �

6'* �� ���3� ���

��������+������'��������������������%�+����������!�������"��#�$�����)�� ����������������������%�������������*������������������2�����������%�2���(�������

0&-�- 2�����������%�2���(������

����2�����������%�2���(������� 3�H�:0&5799-0&<:54,�����*�����+�������+���������������%��!��'�� ��"��$�����)�� ����������+��+�����!������������ ����������&�����+��+���� ������+����������������+������* ������/���,���+��'������!������������!���!������������%�����������������!������ ����,����������%����������������*����!���/������ �2��+������������%������+�����!�����������������%�����(��������������*��������*������������������������������

6'( .��'������������/�.��.��� ���

�!���������"���$�����)�� ���������*�������+����� ���������,������ ����������*�����+���������������������������!�%��������������*��������������������*�����������

��!�����������%� ����������������%� �����,�%�� �����%�� ���!����/��%�+��&������������%�+��+�����������+�?

-� ���!������'���������+��������!������"���$��� ��������/�����2���(�������������)��.��+���������*�����������+��+��� �����/������������� �

5� ���'������)�������������+��������!�����+�������!������������/�������������%�+������������������������� ���'�*������!�������%���������������������+�+�����/��(����H����������������������!������ �����

7� 2���(����������)����������������� ������������������!��������*��������������

<� ������������)�����������������������������������������*����������� ��� +��'���� �������������� �!� ������� �������*��������������� ��.��+�����

9� 3�+������4�������E������)�����������!��/�����������2�,A������3�H�:0&570:-5&<:-4!������!��/��������E������������������

2�����������%�����������������!������������������������*�������+�������������������!��� ����%����%�+���&��������&������������!���*��������������%�������������������������*�&!���������������������������������+,���� ��� �������������� ��!��������������������+������%�������������������������*�����������!������������!���!����/��+�������������+����&����������������

6'4 ������ ����� ����/

��*��������������%��������*�����������!���������������������+�������!�����/��(������%���������+������%������&����������������������%������,������������������������ ����������������'������!!������������+������%���'���������������*��������������������������������+������%�������������������� ����+����*���

�!����������*��������������%������+���������������,���/�&���������������������(�������� ������%���2�����������������������*��(%�������*����������!��������%��+���"�����������8������������������*�����������������!��/���'����!������������������%��2�����/����

6'+ ������B� ��

����������������!��/����������%����������������*���������!��+��+���������������!�����/����!��/�!�������������%�����!��/!�����

0&<�- ��/����!��/�����

>�������!����/��%�+������������'���! �������/����!��/�!�����+��������

-� �������� �����I ���� �����I��!����� ��������������!����!!�

5� ����/��+����0:���������+�������!��/����� ������!����������*����������'����

7� "������ ���� ����� ���������� ����2�����������%�2���(�����,��H�:0&5799-0&<:5�

<� �������� �����I ���� �����I��!����� ��������������!������������������������������*��(������������+����&��%������

0&<�5 ��%�����!��/�����

>�������!����/��%�+������������'���! �������%�����!��/�!�����+������%�

-� ����������������!��/�����������������* ��+����%�����+�+��

5� ����/��+����0:���������+�������!��/����� ������!����������*����������'����

7� "������ ���� ����� ���������� ����2�����������%�2���(��������H�:0&5799-0&<:5�

<� "������������+�+�������������������������*��(�����������+������%������

Page 64: Orion Manual

���������������� ����� ����

������������� ������������������������������

6'5 �3� ����.����3����������� ���

�������+����������������+����������������*������������������������������������������%�����(�����������%�/��������������������������+���������!����J����@�I�������7��A��&��������������+���������%���������������������������'������������+��*���

>�������!����/��%����������������������+���%�+��������&�����+���������3������%����0&-4?

-� ������� �� !��8�*��� ����� ����� ���� �������� ����� �!� �����%��������+��������%��%��

5� ����������������%�������������+���%�����������������+�����

7� ���������%��%���������+��������/��������/�������*��������������������������+��������!��������%��%��

INCHES OF WATER

0.20

.40 .60 .801.0

MAGNEHELIC

CEILING TILE

SAMPLE POINT

HOSE

MAGNEHELICPRESSURE

GAUGE

��%����0&-��A�%����������������&>+

6'6 ����.�� � ������������ ���

A�8����������+���������'���!���������������������������&������!�������������!�����������(���!�������)�������������&�+����������(������������������+�+������������+���%�+����!��������!��������)����������������������!�������������������������������8����������+���������!����J����@�I������7������*�� ������������ ����������������%�����(�������A�������������+���������������������������������������������+��*���

�����/����������+�������������������8����������+���������!������ ����?

-� )�������������!�����������+���%�+�����!��������)����&����

5� ����/���������(�����������+�+���������!�����������+���%+�����

7� "������������������!������!�������)��������������+�������������������������8����������+��������

6'& /��������E�� �� ��/

����%��������(�������������������������!�������������!��������+���%�!������������'�������!��������(��%��������%������,����������&������-�����������-�����������������������������*����+���������������������������/�����������������������"��������������(��%��������%���������������&�����������������(�����/����*������

0&B�- �����������(���+��

������ ���� �� ���*��� �!� ����������� � �'����*��� ����������(���+�� �����J����������(�@�����������!������ ������+&+����� !��� �� ������������ +��������F���� ����%� ���������(�,� ������������� �����%�����(�� ����� ����+������������������/�������������������-������������������� ���.���������*����!�+���������+�� ��

0&B�5 F���������������

����/����*������������������������������������+���������'�������!� ����+����� !������E�������������� ��� �������������&������������+������������'�����������������������+��!�����* ��++� ��%���'����%�������+������!��I2�������������*������(�����+��������!���������'����������I2������������* �'�+��������������������������!�����+�������E�����������/���*�������������,�� ����������������3�2�4�%��������������!�����������������������* &+���������!��'����������I2�������&���������*�����������* ������"���$��)��������

CAUTION!

����%���������!��������!�"��������� ��������!���!������"���%����!���������� �!������;��#�������� �!���"���������8;����������!� ��"�������� � $��8!����"���;�!��������������!1�����$�������;�!��"������������%����#�;� ������ ��� �"����������;� ��� �������!1

0&B�5�- F�"��>""�����-�3�������4

����!����/��%������������������������(�� ����+��������2�'�+���������������� �*���������(�����������!������+�������������%�'�����

���� ����/���������*6�������������%��!�+���������������������������/��������!��/�������� ���������*�����������

2���������0�9�!����35������4����%����!�-:H:�::<��������3-:H:�-���4�:�:-B�!����3:�:B1����4�/����/��������������������!:�:-5��������3:�7���4���������%������I2����������������0�I�����������!����������-0���+�������%�+���/����!�����+�&����� �!� 7�������������� � ����� ������� ���+���� /�����-5:����������!������������!�����%�E������

���� �!���������+������'�� �����������(�����%�'����!!�

Page 65: Orion Manual

�������� ���� �������������

������������� �������������������������������

0&B�5�5 F�"��>""�����5�3�������4

WARNING!

�� ���������� ���� ��� �����!� ��� !�"���"��������;�������# !��"!�������!����#���="������������;!�����!������1

������������ �*���������(������������!������+������������&��%�'�����/�������+������� !��/��� �������������-�������&�*���

2���������7�59�!����3-������4� ���%����!�-:H:�::<�������3-:H:�-���4�:�:-B�!����3:�:B1����4�/����/�������������������!�:�:-5��������3:�7���4���������%������I2����������������0�I�����������!����������-0���+�������%�+���/����!�����+�&����� �!� ���������������� � ����� ������� ���+����/�����-5:����������!������������!�����%�E������

���� �!���������+������������!�����������������������*�*������!!�

Page 66: Orion Manual

���������������� ����� ����

������������� ������������������������������

THIS PAGE INTENTIONALLY LEFT BLANK.

Page 67: Orion Manual

�������� ���� �������������

������������� �������������������������������

��������#����� ����� �� � ��

&'* �� ���3� ���

����� ���+���� ��������������������� ������������� !��� ����"��#�$��� ������������+�����������������*��+��&!���������������������*��������������'���������� �����+��*&���������!����������%��������������������,���!����������*���������%�����2�������'��A����������,�2��+����1��!� �����������

&'( ��0��3�������� ������

���������������������������!������ ������������*��+��&!������ ��� ��� ����*������� �����'�������� �����'��� *��/���+��!���������!�������������+����������������������8&������� ���+�������%���������3�������&B5�����������������.���������4�

&'4 ���� �������.�����3���

����!����/��%�+���%��+�����������%���������������������&��������+�������������*��+��!������������Q����������� Q*�����

B&7�- I������2���(

����'����������(������*��+��!�������'�� ���8�����������������(��������������+�+�����/��(�����%��� �

���+��!��������'����������(��*���'�������������+�+��%����&/��(���������(�!����*�������������������+�+�����������%��� *���(�,�*���(�%��,�����+�,�����

B&7�5 ������ ��������2���(

����*����� �*��(�+�������������+�/�����++� ����+�/��������������������*����������'�� ���8��������

��*����� ������������(����*���������+�������* �������%���������/��������*���������!����*��������������F������������������������,�����������������'������*����� �'����%�����!��� �*��&��� �������-�9�I�������������*���/�����������'����%�,�����*����� ��������*����+������

�������� ,��!������!���������������!�*��������������/,��������&����/���������!����������!���,���������'���*��������+������������*����������!��������������/����������.��������+���������

���� �� �*����� ����������*����������'����!���<1��������������������*����+������

B&7�7 ���������(������

����%��������(��������������H�&��������/���������������������������������+�����������(������������������*��+��&!������ ��� � ����� ������������%� ���� �'�� � ���������!����

���+��!��������� ����,����(�������*�� ����������� ����� �����������+���%��������������*�������!�����+�+�����/��(�������� +��+��� ���+���������� *�� '���!���� * � ����)�����������(��!������+��(�����������/��(��� �*�����������������������(���� ������*�������

���� ���������������++������������������/������++����!���%��������(���������������

B&7�< �����������������I���!������������

�������+���%���������!��/�'���!�������������������������+�+����/��(�������/��%�����!��������+�����������������������������*����������������������%�����/���������� �����!���������������������'�� � ����������!����

���+��!�������������,�������������+���������!�������������&+���%��������������+�+��*�����������*������(��������2��+&���� 0� �!� ������������ !��� ���� +��������� ��� ����(� �������+������������������+����������������*�����+��������������%������������������� �!��� ���!!�����������������,�����������!�������'������������*�������������

B&7�9 �����+���������I���!������������

������8����������+����������!�����+�+�����/��(������*�����������������+��������������������������+�����������������������%��"�!����������%��+��0&9�!�������������������������+���� �����'���!������������������*����������������&������%������'�� � ����������!����

B&7�0 )���������������'�� �����

����)���������������'�� �����������*��+��!������/��������� �����!�������������������'�� ����������� ����������!�����������������*��+��!������'����"���2��!�%����������!�/���3�2�4,��"���$��)��+�� �A����������!�������A�������������,!���������"��H���� ��+�������!�����������������.������������'�� �����,��!������������'�� ����������������+���,��������%���!������*��/��������*�����������������*���8�������!����+���!�'�� �����

8��+��� ���&��������(

���&����������(

�!� �������������������������,

������!�'�& ���������'��

Page 68: Orion Manual

���������������� ����� ����

������������� �������������������������������

����)����������+�� �������!&���������%,������������� ���&6�����%�����*�������!�������� �������������+���������� ���&.������ �� +�������� '������ ���+������� !��� ��)�������� !�������������������+��!�����%�����)���������������'�� ������!���&�����

�!��������!&���������%�!��������!������ ���������������������+���������!��������������������������������������������%�,������*�������������/����*��%���������

B&7�B 2�����)�������

����)���������+������������*��������������������� ,� �������������/��������!����/��%��������+&* &���+�+���������

-� "���'����������������������������������/��������&%��+��1&<�5�

5� �����������������!������/����/����%��E���������������*����+�������������������!���.��������������'���������,�������!��� ������������(/��������+�����!!��"�+�����/������+�����

7� ���/������%��������������������/������ �+����%��+���.����� ����+�����������*���%�����!��������������%�����������������+�������

<� "�����������������������������������������/��������&%��+��1&<�5�

B&7�1 2��������������

-� �+�������������* � �������%�����������-H1� ���������(&/����

5� "���'��������+�����������/�����'����!�����������%�

7� 2�������+����+����������/��������������%����+�������������������������%����������

<� "�!��������%����5&1��"������*���������+�����������������������������!��/�������������

Page 69: Orion Manual

�������� ���� �������������

������������� �������������������������������

��������$����������� ��� ����������%����� �� � ��

7'* �� ���3� ���

"�����%�����+��'��������+�����/�������+� �����%������������������������%�����+��+���������+���������!�����)�������*�!���������+���%���������'��������������

����!����/��%�+���%��+������������������������������� �����������! ��%�������+�����%�!���� ����+���������"��#�2��&!�%����������!�/����3�2�4��������*���������������%�����������

7'( � ���������3� ������ ��� ��0��J3��

����!����/��%������������%���/�������+�� ��������)��+�� A�������������2�?

L 2�>�����*��

L ���!��/�����*��

L ��>�����*��

L )������������*��

L �2����������*��

L >���%��������)��+�� �A����������*��

L 2������������������*��

������!�����������*������ ������������������������������*������������������������������!���������%�+��+��� ������!������������������ ��������* ��������������!�����!����/��%?

L ���������!�����+�/�����++�

L )���%���/����%�������������

L 2��+������!������

L F����%�����+��+��� �������������������)��������

L ���*����������������/��������+�+��%�� �����

F������!�����������������������������������(��/�,�����(������ ��!� ������ ��������� ���+���������*�!�����������%���������������(�� �!�+����*��,��*����� ��!����������*������ ����%����������'����(���+������������ ��!!��������� �����

1&5�- I���������+������

F��������*���������%,�����!������� ��!����*�������'���������%��'���������+��������������2���(�!���*����������'��&�������+������2���(�!���������������������

1&5�5 ��/���2���(�

�������������������������������"���$��� �����������&���'��%�������������+�/�����++� �'����%���*�!������������&*���%������ �����

7'4 ��3����0�� ��/

����)�������� �������������� ����������%� �����!� !����������A����� �����!����������*�����������* �����%������������)��&+�� �A����������2����!��� ��!�����)���������������������!����'�,�����������������������������������*����+�����,������ ��������*�����'������������!������"�!��������*����1&-���1&0�!�������*���������%���+��������!��������

ATTENTION

OBSERVE PRECAUTIONSFOR HANDLING

ELECTROSTATICSENSITIVEDEVICES

CAUTION!

B��� �������� ��;� ���!��� ��# ������ �!��!�"���%��!�$������������ !��"������#"���%��!!�� �"�1� ����"!� ��� �� ���#�;� !�"��� ����# ������#��1

��������������%������*����������* ��������%��������!����/&��%�%���������?

L ��/� ��������������'���������������������������!��������&+������������������%�,�����/������������%��� ������

L F������/���������+�/������������%���'�����������������%����%�������������������������%�����

L �'�����*6��������������������'����'�������������%���'�&������'��������%�����������!����

L �'������ ����������������/��������+�������������������

L �'���� +�����%� �������'�� ��'����� ����� +������� ��� '�� ����!�����

L A�����E�������������%��!��������'����'���������+��������������*������

Page 70: Orion Manual

���������������� ����� ����

������������� ������������������������������

��*���1&-������*���������%������

MODULE/DEVICE DETAILEDILLUSTRATION

FUNCTIONAL DESCRIPTIONPARAGRAPH

REPLACEMENTPROCEDURE

Detector head 8-1 2-3.1 8-4.2

Termination board 8-2 2-3.2 8-4.3

Fan module 8-4 2-3.3 8-4.4

Display Module 8-5 2-4 8-4.5 and 8-4.6

Intelligent Interface Module - 2.5 8.4.7

PEGAsys Addressable Loop Module 8-6 2-5 8-4.8

Self Contained Power Supply 8-7 2-6.1 8-4.9

Multi-Zone Power Supply 8-8 2-6.2 8-4.10

��*���1&5���������%���������!����A���������2��+�����2������������������

INTELLIGENT INTERFACE MODULE TO COMPUTER COMMUNICATION FAULTS

Symptom Corrective Action

No communicationbetween the IIM and thecomputer when using adirect IIM to computerconnection(Local IIM connection)

Ensure that the computer to IIM cable is plugged in to the port marked "PC" on the IIM.

Check the configuration of the OCS under the Setup/System Computer/Configuration menus. The serialport must be set to the same COM port as the communications cable is plugged in to. Connection typemust be set to "Local IIM".

Ensure that the IIM is powered and operating. Depress the hard reset on the IIM. It should momentarilyengage the trouble relay and extinguish all LEDs. The orange (lower) LED will come back on for about 1min while the IIM resets. If no action occurs, the IIM may be defective or not receiving power

Check the DB9 to RJ12 connector by separating the DB9 section from the plastic housing. The wireconfiguration must be as follows: White - Pin 2 Blue - Pin 3 Black - Pin 4 Yellow - Pin 5 Red - Pin 6 Green - Pin 8

No communicationbetween the IIM and thecomputer when using amodem and phone linesto connect to the IIM(Remote IIM Connection)

Check for proper operation of the IIM using a local IIM connection. If this fails, refer to local IIM troubleshootingsection above. If the local IIM connection functions correctly, check that the correct phone number is beingused and that the phone line is properly connected and operating.

Check the configuration of the OCS under the Setup/System Computer/Configuration menus. The serialport must be set to same COM port as the communications cable is plugged into. Connection type mustbe " Remote IIM".

Check that the characters "ATSO=1" appear in the initialisation string box of the configuration screen. Fora very few modems this string may require modification. Consult supplier if problems persist in this area.

If the previous three steps do not resolve the problem, the IIM may be defective.

Page 71: Orion Manual

�������� ���� �������������

������������� �������������������������������

��*���1&7����������� �����������

GENERAL SYSTEM FAULTS

Symptom Corrective Action

Low Suction Pressure

If the system is new, ensure that the actual piping system corresponds with the layout as calculatedby the "SNIFF" design software. Items such as pipe diameters, elbows, sampling hole diameterand junction configurations should be checked.

Check for proper operation of the fan module.

Check the screens located in the union, inside the detector head chamber and Elutriator.Clean if required.

Check for broken pipes, loose joints, leaky junction boxes, or missing pipe caps.

Check for blockages within the pipes. The blockage can be located by checking the suctionpressure at points closest to the detector head(s) and working outward. The suction pressure willdrop downstream from the blockage.

High Suction Pressure

If the system is new, ensure that the actual piping system corresponds with the layout as calculatedby the "SNIFF" design software. Items such as pipe lengths, pipe diameters, elbows, samplinghole diameters and junction configurations should be checked.

Check for blockages within the pipes and blockage of sampling ports. Pipe blockage can belocated by checking the suction pressures on the points closest to the detector head(s) and workingoutward. The suction pressures will be higher upstream of the blockage.

Long Transport Times Perform checks as outlined for low suction pressure.

Low Sensitivity to Smoke

Perform the sensitivity test by selecting the "sensitivity test" option from the OCS graphic display’soptions menu. OCS will either PASS or FAIL.

Perform checks as outlined for low suction pressure.

Detector configuration is not savedafter Detector is powered down

Ensure that the battery backup memory jumper is installed. (See Paragraph 4-2.10.1)

��*���1&<���������%���������!�������)��������2����������������*����

SYMPTOM CORRECTIVE ACTION

Loss of Communicationbetween IIM andProtected Zones

Check the LK1, LK2 and LK4 jumpers on the termination board. They may be shorting the two pins closestto the center of the board.

Check the RS485 loop wiring.

If using an IIM connected to an ARIES panel, be sure that the "Intelligent Interface Module" has been selectedfrom the "Topic" screen in the Configuration Software. Once "Intelligent Interface Module" is selected be sureto check off the "IIM Enable" box to ensure that the IIM is present in the configuration. If non-latching operationfor alarm inputs is desired, select the "Non-Latching" check box. Next review the termination board addressscreen. Here ensure that all termination board addresses existing on the RS-485 loop are enabled.

If using a stand-alone IIM, be sure that the LOCSs set to monitor each Detector correctly. From the Setupmenu select "Setup Detectors."The address of each Detector must be selected. Also, the Alarm and TroubleMonitoring box should be checked in the "Detector Window."

Check the programmed address of each termination board to ensure that it corresponds to the binaryequivalent of the address. Zero is not a valid address.

Page 72: Orion Manual

���������������� ����� ����

������������� ������������������������������

DISPLAY MODULE OR OCS GRAPHIC DISPLAY MESSAGE

INDICATION CORRECTIVE ACTION

Detector Trouble Detector Head Trouble Check connections at the termination board.

Clean the detector head.

If these two steps do not resolve the problem, return the detector to thesupplier.

Display Module (if installed)• COMM TR on Display Module• Sounder was on even though the Display Module is not configured for sound.• Date displayed was 00 JAN 2000 and time was 00:00. This does not change over time.• No other troubles are shown on the Display Module STATUS menu.

OCS can communicate with the terminationboard• Troubles shown: Detector, Airflow and Display• Time and Date are correct on the top of the Detector graphic.• Airflow is -50, but the fan is operating.

Detector Head Trouble Insure that the cable from the detector head to the termination board iscorrectly installed.

If the cable is correctly installed and the symptoms persist, return thedetector head to the supplier.

• Fan is not operating.

• Display Module has power but is displaying COMM trouble.

• Unable to communicate to the Detector via OCS, shows "device not found"

Termination Board PowerSupply Failure

Verify the DC input voltage to the termination board is within the specifiedrange of 18 to 30 Vdc at terminals 1 and 2 on TB1. Resolve probelm withsource if necessary.

Check the termination board fuse F2 and replace if necessary. It is locatedon the lower right corner of the board. Replace with Littlefuse® 1541AT.

If these two steps do not solve the problem, then the converter on thetermination board is not functioning. Return the termination board to thesupplier.

Full-Scale deflection for no apparent reason No specific event is loggedfor this fault

Check that no ambient light is penetrating the pipe and entering thedetection chamber. This can happen in brightly lit areas, especially whenwhite PVC is used as the sampling pipe.

Disconnect the sampling pipe and connect an absolute filter to theDetector. If the deflection goes to zero, there is particulate in the sampledarea. If not proceed.

Clean the detector head.

If these three steps do not resolve the problem, return the unit to thesupplier.

Airflow Trouble Low or High Airflow Level Check the real-time airflow level (see Chapter 4). Ensure that the airflowthresholds are set according to the manual.

Check for proper operation of the Fan Module.

Check for blockages or breaks in the sampling pipe network.

Check for rapid temperature fluctuations in the protected area. If found,widen the airflow thresholds.

Ensure that inlet cam is in the locked position.

Unregistered Display Module Trouble Unreg LCD Enable disply in OCS.

Power Supply Trouble PSU Trouble Measure the output voltage of the supply. It must be above 24 Vdc.

Check the power supply fault lights (only if powered by multi-zone powersupply, not the PEGAsys panel supply). Check the indicated circuit asdescribed in the four steps below.

Check the connections and continuity of the wires connected between thepower supply and the termination board.

Check that the AC voltage at the power supply input terminals is withinoperating range.

Check the battery wiring connections and continuity.

Check the batteries for low output voltage.

Check for ground fault problems throughout all associated system wiring.

Fails Sensitivity Test Detector Trouble Return Detector to supplier.

RX/TX Communication Problems PC Line Trouble Check RX/TX wiring connectors.

��*���1&9��������������������������)��+�� �A����������2�����+����)��+��

Page 73: Orion Manual

�������� ���� �������������

������������� �������������������������������

7'+ ��.�������

����!����/��%�+���%��+���������*����/������+�����'���������+���������������"���$��� �����

CAUTION!

������0�F���

������!������������"!�����������!;'���"����������������������'4�����!� !�"���������8���%��!�������1

1&<�5 "�+�����%�����)������������

�������'��������������������!��������)��������+���������!����/�?

-� "���'������)����������'������������*����������%��+�<&5�5�

5� )��������������0&������������������������%�����������������/�����!�&�������������!��������������������3��������������!�������������������%��������������*�����)��������������������������*�����4

7� "������������������������.������������������������(��+��������

<� "�����������!������������%����+�������������������������!�������������������

9� ��!�������������������������!�����)��������

WARNING!

�������:.��3��� ������

�A���A ��"!�����������'4�����!��!���;�!����!���;�#�;���"���8!��#���������"#���;1

1&<�- "�+�����%�����)�������

�����/�����+���������*���/�/������+�����%�����)���������'���

-� "���'��������+���������)��������!���������������������+��������������������������%����������������%�����&����

5� "���'������)����������'������������*����������%��+�<&5�5�

7� )��������������5<�I���+�/�����++� �!���������������������

<� )���������������8���������*���������������

9� )����������+�+��%����/��(�!�������+���������+����

0� )���������� +�+��%� !���� ���� �8������ +���� ���+���,� �!�����

B� ���(��!!�����!���������������������%�����/��

1� ����������)��������!��������+�+�����/��(�� �����

D� �������� ���� ��/�)�������� ��� ������*��� �������%��+�<&5�

SYMPTOM CORRECTIVE ACTION

No communication between theDetector and the computerrunning OCS.

Check the configuration of OCS under the Setup/System Computer/Configuration menus. The serialport must be set to the same COM port as the communications cable is plugged in to.

Check the DB9 to RJ-12 connector by separating the DB9 section from the plastic housing. The wireconfiguration must be as follows: White - Pin 2 Blue - Pin 3 Black - Pin 4 Yellow - Pin 5 Red - Pin 6 Green - Pin 8

��*���1&0��)�����������2��+�����2����������������*����

Detector Head

Termination Board

Inlet Cam

Connection toTermination Board

��%����1&-��"�+�����%�����)������������

Page 74: Orion Manual

���������������� ����� ����

������������� ������������������������������

������������������������������,��������!����/��%?

-� "���'��������+���������)�������������!�����������&�����������+������������������������������%���������������%���������

5� ������ ������������������ ���+������������+�������/�!���� ��������!������������������������(�������+�����/���������������%����+��

7� "������ ���� ������ �������� .������� ����� ��� ���� ���(��+��������

<� "�������������0&������������*��������������������

9� ������������)����������'������������*����������%��+�<&5�--�

1&<�7 "�+�����%����������������������

�!�������!�����������%����'��*��������%��,���'�����!�%���&�����������/���������������� ������!��������)������������%�2��*�!��������'��%�����������������*�����

�������'�� ���� ������������*����� !��������)��������+��&��������!����/�?

-� "���'������)����������'������������*����������%��+�<&5�5�

5� "���'������5<�I���+�/�����++� �������������������������

7� �!�����,�����'�����A��������

<� "���'������������!�����������������-,���5�������73�����8������������������4�

9� "���'������������!����"G&-5��2������������

0� "���'��������������������������������������

B� "���'��������������������!�����B���������������&�����������

1� "���'����������/������������������+���%�����������!����������������*�����

D� "�����������!������������%����+����������'�����������&�������*�����!��������)�����������������

�����������������������������*������������!����/��%?

-� "���'������������������*�����!���������������������&�+��������������������������%����������������%�����&����

5� ����������������������*��������+�������,��������%�����������+�������+�����* �����!������������%����+��

7� ������� ��������/� ��� ���� ��+���%����������������!� ���*�����������%�����

<� "�+�������������������������������-,���5�������73�����8������������������4�

9� "�+����������������������"G&-5��2������������

0� "�+�����������������������������������������

B� "�+���������������������������B�

1� �!�����,���+��������A��������

D� 2�����������5<�I���+�/�����++� ������������

��%����1&5�����������������������������F����%�)��%���

STATUS LEDFACE PLATE

DISPLAYMODULE

CABLE ASSEMBLYTERM BOARD/LCD DISPLAY

CABLE ASSEMBLYTERM

BOARD/LCD DISPLAY

CABLE ASSEMBLYRJ-12/RJ-12

(FRONT PANEL OPTIONSDISPLAY OR STATUS LED)

CABLE ASSEMBLYTERM BOARD/TRI-COLOR LED

PEGASYSADDRESSABLELOOP MODULE

(OPTIONAL)

CABLE SUPPLIEDWITH FAN

ASSEMBLY FAN

CHASSISGROUND

DETECTOR HEAD

RJ-12 SOCKETLOCATED ON LHS

OF UNIT

1

1

2

2

3

3

4

4

5

5

6

6

7

7

8

8

9

9

10

10

11

11

12

12

13

13

14

141516

TE

RM

INA

TIO

NB

OA

RD

LITTEFUSE1541AT

Page 75: Orion Manual

�������� ���� �������������

������������� �������������������������������

-:� �����������/��(�������������%�����)����/�����

����"�&<19����/��(���++������+� ���-5B����.�����&�������� ����� ���� ����� ��� ������! � ����� E���� �!� ����"���$��� ��������������/�����������������������&���������*����������*������!������������+���������!����������������������/��(������������������*��������&��������)����/�����!���������%��������/��(���������!�������)��������

--� �����������'������!�%�����������������/������������*���������%��2������������"���2��!�%����������!�&/����>���P��������3�H�:0&570:-5&<:-4�!���������������

-5� ������������)����������'������������*����������%��+�<&5�--�

ON TERMINATION BOARDPALM RECEPTICAL

TERMINATIONBOARD

CONNECTOR (P5)

TO CONNECTOR (P5)

��%����1&7��"�+�����%����������������������

1&<�< "�+�����%���������A�����

�������'������!����������+����������!����/�?

-� "���'������)����������'������������*����������%��+�<&5�5�

5� "���'������5<�I���+�/���!��������������������������

7� )����������+�+��%���������8������+�����!������

<� "���'��������������*��(��8������+����* �������%�������+�����/� �!��������!���������

9� �������������������*����,����������������!���������&����,��B,�����������!��������!������������������������&�����*�����

0� "������� ���� ������ ��������%����+��������� �������������%����!�����!����������������%�

B� ��!������!����������!��������)�������������!����������������'�����������+����������

1� "���'���������A������!����������������������+�������������������������%����������������%���������

D� �����+���������!�������������+� �+�������������+���&�������������������/����������������������%����+��

-:� "��������������������*��(��8������+����

--� "����������8������+�+��%�!����!������

-5� "�������������!��������������

-7� "�������������!����������������������*�������������&������������*���������

-<� ������������)����������'������������*����������%��+�<&5�--�

TERMINATIONBOARD

24 Vdc (P7)

��%����1&<��"�+�����%���������A�����

1&<�9 "�+�����%�����)��+�� �A�������������)�������2�'��

�����+���������)��+�� �A������/������� ��� ������������������'����!�����)��������+����������!����/�?

-� "���'������)����������'������������*����������%��+�<&5�5�

5� "���'������)��+�� �A������* �+�����%������/��������&��%����+�,��������������,�����+�����%�!�������������

7� "���'��������+���������)��+�� �A������!�����������&�������� ���+���� ���������� ������������%���������������%���������

<� ������������)��+�� �A���������������*����������%��+�<&9�

9� �������� ���������������'������������*��� �������%��+�<&5�5�

Page 76: Orion Manual

���������������� ����� ����

������������� ������������������������������

DISPLAY MODULE

DETECTOR COVER

RETAINING CLIPS (2)

��%����1&9��"�+�����%�����)��+�� �A�����

1&<�0 "�+�����%�����"������)��+�� �A�����

�����+���������"������)��+�� �A������+����������!����/�?

-� "���'����������/��������*�������!���������������)��&+�� �A������������+������������'���!��������*��(�*�8�

5� "���'������5<�I�����++� �!��������"������)��+�� ���������*���(�

7� )�������������� ��������%������������������������ !����������������*���(��

<� "���'��������+���������)��+�� �A������!�����������&�����������+�����������������������������%���������������%���������

9� "���'����������/��������*�������!�������/�)��+�� A�����,�������+������ ������'��� !���� ����*��(�*�8�)�������������/�*��(�*�8��!�������������*�8�������%�������������

0� ��������������/�)��+�� �A���������������*����������&%��+��<&9�5�

1&<�B "�+�����%������������%���������!����A�����

�����+����������������%���������!����A�����,�+����������!��&��/�?

1&<�B�- "�+�����%������������������������%��������!����A�����

-� "���'����������������!������-�����������������������&%���������!����A������3��A4�������/���������������5<�I��,"�&<19,���8����� �����*���������������

5� "���'���� �"G--������������!��������������6��(�,��!�����

7� "���'��������+��������� ��A�!������������������� ��&�+��������������������������%��������������������%��������

<� �������������A�/��������!�����������%�����/��

9� "����������� �"G--���������������������������-����&�����������F��������+�/�����������������������������������A,���������%��3��/��4��)�/���������������!����*�������������������%���A���������E����������������8���%�����

1&<�1 "�+�����%��������� ����������*������+A�����

�������A�������������������������������*��������!����� &�����������%�+��������������������* �!������������������/������������������%�+�����

�������'���������� ����������*������+�A������3���A4+����������!����/�?

-� "���'������)����������'������������*����������%��+�<&5�5�

5� "���'��!�����/����%�+��%�G-�!�����������A�*�����

7� "���'�� ���� !���� ����� ����� ������� �������A� ��� ����������%�+�����

<� 2���!��� ���+��%������������-<�!�������������������*�����������!���������A��!!�����!����+��������������!����)�������������!����+������������*����!�����+�����������������������������

�����������������+������������A�+����������!����/�?

-� "���'���������A�!��������+��(�%��%�

5� ���+������������������������������%����������������%��������

7� "���'������!����� �������������+�����

<� �������������A��'�������������������*������������)�&�����������%�������������%�����������������A�/�������!����� ����+�������� ���� ������������*���������+� ���+�+�����������������������A��������������������������������������������+�/��������� ����+����������,���������������+������������������������!��������A�������%���/�������������������<��������������������*�����

9� �������������A���/��!���� ��������!���������������������+�����+�������������%�������������%����������������A������-<&+�������������������������������!�������A�*��������������(���������������/�������������%����+�������<��������)��������������������*����������/��������������+��!�����!����+�����

0� �������!�����/����%�+��%������������������������������A*�����

B� ������������)����������'������������*����������%��+�<&5�5�

1� ��������+��+�����'�������+�������������%��2�������&����� �!��������)��+�� ��!������"��H���� ��2����������������%������%��������A������������������2�>���P��������

Page 77: Orion Manual

�������� ���� �������������

������������� �������������������������������

CONNECTOR (P4)

PALM

TERMINATIONBOARD

FIELD WIRINGCONNECTOR

��%����1&0��"�+�����%��������� ���������*������+�A�����

1&<�D "�+�����%��������!&2�����������/�����++�

�������'���������!&2�����������/�����++� �+���������!����/�?

CAUTION!

���!� !��������"������#���� ��!����"���1

-� )�����������2�+�/���!�����������!&2�����������/����++� �����������������*���(���*�8�

WARNING!

3����"���������!#�8����%���!����!�#�"���1������� "��#���� �����$� ��� !#�8� G��!;%��!����# ����� ������������%���!;� ����!�1����������������������������������� �����#�;� ��"�� �#��� ��� ="� #��� �!%���;���G"!;1

5� "���'��������������������/����������������!�������'���"���'��������'��������������������

7� )����������������������������%���*�������������/�����+&+� �A������

<� "���'�������/��+�/�����++� ����������������%�����/���������������!������������

9� "���'������+�/�����++� �* �������%����/�����

�����+������������!&2�����������/�����++� �+���������!����/�?

-� "���'��������+�����������/�����++� �A������!�������+��(�%��%�

5� ���+���� ��������� ���������� ������������%���������������%���������

7� F��������+�/�����++� �����������������*����������&%��+��<&0�

<� ������������/�����++� �A������������������!&2����������/�����++� �����������

9� ������� ���� ��%����� ���� �/�� +�/��� ��++� ��������%����/��

0� "�+�����������'����������+�/�����++� ������������/���������������������/�

COVER

BATT

+

BATT

-

+28V

0V+28V

0VFA

ULT

L

N/CE

N

ACOK FA

ULT

INTERCONNECTINGWIRING

POWER SUPPLYMODULE

��%����1&B��"�+�����%��������!&2�����������/�����++�

1&<�-: "�+�����%�����A����&C������/�����++�

-� "���'�H������!!��2�+�/�����������*����� �+�/���*�&!������+�����%�����A����&C������/�����++� �A������

5� "���'��*���������!������������������+�����*���������������!��+�����

7� "���'������������������!����������5�������7������&����*���(���"���'�������2�����������!����������������*���(����������������������*��(�+�����

<� "���'������!��������/��������%�����+�/�����++� ����&���� ��� ���� +�/��� ��++� � ���������� ���� ����'�� ���+�/�����++� ��������

9� "���'��������+���������+�/�����++� �!��������+��(&�%��%��������+������������������������������%�������������������%���������

0� ��������������/�+�/�����++� �����������������*���������%��+��<&B�<�

B� "�������������*�������������������������+���!��++����*���

1� �������������2�+�/���

Page 78: Orion Manual

����������������� ����� ����

������������� ������������������������������

MOUNTING HOLE

MOUNTING HOLE

MOUNTING HOLES

POWER SUPPLY ENCLOSURE

POWER SUPPLY MODULE

BATTERY STRAPS

CENTER LINK

POWER SUPPLYMOUNTING SCREWS

(12 VDC, 33 AMP HR.)BATTERY

(12 VDC, 33 AMP HR.)BATTERY

R19

C102

C101

R108

R42

BATT

OPR

Q15

D

R45

GND

FLT

DS3DS1

Q16

U2

C11 +

R49

C8

CR10

C B A

W2C2

R23

CR4

CR3

R11

Q4

Q3

R10

BATT

TBL

R8

DS2

U3

R13

R9

R21

Q2

R14

R1

2

R7

R35

R34

C5

CR9

R6

R5

0

Q6 Q7

Q1

R15

R22R107

C13U101

R46

Q9

CR1

02

C

U1

R4

+

CR14

R44R43

R40

R39

C10

CR13

R41

R38

R48

R3

1

R27

R3

2

R3

0

C12

R2

8R2

9 C3

Q8

R1

C9

CR12

R36Q13

Q11C4

Q1

4

R16

R37

CR11

Q1

2

R1

8

C1

CR1

C6C7

R26

+ R2

08

R2

07

C2

01

CR5

R25

R33

R5

R20

CR2

02

Q203

Q5

R3

R2

W1

B A

R24R17

C14

R5

1

Q1

0

BATT1

CR6

C104

TB3

CR1

9

(+)28VDC

TB1

R4

7

(-)

LOAD1

(+)(-)

RT4

CR2

CR16

C1

03

(-) (+)

R101

R104

R102R105

RV1

01

Q1

02

R103CR101

Q1

01

R1

06

R1

09

CR1

7

RT3

TB2

K1

CR18

RT1

(-)(+

) LOA

D2

(+)

K2

Q2

02

CR201

R202

R205

R203

Q103

C2

02

C203

U2

01

R2

06

R2

04

R201

C204

Q201

R2

09

RV201

RT2

CR8

N.C

.

N.O

.

W3

06-129857-001

CR7

CR1

5

(+)

(-)(-)

BATT2

CO

MTR

OU

BLEN

O/N

C

��%����1&1��"�+�����%�����A����&C������/�����++�

Page 79: Orion Manual

�������� ���� �������������

������������� �������������������������������

��������&���������

)'* �� ���3� ���

������*���*���/�+��'����������+�����������!��"��#�$�������*� �+����,���*�����*���������������������.��+������!�����"���$��� �����

��*���D&-������������

DETECTOR

Detector, 0.00075 to 0.3%/ft. (0.0025 to 1.0%/m) 77-297101-000

OPTIONAL DISPLAY

Display Module, English/Spanish/French 77-297102-000

Display Module, English/Spanish/Portuguese 77-297102-200

NETWORK OPTIONS

PEGAsys Addressable Loop Module, connects to a PEGAsys /ARIES SLC loop 77-297103-000

Stand-Alone/ARIES Compatible IIM without Modem in Red Enclosure 77-297114-001

Stand-Alone/ARIES Compatible IIM with Modem in Red Enclosure 77-297114-002

OPTIONAL SELF-CONTAINED POWER SUPPLY

Self-Contained 120/240 Vac Power Supply with Enclosure Only 77-297104-000

One 12 Vdc, 2.0 AH Battery Only 77-297105-000

OPTIONAL MULTI-ZONE POWER SUPPLY

Multi-Zone Power Supply/Battery Enclosure Only 77-297107-000

Multi-Zone 120/240 Vac Power Supply Module Only 77-297106-000

One 12 Vdc, 33 AH Battery Only 77-297108-000

MISCELLANEOUS INSTALLATION PARTS

Sampling Point Kit - Set of 25. Consists of (25) each: Sampling Point, Male 1/2-inch NPT Capillary Tube Adapter,Female 3/8-inch NPT Capillary Tube Adapter, Label for Sample Point

77-297109-000

Capillary Tube, 3/8-inch - 250 ft. Roll 77-297110-000

Sampling Point Label - Roll of 100 (for Extended Sampling Points) 77-297021-000

Sampling Port Label - Roll of 100 77-297022-000

Sampling Pipe Label - Roll of 100 77-297023-000

Elutriator (Inertial Separator) 77-297112-000

Flush Mount Trim Ring for Detector 77-297111-000

Battery Strap Kit for Seismic Zone 4 Installation (Multi-Zone Power Supply) 77-297113-000

RS-232 Programming Cable Assembly - 9 Pin Connector to RJ-12 74-100016-003

Magnehelic Pressure Gauge Kit, 0 to 1.0- inch H2O, with Carrying Case 77-297122-000

ORION XT Manual Doc, # 77.100 06-236005-401

ORION XT Check Sheet, Doc # 77.102 06-235516-402

ORION XT SNIFF Manual, Doc # 77.101 06-235984-401

OCS User’s Guide, Doc # 77.103 06-236012-401

SOFTWARE

"SNIFF" (Version 3.0) Design Program Software CD-ROM and User’s Guide 77-297121-000

OCS (Version 3.0) Software CD-ROM and User’s Guide 77-297120-000

Page 80: Orion Manual

���������������� ����� ����

������������� ������������������������������

��*���D&-�������������3�����4

DEMONSTRATION KIT

Complete ORION XT Demonstration Kit.Consists of: Detector, Hard-sided Case w/ Wheels, Stand, Sample Pipe Network, Power Supply, and ComputerInterface Cord (74-100016-003)

77-297123-000

SPARE PARTS

Spare Detector Head, Standard 06-129896-001

Spare Fan Assembly 06-129897-001

Spare Self-Contained Power Supply Module for 77-297104-000 06-129898-001

Spare Termination Board 06-129899-401

Extra Multi-Zone Power Supply Key 06-118013-001

Spare Cable, Detector Head to Termination Board 06-129995-001

Spare Cable, Display Module to Termination Board 06-129995-002

Spare Cable, Display Module to Termination Board 06-129995-003

Page 81: Orion Manual

���� ���� ���� �� ���� ��� ��!� ��� ���" �� �#�$� ��� � �##��������� �%����& �� ��� ��%� �����' ��%� �� ������ %���" ���� ��� #��% ��������������� ����������� ������������� ��������������� ��� �!"� ���� ��� �#���� �() �� ������������*

� ���

���� ������� ����������� �������������� �����

����� ��������������� �� �������� ������� !������������������

"��������� �� ���

� ����� ���#������ ����� ���� �� ������ ��������� ����������

$� �������� ��������� ����������� ��������%&'%(�)*'�

+������������� ������������ ���

��� �� � � �� �� ��� ������ � ��� ����������� ���� ���� �������� �� �� �� �� ��,'��-.*(��)*/0*1./0)*��&''/,�.,��'2103'4�

�5������� ��� ������� �� �

���� ������

����6����7��8 ���������

.���'%'09'4 :�� %/0)*�'%',,0/; %���30)30/; 4���)<<'*/,

������������������������� !��"�����

Page 82: Orion Manual

������������� ��������� ����������� ����������

�� ��� �!"� ���� ��� �#��

������������

� ��

� ��

Page 83: Orion Manual
Page 84: Orion Manual

06-236005-401 Rev. BA ©2006 Kidde-Fenwal, Inc. Printed in USA

����������������� ��������������������������� ���������������������������������� ������ ����� ����������� ������������������������������������������������������������������������������������ �������������������������������������������������������������������� �������������������� ���� ������� ��������������������������������������� ��������������������������������������������������� �������� ���� !!"#$"%&�'� %(��������� ��)������������

+����" ,--. ��� -#��/�� �� �%% �&������ ����#�$� �! +��������0�%" 1� '/21/3 ��� 456(��� �� ����#�$� �! +��������0�%" 1� '7�% � �� � �&������ ����#�$ �! 7�% � 1�������" 8'7'9����0� �� � �&������ ����#�$ �! :� ���!� ;�������� �� ��� ������ -����� ���<� ���� ������'1����%%-���%� �� �&������ ����#�$ �! -��%��& =� ���%�&���" 1� ' .8( 1����%%-���%� ;��������'