Natural Orange Oil CITRUS PEEL - Fairlane Services

Natural Orange Oil

CITRUS PEEL™

Aerosol Spotter

CERTIFIED®

Great for removing grease, printing inks, adhesive, crayon, gum, tar, oil, and decals

Nilodor, Inc. 10966 Industrial Parkway, N.W., Bolivar, OH 44612 • 800-443-4321 or fax 330-874-3366www.nilodor.com

Citrus Peel™, a blend of natural orange oil solvents, is a betterway of degreasing and spotting. It contains no petroleum distil-lates, no free alkalis. Citrus Peel™ cuts through grease and spotslike magic. There are no harmful or unpleasant fumes. CitrusPeel™ emulsifies in water and leaves no unwanted film.

14 oz. can 12/cs.C346-008

DIRECTIONS FOR USETest fabric in inconspicuous place for color fastness

before using.

Shake Well Before Using:

1. Spray onto spot or stain from 6-10 inches.2. Let Citrus Peel™ dwell on the spot for 2-3 minutes3. Blot with a clean white towel.4. Rinse area with clean water.

R.T.U.

PILE LIFTING - DRY EXTRACTION 1- Scope your facility to determine the carpet problem areas, then determine the lie of the carpet pile. The Pile Brush is a ready-to-use machine. Just plug into the outlet. The height of the handle can be freely adjusted to desired height.

2- Run the Pile Brush forward two to three steps and pull back over the same area. This is where the pile brush is most effective, lifting the pile and removing the deeply embedded soil. The Pile Brush action is complete on the back stroke, against the lay of the nap.

3- Adjust the pile brush handle to a 90° angle and place a wooden block behind the brush to keep from flattening out.

ROTARY SHAMPOO 1- Thoroughly vacuum the area to be cleaned. For optimum results, use a pile brush if available.

2- Remove spots and stains using the appropriate spotting chemical

3- Mix shampoo cleaning solution according to product label instructions

4- Use “pump up” sprayer or fill solution tank on the rotary machine

5- Pre-spray chemical ahead of rotary machine and scrub designated area until a layer of foam is generated. Work across the carpet in a slow, side to side motion. Move slowly backward, making sure to overlap the cleaned area. Be careful no to over wet the area.

6- Use air movers to speed up drying time

7- When dry, vacuum area thoroughly

EXTRACTION 1- Thoroughly vacuum the area to be cleaned. For optimum results, use a pile brush if available.

2- Remove spots and stains using the appropriate spotting chemical

3- Optional - If using a pre-spray; prepare the pre-spray chemical according to the mixing instructions on the product label. Using a “pump up” sprayer, spray the chemical on the carpet in 10’ x 10’ areas allowing for 10-15 minutes of dwell time. Do not allow the pre-spray chemical to dry. Use water only or a rinse agent in the solution tank when making cleaning passes.

4- Mix extraction cleaning solution according to product label instructions.

5- Extract the carpeting, moving in straight lines using overlapping passes. Be careful not to over wet the carpet. 6- To shorten drying times – make a second pass using vacuum only to extract as much moisture as possible. 7- Use air movers to speed up drying time


SPOTTING 1- Identify the spot or stain and which product to use. 2- Pretest fiber in an inconspicuous place for color fastness.

3- Sparingly apply water and blot.

4- Apply Spotter to the stain and tamp or agitate.

5- Repeat step 4 if necessary


800-443-4321 www.nilodor.com

CARPET CLEANING PROGRAMStructured By Nature

What will the Certified® Pile Brush do for me? • Improve indoor air quality throughout a facility.• Enhance performance of cleaning chemicals.• Help remove traffic pattern areas.• Restore breathability back into the carpet.• Break up and remove deeply embedded soil in your carpet.• Add life to your commercial or residential carpet.• Groom the nap.

What is missed by regular vacuuming?Certified’s Dirt-O-Meter shows you dry

soil recovered with the Pile Brush. This is embedded soil that is missed with regular vacuuming.

New Carpet pilebefore heavy traffic,dirt, moisture, etc:•Soft Pile

•Uniform

•Breathabilityin fiber

Carpet pile withheavy traffic, insuffi-cient maintenance,dirt, moisture, etc:•Crushed Pile

•Non-Uniform

•Pile without Breathability

Carpet pile restoredafter Pile Brush isused in a maintenance program:•Pile restored

•Uniform pile

•Recovered Breathability

•Improves Appearance

What are the experts saying?The 1998 Building Service Contractors Association InternationalCarpet Guide says “The pile brush type vacuum will remove deeply embed-ded soil, and open up a nap more than a regular, lightweight vacuum. Usually,a pile brush machine will be used weekly on traffic lanes, monthly on all of thecarpeted areas, and always just before any cleaning process. The pile brushvacuum is a dual-purpose machine because it is used both to maintain com-mercial carpet and to clean”.

Shaw Industries, one of the leading manufacturers of carpet, says,“Using a pile lifter in traffic lanes just prior to cleaning will remove the deeplyembedded soil and open up the pile so the hot water extraction can be moreeffective. After using a pile lifter, the final step...will be less difficult.”Additionally, Shaw’s recommendation for in-house maintenancespecifies “Use a pile lifter...in high traffic areas.” Shaw’s description of apile brush might as well be Certified’s pile brush, it is “...an upright two motor vacuum with a large, adjustable, gentle bristle brush with a motor, a high suction vacuum motor, and a sand trap.”

Above carpet pile photos are from a traffic pattern lane in the same area.

New Carpet

Traffic lane after 12 months(1 year)

The same Traffic lane after the Certified Pile Brush

Elevator

Kitchen

ReceptionA

rea

ConferenceR

oomWhere and when do I use the Pile Brush?

• Traffic lanes and heavy pivot areas in hallways and in front of reception areas.

• Entrances into buildings.

• Elevator areas.

When?• Always the first step

in restorative cleaning.

• Minimum of once a week. More frequently with heavy foot traffic and wear.

What will the Certified® Pile Brush do for me?• Improve indoor air quality throughout a

facility.

• Enhance performance of cleaning chemicals.

• Help remove traffic pattern areas.

• Restore breathability back into the carpet.

• Break up and remove deeply embedded soil in your carpet.

• Add life to your commercial or residential carpet.

• Groom the nap.

The one essential tool for proper carpet care, the Certified® Model “S” Pile Brush removes the deeply embedded dry particulate matter from the carpet while helping groom the nap, eliminate trafficpatterns and prolong the life of your carpetand rugs.

Why the Certified® Pile Brush Stands out!

• Dual motor system.

• One motor drives a 4.5 inch diameter vegetable

fiber or nylon brush.

• New, quieter motor drives vacuum.

• Improved Filtration.

• Self leveling base.

• Larger bag capacity.

• Sand trap for collecting larger particles, and allowing just fine dry particulate to pass through the vacuum motor into paper bag insert.

• Solid die cast aluminum construction.

*Shaded areas indicate pile brush usage.

Certified® has pioneered and developed the use of the pile

brush longer than any other machine manufacturer. Certified®

introduced the first two-motor horizontal Pile Brush unit ever

manufactured. It is the opinion of thousands of Certified® Pile

Brush users, that no cleaning job is complete or professionally

done unless prepared by pile brushing. Skillfully engineered

and ruggedly built, the Certified® Pile Brush is the industry’s

leader.

The Certified® Pile Brush works on both a sweeping and a vac-

uum action. The 4.5 inch brush gets down to the base of the

carpet fibers to break-up caked, embedded soils and dry par-

ticulate matter, which are swept by the brush into the sand

trap area. Once in the sand trap area, all of the heavy par-

ticles such as pebbles, paper clips, sand, and tacks rest in

the sand trap. The vacuum motor then pulls the smaller,

lighter particles into the vacuum bag. This process keeps

the larger particles from being pulled into the vacuum motor

and causing damage.

STEP

Scope your facility to determine the car-pet problem areas, then determine thelie of the carpet pile. The Pile Brush is aready-to-use machine. Just plug into theoutlet. The height of the handle can befreely adjusted to desired height.

STEP

Firmly grip the handle and hold in on thelever under the handle. The pile brushwill gently pull you with the machine. Tooperate most effectively, always start in acorner of the area to be pile brushed fac-ing the lay of the pile.

STEP

Run the Pile Brush forward two to threesteps and pull back over the same area.This is where the pile brush is most effec-tive, lifting the pile and removing thedeeply embedded soil. The Pile Brushaction is complete on the back stroke,against the lay of the nap. Adjust the pilebrush handle to a 90° angle and place awooden block behind the brush to keepfrom flattening out.

BRUSH: Certified® solid spiral brushhas gentle grooming action - doesnot break, cut or pull pile loop.Does not mat and is self-cleaning.Only Certified® permits reversing ofbrush for longer wear. Also available with tufted nylon brush.

Certified Dry Extraction Pile Lifter Specs:WEIGHT: 67 lbs.. (30.4 kilo)OVERALL WIDTH: 19.25” (48.90 cm)OVERALL DEPTH: 18” (45.72 cm)OVERALL HEIGHT: 43.25” (109.86 cm)BRUSH DRIVE MOTOR: 1/2 hp, 60Hz, 115 voltBRUSH LENGTH: 15” Self-Leveling (38.10 cm)BRUSH DIAMETER: 4.5” (10.16 cm)Choice of two brushes: Solid reversible Vegetable fill, Tufted nylonVACUUM MOTOR: 1/2 hp universal 115 voltBASE: Polished rugged aluminum castingCABLE: 50’ x 14.3 U.L. approvedSWITCH: Momentary contactGEARED DRIVE: No slippingOUTER BAG: Heavy C-Tex™ material

(Collection efficiency 97.25% @ 0.3 microns)SAND TRAP: Exclusive hinged sand trap on bottom to top loading refill

filter bag protect vacuum motor from metal, heavy objectsWHEELS: 4” heavy duty, non-markingFLOOR ROD: Heavy 1/4” (32 cm) wall tubing fully adjustableHANDLE: Extra wide 18” (45.72 cm)SWITCH LEVER: 5” (12.7 cm) plastic coated finger tip controlSHIPPING WEIGHT: 80 lbs.. (36.3 kilo)

PORTABLE: The Certified® Pile Brush can be wheeled up aflight of stairs.

MOTOR: Out in the open away from dust and grit meanslonger life.

OPERATION: Only the Certified ® Pile Brush is self-levelingand depth of brushing varies on the same rug conditionsand height of pile.

TRANSMISSION: Brush drive is positive and geared tomotor to insure continuous brush action even when pile ishigh or badly matted.

VACUUM SYSTEM: Certified’s exclusive sand trap preventsbobby pins, paper clips, carpet tacks or other metallicobjects from ruining vacuum fan blades. Only lint and dustreach the blades and refill bag.

Certified Pile Brush Is As Easy As

1 • 2 • 3

3

10966 Industrial Parkway, Bolivar, Ohio 44612

800-443-4321 or fax 330-874-3366 www.nilodor.comMade In America

Every Pile Brush is personally hand crafted in the United States.

2

1

Facts & Specs

Why Encapsulation?Detergents are a necessary element in carpet cleaning products to help loosen dirt from carpet fibers. Unfortunately, detergents can be sticky and may leave a residue if not completely removed from the carpet fibers. This residue will accumulate with each cleaning and leads to problem resoiling, especially in traffic lanes and other heavily used areas. Certified's Encapsulation polymer technology is a safe alternative to traditional detergent based cleaners. Encapsulation polymers are added to the carpet cleaning solution. These encapsulation polymers suspend the detergent and soil at the top of the carpet fibers, drying into a light, non-sticky crystalline which can be easily removed by normal vacuuming.

• Leaves no harmful residue• No rinsing required (Except Pre-Spray)

• Prevents soil wicking• Eliminates rapid resoiling• Carpets stay cleaner longer

Nilodor, Inc. 10966 Industrial Parkway, Bolivar, OH 44612 USA 800-443-4321 or www.nilodor.com

Safe for Nature and You

Environmentally Responsible Encapsulation Carpet Cleaners

EXTRACTION Cleaner•Effective in truckmountand portables

Dilute: 2 oz. - 1 gal.Diluted for use pH 8.5-9

Gallon 4/cs 128SBN EXT

PRE-SPRAY•Breaks down tough grease and dirt.

Dilute: 8 oz. - 1 gal.Diluted for use pH 8.5-9

Gallon 4/cs. 128SBN SPT

SHAMPOO/BONNET•For all Foam, Bonnet and low moisture machines.

Dilute: 16 oz. - 1 gal.Diluted for use pH 8-8.5

Gallon 4/cs. 128SBN SHP

All-Purpose SPOTTER•Ideal, all-purpose spotter.

Dilute: Ready-To-UseDiluted for use pH 9-9.5

Quart 12/cs. 32SBN RTUSP

Why Green?As a leader in odor control and carpet care, Nilodor has taken an active role in manufacturing and promoting environmentally responsible cleaning products. There are many advantages to using our Structured By Nature™ products, some off which are:

• Improve indoor air quality• Biodegradable• Non-Toxic / Non-Caustic• Improved worker health and safety• Low VOC’s• Meets Environmental standardsNilodor will continue to do it’s part to insure a safe and healthy environment for our generation and those to follow.

Formulated in Partnership with the Design for the Environment Program

DIRECTIONS:1. Shake well before using.

2. Test fabric in inconspicuous place for color fastness before using.

3. Dilute 8 oz. (237 mL) of Pre-Spray to 1 gallon (3.78 L) of water.

4. Spray solution on carpet to be cleaned.

5. For best results, agitate with a carpet rake.

6. Allow 5-10 minutes of dwell time, DO NOT allow pre-spray to dry before extracting.

7. Clean in the usual manner.

8. Vacuum thoroughly when dry.NOTE: Freezing will not affect cleaning power. Thaw, shake well and use.

Nilodor, Inc.10966 Industrial Parkway, N.W. P.O. Box 660Bolivar, OH 44612-0660 U.S.A.1-800-443-4321 or (330) 874-1017FAX (330) 874-3366www.nilodor.com

Gallons - 128SBN SPT / 4 per caseDilutes 8 oz. / 1 GallonDiluted pH - 8.5-9

Formulated in Partnership with the Design for the Environment ProgramApproved for all carpets by The Carpet And Rug Institute

Why Encapsulation?• Leaves no harmful residue• No rinsing required• Prevents soil wicking• Eliminates rapid re-soiling• Carpets stay cleaner longer

Environmentally Responsible

Encapsulating Pre-Spray Treatment

Why Green• Improve indoor air quality • Biodegradable• Non-Toxic / Non-Caustic • Improved worker health and safety• Low VOC’s • Meets Environmental standardsNilodor will continue to do it’s part to insure a safe and healthy environment for our generation and those to follow.

A perfect pre-spray for heavily soiled traffic areas. Breaks down tough grease and dirt. For high powered cleaning, use in conjunction with Certified's Extraction Cleaner.

A fast acting, quick drying bonnet/spin cleaner which incorporates Certified's Encapsulating technology to bind the soil, which is then removed through daily vacuuming. Leaves no harmful residue.


Gallons - 128SBN SHP / 4 per caseDilutes 8 oz. / 1 GallonDiluted pH - 8-8.5




Encapsulating Shampoo / Bonnet


DIRECTIONS:1. Shake well before using.2. Test fabric in inconspicuous place for color fastness before using. 3. Prepare carpet for shampooing in normal manner with vacuum or Certified® Pile Brush.4. Dilute 16 oz. (473 mL) of Shampoo to every 1 gallon (3.78 L) of water.5. Rotary Brush - Spray solution to carpet surface and agitate with rotary brush.6. Bonnet Cleaning - Bonnet may be either saturated with diluted solution or solution may be sprayed as a mist, ahead of machine.7. Use furniture protectors under legs if furniture must be replaced before carpet is dry.8. Vacuum thoroughly when dry.

UPHOLSTERY CLEANING:1. Vacuum furniture thoroughly.2. Dilute 16 oz. (473 mL) of Shampoo to every 1 gallon (3.78 L) of water.3. Clean in normal manner with brush or sponge.4. Wipe any excess foam from legs or other un-upholstered areas.5. Finish all nap type coverings with soft brush combing in one direction.6. Vacuum thoroughly when dry.

NOTE: Freezing will not affect cleaning power. Thaw, shake well and use.

A concentrated cleaner that can be used with any type of carpet extraction equipment. This encapsulation formula provides one pass cleaning and eliminates the need for rins-ing. This Extraction Cleaner is compatible with high heat equipment, leaves no sticky residue, and will eliminate rapid re-soiling.


Gallons - 128SBN EXT / 4 per caseDilutes 2 oz. / 1 GallonDiluted pH - 8.5-9



DIRECTIONS:1. Shake well before using.

2. Test fabric in inconspicuous place for color fastness before using.

3. Prepare carpet for extraction in a normal manner with vacuum or Certified® Pile Brush.

4. For Truck Mount - Add 1 quart (liter) of Extraction to 5 gallons (18.9 L)

of water in the concentrate tank.

5. For Portable Equipment - Add 2 oz. (30 mL) of Structured By Nature™ Extraction to every 1 gallon (3.78 L) of water. When using as a Pre-Spray, dilute 2 oz. (60 mL) to every 1 gallon (3.78 L) of water.

6. Vacuum thoroughly when dry.NOTE: Freezing will not affect cleaning power. Thaw, shake well and use.


Encapsulating Extraction Cleaner



Quarts - 32SBN RTUSP / 12 per caseReady-To-UseDiluted pH - 9-9.5



Encapsulating Carpet Spotter


DIRECTIONS:1. Test fabric in inconspicuous place for color fastness before using.2. Wet with plain water.3. Liberally apply Spotter to affected area.4. Work chemical into carpet pile and blot with a clean white towel.5. Rinse with clean water 6. Repeat if necessary.7. Vacuum when completely dry.NOTE: Freezing will not affect cleaning power. Thaw, shake well and use.

Why Encapsulation?Detergents are a necessary element in carpet cleaning.Unfortunately, detergents can be sticky and may leave a residue if not completely removed from the carpet fibers. This residue will accumulate and lead to problem re-soiling, especially in traffic lanes and other heavily used areas.Certified's Encapsulation polymer technology is a safe alternative to traditional detergent-based cleaners. These encapsulation polymers suspend the soil at the top of the carpet fibers, drying into a light, non-sticky crystalline which can be easily removed by normal vacuuming.

ISSA Cleaning Task

Number EquipmentMinutes

Per 1,000 Sq. Ft Sq. Ft. / Hr.

* (330) Champ 3529 Ride-On Scrubber 1.23 49,587327 Champ 2929 Ride-On Scrubber 1.5 40,000

*(322) Wrangler 3330 Auto Scrubber 1.82 32,872320 Wrangler 2730 Auto Scrubber 2.22 27,027320 Wrangler 26 Auto Scrubber 2.3 25,999314 Wrangler 2016 Auto Scrubber, Wheel-driven 3.0 20,000

* (310) Wrangler 2016 Auto Scrubber, Pad Assit 4.0 14,960* (310) Wrangler 2008 Auto Scrubber 4.0 14,960

308 Wrangler 1708 Auto Scrubber 4.71 12,739

288 Charger 2717 DB Burnisher 1.85 32,432286 Charger 2025 DB Burnisher 2.50 24,000285 Charger 2025 AB Burnisher 3.69 16,260

Charger 2022 DB Burnisher 2.50 24,000Charger 2022 AB Burnisher 3.69 16,260

284 Charger 2500 4.80 12,500272 Charger 1500 6.60 9,091272 Mustang 1500 6.60 9,091267 Thoroughbred 30 2,000269 Maverick 300 19.80 3,030269 Mustang 300 DS 19.8 3,030267 Mustang 300 DS, 175 RPM 30 2,000 267 Galaxy 30 2,000

373 Manta 36 Sweeper 54 secs. 66,731* (373) Sidewinder BP 30 Sweeper 3.18 16,544* (370) Sidewinder 27 MB 2 30,140

NSS Production Rates

ISSA Cleaning Task

Number EquipmentMinutes

Per 1,000 Sq. Ft Sq. Ft. / Hr.

NSS Production Rates

Pacer PB 2.00 30,000217 Pacer 30 Carpet Vacuum 3.16 19,000221 Outlaw B/V Vacuum 8.10 7,407

* (204) Pacer 115 UE Vacuum 14.03 4,275204 Pacer 112 UE Vacuum 17.49 3,430211 Pacer 218 UE Vacuum 11.69 5,130207 Pacer 214 UE Vacuum 15.00 4,000227 Model M-1 Vacuum 9.10 6,593

187 Pony 20 SCA Extractor 14.31 4,193184 Stallion 8SC Extractor 35.00 1,714184 Stallion 12SC Extractor 35.00 1,714177 Predator CXH 100 Extractor 120.00 500177 Predator CXC 100 Extractor 120.00 500177 Predator CXH 150 Extractor 120.00 500177 Predator CXC 150 Extractor 120.00 500177 Predator CX300 HP Extractor 120.00 500

Task Number Referenced From The Official ISSA 447 Cleaning Times 2003

* Rates Based On ISSA 447 Task Standard Number

Natural Orange Oil CITRUS PEEL - Fairlane Services

Documents

Transcript of Natural Orange Oil CITRUS PEEL - Fairlane Services