Multi Point Vehicle Inspection Form
Click here to load reader
Transcript of Multi Point Vehicle Inspection Form
1A 1B 1C 1D8010202447
Fuel system (also including gas cap seating)
Engine, transmission, drive axle, transfer case
Engine cooling system: leak/other
Shocks and struts - also check operation
Belts: engine, power steering and/or V-drive
Hoses: engine, power steering and HVAC
Engine air fi lter
Passenger Compartment Air Filter
Steering components and steering linkage
CV drive axle boots or driveshafts and U-joints
Exhaust system components
Body components lubrication
MULTI-POINTVEHICLE INSPECTION
Checked and OK May Require Attention Soon Requires Immediate Attention
CHECK TIRES AND TREAD DEPTH
CHECK FLUID LEVELS
CHANGE ENGINE OIL & FILTER N/A CHECK BRAKES/MEASURE FRONT AND REAR LININGS
REQUIRES ATTENTIONOK FILLEDEngine oil
Brake fl uid reservoir
Transmission (if equipped w/dipstick)
Coolant recovery reservoir
Power steering
Windshield washer
ADDITIONAL CHECKS (Inspect for visible leaks and visual condition)
WIPER BLADES
Cracks______ Chips______
Rear (if applicable)
Windshield condition
LF
RF
Rotation performed
Rotation needed
Alignment performed
Alignment needed
Balance performed
Balance needed
1)
2)
3)
Service Consultant:
Technician: No.:
Additional Recommended Services
GM-FM-0280-08 ©2007, Copyright; all rights reserved. 11/29/10CUSTOMER COPY
CHECK BATTERY
Battery health
Battery cablesand connections
OnStar active
Enrolled in OVD
Enrolled in DMN
Air Conditioning Performance
Remaining engine oil life:_________%Reset:______ N/A:_____
Service History Check
Restraint system component check
Chassis components lubrication
Drive Axle (leak/other)
Evaporative control system
Brake system (also including lines, hoses and parking brake)
(Check body condition)
(Check lamps)
Lowest Tread Depth:_____/32
LF RF
LR RRPSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
LR
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
RF
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
LF
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
RRLF LR
ACTUAL
LF LR
ACTUAL
Lowest Front Lining ______________ Lowest Rear Lining ______________
LF RF RRLR
7 mm greater
6 mm
5 mm
4 mm
3 mm/less
2 mm/less
1 mm/less
LF RF
ACTUAL
LR RR
ACTUAL
Name:_________________________________ Year/Model:____________________ Date:______________________________
Repair Order #:____________ VIN (last 8 digits):_____________ Odometer:___________ Tag#:_____ License#:________________
Wear PatternDamage
B1A8010202447
—— VEHICLE OWNER CHECKLIST ——
AT EACH FUEL STOP
ONCE A MONTH
Engine oil level check
Engine coolant level check
Windshield washer fluid level check
ONCE A YEAR
Tire inflation check
Tire wear inspection
Refer to your vehicle owner’s manual for additional required services. Visit your
GM Goodwrench Dealer’s Service Department to assist you with these
maintenance needs.
2A8010202447
Fuel system (also including gas cap seating)
Engine, transmission, drive axle, transfer case
Engine cooling system: leak/other
Shocks and struts - also check operation
Belts: engine, power steering and/or V-drive
Hoses: engine, power steering and HVAC
Engine air fi lter
Passenger Compartment Air Filter
Steering components and steering linkage
CV drive axle boots or driveshafts and U-joints
Exhaust system components
Body components lubrication
MULTI-POINTVEHICLE INSPECTION
Checked and OK May Require Attention Soon Requires Immediate Attention
CHECK TIRES AND TREAD DEPTH
CHECK FLUID LEVELS
CHANGE ENGINE OIL & FILTER N/A CHECK BRAKES/MEASURE FRONT AND REAR LININGS
REQUIRES ATTENTIONOK FILLEDEngine oil
Brake fl uid reservoir
Transmission (if equipped w/dipstick)
Coolant recovery reservoir
Power steering
Windshield washer
ADDITIONAL CHECKS (Inspect for visible leaks and visual condition)
WIPER BLADES
Cracks______ Chips______
Rear (if applicable)
Windshield condition
LF
RF
Rotation performed
Rotation needed
Alignment performed
Alignment needed
Balance performed
Balance needed
1)
2)
3)
Service Consultant:
Technician: No.:
Additional Recommended Services
GM-FM-0280-08 ©2007, Copyright; all rights reserved. 11/29/10
CHECK BATTERY
Battery health
Battery cablesand connections
OnStar active
Enrolled in OVD
Enrolled in DMN
Air Conditioning Performance
Remaining engine oil life:_________%Reset:______ N/A:_____
Service History Check
Restraint system component check
Chassis components lubrication
Drive Axle (leak/other)
Evaporative control system
Brake system (also including lines, hoses and parking brake)
(Check body condition)
(Check lamps)
Lowest Tread Depth:_____/32
LF RF
LR RRPSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
LR
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
RF
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
LF
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
RRLF LR
ACTUAL
LF LR
ACTUAL
Lowest Front Lining ______________ Lowest Rear Lining ______________
LF RF RRLR
7 mm greater
6 mm
5 mm
4 mm
3 mm/less
2 mm/less
1 mm/less
LF RF
ACTUAL
LR RR
ACTUAL
Name:_________________________________ Year/Model:____________________ Date:______________________________
Repair Order #:____________ VIN (last 8 digits):_____________ Odometer:___________ Tag#:_____ License#:________________
Wear PatternDamage
XOLSG XOLSY
XACRXACY
XWIPY
XWIPY XWIPR
XWIPR
XWNDY XWNDR
XROTR XALGN XBALRXBATY XBATR
XCABY XCABR
XFULY XFULR
XTRAY XTRAR
XSHKY XSHKR
XBELY XBELR
XHOSY XHOSR
XAFY XAFR
XCFY XCFR
XENGY XENGR
XSTRY XSTRR
XCVJY XCVJR
XEXHY XEXHR
XBODY XBODR
XRESY
XCHSY
XEVPY
XRESR
XCHSR
XAXLR
XEVPY
XAXLY
XEVPR
BK7
BK6
BK5
BK4
BK3
BK2
BK1
BK7
BK6
BK5
BK4
BK3
BK2
BK1
BK7
BK6
BK5
BK4
BK3
BK2
BK1
BK7
BK6
BK5
BK4
BK3
BK2
BK1
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
Recommended FRH:
Total FRH Sold:
FRH
XBRKRXBRKY
XOLSR
CUSTOMER FILE COPY
B2A
Category Yellow Red
Wiper XWIPY XWIPR
Windshield XWNDY XWNDR
Air Conditioning XACY XACR
Rotation XROTR
Alignment XALGN
Tire Balance XBALR
Battery XBATY XBATR
Battery Cable XCABY XCABR
Fuel System XFULY XFULR
Engine (Leak, Other) XENGY XENGR
Transmission/Transfer Case (Leak, Other) XTRAY XTRAR
Drive Axle (Leak, Other) XAXLY XAXLR
Shock/Strut XSHKY XSHKR
Belts XBELY XBELR
Hoses XHOSY XHOSR
Engine Air Filter XAFY XAFR
Cabin Air Filter XCFY XCFR
Steering/Suspension XSTRY XSTRR
CV Joint, Driveshaft, U-Joint XCVJY XCVJR
Exhaust System XEXHY XEXHR
Body Components Lubrication XBODY XBODR
Restraint System XRESY XRESR
Chassis Components Lubrication XCHSY XCHSR
Evaporative control system XEVPY XEVPR
Current Recommend Labor Operations
Tires (Tread Depth) Tire 8 thru Tire3
Brake (Lining Measurement) BK7 thru BK1
8010202447
3A8010202447
Fuel system (also including gas cap seating)
Engine, transmission, drive axle, transfer case
Engine cooling system: leak/other
Shocks and struts - also check operation
Belts: engine, power steering and/or V-drive
Hoses: engine, power steering and HVAC
Engine air fi lter
Passenger Compartment Air Filter
Steering components and steering linkage
CV drive axle boots or driveshafts and U-joints
Exhaust system components
Body components lubrication
MULTI-POINTVEHICLE INSPECTION
Checked and OK May Require Attention Soon Requires Immediate Attention
CHECK TIRES AND TREAD DEPTH
CHECK FLUID LEVELS
CHANGE ENGINE OIL & FILTER N/A CHECK BRAKES/MEASURE FRONT AND REAR LININGS
REQUIRES ATTENTIONOK FILLEDEngine oil
Brake fl uid reservoir
Transmission (if equipped w/dipstick)
Coolant recovery reservoir
Power steering
Windshield washer
ADDITIONAL CHECKS (Inspect for visible leaks and visual condition)
WIPER BLADES
Cracks______ Chips______
Rear (if applicable)
Windshield condition
LF
RF
Rotation performed
Rotation needed
Alignment performed
Alignment needed
Balance performed
Balance needed
1)
2)
3)
Service Consultant:
Technician: No.:
Additional Recommended Services
GM-FM-0280-08 ©2007, Copyright; all rights reserved. 11/29/10
CHECK BATTERY
Battery health
Battery cablesand connections
OnStar active
Enrolled in OVD
Enrolled in DMN
Air Conditioning Performance
Remaining engine oil life:_________%Reset:______ N/A:_____
Service History Check
Restraint system component check
Chassis components lubrication
Drive Axle (leak/other)
Evaporative control system
Brake system (also including lines, hoses and parking brake)
(Check body condition)
(Check lamps)
Lowest Tread Depth:_____/32
LF RF
LR RRPSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
LR
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
RF
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
LF
PSI@:_____ set to:_____ PSI
8/32 or Greater
7/32
6/32
5/32
4/32
3/32 or Less
RRLF LR
ACTUAL
LF LR
ACTUAL
Lowest Front Lining ______________ Lowest Rear Lining ______________
LF RF RRLR
7 mm greater
6 mm
5 mm
4 mm
3 mm/less
2 mm/less
1 mm/less
LF RF
ACTUAL
LR RR
ACTUAL
Name:_________________________________ Year/Model:____________________ Date:______________________________
Repair Order #:____________ VIN (last 8 digits):_____________ Odometer:___________ Tag#:_____ License#:________________
Wear PatternDamage
XOLSG XOLSY
XACRXACY
XWIPY
XWIPY XWIPR
XWIPR
XWNDY XWNDR
XROTR XALGN XBALRXBATY XBATR
XCABY XCABR
XFULY XFULR
XTRAY XTRAR
XSHKY XSHKR
XBELY XBELR
XHOSY XHOSR
XAFY XAFR
XCFY XCFR
XENGY XENGR
XSTRY XSTRR
XCVJY XCVJR
XEXHY XEXHR
XBODY XBODR
XRESY
XCHSY
XEVPY
XRESR
XCHSR
XAXLR
XEVPY
XAXLY
XEVPR
BK7
BK6
BK5
BK4
BK3
BK2
BK1
BK7
BK6
BK5
BK4
BK3
BK2
BK1
BK7
BK6
BK5
BK4
BK3
BK2
BK1
BK7
BK6
BK5
BK4
BK3
BK2
BK1
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
TIRE8
TIRE7
TIRE6
TIRE5
TIRE4
TIRE3
Recommended FRH:
Total FRH Sold:
FRH
XBRKRXBRKY
XOLSR
SERVICE CONSULTANT COPY