Microturbine ppt
-
Upload
rahul-kumar-prasad -
Category
Engineering
-
view
403 -
download
12
Transcript of Microturbine ppt
![Page 1: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/1.jpg)
1
![Page 2: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/2.jpg)
2
MICROTURBINE
PRESENTED BY-RAHUL KUMAR PRASADMECHANICAL, ME-1, GRP-1REDG. NO. : 1201219418
![Page 3: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/3.jpg)
3Introduction Micro Turbines are new type of
combustion turbine used for energy generation.
They provide not only electricity , but also the thermal energy for heating needs.
they typically have power outputs in the range of 25 to 300kW.
![Page 4: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/4.jpg)
4 Need of Micro turbines
Demand of alternate energy sources Need of energy in Remote locations Need of compact & portable power generator better efficiency and require infrequent
maintenance. Need of clean energy generating device
![Page 5: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/5.jpg)
5
Micro Turbine producing power, as well as heat
![Page 6: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/6.jpg)
6Components of Microturbine
CompressorCombustorGeneratorRecuperator (Heat Exchanger)Turbine Power Electronics (Rectifier & Inverter)
![Page 7: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/7.jpg)
7Combined Heat & Power (CHP) Diagram
![Page 8: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/8.jpg)
8Working Principle Micro turbines are small gas turbines, most of which feature an
internal heat exchanger called a recuperator. In a micro turbine, a radial flow (centrifugal) compressor
compresses the inlet air that is then preheated in the recuperator using heat from the turbine exhaust.
Next, the heated air from the recuperator mixes with fuel in the combustor and hot combustion gas expands through the expansion and power turbines. The expansion turbine turns the compressor and, in single-shaft models, turns the generator as well.
Finally, the recuperator uses the exhaust of the power turbine to preheat the air from the compressor.
Single-shaft models generally operate at speeds over 60,000 revolutions per minute (rpm) and the permanent magnet generator generates electrical power of high frequency, and of variable frequency (alternating current --AC). This power is rectified to direct current (DC) and then inverted to 50/60 Hz for commercial use.
![Page 9: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/9.jpg)
9Types of MicroturbineUnrecuperated Microturbine
Recuperated Microturbine
![Page 10: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/10.jpg)
10ComparisonUnrecuperated
Compressed air is mixed with fuel and burned under constant pressure conditions.
Efficiency 15%.
Recuperated A sheet metal heat
exchanger (recuperator) recovers temperature of the air stream supplied to the combustor.
Efficiency 20~30%.
![Page 11: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/11.jpg)
11Micro turbine Overview Commercially Available Yes (Limited)
Size Range 25-500 kW
Fuel Natural gas, hydrogen, propane, diesel
Efficiency 20-30% (Recuperated)
Environmental Low (<9-50 ppm) Nox
Other Features Cogeneration (50-80°C water)
Commercial Status Small volume production, commercial prototypes now.
)
![Page 12: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/12.jpg)
12Advantages of Microturbine
Small number of moving parts Compact size Lightweight Good efficiency in cogeneration Low emission Long maintenance interval less vibration Less noise than reciprocating engines
![Page 13: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/13.jpg)
13Application of Microturbine
Cogeneration Small scale power generation
In Automobiles (turbocharger)
Auxiliary power unit for air planes
![Page 14: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/14.jpg)
14Microturbine Manufacturers
Bowman power systemsCapstone Turbine CooperationElliott energy systemsTurbec AB Ingersoll-Rand Company
![Page 15: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/15.jpg)
15
![Page 16: Microturbine ppt](https://reader033.fdocuments.us/reader033/viewer/2022061504/58788b421a28ab375f8b4c37/html5/thumbnails/16.jpg)
16
THANK YOU