Maintenance - Mercedes-Benz of Cary

MaintenanceBooklet

SH USA 197 Edition A 2011; 1; 4, en-USd2sboike Version: 3.0.2.13

2010-03-18T07:21:53+01:00 - Seite 1

Welcome to the world of Mercedes-BenzWe want you to enjoy your Mercedes-Benzautomobile. Vehicle safety and operationalreliability are two very important factors. Tomaintain them, regular maintenance servicesare necessary.We continuously strive to improve ourproduct and ask for your understanding thatwe reserve the right to make changes in theperiodic maintenance work for our vehicles.The information in this manual is accurate asof the press date. At the time of yourscheduled maintenance appointments withyour authorized Mercedes-Benz Center, themost current maintenance work informationwill be utilized for your vehicle’s age ormileage. Please check with your authorizedMercedes-Benz Center for any changes to theperiodic maintenance work required for yourvehicle.

PLEASE NOTE

WE STRONGLY RECOMMEND THAT YOUHAVE YOUR VEHICLE SERVICED BY YOURAUTHORIZED MERCEDES-BENZ CENTERWHO IS FULLY EQUIPPED TO PROVIDE THISSERVICE AND THAT GENUINE MERCEDES-BENZ PARTS BE USED.SERVICE, REPLACEMENT, OR REPAIR OF THEEMISSION CONTROL DEVICES ANDSYSTEMS CAN BE PERFORMED BY ANYAUTOMOTIVE REPAIR ESTABLISHMENT ORINDIVIDUAL USING CERTIFIED PARTS.THE USE OF DEFECTIVE OR NON-EQUIVALENT PARTS MAY RESULT IN YOUREMISSION PERFORMANCE WARRANTYCLAIM BEING DENIED.

Symbols

The following symbols are found in thisbooklet:

G Warning!Warning notices draw your attention tohazards that may endanger your health or life,or the health or life of others.

! Highlights hazards that may result indamage to your vehicle.

i Helpful hints or further information youmay find useful.

Y page This symbol tells you where to lookfor further information on a topic.

YY This continuation symbol marks awarning or procedure which iscontinued on the next page.


2010-03-18T07:21:53+01:00 - Seite 2

General information .............................. 3Vehicle data ............................................. 3Protection of the environment ................. 3

Maintenance Booklet ............................ 5Introduction ............................................. 5

Mercedes-Benz Maintenance System 5Required and RecommendedService Work ...................................... 5Tire rotation ....................................... 5Severe operating conditions .............. 6Wear items ......................................... 6Tested and approved engine oilsand oil filters ...................................... 6Regular checks .................................. 7Notes on the warranty ....................... 7Service records .................................. 8Parts/operating materials ................. 8

Emission System Maintenance ................ 8Gasoline engine ................................. 8Emission Control System Caution– Gasoline Engines ............................. 9

Description of Emission SystemMaintenance Jobs .................................... 9

Changing the engine oil and filter ...... 9Replacing the air filter ...................... 10Replacing the fuel filter .................... 10Replacing spark plugs ...................... 10

Maintenance service descriptions ......... 10Vehicle Maintenance ServiceWork (including Emission SystemMaintenance) ................................... 10

Tire rotation at 5000 miles .................... 11Recommended Service Work ........... 11

Service at 10,000 miles or after 1 year . 11Required Service Work .................... 11Recommended Service Work ........... 12

Service at 20,000 miles or after 2 years 12Required Service Work .................... 12Recommended Service Work ........... 13


Service at 40,000 miles or after 4 years 16

Required Service Work .................... 16Recommended Service Work ........... 17






Service at 100,000 miles or after10 years ................................................ 25












Vehicle Maintenance High-mileageService Work ......................................... 35

High-mileage Service at160,000 miles or 16 years; thenevery 20,000 miles or 2 years ......... 35

1975840093 É1975840093vËÍ

Contents 1


2010-03-18T07:21:53+01:00 - Seite 1

High-mileage Service at170,000 miles or 17 years; thenevery 20,000 miles or 2 years –Required Service Work .................... 37

High-mileage additional work ................ 39Confirmations ........................................ 39

Tire rotation ..................................... 39Maintenance service ........................ 41

2 Contents


2010-03-18T07:21:53+01:00 - Seite 2

Vehicle data

X XModel Vehicle Identification Number (VIN)

X XDate of initial registration Paint color and code

X XLicense Plate No. License Plate No.




Protection of the environment

Natural resources form the basis of ourexistence on this planet. The objectives of ourpolicy are for these resources to be usedsparingly and in a manner which takes therequirements of both nature and humanityinto account.Our declared policy is integratedenvironmental protection. This policy startsat the root causes and encompasses in itsmanagement decisions all the consequencesfor the environment which could arise fromproduction processes or the productsthemselves.You too can help to protect the environmentby operating your Mercedes-Benz in anenvironmentally responsible manner.

Operating conditions and your individualdriving style to a large extent influence fuelconsumption and the rate of engine, brake,and tire wear. To reduce fuel consumptionand the rate of wear, please consider thefollowing:Ravoid short trips.Rmake sure that the tire pressures are

always correct.Ravoid frequent, abrupt acceleration.Rdo not carry any unnecessary weight.Rdo not warm up the engine with the vehicle

stationary.Rshift gears such that each gear is used only

up to 2/3 of its maximum engine speed.Rkeep an eye on the vehicle’s fuel

consumption.A regularly serviced vehicle will also helpprotect the environment. You should adhereto the maintenance intervals displayed by theMaintenance System service indicator, along

Protection of the environment 3

Gene

ral i

nfor

mat

ion

GWarning! Please make sure you read the technical documentation, such asthe Operator’s Manual and workshop information, before carryingout any maintenance work.


2010-03-18T07:21:53+01:00 - Seite 3

with other maintenance work described inthis booklet.We recommend that you have maintenanceservices performed by your authorizedMercedes-Benz Center using GenuineMercedes-Benz parts.

4 Protection of the environmentGe

nera

l inf

orm

atio

n



2010-03-18T07:21:53+01:00 - Seite 4

Introduction

Mercedes-Benz Maintenance SystemYour Mercedes-Benz comes equipped withthe Mercedes-Benz Maintenance System.The Maintenance System tracks distancedriven and the time elapsed since your lastservice. The maintenance service is indicatedin the multifunction display in the instrumentcluster.Approximately 1 month before amaintenance service is due, a messageappears in the multifunction display. Themessage provides the remaining miles ordays until the next maintenance service isdue.A descriptive listing of the service items arecontained in this booklet starting on(Y page 10). Following each maintenanceservice, your authorized Mercedes-BenzCenter will reset the Maintenance Systemservice indicator by confirming the serviceitems performed.The authorized Mercedes-Benz Centerperforming the maintenance services willconfirm the work has been carried out usingthe Confirmation pages in this booklet(Y page 39).We continuously strive to improve ourproduct and ask for your understanding thatwe reserve the right to make changes in theperiodic maintenance work for our vehicles.The information in this manual is accurate asof the press date. At the time of yourscheduled maintenance appointments withyour authorized Mercedes-Benz Center, themost current maintenance work informationwill be utilized for your vehicle’s age ormileage. Please check with your authorizedMercedes-Benz Center for any changes to theperiodic maintenance work for your vehicle.

i If the Maintenance System servicecounter was inadvertently reset, have anauthorized Mercedes-Benz Center correctit. Please only reset if the proper

maintenance service has been performed.Resetting the system without performingthe proper maintenance service will resultin engine and/or other vehicle damage notcovered by the Mercedes-Benz NewVehicle Limited Warranty.

Required and Recommended ServiceWork

Required and Recommended Service Workincludes inspection or maintenance of manydifferent components and systems in yourvehicle. The replacement of certaincomponents at varying intervals is also partof Required and Recommended ServiceWork.Required Service Work is intended to helpmaximize the service life of components orsystems important to your vehicle’scontinued proper operation.In addition to the Required Service Work,Recommended Service Work is intended toprovide you with the flexibility to choosewhich maintenance work is performed onyour vehicle based on its needs orrecommendations from your authorizedMercedes-Benz Center.

i Please note any maintenance work notperformed or not performed at thespecified interval which results in thefailure of the warranted component(s) orsystem(s) in question may not be coveredby the Mercedes-Benz New Vehicle LimitedWarranty.

Tire rotationYour vehicle’s tires are a critical componentto overall vehicle performance and vehiclestability. The useful life of tires will vary andis proportional to tire type, speed rating,ambient conditions, tire loading, tire inflationpressure, road surfaces, and individualdriving style, among other factors. Therefore,

Introduction 5

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 5

Mercedes-Benz recommends regular checksfor wear and proper inflation and, if applicableto your vehicle’s tire configuration, tirerotation.Tire rotations can be performed on vehicleswith the same front and rear tire dimensions,e.g. if appropriate winter tires are mounted.If your vehicle is equipped with the same tiredimensions, tires can be rotated by observinga front-to-rear rotation pattern that willmaintain the intended rotation (spinning)direction of the tire (on unidirectional tires, anarrow on the sidewall indicates the intendedrotation or spinning direction of the tire). Ifyour vehicle is configured with staggered tiresizes (different tire sizes, front vs. rear), tirerotations are not possible.If your vehicle’s tire configuration allows fortire rotation, tire rotation should beperformed in accordance with therecommended intervals, or sooner at firstsigns of irregular (uneven) tread wear. Tirerotation recommendations will likelynecessitate a tire rotation at least once inbetween maintenance services and at everymaintenance service based on Mercedes-Benz maintenance intervals.For your convenience, this MaintenanceBooklet contains a tire rotation confirmationpage on which you can record the date andmileage when tire rotations were performed(Y page 39).

Severe operating conditionsThe maintenance intervals have beendetermined so that the vehicle, under normaloperating conditions, should operateproperly between maintenance services.Severe operating conditions may call forcorrespondingly sooner replacement of thefollowing items:RInterior filters

(combination filter) is replaced as called forby the Maintenance System. Under severe

dust conditions, or with the Climate Controlfrequently operating in the air recirculationmode, the filter should be replaced morefrequently than indicated by theMaintenance System.RSpark plugs

Spark plugs should be replaced accordingto the specified maintenance interval.Severe operating conditions (frequentstarting and stopping, excessive idling,sustained fast highway driving) may call forspark plugs to be replaced correspondinglysooner.RCoolant

Have the coolant (water/anticorrosion/antifreeze mixture) replaced at thespecified maintenance interval.Replacement of coolant may be requiredmore frequently if coolant is not maintainedaccording to instructions and/or otherthan approved anticorrosion/antifreezeproducts for your vehicle are being used.For instructions on coolant, see "Coolants"in your vehicle Operator's Manual. For alisting of approved anticorrosion/antifreeze products for your vehicle,contact your authorized Mercedes-BenzCenter.

Wear itemsWhile the Maintenance System calls forinspection of certain wear items, the systemdoes not make any judgment on the conditionof these wear items. Only a qualifiedtechnician can determine if a wear item needsto be replaced.

Tested and approved engine oils andoil filters

Engine oils and oil filters are specificallytested for their suitability in our engines anddurability for our service intervals. Therefore,only use approved engine oils and oil filters

6 IntroductionM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 6

required for vehicles with MaintenanceSystem. Conventional petroleum-based oilsmust not be used for vehicles equipped withthe Mercedes-Benz Maintenance System.The following cases are not covered by theMercedes-Benz New Vehicle LimitedWarranty:Rusing engine oils and oil filters of

specification other than those expresslyrequired for the Maintenance System.Rchanging of oil and oil filter at change

intervals longer than those called for by theMaintenance System.Rusing any oil additives.Mercedes-Benz USA, LLC recommendsMOBIL OIL.The following MB sheet number applies to theengine type of your vehicle.

MB sheet number 229.5

i MB sheet numbers are printed on theoutside of oil containers.

Viscosity grades for engine oilsUsing the chart below, select oil viscosityaccording to the lowest air temperatureexpected before the next oil change.

For more information on selecting the properengine oils for your vehicle, please refer tohttp://www.startekinfo.com/MB Workshop Resources/Recommended Fluids or

http://www.mbusa.com/ownersonline/Important Vehicle Specifications or yourauthorized Mercedes-Benz Center.

Regular checksIn addition to the services, we recommendthat you check the following items regularly(for example: weekly, when refueling, orbefore any long journey):REngine oil level - Further information

about engine oil level measurement can befound in the vehicle Operator's Manual.RCoolant level - Please refer to the

Operator’s Manual for the correctprocedure to check the coolant level.RBrake fluid level - If brake fluid has to be

added, see an authorized Mercedes- BenzCenter to determine the cause, e.g. leaksor worn brake pads.RWindshield washer system - If the

washer fluid level drops below theminimum level, a display message appearsin the multifunction display. Add washerfluid mixed with Mercedes-Benz windshieldwasher solvent/concentrate, test functionand check wiper blades.RLighting systemRTire condition and pressures – Check at

least monthly. Please refer to section "Tiresand wheels" in the Operator's Manual forguidelines and correct procedures to checktire condition and pressures.

Notes on the warrantyAn extensive and well-equipped network ofauthorized Mercedes-Benz Centers is at yourdisposal for service work. Your authorizedMercedes-Benz Center can ensure that yourvehicle is professionally and thoroughlyserviced and repaired.

Introduction 7

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 7

Please see the Service and WarrantyInformation booklet for detailed informationon warranty terms and coverage.Please follow the instructions given in this Maintenance Booklet, even if you entrust the vehicle to a third party for use or care. Only in this way will you be able to ensure that your warranty rights are not affected.Service, replacement, or repair of the emission control devices and systems can be performed by any automotive repair establishment or individual using certified parts.We strongly recommend that you have your vehicle serviced by your authorized Mercedes-Benz Center which is fully equipped to provide this service.Please note that engines have to be servicedin accordance with special instructions andusing special measuring equipment tocomply with legal requirements concerningexhaust emissions. Modifications to ortampering with emissions components is notpermissible. Your authorized Mercedes-BenzCenter is familiar with the relevantregulations.

Service recordsYour authorized Mercedes-Benz Center willcertify in this booklet the maintenanceservices on your vehicle which it hasperformed.Other than the maintenance servicesdescribed, the Maintenance Booklet does notrecord or reflect any repair work that mayhave been performed to your vehicle. Pleasekeep those receipts with your vehiclerecords.For information concerning warranty, seeyour Service and Warranty Informationbooklet.

Your authorized Mercedes-Benz Center willgladly furnish additional information on themaintenance of your vehicle.Mercedes-Benz USA, LLCA Daimler Company

Parts/operating materialsWe recommend only the use of GenuineMercedes-Benz parts for service and repairs,since they meet our specifications. It is alsoimportant to only use fuels, lubricants andanticorrosion/antifreeze coolant meetingfactory specifications. Please see yourauthorized Mercedes-Benz Center for moreinformation on this subject.

Emission System Maintenance

Gasoline engineThe U.S. Environmental Protection Agencyand, in California, the Air Resources Boardhave certified that the emission controlsystems of your vehicle comply with theapplicable exhaust emission standards forMY 2011 vehicles.To be certain that the emission controlsystems function as designed, regularmaintenance is necessary for components ofthe vehicle which affect exhaust andevaporative emissions composition.The vehicle owner is responsible for theregular maintenance of the emission controlsystem, as well as the use of premiumunleaded gasoline with an anti-knock index ofat least 91 (displayed on the pump) in allgasoline engine models unless otherwisespecified.Failure to properly maintain the emissionsystem may result in repairs not beingcovered by the emission system warranties.Explanations of each maintenance job aregiven on (Y page 9).

8 Emission System MaintenanceM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 8

Emission Control System Caution –Gasoline Engines

Your Mercedes-Benz vehicle is equipped withboth a three-way catalyst and a closed loopoxygen sensor system to comply with currentexhaust emission regulations. Keep yourvehicle in proper operating condition byfollowing our recommended maintenanceinstructions as outlined.The following must be adhered to:a) In all gasoline engine models, use only premium unleaded gasoline with an anti-knock index of at least 91 (as displayed on the pump) unless otherwise specified. Damage to the engine could occurif premium unleaded fuel is not used. Refer tothe Operator’s Manual for specialprecautions.b) Leaded gasoline should not be used under any circumstances. Damage to theemission control components will result.c) In select models, the use of Ethanol (E85) is also permissible. Models capableof also operating with E85 are identified by alabel on the fuel filler flap reading ’Premiumgasoline or E85 only!’. Do not use Ethanol fuel(E85) to operate any vehicle unless it isspecifically identified as Ethanol fuel (E85)compatible. Damage to the engine couldoccur if improper fuels are used. Refer to theOperator’s Manual for special precautions.d) The specified engine maintenance jobs must be performed completely and at the required intervals. Properly functioningspark plugs for instance are important for theservice life of the catalysts. Failure to properlyperform the specified maintenance jobs mayadversely affect the emission control systemon the vehicle and reduce its service life.e) The operation of the emission control system must not be altered in any way.Alterations are not permissible by law. Inaddition, alterations may result in damage tothe catalysts, increased fuel consumption,and impaired engine running conditions.

f) Irregular engine running conditions should be corrected immediately by an authorized Mercedes-Benz Center. Suchirregular running conditions can influence theproper function of the emission controlsystem.If the "CHECK ENGINE" indicator lamp in theinstrument cluster illuminates when theengine is running, it indicates a possiblemalfunction of the engine managementsystem or emission control system.We recommend that you have themalfunction checked as soon as possible.

Description of Emission SystemMaintenance Jobs

The composition of exhaust emissions isinfluenced not only by the special emissioncontrol equipment, but also by various enginecomponents and their adjustments.Therefore, emission system maintenancemust include these engine components.Some maintenance jobs are actually onlytests. They are important however, becausethey allow early detection of discrepancieswhich can later lead to increased exhaustemissions. It is generally less expensive tohave such items adjusted immediately ratherthan allowing them to contribute to costlyrepairs. The maintenance intervals have beendetermined so that the vehicle, under normalconditions, should operate properly betweenservices.

Changing the engine oil and filterChange the engine oil and oil filter every10,000 miles or 1 year. If oil consumptionshould increase, determine the cause andtake necessary corrective steps. Do not resetthe Maintenance System service indicator ifthe oil level is adjusted or changed outsidethe interval of 10,000 miles or 1 year.

Description of Emission System Maintenance Jobs 9

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 9

Replacing the air filterUnder normal dust conditions, replace the airfilter at every 40,000 miles or 4 years. Cleanair filter cover and housing prior to removalof air filter.

Replacing the fuel filterReplace the fuel filter every 150,000 miles or15 years.

Replacing spark plugsSpark plugs are subject to electrode erosionand must be replaced according to thespecified maintenance intervals, or morefrequently as may be required when subjectto severe operating conditions.

Maintenance service descriptions

Vehicle Maintenance Service Work(including Emission SystemMaintenance)

i Maintenance services should beperformed at the number of miles or years(whichever comes first) as indicated.If your vehicle exceeds the time or mileageof the maintenance service descriptions,continue to maintain the vehicle followingthe maintenance services specified in theHigh Mileage section .Detailed descriptions for eachmaintenance service can be found startingon .For description of emission systemmaintenance jobs, see (Y page 9).

10 Maintenance service descriptionsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 10

Tire rotation at 5000 miles

A 5,000-mile recommended tire rotation interval will likely necessitate tire rotation at leastonce in between each 10,000-mile maintenance service and at every 10,000-milemaintenance service. Please refer to (Y page 5) for additional tire rotation information and(Y page 39) to record when your vehicle’s tires have been rotated.

Recommended Service Work

Tire checks

Tire rotation (where applicable)1

Service at 10,000 miles or after 1 year

Required Service Work

Engine - oil and filter change

Check catch, safety catch and hinges on engine hood for proper operation

Clean visible area of water deflector

Reset maintenance service indicator in instrument cluster

Check thickness of brake pads, front and rear

Correct tire inflation pressure

Check underbody protection

Check the following fluid levels, correct if necessary

If there is a loss of fluid, determine cause and perform repair with separate work order

Check coolant level

Brake system

Power steering

Windshield washer system

1 Tire rotation can not be performed on vehicles equipped with staggered front/rear tire sizes.

Service at 10,000 miles or after 1 year 11

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 11


Replace wiper blades



Starter battery

Electrical system checks

Horn, high beam flasher, hazard warning lamps, turn signals

Warning/indicator lamps, illumination and interior lighting/exterior lighting

Check trunk lighting

Check battery condition (starter battery) using "Midtronics MCR 717" tester

Visual and functional checks

Check windshield washer and headlamp cleaning system

Tire checks

Tire rotation (where applicable)

Inspect tires for damage, measure tread depth

Check TIREFIT sealant expiration date

Activate Tire Pressure Monitoring System

Chassis checks

Visually check brake system components, lines, hoses, calipers

Check thickness of brake pads and disks, front and rear wheels removed

Service at 20,000 miles or after 2 years




Check condition of poly-V-belt



12 Service at 20,000 miles or after 2 yearsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 12

Replace brake fluid

Combination filter replaced




Leakage - Major components: Check for chafe marks, line routing, damaged components.In the event of leakage, determine cause and perform repair with separate work order

Visually inspect condition of front axle ball joints, rubber boots

Visually inspect condition of rear axle ball joints, rubber boots

Visually inspect condition of steering mechanical components, rubber boots



Check coolant level

Brake system

Power steering


Function check

Check parking brake (function test only)





Starter battery




Boot lighting checked


Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 13

Check and correct headlamp setting



Check seat belts and buckles for signs of external damage and proper function


Check bodywork for paint work damage

Tire checks





Chassis checks



Chassis and load-bearing body components: Check for damage and corrosion












Check coolant level


aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 14

Brake system

Power steering






Starter battery








Tire checks





Chassis checks




Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 15








Replace brake fluid









Oil change in dual clutch transmission

Replace air filter



Check coolant level

Brake system

Power steering


Function check



aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 16





Starter battery











Tire checks





Chassis checks





Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 17












Check coolant level

Brake system

Power steering






Starter battery









aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 18

Tire checks





Chassis checks










Replace brake fluid









Replace spark plugs


Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 19



Check coolant level

Brake system

Power steering


Function check






Starter battery











Tire checks





aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 20


Chassis checks















Check coolant level

Brake system

Power steering






Starter battery


Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 21








Tire checks





Chassis checks










Replace brake fluid






aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 22





Replace air filter



Check coolant level

Brake system

Power steering


Function check






Starter battery










Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 23



Tire checks





Chassis checks















Check coolant level

Brake system

Power steering



aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 24





Starter battery








Tire checks





Chassis checks











Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 25

Replace brake fluid











Check coolant level

Brake system

Power steering


Function check






Starter battery






aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 26







Tire checks





Chassis checks















Check coolant level


Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 27

Brake system

Power steering






Starter battery








Tire checks





Chassis checks




aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 28








Replace brake fluid









Replace air filter

Replace spark plugs



Check coolant level

Brake system

Power steering


Function check



Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 29





Starter battery











Tire checks





Chassis checks





aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 30












Check coolant level

Brake system

Power steering






Starter battery









Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 31

Tire checks





Chassis checks










Replace brake fluid










aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 32



Check coolant level

Brake system

Power steering


Function check






Starter battery











Tire checks





Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 33


Chassis checks








Replace fuel filter






Replace coolant



Check coolant level

Brake system

Power steering



aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 34





Starter battery








Tire checks





Chassis checks



Vehicle Maintenance High-mileage Service Work

High-mileage Service at 160,000 miles or 16 years; then every 20,000 miles or2 years





Vehicle Maintenance High-mileage Service Work 35

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 35



Replace brake fluid









Applicable additional work XXX Link einfuegen



Check coolant level

Brake system

Power steering


Function check






Starter battery



36 Vehicle Maintenance High-mileage Service WorkM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 36









Tire checks





Chassis checks




High-mileage Service at 170,000 miles or 17 years; then every 20,000 miles or2 years – Required Service Work









Vehicle Maintenance High-mileage Service Work 37

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 37

Applicable additional workXXX Link einfügen



Check coolant level

Brake system

Power steering






Starter battery








Tire checks





Chassis checks



38 Vehicle Maintenance High-mileage Service WorkM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 38

High-mileage additional work

If more than 40,000 miles or 4 years since last replacement

Replace air filter


Replace spark plugs


Replace fuel filter

Replace coolant

Confirmations

Tire rotationPlease refer to (Y page 5) and (Y page 11) for tire rotation information.

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Confirmations 39

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 39

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

Date: Odometer:

40 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 40

Maintenance service

Vehicle Identification Number (VIN) Date Odometer Repair order no. (if applicable) Next maintenance due: Miles Next maintenance due: Month/year

Oil brand/viscosity:Engine oil

Dual clutch transmission

Replaced: Engine oil Transmission oil Brake fluid

Brake pads, front axle Brake pads, rear axle Fuel filter Combination filter Air filter Coolant Spark plugs

Rubber stamp/Signature

Confirmations 41

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 41







42 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 42







Confirmations 43

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 43







44 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 44







Confirmations 45

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 45







46 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 46







Confirmations 47

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 47







48 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 48







Confirmations 49

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 49







50 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 50







Confirmations 51

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 51







52 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 52







Confirmations 53

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 53







54 ConfirmationsM

aint

enan

ce B

ookl

et



2010-03-18T07:21:53+01:00 - Seite 54







Confirmations 55

Mai

nten

ance

Boo

klet



2010-03-18T07:21:53+01:00 - Seite 55

56


2010-03-18T07:21:53+01:00 - Seite 56

Publication detailsInternet

For further information you can find us on theMercedes-Benz web-sitehttp://www.mbusa.com.

Service and Literature

Reprinting, translation and copying, even ofexcerpts, are not permitted without our priorauthorization in writing.

Model

SLS AMG

As at 05.01.2010


2010-03-18T07:21:53+01:00 - Seite 57

Order no. 6515 8368 13 Part no. 197 584 00 93 Edition 197 Edition A 2011

É1975840093vËÍ1975840093


2010-03-18T07:21:53+01:00 - Seite 58

Maintenance - Mercedes-Benz of Cary

Documents

Transcript of Maintenance - Mercedes-Benz of Cary